The Heat of Vaporization of Nicotine from Tobacco Kelley St.Charles 1 , Serban Moldoveanu 2 1) Consultant to R.J. Reynolds Tobacco Company 2) R.J. Reynolds Tobacco Company, Winston-Salem, NC 1 Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015 2015_TSRC33_StCharles.pdf TSRC2015(69) - Document not peer-reviewed
21
Embed
The Heat of Vaporization of Nicotine from Tobacco · The Heat of Vaporization of Nicotine from Tobacco Kelley St.Charles1,Serban Moldoveanu 2. 1) Consultant to R.J. Reynolds Tobacco
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
The Heat of Vaporization of Nicotine
from Tobacco
Kelley St.Charles 1, Serban Moldoveanu 2
1) Consultant to R.J. Reynolds Tobacco Company 2) R.J. Reynolds Tobacco Company, Winston-Salem, NC
1Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Introduction
2Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
• Follow up to 2014 TSRC Paper*• Nicotine vapor pressure at 23 ºC measured• Pure nicotine and multiple tobacco types• Vapor pressure since measured at higher
temperatures
*K. St.Charles & S. Moldoveanu, Nicotine activity in tobacco. Paper # 40.
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Introduction
Clausius-Clapeyron Equationln(P) = - ΔHvap /RT + C
P = Vapor Pressure (any pressure units)ΔHvap = Heat of vaporization* (J/mol)R = Gas Constant (8.314 J/K/mol)T = Absolute Temperature (K)C = Unitless constant
3Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
* Enthalpy of Vaporization or Sublimation
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Experimental
4Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Rearranged Clausius-Clapeyron Eqn.
5Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
ln(P) = (-ΔHvap/R) * 1/T + C
• Vapor P measured at 23, 30, 40 ºC• Linear regression of ln(P) versus 1/T• Slope = -ΔHvap/R• ΔHvap = - Slope * R
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Experimental summary
• Details in 2014 presentation• Used pure nicotine and multiple tobacco types• Samples stored in Al-foil lined gas bags with septum• Diaphragm pump to sample 2 L headspace (HS) from
tobacco• 10 mL gas-tight syringe to sample pure nicotine HS• HS sampled through XAD-4 cartridge similar to ETS
nicotine• Pure nicotine HS also sampled directly in syringe
containing extraction solution
6Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Experimental summary (cont.)
• Analysis by GC/MS/MS– Ethyl acetate solvent with 5000 ppm triethylamine– Deuterated nicotine (methyl -d3) internal standard– MRM Nicotine m/z 162 → 84 & m/z +3 for internal standard– 30 minute run time
• Calibration from 4.2 – 2140 ng/mL nicotine
• Signal to noise = 240 @ 8.3 ng/mL
7Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Foil-lined gas bag modified• 1/8” stainless steel Swagelok® union replaced
Restek® polypropylene septum holder– Bulkhead union nut inside bag– PTFE lined septum replaced back ferrule outside bag
• Outer changed to Sorbent Systems bag– 5 mil (127 µm) thick, 4-layer film: PET/PE/Al foil/PE– ~20 x 25 cm (nicotine HS) & 40 x 50 cm (tobacco HS)
• Heavy-duty Al foil (~23.5 µm) inner liner– Added Al tape to reinforce foil at union penetration– Edges double folded and reinforced with Al tape– Tested heavier gauge foil with pure nicotine
8Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Tobacco headspace sampling
9Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
Needle
XAD-4Cartridge
½ of size 6D Silicone Stopper
4.8 ID x 7.9 OD mm Tubing
4.8 x 7.9 mm Tubing
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Tobacco types
Conditioned to water activity = 0.61Used 50+ g per bagBags filled with nitrogen
10Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Results
11Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Pure nicotine vapor pressure
XAD-4 = 62% of in-syringe sampling
12Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
2015
_TS
RC
33_S
tCha
rles.
pdf
TS
RC
2015
(69)
- D
ocum
ent n
ot p
eer-
revi
ewed
Pure nicotine resultsIn-syringe comparison to published results
A. Harlan & Hixon. Ind Eng Chem. 1928, 20(7): 723–724.
B. Walker et al. Chem Senses. 1990, 15(2): 165-177
C. Norton et al. J Amer Chem Soc. 1940, 62: 261-264.
D. Boldridge & Kelly. 1988. Eqn. 6. http://legacy.library.ucsf.edu/tid/usx83d00/pdf
E. Johnson. 1990, Eqn. 2. http://legacy.library.ucsf.edu/tid/fma51f00/pdf
F. Banyasz. 1999. Eqn. 2. in: Analytical determination of nicotine and related compounds and their metabolites. p.153
13Tobacco Science Research Conference, Naples, FL, Sept. 20-23, 2015
Linear Regression ofln P vs 1/TR2 = 0.9995
ΔHvap = 56.6 kJ/mol
Ref A = 64.4 kJ/molRef D = 72.3 kJ/molRef E = 82.4 kJ/molRef F = 65.0 kJ/mol