Infrared absorption spectra of some experimental glasses ... · Infrared Absorption Spectra of Some ... magnesium, and silicon. The neodymium oxide was ... Infrared absorption spectra
Post on 23-Apr-2018
223 Views
Preview:
Transcript
U. S. Department of Commerce National Bureau of Standards
Research Paper RP1761 Volume 38, January 1947
Part of the Journal of Research of the National Bureau of Standards
Infrared Absorption Spectra of Some Experimental
Glasses Containing Rare Earth and Other Oxides
By Ralph Stair and Conrad A. F aick
This paper g ives specLral Lransmi ion data on soda lime glass containin g ra re ear th
(Y, PI', Nd, Sm, Cd , E r) or oLher coloring oxi les (V, Cr, Mn , Co, Ni, U) in the spectral
region of 0.7 to 4.5 microns.
1. Introduction
In connection with experiments upon glass spectral filters and upon the physical propertie of cer tain other glasses as a function of their composition, infrared transmissions were measured upon a number of soda-lime-silica glasse containing som e rare earth and other coloring oxides . All glasses were made with the sam e basic compo ition, namely: Si02, 7l.4 percent ; Na20 , 18.4 percent ; and CaO, 10.2 per cent, as computed from the batch materials. Calcium and anhydrous sodium carbonate of reagent quality and powdered crystalline quartz were employed for the base glass . The other materials were added in the form of oxides.
These glasses wer e m elted in a 25-ml platinum crucible, in a platinum-resistance furnace. The melting procedure followed very closely that used in previous experimental work [1] * and all glasses received the sam e t reatm ent. Data on the specific refraction and dispersion of some of these glasses have been published elsewhere [12] .
The samples obtained often con tained a few seeds and a small amount of striation which may have caused small errors in absorption measm em en ts. However , as the complete infrared absorp tion curve was obtained through the same
' Figures in brackets indicate tbe literature references at the end of this paper.
Rare Earth Oxide Glasses 724217--47-- 7
area of the sample, r elative values between the different wavelengths should be adequate.
The r are-earth oxides used in the production of these glasses were from the Jam e collection that had been acq uired by the B ureaLl . 1 According to tests mad e by the Spectroscopy Section of thi Bureau , these rare-earth oxide contained varying amount of impurities, especially other rare-earth materials, but their purity was judged to be adequate for the purpo es.of this r eport.
The praseodymium oxide con tained small amou.nts of lanthanium and yttrium in addition to traces of calcium, copper , iron, magnesium, and silicon. The neodymium oxide was of high puri ty, containing only traces of calcium, copper , iron, magnesium, and silicon. The samarium oxide was especially good, containing, in addition to small amounts of calcium and silicon, only traces of magnesium and lead, with praseodymium doub tful. The gadolinium oxide contained about 10 percent of europium, about 1 per cen t each of bismuth and magnesium, in addition to a small amount of calcium, traces of erbium, silicon, and samarium, and possibly traces of potassium and lead. The erbium oxide was no t subj ected to as thorough spectrochemical study, but it con tained
I Collection of rare-earth materials prepared by the late Professor Jam es of tbe UniverSity of New Harnl)shire and subsequently purchased from tbe Uni versity by the National Bureau of Standards.
95
about 1 percent of yttrium, smaller amounts of holmium and thulium, and traces of scandium and ytterbium. The purity of the yttrium oxide is not known.
An examination of the different absorption curves shows no significant bands for yttrium (see fig. 2) or for europium (see curve 6 for gadolinium, which contains Eu as an impurity) nor the presence of overlapping of absorption bands that might be expected in mixed materials, where the same impurities are present for a number of the glasses. Hence, in most cases, at least, these impurities were in very small amount or else of a type that is known to produce relatively weak absorption within the region of 0.7 to 4.5 J..I. .
Reagent quality oxides were used for the other coloring materials.
All glasses having a silica base show a high absorption in the region of 2.8 to 4.5 J..I., which is caused by some combination of silica with water and other base materials of which the glass is composed. Because this silica absorption may be made to vary between wide limits [9] in the region of 2.9 J..I. simply by controlling the amount of water within the glass, it is impossible to attempt to make accurate calculations on comparative transmissions within this silica absorption region. Furthermore, analysis of the oxide absorption in the region of 2.8 to 4.5 J..I. is greatly
100
90
eo
I- 70 z 1&1
~ 60 1&1 Q.
Z 50
~ 40 III en i 30 III Z
: 20 I-
96
10
o o
BASE GLASS
..... . 1, ~t' 5i 28mn
I
"" \ \
.--"'0
1\
2 3 4 WAVELENGTH (MICRONS )
Figure 1.
\ 5
complicated as the result of the high absorption in the base glass. Either because of this high and variable absorption in the base glass or because the oxides studied have no characteristic bands in this region, no absorption bands between 2.8 and 4.5 J..I. were discovered that could positively be attributed to the oxides added.
The transmission of the base glass is given in figure 1. This glass shows no absorption bands at wavelengths shorter than about 2.8 J..I.. Beyond this wavelength the silica absorption increases rapidly with increase in wayelength.
The glasses vary somewhat in thickness. For several of them two thicknesses were available. This is often useful in infrared studies, because a proper selection of thickness of the specimen permits the structure of the absorption spectrum to be exhibited to best adyantage. In this work the more suitable sample was chosen.
II. Instruments and Methods
For a detailed discussion of the experimental procedure, reference is made to previous publications [3, 4, 5, 6, 7, 8]. The spectroradiometer consisted of a mirror spectrometer, with mirrors 50 cm in focal length. A small fluorite prism on a Wadsworth mounting was employed.
The observations were made by the "point by point" method. A portable vacuum thermopile of bismuth-silyer, comlected with an iron-clad Thomson galvanometer, was used for measuring the radiation. The source of radiation was a N ernst glower, focused upon the entrance slit of the spectrometer by means of a large concave mirror of I-m focal length. The galvanometer readings were read visually and recorded. The sample was placed in front of the entrance slit of the spectrometer by means of a mechanical carriage which placed it in the same position for each wavelength. The effective spectral slit width varied from about 0.17 at 2 to 0.07 at 4.5 J..I..
III. Spectral-Transmission Data
A brief description is given of the glass and its special transmission characteristics. A general summary covering the kinds and amounts of oxides added is given in table 1. The glass numbers correspond to the same samples examined in the visible spectrum and reported on elsewhere [2].
Journal of Research
TABLE I. -Amount oj oxide added to the base glass
Glass No.
6a 6
13 15 18 19 20 23
Index of rc-Thick- fraction
ness wavelength, Weight of oxid e added 5893 A
Percent mm Base gl~ss _______ __ _ . ______ ---- 5.28 1. 5224
3.0 V,O, ___ _________________ 4.73 1.5285
1.0 C"O, _______________ ____ 4.21 1. 5255
1.0 Mn 0 2. _________________ 4.40 1.5237
0.04 Co 0 _____ __ ____ ________ 4.22 1.5216
. 05 Ni 0 _______ ____________ 4.22
. 50 Ni 0 ___________________ 4.47
10.0 y ,O, _______ ____ _____ __ _ 6.81 1. 5439
10.0 Pr,Ou __________ ____ ____ 7.13
10.0 N d' O' __________________ 7. 27
10.0 Sm,O' _____________ __ ___ 6.80
10.0 Gd ,O, __________________ 6.28 1. 5343
10.0 EnO' ___________________ 6. 52
3.0 U,O, ___________________ 2. 52
L Yttrium Oxide Glass
No appreciable absorption in the near infrared is caused by yttrium oxide (Y20 3) when added in an amount of 10 percent (see fig _ 2) _ Neither was
10 0
8
... 7 z ....
0
0
~ 6 ~
0
z50
Z
24 CI'l
0 CI'l
~ 3 Ul z «
0
~ 2
0
0 o
~ I-... y --""'" ... 1 ' 6.slmm
9
•
t \
.... V 1\ \
2 3 4 .5 WAVELENGTH (MICRONS)
FIGURE 2.
any absorption observed within the visible spectrum (see reference [2]).
A comparison of the absorption curve for yttrium oxide glass with those for the base glass
Rare Earth Oxide Glasses
and the erbium and gadolinium oxide glasses (see figs. 1, 6, and 7) indicates the possibility of some general absorption in the region of 2.7 to 4.2 J.L.
However, differences in thickness and amounts of water within the glass may account for the greater absorption in this region.
2. Praseodymium Oxide Glass
Two strong absorption maxima occur at about 1.45 and 1. 90 J.L as the result of the addition of praseodymium (Pr6011) in the amount of 10 percent_ Weak bands occur at about 0.76 and 1.0 J.L
(see fig. 3). The general shape of the transmission
90
80
70 f--z w
60 U a: w 0..
~ 50
z Q 40 VI VI
~ 30 z « a: t- 20
10
o o
~ l..-, Pr
~t : 7.13mm
I 7
13
"\ -'\ \ ~
2 3 4
WAVELENGTH (MICRONS)
FIG U RE 3_
curve indicates the possibility of additional bands in the region of 2.4 and 4.0 J.L- Absorption in the visible spectrum gives this glass a light yellowish green color.
3 . Neodymium Oxide Glass
The addition of neodymium (N d20 a) 111 the amount of 10 percent results in tluee strong absorption bands at about 0.77 , 1.63, and 2.43 J.L
(see fig. 4). It is to be expected that this material would produce a number of absorption bands in the near infrared judging from the number and intensity of the bands in the visible spectrum [2], which give this glass its bright-purple hue.
97
10 0
9 0
8 0
I- 7 z
0
III
~ 6 III "-
0
Z 5
:z 24 <J1 ~
~ 3 Z < ~ 2
0
0
0
0
o o
N.
-~
~( r\' 07.27m ~
~ 11 15
~
~ r\ \
'~ \
2 3 4 5
WAVELENGTH (MICRONS)
FIGURE 4.
4 . Samarium Oxide Glass
The addition of samarium oxide (Sm20g) in an amount of 10 percent gives rise to a very strong absorption band at about 1.47 fJ. , and weaker bands at about 1.1, 1.92, 2.62, and 4.1 fJ. (see fig . 5). The strong band at 1.47 fJ. almost completely
90
80
7 0
~
~60 ~ t.J "- 5 z z 04 iii Vl
~ 3 Z < ~ 2
98
0
0
0
0
0
o o
.&
f\ 1\ f\ s'"
.." \ t o 6-rO mm
\ "I 1\ , \ \18
\ ~
\ '... 1\ \ ~
K 234
WAVELENGTH (MICRONS)
FIGURE 5.
5
masks the one in the neighborhood of 1.1 fJ.. The presence of so many bands within this part of the infrared spectrum suggests the possibility of other bands at longer wavelengths. Hence it would be interesting to study this material incorporated into a special infrared transmitting glass. Absorption in the visible spectrum gives this glass a light yellowish hue.
5 . Gadolinium Oxide Glass
No appreciable absorption occurs in the near infrared (or in the visible spectrum) because of the addition of gadolinium oxide (Gd20 g) (see fig. 6).
IZ III
100
90
80
70
~ 60 t.J II.
~ 50
z Q 40 Vl Vl
1 30
~ ~ 20
0
0 o
Cd.
.... 1"\. 6. 28 mm
... 19
\ \ ~
\ 234
WAVELENGTH ( MICRONS)
FIGURE 6.
6 . Erbium O xide Glass
\ 5 !
The addition of erbium oxide (Er20g) in an amount of 10 percent gives rise to one strong absorption band at about 1.52 fJ. and two weaker bands at about 0.80 and 0.95 fJ. , respectively (see fig . 7). A comparison with the transmission curve for gadolinium (fig. 6), which probably produces but little or no absorption in the infrared between 0.6 and 4.5 fJ., indicates no other important absorption bands shorter than 4.5 fJ.. Absorption in the visible spectrum gives this glass a light-pink color.
Journal of Research
10 0
9 0
8 0
7
~ ... v 6 II:
~
0
0
~ 50
z o 4
~ ~ 3 If)
z < ~ 2
0
0
0
0 o
Er
tA ,....., r ....... r,"S_52mm
I I
\ 20
"' \ \ -\
\ \
2 3 4 5
WAVELENGTH (MICRONS)
FIG UHE 7.
7. Other Oxide Glasses
The addit ion of vanadium (V20 5), cobalt (CoO), nickel (NiO), or uranium (U 30 8) oxide in small amounts (see table 1) produce strong absorption bands in the spectral region between 1 and 4/L (see figs. 8, 11 , 12, and 13 ). It is to be noted that much smaller concentrations of these metals were
100
90
80
f- 70 Z ... ~ 60 w CL
~ 50 z o iii 40 If)
a 30 z < ~ 20
10
o o
v
I ......,
"4.73mm
! I \ I \ I
I ~ 1.,2
\ \
'r.--
234 WAVELENGTH (MICRONS 1
FIGURE 8.
Rare Earth Oxide Galsses
\
\ \
5
required to produce absorption of magnitude similar to that resulting from the addition of 10 percen t of some of the rare-earth oxides . In the case of the addition of chromium (Cr20 3) and manganese (Mn0 2) oxides, little change in absorption occurs within the near infrared regIOn (see figs. 9 and 10) .
100
90
80
f- 70 Z ... U
" eo ... CL
~ 70
Z Q 40
'" C/I
~ 30 Z < II: ....
f-Z ... V a: w a.
20
10
o o
100
90
80
70
60
z 50
z ~ 40 U1
~ 30 :z <{
a: f- 20
10
o o
f
/ I
t
Cr ...... ~"4~21 mm
I.,.
~ ~
\
'\ \
2 3 4
WAVELENGTH (MICRONS)
F lGUHE 9.
Mn
"\" 4.4 0 mm
-- -
\
~ \ .,-..
1\ \
2 3 4 5 WAVELEI~GTH (MICRONS)
FIGUHE 10.
99
100
IZ
90
80
70
tl 60 a: ~ Z 50
z Q 40 <1'1 <1'1
~ 30 Z -< ~ 20
fz IoJ v a: IoJ Go
~
Z o <1'1 <1'1
~ <1'1 Z -< a: I-
10
o o
90
80
70
60
40
30
20
10
0 o
Co
[ \ / ,",1=4.22 mn
~ ...
~
\ io' \ 1 '. V
~
\\ \5
" r---. \
~
234 WAVE LENGTH (MICRONS)
FIGU RE 11.
... ~ Ni
..... V 1"\=4.22 mm
\ \,
1'\ 6A r 1\ \ I \ .I h6 'It-"-~ , V' l 1 = 4. 47mm .....
1 \
\ ..... V r\\
.~ 2 3 4
WAVELENGTH (MICRONS)
FIGU R E 12.
5
.. -
5
Accor ing to the work of Kiess, Humphreys, and La n upon its atomic spectrum, uranium is a rare-earth type elem en t and is the homologue of neodymium [10]. It has the same valence electron structure and we would expect, therefore, its behavior would be similar to neodymium. A comparison of figures 4 and 13 is interesting.
Each of the metal oxides also produces a large amount of absorption in the visible spectrum resulting in a distinct color for each glass. The
100
100
90
80
~ ~~ u
..... ~ \ j \1=2 .52mm
I- 70 z IoJ v a: 60 IoJ Go
~ 50
\. 23
I'". z 0 iii 40 ~
~ <1'1
~ <II Z -< a: f-
30
20
lO
o o
\ \ \
2 3 4
WAVELENGTH (MICRONS)
FIGURE 13.
r\
5 I
I
colors resulting in the glasses of this group are as follows for the different oxides: Cobalt, pale blue; nickel, light to dark smoke to dark purple ; vanadium, light yellow to yellow green (similar to novial B); uranium, light yellow (near novial 0) ; chromium, green to yellowish green; and manganese, amethyst.
References
[1] C. A. Faick and A. N. Finn, The index of refraction of some soda-lime-silica glasses as a func tion of the composition, BS J . Research 6, 993 (1931) RP320; J. Am. Ceram. Soc. 7, 518 (1931).
[2] C. A. Faick, The visible absorption spect ra of glasses containing rare earth and other coloring oxides. Publication pending.
l3] R . Stair and W. W. Coblentz , Infrared absorption spectra of som e plant pigments, BS J. Research 11, 703 (1933) RP617.
[4] W. W. Coblent z, Constants of spectral radiat ion of a uniformly heated inclosure, or so-called black body, BS Bul. 10, 1 (1913) S204.
[5] W. W . Coblentz , Sensitivity and magnetic shielding test s of a Thomson galvanometer for use in radiometry, BS Bu!. 13, 423 (1916) S282.
l6] W. W . Coblentz, A portable vacuum thermopile, BS Sci. Pap. 17, 187 (1 921) S413.
[7] W. W. Coblen tz, Infrared transmission and refract ion data on standard lens a nd prism material, BS Sci. Pap. 16,701 (1920) S401.
[8] R. Stair and W . W. Coblen tz, Infrared absorption spectra of plan t and a nimal tissue and of various other substances, J. R esearch NBS 15, 295 (1935) RP830 .
J oUInal of Research
[9] Anna J. Harrison, Effect of water content on infrared t ransmission of simple gla se. Paper given before t he Glass Divisio n at t he Buffalo m eeting of t he Amer. Ceram. Soc. , May 1, H)46.
[10] C. C. Kiess, C. J . Humphreys, a nd D. D . Laun, Prelimina ry repo rt on t he descrip tion and analysis of t he first spectrum of uranium, J . Research N BS 37, 57 (1946) RP1729.
Rare Earth Oxide Glasses
[11] Woldema n A. Weyl, Colored glasses, J. Soc. Gla T ech . 28, 158 (19«4).
[12] John C. Young and Alfred N. F inn, E ffect of composit ion and other fac tors on t he specific refraction and dispersion of glasses, J. Research N BS 25, 759 (1940) RP1352.
WASHING'l.' ON, June 5, 1946.
101
top related