SERVICE MANUAL US Model - sportsbil.comsportsbil.com/sony/STR/STR-V/STR-V220_.pdfMANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ... Location of Parts and Controls 1 1/u button 2 VIDEO

– 1 –

MICROFILM

US Model

SPECIFICATIONS

SERVICE MANUAL

FM STEREO/FM-AM RECEIVER

STR-V220

— Continued on next page —

– 2 –

SAFETY-RELATED COMPONENT WARNING !!

COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE

WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN

THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.

REPLACE THESE COMPONENTS WITH SONY PARTS

WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS

MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

SAFETY CHECK-OUT

After correcting the original service problem, perform the follow-ing safety checks before releasing the set to the customer:Check the antenna terminals, metal trim, “metallized” knobs, screws,and all other exposed metal parts for AC leakage. Check leakage asdescribed below.

LEAKAGEThe AC leakage from any exposed metal part to earth Ground andfrom all exposed metal parts to any exposed metal part having areturn to chassis, must not exceed 0.5 mA (500 microampers). Leak-age current can be measured by any one of three methods.1. A commercial leakage tester, such as the Simpson 229 or RCA

WT-540A. Follow the manufacturers’ instructions to use theseinstruments.

2. A battery-operated AC milliammeter. The Data Precision 245digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of a VOMor battery-operated AC voltmeter. The “limit” indication is 0.75V, so analog meters must have an accurate low-voltage scale.The Simpson 250 and Sanwa SH-63Trd are examples of a pas-sive VOM that is suitable. Nearly all battery operated digitalmultimeters that have a 2V AC range are suitable. (See Fig. A)

Fig. A. Using an AC voltmeter to check AC leakage.

0.15µF

To Exposed MetalParts on Set

1.5kΩACvoltmeter(0.75V)

Earth Ground

– 3 –

TABLE OF CONTENTS

SECTION 1SERVICING NOTE

1. SERVICING NOTE .......................................................... 3

2. GENERAL .......................................................................... 4

3. ELECTRICAL BLOCK CHECKING...................... 5

4. DIAGRAMS4-1. Circuit Boards Location ........................................................ 64-2. Schematic Diagram – Main (1/3) Section – .......................... 74-3. Schematic Diagram – Main (2/3) Section – .......................... 94-4. Schematic Diagram – Main (3/3) Section – ........................ 114-5. Printed Wiring Board – Main Section – .............................. 13

FACTORY SETMode which sets the preset settings of the unit to that at shipment.

Procedure:While pressing the VIDEO button and TV/SAT button together, press the 1/u button to turn on the power.“FACTORY” will be displayed and factory settings executed.

INITIALIZATIONMode which erases all the preset settings of the unit.Use this mode when returning the unit to the customer.

Procedure:While pressing the VIDEO button, TV/SAT button, and TAPE/MD button together, press the 1/u button to turn on the power.“INITIAL” will be displayed and initialization executed.

FLUORESCENT INDICATOR TUBE LIGHTING CHECKMode which lights up the whole fluorescent indicator tube or partially.

Procedure:While pressing the TV/SAT button and TAPE/MD button together, press the 1/u button to turn on the power.The fluorescent indicator tube will light up in about 0.5 seconds, and then start to light up partially. After partial lighting completes, theBASS BOOST indicator will light up, “FINISH” will be displayed, indicating that fluorescent indicator tube lighting check has completed.

SWITCHING OF 9 kHz/10 kHz AM CHANNEL STEPThe AM channels of this unit can be switched between 9 kHz and 10 kHz.

Procedure:Set FUNCTION to AM and turn off the power.While pressing the TUNING + button, press the 1/u button to turn on the power.“9 k STEP” or “10 k STEP” will be displayed, and the channel step will be switched.

4-6. Printed Wiring Board – Display Section – .......................... 154-7. Schematic Diagram – Display Section – ............................ 174-8. Schematic Diagram – Panel Section – ................................ 194-9. Printed Wiring Board – Panel Section – .............................. 214-10. IC Block Diagrams ........................................................... 234-11. IC Pin Functions ............................................................... 26

5. EXPLODED VIEWS5-1. Case Section ........................................................................ 285-2. Chassis Section ................................................................... 29

6. ELECTRICAL PARTS LIST ........................................ 30

– 4 –

Front Panel Descriptions

SECTION 2GENERAL

Location of Parts and Controls

1 1/u button2 VIDEO button3 TV/SAT button4 TAPE/MD button5 CD button6 TUNER button7 BASS BOOST indicator8 MASTER VOLUME knob9 BALANCE knob

7 82 3 4 651

1617 1011131415 12 918192122232425 20

10 TREBLE knob11 BASS knob12 SURROUND ON/OFF button13 CENTER MODE button14 EFFECT/DELAY TIME button15 SURROUND MODE button16 Numeral (1 to 0) button17 Display window18 DIRECT button

19 SHIFT button20 MEMORY button21 AM button22 TUNING + button23 FM button24 TUNING – button25 PHONES jack

This section is extracted frominstruction manual.

STR-V220SECTION 4DIAGRAMS

4-1. CIRCUIT BOARDS LOCATION

THIS NOTE IS COMMON FOR PRINTED WIRINGBOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printedin each block.)

For schematic diagrams.Note:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• ¢ : internal component.• 2 : nonflammable resistor.• C : panel designation.

For printed wiring boards.Note:• X : parts extracted from the component side.• b : Pattern of the conductor side.

• U : B+ Line.• V : B– Line.• Voltages and waveforms are dc with respect to ground

under no-signal (detuned) conditions.no mark : FM

WAVEFORMS

1 2

IC201 #¢ X1IC301 #™

Note: The components identified by mark ! or dotted linewith mark ! are critical for safety.Replace only with part number specified.

• Indication of transistor

CThese are omitted

EB

8MHz

4.8Vp-p

4.19MHz

5.4Vp-p

Caution:Pattern face side: Parts on the pattern face side seen from(Conductor Side) the pattern face are indicated.Parts face side: Parts on the parts face side seen from(Component Side) the parts face are indicated.

• Voltages are taken with a VOM (Input impedance 10 MΩ).Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.F : FM

SECONDARY board

PRIMARY board

STANDBY board

MAIN board

VOL-TONE board

DISPLAY board

PHONE JACK board

KEY board

MAIN (1/3) SECTION DISPLAY SECTION

– 5 – – 6 –

SECTION 3ELECTRICAL BLOCK CHECKING

ADJUSTING THE FM/SD SIGNAL SENSITIVITY

Setting:

oscilloscope

Main board

TP (IC501 6 pin)

Procedure:1. Set the SSG output level to 26 dB and input the signal.2. Adjust SFR501 so that the oscilloscope level becomes 0V.3. Raise the SSG output level slightly (max. 35 dB) when the ad-

justment in step 2 fails, and repeat steps 1 and 2.NOTE: If the adjustment cannot be performed even when set to 35

dB, the sensitivity may be faulty, etc. Check the antennaterminal connection, FM front end and IF circuit, etc. andperform adjustments again.

FM ANTENNA (75Ω)FM RF SSG

Set

Carrier frequency: 98 MHzModulation: AUDIO 1 kHz,

75 kHz deviation (100%)Output level: 26 dB (at 75 Ω open) (MAX 35 dB)

STR-V220

– 7 – – 8 –

4-2. SCHEMATIC DIAGRAM – MAIN (1/3) SECTION –• See page 6 for Waveforms.• See page 13 for Printed Wiring Board.• See page 23 for IC Block Diagrams.

(Page 19)

(Page 11)

(Page 11)

(Page 17)

STR-V220

– 9 – – 10 –

4-3. SCHEMATIC DIAGRAM – MAIN (2/3) SECTION –• See page 13 for Printed Wiring Board.

(Page 11)

(Page 20)

STR-V220

– 11 – – 12 –

4-4. SCHEMATIC DIAGRAM – MAIN (3/3) SECTION –• See page 24 for IC Block Diagrams.

(Page 9, 10)

(Page 8)

(Page 8)

STR-V220

JW269

J402

JW133 JW123

32

E

E

11

1

CB

1123

1

22

1

22

1

1 5

4

1

E

E

E

E

4

8

5

21

2223

E

E1617

32

33

48 49

64

1

E

1

4

8

289 1

1

15

1

1

11

22

12 15

30

16

30

16

21

67

5

E E

E

EE

E E

E

E

E

E

E

E

E

MIXAUDIO OUT

AUDIOIN

AUDIOOUT

TA/SATAUDIO IN

RECONT INCD IN

AMFM

75ΩFM

300Ω LRLR

LR

CENTER

REAR

SPEAKER

FRONT

LRLRLRLRLR

VIDEO

ANTENNA

TAPE/MD

09 6

E

54321

D

C

B

A

(CHASSIS)(CHASSIS)

(CHASSIS)

MAIN BOARD

11(11)1-673-709-C

B

A

4

1

3C806

R823

R824

JW100R830

Q809

R831D818 JW099JW098

D822

D823C812C811

R810

R811D804

JW110

JW109

C809

R804

C801

JW108D801

C802

JW107

JW106

C807

Q801

C814

C813

JW10

4

JW10

5

JW11

1

CN80

1

JW15

0JW

151

JW15

2

C651

Q670

R656

RY80

1

G202

C810

C808

JW103JW102JW101

IC802IC

801

D820

D821

C805

C751

R752R652

JW149JW148C653

R653C654R654

C655JW162

R660

R671

JW145R721R710

JW169JW142

C712

C707

C706

R706R701

Q793

C796JW182JW181

JW193JW180JW179 CNS204

C701C702

C703

R702R703

R299R298

JW137C413

R705

R711

R707

JW14

0IC

701

R704

JW18

4

JW18

5JW

186

JW18

7JW

183

JW18

8JW

189

R441

R442

R435

C434 C4

35JW

190

JW19

1

JW19

2JW19

4 C309

L301R3

01C3

53

C354

R305

R302

R353

R303

R354

JW13

9

C704

C416

JW13

6

C415

R673C670

R674D670

R670JW271JW272

JW273

JW274

JW275JW206

JW204

JW203

JW201

JW199JW200

C329C331

C328

C327

C325IC301

C324

R465

C343

C342

R470

R415

C326

C318C365

C363

JW237 R363

R300CX301

C302

D817C305

C304C303

JW235

C308C307JW236

C822

R825

C823G203

Q808B C E

C335C334C323

R420

JW188

JW197

JW196

CNS701

C330C350

C362

C338Q308

Q307

R308C355R355

R309

C356

R352JW243C359

R361

R360C310

R304

C360

R356

R362R359

C340

C341

C339

JW244C322

C317IC302

R357C315

R307C314

C312

JW238

R306

Q304

Q303 C313C306

C316C311

JW239

C344

JW24

0

JW24

7

C345

C349

C348

C346

C342

C332

C333

C351

C352

R651C652

C752R751Q794

C720R723

Q720D720R720R672

JW257

UCCGNDANT

ANT

IF OUT

GNDOSC

UT

C501

C507

R452

JW23

4JW

270

JW24

2

R407

R457

R406

R456

R405

R455

R404

R454

R403

R453

R402

R408

R458

JW26

4

TM001

JW26

1R5

04JW

266

JW25

9JW

268

R511

CF501

C502

R512

C511

SFR501

C509

G201

OSC

ANT

T502

R514C508

JW256

JW250

R513

C517

C512

C515

R537

R529

C539

C531R535

R531

JW24

8JW

249

T505

C533

CNS301

C534

C540

T504

R532

R536

C532

R521C528

C530

IC50

1

C514

JW25

1

C516

C505

R505

FE50

1

R506

R507C506

CF502

R508

Q501

Q503

JW253

C549

C518

CD501

T503

C520

C519

C544

R544

R501

C543

R546

R545JW

265

JW26

3

JW262R547

C548C503C542R548

R549C541

R550

JW258

JW229

D503

R554

R561JW255

JW254

TP6

JW218

R632R730

D723

JW138

D725

R734J253J403

TM601

X501

JW233 JW175

JW176

JW232

JW231

JW177

JW178R410

C411C412

JW171

IC401JW228

JW224

JW225JW226

JW227

JW222

JW223

JW220

JW219

JW221

R414

C408C406

R460

IC50

2

R459

R558

R557

R556

C545

R559

R541

JW174

JW173JW172

R617 R667

C661

R725

C611

JW14

3

JW17

0

R668R618

L651

L601

JW13

5

JW13

4

RY601

R631 L751

R718 JW13

0R7

81

C791

R768

L701

R792

JW132

Q791

D793

R630

Q610

JW13

1D6

10

D792

R731

JW12

9

JW12

8JW

127

IC95

0

R955

R957

Q710

R956

R951

D710

JW124JW125JW126

R717

R767

C711

C761

Q951

R791

R782

R783

R733

R732

R719R772

R622R619

R954

R960

R953

R950

JW114

C951

C955

R952

JW121JW120

JW296

C950

C954 R8

22

R821

C952

C953 Q9

02D810

D811

C821

C820

R958

D812

D815

D814

D813

JW25

2

C521

C523

R515

R516

R517

C538

C525

C526

C524

Q505

R538

Q504

R519

JW212

JW209JW205

JW211

JW208

JW207

C536

C522

C535

SFR502

C527

JW217JW216

JW214JW215

C537

R542

R543

D722

R724Q721

Q722 C722

C604

R604

D724

R727

Q723

JW23

0

D721

C721

C606

C601

C602

C612

C757

C603R603

R602R606

R605

R610R621

JW160JW165

R771

R756

R760

R757

R755

C756

C770C620

R773R623

Q620 Q770

D620R620R774

JW280

R770

R772D770

C797

C754R754

JW158R753

C753

R601

JW16

8JW

141

JW16

6JW

163

IC70

2JW278

JW276JW277 JW154

JW11

9

JW11

7

JW11

8JW

115

JW11

6

JW113

R803

JW11

2

C804

C803

E C B

SS

RY70

1

JW12

2

JW21

3

(Page 21)

(Page 21)

(Page 15)

– 13 – – 14 –

4-5. PRINTED WIRING BOARD – MAIN SECTION –• See page 6 for Circuit Boards Location.

Ref. No. Location

• SemiconductorLocation

1-673-705-11

(11)

SONY1-673-705-11STANDBY

T902POWER TRANSFORMER

1

4

N

N

L

R901

(CHASSIS)ACIN

D816

RY90

1

CNP8

02

CNJ9

02

CNP9

03CN

P901

G900

2

1

ACOUTLET

STANDBY BOARD

09 1

B

2 3

A

JW29

7

SONY

PHON

E JA

CK1-

673-

706-

11

J741

1 5

R793

1-673-706-

D791

C792

CNP702

V M R L B

4

11(11)

PHONEJACK

PHONE JACK BOARD

091 2

A

TP901POWERTRANSFORMER

JW29

5

JW29

4

JW29

3

JW29

2

JW29

1

JW29

0CN

P801

SONYSECONDARY

1-673-707-111-073-707-

1

11

SONY1-673-708-11

PRIMARYF901

CNP9

02

NL

1-673-708-

3

211

(11)

11(11)

SECONDARYBOARD

09

A

1 2 3

PRIMARY BOARD

09

A

1 2

D503 B-2D610 B-5D620 C-3D670 D-3D710 B-5D720 D-3D721 B-4D722 B-4D723 A-4D724 B-4D725 A-4D770 C-3D792 B-5D793 A-5D801 E-6D802 D-6D804 E-5D810 B-6D811 B-6D812 B-6D813 B-6D814 A-6D815 A-6D817 E-1D818 E-6D820 E-6D821 E-6D822 E-6D823 E-6

IC301 E-2IC302 D-2IC401 B-3IC501 C-2IC502 B-2IC701 E-4IC702 C-4IC801 E-6IC802 E-6IC950 B-6

Q303 E-1Q304 E-1Q307 D-1Q308 D-2Q501 B-2Q503 B-2Q504 C-2Q505 C-2Q610 B-5Q620 C-3Q670 D-3Q710 B-5Q720 D-3Q721 B-4Q722 B-4Q723 B-4Q770 C-4Q791 A-5Q793 E-3Q794 D-4Q801 E-5Q802 B-6Q808 E-2Q809 E-6Q951 B-6

STR-V220

– 15 – – 16 –

4-6. PRINTED WIRING BOARD – DISPLAY SECTION –• See page 6 for Circuit Boards Location.

Ref. No. Location

• SemiconductorLocation

D201 B-3D202 A-3D203 A-3D204 A-6D213 C-8D214 C-8D225 C-8D231 A-7

IC201 B-5IC202 B-3IC203 C-8

Q201 A-7Q202 A-7Q231 A-7

JW96

JW85

JW86

JW87

JW90

JW12

9

JW95

JW94

JW93

JW92

JW91

JW39

JW31

JW30

JW21

JW20

JW19

JW29

JW28

JW27

JW36

JW35

JW34

JW33

JW32

JW22JW23JW24JW25JW26JW37JW38

JW4JW5JW3

JW82

JW65JW66JW67JW68

JW51

JW10

2

JW50

JW48

JW47

JW46

JW61

JW62

JW57

JW59

JW63

JW69 JW

2

JW45

JW52

JW49

JW9

JW8

JW7

JW1

JW53

JW60

JW75

JW74

JW73

JW11

JW71

JW76

JW64

JW70

JW72

JW10

4

JW58

JW43JW42

JW44

JW56

JW98

JW14JW

13

JW41

JW40

JW81

JW77

JW80

JW6

JW103 JW12JW89

JW99

JW105

JW100

JW10

1

JW10

JW16

JW15

JW18

JW17

C425

R420

JW88 R470

JW97 JW84

R474

C474

C473

R473

C423

R423R471

C471

R424C424

RU421RU422RU423

C421

R421 JW55JW54

C207

C422

C472

R422

R226R227

S218 S219

S217 S238

R472

IC202C2

05R2

05

D203

R202

D201

D202

L401

C201

R225

R224R223R222R221

C202

RR2

JW78 JW79

CNS201

1

X201

R201R270

6580

25 40

64

1

4124

R204

R286

C204

C203

D204Q201

Q202

Q231D231

R203

R207

C206

R231

R284

R283

R228

R232

R233 R234

R200

R235

CNP205

S200

S229

S215 S214

S210 S209

S216

D214D213D225

R216

R214R213R212R211

SONY1-673-693-11

DISPLAY

IC20

1

RR135 FL201

1

IC203

11(11)

09

A

C

B

108 96 74 51 2 3

BASS

DC

F E

1 2 3 4 5 6 7 8 9 10 11

1-673-693-

TREBLEBALANCE

18

13

19

232 22 E

E

E

EFFECT,DELAY TIME

SET UP

MODEON/OFF SURROUND

MEMORY

FMAM

SHIFT

TUNING

1/u

DISPLAY BOARD

(Page 21) (Page 21)

(Page 13) (Page 22)

STR-V220

– 17 – – 18 –

4-7. SCHEMATIC DIAGRAM – DISPLAY SECTION –• See page 6 for Waveforms.• See page 25 for IC Block Diagrams.• See page 26 for IC Pin Function.

(Page 7)

(Page 19)

(Page 20)

(Page 20)

STR-V220

– 19 – – 20 –

4-8. SCHEMATIC DIAGRAM – PANEL SECTION –

(Page 17)

(Page 8) (Page 9)

(Page 18)

(Page 18)

STR-V220

– 21 – – 22 –

4-9. PRINTED WIRING BOARD – PANEL SECTION –• See page 6 for Circuit Boards Location.

1 2 3

C

B

A

09

1 92 8

M

MASTERVOLUME

JW108

654321 1110987

1 72 6

1 4

8 5

EE

E E

1-673-692-11

(11)G G G

JW109

JW096

JW098

JW099

JW097

CNS402

C475

JW83

JW12

4

JW11

6

C492

D421

R483

R438

C433C4

32 JW12

3

JW115

CN5403

IC404

JW11

4

JW12

7

JW11

1

JW11

0

JW11

3JW

112

JW11

7

JW12

0

JW12

1

JW12

5

JW12

6

R482

R484

Q402

C479

C478

R481R4

64R4

91

Q451

C447

C426

C476

R477

R427

R492

JW12

8

R432

R434

Q452

C429

C428

R431

R433

RR46

9

C427

R441Q4

01JW

118

JW11

9R430

R425

C470

R476

R475R480

C430 C431 RU404

C420R426

RO LI RI

DBFB

UP DWN

LO G

E

B

F

A

SONY

1-67

3-69

2-11

VR-T

ONE

VOL-TONE BOARD

(Page 13)

(Page 15) (Page 15)

(Page 13)

61

D238

K A

BASS BOOST

TUNERS222

TAPE/MDS239

VIDEOS223

DIRECTS237

TV/SATS231

CDS221

0S228

9S227

8S226

7S225

6S224

5S236

4S235

3S234

2S233

1S232

1-673-694-11

(11)

R242 R241 R240 R239

R237

R249 R248 R247

CNS205

R243

R281

R282

JW130

R280

R238

R244

R246

D1

092 3 4 5 6

A

SONY1-673-694-11

KEY

KEY BOARD

(Page 16)

STR-V220

– 23 – – 24 –

4-10. IC BLOCK DIAGRAMS• Main section

IC301 LV1035M

STRIM

OSC

VOL

VOL

VCA VCAA

B

A

B

VCA VCA

VCA VCA VCA VCA

DEVNOISEGEN

NOISEFILTER

BPFCONTROL

CHCONTROL

BPF

V REF

STRIM

SMODE

RECT

RECT

DCCUT

B NR

OUTFILTER

DATADECODERVOL/

MUTE

BPF

RECT

LOGICFF

LOGICFF RECT

C MODE

LOGIC LOGIC

S

S

S

A A S

B

B B

A

B

CB

LR

A A

A

B

A

B

A

BA

B

A

B

S

VDD

PCM

PCMCONTROL

SRAM

INFILTER

R

L

C

S

R

A

B

A

B

AB

ABL

L

R

L

R

R BPF2

R BPF1

S DC OUTC DC OUTR DC OUTL DC OUT

V REFVCC

C OUT

S OUT

R OUT

L OUT

GND

L IN

R IN

S IN

DELA

Y OU

T

L BPF2

L BPF1

RT IN

LT IN

DC CUT

C MODE

GNDNS BPF1

OSC

NS BPF2

ENABLE

DATA

CLK

DATACLK

VSS

OSC

OSC

VDD

A/DNSD/A

DC C

UT

DC C

UTVCC

DET

IREF

GND

S-OU

T

R-OU

T

L-OU

T

L RE

CT

DC C

UT4

R RE

CT

DC C

UT3

L BP

F3

VLR

TH

VLR

1

VLR

2

VCS

2

VCS

1

VCS

TH

L+R

RECT

DC C

UT2

L-R

RECT

DC C

UT1

R BP

F3

64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49

48

47

46

45

44

43

4140

39

38

37

36

3534

33

1817

16

15

14

13

12

11

10

9

7

3456

1

2

8

19 20 21 22 23 24 25 26 27 28 29 30 31 32

42

IC401 LC7822

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

30

29

28

27

26

25

24

23

22

21

20

19

18

17

16

CONT

ROL LATCH

SHIFT RESISTOR

LEVEL SHIFT

CL

DI

CE

VEE

OUT

IN

OUT

IN

OUT

IN

VSS

S

RESET

VDD

OUT

ININ

OUT

IN

OUT

IN

IC950 NJM2103D

1

2

3

4 5

6

7

8

V+

VSB/SESIN

VSA

RESET

GND

OUTC

VSC

CR

VREF

+ –

– +

–+–+

Q

R S

IC501 LA1838

ALC

BUFF

AMOSC

AMMIX

AMRF. AMP

AGC

IF DET

S-CURVE

AM/FMIF

BUFF

REG

TUNINGDRIVE

GND VCC

PILOTDET

VCO

FF

STEREODRIVE

STEREOSW

MUTE

FF FF

FMIF

FMDET

DECODERANTI BIRDIE

1 2 3 4 5 6 7 98

20 19 18 17 16

15141110

212223242527 262930

OSC.

BUFF

FM-S

D.AD

J

AM-O

SC

REG

FM-A

FC

AM-R

F-IN

AGC

MPX

-IN

FM-D

ET O

UT

AM-D

ET O

UT

OUT

L

OUT

R

AMP-

IN L

AMP-

IN R

AMP

OUT

R

AMP

OUT

L

VCO-

STOP

STER

EO

AM/F

M

AM. S

D

FM. S

D

AM. S

D AD

J

IF-B

UFF

MUT

E

VCC

FM D

ET

FM-IN

AM-M

IXFM

-IF

AM-IF

GND

TUNE

D

S METERFM S METER

AM

COMPSD

AM

12 13

PHASEDET

28

– 25 –

• Display section

IC202 BA6208

1 2 3 4 5 6 7 8 9

NC

OUTP

UT 2

Vcc

GND

NC

INPU

T 2

INPU

T 1

NC

MOTORDRIVE

MOTORDRIVE

REG

SWITCH

SWITCH

OUTP

UT1

IC502 LC72131

PHASEDETECTOR

CHARGE PUMP

SWALLOW COUNTER1/16, 1/17 4BITS

12BITSPROGRAMMABLE

DIVIDER

UNIVERSALCOUNTER

REFERENCEDIVIDER

POWERON

RESET1/2

C2BI/F

1 3 4 5 6 8 10 11

18 17 16 15 12

13

19202122

XOUT

VSS

AOUT

AIN

PD VDD

FMIN

AMIN

XIN

D OU

TS

CLK

S DA

TACE

IFIN

I/O IN

I/O IN

MON

OFM

/AM

UNLOCKDETECTOR

DATA SHIFT REGISTER LATCH

– 26 –

Pin No. Pin Name I/O Function

• IC201 uPD78044FGF-145-3B9 (Display board)

4-11. IC PIN FUNCTION

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

O

O

O

O

O

O

O

—

I

I

I

O

O

I

I

I

I

I

I

—

O

O

O

—

I

I

I

I

—

—

—

—

—

I

O

O

O

O

O

O

Fluorescent indicator tube drive

Power supply (+5V)

System clock

System data

PLL data input from TU001

Chip enable output

Chip enable output

Input for model select (Connected to ground)

Protector detect input

Protector detect input

System reset terminal

Auto stop detect input

Stereo detect input

Ground

Speaker relay drive

Surround Relay

Power relay drive

Ground (Not used)

A/D signal input terminal

A/D3 key input terminal



Power supply (+5V)

Reference voltage (+5V)

Ground

Not used (Open)

Ground

System clock (4.19MHz)

System clock (4.19MHz)

Mute drive output for µPD2581V (IC701)

Plologic LED (Not used)

CINEMA STUDIO LED (Not used)

HALL LED (Not used)

Tuner mute drive output

DIG7

DIG6

DIG5

DIG4

DIG3

DIG2

DIG1

+5V

S. CLK

S. DATA

PLL. DATA

S. CE (LC7288)

S. CE (LV1010)

REAR-R

BRIDGE

PROTECT

RESET

AUTO-STOP

STEREO-IN

AVSS

SP-RY

SURR-RY

POWER-RY

AVSS

SIGNAL

A/D3

A/D2

A/D1

AVDD

AV. REF

GND

NC

VSS

X1

X2

IC. MUTE

PROLOGIC

SIMULATED

HALL

T. MUTE

– 27 –

Pin No. Pin Name I/O Function41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

71

72

73

74

75

76

77

78

79

80

O

O

O

I

I

I

I

—

I

I

—

—

I

O

O

I

I

I

I

I

O

O

O

O

O

O

O

O

O

O

—

O

O

O

O

O

O

O

O

O

Volume up

Volume down

Standby LED drive (Not used)

System power ON/OFF

RDS data input (Not used)

RDS clock input (Not used)

Stop signal input from NJM2103D (IC950)

Ground

Sircs signal input

Power switch input terminal

5.1ch LED drive (Not used)

Power supply (+5V)

Bass boost LED drive

Line mute drive

SL mute drive

Input for model select

Key in 4

Key in 3

Key in 2

Key in 1

SR mute drive

Not used


Connect to –24V



VOLUME UP

VOLUME DOWN

STANDBY

SYS. POWER

RDS. DATA. IN

RDS. CLK. IN

STOP

VSS

SIRCS

POWER SW

5.1ch LED

+5V

BASS BOOST

FUNC. MUTE

SL MUTE

VERSION

K14

K13

K12

K11

SR MUTE

S15

S14

S13

S12

S11

S10

S9

S8

S7

VLOAD

S6

S5

S4

S3

S2

S1

DIG10

DIG9

DIG8

– 28 –

SECTION 5EXPLODED VIEWS

5-1. CASE SECTION

NOTE:• Items marked “*” are not stocked since they are

seldom required for routine service. Some delayshould be anticipated when ordering these items.

• The mechanical parts with no reference number inthe exploded views are not supplied.

• Hardware (# mark) list and accessories and pack-ing materials are given in the last of this parts list.

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

The components identified bymark ! or dotted line with mark! are critical for safety.Replace only with part numberspecified.

11 1-673-706-11 PHONE JACK BOARD12 A-4419-635-A VOL-TONE BOARD, COMPLETE13 1-782-074-11 WIRE (FLAT TYPE) (7 CORE)14 1-782-075-11 WIRE (FLAT TYPE) (9 CORE)

* 15 4-921-941-01 CUSHION (FL)

* 16 4-210-383-01 HOLDER (FL TUBE)17 3-704-366-31 SCREW (CASE) (M3X6)

* 18 4-210-365-01 CASEFL201 1-517-141-11 INDICATOR TUBE, FLUORESCENT

1 A-4411-215-A KNOB ASSY2 4-210-373-01 KNOB (EQ)3 4-951-620-01 SCREW (2.6X8), +BVTP

* 4 4-978-398-21 CUSHION5 4-977-593-01 RING (DIA. 50), ORNAMENTAL

6 A-4411-579-A PANEL ASSY, FRONT7 4-996-698-41 EMBLEM, SONY8 A-4419-637-A KEY BOARD, COMPLETE9 1-782-100-11 WIRE (FLAT TYPE) (23 CORE)10 A-4419-636-A DISPLAY BOARD, COMPLETE

1

2

4

4

5

5

6

7

8

10

11

12

3

3

3

3

3

33

14

13

17

1717

18

15

15

16

9

Including with RV404

FL201

not supplied

Including withJ741

#1

#1

#1

– 29 –

5-2. SHASSIS SECTION


57 4-900-386-01 SCREW58 4-210-380-01 RIVET, NYLON

* 59 3-703-244-00 BUSHING (2104), CORD* 60 4-978-398-21 CUSHION

61 A-4419-639-A MAIN BOARD, COMPLETE!T901 1-431-258-31 TRANSFORMER, POWER

51 X-4947-412-1 FOOT (SMALL) ASSY52 4-210-367-11 PANEL, BACK53 1-673-708-11 PRIMARY BOARD54 1-673-707-11 SECONDARY BOARD55 1-673-705-11 STANDBY BOARD

!56 1-783-531-21 CORD, POWER

The components identified by mark ! or dottedline with mark ! are critical for safety.Replace only with part number specified.

53 57 54

5755

58

61

52

56

59

60

51notsupplied

#1

#1

#1

#3

IC701

#1

#1

#1

#4

#1

#2

#2 #2#1

#1not supplied

not supplied

not supplied

not supplied

not supplied

T901

#1

IC702

– 30 –

• SEMICONDUCTORSIn each case, u: µ , for example:uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,uPC...: µ PC..., uPD...: µ PD...

• CAPACITORSuF : µ F

• COILSuH : µ H

• Due to standardization, replacements in the parts listmay be different from the parts specified in thediagrams or the components used on the set.

• -XX, -X mean standardized parts, so they may havesome difference from the original one.

• Items marked “*” are not stocked since they areseldom required for routine service. Some delayshould be anticipated when ordering these items.

• RESISTORSAll resistors are in ohmsMETAL: Metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF : nonflammable

SECTION 6ELECTRICAL PARTS LIST

Note:

When indicating parts by referencenumber, please include the boardname.


The components identified bymark ! or dotted line with mark! are critical for safety.Replace only with part numberspecified.

DISPLAY

A-4419-636-A DISPLAY BOARD, COMPLETE************************

* 4-210-383-01 HOLDER (FL TUBE)* 4-921-941-01 CUSHION (FL)

< CAPACITOR >

C201 1-104-905-11 CAPACITOR 0.22F 5.5VC202 1-164-159-21 CERAMIC 0.1uF 50VC203 1-124-465-00 ELECT 0.47uF 20% 50VC204 1-164-159-21 CERAMIC 0.1uF 50VC205 1-162-294-31 CERAMIC 0.001uF 10% 50V

C206 1-164-159-21 CERAMIC 0.1uF 50VC207 1-126-096-11 ELECT 10uF 20% 35VC421 1-137-440-11 FILM 0.018uF 5% 50VC422 1-124-463-00 ELECT 0.1uF 20% 50VC423 1-137-368-11 FILM 0.0047uF 5% 50V

C424 1-137-372-11 FILM 0.022uF 5% 50VC425 1-126-795-11 ELECT 10uF 20% 25VC471 1-137-440-11 FILM 0.018uF 5% 50VC472 1-124-463-00 ELECT 0.1uF 20% 50VC473 1-137-368-11 FILM 0.0047uF 5% 50V

C474 1-137-372-11 FILM 0.022uF 5% 50V

< CONNECTOR >

* CNP205 1-580-160-11 PIN, CONNECTOR (PC BOARD) 8PCNS201 1-695-346-21 PIN, CONNECTOR (PC BOARD) 23P

< DIODE >

D201 8-719-815-85 DIODE 1S1585D202 8-719-815-85 DIODE 1S1585D203 8-719-815-85 DIODE 1S1585D204 8-719-815-85 DIODE 1S1585D213 8-719-815-85 DIODE 1S1585

D214 8-719-815-85 DIODE 1S1585D225 8-719-815-85 DIODE 1S1585D231 8-719-815-85 DIODE 1S1585

< FLUORESCENT INDICATOR >

FL201 1-517-141-11 INDICATOR TUBE, FLUORESCENT

< IC >

IC201 8-759-587-56 IC uPD78044FGF-145-3B9IC202 8-759-962-08 IC BA6208IC203 8-749-011-05 IC GP1U28X

< COIL >

L401 1-410-509-11 INDUCTOR 10uH

< TRANSISTOR >

Q201 8-729-900-63 TRANSISTOR DTA124ESQ202 8-729-900-36 TRANSISTOR DTC124ESQ231 8-729-900-36 TRANSISTOR DTC124ES

< RESISTOR >

R200 1-247-863-91 CARBON 22K 5% 1/4WR201 1-247-903-00 CARBON 1M 5% 1/4WR202 1-249-429-11 CARBON 10K 5% 1/4WR203 1-249-429-11 CARBON 10K 5% 1/4WR204 1-249-425-11 CARBON 4.7K 5% 1/4W F

R205 1-249-441-11 CARBON 100K 5% 1/4WR207 1-249-429-11 CARBON 10K 5% 1/4WR211 1-247-863-91 CARBON 22K 5% 1/4WR212 1-247-863-91 CARBON 22K 5% 1/4WR213 1-247-863-91 CARBON 22K 5% 1/4W

R214 1-247-863-91 CARBON 22K 5% 1/4WR216 1-247-863-91 CARBON 22K 5% 1/4WR221 1-247-807-31 CARBON 100 5% 1/4WR222 1-247-807-31 CARBON 100 5% 1/4WR223 1-247-807-31 CARBON 100 5% 1/4W

R224 1-247-807-31 CARBON 100 5% 1/4WR225 1-247-807-31 CARBON 100 5% 1/4WR226 1-249-441-11 CARBON 100K 5% 1/4WR227 1-249-441-11 CARBON 100K 5% 1/4WR228 1-249-412-11 CARBON 390 5% 1/4W F

R231 1-249-427-11 CARBON 6.8K 5% 1/4W FR232 1-249-411-11 CARBON 330 5% 1/4WR233 1-249-413-11 CARBON 470 5% 1/4W FR234 1-249-415-11 CARBON 680 5% 1/4W FR235 1-247-840-00 CARBON 2.4K 5% 1/4W

R270 1-247-807-31 CARBON 100 5% 1/4WR283 1-249-427-11 CARBON 6.8K 5% 1/4W FR284 1-249-427-11 CARBON 6.8K 5% 1/4W FR286 1-249-437-11 CARBON 47K 5% 1/4WR420 1-249-415-11 CARBON 680 5% 1/4W F

R421 1-249-430-11 CARBON 12K 5% 1/4WR422 1-249-422-11 CARBON 2.7K 5% 1/4W FR423 1-247-903-00 CARBON 1M 5% 1/4WR424 1-247-903-00 CARBON 1M 5% 1/4WR470 1-249-415-11 CARBON 680 5% 1/4W F

R471 1-249-430-11 CARBON 12K 5% 1/4WR472 1-249-422-11 CARBON 2.7K 5% 1/4W F

– 31 –


R473 1-247-903-00 CARBON 1M 5% 1/4WR474 1-247-903-00 CARBON 1M 5% 1/4W

< VARIABLE RESISTOR >

RV421 1-225-658-11 RES, VAR 100K/100K (BASS)RV422 1-225-659-11 RES, VAR 125K/125K (TREBLE)RV423 1-225-660-11 RES, VAR 100K/125K (BALANCE)

< SWITCH >

S200 1-554-937-11 SWITCH, KEY BOARD (1/u)S209 1-554-937-11 SWITCH, KEY BOARD (TUNING -)S210 1-554-937-11 SWITCH, KEY BOARD (TUNING +)S214 1-554-937-11 SWITCH, KEY BOARD (FM)S215 1-554-937-11 SWITCH, KEY BOARD (AM)

S216 1-554-937-11 SWITCH, KEY BOARD (MEMORY)S217 1-554-937-11 SWITCH, KEY BOARD (SURROUND ON/OFF)S218 1-554-937-11 SWITCH, KEY BOARD (SET UP)S219 1-554-937-11 SWITCH, KEY BOARD (EFFECT DELAY TIME)S229 1-554-937-11 SWITCH, KEY BOARD (SHIFT)

S238 1-554-937-11 SWITCH, KEY BOARD (SURROUND MODE)

< VIBRATOR >

X201 1-577-101-11 VIBRATOR, CERAMIC (4.19MHz)

**************************************************************

1-673-706-11 PHONE JACK BOARD*****************

< CAPACITOR >

C792 1-127-876-21 CERAMIC 0.01uF 10% 50V

< DIODE >

D791 8-719-815-85 DIODE 1S1585

< JACK >

J741 1-785-959-11 JACK (LARGE TYPE)(PHONE JACK)

< RESISTOR >

R793 1-249-411-11 CARBON 330 5% 1/4W

**************************************************************

A-4419-637-A KEY BOARD, COMPLETE********************

< CONNECTOR >

* CNS205 1-580-169-11 PIN, CONNECTOR (PC BOARD) 8P

< DIODE >

D238 8-719-070-78 DIODE SEL6810A-TP6

< RESISTOR >

R237 1-249-421-11 CARBON 2.2K 5% 1/4W FR238 1-247-843-11 CARBON 3.3K 5% 1/4WR239 1-249-411-11 CARBON 330 5% 1/4W

R240 1-249-413-11 CARBON 470 5% 1/4W FR241 1-249-415-11 CARBON 680 5% 1/4W F

R242 1-249-417-11 CARBON 1K 5% 1/4W FR243 1-249-419-11 CARBON 1.5K 5% 1/4W FR244 1-249-426-11 CARBON 5.6K 5% 1/4WR246 1-249-411-11 CARBON 330 5% 1/4WR247 1-249-413-11 CARBON 470 5% 1/4W F

R248 1-249-415-11 CARBON 680 5% 1/4W FR249 1-249-417-11 CARBON 1K 5% 1/4W FR280 1-249-419-11 CARBON 1.5K 5% 1/4W FR281 1-249-421-11 CARBON 2.2K 5% 1/4W FR282 1-247-843-11 CARBON 3.3K 5% 1/4W

< SWITCH >

S221 1-554-937-11 SWITCH, KEY BOARD (CD)S222 1-554-937-11 SWITCH, KEY BOARD (TUNER)S223 1-554-937-11 SWITCH, KEY BOARD (VIDEO)S224 1-554-937-11 SWITCH, KEY BOARD (6)S225 1-554-937-11 SWITCH, KEY BOARD (7)

S226 1-554-937-11 SWITCH, KEY BOARD (8)S227 1-554-937-11 SWITCH, KEY BOARD (9)S228 1-554-937-11 SWITCH, KEY BOARD (0)S231 1-554-937-11 SWITCH, KEY BOARD (TV/SAT)S232 1-554-937-11 SWITCH, KEY BOARD (1)

S233 1-554-937-11 SWITCH, KEY BOARD (2)S234 1-554-937-11 SWITCH, KEY BOARD (3)S235 1-554-937-11 SWITCH, KEY BOARD (4)S236 1-554-937-11 SWITCH, KEY BOARD (5)S237 1-554-937-11 SWITCH, KEY BOARD (DIRECT)

S239 1-554-937-11 SWITCH, KEY BOARD (TAPE/MD)

**************************************************************

A-4419-639-A MAIN BOARD, COMPLETE*********************

1-533-217-31 HOLDER, FUSE4-210-380-01 RIVET, NYLON7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-37-685-650-91 SCREW +BVTP 3X16 TYPE2 TT(B)7-685-872-09 SCREW +BVTT 3X8 (S)

< CAPACITOR >

C302 1-126-934-11 ELECT 220uF 20% 16VC303 1-130-494-11 MYLAR 0.082uF 5% 50VC304 1-137-367-11 FILM 0.0033uF 5% 50VC305 1-130-494-11 MYLAR 0.082uF 5% 50VC306 1-126-959-11 ELECT 0.47uF 20% 50V

C307 1-126-964-11 ELECT 10uF 20% 50VC308 1-126-964-11 ELECT 10uF 20% 50VC309 1-162-291-31 CERAMIC 560PF 10% 50VC310 1-126-962-11 ELECT 3.3uF 20% 50VC311 1-126-961-11 ELECT 2.2uF 20% 50V

C312 1-164-159-21 CERAMIC 0.1uF 50VC313 1-126-934-11 ELECT 220uF 20% 16VC314 1-164-159-21 CERAMIC 0.1uF 50VC315 1-126-934-11 ELECT 220uF 20% 16VC316 1-124-252-00 ELECT 0.33uF 20% 50V

DISPLAY MAINKEYPHONE JACK

– 32 –


C317 1-126-934-11 ELECT 220uF 20% 16VC318 1-136-357-11 FILM 680PF 5% 50VC322 1-126-962-11 ELECT 3.3uF 20% 50VC323 1-136-173-00 FILM 0.47uF 5% 50VC324 1-136-165-00 FILM 0.1uF 5% 50V

C325 1-136-165-00 FILM 0.1uF 5% 50VC326 1-104-664-11 ELECT 47uF 20% 16VC327 1-126-959-11 ELECT 0.47uF 20% 50VC328 1-126-963-11 ELECT 4.7uF 20% 50VC329 1-126-959-11 ELECT 0.47uF 20% 50V

C330 1-126-963-11 ELECT 4.7uF 20% 50VC331 1-124-250-11 ELECT 0.15uF 20% 50VC332 1-126-962-11 ELECT 3.3uF 20% 50VC333 1-124-250-11 ELECT 0.15uF 20% 50VC334 1-137-372-11 FILM 0.022uF 5% 50V

C335 1-136-161-00 FILM 0.047uF 5% 50VC337 1-126-964-11 ELECT 10uF 20% 50VC338 1-126-964-11 ELECT 10uF 20% 50VC339 1-126-964-11 ELECT 10uF 20% 50VC340 1-126-964-11 ELECT 10uF 20% 50V

C341 1-126-934-11 ELECT 220uF 20% 16VC342 1-126-962-11 ELECT 3.3uF 20% 50VC343 1-126-962-11 ELECT 3.3uF 20% 50VC344 1-136-165-00 FILM 0.1uF 5% 50VC345 1-136-165-00 FILM 0.1uF 5% 50V

C346 1-126-959-11 ELECT 0.47uF 20% 50VC347 1-126-963-11 ELECT 4.7uF 20% 50VC348 1-126-959-11 ELECT 0.47uF 20% 50VC349 1-126-963-11 ELECT 4.7uF 20% 50VC350 1-124-250-11 ELECT 0.15uF 20% 50V

C351 1-126-962-11 ELECT 3.3uF 20% 50VC352 1-124-250-11 ELECT 0.15uF 20% 50VC353 1-164-159-21 CERAMIC 0.1uF 50VC354 1-164-159-21 CERAMIC 0.1uF 50VC355 1-164-159-21 CERAMIC 0.1uF 50V

C356 1-164-159-21 CERAMIC 0.1uF 50VC359 1-126-963-11 ELECT 4.7uF 20% 50VC360 1-126-963-11 ELECT 4.7uF 20% 50VC362 1-126-934-11 ELECT 220uF 20% 16VC364 1-126-934-11 ELECT 220uF 20% 16V

C365 1-126-962-11 ELECT 3.3uF 20% 50VC406 1-164-159-21 CERAMIC 0.1uF 50VC408 1-162-294-31 CERAMIC 0.001uF 10% 50VC411 1-164-159-21 CERAMIC 0.1uF 50VC412 1-162-291-31 CERAMIC 560PF 10% 50V

C413 1-164-159-21 CERAMIC 0.1uF 50VC415 1-164-159-21 CERAMIC 0.1uF 50VC416 1-164-159-21 CERAMIC 0.1uF 50VC434 1-162-286-21 CERAMIC 220PF 10% 50VC435 1-162-286-21 CERAMIC 220PF 10% 50V

C501 1-161-494-00 CERAMIC 0.022uF 25VC502 1-161-494-00 CERAMIC 0.022uF 25VC503 1-162-207-31 CERAMIC 22PF 5% 50VC505 1-164-097-11 CERAMIC 0.022uF 50VC506 1-164-097-11 CERAMIC 0.022uF 50V

C507 1-104-660-11 ELECT 47uF 20% 16VC508 1-164-097-11 CERAMIC 0.022uF 50V

C509 1-110-671-31 CERAMIC 47000PF 50VC511 1-164-096-11 CERAMIC 0.01uF 10% 50VC512 1-128-551-11 ELECT 22uF 20% 25V

C514 1-110-671-31 CERAMIC 47000PF 50VC515 1-126-962-11 ELECT 3.3uF 20% 50VC516 1-110-671-31 CERAMIC 47000PF 50VC517 1-126-963-11 ELECT 4.7uF 20% 50VC518 1-104-664-11 ELECT 47uF 20% 16V

C519 1-110-671-31 CERAMIC 47000PF 50VC520 1-110-671-31 CERAMIC 47000PF 50VC521 1-110-671-31 CERAMIC 47000PF 50VC522 1-126-960-11 ELECT 1uF 20% 50VC523 1-110-671-31 CERAMIC 47000PF 50V

C524 1-126-960-11 ELECT 1uF 20% 50VC525 1-126-959-11 ELECT 0.47uF 20% 50VC526 1-126-960-11 ELECT 1uF 20% 50VC527 1-110-671-31 CERAMIC 47000PF 50VC528 1-127-882-21 CERAMIC 0.033uF 10% 50V

C529 1-126-964-11 ELECT 10uF 20% 50VC530 1-162-293-11 CERAMIC 820PF 10% 50VC531 1-136-158-00 FILM 0.027uF 5% 50VC532 1-136-160-00 FILM 0.027uF 5% 50VC533 1-126-964-11 ELECT 10uF 20% 50V

C534 1-126-964-11 ELECT 10uF 20% 50VC535 1-126-963-11 ELECT 4.7uF 20% 50VC536 1-126-963-11 ELECT 4.7uF 20% 50VC537 1-126-933-11 ELECT 100uF 20% 16VC538 1-126-964-11 ELECT 10uF 20% 50V

C539 1-161-048-00 CERAMIC 0.0056uF 10% 25VC540 1-161-048-00 CERAMIC 0.0056uF 10% 25VC541 1-126-933-11 ELECT 100uF 20% 16VC542 1-164-097-11 CERAMIC 0.022uF 50VC543 1-126-963-11 ELECT 4.7uF 20% 50V

C544 1-126-959-11 ELECT 0.47uF 20% 50VC545 1-162-203-31 CERAMIC 15PF 5% 50VC546 1-162-203-31 CERAMIC 15PF 5% 50VC548 1-101-001-00 CERAMIC 0.001uF 50VC549 1-127-876-21 CERAMIC 0.01uF 10% 50V

C601 1-126-961-11 ELECT 2.2uF 20% 50VC602 1-162-282-31 CERAMIC 100PF 10% 50VC603 1-126-933-11 ELECT 100uF 20% 16VC604 1-162-201-31 CERAMIC 12PF 5% 50VC606 1-104-664-11 ELECT 47uF 20% 35V

C611 1-137-372-11 FILM 0.022uF 5% 50VC612 1-128-576-11 ELECT 100uF 20% 63VC620 1-127-881-21 CERAMIC 0.027uF 10% 50VC651 1-126-961-11 ELECT 2.2uF 20% 50VC652 1-162-282-31 CERAMIC 100PF 10% 50V

C653 1-126-933-11 ELECT 100uF 20% 16VC654 1-162-201-31 CERAMIC 12PF 5% 50VC656 1-104-664-11 ELECT 47uF 20% 35VC661 1-137-372-11 FILM 0.022uF 5% 50VC670 1-127-881-21 CERAMIC 0.027uF 10% 50V

C702 1-162-282-31 CERAMIC 100PF 10% 50VC703 1-126-933-11 ELECT 100uF 20% 16VC704 1-162-201-31 CERAMIC 12PF 5% 50VC706 1-104-664-11 ELECT 47uF 20% 35V

MAIN

– 33 –


C707 1-128-576-11 ELECT 100uF 20% 63V

C708 1-164-159-21 CERAMIC 0.1uF 50VC711 1-137-372-11 FILM 0.022uF 5% 50VC712 1-128-576-11 ELECT 100uF 20% 63VC720 1-127-881-21 CERAMIC 0.027uF 10% 50VC721 1-126-934-11 ELECT 220uF 20% 10V

C722 1-126-964-11 ELECT 10uF 20% 50VC751 1-126-961-11 ELECT 2.2uF 20% 50VC752 1-162-282-31 CERAMIC 100PF 10% 50VC753 1-126-933-11 ELECT 100uF 20% 16VC754 1-162-201-31 CERAMIC 12PF 5% 50V

C756 1-104-664-11 ELECT 47uF 20% 35VC757 1-128-576-11 ELECT 100uF 20% 63VC761 1-137-372-11 FILM 0.022uF 5% 50VC770 1-127-881-21 CERAMIC 0.027uF 10% 50VC791 1-126-960-11 ELECT 1uF 20% 50V

C796 1-109-889-11 ELECT 1uF 20% 50VC797 1-109-889-11 ELECT 1uF 20% 50VC801 1-104-664-11 ELECT 47uF 20% 25VC802 1-104-664-11 ELECT 47uF 20% 25VC805 1-137-397-11 FILM 0.047uF 5% 100V

C806 1-137-397-11 FILM 0.047uF 5% 100VC807 1-104-664-11 ELECT 47uF 20% 25VC808 1-104-664-11 ELECT 47uF 20% 25VC809 1-126-960-11 ELECT 1uF 20% 50VC810 1-126-960-11 ELECT 1uF 20% 50V

C811 1-126-942-61 ELECT 1000uF 20% 25VC812 1-126-942-61 ELECT 1000uF 20% 25VC813 1-101-001-00 CERAMIC 0.001uF 50VC814 1-101-001-00 CERAMIC 0.001uF 50VC820 1-164-097-11 CERAMIC 0.022uF 50V

C821 1-164-097-11 CERAMIC 0.022uF 50VC822 1-104-664-11 ELECT 47uF 20% 16VC823 1-104-664-11 ELECT 47uF 20% 16VC950 1-126-767-11 ELECT 1000uF 20% 16VC951 1-164-097-11 CERAMIC 0.022uF 50V

C952 1-126-960-11 ELECT 1uF 20% 50VC953 1-124-464-11 ELECT 0.22uF 20% 50VC954 1-126-964-11 ELECT 10uF 20% 50VC955 1-164-159-21 CERAMIC 0.1uF 50V

< FILTER >

CF501 1-760-127-11 FILTER, CERAMICCF502 1-760-127-11 FILTER, CERAMICCF503 1-760-127-11 FILTER, CERAMIC

< CONNECTOR >

* CN701 1-564-778-11 PLUG, CONNECTOR (2.5MM) 4PCNS204 1-695-346-21 PIN, CONNECTOR (PC BOARD) 23PCNS701 1-695-330-31 PIN, CONNECTOR (PC BOARD) 7P

* CNS802 1-564-778-11 PLUG, CONNECTOR (2.5MM) 4P

< CERAMIC VIBRATOR >

CX301 1-579-952-21 VIBRATOR, CERAMIC (8MHz)

< DIODE >

D503 8-719-815-85 DIODE 1S1585D610 8-719-815-85 DIODE 1S1585D620 8-719-815-85 DIODE 1S1585D670 8-719-815-85 DIODE 1S1585D710 8-719-815-85 DIODE 1S1585

D720 8-719-815-85 DIODE 1S1585D721 8-719-815-85 DIODE 1S1585D722 8-719-815-85 DIODE 1S1585D723 8-719-815-85 DIODE 1S1585D724 8-719-200-82 DIODE 11ES2

D725 8-719-815-85 DIODE 1S1585D770 8-719-815-85 DIODE 1S1585D792 8-719-815-85 DIODE 1S1585D793 8-719-815-85 DIODE 1S1585D801 8-719-922-17 DIODE MTZJ-24B

D802 8-719-302-38 DIODE RBV-602-01D804 8-719-109-85 DIODE RD5.1ES-B2D810 8-719-200-82 DIODE 11ES2D811 8-719-200-82 DIODE 11ES2D812 8-719-200-82 DIODE 11ES2

D813 8-719-200-82 DIODE 11ES2D814 8-719-815-85 DIODE 1S1585D815 8-719-815-85 DIODE 1S1585D817 8-719-921-74 DIODE MTZN-10AD818 8-719-815-85 DIODE 1S1585

D820 8-719-200-82 DIODE 11ES2D821 8-719-200-82 DIODE 11ES2D822 8-719-200-82 DIODE 11ES2D823 8-719-200-82 DIODE 11ES2

< EARTH TERMINAL >

* G201 1-537-738-21 TERMINAL, EARTH* G202 1-537-738-21 TERMINAL, EARTH* G203 1-537-738-21 TERMINAL, EARTH

< FRONT END >

FE501 1-693-457-11 TUNER

< IC >

IC301 8-759-527-00 IC LV1035MIC302 8-759-634-51 IC M5218APIC401 8-759-805-14 IC LC7822IC501 8-759-495-82 IC LA1838IC502 8-759-584-70 IC LC72131

IC701 8-749-921-04 IC STK-4211MK-2IC702 8-749-921-04 IC STK-4211MK-2IC801 8-759-231-58 IC TA7812SIC802 8-759-929-65 IC LM7912CTIC950 8-759-333-83 IC NJM2103D

< JACK >

J253 1-770-377-21 JACK, PIN 1PJ402 1-770-615-21 JACK, PIN 6PJ403 1-774-005-21 JACK, PIN 6P

MAIN

– 34 –


< COIL >

L301 1-410-509-11 INDUCTOR 10uHL601 1-420-872-00 COIL, AIR-COREL651 1-420-872-00 COIL, AIR-COREL701 1-420-872-00 COIL, AIR-COREL751 1-420-872-00 COIL, AIR-CORE

< TRANSISTOR >

Q303 8-729-141-30 TRANSISTOR 2SC3623A-LKQ304 8-729-141-30 TRANSISTOR 2SC3623A-LKQ307 8-729-141-30 TRANSISTOR 2SC3623A-LKQ308 8-729-141-30 TRANSISTOR 2SC3623A-LKQ501 8-729-922-66 TRANSISTOR 2SC2410SN

Q503 8-729-027-38 TRANSISTOR DTA144EKA-T146Q504 8-729-027-38 TRANSISTOR DTA144EKA-T146Q505 8-729-030-02 TRANSISTOR DTC144ESAQ610 8-729-119-78 TRANSISTOR 2SC403SP-51Q620 8-729-140-82 TRANSISTOR 2SA988-PAFAEA

Q670 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ710 8-729-119-78 TRANSISTOR 2SC403SP-51Q720 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ721 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ722 8-729-184-53 TRANSISTOR 2SC1845-EA

Q723 8-729-119-78 TRANSISTOR 2SC403SP-51Q770 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ791 8-729-119-78 TRANSISTOR 2SC27S5TP-HFEQ793 8-729-141-30 TRANSISTOR 2SC3623A-LKQ794 8-729-141-30 TRANSISTOR 2SC3623A-LK

Q801 8-729-140-97 TRANSISTOR 2SB734-34Q802 8-729-119-78 TRANSISTOR 2SC403SP-51Q808 8-729-180-92 TRANSISTOR 2SD809-KQ809 8-729-119-78 TRANSISTOR 2SC403SP-51Q951 8-729-209-15 TRANSISTOR 2SD2012

< RESISTOR >

R298 1-249-387-11 CARBON 3.3 5% 1/4W FR299 1-249-387-11 CARBON 3.3 5% 1/4W FR300 1-247-903-00 CARBON 1M 5% 1/4WR301 1-249-421-11 CARBON 2.2K 5% 1/4W FR302 1-249-421-11 CARBON 2.2K 5% 1/4W F

R303 1-249-439-11 CARBON 68K 5% 1/4WR304 1-249-441-11 CARBON 100K 5% 1/4WR305 1-249-429-11 CARBON 10K 5% 1/4WR306 1-249-436-11 CARBON 39K 5% 1/4WR307 1-247-862-11 CARBON 20K 5% 1/4W

R308 1-249-421-11 CARBON 2.2K 5% 1/4W FR309 1-249-421-11 CARBON 2.2K 5% 1/4W FR352 1-249-441-11 CARBON 100K 5% 1/4WR353 1-249-425-11 CARBON 4.7K 5% 1/4W FR354 1-249-425-11 CARBON 4.7K 5% 1/4W F

R355 1-249-425-11 CARBON 4.7K 5% 1/4W FR356 1-249-425-11 CARBON 4.7K 5% 1/4W FR357 1-249-441-11 CARBON 100K 5% 1/4WR358 1-249-441-11 CARBON 100K 5% 1/4WR359 1-249-425-11 CARBON 4.7K 5% 1/4W F

R360 1-247-843-11 CARBON 3.3K 5% 1/4WR361 1-249-429-11 CARBON 10K 5% 1/4W

R362 1-249-429-11 CARBON 10K 5% 1/4WR363 1-249-411-11 CARBON 330 5% 1/4WR402 1-249-421-11 CARBON 2.2K 5% 1/4W F

R403 1-249-417-11 CARBON 1K 5% 1/4W FR404 1-249-417-11 CARBON 1K 5% 1/4W FR405 1-249-417-11 CARBON 1K 5% 1/4W FR406 1-249-417-11 CARBON 1K 5% 1/4W FR407 1-249-417-11 CARBON 1K 5% 1/4W F

R408 1-249-429-11 CARBON 10K 5% 1/4WR409 1-249-417-11 CARBON 1K 5% 1/4W FR410 1-249-437-11 CARBON 47K 5% 1/4WR414 1-249-425-11 CARBON 4.7K 5% 1/4W FR415 1-249-417-11 CARBON 1K 5% 1/4W F

R420 1-249-441-11 CARBON 100K 5% 1/4WR435 1-249-418-11 CARBON 1.2K 5% 1/4W FR441 1-249-418-11 CARBON 1.2K 5% 1/4W FR442 1-249-418-11 CARBON 1.2K 5% 1/4W FR452 1-249-421-11 CARBON 2.2K 5% 1/4W F

R453 1-249-417-11 CARBON 1K 5% 1/4W FR454 1-249-417-11 CARBON 1K 5% 1/4W FR455 1-249-417-11 CARBON 1K 5% 1/4W FR456 1-249-417-11 CARBON 1K 5% 1/4W FR457 1-249-417-11 CARBON 1K 5% 1/4W F

R458 1-249-429-11 CARBON 10K 5% 1/4WR459 1-249-417-11 CARBON 1K 5% 1/4W FR460 1-249-437-11 CARBON 47K 5% 1/4WR465 1-249-417-11 CARBON 1K 5% 1/4W FR470 1-249-441-11 CARBON 100K 5% 1/4W

R501 1-249-422-11 CARBON 2.7K 5% 1/4W FR502 1-249-415-11 CARBON 680 5% 1/4W FR503 1-247-791-91 CARBON 22 5% 1/4WR504 1-249-393-11 CARBON 10 5% 1/4W FR505 1-249-411-11 CARBON 330 5% 1/4W

R506 1-247-891-00 CARBON 330K 5% 1/4WR507 1-249-417-11 CARBON 1K 5% 1/4W FR508 1-249-411-11 CARBON 330 5% 1/4WR511 1-249-441-11 CARBON 100K 5% 1/4WR512 1-249-441-11 CARBON 100K 5% 1/4W

R513 1-249-425-11 CARBON 4.7K 5% 1/4WR514 1-249-418-11 CARBON 1.2K 5% 1/4W FR515 1-249-410-11 CARBON 270 5% 1/4W FR516 1-249-402-11 CARBON 56 5% 1/4W FR517 1-247-842-11 CARBON 3K 5% 1/4W

!R519 1-249-403-11 CARBON 68 5% 1/4W FR521 1-249-426-11 CARBON 5.6K 5% 1/4WR531 1-249-425-11 CARBON 4.7K 5% 1/4WR532 1-249-425-11 CARBON 4.7K 5% 1/4WR535 1-249-418-11 CARBON 1.2K 5% 1/4W F

R536 1-249-417-11 CARBON 1K 5% 1/4W FR537 1-249-420-11 CARBON 1.8K 5% 1/4W FR538 1-249-427-11 CARBON 6.8K 5% 1/4W FR539 1-249-427-11 CARBON 6.8K 5% 1/4W F!R541 1-249-403-11 CARBON 68 5% 1/4W F

R542 1-249-420-11 CARBON 10K 5% 1/4W FR543 1-249-429-11 CARBON 10K 5% 1/4WR544 1-249-421-11 CARBON 2.2K 5% 1/4W FR545 1-249-425-11 CARBON 4.7K 5% 1/4W F


MAIN

– 35 –


MAIN

R546 1-247-807-31 CARBON 100 5% 1/4W

R547 1-249-425-11 CARBON 4.7K 5% 1/4W FR548 1-249-421-11 CARBON 2.2K 5% 1/4W FR549 1-249-429-11 CARBON 10K 5% 1/4WR550 1-249-417-11 CARBON 1K 5% 1/4W FR553 1-249-417-11 CARBON 1K 5% 1/4W F

R554 1-249-429-11 CARBON 10K 5% 1/4WR555 1-247-843-11 CARBON 3.3K 5% 1/4WR556 1-249-417-11 CARBON 1K 5% 1/4W FR557 1-249-417-11 CARBON 1K 5% 1/4W FR558 1-249-417-11 CARBON 1K 5% 1/4W F

R559 1-247-863-91 CARBON 22K 5% 1/4WR561 1-247-843-11 CARBON 3.3K 5% 1/4WR601 1-249-421-11 CARBON 2.2K 5% 1/4W FR602 1-249-438-11 CARBON 56K 5% 1/4WR603 1-249-412-11 CARBON 390 5% 1/4W F

R604 1-249-438-11 CARBON 56K 5% 1/4WR605 1-247-760-11 CARBON 4.7K 5% 1/2W FR606 1-249-425-11 CARBON 4.7K 5% 1/4W F!R610 1-220-755-11 METAL 0.22 10% 2W!R617 1-249-393-11 CARBON 10 5% 1/4W F

R618 1-249-389-11 CARBON 4.7 5% 1/4W F!R619 1-249-405-11 CARBON 100 5% 1/4W F

R620 1-249-420-11 CARBON 1.8K 5% 1/4W FR621 1-247-815-91 CARBON 220 5% 1/4W!R622 1-249-403-11 CARBON 68 5% 1/4W F

R623 1-249-437-11 CARBON 47K 5% 1/4WR630 1-249-426-11 CARBON 5.6K 5% 1/4WR631 1-247-887-00 CARBON 220K 5% 1/4WR632 1-249-426-11 CARBON 5.6K 5% 1/4WR651 1-249-421-11 CARBON 2.2K 5% 1/4W F

R652 1-249-438-11 CARBON 56K 5% 1/4WR653 1-249-412-11 CARBON 390 5% 1/4W FR654 1-249-438-11 CARBON 56K 5% 1/4WR656 1-249-425-11 CARBON 4.7K 5% 1/4W F!R660 1-220-755-11 METAL 0.22 10% 2W

R665 1-247-760-11 CARBON 4.7K 5% 1/2W F!R667 1-249-393-11 CARBON 10 5% 1/4W F

R668 1-249-389-11 CARBON 4.7 5% 1/4W FR670 1-249-420-11 CARBON 1.8K 5% 1/4W F!R671 1-247-815-91 CARBON 220 5% 1/4W

R672 1-249-431-11 CARBON 15K 5% 1/4WR673 1-249-437-11 CARBON 47K 5% 1/4WR674 1-249-431-11 CARBON 15K 5% 1/4WR701 1-249-421-11 CARBON 2.2K 5% 1/4W FR702 1-249-438-11 CARBON 56K 5% 1/4W

R703 1-249-412-11 CARBON 390 5% 1/4W FR704 1-249-438-11 CARBON 56K 5% 1/4WR705 1-247-760-11 CARBON 4.7K 5% 1/2W FR706 1-249-425-11 CARBON 4.7K 5% 1/4W F!R707 1-249-405-11 CARBON 100 5% 1/4W F

!R710 1-220-755-11 METAL 0.22 10% 2WR711 1-249-405-11 CARBON 100 5% 1/4W F!R717 1-249-393-11 CARBON 10 5% 1/4W F

R718 1-249-389-11 CARBON 4.7 5% 1/4W F!R719 1-249-405-11 CARBON 100 5% 1/4W F

R720 1-249-420-11 CARBON 1.8K 5% 1/4W FR721 1-247-815-91 CARBON 220 5% 1/4W!R722 1-249-403-11 CARBON 68 5% 1/4W F

R723 1-249-437-11 CARBON 47K 5% 1/4WR724 1-249-425-11 CARBON 4.7K 5% 1/4W F

R725 1-249-427-11 CARBON 6.8K 5% 1/4W FR727 1-247-752-11 CARBON 1K 5% 1/2W FR730 1-249-426-11 CARBON 5.6K 5% 1/4WR731 1-249-426-11 CARBON 5.6K 5% 1/4WR732 1-247-753-11 CARBON 1.2K 5% 1/2W F

R733 1-247-753-11 CARBON 1.2K 5% 1/2W FR734 1-249-429-11 CARBON 10K 5% 1/4WR751 1-249-421-11 CARBON 2.2K 5% 1/4W FR752 1-249-438-11 CARBON 56K 5% 1/4WR753 1-249-412-11 CARBON 390 5% 1/4W F

R754 1-249-438-11 CARBON 56K 5% 1/4WR755 1-247-760-11 CARBON 4.7K 5% 1/2W FR756 1-249-425-11 CARBON 4.7K 5% 1/4W F!R757 1-249-405-11 CARBON 100 5% 1/4W F!R760 1-220-755-11 METAL 0.22 10% 2W

!R767 1-249-393-11 CARBON 10 5% 1/4W FR768 1-249-389-11 CARBON 4.7 5% 1/4W FR770 1-249-420-11 CARBON 1.8K 5% 1/4W FR771 1-247-815-91 CARBON 220 5% 1/4WR772 1-249-431-11 CARBON 15K 5% 1/4W

R773 1-249-437-11 CARBON 47K 5% 1/4WR774 1-249-431-11 CARBON 15K 5% 1/4WR781 1-247-887-00 CARBON 220K 5% 1/4WR782 1-247-753-11 CARBON 1.2K 5% 1/2W FR783 1-247-753-11 CARBON 1.2K 5% 1/2W F

R791 1-249-441-11 CARBON 100K 5% 1/4WR792 1-249-441-00 CARBON 100K 5% 1/4W!R803 1-247-739-11 CARBON 100 5% 1/2W F

R804 1-249-425-11 CARBON 4.7K 5% 1/4W F!R810 1-249-381-11 CARBON 1 5% 1/4W F

!R811 1-249-381-11 CARBON 1 5% 1/4W FR821 1-249-437-11 CARBON 47K 5% 1/4WR822 1-249-425-11 CARBON 4.7K 5% 1/4W FR823 1-249-437-11 CARBON 47K 5% 1/4WR824 1-249-425-11 CARBON 4.7K 5% 1/4W F

R825 1-249-407-11 CARBON 150 5% 1/4W F!R830 1-249-405-11 CARBON 100 5% 1/4W F!R831 1-249-403-11 CARBON 68 5% 1/4W F

R950 1-249-421-11 CARBON 2.2K 5% 1/4W FR951 1-249-429-11 CARBON 10K 5% 1/4W

R952 1-247-843-11 CARBON 3.3K 5% 1/4WR953 1-247-863-91 CARBON 22K 5% 1/4WR954 1-249-439-11 CARBON 68K 5% 1/4WR955 1-249-429-11 CARBON 10K 5% 1/4WR956 1-247-843-11 CARBON 3.3K 5% 1/4W

R957 1-249-417-11 CARBON 1K 5% 1/4W FR958 1-249-401-11 CARBON 47 5% 1/4W FR960 1-249-429-11 CARBON 10K 5% 1/4W

< RELAY >

RY601 1-515-921-11 RELAY (12V)RY701 1-515-921-11 RELAY (12V)


– 36 –


MAIN

RY801 1-755-013-11 RELAY

< SFR >

SFR501 1-238-599-11 RES, ADJ, CARBON 4.7K

< TRANSFORMER >

T502 1-234-304-11 ENCAPSULATED COMPONENTT503 1-233-885-11 ENCAPSULATED COMPONENTT504 1-234-305-11 ENCAPSULATED COMPONENT (LPF)T505 1-234-305-11 ENCAPSULATED COMPONENT (LPF)

< TERMINAL >

TM1 1-537-240-51 TERMINAL BOARD (CHECKER PIN)TM601 1-537-923-11 TERMINAL BOARD (SPEAKER) (6P)TM701 1-537-240-11 TERMINAL BOARD (CHECKER PIN)

< VIBRATOR >

X501 1-781-385-11 VIBRATOR, CRYSTAL (7.2MHz)

**************************************************************

1-673-708-11 PRIMARY BOARD**************

< CONNECTOR >

CNP903 1-564-321-00 PIN, CONNECTOR 2P

< FUSE >

!F901 1-576-109-11 FUSE (5A/125V)

< TRANSFORMER >

!T901 1-433-879-11 TRANSFORMER, POWER

**************************************************************

1-673-707-11 SECONDARY BOARD*****************

< CONNECTOR >

CNS801 1-764-480-11 PIN, CONNECTOR (PC BOARD) 11P

**************************************************************

1-673-705-11 STANDBY BOARD**************

< CONNECTOR >

CNJ902 1-540-057-11 OUTLET, AC (POLAR)CNS301 1-568-828-11 PIN, CONNECTOR (PC BOARD) 9P BOARD

< DIODE >

D816 8-719-815-85 DIODE 1S1585

< EARTH TERMINAL >

* G900 1-537-738-21 TERMINAL, EARTH

< RESISTOR >

R901 1-202-725-00 SOLID 3.3M 10% 1/2W

< RELAY >

RY901 1-755-018-11 RELAY

< TRANSFORMER >


**************************************************************

A-4419-635-A VOL-TONE BOARD, COMPLETE*************************

< CAPACITOR >

C420 1-162-207-31 CERAMIC 22PF 5% 50VC426 1-126-795-11 ELECT 10uF 20% 25VC427 1-124-252-00 ELECT 0.33uF 20% 50VC428 1-130-489-00 MYLAR 0.033uF 5% 50VC429 1-102-973-00 CERAMIC 100PF 5% 50V

C430 1-104-942-11 ELECT 1uF 20% 50VC431 1-104-942-11 ELECT 1uF 20% 50VC432 1-126-795-11 ELECT 10uF 20% 25VC433 1-126-795-11 ELECT 10uF 20% 25VC470 1-162-207-31 CERAMIC 22PF 5% 50V

C475 1-126-795-11 ELECT 10uF 20% 25VC476 1-126-795-11 ELECT 10uF 20% 25VC477 1-124-252-00 ELECT 0.33uF 20% 50VC478 1-130-489-00 MYLAR 0.033uF 5% 50VC479 1-102-973-00 CERAMIC 100PF 5% 50V

C492 1-124-464-11 ELECT 0.22uF 20% 50V

< CONNECTOR >

CNS402 1-695-330-31 PIN, CONNECTOR (PC BOARD) 7PCNS403 1-568-828-11 PIN, CONNECTOR (PC BOARD) 9P

< DIODE >

D421 8-719-815-85 DIODE 1S1585

< IC >

IC404 8-759-634-51 IC M5218AP

< TRANSISTOR >

Q401 8-729-202-67 TRANSISTOR 2SK246-GR3Q402 8-729-141-30 TRANSISTOR 2SC3623A-LKQ451 8-729-202-67 TRANSISTOR 2SK246-GR3Q452 8-729-141-30 TRANSISTOR 2SC3623A-LK

< RESISTOR >

R425 1-249-429-11 CARBON 10K 5% 1/4WR426 1-249-439-11 CARBON 68K 5% 1/4WR427 1-249-417-11 CARBON 1K 5% 1/4W FR430 1-249-437-11 CARBON 47K 5% 1/4WR431 1-247-843-11 CARBON 3.3K 5% 1/4W

R432 1-247-883-00 CARBON 150K 5% 1/4W


PRIMARY STANDBYSECONDARY VOL-TONE

– 37 –


Ref. No. Part No. Description Remark

R433 1-249-427-11 CARBON 6.8K 5% 1/4W FR434 1-249-413-11 CARBON 470 5% 1/4W FR438 1-249-441-11 CARBON 100K 5% 1/4WR441 1-249-441-11 CARBON 100K 5% 1/4W

R464 1-247-903-00 CARBON 1M 5% 1/4WR469 1-247-903-00 CARBON 1M 5% 1/4WR475 1-249-429-11 CARBON 10K 5% 1/4WR476 1-249-439-11 CARBON 68K 5% 1/4WR477 1-249-417-11 CARBON 1K 5% 1/4W F

R480 1-249-437-11 CARBON 47K 5% 1/4WR481 1-247-843-11 CARBON 3.3K 5% 1/4WR482 1-247-883-00 CARBON 150K 5% 1/4WR483 1-249-427-11 CARBON 6.8K 5% 1/4W FR484 1-249-413-11 CARBON 470 5% 1/4W F

R491 1-249-441-11 CARBON 100K 5% 1/4WR492 1-247-903-00 CARBON 1M 5% 1/4W

< VARIABLE RESISTOR >

RV404 1-225-229-11 RES, VAR, CARBON 100KX4 (MASTER VOLUME)

**************************************************************

MISCELLANEOUS*************

9 1-782-100-11 WIRE (FLAT TYPE) (23 CORE)13 1-782-074-11 WIRE (FLAT TYPE) (7 CORE)14 1-782-075-11 WIRE (FLAT TYPE) (9 CORE)!56 1-783-531-21 CORD, POWER

FL201 1-517-141-11 INDICATOR TUBE, FLUORESCENT


**************************************************************

ACCESSORIES & PACKING MATERIALS*******************************

1-475-710-11 COMMANDER, STANDARD (RM-U302)1-501-374-11 ANTENNA, LOOP1-501-659-41 ANTENNA (FM)3-866-100-01 MANUAL, INSTRUCTION (ENGLISH)4-981-643-01 COVER, BATTERY (for RM-U302)

**************************************************************

*************HARDWARE LIST*************

#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S#2 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S#3 7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3#3 7-685-650-91 SCREW +BVTP 3X16 TYPE2 TT(B)#4 7-685-872-09 SCREW +BVTT 3X8 (S)

VOL-TONE

– 38 –

Sony CorporationHome A&V Products Company9-928-834-11

99D097020-1Printed in Singapore © 1999. 4

Published by Quality Assurance Dept.(Shinagawa)

STR-V220

SERVICE MANUAL US Model - sportsbil.comsportsbil.com/sony/STR/STR-V/STR-V220_.pdfMANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ... Location of Parts and Controls 1 1/u button 2 VIDEO

Documents