INDEX 1 WARNING Your common sense, good judgement and general alertness are crucial to safe and successful service work. Before attempting any work on your Audi, be sure to read 00 Warnings and Cautions and the copyright page at the front of the manual. Review these warnings and cautions each time you prepare to work on your car. Please also read any warnings and cautions that accompany the procedures in the manual. A ABS see Antilock brakes (ABS) Acceleration sensors ABS 45-6 Accelerator pedal assembly 20-28 Accessory belt 03-36 Air-conditioning (A/C) air distribution 87-7 blower motor 87-12 capacities 87-4 components 87-9 compressor 87-13 controls and power supply 87-5 dust and pollen filter 03-59 evaporator housing 87-14 flap motors 87-7 refrigerant and refrigerant oil 87-4 repairs 87-12 troubleshooting 87-2 Air filter 03-46 Airbags 02-19, 03-58, 69-10 Alignment 44-5 Alternator (generator) belt 03-36 removing and installing 27-10, 27-13, 27-15, 27-17 Aluminum body panels 55-1 Antenna 91-3 Antifreeze 03-27, 19-5 Antilock brakes (ABS) 02-16, 45-1 components Bosch 5.7 45-6 Bosch 8.0 45-9 diagnosis 45-4 impulse wheel front 45-12 rear (FWD) 45-13 rear (quattro) 45-16 wheel speed sensors 45-11 Anti-theft 96-29 A-pillar connector left 97-12 right 97-11 trim 70-23 Arm rest 70-15 Ashtray front 70-16 Automatic transmission 02-12 ATF 37-3 codes 37-1 CVT ATF 37-5 identification 03-8 selector mechanism 37-15 shift lock 37-16 see also Continuously variable transmission (CVT) B Back-up lights manual transmission 34-15 Balance shaft 02-8, 17-9 Battery 27-3 service 03-33 Belt accessory 03-36 timing 03-41, 13-2, 13-10, 13-17 Bi-xenon 94-4, 94-10, 94-17, 94-19, 94-21, 94-25, 94-28 Bleeding brakes 03-30 Blower motor 87-12 Body aluminum panels 55-1 Cabriolet AppendixA-2 dimensions 02-4 front fender 50-4 grill 55-6 overview 02-18 wheel housing liner 66-1 see also Trim B-pillar trim 70-25 Brake booster vacuum pump 15-17 Brake fluid 47-1 bleeding 03-30 level 03-29 Brake light switch 46-21 Brakes 02-16 antilock 45-1 bleeding 03-30 booster 47-3 vacuum pressure sensor 47-8 vacuum pump 47-7 caliper front 46-3, 46-6, 46-9 rear 46-15, 46-17 inspection 03-51 master cylinder 47-3 pads and discs checking 03-51 parking brake 46-20 specifications front 46-1 rear 46-2 troubleshooting 47-1 vacuum pump 47-7 see also Antilock brakes (ABS) see also Brake fluid Bulbs exterior see Headlight component and Taillight component diagrams in 95 Exterior Lights Bumpers front 63-1 rear 63-7 Bus systems 02-22, 9-2 C Caliper front 46-3, 46-6, 46-9 rear 46-15, 46-17 Camshaft sensor 28-7, 28-12
7
Embed
Audi A4 (B6, B7) Service Manual: 2002-2008 - Complete Index
The complete index from the Audi A4 (B6, B7) Service Manual: 2002-2008. For more information on this new repair manual, visit http://www.bentleypublishers.com/product.htm?code=a408 .
Welcome message from author
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
INDEX 1
WARNING
Your common sense, good judgement and general alertness are crucial to safe and successful service work. Before attempting any work on your Audi, be sure to read 00 Warnings and Cautions and the copyright page at the front of the manual. Review these warnings and cautions each time you prepare to work on your car. Please also read any warnings and cautions that accompany the procedures in the manual.
A
ABSsee Antilock brakes (ABS)
Acceleration sensorsABS 45-6
Accelerator pedal assembly20-28
Accessory belt 03-36
Air-conditioning (A/C)air distribution 87-7blower motor 87-12capacities 87-4components 87-9compressor 87-13controls and power supply 87-5dust and pollen filter 03-59evaporator housing 87-14flap motors 87-7refrigerant and refrigerant oil 87-4repairs 87-12troubleshooting 87-2
Air filter03-46
Airbags02-19, 03-58, 69-10
Alignment44-5
Alternator (generator)belt 03-36removing and installing 27-10, 27-13, 27-15, 27-17
A408_index.fm Page 2 Wednesday, October 13, 2010 9:38 AM
INDEX 3
WARNING
Your common sense, good judgement and general alertness are crucial to safe and successful service work. Before attempting any work on your Audi, be sure to read 00 Warnings and Cautions and the copyright page at the front of the manual. Review these warnings and cautions each time you prepare to work on your car. Please also read any warnings and cautions that accompany the procedures in the manual.
Electrolyte03-33, 27-5
Electronic braking control (EBC)45-2
Electronic differential lock (EDL)45-2
Electronic immobilizer96-29
Electronic stabilization program (ESP)
02-16, 45-2
Electronic power control (EPC) 02-11, 20-37
Electronics box (E-box)97-11
Emergency flasher switch96-21
Emergency convertible top AppendixVB-3sunroof closing 60-3
Engine02-5accessory belt 03-36applications table 02-5balance shaft 02-11compartment 03-16covers 03-18identification 03-6fluid leaks 03-20speed sensor 28-5, 28-11technical data 02-5timing belt 03-41
Heating and ventilationdust and pollen filter 03-59heater core 87-17see also Air-conditioning (A/C)
HFC (hydraulic fading compensation)02-16
HID headlightsee Xenon headlight
High intensity headlightsee Xenon headlight
Hoodengine hood 55-2
Horn96-28
Hydraulic fading compensation (HFC)02-16
I
Ignition coil28-19
Ignition shift lock37-16
Ignition switchelectrical 96-19key cylinder 96-18
Ignition system28-2coil 28-19disabling 28-2firing order 28-2knock sensor 28-2, 28-7, 28-11
Immobilizer96-29
Instrument cluster02-24, 90-1diagnostics 90-2removing and installing 90-3
Intake manifold15-5, 15-12, 24-23see also Engine management diagrams in 24 Fuel Injection
Intercooler21-19, 21-20
Interior lightssee Lights, interior
J
Jacking vehicle03-13
K
Knock sensor28-2, 28-7, 28-11
L
Leak detection 20-34
License plate light94-42
Lid, trunk55-7
Lifting vehicle03-13
Lights, exteriorfoglights 94-30switch 96-20taillights 94-32, 94-35see also Headlightsee also Turn signal
Lights, interior96-2dome 96-5
Lock carrier, frontservice position 50-2
M
Maintenanceaccessory belt 03-36air filter 03-46ATF 03-58, 37-3battery 03-33, 27-3body and interior 03-58brake fluid 03-29brake system 03-52cooling 03-26CV joint boot 03-52diagnostic trouble codes (DTCs) access 03-64
dust and pollen filter 03-59engine covers 03-18engine oil 03-20exhaust system 03-53fuel filter 03-54headlight adjustment 03-60parking brake 46-20schedules 03-66spark plugs 03-42timing belt 03-41, 13-2, 13-10, 13-7tires and wheels 03-54transmission fluid 03-58
automatic 37-3manual 34-5
underbody sealant 03-58under car maintenance 03-58windshield wipers and washers 03-62
Manual transmission02-12gear selector 34-9identification 03-8oil 34-5removing and installing 34-16specifications 34-2
Master cylinderbrakes 47-3clutch 30-5
MCB (Multicommunication bar)91-2
Mirrorinterior 70-2outside 66-3switch 96-23
A408_index.fm Page 4 Wednesday, October 13, 2010 9:38 AM
INDEX 5
WARNING
Your common sense, good judgement and general alertness are crucial to safe and successful service work. Before attempting any work on your Audi, be sure to read 00 Warnings and Cautions and the copyright page at the front of the manual. Review these warnings and cautions each time you prepare to work on your car. Please also read any warnings and cautions that accompany the procedures in the manual.
Motronicsee Engine management
Mufflersee Exhaust system diagrams in 26 Exhaust System
Transmissionidentification 03-8oil 03-58see also Automatic transmissionsee also Manual transmission
Trimdashboard end 70-3door 70-17driver storage compartment 70-9pillar and side trim 70-23steering column trim 70-7tailgate trim 70-32trunk trim 70-30, 70-36
Trunk lid 55-7light 96-10lock 55-11, 57-11trim 70-30, 70-36
Turbocharger21-3, 21-10hoses 21-2, 21-5, 21-11
Turn signalfront 94-15, 94-26switch 96-16
V
Vacuum pressure sensor 47-8
Vacuum pumpbrake booster 15-17, 47-7
Vehicle identification number (VIN)01-1, 03-5
Vehicle level sensor 40-19, 42-9
Ventilationdust and pollen filter 03-59see also Air conditioning (A/C)see also Heating and ventilation
Vibration damper13-4, 13-6, 13-19
Voltage9-4
W
Washers92-10fluid 03-63headlight 92-14
Water pumpremoving and installing 19-7, 19-11, 19-23, 19-32
Wheel alignment44-5
Wheel bearing40-11
Wheel housing liner66-1
Wheel speed sensor45-11
Wheels03-54, 44-1alignment 44-5
Windowglass service 64-2motor reinitializing 64-1motor service 64-6switch 96-24
Wipersarms and blades 92-2blades 03-62repairs 92-2, 92-6, 92-9
Audi A4 (B6, B7)Service Manual: 2002-2008 1.8L turbo, 2.0L turbo, 3.0L, 3.2L including Avant and Cabriolet
Price: $149.95Bentley Stock Number: A408Publication Date: 2010.dec.20ISBN: 978-0-8376-1574-5Hardcover, 8 3/8 in. x 11 in.Case quantity: 11430 pages, 2610 photos, illustrations and diagrams
The Audi A4 Service Manual: 2002-2008 contains in-depth maintenance, service and repair information for Audi A4 models from 2002 to 2008 built on the B6 or B7 platforms. Service to Audi owners is of top priority to Audi and has always included the continuing development and introduction of new and expanded services. Whether you’re a professional or a do-it-yourself Audi owner, this manual will help you understand, care for and repair your Audi.
Technical features:• Covers Audi A4 Sedan, A4 Avant (station wagon) and A4 Cabriolet
models including quattro versions. (Does not cover S4 or RS4 sport models.)
• Audi A4 product familiarization section in full color, highlighting technical features, year-to-year changes and application information.
• Maintenance procedures from routine oil changes to brake pad and rotor inspection and replacement.
• Engine and cylinder head service, including timing belt and brake booster vacuum pump replacement.
• Component testing, removal and installation for engine lubrication, cooling, turbocharger and exhaust systems.
• Fuel supply system service, including fuel pump delivery volume test, EVAP system component locations and electronic power control (EPC).
• Fuel injection and ignition system component identification and technical data, including intake manifold removal and installation.
• Drivetrain maintenance, troubleshooting, adjustment and repair, including hydraulic clutch, gearshift linkage and axles.
• Repair information for ABS brake systems.• Suspension component replacement, including struts, stabilizer bar,
multi-link elements and wheel bearings.• Body adjustment and repairs, including doors, fenders, front
radiator support, dashboard, sunroof and seats.• Heating and air-conditioning repair, including A/C component
replacement such as evaporator housing.• Includes factory wiring diagrams, component locations and a
general explanation of electrical circuitry.• Audi OBD II diagnostic trouble code section, including SAE and