YOU ARE DOWNLOADING DOCUMENT

Please tick the box to continue:

Transcript
Page 1: Starswitch O&M Manual

OPERATION AND MAINTENANCE MANUALSTSTSTSTSTARARARARARswitch TM 1:8 REDUNDANCY SWITCH

TP 1Title Page

Manual Number TM 112597

COMSAT RSI warrants its products for a period of one year fromthe date of shipment to be free from defects caused by faulty mate-rials or poor workmanship. The terms and conditions of this war-ranty are as follows:

The purchaser must notify COMSAT RSI, Anghel Labora-tories promptly upon the discovery of such defect.

The purchaser must return the defective product to COM-SAT RSI, Anghel Laboratories, Rockaway, New Jersey, postpaid.

Evaluation of the defective product at COMSAT RSI shalldisclose that such defects exist and have not been causedby misuse, neglect, improper handling, alteration or acci-dent.

COMSAT RSI, Anghel Laboratories reserves the right to make prod-uct improvements and/or design changes in any of its productswithout incurring any obligation or liability to make the same changesin units previously shipped.

Copyright 1997 by COMSAT RSI, Anghel LaboratoriesAll rights reserved.

Printed in the United States of AmericaContents of this manual are subject to change.

No part may be reproduced or transmitted in any form or by anymeans without the written permission of

COMSAT RSI, Anghel Laboratories101 Roundhill Drive, Rockaway, NJ 07866, USA

WARRANTY

OPERATION AND MAINTENANCE MANUAL

STSTSTSTSTARARARARARswitch TM 1:8 REDUNDANCY SWITCH

Page 2: Starswitch O&M Manual

OPERATION AND MAINTENANCE MANUAL

STSTSTSTSTARARARARARswitch TM 1:8 REDUNDANCY SWITCH

Record of Revisions ROR 1

REVISIONDESCRIPTION

REVISEDBY

REVISIONDATE

REVISION

RECORD OF REVISIONS

11/25/97 Original Print BL

Page 3: Starswitch O&M Manual

OPERATION AND MAINTENANCE MANUAL

STSTSTSTSTARARARARARswitch ™ 1:8 REDUNDANCY SWITCH

TOC 1TTTTTaaaaabbbbble ofle ofle ofle ofle of Contents Contents Contents Contents Contents

TABLE OF CONTENTS

PARAGRAPH PAGE

Section 1. General Information ........................................................................

1-0 Introduction ...................................................................................................

1-1 Equipment Overview .....................................................................................1-2 Specifications ................................................................................................1-2.1 IF Specifications .........................................................................................1-2.2 RF Specifications .......................................................................................1-2.3 Environmental Specifications .....................................................................1-2.4 Physical Specifications ...............................................................................BLANK .................................................................................................................

Section 2. Installation .......................................................................................

2-0 Introduction ...................................................................................................2-1 Unpacking and Inspection .............................................................................2-2 Installation Requirements..............................................................................2-3 Mechanical Installation .................................................................................2-4 Electrical Connections...................................................................................2-4.1 Power .........................................................................................................2-4.2 IF Connections ...........................................................................................2-4.3 RF Connections .........................................................................................2-4.4 Communications Connections ...................................................................2-4.4.1 J1-Multi Connector Cable........................................................................2-4.4.2 J2-1:8 Switch Expansion Cable ..............................................................2-4.4.3 J3-Backup Converter ..............................................................................2-4.5 Supplied Equipment ...................................................................................BLANK .................................................................................................................

Section 3. Description and Operation .............................................................

3-0 Introduction ...................................................................................................3-1 General .........................................................................................................3-2 Controls and Indicators .................................................................................3-2.1 Controls ......................................................................................................3-2.2 Indicators ...................................................................................................3-3 Theory of Operation ......................................................................................3-3.1 IF and RF Switching ...................................................................................3-3.2 Control Logic and Switch Drivers ...............................................................3-4 Converter Operation......................................................................................3-4.1 General Displays ........................................................................................3-4.2 Request Menu ............................................................................................

1-1

1-1

1-11-21-21-21-21-31-4

2-12-12-12-12-12-12-12-12-12-22-22-22-22-22-22-4

3-1

3-13-13-13-13-13-23-23-33-43-43-5

Page 4: Starswitch O&M Manual

OPERATION AND MAINTENANCE MANUAL

STSTSTSTSTARARARARARswitch ™ 1:8 REDUNDANCY SWITCH

TOC 2 TTTTTaaaaabbbbble ofle ofle ofle ofle of Contents Contents Contents Contents Contents

TABLE OF CONTENTS (continued)

PARAGRAPH PAGE

3-4.2.1 Switch Request .......................................................................................3-4.2.2 Standby Request .....................................................................................3-4.2.3 Online Request .......................................................................................3-5 General Alarm and Alarm Mask ....................................................................3-6 Configuration Examples ................................................................................3-6.1 Any converter in System may be backed Up..............................................3-6.2 Only One Converter in System may be backed Up ....................................3-6.3 System is set toa single configuration, remains in same state after powerfailure ...................................................................................................................3-7 Operational Checkout ....................................................................................3-7.1 Initial Configuration ....................................................................................3-7.2 Frequency Selection ..................................................................................3-7.3 Alarm Checkout Procedure ........................................................................3-8 M&C Commands ............................................................................................3-9 Block Diagram ................................................................................................Blank ....................................................................................................................

Section 4. Maintenance and Repair .................................................................

4-0 Introduction ...................................................................................................4-1 Maintenance .................................................................................................4-1.1 Cleaning .....................................................................................................4-2 Performance Checks.....................................................................................4-3 Removal and Replacement-General .............................................................4-4 Unit to Unit Interconnections .........................................................................4-4.1 Converter Interface Cable-J1 .....................................................................4-4.2 1:8 Expansion Switch Cable-J2 .................................................................4-4.3 Backup Converter Interface Cable-J3 ........................................................4-5 Removal and Replacement ...........................................................................4-5.1 IF/Control Board Assembly-A1 ...................................................................4-5.1.1 Removal ..................................................................................................4-5.1.2 Replacement ...........................................................................................4-6 Removal and Replacement-Optional RF Switches .......................................4-6.1 Five Throw RF Switch-RF5 ........................................................................4-6.1.1 Addition to STARswitch™ .......................................................................4-6.1.2 Removal ..................................................................................................4-6.2 SPDT RF Switches ....................................................................................4-6.2.1 Addition to STARswitch™ .......................................................................4-6.2.2 Removal ..................................................................................................4-7 Repair ...........................................................................................................4-7.1 Fault Indications .........................................................................................Blank ....................................................................................................................

3-53-53-63-63-63-63-6

3-63-73-73-73-73-83-93-10

4-1

4-14-14-14-14-14-24-24-34-34-44-44-44-44-44-44-44-44-54-54-54-54-6

Page 5: Starswitch O&M Manual

OPERATION AND MAINTENANCE MANUAL

STSTSTSTSTARARARARARswitch ™ 1:8 REDUNDANCY SWITCH

TOC 3TTTTTaaaaabbbbble ofle ofle ofle ofle of Contents Contents Contents Contents Contents

TABLE OF CONTENTS (continued)

PARAGRAPH PAGE

Section 5. Maintenance and Repair .................................................................

5-0 Introduction ...................................................................................................5-1 STARswitch™ Unit Part Numbers .................................................................5-2 Options Parts List- STARswitch™ Redundancy Switch ................................5-2.1 Five Throw RF Switch Kit Parts List ...........................................................5-2.2 SPDT RF Switch Kit Parts List ...................................................................5-3 Parts List- STARswitch™ Redundancy Switch..............................................Blank ....................................................................................................................

Section 6. STARswitch™ Configuration ..........................................................

6-0 Introduction ...................................................................................................6-1 1:1 Configurations .........................................................................................6-2 1:4 Up Converter ...........................................................................................6-3 1:4 Down Converter-Multiple RF Feeds-Non-Terminated .............................6-4 1:4 Down Converter-Single RF Feed ............................................................6-5 1:8 Down Converter-Single RF Feed ............................................................

5-1

5-15-15-25-25-25-35-4

6-1

6-16-16-16-16-16-1

Page 6: Starswitch O&M Manual

OPERATION AND MAINTENANCE MANUAL

STSTSTSTSTARARARARARswitch ™ 1:8 REDUNDANCY SWITCH

TOC 4 TTTTTaaaaabbbbble ofle ofle ofle ofle of Contents Contents Contents Contents Contents

TABLE # DESCRIPTION PAGE

IF Specifications ......................................................................RF Specifications ....................................................................Environmental Specifications ..................................................Physical Specifications ............................................................

Supplied Cables ......................................................................

Additional M&C Commands ....................................................

STARswitch™ J1 Pinout Nomenclature ..................................STARswitch™ J3 Pinout Nomenclature ..................................

STARswitch™ Unit Part Numbers...........................................Five Throw RF Switch Kit Parts List ........................................SPDT RF Switch Kit Parts List ................................................STARswitch™ Parts List .........................................................

1-21-21-21-3

2-2

3-8

4-24-3

1-11-21-31-4

2-1

3-1

4-14-2

5-15-25-25-3

5-15-25-35-4

LIST OF TABLES

LIST OF FIGURESFIGURE # PAGE

2-1

3-13-23-33-43-53-63-73-8

5-1

6-1(a)6-1(b)6-26-3

6-4

6-5

Mechanical Layout (shown without RF switches) ....................

IF Switching Paths ..................................................................Converter Display Window ......................................................Default Menu ...........................................................................Fault Code Menu.....................................................................Switch Request Display- AUTO Selection ..............................Switch Request Display- SBY Selection .................................Online Request Menu .............................................................STARswitch™ Block Diagram with Options ............................

STARswitch™Redundancy Switch Component LayoutDiagram...................................................................................

1:1 Up Converter Redundancy Switch System .......................1:1 Alternate Up Converter Redundancy Switch System........1:4 Up Converter Redundancy Switch System .......................1:4 Down Converter Redundancy Switch System-Multiple RFFeeds, Non -Terminated .........................................................1:4 Down Converter Redundancy Switch System-Single RFFeed ........................................................................................1:8 Down Converter Redundancy Switch System with aSingle RF Feed .......................................................................

2-3

3-23-43-43-43-53-53-63-9

5 5/6

6-26-26-3

6-4

6-5

6-6

Page 7: Starswitch O&M Manual

������������������������� ��

����������������� �

������������������������� �����

��� ����������

������������� ���������������������������������������������������������� �� �������������������������������������������������������������������������������������� ����!���������"������#���$�����%

��� ����������������

�������������������������� �������������������������������������������������������������������������� ������%�������������������������������������������� �������������� �������������%�&�������������������������������������������������������� �����'�(�������!������������������������������%

������������������������������� ������� �����������������)

� *�������&����������������������������&����������������������������+�,�� �����������-).����-)/���������� 0���!��!�������������������-)-���-)/���������� ������������������������������������������� 1������2�*&�������������������� ����������

3������������������������������������������������ ������������������������������������������������������������������ ������������������������&�������%������������������������������������������ �����������������������4������������������������������������!��������������%������������������������������������������������������������������������������� ������������ �����'�(%

56��������� �������������������-).�����-)/���������������������������-).�������������������������������������6������-).���������������������������� ������%�������������-).������������4���������������������������������������������������������������������%

����������������������������������� ��������������������������������������� ��������!���������������������������������������������������������������������������%

�������������������������������������������������������������� �������������������&���������������������� ����������������������%�7���������� ����������������������������������������������������������&�������%�*���89����:8���� ����������������������� �������%�����������8���������������%

��������������������������������������������������-;!�������"%����������������������������������� ��������������������������������������������������%

���������������������������������������������� �������������������� �������������������������������������������������%���������������� ��������� �������������� ���������������������<�=%������� ������������� ����������������� ������ �>����������2���-%

��������������� �������� ����

Page 8: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� �������������� �

��� ��������������

����� ������� ��� ��

�����&��������������������������-!-�����������������������������������89���:8������������%

������������������ ��� ��

����� ������� ��� ��

�����&��������������������������-!?����������� �������&�������������89�������������%

������������������ ��� ��

����� ��� ������������� ��� ��

�������������� ������������� ��� ��

�������� �������� �������� �������� �������� ����������� ����������� ����������� ����������� �����������

�� �������� �� �������� �� �������� �� �������� �� �������� �� ���� �� �� � ���� ��

������ � ������ � ������ � ������ � ������ �������

�������������������

�������������

�� ����� �� ����� �� ����� �� ����� �� ����� ������ �! ������ �"

������#�$%&��'( ������#�$%&��'( ������#�$%&��'( ������#�$%&��'( ������#�$%&��'(�������� ������'��������������

����������#�����������)��������

����*���� +��, ����*���� +��, ����*���� +��, ����*���� +��, ����*���� +��, -'.�/!�0

1'��2����3���4�� ��* 1'��2����3���4�� ��* 1'��2����3���4�� ��* 1'��2����3���4�� ��* 1'��2����3���4�� ��* ���.5�!�

1'������3���4��������6 1'������3���4��������6 1'������3���4��������6 1'������3���4��������6 1'������3���4��������6 �7�.5�"��

���������� ���������� ���������� ���������� ���������� �����,��5

����*���� +��, ����*���� +��, ����*���� +��, ����*���� +��, ����*���� +��, -�8�!�0 -�8�!�!

���4�� ��* ���4�� ��* ���4�� ��* ���4�� ��* ���4�� ��* ���.5�9! ���.5��!

���4��������6 ���4��������6 ���4��������6 ���4��������6 ���4��������6 �7�.5�"�� �7�.5�"��

Page 9: Starswitch O&M Manual

������������������������� ��

����������������� �

������������������������� �����

����� �� � �������� ��� ��

������������� � �������� ��� ��

������������'�������'2 ������������'�������'2 ������������'�������'2 ������������'�������'2 ������������'�������'2 ������������( ������������( ������������( ������������( ������������(

�'���� �'���� �'���� �'���� �'���� :���!

'���;����2���* '���;����2���* '���;����2���* '���;����2���* '���;����2���* :����!

'���;�����'� '���;�����'� '���;�����'� '���;�����'� '���;�����'� :���9!

'���0 '���0 '���0 '���0 '���0 :����!

�'���; �'���; �'���; �'���; �'���; ��#��

Page 10: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� �������������� �

�������������� ���������������

Page 11: Starswitch O&M Manual

������������������������� ��������������������������� �����

���������������

��� ����������

����������������������� ������������������������������������������������������������������������������������������������������������������������������������

�� �����������������������

���������������������������� ���������������������������� ������ ���������������������!� �����������������������"��!����������������������������������������� ��"��!������������ ���������������������������� �����������������#�����$�������%&�� ������"����������������� ����������

��� ������������������������

����������������������� �����"������������������������������'%��()*�������!���������������"������������������������������������"����������������������������������������������������� �����������������"�������������������������������������"�������"���(*+����,� ����-*(�

��� �����������������������

����������������� ����������������������������������,� ����-*(������������������������������������� �"���!�������*���������� &����������������������� ������������������������������������������������������������������������������������������� ������&�������&���������������"������� ������������"�����������������(-./)*(0&�������"�������������$������%&�� ������"���������������������������������������������������������������� ��������$�"�����������������������������������������������,����%,���������������������������������������������������������������� ���������������������&���������1����,� ����2*(3���������������������������������������!������"��������������������������������������������������������

��� ����������������������

����%,&��,&����������������������������������������������������������������������������,� ����-*(�������������������������� ������������������������������ ����� � ������ ����������������������������������� ��� ������������������������������������������������ ! �����"�����#��������������$

�� ������

����������������������"�������������1�3�4����*$�������"��������������������������5(&����������������� �������6������������������ ��������"�����������������������������������������#���������������������������,�����������,(*�,/�������������������������������������&��������2*�������������,2�������������������������"��!�����������

������������������

����%,���������������������7#$����������"������8��(*�8��/����$6#9�(*$6#9�/��#�����������7#$���������������"��!�����������������"�����7�$:;<�$6#9����46#�

�������������� �� ����

Page 12: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� ������������

������������� ������������� ������������� ������������� �������������

�� �������� �������� �� �� ��

����������� �������������������

������ ��! ��"��# "$��%�%�

����������� � �����������������

� ���� ��! ��"��# "$��%�%�

����������� ��&����&���!$��

��!��� ��! $�"$"��# "$��%�%�

����������� � &����&���!$��

� !��� ��! $�"$"��# "$��%�%�

����������� �����������$��

������ ��! ��"$"��# '���%�%�

����������� � ���������$��

� ���� ��! ��"$"��# '���%�%�

�������������������

�����,�����������������������������,���������&��,(����� ���,2������4�����������������,� ����2*(���������������������������/������������������������

������������������������������

��������"���������� ����������������������������������"��������������������������������������=����������"����������������"���������� ������������������� �����������������"���-*(������"���������������������������������������������������

����������������� ��������� ���

�������"���1����������������������������������3������������������ ����������=7*-2����������������������������"����� ����������=7*(2���������������������"���������������������*��������15>���������3����������������������������������"��������� ����������������������������������������

��������������������������������� ���

�������"��������(-����""������������=7*)��������������!�������������������

���������������� �� ��!�����

�������"������/?��� ������=7*(2�������������������������7������������������������������!��������� ������5>������7��!���$�������

�����������������������

��"���-*(� ��������������������"�������������������������������������������������������$��������������������"�����"�����������������������!� �������������������,���<����&�<@#�7((?.+��������������������������

������������ �����������

Page 13: Starswitch O&M Manual

������������������������� ��������������������������� �����

���������������

������������������������������������� ���!�� ������� ��������������"

-�

-�

-�

,)�%2$5'�&29(5�

�����

������

��

�6<6��

&219��

&219��

&219��

&219��

6<6��

6<6��

6<6��

%8�&219�

021

3:5

)$8/7

�����

�����

��

� � �

&211(&725�'(6,*1$7,216�6+2:1)25�&/$5,7<�

6<6

67%<021

%$&.83

&219

&219

��

6<6

&219

67%<021

&219

%$&.83

�����

6<6 �

6<6 �

6<6 �

6<6 �

67%<021

�&219

�&219

&219 �

&219 �

&219

%$&.83

��

�����

5)�&$%/,1*

�����

5)�&$%/,1*

5)�&$%/,1*

$/7(51$7(

%'�-�

&21752/

72

%'�-�

&21752/

72

%'�-�

&21752/

72

%'�-�

&21752/

72

%'�-�

&21752/

72

%'�-�

&21752/

72

%'�-�

&21752/

72

%'�-�

&21752/

72

67%<021

��

�����

5)�&$%/,1*

&219

%$&.83

��

��

���

&21752/

72%'�-�&2

1752/

72%'�-�

%'�-�

&21752/

72

���

���

���

���

���

���

���

���

&21752/�%2$5'

-�

-�

-�

-�

-�

-�

� � �

&219��

6<6��

67$5��

&219��

6<6��

67$5��

Page 14: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� ������������

�������������� ���������������

Page 15: Starswitch O&M Manual

������������������������� ����������������������������� �����

���

��

����������� ��������

�������������� �������������� �����

��� ����������

������������� ���������������������������������������������������������������������������������������������������������������������������������������������������������� �����������������

���������������������������������������������������������������������������������� �������������������������������������������� ���������������� ��������!����������������������������������������������������� ��������!����������"�����#��� ����������������������� �������������������$�%���������������������������� ���&���'(������� ��������������

��� ������

)��������� ������������������ ����������������������������� �����������������*�����+���������������������������� ����������� �������������������������������������������*�����

���������������������������������� ,����-�������������������������� ���������������.������������������������������/*�����,����������� ������������������)#���,���������0�����1�������������������������������� ����������������������������������������������������������������(23�����������

+ ��������������������������������� �����������������������.���� ���������������������������������������� ���45����������������� ������������������������������

��� ������� �� ������

����� ����

������������������������������������������� ������������������������������������������������ ������� ���������������������������������������������������������������������� ������ ������������������������ ������������������$�%������������������������������������������������������������� ����6*7�

����� ������ �

���!8#���������������� �����������������������������������������������������������������45����46�

0(1���������!8#������������������)9��������������������������������������������������������� �������

051�������!8#������������������,�"!�������������������������������������������������������������������������������������������������������������������������������������� ,�������������������������,����������� ������,�"!��!8#��������������������������:��.���� �����������������';������,�"!���+#8��������������� ���������������!8#�������������������������������.�����������������

Page 16: Starswitch O&M Manual

������������������������� ����������������������������� �����

���

��

����������� ��������

��� ���������������

����� �����������������

���������������������������������/*������������0������,������6*(1������������� ,�����:��������������������������������������������������������������������������������������������������������<���������������)#���������������������:��.���� ������ ,���������������������������� ������ ,��������� ���������������

,������6*(0�1����������� ,�������������������������������������0�����������������������1���������� ,����������������������������� ��� ������� ������ ���������������0� ������'(����������,������6*(0�11���������������������������������� �������������/*����������������������������������'(� ,��������������������������:��.���� ������ ,���������������������������������������������������������������������� ������������������������������

���������� �����������������

������ ������

���,)�,1387��6<6���

72�%$&.83&219(57(5�,)�%$&.83�&219�

���,)�,1387��6<6���

���,)�,1387��6<6���

���,)�,1387��6<6���

67$1'%<021,725�021�

������������

��7+52:

6:,7&+

&219(57(5����,)��&219���

&219(57(5����,)��&219���

&219(57(5����,)��&219���

&219(57(5����,)��&219���

���,)�,1387��6<6���

���,)�,1387��6<6���

���,)�,1387��6<6���

���,)�,1387��6<6���

������������

��7+52:

6:,7&+

&219(57(5����,)��&219���

&219(57(5����,)��&219���

&219(57(5����,)��&219���

&219(57(5����,)��&219���

72�%$&.83&219(57(5�,)�%$&.83�&219�

67$1'%<021,725�021�

Page 17: Starswitch O&M Manual

������������������������� ����������������������������� �����

���

��

����������� ��������

����� ���������������������������

+�������,����������������������������,��������������.����������������������������������������������������,������������������������� ,�������������=�����/*������,������������������)#��,����������

����� ���� ������������������ ��� �

,������6*3���������������� ,�����,�(27�������������������������������������������������:������������������������������������������������ ����������������������������������������������������������������������������������� ,�����,���������������������������:����

+������������������������������������������������������������������������������������������.��� ������������������������������������������������������������������������������������������������������

����������������������������������������������� ������������������������������������������������� ������� ������������������������������ �������������������� ������������������������&>���������������8����������� ������������������������������������ ������������������������������������������������������������������������ �������������������������������������������������������� �������������������������������������������������:���������������������������������������������������� ������������������������������������

�������������������������������������������������������������.���� ������������������������.��� ��������������������&>��� ������ ������������������������������������.���� ������������������� ��������������������������������������������������������� ������� ����������������������������������� ���������������������� ��������������������������������

����������������.���� ���������� ����������������-���������� ������������������������������������������������������� ����������������������������������� ������������������������.���� ���������������������������&>�������������������������������� ���������������������������&�������?(*?3���������� �����������.���� �������������� ��������������

Page 18: Starswitch O&M Manual

������������������������� ����������������������������� �����

���

��

����������� ��������

��� � �������������

�� �� �����������������

� ��������������������������������������������������������������� ������������������,������6*5���������������������������������������������!����� �������,������6*6���������������������0����@1��������������������������,������6*7����������,�����������������0&��;1������������������������������������������������������������������������������������� ������������0(A�����1�����������������������������������������������������������$(%��������������������������������$(%��9��������������������������,������6*7�������� ��������������������� ������������������������������������������.���� ������������������

���������������������������� ��

������������������� �!��

������������"�����#��

����������������������������������������

������

������

� � � � � � � � � �� ��

������� �� ��

�����

� � � � � � � � � �� �� �� �� ���� �� �� �� �� ��

���������

���������������� �������������������������������������

��������������� �������������������������������

��������������� ��������������������������������������

��������������� ��������������������������

�� �� ���� �� ��

����������������������������� ������ ������������������������

�������������������������������������������������������������

32:(5�6833/<�021,725��

3/2�/2&.�$/$50

6<17+(6,=(5�/2&.�$/$50 5(6(59('�)25�)8785(�86(

86('�$6�6:,7&+�)$8/7�$/$50��:+(1�&219(57(5�,6�'(',&$7('�$6�%$&.83�&219(57(5

287387�/(9(/�$/$50

6800$5<�$/$50

5(6(59('�)25�)8785(�86(

����9�����9����9

Page 19: Starswitch O&M Manual

������������������������� ����������������������������� �����

��$

��

����������� ��������

�� �� �������������

��������������������������������!����� ������������������������ �����������$�%��������0�������(�������������1����������������������������������������������������������������������������������������������������������0����@1�����������������������������������������������������������������������&>�������������������������������������"�+���:B����+C! C8������������������������������������0����,����6*71��)����������� �������������������������������������������� ����������������������������������������������� ����������������������")����#+9C�.���������������������������������������������������������!8,������ DE�.���������������8C�8�����������-����������������� �������

�� ���� ��������������

"����������������-�����&���������������������,������6*/������������������������ ����*���9��������� �������������������"�+���:B���+C! C8����� ��������� �����������������"�+�����������9��������������!8,����� DE�������.�������������������������������������*�������������� ��������������������������������� �������������8C�8��.��������������

���������������� ����������������"�+������������������������ ��������������������.���������������.���� ������������������������������������������������ � ������������������������� ������������� ���������������������

������ !����!���"

�������$���������%&������������'()*��������

�� ���� ���� ���������

9����:B��������������������������������������������������������������,������6*;0�1�� �������������� �����������������������������������.���������������������������������������������"�������� ������������.���� ��������������������������������,������6*;0�1�����������:B���������� ����9�����"�����������������������������������������������$(%����������������������������� ����������� ���������� ������������������������������������������������������������$(%��������������������������������������������������������������� ��������������������������� ������;������,������������������������������������������ ������������������������������ ��������������������������������$(%�

�������+���������%&�������������,-��������

������������������������������������������� �� ���������� �

�������������������������������� ������������������

��������������������������������� ������������������

��+.�/ ��+.0/

Page 20: Starswitch O&M Manual

������������������������� ����������������������������� �����

��+

��

����������� ��������

!�"#�����$�������%�&#����'�#

�� ���� !�������������

9���+C! C8��������������������������������������������������������������,������6*@���������������������������������������-����������������������������������������$?%����� ���������������� ����������������� ����������������������������������������������������-���������������������������� ��������������������������� �������;������,����������������������������������������� ������������������������������ ���������������������������������$?%�

C+�82� ������� �����������������������������+C! C8��8F"8����������� �������������������������������������������������������������������

��$ 1�����������'��#��� �'��#�!��2

�����������������������������������������������������������������������������������������������.���� ������� ����������������������������������������������������,������������0';1�������$(%�����������������������������������������������������������������������������������.�����$?%����������������� ����������������������������������������������������������������.���

��+ ���"���������34�#���

���������������������������������������������������������������������������=�����������������������

��"�� #���$��%��������������&�&��� �� ��'��(�

0(1������ ������'(���&���'3���9 ��E��8F"8���051��������"�+�061��������0(1����051���������� ���������������

��"�� !��������$��%��������������&�&��� �� ��'��(�

0(1������ ��������������.��������&���'3���9 ��E��8F"8���051������ ��������������.���������:B�061��������������� ����������"�+�

��"�� �����&����������������)������*�)�������+���&����������&���������*���������*�������

0(1������ ��������������.��������&���'3���9 ��E��8F"8���051������ ��������������.���������:B�061��������������� ���������+C! C8�

����������������������������� �� �� ������������

Page 21: Starswitch O&M Manual

������������������������� ����������������������������� �����

��5

��

����������� ��������

��5 *������������2���

+��������������������� ����������������������������������������������������������������*���������.���������������������������������������������������������������������������������

��,���-�������$��*�)�������

0(1������������������������ ������������������������������ �������

051����������9 ��E��8F"8�������0����'31�������� ������������������"�+�

061���������&���';�0,�"!���+#81�������� �����������������������������������$?%�

071����������������������!8#���������0)9�1��������������������������������������

0/1��������������������!8#���������0,�"!�1����������������������������������������

� #���������� #���������#��$�� ��$��%�%��&����������������������������$�'()*�+,���%�����������$�����������������$�

��,�� .������������������

0(1���������&���'(?���8��,�8F"8C�B����� ������'(��������������.�����������������-��������-����������������)�����8C���������������������

051���������&���'((���8��!�:�C#����8C�0������� ������1����� ������'(���������������-�������������������������)�����8C���������������������

061���������&���'(5���8�� ,����8C�0������������� ������1����� ������'(��������������-��������������������������)�����8C���������������������

071���������&���'(/���8��&8&+�B����� ������'(������������&�����������?(��)�����8C�����������������-����������������0(1������������������������������������051���G��061�

0/1��������0(1��������061���������� ��������������������������-�������������������������������?5��������?7�� ���������������������������������(23���������������?/��������?3�����������������

��,�� #���&�$���'����/�������

0(1���������&���'3�0�9 ��E��8F"8��1�����������������������������������,������6*6�

051�����&���'3�0�9 ��E��8F"8��1������'(�� �����������C#:B��8F"8���� ����������������.���� �����������������������-������������0'(1������������������������������ �������������*������:B����������!8#�0���������!��&1���������������������� ������������������������������� ������������������.���� �������������������������� �����������������.������������������+C�(�

061��������051���������� �������������������

Page 22: Starswitch O&M Manual

������������������������� ����������������������������� �����

��6

��

����������� ��������

��� ��� ��� ��� ���������

����� � ����� � ����� � ����� � ����� � ������ ������ ������ ������ ������ ����� � ����� � ����� � ����� � ����� �

�� ����������

����� ��

����� ������

����� ����

�� �� !�"##$�� ��%��

&'$�'�����(�##$��! �(���#$)' ��$�'���$

�� *'�&' +���� ,' ��$ #�� !�"

�� �� !�"�� ��%��

�'�����(��� � &'$���#$)' ��$�'���$ ' ���

&���#��'�#�'$+�' �(,' ��$ #

��6 !�7�����##�� �

�����������������������������������������������������&�>����������������������������������������������������-�����&������������8������8��!!�������������������������������������6*(���������������������������������������������������,������������������������������������������������������ �������������

0� ��������#����������1�$�$�&&���

Page 23: Starswitch O&M Manual

������������������������� ����������������������������� �����

��8

��

����������� ��������

!�"#�����(���)�*%�+����,�-��.����"��/�+���������

��8 ,���2������#

,������6*3�������������������������������� �����������������������������.�������������������������������������������������������� ����������������������������������������������� ���������;��������������

-�-�

5)�

-�

-�

-�

-�

-�

-�

5)�

5)�

5)�

5)�

����6:,7&+(;3$16,21

%$&.83&219(57(5

5)�287

5)�,1��&�19���

5)�287

5)�,1��&�19���

5)�287

5)�,1��&�19���

5)�287

5)�,1��&�19���

5)�,1��67%<�&219(57(5�

67%<�021,725

-� -�

21�/,1(�&219(57(5���

21�/,1(�&219(57(5���

21�/,1(�&219(57(5���21�/,1(�&219(57(5���

%$6,&�6:,7&+&21),*85$7,21

237,21$/�5)6:,7&+,1*

��

,1

-�

-�

67$5

&21752/

%2$5'

���,)�,1387��6<6���

72�%$&.83&219(57(5�,)�%$&.83�&219�

���,)�,1387��6<6���

���,)�,1387��6<6���

���,)�,1387��6<6���

67$1'%<021,725�021�

,)

&21752/

%2$5'

��7+52:

6:,7&+

&219(57(5����,)��&219���

&219(57(5����,)��&219���

&219(57(5����,)��&219���

&219(57(5����,)��&219���

Page 24: Starswitch O&M Manual

������������������������� ����������������������������� �����

���9

��

����������� ��������

�������������� ���������������

Page 25: Starswitch O&M Manual

������������������������� �������������������������� �����

�����������������������

����������������������� �������

��� ����������

������������� ������������������������������������������������� ����������������������������������������������������������������������������������������������������������������������� ������!���"�����#

���������������������������$������������������������%����������������������������������&'�����#�������������������������������� ����� ��������������������������������������� �����������������'��������������������������������������������������� ��#

�� �������������

��������������

����������������������������� ����� ����������������������������#������������������������������������������������������� ���#

�������������� ������� ��������������� ��������� ������ �� �

���������������������������� �������������������������������������� �������������������������������#

������������ ��������� ���������������������������� � ��� �� ��� ��� ������

�������������������������������������������������������������������������#

������������������������������������������������������� �����������������������#�(��������������������������������������������������#��� !�"#�$%& '��()�*+)�&,�($�+(�!()- !$"+�&�+��&./�+&"%).�+�������������������������������#

�����������������������

����������������������������������������������� ������������������)������������������������������������������������������������#

�����������������������������������

������������ ��������������������������������������������������������������������#������ �����������������������������������*��(+����������,������%&$#��������������������������������������-.&%/��-0&01�����-/&).���������#������������������������������������������������������������������������������������#���������������������������������������������������������������#2������������������� ���������������������)�������������������� ���#

Page 26: Starswitch O&M Manual

������������������������� ��

��� ��������������������

������������������������ �����

����� ����!�� ��������������������

�������������������� ������������������������������������������������������������������������������������������ ������#��������������������������������������������������������������������������'�����������#

� ���������������������������������

������������������� ������������������������������ ����������������������������������������������������������������#

������ �������������� ����!���"��#�$������"��

Page 27: Starswitch O&M Manual

���� ������������� ���� ��� ����

������������� ������������������������������������ ������� �� ��������������� ������������������������ ������������������������ ������ ������������� ��� ���� ��������������������� ��������������������������

������������� ������������ �� ��

������������� ��������� ���������������������������������������� ���� ������ ����������������� ��� ���������������������

����� ����� � ������������������������ �������

���� ���� ���� ���� ��������

�������� �������� �������� �������� ������������

�������� �������� �������� �������� ������������

��������� ��������� ��������� ��������� �������������

��������� ��������� ��������� ��������� �������������

�������� �������� �������� �������� ��������

� � �����

� � ���

� � ����������

� � �������

�� �����

� � �����

� � ���

! � ����������

"� � �������

�� �� �����

��

�� � ������

�� � ���

� � �����������

� � ��������

�� �� ������

��

!� � ������

"� � ���

�� � �����������

�� � ��������

�� �� ������

��

Page 28: Starswitch O&M Manual

������������������������� �������������������������� �����

�����������������������

� �%��&'�()����������������������������������%

����34����������������������������".��������������������������������567�������������� ��&�������������#

� �*�+��,"�������������������������������*

������������������� �����������������������������6�� ��� ��������������������������������������������������������������������")����������6�� ���� ���������"0#

������ �%������������ ��*�!���"��#�$������"��

���� ���� ���� ���� ��������

������ ������ ������ ������ ����������

������ � ������ � ������ � ������ � ������ �

� � �����

� � ���������

� �

�����

� �

� �

� � ���

! ! ��

"� "� #�

�� �� ��

�� �� ��

�� �� �����

� � ��

�� �� ����

Page 29: Starswitch O&M Manual

������������������������� ��

��� ��������������������

������������������������ �����

��" ����������������������

������������������������������������������*��(+���������������������������� ��������������#��������,������%&$������������������#�2����������������������������� ���������������,�������������������� ��������������#

�-�� �./��������+��������$��0����

��������������

*$+���� �����������������*0+��������������������� ����������������#*.+���� �����������������*0+���������������������������������� ���*)+������ �����#���� ��������������� ��#*)+���� �����������������*0+#*0+�5����������������������������������������� ���������������������*$+#*%+���� �����������*$+����������#

������������ ������

*$+�2������,8�����6��������������$�*$+�����������������������������������������������6!���������������������������������������������������#*.+�����������������9��������*0+���� ��������� �����������*$+��*.+����*)+���������� �����������#*)+��������������� ��������� ���������������������������������������#

��# �����������������������$���������%�&'������

������ ��������,���������,%�*9+�������������25���,�����������,$&0��*$$+������������������&'�����#������������������������� ����������� �����������������������������������#����������%������������������������������#

�1�� .����������.����������.-

������������������������������

*$+����������������������������������������������������������������������������� �����#*)+��������������������*7+��������*$1+��� ������� ���������������������������#*0+�������������������������"7�����������������������,8�����6��������������$�*$+���������������#

�������������

*$+���� �����������������*7+��������*$1+��������������������,%����������#*)+�5�����������������"7�����������������������,8�����6��������������$�*$+#*0+���� ���,%����������#

Page 30: Starswitch O&M Manual

������������������������� �������������������������� �����

�����������������������

�1�% �!2��.������������.��.

������������������������������

*$+������������������������������������������������������������������������������ �����#*)+�2������������*$)+�������������6��� ���*$.+�����������������������������������������������������������#*0+������������������������������������������*"%&"9+�����������������������,8�����6�������������$����������������#

�������������

*$+���� ������������6��� ���*$.+�������������������*$)+���������������������������������#*)+�5�������������*"%&"9+��������������������������,8�����6��������������$#*0+���� ������������������#

��(��������

���������������������������(�*�$+���������4���������������������������������������������������#��������������������������������,����������������������� ��������������������$����������� ������������������0&%#$�������������#���������������������������������������������� ���������������������$���������������#���������������������������������������������������������������������������������������#

�3�� .�"�������������

����������������������������������������������������������������*2:�+��������������������������*,�(��+��������#

*�+�2:��&����������35������������������2:��������������������������������������������������������� ������#

*�+�,�(���&��������������������������������������������������������*�,����,+������������������������������������������������������������������������������������������������ ������������� ������������������$#

Page 31: Starswitch O&M Manual

������������������������� ��

��� ��������������������

������������������������ �����

�������������� ���������������

Page 32: Starswitch O&M Manual

������������������������� ��������������������������� �����

������������������� ����

������������ ���������������������

��� ����������

������������� ���������������������������������������������������������������������������������������������������������������������������������������������������������������������������� ����!�������������"������#���$�����%����������� ����&�'���������������������������������������������������������%�������������������������������������������������������������������� ����&�'%

�� �����������������������������

������������������������������������ ����������������������������������������%����������������������������������������������������������%

(')�������'����*�������+�������� ��������%�%�','��������%����������������������������������� ��������� �������������-���������������������� ��������������"���� �����������%

(*)�������.����/����������������������+����������','���',/%��������������������������������������������� �������������-��������������������������� ���������������"���� ����������%

(.)�������&����0����������������-���������+������������������',1%����������������������� ������������������+���������������"������������������� ����%

��� ������������������������ �

������

'

*

.

/

&

0

� �������������

&2�3��������������','�#�4+�������

5&�3��������������','�#�4+�������

&2�3��������������',/��������

5&�3��������������',/��������

&2�3��������������',/�4+�����������

5&�3��������������4+�����������

� ��������

�''506�#&2

�''506�#5&

�''506��&2

�''506��5&

�''506�4&2

�''506�45&

���������

�7�

�7�

�7�

�7�

�7�

�7�

Page 33: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� ���������������� ����

��� � ������������!����������������������"�������

����� ��������������������� �������������

3������� ����������������������-���������������������� ������������',/%�����������0������ �������+������%

��� ���������������������������� �������������

����� ��!������������ �������������

8���������9:����������������������������������������������������������������� �������� ������%�����������0������� �������+������%

��� ����"�����!������������ �������������

������� ������� ������� ������� ������� ����� ����� ����� ����� ����� ����� ���� �� ����� ���� �� ����� ���� �� ����� ���� �� ����� ���� �� ����� �� ����� �� ����� �� ����� �� ����� �� ������� ������� ������� ������� �������

�� ��������� ��� !!"#$% �&�

'�(��)������*

�� $$ �+������������ ���,-���$��.

$

�� /$ ������� �+��* $

�� #$ �� �� /

������� ������� ������� ������� ������� ����� ����� ����� ����� ����� ����� ���� �� ����� ���� �� ����� ���� �� ����� ���� �� ����� ���� �� ����� �� ����� �� ����� �� ����� �� ����� �� ������� ������� ������� ������� �������

�� ������� �0��� ���� ��� "!"#$% �&�

'�(��)������*

�� ! ����� �0��� ���� ���,���.�+�����

$

�� " �� �� -

�� 1$ �� -

Page 34: Starswitch O&M Manual

������������������������� ��������������������������� �����

������������������� ����

�#$ ������!����������������������"�������

������&�/����������������������������������������������������������������������%�����������;�����������������������������������������������������������������������%��������������������"�����������������������������������&�*����&�.%�������*�5��������������������%

� ���������� �!"�#���$%�� ����&���

������� ������� ������� ������� ������� ����� ����� ����� ����� ����� ����� ���� �� ����� ���� �� ����� ���� �� ����� ���� �� ����� ���� �� ����� �� ����� �� ����� �� ����� �� ����� �� ������� ������� ������� ������� �������

�� 2������% ���31��+��)���4&����$'$ 1���"56$$* �&�

$ $ ) ��7+� ��*����31� 1��"�6$$7 $

�� 2������% ���3�6�+��)���4&����$'$ �6��"56$$* �&�

$ $ ) ��7+� ��*����3�6 �6�"�6$$7 $

�� 2������% ���31� �++� ��*-'$ 1�*�"56$$* �&�

$ ) ��7+� ��*����31� 1��$""#$% $

�� 2������% ���3�6 �++� ��*-'$ �6*�"56$$* �&�

$ ) ��7+� ��*����3�6 �6�$""#$% $

�� 2������% ���31�������������4&-'$ 1�&�"56$$* �&�

$ $ ) ��7+� ��*����31� 1��$""#$% $

�� 2������% ���3�6������������4&-'$ �6&�"56$$* �&�

$ ) ��7+� ��*����3�6 �6�$""#$% $

�� / �� ������* 166$$* $

�� # �� �+��*8�(�� 7 6!"#$% $

�� - 95$��4/#�58)��:���8�� �� -�#5-/$% !

�� � ������;������*8�(�� 7 5#!$$7 /

�� 5 9/�$4/#�1$8)��:���8�� �� #5�6�"$��; 5

�� 6 )����+����� �����+������ � #6!$$7 $

Page 35: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� ���������������� ����

�������������� ���������������

Page 36: Starswitch O&M Manual

������������������������� ��������������������������� �����

��������������

������������ ���������������������

�� ����������

������������� ���������������������������� ��������������������������������������������������������������������������������������������������������� ������!���"�����#�$����������������������������%������������%&'�%(�����������)���������������������������������������������������)������������ ������*�����'�����+#�����������������������������������������������������������������������������������������������������������������)�������#��������������� ������������������������������� ����� � ������� ����������������������������������� ��� ����������������������������������������������� !" �����#�����$��������������� �%

��� ��������� ���������� ���������������������

���������������������������������������������������&,&����� �����#�%������-'&*�+����������������������������� ���������������.����������)�����������(�������%����������%(�������-'&*�+�����������)������������ ��������������������������������������������'������#������������������������������/����'���������������������"&�����������������������������)������������������������#

��� ������������ �� ����� ������

�������������������&,0����� ���������������#�1�������%������������%&'�%(�����������)������������������������������#�����������(���������������#

��� �������������� �� � �!��!��"�������#�$����%� &���������� ������

��&,0����� ����������������������������������������������#�2�����%����������� ��������������������������������(�������%����������%(���������������������������������������'����������� �����*����������+#

��� �������������� �� �'��!��"����������� ������

��&,0����� ��������������������%��������������������������#���('����������� ����*����������+�����������)������������������������������#��%&'�%(��������������)����������������������#

��( ��)����������� �� �'��!��"����������� ����(�

��&,3����� ��������������������%��������������������������#���3'����������� ����*����������+�����������)������������������������������#��%&'�%(��������������)����������������������#���������������������)���������������������������,

*&+������.�����������"4#

*5+�����.���������������������/1!�������&,0���������������67��1!$�������.�����������#

Page 37: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� �����������

��������������������������� �� �"�������*+�'��*,�'+���&

����������������-!�� ����������������� �� �"�������*+�'��*,�'+���&

5)� 5)�

5)�

5)�

6<6

67%<

021

-�-�

-� -�

67$1'%<,1387

&219��6<6�� 6<6�� &219�� &219��6<6�� 6<6�� &219�� %8�&219 021�

,)�,1387

-�

-�

-�

-�

����������

��� ������������

����������70

-� -� -�

-�-�

-� -�

67$1'%<,1387

,)�,1387

-�

-�

-�

-�

����������

��� ������������

����������70

67%<

0216<6

-� -�-�

-�

-�

-�

3:5

)$8/7

3:5

)$8/7

&219��6<6�� 6<6�� &219�� &219��6<6�� 6<6�� &219�� %8�&219021�

Page 38: Starswitch O&M Manual

������������������������� ��������������������������� �����

��������������

������������������������� �� �"�������*+�'��*,�'+���&

5)�

5)�

6<6���

67%<021

-�-�

-� -�

67$1'%<,1387

,)�,1387���

-�

-�

-�

-�

����������

��� ������������

����������70

-� -� -�

-�

-�

3:5

)$8/7

5)� 5)�

-� -�

-�

-�

�����������

-�

-� -�

-�

-�

�����������-�

,)�,1387���

,)�,1387���

,)�,1387���

%8�&219 021�

-� -�

-�

-�

�����������-�

6<6��� 6<6���

5)�

6<6���

&219�� &219�� &219��&219��6<6�� 6<6�� 6<6�� 6<6��

Page 39: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� �����������

��������������������������� �� �"�������*+�'��*,�'+���&��������������,� �!��!��"�������#�$���%� &�����

5)�

-�-�

-� -�

67$1'%<,1387

,)����287

-�

-�

-�

-�

����������

��� ������������

����������70

-� -� -�

-�

-�

3:5

)$8/7

-� -�

-�

-�

�����������

-�

-� -�

-�

-�

�����������-�

,)����287

,)����287

,)����287

%8�&219 021�

-� -�

-�

-�

�����������-�

&219�� &219�� &219��

�����

����������

����������

��������

��������

��������

��������

������������������������������������������ ���!���!�������������������!��"�������������!������������������!��������� ����#

6<6�� &219�� 6<6�� 6<6�� 6<6��

Page 40: Starswitch O&M Manual

������������������������� ��������������������������� �����

��������������

��������������������������� �� �"�������*+�'��*,�'+���&��,���'��!��"������

-�-�

-� -�

67$1'%<,1387

,)����287

-�

-�

-�

-�

����������

��� ������������

����������70

-� -� -�

-�

-�

3:5

)$8/7

-� -�

-�

-�

�����������

-�

-� -�

-�

-�

�����������-�

,)����287

,)����287

,)����287

%8�&219 021�

-� -�

-�

-�

�����������-�

&219�� &219�� &219��&219��

��������

��������

��������

��������

���������������������������������������������� ��� ��!

��������

6<6�� 6<6�� 6<6�� 6<6��

Page 41: Starswitch O&M Manual

������������������������� ��������������������������� �����

��� �����������

���������������)����������� �� �"�������*+�'��*,�'+���&��,���'��!��"������

-� -�

-� -�

,)����287

-�

-�

-�

-�

&219(57(5���

%$&.83�&219(57(5

67$5VZLWFK70

-� -� -�

-�

-�

3:5)$8/7

-� -�-�

-�

&219(57(5���

-�

-� -�-�

-�

&219(57(5���-�

,)����287

,)����287

,)����287%8�&219 021�

-� -�-�

-�

&219(57(5���-�

&219�� &219�� &219��&219��

5)�,1387

5)�,1387

5)�,1387

5)�,1387

127(��5)�,13876�$5(�)520�$�&200216<67(0�32:(5�',9,'(5�

5)�,1387

6<6�� 6<6�� 6<6�� 6<6��

-� -�

67$1'%<,1387

,)����287

-�

-�

&219(57(5���

67$5VZLWFK70

-� -� -�

-�

3:5)$8/7

-� -�-�

-�

&219(57(5���

-�

-� -�-�

-�

&219(57(5���-�

,)����287

,)����287

,)����287%8�&219 021�

-� -�-�

-�

&219(57(5���

-�

&219�� &219�� &219��&219��

5)�,1387

5)�,1387

5)�,1387

5)�,1387

6<6�� 6<6�� 6<6�� 6<6��

������������� ��������������

�������������

���������������� �������������� �������