Brown CCRT Exhibit E EXHIBIT E ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS BROWN The following sub-suppliers have been pre-approved by the Owner to provide the corresponding components. Pre-approval of a supplier for one component category is not blanket acceptance for other components by that supplier. If Contractor proposes to substitute a sub-supplier not on this list, then the sub-supplier’s credentials shall be submitted to Owner for approval. Any cost savings to Contractor shall be credited to Owner if a substitute sub-supplier is requested and approved. Sufficient data must be provided to Owner in a timely manner to prove that the proposed equipment is of an equivalent quality and has proven operation in similar service conditions, including capacity, to that provided by the pre-approved sub-suppliers. If an offshore sub-supplier is proposed, Contractor shall provide information proving satisfactory domestic stockpiling of any required spare parts. Final decision concerning acceptance of an alternate sub-supplier shall be solely at Owner’s discretion. Owner will have access to Contractor’s equipment bids and will have ultimate approval / right of refusal on selection of suppliers / manufacturers. Where multiple sub-suppliers are identified, those indicated in bold text are preferred by Owner and should be used for base bid purposes. Where no sub-supplier is named, Contractor shall select based on previous successful service in similar utility power plant applications. Contractor shall indicate on the fill-in data sheets which sub-contractors and/or sub-suppliers shown are to be the source of the indicated equipment and those provided only as “typical” of the intended by Contractor. The following listing and categories of Acceptable Subcontractor are general and may include categories outside the scope of the Agreement COMPONENT PREAPPROVED SUBSUPPLIER Actuators (Motor operated valves) Rotork – On/Off Service Beck – Modulating Service REXA – Modulating Service Limitorque Promation Agitators, mechanical tank Chemineer Ekato Lightnin Air Conditioning Units Trane York International Page 1 of 33
33
Embed
Exhibit E Acceptable Equipment and Material Supplier …psc.ky.gov/pscecf/2014-00082/[email protected]/... · ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS . ... Dew Point
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
Brown CCRT Exhibit E EXHIBIT E
ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS
BROWN
The following sub-suppliers have been pre-approved by the Owner to provide the corresponding components. Pre-approval of a supplier for one component category is not blanket acceptance for other components by that supplier. If Contractor proposes to substitute a sub-supplier not on this list, then the sub-supplier’s credentials shall be submitted to Owner for approval. Any cost savings to Contractor shall be credited to Owner if a substitute sub-supplier is requested and approved. Sufficient data must be provided to Owner in a timely manner to prove that the proposed equipment is of an equivalent quality and has proven operation in similar service conditions, including capacity, to that provided by the pre-approved sub-suppliers. If an offshore sub-supplier is proposed, Contractor shall provide information proving satisfactory domestic stockpiling of any required spare parts. Final decision concerning acceptance of an alternate sub-supplier shall be solely at Owner’s discretion. Owner will have access to Contractor’s equipment bids and will have ultimate approval / right of refusal on selection of suppliers / manufacturers. Where multiple sub-suppliers are identified, those indicated in bold text are preferred by Owner and should be used for base bid purposes. Where no sub-supplier is named, Contractor shall select based on previous successful service in similar utility power plant applications. Contractor shall indicate on the fill-in data sheets which sub-contractors and/or sub-suppliers shown are to be the source of the indicated equipment and those provided only as “typical” of the intended by Contractor. The following listing and categories of Acceptable Subcontractor are general and may include categories outside the scope of the Agreement COMPONENT PREAPPROVED SUBSUPPLIER Actuators (Motor operated valves)
Rotork – On/Off Service Beck – Modulating Service REXA – Modulating Service Limitorque Promation
Agitators, mechanical tank Chemineer Ekato Lightnin
Air Conditioning Units Trane York International
Page 1 of 33
Brown CCRT Exhibit E
McQuay
Anemometers Manufacture’s standard.
Ammonia Receiving, Pump Forwarding and Injection Skids
Toromont
Auxiliary Relays Allen-Bradley Bulletin 700 Type P
Allen-Bradley Bulletin 700 Type PK General Electric Type HFA or HGA ABB Type MG-6 Allen –Bradley Type 700P, IDEC Potter and Brumfield (Tyco) type KRP
Bin Activators Bottom Ash Equipment
Kinergy Corp. Vibranetics, Division of Carrier Vibra Screw Carman Close Allen Sherman Hoff Alstom Clyde Bergemann United Conveyor Corporation
Bridge Cranes Columbus McKinnon Corp. Demag Cranes and Components EMH, Inc Harrington Hoists, Inc. KCI Konecranes America Morris Material Handling OMI Crane Systems Proservce Anchor Crane Group
Cable Trays B-Line Systems Chalfant Products Husky Products (Burndy) P-W Industries T.J. Cope US Gypsum Globe Div.
Cable – Coaxial and Triaxial Belden Brand Rex Rockbestos
Page 2 of 33
Brown CCRT Exhibit E Cable-600V Power Cable Brand Rex
Brown CCRT Exhibit E Connectors (control) 3M – MNG-18, MNG-14, MNG-10
AMP Special Industries - PIDG Panduit Corporation – PN18, PN14, PN10 Thomas & Betts Co. – RA18, RB14, RC10
Connectors (power, 600V and below) 3M – M10, M8, M6, M4, 30000 Series, 31100 Series AMP Special Industries – Solistrand, Ampower Panduit Corporation – P10, P8, P6, P4, LCA, LCC Thomas & Betts Co. – C10, D8, E6, F4, 54100 Series, 54200 Series
Connectors (power, above 600V) 3M – 30000 Series, 31100 Series AMP Special Industries – Ampower (5kV and below) Panduit Corporation – LCA (5kV and below) LCC (5kV and below) Thomas & Betts Co. – 54400 Series
Contactors Allen-Bradley
Contactors (Lighting) ASCO Cutler-Hammer Siemens Square D
Control Component Devices Manufacturer’s standard with approval by Owner
Controls Drives – Electric REXA Beck
Control Drives – Pneumatic Bailey Controls Rosemount (Hagan) Ktech
Control Panels Comsip Customline Hatch Inc. Johnson Controls KEMCO Powell Sewell Hoffman
Control Stations (local) Allen Bradley Crouse Hinds
Page 5 of 33
Brown CCRT Exhibit E
Cutler Hammer Square D
Controllers (Local) Fisher 2502 for Level Fisher 4160 or 4195 Series for Pressure Fisher 4166 or 4196 Series for Temperature Foxboro 43AP series Siemens, Masoneilan
Controllers (Photoelectric) Fisher Pierce N7790B
Control Valves and Regulators Fisher Controls Fujikin (with Beck drive) Masonelian International Flowserve
Control Valves and Regulators (steam service) Fisher Fujiken Copes Vulcan CCI Masonelian International
Control Valves – Rotary Fisher Controls Jamesbury Beck Masonelian International
Control Valves – Slurry Fujikin
Convenience Receptacles (Duplex and Single) Hubbell (Generic Cat. No. 5362) Pass & Seymour Cooper Wiring Leviton International
Convenience Receptacles (Duplex, gray for finished areas, brown for unfinished areas)
Detectors (admittance type high ash level) Drexelbrook Engineering Colconda Bindicator Princo Instruments
Detectors (Powder level) Drexelbrook Engineering Company Bindicator FLS or equal (for point level) Rosemount Saab Krone (or equal) for continuous measurement (radar)
Dew Point Test Apparatus EG&G Chandler Engineering Company “Catalog No. 13-75 with thermometer No. 13-2”
Direct DCS and Components (Temperature Controls Panels and Room Thermostats)
Hoffman Engineering Company (temp control panel) Honeywell Johnson Controls Siebe CSI
Direct DCS (Terminal Strips) Entrelec
Page 8 of 33
Brown CCRT Exhibit E
Phoenis Weidmuller Marathon 1500
Direct DCS (Auxiliary Relays) Allen-Bradley Type 700P IDEC
Direct DCS (Contactors) Allen-Bradley Type 700P
Direct Digital Control System (Temp Sensors & Moister Sensors)
Honeywell Johnson Controls Siemens Automatic Logic
Direct Digital Control System (Pressure Sensors)
Honeywell Johnson Controls Siemens Automatic Logic
Direct Tension Indicators (DTIs) TurnaSure LLC
Distribution Panelboards – 120VAC/125VDC
General Electric ITE Square D Westinghouse Cuttler Hammer
Distributed Control System (DCS) Foxboro I/A Doors (Fire Rated) Amweld “Series 3700”
Ceco “Regent” Mesker “PyroDor” Pioneer “Series C”
Doors (Insulated Rolling Steel) Atlas “Thermal Series” Cornell “Thermiser” Overhead Door “625”
Drives - Variable Speed (600V and below) (600V and above)
Allen Bradley Emerson GEC/CEG Electric Square D Toshiba - Houston International Reliance Robicon ABB
Page 9 of 33
Brown CCRT Exhibit E
Ductwork Fabricators Merrill
JT Cullen Custom Metals PSP CPF
Duct Slide PlatesDuct Slide Plates American Bearings Merriman Inc. R. M. Engineered Products Con-ServAmerican Bearings Merriman Inc. R. M. Engineered Products Con-Serv
Dust Collectors (dry) American Air Filter Flex-Kleen Mikropul
Dow Chemical Company Resistoflex Corporation Peabody Dore
Fittings - Rubber lined Dow Chemical Company
Fittings - FRP Centrifugally cast Fibercast Company – Fibercast
Fittings - FRP Filament wound Ameron Corrosion Control Division - Bondstrand Reinforced Plastics Systems Inc. - ABCO Plastics Division Smith Fiberglass Products Inc. Fibercast Company – Fibercast
Fittings - HDPE Factory Mutual (FM) approved
Phillips Petroleum Company - Driscopipe 1000 FM Class 200 Amsted Industries - Plexco EHMW - Class 200 - FM Bluestripe - Class 200 - FM Redstripe - Class 200 - FM Poly Systems Incorporated KWH Class 200
Hoffman Process Hydro Dyne Manning & Lewis Senior Engineering (Southwest) Struthers Industries Yuba Basco Thermal Transfer Young Radiator Trane Markel Qmark
Adhesive for Elastomeric Antisweat Insulation Armstrong 520 Adhesive
Insulation (Fiberglass) CertainTeed Manson Owens-Coming
Page 15 of 33
Brown CCRT Exhibit E Insulation (Mineral Fiber) Delta “Rock Wool”
Fibrex Industrial Insulation Group
Insulation (Perlite) Industrial Insulation Group LLC “Sproulle” Knauf “Innova”
Insulation (Treated Rigid Fiber) Owens-Coming
Insulation – Welded Studs for Attachment Nelson
Instrument Enclosures, heated Thermon – ThermoCase O’Brien – Vipak, A Series
Instruments (chute plugs) Drexelbrook
Instruments (fittings) Parker
Instruments (general control and indication) General Electric (type CR2940 control switch) Honeywell (type CMC control switch) Master Specialties Corporation (indicating lamps) Allen Bradley United Electric
Ruskin Manufacturing EME6625 Arrow United Industries EA-662-VSL Construction Specialties R5-5605 Greenheck
Jib Cranes Abell Howe Co. Anchor Crane and Hoist Service Co. Gorbel, Inc. Kone-Landel, Inc. Lift-Tech International, Inc. Orley Meyers Robbins and Meyers Seppard Niles, Inc.
Page 17 of 33
Brown CCRT Exhibit E
Lighting Abolite
Crouse Hinds Co. General Electric Holophane Lithonia
Lighting (panelboard) General Electric ITE Square D Cuttler Hammer
Lighting (Photo electric light) Sigma Instruments Co. Tork Electric Company
Lighting (receptacles) Crouse Hinds Co. Hubbell, Inc.
Piping (PP lined, PVDF lined, PTFE lined) Dow Chemical Company
Page 21 of 33
Brown CCRT Exhibit E
Resistoflex Corporation Peabody Dore
Piping (rubber lined for slurry) (not for use with gypsum)
ARDCO Holz Rubber Company Rubber Engineering Dow Chemical Company
Plug Resistant Orifices CU Services
Post Installed Mechanical Anchor Bolts Hilti Kwik-Bolt TZ
Positioner CCI “QuickTak” Fisher Controls – “Fieldvue” DVC 6000 Series Siemens – “Sipart PS2” Valtek - Logix 3200IQ
Pressure Indicator (Wetted Parts) Weksler AA44 Ashcroft 1279SS US Gauge 1981 3-D Instruments Accu-Drive Series 25 Perma-Cal 111TIDxxAx3LT Dwyer Series 4000
Programmable Logic Controllers (PLC) Rockwell Control Logics (Allen-Bradley)
Pressure Switch -Gauge Dwyer Instruments, Inc. – (Capsu-Photohelic) S-O-R, Inc United Electric
Pressure Switch - Differential Dwyer Instruments, Inc. – (Capsu-Photohelic) S-O-R, Inc United Electric
Pumps (cantilever) ASH (BGA) Hazelton Lawrence Warman Nagle
Pumps – Lube Oil Service IMO Delaval Viking Rivett Tuthill
Page 22 of 33
Brown CCRT Exhibit E
Pumps – Miscellaneous Service Goulds
Flowserve Lawrence Weir KSB
Pumps - Slurry ASH (BGA)
Denver Duchting Hazelton with Inpro Seals Lawrence Warman Townley
Pumps (water, except filtrate pumps) Rebar
Durco/Duriron Goulds Flowserve TBD
Relays – Auxiliary Control
Allen Bradley Diversified Electronics General Electric Square D Potter Brumfield Cutler Hammer
Relays – Timing
Agastat Eagle Adalake Potter Brumfield Diversified Electronics Allen Bradley
Relays – Lockout ABB Electro Switch General Electric
Relay Test Switches ABB
Page 23 of 33
Brown CCRT Exhibit E Relays – Protective Type for Generators, Motors, Transformers, and Switchgear
ABB Basler General Electric/Multilin SEL (Schweitzer Engineering Labs)
RTDs Foxboro Rosemont Tem-Pro, Inc. Ronan Honeywell RAM
Sealants and Chalking Bostik Construction Products Div. Dow Corning Corp. General Electric Co. Pecora Corporation Sika Chemical Corp. Sonneborn Building Products Tremco Manufacturing Company W. R. Meadows, Inc.
Sealant Backer Rod (Closed-cell) Bostik Construction Products Div.
Sonneborn Building Products - Sonofoam W. R. Meadows - Sealtight Backer Rod or Cera-Rod
Sealant Backer Rod (Open-cell)
Bostik Construction Products Div. Denver Foam
Signal Converters (electric to pneumatic) Rosemount 3311 Foxboro E69F ITT – Conoflow GT 8
Silencers Glynn-Johnson 64
Silos, Concrete Hamon Custodis, Inc. Marietta Silos LLC Pullman Power San-Con Industries, Inc.
Cutler-Hammer Honeywell Micro-Switch Namco Thermo Ramsey Pro-Line (Model ROS) Square D Cooper Crouse-Hinds
Switches (Control) General Electric Type SB-1 with large cover General Electric Type SB-10 with large cover Electro-Switch Type 24 Electro-Switch Type W Electro-Switch Type 20K
Transmitter (Level) Rosemount – 3051 C or T Honeywell – ST 3000 Yokogawa – EJA Series Anderson Greenwood, Swagelock, PGI, or Rosemount manifolds
Transmitter (Level) (4-20 mA) Magnetrol International Fisher Controls Milltronics Rosemount –3051 C or T Honeywell – ST 3000Yokogawa – EJA Series Anderson Greenwood, Swagelock, or PGI manifolds for DP style transmitters
Transmitter (Pressure) Rosemount – 3051 C or T Honeywell – ST 3000 Yokogawa – EJA Series Anderson Greenwood, Swagelock, PGI, or Rosemount manifolds