Ghent Environmental Air Compliance Project KU Exhibit E EXHIBIT E ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS GHENT STATION The following sub-suppliers have been pre-approved by the Buyer/Engineer to provide the corresponding components. Pre-approval of a supplier for one component category is not blanket acceptance for other components by that supplier. If the Seller proposes to substitute a sub-supplier not on this list, then the sub-supplier’s credentials shall be submitted to the Buyer/Engineer for approval. Any cost savings to the Seller shall be credited to the Buyer if a substitute sub-supplier is requested and approved. Sufficient data must be provided to the Engineer in a timely manner to prove that the proposed equipment is of an equivalent quality and has proven operation in similar service conditions, including capacity, to that provided by the pre-approved sub-suppliers. If an offshore sub-supplier is proposed, the Seller shall provide information proving satisfactory domestic stockpiling of any required spare parts. Final decision concerning acceptance of an alternate sub-supplier shall be solely at Buyer’s discretion. Where multiple sub-suppliers are identified, those indicated in bold text are preferred by the Buyer and should be used for base bid purposes. Some Components are preferred by different stations; these are noted in the list and should be used as base bids for the specific station. Where no sub-supplier is named, the Seller shall select based on previous successful service in similar utility power plant applications. The Seller shall indicate on the fill--in data sheets which sub-contractors and/or sub-suppliers shown are to be the source of the indicated equipment and those provided only as “typical” of the intended by the Seller. COMPONENT PREAPPROVED SUBSUPPLIER Actuators (Electric) AUMA Actuators Inc. (E645.1.3) Rotork (E645.1.3) Limitorque Corp. (E645.1.3) Harold Beck &Sons, Inc. (E645.1.3) (Preferred) Rexa Actuators (Pneumatic) Air Compressor (Screw) Worcester Bettis Fisher Masonelian Atlas Copco Capital Machinery Systems Ingersol Rand National Pump and Compressor Aluminum Pigmented Mastic Foster No. 35-01 (15941.1.6) ANSI/IEEE Vendors Cleveland Switchboard (16120.1.6) Cutler-Hammer (16120.1.6) GE Electrical Distribution and Control (16120.1.6) Group Schneider – Square D (16120.1.6) Keystone (16120.1.6) Siemens (16120.1.6) Area Lighting In-line Fused Connectors Bussman (16501.1.6) Page 1 of 21
21
Embed
EXHIBIT E ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS ...skofirm.com... · ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS . GHENT STATION . ... Emerson Ovation DCS : Direct
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
Ghent Environmental Air Compliance Project KU Exhibit E
EXHIBIT E
ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS
GHENT STATION
The following sub-suppliers have been pre-approved by the Buyer/Engineer to provide the corresponding components. Pre-approval of a supplier for one component category is not blanket acceptance for other components by that supplier. If the Seller proposes to substitute a sub-supplier not on this list, then the sub-supplier’s credentials shall be submitted to the Buyer/Engineer for approval. Any cost savings to the Seller shall be credited to the Buyer if a substitute sub-supplier is requested and approved. Sufficient data must be provided to the Engineer in a timely manner to prove that the proposed equipment is of an equivalent quality and has proven operation in similar service conditions, including capacity, to that provided by the pre-approved sub-suppliers. If an offshore sub-supplier is proposed, the Seller shall provide information proving satisfactory domestic stockpiling of any required spare parts. Final decision concerning acceptance of an alternate sub-supplier shall be solely at Buyer’s discretion. Where multiple sub-suppliers are identified, those indicated in bold text are preferred by the Buyer and should be used for base bid purposes. Some Components are preferred by different stations; these are noted in the list and should be used as base bids for the specific station. Where no sub-supplier is named, the Seller shall select based on previous successful service in similar utility power plant applications. The Seller shall indicate on the fill--in data sheets which sub-contractors and/or sub-suppliers shown are to be the source of the indicated equipment and those provided only as “typical” of the intended by the Seller. COMPONENT PREAPPROVED SUBSUPPLIER Actuators (Electric) AUMA Actuators Inc. (E645.1.3)
Rotork (E645.1.3) Limitorque Corp. (E645.1.3) Harold Beck &Sons, Inc. (E645.1.3) (Preferred) Rexa
Actuators (Pneumatic) Air Compressor (Screw)
Worcester Bettis Fisher Masonelian Atlas Copco Capital Machinery Systems Ingersol Rand National Pump and Compressor
ANSI/IEEE Vendors Cleveland Switchboard (16120.1.6) Cutler-Hammer (16120.1.6) GE Electrical Distribution and Control (16120.1.6) Group Schneider – Square D (16120.1.6) Keystone (16120.1.6) Siemens (16120.1.6)
Area Lighting In-line Fused Connectors Bussman (16501.1.6)
Page 1 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Auxiliary Relays Allen-Bradley Bulletin 700 Type P (E530.2)
(Preferred) Allen-Bradley Bulletin 700 Type PK (E530.2) General Electric Type HFA or HGA (E530.2) Westinghouse Type MG-6 (E530.2) Allen –Bradley Type 700P, IDEC Potter and Brumfield (Tyco) type KRP (E530.2) Square D Cutler-Hammer (Eaton)
Belf (FMK) DuPont Viton B Polymer with "C" cure or 3M Fluoroel terpolymer (01503.2.19.3.1)
Caulking Tape Tremco "MBT" Metal Building Tape (07410.1.6) Pecora "BB-50" ExtruSeal (07410.1.6) Protective Treatment Inc., "606 Sealant Tape" (07410.1.6)
Compressed Air Fittings (Grip/Compression Style) Clampett Parker CPI
Compressed Air Fittings (Threaded) Parker CPI IMM (Preferred) Connectors (Special) Gray Tool Company (15221.1.6)
Anchor Darling Pressure Seal (15221.1.6) Connections (Thermowell) Bonney Forge (15221.1.6)
WFI (15221.1.6) WOI (15221.1.6)
Contactors Allen-Bradley (15920.1.5) (Preferred) Cutler-Hammer GE Square D
Contactors (Lighting) ASCO (16501.1.6) Cutler-Hammer (16501.1.6) General Electric (16501.1.6) Siemens (16501.1.6) Square D (16501.1.6)
Control Component Devices Allen-Bradley (Preferred) Cutler-Hammer GE Square D
Control Panel (Temperature) Hoffman Engineering Company (15920.1.5) Honeywell (15920.1.5) Johnson Controls (15920.1.5)
Controllers (Local) Fisher 2502 for Level (K100.9) Fisher 4160 or 4195 Series for Pressure (K100.9) Fisher 4166 or 4196 Series for Temperature (K100.9) Foxboro 43AP series (K100.9)
Page 2 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Controllers (Photoelectric) Fisher Pierce N7790B (16501.1.6)
Tork Electric (Preferred)
Convenience Receptacles (Duplex and Single) Hubbell (Generic Cat. No. 5362) (16501.1.6) Pass & Seymour (16501.1.6) Cooper Wiring (16501.1.6) Leviton (16501.1.6)
Convenience Receptacles (Duplex, gray for finished areas, brown for unfinished areas)
American Solder and Flux Company “Galvanizing Powder M-321” (11503.1.7) Industrial Metal Protectives, Inc. “Zincilate 810” (11503.1.7) ZRC Chemical Products Company “Zinc Rich” (11503.1.7)
Dampers American Warming & Ventilating (15820.1.5) Ruskin Arrow United (15820.1.5) Cesco Products (15820.1.5) Greenheck (15820.1.5)
Page 3 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Dampers (guillotine or louver man-safe isolation, or louver control)
Wahlco Metroflex NEM Power TLT Bachman Clyde Bergemann Bachmann Effox
Ghent Environmental Air Compliance Project KU Exhibit E
Electronic Control Systems (Room Thermostats and Humidistats)
Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Electronic Control Systems (Shielded Room Static Pressure Sensor)
Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Electronic Control Systems (Static Outside Probe) Johnson Controls (15920.1.5) Siemens (15920.1.5) Automatic Logic (15920.1.5)
Expansion Anchor Hilti Kwikbolt (08100.1.6) ITT Philips Red Head Wedge and Sleeve Anchors (08100.1.6) Ramset Trubolt and Dynabolt (08100.1.6) Drilco Maxi-Bolt (08100.1.6)
Fittings (PP lined, PVDF lined, and PTFE lined) Dow Chemical Company Resistoflex Corporation Peabody Dore
Fittings Rubber lined Dow Chemical Company
Fittings FRP Centrifugally cast Fibercast Company – Fibercast
Fittings FRP Filament wound Ameron Corrosion Control Division - Bondstrand Reinforced Plastics Systems Inc. - ABCO Plastics Division Smith Fiberglass Products Inc. Fibercast Company – Fibercast
Fittings HDPE Factory Mutual (FM) approved Phillips Petroleum Company - Driscopipe 1000 FM Class 200
Amsted Industries - Plexco EHMW - Class 200 - FM Bluestripe - Class 200 - FM Redstripe - Class 200 - FM Poly Systems Incorporated, KWH Class 200
Fittings HDPE Non-FM applications Phillips Petroleum Company - Driscopipe 1000 Amsted Industries - Plexco PE 3408 Poly Systems Incorporated, KWH – Sclairpipe
Fittings - Tubing Parker CPI
Fluorescent Dimming System Lutron Grafik Eye series (16501.1.6)
Page 7 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Flow Elements Daniel Industries
Fluidic Techniques Vickery-Simms Vickery Simms/Fluidic Techniques (K100.14) Triad (K100.14) Dieterich Standard (K100.14) Primary Flow Signal (K100.14) Daniel Measurement and Control (K100.14)
Goodall Rubber Co.(Type H butyl and other flexible) (15245.1.6) Rubber Engineering Federal Hose Mfg. (15245.1.6) Universal Metal Hose (15245.1.6) Flexonics, Inc. (15245.1.6) American Boa, Inc. (15245.1.6) Flexible Metal Hose Co. (15245.1.6)
Cutler-Hammer (16501.1.6) General Electric (16501.1.6) Siemens (16501.1.6) Square D (16501.1.6) Allen-Bradley (preferred)
Meter (Panel) Yokogawa (E530.7) Weschler Electric Corporation (E530.7) Crompton Instruments (E530.7)
Meter (Switch-Board)
Yokogawa (E530.7) Weschler Electric Corporation (E530.7) Crompton Instruments (E530.7)
Motors (Low Voltage)
General Electric (E642.1.3) Reliance (E642.1.3) U.S. Motors (E642.1.3) Toshiba (E642.1.3) Siemens (E642.1.3) Marathon (E642.1.3) TECO-Westinghouse Electric Machinery
Page 10 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Motors (Medium Voltage)
General Electric Reliance TECO-Westinghouse Siemens Toshiba
Photoelectric Controllers Fisher Pierce N7790B (16501.1.6) Tork Electric (preferred)
Dwyer Instruments, Inc. – (Capsu-Photohelic) (K100.3.1) S-O-R, Inc (K100.3.1). (preferred) United Electric (K100.3.1) Barksdale ASCO Ashcroft
Page 12 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Relays – Protective Type for Motors, Transformers and Switchgear
General Electric/Multilin (16125.4) (preferred) Basler I-T-E Electrical Products (Transformers) (16125.4)
Signal Converters (electric to pneumatic) Rosemount 3311 (K100.13)
Foxboro E69F (K100.13) ITT – Conoflow GT 8 (K100.13) Moore Industries Action Pak Rochester
Silencers Glynn-Johnson 64 (08100.1.6) Universal
Strapping for Support of Insulation on Vertical Pipe Runs
Acro Metal Stamping Co. “Acroflex” (15941.1.6)
Structural Steel Expansion Bearing Assembly
Merriman “Lubrite” (11503.1.7)
Switches (Control)
General Electric Type SB-1 with large cover (E530.7) General Electric Type SB-10 with large cover (E530.7) Electro-Switch Type 24 (E530.7) Electro-Switch Type W (E530.7) Electro-Switch Type 20K (E530.7)
Switches (Dimmers) Lutron “NOVA” series (16501.1.6)
Transmitter (Level) Rosemount – 3051 C or T (K100.6) Ametek Drexelbrook Bindicator Yokogawa – EJA Series (K100.6) Anderson Greenwood, manifolds (K100.6)
Transmitter (Level)(4-20 mA) Magnetrol International (K100.6) Rosemount –3051 C or T (K100.6) Ohmart Vega Yokogawa – EJA Series (K100.6) Anderson Greenwood, manifolds for DP style transmitters (K100.6)
Transmitter (Pressure) Rosemount – 3051 C or T (K100.6) Yokogawa – EJA Series (K100.6) Anderson Greenwood, manifolds (K100.6)
Valves ( Cast Steel) Bonney Forge Weir Valves & Controls American Evergy Services (15263.1.6) Atwood/Tricentric (15263.1.6) Cooper (15263.1.6) Crane (15263.1.6) Edward (15263.1.6) Grinnell (15263.1.6) Grove (15263.1.6) Newco (15263.1.6) Pacific (15263.1.6) Powell (15263.1.6) Stockham (15263.1.6) Velan (15263.1.6) Wheatley (15263.1.6) Milwaukee Valve Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Page 17 of 21
Ghent Environmental Air Compliance Project KU Exhibit E Valves (Check) – Insert Type
Keystone/Anderson Greenwood Power & Process (Technocheck) Consolidated (15263.1.6) Dow (15263.1.6) Nupro (15263.1.6) Stockham (15263.1.6) Wheatley (15263.1.6) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Valves (Check) – Tilting Disc
Anchor/Darling Atwood & Morhill Townley Pacific Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco
Valves (Diaphragm) Hills McCanna
ITT-Engineered Valve Dow (15263.1.6) GEMU (15263.1.6) ITT (15263.1.6) Saunders (15263.1.6) Red Man Mcjunkin Pipe products or Wolseley Tyco Trivaco