GDM·20SHT - bitsavers.org

GDM·20SHT SERVICE MANUAL Chassis No. SCC-H71 A-A

Multiscan 20sh

••••• ••••• ••• MICROFILM

SPECIFICATIONS

Picture tube 0.25 mm aperture grille pitch 20 inches measured diagonally (19" visual) 90-degree denection

Effective picture size Approx. 384 x 290 mm (w /h) (15 1ft x 11 In inches)

Display picture size Approx. 373 x 280 mm (w /h) (14 y, x 11 1;" inches)

Resolution

or Approx. 350 x 280 mm (w /h) (13 % x 11 1,1" inches) Horizontal: 640- to 1600 dots (-VGA mode) Vertical: 480- to 1200 lines (-VGA mode)

Deflection frequency Horizontal: 30 to 107 kHz Vertical: 50 to 160 Hz

Input signal Sync: Sync on Green: 0.286 Vp·p, Negative H/V Composite Sync: 75 ohms/2 kohms, TIL Positive/Negative H. Sync/V. Sync Separate: 75 ohms/ 2 kohms, TIL Positive/Negative

Video: R/G/B: 0.714 Vp-p, Positive

AC input voltage/current 100 to 120 V, 50/60 Hz, max. 2.5 A 200 to 240 V, 50 - 60 Hz, max. 1.2 A

Dimensions Approx. 474 x 474 x 502 mm (w/h/d) (18 1f. x 18 Yt x 19 Yt inches)

Mass Approx. 31 kg (68 Ib 4 oz) Supplied ilCc('s5ories AC power cord (1)

15-pin mini D-sub (HD15 - HOtS) videu cable (1)

Ferrite core (1)

Binder (1)

Design and specifications are subject to change without

notice.

P-5 CHASSIS

For Service Manuals MAURITRON SERVICES

B Cherry Tree Road, Chlnnor Oxfordshlre, OX9 4Qy'

Tel (01844) 351694 Fax (01844) 352554

email:[email protected]

TRINITRON® COLOR GRAPHIC DISPLAY SONY

GDM-20SHT

Power Saving Function This monitor meets the power saving guidelines set by TCOn guidelines (NUTEK). It is capable of reduced power consumption when used with a computer equipped with Display Power Management Signaling (DPMS). By sensing the absence of the sync signal coming from the computer, it will reduce the power consumption as follows:

Normal operation 100%

2 Suspend

approx.l0% (1st step of power saving)

Active-off 3 (2nd step of power saving) approx.7%

TIMING SPECIFICATION

Mode 1 2 3

Graphics mode YGA YESA-75 Macintosh (Graphics) 16" Color

Resolution (H x V) 640 x 480 800 x 600 832 x 624

Oat Clock 25.17 MHz 49.5 MHz 57.283 MHz

H Frequency 310463 kHz 46.875 kHz 49.725 kHz

HTotal 31.784 ~S 21.333 ~S 20.111 ~

H Front porch 0.318 ~S 0.323 ~S 0.559 ~

HSync width 3.814 ~S 1616 ~S 1.117~

H Back porch 1.589 ~S 3.232 ~S 3.910 ~S

H Blanking 5.721 ~S 5.172 ~S 5.586 ~S

H Active Area 26.063 ~ 16.162 ~S 14.524 ~S

V Frequency 59.929 Hz 75.000 Hz 74.550 Hz

V Total 525 H Lines 625 H Lines 667 H Lines

Y Front porch 2 H Lines 1 H Line 1 H Line

Y Sync width 2 H Lines 3 H Lines 3 H Lines

Y Back porch 25 H Lines 21 H Lines 39 H Lines

Y Blanking 29 H Lines 25 H Lines 43 H Lines

Y Active Area 496 H Lines 600 H Lines 624 H Lines

Sync External External External

Sync Polarity H H (+) H

Sync Polarity V H (+) (-)

Scan Mode Non- Non- Non-interlace interlace interlace

1) VGA does not include the border area. 2) Recommended horizontal frequency timings are:

Horizontal front porch is 0.1 ~sec or more. Horizontal sync. width is 0.8 ~sec or more. Horizontal back porth is 0.6 ~sec or more. Horizontal blanking width is 2.4 ~sec or more.

CAUTION: The Power Saving function will automatically put the monitor into the Active-off state if the power switch is turned on without any video signal input. Once the horizontal and vertical syncs are sensed, the monitor will automatically return to its Normal operation state.

green on off

approx. 3 sec. green on orange on

approx. 10 sec. off orange on

4 5 6 7 8

Macintosh Macintosh YESA-75 YESA-75 VESA-80 19" Color 21" Color

1024 x 768 1152 x 870 1280 x 1024 1600 x 1200 1600 x 1200

80 MHz 100 MHz 135 MHz 202.5 MHz 216 MHz

60.241 kHz 68.681 kHz 79.976 kHz 93.750 kHz 100.00 kHz

16.600 ~ 14.560 ~ 12.504 ~ 10.667 ~S 10.000 ~S

0.550 ~ 0.320 ~S 0.119 ~ 0.316 ~S 0.296 ~S

1.200 ~ 1.280 ~ 1.067 ~S 0.948 ~ 0.889 ~

2.050 ~S 1.440~ 1.837 ~S 1.501 ~S 10407 ~S

3.800 ~S 3.040 ~S 3.022~ 2.765 ~S 2.593 ~S

12.800 ~S 11.520 ~S 9.481 ~S 7.901 ~S 7.407 ~S

74.927 Hz 75.062 Hz 75.025 Hz 75.000 Hz 80.000 Hz

804 H Lines 915 H Lines 1066 H Lines 1250 H Lines 1250 H Lines

3 H Lines 3 H Lines 1 H Line 1 H Line 1 H Line





External External External External External

(-) H (+) (+) (+)

(-) (-) (+) (+) (+)

Non- Non- Non- Non- Non-interlace interlace interlace interlace interlace

-2-

9

YESA-85

1600 x 1200

229.5 MHz

106.250 kHz

9.412 ~

0.279 ~S

0.837~

1.325 ~S

2.440 ~S

6.972~

85.000 Hz

1250 H Lines

1 H Line

3 H Lines

46 H Lines

50 H Lines

1200 H Lines

External

(+)

(+)

Non-interlace

GDM-20SHT

SAFETY CHECK-OUT

(US Model only)

After correcting the original service problem, perform the

following safety checks before releasing the set to the customer:

1. Check the area of your repair for unsoldered or poorly-sol:

dered connections. Check the entire board surface for solder

splashes and bridges.

2. Check the interboard wiring to ensure that no wires are

"pinched" or contact high-wattage resistors.

3. Check that all control knobs, shields, covers, ground straps,

and mounting hardware have been replaced. Be absolutely

certain that you have replaced all the insulators.

4. Look for unauthorized replacement parts, particularly tran

sistors, that were installed during a previous repair. Point

them out to the customer and recommend their replacement.

5. Look for parts which, though functioning, show obvious

signs of deterioration. Point them out to the customer and

recommend their replacement.

6. Check the line cords for cracks and abrasion. Recommend

the replacement of any such line cord to the customer.

7. Check the B+ and HV to see if they are specified values.

Make sure your instruments are accurate; be suspicious of

your HV meter if sets always have low HV.

8. Check the antenna terminals, metal trim, "metallized"

knobs, screws, and all other exposed metal parts for AC

Leakage. Check leakage as described below.

O.1SIlF

To Exposed Metal Parts on Set

1.5 kfl AC Voltmeter (0.75 V)

LEAKAGE TEST The AC leakage from any exposed metal part to earth ground

and from all exposed metal parts to any exposed metal part having a

return to chassis, must not exceed 0.5 rnA (500 microampers).

Leakage current can be measured by anyone of three methods.

1. A commercial leakage tester, such as the Simpson 229 or

RCA WT-540A. Follow the manufacturers' instructions to

use these instruments.

2. A battery-operated AC milliammeter. The Data Precision

245 digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of a

YOM or battery-operated AC voltmeter. The "limit" indica

tion is 0.75 V, so analog meters must have an accurate low

voltage scale. The Simpson 250 and Sanwa SH-63Trd are

examples of a passive VOMs that are suitable. Nearly all

battery operated digital multimeters that have a 2 V AC

range are suitable. (See Fig. A)

WARNING!! NEVER TURN ON THE POWER IN A CONDITION IN WHICH THE DEGAUSS COIL HAS BEEN REMOVED.

SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY SHADING AND MARK .& ON THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT ARE CRITICAL FOR SAFE OPERATION ARE IDENTIFIED IN THIS MANUAL. FOLLOW THESE PROCEDURES WHENEVER CRITICAL COMPONENTS ARE REPLACED OR IMPROPER OPERATION IS SUSPECTED.

AVERTISSEMENT!! NE JAMAIS METTRE SOUS TENSION QUAND LA BOBINE DE DEMAGNETISATION EST ENLEVEE.

ATIENTION AUX COMPOSANTS RELATIFS A LA SECURITE!!

-=- Earth Ground LES COMPOSANTS IDENTIFIES PAR UNE TRAME ET PAR UNE MARQUE .& SUR LES SCHEMAS DE

Fig. A. Using an AC voltmeter to check AC leakage. PRINCIPE, LES VUES EXPLOSEES ET LES LlSTES DE PIECES SONT D'UNE IMPORTANCE CRITIQUE POUR LA SECURITE DU FONCTIONNEMENT. NE LES REMPLACER QUE PAR DES COMPOSANTS SONY DONT LE NUMERO DE PIECE EST INDlQUE DANS LE PRESENT MANUEL OU DANS DES SUPPLEMENTS PUB LIES PAR SONY. LES REGLAGES DE CIRCUIT DO NT L'IMPORTANCE EST CRITIQUE POUR LA SECURITE DU FONCTIONNEMENT SONT IDENTIFIES DANS LE PRESENT MANUEL. SUIVRE CES PROCEDURES LORS . .~ DE CHAQUE REMPLACEMENT DE COMPOSANTS CRITIQUES, OU LORSQU'UN MAUVAIS FONCTIONNE-MENT EST SUSPECTE.

-3-

GDM-20SHT

TABLE OF CONTENTS

1. GENERAL ............................................. ·.··· ................. 5

2. DISASSEMBLY 2-1. Rear Cabinet and Top Cover Removal............... 7

2-2. D Block Assy Removal....................................... 7

2-3. Power Block Assy Removal............................... 8

2-4. L Board Removal ................................................ 8

2-5. M Board Removal ............................................... 9

2-6. A Block Assy Removal....................................... 9

2-7. H Board Removal ................................................ 10

2-8. Picture Tube Removal......................................... 10

2-9. Wiring Harness Layout ....................................... 11

3. SAFETY RELATED ADJUSTMENT ............. 12

4. ADJUSTMENTS ...................................................... 13

5. DIAGRAMS 5-1. Block Diagrams ................................................... 17

5-2. Frame Schematic Diagram .................................. 25

5-3. Circuit Boards Location ...................................... 27

5-4. Schematic Diagrams and Printed Wiring Boards

(1) Schematic Diagrams of D and L Boards ............ 31

(2) Schematic Diagram of DA Board ....................... 35

(3) Schematic Diagram of A Board .......................... 45

(4) Schematic Diagrams of DB, G, Hand

M Boards ......................................................... 49

5-5. Semiconductors ................................................... 56

6. EXPLODED VIEWS 6-1. Chassis... .............................................................. 57

6-2. Picture Tube ........................................................ 58

6-3. Packing Materials ................................................ 59

7. ELECTRICAL PARTS LIST ............................ 61

-4-

U1

I

The operating Instructions mentioned here are partial abstracts from the Operating Instruction Manual. The page numbers of the Operating Instruction Manual remeln as In the manual.

SECTION 1

GENERAL

Function of Controls See the given pages for further descnption.

Front panel Rear panel

4 , '. i •.

II II

ill RESET button (page 10) Resets the adjustment data to the factory-preset levels for the Input Signal being received.

III M01RE button and indicator (page 10) Eliminates moire.

~ Adjustment parameter buttons and indicators Select the adjustment parameters. The mdlcator of the selected parameter lights. ROTATION: Raster rotation and color distortion

(page 101 COLOR: Color temperature (page 9) CONY: Convergence (page 9) SHAPE: Pincushion and keystone distortions (page 9) SIZE: Picture size (page 9) CENTER: Centering (page 8)

[II 0. (brightnes!.) buttons Adjust the picture bnghtness in normal operation mode (page 8). Act as +/- or % controls to adjust pICture size, centenng, convergence, rotation, keystone distortion and coJor temperature (pages 8 - 10).

~ () (contrast) buttons Adjust the picture contrast in normal operation mode (page 8).

Act as +/- or ¢fc> controls to adjust picture size, centering, con\"t:~rgence, beam landing, pincushIOn distortion, color temperature and moire (pages 8 - 10).

[ID roWEI{ SA VIt\:G indicato( (page II) Lights up when the mom tor is in Power Saving mode. Flashes when the limit value for an adju~tment IS

reached. Also fla5he~ If you press the adjustment buttons on the front panel In the Lock mode.

m t:> power switch and indICator Turns the momtor on and off. The indicator illuminates when the monitor IS turned on. To disconnect the power completely, unplug the power cord.

[ID AC IN connector (page 6) input for the ~upphed AC power cord

(ID Video mput connectors (5 BNC) (page 6) Accept ReB vldt;O'o and sync :'Ignab

BNC

Input onnntorsl R

_:l~ll3b (@) SYnc on l.rl:'"t'n

H/V Composite Sync

R<d

Red

G B

(@) (@) C0m~t~ I Blue ~yn( nn

Gr ... t'ro

Crt>t:'n I Slut'

HO (@)

H/V

Cumpo>llt Svnc

vo (@)

HjV

s.-p.uale S~'nc

Red Grt:'l;'n ! Blut' H Sync I V Sync

llil 8:-JC/O-SUB ;witch (p"ge 6) Select::. the RGB or O-sub Signal

l __ ~'

[j] Video input connector OS-pin mini D-sub) (page 6) Accepts D-sub Video and sync signals. To connect this connector, use the supplied IS-pin mini D-sub cable.

o o

Pm,\iu ! Signal Signal

Red N/C

Green Ground (Cump..>Slte Sync on Green)

Slue Ground

Ground Bi-Due-ctlonal D.lta (SDA)'

DOC Ground· !3 H. Sync

Red Ground 14 V. Sync

Green Ground tS Data Clock (5CU·

Blue Ground

• DIsplay Data Channd (DOC) Standard by VESA

~ 7S0/2kO SWitch SWitches the impedance of the sync input connectors «(ID, [j]) termindtion to 75 n or 2 kn. ThiS monitor is Lnltially set to 2 kfl, whICh LS appropn<\te for the majonty of IBM compatible .md Maclnto!>h systems. For UllIlllH!

systems which may require 75ft ~et' the Oper .. lllng In~tructions ot your computer.

[j] CONTROL LOCK switch Locks the montlor so that the buttons, except the power SWitch, on the front panel cannot be operated (Lock mode) With this switch, you can ensure that the display remainS In the optimum condition even when the mom tor is placed where the control buttons can be touched by unauthorized persons. To release the Lock mode, set to OFF I\!ormally keep this switch set to OFF.

[j1J SERVICE terminal The term mal is to be used by servICe personnel only.

., 5

en I

Connection You (,In connect this mOnitor to imy IBM or compatible system, Macintosh, and othH various computers. In order to comply with the mandatory FCC standards, use the supplied Video signal cablt'.

Connecting an IBM or compatible system CSt' the supplied video Signal cable.

Set to D-SUB.

Toawa~et ~ II 111~ci l·f·':: .. ~1111 III BNC c=m O·SUB ......... Power cord (supplied)

To video output

~ Video signal (able (supplied)

Connecting a Macintosh system Use the supplied video signal cable, and d MaCintosh adapter (not supplied).

Set to D-SUB.

To a wall outlet

+- ~ 1'1 ttrn~IU Power cord (SUPPlied: I \

Connecting a computer to the BNC connector Use it BNC video signal cable (not supplied) Set to BNC.

Toawal~t ~ II 1,5.1111 II r BNemlDsuB1 Power cord (supplied)

Computer

I~~Q£JI To video output

Video signal cable (not supplied)

6 F ~"!

Attaching the ferrite cores

Wht:'n you use a Video signal cable otiWf Ih,1I1 the ~uppllL'J one, be sure to dtt,Kh the supplied terntl' core ,l~ dlll~trdted

Close the lid.

~ ~ Pull the supplied plastic binder tightly.

~ ~~ -~-~" 1l-~1

Preset Mode

The Multiscan 205h autoillatically ad!ll~b the J.l~pl<ly ~ize .lnd POSition to the optimum 1Il J((ordann: \'11th the Input Signal up to l~ Jltfert:'nt types. [t has factory-presd adjustment dato for 9 Jlfferent types of ~ignab (preset mode). When a computer or it \ .... orkstation

No. Display Horizontal (dots x lines) frequency

I 640 x 480 31.5 kill --

2 800 x 600 46.9 kllz

3 832 x 624 497kHz

4 1024 x 768 60.2 kHz

5 1152 x 870 68.7 kHz

6 1280 x \024 80 0 kHz

_7_ 1600 x 1200 93.6 kHz I-----~~~-

I 8 1600 x 1200 100 kHz

9 1600 x 1200 106.3 kHz I -

l)VGA I~ d tr,ldemMb nf lUr-..t Cnrporat!on 2)VESA i~ ,I tr,ldl'm,lrl-.ul tilt.' Illln-pmfit llrg,lIl1L,ltHlll, VIdeo

Electrolllc~ Stcll1d,1rd r\~Sl)(l<lt\On 3)r-.tacI!Ho~h l~ ,I Ir,lliL'marl-. ()f Applt' Compukr [nc

Em • Tht' button~ nil the tront panel ,III<H\' IlMlllldl iHijustnwnt

\\·hen ,1 "'1~n .... 1 tWin l'qulpnH'nt uther 111,111 the pre~et·type HHH.it'b.,.; mput \;inL' dllterl'lIt m,lnu,llly ,1Jju~tl;.'d d,lta .HI..' ~tllrl'd in 1lH"II\llrv, ,1nd LlllL'd b.l~l.. when the '>,lnlL'

:::OlMI1,lll:::O Input ,1g,lIn:::oo th,lt tilt., Opltll1Ul\1 dl:>plav lor thl~ '>1 t; 11 ,1 I I." ,)bt,lllll'd ,lut{ltn,IIIl,llly

mn1 If you do not att,Kh the h~rnte core, the monitor will not (ontorm 10 manJatory FCC st,lIldarJ."

that Issues :::ouch ~lgnal I::. connected, thl! optimum dbplay IS

obtained without any manual adjustment . The factory-preset adjustment data are listed below:

Vertical Graphics mode

frequency

Iilliz YGA GraphiC 1)

75 Hz YESA2)

75 Hz Macmtosh 16" color)) I

75 Hz M,Kinto~h 19" color

75 Hz Macmtosh 21" color

75 Hz VESA

75 Hz VESA

80Hz 1

VESA

85 Hz I VESA

• The type ot Input vldeu Signal is dlstlnguisht:'d according to its ~ignal ::.peClficatlOns, such.1s horizontal frequency or ::.ync polaflty. When the Signal specitications 01 the mput ::.!gnaJs iHe almost same, these signals may not be dIStingUished ,l~ bemg different.

• If \fOll use a computer or vH.iea board of high output level (,lbullt 1.0 Yp-pl, you may not bt' able to obtam the optimum display. In such case, try decre,\sing the pICture

(Ulltr""t (p,lge H)

7

SECTION 2

DISASSEMBL Y

GDM-20SHT

2-1. REAR CABINET AND TOP COVER REMOVAL

2-2. D BLOCK ASSY REMOVAL

CD Five screws (-t-BVTP M4 x 8) CD Four screws

(+BVTP 4 x 16)

CD Rea' cablnel j ~/~ ,. ,

~

®Two screws (+-BVTP M4 x 8)

!J) Rear shield

I

)

CD Two push rivets

!J) Two screws (+-BVTP M3 x 8)

\ @Two PCB holde'

,.1

CD Screw j Push (+--BVTP M4 ,81 ~ ~

CD Four screws (-t-BVTP M4 x 8)

-7-

CD 0 block assy (Remove the twelve connectors, CN401-404, 406-411, FV1, FV2)

GDM-20SHT

2-3. POWER BLOCK ASSY REMOVAL

IJ) Top shield

""Q , CD Two PCB holder

CD Four screws G)Twoclaws

CD Power block assy (+-BVTP M4 x 8)

(Remove the three connectors CN603, 605, 606)

2-4. L BOARD REMOVAL

G) L board

~~d--t~CD Two claws

-8-

2-5. M BOARD REMOVAL

2-6. A BLOCK ASSY REMOVAL

FV1

Earth lead CN101

@M board

CD Two screws

. ~ (-t-BVTP M4 x 8)

~:?"\ 1 CD Two screws

(+-BVTP M3 x 8) CD Two screws

(+-BVTP 3 x 12)

CD Video shield cover

CN104

)~ " CN102

CD A block assy (Remove the eleven connectors,

GDM-20SHT

CN1 01-1 04, J1 01-301, FV1, FV2, NTC, Earth lead)

(DScrew (Hexagon head screw M4 x 20)

-9-

GDM-20SHT

IDBI [8J REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

RESISTOR D901 8·719-045-19 DIODE SPB-26MVWF D902 8-719-311-90 DIODE SEL 1922D-C

Rl0l 1-216-073-00 METAL GLAZE 10K 5% WOW D903 < 4-049-089-01 HOLDER, LED

Rl02 1-208-806-11 METAL CHIP 10K 0.50%1/10W 0903 8-719-311-90 DIODE SEL 1922D-C

Rl03 1-218-768-11 METAL CHIP 470K 0.50%1/10W

Rl04 1-218-760-11 METAL CHIP 220K 0.50%1/10W 0904 8-719-311-90 DIODE SEL 1922D-C

Rl05 1-216-649-11 METAL CHIP 820 0.50%1/10W D905 8-719-311-90 DIODE SEL 1922D-C 0906 8-719-311-90 DIODE SEL 1922D-C

Rl06 1-216-663-11 METAL CHIP 3.3K 0.50%1/10W 0907 8-719-311-90 DIODE SEL1922D'C Rl07 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W 0908 8-719-911-19 DIODE lSSl19-25

Rl08 1-216-073-00 METAL GLAZE 10K 5% 1/10W

Rl09 1-216-627-11 METAL CHIP 100 0.50%1/10W D909 8-719-911-19 DIODE lSSl19-25

Rll0 1-216-049-91 METAL GLAZE lK 5% 1/10W D910 8-719-911-19 DIODE lSS119-25 D911 8-719-911·19 DIODE lSS119-25

Rlll 1-216-049-91 METAL GLAZE lK 5% 1/10W 0912 8-719-311·90 DIODE SEL1922D-C R112 1-216-049-91 METAL GLAZE lK 5% 1/10W 0913 8-719-109·85 DIODE RD5.1 ESB2

R113 1-249-887-11 CARBON 33 5% 1/4W F R114 1-208-806-11 METAL CHIP 10K 0.50%1/10W 0914 8-719-109-85 DIODE RD5.1 ESB2

R115 1-208-814-11 METAL CHIP 22K 0.50%1/10W 0915 8-719-109-85 DIODE RD5.1 ESB2 D916 8-719-109-85 DIODE RD5.1ESB2

Rl16 1-208-814-11 METAL CHIP 22K 0.50%1/10W D917 8-719-109-85 DIODE RD5.1 ESB2 Rl17 1-208-e06-11 METAL CHIP 10K 0.50%1/10W 0918 8-719-109-85 DIODE RD5.1 ESB2

R118 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W

R119 1-216-627-11 METAL CHIP 100 0.50%1/10W D919 8·719-109-85 DIODE RD5.1 ESB2 R123 1-249-437·11 CARBON 47K 5% 1/4W 0920 8-719-911-19 DIODE lSS119-25

0921 8-719-911-19 DIODE lSSl19-25 R124 1-249-437-11 CARBON 47K 5% 1/4W 0922 8-719-911-19 DIODE lSSl19-25 R126 1-208-854-11 METAL CHIP 1M 0.50%1/10W D923 8-719-911-19 DIODE lSS119-25

R130 1-208-806-11 METAL CHIP 10K 0.50%1/10W 0924 8-719-311-90 DIODE SEL 1922D-C

1rw ............. , ................................................................. 1I''Ir* .............. ."." ... .",., ....... 11' ...... ."." • ."11'11',,, ......... IC

H BOARD IC931 8-759-285-18 IC MC68HC05P7BSC402191 B ........................... - IC932 8-759-165-81 IC PST600D-T (BOARD PART NO. 1-657-355-11)

4-045-133-01 HOLDER (B), LED COIL

L901 1-410-482-31 INDUCTOR 100UH CAPACITOR

C904 1-102-114-00 CERAMIC 470PF 10% 50V TRANSISTOR - . C905 1-102-114-00 CERAMIC 470PF 10% 50V - .

C906 1-102-114-00 CERAMIC 470PF 10% 50V 0931 8-729-900-36 TRANSISTOR DTC124ES C907 1-102-114-00 CERAMIC 470PF 10% 50V 0932 8-729-902-80 TRANSISTOR DTA 114 YS C931 1-128-057-11 ELECT 330MF 20% 6.3V 0933 8-729-902-80 TRANSISTOR DTA 114 YS

C932 1-161-051-00 CERAMIC O.OlMF 10% 50V C933 1-126-160-11 ELECT lMF 20% 50V RESISTOR C945 1-136-165-00 FILM O.lMF 5% 50V C990 1-136-153-00 FILM O.Q1MF 5% 50V R901 1-247-807-31 CARBON 100 5% 1/4W

C991 1-136-153-00 FILM O.Q1MF 5% 50V R902 1-247-807-31 CARBON 100 5% 1/4W R903 1-247-807-31 CARBON 100 5% 1/4W

C992 1-136-153-00 FILM O.OlMF 5% 50V R904 1-247-807-31 CARBON 100 5% 1I4W

C993 1-136-153-00 FILM O.OlMF 5% 50V R905 1-247-807-31 CARBON 100 5% 1/4W

R906 1-249-423-11 CARBON 3.3K 5% 1/4W

CONNECTOR R907 1-247-807-31 CARBON 100 5% 1/4W R908 1-249-425-11 CARBON 4.7K 5% 1/4W

CN901<1-564-525-11 PLUG, CONNECTOR lOP R909 1-249-425-11 CARBON 4.7K 5% 1/4W R910 1-249-425-11 CARBON 4.7K 5% 1/4W

DIODE R911 1-249-425-11 CARBON 4.7K 5% 1/4W

R912 1-247-807-31 CARBON 100 5% 1/4W' . . "-0901 < 4-049-089-01 HOLDER. LED R913 1-247-807-31 CARBON 100 5% 1/4W

-76 -

GDM-20SHT

[H] [IJ REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

R914 1-247·807·31 CARBON 100 5% 1/4W C711 1·124-122-11 ELECT 100MF 20% 50V R915 1-247·807·31 CARBON 100 5% 1/4W C712 1-102·973-00 CERAMIC 100PF 5% SOV

R916 1-247·807·31 CARBON 100 5% 1/4W C713 1-102·973-00 CERAMIC 100PF 5% 50V

R917 1·247·807·31 CARBON 100 5% 1I4W C714 1-102·121·00 CERAMIC 0.0022MF 10% 50V R918 1·247·807·31 CARBON 100 5% 1/4W C715 1-126-964·11 ELECT 10MF 20% 50V R919 1·247·807-31 CARBON 100 5% 1/4W C716 1-126·964-11 ELECT 10MF 20% 50V R921 1-247-903-00 CARBON 1M 5% 1/4W C717 1·126·967·11 ELECT 47MF 20% 50V

R931 1-249-437-11 CARBON 47K 5% 1/4W C718 1-126-967-11 ELECT 47MF 20% 50V R932 1-249-437-11 CARBON 47K 5% 1/4W C719 1·126-964-11 ELECT 10MF 20% 50V R933 1-249-437-11 CARBON 47K 5% 1/4W C720 1·126·964-11 ELECT 10MF 20% 50V R934 1-249·437-11 CARBON 47K 5% 1/4W C721 1·136-165-00 FILM 0.1MF 5% 50V

R935 1·247-903-00 CARBON 1M 5% 1/4W C722 1-137 -364·11 FILM 0.001MF 5% 50V

R936 1·247·895-00 CARBON 470K 5% 1/4W C723 1-136-165-00 FILM 0.1MF 5% 50V R937 1-249-437-11 CARBON 47K 5% 1/4W C726 1-126-964-11 ELECT 10MF 20% 50V R938 1-249-437-11 CARBON 47K 5% 1/4W C727 H26-964·11 ELECT 10MF 20% 50V R939 1-247·895-00 CARBON 470K 5% 1/4W C728 H36-169-00 FILM 0.22MF 5% 50V R940 1·249-437·11 CARBON 47K 5% 1/4W C729 1-136-169-00 FILM 0.22MF 5% 50V

C730 1-102·074·00 CERAMIC 0.001MF 10% SOV SWITCH C731 H02-074·00 CERAMIC 0.001MF 10% 50V

C732 1-136-169-00 FILM 0.22MF 5% 50V S902 1·571-532-21 SWITCH, T ACTIL S903 1-571-532-21 SWITCH, T ACTIL S904 1-571·532-21 SWITCH, TACTIL CONNECTOR

S906 1-571-532-21 SWITCH, TACTIL S907 1-571·532-21 SWITCH, TACTIL CN701'1-564-514·11 PLUG, CONNECTOR 11 P

CN702'1-564-511·11 PLUG, CONNECTOR 8P S908 1-571·532·21 SWITCH, TACTIL S910 1-571-532·21 SWITCH, TACTIL S911 1-571-532-21 SWITCH, TACTIL DIODE

S912 1-571-532·21 SWITCH, TACTIL S913 1-571-532·21 SWITCH, TACTIL 0701 8-719-979-84 DIODE EGP20DPKG23

0702 8-719-979-84 DIODE EGP20DPKG23 S914 1·571-532·21 SWITCH, TACTIL 0703 8-719-911-19 DIODE 1SS119-25 S915 1-571-532-21 SWITCH, T ACTIL 0704 8-719-911-19 DIODE 1SS119-25

S916 1-571·532-21 SWITCH, TACTIL 0705 8-719-109-54 DIODE RD2.2ESB2

0706 8-719-109-54 DIODE RD2.2ESB2 CRISTAL

X931 1·577·358-21 VIBRATOR, CERAMIC IC

IC701 8-759-803-42 IC LA6500-FA IC702 8-759-803-42 IC LA6500-FA

....... * ............................ 11' .................................................................................................................................................. ,.. ............ IC703 8-749-924-04 IC STK390-120 IC704 8-759-803-42 IC LA6500-FA

CONVERGENCE ADJ MCB ASSY (L BOARD) .................................................................. ,.. ................................

(BOARD PART NO. 1·657-356-11) TRANSISTOR

4·382·854-21 SCREW (M3X14), P, SW (+) (IC703) 0701 8-729-900-36 TRANSISTOR DTC124ES

CAPACITOR RESISTOR

C703 1-137 -364-11 FILM 0.001MF 5% 50V R701 1-215-469-00 METAL 100K 1% 1/4W

C704 1-136-165-00 FILM 0.1MF 5% 50V R703 1-249-423-11 CARBON 3.3K 5% 1/4W

C705 1-137-364-11 FILM 0.001MF 5% 50V R704 1-215-434-00 METAL 3.6K 1% 1/4W

C706 1-136-165-00 FILM 0.1MF 5% 50V R705 1-215-423-00 METAL 1.2K 1% 1/4W

C707 1-102-518-11 CERAMIC 33PF 5% 50V R706 1·249-381·11 CARBON 1 5% 1/4W F

C708 1-102-074-00 CERAMIC 0.001MF 10% 50V R707 1-215-373-31 METAL 10 1% 1/4W

C709 H07-889-11 ELECT 220MF 20% 25V R708 1-249-429-11 CARBON 10K 5% 1/4W . 1-124-122-11 ELECT R709 1-249-420-11 CARBON

. "-C710 100MF 20% 50V 1.8K 5% 1/4W

-77-

GDM-20SHT

REF.NO. PART NO. DESCRIPTION

R710 1·249-422-11 CARBON 2.7K R711 1·249-407-11 CARBON 150

R712 R714 R715 R716 R717

R718 R719 R720 R721 R722

R723 R724 R725 R726 R727

R728 R729 R730 R731 R732

R733 R739 R741

9-978-489-01

1-249-386-11 CARBON 1-249-425-11 CARBON 1-249-421·11 CARBON 1-249·405·11 CARBON 1-249·405·11 CARBON

1·216-423-11 METAL OXIDE 1-216-351·00 METAL OXIDE 1-249-425-11 CARBON 1-249-441·11 CARBON 1-249-437·11 CARBON

1-249-434-11 CARBON 1-217-637-00 FUSIBLE 1-217-637-00 FUSIBLE 1·215-453-00 METAL 1·249-423-11 CARBON

1-215-434-00 METAL 1-215-421-00 METAL 1-249-381-11 CARBON 1-215-373-31 METAL 1-215-428·00 METAL

1-249·422-11 CARBON 1-215-458-00 METAL 1-215-445-00 METAL

MISCELLANEOUS ,.. ........ ,..,.. ...... ******.**.** ...

2.7 4.7K 2.2K 100 100

27 1.5 4.7K lOOK 47K

27K 1 1 22K 3.3K

3.6K 1K 1 10 2K

2.7K 36K 10K

5% 5%

5% 5% 5% 5% 5%

5% 5% 5% 5% 5%

5% 5% 5% 1% 5%

1% 1% 5% 1% 1%

5% 1% 1%

Les composants identifies per un trame et une marque Lt; sont critiques pour la securite. Ne les remplacer que par une piece portant Ie numero specifie.

REMARK REF.NO. PART NO.

1/4W 1/4W F

1/4W F 1/4W 1/4W 1/4W F 1/4W F

lW F 1W F 1/4W 1/4W 1/4W

1/4W 1/4W F 1/4W F 1/4W 1/4W

1/4W 1/4W 1/4W F 1/4W 1/4W

1/4W 1/4W 1/4W

Sony Corporation . Consumer A&V Products Company

TV&Display Products Div.

-78-

The components identified by shading and mark Lt; are critical for safety. Replace only with part number specified.

DESCRIPTION REMARK

Engllsl) ',_ 95FK0506-1

Printed in Japan © 1995. 6

GDM-20SHT

2-7. H BOARD REMOVAL

CD Two screws (+P4x12)

CD Bezel assy

2-8. PICTURE TUBE REMOVAL

CD Four claws

CD Picture tube (Remove the four connectors, CN404, 407, 4P, 2P)

-10 -

CD A block assy (Refer to 2-6)

GDM-20SHT

2-9. WIRING HARNESS LAYOUT

(1) Left Side (2) Right Side

o block assy Power block assy

• REMOVAL OF ANODE-CAP NOTE: Short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon painted on the CRT, after

removing the anode.

• REMOVING PROCEDURES

CD Turn up one side of the rubber cap in the direction indicated by the arrow 0.

• HOW TO HANDLE AN ANODE-CAP

® Using a thumb pull up the rubber cap firmly in the direction indicated by the arrow®.

~ Don't hurt the surface of anode-caps with shartp shaped material! Don't press the rubber hardly not to hurt inside of anode-capsl A material fitting called as shatter-hook terminal is built in the rubber.

® Don't turn the foot of rubber over hardly! The shatter-hook terminal will stick out or hurt the rubber.

- 11 -

Anode Button

® When one side of the rubber cap is separated from the anode button, the anode-cap can be removed by turning up the rubber cap and pulling up it in the direction of the arrow @'

GDM-20SHT SECTION 3

SAFETY RELATED ADJUSTMENT

When replacing or repairing the shown below table, the

following operational checks must be performed as a

safety precaution against X-rays emissions from the .unit.

HV Regulator D board CPI, R099, RI02, Circuit Check RI05, T6

DA board C104, C106, ICIOI, ICI02, Q106, RI02, R104, RI05, RI06, RI30 • Mounted D board • Mounted DB board

HV Hold-Down D board C025, CPI, D9, Circuit Check D21, R099, RI02,

R104, R114, R115, R116, T6 • Mounted D board

Beam Current D board C068, C076, C079, Protector Circuit C081, CPI, D021, CD and ® Check D022, D024, D025,

L009, R099, RI02, RI04, R105, RI07, T6 • Mounted D board

B+ Regulator G board IC657, R673 Circuit Check • Mounted G board

OVP Circuit G board C654, D658, D659, Check IC657, Q654, R659,

RY603 • Mounted G board

Check Condition

Input signal: White dots, fH: 107 KHz BRT and CONT

control to minimum.

a) HV Regulator Check

1) Check that the voltage at pin (]) of N405 IS -.

9.00 ± 0.03 VDC.

b) HV Hold-Down Circuit Check

1) Using an external DC power supply, apply the volt

age is less than 8.87 VDC between pin ® of CN405

on D board and confirm that the HV Hold-Down cir

cuit works (Raster disappears or Power LED blinks.)

c) Beam Current Protector Circuit Check-1

I) Short between pin ® of CN405 on D board and

GND by a short clip under Power off condition.

2) Confirm that the raster appears on the CRT screen

under Power on condition.

3) Connect a variable resistor (12 KQ or more) and an

ammeter in series between pin @ of CN405 on D

board and GND, then decrease gradually the resis

tance of the variable resistor from maximum to mini

mum, and confirm that the beam current protector

circuit-I works (TV Raster disappears or Power LED

blinks).

The current must be less than 1.35 rnA.

4) Remove the short clip between pin ® of CN405 on

D board and GND.

d) Beam Current Protector Circuit Check-2

I) Confirm that the raster appears on the CRT screen

under Power on condition.

2) Connect a variable resistor (12 KQ or more) and an

ammeter in series between pin @ of CN405 on D

board and GND, then decrease gradually the resis

tance of the variable resistor from maximum to mini

mum, and confirm that the beam current protector

circuit-2 works (TV Raster disappears or Power LED

blinks).

The current must be less than 1.50 rnA.

e) OVP Circuit Check

I) Using an external DC power supply, increase gradu

ally the voltage between pin CD of CN605 on G

board and GND, and confirm that the OVP circuit

works (TV Raster disappears when the voltage be

tween pin CD of CN605 on G board and GND is less

than 199.0 VDC. • ,_

-12 -

GDM-20SHT

SECTION 4

ADJUSTMENTS

Input Signals: SONY-STD-2 (63.337 kHz x 59.978 kHz, 1280 x 1024)

1. Confirming VIDEO output waveform, and ad

justing RV101, 201, 301 1) Enter the full white signal. 2) Set the R/G/B contrast data to "00", and confirm at the KR,

KG, KB pins of CRT socket that the pedestal voltage is as shown below.

VP=50 V±2 V

3) Set the R/G/B contrast data to "FF", connect an oscilloscope to the KR, KG. KB pins of CRT socket, and adjust the RVI01, 201, 301, so that the VIDEO output waveform Vs satisfies the following specification.

Vs KR : 42 Vp-p ± 1 Vp-p KG. KB : 40 Vp-p ± 1 Vp-p

2. Confirming and adjusting transient response 1) Connect respective measuring units as shown below.

Tr = Tf = 2.0±0.1 ns

Pulse Gem

2) Enter the pulse signals from pulse generator to R input and set contrast data to "FF".

3) Connect an oscilloscope probe to KR. set the time axis to 20 ms/div, and adjust the CTI0l not to allow a sag or smear in the falling edge of waveform.

U-' 100%

I I

I I

\ I

- - 0% ~ I ~d~~~ the trimmer Smear Q ~e flat

Sag

4) Press the x IOMODE button of time axis on oscilloscope. and confirm that the Tr. Tf. undershoot, overshoot. and ringing of waveform are within the specification.

5) If the undershoot is over the specification. readjust the trimmer so that the undershoot is below 12%.

Overshoot ;;;; 10%

J~ __ _

Ringing;;;; 10%

10% I Trm ;;;;3.8ns

.. I I ..

6) Also for the KG and KB pins of CRT socket, perform adjustment given in steps (2) to (5) in the same manner. (For the KG, adjust CT201; for the KB. adjust CT301)

• Landing Rough Adjustment 1. Enter the full white signal. 2. Adjust the contrast to the maximum. 3. Make the screen monogreeen. (tum off R, B input signals). 4. Reverse the DY, and adjust coarsely the purity magnet so

that a green raster positions in the center of screen. 5. Moving the DY forward, adjust so that an entire screen be

comes monogreen. 6. Adjust the tilt of DY. and fix lightly with a clamp.

• Convergence Rough Adjustment 1. Enter the white crosshatch signal. 2. Open the hexode knob mounted at the CRT neck to 60'. 3. Adjust coarsely the horizontal convergence using the H

STAT VR on the board A. 4. Adjust coarsely the vertical convergence through the V

ST AT bus adjustment.

XBV

DY spacer

Purity magnets

H.STAT VR (RV2)

-13 -

GDM-20SHT

• Landing Fine Adjustment 1. Place the set in the Helmholtz coil. 2. Enter a green signal only, and adjust the contrast to the maxi

mum. 3. Attach a wobbling coil to the specified position of CRT

neck. 4. Attach a landing adjuster sensor on the CRT. 5. Using a landing checker, adjust the DY position, purity, tilt

of DY, and landing at the center and four comers. 6. Remove the landing adjuster sensor. 7. Swing up and down the DY so that the top and bottom pins

are equal. Also, swing left and right the DY so as to attain the best horizontal trapezoid, and insert wedges in the form of reverse "Y" to secure the DY.

8. Attach a landing adjuster sensor on the CRT. 9. Confirm the landing at each comer. and if out of specifica

tion, stick a disk magnet to the funnel section. and perform adjustment.

10. Change over the input signal to R, G, B and confirm that the purity of monocolor is good.

11. Confirm that the DY is not tilted, then fix the purity magnet with a white pen.

• Convergence Fine Adjustment 1. Enter the white crosshatch signal of the mode 3. 2. Confirm that the V -ST AT and H-STAT for the user control

are in the center. 3. Adjusting the RV -2 (H-STAT VR) on the board A, make

red, green, and blue lines parallel (vertical lines). Through the bus adjustment, adjust the V -STAT to make red, green, and blue lines parallel (horizontal line).

4. Adjust the magnet ring (hexode) at the rear of NTC so that the distance between red and green, and the distance between blue and green of three color lines are equal. If the compensation is deficient. adjust additionally the magnet ring at the rear of DY.

5. Returning the H-ST AT VR and the V -ST AT bus control adjusted in step 3, eliminate a misconvergence in the center of creen.

6. Fine adjustment of convergence 1) Adjust the XBV misconvergence with the XBV reactor. 2) Adjust the XCV misconvergence with the XCV reactor. 3) Adjust the Vertical misconvergence with the TVL. 4) Confirm the convergence of entire screen. 5) Fix the XBV, XCV, hexode, and H-STAT VR with a

white pen.

RGB XCV Misconvergence

B R

>< --~f:--- R -- -- G --~ \--- B

I I

• Digital Convergence Fine Adjustment 1. Enter the white crosshatch signal of the mode 3. 2. Connect only the Rand B signals. 3. Adjustment of NTC (bus adjustment)

1) Adjust the center convergence of screen with the V-STAT.

2) Adjust the bottom convergence of screen with the NTC BOTTOM.

3) Adjust the top convergence of screen with the NTC TOP.

4. H-CONV. adjustment (bus adjustment) 1) Set the bus data H-STAT to 148 (94h), and adjust the H

ST A T with the H-ST AT VR on the board A. 2) Adjust the convergence at the position as shown in the

order of numbers. 3) The H-STAT, if finely adjusted again, should be in the

range of 120 to 168. 4) Save the data. 5) Although the adjustment is executed for the signals

other than mode 3, the factory area for V -STAT and HST AT is common to all modes, and therefore, do not change the V -ST AT and H-STA T after they are adjusted in the mode 3.

6) Copy the bus data of mode 3 to all modes. 7) Execute adjustment in all modes in the same manner as

that in 4-2). 8) After the adjustment is over, save the data. 9) If out of specification 0.24 mm or less, adjust using a

sheet of permalloy. (Replace the DY, if more than five sheets are required.)

B Prime mode 0.24 mm A Others 0.24 mm

B Prime mode 0.24 mm Others 0.28 mm

-14 -

GDM-20SHT

Connect the communication cable of the computer to the connector located on the D board on the monitor. Run the service software and then follow the instruction.

Adjustment Software

DAS Ver X.X

~ Programmable

S.G Serial

IIF

RS232C

Serial IIF

RS232C

ex. PC-AT compatible

• White Balance Adjustment Methods

Adjustments Input signal Value of CONT, BRT

procedure

ADJUSTMENT G2

I COLOR Mode "H"

2 Grayscale pattern CONT=255. BRT=85

ADJUSTMENT 9300K

I Gray scale RBKC. BBKC to ° CONT=255. BRT=x5

2 Gray scale CONT=255, BRT=85

3 Full white pattern CONT=255, BRT=85

4 Full white pattern CONT=O, BRT=85

5 Black pattern CONT=O, BRT=255

6 Full white pattern CONT=255, BRT=255

Adjust point

G2

GBKC

RBKC,BBKC

RDCM. GDCM, BDCM

RDCN, GDCN, BDCN

RBKM, GBKM, BBKM

RDMM, GDMM. BDMM

7 Confirm white balance tracks with CO NT and BRT. Set CONT=255 and BRT=85 color savc

ADJUSTMENT 6500K

I COPY 9300K data to 6500K. Select color mode to "MID"

2 Gray pattern CONT=255, BRT=85 RBKC,BBKC

3 Full white pattern CONT=255, BRT=85 GDCM, BDCM

4 Full white pattern CONT=O, BRT=85 GDCN. BDCM

5 Black pattern CONT=O, BRT=255 RBKM, GBKM. BBKM

6 Full white pattern CONT=255. BRT=255 RDMM. GDMM, BDMM

7 Confirm white balance tracks with CO NT and BRT. Set CONT=255 and BRT=85 color save

ADJUSTMENT 5000K

I COPY 9300K data to 5000K. Select color mode to "LOW"

2 Gray pattern CONT=255, BRT=85 RBKC,BBKC

3 Full white pattern CONT=255, BRT=85 GDCM. BDCM

4 Full white pattern CONT=O, BRT=85 GDCN, BDCN

5 Black pattern CONT=O, BRT=255 RBKM, GBKM, BBKM

6 Full white pattern CONT=255, BRT=255 RDMM. GDMM, BDMM

7 Confirm white balance tracks with CONT and BRT. Set CONT=255 and BRT=85 color save

-15 -

--

GDM-20SHT

• DIAGNOSIS

The monitor is equipped with self diagnosis and failure indication. Indicators will blink when the monitor detects adjust- _

ment limit or a major failure.

~ CONVER SHAPE SIZE CENTER Power Save Power

State (Amber) (Green)

Power ON Normal OFF OFF OFF OFF OFF ON

NO. H Sync Stand-by OFF OFF OFF OFF ON ON

NO. V Sync Suspend OFF OFF OFF OFF ON ON

NO. H/V Sync Active off OFF OFF OFF OFF ON OFF

Out of Range Out of Range OFF OFF OFF OFF ON Fla,hing

H. Failure Failure OFF OFF OFF ON Flashing Flashing

V. Failure Failure OFF OFF ON OFF Flashing Flashing

IK Protector Failure OFF ON OFF OFF Flashing Flashing

HV Protector Failure ON OFF OFF OFF Flashing Flashing

-16 -

SECTION 5

DIAGRAMS

5-1. BLOCK DIAGRAMS

~-----

-17 -

GDM-20SHT

L ___ '

TS02

?" ~ - - - I"

GC

L

I, G==j 1 ____ -.J

GDM-20SHT

For Service Manuale MAURITRON SERVICES

8 Cherry Tree Road, Chlnnor Oxford.hlre, OX9 4Qy'

Tel (01844) 351694 Fax (01844) 352554

email:-mauritron<S>dial.pipe)(.com

G (POWER SUPPLY)

s.Tav (12")

-18 -

FIIOM/To [) 110,0,1'10

( s,lON"'I... IN

F~O ... /To

~ aOARC C r-.,-<t<o+=----

H (POWER) SW !R

M (!NTERFAC SYNC SEF

--------.1 .)1105

---8--'----

IFiJ"'" 00<

'!i so ...

G SCL

1 yeLl(

_~1!I'l1 '~..,. 12

H CL"'~P

cu' oeOl.802

C .. 103

H """ ,

A V SYNC

, j H PC, , j , PC,

c .. eOl

H (.1..""'"" ,

, '" , J

C"'801

0 . " . B . ., ,

TXO ..

CHeo ..

se02 rllo----r---',:.::'-:' t<;>' -!------, TE 50 T ~ 50 1 1

'iTERFACE) YNC SEP

-- ----------,I~: rff~~; I=QP "'" L~

KS5 2

f(Sl 1

------------------~

h , 90""0 (. ..... 11

FAO ... , 1I0",RO E (. .... 02

FRO •• VTo 0 BOARD

(. .. -409

FAO ... o BO .... RO

CN'tO& F

GDM-20SHT C

,...-------------------------------------------------------I " PIX CONT IClel

aUFFEAI-_________ ~'0 VIN ou-r A 1~ ~ OUT ~ORIV£ ~ IUF""'illl

0100 r------~lZ ell" OUT II 1~ O'Ol~'05 1 lel02 010~10' ~ ____ --\B PI", OUT C. ,~

.. ,2V --Vv .. 11"1.." L... ___ ~

Jl01 \':::7

1(201

Go IUFFEP I---HI------t-~~'o vi N .)201 ~(ot-"-------, Q200 ,.(,i Cu" :~: ::rl 0. OUT

Q201-205

(.Nl02

, ,,0

l , ce'

l , ..,,,

CN1.rtllKV

I

~LD

~YIN ~+_+_--_+_~~~~2'CLP

y::: ...

O/A CONY

'" AD118 ,-

OUTc,q '----~

..},-" CL ~ ",",201

A021. %-.. ,2V

"" '" ,

" ", ,)--- % --

j 0.1 alAS ""O<l5'}-----..,J CONT

.. , .. <;>------..,J le1. le2. 11/2)

,,05 '!i'}------'l 0400. !oDD. '00

J ADa 1')--------t----j, H STAT

",." IC9. 01

-~. -+a~_+a2

E

A (VIDEO)

- -----------------------------

-19 -

GDM-20SHT GDM-20SHT

F= ::~: 1------------------ GI-a

A (VIDEO)

- 20-

- 21 -

GDM-20SHT GDM

9 ~ CA~C~L & ,

·~·sn::;:: ~'''' le120 :2 }'-'-----t------+-+

~+-----~~" • " .

~-..j-(::>+':"-:----+-f-----------<9) >IS

~-_k~~-~-+----------~~~" 1--_-1-<"'>+'"...:'..:"'-=---_+ _________ ----00<1]) ... ,,"OL

I--_..j-(:n~'...:.~o~'--f_---------~,~.v PO~ ~-~~~'~.O~--t----------~'~BRXO

"1 HV PROT

l-_.k,.~,-'O::u"-,-___': tC1l1):i,~, __ -rt+--14--~37 V STOP

~-+'*".,.G"-'---------+----o{~ IIQA

1~ HF9

DA (V BLK.HV REG. HV PROT)

"u lell'

WUT~ ~~-------+

LO:: X(,~", _--------+

0"'"'" IOIi"J'-----H CLT

COM lO{iO)----_LOAO

.. os I 2Oi\--1~---~"

CL ~:D ! CL K

I ~ E'I' 1'10l0I

• IC108 :I le10e

DL02(,~~------t--

L,_, _____________________________________________ --------

GDM-20SHT

__ NeLT

_LOAD

_...oSI

0~~" Ii IC10e :2

1 IC109

D£GAUSS

-

i I

>'4 CONT

lel02 I 0ouu:', ','}--+--~4-~--~ I,------t-t-r-r----------------~-------j 1'1£1''1 ,

~ ________ ~,'25 IHI'1 OU,'! 10)----

~~ :10::1'1'" ~~:::~ ~f----------'2lZ7 "'0; OUTG ","',,---,-,--

II ~~~,~EN II-+-+---l-H-l-------------<- OUT71i'''~-+_t--_t 010'1. 107 :~2B_ II s...... OUT8:<>4

LOAO '.1..0",0 OVT9 ~

""OS I 15 SO lOUT 10 f CI..I' IS eu.:. J '---_ .....

I

."

1& LO vo ... r.!; I!> VI ... vaG 12

14 VIa. VOl' 11 , YO' '0' "r-----· '" VOO :204

22 VIC VOO , ZlV]C vo, , · V" '0' , ,

'" MOS] ~ 20 SOl

CL~ ~ ¥ell( CON\/' COI'IT

lela-.

· ." " OUT I r!-2S v SA ... OUT? 9

'I REF'! OUT' 10

210 V PARA OUT'" 20 v PARA OUT!> :n ,"p

OUTS 22

~ OU;7 ?wi 2 R£F2 OUTe 2't

OUT9 !!I

LOAD ---\, ... LOAD

ou". r IooIOS14' !> SOl

Cll<: ---(, 10 ell(

-(27 VS

v STAT

'"P lCl:n

='Y-

N PIN

'"P G~lOf? ;:) ,

II STAT " ... P le122

~,... ,

I~ -~ Lj:~ ~

P ...... "'1i: CONT

~~8-'" " PVLS€ lCI2'1

, .

1-------------------------------------------------------------------------------------------------

. . . '-

-22-

~T GDM-20SHT

---------------------~ 1 ,jr------

(N4l)8 CN701 -~r-~-,-----':"~':;;Q'..:' -ct~":'>--I'·-'-"---r ______ ~~"~'G'M' -----,_----,--k,~-I-r-i---l ~~; I -:J I l co .. ", SIOIO 9 ...... Ql I J IC7(l.4 f-___ -""~'G,.'.:.I_<.'*---.:Jo\ ce,

L CO .. ", (E ... 1" e J l 5W PULSE 10

c P TIl.. T G J

(N410

""" ,

c l '" I .. eLT . ""O"'/To

"'] SO , I '" 90 ... I'ID

C l'Ieo ~

HV PWM ,~ 1 " 1

vOv ,

f--------+-~-".':::'o·U'W~'"· ( PI'IT ~

i-

"T

l ·o, 12/ ~l

",) SO 10

,.," I-IV FI"Gr,~2/21 .. v REF 11

Lbi~f-r-i ........ ~'''J1---;:-j~l-''')-) _-_-j-~ j-t-_-_ -_ -_ -_ -_ ~'-"~C~£·l'-~O.~ B iL--" I ,xO :2

1'1-'<0 :-. FAO"'/To

"" 80"'I'ID eNel'l7

1-M POL :-. FI'IOIooI

J

I (NO] (2/2)

, ,oc " H POL 2S

V SYNC 2'2

H SVNC 21

R)(D 29

v OUT 14

FQP 1

'"'''9 15

HV pROT 7

flY REF Ii

l cp, PROTECT

I ~,"'BL lit PRO:~~ 1111. PROT !i

I!o ProT HV PROT G:>-______ + ______ _'"~V~'.~O~TU' 8 VPA IIV 'HI' l~'-----~-------'"~V~'O'-"'\..C' '--__ -.--J

.... BOARD CNI!I05

_______ ----------______ ~""~,,~~~,~'N-~02,_~ '" 2 E ALe -J

. _________ .....Jy To

" BOARD C"'1C2

a CONV CENT

L (CONVERGENCE)

~--------------~

r-------------------,;.;~ -~

::::::~ I "MUH@

~-+,~,~~-a'-02~~~~~~~~~1~r-,-:~-,,~ ~--tD".-J..-"'-.-----I 8~~::A 1--________ ~ ___ __.I I

7 Y STAT

DB ~------------------------------~

-24-

5-2. FRAME SCHEMATIC DIAGRAM

.-------------------CRT Sh,.,d

0----..... 6 ~~AT

~ ADJ RV2!

CRT 5" •• ,

A

GDM-20SHT

CRT Socket

I +82 64V ~

CNI03 2 GNt! ~

.Ji-L 3 +15V ~ ,S-MICRO 4 GNt! ~

l'"' VIDEO

f..=5+"_~5~V---l~ 6 H- ~

H

SIGNAL CONTROL

LAMP SW

~~~~~~~:J;;:(JJ ~\,!) u<"> ~::w:::::.::::::.::

:r

JJJ11)T]T

C~dW' RE~-L

,S-MICRO

,.- Go J202

a 0 J302 CNIOI

3P IIHT-L

,S-MICRO

r-r-r-_ N "'

"-"''' :CZZ <C')< ..J ..J U '" I U

1

SIGNAL IN [:::: :

J8060

J810 0

0 0

0 0

0

JB07

o

M

CNI04 2P

It'HT-L ,VH

r::r;:;-» "" - -

'-

0 0 INTERFACE 0 0

0 SYNC SEP 0 0

0 0

COMMUNICAT ION ~,-,J~80-.6 ......... --. ........ _,._,.__,__r_. Yro 0> '" .... '" '" .. .., N -

CNB04 lOP

WHT-L S-MICRO

- 25-

Il. " :c z < < ..J ..J

U"'''' ·z IC')U

-=-.:::.:. CNBOI

3P It'HT-L

,S-MICRO

CNI02 5P

BL(-L ,S-MICRO

_ N po') ..... U1

Q~-:>c;:I --.J....JU10Z -«uor--..(!)

:c ,

1 fj. SYNC

Z V.SYNC

CN803 3 H - POL 7P 4 v. POL

'SY_~LI-C~O 5 STBY + 12V 6 GNt! 7 +SV

I U.GNU

2 TXIl

CN807 3 RXIl 8P 4 C.ELK

'~~~IC~O 5 LOCK b STBY 5V 7 C.COOE a

B C.COoE I

CN802 6P

IIHT-L ,S-MICRO

f--------

f---f---f---

-~

---

7 H+ -...,

CNz1P6 WHT ,MINI

IKV II

H.SYNC 1

V.SYNC Z

H.POL 3

V.POL 4

STBY+12V 5

GNt! 6

+5V 7

U.GNU 1

TXt! z RXU 3

C.ELK 4

COCK 5 STBY 5V 6

C.COOE a 7

C. CODE I 8

CN411 7P

YEL ,S-MICRO

CN409 8P

REB ,S-MI CRO

CN402 5P BU

, S-MICRO

CN40S 7P

IIHT-L ,S-M I CRO

GD

-

(

DEF

II U L

>->Qc;JZ:L

II

Q Z

'"

RO

r;::-...., Q .."

> I

-

GDM-20SHT

~

8 u u ~

r=-r::

, + - -'" '" ., ., '" '"

I

+ I + I + I

UULJU~~l +

L CONVERGENCE

»Q»~ Olf'lZU10-.J N1~(,!)-rot1-

+ + I I I-

,,:

I >--l

~

8 >--~ ->--

r=-~ + , >- >-

TILT -l-l - -Jl'T

>- >-

0.0.

1 I

CN701 II P

YEl S'MICRO

F.PAC[

CY ,p

IIHT

~ '-' ., '"

:r ,.;

11[[ _ N "' .. + , + ,

uu u u .." .." "'''' II ,.,.

J J J

CN403 » » .... -OUlQU101-<.!) J"f'l-Z-f'fl 0« + + C,.") I I 0.. ~ ~ II--- 12P

REO ,S-HICRO

D

CI~~DB YEl

,S-HICRO

FOr

'" FBT

DEFLECTION

CN4D4 CN407 BP SP

BlK III-iT ,OY ,OY

- N "' . '" "" .... '" _ N "' .. '" I I • U U ;";,, >- >- >-->-Q

uu ....,...., QQ a:a:Z ,. ,. . ,. ,. 0.0."> QQ zz "'''' > >

II II

U ~u 1 H. DY V. DY

FBr HV

1 +BI ISOV ~

Z +BI ISOV ~

3 GNll ~

4 +15V ~

5 GNll ~

6 -15V ~

7 -5V ~

8 ST8Y 11V ~

9 +5V ~

10 5T8Y SV ~

11 DEGAUSS ~

I Z PO'o'ER ~

I ST8Y 5V ~

Z GN!l ~

3 HO ~

4 CLK ~

5 H.CTL ~

CN401 6 HI c----

3P CN410 \/HI ,S-HICRO bP

\/HT r::--;;-;;;- ,S-HICRO

+ , , uuu >-- >- >-zzz

-

NTC

5-

r Rcv-F====~=~~~~

~~....J0: ::::::: >-~PICTURE H= I 1111111 TUBE - 11 I :::::::

Irll~

CNbDb 7P

'fHT ,S-H I CRO CNb03

+61 64V 1 II !lGC

12 !lGC DUAUSS CO IL

GN!l 2

+15V 3

GN!l 4

-5V 5 HI- 6 CNb04

Hl+ 7 G I: DGe. C I I Z DGC .C I

+BI I BOV 1

+BI IBOV 2

GNll 3 POWER +15V 4 SUPPLY CNbOI

GN!l 5 l' AC IN ,--lOO At

15V 6 I Z AC IN ~ 0

IIL£T -5V 7

STBY 12V 8

+5V 9

STBY 5V 10 CNbOZ

!lEGAUSS II [I E F1IAIE g 5· PO'o'ER I Z

~

CNbD5 II E

12P Ne REO CNb07

,S-HICRO

DB AMP

8 T 8

DA B T 8

V.BLK, HV REG HV POT

.

- 26-

GDM-20SHT

5-3. CIRCUIT BOARDS LOCATION

DB

H

5-4. SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDS

Note: All capacitors are in ~F unless otherwise noted. pF: ~~F

50 WV or less are not indicated except for electrolytic. Indication of resistance, which does not have one for rating

electrical power, is as follows.

Pitch: 5 mm Rating electrical power 1/4 W

All resistors are in ohms. -EJ- : nonflammable resistor.

~ : fusible resistor.

£::" : internal component. c:::==:J : panel designation, and adjustment for repair. All variable and adjustable resistors have characteristic curve B,

unless otherwise noted. ...L : earth-ground.

,.J.y : earth-chassis.

All voltages are in V. Readings are taken with a 10 Mil digital multimeter. Readings are taken with a color-bar signal input.

Voltage variations may be noted due to normal production

tolerances.

* : Can not be measured. Circled numbers are waveform references.

: B + bus.

B - bus.

Reference information RESISTOR : RN METAL FILM

: RC SOLID

: FPRD NONFLAMMABLE CARBON

: FUSE NONFLAMMABLE FUSIBLE

: RW NONFLAMMABLE WIREWOUND

RS NONFLAMMABLE METAL OXIDE

: RB NONFLAMMABLE CEMENT

COIL : LF-8L MICRO INDUCTOR

CAPACITOR : TA TANTALUM

: PS STYROL

: PP POLYPROPYLENE

PT MYLAR MPS METALIZED POLYESTER

MPP METALIZED POLYPROPYLENE

ALB BIPOLAR

: ALT HIGH TEMPERATURE

: ALR HIGH RIPPLE

Note: The components Identified by shading and mark ••• &, are critical for safety. Replace only with part ••• number specified.

Note: Les composants Identifies per un trame et une marque &, sont critiques pour la securlte. Ne les remplacer que par une piece portant Ie numero speclfle .•

-27-

GDM-20SHT

[!:] [CONVERGENCE]

- L Board-

C70S I C707 A71 b

C709 R714 ~E

'" R7Z. R727 C71S +~D ~E '" N

co

023

R731

,729

'" N ~ W

I

R730 l1--li C729

,"'-

0 N ~

'"

.. e711

~I ~E to'" cnD

I~ +~~ ,.....~

C717

~E

'-----,U'l01 i<lU'l 10

1'-_

16 ,Wf .... C731 U'll'-I.... __ _

'" - C72b 1 -.;:IE 0

.,~ c~r .: +;t;6.+;t; ::} I

1;;.1", +~_C7D2 _ ~ R719 _ I 5

_ Z I;:: I ~ ~ R709

R70S ,a: u a:

02 R71B

R710 I l " CN70Z '---, ~, --~

- 0 Board (Conductor Side) -

A

8

c

D

-28 -

UOY

.I5Y ... -15' -JO'

P$lILT .... ,

1

... , IF-'f

" 14

RIO! }- ~ ,,'UII,o.," ~_,.

"

2

os 1 "141

:;1 ,_

...,

11 11

1-657-360~\1 lm ~;;a: -I~I:;:I~I~I_ ~3Wl'foi~~;_"",-__ ._"~_"~"'__ '~""

: Pattern of the rear side.

GDM-20SHT

I D I [OEFLECTION]

2 3 4 • 0 BOARD

Ie 06 0-1 D-4 D7 0-4 D-1

( conductor) Side

(Component) Side D8 0-4 D-1

09 0-1 D-3 IC1 8-2 8-3

010 0-3 D-2 IC2 A-2 A-3

D11 D-2 D-3 IC4 8-2 8-2

D14 D-3 D-1 IC5 8-2 8-3

D15 0-4 D-1 IC6 C-1 C-4

D16 D-3 D-1 IC7 A-2 A-2

017 0-3 D-1 IC11 A-1 A-4

D18 C-1 C-3 019 C-1 C-4

TRANSISTOR D20 D-3 D-2 021 0-2 D-2

(Conductor) Side

(Component) Side D22 0-2 D-2

0-3 D-2 023 02 8-4 8-1 D24 C-1 C-4 03 C-4 C-1 D25 C-1 C-4 04 8-3 8-1 D26 C-1 C-3 05 0-3 0-2 D27 A-1 A-3 06 8-3 8-1 D28 C-1 C-3 Q7 D-1 D-3 D29 A-1 A-4 08 0-1 0-3 D30 A-1 A-4 09 A-2 A-2 031 A-1 A-4 011 0-4 0-1 032 A-1 A-4 012 8-4 8-1 033 A-3 A-1 013 0-4 0-1 034 A-4 A-1 014 0-3 0-2 035 A-3 A-1 015 0-3 0-2 D36 A-3 A-1 016 A-1 A-3 D37 8-2 8-3 017 A-3 A-1 038 0-4 D-1 018 A-3 A-1 039 A-1 A-4 019 A-4 A-1 040 C-3 C-2 020 A-4 A-1 041 A-2 A-2 021 A-3 A-1 042 8-2 8-3 022 A-4 A-1 043 C-3 C-2 023 C-2 C-2 044 C-1 C-4 024 8-4 8-1 045 C-1 C-4 025 C-2 C-2 046 C-1 C-4 026 A-2 A-2 047 C-2 C-3 028 C-2 C-2 048 C-2 C-3 0027 A-27 A-2 049 C-2 C-3

050 C-2 C-3 051 A-2 A-3 DIODE 052 A-2 A-3

( conductor) (Component) 053 A-4 8-1 Side Side

054 0-3 D-2 01 8-4 8-1 055 8-1 B-3 02 8-3 8-1 056 8-1 B-4 03 B-3 B-1 0012 8-3 8-1 04 C-4 C-1 0013 B-3 B-1

-29-

T GDM-20SHT

- D Board (Component Side)-

A

B

c

D

: Pattern from the side which enables seeing.

: Pattern of the rear side. -30-

(1) Schematic Diagrams of D and L Boards

A

B

c

E

F

DA

G

z

TO A BOARll CNID2

CN402 5P

BLK :5-MICRO

----,

CN02 30P

Txe 30 Rxe 29

H.POL 28

V.POL 27

llEGAU55 26

POWER 25

LOCK 2' SARS 23 C089

v.s 22 33o~ H.5 21

Alll 20

V.ElK 19

TXD

Axe H. P

V. P

DEGAUSS

POIIER.511

lOCK

V.S

H.S

Alfl

Y. BlK

A. GNIl 18 h COb2 a42

A • GNll I 7 t T ,',;,.'5 'W~JTEEScBl +12V 16 l0l7 10a.H /

-12V IS r; V. OUT V. OUT 14

H.FB 13 H.PWM 12

MUTE II

P.GNll IO~ ACOI 9 Alll2 8

HV. PROT 7 HV.REF 6

VGA 5

IK. PROT 4

H. FB

H. PIIM

HY. PROT

YGA

IK.PROT HV. flRV (PRT>

HY. flRY (PRT> 3

+9V 2 FBP I ~?~= LJ;~BP

C008 0.001 SOOV

Vll I HIl 2

C5 4 3 C5 3 4 C5 2 5 C5 1 6

H. CTl 7 ClK B

MO 9 MIlO

C55 II 12

B HD

eS4

CS3

C52

CS I

H. eTl R026 100 elK

A027 100 HO

MI

CSS

3

H.FB

C017C012 0.1 10 :PFS :HT

lOla loll

TO G BOARll CNb05

TPS

.... ~ W.

-5V

P9oo3 2.7"

ass 155119 lyV so

aS6 155119

so

..J ..... ca07

r= ROOI IHO

coa3 100 2SV :HT

47 2SV YHe ,HT

«

'" >

lOD2 1000H

-5V

+5V

ll.GNll STBY

13

14h IS

.-___ +__, -thCI'lI'a2 l'o'aO.~ I STBY 5V I l~~

C.coaEO t!,

T 1:00& SVJ: ~'Iao

+1&'1 :HT

H C.COllED 16

H. CENT 17

V.llEFL IB 511.PUlSE 19

V.5TAT 20

llFX. PULSE 21 P. TILT 22

H. CENT I V. iJEFL Ctt53

511. PULSE If~ :HT

V. ST AT

P. TIL T

4

TPIS

RD42 22.

----

lei TA78125 tI2V-REG

Q7 25C3311A HO.9RIV

R,0~03 r

ISV

R053 I.

R004 62. ,AN

:-J. C088

10•022

Q027 2SC33 II A

VGA.5\1

5

~ 8 QB

-SV

25A 1309A HO.BRIVE

1~ 1/2'1/ :FPflll

-15V

C021

it~

TP2

----

R034 I.

6

r-C-

CO~4;

268v ~ :1fIHT I

R037 10'

R04[' 1501

RD3 10.

-; o ~ CN~03

12P ,- REH ~ :S-MICRO

PIS

LOOS lOa'"

5

---- -----

For Service Manual. MAURITRON SERVICES

8 Cherry Tree Road, Chlnnor OXfordehlre, OX9 4Qy'

Tel (01844) 351694 Fax (01844) 352554

emall:[email protected]

uo:~be2 R004 'as :"PS 62. . ~" 'FIN

R,S3

" 0:86St.

h co •• r 0_022

Q027

016.l.. ~f 2SC3311 A

"1R04&

VGA_S'oI I'f'S ~7k

ISV

I~

1-

t iV

a7 2SC3311A HO.BRIV

R003 lOa

as 2SA 1309A HO.!lRIVE

~ I/Z1/

:FPR9

-15V

AD02 'laM 68 • e. 'FIN : FIN

C021

I1ff

TP2

---...,.....

6 7

---- ---- - -..,.-- ----

8

---- ----

9

----

IJ: UL

~ ~ ~I~~ ~ :J:.J:ZZZI

- ---f-+-+--+-l-.I-

~----------------------------~J~D

0037 10'

~

R040 R041 150. 2.2k

953 155119

PRO,\ECT C033 030 I ~;.ij 'g~' 10

R03'.l~ -l 10. 1.1. J ~.

>< oJ

'" ,;

:::>

\~~ NNU o~;:

>< oJ

'" u

a21 2SC3311 A

eYNAMIC FOCUS 'B

~~ ~~~ ~~% N~

'"

LOI. ;;J;H

... a: !!:

§ > a: ~ ~

> >< :I: -

:; 0: 0.

,; :I:

I SV

T8 L ROS6

,--------~~~-y~ --~.:-'--y-, : 3 2 :

in:rrii , T- 't -- r:-~-~~-~

HV. FP

IK. aT

HV. IROT

G 25C

VG,

-.~

,', :Ff

9

-

RU3 ~

[6'1l's Q24

S!J2012 H. CENT

074C042 \. 0.1

,1f'S

I--R089

~

10 11 12 13 14

H.f1Y .&.

~ .~ n

II u u CM04 >->- • >- >- 8P C+lC+luu "'''' BlK

~~ ,m I:rZZ I I - - --- - --- - --- - --- - --- -------- -----

R~~$ ,RS ~ LOl2 ,." C060.J

10. : 250YI 'fftfT

HV.FEF

_ (\of I'f) "'" In ... " .,

10'"" W LOIS LOlb ILC I 2 ff.C I

1Y:.··'RYOOI

~15V c,o.9J' 1 ,-0-H n' ~I--, ~2~I u 10,097 ~ I~Ht 'B43

Rise 155119 68 PROTECT

IZ6RIZS 47 .. "1.

RI30 I.

D24 I 5S1 19 PROTECT

15V

~ 'OSI coso I K. OT I k7 ''iii HY e. I

~~HV.F¥~O~lT--------~+-~~~~~~' rilf'S

o ",

R129 41.

Rl06 1M

I ~ii~~~

400V ,pp

r-I --------

I

----

DB

- N I- c.!J1.L>l:c.!J 00:( wWO:)tUJ

> »> l-+la:CI:Qa..a:W Ln41111001-tnuu .1-~Z-l'Ilf'Oa:: 'I-I-»»>:J +(!)I +1a.>ZZ::c:r::r::x::::r::z:

>-

In CN03 ISP

'BTOB

,------1--;--------------~~~ ~ In

,;

I

I

qCq'L---~TRO.~h----~O~I',-----~========================::------------------_iii+_----------------------------------------~--------_1.[

13 14 15

-- - - -

DB I

I

N I ~ (!)LL>:t:(!)

"" WWa:::".J:W > »> 1-+ I a:a::QQ..il:W I 111", U10ol-U1UU . ~

I -z -!'11 1'0 0:: .I-I-»»>::l + C!> I + I Q..:>ZZI:r.::::C:::X:::I::Z:

_ N !'Il ... In ..n t' <Xl C\ ~ = ~ ~ ! ~ CN03

ALL IS? I ,STOB

I

I

I

I~

I

~

RT I C083 QZS O'~~331IA , VGA.S\!

':!: ?~A085 Co"-~ b';: 22' I ,"PS

'Deus PACK

I

I

I

CN~05 7P

WHT-L 'S-HICRO

7 HV.AtlJ

~6 GNtl 5 PRT 4 ABL 3 IK.PROT

2 HV.PROT I VPR

CN406 IP

WliT ,MINI

~~~--, I I 1~V I

D BOARD WAVEFORMS

CD h1L 5.0 Vp-p (H)

®

JL1L 40 Vp-p (H)

® ~ 160 Vp-p (H)

(j)

~ 2.5 Vp-p (V)

VOLTAGE LIST • D BOARD

Ref. Pin No. Voltage [V]

IC4 2 5.2 3 0 4 5.2 5 0 6 5.2 7 0 8 5.2 9 0 10 5.2 11 0

IC5 1 0.2 2 0.4 3 0.5 4 0 5 0.2 6 0.4 8 0.7 9 0.8 10 0.8 11 2.7 12 2.6 13 2.6 14 5.1

IC6 1 0 2 14.7 3 -14.7 4 -15 5 0.3 6 14.3 7 0

IC7 1 -3.9 2 0 3 3 4 -15.5 8 15.3

IC11 1 -2.7 2 0 3 a 5 1.9 6 -D.2 7 7

02 G 182.2 D 33.9 S 183.4

03 B -D.9

C * 04 B 45.9

C 47~5

® h1L 2.0 Vp-p (H)

@

JLJL 1000 Vp-p (H)

® JLJ-

48 Vp-p (V)


08 B 2.6 E 2.5

09 B -3.9 C 34.9 E -4.4

011 G 182.3 D 41.9 S 183.3

012 B 0 C 45.9 E 48.2

013 G 9.5 D 42.2

014 B 9.5 C 15.1 E 9.5

015 B 0.2 C 10.3

016 B -D.9 C 111.8 E -D.7

017 B 0.8 C a

018 G -D.2 D a S 0.2

019 G 12.3 D 0

020 B 13.7 E 13.3

021 B. 13.3 E 13.3

022 B 0.7 C 13.7

023 B -15.2 C -D.2 E -15.2

024 B 44.7 C 45.9 E 43.9

025 B O~ 7

A

-

B

-

e

-

fJ

-

E

-

F

r- +I~ ,

em I < to

I -I em

lO-

I I

E +30V I r-- G: +15V 2

GNII ~f2-ISV

30V sf-P. TILT •

MAGI 7

CONV. CENT • F CDNV.SIBE 9

S\!. PULSE 1"-HAG2 I I C7

I'

CWOI liP 'EL

'S-"ICRO TO 9 BOAA£I r-

CN408 I cn

I 10

!

~ IT j~ .

li;l f.l~

~ .=

f ~ I

e70'

I \551\

~

- u

I -~---

VOLTAGE'LiST • L BOARD

Ref. Pin No. Voltag'

IC701 1 a 2 0 4 0

IC702 1 O.~

2 0.; 4 0.:

IC703 1 0 2 0 4 -29 5. 0 .-30 6 - "-30

7 0 10 15. 11 31 12 -2~

13 -31

15 -D

t Soard IC703'

h P (H)

lL -p (H)

lJL p (V)

Voltage [V]

2.6 2.5

-3.9 34.9 -4.4

182.3 41.9 183.3

0 45.9 48.2

9.5 42.2

9.5 15.1 9.5

0.2 10.3

-D.9 111.8 -D.7

0.8 0

-D.2 0

0.2

12.3 0

13.7 13.3

13.3 13.3

0.7 13.7

-15.2 -D.2 -15.2

44.7 45.9 43.9

0.7 0

1 2 I 3 4

A r -- --"" - ---;;;;- ---I I~ 0.001 if- j Ii PT

r-' ~~!~

-

B

.\ r+-..,.-+-+--~----' R7"

'ii'~ EWl ,\3. I

\ I

',"30vl Vi! R7t11 OC::, :/til ',0£1 :PT

- r-~~~~~r,~--4-~*-~~--~l~ +30V 'r- I't ,,2'OV'ilVII+--f----+--"""'H:I!1;;1~,--1 t 1 5V 2 om '" ,'" >.... I,.,:

\ I

c

-

-

E

-

F

GNll :1-1. f! -15\1 ~ r-=-- + Je701 , R706 -30V 5 r- Tj~~S~ ~cm I ",.h.o

~~P~.~T"~LT~~·~~tt~~~~~~==:l~f.~.l:lJ L~-'~-·,-4~~-5~--------,-h fi~ CONY ~~~~T : G1J ~:, CONY.SlflE 9 o~:~ 5 .... PULSE 10 I R708 oC'o'J\~1 L~Cl?lo

MAG2 11 C719--; IO~ PT Y 0 C AMP 10 1 + ~~ ____ ~~ ______ ++,

0'" ~ :1: ~ 0'" iii *"D6 CN701 liP YEL

:S-"iCR(]

TO e BOA.Re

CN408

.~. ""l I! . I "10 I~i ,I :~ '"" ji, '!3'i

\

I

I c~a2

IIliT ,S-MICRO TO £I. Y.

1 H. A. C. + 2 H. A. C.-I ~

"'-----sr<lUOO_3'20-H.A..C A.MP

3 LB.C.t My.a.c .. • Y.B.C.-~_I-"

~I ~~N~t;~ I Z S 4 5 , 1 , , II 11 12 13 14 IS

- ~rj" C71L, l, ",,;;: f 1O"re,.,. 1&1' 7 M~Gl i§f I ~ 0.001 .~ 8,1:714 L--- 8 MAGI t

~ C1'O~ IoioIlI _ N N I a::-. 0.0021

f~ 7"-=- lOa r I ""1"7.'.' ~~ ~ .• f-<~ • II i:!! ~ t- "ZI ""I /,!,II I~ s~ g

\

,0,;Js 100 ~ ~ f l W: .":. R718 +---+--+--hl;.--'~=-t-d...,.,=_--t----

CH L! l-. 27 I b BR7Z4 R1ZS

r'" I :.: 1 ,~ " ,iF ,iF ~ .n

I i!! f.i~~ f.ll \.~ I~

n=N' +30V ,,,, ~ :-:: Q701.~.1 l ~ BTC124ES 11723 ~JI1:!: :!! L,J, ni: ~L '" ~

I 9104 an t .. .fi I~

I Pk~%'ct f"" r '1,'.'1 l~ I

~ ,~mg C715.I, "" ~l' :1:\111 be,"e, I I PROTECT"! 10 I I ~l'! I iPs ICONV:::J

-- ------ - ------ - ------ - ------ - ------ -

5 P.TILH Dn!.T. COIL • P.TILT . G(cCCOlC

" <;\; ,

B-5583~9< ••• >-L •.

VOLTAGE LIST • L BOARD

ReI. Pin No. Voltage [V] ReI. Pin No. Voltage [V]

IC701 1 0 IC704 1 0 2 0 2 0 4 0 4 0

IC702 1 0.2 Q701 B -0.5 2 0.2 C 0.2 4 0.3

IC703 1 0 2 0 4 -29.1 5 -30.4 6 30.8 7 0

10 15.5 11 31.1 12 -2.4 13 -31.0 15 -D.4

L Board IC703 STK390-120

E

F

G

H

J

K

I

I I

DA

l_

CNOZ 30P

TXfJ 30 RX{] 2.

H. POL 28

V. POL 27

BEGAU5S 26 POWER 25

LOCK H

SARS 23 ~8' V.5 22

1';OP

H. S 21

Alll 20

V.BlK 19

TX~

RX~

H. P

V. P

flEGAUSS

POWER. SW

lOCK

Y. S H. S

Alfl

V.BlK

H.PWM

H. FB

A.GNlJ 16 .. C062 £42

A. GNlJ 17 'P,;is R~\fNrf +1 ZV 16

12V 15 lD17 100. I / V. OUT 1 COOl

V.OUT 14 H.FB 13

H.PWM 12 MUTE II

P.GNlJ ~--, ACOI '" AlBZ B

HV. PROT 7 HV. REF 6

VGA 5

I K. PROT 4 HV. flRV IPRT) 3

+9V 2

FBP 1

VlJ 1

HIl 2 CS 4 3 CS 3 4 CS Z 5 CS I 6

H. CTl 7 ClK 8

MO 9 M I 10

CS5 11

5V 12

+5V 13

B.GNlJ 14b STBY 15

C.COBEO 16

H. CENT 17 V.BEFl 18

SW.PUlSE 19 V. STAT 20

BFX. PULSE 21

P. TIll 22 IlFY 23

IlFX 24

MAG I 25

C.COlJEI 26 CONV. 5 I lJE 27

MAG Z 28

CONY. CENT 29 Y. PARA- 30

CNOI 3DP

H. FB

H.PWM

HV. PROT

VrJA

IK.PROT HV. flRV IPRT)

A026 100

R027 100

Hfl

CS4

CS3

CS2

CSI

H. CTL

ClK MO

M I

CS5

i"m 'HT

C017COl2 0.1 10 tl'lPS :KT

LOID I.H

.----..Jh i:1W 1 STBY sv I l:~

c. CO~EO t!H.CENT I V.eEFl CDS3

SW. PULSE Ife V. STA T

P. T) L T

~FY

eFX

MAG 1

C. COflE I

CONV. 5 I flE

:HT

MAG 2 V. eEFl

CONV. CENT

V. PAR"

SW. PUlS

I e55

155119 IL:-£56

155119 SW

...r "'" ":CD07 =r RDD11 '"470 47 25V

,~~ ,HT CDD3 100 <0(

~Hl ~

LOOI 100 .. H

I CDDb 5V

1 ~'IDO

+16V 'HT

L002 IDOl'll

CoNV. S I E

CoNV.CE T - ----', MAG 1

il8682 RODS U:!:" :"PS 6;Ml'

RQ42 22'

CD161 ~-0.1 IRD4/. :I'PS 47k

h CD88

I D•m

QDZ7 25C3311A

YGA.SW

15V

-SV

R006 4.711 'RN

.....

'l!Jl'! ,""

CD21

;r1000 25V 'HT

TP2

TP14

I~

-hl >4JO~..JlIlZx:...JI-:L

<!> UU ,.. III f-en

CN410 6P

\/HT ,5-MICRO

TO ~JWre

lOll 4711H

UU...-J.-J>4J> ZZOONZlf1 >->-a..a....-c.!:I+ f.!)f.!) .. I > >-

:1:> III f'fl

CN411 7P

YEL ,5-MICRO

TO t!1..100rfl

1

CN409 BP

REB ,S-MICRO

TO t!1..JHlfRfl

- 31 -

»Q»I-_I-L.LJWN Ot!)ZUlO...J Zc:;J(f} 1'0 ..... c.!:I ..... r-o-olJJ-...-Jc.!J ++ 11t-<utn::><

• 2: • • Il.. :c a.. > > .

ZZ~ ooen uu

CN408 liP YEL

,S-MICRO TO b,}Hy.Rll

I I + UUU f-f-fZZZ CN401

3P \/HT

,S-MICRO

NTC&

1+11-1->->Za:a:c;I.c;J <!> 0.. 0.. > > CN407

SP \tiT ,BY

I

.-

RD34 I.

L

- -----"--

-1~" -

-

R006 4.7l ,R!<

TP2

ROI8r-1. 1" -12V

cozo t -+--------",O.~~,uL : R017 it'S 2.41(

,AI<

~i~t;

TP14

-

-'" "' ~g: 4~

155119 PROTEC

~r-~ _ __ ___ ~~~~~~~+N~-~ ______ __ , + JU -fzz

-

CN401 3P

\IHT : 5-M1 CRD

'+II-~>->Za:a:Cil'+l '" a. a. > > CN407

SP 'tIIiT ,BY

U w & V.flY

C031 R034 100, Il CH

I

...--w.--.---I

R03? 10'

E&'fO!J rIlRI12 PUMP UP ~,~

846 155B3TB ~

------- -

>< ..J

'" ,:

>< ..J

'" ...;

... z w u

i.

-15V

~~ RC4558P H. CENT

IC5(1/4) SN74HC32AN

BLK

15V

QI~ ZSC2 6" ~~r. HV.IIAI E

~~~ IY')

R06~ll 2.211.

J. ~

§1~ -

... '" (; ... > 0

'" a:

'" 0..

,: ,;. " -

... 0

'" ": >

"

15V

TB f 1:f~ :--------~;~-t--2--_y-l-

l~:~-:~~~ ROSO

C~:;~ e33 4.7 RlJ1BE5B2

m~ ~ PROTECT o~gAh

.J. ~ ~:'PT", ~I g§ ,.,"-R..o .. 'if ~~~ ~ c~r

.. ~jh'-O--J FBI II "->: F-.200V tl35 O. 4!:U1 ~~ dftiT

195119 l 1;; ~ -

r----~---.,

1 Cb ~~~ ¢ ¢ $ ¢ ~:

I 1----------_..1

10.

1~~6Bo/c~

R089 ,~

~~6 h~t3 ~~ 155119..... 1 \ ''''

5\1 634 I. '-: 5 R818ESB27 ci9 PROTECT I 1 RF 1624&

? R070

eYNAMI C FOCU5 00 017

2511774 • 6~~i eYNAM 1 C FOCU5 eFX

:Pf'5

ADS1 22'

R052 .,.

- - - -

-32-

I

1<. OT

liV. ROT

~'~7' ~R~

155119 2'~ H

PROTECT aZ6 f-..

if 5C4686A t~OI T VGA.5\I

C092 ~ 4.7 ,HT .-- - . .~---

I

> " 0

mb TPI3 LOI. ERC90H-O' 21.H PROTEcT"

al7

RB26lf~' ?"". i\-~-f---'

R087 ~ ~~I 1 560 ~ Ql /~~H

COS6 059 -,.;,

26ijy r0J. lR~~~~~&(15

Q14 ~ J~ i 'HR ~;l:':b ~1 Z5C3311A ~ ,---"fMm m ~g~i. HV.6RlVE ) lRFP(150LF 2'Y

T"12 RI53 CllNVERTE~ 'PI'I :.l 1,~)~SA~~O:A 2.2 tRa1e;~5BZ~ -LJ: HV,6RIVE PROT aS4

155119 Wl~dr[ ~rrCT ~~~~H--~~~

CObb I e23 M; 0,004' :!:EflA34-10 410 2~V' 1IKV,REC 'FPRB

TPI

1

HV. IEF

624 155119 PROTECT

15V

IK. OT . rn l HT 'if.~0 ~~~~--------------~+--+-----+~~~' ~

~ -'Ii ~j

R010 10.

~~68o/c~ ~lC FOCUS 00

R051 21.

HV.ROT ~

SGI

eS2 ERA34-10

H,eF

C090 f--bF),I41

!Focusl CRI &

FOCUS

r~i-"""" IL I

J.;' J:

!).(Z 11 11 II}-

FY'

IIT91l--

'"' C!> >

I I

I

R052 41.

[;092 4.7

~~i I 1,5~J D (n E F LEe TID N) 150); ,RH R142 D d

L-____ ~,HT~ ____________________________________________________________________________ __

. -B-SS3321 <.,. >-0 ..

- 32-

I

- - -

o Board CP1 HVpJo

::I-Efifl::. '., AD) : : GNDI®--! ' ... ' VPl C!)---------------

'821fTO -- -.. : . .: .... l

- 33-

~ I I I

I

~ I

8p1

CRT I C083 Q25 o .. ~ 2SC3311A

~A.S'tI

'1 ~A ROBS CoD.Sf A"1l 22'

I 'MPS

FOCUS PACK

I

I

I

CN405 7P

IItiT-L :5-MICRO

7 HV.AIlJ

~6 GNIl 5 PRT 4 ABL 3 IK.PROT 2 HV.PROT 1 VPR

CN406 IP

WHT :MINI

1 IKV 1 TO C~l~~ARa

--- - - -

D Board CPl HVpM2

HT IIVP

- 33-

VOLTAGE LIST • D BOARD

Ref. Pin No. Voltage (V]

IC4 2 5.2 3 0 4 5.2 5 0 6 5.2 7 0 8 5.2 9 0 10 5.2

·11 0

IC5 1 0.2 2 0.4 3 0.5 4 0 5 0.2 6 0.4 8 0.7 9 0.8 10 0.8 11 2.7 12 2.6 13 2.6 14 5.1

IC6 1 0 2 14.7 3 -14.7 4 -15 5 0.3 6 14.3 7 0

IC7 1 -3.9 2 0 3 3 4 -15.5 8 15.3

Icn 1 -2.7 2 0 3 0 5 1.9 6 --Q.2 7 7

02 G 182.2 D 33.9 S 183.4

03 B --Q.9 C *

04 B 45.9 C 47.5 E 45.8

05 B 9.5 E 9.5

06 B 45.9 C 44.7 E 45.9

07 B 2.6 E2.5

Ref. Pin No. Voltage IV]

OB B 2.6 E 2.5

09 B -3.9 C 34.9 E -4.4

011 G 182.3 D 41.9 S 183.3

012 B 0 C 45.9 E 48.2

013 G 9.5 D 42.2

014 B 9.5 C 15.1 E 9.5

015 B 0.2 C 10.3

016 B --Q.9 C 111.8 E --Q.7

017 B 0.8 C 0

018 G --Q.2 D 0 S 0.2

019 G 12.3 D 0

020 B 13.7 E 13.3

021 B 13.3 E 13.3

022 B 0.7 C 13.7

023 B -15.2 C --Q.2 E -15.2

024 B 44.7 C 45.9 E 43.9

025 B 0.7 C 0

026 B 0.7 C 0 E 0

027 B 0.7 C 0

028 B 0.8 C 0.5

E

F

~ Ill!

I~ ij I

I 1

PI

E

VOLTAGE LIS • L BOARD

Ref. Pin No. Voi

IC701 1 2 4

IC702 1 2 4

IC703 1 2 4 5 6 7 10 11 12 13 15

L Board IC70

.... _ ....................... 4

.-

oltageM

2.6 2.5

E -3.9 34.9 -4.4

182.3 41.9 183.3

0 45.9 48.2 F

9.5 42.2

9.5 15.1 9.5

0.2 10.3

-{l.9 111.8 -{l.7

0.8 0

-{l.2 0

0.2

12.3 0

13.7 13.3

13.3 13.3

0.7 13.7

-15.2 -{l.2 -15.2

44.7 45.9 43.9

0.7 0

0.7 0 0

0.7 0

0.8 0.5

~ I~~f'"'''' Lftt 'TtLT COIL

_-i.Ce t;'OIL L.::..I-"'-:'::":'':''''''''---l-:'

Ii

I~ ~ I~

I -loV I

_ 1!m9 em "16 'W rn L I PROTECT ID 1 IG I I '1)'1 I ,iPs (CONVERGENCE) I ------------------

VOLTAGE LIST • L BOARD


IC701 1 0 2 0 4 0

IC702 1 0.2 2 0.2 4 0.3

IC703 1 0 2 0 4 -29.1 5 -30.4 6 30.8 7 0 10 15.5 11 31.1 12 -2.4 13 -31.0 15 -{l.4

Ref. Pin No.

IC704 1 2 4

Q701 B C

L Board IC703 STK390-120

•.....................................

i .... _ ...................... .

B-SSB3i.9< ... >-L ..

Voltage [V]

0 0 0

-0.5 0.2

-34-

.-

(2) Schematic Diagram of DA Board

DA Board IC115 CXA1543M

VOLTAGE LIST • DA BOARD


IC10l 2 2.5 3 2.2 5 0.2 7 1.2 8 0 9 0 10 0 11 0.8 12 -0.7 13 a 14 -0.5 15 1 16 0.9 19 0 20 a 21 1.9 23 0.8 24 1.1 25 2.7 26 1.1 27 2.6

IC102 2 0.8 3 -0.7 4 3.2 5 -0.2 8 0 9 1.4 10 -0.2 14 a 15 5.2 16 5.2 19 -5 20 -0.2 21 0 22 1.1 23 0.3 24 0 25 -0.5 26 0.8 27 0 28 0

IC303 1 -1.2 2 0 3 0 4 2.8 5 2.8 8 -0.7 9 2.8 10 0 11 a 12 0 13 0 14 0 15 -0.5 16 0 17 5.1 20 5.2 22 2.8 23 2.8 24 2.8

Ref. Pin No.

IC104 2 3 4 8 9 14 15 16 20 21 26 27 28

IC105 6 7 8 9 10 11 12 13 14 17 18 19 20 21 22 23 24 25 26 27 28 29 30

IC106 1 2 3 5 6 7

IC107 1 2 3 5 6 7

IC108 1 2 3 5 6 7

IC109 1 2 3 5 6

Voltage [V]

1.6 0

2.8 0

0.7 0

5.2 5.2 a a

0.8 0.6 0

0 1.4 a a a

0.5 0.6 0 0 0 0

-0.7 -0.7 0.4

-0.1 0 0 0 0 a a a

3.2

-1.5 -0.5 -0.5

0 0

1.6

-0.7 0 0

1.2 1.2 1.6

5.3 3.8 5.2 5.2 5.2 5.2

5.2 3.8 5.2 5.2 5.2

Ref. Pin No.

ICll0 2 3 5 6 8 9 11 12

IC111 1 2 3 4 5 7 9 10 11 12 13 14 16 17 18 19 20 21 22 23 25 26 27 28 29 30 32 33 34 35 36 37 38 39 42 43 44 45 46 47 55 57 58 59 60 61 62 63 64

IC112 1 2 3 5 .

DA Board IC116 CXJI

3

DELAY GEN

4

Voltage [V] Ref. Pin No. Voltage [V] Ref. Pin No. Voltage [V] 9

5.2 IC113 t 05 ICI17 1 0.2 5.1 3 0 2 0.2 5.2 7 * 3 11.6 5.1 8 5.2 4 11.6 0 5 0.8 0 IC114 2 0 6 0.8

5.2 3 5.3 8 2.1 5.2 5 0.2 9 2.1

6 a 10 11.7 2.9 7 5 11 11.2 2.4 9 2.1 12 10.4 5.3 10 5.1 13 0 5.3 11 5.1

5.3 14 0 IC119 1 * 5.3 15 4 2 2.6 0.8 3 * a IC115 1 4.9 8 0.4

5.2 2 a 10 -0.1

2.5 3 0.9 11 5.1 0.2 4 7 13 0.3 0.2 5 0.9

5.2 6 8.5 IC120 2 * 5.2 7 4.9 3 0.4

5.2 8 0 4 5.1

0.2 9 1.2 5 2.7

5.2 10 6.8 6 * 3.8 11 6.1 8 2.6

5.2 13 8.7 9 2.6

0 15 8.9 11 0.2

5.2 16 2.5 12 2.6

5.2 18 0.8

5.2 19 5 IC121 2 2.5

5.2 20 7.6 3 5.1

22 5.2 4 * 5.2 5 * 5.2 24 a

5.2 25 0.2 6 0

5.2 16 0.2 7 4.8

27 1.9 10 • 0 4.7 28 • 11 5.1

4.6 29 6.3 14 0

4.2 30 6.2 15 4.7

4.2 IC122 1 -0.6 IC116 2 5.2 5 3 2.5 2 -0.2

5.2 4 1.0 3 0 5.2 5 0 5 0.3 5.2 6 1.7 6 0.3 0 7 • 7 0.5 0

8 1.6 IC130 0 9 3.1

1 0 5.2 10 12.2 • 2 0.3 5.2 4 0

11 9 0 12 0 0 IC131 1 5.2

14 0.2 2 5.2 0.2 15 0.2 5.2 16 2.2 0101 B 0 5.2 17 2.2 C 0.2 3.0 18 4.3 5.2 19 4 0103 B 0.2

0 20 0.5 C 5

1.1 21 4.2 0104 B 0

1.1 22 4.2 5.2 C

0 23 0 . 1""'\."::: ~ " "

Voltage [V]

0.2 0.2 11.6 11.6 0.8 0.8 2.1 2.1 11.7 11.2 10.4 a

* 2.6

* 0.4

-0.1 5.1 0.3

* 0.4 5.1 2.7

* 2.6 2.6 0.2 2.6

2.5 5.1

* * a

4.8

* 5.1 a

4.7

-0.6 -0.2

a 0.3 0.3 0.5

a 0.3 a

5.2 5.2

a 0.2

0.2 5

a 5.2

DA Board ICl16 CXA l544M

A

B

C

f)

E

F

G

H

2

--- - --- - ---

0218 ,. II16W 100lP

0273 151 1I16W :01IP

Cl01. , 'HT-ep

3

---------

ICI07IVV CII'15 RC4558PS 0.001 H. PARA AMP X7R

RI13

,}f~\t ,RlKP

RIl2 '5' I/H'.,

:RtH:P

SV e2i R125

" ,m. R12& " 470 HT :CHIP l/!toW

:CHIP

e111 alol zz IbY 1 aTZ2.48

:HT-CP REF. VOLT ICI03

DACSS40FSR ac al!,ITAl ATT

2 I 3 I 4 I 5 I 6 I 7

----------- ---- ---- ---- ---- ---- ----1 ______________________________________________________ ----------V~~~B~B8~-----------------------------------

HI! BB7

HA '"

HSA'tI' ~ CIOB 1

:HT-CP HSA\I ;;;:}---r---f

IPARA+ ;:

IPARA- ==

HCl ;:

VCl ;;;

I Rm ICI0612/2) no C~bA12 RC4558PS 1/16'1{ 33, .PIN AMP

1~}1!1~ L-'",RlH __ P+-CH-Ill ~08 RI3S : RH-(P I l~nW

kJ..::.J ,I ""KP ,.----w.-.... ;T.'-"4t/ ':/

RI12 S R12S V 15k ?}1~\

:RN-CP 10k 82_ 1/1t.'tf ll1liW

R134 '2' , 1. 1116'

m :Flt-CP

H.SQ·OBI2

'"'UTE BBll

H.PIN. BB2

1/16'" R119 : RN-tP I RlII

~;==++====,FfI-C==P====f==rt:::J ~124 ,RH-CP I ~~f:~aN L ________ --,

SV C2D2 R1ZS 116~

/1 V R303

'" 1/16w ,CHip

~~: ,~;~. f Rt;; HH"J :CHIP l/1b'W ~

1~------~H_~---H~~+_----~----~~-'-c-HI-P--_14__,1 ~4 el11,1

1/11.'1' ,RH-CP ICI02 (is)

CXA8021 H I 3\ ~ H.CONT ,21M I 0 z~.=

'

6y :r :HT-CP

6101 nZ2.4B REF. VULT

V.SA :::

V.SI :::

I.PAR ::

REF.l~ 12

OUT 0;:

OUT :::

OUT ~

OUT

OUT

N CONV.lE

:::>=C",ON",V",.:..:R'11 f+,T

CSI;;; 5V

V ;;

+5V ==

Cl ;:

SBI ;;;

",,19

" 1/16'11 ICHIP

RZ2'

" 116W :DUP

IC103 BAC8840FSR

DC 61~ITAl ATT

eFX OUTC VOOT

o;:BF.AL.

V IN t=}--+++-4 HaiRE

~ OUTA V IN ~

- IN B V::::

U'1 IN A SO I :::),-'"SV"f-H-R2-

2-,'

SV VS ;:;: ~f~tr-.... R se i;

Cl ==_.>-+++--,

- IN F l ;: -afY

;;;; OOTE V IN ;:;:;

P.T1lT = DUTF V IN :;::

.5-J H. SEXY ;::; OUTS VOIJT;:;:;

-5V

3.31: .,. '30S - S~, Y.SA _

~.,., - V ..... EF. V.SI ~

4---.j------{~ EF.3 Y.PAR ::

,-4-------~- EF. Be REF. 1 ~

V,STAT. ~ UT9 OUT ::}-'N:.:.T::.C 'c:T",".::Bh

~ UTI 0 OUT :::)-!.H~. ~OS~C:.:.._+_+.,a!.!B'-'5"1

v.a l. ~ UTI

H. CENT. ~ un

H.SIZE -5Y 0 un

= 52

-5V

5

+SY ;;; oaE

:; OAe

R2Z.

" 1/1&'" IGUP

OUT :::)-!.H~. ~5H.!:I~F~T+-j-!a!.!B,-,."1

OUT _~~.!:H~.B~A~L~._+_+~a!.!B~3"1

OUT :: H.PIN.

-5V

C51 ;;

V ;;

t5V SB ::;

Cl ;:

SBI ;;;

-5V

S\I.PUlSE aBg

HOIRE.PUl5 OB13

OB7 He

BB 11 ~UTE

BB8 VB

~

:CHIP

105 126M .CDNT

RI07 f 3.3_ 1/16V :OiIP

IN5X ::::}--+-+

IN5X :::

IN5Y

IN5Y - :b\tJ ~ C161

S. CHd608

IN6 o;::}-+--"'-++H-. RIOZ r

IN6 ~ 1}f: ... ~

OUT

ICH)P

OUT:::: I!m--OUT ",:}-~:,7Qt,,,,··,.~·!-H++'

IN7X ='}-.--4-~

IN7X ;;;

I N7Y ;;_}------+_+'

I N7Y ,::;_:~. ------.:--'--'-.:-.....

ICI19 SN74HC86ANS MOIRE PULSE~SV

- IA vca:;: +5Y >;:: IB 48;;;

>::: IY 4AJ;:;

-';2A 4'11 =l---~';2B 38;;l---

-';2y 3"'~h -)iNa 3'11-1

~SV SN7r~mANS

5 MO I RE CANCEL sv

~ 1 ITA vca:;: ~ -;.. la 2 ern;;; ~ lClK 29== I-

~ ~IPRE 2ClKl= I-~~IQ 2PRE1;;

-;:'IQ 2Q-}--

~ 2li-}--

R291 , .. l/1b .. ICHIP

R280 30' ,1~l

Rzel S.b_ I/lbW ,RfH:P

CII9 0.' '6Y

ICI13 MMI170BFB \lATCH flOG

5TBY s;.-4 5TBy t5V

0~- Te NC

V5 --l--n

V.S DA I

RCT r -L-_GN_O_v_ec--l~l-- om

BA 1

OA 19

BA 18

RU3

" 1/16'« :CHIP

I L C112 0.001 g~ X7R

BICHIP

R292 10'

:Otl

:: .......

III IN ,CHIP

~ ItnN-Ocnt-

ellS 16 ~ ~ ~ o*u . Q

CH:~"60e XIOI 8 S >:Jr: r - XTAl u u u t--t C114r:::::J .... EXTAL

R14! RI49 1-----1-mJl

mJO 5TBY SV!~-~4 CH,~'6" ----1-

l/ny STBY+5V 1~1~v i----I ~ NMT :OiIP ICHIP

; 1. [1,16 l~ = ;~~Y

il

DA3 I '6Y :TA-CP RI"S _ rl- VSS

III 1/16'" lotlp· 'w. H.!j

IC III H8641~

BA2 ~ SYNC.ASYNC

~~~----------4---~~= ~

aA. ~ I.;.Y L!!e~A~5--,,<rrn~,.,{-.,"-,.-+--r.:2 H.POL

" I/n~'CH'p B V.POl

~ eSR

R1«"T. 1/16V ,CHIP

;; R258 lit 1/16,. :CHIP

5TBy t5V ~~~X "'f

RZ06 IC108 1}~~'i X25040S 'CHIP E2 PROM

R,~o; 'f,',s I C 1 09 I/16V '/16V X25040S

5TBY ",5V-4

,CHIP ,CH'P E2 rROM

R301

~fM~

~TBY

IC131 TC7S04F INVERT

t5V

R2Z9 ,. 1/16';' :OHP

ICIIO 5H!4 SN74HC 1 Z5ANS

BUFFER

R' , " 'C

R2Z7

" 1/litW ,CHIP >=<Til

~---+------------~---H- IA ,-- >::: lY

VCC :;:)-

4G ;;; 4A ;:;

4Y = lG ;;

-::[[ RZ3(

" 1I1b - ze

D120~Tf RDS.ISB PROTECT

rl DIZI ADS,ISBI PRUTECT

3A -H-+----~

3Y - f--

ICHI

Fa4! R240 1. III

1/!6'W' III&''' :OHP :CHIP

6 7 8 9 10 11

-- - --- - --- - --- ---- -------- ---- - ------- - ------- - ------- - ------- - ------- - ------

:':""'Illi--

Rll. !- '),~'W

:oUP

I-r--ru-i _1~BI3

• r~

~ u ~ z

-

Rzao ". 1/11.., 'Rlt-CP

e.l

9.19

e.16

SA3

I CI13 MMI170BFB WATCH BOG

R143

" 1/1&W =CHIP

5TBY _1-- 4 STBY +5Y

A292 10.

:Oil

XTAL

,1,Cll'· I : } '.V

EXHL

mJl

mJO

NMT vee

STHY

VSS ICIII _~'O

5V

I C184

~- 0288 120' 1/11."1 'RIHP r~1

AZ35 IC112 11/2) IC112(212) ,.iVt. f=sv RC4SSBPS RC4SS6P5

'RN--<P~~O V.SAWeEN ::"'AW GEN

r~: tl62 - ~J~ ,1 ---:-r>-z--~ ~!~ L....a R2!91/1&Y~I Cl,e3 ~

'PPHl:f 1 1~~2w CHIP IHT-tp

R2" Rl&D"-" 'CHIP t---'M~-II---' Zf.' 8Z'~07 :fHf¢ .~ }S81218A \'3~

QI03 ..I' SAW ~ '6\t~ •~UH5213 L---I Rl., ,J,,/, lC'65

V.SAW eEN ~Z4 A17. 1~~. ~' 0.1 1211 :QiIP .--. T

,,,w,,, :6\I~ ~ -5V

..... ~ en - 0 COI...JU-I...J

• U • W W GI • Q V1 to < ~ ~ E+i coiN.C. ;t:i

..0( .c:SARS ~,)-___ ----,

D.LD.2 :;O)-----h

ALB 1 ;:;)----__+-h

~8; C01·13 (,/'bw IbV

IRJ+--CP 1PPS-tP

-

ALB2 ~}-------~+------------------------------+t-~-, ROM I 'AJ-----ROMZ ;8 ROM3 ;.§

eB7

Bag S\t.Pl

flBb v.au

eBIZ H.S

:TA-<:P Rl48 r-I,. IllbW :Qilp...I. o,Q

H.5

r- c; SYNC. ASYiiC De~A~2 __ ~ __________ ~--_(=)_~

VS5 :=r-, LOCK ~)--*--r-1-tt+t-1--------------H--t--t--+---

H. STOP ~W 1r4+1-H-------~r_-----+l_, ~eEBL7~HO~--~--~_4~--------------_4--~:N~~HO ~

~~"A"'·'---__.rm~--w.__+-_{;;:- H. POL ~a",A",5,--..lL "..I.,/<j77L,Hz,;;' .... ,,".Lt:...,P_w.__+---{=_ V.POL

DB6 ve

~

V.5 BA I

111 I/n~ :CHIP

~ NO,", N-W

-:c5 Glxg:

....,oti ~ N-W ..... :;:b C4l::rg: L-

STBY +5Y ~~~X R307 • RI38 RI39 R140 47k

'r~ 47.

:~~W )~~tP :~M~

R201. ICI08 R2D1 R20e ICI09 R,'O~ ~TBX 10' X25040S 10' 10' X25040S 1/16\1 :6\1_ 1116'11 1/16'11 1--:CHIP E2 PROM :OiIP £2 PROM ,CHIP

dJ STBY +SY D 1 - r-- ,-!;- cs'-;cc -- cs vce

~ so HOLD - ,- >:' so HliUi - I "11 ~ ~ "" "~ - liP SCK rr- VS9 51 >-< CII1 ~1 IY VS5 51 'Tj ~

B:CHIP

R301

)t~t~

5TBY ..,5V-4

~STBY

ICI31 TC7504F INVERT

+5V

B120'Tf ROS.I58 PROTECT I F BI21

~5.1SBI PRUTEeT

0241 ,. 1/16.., :OiIP

R22' ,. 1/1&14 lCHIP

STBY +5V

RZ3. ,. I116Y ICHIP

RZ40 ,. 1/11M :CHIP

! ~~;: R20-\. 'a. V.STOP B I IK.PROT ~ HV. PROT B~--__4++++...c"'-E.-----_+-r-------1-h DEGAUSS ~~~IIr-+H-1+-"'~

;1~~ :6\I~ :6\t~ DAb t 023. R2DS

DA 17 P~R ~r-~~++~~~~ RI54

,;r· ,cHf¢ ,m~

,. 1/1&"1 :CHIP

DA'I .,",. OA 12

.,",. £lAo 13 ~A1 V.S

.,",. DA I. , '.,",. DAIS

III I/lbW lCHIP

eA3 H_5

V. STOP L-

RZll 02., 1.511 II1IN :ftt~ lCHIP

. ICI1713/4) ~ " HC14011BF

H. V. STOP MITE

'ZV ~

~ RI59 47.

1/11.14 lCHIP

~~'~ MY , .. lCHIP -CI' CLAMP

CI~°r. -12V

~T RIS7 810b -1 'lV

eBB V~

~3Z 1 ,',"1 ICHIP

VOA DBIO

{lBI I MUTE

DB13 MOIR:

OB4 H.SH

u~52' MOIRE

ilBS H.DS

DB3 H.BA

ilDIO VGA R3DO 10'

1/11, ... :CHIP

~ - TCT ~ HL

eB7 HO

_. . . '-

OBI I MUTE

eBZ H.PIN

eBb V.!lLK r---

a I 11 I 12 I 13 I 14

- - -- ---

1 ~B7 HlI

III1YtI~VRI7'I IC11712/4) II~lI'6~ ~IZVI+12VI

rr-_____________________________ ~~~~~~M:C:~1401IBF ~,CHIP H.STOP flo V.STOPIMUTE~ BI09 IC117 11/4) HAIIO 4 MC14011BF

AI63~l R2.. J:'. 3 flo V.STOPIMUTE

I/IS:. Z.7' "' I 2 :CHIP 1 ICHt 6Y CI40 7J i

: IP I o.D! B:CHIP

- I I

~B9 S'II.PUlSE

:C~:; t C172, ~ 1/16W 120, ~ :RN-CP CH:160e

eBb v.BL~

i-..!!BI Z H.se.

IC114 TC74HC 123AF CONV. PULSE

IA vc ;:

- IB IR/ u;

- ICLR I :;:

-IQ I ;;;

~ Q Z ;::; - C ZCL = - R/C 2 ;;;

- Z ~

-

fA Bloe RBS.ISBI

SLICE

5~ --1 COI.~ t;~I~~ 1 T 25V J/lltV lB:CHIP :OUP

----'L..-J 1:130

CH"'t'loa

1

~

------~ ::::tf=jr-~---r::~~------t-------------------------~--1----------A204 ...., , .. :b\t~ ~B6 ve

h

WA ~BI 0

RZ32 1)1~6W ICHIP

r--Itttt--t-+--- .1 ~

I :,!!.TOP

3D 2!

18

R210 ,. :b\t~

II 27 21 25 14

C141 r 0.0033 ~

,~!cpI

23 11 II II

BELAY BUTY '" CAl ZFH :;:

DTC RA ;;;

IN1. CAZ .. - INI- IN .. ;::;

FBI INZ- ;::

FB2 u;

-('- Dun C2 -;:-

II 17

.

I

-- ---

BLK. HV

"

15

DA HV REG)

PROT

~ Ie 117 (4/',1 MC 1401lBF

~ "

A311 3.3" l/lbV :D1IP

1

1 I

I I I

I I

I

I I

I I

I

I

I

I

,

.. . . '-

7 1.2 8 0 8 0 9 0.7 9 0 14 0 10 0 15 5.2 11 0.8 16 5.2 12 ...(J.7 20 0 13 0 21 0 14 ...(J.5 26 0.8 15 1 27 0.6 16 0.9 28 0 19 0 20 0 IC105 6 0

21 1.9 7 1.4

23 0.8 8 0

24 1.1 9 0

25 2.7 10 0

26 1.1 11 0.5

27 2.6 12 0.6 13 0

IC102 2 0.8 14 0 3 ...(J.7 17 0 4 3.2 18 0 5 ...(J.2 19 ...(J.7 8 0 20 ...(J.7

9 1.4 21 0.4 10 ...(J.2 22 ...(J.l 14 0 23 0 15 5.2 24 0 16 5.2 25 0 19 -5 26 0 20 ...(J.2 27 0 21 0 28 0 22 1.1 29 0 23 0.3 30 3.2 24 0 25 ...(J.5 IC106 1 -1.5

26 0.8 2 ...(J.5

27 0 3 ...(J.5

28 0 5 0 6 0

IC303 1 -1.2 7 1.6 2 0 3 0 IC107 1 ...(J.7

4 2.8 2 0

5 2.8 3 0

8 ...(J.7 5 1.2

9 2.8 6 1.2

10 0 7 1.6

11 0 IC108 1 5.3

12 0 2 3.8 13 0 3 5.2 14 0

5 5.2 15 ...(J.5

6 5.2 16 0 7 5.2 17 5.1 20 5.2 IC109 , 5.2 22 2.8 2 3.8 23 2.8 3 5.2 24 2.8 5 5.2

6 5.2 7 5.2

DA BOARD WAVEFORMS

CD ® r-LlL I I ,

5.0 Vp-p (H) 4.2 Vp-p (V)

® ® ~ ~

2.6 Vp-p (H)

@ @

J'J\-2.2 Vp-p (V)

Schematic diagrams

... [Q] [1J boards

2.2 Vp-p (H)

M 3.8 Vp-p (H)

6 5.1 8 5.2 8 0 9 0 IC114 2 0

11 5.2 3 5.3

12 5.2 5 0.2 6 0

lel" , 2.9 7 5 2 2.4 9 2.1 3 5.3 10 5.1 4 5.3 11 5.1 5 5.3 14 0 7 5.3 15 4 9 0.8 10 0 IC115 1 4.9

11 5.2 2 0

12 2.5 3 0.9

13 0.2 4 7

14 0.2 5 0.9

16 5.2 6 8.5

17 5.2 7 4.9

18 5.2 8 0

19 0.2 9 1.2

20 5.2 10 6.8

21 3.8 11 6.1

22 5.2 13 8.7

23 0 15 8.9

25 5.2 16 2.5

26 5.2 18 0.8

27 5.2 19 5

28 5.2 20 7.6

29 5.2 22 5.2

30 5.2 24 0

32 5.2 25 0.2

33 5.2 16 0.2

0 27 1.9 34 35 4.7 28 * 36 4.6 29 6.3

37 4.2 30 6.2

38 4.2 ICl16 2 5.2

39 5 3 2.5

42 5.2 4 1.0 43 5.2

5 0 44 5.2

6 1.7 45 0 7 * 46 0 47 0

8 1.6 9 3.7

55 5.2 10 12.2

57 5.2 11 9 58 0 12 0 59 0

0.2 14 0.2

60 15 0.2 61 5.2 16 2.2 62 5.2 17 2.2 63 3.0 64 5.2

18 4.3 19 4

IC112 1 0 20 0.5

2 1.1 21 4.2

3 1.1 22 4.2

5 0 23 0

6 0 7 1.2

® @

~ ~ 2.2 Vp-p (V) 2.2 Vp-p (V)

@ @

~ JV\ 2.2 Vp-p (V) 1.2 Vp-p (V)

@ @ . r-LlL , , ,

4.6 Vp-p (H) 2.0 Vp-p (V)

-35-

4 11.6 5 0.8 6 0.8 8 2.1 9 2.1 10 11.7 11 11.2 12 10.4 13 0

ICl19 1 * 2 2.6 3 * 8 0.4 10 ...(J.l 11 5.1 13 0.3

IC120 2 * 3 0.4 4 5.1 5 2.7 6 * 8 2.6 9 2.6 11 0.2 12 2.6

IC121 2 2.5 3 5.1 4 * 5 * 6 0 7 4.8 10 * 11 5.1 14 0 15 4.7

IC122 1 ...(J.6 2 ...(J.2 3 0 5 0.3 6 0.3 7 0.5

IC130 1 0 2 0.3 4 0

IC131 1 5.2 2 5.2

0101 B 0 C 0.2

0103 B 0.2 C 5

0104 B 0 C 5.2

0105 B 5.2 C 1.7 E 0

0106 B 5.2 C 0

®

J'J\-2.3 Vp-p (V)

@

J'J\-2.2 Vp-p (V)

@

, , ,

5.0 Vp-p (V)

For Service Mllnullie MAURITRON SERVICES

8 Cherry Tree Road, Chlnnor Oxfordehire, OX9 4Qy'

Tel (01844) 351694 Fax (01844) 352554

emall:[email protected]

® 0 (\1\ J

2.2 Vp-p (V) 2.:

@ @

~ J 2.2 Vp-p (V) 2.:

® @ '-r

, , ,

4.5 Vp-p (V) 4.!

Schematic diagram

IDAI board"

4 11.6 5 0.8 6 0.8 8 2.1

! 9 2.1

I 10 11.7 11 11.2 12 10.4

I 13 0 I

IC119 1 * 2 2.6 3 * 8 0.4 10 -D.1 11 5.1 13 0.3

IC120 2 * 3 0.4 4 5.1 5 2.7 6 * 8 2.6 9 2.6 11 0.2 12 2.6

IC121 2 2.5 3 5.1 4 * 5 * 6 0 7 4.8 10 * 11 5.1 14 0 15 4.7

! IC122 1 -D.6

2 -D.2 3 0 5 0.3 6 0.3 7 0.5

IC130 1 0 2 0.3 4 0

IC131 1 5.2 2 5.2

0101 B 0 C 0.2

0103 B 0.2 C 5

I 0104 B 0 C 5.2

10105 B 5.2

I C 1.7

i E 0

I 0106 B 5.2 I C 0

® ®

J\A VV\ 2.3 Vp-p (V) 2.2 Vp-p (V)

@ @

J\A ~ 2.2 Vp-p (V) 2.2 Vp-p (V)

@ ® ! ! I ! ! I

5.0 Vp-p (V) 4.5 Vp-p (V)

Schematic diagram

IDAI board'"

E

F

G

H

(j)

fV\ J

2.2 Vp-p (V)

@

fV\ 2.2 Vp-p (V)

@

hJL 4.5 Vp-p (H)

R2" I'

1/16" ICHIP R219

I'

!fM1

11173 15t 1116W :OiIP

(170

?t, IHT-CP

loV' :Hl-CP

ICI03 DAC88~OFSR

DC DlfrlTAL ATT

11150 ", 1116",

SN7 HOI

'RN-<:~

R24 R24l1 10. 10k

1/16'1f 1111. ....

,RH-CP ''Y'C'iP2 RC4

V.ST

~======-~-~-~1

-36-

,

I

-

V.S SAl

e.3

0.2

OM e.5 .. "n~' .,u,.

111 l/n~ :CHIP

IlSR 0 0

'" '" ~ ~

STBY +5V H~l "f'

0206 ". 1/16'W 100lP

IC 1 OB X25040S E2 PROM

STBY ... 5V-4

R3DI

A207 , .. 1/1b'lt ICHIP

~fM~

~TBY

ICI31 TC7S04F INVERT

+SV

0208 ". 1/16V IOIIP

IC 111 -~'O

"" d ~ "" 0 " i: .... w X u

IC109 X25040S EZ PROM

RZZ9 ,. \/1" .. ICHIP

::' i1

IC110 SH!4 SN74HC 1 ZSANS

BUFFER RZZ7

" 1/16W STBY +SV

,CHIP

R228

" 1116'4 ICHIP

e120~Tf ReS. ISO PROTECT

CD en - N ,.., .... Ul

~: :~::: _ 0

ww

"'''' 00 u u

u u

~ TG 1A

l;;; IY >:< 2ij

~ 2A >;< 2Y >:;< (}NO y

BI21 RDS.ISOI PRUTECT

VCC ;:J- RI42 .,. 4G '" 1/16W

:CHIF' 4A ;; 0-- RD. 4Y = i- ,.

1/16,.

3G " ICHIP

3A >;: 3Y >;;: i-t----Y

R241 R240

" ,. 1116W IIIlair' :OHP ICHIP

...... ~ " ... ... ... ...

'" '" '" '" .... 6 ~ ... ;;; u

;i '" '" .. .. x ~; x>

, .... - ,~ >::< R0I13 B vss g.,1

lOCK

~ H.STOP ~ I V. STOP ~}.-J IK. PROT

HV. PROT '" ":r-!i.ltr

8Ea.AUSS '" e ••

PO'tIER t: e,4,17

A'"

" 1I1M1' 100JP

:~ N - '" ... ... ... "' ... '" '" '" '" ., ., '" ~ ~ 19

., ., > '" ~ c.

--- - --- - --- ---- - --- - --- - --- -----

IRO

- 37-

f~ A204 '0'

){,ItJ ){,ItJ

t 0239 02.5 4.7.

)mJ )f~W

V. STOP

J ~B' ve

OBll

OB13

OB4

MUTE

., .. 22.

1/14V ICHIP

L2~' ~~~~ =. 111" t101AE.PULSEBI~ H.SHIFT

OB3 H.BAl

DB'. VGA +SVI.TOv

R3DO N-f!!!.~~~"'---~__ 100 ,-----1116 .. :CHIP ~

- ICI30 ~ J. £I - TC75bbF HA', ~MUTE_ ~

R2.11 RZ15

l/hw ~~! (Illy ,CHIP ~fM~ :CHIP

lel17 13/41 ~,'nr u---++.j--+--.j--------ji-',w~~ ~ MCI401lBF a 'CHIP

II. V. STOP /I1UTE

12V ~ OBl1 0\ E@ HUTE gl04W

,R~rYv U~a~~3 J ,CHIP

~B2

'l.'.r. I/I'V ,CHIP

C12~i tilOS H.PIN HT-c!' CLAMP Nv HAil 0 lit=~=:t:==i===~====

caD r--1D~~ .

,";;·h H=ml AI57 ",;

11'011 'CHIP

810b HAIIO CLAHP

-12V

>:> o ,:

111111 C 01 CD

.... ..0 '" '" N N N N N

~ '" N N N N

_ 0

N N

~ V.BlK

12Vr+i2V1

A~~ ,4 !~ 8103

~ MA~U\~ r-------,

I "'''' .... ~ '" ~ '" N

_ 0

-

r--

r en .. .... .. "',

~ 1 __ ~I~I~I-----r--------R204 'd. lbltJ

I.STOP

---

l

vtlAeB'~

ilBB ve

6B'3 6B4

"''' l)t-&y I!;HIP

..J

""~r ,. !blt~

!O I! 17 II

1 B

~": I/ll.V sCHIP

-

IS

19 20

'f :CHIP iet,i;; I "'··U

l~ tn L--

C141 0.0033

:~~pI

I! II

I Cl15 CXAl543M

H OSC, V OSC

I'

"46 I 1~1

C'+I 47 '6Y

Hl-tf'

CI<7 "87 '50, ,m. m~ II 11

;:; p.GNe OUT2 ;;;

- 38-

ello R~m~2

f!.~~9 ,~'" ,CHIP

17

21

" ,

R311

bhk.." loHP

~ ~

" " no if ~

"-,; "" '"

I

I

I I

.-

- DA Board (Conductor Side) -

A

B

c

1

: Pattern from the side which enables seeing.


GDM-205HT G[

I D A I [v. BLK, HV REG, HV PROT]

2 3 4

.-

-39-

'1 . , O-f:, i

". 1 rnJ J £I t.G2 •. 'j

~ .. eN' .

~ li 11

~11 ~ , I

GDM-20SHT

:,111\1' 1 ; ]! 1

'I i~ '~

_·.0 rIJ 1 ,

,. 30

'-'l 0'

r,i

• DA BOARD

IC 0104 '0105

(Conductor) Side

(component) Side 0106

IC101 A-1 0107

IC102 A-2 IC103 8-2 IC104 8-4 IC105 C-1 IC106 A-3 IC107 A-3 0101

IC108 C-3 0102

IC109 C-3 0105

IC110 C-2 0106

IC111 8-2 0108

IC112 A-2 0109

IC113 A-2 0110

IC114 8-4 0111

IC115 A-4 0112

IC116 8-4 0116

IC117 C-1 0118

IC119 8-3 0119

IC120 C-3 0120

IC121 8-3 0121

IC122 C-3 0122

IC130 A-3 0123

IC131 C-3 0124

TRANSISTOR (Conductor)

Side (Component)

Side

0101 A-2 X101 0103 A-3

-40 -

8-3 8-3

8-2 A-3

DIODE (Conductor)

Side (Comparent)

Side

8-4 8-4

C-4 C-4

8-1 C-1 C-1

C-4 C-3 8-3 8-3 8-3 C-2 C-2 C-3 C-3 8-3

CRYSTAL (Conductor)

Side (component)

Side

8-2

- DA Board (Componer

Pattem :rom tr

: Pattern of the r

GDM-20SHT

rd (Component Side) -

: Pattern from the side which enables . . seeing . . Pattern of the rear side.

-41 -

GDM-20SHT

IAI [VIDEO]

- A Board (Conductor Side)-

1

A

DEl / C24 + ;)~ , r(] => . ,

" '

-- == ,-~.

B

C

o

: 7~ . C 14

GNfJ I C c.~ c, FU2

+15~ FLIO o ~.') 0

I, 0::; 1 ~ I

Patlern from the side Nhlch enables seeing,


SKt

o

For Service Manuals MAURITRON SERVICES

8 Cherry Tree Road, Chlnnor Oxfordshire, OX9 4Qy'

Tel (01844) 351694 Fax(0184~ 352554

emall:·[email protected]

-42-

4

'H!:!·' ='

/

4 5

• A BOARD

Ie 0300 0301

(Conductor) Side

(component) Side 0302

IC1 C-4 0303

IC2 0-4 0304

IC3 B-1 B-5 0305

IC4 A-1 A-5 0400

IC5 0-2 0500

IC9 A-1 0600

IC101 A-3 A-2 IC102 B-4 B-2 IC201 A-3 A-3 IC202 B-3 B-3 IC301 A-2 A-4 IC302 B-2 B-4 01

03 04

TRANSISTOR 05

(Conductor) (Component) Side Side

06 07

01 B-4 B-1 09

02 C-4 010

05 C-4 012

07 0-4 C-2 013

09 B-1 B-5 015

0100 A-3 016

0100 A-3 0101

0101 B-2 0102

0102 B-2 0105

0103 B-4 0106

0104 B-2 0201

0105 B-2 0202

0200 A-2 0205

0201 B-3 0206

0202 B-3 0301

0203 B-3 0302

0204 B-3 0305

0205 B-3 0306

-43-

A-1 B-4 B-4

B-2 B-3 B-3 C-4 C-4 C-4

DIODE

(Co~;~~!cr ) (Component) Side

C-2 C-3

C-2 C-2 C-2

0-1 B-1 B-4

B-1 B-1

C-4 B-4 A-3

A-2 B-3

B-2 A-3 A-3

B-2 B-3 A-4 A-3

B-2 B-2

A

8

c

o

GDM-20SHT

- A Board (Comp

1

eNIO. ; N ~

"*--_:] : > -

'"

: Pattern from the sid,

: Pattern of the rear si

GDM-20SHT

(Component Side) -

1

the side which enables seeing.

the rear side.

2

-44-

(3) Schematic Diagram of A Board

A

B

[

{)

E

F

G

TO 1'1 BOARD

J801-803

CN'02 5P

z

1----

'" lOOP :EMJ

3

FLI

" lOOP ,EM! " :CHIP ~I

~I

FL2 lOOP :011

~I~~--~----------------~ 'S~~I-C~O FL' lOOP

t===A~l~lldtll-______ ---{~I' a 0 BOARO elK 2 I-::FL-:-.-t---1~----------'

CN402 -~~ ~ h1L...-____ -I~~I__+_-I__-~ l-----~ ~ 1,.

4 s

------- - ------- - ------- - ---

CNZlp04 Fill rttl! ,aa. 1:~' 100.

·r:=~'~~!K~If-r~-~'~·'~~~-~·'F~~~i---i.'~~~lrP~'~~IP~'C~HI:P------+-t~4_+-+_-_r------~-------------TO 0 Ba'RO~ , KY ~ I .... .,,!: CN406 L,-__ ,,-' ,,-KY,-+~ZJ'""" 'NFl

H

I

1 I

I ,

~ FL'

lODOP 'EMI

RVID!. 201. 301

~

"'" 5.6. ;CHI

IC5 K/,23S3FP 8/A C(JIV

- .\ .... Gf+tl;;: rna 10 •

1"'-

R¥IOl

1'" f.t. ..---.. __ ...... --i- A02 AO' _",}--", __ :..I"1iU '~'i'!:,p

'1R6~~,~ r;, R't301 ''01<. -

... '''" I. ,III

Q,

~~SfN¥'OO

I lC911/2) 2 RC4558P5 1. 2~' \ ~ H.ST.T CONT ,~if

:OfIP 100'Prl""T 3 1 CD eq' I fm._=o ...

4 I 5 I 6 I 7 I 8 I 9 I 10

- ---- ---

RI02

,~'p

~

8:W,PI

, .. ". n'RM-cp" R61

5 ... :CHIP

11 11 Il IS 14 15 a N

> :; ~ d

I 7 ~ 5 4 3 2 1

'},g' ~ ,CHIP

"1g' RIOB ,CHIP ,biip

1 ellZ CH~~IP RIl2. 12>

:CHIP

il03 2SC3545

R-OUT )

£102 r 1 HAI53ic ' BlAST j

RIIO 15>

'AIKP ~w T,aov rh,HT

] I cd.?I ~lD3r,~~.~'1''''=-------------------------t-l----------J

B..2dr,,;r :~~ B:ZJ.V1P

RI04 15.

RN-CP R121 10>

'iOKP

f-r ~l 1'1;: : ~ Q200 j.CHIP

TL J 25C3357 tr/ WFFER C201 ~

I '!::I) .~dHp +-+-----~ IP r--t-+---lll-+-+--r.--,All'

~~ TL J mo

~1p357

"'IP

IJ 11 II 1Z 15 14 15 a

IC201 CXA 17091'

a.Plx C[J<T

I 1 ~ 5 ~ 3 2 1

le30' ~

IB:CHIP

'lBS

:CHIP

RU' R3118 'l12 ,CHIP no CH'C~IP

Rii7 :~ Q303

'Woo ,CHIP UII 2SC35~G

. ~

'tiN RNJ :CHIP :CHIP

"" '" ,CHIP

I 'b.l UFFER

I'

I---I--+-__ ~"lf e30! :CHiP

,CHIP !(/\ Q~~IP q-OUT c'" 2S~'lj3\' ~ rtJ...., 25C3357 +- ~i _ B-OUT

,---f---+----..jl-.-J -,- 8-0UT BICHIP rv) Am 0302 r 11 1 \t:),. ___ ,cI1'IP

1 R3D2 "'. :CHIP .~a11p

IJ II II Iz IS 14 15 a

b IC301 CXA1709P

B PIX.CONT

I 7 , 5 4 3 Z I

,\,~,' 25C3357 _ ~IOJ3!': J. L..'O¥CH",IP-+ __ B-(lJ_~ TT~-{l;ff ) BIAS'T 1 ;(() '315

C307 [3001 RfNJ 2sOfl0i:f :C~DIP B~t~lpI lI~t~l~ IOtIP B-ruT cyz

"" 41. :OUP Am 470

:CHIP

Ftf71oa_~ r .. f----1~ R304 100lP '-----'e'i';;l1-t4.-----++----.J lSI II I

Ir202 CR2428 1IAIVE

'~4S , II .J.e21'~ "I).ODZ 5DIJV •

T~2~,~ L 0205 '"lOa, ,"~5H83 B:CHIP ,.ROTECT

R219 ",. :IIt-CP

H1ZO 15.

,/1IKP

fiZZ! ,a. :RH-CP

IC302 CR2428 flRlVE

C~! SQj'

"19 15k 'i!II-CP

1 2

£20b H5H83

PROTECT

-cl..'ll' T,aov ,J,:HT

t~I~~'-~--P----------------------------B-~-tr-lpl=---------+-+-----------------~ ~ZI } ".

~,~~~ -25V :r . 31 B:g~P ""'1',1, , -" H------------~-------.L--m,J,

,I.IT,!

!-

". 'OIl ,. ,,..

~ ,,..

... , AH5~~S 101 61 HIASCOO R403

r--I----' ... "' .. I.---I+ :6cH81~ 2S~~O

R402

,~ ~l ~I BIAS C[J<T e40'

""l'T ( 100. BICHIP

IC4 NJM78H09FA

+9V REG

". R40 IH 111 ICHIP ,QUP

. ..... ,. !~IP

9 10 II ______ . ______ ---------------~-----1-2-------L----~1~3------~----~1-4------~--.---1-5_

--~

~01 418 10 lYE

l • 5

fi

RII!! "', ,11K!'

RI20 , .. 'RIHP

RI!1 10.

'llIKP

.101 1418 lYE

Blab HSH83

PROTECT

~ II

~C2\6 il205 ~Ji~OV, f HSMB3 B:CHIP ROTECT

810b Rm HSM83 '5> PROTECT

'ltHP

HIza '5>

AI" ., 11,. '~

Rl15

" '/2\1 "~8

FlI10l

FlIZOl

T~O:""~02

~ '1lIKP

':!.'ll' I':'WrV

RZ" 10. ,RII-CP

C301 2428 lYE

~ I Z

t''',r 8305 "If

~'ooaf HSM83 11,. .'CHIP PROTECT -:~ FlI3QI

f;,R319 B30b ~0~~02 ,5< IISMBl

'R't-CP PROTECT

R320 , .. ,11IH:P "wi

1~$'1 Al2' J 10k ,11IH:P

"?± ,Ilr ]-

IJh\tA Y R G

P \~l ~ ,,'51,)

~'?~ f 'nf ,OllP ,CHIP

~ iJ, ~fjf

&. PSI

,r .. ,:;

tt" &. ~gl 1

~ 64 ., ~

iflJ}Jv 1~~'t$H~ R~:'"{<.;r'-2

~'~~>i~ AS, ,- 1I~ 2 ,~

RVI b 8 ",.. ~Cl1 "" 1"" 0.0041 0.0041 I z~v '" Ifi R55

,'ll!. Rll ,., 220. ,

fjf BIO

se015-1 +Bl REG

~ I ,.. 2SC4~959-£~ .pJ +82 REG

R57 100 Bll 'I'':!. '12'< ALZ30e ':'mVI +BZ REG

813

+lj\-l~OE~ n,m lB~calp

~

IC3 TA7811S

ElpJ +'2Y REG

C,b-:¥ l ,

! m 'HTI I" ,HT

FLI 2200P 15"

1

EMI

FV ,

CN'03 7P

\/HT-L 'S-!1ICRO

TO e BOAAe

FBT

}-~:::::::::{i7~H~+~~~ • H-5 -5V

r- 4 GNil TO () BOARe

T EMI

~r:"~ 3 +15\1 CN'O'

..... Z I7NB 20.

"" lr ..... , +BZ ,lIC

,'-', lO0OP

-@--EMI

I.,~

~ I

I FLIO 'OO1lP :E.I"II

EMI

Fl.12 100011 'E"' EMI

.-

14

FV I

CNI03 7P

IIHT-L ,5-~'CRO

H-

TO g BOARe

FBT

I:::::::~~H+~~~ 5 -5V TO • BOARD

Ir_--t...gnGN~!l~=1 CN6Q6. II +15V GN!l +BZ

15 VOLTAGE LIST • A BOARD


IC1 1 • 2 • 3 • 4 • 5 • 6 • 7 • 8 •

IC2 1 • 2 * 3 * 5 • 6 • 7 *

IC5 2 • 3 • 4 • 5 • 6 • 7 * 10 * 11 • 12 • 13 • 14 • 15 *

IC9 5 • 6 • 7 •

IC101 1 3.2 2 6.9 3 3.1 4 4 8 3.4 10 4 12 0.5 14 1.9 15 2 16 2.7

Ref. Pin No. Voltage ['

IC102 1 1.7 5 35.2

IC201 1 3':2' 2 6.8 3 3.2 4 4 8 3.2 10 3.9 12 0.5 14 2 15 2 16 2.7

IC202 1 1.7 5 36.6

IC301 1 3.3 2 6.8 3 3.2 4 4 8 3 10 3.9 12 0.5 14 1.9 15 2 16 2.7

IC302 1 1.7 5 36.4

01 8 0 C 254 E -{J.7

02 8 • C •

05 8 • C • E •

A BOARD WAVEFORMS

CD W __ -- --... ---~ .... - "-"-fA---

---------.............. _ .... _ ......... -

0.7 Vp-p (H) 1.0 Vp-p (H)

@ ~-- -- ---_ .... ,. ...... ,.-_ .. ,.---

............... _ ............... _ .. ---------0.7 Vp-p (H) 1.0 Vp-p (H)

0 ® r~"-r" r~~"

0.55 Vp-p (H) 0.45 Vp-p (H)

@) ------ @ -- -_ .... ----_ ..

. -. .. ~ - - - ,.. ~ ... ,.. I ... ... -...

40 Vp-p (H) - - 40-Vp-p (H)

@ @ ------ --------'

-- - ............. , - - - ... ......... -40 Vp-p (H) 40 Vp-p (H)

VOLTAGE LIST • A BOARD


ICI 1 • 2 • 3 • 4 • 5 • 6 • 7 * 8 *

IC2 1 * 2 * 3 • 5 • 6 • 7 •

IC5 2 • 3 * 4 * 5 • 6 * 7 * 10 * 11 * 12 * 13 * 14 * 15 *

IC9 5 * 6 * 7 *

IC10l 1 3.2 2 6.9 3 3.1 4 4 8 3.4 10 4 12 0.5 14 1.9 15 2 16 2.7


IC102 1 1.7 5 35.2

IC201 1 3.2 2 6.8 3 3.2 4 4 8 3.2 10 3.9 12 0.5 14 2 15 2 16 2.7

IC202 1 1.7 5 36.6

IC301 1 3.3 2 6.8 3 3.2 4 4 8 3 10 3.9 12 0.5 14 1.9 15 2 16 2.7

IC302 1 1.7 5 36.4

01 B 0 C 254 E -0.7

02 B * C *

05 B • C * E *

A BOARD WAVEFORMS

CD .®- - -- --...... jIO ....... JIO ......... jIO---

---------............... _ ............... -

0.7 Vp-p (H) 1.0 Vp-p (H) .

@ ~-- -- --....... -jIO •• ~ JIO---jIO---

.............. -_ ..................... ---------0.7 Vp-p (H) 1.0 Vp-p (H)

.

(j) ® ~Y"-r" ~"-r"-r"

0.55 Vp-p (H) 0.45 Vp-p (H)

@ ------ ® -- -------_ .... ----'----' ---- ... ---

40 Vp-p (H) 40 Vp-p (H)

@ @ ------ ----------

---_.-,..-, - - -- ......... -40 Vp-p (H) 40 Vp-p (H)

Ref. Pin No. Voltage [V] Ref. Pin No. Voltage [V]

07 B 0 0205 B • C 290 E • E -0.6

0300 B 0.4 09 ~ 62.5 E -0.4

0100 B 0.4 0301 B • E -0.5 C •

E * 0101 B * C * 0302 B * E • C •

E * 0102 B • C • 0303 B 4.3 E • E 3.6

0103 B 4.4 0304 B * E 3.7 E *

0104 B * 0305 B • E * E •

0105 B * 0400 C • E * E •

0200 B 0.3 0500 C • E -0.5 E *

0201 B * 0600 C • C * E * E *

0202 B • C * E *

0203 B 4.4 E 3.7

0204 B * E *

® - ~ .-- -- -- - -

0.7 Vp-p (H)

® - ~ .-- -- - - -

0.7 Vp-p (H)

® ~"-r"-r" 0.45 Vp-p (H)

@ - - - - - .-

- - - -38 Vp-p (H)

@ - - - - -- - - -

38 Vp-p (H)

£I

E

F

G

H

J

o t1 BOAR CNeDI

e

e o {l BOAR

CN402

TO fl BOAR

CN406

e

I I

I I

I I

I~ol ~ ~N5'3 r

IN !Q-l PROTECTL

B Lf=h R3D~, ± R30~± 0351 ISO 150 47

IIiH:P IfIt-CP IOIIP

I

~ CNIDI

3P Fli \lHT-L :~

., ,5-KICRO " :DHP H. CLAMP I EHI

GNB g--, C. BLANK 3 .J, EHI

FU lOOP .EMI

I Fl4

CNI02 lOOP SP =011

,?.L~'-C~O EHI Fl' lOOP ALB I ",n ClK z EHI

FL' MO ~hl

lOOP :EI1I

-70V EHI GNB 5

~ CHID4 ." •• RS 2P FOI "

lOOk IDar. 100M 'VH a.4!Jl1l .:= ICHIP ltHlP ICHIP

I KV h-J - CO,,!: I KV O'f~v471

T ,

Fl7 !OOOP :EMI

f

I RV, 0 " 201. 301

I ~ IC5

I 1162353FP BlA CONY .,.

n,'D1 10' - 11.1MB 1l!Hl;: 1O'ft. I. "10 ,,," ... 10 • ~ ltM ... ;'02 AOI ..... ... '1!~s> 1m Rl6~1 "~IP m f ••• .... A03 ., :;:

I lH'!"F ~ a~IP

- A04 eLK ...

UI~IP - ADS

Le _

! CIA eo = RZ4 - A06 r :3t9~rp 56.

f :CHIP

.... AD7 A08 _

I - Vlld \ltC ...

I: ';O:"l!: CI~:!: ... :Ml .~cllI! 1.2_

f ~7 :CHIP

I DZ-TT11 REF.V1l..T

L-_____ _

-45 -

czo! 1

~ .,~,J G.PIX C

I , , 5 '

:z~J cz .. 0.1

~ 25' ,CHI! B1CH'l U

lC~Z is'

~ IB,CHv,P -

~fX&' J tV U ER -.::

~; ~I

.r" B~calp ! II 11 IZ I

b IC31 C3D3 CXAI7

.,~,J B PIX.

trrr 00. t50~ ! 0.1 0.1

I±:IID- I1fJI~ B?5rIJ

.. Z. IV

,ON

RSI 031 R8 10' '''' 1m IV IV ,,.. ,AN

Am~~ r-~f1: QI

25C4i>8I>A .STAT CONT

RS4 ~ R25 ~E~J~'~s . ~ C32 R35 11;'1

g;~af~ ,IO~pPROl Z~. \ t 10. H.STAT CONT .

'''gbl'~ l~~l MN'D ,CH IPl on ,CHIP ~ ROTECT +

IC 12/ RC{55SPS

W H.STA! CONT 0.01 !,CH

B:CHIP .»0,01 :QiIP

OZ. 10.

:CHtP

~

"~IP·" "~~lP

) 1 '" I ,'6fI,

~ .'~IJ

-5V

~ ,~I o CXA170!J'

6.PIX CONT

""'m .. r ,l,.\;.'(p

~i ',1 ~(I.l I~ m 1 ." J;t:HIP I

12: 15 14

IC3DI CXAI7D9P

B PIX.COIIT

(t"

B'~IP

15 U

(2071 ti~·l l .~dll'r .,tHI[

0311 ••• :CHIP

"li' ICHIP

,"l" ""~. ,!Hlp

QZO~,'.!::: IC'HIP '-'"

~J ,,.

~"J ,IIHP ImiP Z~1-M2 ,m rOt- IOtIP 02,.

~o ,81/, ,.....,. ~ J. 'IP!

'Vill' ,"'..,.

killJ

fl320

.~

~~------------------~------~ O3Z1 'Ok ,"'..,.

R404 116.

:fti-CP ~s IC2111Z} R4~.~

Ifirt-tf' RC4558PS ICHIP 61 BIAS CONT

eso. I R5113 ~.Ol 'T USOO 6.811 B. CH1PAr25A1330 :CHIP 61 BIAS JC\lONT

{~trJ ~ ..!HY'l ~

.... ". :OIIP

I

-46-

[0' ,HT

IC4 NJ+'1fv8/1RWA l

~

.'" 10k :CtlIP

." lOt tOIlP

I !

~ l~l:

" 1 IODV ,lIT

--

.,,' 47D IOIIP

'''' ;flt-CP

RZZO

'''' '11IKP

I PkOl[[l.J,

1!'B' I','""

\'fo 1I2V

l t '------EI1I

"n no.

DlO SC015-2 +B2 REG

FlJO

rt ___________________ ~~-------------+--------~~----+--~~----~---------~~-j5~V~-------~

-

~T

-

-46-

1[3 TA78125

~ tl2VllEG

3 1)-------------t-~C:'~I-,~----t-----------+-----------+---~:J::-----+----~~3 I ! , ~ ~.~

Z5~ T 1°·1'=' !

Rib 10k :01IP

R47 10k ICHIP

"I! 10l .CHIP

B;OUf""'P lIfT

C6 C7 C8

\~V] \iDfJ: ':~v1

A (V]flEOl

------- - ------- -~ B-S9B369< ... >-A ..

F\.1Z IDOOP IE,H

r---~EI1I

CJ3

1,Wr

" 'II' C'!)r ,OV H

'~I-C~O 7 H+ 6 H-5 -SV

TO a BDARt)

ISp • GNe ;ov 3 +ISV

CH'OIf.

B 2 (7ND

I tBZ

-47-

L u.~

02 B 3 3.1 C 4 4 8 3.4 05 B 10 4 C 12 0.5 E 14 1.9

15 2 16 2.7

A BOARD WAVEFORMS

CD ...... -,. .. _- ,.---~---

----_ ..... - ..... - ...........

0.7 Vp-p (H)

@ .. --.~ ... - ,.---,. .. --

... _-_ ........ _ ........................

0.7 Vp-p (H)

0 r"-r"-r"-

0.55 Vp-p (H)

@ -- - - - - - - -___ .-- __ 1

40 Vp-p (H)

~- - - -- - --_-.-- __ 1

40 Vp-p (H)

0~_ ~

- - - --1.0 Vp-

~~- ~

- - - --1.0 Vp-

® r"-r\

0.45 Vp

@ --_ .... ------40 Vp-

@ ------

- - --40 Vp-

. .

-2 6.9 3 3.1

02 B * C * 0203 B 4.4

4 4 E 3.7 8 3.4 05 B • 10 4 C • 0204 B • 12 0.5 E · E • 14 1.9 15 2 16 2.7

A BOARD WAVEFORMS

CD .. _-- .... -. ,.- .... ~---

................ - ..................

0.7 Vp-p (H)

0 -............ ~ ,._ .. -,.---

............... - ...................

0.7 Vp-p (H)

(j)

r~~\.. 0.55 Vp-p (H)

~- - - - -- -- ... - ,- .. ,.. ,.. I

40 Vp-p (H)

@ -- - - - -- - -- - ,.. ... _ ... ,.. I

40 Vp-p (H)

.®~ - ® -- -- - - - ---------- -- - --.

0.7 Vp-p (H) 1.0 Vp-p (H)

~~- ® -- -- - - - ---------- - - --.

0.7 Vp-p (H) 1.0 Vp-p (H)

® ® r~~\.. r~~\.. 0.45 Vp-p (H) 0.45 Vp-p (H)

@ @ ---~------ - - - - -

.. .. .. .. - - ----- -40 Vp-p (H) 38 Vp-p (H)

@ @ - --- .... ---_ .... -- - - -- --- .. .. .. - - - - -

40 Vp-p (H) 38 Vp-p (H)

For Service Manuala MAURITRON SERVICES

8 Cherry Tree Road, Chinn or Oxfordahlre, OX9 4Qy'

rei (01844) 351694 Fax (01844) 352554

emall:-maurltron@<jlal.plpex.com

-48-

.-

(4) Schematic Diagrams of DB, G, Hand M Boards

2 3 4 5 6

,--------12. ---------------~ I ~GI .J'~t.... I

'i .,,, ". ! I 15' I

B I l'l.~ I

I I I tll I , I.

I I 11119

'iII-CP

\~':l -15' I I ~

C I I I

ClI3

l'~ I

I I I

A AI: IN

&

B

c

!l & eec

,,,'CI1 AC IN AC IN

""'" IP

"""

I

cu· DBU -30V 1'1fT (AMP)

_-+-+ ... +"'::.j-:.. .. +="'+=-.. f.:"+m+.,+'~*=t=~;.j.!::=+=:!+'~~ __________________________ _ >1iJ»> ..... +1

c~ UlZU1ooa:: uu I -C!)-"'I'f]Q.. t-t:B B + I + I Z Z

TO e aOARi!

2 3

W I:::J >:

VOLTAGE LIST • DB BOARD


IC101 1 9.3 2 9.3 3 9.3 5 9.3 6 9.3 7 9.7

IC102 2 6.1 3 11.6 5 1.0 6 10.3 9 11.6 10 1.0 11 8.9 14 11.4

4 5

11 r-+-+-" L.. ______ --,

Ref.

IC103

Q102

0103

B-593321< ... >-{)B.

Pin No. Voltage [V] Ref. Pin No. Voltage [V]

1 1.8 0104 B 10.3 2 0.2 C 15.1 3 0.2 E 19.9 5 -4.3 6 0.2 Q105 B 10.3

7 14.3 E 19.9

B 0 0106 B 10.3

C 9.3 C 6.1 E 10.9

B 9.5 E 9.0

b 7

.....

8

I 5 I b I 1 I 2 ~-------------------, -

I I-I A I

I

gill 15Y I -

I C~'<! ll'~1

1Q4IP I , I

I ..rR114 Rll'

,~ '!f'- ,~ R90B

B 4.7k 5902 5903

I "15 1."17"'"

lei 0311/2l ! ~ 11 I ,J, OO~ OO~ I

I~ ;~ ~,t·~ ICH1P

I R909

illl "1'gIJ 4.7k 590. 5907 ffiD- ~ ,11K!'

,J, roo~ roo~ 1/ -ISY I

I - I U 1 U

R910

~ 4.711 5910 59\1

I-- {c!ft. ,/;

G~ 0~ 1/ I' I

I R9\1

C I 4.7'9913 9914 5915

,I, 6 6~ II> I>~ roo~ n I IpOIiERI l-J L,t I-

c~. DB~ ~ a: a908 >-

~~ _________ ~~Pl ",< ~~ I 155119 0'"

MATRIX "'", ~~ "'-- '" en B-SS33Z 1 < ••. >-flB. '" ~

5904

5912

591.~~

'" '" >< >< >< a:

~ a: >- >-ST ~~

N< on'" I N'" N'" enen ~~ 0 "'-

f) '" '" en ~ '" ~ oltage [V] Ref. Pin No. Voltage [V] Ref. Pin No. Voltage [V]

D' 5EL 19: R9~qN\ 100

R91.

9.3 IC103 1 1.8 0104 B 10.3 9.3 2 0.2 C 15.1

R913 100

9.3 3 0.2 E 19.9 I 9.3 5 -4.3 R9

9.3 6 0.2 0105 B 10.3 -9.7 7 14.3 E 19.9 R914 100

6.1 0102 B 0 0106 B 10.3 R916 100

11.6 C 9.3 C 6.1

1.0 E 10.9 I 10.3 0103 B 9.5 L_ 11.6 E 9.0

E 1.0 8.9 11.4 -

'fIo'(

R919 100

5 I b I 7 I 8 I 9 I 10 I 11 I 12

--------------------------------------------. § 't..,. .f.i I

I I

'f I: [ 'I

'I .--- 1:. tr. \I I r.lf

~~ ~.~I 1- ~

A ..I8a cUW: I r-- - -:; !lIZ II t--- 5r-- r-4" - f 'f I , l'rI:-: -

l..at.. l .... . , 'I.:r-irLJ

1- - 1.'1 ;t !Ita w =I.I?- I

- <?- "I'"~ :t:. • I ~

I n, ~~1 ~ -!~ ~ Ir.,

r' [1'1 lIIf tv· ~ T - r : '" -~

T r~r - l'~ I .

r - I r' ~ -::...--:

~ i ..M..I:'I'J. 'fir '!I' .,. ,

I

I ~.

~~ f'I .~~j I .... I ,!,

~, !I!f- jf; ~ .--~ $ ~ ~ r.t

\,i $ ISfJ ~ I

~ ~JlX lf~.?> ~!6 It. II ~

c_ .Ilt. II 'I' '5-iCHl ~ rf- I!'I ll'~'hf --'!I!! I, I » I I +Bl 180V

~ ~

I r tff ! f ft. IImI:Il.E -1 1 +Bl laDV

1_< t Ir 1 : ....

.. M.. 1 ,,,".L 1M , - +15V

---~. 1 : GNtl I""'!!!: :f l "'!' I .IIM4. II I -ISV , o 11 80 ......

I 2 I 3

f-- - - - -CNo' ~ 6.3V I

-hFS52 f·;1

STBY +5V

5902 5903

5906 5907 5908 >-UJ

'" UJ a:

I -

.Jt "933 I I

"'-' '"

-4

R931 ,7.

'" -' "

R932 47'

N -' "

-R933 47'

-' '"

I

R,'lf.4;

o -'

"

I C907 470,

B

5

----

'" -' u III

'" >

I -

R937 47.

b

-

L9DI 100 .. H IFLRSO

I

I I _ ..

TO M E CNBC

CN901 lOP

\/HT -l :S-HIC. ~906 3.3. 10 STBY

~F'-IfIO=---"""nan91"'7~------' ,- 9 GNil

R905 100 R~Sb+m B MO flg(A~ 7 CLK I 2 3 4 5 6 7 8 9 ID II 12 13 I RllS. I ES~z.. 6 H • C T L 5SIO 5911 5912 I PROTECT

61 RS.QI 100 - f-- 5 M I

~~ ~~ W~ r ~{;~ I R902 3.3k ~; ~~~

5914 5915 5S161n7r~~I~~~~li~~~i~ii~i~~~i:t:[Jr~ ~~~~Efl~NTA:~B~t~~E4~Es1.~=~tl:R:~QT210.oc~t· "it-~ 'fplt~~:tt-;jl--;-{f~jj~~~d~= 6 6~ 6 6~ 6 6~11 Y R904 ~ -J I ---J I -J I C990 ,oo!~!

a: a: a: >- >- >-

~~ 0'" =~ ~~ ~~ "'''' "'-;;; ;;; '" III III III - - -

>< >< g: g:

N< N'"

",< N'" <nO' "'- ~~

III ;;; III III -

---------

I 12

--.

I I I

i I I

I I

I I

I I

I I

CN6G5

I!'.-, .o-L +81 180'1

... z til 180'1

• .... · +15'1

• """ ....j... • 15' TO I BOARI

r-+-7~S\l r~. ,.

Co?fif:;: ~~~Sl 5~1 ll916 ~~~:'!~~~~~ C9.94rC9.:ETC99.6rC99.1T I l' 1t'5 ------.--t ,J, ,J, :1'fJ5 '----r'*-1-l----l I eS.IESB2 a'I-:l:3cn-:t;01-:t;

"' PROTECT 'PlI1a: CiJ lJ1a: C4JVlO:

m~~ L~ ~~~ LEll llRIVE

'f-Iolf "Sr~1 R939 SPB-26HVIIF 470. _ PO'tlER LEll .!. ___ _

5TBY +5V

C932 flTAIIHS LEa llRIVE

R936 470.

----

ll919~+ RllS.IESB PROTECT I

----

H (51 GNAL LAMP,) I CONTROL SW

---- -B-593321< ... >-H ..

VOLTAGE LIST eH BOARD

Ref. Pin No. Voltage [V] Ref. Pin No. Voltage [V]

IC931 1 5.2 IC932 3 5.2 2 4.5 3 5.2 0931 B 0 4 5.2 C 3.7

6 5.2 E 5.2

7 5.2 8 5.2 0932 B 2.8

9 5.2 C 2.5

10 3.3 0933 B 2.8 11 5.5 C 2.6 12 4.9 13 4.9 15 0 16 5.2 17 2.8 18 2.8 19 3.8 20 5.2 21 3.8 22 5.2 23 4.6 25 5.2 26 2.5 27 2.7

6 I 7 r- --- --

I -

I

L901 100,H IfLRSO

I TO C~8~~ARe

CN901 lOP

\/HT -L

~ :5-M1CRO

...I. 10 STBY 3.3>

,-- 9 GNfl 8917 IS 'MO e5.IE5~'f

~OTECT 7" elK 5 'DO

~~Z: r. I 6

I' t-- 5 ECT 100 t I- 4 3.3. J t- 3 ,00 - t- 2

I ,t~kf m ......

I I

~? :"'C;'1 I PROTECT I

I (S I GNAL LAMP,) I ~ CONTROL SW

I- - --B-SS3321< •.• >-H ••

] Ref. Pin No. Voltage [V]

IC932 3 5.2

0931 B 0 C 3.7 E 5.2

0932 B 2.8 C 2.5

0933 B 2.8 C 2.6

H. CTl M I GNfl KLI KS3

KSI

A

S, GNAl

B

C

J807

HtI/C9

CHS02 bP

fJ llliT-L

: S-MICRO TO e SOARe

5TBY GNe

MO ClK r-- H. CLK

MI

5TBY GNtl

E MO ClK

H. ClK HI

GNtl KLI K53 KSI

CHSO' , OP IrnT-L

,S-MICRO TO H BOARD

F

G

2 3

-'91l • g~ ""., R.!~~ ,AA-cp ,1<+-, ',w,t ,

I ~ P

-~ +5'{j

if1 ',-2

1 ~857 ... .- Lf!M~N5\ 3

.mp ,I, PROTECT .~

--, Sh b-.r'!

~ B ~ B u

~ w 70 :i1~ ~ 5

0: ~o..

!--~"- "'0..

'" 9r-

21~ =>'" ~:;j I~ 8r

~~~ ~~ i' ~i' 7r-+--t-

~ ~ ~ 6f'-t-

..l. St'-'r- .. .. 3r- -

-:~~ _J R831 100 :CHrp

~,,1 -.e:::= R832 !OO :CH1P

.JM,- W3 It :CH}P

~~

4

5T3Y -12V

'II' !~~l lbV x

II

VOLTAGE LIST M BOARD •

Ret. Pin No. Voltage [V]

IC801 1 0.4 2 3.5 3 4.4 4 4.2 5 3.6 6 2.9 7 4.7 8 0.3 9 10.4 10 0.3 12 4.9 14 0.2 16 0.2 17 0.2 18 0.7 19 0-

Ret.

IC851

0801

0802

-----

i'!: :CHI

-Pin No. Volta

1 7

~ '1-' 11-2 3

4 5 5 _L

6 -, 11 5 12 5 13 14 -~

B 0 E 0

B 0 E r

3 4 5 6 7

---~

- ~----------------------t-C:r~~-t.,,] ,/; --;;.-1 ~:'>!Q2

'I ,/; --;;.-1 p:"" ,/; ---I-.J IST3Y +5YI ,

~ K: tt~ Ila ,. ..

-ttttttt I--- lJ I

I 1

ST3Y +12V

t-+l L J

'Iii S~il 1 loY x

I1 II

12 11

"

.. I

15 I ~ N

" N

'"

I

1 IN I ..

WBOI

'S~!~O

8

TO A 30A;HJ

JIQI. ZOI. 301

I H. CLAMP TO A BOARe

I rf).;3Z+~GN~!l:!-_--..; eN I a I

oeol 25A1309A

H. CLAMP OUT

:.itf C.3LK

831 IGQ :CH]?

832 loa I(;HIP

~!I' ,<:HIP r-----------------t~ STBY +5Y

','P,I :CHIP

1& 15 "

ca,S! '-,-.d, ~l+----' CS,S5

II 1%

~a55~d ~ "54 I m& ReS! W R£IZSB I I 1+ I ,~!p r. 1 I ~1 Be53 PROTECT ,J. : "' MAI53 BB56

assl L.t,LJ _...!L*J.:.P:::RO::TE.::C::T __________ ---.,;~~Mm ?RM~~T 1---- - --- - - __

VOLTAGE LIST • M BOARD

Ref.

IC801

Pin No. Voltage [V]

1 0.4 2 3.5 3 4.4 4 4.2 5 3.6 6 2.9 7 4.7 8 0.3 9 10.4 10 0.3 12 4.9 14 16 17 18

0.2 0.2 0.2 0.7

Ref.

IC851

0801

0802

Pin No. Vollage [V]

1 7.6 2 10.1 3 2.5 4 5.3 5 -4.7 6 -9.8 11 5.2 12 5.2 13 0 14 -9.9

8 E

8 E

0.9 0.4

0.9 04

10

M BOARD WAVEFORMS

® ---'-I _ ..... , _ ...... ' _.

I" I

II

B-SS3321 < .•• >-1'1 ••

I" I

'tL

4.0 Vp-p (V) 5.0 Vp-p (H)

" .\ '\

l

A At IN

~

B

c

fI

E

F

G

~l

E

z 3

VOLTAGE LIST • DB BOARD


IC101 1 9.3 2 9.3 3 9.3 5 9.3 6 9.3 7 9.7

IC102 2 6.1 3 11.6 5 1.0 6 10.3 9 11.6 10 1.0 11 8.9 14 11.4

4 5

Ref. Pin No.

IC103 1 2 3 5 6 7

0102 B C

0103 B E

Voltage [V] Ref. Pin No. Voltage [V]

1.8 Q104 B 10.3 0.2 C 15.1 0.2 E 19.9

-4.3 0.2 0105 B 10.3

14.3 E 19.9

0 0106 B 10.3

9.3 C 6.1 E 10.9

9.5 9.0

b 7 8

-------------------------------------------

1~'

i--I

1-. '. I

H L __ ---____________________ ~ Schematic diagram

.. ~ board

-49-

Schematic diagrams

I DB I ~ [HJ [MJ boards'"

>< >< a: go

~; N"'" N'" en", <+>-

iii '" '" fl ,e [V] Ref. Pin No. Voltage [V] Ref. Pin No. Voltage [V]

3 IC103 I 1.8 0104 B 10.3 3 2 0.2 C 15.1 3 3 0.2 E 19.9 3 5 -4.3

3 6 0.2 0105 B 10.3

7 7 14.3 E 19.9

I 0102 B 0 0106 B 10.3

.6 C 9.3 C 6.1

0 E 10.9

.3 0103 B 9.5

.6 E 9.0

0 9 .4

5 b 7 8 9 10 II

'\';";' , ''''''

I ,I ...-.. E!RJI __

"i""

~ ~ !--

'J: 'th' I,wt, I,~ & JI '1i 'f,' G(PDWER 5UPPL Y)

~ "r.' ... ,m.. r-----------------~ 't.f~ ¥ ~, ! .".".. ...

I

-----=--------~ Schematic diagrams

I DB I [§] [ffi [M boards'"

>< go

~~ enen "'-

iii

12

- 50-

eg07 SEL 1922e-

CONY LE R912 100

A

R91b 100:

R9\3 100 A

¥

R917 ,

R91. 100

~'B r1I

n

R91S 100

JJ R919 ~ 100 SPB

POI

VOLT, eG

Ref.

IG601

IC602

IC603 ,

. -

!:: >< ~

~ ~ ~ ",< ::J< ",r

~~ "'''' "'-:g "' on "' "'

II 12

ClI ...

,sfCRtl +8' 180V

+81 18DV

0Nfl +15V

GNIl -15Y TO e B04fte

-5V CH403

5THr 12V +5V

I sur sv 11 roE

P. sow

+82 64V GNIl

+15V TO A BDARe

GNIl -5V

CHIO!

HI-H2+

,. 1M!

:5-M1CRO

- 50-

R914 100

R91B 100 ~

R915 100

R919 <S-1l901 100 SPB-26HV'tIF R939

PIl'tlER LEll 47011

VOLTAGE LIST e G BOARD


IC601 1 9.1 2 120.2 3 120.0 4 119.8 5 1.7

IC602 1 14.7 2 13.7 4 -37.6 5 -34.6

IC603 1 -37.5 2 -37.4 3 -37.5 4 -37.6 5 -35.1 6 -34.2 7 -37.5 8 -22.6 9 -31.4 10 -31.6 11 -22.9 12 -22.3 13 -32.1 14 -32.1 15 -32.1 16 -37.5

Q932 IlTAII4YS

LEG IlRIVE

G906 SEL1922G-C. G

CENTER LElJ !l905

SEL 19ZZB-C. B COLOR LEe

G904 SEL I 922B-C. II

SIZE LEll e912

SEll 922G-C. II SHAPE LEG

G924 SEL I 92211-C. e

HOIRE LEe

R936 4701r.

Ref. Pin No.

IC604 1 2 3 5 6 7 9 10 11 12 13

IC651 3

IC652 2

IC653 3

IC655 1 4

IC656 1 2 3 4 5 6 7

I

Voltage [V] Ref. Pon No. Vollage [V]

-31.2 IC657 1 183.4 -37.5 2 183.4 -22.4 4 12.1 120.0 5 2.6 135.0 6 0 126.5 8 1.4 -22.3 9 0.3 -31.7 10 0 -37.5 11 0 -31.4 12 0 -37.5

0601 B -24.5 7.4 C 277.0

E -22.1 -7.3

0603 B -36.8 14.4 C -37.6

8.0 E -37.4

1.3 0605 G 126.5

0.2 D 276.0

5.1 S 119.8

1.1 0606 G -31.1 0 D 119.8

5.1 S • -37.5 3.7 2.5 0651 B 0.8

C 0.2

~'2u 155119

S'tI G919 t ReS.IE58

PROTECT

H (5 [GNAL LAM CONTROL S'w

E-SS3321 < ....

VOLTAGE LIST eH BOARD

Ref. Pin No. Voltage [V] Ref. Pin No. Volta(

IC931 5.2 IC932 3 5. 2 4.5 3 5.2 0931 B l

4 5.2 C 3.

6 5.2 E 5.

7 5.2 0932 B 8 5.2

2.

9 5.2 C 2.

10 3.3 0933 B 2. 11 5.5 C 2. 12 4.9 13 4.9 15 0 16 5.2 17 2.8 18 2.8 19 3.8 20 5.2 21 3.8 22 5.2 23 4.6 25 5.2 26 2.5 27 2.7


0652 B 0 C 12.6

0653 B 6.7 C 7.4 E 7.4

0654 B 0.8 C 0.2

0655 B 7.4 C -2.9 E 7.1

0656 B 7.8 C -0.8 E 7.6

0657 B 0 C 39.4

0660 B 39.0 C 2.3 E 39.6

0661 B 39.4 E 39.4

0662 B 2.1 C 39.6 E 14.4

!J9z0 155119

SYI "1l919 1 RIlS.1E5B

PROTECT I

H (5 I GNAL LAMP,) I CONTROL 5W ---- -

LTAGE LIST i BOARD

f. Pin No. Vol1age [VI

31 1 5.2 2 4.5 3 5.2 4 5.2 6 5.2 7 5.2 8 5.2 9 5.2 10 3.3 11 5.5 12 4.9 13 4.9 15 0 16 5.2 17 2.8 18 2.8 19 3.8 20 5.2 21 3.B

22 5.2 23 4.6 25 5.2 26 2.5 27 2.7

In No. Voltage [VI

B 0 C 12.6

B 6.7 C 7.4 E 7.4

B 0.8 C 0.2

B 7.4 C -2.9 E 7.1

B 7.B C -0.8 E 7.6

B 0 C 39.4

B 39.0 C 2.3 E 39.6

B 39.4 E 39.4

B 2.1 C 39.6 E 14.4

B-553321 < ..• >-H ••

Ref. Pin No. Vollage [VI

IC932 3 5.2

0931 B 0 C 3.7 E 5.2

0932 B 2.8 C 2.5

0933 B 2.8 C 2.6

E

F

G

- 51 -

MO 3 ClK

H.ClK M I 6

5TBY 10 (Hffi 9

MO 8 ClK

H. eLK MIS

(Hffi 4

Kli

J~09 I ,MINt-ilIN I

VISCA

~ ~ u bl ~

00 ~~ FA~ j:l&: 0> ... !!i&1 =~ "' .. "'

~ ~

R831 100 ICHIj:)

R832 100 ,CHIP

L.::::===:" +----+--w.-- RS33 It :CHIP

!S801

"' Ili

L-__ ~~ ______________ ~~I~ ____________ ~r-__ ~ __ ~

VOLTAGE LIST eM BOARD

Ref. Pin No. Voltage ~

IC801 1 0.4 2 3.5 3 4.4 4 4.2 5 3.6 6 2.9 7 4.7 8 0.3 9 10.4 10 0.3 12 4.9 14 0.2 16 0.2 17 0.2 18 0.7 19 2.7 20 2.7 21 0.2

ICB03 0.8 13 0.2 14 0 15 5.2

lil "8S7 l!' 5966 ,me J~A ~ S3

"PROTECT

~ 8 ~ ~ u

~ J ~

~ ~~ 0

:?:"" ~g: '" ",N

$~ a:ffi """, "'Ill "'Ill

~ ~ is ~ c:

R!31 lOCI ,CHI?

RIl2 tDD ICHIP

R!!3 11 :CHIP

COD. 4.7

ReI" ,1~!p

1 am : ~AIS3 !ROTE:T

R8(..2 • :~Y.

,1Wp

~m :CHIP C!12 •

5TBY +5Y

R11!

'" :tHIP

C~BD7 BP

'«'HT-L :S-MICRO

r-;~-t-~~==t=~--+-++--------+-u:t5~~~~ TO A BOARS

eN! 01

r-----------------t- STBY + V

M (INTERFACE) I

aS51 L ... JL---",Of..L--:...=-_________ --...c

P~M~~T - _______ - _______ " - ~p _________ 1 - ---- - ------ - -------

VOLTAGE LIST • M BOARD


ICBOt t 0.4 2 3.5 3 4.4 4 4.2 5 3.6 6 2.9 7 4.7 8 0.3 9 10.4 10 0.3 12 4.9 14 0.2 16 0.2 17 0.2 18 0.7 19 2.7 20 2.7 21 0.2

IC803 1 0.8 13 0.2 14 0 15 5.2

Ref.

IC85t

0801

0802

0821

0822

B-S53321 < .•. >-M .•

M BOARD WAVEFORMS

Pin No. Voltage [V] ® t 7.6 ~ ~ ~

2 10.1 3 2.5

I I

11 '~L....-

4 5.3 5 -4.7

4.0 Vp-p (V) 5.0 Vp-p (H)

6 -9.8 11 5.2 12 5.2 13 0 14 -9.9

B 0.9 E 0.4

B 0.9 E 0.4

B 5.5 E 4.B

B 0.8 E 0.4

-52-

I H I [SIGNAL LAMP]

- H Board-

I~

5913

~I

o

R920

I

o n

6903 ::0 I ~ ~ I ~ :;:: ~ N ~

'" ~ ~ =: R9,3 ... 0:;

6908 R919 III I +I- -

'+ ...... '" ...... '" (1 7 1 0591 1 1) ~"';:'+ .,. ~

1-657-355-1 1 ~

- M Board (Conductor Side)-

- DB Board (Conductor Side) -

GDM-20SHT GC

IMI [INTERFACE SYNC SEP]

I 5910 I

eN901

..0 ~ ..0 ~ .. Go ~u~ I 5911. I I 5912 I I~ I:

• • R910 .- 0909

+I-

9910 +I-

R9H

H .~ •

I ~:: I ~ I I

6911

I ILl I- .. " ~II~ +I-~.

-53-

CN903 C9S0

[

T GDM-20SHT

I DB I [AMP]

~ , ;:';'; , , ;,,; , .' ~' , -.:g ....... I ;907~ I 9924 I ~90; I - .:: D922 c ~ _

- , '*. .,,' SONY ! , ~1 - ~ 1 g 1 .m • -* ;'" ~ ,~ § : II] '" I "'- * -* - .". '.Ja~ -* * ~"

-+i-::: ~ ~ • ~ 1.0

• R909 I '-.. '-. :m ..... "111 'Ii ~ + ..... to R933~-+~ 1--- n n.-. ""0 • -0 i!. _ •• I • • t:: -.. I I - R938 :

I:il, '..,,~ "" "" "" ··'ii' : [;J I!illl ;; ,

[990

d (Component Side)- M Boar

d (Component Side) -- DB Boar

-54-

f am the side which enables seeing . . Pattern r


r I ~

r ..... ~

-------" I Q

1",,1 f----

( 6

-(:r Ft;:

~ iii--

-"'MO'

0

o AU1

{;i3 [

Ie

Jl" ;~

. .

MP] I G I [POWER SUPPLY]

-G Board-

.m

......

-55-

+~3 §I

Jf ""

-.+-1+"'75

I I

!'\----iiI ~

0

Jf l:i12

GDM-20SHT

. .

GDM-20SHT 5-5. SEMICONDUCTORS

CXA1543M-T6

t:J , "

CXA1544M-T6

o , "

(lcP VIEw)

CXA1616S 22 12

~:::::::] II

{rop vitw}

CXA1470AM-T6 CXA8021 M-T6

o , "

DAC8840FS

11 {rOLl ""...,1

HD74HC123AP IR3M02A M62353FP MAX232N TC4528BPHB

(TO"VI(.'

LA6500-FA

o o

o

LM7812CT NJM78l12A NJM78M05FA NJM78M09FA NJM78M12FA TA7812S

MC14011BF-T2 SN74HC125ANS TC74HC86AF

o 7

MC68HC05P7BSC402191 B

TOP VIEW

MMl170BFB NJM4558V-TE2 Tl082ACP UPC358C UPC393C UPC4558C X25040S1

8 7 6 5 o 1 2 3 4

(Top v,ew)

NJM79L 12A

0_ ~ ,- )~

1 ) W ..

NJM79M05FA

131

/\\ COMMON IN OUT

(GND)

PST600D-T

RC4558PS • 1 , ~

o 11 J'

'TOI''''[Wl

SC7S04F ,

'~ ~ . SN74HC32AN .. . ~:::::::I , ,

HOP' ""(w,

SN74HC74ANS

o 1 "

(1Cf" ""(W)

STK-390120 STK390-120

MARKING SIDE VIEW

STR-81145A

TC74HC123AF

[101""'(")

TDA8172

2SC2668-Y DTAl14YS DTC124ES

~ E e B

2SB1094-lK 2SC3746 2SC4159·E 2SC4507 2SC4686A (LB SONY) 2SD2012 IFF19630GS IRF19630G

~ Bel:

IRFPG50LF

IRHT5305

12

2SAl162-G 2SA1330·06 2SA 1462· Y33 2SB1218A·QRS 2SC1623·L5 L6 2SC3545·T43 2SC4116-YG UN5213

B~ 2SA 1175-HFE 2SC2785-HFE

"'j E C 8

2SC2780-NK 2SC2954

.~ E

2SD774-34

m E C 8

DTZ· TTll-2.4B

~ATHODE

YANODE

DTZ5.1C MAllO RD12SB2 RD5.1SB2·T2

~ CATHOOE:

Dl0SC6M D8LC40

, , ,

- 56-

Dl0SC6MR D8LC20U

~ ",

lSSl19 lSS120 D1N20R D1NS4 ERA38-06 RD12ES-B2 RD13ES-B1 RD13ES-B2 RD15ES-B2 RD18ES-B2 RD2.2ES-B2 RD20ES-B2 RD22ES-B3 RD30ES·B2 RD5.1ES-B2

ANODE

D2S6M

==lIJ== --D4SB60L

EGP10D EGP20DPKG23 ERA91-02

f~"' ANODE

lSS83 GP08D

PC111YS

o , , ,

~ . , ,

: I~(l - I

RGP02-17 RGP02·17EL·6433 °8340

KCATHODE

RANOOE

RGP02-20EL-6394 S2LA20F

cathode

anode

RlZ30D-TE11

SC015-2

~ ,

rn , l ,

lSS226

p CA THODE MARK

D SEL 1922D-C

R / calhode

anode

. .

6433

·6394

• Items with no part number and no

description are not stocked because thy

are seldom required for routine service.

• The construction parts of an assembled

part are indicated with·a collation number

in the remark column.

6-1. CHASSIS • 7-685-648-79 +BVTP 3X12 • 7-685-663-14 +BVTP4X16 ... 7 -682-548-04 +-BVTP M3X8

SECTION 6

EXPLODED VIEWS • Items marked" • " are not stocked since

they are seldom required for routine

service. Some delay should be

anticipated when ordering these items.

o 7-685-246-14 <) 7-682-560-04 /:::,. 7 -685-161 -01

+KPT 3X8 +-BVTP M4X6 +P 4X12

GDM-20SHT

NOTE:

The components identified by shading and mark .& are critical for safety. Replace only with part number specified.

Les composants identifies per un trame et une marque &. sont critiques pour la securite. Ne les rem placer que par une piece portant Ie numero specifie.

REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

1 2 3 4 5

6 7 8 9 10

X·4032-773·1 BEZEL ASSY 2,3 4·041-622-61 POWER, BUTTON 3-571-801-01 SPRING, COMPRESSION 8-933-123-00 H BOARD

• 4·049-207-01 BOX, CONTROL

• 9-911-844-99 CUSHION 1-543-798-11 FILTER, CLAMP (FERRITE CORE) 4·365-808-01 SCREW (5), TAPPING 8-933-120-00 DEFLECTION MCB ASSY (0 BOARD) 4-041-043-05 HOLDER, HV CABLE

20

10

1nmj45345$ZiTAANsF~5RASSyr.FIiYSAcK/ 26 27 28

12 • 4-049-742·01 COVER, ANODE CAP 13 4-381·962·11 SCREW (M4X8), TAPPING, (+-) (BV) 14 4·040-985·01 RIVET, PUSH 15 A-1429·504-A PANEL ASSY, CONNECTOR 16-19

-57-

4-038-522-01 CAP (VISCA)

X-4032-772·1 CABINET ASSY 8-923-121·00 DA Mount 1-900·211·98 Main Harness

T GDM-20SHT

6-2. PICTURE TUBE • 7-682-548-04 +-BVTP M3X8 • 7 -685-663-79 +BVTP 4X 16 V 7-682-563-04 +-BVTP M4X12 • 7-685-663-14 +BVTP4X16

The components identified by shading and mark & are critical for safety. Replace only with part number specified.

Les composants identifies per un trame et une marque & sont critiques pour la securite. Ne les rem placer que par une piece portant Ie numero specifie.


K

51 A·1020-756-A CRT COMPLETE ASSY 52-56 52 1-452-032-00 MAGNET, DISC

~£~~~fsm*tjii#ii¢~YQKgY@$mi4J $&',M*~fMM$~fl~~1P§g~l$P~~'t)}

57 58 58 59 60

61 62 63 64 65

1-452-729-11 NECK ASSEMBLY (NA3011) 8-933-119-00 A BLOCK ASSY 59-61 X-403-058-41 PERMALLOY ASSY, CORRECTION 60 X-4029-794-1 RETAINER ASSY, VIDEO 4-041-627-01 SCREW (M4X20), HEXAGON HEAD

1-543-798-11 FILTER, CLAMP (FERRITE CORE) • 4-041-027-01 COVER, VIDEO SHIELD 4-369-318-00 SPRING, TENSION 1-411-471-11 COIL, DEMAGNETIZATION 1-411-472-11 COIL, LANDING CORRECTION

66 67 68 69 70

71 72 73 74 75

76 77

-58-

• 4-395-824-01 HOLDER, DEGAUSSING COIL ·9-911-844-99 CUSHION 4-381-962-11 SCREW (M4X8), TAPPING, (+-) (BV) 8-933-124-00 CONVERGENCE ADJ MCB ASSY (L BOARD) X-4032-774-1 STAND (B) ASSY 71-75

4-042-282-01 SPRING, TENSION • 4-043-646-01 HOLDER, STAND 4-041-623-01 STOPPER (A)

• 4-041-625-01 RING, TILT SWIVEL 4-041-621-01 STOPPER (B)

4-308-870-00 CLIP, LEAD WIRE 1-452-094-00 MAGNET ROTA TABLE DISK; 15MM0

GDM-20SHT

6-3. PACKING MATERIALS

.1-----.15


151 *1-543-830-11 CLAMP, SLEEVE FERRITE 161 * 4-038-264-0 1 TRAY 152 1-775-508-11 CABLE ASSY (15P DSUB CONNECTOR) 153 ....... :3-f300~11?:.1J.MANl,JA!" •. IN$IRl,JGIIQN ................................ .

:j54:ifl:~f:1~$$gti:::CPa.p.satte~B$UpP4¥j~V): 155 * 4-041-498-01 CUSHION (UPPER) (ASSY)

156 * 4-049-760-01 INDIVIDUAL CARTON 157 * 4-368-079-01 BAG, POLYETHYLENE 158 *4-041-505-01 PAD 159 * 4-041-499-01 CUSHION (LOWER) (ASSY) 160 * 4-396-077-01 JOINT

-59 -

GDM-20SHT

MEMO

.. ... .............. ... ................................. ............ ... .. .......... ;.., ... ,--

-60 -

GDM-20SHT

NOTE:

The components identified by shading and mark &, are critical for safety. Replace only with part number specified.

SECTION 7

ELECTRICAL PARTS LIST

The components identified by B in this RESISTORS

manual have been carefully factory- • All resistors are in ohms

selected for each set in order to satisfy • F: nonflammable

regulations reg.arding X-ray radiation.

Should replacement be required, replace

only with the value originally used.

• Items marked" •. , are not stocked since

they are seldom required for routine

service. Some delay should be Les composants identifies per un trame et une marque &, sont critiques pour la securite. Ne les remplacer que par une piece portant Ie numero specifie.

• All variable and adjustable resistors have anticipated when ordering these items.

characteristic curve B, unless otherwise

When indicating parts by reference number,

please include the board name.

noted.

REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION

VIDEO AMP, MCB ASSY (A BOARD) C104 1-164-004-11 CERAMIC CHIP 0.1MF ** ............... * .................................................. '1" ......... C10S 1-164-004-11 CERAMIC CHIP 0.1MF (BOARD PART NO. 1-6S7-3S4-11) C106 1-164-004-11 CERAMIC CHIP 0.1MF

C107 1-164-232-11 CERAMIC CHIP 0.01MF 1-S43-298-11 BEAD, FERRITE C108 1-164-232-11 CERAMIC CHIP 0.01MF 4-382-8S4-11 SCREW (M3X10), P, SW (+)

C109 1-164·004-11 CERAMIC CHIP 0.1MF C111 1-164·004-11 CERAMIC CHIP 0.1MF

CAPACITOR C112 1-163-113-00 CERAMIC CHIP 68PF C113 1-164-489-11 CERAMIC CHIP 0.22MF

C1 1-162-114-00 CERAMIC 0.0047MF 2K C114 1-101-821-00 CERAMIC 0.0022MF C3 1-107-939-11 ELECT 1MF 20% 160V C4 1-107-939-11 ELECT 1MF 20% 160V C116 1-163-831-00 CERAMIC CHIP 0.047MF

CS 1-107-939-11 ELECT 1MF 20% 160V C117 1-107-931-11 ELECT 33MF C6 1-107 -92S-11 ELECT 1MF 20% 100V C120 1-163-23S-11 CERAMIC CHIP 22PF

C122 1-164-004-11 CERAMIC CHIP 0.1MF C7 1-107-92S-11 ELECT 1MF 20% 100V C201 1-164-232-11 CERAMIC CHIP 0.01 MF C8 1-107-92S-11 ELECT 1MF 20% 100V C9 1-162-114-00 CERAMIC 0.0047MF 2KV C202 1-164-004-11 CERAMIC CHIP 0.1MF

C10 1-102-989-00 CERAMIC 68PF S% SOOV C203 1-164-004-11 CERAMIC CHIP 0.1MF

C11 1-162-114-00 CERAMIC 0.0047MF 2KV C204 1-164-004-11 CERAMIC CHIP 0.1MF C20S 1-164-004-11 CERAMIC CHIP 0.1MF

C12 1-162-114-00 CERAMIC 0.0047MF 2KV C206 1-164-004-11 CERAMIC CHIP 0.1MF

C13 1-107-929-11 ELECT 10MF 20% SOV C14 1-107-929-11 ELECT 10MF 20% SOV C207 1-164-232-11 CERAMIC CHIP 0.01MF

C1S 1-107 -929-11 ELECT 10MF 20% SOV C208 1-164-232-11 CERAMIC CHIP 0.01MF

C16 1-163-131-00 CERAMIC CHIP 390PF S% SOV C209 1-164-004-11 CERAMIC CHIP 0.1MF C210 1-164-489-11 CERAMIC CHIP 0.22MF

C17 1-107-929-11 ELECT 10MF 20% SOV C211 1-164-004-11 CERAMIC CHIP 0.1MF C18 1-164-232-11 CERAMIC CHIP 0.01MF 10% SOV C19 1-102-989-00 CERAMIC 68PF S% SOOV C212 1-163-113-00 CERAMIC CHIP 68PF

C20 1-102-989-00 CERAMIC 68PF S% SOOV C213 1-164-489-11 CERAMIC CHIP 0.22MF C21 1-107 -943-11 ELECT 10MF 20% 160V C214 1-101-821-00 CERAMIC 0.0022MF

C216 1-163-831-00 CERAMIC CHIP 0.047MF C22 1-164-232-11 CERAMIC CHIP 0.01MF 10% SOV C217 1-107-931-11 ELECT 33MF

C23 1-164-232-11 CERAMIC CHIP 0.01MF 10% SOV C24 1-107 -929-11 ELECT 10MF 20% SOV C220 1-163-23S-11 CERAMIC CHIP 22PF

C26 1-163-133-00 CERAMIC CHIP 470PF S% SOV C301 1-164-232-11 CERAMIC CHIP 0.01MF C27 1-163-229-11 CERAMIC CHIP 12PF S% SOV C302 1-164-004-11 CERAMIC CHIP 0.1MF

C303 1-164-004-11 CERAMIC CHIP 0.1MF C28 1-163-229-11 CERAMIC CHIP 12PF S% SOV C304 1-164-004-11 CERAMIC CHIP 0.1MF

C30 1-102-244-00 CERAMIC 220PF 10% SOOV C32 1-164-161-11 CERAMIC CHIP 0.0022MF 10% SQV C30S 1-164-004-11 CERAMIC CHIP 0.1MF

C33 1-164-232-11 CERAMIC CHIP 0.01MF 10% SOV C306 1-164-004-11 CERAMIC CHIP 0.1MF

C41 1-164-004-11 CERAMIC CHIP 0.1MF 10% 2SV C307 1-164-232-11 CERAMIC CHIP 0.01MF C308 1-164-232-11 CERAMIC CHIP 0.01MF

C71 1-107 -92S-11 ELECT 1MF 20% 100V C309 1-164-004-11 CERAMIC CHIP 0.1MF C72 1-164-232-11 CERAMIC CHIP 0.01MF 10% SOV C101 1-164-232-11 CERAMIC CHIP 0.01MF 10% SOV C311 1-164-004-11 CERAMIC CHIP 0.1MF

C102 1-164-004-11 CERAMIC CHIP 0.1MF 10% 2SV C312 1-163-11~-00 CERAMIC CHIP 68PF

C103 1-164-004-11 CERAMICCHIPO.1MF 10% 2SV C314 1-101-821-00 CERAMIC 0.0022MF

- 61 -

REMARK

10% 2SV 10% 2SV 10% 2SV 10% SOV 10% SOV

10% 2SV 10% 2SV S% SOV 10% 16V SOOV

10% 100V 20% 100V S% SOV 10% 2SV 10% SOV

10% 2SV 10% 2SV 10% 2SV 10% 2SV 10% 2SV

10% SOV 10% SOV 10% 2SV 10% 16V 10% 2SV

S% SOV 10% 16V SOOV 10% 100V 20% 100V

S% SOV 10% SOV 10% 2SV 10% 2SV 10% 2SV

10% 2SV 10% 2SV 10% SOV 10% SOV 10% 2SV

10% 2SV S% SOV SOOV

., . '-

GDM-20SHT

Les composants identifies per un trame et une marque,& sont critiques pour la securite. Ne les rem placer que par une piece portant Ie numero specifie.

The components identified by shading and mark ,& are critical for safety. Replace only with part number specified.


C316 1-163-831-00 CERAMIC CHIP 0.047MF 10% 100V C317 1-107-931-11 ELECT 33MF 20% 100V

C320 1-163-235-11 CERAMIC CHIP 22PF 5% 50V C400 1-163-831-00 CERAMIC CHIP 0.047MF 10% 100V C500 1-163-831-00 CERAMIC CHIP 0.047MF 10% 100V C501 1-164-232-11 CERAMIC CHIP 0.01 MF 10% 50V C502 1-164-232-11 CERAMIC CHIP 0.01MF 10% 50V

C600 1-163-831-00 CERAMIC CHIP 0.047MF 10% 100V C601 1-164-232·11 CERAMIC CHIP 0.01MF 10% 50V C602 1-164-232-11 CERAMIC CHIP 0.01MF 10% 50V

CONNECTOR

CN101'1-564-518-11 PLUG, CONNECTOR 3P CN102'1-564-520-11 PLUG, CONNECTOR 5P CN103'1-564-522-11 PLUG, CONNECTOR 7P CN104'1-766·179-11 PIN, CONNECTOR (PC BOARD) 2P

TRIMMER

CT101 1-141-436-11 CAP, ADJ CT201 1-141-436-11 CAP, ADJ CT301 1-141-436-11 CAP, ADJ

DIODE

D1 8-719-404-46 DIODEMA11 0 D3 8-719-404-46 DIODEMA11 0 D4 8-719-901-83 DIODE 1SS83 D5 8-719-901-83 DIODE 1 SS83 D6 8-719-901-83 DIODE 1 SS83

D7 8-719-977-00 DIODE DTZ5.1C 09 8-719-404-46DIODEMA110 D10 8-719-018-47 DIODE SC015-2 012 8-719-985-10 DIODE RLZ30D-TE11 013 8-719-985-10 DIODE RLZ30D-TE11

D15 016 D101 D102 D105

D106 D201 D202 D205 D206

D301 D302 D305 D306

FB1 FB101 FB201 FB301

8-719-404-46 DIODEMA11 0 8-719-901-83 DIODE 1SS83 8-719-800-76 DIODE 1SS226 8-719-800-76 DIODE 1 SS226 8-719-901-83 DIODE 1SS83

8-719-901-83 DIODE 1SS83 8-719-800-76 DIODE 1SS226 8-719-800-76 DIODE 1SS226 8-719-901-83 DIODE 1SS83 8-719-901-83 DIODE 1SS83

8-719-800-76 DIODE 1SS226 8-719-800-76 DIODE 1SS226 8-719-901-83 DIODE 1SS83 8-719-901-83 DIODE 1SS83

FERRITE BEAD

1-410-396-41 FERRITE BEAD INDUCTOR 0.45UH 1-412-390-21 INDUCTOR CHIP OUH 1-412-390-21 INDUCTOR CHIP OUH 1-412-390-21 INDUCTOR CHIP OUH

FILTER

FL 1 1·236-058-21 ENCAPSULATED COMPONENT FL2 1-236-058-21 ENCAPSULATED COMPONENT FL4 1·236-058-21 ENCAPSULATED COMPONENT FL5 1·236-058-21 ENCAPSULATED COMPONENT FL6 1-236-058-21 ENCAPSULATED COMPONENT

FL7 1-236-163-11 ENCAPSULATED COMPONENT FL8 1·104-963-11 CERAMIC 0.0022MF 20% 250V FL9 1-104-963-11 CERAMIC 0.0022MF 20% 250V FL 10 1-236-163-11 ENCAPSULATED COMPONENT FL 11 1-236-163-11 ENCAPSULATED COMPONENT

FL12

IC1 IC2 IC3 IC4 IC5

IC9 IC101 IC102 IC201 IC202

1-236-163-11 ENCAPSULATED COMPONENT

IC

8-759-996-43 IC RC4558PS 8-759-996-43 IC RC4558PS 8-759-231-58 IC TA7812S 8-759-701-59 IC NJM78M09FA 8-759-080-95 IC M62353FP

8-759-996-43 IC RC4558PS 8-752·059-94 IC CXA 1709P 8-749-924-03 IC CR2428 8-752-059-94 IC CXA 1709P 8-749-924-03 IC CR2428

IC301 8-752-059-94IC CXA1709P IC302 8-749-924-03 IC CR2428

JACK

J101 '1-568-547-11 JACK, MINIATUER PIN J201 '1-568-547-11 JACK, MINIATUER PIN J301 '1-568-547·11 JACK, MINIATUER PIN

01 02 05 Q7 09

0100 0101 0102 0103 0104

0105 0200 0201 0202 0203

-62 -

IC LINK

TRANSISTOR

8-729-020-07 TRANSISTOR 2SC4686A (LBSONY) 8-729-104-27 TRANSISTOR 2SC2780-NK 8-729-104-27 TRANSISTOR 2SC2780-NK 8-729-020-07 TRANSISTOR 2SC4686A (LBSONY) 8-729-809-29 TRANSISTOR 2SC4159-E

8-729-129-54 TRANSISTOR 2SC2954 8-729-129-54 TRANSISTOR 2SC2954 8-729-129-54 TRANSISTOR 2SC2954 8-729-107-31 TRANSISTOR 2SC3545-T43 8-729-129-54 TRANSISTOR 2SC2954

8-729-112-65 TRANSISTOR 2SA 1462-Y33 8-729-129-54 TRANSISTOR 2SC2954 8-729-129-54 TRANSISTOR 2SC2954 8-729-129-54 TRANSISTOR 2SC2954 8-729-107-31 TRANSISTOR 2SC3545-T43

GDM-20SHT

[AJ REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

0204 8-729-129-54 TRANSISTOR 2SC2954 R69 1-216-067-00 METAL GLAZE 5.6K 5% 1I10W

0205 8-729-112-65 TRANSISTOR 2SA1462-Y33 R73 1-249-419-11 CARBON 1.5K 5% 1/4W F

0300 8-729-129-54 TRAr-lSISTOR 2SC2954 R78 1-249-417-11 CARBON 1K 5% 1/4W F 0301 8-729-129-54 TRANSISTOR 2SC2954 0302 8-729-129-54 TRANSISTOR 2SC2954 R80 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W

R81 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W

0303 8-729-107-31 TRANSISTOR 2SC3545-T43 R82 1-216-057-00 METAL GLAZE 2.2K 5% 1I10W 0304 8-729-129-54 TRANSISTOR 2SC2954 R100 1-216-631-11 METAL CHIP 150 0.50%1/10W 0305 8-729-112-65 TRANSISTOR 2SA1462-Y33 R101 1-216-631-11 METAL CHIP 150 0.50%1/10W 0400 8-729-105-08 TRANS ISTOR 2SA 1330-06 0500 8-729-105-08 TRANSISTOR 2SA 1330-06 R102 1-216-047-00 METAL GLAZE 820 5% 1/10W

R103 1-216-663-11 METAL CHIP 3.3K 0.50%1/10W 0600 8-729-105-08 TRANSISTOR 2SA 1330-06 R104 1-208-810-11 METAL CHIP 15K 0.50%1/10W

R105 1-216-021-00 METAL GLAZE 68 5% 111 OW R106 1-216-021-00 METAL GLAZE 68 5% 111 OW

RESISTOR R107 1-216-021-00 METAL GLAZE 68 5% 1/10W

R1 1-216-049-91 METAL GLAZE 1K 5% 1I10W R108 1-216-033-00 METAL GLAZE 220 5% 1/10W R4 1-216-097-91 METAL GLAZE WOK 5% 1/10W R109 1-216-033-00 METAL GLAZE 220 5% 1/10W R5 1-216-097-91 METAL GLAZE WOK 5% 1/10W R110 1-216-025-91 METAL GLAZE 100 5% 111 OW

R6 1-216-097-91 METAL GLAZE 100K 5% 111 OW R111 1-216-025-91 METAL GLAZE 100 5% 1/10W R8 1-214-921-00 CARBON 220K 5% 1/2W

R112 1-216-081-00 METAL GLAZE 22K 5% 1/10W R9 1-208-610-11 METAL OXIDE 2M 5% 1W R113 1-216-041-00 METAL GLAZE 470 5% 1/10W R11 1-202-842-11 SOLID 220K 20% 1/2W R114 1-216-001-00 METAL GLAZE 10 5% 1/10W R14 1-208-610-11 METAL OXIDE 2M 5% 1W R115 1-216-001-00 METAL GLAZE 10 5% 1/10W R19 1-208-612-11 METAL OXIDE 10M 5% 1W R116 1-216-033-00 METAL GLAZE 220 5% 1/10W R23 1-216-113-00 METAL GLAZE 470K 5% 1/10W

R117 1-216-017-00 METAL GLAZE 47 5% 111 OW R24 1-216-091-00 METAL GLAZE 56K 5% 111 OW R118 1-216-041-00 METAL GLAZE 470 5% 111 OW

R25 1-216-073-00 METAL GLAZE 10K 5% 1/10W R119 1-208-810-11 METAL CHIP 15K 0.50%1/10W R26 1-216-073-00 METAL GLAZE 10K 5% 1/10W R120 1-208-810-11 METAL CHIP 15K 0.50%1/10W R31 1-208-612-11 METAL OXIDE 10M 5% 1W R121 1-208-806-11 METAL CHIP 10K 0.50%1/10W

R32 1-216-073-00 METAL GLAZE 10K 5% 111 OW R125 1-247-735-11 CARBON 47 5% 1/2W F

R33 1-216-091-00 METAL GLAZE 56K 5% 1/10W R131 1-216-041-00 METAL GLAZE 470 5% 1/10W R34 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W R132 1-216-041-00 METAL GLAZE 470 5% 1/10W

R35 1-216-073-00 METAL GLAZE 10K 5% 1/10W R151 1-216-017-00 METAL GLAZE 47 5% 111 OW R36 1-214-921-00 CARBON 220K 5% 1/2W R152 1-216-013-00 METAL GLAZE 33 5% 111 OW R37 1-215-874-11 METAL OXIDE 6.8K 5% 1W F

R200 1-216-631-11 METAL CHIP 150 0.50%1/10W R39 1-216-121-00 METAL GLAZE 1M 5% 1/10W R201 1-216-631-11 METAL CHIP 150 0.50%111 OW R40 1-216-121-00 METAL GLAZE 1M 5% 1I10W R202 1-216-047-00 METAL GLAZE 820 5% 1/10W R41 1-216-121-00 METAL GLAZE 1M 5% 111 OW R203 1-216-663-11 METAL CHIP 3.3K 0.50%1/10W R42 1-216-009-00 METAL GLAZE 22 5% 1/10W R204 1-208-810-11 METAL CHIP 15K 0.50%1/10W

R43 1-216-009-00 METAL GLAZE 22 5% 1/10W R205 1-216-021-00 METAL GLAZE 68 5% 1/10W

R44 1-216-009-00 METAL GLAZE 22 5% 1/10W R206 1-216-021-00 METAL GLAZE 68 5% 111 OW R45 1-216-097-91 METAL GLAZE WOK 5% 111 OW R207 1-216-021-00 METAL GLAZE 68 5% 1/10W R46 1-216-073-00 METAL GLAZE 10K 5% 1I10W R208 1-216-033-00 METAL GLAZE 220 5% 1/10W

R47 1-216-073-00 METAL GLAZE 10K 5% 1/1 OW R209 1-216-033-00 METAL GLAZE 220 5% 111 OW

R48 1-216-073-00 METAL GLAZE 10K 5% 1/1 OW R210 1-216-025-91 METAL GLAZE 100 5% 111 OW

R54 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W R211 1-216-025-91 METAL GLAZE 100 5% 1/10W R55 1-247-739-11 CARBON 100 5% 1/2W R212 1-216-081-00 METAL GLAZE 22K 5% 111 OW R57 1-247-739-11 CARBON 100 5% 1/2W R213 1-216-041-00 METAL GLAZE 470 5% 1/10W

R59 1-247-739-11 CARBON 100 5% 1/2W R214 1-216-001-00 METAL GLAZE 10 5% 1/10W R61 1-216-049-91 METAL GLAZE 1K 5% 1/10W

R215 1-216-001-00 METAL GLAZE 10 5% 1/10W R62 1-216-049-91 METAL GLAZE 1K 5% 1/10W R216 1-216-033-00 METAL GLAZE 220 5% 1/10W R63 1-216-049-91 METAL GLAZE 1K 5% 1/10W R217 1-216-017-00 METAL GLAZE 47 5% 1/10W R64 1-216-067-00 METAL GLAZE 5.6K 5% 1/10W R218 1-216-041-00 METAL GLAZE 470 5% 1/10W

R65 1-216-051-00 METAL GLAZE 1.2K 5% 111 OW R219 1-208-810-11 METAL CHIP 15K 0.50%1/10W R66 1-216-677-11 METAL CHIP 12K 0.50%1/10W

R220 1-208-810-11 METAL CHIP 15K 0.50%1/10W . R67 1-208-800-11 METAL CHIP 5.6K 0.50%1/10W R221 1-208-800-11 METAL CHIP 10K 0.50%1/10W

. -'-

R68 1-216-067-00 METAL GLAZE 5.6K 5% 1I10W R225 1-247-735-11 CARBON 47 5% 1/2W F

-63 -

GDM-20SHT

[8J M Les compos ants identifies per un trame •• The components identified by shading et une marque..t sont critiques pour la •• and mark ..t are critical for safety. securite. Ne les remplacer que par une Replace only with part number specified. piece portant Ie numero specifie. :,


R231 1-216-041-00 METAL GLAZE 470 5% 1/10W SPARK GAP R232 1-216-041-00 METAL GLAZE 470 5% 1/10W

SG2 1-519-422-11 GAP, SPARK R251 1-216-017-00 METAL GLAZE 47 5% 1/10W SG3 1-519-422-11 GAP. SPARK R252 1-216-013-00 METAL GLAZE 33 5% 1/10W SG4 1-519-504-11 GAP, DISCHARGE R300 1-216-631-11 METAL CHIP 150 0.50%1/10W SG5 1-519-504-11 GAP, DISCHARGE R301 1-216-631-11 METAL CHIP 150 0.50%1/10W SG6 1-519-504-11 GAP, DISCHARGE R302 1-216-047-00 METAL GLAZE 820 5% 111 OW

SG701 1-519-504-11 GAP, DISCHARGE R303 1-216-663-11 METAL CHIP 3.3K 0.50%1/10W SG801 1-519-504-11 GAP, DISCHARGE R304 1-208-810-11 METAL CHIP 15K 0.50% 111 OW SG901 1-519-504-11 GAP, DISCHARGE R305 1-216-021-00 METAL GLAZE 68 5% 1/10W R306 1-216-021-00 METAL GLAZE 68 5% 111 OW R307 1-216-021-00 METAL GLAZE 68 5% 1/10W SOCKET

R308 1-216-033-00 METAL GLAZE 220 5% 1/10W R309 1-216-033-00 METAL GLAZE 220 5% 1/10W R310 1-216-025-91 METAL GLAZE 100 5% 1/10W R311 1-216-025-91 METAL GLAZE 100 5% 1/10W R312 1-216-081-00 METAL GLAZE 22K 5% 111 OW ......... * ............................ -t' ... * ...... * .................. 'i' ............................. *** ................. * .... ** ......................... * ........................ ** ...

R313 1-216-041-00 METAL GLAZE 470 5% 1/10W CONNECTOR PANEL (M BOARD) R314 1-216-001-00 METAL GLAZE 10 5% 1/10W ............ ." ................................................... R315 1-216-001-00 METAL GLAZE 10 5% 1/10W (BOARD PART NO. 1-657-361-11) R316 1-216-033-00 METAL GLAZE 220 5% 111 OW R317 1-216-013-00 METAL GLAZE 33 5% 1/10W

CAPACITOR R318 1-216-041-00 METAL GLAZE 470 5% 1/10W R319 1-208-810-11 METAL CHIP 15K 0.50%1/10W C801 1-124-234-00 ELECT 22MF 20% 16V R320 1-208-810-11 METAL CHIP 15K 0.50%1I10W C802 1-161-051-00 CERAMIC O.OlMF 10% 50V R321 1-208-806-11 METAL CHIP 10K 0.50%111 OW C803 1-124-234-00 ELECT 22MF 20% 16V R325 1-247-735-11 CARBON 47 5% 1/2W F C804 1-161-051-00 CERAMIC O.OlMF 10% 50V

C805 1-102-123-00 CERAMIC 0.0033MF 10% 50V R331 1-216-041-00 METAL GLAZE 470 5% 111 OW R332 1-216-041-00 METAL GLAZE 470 5% 1/10W C806 1-102-973-00 CERAMIC 100PF 5% 50V R351 1-216-017-00 METAL GLAZE 47 5% 1/10W C807 1-136-169-00 FILM 0.22MF 5% 50V R352 1-216-013-00 METAL GLAZE 33 5% 111 OW C808 1-126-163-11 ELECT 4.7MF 20% 50V R401 1-216-073-00 METAL GLAZE 10K 5% 1/10W C809 1-136-169-00 FILM 0.22MF 5% 50V

C810 1-136-169-00 FILM 0.22MF 5% 50V R402 1-218-759-11 METAL CHIP 200K 0.50%1I10W R403 1-216-069-00 METAL GLAZE 6.8K 5% 1/10W C811 1-136-165-00 FILM O.lMF 5% 50V R404 1-218-758-11 METAL CHIP 180K 0.50%111 OW C813 1-163-245-11 CERAMIC CHIP 56PF 5% 50V R405 1-208-854-11 METAL CHIP 1M 0.50%1/10W C814 1-161-051-00 CERAMIC O.OlMF 10% 50V R406 1-216-089-00 METAL GLAZE 47K 5% 111 OW C815 1-136-153-00 FlLM O.OlMF 5% 50V

C821 1-124-584-00 ELECT 100MF 20% 10V R501 1-216-073-00 METAL GLAZE 10K 5% 111 OW R502 1-218-759-11 METAL CHIP 200K 0.50% 111 OW C822 1-126-163-11 ELECT 4.7MF 20% 35V R503 1-216-069-00 METAL GLAZE 6.8K 5% 111 OW C823 1-126-320-11 ELECT 10MF 20% 16V R504 1-218-758-11 METAL CHIP 180K 0.50%111 OW C824 1-163-127-00 CERAMIC CHIP 270PF 5% 50V R505 1-208-854-11 METAL CHIP 1M 0.50%1/10W C851 1-161-051-00 CERAMIC O.OlMF 10% 50V

C852 1-124-584-00 ELECT 100MF 20% 10V R506 1-216-089-00 METAL GLAZE 47K 5% 1/10W R601 1-216-073-00 METAL GLAZE 10K 5% 1/10W C853 1-126-160-11 ELECT lMF 20% 50V R602 1-218-759-11 METAL CHIP 200K 0.50%1/10W C854 1-126-160-11 ELECT lMF 20% 50V R603 1-216-069-00 METAL GLAZE 6.8K 5% 111 OW C855 1-126-160-11 ELECT lMF 20% 50V R604 1-218-758-11 METAL CHIP 180K 0.50%111 OW C856 1-126-160-11 ELECT lMF 20% 50V

R605 1-208-854-11 METAL CHIP 1M 0.50%1/10W R606 1-216-089-00 METAL GLAZE 47K 5% 1/10W CONNECTOR

CN801*1-564-518-11 PLUG, CONNECTOR 3P VARIABLE RESISTOR CN802*1-564-521-11 PLUG, CONNECTOR 6P

CN803'1-564-522-11 PLUG, CONNECTOR 7P RV2 1-223-410-11 RES, ADJ, METAL FILM 110M CN804 *1-564-525-11 PLUG, CONNECTOR lOP RV10l 1-238-090-11 RES, ADJ CERMET 10K CN807 1-564-523-11 PLUG, CONNECTOR 8P RV201 1-238-090-11 RES, ADJ CERMET 10K . . "-RV301 1-238-090-11 RES, ADJ CERMET 10K

-64-

GDM-20SHT

M REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

'. ". '"

DIODE RESISTOR

D851 8-719-800·76 DIODE lSS226 R801 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W D853 8-719-800-76 DIODE lSS226 R802 1-216-063-00 METAL GLAZE 3.9K 5% 111 OW D855 8-719-158-49 DIODE RD12SB2 R803 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W D856 8-719-158-49 DIODE RD12SB2 R804 1-216-689-11 METAL GLAZE 39K 5% 1/10W D857 8-719-159-12 DIODE RD5.1SB2-T2 R805 1-216-091-00 METAL GLAZE 56K 5% 111 OW

D858 8-719-159-12 DIODE RD5.1SB2-T2 R806 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W D859 8-719-159-12 DIODE RD5.1SB2-T2 R807 1-216-095-00 METAL GLAZE 82K 5% 111 OW D860 8-719-159-12 DIODE RD5.1SB2-T2 R808 1-216-073-00 METAL GLAZE 10K 5% 1/10W D862 8-719-800-76 DIODE lSS226 R809 1-216-085-00 METAL GLAZE 33K 5% 1/10W D863 8-719-800-76 DIODE lSS226 R810 1-216-025-91 METAL GLAZE 100 5% 111 OW

D864 8-719-404-46 DIODE MA 110 R811 1-216-025-91 METAL GLAZE 100 5% 1/10W D865 8-719-404-46 DIODE MAllO R812 1-216-025-91 METAL GLAZE 100 5% 1/10W D866 8-719-800-76 DIODE 1 SS226 R813 1-216-025-91 METAL GLAZE 100 5% 1/10W D867 8-719-800-76 DIODE 1 SS226 R814 1-216-035-00 METAL GLAZE 270 5% 1/10W 0868 8-719-800-76 DIODE lSS226 R815 1-216-121-00 METAL GLAZE 1M 5% 1/10W

D870 8-719-159-12 DIODE RD5.1SB2-T2 R816 1-216-081-00 METAL GLAZE 22K 5% 1/10W D871 8-719-404-46 DIODE MA 110 R821 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W D872 8-719-404-46 DIODE MA 110 R822 1-216-089-00 METAL GLAZE 47K 5% 1/10W

R823 1-216-089-00 METAL GLAZE 47K 5% 1/10W R824 1-216·049-91 METAL GLAZE lK 5% 1/10W

FILTER R831 1-216-025-91 METAL GLAZE 100 5% 1/10W

FL801 1-236-058-21 ENCAPSULATED COMPONENT R832 1-216-025-91 METAL GLAZE 100 5% 1/10W FL802 1-236-058-21 ENCAPSULATED COMPONENT R833 1-216-049-91 METAL GLAZE lK 5% 1/10W FL851 1-236-058-21 ENCAPSULATED COMPONENT R834 1-216-617-11 METAL CHIP 39 0.50%1/10W FL852 1-236-058-21 ENCAPSULATED COMPONENT R835 1-216-617-11 METAL CHIP 39 0.50%1/10W FL853 1-236-058-21 ENCAPSULATED COMPONENT

R836 1-216-617-11 METAL CHIP 39 0.50%1/10W R837 1-216-617-11 METAL CHIP 39 0.50%1/10W

IC R838 1-216-665-11 METAL CHIP 3.9K 0.50%1/10W R839 1-216-665-11 METAL CHIP 3.9K 0.50%1/10W

IC801 8-752-057-43 IC CXA1616S R840 1-216-025-91 METAL GLAZE 100 5% 1/10W

IC802 8-759-338·37 IC 24LC21 liP IC803 8-759-054·26 IC HD74HC123AP R841 1-216-665-11 METAL CHIP 3.9K 0.50%1/10W IC851 8-759-065-85 IC MAX232N R842 1-216-665-11 METAL CHIP 3.9K 0.50%1/10W

R843 1-216-037-00 METAL GLAZE 330 5% 1/10W R844 1-216-057-00 METAL GLAZE 2.2K 5% 1/10W

JACK R845 1-216-113-00 METAL GLAZE 470K 5% 1/10W

J801 '1-568-547-11 JACK, MINIATUER PIN R848 1-216-113-00 METAL GLAZE 470K 5% 1/10W

J802 '1-568-547-11 JACK, MINIATUER PIN R851 1-216-089-00 METAL GLAZE 47K 5% 1/10W

J803 '1-568-547-11 JACK, MINIATUER PIN R852 1-216-025-91 METAL GLAZE 100 5% 1/10W

J804 1-562-227-31 RECEPTACLE, BNC R853 1-216-025-91 METAL GLAZE 100 5% 1/10W J805 1-562-227-31 RECEPTACLE, BNC R856 1-216-049-91 METAL GLAZE lK 5% 1/10W

J806 1-562-227-31 RECEPTACLE, BNC R857 1-216-033-00 METAL GLAZE 220 5% 1/10W

J807 1-562-227·31 RECEPTACLE, BNC R858 1-216-017-00 METAL GLAZE 47 5% 1/10W J808 1-562-227-31 RECEPTACLE, BNC R859 1-216-017-00 METAL GLAZE 47 5% 1/10W J809 1-750-628-11 SOCKET, DIN 8P R860 1-216-659-11 METAL CHIP 2.2K 0.50%111 OW J810 1-750-002-11 CONNECTOR, D SUB 15P R861 1-216-089-00 METAL GLAZE 47K 5% 1/10W

R862 1-216-089-00 METAL GLAZE 47K 5% 1/10W TRANSISTOR R872 1-216-097-91 METAL GLAZE lOOK 5% 111 OW

0801 8-729-119-76 TRANSISTOR 2SAl175-HFE 0802 8-729-119-78 TRANSISTOR 2SC2785-HFE SWITCH 0821 8-729-119-78 TRANSISTOR 2SC2785-HFE 0822 8-729-119-78 TRANSISTOR 2SC2785-HFE S801 1-692-623-11 SWITCH, T ACTIL

S802 1-570-845-11 SWITCH, SLIDE S803 1-570-145-11 SWITCH, SLIDE S804 1-570-145-11 SWITCH, SLIDE . S805 1-554-949-21 SWITCH, SLIDE

. "-

-65 -

GDM-20SHT


Les composants Identifies per un trame et une marque,t sont cntlques pour la secunte. Ne les remplacer que par une puke portant Ie numero speclfle.

REMARK REF.NO. PART NO. DESCRIPTION

-66-

REMARK


Les composants Identifies per un trame et une marque ~ sont critiques pour la securlte. Ne les rem placer que par une pu~ce portant Ie numero specltte.


-67-

GDM-20SHT

REMARK

.-

GDM-20SHT


11',..,..** .......... 1r11' ............. ,.. •• 11'11'11' ....... 11' ... * ... 11'*11'11''11'11'11'11'.11'11'**11'11'1r ..... *11''11'**** ... *** .... ***** ...... **** ......

DEFLECTION MCB ASSY (0 BOARD) ** .......... * .......... ******** ........... ******

(BOARD PART NO. 1-657-360-11) (INCLUDING DA, DB BOARD)

4-040-988-01 SPRING (B), TR RETAINER 4-040-989-01 SPRING (A), TR RETAINER 4-040-994-01 SPRING (BB), TR RETAINER 4-041-004-01 SPRING (C), TR RETAINER

*4-381-908-01 INSULATOR (B)

7-685-646-79 SCREW (3X8), TAPPING, (+-) (BV) 4-382-854-01 SCREW (M3X8), P, SW (+)

CAPACITOR

C001 1-128-526-11 ELECT 100MF 20% 25V C002 1-128-526-11 ELECT 100MF 20% 16V C003 1-128-526-11 ELECT 100MF 20% 25V C004 1-107-908-11 ELECT 33MF 20% 50V C005 1-107-908-11 ELECT 33MF 20% 50V

C006 1-128-526-11 ELECT 100MF 20% 16V C007 1-128-528-11 ELECT 470MF 20% 25V C008 1-162-318-11 CERAMIC 0.001MF 10% 500V C009 1-128-526-11 ELECT 100MF 20% 25V C010 1-128-526-11 ELECT 100MF 20% 25V

con 1-1 06-365-00 MYLAR 0.0082MF 10% 100V C012 1-107-929-11 ELECT 10MF 20% 50V C013 1-137-366-11 FILM 0.0022MF 5% 50V C014 1-136-173-00 FILM 0.47MF 5% 50V C015 1-106-361-00 MYLAR 0.0056MF 10% 100V

C016 1-136-165-00 FILM 0.1MF 5% 50V C017 1-136-165-00 FILM 0.1MF 5% 50V C018 1-106-357-00 MYLAR 0.0039MF 10% 100V C019 1-136-155-00 FILM 0.015MF 5% 50V

TRANSFORMER C020 1-136-156-00 FILM 0.018MF 5% 50V . . '-

C021 1-126-105-11 ELECT 1000MF 20% 25V

-68-

The components identified by shading and mark & are critical for safety. Replace only with part number specified.


C022 1-137 -423-11 MYLAR C023 1-136-153-00 FILM C024 1-110-641-51 ELECT C025 1-136-165-00 FILM

C026 1-106-359-00 MYLAR C027 1-106-391-12 MYLAR C028 1-128-528-11 ELECT C029 1-128-528-11 ELECT C030 1-102-973-00 CERAMIC

C031 1-102-973-00 CERAMIC C032 1-128-226-11 ELECT C033 1-136-153-00 FILM C034 1-126-326-51 ELECT C035 1-106-351-00 MYLAR

C036 1-107-444-11 CERAMIC C037 1-113-508-11 FILM C038 1-106-367-00 MYLAR C039 1-107-444-11 CERAMIC C040 1-104-711-11 ELECT

C041 1-136-165-00 FILM C042 1-136-165-00 FILM C043 1-104-966-11 ELECT C044 1-106-351-00 MYLAR C045 1-136-165-00 FILM

C046 1-136-177-00 FILM C047 1-106-391-12 MYLAR C048 1-126-105-11 ELECT C049 1-126-105-11 ELECT C050 1-136-165-00 FILM

C051 1-104-664-11 ELECT C052 1-106-371-00 MYLAR C053 1-128-526-11 ELECT C055 1-136-165-00 FILM C056 1-110-641-51 ELECT

C057 1-102-525-11 CERAMIC C058 1-126-157-11 ELECT C059 1-106-391-12 MYLAR

GDM-20SHT

les composants identifies per un trame et une marque & sont critiques pour la securite. Ne les remplacer que par une piece portant Ie numero specifie.

REMARK REF.NO. PART NO. DESCRIPTION REMARK

0.15MF 10% 100V C079 1-107-909-11 ELECT 47MF 20% 50V O.Q1MF 5% 50V C080 1-136-121-00 FILM 0.27MF 5% 400V 33MF 20% 200V' C081 1-136-103-00 FILM 0.1MF 5% 200V 0.1MF 5% 50V

C082 1-130-481-00 FILM 0.0068MF 5% 50V 0.0047MF 10% 100V C083 1-136-159-00 FILM 0.033MF 5% 50V 0.1MF 10% 200V C084 1-136-165-00 FILM 0.1MF 5% 50V 470MF 20% 25V C085 1-113-603-91 CAP, ELECT 10MF 470MF 20% 25V C086 1-137-433-11 FILM 0.0012MF 5% 50V 100PF 5% 50V

C087 1-106-391-12 MYLAR 0.1MF 10% 200V 100PF 5% 50V C088 1-136-157-00 FILM 0.022MF 5% 50V 220MF 20% 50V C089 1-102-820-00 CERAMIC 330PF 5% 50V 0.01MF 5% 50V C090 1-104-718-91 CERAMIC 33PF 5% 2KV 10MF 20% 200V C091 1-104-718-91 CERAMIC 33PF 5% 2KV 0.0022MF 99% 200V

C092 1-126-163-11 ELECT 4.7MF 20% 50V 100PF 5% 2KV C094 1-137-380-11 FILM 0.47MF 5% 50V O.OO43MF 3% 2KV C096 1-107-849-11 FILM 1.5MF 5% 400V 0.01MF 10% 200V C097 1-126-163-11 ELECT 4.7MF 20% 50V 100PF 5% 2KV C098 1-107-929-11 ELECT 10MF 20% 50V 4.7MF 0 200V

C099 1-162-116-00 CERAMIC 680PF 10% 2KV 0.1MF 5% 50V 0.1MF 5% 50V 10MF 0 200V 0.0022MF 99% 200V CONNECTOR 0.1MF 5% 50V

CN01 *1-750-627-11 CONNECTOR, BOARD TO BOARD 1MF 5% 50V CN02 * 1-750-627-11 CONNECTOR, BOARD TO BOARD 0.1MF 10% 200V CN03 *1-691-616-11 CONNECTOR, BOARD TO BOARD 15P 1000MF 20% 25V CN401*1-564-506-11 PLUG, CONNECTOR 3P 1000MF 20% 25V CN402*1-564-508-11 PLUG, CONNECTOR 5P 0.1MF 5% 50V

CN403*1-564-515-11 PLUG, CONNECTOR 12P 47MF 20% 25V CN404*1-750-916-11 PIN, CONNECTOR (DY) (PC BOARD)8P 0.015MF 99% 200V CN405*1-564-522-11 PLUG, CONNECTOR 7P 100MF 20% 16V CN406 1-508-784-00 PIN, CONNECTOR (5MM PITCH) 1P 0.1MF 5% 50V CN407*1-573-986-11 PIN, CONNECTOR (PC BOARD) 5P 33MF 20% 200V

CN408*1-564-514-11 PLUG, CONNECTOR 11 P 68PF 5% 50V CN409*1-564-511-11 PLUG, CONNECTOR 8P 10MF 20% 16V CN410*1-564-509-11 PLUG, CONNECTOR 6P 0.1MF 10% 200V CN411 *1-564-510-11 PLUG, CONNECTOR 7P

C060 1-113-603-91 CAP, ELECT 10MF C061 1-137-366-11 FILM 0.0022MF 5% 50V

MODULE C062 1-136-165-00 FILM 0.1MF 5% 50V C063 1-130-472-00 MYLAR 0.0012MF 5% 50V :¢jM:1EJJHb;;tm%l$PBtttt!tttoa:~jj~Ml¥n~vpM~MWf: C064 1-109-842-11 CERAMIC 10PF 5% 2KV C065 1-109-842-11 CERAMIC 10PF 5% 2KV C066 1-162-114-00 CERAMIC 0.0047MF 2KV RES ASSY

C067 1-136-539-11 FILM 0.0022MF 3% 2KV 'QBj!$.M~ij~~al:Ai$&'$$¥:t~fml~TAGt!I:WilE'mij}}: C068 1-107-902-11 ELECT 1MF 20% 50V C069 1-162-134-11 CERAMIC 470PF 10% 2KV C070 1-107-803-11 FILM 0.18MF 5% 400V DIODE C071 1-136-105-00 FILM 0.33MF 5% 200V

01 8-719-110-13 DIODE RD9.1 ESB2 C072 1-1 06-351-00 MYLAR 0.0022MF 99% 200V 02 8-719-048-73 DIODE ERC90M-03 C073 1-107-847-11 FILM 0.36MF 5% 400V 03 8-719-048-73 DIODE ERC90M-03 C074 1-109-961-11 FILM 0.75MF 5% 400V 04 8-719-053-57 DIODE 5VUZ52 C075 1-107-846-11 FILM 0.1MF 5% 400V 06 8-719-911-19 DIODE 1SS119-25 C076 1-107-909-11 ELECT 47MF 20% 50V

07 8-719-979-85 DIODE EGP20G-PKG23 C077 1-107 -929-11 ELECT 10MF 20% 100V 08 8-719-979-85 DIODE EGP20G-PKG23

. . -'-C078 1-136-060-00 FILM 0.047MF 5% 400V 09 8-719-912-20 DIODE 1SS120

-69 -

GDM-20SHT


010 8-719-975-77 DIODE SB340 011 8-719-911-19 DIODE 1SS119-25

D14 8-719-979-58 DIODE EGP10D 015 8-719-048-73 DIODE ERC90M-03 016 8-719-048-73 DIODE ERC90M-03 017 8-719-110-13 DIODE RD9.1ESB2 018 8-719-911-19 DIODE 1SS119-25

019 8-719-908-03 DIODE GP08D 020 8-719-911-19 DIODE 1SS119-25 021 8-719-911-19 DIODE 1SS119-25 D22 8-719-911-19 DIODE 1SS119-25 023 8-719-018-82 DIODE RGP02-20EL-6394

024 8-719-911-19 DIODE 1SS119-25 025 8-719-911-19 DIODE 1SS119-25 026 8-719-908-03 DIODE GP08D 027 8-719-911-19 DIODE 1SS119-25 028 8-719-979-84 DIODE EGP20DPKG23

029 8-719-911-19 DIODE 1SS119-25 030 8-719-911-19 DIODE 1SS119-25 D31 8-719-911-19 DIODE 1SS119-25 032 8-719-911-19 DIODE 1SS119-25 033 8-719-110-49 DIODE RD18ESB2

D34 8-719-110-49 DIODE RD18ESB2 035 8-719-911-19 DIODE 1SS119-25 D36 8-719-911-19 DIODE 1SS119-25 037 8-719-911-19 DIODE 1SS119-25 D38 8-719-110-49 DIODE RD18ESB2

039 8-719-110-31 DIODE RD12ESB2 040 8-719-951-30 DIODE ERA91-02 041 8-719-911-19 DIODE 1SS119-25 042 8-719-110-41 DIODE RD15ESB2 043 8-719-911-19 DIODE 1SS119-25

044 8-719-911-19 DIODE 1SS119-25 D45 8-719-911-19 DIODE 1SS119-25 046 8-719-901-83 DIODE 1SS83 D47 8-719-911-19 DIODE 1SS119-25 048 8-719-911-19 DIODE 1SS119-25

049 8-719-911-19 DIODE 1SS119-25 050 8-719-911-19 DIODE 1SS119-25 051 8-719-018-82 DIODE RGP02-20EL-6394 052 8-719-018-82 DIODE RGP02-20EL-6394 053 8-719-911-19 DIODE 1SS119-25

054 8-719-018-82 DIODE RGP02-20EL-6394 055 8-719-911-19 DIODE 1SS119-25 056 8-719-911-19 DIODE 1SS119-25 0012 8-719-045-48 DIODE FML-G12S 0013 8-719-045-48 DIODE FML-G12S

FERRITE BEAD

Les composants identifies per un trame et une marque &. sont critiques pour la securite. Ne les rem placer que par une piece portant Ie numero specifie.

The components identified by shading 0: and mark &. are critical for safety. Replace only with part number specified. '


IC

IC1 8-759-234-65 IC TA7812S IC2 8-759-700-69 IC NJM79L 12A IC4 8-729-021-70 TRANSISTOR IRHT5305 IC5 8-759-916-25 IC SN74HC32AN IC6 8-759-980-58 IC TDA8172

IC7 8-759-145-58 IC UPC4558C IC11 8-759-503-91 IC TL082ACP

L001 L002 L003 L004 L005

COIL

1-412-537-31 INDUCTOR 1-412·537-31 INDUCTOR 1-412-537-31 INDUCTOR 1-412-534-31 INDUCTOR 1-412-537-31 INDUCTOR

100UH 100UH 100UH 56UH 100UH

L006 1-406-818-11 COIL, CHOKE 2.2MMH L007 1-406-670-11 COIL, CHOKE 680UH L008 1-412-519-11 INDUCTOR 3.3UH L009 1-412-045-11 INDUCTOR 2.2MMH L010 1-412-549-31 INDUCTOR 1MMH

L011 1-412-533-21 INDUCTOR 47UH L012 1-406-671-11 COIL, CHOKE 1.0MMH L013 1-406-661-11 COIL, CHOKE 22UH L014 1-412-529-11 INDUCTOR 22UH

REMARK

L015 1-411-477-11 COIL, HORIZONTAL LINEARITY

L016 1-411-478-11 COIL, HORIZONTAL LINEARITY L017 1-412-537-31 INDUCTOR 100UH L018 1-406-675-11 COIL, CHOKE 4.7MMH

IC LINK

TRANSISTOR

02 8-729-015-28 TRANSISTOR IRFI9630GS 03 8-729-031-87 TRANSISTOR 2SC5047-CA 04 8-729-119-78 TRANSISTOR 2SC2785-HFE 05 8-729-119-76 TRANSISTOR 2SA 1175-HFE 06 8-729-119-76 TRANSISTOR 2SA1175-HFE

Q7 8-729-119-78 TRANSISTOR 2SC2785-HFE 08 8-729-119-76 TRANSISTOR 2SA 1175-HFE 09 8-729-140-96 TRANSISTOR 2SD774-34 011 8-729-015-28 TRANSISTOR IRFI9630GS 012 8-729-141-83 TRANSISTOR 2SB1094-LK

013 8-729-020-64 TRANSISTOR IRFPG50LF 014 8-729-119-78 TRANSISTOR 2SC2785-HFE

FB1 1-410-396-41 FERRITE BEAD INDUCTOR 0.45UH 015 8-729-266-83 TRANSISTOR 2SC2668-Y FB2 1-410-396-41 FERRITE BEAD INDUCTOR 0.45UH 016 8-729-020-07 TRANSISTOR 2SC4686A (LBSONY) FB3 1-410-396-41 FERRITE BEAD INDUCTOR 0.45UH 017 8-729-140-96 TRANSISTOR 2SD774-34 FB4 1-410-396-41 FERRITE BEAD INDUCTOR 0.45UH

018 8-729-015-28 TRANSISTOR IRFI9630GS 019 8-729-031-97 TRANSISTOR IRFI624G 020 8-729-119-76 TRANSISTOR 2SA 1175-HFE

-70 -

GDM-20SHT

[Q] REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

021 8·729·119-78 TRANSISTOR 2SC2785-HFE R046 1-249-437-11 CARBON 47K 5% 1/4W

022 8-729-266-83 TRANSISTOR 2SC2668-Y R047 1-215-457-00 METAL 33K 1% 1/4W R048 1-249-470-11 CARBON 0.47 5% 1/2W F

023 8-729·820-73 TRANSISTOR 2SC3746 R049 1-260-288-11 CARBON 0.47 5% 1/2W

024 8-729-209-15 TRANSISTOR 2SD2012 R050 1-249-417-11 CARBON lK 5% 1I4W F

025 8-729-119-78 TRANSISTOR 2SC2785-HFE 026 8-729-020-07 TRANSISTOR 2SC4686A (LBSONY) R051 1-249-433-11 CARBON 22K 5% 1/4W

028 8-729-119-78 TRANSISTOR 2SC2785-HFE R052 1-249-437-11 CARBON 47K 5% 1/4W R053 1-249-417-11 CARBON lK 5% 1/4W

0027 8-729-119-78 TRANSISTOR 2SC2785-HFE R054 1-215-437-00 METAL 4.7K 1% 1/4W R055 1-249-421-11 CARBON 2.2K 5% 1/4W

RESISTOR R056 1-249-425-11 CARBON 4.7K 5% 1I4W R057 1-247·807-31 CARBON 100 5% 1/4W

ROOl 1-260-312-11 CARBON 47 5% 1/2W R058 1-249-434-11 CARBON 27K 5% 1/4W

R002 1-215-465-00 METAL 68K 1% 1/4W R059 1-249-421-11 CARBON 2.2K 5% 1/4W

R003 1-247-807-31 CARBON 100 5% 1/4W R060 1-215-861-00 METAL OXIDE 47 5% lW F

R004 1-215-464-00 METAL 62K 1% 1/4W R005 1-215-441-00 METAL 6.8K 1% 1/4W R064 1 ·21 5-455-00 METAL 27K 1% 1/4W

R065 1-249-433-11 CARBON 22K 5% 1/4W

R006 1-215-437-00 METAL 4.7K 1% 1/4W R066 1-215-439-00 METAL 5.6K 1% 1/4W

R007 1-249-425-11 CARBON 4.7K 5% 1/4W R067 1-249-421-11 CARBON 2.2K 5% 1/4W

R008 1-249-425-11 CARBON 4.7K 5% 1/4W R068 1·249-425-11 CARBON 4.7K 5% 1I4W

R009 1-260-294-11 CARBON 1.5 5% 1/2W R010 1-249-420-11 CARBON 1.8K 5% 1/4W F R070 1-249-429-11 CARBON 10K 5% 1/4W

R071 1-249-429-11 CARBON 10K 5% 1/4W

R011 1-249-401-11 CARBON 47 5% 1/4W R072 1-247-899-11 CARBON 680K 5% 1/4W

R012 1-215-469-00 METAL 100K 1% 1/4W R073 1-249-417-11 CARBON 1K 5% 1/4W

R013 1-249-428-11 CARBON 8.2K 5% 1/4W R074 1-249-417-11 CARBON 1K 5% 1/4W

R014 1-249-421-11 CARBON 2.2K 5% 1/4W R015 1-249-417-11 CARBON lK 5% 1/4W R075 1-249-431-11 CARBON 15K 5% 1/4W

R076 1-249-433-11 CARBON 22K 5% 1/4W

R016 1-249-402-11 CARBON 56 5% 1/4W R077 1-202-830-00 SOLI D 10K 20% 1/2W

R017 1-215-430-00 METAL 2.4K 1% 1/4W R078 1-216-386-11 METAL OXIDE 0.56 5% 3W F

R018 1-247-903-00 CARBON 1M 5% 1/4W R079 1-215-449-00 METAL 15K 1% 1/4W

R019 1-214-800-11 METAL 2.2 1% 1/2W R020 1-214-800-11 METAL 2.2 1% 1/2W R080 1-208-611-11 METAL OXIDE 3.9M 5% lW

R081 1-247-895-00 CARBON 470K 5% 1/4W

R021 1-215-892-11 METAL OXIDE 1K 5% 2W F R082 1-249-433-11 CARBON 22K 5% 1/4W

R022 1-249-397-11 CARBON 22 5% 1/4W F R083 1-215-461-00 METAL 47K 1% 1/4W

R023 1-249-402-11 CARBON 56 5% 1/4W R084 1-249-431-11 CARBON 15K 5% 1/4W

R024 1-249-417-11 CARBON lK 5% 1I4W R025 1-216-425-11 METAL OXIDE 56 5% lW F R085 1-249-433-11 CARBON 22K 5% 1/4W

R086 1-249-397-11 CARBON 22 5% 1/4W F

R026 1-247-807-31 CARBON 100 5% 1/4W R087 1-249-414-11 CARBON 560 5% 1/4W

R027 1-247-807-31 CARBON 100 5% 1/4W R088 1-247-903-00 CARBON 1M 5% 1/4W

R028 1-249-419-11 CARBON 1.5K 5% 1/4W R089 1-249-887 -11 CARBON 33 5% 1/4W F

R029 1-216-398-11 METAL OXIDE 5.6 5% 3W F R030 1-216-398-11 METAL OXIDE 5.6 5% 3W F R090 1-215-860-11 METAL OXIDE 33 5% lW F

R091 1-249-423-11 CARBON 3.3K 5% 1I4W

R031 1-216-398-11 METAL OXIDE 5.6 5% 3W F R092 1-249-437 -11 CARBON 47K 5% 1/4W

R032 1-260-295-11 CARBON 1.8 5% 1/2W R093 1-208-609-11 METAL OXIDE 1.5M 5% lW

R033 1-249-433-11 CARBON 22K 5% 1I4W R094 1-208-609-11 METAL OXIDE 1.5M 5% lW

R034 1-249-417-11 CARBON lK 5% 1/4W R035 1-260-295-11 CARBON 1.8 5% 1/2W R095 1-215-437-00 METAL 4.7K 1% 1/4W

R096 1-215-912-11 METAL OXIDE 150 5% 3W F

R036 1-215-465-00 METAL 68K 1% 1/4W R097 1-249-425-11 CARBON 4.7K 5% 1/4W

R037 1-249-429-11 CARBON 10K 5% 1/4W R098 1-249-413-11 CARBON 470 5% 1I4W F

R038 1-216-447-00 METAL OXIDE 27 5% 2W F R099 1-215-922-11 METAL OXIDE 6.8K 5% 3W F

R039 1-249-429-11 CARBON 10K 5% 1/4W R040 1-247-883-00 CARBON 150K 5% 1/4W Rl00 1-215-914-11 METAL OXIDE 330 5% 3W F

R101 1-249-405-11 CARBON 100 5% 1I4W F

R041 1-249-421-11 CARBON 2.2K 5% 1/4W R102 1-215-922-11 METAL OXIDE 6.8K 5% 3W F

R042 1-249-433-11 CARBON 22K 5% 1/4W R104 1-249-423-11 CARBON 3.3K 5% 1/4W

R043 1-247-815-91 CARBON 220 5% 1/4W R105 1-249-423-11 CARBON 3.3K 5% 1I4W

R044 1-247-815-91 CARBON 220 5% 1/4W '-

R045 1-249-441-11 CARBON 100K 5% 1/4W Rl06 1-247-903-00 CARBON 1M 5% 1/4W

-71 -

GDM-20SHT

Les composants identifies per un trame et une marque Lt sont critiques pour la securite. Ne les remplacer que par une piece portant Ie numero spEkifie.

The components identified by shading and mark Lt are critical for safety. Replace only with part number specified.


Rl07 1·216-449-11 METAL OXIDE 56 Rl08 1-215-914-11 METAL OXIDE 330 Rll0 1-249-406-11 CARBON 120 RIll 1-249-429-11 CARBON 10K

R112 1-249-383-11 CARBON

R125 1-249-437-11 CARBON 47K R126 1·249-437 -11 CARBON 47K R127 1-249-384-11 CARBON 1.8 R128 1-249-384-11 CARBON 1.8 R129 1-218-748-11 METAL CHIP 220K

R130 1-249-417-11 CARBON lK R138 1-215-863-11 METAL OXIDE 100 R139 1-249-417-11 CARBON lK R141 1-215-473·00 METAL 150K R142 1-215-473-00 METAL 150K

R149 1-202-830-00 SOLID 10K RISO 1-249-403-11 CARBON 68 R151 1-249-437-11 CARBON 47K R152 1-249-433-11 CARBON 22K R153 1-249-385-11 CARBON 2.2

RELAY

RYOOI 1-515-669-21 RELAY

SPARK GAP

SGI 1-519-422-11 GAP, SPARK SG2 I-S19-422-11 GAP, SPARK SG3 1-519-422-11 GAP, SPARK

TRANSFORMER

REMARK

5% 2W 5% 3W 5% 1t4W 5% 1/4W

1/4W

5% 1/4W 5% 1/4W

5% 1/4W

5% 1/4W 0.50%1/16W

5% 1/4W

5% lW 5% 1/4W 1% 1/4W 1% 1/4W

20% 1I2W 5% 1/4W

5% 1/4W

5% 1/4W 5% 1/4W

Tl 1-423-769-11 TRANSFORMER, HORIZONTAL DRIVE T2 1-429-146-11 TRANSFORMER, FERRITE (HOT) T4

F F

F

F F

F

1-429-147-11 TRANSFORMER, FERRITE (LOT) {[& mWJ.&~aM~?g~EMgRA$$:Y.(ImY!M¢@·:::

T7 1-424-555-11 TRANSFORMER, FERRITE (OFT)

T8 1-423-405-12 TRANSFORMER, FERRITE (FRT)

CRISTAL

Xl01 1-760-040-11 VIBRATOR, CRYSTAL

REF.NO. PART NO. DESCRIPTION REMARK

DA BOARD, COMPLETE

(BOARD PART NO. 1-657-358-12)

CAPACITOR

Cl0l 1-162-927-11 CERAMIC CHIP 100PF 5% 50V Cl02 1-104-563-11 FILM CHIP O.IMF 5% 16V Cl03 1-104-551-11 FILM CHIP O.OIMF 5% 16V Cl04 1-126-396-11 ELECT CHIP 47MF 20% 16V Cl05 1-107-439-11 CERAMIC CHIP O.OOIMF 10% 50V

Cl06 1-126-401-11 ELECT CHIP lMF 20% 50V Cl07 1-104-559-11 FILM CHIP 0.047MF S% 16V Cl08 1-126-401-11 ELECT CHIP lMF 20% SOV Cl09 1-126-394-11 ELECT CHIP 10MF 20% 16V ClIO 1-126-396-11 ELECT CHIP 47MF 20% 16V

Clll 1-126-39S-11 ELECT CHIP 22MF 20% 16V C112 1-162-921-11 CERAMIC CHIP 33PF 5% SOV C113 1-107-439-11 CERAMIC CHIP O.OOIMF 10% SOV C114 1-162-913-11 CERAMIC CHIP 8PF 0.5PF SOV C115 1-162-913-11 CERAMIC CHIP 8PF O.SPF 50V

C116 1-135-091-91 TANTAL. CHIP lMF 20% 16V CI17 1-164-004-11 CERAMIC CHIP O.IMF 10% 25V C118 1-135-091-91 TANTAL. CHIP lMF 20% 16V C119 1-104-563-11 FILM CHIP O.IMF 5% 16V C120 1-126-399-11 ELECT CHIP 10MF 20% 35V

C121 1-126-399-11 ELECT CHIP 10MF 20% 35V C122 1-164-004-11 CERAMIC CHIP O.IMF 10% 25V C123 1-107-439-11 CERAMIC CHIP 0.001 MF 10% SOV C124 1-104-563-11 FILM CHIP O.IMF 5% 16V C12S 1-107-443-11 CERAMIC CHIP O.OIMF 10% SOV

C126 1-126-401-11 ELECT CHIP lMF 20% SOV C127 1-164-004-11 CERAMIC CHIP 0.1 MF 10% 25V C128 1-104-562-11 FILM CHIP 0.082MF 5% 16V C129 1-164-004-11 CERAMIC CHIP O.IMF 10% 2SV C130 1-162-928-11 CERAMIC CHIP 120PF 5% SOV

C131 1-164-315-11 CERAMIC CHIP 470PF S% SOV C132 1-104-S52-11 FILM CHIP 0.012MF 5% 16V C133 1-164-004-11 CERAMIC CHIP O.IMF 10% 25V C134 1-107-443-11 CERAMIC CHIP O.OIMF 10% 50V C13S 1-162-927-11 CERAMIC CHIP 100PF 5% SOV

C136 1-104-540-11 FILM CHIP 0.0012MF S% SOV C137 1-164-315-11 CERAMIC CHIP 470PF S% SOV C138 1-126-401-11 ELECT CHIP lMF 20% SOV C139 1-126-398-11 ELECT CHIP 4.7MF 20% 35V C140 1-164-232-11 CERAMIC CHIP O.OIMF 10% SOV

C141 1-104-54S-11 FILM CHIP 0.0033MF S% 16V C142 1-126-401-11 ELECT CHIP lMF 20% SOV C143 1-104-539-11 FILM CHIP O.OOIMF 5% SOV CI44 1-126-396-11 ELECT CH IP 47MF 20% 16V C14S 1-109-855-11 FILM CHIP O.OOIMF 2% SOV

C146 1-107-443-11 CERAMIC CHIP O.OIMF 10% SOV C147 1-164-217-11 CERAMIC CHIP 150PF 5% SOV C149 1-126-402-11 ELECT CHIP 2.2MF 20% SOV C150 1-126-402-11 ELECT CH IP 2.2MF 20% 50V

-72 -

_c,-,,--

GDM-20SHT

IDAI REF.NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK

C152 1-164·004-11 CERAMIC CHIP 0.1 MF 10% 25V D123 8-719-404-46 DIODE MA 110 D124 8-719-033-52 DIODE RD5.1SB1-T1

C153 1-107-443-11 CERA'MIC CHIP 0.01MF 10% 50V C154 1-164-315-11 CERAMIC CHIP 470PF 5% 50V C155 1-107-443-11 CERAMIC CHIP 0.01MF 10% 50V IC C156 1-126·396·11 ELECT CHIP 47MF 20% 16V C157 1-107-443-11 CERAMIC CHIP 0.01MF 10% 50V IC101 8-752·065-79 IC CXA1470AM-T6

IC102 8-759-158-86 IC CXA8021 M-T6 C158 1-126-401-11 ELECT CHIP 1MF 20% 50V IC103 8-759-041-45 IC DAC8840FS C160 1-126-396-11 ELECT CHIP 47MF 20% 16V IC104 8-759-158-86 IC CXA8021M-T6 C161 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V IC105 8-752-066-34 IC CXA 1726M-T6 C162 1-104·563-11 FILM CHIP 0.1MF 5% 16V C163 1-104-563-11 FILM CHIP 0.1MF 5% 16V IC106 8-759-996-43 IC RC4558PS

IC107 8-759-996-43 IC RC4558PS C164 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V IC108 8-759-156-54IC X25040S1 C166 1-107-443·11 CERAMIC CHIP 0.01MF 10% 50V IC109 8-759-156-54 IC X25040S1 C167 1-126-395-11 ELECT CHIP 22MF 20% 16V IC110 8-759-926-05 IC SN74HC125ANS C168 1-126-396-11 ELECT CHIP 47MF 20% 16V C169 1-126-395-11 ELECT CHIP 22MF 20% 16V IC111 8-759-351-05 IC HD6473256F10

IC112 8-759-996-43 IC RC4558PS C170 1-126-395-11 ELECT CHIP 22MF 20% 16V IC113 8-759-162-80 IC MM1170BFB C171 1-126-395-11 ELECT CHIP 22MF 20% 16V IC114 8-759-239-55 IC TC74HC123AF C172 1-162·928-11 CERAMIC CHIP 120PF 5% 50V IC115 8-759-158-84 IC CXA 1543M-T6 C173 1-107-439-11 CERAMIC CHIP 0.001MF 10% 50V C174 1-107-439-11 CERAMIC CHIP 0.001 MF 10% 50V IC116 8-759-158-82 IC CXA 1544M-T6

IC117 8-759-009-82 IC MC14011 BF-T2 C175 1-107-439-11 CERAMIC CHIP 0.001MF 10% 50V IC118 8-759-278-58 IC NJM4558V-TE2 C176 1-164-218-11 CERAMIC CHIP 180PF 5% 50V IC119 8-759-239-23 IC TC74HC86AF C177 1-162-928-11 CERAMIC CHIP 120PF 5% 50V IC120 8-759-925-90 IC SN74HC74ANS C178 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C180 1-126-395-11 ELECT CHIP 22MF 20% 16V IC121 8-759-239-55 IC TC74HC123AF

IC122 8-759-996-43 IC RC4558PS C181 1-107-443-11 CERAMIC CHIP 0.01MF 10% 50V IC130 8-759-062-66 IC TC7S66F C182 1-104-557-11 FILM CHIP 0.033MF 5% 16V IC131 8-759-031-84 IC SC7S04F C183 1-126-401-11 ELECT CHIP 1MF 20% 50V C184 1-107-443-11 CERAMIC CHIP 0.01MF 10% 50V C185 1-107-443-11 CERAMIC CHIP 0.01MF 10% 50V TRANSISTOR

C202 1-126-394-11 ELECT CHIP 10MF 20% 16V 0101 8-729-402-42 TRANSISTOR UN5213 0102 8-729-230-63 TRANSISTOR 2SC4116-YG 0103 8-729-402-42 TRANSISTOR UN5213

CONNECTOR 0104 8-729-402-42 TRANSISTOR UN5213 0105 8-729-420-24 TRANSISTOR 2SB1218A-ORS

CN1 *1-750-626-21 CONNECTOR, BOARD TO BOARD (PLUG) CN2 * 1-750-626-21 CONNECTOR, BOARD TO BOARD (PLUG) 0106 8-729-402-42 TRANSISTOR UN5213

0107 8-729-420-24 TRANSISTOR 2SB1218A-ORS

DIODE RESISTOR

D101 8-719-977-95 DIODE DTZ-TT11-2.4B D102 8-719-404-46 DIODE MA 110 R101 1-216-830-11 METAL GLAZE 5.6K 5% 1/16W D105 8-719-404-46 DIODE MA 110 R102 1-216-834-11 METAL GLAZE 12K 5% 1/16W D106 8-719-404-46 DIODE MA 110 R103 1-216-830-11 METAL GLAZE 5.6K 5% 1/16W D108 8-719-033-52 DIODE RD5.1SB1-T1 R104 1-216-821-11 METAL GLAZE 1K 5% 1/16W

R105 1-218-702-11 METAL CHIP 2.7K 0.50%1/16W D109 8-719-404-46 DIODE MA 110 D110 8-719-158-49 DIODE RD12SB2 R106 1-218-692-11 METAL CHIP 1K 0.50%1/16W D111 8-719-404-46 DIODE MA 110 R107 1-216-827-11 METAL GLAZE 3.3K 5% 1/16W D112 8-719-404-46 DIODE MA 110 R109 1-215-914-11 METAL OXIDE 330 5% 3W F D116 8-719-404-46 DIODE MA110 R109 1-216-821-11 METAL GLAZE 1K 5% 1/16W

R110 1-218-707-11 METAL CHIP 4.3K 0.50%1/16W D118 8-719-404-46 DIODE MA110 D119 8-719-404-46 DIODE MA 110 R111 1-218-710-11 METAL CHIP 5.6K 0.50%1/16W D120 8-719-033-52 DIODE RD5.1SB1-T1 R112 1-218-720-11 METAL CHIP 15K 0.50%1/16W D121 8-719-033-52 DIODE RD5.1SB1-T1 R113 1-218-873-11 METAL CHIP 12K 0.50%1/16W .. D122 8-719-404-46 DIODE MA 110 R114 1-218-7tJ4-11 METAL CHIP 3.3K 0.50%1/16W '-

R115 1-218-716-11 METAL CHIP 10K 0.50%1/16W

-73 -

GDM-20SHT

IDAI REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

Rl16 1·218·708·11 METAL CHIP 4.7K 0.50%1/16W Rl72 1·216·832·11 METAL GLAZE 8.2K 5% 1/16W Rl17 1·218·858·11 METAL CHIP 3K 0.50%1/16W R173 1-218-710-11 METAL CHIP 5.6K 0.50%1/16W

Rl18 1-218-694-11 METAL CHIP l.2K 0.50%1116W R174 1-218-881-11 METAL CHIP 27K 0.50%1/16W Rl19 1-218-716-11 METAL CHIP 10K 0.50%1/16W R175 1-216-833-11 METAL GLAZE 10K 5% 1/16W

R120 1-218-873-11 METAL CHIP 12K 0.50%1/16W R176 1-216-837-11 METAL GLAZE 22K 5% 1/16W

R121 1-218-710-11 METAL CHIP 5.6K 0.50%1/16W Rl77 1-216-009-00 METAL GLAZE 22 5% 1/10W

R122 1-218-704-11 METAL CHIP 3.3K 0.50%1/16W R178 1-216-821-11 METAL GLAZE lK 5% 1/16W

R123 1-218-733-11 METAL CHIP 51K 0.50%1/16W R179 1-216-853-11 METAL GLAZE 470K 5% 1/16W

R124 1-218-700-11 METAL CHIP 2.2K 0.50%1/16W R180 1-216-065-00 METAL GLAZE 4.7K 5% 111 OW R125 1-216-817-11 METAL GLAZE 470 5% 1/16W

R181 1-218-732-11 METAL CHIP 47K 0.50%1I16W R126 1-216-817-11 METAL GLAZE 470 5% 1/16W R182 1-216-673-11 METAL CHIP 8.2K 0.50% 111 OW R127 1-218-738-11 METAL CHIP 82K 0.50%1/16W R183 1-216-827-11 METAL GLAZE 3.3K 5% 1/16W

R128 1-218-748-11 METAL CHIP 220K 0.50%1/16W R185 1-216-845-11 METAL GLAZE 100K 5% 1/16W R129 1-249-437-11 CARBON 47K 5% 1/4W R187 1-218-724-11 METAL CHIP 22K 0.50%1/16W R130 1-218-724-11 METAL CHIP 22K 0.50%1/16W

R189 1-216-837-11 METAL GLAZE 22K 5% 1/16W R131 1-218-889-11 METAL CHIP 56K 0.50%1/16W R190 1-216-833-11 METAL GLAZE 10K 5% 1/16W R132 1-218-716-11 METAL CHIP 10K 0.50%1/16W R195 1-218-702-11 METAL CHIP 2.7K 0.50%1I16W R133 1-218-717-11 METAL CHIP 11K 0.50%1/16W R196 1-218-881-11 METAL CHIP 27K 0.50%1I16W R134 1-218-873-11 METAL CHIP 12K 0.50%1/16W R200 1-218-851-11 METAL CHIP l.5K 0.50%1/16W

R135 1-218-724-11 METAL CHIP 22K 0.50%1I16W R201 1-218-724-11 METAL CHIP 22K 0.50%1/16W

R136 1-218-883-11 METAL CHIP 33K 0.50%1/16W R203 1-216-833-11 METAL GLAZE 10K 5% 1/16W R137 1-218-724-11 METAL CHIP 22K 0.50%1/16W R204 1-216-833-11 METAL GLAZE 10K 5% 1I16W R138 1-216-841-11 METAL GLAZE 47K 5% 1/16W R205 1-216-833-11 METAL GLAZE 10K 5% 1I16W R139 1-216-841-11 METAL GLAZE 47K 5% 1/16W R206 1-216-833-11 METAL GLAZE 10K 5% 1/16W

R140 1-216-841-11 METAL GLAZE 47K 5% 1/16W R207 1-216-833-11 METAL GLAZE 10K 5% 1I16W

R141 1-216-833-11 METAL GLAZE 10K 5% 1/16W R208 1-216-833-11 METAL GLAZE 10K 5% 1/16W R142 1-216-841-11 METAL GLAZE 47K 5% 1/16W R209 1-216-833-11 METAL GLAZE 10K 5% 1/16W R143 1-216-821-11 METAL GLAZE lK 5% 1/16W R210 1-216-821-11 METAL GLAZE lK 5% 1/16W

R144 1-216-821-11 METAL GLAZE lK 5% 1/16W R211 1-216-823-11 METAL GLAZE l.5K 5% 1/16W R145 1-216-809-11 METAL GLAZE 100 5% 1/16W

R213 1-218-700-11 METAL CHIP 2.2K 0.50%1I16W R146 1-216-821-11 METAL GLAZE lK 5% 1/16W R214 1-218-716-11 METAL CHIP 10K 0.50%1/16W R147 1-216-821-11 METAL GLAZE lK 5% 1/16W R215 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W R148 1-216-821-11 METAL GLAZE lK 5% 1/16W R216 1-216-833-11 METAL GLAZE 10K 5% 1/16W R149 1-216-833-11 METAL GLAZE 10K 5% 1/16W R217 1-216-845-11 METAL GLAZE lOOK 5% 1/16W R150 1-216-821-11 METAL GLAZE lK 5% 1/16W

R218 1-216-821-11 METAL GLAZE lK 5% 1/16W R151 1-216-821-11 METAL GLAZE lK 5% 1/16W R219 1-216-821-11 METAL GLAZE lK 5% 1/16W A152 1-216-821-11 METAL GLAZE lK 5% 1/16W R220 1-216-821-11 METAL GLAZE lK 5% 1/16W

A153 1-216-821-11 METAL GLAZE lK 5% 1/16W R221 1-216-821-11 METAL GLAZE lK 5% 1/16W R154 1-216-821-11 METAL GLAZE lK 5% 1/16W R222 1-216-821-11 METAL GLAZE lK 5% 1/16W R155 1-216-821-11 METAL GLAZE lK 5% 1/16W

R223 1-216-821-11 METAL GLAZE lK 5% 1/16W R156 1-216-827-11 METAL GLAZE 3.3K 5% 1/16W R224 1-216-821-11 METAL GLAZE lK 5% 1/16W

R157 1-216-049-91 METAL GLAZE lK 5% 111 OW R225 1-216-821-11 METAL GLAZE lK 5% 1/16W

R158 1-216-843-11 METAL GLAZE 68K 5% 1/16W R226 1-216-821-11 METAL GLAZE lK 5% 1/16W

A159 1-216-841-11 METAL GLAZE 47K 5% 1/16W R227 1-216-821-11 METAL GLAZE lK 5% 1/16W A160 1-218-738-11 METAL CHIP 82K 0.50%1I16W

R228 1-216-821-11 METAL GLAZE lK 5% 1/16W A161 1-216-837-11 METAL GLAZE 22K 5% 1/16W R229 1-216-821-11 METAL GLAZE lK 5% 1/16W

R162 1-216-833-11 METAL GLAZE 10K 5% 1/16W R230 1-216-821-11 METAL GLAZE lK 5% 1/16W R163 1-216-823-11 METAL GLAZE 1.5K 5% 1/16W R232 1-216-821-11 METAL GLAZE lK 5% 1/16W

R164 1-216-837-11 METAL GLAZE 22K 5% 1/16W R233 1-218-708-11 METAL CHIP 4.7K 0.50%1I16W

R165 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W R234 1-218-694-11 METAL CHIP 1.2K 0.50%1/16W

A166 1-216-834-11 METAL GLAZE 12K 5% 1/16W A235 1-218-716-11 METAL CHIP 10K 0.50%1/16W

R167 1-216-851-11 METAL GLAZE 330K 5% 1/16W A236 1-216-851-11 METAL GLAZE 330K 5% 1/16W

A168 1-216-833-11 METAL GLAZE 10K 5% 1/16W R237 1-216-821-11 METAL GLAZE lK 5% 1/16W

A169 1-216-835-11 METAL GLAZE 15K 5% 1/16W R238 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W

A 170 1-216-839-11 METAL GLAZE 33K 5% 1/16W R239 1-2H3-829-11 METAL GLAZE 4.7K 5% 1I16W·.

. "-

R171 1-218-724-11 METAL CHIP 22K 0.50%1I16W R240 1-216-821-11 METAL GLAZE lK 5% 1/16W

-74-

GDM-20SHT

IDAI ID81 REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK

R241 1·216-821-11 METAL GLAZE lK 5% 1/16W R311 1-216-827-11 METAL GLAZE 3.3K 5% 1/16W

R242 1-216-833-11 METAL GLAZE 10K 5% 1/16W

R243 1-216-853-11 METAL GLAZE 470K 5% 1/16W

R244 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W ......................... * ............... * ... ,.. ... ******************** ......... *** ........ ********** ... ** ...... ******** ... ** ......

R245 1-218-710-11 METAL CHIP 5.6K 0.50%1/16W R246 1-216-826-11 METAL GLAZE 2.7K 5% 1/16W DB BOARD, COMPLETE

R247 1-218-716-11 METAL CHIP 10K 0.SO%1/16W ..................... * ... * ... 1t'" ***** ** **** ..................

R248 1-218-716-11 METAL CHIP 10K 0.50%1/16W (BOARD PART NO. 1-657-359-11)

R249 1-218-716-11 METAL CHIP 10K 0.50%1/16W R250 1-218-717-11 METAL CHIP 11K 0.50%1/16W CAPACITOR R251 1-218-724-11 METAL CHIP 22K 0.50%1/16W

R252 1-218-873-11 METAL CHIP 12K 0.50%1/16W Cl0l 1-104-664-11 ELECT 47MF 20% 25V

R253 1-218-873-11 METAL CHIP 12K 0.50%1/16W Cl02 1-136-165-00 FILM O.lMF 5% SOV Cl03 1-163-125-00 CERAMIC CHIP 220PF 5% 50V

R254 1-218-873-11 METAL CHIP 12K 0.50%1/16W Cl04 1-137-368-11 FILM 0.0047MF 5% 50V R255 1-218-873-11 METAL CHIP 12K 0.50%1/16W Cl05 1-104-664-11 ELECT 47MF 20% 25V

R257 1-216-821-11 METAL GLAZE lK 5% 1/16W

R258 1-216-821-11 METAL GLAZE lK 5% 1/16W Cl06 1-137-364-11 FILM O.OOlMF 5% 50V

R259 1-216-089-00 METAL GLAZE 47K 5% 1/10W Cl07 1-136-165-00 FILM O.lMF 5% 50V Cl08 1-164-073-11 CERAMIC 100PF 10% 50V

R260 1-216-089-00 METAL GLAZE 47K 5% 111 OW Cl09 1-163-009-11 CERAMIC CHIP O.OOlMF 10% 50V R261 1-216-826-11 METAL GLAZE 2.7K 5% 1/16W Cl10 1-104-664-11 ELECT 47MF 20% 25V

R262 1-216-049-91 METAL GLAZE lK 5% 1/10W

R263 1-216-049-91 METAL GLAZE lK 5% 111 OW Cl11 1-104-664-11 ELECT 47MF 20% 25V R265 1-218-897-11 METAL CHIP 120K 0.50%1/16W C113 1-104-799-11 ELECT 22MF 20% 50V

C114 1-104-799-11 ELECT 22MF 20% 50V

R266 1-216-825-11 METAL GLAZE 2.2K 5% 1/16W C115 1-102-978-00 CERAMIC 220PF 5% 50V R267 1-216-839-11 METAL GLAZE 33K 5% 1/16W C116 1-136-165-00 FILM O.lMF 5% 50V R268 1-216-825-11 METAL GLAZE 2.2K 5% 1/16W R269 1-216-833-11 METAL GLAZE 10K 5% 1/16W Cl17 1-136-165-00 FILM O.lMF 5% 50V R270 1-216-837-11 METAL GLAZE 22K 5% 1/16W Cl18 1-126-163-11 ELECT 4.7MF 20% 50V

R271 1-216-830-11 METAL GLAZE 5.6K 5% 1/16W R272 1-216-834-11 METAL GLAZE 12K 5% 1/16W CONNECTOR R273 1-216-835-11 METAL GLAZE 15K 5% 1/16W R274 1-216-833-11 METAL GLAZE 10K 5% 1/16W CN3 • 1-691-632-11 CONNECTOR, BOARD TO BOARD 15P

R275 1-216-833-11 METAL GLAZE 10K 5% 1/16W

R276 1-216-833-11 METAL GLAZE 10K 5% 1/16W DIODE R277 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W

R278 1-218-716-11 METAL CHIP 10K 0.50%1/16W 0101 8-719-404-46 DIODE MA 110

R279 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W 0103 8-719-027-50 DIODE MA142WK

R280 1-218-730-11 METAL CHIP 39K 0.50%1I16W 0106 8-719-158-49 DIODE RD12SB2 0107 8-719-404-46 DIODE MA110

R281 1-218-710-11 METAL CHIP 5.6K 0.50%1/16W 0108 8-719-404-46 DIODE MA110

R282 1-216-821-11 METAL GLAZE lK 5% 1/16W R284 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W 0109 8-719-158-49 DIODE RD12SB2

R285 1-216-829-11 METAL GLAZE 4.7K 5% 1/16W

R286 1-216-845-11 METAL GLAZE lOOK 5% 1/16W IC

R287 1-218-748-11 METAL CHIP 220K 0.50%1/16W R288 1-218-748-11 METAL CHIP 220K 0.50%1I16W IC101 8-759-135-80 IC UPC358C

R289 1-216-809-11 METAL GLAZE 100 5% 1/16W IC102 8-759-208-17 IC TC4528BPHB

R291 1-216-833-11 METAL GLAZE 10K 5% 1/16W IC103 8-759-602-79 IC M5216L R292 1-216-073-00 METAL GLAZE 10K 5% 1/10W IC104 8-759-708-12IC NJM78L12A

R300 1-216-809-11 METAL GLAZE 100 5% 1/16W

R301 1-216-809-11 METAL GLAZE 100 5% 1/16W TRANSISTOR

R303 1-216-817-11 METAL GLAZE 470 5% 1/16W R304 1-218-704-11 METAL CHIP 3.3K 0.50%1/16W 0102 8-729-120-28 TRANSISTOR 2SC1623-L5L6

R305 1-218-704-11 METAL CHIP 3.3K 0.50%1/16W 0103 8-729-120-28 TRANSISTOR 2SC1623-L5L6 0104 8-729-120-28 TRANSISTOR 2SC1623-L5L6

R308 1-218-716-11 METAL CHIP 10K 0.50%1I16W 0105 8-729-216-22 TRANSISTOR 2SA1162-G

R309 1-218-697-11 METAL CHIP 1.6K 0.50%1I16W 0106 8-729-21.6-22 TRANSISTOR 2SA 1162-G . '-

R310 1-216-825-11 METAL GLAZE 2.2K 5% 1/16W

-75-

GDM·20SHT - bitsavers.org

Documents