Tower 1 and B1&B2 - 29 Comments

7/30/2019 Tower 1 and B1&B2 - 29 Comments

1/22

S/N DESCRIPTION

1 BASEMENT-2

X X X X X X X X X X X X


X X X X X X X X X X X


X X X X X X X

X

X X

X X X X

2 BASEMENT-1


X X X X X X X X X X X XX X X X X X X X X X X


X X X X X X

X

X X

X X X X

3 LOWER GROUND FLOOR



X X X X X X X X X X XX X X X X X X X X X X

X X X X

X

X X

X X X X

4 GROUND FLOOR




X X X X X

X X X X

5 1st FLOOR TO 9th FLOOR


X X X X X X X X X X

X X X X X X X X X X

X X X X X

X X X X

APARTMENT A

RecallElevatortoGroundFloor

EvacuationMessagesthroughVASystemin

FlatUnits&LiftCorridors.

ActivationOfFIREALARMS

ounder/Bell

IndicationinMainMIMICPanelInFire

CommandCentreInTower-2

TroubleIndication&BuzzerinFACP-AIn

GroundFloorReceptionLob

by

SupervisoryIndication&Buz

zerinFACP-AIn

GroundFloorReceptionLob

by

AlarmIndicationinFACP-AInGroundFloor

ReceptionLobby

IndicationinMIMICPanelGroundFloor

ReceptionLobby

Activation of Manual Call Point

2nd Alarm Signal of FM200

First/Trouble Alarm Signal of FM200

TroubleIndication&BuzzerinMFACPInFire


Activation of Smoke Detector

EFFECTS

DESCRIPTION

Activation Of Water - FLOW SWITCH

Activation of Heat Detector (CP Ventilation)

Activation of Heat Detector





Activation of Heat DetectorActivation of Manual Call Point




Activation of Tamper Switch (Valve)

StopFreshAirFan-ROOF

CAUSE DESCRIPTION

AlarmIndicationinMFACPInFireCommand

CentreInTower-2






SIGNALtoFireBrigadeViaAutoDialer

AlarmsandTroubleMonitoringinBMSin

MainControlRoom

ATSChangeover&GeneratorStart-UP

ActivationOfFIREPUMP-EXHAUSTFANS.

SupervisoryIndication&Buz

zerinMFACPIn

FireCommandCentreInTower-2

ActivationOfCarParkVentilationSystem

(MFAF,MEF,JF)

StaircasePressurizationFan

s(ASPF-01,02)

ToOpenallAccessDoorsandGateBarrier














2/22

6 10th FLOOR


X X X X X X X X X X

X X X X X X X X X X

X X X X X

X X X X

7 ROOF FLOOR




X X X X XX X X X

8 COMMON

X X X X

X X X X

X X X X X

X X X X

X X X X

X X X X

Devices Trouble





Battery Failure

Power Failure

Network Failure

Short / Open Circuit

Grounding Fault








3/22

S/N DESCRIPTION

1 BASEMENT-2




X X X X X X X X X X X X X

X X X X X X X X X X X X X X X X X

X

X X

X X X X

2 BASEMENT-1






X

X X

X X X X







X

X X

X X X X

4 GROUND FLOOR





X X X X






X X X X




































TroubleIndication&BuzzerinM

FACPIn


TroubleIndication&BuzzerinF

ACP-AIn

GroundFloorReceptionLobby

SupervisoryIndication&BuzzerinMFACP

InFireCommandCentreInTow

er-2


SupervisoryIndication&BuzzerinFACP-A

InGroundFloorReceptionLobby




ActivationOfFIREALARMSou

nder/Bell


(MFAF,MEF,JF)

StaircasePressurizationFans(ASPF-01,02)



CAUSE DESCRIPTION

APARTMENT B

EFFECTS

DESCRIP

TION

AlarmIndicationinMFACPInF

ireCommand

CentreInTower-2

IndicationinMainMIMICPanel

InFire


AlarmIndicationinFACP-BInG

roundFloor

ReceptionLobby


ReceptionLobby

AlarmsandTroubleMonitoring

inBMSin

MainControlRoom


4/22

6 10th FLOOR





X X X X

7 ROOF FLOOR





X X X X

8 COMMON

X X X X

X X X X

X X X X X

X X X XX X X X

X X X X

Devices Trouble

Battery Failure

Power Failure

Network FailureShort / Open Circuit

Grounding Fault












5/22

S/N DESCRIPTION

1 BASEMENT-2






X

X X

X X X X

2 BASEMENT-1






X

X X

X X X X







X

X X

X X X X

4 GROUND FLOOR




X X X X X X X X X X X X X X X X

X X X X






X X X X





























ATSChangeover&Generator

Start-UP








TroubleIndication&BuzzerinMFACPIn


TroubleIndication&BuzzerinFACP-AIn

GroundFloorReceptionLobby



er-2


SupervisoryIndication&BuzzerinFACP-A

InGroundFloorReceptionLobby




ActivationOfFIREALARMSou

nder/Bell


(MFAF,MEF,JF)

StaircasePressurizationFans(

ASPF-01,02)



CAUSE DESCRIPTION

APARTMENT C

EFFECTS

DESCRIP

TION


ireCommand

CentreInTower-2



AlarmIndicationinFACP-CInG

roundFloor

ReceptionLobby

IndicationinMIMICPanelGrou

ndFloor

ReceptionLobby


inBMSin

MainControlRoom


6/22

6 10th FLOOR





X X X X

7 ROOF FLOOR





X X X X

8 COMMON

X X X X

X X X X

X X X X X

X X X XX X X X

X X X X

Devices Trouble

Battery Failure

Power Failure

Network FailureShort / Open Circuit

Grounding Fault












7/22

S/N DESCRIPTION

1

X X X X X X X X X X X X X X X




X X X X X X X X X X X X X X X X X X X

X

X X

X X X X

2






X

X X

X X X X

3




X X X X X X X X X X X X X X X X X X

X X X X

X X X

4





X X X X X X X X

X X X

5





X X X X X X X X

X X X







BASEMENT-2

1ST & 2ND FLOOR

BASEMENT-1



GROUND FLOOR






3RD FLOOR

Failure Of Openable Window Panel


inBMSin

MainControlRoom

SupervisoryIndication&Buzze

rinMFACP

InFireCommandCentreInTower-2


Activation of Heat Detector (CP Ventlation)

CAUSE DESCRIPTION

TOWER-1

AirHandlingUnitOfAffectedFloor

TreatedFreshAirHandlingUnit


Start-UP

ROOFFreshAirFan(FAF)Sto

p

ActivationOfFirePumpExhaustFans





(MFAF,MEF,JF)


ToOpenallAccessDoorsand

GateBarrier


ireCommand

CentreInTower-2




EFFECTS

DESCRIP

TION






Offices&LiftCorridors.

ActivateOpenableWindowate

veryoffice

floor

IndicationinMIMICPanel1stB

asement

ControlRoom

LiftLobbyPressurizationFan(LPF-01,02)

LiftShaftPressurizationFan(LSPF-01,02)

ActivationOfFIREALARMSOUNDER/

ALARMBell
















8/22

S/N DESCRIPTION AlarmsandTroubleMonitoring

inBMSin

MainControlRoom

SupervisoryIndication&Buzze

rinMFACP

InFireCommandCentreInTower-2


CAUSE DESCRIPTION

TOWER-1




Start-UP

ROOFFreshAirFan(FAF)Sto

p






(MFAF,MEF,JF)



GateBarrier


ireCommand

CentreInTower-2



EFFECTS

DESCRIP

TION



ActivateOpenableWindowate

veryoffice

floor

IndicationinMIMICPanel1stB

asement

ControlRoom



ActivationOfFIREALARMSOUNDER/

ALARMBell

6





X X X X X X X X

X X X

7





X X X X X X X X

X X X

8





X X X X X X X X

X X X

9





X X X X X X X X

X X X

10





X X X X

11

X X

X X

X X X

X X

X X

Devices Trouble


4th FLOOR

ROOF & UPPER ROOF

17th FLOOR

5th to 16th FLOOR









18th FLOOR



COMMON








Battery Failure

Power Failure

Network Failure














9/22

S/N DESCRIPTION

1






X

X

X X X X

2






X

X

X X X X

3





X X X X

X X X

4





X X X X X X X X

X X X

5





X X X X X X X X

X X X


3RD FLOOR











1ST & 2ND FLOOR




GROUND FLOOR

Activation of Smoke DetectorActivation of Heat Detector











CAUSE DESCRIPTION

TOWER-2


BASEMENT-1

ROOFFreshAirFan(FAF)Stop

AirHandlingUnitOfAffectedFlo

or

ActivationOfFIREALARMSOU

NDER/

ALARMBell

ActivationOfCarParkVentilatio

nSystem

(MFAF,MEF,JF)

StaircasePressurizationFans(A

SPF-01,02)




MainControlRoom



LiftShaftPressurizationFan(LS

PF-01,02)

ToOpenallAccessDoorsandG

ateBarrier

ActivateOpenableWindowateveryoffice

floor


BASEMENT-2









EvacuationMessagesthroughV

ASystemin


EFFECTS

DESCRIPTION

AlarmIndicationinMFACPInFire




IndicationinMIMICPanel1stBasement

ControlRoom


FACPIn


SupervisoryIndication&Buzzer

inMFACP


er-2


10/22

S/N DESCRIPTION

CAUSE DESCRIPTION

TOWER-2


AirHandlingUnitOfAffectedFlo

or

ActivationOfFIREALARMSOU

NDER/

ALARMBell

ActivationOfCarParkVentilatio

nSystem

(MFAF,MEF,JF)

StaircasePressurizationFans(A

SPF-01,02)




MainControlRoom



LiftShaftPressurizationFan(LS

PF-01,02)

ToOpenallAccessDoorsandG

ateBarrier


floor



EvacuationMessagesthroughV

ASystemin


EFFECTSDESCRIPTION






ControlRoom


FACPIn


SupervisoryIndication&Buzzer

inMFACP


er-2

7





X X X X X X X X

X X X

8




X X X X X X X X X

X X X X X X X X

X X X

9





X X X X X X X X

X X X

10





X X X X X X X X

X X X

11





X X X X X X X X

X X X

12





ROOF & UPPER ROOF

21st FLOOR





Activation Of Water FLOW SWITCH








20th FLOOR













19th FLOOR






6th to 18th FLOOR


5th FLOOR





11/22

S/N DESCRIPTION

1






X

X X

X X X X

2X X X X X X X X X X X X X X X





X

X X

X X X X

3

X X X X X X X X X X X X X X X XX X X X X X X X X X X X X X X



X X X X

X X X

4





X X X X X X X X

X X X

5





X X X X X X X X

X X X

1ST & 2ND FLOOR




Activation Of Water - FLOW SWITCHActivation of Tamper Switch (Valve)


3RD FLOOR







BASEMENT-1Activation of Smoke Detector








GROUND FLOOR






CAUSE DESCRIPTION

TOWER-3

EFFECTS

DESCRIPT

ION

ActivationOfCarParkVentilation

System

(M

FAF,MEF,JF)

StaircasePressurizationFans(AS

PF-01,02)

LiftLobbyPressurizationFan(LPF

-01,02)

LiftShaftPressurizationFan(LSP

F-01,02)



floor

EvacuationMessagesthroughVA

Systemin

O

ffices&LiftCorridors.

BASEMENT-2










ActivationOfFirePumpExhaustF

ans

A

TSChangeover&GeneratorStart-UP


M

ainControlRoom



ActivationOfFIREALARMSOUN

DER/

ALARMBell

ToOpenallAccessDoorsandGa

teBarrier


Command

CentreInTower-2

In

dicationinMainMIMICPanelIn

Fire


In

dicationinMIMICPanel1stBasement

ControlRoom

TroubleIndication&BuzzerinMF

ACPInFire


SupervisoryIndication&Buzzerin

MFACPIn




12/22

S/N DESCRIPTION

CAUSE DESCRIPTION

TOWER-3

EFFECTS

DESCRIPTION

Ac

tivationOfCarParkVentilationSystem

(M

FAF,MEF,JF)

StaircasePressurizationFans(AS

PF-01,02)

LiftLobbyPressurizationFan(LPF

-01,02)


SIGNALtoFireBrigadeViaAutoD

ialer

Ac

tivateOpenableWindowateveryoffice

flo

or

Ev

acuationMessagesthroughVA

Systemin



Ac

tivationOfFirePumpExhaustF

ans



MainControlRoom



Ac

tivationOfFIREALARMSOUN

DER/

AL

ARMBell

To

OpenallAccessDoorsandGa

teBarrier


Command

CentreInTower-2

IndicationinMainMIMICPanelIn

Fire



ControlRoom

TroubleIndication&BuzzerinMFACPInFire


Su

pervisoryIndication&Buzzerin

MFACPIn



8





X X X X X X X X

X X X

9





X X X X X X X X

X X X

10





X X X X X X X XX X X

11





X X X X X X X X

X X X

12

X X X X X X X X X X X XX X X X X X X X X X X X



X X X X

13

X X

X X

X X X

X X

ROOF & UPPER ROOF





COMMON

Devices Trouble

Battery Failure

Power Failure

Network Failure

20th FLOOR





Activation of Tamper Switch (Valve)Failure Of Openable Window Panel

21st FLOOR







6th to 18th FLOOR







19th FLOOR







13/22

S/N DESCRIPTION

1

X X X X X X X X X

X X X X X X X X X

X X X X X X X X

X X X X

X

X

X X X X

2

X X X X X X X X X

X X X X X X X X X

X X X X X X X X X

X X X X

X

X

X X X X

3

X X X X X X X X

X X X X X X X X

X X X X X X X X

X X X X X

X X X X

X X

4

X X X X X X X X

X X X X X X X X

X X X X X X X X

X X X X

X X X X

5

X X

X X

X X X

X X

X X

X X

COMMON

Devices TroubleBattery Failure

Power Failure

Network Failure


Grounding Fault

ROOF & UPPER ROOF






GROUND FLOOR












SIGNALtoFireBrigadeViaAu

toDialer


BASEMENT-1



EFFECTSDESCRIPTION


CentreInTower-2

IndicationinMainMIMICPane

lInFire



Office



inBMSin

MainControlRoom

ActivationOfFIREALARMSO

UNDER/

ALARMBell

CAUSE DESCRIPTION

BASEMENT-2


(MFAF,MEF,JF)


GateBarrier

UTILITY

TroubleIndication&Buzzerin

MFACPIn

FireCommandCentreInTowe

r-2


InFireCommandCentreInTo

wer-2





ActivationOfFirePumpExhau

stFans

EvacuationMessagesthrough

VASystem


14/22

S/N DESCRIPTION1

X X X X X X X X X

X X X X X X X X X

X X X X X X X X X

X X X X X

X X X X

X X

2

X X X X X X X X X

X X X X X XX X X X X X

X X X X X

X X X X X

X X X

5

X X X X X X X X X

X X X X X X X X X

X X X X X X X X X

X X X X X

X X X X X

X X X

6

X X X X X X X X X

X X X X X X X X X

X X X X X X X X X

X X X X X

X X X X X

X X X

7

X X X X X X X X X

X X X X X X X X X

X X X X X X X X X

X X X X X

X X X X X

X X X

8

X X X X X X X X X

X X X X X X X X X

X X X X X X X X X

X X X X X

5th FLOOR




Activation Of Water FLOW SWITCH

4th FLOOR







3rd FLOOR







2nd FLOOR







1st FLOOR






GROUND FLOOR







CAUSE DESCRIPTION

CARPARK

EFFECTSDESCRIPT

ION

A

larmIndicationinMFACPInFire

Command

C

entreInTower-2

IndicationinMainMIMICPanelIn

Fire

C

ommandCentreInTower-2

IndicationinMIMICPanelGround

Floor

C

ontrolRoom

A

ctivationOfFIREALARMSOUN

DER/

A

LARMBell

T

oOpenallAccessDoorsandGa

teBarrier

T

roubleIndication&BuzzerinMF

ACPInFire

C

ommandCentreInTower-2

S

upervisoryIndication&BuzzerinMFACPIn

F

ireCommandCentreInTower-2

R

ecallElevatortoGroundFloor

E

vacuationMessagesthroughVA

Systemin

O

ffices&LiftCorridors.

S

IGNALtoFireBrigadeViaAutoDialer

A

ctivationOfFirePumpExhaustFans

ATSChangeover&GeneratorSt

art-UP

A

larmsandTroubleMonitoringin

BMSin

M

ainControlRoom


15/22

S/N DESCRIPTION

1



X X X X X X X X X

X X X X

X

X

X X X X

2




X X X X

X

X

X X X X

3




X X X X X X XX X X X

X X

4


X X X X X X X X

X X X X X X X X

X X X X X X X

X X X X X X X

X X X

5




X X X X X X X

X X X X X X X

X X X

6



4th FLOOR



1ST & 2ND FLOOR







3RD FLOOR FLOOR







BASEMENT-1







GROUND FLOOR






CAUSE DESCRIPTION

RECREATION BUILDING

EFFECTS

DESCRIPTION


CentreInTower-2

IndicationinMainMIMICPane

lInFire


IndicationinMIMICPanelLow

erGround

ControlRoom

TroubleIndication&Buzzerin

MFACPIn

FireCommandCentreInTowe

r-2


InFireCommandCentreInTo

wer-2

RecallElevatortoGroundFloo

r

EvacuationMessagesthrough

VASystemin


BASEMENT-2








SIGNALtoFireBrigadeViaAu

toDialer

ActivationOfFirePumpExhau

stFans



inBMSin

MainControlRoom

AirHandlingUnitOfAffectedF

loor

ActivationOfFIREALARMSO

UNDER/

ALARMBell


(MFAF,MEF,JF)


GateBarrier

TreatedFreshAirHandlingUn

it


16/22

X X X X X X X

X X X

7




X X X X X X XX X X X X X X

X X X

8




X X X X X X X

X X X X X X X

X X X

9




X X X X X X X

X X X X X X X

X X X

10




X X X X X X X

X X X X X X X

X X X

11




X X X X X X X

X X X X X X X

X X X

12

X X X X X X X X X

X X X X X X X X X

X X X X X X X X X

X X X X

X X X X

13

X X

X X

X X X

X X

X X

X X

ROOF & UPPER ROOF






COMMON

Devices Trouble

Battery Failure

Power Failure

Network Failure

Short / Open CircuitGrounding Fault

20th FLOOR






21st FLOOR







6th to 18th FLOOR







19th FLOOR









5th FLOOR







17/22

Updated : 22 November 2011

Item Deficiencies/Deviations/Directions AEB Supervising Consultant Response/Remarks Midmac & Samko/Fire Specialists

1 Submit the complete sheets of CDD approved plans of Tower 1 ( Architectural, Fire Alarm, Fire Fightingand ACMV ) CD copy.

Refer to Soft Copy of Architectural and Fire Alarm

Drawings. ( HVAC No CDD approved drawing). FireFighting Drawing /Justification submitted to CDD for

Approval.

2No designated Fire Engine Hard standing. of 6m x 15m ( minimum ), with longer side parallel to the

faade of the building provided ( Tower 1 ).Done - See Attached Photo

3

Fireman's access panel shall be provided with either a red or orange triangle of equal sides ( minimum

150mm on each side), which can b upright or inverted, on the external side of the building wall and

wordings "Fire Fighting Access - Do not Obstruct" of at least 25mm height on the internal side ( Tower 1

).

Done See Attached Photo

* Fire department access panel shall be tempered glass ( NFPA 5000, Chapter 39, Section 46.5.31 ).

4 Justify the rating of double swing glass doors at the lift lobby of Basement levels 1 & 2.AEB actions to justify fire rating of double swing glass

doors in lift lobby.Done - See Attached Documents

5Justify the installation of non fire rated sliding glass window in aluminum frames within the exit staircase

enclosure at the roof top level of Tower 1.

AEB confirmed the CDD requirements to be executed by

MidmacDone - See Attached Photo

6 Justify un-enclosed electrical equipments inside the exit staircase at the top most level of Tower 1.As per IFC design layouts - the MCC Panels must be

totally enclosed on staircase landing.

Refer to Attached Sketch Proposal & CDD approved Architectural

Layout; AEB design layout with MCC Panel.

7

All vertical and horizontal penetrations or openings on the fire rate walls / slabs particularly exit access

corridor, fire fighting / smoke - stop lobby, electrical room, shall be sealed with approved CDD fire

stopping materials.

This is similar to CDD comments at Apartments; AEB request

Midmac to provide letter of confirmation for the works

performed in accordance to CDD approved methodology and

approved materials.

Done - See Attached Photo

8 No testing of fire fighting system at the time inspection.

* Justify reducing the capacity of fire pumps serving basement 1 and basement 2 as indicated in the CDD

approved plan 528-MP-M-FF-004 ( 8 of 9 ) dated April 10, 2011 should be 1900 GPM. During inspection it

was found out the pump capacity is 1000 GPM. "As Built" drawings including justification shall be

submitted in the CDD Planning Section for evaluation and approval.

AEB uploaded the justification of using 3-numbers Fire

Pumps to CDD Planning Section . Awaiting Approvalfrom CDD.

9 Provide automatic suppression system in the storages at basement level.

AEB to check and verify CDD approved plans for storage

rooms are equipped with automated suppression

system at basement areas.

Store provided with Sprinkler System - Refer to Attached Photo

10 Justify non provision of sprinkler system in the Ground Floor and 1stFloor Offices of Tower 1.

As per CDD approved plans for General Towers at

Ground & 1st floor provision of fire sprinklered

system; however the CDD requirements will be carried

out by ID Fit-out tenancy works.

11Provide proper directional arrows and identification of each zone control valve, riser and piping which

are serving.Done - See Attached Photo

12 Some sprinkler heads were still provided with protected seal at the time of inspection. Done - See Attached Photo

5-Oct-11

Reference FPD INSP - 782/11 CDD FILE NUMBER 22580


18/22

13

It was noted that there were a lot of Common & Supervisory Fault / Trouble at FACP. Rectify the system

and restore to normal operating condition. Submit Record of Completion duly acknowledged, signed /

stamped by the supervising consultant.

Supervisory fault still experienced at the Apartment Buildings are

operational and at many occasions valves are being closed by the

Facility maintenance team/tenants which is causing common

faults.

14 Justify non provision of evacuation message through PS System in Offices and Lift Corridors in Tower 1. Done - Refer to attached T & C Report

15 Justify non provision of detection system in the Ground Floor and 1st Floor Offices of Tower 1.Similar comment as Item-10 to be carried out by ID Fit-

out tenancy works.

16Provide Duct Smoke Detector in the air supply to the pressurized stairwell. On detection of smoke in the

air supply, the supply fan (s) shall be stopped ( as per NFPA 92A).AEB verified the CDD requirements to provide Done - See Attached Photo

17

Submit the update Cause and Effect Matrix showing the sequence of operation of all the system related

to LIFE, SAFETY & FIRE PROTECTION indicating what will occur during fire alarm activation / simulation.

Shall be acknowledged, signed / stamped by supervising consultant.

AEB will update the Cause and Effect Matrix for

Midmac & Samko with all fire specialists to perform

the sequence of operation of the Smoke Management

System

> Submit fire strategy report detailing the sequence of operation of the smoke management system

18

A/C units for all FM 200 protected areas shall be interfaced or associated with the Control Panel. Split

type A/C units at Qtel room did not shut down upon activation of alarm for FM 200 System at the time of

inspection.

AEB requested for a dialogue session with NAFFCO

specialist for technical clarification and justify CDD

requirement for implementation inside all FM-200

system rooms.

Works in Progress to be Completed by 15 December 2011.

19Local fire alarm bells installed inside the enclosed rooms protected by FM 200 system shall be relocated

outside and it will activated.Similar to Item-18 Works in Progress.

20Justify the resume normal operation of all elevators / lifts after resetting the FACP. It should be at lift

machine room.

AEB requested Midmac & ETA to justify CDD comments

necessary to provide.Done - See Attached Photo

21Smoke management system testing at Basement Level 1 & 2 was not satisfactory at the time of

inspection.

* Some supply and exhaust fans not interfaced at FACP working during testing at fire mode.System tested and inspected on 21.11.2011 , However one Fan

found not working; Rectifications work in progress.

* Justify non provision of manual override for the smoke management system at FCC.

Midmac & Samko to provide the basement smoke management

schematic diagram operating as individual system; and provide

justification overall manual over-ride at Main Fire Command

Centre. Works in progress and expected to complete by

30.11.2011.

* Justify the efficiency of jet fans of basement ventilation system since there are a lot of obstructions.Done - Guide Vanes provided on Jet Fans by the Specialist

(Systemair) - refer to attached Letter.

22

Submit CFD analysis and calculation for Basement Ventilation System ( Sufficient make up air should be

provided to satisfy the exhaust requirements and attain a 10 ACH at fire mode and 4 to 6 ACH at normal

mode).

AEB requested Specialist - Systemair to examine the

CFD Analysis as per CDD requirements for confirmation

reply to CDD

Done - Refer to attached CFD Analysis and Calculations in Soft

Copy.( CD)

23 Interfacing of escalator to FACP was not yet demonstrated at the time of inspection.

AEB to review CDD requirements for the installed

outdoor escalators (ground level) to be interfaced with

FACP.

Interfacing control cables for CDD requirements of Escalators

linked with main FACP- Escalator panel in progress. Work schedule

to be completed on 30.11.2011.

Done - Refer to Updated |Cause and Effect Matrix


19/22

24Data tabulation for pressurization system ( Staircase Pressure Differential ) of staircases and f ire lift lobby

per floor shall be acknowledged, signed / stamped by supervising consultant ( for Tower 1 ).

AEB confirmed receipt of test report conducted with

Staircase Pressurization System; but the Fire Lift Lobby

test reports for Tower-1/2/3 still outstanding.

Data Tabulation for Staircase Pressurization - Refer to attach

Report. Fire Lift Lobby Pressurization System for Tower -1/2/3 by

30.11.2011.

25 The independent ventilation system at FCC shall be connected to Emergency Power Supply System.

AEB request for submission of Emergency Power Single

Line Diagram related to installed Split Air-ConditioningUnits in the FCC room complete with room layout

defining the indoor fan coil units locations.

Done - Refer to attached Diagram.

26Some identification markings for mechanical equipment rooms, shafts ( exhaust & fresh air ) and other

important building services / rooms shall be provided.Done - Refer to attached Photos.

27 FM 200 System shall comply to the requirements as follows: Done - See Attached Photo

* Caution signs shall be provided outside the protected areas of FM 200 System "This room is protectedwith FM 200 System ; Do Not Enter In Case of Alarm".

As per CDD requirements, the caution signs must be

visible, 100mm height and installed outside protected

rooms of FM-200 System

Done - See Attached Photo

* Manual Pull Station shall be provided with proper label " Manual Gas Release Station" and should

have protective cover for accidental release of agent and tampering.

As per CDD requirements, the caution sign must be

provided with proper label wordings complete with

protective cover against accidental release of agent

and tampering/vandalism act.

Midmac to provide CDD requirements accordingly with the correct

identification words; however NAFFCO confirmed not required.

* A manual mechanical means of discharging the required agent shall be provided on the storage

container.Done - See Attached Photo and Material Brochure.

* The Control Panel shall be connected to the Buildings Main Fire Alarm Panel and shall provide Alarm,

Gas Discharged and Fault indications on the Main Panel.Only one alarm is provided - Print Out Attached.

* The activation of Abort Button during second alarm will stop the countdown t imer and as soon abort

button is released, the discharged delay countdown will restart at the preset duration.Done- refer to attached drawing.

28

Functional test of ATS for power change-over of Kahramaa to Emergency Power Supply System /

Generator Set ( EPSS ) and vice versa initiating an alarm ( Life Safety & Fire Protection ) with essential

loads connected shall be witnessed by QCDD.

This CDD comment is related to the basement

ventilation system under fire scenario activation and

local Kahramaa electricity supply failure shall require

the auto-transfer power to the emergency generator

system serving all fire fighting systems.

Done - Refer to attached T & C Report

29

Submit testing, commissioning and acceptance data report of Fire Alarm and Detection System, Fire

Fighting System, Smoke Control and Ventilation System and lift operations done by the contractors duly

acknowledged by the supervising consultants for Tower 1, Basement 1 & 2.

Similar Item-28 but to include Lifts System integration

report under fire scenario activation.

Refer to attached T & C Report for Smoke Control and Ventilation

System ; Lift Load Test Report.


20/22

July 16 2011

CDD REQUIREMENTS FOR SUBMISSION-INSPECTION

S/N

AEB SUBMISSION

REQUIRED

MIDMAC SUBMISSION

REQUIRED

AEB HEAD OFFICE

SUBMISSION REQUIRED

1

CDD approved plans are

included in application; refer

to attached material

certificates for FM 200 & Fire

extinguisher

2

Midmac to submit all

reports and include

test/commissioning for fire

protection, fire alarm &

voice evacuation, fire

pumps, FM-200, lifts,

smoke control & ventilation

systems

3See attached scan approved

CDD drawings.

4

Midmac to submit all

battery calculations for fire

alarm system, FM 200,

voice evacuation system.

5Midmac to submit all test

reports for fire sprinkler

system

6Test in progress - Midmac

to compile and submit all

tests

7

Complete Hydarulic Flow

calculations of FM-200System.

8 Midmac submitted .

9

Fault signal correctly registered at control panel/sub-main fire alarm panel

a) Audible fault alarm and fault indicator functioning

b) FM200 must be integrated also with main fire alarm. All ventilation must automatically shut down during the alarm.

10Midmac to submit all T & C

reports

Submit the complete sheets of CDD approved plans and CDD approved product certificate for Automatic Dry Powder Fire

Extinguisher System, FM 200 system and other gaseous system (if any)

Submit testing, commissioning, acceptance report (w/procedure/methodology), sequence of operation of fire protection

system, fire detection and alarm system including the communication and voice evacuation system, fire pumps including its

control, FM-200 Automatic Dry Powder Fire Suppression system, lifts and smoke control and ventilation system done by

the contractor duly approved, acknowledged by supervising consultant.

Submit detailed lift sections and lay-out plan on how to ccess the fire lift and its accessibility on all floors.

Provide calculations for battery stand-by power supply taking into consideration the power requirements of all alarms,

initiating devices and auxiliary components under full load conditions for Fire Detection & Alarm System, FM 200 System

and other systems.

Note that all rooms with FM-

200 are not provided with

ventilation, instead split a/c

units installed.

Midmac to perform the test

required and submit the

test report with

endorsement.

Submit hydrostatic pressure testing and flushing report for the sprinkler system done by the contractor and witnessed,

acknowledged, signed/stamped by the supervising consultant.

Submit tabulation of pressurization system (Staircase Pressure Differential, fire lift lobby, smoke stop lobby) per floor.

Submit complete hydraulic flow calculations of FM-200 automatic fire suppression system. The individual sections of pipe

and each fitting to be uised, as shown on the isometrics, must be identified and included in the calculation. Total agent

discharge time must be shown and detailed by zone and calculations for battery stand-by power supply taking intoconsideration the power requirements of all alarms, initiating devices and auxiliary components under full load conditions of

FM-200 system.

Submit enclosure integrioty test report for FM 200 system. The test shall be conducted by a qualified tester acceptable to

the QCD.

Submit FM 200 Testing and alarms report - Simualtion test for the 1st mode and 2nd mode and test on electrical

supervision system (simulate fault by disconnecting any detector/devioce connected to the f iring circuit). Following shall be

satisfied:

Submit the fire pumps sequence of operation, test report to evaluate its performed through the flow meter on its rated/peak

flow and pressure.


21/22

11

Midmac to submit omplete

Fire Pump test reports

including performance

curve and hydraulic

calcualtions.

12 Calculations are provided &available.

13

14

15Midmac to provide

certificate for glass

composite

16

17

18

mac o su m

test/commissioning report

of generator running at full

19

Midmac to submit

test/commissioning report

of ATS change-over & vice

versa with generatorconnected with essential

loads

20 See attached documents


22 See attached documentsCDD format for AEB

endorsement - structural

declaration


24

a) Flush bolts for doors (auto per 7.2.1.5.10) locks shall not require use of key (7.2.1.5.2)a) Access Control

schematic

b) Location of latches (7.2.1.5.9.1)

c) Physical barrier fr. BFL to GFL discharge See attached documents

See attached documents

25 Complied; see attached liftdetails.

26 Staircase pressurization/smoke purging system.

a) Fire rated cables per NFPA 70. a) See attached documents.

b) Motorized pressure relief dampers w/ DPS (measure change pressure across doors). b) Midmac to provide.

Submit proof of certification that smoke exhaust duct thickness have an appropriate fire resistance rating to withstand

temperature of smoke to ensure reliability at the design temperature and length of exposure.

Submit the Fire Strategy Report for the Smoke Prging System / Management Systems.

Submit the Cause and Effect Matrix showing the sequence of operation of all the system related to LIFE SAFETY & FIRE

PROTECTION indicating what will occur during f ire alarm activation/simulation.

Submit the Single Line Diagram of EPSS (Emergency Power Supply System) and test/commissioning report of generator

running on its full load with essential load connected.

Submit functional test of ATS for power change-over of Kahramaa to emergency power supply system (EPSS) and vice

versa initiating an alarm (Life Safety & Fire Protection) with essential loads connected and test shall be witnessed by

QCDD.

Fireman lifts - protected against H2 0 per 101 7.2.13.6

Submit fire pumps test performance curve on which the system curve and duty point (100% & 150% data) together with

hudraulic calculations of the sprinkler system.

Exit Discharge - panic hardware (no locks)

Submit letter of confirmation from the supervising consultant stating that approved fire stopping materials were used in all

penetrations for protected areas (attached product catalogue/brochure) with accredited applicators.

Submit calculation for the duration of fire water storage tank (excluding freeboard) in relation with the fire pump capacity.

Submit Test Report for the composite glass panels used in the curtain wall/faade (shall not have plastic

materials/combustible core)

Submit site development plan showing the access way of fire apparatus, various provisions of breeching inlets and fire

hydrants.

Fire engine hardstanding access roads shall be kept clear of obstructions with vertical clearance of 4.5 meters and clear

width of 4.0 meters.

Provide fire engine hardstanding certificate showing the ground floor slab is capable of carrying an imposed stationary load

of 45 Tons.

Site Access - Fire Engine Hardstanding.

d) handrails (760 mm ) of all portions of required egress width of stairs - the egress width shall be provided along the

natural path of travel (7.2.2.4.2 - handrails)


22/22

c) Manual override system @ FCC c) Midmac to provide

d) Smoke vents (listed, visual insp., fail safe, auto open, override etc. - NFPA 704 - 5.1, 5.2.4/5.3 d) Refer to matrix table.

27 FCC room.

a) Fire resistance rating (ext.) a) See attached documents

b) Manual override for energy fans

c) EPSS annunciators/indicator

c) refer to genset control

panel signal to FACPd) Etc.

28 AEB HO to provide

29 Fire pump room

a) Ventilation

b) Fire telephone b) Complied

c) Fuel tank for diesel pump c) Complied

d) Ventilcation for tank d) Complied

NOTE : Midmac to submit allcalibrated certificates for

actual test of systems.

Midmac to submit fire

pump room layout c/w all

items required by CDD

Midmac to submit fire

command center layout c/w

all items required by CDD

Fire strategy report (evacuation plan)

All calibrated equipments/tools necessary for the actual test of the system such as manometer, anemometer, cold smoke

generator, techometer, volt-meter/multi-tester, etc. shall be available on site.