Transcript
7/28/2019 Utility ISO 14001 Training
1/48
1
1
7/28/2019 Utility ISO 14001 Training
2/48
2
JSW Steel Limited is committed to minimize the impact of itsoperations on the environment and strive for improvement oncontinual basis by
1. Controlling pollutants with in the specified limits.2. Compliance with all applicable environmental legal and
ethical requirements.
3. Minimizing the process waste and promoting its recovery,recycle,reuse and disposal.
4. Developing green belt and rehabilitate waste dump throughafforestation and landscaping.
5. Educate and developing environment friendly workforce.
This policy has been communicated to all employees of JSWSteel Limited and shall be made available to the public and allinterested parties on demand.
D. RAVICHANDARChief Executive Officer
7/28/2019 Utility ISO 14001 Training
3/48
3
What is EMS
This is a system of managing environment, whichmeans to ensure effective use of resources andPrevention of Pollution
Characterized by notice assessment of
Environmental Impacts
Management commitment to compliance withapplicable Laws and Regulations
Opportunity for continual improvement of environmental performance
7/28/2019 Utility ISO 14001 Training
4/48
4
Protect human health and the environment fromthe potential impact of the activities, products andservices
Assist in maintaining and improving the quality of the environment
Resource conservation
It encourages planned investment at the start of the project, instead of forced investment incleaning-up at the end
BENEFITS OF ISO 14001
7/28/2019 Utility ISO 14001 Training
5/48
5
5
Doc.No.: QD/EMS/01-VII
Rev.No.:02
Date: 28.02.09
Page No.: 1 of 2
Area: Water Treatment Plant
(Softening & DM)
1 Emission to air:
2 Discharge to water resource:
3 Consumption of water:
4Generation of non-hazardouswaste:
5 Generation of hazardous waste:
6 Disposal method :
7 Noise:
8 Odor:
9 Radiation:
10 Risk of Fire/Accident:
Sl.No. Identification of Preliminary Aspects
Emission from HCL storage tank, preparation tank & caustic flakes.
NA
Department: Utility
Environmental Management System
Initial Environmental Review
Resin, Oil soaked cotton waste, empty chemical containers,
Resign stored in cans and returned to store department oil soaked cotton waste disposed improperly
NA
Fumes from HCL.
NA
Accidental spillage of HCL and caustic flakes fire due to short circuit.
For Chemical preparation, back wash and re generation of softener and DM Plant
Paper waste, cotton waste and stationery waste
7/28/2019 Utility ISO 14001 Training
6/48
6
6
11 Emergency Response:
12 Land Contamination:
13 Consumption of Power:
14 Consumption of Chemicals:
15 Consumption of material:
16 Legislative requirements:
17 Recycle/Reuse/recovery:
18 New projects:
19 Planned Activities
20 Contractor Activity:
Sl.No. Identification of Preliminary Aspects
For lighting and pumping
NACL, HCL, Calcium chloride
Drying beds for existing plant
House keeping
Refer raw material list
Water act Manufacture , storage and hazardous chemicals rule 1989, 2000 (MSIC)
Neutralized effluent reuse of water for open circuits .
Nil.
Availability of Fire Extinguishers, fire hydrant and PPEs like shoes, helmet & mask
Spillage of chemicals - oil
7/28/2019 Utility ISO 14001 Training
7/48
77
Doc.No.: QD/EMS/02
Rev.No.:02
Date: 28.02.09
Page No.: 1 of 2
Consumption Storage
1 Sulphuric acid 98 % cooling water system 30 kgs/day 1000 kgs YES Yes
2 N 1336 Cooling Towers 16 - 20 kgs/month 150 Kgs YES No
3 N 2495 Cooling Towers 300 kgs/month 400 Kgs YES No
4 N 2593 Cooling Towers 180 - 200 kgs/month 240 Kgs YES No
5 N 2890 Cooling Towers 30 - 40 kgs/month 60 Kgs YES No
6 N 7320 Cooling Towers 30 - 40 kgs/month 60 Kgs YES No
7 N 7357 Cooling Towers 50 - 60 kgs/month 30 Kgs YES No
8 N 7359 Cooling Towers 210 - 230 kgs/month 300Kgs YES No
9 N 8173 Water Treatment 300 - 350 kgs/month 400 Kgs YES No
10 N 8338 Cooling Towers 400 - 420 kgs/month 500 Kgs YES No
11 N 8185 Water Treatment 90 - 100 kgs/month 100 Kgs YES No
12 N 8312 Water Treatment 200 - 210 kgs/month 250 Kgs YES No
13 N 1389 Cooling Towers 225 - 250 kgs/month 300 Kgs YES No
14 N 3935 Cooling Towers 750 - 800 kgs/month 1000 Kgs YES No
15 N 7330 Cooling Towers 25 - 30 kgs/month 60 Kgs YES No
16 Hydrochem C 5031 Cooling Towers 40 - 50 kgs/month 50 Kgs YES No
17 Hydrochem C 5010 Cooling Towers 20 - 30 kgs/month 50 kgs YES No
Environmental Management System
Raw material / Material / Consummables List
Department: Utility
MSDS Hazardous ?Sl.No. Description Activity / Area of useQuantity
7/28/2019 Utility ISO 14001 Training
8/48
88
Doc.No.: QD/EMS/02
Rev.No.:02
Date: 28.02.09
Page No.: 2 of 2
Consumption Storage
18 Hydrochem C 5020 Cooling Towers 20 - 30 kgs/month 50 kgs YES No
19 Hydrochem C 3126 Cooling Towers 40 -50 kgs/month 50 kgs YES No
20 Hydrochem C 3042 Cooling Towers 125 - 150 kgs/month 150 kgs YES No
21 Hydrochem C 3020 Cooling Towers 270 - 300 kgs/month 300 kgs YES No
22 Hydrochem C 5025 Cooling Towers 40 - 50 kgs/month 50 kgs YES No
23 Sodium Hypo Chloride Cooling Towers 4000 - 4100 kgs/month 4250 kgs YES No
24 Cartridge filter Drinking water Filter 6 Nos/month 25 Nos NA No
25 Resin Softner and DM plant 10000 ltrs/annum 1000 ltrs YES Yes
26 W ater Hose Water plant 100 mtrs/annum 200 Mtrs NA No
27 Cartridge for printer Office 1 nos/Month 1 No NA Yes
28 Lubrication oil/grease Cooling tower, thickener comprssor & 400 Kgs / year 400 Kgs / 6 month Applicable Yes
29 Cotton waste, gloves Equipment cleaning 25 Kgs / month 25 Kgs / month NA No
30 Fuel & gases For diesel engine & cutting 1000Kgs / year 1000Kgs / 6 month Applicable Yes
31 Welding electrodes For replacing maintance of equimrent 20 Kgs / month 20 Kgs / month NA No
32 sodium chloride softner plant 1000 kg/day 15000 kgs/10 days YES No
33 Hydro chloric acid 33% DM plant regeneration 15 kgs/day 5000 kgs/month YES Yes
34 Caustic Flakes DM plant regeneration 10 kgs/day 500 kgs/month YES Yes
35 Light Soda Ash For GCP Water Treatment 300 kgs/day 4200 Kgs/week YES Yes
36 A3 & A4 papers For documents print out 1 ream / month 1 ream / month NA No
Department: Utility
Sl.No. Description Activity / Area of useQuantity
MSDS Hazardous ?
Environmental Management System
Raw material / Material / Consummables List
7/28/2019 Utility ISO 14001 Training
9/48
99
Doc.No.: QD/EMS/03
Rev.No.:02
Date: 28.02.09
Page No.: 1 of 2
Sl.No Description Activity / Area of generationCategory
( Solid/Semi
solid/Liquid)
Quantity( UOM)
Storage Disposal Frequency Hazardous ?
1 Effluent water Pre treatment plant Liquid 10 m3/day Pit Reuse daily No
2 Effluent water Softening plant Liquid 40 m3/day Pit Reuse daily No
3 Effluent water DM plant Liquid 1 m3/day Pit Reuse daily No
4 Blow Down Water Water Treatment Liquid 150 (m3/day) 50 m3 Reuse Daily No
5 Used Lub oil For Gear box etc Liquid 20 lts/month Nil to Stores monthly yes
6 Used Grease For Pumps, Gear box Etc Semi solid 20 kgs/month Nil to Stores monthly yes
7 Used Gland Packings For Pumps, Valves Etc Solid 1 kg / month Nil to Stores monthly No
8 Used Cotton Waste General Maintanance Solid 10 kgs/month Nil to Stores Daily No
9 Used Filter Element Lubrication / Filtering System Solid 3 Nos / month Nil to Stores monthly No
10 Worn out MechanicalSpares General Maintanance Solid As per requirement Nil to Stores monthly No
ENVIRONMENTAL MANAGEMENT SYSTEM
Waste Generation List
Department: Utility
11 Used Filter Media For Dual media Filters Solid 1000 Kgs/month Nil Disposal Yearly No
12 Used Resin Water Treatment Solid 7000 Lts / 5 years Nil Disposal 5 Year only No
13 Used PP Filter Cloth Waste Water Treatment Solid 75 Nos / 3 months Nil to Stores monthly yes
14 Used Chemical Packets Water Treatment Solid 45 Nos / monthly Nil to Stores monthly yes
15 Used Paint Tins General Maintanance Solid 100Lts / Yearly Nil to Stores Yearly yes
16 Disposal of Filter Cake Waste Water Treatment Solid 175 Tons / Day Nil To Sinter Plant Daily No
17 Used Stationaries Office Solid As per generation Dust bin Scrap yard Weekly No
7/28/2019 Utility ISO 14001 Training
10/48
1010
Sl.No. Activity Environmental Aspect Environmental Impact Legal/Other Requirements Description of the legal /Other requirements How The legal/Other requirementsare applicable? Remarks
1 Raw Water Treatment Plant
1.1 Pumping Raw water fromReservoir to Clarifloculator Consumption of Power Resource Depletion NA
1.2 Raw Water Treatment Consumption of Polyeletrolyte & Sodiumhypochlorite Resource Depletion Legal RequirementThe Manufacture, Storeage and import of
Hazardous chemical Rules. For following the instruction of MSDS
Consumption of water for chemicalpreperation Resource Depletion Legal Requirement
The Water Cess ( Prevention & Control of Pollution) Act & Rules.
To pay cess annually for theconsumed water.
Spillage of Polyelectrolyte & Sodiumhypochlorite Land contamination NA
Disposal of used Poly bags & Plasticcontainers Land contamination Legal requirement
Hazardous waste ( Management ,Handling &Transboundary Movement ) Rules.
For the safe disposal of hazardouswaste to the authorized vendor.
Disposal of sludge and used as manure Positive Impact NA
Leakage of water Resource Depletion NA
Damage of Clarifier tank / Reservoir/Pipeline
Resource Depletion /Personal Safety NA
1.3 Storage & Distribution of treated water Consumption of Power Resource Depletion NA
Leakage of water from storage sump Resource Depletion NA
Leakage of water from pipelines Resource Depletion NA
2 Softening Plant & DM Plant
2.1 Generation of Soft water & DMwater from Raw water Consumption of Raw water Resource Depletion Legal RequirementThe Water Cess ( Prevention & Control of Pollution) Act & Rules.
To pay cess annually for theconsumed water.
Consumption of Power Resource Depletion NA
Con su mp tion o f chemica ls Resou rce D ep le tion Leg al Req ui rement The Manufacture, Storeage and import of Hazardous chemical Rules. For following the instruction of MSDS
Department: Utility
ENVIRONMENTAL MANAGEMENT SYSTEMDoc. No.: QD/EMS/04
Rev.No.: 03
ASPECT AND IMPACT IDENTIFICATION.Rev. Date.: 09.07.09
Page No.: 1 Of 8
7/28/2019 Utility ISO 14001 Training
11/48
11
METHODS OF OPERATIONALCONTROL
1 ----- O perational Control P rocedure -- OCP
2 ----- Environmental Management P rogramnme (s) -- EMP
3 ----- Emergency Manual-- EM
4 ----- Monitoring and Measurement P lan --- MMP
5 ----- P ersonal P rotective Equipment P lan --- PPEP
6 ----- T raining P lan --- TP
7/28/2019 Utility ISO 14001 Training
12/48
12
PURPOSE OF OCP
The organization shall identify those operations andactivities that are associated with the identified significantenvironmental aspects in line with its policy, objectivitiesand targets
Establishing & maintaining documented procedure to cover
certain activities Stipulating operating criteria in the procedures
Establishing and maintaining procedures related to theidentified significant environmental aspects
7/28/2019 Utility ISO 14001 Training
13/48
13
7/28/2019 Utility ISO 14001 Training
14/48
14
?
Disposal meansany operation which may lead to resource recovery,recycling, reclamation, direct re-use or alternative uses(Annex IVB of the Basel convention)
7/28/2019 Utility ISO 14001 Training
15/48
15
Municipal waste (Including Household and
commercial)Industrial waste (including manufacturing)Hazardous wasteConstruction and demolition waste
Mining wasteWaste from Electrical and Electronic equipment
(WEEE)Biodegradable municipal wastePackaging wasteEnd of Life vehicles (ELVs) and tyres
Agricultural waste
7/28/2019 Utility ISO 14001 Training
16/48
16
Kinds of WastesSolid wastes: domestic, commercial and industrial
wastes especially common as co-disposal of wastes
Examples: plastics, containers, bottles,cans, papers, scrap iron etc
Liquid Wastes: wastes in liquid form
Examples: domestic washings, chemicals, oils,waste water from ponds,manufacturing
industries and other sources
7/28/2019 Utility ISO 14001 Training
17/48
17
Bio-degradable
can be degraded (paper, wood, fruits and others)
Non-biodegradable
cannot be degraded (plastics, bottles, old machines,cans, styrofoam containers and others)
7/28/2019 Utility ISO 14001 Training
18/48
18
Hazardous wastes Substances unsafe to use commercially, industrially,
agriculturally, or economically that are shipped, transported to or brought from the country of origin for dumping or disposal in, or in transit through, any part of the territory of the Philippines
Non-hazardous Substances safe to use commercially, industrially, agriculturally,
or economically that are shipped, transported to or brought fromthe country of origin for dumping or disposal in, or in transitthrough, any part of the territory of the Philippines
7/28/2019 Utility ISO 14001 Training
19/48
19
Households
Commerce and Industry
7/28/2019 Utility ISO 14001 Training
20/48
20
7/28/2019 Utility ISO 14001 Training
21/48
21
7/28/2019 Utility ISO 14001 Training
22/48
22
7/28/2019 Utility ISO 14001 Training
23/48
23
Agriculture
Fisheries
7/28/2019 Utility ISO 14001 Training
24/48
24
Oil from a leaking pipeline burns in a swamp area of the Niger Delta in Nigeria. Nigeria is one of the worst
polluted countries in the world
C t t l ft l g i b k t Y i ill g Chi El t i t
7/28/2019 Utility ISO 14001 Training
25/48
25
Computer waste are left along a river bank at Yaocuowei village, China. Electonic wastecontains 1,000 different substances such as lead, cadmium, chromium, and mercury
heavy metals which are highly toxic
7/28/2019 Utility ISO 14001 Training
26/48
26
Waste Chokes India
7/28/2019 Utility ISO 14001 Training
27/48
27
7/28/2019 Utility ISO 14001 Training
28/48
28
Products that run on electricity have the potential to cause damage to human health andthe environment if not disposed of in a safe manner. Depending on how e-waste ishandled when disposed of and where it is disposed of, certain components of electronicproducts can be rendered hazardous. For instance, CRTs (cathode ray tubes) from PCmonitors contain an average of 1.8 to 3.6 kg of lead, some of which could be released
into the environment if not properly handled and recycled
7/28/2019 Utility ISO 14001 Training
29/48
29
7/28/2019 Utility ISO 14001 Training
30/48
30
Electronic Waste plastic separation
7/28/2019 Utility ISO 14001 Training
31/48
31
D i d y o u k n o w . . ? People discard computers every two to four years
on average. Cell phones have a life-cycle of less than two yearsin industrialised countries.
315 million PCs will become obsolete in 2004 alone. 130 million mobile phones will be disposed of
world-wide in 2005. Each computer screen contains about 20% lead by
weight.
7/28/2019 Utility ISO 14001 Training
32/48
32
Affects our health Affects our socio-economic conditions Affects our coastal and marine environment Affects our climate
According to NAS (National Academy of
7/28/2019 Utility ISO 14001 Training
33/48
33
According to NAS (National Academy of Sciences):
GHGs ( Gases that trap heat in the atmosphere are often called greenhouse gases)are accumulating in Earths atmosphere as a result of human activities, causingglobal mean surface air temperature and subsurface ocean temperature to rise.
(Carbon dioxide CO2- enters the atmosphere through the burning of fossil fuels (oil, natural gas, and coal), solidwaste, trees and wood products, and also as a result of other chemical reactions (e.g., manufacture of cement). Carbondioxide is also removed from the atmosphere (or sequestered ) when it is absorbed by plants as part of the biologicalcarbon cycle.
Methane CH4- is emitted during the production and transport of coal, natural gas, and oil. Methane emissions alsoresultfrom livestock and other agricultural practices and by the decay of organic waste in municipal solid waste landfills.
Nitrous oxide N20- is emitted during agricultural and industrial activities, as well as during combustion of fossil fuelsand solid waste.
Fluorinated gases : Hydrofluorocarbons, perfluorocarbons, and sulfur hexafluoride are synthetic, powerful greenhousegases that are emitted from a variety of industrial processes.
Fluorinated gases are sometimes used as substitutes for ozone depleting substances (i.e., CFCs, HCFCs, and halons).
These gases are typically emitted in smaller quantities, but because they are potent greenhouse gases, they aresometimes referred to as High Global Warming Potential gases (High GWP gases ).
Rising global temperatures are expected to raise sea levels and change precipitationand other local climate conditions.
Changing regional climates could alter forests, crop yields, and water supplies. This could also affect human health, animals, and many types of ecosystems. Deserts might expand into existing rangelands, and features of some of our national
parks might be permanently altered.
http://www.epa.gov/highgwp/sources.htmlhttp://www.epa.gov/nitrousoxide/sources.html7/28/2019 Utility ISO 14001 Training
34/48
34
According to NAS:- Some countries are expected to become warmer,
although sulfates might limit warming in some areas.
- Scientists are unable to determine which parts of those countries will become wetter or drier, but there
is likely to be an overall trend toward increasedprecipitation and evaporation, more intenserainstorms, and drier soils.
- Whether rainfall increases or decreases cannot bereliably projected for specific areas.
7/28/2019 Utility ISO 14001 Training
35/48
35
WHAT SHOULD BE DONE
Reduce Waste
- Reduce office paper waste by implementing a formal policy toduplex all draft reports and by making training manuals andpersonnel information available electronically.
- Improve product design to use less materials.
- Redesign packaging to eliminate excess material whilemaintaining strength.
- Work with customers to design and implement a packagingreturn program.
- Switch to reusable transport containers.
- Purchase products in bulk.
7/28/2019 Utility ISO 14001 Training
36/48
36
WHAT SHOULD BE DONE
Reuse
- Reuse corrugated moving boxes internally.
- Reuse office furniture and supplies, such as interoffice envelopes,file folders, and paper.
- Use durable towels, tablecloths, napkins, dishes, cups, andglasses.
- Use incoming packaging materials for outgoing shipments.
- Encourage employees to reuse office materials rather thanpurchase new ones.
7/28/2019 Utility ISO 14001 Training
37/48
37
WHAT SHOULD BE DONE
Donate / Exchange
- old books
- old clothes
- old computers
- excess building materials
- old equipment to local organizations
7/28/2019 Utility ISO 14001 Training
38/48
38
WHAT SHOULD BE DONE
Employee Education
- Develop an office recycling procedures packet.
- Send out recycling reminders to all employees includingenvironmental articles.
- Train employees on recycling practices prior to implementingrecycling programs.
- Conduct an ongoing training process as new technologies areintroduced and new employees join the institution.
7/28/2019 Utility ISO 14001 Training
39/48
39
WHAT SHOULD BE DONE
Preventing Waste
- packaging waste reductions and changes
in the manufacturing process
- use biodegradable materials
7/28/2019 Utility ISO 14001 Training
40/48
40
WHAT SHOULD BE DONE
Conduct outreach program adopting anecologically sound waste management systemwhich includes:
waste reduction segregation at source composting recycling and re-use more efficient collection more environmentally sound disposal
7/28/2019 Utility ISO 14001 Training
41/48
41
Data released by the United StatesEnvironmental Protection Agency shows
that somewhere between 500 billion and atrillion plastic bags are consumedworldwide each year.
National Geographic News September 2,2003
Less than 1% of bags are recycled. It costmore to recycle a bag than to produce a
new one.
7/28/2019 Utility ISO 14001 Training
42/48
42
Then
Where Do They Go?
A study in 1975, showed oceangoing vessels togetherdumped 8 million pounds of plastic annually. The real reasonthat the world's landfills weren't overflowing with plastic was
because most of it ended up in an ocean-fill
7/28/2019 Utility ISO 14001 Training
43/48
43
Plastic bags photodegrade:Over time they break down into smaller,
more toxic petro-polymers
7/28/2019 Utility ISO 14001 Training
44/48
44
which eventually contaminate soils andwaterways
7/28/2019 Utility ISO 14001 Training
45/48
45
Birds becometerminallyentangled
Nearly 200 different speciesof sea life including whales,
dolphins, seals and turtles diedue to plastic bags
If we use a cloth bag,
7/28/2019 Utility ISO 14001 Training
46/48
46
If we use a cloth bag,we can save 6 bags a week
That's 24 bags a month
That's 288 bags a year
That's 22,176 bagsin an average life time
If just 1 out of 5 people in ourcountry did thiswe would save
1,330,560,000,000 bagsover our life time
7/28/2019 Utility ISO 14001 Training
47/48
47
It is possible ...
7/28/2019 Utility ISO 14001 Training
48/48
48
top related