SERVICE MANUAL US Model Canadian Model AEP Model UK … - XM-7547_Car Power Amplifier SM.pdf · 2020. 10. 27. · XM-7547 10 10 5-4. PRINTED WIRING BOARD – LED/FILTER SECTION –

1

MICROFILM

XM-7547US Model

Canadian ModelAEP Model

UK ModelE Model

SPECIFICATIONS

SERVICE MANUAL

STEREO POWER AMPLIFER

2

TABLE OF CONTENTS

1. SERVICE MODE ............................................................. 3

2. GENERAL .......................................................................... 4

3. DISASSEMBLY3-1. Side Plate and Filer Board .................................................... 73-2. Amplifier/Power Board and LED Board .............................. 7

4. ELECTRICAL ADJUSTMENT .................................... 7

5. DIAGRAMS5-1. Block Diagram – Amplifier Sction – .................................... 85-2. Block Diagram – Power Section – ........................................ 95-3. IC Block Diagram ............................................................... 105-4. Printed Wiring Board – LED/Filter Section – ..................... 105-5. Schematic Diagram – Filter/Amplifier (1/3) Section – ....... 115-6. Printed Wiring Board – Amplifier Section – ....................... 125-7. Schematic Diagram – Amplifier (2/3) Section – ................. 135-8. Schematic Diagram

– Power/Amplifier (3/3)/LED Section – ............................. 145-9. Printed Wiring Board – Power Section – ............................ 15

6. EXPLODED VIEWS6-1. Plate and Cover Section ...................................................... 176-2. Board and Heat Sink ........................................................... 18

7. ELECTRICAL PARTS LIST ........................................ 19

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

3

SECTION 1SERVICE NOTE

Clearing the Protector During Repairs• OVER CURRENT : Detects overcurrent during output.• OFF SET : Detects DC offset at the speaker terminal.

1. Clearing the OVER CURRENT protector1 When the position of the MODE switch (S801/power board)

is set to HI-VOLTAGE :Cut the jumper wire JW535 of the amplifier board.

2 When the position of the MODE switch (S801/power board)is set to HI-CURRENT :Cut the jumper wire JW690 of the amplifier board.

2. Clearing the OFF SET protector• Cut the jumper wire JW502 of the amplifier board.

3. TEST TONE Function1 Press the TEST TONE button (S851/amplifier board) with the

power ON. The amplifier is normal if sound is produced fromthe speaker.

2 If no sound : Problem causer by incorrect connecttion of the power supply

system or sperker system. : The signals input by the RCA cable before the amplifier system

are abnormal.

Adjustment Location:

S851

TESTTONE

JW535JW690

JW502

- POWER BOARD - (Component side) - AMPLIFIER BOARD - (Component side)

S801

MODE

4

SECTION 2GENERAL

This section is extracted frominstruction manual.

5

6

77

SECTION 3DISASSEMBLY

Note: Follow the disassembly procedure in the numerical order given.

3-1. SIDE PLATE AND FILTER BOARD

3-2. AMPLIFIER/POWER BOARD AND LED BOARD

!™ CNP806 (2P)

1 Three screws (BTP3x8)

2 Four screws (BTP3x8)

3 Bottom plate

6 Side panel (L)

8 Side panel (R)


!¡ Auto fuse (F901 to 904)

!£ Screw (BTP3x8)

!∞ Screw (BTP3x8)


5 Two screws (BTP3x8)

9 Two screws (M4)

0 Cover

!§ Filter board

!¢ Fan motor block

1 Four screws (BTP3x12)

3 Six screws (BVTP3x14)!™ Sub heat sink

(Amplifier)2 Three screws (P4x40)

!¡ Three screws (P3x6)

8 Four screws (P3x10)

!£ Four insulating sheets (AMP)

9 Four screws (P3x14)

0 Screw (BTP3x8)

4 Retainers

5 Two screws (BVTP3x10)

6 Power board

7 Amplifier board

!¢ Two screws (P2x10)

!∞ LED board

!§ LED holder

SECTION 4ELECTRICAL ADJUSTMENT

IDLING CURRENT ADJUSTMENT

• Perform adjustments in the HI-VOLTAGE mode.

1Adjustment pointSemi-fixed resistors VR101, VR201, VR301, VR401 of ampli-fier board.

2Precautions on adjustments1. Set the RCA input terminal to open.2. Apply a voltage of 14.4V between the +12V terminal, REMOTE

terminal, and GND terminal.3. Rotate the above semi-fixed resistors completely in the counter-

clockwise direction while observing the component side.4. Check that the voltage at the adjustment point becomes 0 mV in

step 2.5. Fine adjustments may be required according to the characteris-

tics of the MOS-FET used.• When adjusting the idling current

Rotating the semi-fixed resistor in the clockwise direction:In creases the idling currentRotating the semi-fixed resistor in the counterclockwise direction:

Decreases the idling current

*Take note that rotating excessively in the clockwise directionwill increase the idling current suddenly.

3Approximate adjustment valuesAdjust as follows so that the following voltages become0.4 to 0.5 mV .

A channel :Voltage between TP101 and TP102: Use VR101 of the ampli-fier board B channel :Voltage between TP201 and TP202: Use VR201 of the ampli-fier board C channel :Voltage between TP301 and TP302: Use VR301 of the ampli-fier board D channel :Voltage between TP401 and TP402: Use VR401 of the ampli-fier board

TP401(D-CH)TP201(B-CH)TP101(A-CH)

TP102(A-CH) TP202(B-CH) TP402(D-CH)

IDLING

VR401(D-CH)

VR301(C-CH)

IDLING

VR201(B-CH)

VR101(A-CH)

TP301(C-CH)

TP302(C-CH)

Digital voltmeter

TP101(A-CH)TP201(B-CH)TP301(C-CH)TP401(D-CH)

TP102(A-CH)TP202(B-CH)TP302(C-CH)TP402(D-CH)

- AMPLIFIER BOARD - (Component side)

Adjustment Location

XM-7547

88

SECTION 5DIAGRAMS

5-1. BLOCK DIAGRAM – AMPLIFIER SECTION –

2 23

5 7 6 7 6 756

7

DIFFERENTIALAMP

Q104,106

DIFFERENTIALAMP

Q105,107

POWER AMP(VOLTAGE STAGE)

Q108

BIASVR101,Q110

LEVEL SHIFTQ101

OVERLOADQ113,115

OVERLOADQ114,116

5 7 6 7 5 7 6 7 6 756

7

DIFFERENTIALAMP

Q304,306

DIFFERENTIALAMP

Q305,307

LEVEL SHIFTQ301

OVERLOADQ313,315

OVERLOADQ314,316

OFFSETSET

Q857-861

CNJ807

82

3

9

41

10

67

5

CNP805


Q109


Q308

BIASVR301,Q310


Q309

POWER AMP(FINAL STAGE)

Q111-112

POWER AMP(FINAL STAGE)

Q311-312

NFB ON

NFB OFF

NFB ON

NFB OFF

RY801(1/2)

RY801(2/2)

DIRECTS806-1

DIRECT S805-1

LINE SWITCHQ102

LINE SWITCHQ103

LOWBOOSTIC806-1

LOWBOOSTIC812-1

LINE SWITCHQ302

LINE SWITCHQ303

FAN CTLQ852

CNP806

POWERDRIVEQ854

THERMALDET

TH851

POWERCONTROL

Q853

FAN DRIVERQ851

INVERTERQ855

B-CH

D-CH

CN811

CN810SPEAKER OUTON OFF

ON OFF

B-

B+

B-

B+

H.P.FIC803-1

L.P.FIC805-1

L.P.FIC804-1FILTER

VR805-1FILTER

VR805-3

PRE AMPIC807-1

H.P.FIC808-1

H.P.FIC809-1

L.P.FIC811-1

L.P.FIC810-1LEVEL

VR802-1FILTER

VR806-1FILTER

VR806-3

X10-X1FILTER

CNP808

CNJ808

CNJ808

CNP808

CNJ809

CNP809

CNP809

CNJ809

HPF

LPF

FLAT

HPF

LPF

FLAT

LOWBOOSTVR803-1

LOWBOOSTVR804-1

CNJ806

FN801DC FAN MOTOR

INVERTERQ856

+45V

+15V

-15V

-45V

T851 D854

D855

D856

D857D858

D859D861

D860

B+

B-CH

D-CH

TOPOWERBOARD

CNB805

09

FILTER BOARD

AMPLIFIER BOARD

31

TEST TONE AMPIC851-2

TEST TONE AMPIC851-1

FILTER

FILTER

FILTER

S803-1S801-1

S801-3

X10-X1FILTERS802-1

S802-3

S804-1

A

A+B MONO

C+D MONO

B

(MONO)

(MONO)

INPUT

C

D

SPEAKER OUT

B

A

C

D

2

1

2

1

2

57

6

TEST TONES851

2 2

3

3 3

M

5 7 6 7

PRE AMPIC801-1

H.P.FIC802-1LEVEL

VR801-1

• Signal path : Audio

XM-7547

99

5-2. BLOCK DIAGRAM – POWER SECTION –

7

8

9

2

5

6

10

3

4

CNB805

CN802

CNJ801

TOAMPLIFIER

BOARDCNP805

BATTERY

GND

REMOTE

BATTERY

547

631

CNP804

POWER BOARD

OFFSET CONTROLQ809-810

OFFSET LEDSET

Q804

THERMAL DETECTOR(For H,S)TH903

THERMAL DETECTOR(For TRANS)

TH904

NFBS802

SWITCHQ901-902

SWITCHQ904

SWITCH CTLQ903

THERMALCONTROL

Q918

THERMALSWITCH

Q917

THERMALLED SWITCH

Q806

11

1012

1516

3

8

9

12

14

REF-REG

THERMAL SWITCHTH905,Q919

DRIVERQ921 INVERTER

Q924,926,928

DRIVERQ920

INVERTERQ925,927,929

T902

SWITCHINGCONTROLQ922-923

11

1012

15

3

8

9

12

14

REF-REGDRIVER

Q908 INVERTERQ911,913,915

DRIVERQ907

INVERTERQ912,914,916

T901

SWITCHINGCONTROLQ909-910

THERMAL SWITCHTH902,Q906

SWITCHQ905

D901

F903 (25A)

F904 (25A)

F901 (25A)

F902 (25A)

S801-1

HI-VHI-C

+28V

-28V

TO AMPLIFIERBOARD

+28V

-28V

TO AMPLIFIERBOARD

D905

D912

D913

D906

IC903DC DET

IC901DC DET

DC-DCCONVERTER

IC904

DC-DCCONVERTER

IC902

THERMALDET

TH901D904

D903

OVER CURRENTCONTROLQ807-808

OVER CURRENTLED SWITCH

Q805

D908

D909

OR

D806

OR

OR

D907

16

MUTE CONTROLD808,Q811

MUTE SWITCHQ812

OFFON

S801-3MODE

HI-C HI-V

S801-4

D911

D910

MUTE ENABLERIC813

D801HI-VOLTAGE

D802HI-CURRENT

D803OVER CURRENT

G G GR

D804OFFSET

GR

D805THERMAL

GR

B+Q801

SWITCHQ802

SWITCHQ803

SWITCHCNB804

LED BOARD

09

MODE

MODE

S801-2

D911

HI-V

HI-C

MODE

+12V

+12V

2

1

3

4

2

1

3

4

B +

B –

B +

B –

HI-V

HI-C

4

3

1

2

XM-7547

1010

5-4. PRINTED WIRING BOARD – LED/FILTER SECTION –

THIS NOTE IS COMMON FOR PRINTED WIRINGBOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printedin each block.)

For schematic diagrams.Note:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwisespecified.

• C : panel designation.• U : B+ Line.• Powr voltage is dc 14.4V and fed with regulated dc power

supply from +12V and REMOTE terminals.• Voltages and waveforms are dc with respect to ground

under no-signal conditions.no mark: POWER ON

* : Impossible to mersure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.F : AUDIO

For printed wiring boards.Note:• X : parts extracted from the component side.

5-3. IC BLOCK DIAGRAM

• POWER sectionIC902, 904 µPC494G2

41 2 3 5 6 7 8

91016 15 14 13 12 11

ERROR

0.1V

REG.REF.

OSC

ERROR

• SemiconductorLocation

Ref. No. Location

IC803 C-3IC804 B-3IC805 B-2IC809 C-5IC810 B-6IC811 B-6


Ref. No. Location

D801 A-4D802 A-4D803 A-2D804 A-3D805 A-1

Q801 A-2Q802 A-3Q803 A-1

A

B

C

1 2 3 4 5 6 7

R489R289

R387

R487C354

JW10

2

R486

R383R183

R187

R287

R286

R484

R483

R481

R482

R485C451

R284 R282

R285C251

R490

R382

R384

R385C351

R38

9

R38

6

R182

R184

R185C151

R290

R28

3

R28

1

R39

0

R38

1

R18

1

R18

6

R19

0

R18

9

IC811IC810

IC809

IC804

IC803

IC805

JW117

1-675-246- 11

09

FILTER BOARD

JW104

JW103

JW105

JW106

JW107

C452

C45

4JW

101

S802

JW11

8 CNJ809

C453C455

JW11

9

JW12

0

JW111

JW11

0

JW10

9

JW116

JW115

C35

2

C75

3

C75

4

C35

7

C356

JW12

1

JW12

2

C45

7

C45

6

JW114

JW113

JW112

C355

C353

S804

VR806

JW108JW125

JW137

C254 C154

JW138

JW129

JW130

JW123

JW124

JW128

JW131

JW139

JW140

JW141

JW14

2

C75

1

C75

2

JW12

6

JW12

7

JW14

3

JW13

6

JW13

5

JW13

4

JW13

3

JW13

2

C25

2

C15

7

C25

6

C25

7

C156

C153

C253 C255

C155

C15

2

CNJ808

VR805

S803S801

1

9

1

9

C(Page 12)

S801FILTER

(X1 X10)

VR805FILTER

(50Hz — 400Hz)

S803FILTER

(LPF OFF HPF)

S804FILTER

(X1 X10)

VR806FILTER

(50Hz — 400Hz)

S802FILTER

(LPF OFF HPF)

AMPLIFIER BOARDCNP808 B

(Page 12)

AMPLIFIER BOARDCNP809

1

A

2 3 409

1-675-245-

LED BOARD

11

CNB804

GGRG GR

G

E

E E

R G

D802

D801

D803

D804

D805

1 7

D

(Page 16)

HI-CURRENT

POWER BOARDCNP804

BLK

+

BB

LU

GN

DB

LU

TH

BLU

C

FF

SB

LU

O-C

BLU

H

-V

BLU

H

-C

R81

5

R81

2R

811

Q80

3

R81

4 R80

8

R80

7

R80

6

R80

5

Q80

2

R81

3 R80

4

R80

3

R802

R810 R809

R80

1

Q80

1

D804D803D805THERMAL OFFSET OVER CURRENT

D801HI-VOLTAGE

POWER/PROTECTOR MODE

D802

XM-7547

1111

5-5. SCHEMATIC DIAGRAM – FILTER/AMPLIFIER (1/3) SECTION – • See page 10 for IC Block Diagram.

A

B

C

D

C1014.7/50V

R10122k

C102 4.7/50V

R10222kR851

3.3k

C85133025V

C10433P 5

6

7 6

5

7

2

3

4

5

6

7

2

3

1

3

21

IC801-1NJM4580E(T1)

IC802-1NJM4580E

(T1)

IC802-2NJM4580E

(T1)

6

5

7

3

21

IC808-1NJM4580E

(T1)

IC808-2NJM4580E

(T1)

IC801-2NJM4580E(T1)

IC807-1NJM4580E(T1)

IC807-2NJM4580E(T1)

R105 22k

C105 47P

R205 22k

C205 47P

C405 47P

C305 47P

R405 22k

R305 22k

R20122k

C2014.7/50V

R30122k

C3014.7/50V

R30222k

C3024.7/50V

R40222k

C4024.7/50V

R40122k

C4014.7/50V

R20222k

C2024.7/50V R206

150

R306150

R406150

R106150

C106 100P

R107 4.7k

C206 100P

R207 4.7k

R307 4.7k

C306 100P

R407 4.7k

C406 100P

C30433P

C856 0.1

C40433P

CNJ809 9P

CNP809 9P

R48910k

C45747/16V

C45647/16V

HPF

LPFFLAT

R49010k

R3083.3k

R3094.7k

IC810-2NJM4580E

(T1)

IC811-1NJM4580E(T1)

IC811-2NJM4580E

(T1)

IC810-1NJM4580E

(T1)

IC809-2NJM4580E(T1)

C455 0.015

C453 0.015

4

12

3

4

8

11

2

34

2

3

C4540.15

C4520.15

R487 2.2k

R484 10k

R486 2.2k

C451 100P

R483 6.8k

R48510k

R48222k

R48110k

R38110k

R38222k

R386 2.2k R387 2.2k C355 0.015

R384 10k

C353 0.015C351 100P

R38510k

C3520.15

C3540.15 C357

47/16V

C35647/16V

IC809-1NJM4580E(T1)

76

58

7

6

58

765R383

6.8k R39010k

R38910k

5

6 8

7

Q302 2SC3327-A

Q202 2SC3327-A

Q2032SC3327-A

Q1032SC3327-A

Q102 2SC3327-A

Q2012SC3624-T1L1718

Q1012SC3624-T1L1718

Q3032SC3327-A

Q4032SC3327-A

IC812-2NJM4580E(T1)

IC812-1NJM4580E(T1)

IC806-2NJM4580E(T1)

IC806-1NJM4580E(T1)

R310 3.3k

R410 3.3k

C307 100P

C407 100P

C3084.7/50V

R311680

R312 22k

R31510k

R31410k

R21410k

R21510k

R11510k

R11410k

R11610k R117

3.3k

R2083.3k R216

10k

R2173.3k

C3090.22

C4090.22

C4084.7/50V

R313 6.8k

R411680

R4126.8k

R413 6.8k

R31610k

R41610k

R41510k

Q402 2SC3327-A

R41410k

R3173.3k

R4173.3kR409

4.7k

R4083.3k

12

3 4

12

3

75

6

C207 100P

C107 100P

C2084.7/50V

C1084.7/50V

R2094.7k

R1083.3k

R1094.7k

R2103.3k

R110 3.3k

R211680

R21222k

R111680k

R11222k

R2136.8k

C2090.22

R113 6.8k

C1090.22

CNP808 9P

CNJ808 9P

R18810k

C15747/16V

C1540.15

R19010k

R187 2.2k

R184 10k

R186 2.2k

R286 2.2k

R28510k

R267 2.2k

C155 0.015C153 0.015

C152 0.15

C2540.15

C2520.15

C255 0.015C253 0.015C251 100P

C15647/16V

HPFFLAT

LPF

IC805-1NJM4580E(T1)

IC804-2NJM4580E(T1)

R29010k

R28910k

C25647/16V

C25747/16V

1

2

31

2

3

7

5

6

IC805-2NJM4580E

(T1)

IC803-2NJM4580E(T1)

1

2

3

7

5

6

7

5

6

IC803-1

R284 10k

R1836.8k

R2836.8k

R28

2 22

kR

182

22kC7

03 2

20 1

6V

C704

220

16V

R28110k

R18110k

C151 100P

R185 10k

C8860.1

C8890.1

CNJ807

R85

2 1

K

C705

0.0

01

C852

0.2

2

R1034.7M

R10

4 22

k

R2034.7M

R20

4 22

k

C203

47p

C103

47p 8

C853

330

25V

R8533.3k

R3034.7M

R30

4 22

k

C303

47p

R4034.7M

R40

4 22

k

R85

4 1

K

C854

0.2

2

4

8

S851TEST TONE

VR801-15KC

VR801-25KC

VR802-15KC

VR802-25KC

8

4

8

4

09

VR80

3-1

5KC

C218

100

PC3

18 1

00P

C318

100

P

C418

100

PC1

18 1

00P

C751

0.1

C752

0.1

VR80

3-2

5KC

4

8

S805-1

ON

OFF

S806-1ON

OFF

S805-2ON

OFF

S806-2ON

OFF

VR80

4-2

5KC

VR80

4-1

5KC

S801-1S801-3

S803-1

888

VR805-320KE

S803-2

S801-2 S801-4

444

VR805-420KE

VR805-120KE

VR805-220KE

S802-1S802-3

S804-1

VR806-320KE

S804-2

S802-2 S802-4

VR806-420KE

VR806-120KE

VR806-220KE

2

3

1

IC851-2NJM4580E(T1)

4

R88410k

R8854.7k

C899

0.0

1

R88

7 3.

9k C8500.01

R8863.8k

R85510k

R88310k

R85610k

R85715k

D8511SS184

C20433p

LEVEL

(MIN-MAX)

6

5

7

IC851-1NJM4580E(T1)

8

R85910k

R8584.7k

C857

0.0

1

R86

0 18

0k C8580.01

R861180k

R8821M

MONO

INPUT

MONO

LEVEL

(MIN-MAX)

IC804-1NJM4580E

(T1)NJM4580E(T1)

VR805FILTER

(50Hz–400Hz)

VR806FILTER

(50Hz–400Hz)

FILT

ER(L

PF

OFF

H

PF)

FILT

ER(L

PF

OFF

H

PF)

SW801, 802FILTER

(X1 X10)

9 1

9 1

1 9

1 9

DIR

ECT

(ON

O

FF)

DIR

ECT

(ON

O

FF)

LINE SW

LINE SW

LEVEL SHIFT

LINE SW

LEVEL SHIFT

LINE SW

Q3012SC3624-T1L1718

LEVEL SHIFT

LINE SW

LINE SW

Q4012SC3327-T1L1718

LINE SW

LEVEL SHIFT

LINE SW

LOWBOOST(0dB—+10dB)

LOWBOOST(0dB—+10dB)

C403

47p

LPF

HPFFLAT

C7530.1

C7540.1

TO A

MPL

IFIE

R B

OR

AD (

2/3)

(Pag

e 13

)

AMPLIFIER BOARD

LPFFLATHPF

TO AMPLIFIER BORAD (3/3)

(Page 14)

IC806LOW BOOST

IC812LOW BOOST

IC805, 810L.P.F

IC803, 809H.P.F

IC804, 811L.P.F

IC851PRE AMP

IC808PRE AMP

IC807PRE AMP

IC802PRE AMP

IC801PRE AMP

0

150

0

0

-150

0

0

0

015

0

0

0

15

00

0

-15

00

-15

0

0

0

015

0

0

0

15

00

0

-15

00

-15

0

00

00 0

0

15

0

15

00

0

0

-15

0

-15

15

00

-15

00

00 0

0

15

0

15

0

0

0

0

-15

0

-15

15

00

-15

150

-0.6

0

00

15

00

0.800

0.8

-0.60

0

0

0

-15

0

0

15

0.8

0.8

0

-0.6

0

00

00

0.800

-0.6

0

0

0

0

00

00

15

0.8

0.8

0.8

0

0

15

-15

15

9 107 8

XM-7547

1212

5-6. PRINTED WIRING BOARD – AMPLIFIER SECTION –

• Semiconductor Location

D101 H-12D102 H-11D103 F-11D104 F-11D105 E-9D106 F-9D201 H-9D202 G-9D203 F-8D204 F-7D205 E-8D206 F-8D301 H-6D302 H-5D303 F-7D304 F-7D305 E-6D306 F-6D401 H-4D402 G-3D403 E-3D404 E-2D405 E-3D406 F-3D851 A-2D853 C-1D854 E-1D855 E-1D856 E-2D857 E-1D858 E-2D859 E-1D860 E-2D861 E-1D862 G-2D863 G-7D864 G-2D865 G-7

IC801 B-8IC802 B-9IC806 B-10IC807 B-7IC808 B-6IC812 B-4IC851 A-1

Q101 A-10Q102 A-9Q103 A-10Q104 G-11Q105 G-11Q106 G-11Q107 G-11Q108 G-11Q109 G-11Q110 H-11Q111 H-12Q112 H-11Q113 E-12Q114 F-12Q115 E-12Q116 F-12Q201 A-10

Q202 B-9Q203 B-11Q204 G-9Q205 G-9Q206 G-9Q207 G-9Q208 G-9Q209 G-9Q210 H-8Q211 H-9Q212 H-8Q213 E-9Q214 F-9Q215 E-8Q216 F-8Q301 A-4Q302 A-6Q303 A-4Q304 G-6Q305 G-5Q306 G-6Q307 G-5Q308 G-6Q309 G-5Q310 H-6Q311 H-6Q312 H-5Q313 E-6Q314 F-6Q315 E-6Q401 A-4Q402 A-6Q403 B-4Q405 G-3Q406 G-3Q407 G-3Q408 G-3Q409 G-3Q410 H-3Q411 H-3Q412 H-2Q413 E-3Q414 F-3Q415 E-3Q416 F-3Q851 H-1Q852 C-12Q853 C-2Q854 C-1Q855 D-1Q856 D-2Q857 C-12Q858 C-12Q859 A-12Q860 A-12Q861 A-12

Ref. No. Location Ref. No. Location

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11 12

JW589

JW581

JW570JW571

JW55

1

JW55

3

JW55

2

JW572

JW573

JW557

JW540

JW539

JW536JW537

JW561

JW562

JW563

JW558

JW559

JW554

JW555

JW525

JW526

JW527

JW521CNP808

C118

JW517CNP805

JW518

JW519

JW520

JW522

JW523

JW524

JW54

1

JW528JW529

JW531

JW530

JW532

JW531

JW535

JW690

JW556

JW574JW582

JW583

JW584

JW585

CNP809JW

595

JW59

4

JW59

2

JW59

3

JW58

8

JW58

7JW

586

JW58

0

JW57

9

JW57

8

JW57

7

JW57

6

JW57

5

JW54

6

JW53

8

JW56

0

JW55

0

JW54

9

JW54

8JW

547

JW53

3

JW56

4

JW56

5

JW56

6

JW56

7JW

568

JW56

9

JW54

5

JW54

2

JW51

1

JW51

0

JW50

9

JW50

7

JW50

5

JW50

4

JW51

2

JW51

6

JW51

5

JW50

8

JW50

6

JW50

3

JW50

2 JW50

1

JW51

4

JW51

3

JW54

4JW

543

JW59

8

JW59

7

JW60

1

JW60

2

JW60

8

JW60

7JW

606

JW60

5

JW59

6

JW68

5JW

684

JW68

3

JW63

7

JW62

8

JW61

2

JW61

1

JW61

3

JW61

4

JW61

5

JW61

6

JW62

7

JW62

9

JW63

0

JW63

1

JW63

6

JW64

5

D86

3

D86

5

JW64

6

JW64

7

JW64

8

JW64

9

JW65

0

JW66

0

JW66

2

JW66

1JW

658

J659

9

JW644

JW635 JW640 JW641

JW642

JW633

JW634

JW651

JW694

JW652JW643

JW625

JW619

JW626

JW618

JW617JW622

C413

VR401 VR301

JW621

JW620

JW623

JW624

JW638

JW632

JW639

JW686JW688

JW689E

E

E

ED305

R340

R338

JW675

JW676

JW677

JW672

JW673

JW674

JW666 JW667

JW664

JW671JW663JW653

JW665

JW668

JW669

JW670

JW678

JW680

JW681

JW682JW679

JW656

JW655JW654

JW657

JW687

JW58

9

JW60

3

JW60

4

JW590

JW591

C880C881

R353R453 R153

R457 R357

R356

C41

6

R45

4

R45

5

C41

2

R42

5C

411

R41

9

R41

8C

410

R42

8

R32

9

R35

5

C31

2

R35

4C

315

C41

5

R32

8

R42

9

R456

C314C414

C708

TH851

Q853

C85

9

C86

0

C313

C30

2

C30

1

C40

1

C10

2

C20

2

C20

1

C40

2

C10

1

C85

3

C85

1

C31

6

R257

C21

6

R25

4

R25

5

C21

2

R22

5C

211

R21

9

R21

8C

210

R22

4

R22

8

R12

9

R15

5

C11

2

R12

5C

111

R11

9

R11

8C

110

R12

4

R15

4C

115

C21

5

R12

8

R22

9

R256

R157

R156

C11

6

C861

C863 C864

JW609

JW610

C862

C113

R253

C87

0

C875

C874

R140

R138

S851

S851

VR804 VR802 S806

C114C214

D85

5

D85

4

D85

7

D85

9

D85

6

D86

0

D85

8

D86

1

C865 C866JW691

JW692E

E

E

E

JW693

CNP806

Q410

C213 VR201

VR101

R240

R238

C876

C877

D86

2

D86

4

C879 C878

C872

VR803VR801S805

CNJ807

CNJ807

L851

TEST TONE

Q852

E

Q413

Q414

Q85

4

Q415

D406

Q416

Q313

Q314Q316

Q315

Q213

Q214

Q215

Q216

Q113

Q114

Q115

Q860 Q861

Q20

1

Q10

1

Q85

7

Q85

9

Q85

8

Q116

R31

3

Q851

R427 R426

C895

C894

R86

2

R86

3

R43

3

R43

1

R43

0

R42

4

R88

1C

887

R23

3

R23

1

C88

5R87

9

R14

9

R14

8

R14

7

R14

6

R11

7

R21

7

R13

6R

137

R13

4

R13

3

R13

1

R13

2

R13

0

R421 R420

C892

C893

C886

R327 R326

R880R321

R32

5C

311

R31

9

R31

8C

310

R32

4

R33

2

R33

0

R33

3

R33

1

R320

R227 R226

R23

0

R23

2

R884 R878R121 R120

R127 R126

C882

C883

R151R145

R150

R143

R135

R23

6

R23

4

R23

7R24

6

R24

7

R24

8

R24

9

R34

6

R34

7

R34

8

R34

9

R245

R250

R251

R243

R235

R33

6

R33

4

R33

7

R350

R343

R335

R351R345

R43

6

R44

9

R86

7

R88

3

R88

6

C89

9R

887

C85

0R88

4

R85

6

R85

7

R86

1C

858

R86

0C

857

R85

9R

855

R85

8

R86

8

C898C896

C897

Q855 Q856

R866

R885

R44

8

R44

7

R44

6

R43

4

R43

7

R450D405

C868C887

R445 R451

R440

R438

R443

R435

R43

2

R41

7

R31

7

R86

4

IC851

Q40

1

Q301Q303

Q403

R41

6

R85

2

R21

6

R85

3

R11

4

R21

4

R10

6

R21

5

R88

2

R11

0C

107

R11

3

C20

9

R21

1

R21

2R

109

R10

8

R85

1

R41

2

R41

5

R45

2

R35

2

R31

5 C407 R408

R308

R310C307C318

R312

R309

C309

C409

C408

C308

R411

R306

R405C405 R401

C303R304C304C305

R301R305

R303

R314

R414

R316

C854

R854

C852

R116

R107

R115

JR001

R111

C86

9

R87

4

R87

6R

871R

873C871 E E

E

R877

R875

R870E

E

R872

R252

R152

R213R112

C109

R209

C218

R208R210C207

C106

R206C206

R207

R404C403 C704

R201

R204C203

C703C103R104C104C105

R101R105

R205C205

R403C40

4

R40

2

C88

8C

889 R20

3R

103

R10

2

R30

2

C85

6

C20

4

R20

2

R307C306

Q302

R406R407

C406

R413E

ER311

R410 R409

IC812

IC808

IC807 IC801

IC802

IC806

Q110Q111Q112

Q109 Q108

Q107

Q105

Q104

Q106

1

9

10

1

9

1

RY802 RY801

E

E

E

Q402E

Q102E Q103 E

Q203E

Q202E

Q412

Q409

Q405

Q407

Q404

Q406

Q408 Q309

Q307

Q305

Q304

Q306

Q308

Q312 Q311Q310 Q212 Q211

Q210

Q209

Q207

Q205

Q204

Q206

R221 R220

Q208

T851

E

E

E

TP102

TP201

TP202

TP101

TP402

TP401

C208 E

EC108

1 2

AMPLIFIER BOARD

VR804 VR802LEVEL

(MIN MAX)

VR101,201IDLING

VR301,401IDLING

S806DIRECT

(ON OFF)LOW BOOST

(40Hz)(0dB +10dB)

VR803VR801LEVEL

(MIN MAX)

S805DIRECT LOW BOOST

(40Hz)(0dB +10dB)

FILTER BOARDCNJ809B (Page 10)

FILTER BOARDCNJ808 C(Page 10)

BLU TH

BLU +15V

BLU RELAY

BLU MUTE.BLU OFFSBLU H-C

BLU H-V

POWER BOARDCNB805

A

(Page 15)

TO POWER BOARD

(Page 15)

TODC FAN MOTOR

BLU FAN

BLK GNDBLU +B

111-675-240-

D

MONO-R MONO-L

C B A

INPUT

RE

DB

LK

09

-28V

GND

+28V

+28V

GND

-28V

CN811SPEAKER OUT

CN810

AB

SPEAKER OUT

A+B

MONO

CD

C+D

MONO

C706 C707

D405D306

C418

D205

E

E

E

ED206

D105

E

E

E

E

D106

(ON OFF)

D851

D853

D404 D403

D40

1

D402

D301

D302

D304 D303 D204 D203

D202

D20

1 D101

D102

D104 D103

S SS S S S SS

XM-7547

1313

5-7. SCHEMATIC DIAGRAM – AMPLIFIER (2/3) SECTION – • See page 10 for IC Block Diagram.

R12047K

Q1062SC1841-FA

R1184.7K

Q1042SC1841-FA

42.3

-0.5

-42.3-42.9

0.6

Q1052SA988-FA

Q1072SA988-FA

R1194.7K

C11210P

Q1092SC3423-Y

R1263.3K

R1271K

Q1082SA1360-Y

VR101470

R12822K

Q1102SC3421-Y

R130100K

C1130.1

R131100K

R12922K

R13222

D10102CZ16-TE85L

D1020ZCZ16-TE85L

R133 22

Q111FS70SMJ-2

POWERAMP

R1380.06X2 5W

R15010K

D105 RD12EB2

D106RD12EB2

D205RD12EB2

D206RD12EB2

D306 RD12EB2

D405RD12EB2

D406RD12EB2

D305RD12EB2

R1432K

R1341K

R1351K

Q1142SA1162-Y

D1031SS181-TE85R

Q1132SA1162-Y

R1420.06X2 5W

R1361K

R1452K

R1371K

Q112FX50SMJ-2

POWERAMP

D1041SS181-TE85R R148

10K

R14910K

R151 10K

Q1152SC2712YG-TE85R

Q1162SC2712YG

-TE85R

Q3162SC2712YG

-TE85R

Q4162SC2712YG

-TE85RD862 11ES2

D863 11ES2

D864 11ES2

D865 11ES2

R152470K

R153331W

C1140.047

R12147K

R156 10KR155 6.8K

C11647/16V

R15710K 1/4W

R87910

R87810 C884

4700PC885

4700P

R154 3.3 C115 47/16V

RY801TXD2-

2M-12V

R248 10K

C215 47/16V

C216 47/16V

R254 4.7K

R255 6.8K R256 10K

R2184.7K

Q2042SC1841-FA

Q2052SA988-FA

Q2062SC1841-FA

R2194.7K

R22147K

R22047K

Q2072SA988-FA

C21210P

R2263.3K

R2271K

Q2092SC3423-Y

Q208-210DRIVE AMP

Q408-410DRIVE AMP

R22822K

VR201470

Q2082SA1360-Y R229

22K

R230100K

C2130.1 R231

100K

R25710K

R232 22

ES70SMJ-2D201

02CZ16-TE85L

D20202CZ16-TE85L

R23322

R2380.06X2 5W

Q2142SA1162-YOVER LOAD

Q2132SA1162-Y

Q3132SA1162-Y

Q4132SA1162-Y

R2353.3K

Q211FS70SMJ-2

POWERAMP

R2432K

R2501K

D2041SS181-TE85R R248

10K

R249 10K

D2031SS181-TE85R

R246 10K

R247 10K

R146 10K

R147 10K

R25110K

Q212FX50SMJ-2

POWERAMP R240

0.06X2 5W

R236 1K Q2152SC2712YG

-TE85R

Q2162SC2712YG

-TE85R

R252470K

R253331W

C2140.047

R32047K

Q3042SC1841-FA

Q3062SC1841-FA

Q3052SA988-FA

Q3072SA988-FA

Q3082SA1360-Y

Q3092SC3423-Y

R3184.7K

R3194.7K

R32147K

R88110

R348 10K

C315 47/16V

VR301470

R3263.3K

R3271K

C31210P

Q3102SC3421-Y

R32822K

C31647/16V

R356 10KR355 6.8K

R330100K

C3130.1

R331100K

R32922K

Q311FS70SMJ-2

POWERAMP

R33222

FS70SMJ-2D301

02CZ16-TE85L

D30202CZ16-TE85L

R333 22

R357 10K

R3380.06X2 5W

R2371K

R2452K

R3400.06X2 5W

R4400.06X2

5W


R3432K

R3452K

R35010K

R3351K

D3041SS181-TE85R R348

10K

R34910K

R351 10K

Q312FX50SMJ-2

POWERAMP

R3361K Q315

2SC2712YG-TE85R

R88010

C8864700P

R42047K

R4184.7K

Q4042SC1841-FA

Q4062SC1841-FA

Q4052SA988-FA

Q4072SA988-FA

Q4082SA1360-Y

R4194.7K

R421 47K

R354 3.3K

C8874700P

RY802TX02-2M-12V

C415 47/16V

C416 47/16V

R4544.7K

R455 6.8K R456 10K

R42822K

VR401470

R4263.3K

R4271K

C41210P

Q4102SC3421-Y

Q4092SC3423-Y

R429 22K

R45710K

R43222

R430100K

C4130.1

R431100K

FS70SMJ-2

D40102CZ16-TE85L

D40202CZ16-TE85L

R43322

R4380.06X2

5W

Q411FS70SMJ-2

POWERAMP

R4432K

R45010K

R4351K

Q412FX50SMJ-2

POWERAMP


Q4152SC2712YG

-TE85R

D4041SS181-TE85R R448

10K

R449 10K

R45110K

R4452K

R436 1K

R352470K

R353331W

C3140.047

R452470K

R453331W

C4140.047

C7080.01

Q104-107DIFFERENTIAL

AMP


AMP

Q108-110DRIVEAMP

Q308-310DRIVEAMP

B+

IDLING

IDLING

IDLING

IDLING

Q2102SC3421-Y

B-B- B-

B+

B+

B+

B+

42.3

42.9

1.5

1.3

42.9

1.5

1.5

S

S

S

S

S

S

S

S

1.5

1.5

26.8

26.8

26.8

26.8

26.8

26.8-0.6

-27.7

26.8

26.8

26.8

-27.7

-27.7

-27.7

-0.6

-0.3

-0.3

-1.8

-27.7

0

26.8

-27.7

-27.7

26.8

26.8

26.8

-27.7

26.8

26.8

0

0

-27.7

-27.7

26.8

0

-27.7

-1.8

1.5

1.5

-1.8

-1.8

-42.9

-42.9

-42.9

-42.9

42.9

42.9

1.5

1.3

B+

B+

B-

B+

B-

B+

B-

B+

B-

B-

B+

B-

B+

B+B-

B-

B-

B-

-1.8

1.3

1.3

-1.8

-1.8

-0.5

0

-0.5

-0.5

-0.5

0

0

0

-0.5

0.6

B-

B-


AMP


AMP

B+

B+

B-

B- B-

42.9

-42.9

42.9

-42.9

42.9

-42.9

42.9

-42.3

42.3

42.3

-0.5

0.6

-0.5

0

0

0.6

-42.3

-42.3

-1.8

OVER LOAD

OVER LOAD

OVER LOAD

OVER LOAD

OVER LOAD

A

B

C

D

C+D

CN81

0 4P

SPEA

KER

OU

TCN

811

4PSP

EAKE

R O

UT

C1100.1

R125 220

C111 0.1

R124220

C210 0.1

R224 220

R225220 C211

1

C3100.1R324

220

R325 220

C311 0.1

C410 0.1

R424 220

R425220

C4110.1

R3371K

R4371K

R3341K

R2341K

R4341K

D4031SS181-TE85R

R446 10K

R447 10K

D3031SS181-TE85R

R346 10K

R347 10K

C8821000P

C8831000P

C8901000P

C8911000P

C8921000P

C8931000P

C8941000P

C8951000P

AMPLIFIER BOARD

MO

NO

A+B

MO

NO

TO AMPLIFIER BOARD (3/3)

(Page 14)TO AMPLIFIER BOARD (3/3)

(Page 14)

TO A

MPL

IFIE

R B

OAR

D (

1/3)

(Pag

e 11

)

XM-7547

1414

5-8. SCHEMATIC DIAGRAM – POWER/AMPLIFIER (3/3)/LED SECTION – • See page 10 for IC Block Diagram.

R811470

R812470

R809680

R810680

R807470

R808470

R805680

R806680

R801680

R802680

R803470

R804470

R8152.2k

R816470

R817470

R818470

R819470

R82010k

R82110k

D80

5

R8142.2k

D80

4

Q803

Q802R8132.2k

D80

3D

802

D80

1

Q801

OVERCURRENT

OFFSET

THERMAL

HI-CURRENT

HI-VOLTAGE

Q80

1-80

32S

C271

2-Y

SWIT

CH

7 7

1 1

CNB8

04 7

PCN

P804

7P

21

12P

2

CNJ806

CNP806

FN801

R852470

R8862.2k

C859

22/1

6VC860

470/10

R86447k

D85302CZ10Y

R863 4.7k

R8671k R868

10

Q8512SA1358-Y

Q8522SC2712-Y

Q851, 852FAN MOTOR

DRIVE

D854, 855, 860, 86111EFS2-TB5

D856, 857, 858, 85911EQS04-TA1B

46+

C896 0.01

C897 0.022

C899 0.022

Q8562SC3074-Y

(TE16L)INVERTER

D861

D860

D859 –15V

+15V

–45V

+45V

D858

D857 D856

D855

D854

Q8552SC3074-Y (TE16L)

INVERTER

Q8542SC2712-Y

DRIVER

TH851

T851

L851BL01RN1-A62

0.45µH

C86210050V

C8640.047

R8821M

R87010K

R87510K

R87110K

R87210K

R8741M

R87310K

C86610016V

C8690.1

C86510016V

C8670.1

C861100/50V

C8630.047

Q804

Q804-807, 8092SC2712-Y

Q804-806LED DRIVE

Q807, 808OVER

CURRENT

Q809, 810OFF SET

Q917, 918DRIVER

Q805

R82310k

R82210k

Q806

R82510k

R82410k

C801470P

R82810k C8

0322

/16V

R8263.3k

R8293.3k

R8333.3k

R82710k

R83110k

R83010k

R832 47k

C80522/16V

C80622

16V

R83591k

R8343.3k

R8361K

R83710K

S801MODE (HI-VOLTAGE HI-CURRENT)Q807

Q808

Q808, 810 2SA1162-Y

Q810

Q809C802

2216V

C804470P

D8061SS184-TE85L

IC81

3PS

2501

-1-K

IC903PS2501-1-K

FAN MOTORDETECT

Q8112SC2712-Y

SWITCH

Q8122SA1162-Y

SWITCH

D80802CZ6.8-TE85L

D8071SS184-TE85L

R838 100

S802

101

101

CNB805CNP805 10P

Q8592SC2712-Y Q858-861

OFF SET

Q8572SC2712-Y

Q8582SA1162-Y

R87610K

Q8612SA1162-Y

C8591000P C870 47/16V

Q8602SC2712-Y

R8771M

C8730.01

C8788200/35V

C881

8200

/35V

C8798200/35V

C880

820

0/35

V

C8711000P

C87247/16V

+28V

–28V

+28V

–28V

R9514.7k

R952220

D91102CZ15-TE85L

D91

0R

D36

FB2

Q9192SC2712-Y

SWITCHQ921

Q920 Q922 Q924 Q926 Q928

Q929Q927Q925Q923

TH905 22k

R96122

1/4W

R9621k

R9651

R9671

R9691

R95

9 1k

R95

7 10

0 2W

R95

8 10

0 2W

R955150

R9541k

R9601k R964

22

R9661

R9681

R9701

R9631k

C9292200 16V

C9302200 16V

C9312200 16V

C9322200 16V

C9330.047

T902L904

BL01RN1-A620.45µH

C93522035V

C93622035V

C9110.1

R9341

R9321

R9301

R9271K

R9281k

R92922

R9262.2

C9132200 16V

C9142200 16V

C9152200 16V

C9162200 16V

B+

B+

B+

B+

B+

B–

B–

B+B+

B–

D912FCH20A15

D913FRH20A15

Q915Q913

Q911-916 MTP75N06HD INVERTER

Q924-929 MTP75N06HD INVERTER

Q911Q909

Q910Q907

IC902UPC494GS-T1

Q908

Q9062SC2712-Y

SWITCH

D903RD36FB2

D90402CZ15-TE85L

D905FCH20A15

D906FRH20A15

IC901PS2501-1-K

Q916Q914Q912

R9241k

R92

3 10

0 2W

R92

5 1k

R92

2 10

0 2W

R920150

C908

0.0

1C9

09 2

2 16

V

C910

100

0PR91

3 10

k

R91

4 15

k

R91

5 12

k

R921150

R9191k

R9311

R9331

TH90222k

R9164.7k

R917220

R9351

R9181k

R91

2 10

K

R910220k

C90622 16V

C905

100

16V

R911220

C90747 10V

R90

9 47

0TH

901

22k

R9083.3k

R9041k

Q9012SB1243-QR-TV2

B+ SWITCH

Q9022SA1162-Y

POWER ON/OFF

Q9032SC2712-YB+ SWITCH

Q90

42S

C271

2-Y

B+ S

WIT

CH

Q91

82S

C271

2-Y

DR

IVER

Q91

72S

A116

2-Y

DR

IVER

Q9052SC2712-YB+ SWITCH

R9033.3k

R9054.7k

R9061.5K

R902330

D90202CZ5.1Y-TE85L

D9071SS184-TE85L

D90

102

CZ16

-TE8

5LR90110k

C9041000P R907

4.7k

R93910k

C9211000P

R94047k

R9411.5k

R942470

R93710k

C92422/16V

R945220k

C92547/10V

C923

100/

16V

R946220 R948

10kR94915k

C928

100

0P

R95

0 12

k

C926

0.0

1

C92722/16V

IC904UPC494GS-T1

R94710k

R9531k

R956150

R9433.3k

TH90422k

TH90322k

C9220.01

R93610k

R938470k

D90

91S

S184

-TE8

5L

D90

81S

S184

-TE8

5L

F903 25A

F904 25A

F901 25A

F902 25A

C9021000P

C917220 35V

C918220 35V

C9450.01

C9190.01

L902BL01RN1-A62

0.45µH

T901

Q920, 9212SA1680-TPE6

DRIVER

Q909, 9102SC4408-TPE6

DRIVER

Q922, 9232SC4408-TPE6 DRIVER

9.5

10.111.8

9.4

12.6

0.1

9.4

–2.3 –2.4

12.7

12.70.2

0 0

–27.6

–27.6

12.7

GL-5ED60

GL-5ED60

GL-5ED60

GL-5ED60

GL-5ED60

+12V

+12VGND

0

0

0

0

0

0

CN80

2 3P

REMOTE

CNJ8011P

1

SUB WOOFER

3

4CH

0

0 0 0 0

12.9

12.8

–22.5

–26.5

13.8

12.8

0

5

0

23.8

0.2

2.5

5

0.4

12.8

5

13.8

0.40.40.4

0.4

0.4 0.4

13.8

12.7

12.8

552.5

02.

52.

5 4

0.5

1.7

3.7

12.7

–23.8

0.9

0.3

26.8 26.7

–25.812.8

12.8

5

0.7

5.9

13.9

13.2

0.1 02.

52.

5

4 0.5

1.7

3.8

12.7

5.2

5.3

0

2.5 5 5

12.8

12.7

12.9

12.8

5

13.813.8

0.1

0.4

0.4

0.4 13.8 13.8

12.8

0.4

0.4 0.4 0.4

13.8

2.5

0.4

0.1

0.4 0.4

26

0 0

012.8

0

12.8

12.8 12.8

12.8 12.8

IC813

CONVERTERIC904

CONVERTERTEMPERATURE

DETECT

Q907, 9082SA1680-TPE6

DRIVER

IC902IC901

TEMPERATUREDETECT

IC903

ON

OFFNFB

0.5

23.8

0.1

–24.1

13.80.5 13.8

–26.8

–26.2

12.8

12.8–22.5

13.8

0.1

13.8

B+

B+

B+

B+

B–

B–

B–

B–

B+ B+ B+

B+

B+

B+

B+

B+

B+

B+ B+

B+

B+

B–

B–

B–

B– B–

B+ B+

B+

B+B–

B–

TH852

C8740.1

C8760.1

C8770.1

C8750.1

L903

L901

AMPLIFIER BOARD

Q8532SB1375

POWER CONTROL

2P

TO AMPLIFIER BOARD (1/3)

(Page 11)TO AMPLIFIER BOARD (2/3)

(Page 13)TO AMPLIFIER BOARD

(2/3) (Page 13)

DC FAN MOTOR

C9370.01

C9440.01

C7060.001

C7070.001

XM-7547

1515

5-9. PRINTED WIRING BOARD – POWER SECTION –

D806 E-5D807 B-1D808 B-2D901 B-7D902 B-7D904 E-9D907 E-5D908 G-2D909 E-4D911 E-1

IC902 F-9

Q804 B-9Q805 B-9Q806 B-9Q807 D-6Q808 D-6Q809 D-5Q810 D-4Q811 B-2Q812 B-2Q902 B-7Q903 B-8Q904 B-7Q905 B-7Q906 F-9Q917 E-4Q918 D-5Q919 F-1


Ref. No. Location

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9

R94

1R

964

R94

4

R82

9

R83

1C

804

R83

0R

940

R93

9

R937

R833

R943

R828

R938

R941R936

C922

R832

R95

0

C92

8

R94

9R

946

R94

5

C93

7

R83

4

R83

6

R835

R837

C921T

H90

5

TH

904

R95

2

R96

1

R95

4R

953

R95

5R

956

TH903

R947

R960

R959

R963R962

R942

R951

C926

R948

D908

D911

Q919

Q81

2

Q81

1

D808

D909D907

Q917

Q810

Q918

R82

4

C80

1

R82

5

R82

6R

827

Q80

8Q

807

R90

8

R90

6R

905

R90

2

C90

4

R904R903

C902

D901

Q90

5

Q90

4

Q90

3

JR051

R820

R82

3

R82

2R

821

R81

9

R81

7

R81

8

R81

6

Q80

6Q

804

Q80

5

R909

C908

R914C910R915

R928

R927R925

R924

R91

3

C91

9

R92

9

C91

1

R91

9R

920

R91

8R

921

R92

6

R91

6

R91

1

R91

0

R91

2 TH

902

R91

7

Q90

6

D904

Q902

D902

Q80

9

D807

IC904

IC902

E

E

E

E

E

E

EE

E

E

E

E E

E

TH

901

1-675-241- 11

POWER BOARD (SIDE A)

C802

09

XM-7547

1616

D809 A-1D903 F-9D905 E-7D906 E-8D910 F-1D912 E-2D913 E-3

IC813 B-3IC901 F-9IC903 F-1

Q901 B-7Q907 G-9Q908 G-9Q909 G-9Q910 G-9Q911 H-7Q912 H-9Q913 H-6Q914 H-8Q915 H-6Q916 H-8Q920 G-1Q921 G-1Q922 G-1Q923 G-1Q924 H-3Q925 H-4Q926 H-2Q927 H-4Q928 H-1Q929 H-3


Ref. No. Location

09

POWER BOARD (SIDE B)

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 91-675-241- 11

Q923

Q920

E

E

E

E

Q901

Q908

Q909 Q910

Q907

E

E

E

E

C909

C90

5

C90

7

C90

6

C91

8

C803

C91

7

C93

0

C92

9

C91

6C

914

C91

5C

913

PL901

C93

2

C92

3

C92

5

C92

7

C93

6C

935

C92

4

C93

1

R95

8

Q922

Q921

R96

9

R96

7

R96

5

R97

0

R96

8

R96

6

R93

4

R93

2

R93

0

R93

5

R93

3

R93

1

R92

3

R92

2

Q912 Q916 Q911Q914 Q913 Q925Q915 Q927 Q929 Q924 Q928

S S S S S SS SS SS S

Q926

D905

R95

7

L904

D903

IC901

L902

D91

0

C806

C80

5

R838

D809

IC903

CNB805

1

10

R90

1

CNJ801

R90

7

D912D913D906

S802F90425A25A

F903S801

MODEHI-C HI-V

CNP804

F90225A25A

F901

TOAMPLIFIER

BOARD

(Page 12)+28V

GND

-28V

+28V

GND

-28V

REMOTECNJ801

+12VGND

CN802

+12V

LED BOARDCNB804

D

(Page 13)

1

7

T901 T902

BLKBLUBLUBLUBLUBLUBLU

AMPLIFIER BOARDCNP805

A

(Page 12)

BLK

BLUBLUBLUBLUBLUBLU

BLU

BLU

BLU

IC813

C944C945

E

NFBOFF ON

17

F903 F902F901

F904

FN801

#1

#1

#1

#1

#1

#1

#1 #1

#1

#1

#1#1

#1

#1

#1

#1

#1

#11

#11

#1

#1

#1

#1

1

3

3

5

4

10

211

3

9

9

7

3

68

not supplied

11

SECTION 6EXPLODED VIEWS

6-1. PLATE AND COVER SECTION

• F901 to F904 are including into the Power board (Ref No. 62).

NOTE:• Items marked “*” are not stocked since they are

seldom required for routine service. Some delayshould be anticipated when ordering these items.

• The mechanical parts with no reference number inthe exploded views are not supplied.

• Hardware (# mark) list and accessories and pack-ing materials are given in the last of this parts list.

• AbbreviationCND : Canadian model

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

10 3-704-177-11 EMBLEM (No. 7), SONY

11 3-040-933-01 BOLT, M4 HEXAGON HOLEF901 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)F902 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)F903 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)F904 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)

FN801 1-763-107-11 MOTOR, FAN

* 1 3-039-168-01 PANEL (R), SIDE* 2 3-039-205-01 HEAT SINK (COVER)* 3 3-039-173-01 PLATE (BKT), BOTTOM* 4 3-039-170-01 LENS(COVER)* 5 3-039-201-01 PLATE, BOTTOM

* 6 3-039-167-01 PANEL (L), SIDE* 7 1-675-246-11 FILTER BOARD* 8 3-039-202-01 BRACKET (FAN)* 9 3-039-172-01 HOLDER, VOL

18

6-2. BOARD AND HEAT SINK SECTION


* 59 3-039-200-01 BRACKET (PWB)

* 60 3-039-179-01 HEAT SINK, SPACER* 61 3-039-180-01 BAR(PC-PC), BUS* 62 A-3317-933-A POWER BOARD, COMPLETE

63 3-912-431-01 SCREW (P)* 64 3-039-172-01 HOLDER, VOL

* 65 3-039-178-01 HEAT SINK (RECTIFIER), SUB

* 51 3-039-210-01 HEAT SINK (US,CND)* 51 3-039-210-11 HEAT SINK (AEP,UK,E)

52 3-039-171-01 HOLDER, LED* 53 1-675-245-11 LED BOARD* 54 3-039-184-01 SHEET (AMP), INSULATING

* 55 A-3317-930-A AMPLIFIER BOARD, COMPLETE* 56 3-039-204-01 HEAT SINK (AMPLIFIER), SUB* 57 3-039-183-01 SHEET (POWER), INSULATING* 58 3-033-321-01 RETAINER

51

52

53

5554

54

54

54

57

56

#9

#3

#7

#2

#2

#2

#2

#1

#1

#1

#1

#1

#1

#9

#1

#4 #4#10

#10#10

#10

#4

#4

#9 #8#8

#8

#8#8

#8

#6

#4

#4#4

#5#1(Including Ref No.62)#1

(Including Ref No.55)

#1(Including Ref No.55)



#5

#4

#6

58 58

57

6060

62

63

63

63

64

64

65

65

59

59

64

61

61

19

SECTION 7ELECTRICAL PARTS LIST

Note:


AMPLIFIER

• SEMICONDUCTORSIn each case, u: µ , for example:uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,uPC...: µ PC..., uPD...: µ PD...

• CAPACITORSuF : µ F

• COILSuH : µ H

• AbbreviationCND : Canadian model

• Due to standardization, replacements in the parts listmay be different from the parts specified in thediagrams or the components used on the set.

• -XX, -X mean standardized parts, so they may havesome difference from the original one.

• Items marked “*” are not stocked since they areseldom required for routine service. Some delayshould be anticipated when ordering these items.

• RESISTORSAll resistors are in ohmsMETAL: Metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF : nonflammable

When indicating parts by referencenumber, please include the boardname.

* A-3317-930-A AMPLIFIER BOARD, COMPLETE********************

< CAPACITOR >

C101 1-126-047-81 ELECT 4.7uF 20% 50VC102 1-126-047-81 ELECT 4.7uF 20% 50VC103 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC104 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC105 1-163-243-11 CERAMIC CHIP 47PF 5% 50V

C106 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC107 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC108 1-126-047-81 ELECT 4.7uF 20% 50VC109 1-164-222-11 CERAMIC CHIP 0.22uF 25VC110 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C111 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC112 1-102-508-11 CERAMIC 10PF 0.5PF 50VC113 1-136-165-00 FILM 0.1uF 5% 50VC114 1-136-161-00 FILM 0.047uF 5% 50VC115 1-126-008-51 ELECT 47uF 20% 16V

C116 1-126-008-51 ELECT 47uF 20% 16VC118 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC201 1-126-047-81 ELECT 4.7uF 20% 50VC202 1-126-047-81 ELECT 4.7uF 20% 50VC203 1-163-243-11 CERAMIC CHIP 47PF 5% 50V

C204 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC205 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC206 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC207 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC208 1-126-047-81 ELECT 4.7uF 20% 50V

C209 1-164-222-11 CERAMIC CHIP 0.22uF 25VC210 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC211 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC212 1-102-508-11 CERAMIC 10PF 0.5PF 50VC213 1-136-165-00 FILM 0.1uF 5% 50V

C214 1-136-161-00 FILM 0.047uF 5% 50VC215 1-126-008-51 ELECT 47uF 20% 16VC216 1-126-008-51 ELECT 47uF 20% 16VC218 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC301 1-126-047-81 ELECT 4.7uF 20% 50V

C302 1-126-047-81 ELECT 4.7uF 20% 50VC303 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC304 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC305 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC306 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C307 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC308 1-126-047-81 ELECT 4.7uF 20% 50V

C309 1-164-222-11 CERAMIC CHIP 0.22uF 25VC310 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC311 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C312 1-102-508-11 CERAMIC 10PF 0.5PF 50VC313 1-136-165-00 FILM 0.1uF 5% 50VC314 1-136-161-00 FILM 0.047uF 5% 50VC315 1-126-008-51 ELECT 47uF 20% 16VC316 1-126-008-51 ELECT 47uF 20% 16V

C318 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC401 1-126-047-81 ELECT 4.7uF 20% 50VC402 1-126-047-81 ELECT 4.7uF 20% 50VC403 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC404 1-163-239-11 CERAMIC CHIP 33PF 5% 50V

C405 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC406 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC407 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC408 1-126-047-81 ELECT 4.7uF 20% 50VC409 1-164-222-11 CERAMIC CHIP 0.22uF 25V

C410 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC411 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC412 1-102-508-11 CERAMIC 10PF 0.5PF 50VC413 1-136-165-00 FILM 0.1uF 5% 50VC414 1-136-161-00 FILM 0.047uF 5% 50V

C415 1-126-008-51 ELECT 47uF 20% 16VC416 1-126-008-51 ELECT 47uF 20% 16VC418 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC703 1-126-010-81 ELECT 220uF 16VC704 1-126-010-81 ELECT 220uF 16V

C705 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC706 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC707 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC708 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC850 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V

C851 1-126-025-11 ELECT 330uF 20% 25VC852 1-164-222-11 CERAMIC CHIP 0.22uF 25VC853 1-126-025-11 ELECT 330uF 20% 25VC854 1-164-222-11 CERAMIC CHIP 0.22uF 25VC856 1-165-319-11 CERAMIC CHIP 0.1uF 50V

C857 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC858 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC859 1-126-006-11 ELECT 22uF 20% 16VC860 1-124-997-11 ELECT 470uF 20% 10VC861 1-126-052-11 ELECT 100uF 20% 50V

C862 1-126-052-11 ELECT 100uF 20% 50VC863 1-136-161-00 FILM 0.047uF 5% 50VC864 1-136-161-00 FILM 0.047uF 5% 50V

20


C865 1-126-009-81 ELECT 100uF 20% 16VC866 1-126-009-81 ELECT 100uF 20% 16V

C867 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC868 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC869 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC870 1-126-008-51 ELECT 47uF 20% 16VC871 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

C872 1-126-008-51 ELECT 47uF 20% 16VC874 1-136-165-00 FILM 0.1uF 5% 50VC875 1-136-165-00 FILM 0.1uF 5% 50VC876 1-136-165-00 FILM 0.1uF 5% 50VC877 1-136-165-00 FILM 0.1uF 5% 50V

C878 1-131-730-11 ELECT 8200uF 35VC879 1-131-730-11 ELECT 8200uF 35VC880 1-131-730-11 ELECT 8200uF 35VC881 1-131-730-11 ELECT 8200uF 35VC882 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

C883 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC884 1-163-029-11 CERAMIC CHIP 0.0047uF 50VC885 1-163-029-11 CERAMIC CHIP 0.0047uF 50VC886 1-163-029-11 CERAMIC CHIP 0.0047uF 50VC887 1-163-029-11 CERAMIC CHIP 0.0047uF 50V

C888 1-165-319-11 CERAMIC CHIP 0.1uF 50VC889 1-165-319-11 CERAMIC CHIP 0.1uF 50VC890 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC891 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC892 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

C893 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC894 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC895 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC896 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC897 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25V

C898 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25VC899 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V

< CONNECTOR >

CN810 1-694-619-11 TERMINAL BOARD 4P(SPEAKER OUT/C/D CHANNEL)

CN811 1-694-619-11 TERMINAL BOARD 4P(SPEAKER OUT/A/B CHANNEL)

< JACK >

CNJ807 1-770-068-71 JACK, PIN 4P (INPUT MONO A/B C/D)

< CONNECTOR >

* CNP805 1-564-513-11 PLUG, CONNECTOR 10P* CNP806 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P

CNP808 1-784-917-11 CONNECTOR, BOARD TO BOARD 9PCNP809 1-784-917-11 CONNECTOR, BOARD TO BOARD 9P

< DIODE >

D101 8-719-025-50 DIODE 02CZ16-TE85LD102 8-719-025-50 DIODE 02CZ16-TE85LD103 8-719-820-05 DIODE 1SS181-TE85RD104 8-719-820-05 DIODE 1SS181-TE85RD105 8-719-100-65 DIODE RD12EB2

D106 8-719-100-65 DIODE RD12EB2D201 8-719-025-50 DIODE 02CZ16-TE85LD202 8-719-025-50 DIODE 02CZ16-TE85LD203 8-719-820-05 DIODE 1SS181-TE85RD204 8-719-820-05 DIODE 1SS181-TE85R

D205 8-719-100-65 DIODE RD12EB2D206 8-719-100-65 DIODE RD12EB2D301 8-719-025-50 DIODE 02CZ16-TE85LD302 8-719-025-50 DIODE 02CZ16-TE85LD303 8-719-820-05 DIODE 1SS181-TE85R

D304 8-719-820-05 DIODE 1SS181-TE85RD305 8-719-100-65 DIODE RD12EB2D306 8-719-100-65 DIODE RD12EB2D401 8-719-025-50 DIODE 02CZ16-TE85LD402 8-719-025-50 DIODE 02CZ16-TE85L

D403 8-719-820-05 DIODE 1SS181-TE85RD404 8-719-820-05 DIODE 1SS181-TE85RD405 8-719-100-65 DIODE RD12EB2D406 8-719-100-65 DIODE RD12EB2D851 8-719-801-78 DIODE 1SS184-TE85L

D853 8-719-018-77 DIODE 02CZ10YD854 8-719-987-67 DIODE 11EFS2-TB5D855 8-719-987-67 DIODE 11EFS2-TB5D856 8-719-210-21 DIODE 11EQS04-TA1BD857 8-719-210-21 DIODE 11EQS04-TA1B

D858 8-719-210-21 DIODE 11EQS04-TA1BD859 8-719-210-21 DIODE 11EQS04-TA1BD860 8-719-987-67 DIODE 11EFS2-TB5D861 8-719-987-67 DIODE 11EFS2-TB5D862 8-719-200-82 DIODE 11ES2-TB5

D863 8-719-200-82 DIODE 11ES2-TB5D864 8-719-200-82 DIODE 11ES2-TB5D865 8-719-200-82 DIODE 11ES2-TB5

< IC >

IC801 8-759-711-82 IC NJM4580E(T1)IC802 8-759-711-82 IC NJM4580E(T1)IC806 8-759-711-82 IC NJM4580E(T1)IC807 8-759-711-82 IC NJM4580E(T1)IC808 8-759-711-82 IC NJM4580E(T1)

IC812 8-759-711-82 IC NJM4580E(T1)IC851 8-759-711-82 IC NJM4580E(T1)

< COIL >

L852 1-410-396-71 INDUCTOR 0.45uHL951 1-410-396-71 INDUCTOR 0.45uH

< TRANSISTOR >

Q101 8-729-107-43 TRANSISTOR 2SC3624-T1L1718Q102 8-729-203-48 TRANSISTOR 2SC3327-AQ103 8-729-203-48 TRANSISTOR 2SC3327-AQ104 8-729-184-53 TRANSISTOR 2SC1841-FAQ105 8-729-140-82 TRANSISTOR 2SA988-FA

Q106 8-729-184-53 TRANSISTOR 2SC1841-FAQ107 8-729-140-82 TRANSISTOR 2SA988-FAQ108 8-729-209-18 TRANSISTOR 2SA1360-YQ109 8-729-203-45 TRANSISTOR 2SC3423-Y

AMPLIFIER

21


Q110 8-729-207-82 TRANSISTOR 2SC3421-Y

Q111 8-729-049-52 TRANSISTOR FS70SMJ-2Q112 8-729-049-53 TRANSISTOR FX50SMJ-2Q113 8-729-216-21 TRANSISTOR 2SA1162-YQ114 8-729-216-21 TRANSISTOR 2SA1162-YQ115 8-729-230-51 TRANSISTOR 2SC2712YG-TE85R

Q116 8-729-230-51 TRANSISTOR 2SC2712YG-TE85RQ201 8-729-107-43 TRANSISTOR 2SC3624-T1L1718Q202 8-729-203-48 TRANSISTOR 2SC3327-AQ203 8-729-203-48 TRANSISTOR 2SC3327-AQ204 8-729-184-53 TRANSISTOR 2SC1841-FA

Q205 8-729-140-82 TRANSISTOR 2SA988-FAQ206 8-729-184-53 TRANSISTOR 2SC1841-FAQ207 8-729-140-82 TRANSISTOR 2SA988-FAQ208 8-729-209-18 TRANSISTOR 2SA1360-YQ209 8-729-203-45 TRANSISTOR 2SC3423-Y

Q210 8-729-207-82 TRANSISTOR 2SC3421-YQ211 8-729-049-52 TRANSISTOR FS70SMJ-2Q212 8-729-049-53 TRANSISTOR FX50SMJ-2Q213 8-729-216-21 TRANSISTOR 2SA1162-YQ214 8-729-216-21 TRANSISTOR 2SA1162-Y

Q215 8-729-230-51 TRANSISTOR 2SC2712YG-TE85RQ216 8-729-230-51 TRANSISTOR 2SC2712YG-TE85RQ301 8-729-107-43 TRANSISTOR 2SC3624-T1L1718Q302 8-729-203-48 TRANSISTOR 2SC3327-AQ303 8-729-203-48 TRANSISTOR 2SC3327-A

Q304 8-729-184-53 TRANSISTOR 2SC1841-FAQ305 8-729-140-82 TRANSISTOR 2SA988-FAQ306 8-729-184-53 TRANSISTOR 2SC1841-FAQ307 8-729-140-82 TRANSISTOR 2SA988-FAQ308 8-729-209-18 TRANSISTOR 2SA1360-Y

Q309 8-729-203-45 TRANSISTOR 2SC3423-YQ310 8-729-207-82 TRANSISTOR 2SC3421-YQ311 8-729-049-52 TRANSISTOR FS70SMJ-2Q312 8-729-049-53 TRANSISTOR FX50SMJ-2Q313 8-729-216-21 TRANSISTOR 2SA1162-Y

Q314 8-729-216-21 TRANSISTOR 2SA1162-YQ315 8-729-230-51 TRANSISTOR 2SC2712YG-TE85RQ316 8-729-230-51 TRANSISTOR 2SC2712YG-TE85RQ401 8-729-107-43 TRANSISTOR 2SC3624-T1L1718Q402 8-729-203-48 TRANSISTOR 2SC3327-A

Q403 8-729-203-48 TRANSISTOR 2SC3327-AQ404 8-729-184-53 TRANSISTOR 2SC1841-FAQ405 8-729-140-82 TRANSISTOR 2SA988-FAQ406 8-729-184-53 TRANSISTOR 2SC1841-FAQ407 8-729-140-82 TRANSISTOR 2SA988-FA

Q408 8-729-209-18 TRANSISTOR 2SA1360-YQ409 8-729-203-45 TRANSISTOR 2SC3423-YQ410 8-729-207-82 TRANSISTOR 2SC3421-YQ411 8-729-049-52 TRANSISTOR FS70SMJ-2Q412 8-729-049-53 TRANSISTOR FX50SMJ-2

Q413 8-729-216-21 TRANSISTOR 2SA1162-YQ414 8-729-216-21 TRANSISTOR 2SA1162-YQ415 8-729-230-51 TRANSISTOR 2SC2712YG-TE85RQ416 8-729-230-51 TRANSISTOR 2SC2712YG-TE85RQ851 8-729-207-89 TRANSISTOR 2SA1358-Y

Q852 8-729-230-49 TRANSISTOR 2SC2712-YQ853 8-729-141-83 TRANSISTOR 2SB1375Q854 8-729-230-49 TRANSISTOR 2SC2712-YQ855 8-729-205-88 TRANSISTOR 2SC3074-Y(TE16L)Q856 8-729-205-88 TRANSISTOR 2SC3074-Y(TE16L)

Q857 8-729-230-49 TRANSISTOR 2SC2712-YQ858 8-729-216-21 TRANSISTOR 2SA1162-YQ859 8-729-230-49 TRANSISTOR 2SC2712-YQ860 8-729-230-49 TRANSISTOR 2SC2712-YQ861 8-729-216-21 TRANSISTOR 2SA1162-Y

< RESISTOR >

R101 1-208-518-61 RES,CHIP 22K 2% 1/10WR102 1-208-518-61 RES,CHIP 22K 2% 1/10WR103 1-208-291-11 RES,CHIP 4.7M 5% 1/10WR104 1-208-518-61 RES,CHIP 22K 2% 1/10WR105 1-208-518-61 RES,CHIP 22K 2% 1/10W

R106 1-216-631-11 METAL CHIP 150 0.5% 1/10WR107 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR108 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR109 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR110 1-208-449-61 RES,CHIP 3.3K 2% 1/10W

R111 1-216-647-11 METAL CHIP 680 0.5% 1/10WR112 1-208-518-61 RES,CHIP 22K 2% 1/10WR113 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR114 1-208-510-61 RES,CHIP 10K 2% 1/8WR115 1-208-510-61 RES,CHIP 10K 2% 1/8W

R116 1-208-462-61 RES,CHIP 10K 2% 1/10WR117 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR118 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR119 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR120 1-216-238-00 RES,CHIP 47K 2% 1/8W

R121 1-216-238-00 RES,CHIP 47K 2% 1/8WR124 1-216-635-11 METAL CHIP 220 0.5% 1/10WR125 1-216-635-11 METAL CHIP 220 0.5% 1/10WR126 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR127 1-208-437-61 RES,CHIP 1K 2% 1/10W

R128 1-249-955-11 CARBON 22K 5% 1/4WR129 1-249-955-11 CARBON 22K 5% 1/4WR130 1-208-534-61 RES,CHIP 100K 2% 1/10WR131 1-208-534-61 RES,CHIP 100K 2% 1/10WR132 1-211-960-11 RES,CHIP 22 2% 1/10W

R133 1-211-960-11 RES,CHIP 22 2% 1/10WR134 1-208-437-61 RES,CHIP 1K 2% 1/10WR135 1-208-437-61 RES,CHIP 1K 2% 1/10WR136 1-208-437-61 RES,CHIP 1K 2% 1/10WR137 1-208-437-61 RES,CHIP 1K 2% 1/10W

R138 1-242-799-11 METAL 0.06/0.06 5W FR139 1-242-799-11 METAL 0.06/0.06 5W FR140 1-242-799-11 METAL 0.06/0.06 5W FR141 1-242-799-11 METAL 0.06/0.06 5W FR143 1-208-789-11 RES,CHIP 2K 2% 1/10W

R145 1-208-789-11 RES,CHIP 2K 2% 1/10WR146 1-208-462-61 RES,CHIP 10K 2% 1/10WR147 1-208-462-61 RES,CHIP 10K 2% 1/10WR148 1-208-462-61 RES,CHIP 10K 2% 1/10WR149 1-208-462-61 RES,CHIP 10K 2% 1/10W

AMPLIFIER

22


R150 1-208-462-61 RES,CHIP 10K 2% 1/10WR151 1-208-462-61 RES,CHIP 10K 2% 1/10WR152 1-208-550-61 RES,CHIP 470K 2% 1/10WR153 1-217-784-11 FUSIBLE 10 5% 5W FR154 1-249-935-11 CARBON 3.3K 5% 1/4W

R155 1-249-943-11 CARBON 6.8K 5% 1/4WR156 1-249-576-11 CARBON 10K 5% 1/4WR157 1-249-576-11 CARBON 10K 5% 1/4WR201 1-208-518-61 RES,CHIP 22K 2% 1/10WR202 1-208-518-61 RES,CHIP 22K 2% 1/10W

R203 1-208-291-11 RES,CHIP 4.7M 5% 1/10WR204 1-208-518-61 RES,CHIP 22K 2% 1/10WR205 1-208-518-61 RES,CHIP 22K 2% 1/10WR206 1-216-631-11 METAL CHIP 150 0.5% 1/10WR207 1-208-453-61 RES,CHIP 4.7K 2% 1/10W

R208 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR209 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR210 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR211 1-216-647-11 METAL CHIP 680 0.5% 1/10WR212 1-208-518-61 RES,CHIP 22K 2% 1/10W

R213 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR214 1-208-510-61 RES,CHIP 10K 2% 1/8WR215 1-208-510-61 RES,CHIP 10K 2% 1/8WR216 1-208-462-61 RES,CHIP 10K 2% 1/10WR217 1-208-449-61 RES,CHIP 3.3K 2% 1/10W

R218 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR219 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR220 1-216-238-00 RES,CHIP 47K 2% 1/8WR221 1-216-238-00 RES,CHIP 47K 2% 1/8WR224 1-216-635-11 METAL CHIP 220 0.5% 1/10W

R225 1-216-635-11 METAL CHIP 220 0.5% 1/10WR226 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR227 1-208-437-61 RES,CHIP 1K 2% 1/10WR228 1-249-955-11 CARBON 22K 5% 1/4WR229 1-249-955-11 CARBON 22K 5% 1/4W

R230 1-208-534-61 RES,CHIP 100K 2% 1/10WR231 1-208-534-61 RES,CHIP 100K 2% 1/10WR232 1-211-960-11 RES,CHIP 22 2% 1/10WR233 1-211-960-11 RES,CHIP 22 2% 1/10WR234 1-208-437-61 RES,CHIP 1K 2% 1/10W

R235 1-208-437-61 RES,CHIP 1K 2% 1/10WR236 1-208-437-61 RES,CHIP 1K 2% 1/10WR237 1-208-437-61 RES,CHIP 1K 2% 1/10WR238 1-242-799-11 METAL 0.06/0.06 5W FR239 1-242-799-11 METAL 0.06/0.06 5W F

R240 1-242-799-11 METAL 0.06/0.06 5W FR241 1-242-799-11 METAL 0.06/0.06 5W FR243 1-208-789-11 RES,CHIP 2K 2% 1/10WR245 1-208-789-11 RES,CHIP 2K 2% 1/10WR246 1-208-462-61 RES,CHIP 10K 2% 1/10W


R252 1-208-550-61 RES,CHIP 470K 2% 1/10WR253 1-217-784-11 FUSIBLE 10 5% 5W F

R254 1-249-568-11 CARBON 4.7K 5% 1/4WR255 1-249-943-11 CARBON 6.8K 5% 1/4WR256 1-249-576-11 CARBON 10K 5% 1/4W

R257 1-249-576-11 CARBON 10K 5% 1/4WR301 1-208-518-61 RES,CHIP 22K 2% 1/10WR302 1-208-518-61 RES,CHIP 22K 2% 1/10WR303 1-208-291-11 RES,CHIP 4.7M 5% 1/10WR304 1-208-518-61 RES,CHIP 22K 2% 1/10W

R305 1-208-518-61 RES,CHIP 22K 2% 1/10WR306 1-216-631-11 METAL CHIP 150 0.5% 1/10WR307 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR308 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR309 1-208-453-61 RES,CHIP 4.7K 2% 1/10W

R310 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR311 1-216-647-11 METAL CHIP 680 0.5% 1/10WR312 1-208-518-61 RES,CHIP 22K 2% 1/10WR313 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR314 1-208-510-61 RES,CHIP 10K 2% 1/8W

R315 1-208-510-61 RES,CHIP 10K 2% 1/8WR316 1-208-462-61 RES,CHIP 10K 2% 1/10WR317 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR318 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR319 1-208-453-61 RES,CHIP 4.7K 2% 1/10W

R320 1-216-238-00 RES,CHIP 47K 2% 1/8WR321 1-216-238-00 RES,CHIP 47K 2% 1/8WR324 1-216-635-11 METAL CHIP 220 0.5% 1/10WR325 1-216-635-11 METAL CHIP 220 0.5% 1/10WR326 1-208-449-61 RES,CHIP 3.3K 2% 1/10W

R327 1-208-437-61 RES,CHIP 1K 2% 1/10WR328 1-249-955-11 CARBON 22K 5% 1/4WR329 1-249-955-11 CARBON 22K 5% 1/4WR330 1-208-534-61 RES,CHIP 100K 2% 1/10WR331 1-208-534-61 RES,CHIP 100K 2% 1/10W

R332 1-211-960-11 RES,CHIP 22 2% 1/10WR333 1-211-960-11 RES,CHIP 22 2% 1/10WR334 1-208-437-61 RES,CHIP 1K 2% 1/10WR335 1-208-437-61 RES,CHIP 1K 2% 1/10WR336 1-208-437-61 RES,CHIP 1K 2% 1/10W

R337 1-208-437-61 RES,CHIP 1K 2% 1/10WR338 1-242-799-11 METAL 0.06/0.06 5W FR339 1-242-799-11 METAL 0.06/0.06 5W FR340 1-242-799-11 METAL 0.06/0.06 5W FR341 1-242-799-11 METAL 0.06/0.06 5W F


R349 1-208-462-61 RES,CHIP 10K 2% 1/10WR350 1-208-462-61 RES,CHIP 10K 2% 1/10WR351 1-208-462-61 RES,CHIP 10K 2% 1/10WR352 1-208-550-61 RES,CHIP 470K 2% 1/10WR353 1-217-784-11 FUSIBLE 10 5% 5W F

R354 1-249-935-11 CARBON 3.3K 5% 1/4WR355 1-249-943-11 CARBON 6.8K 5% 1/4WR356 1-249-576-11 CARBON 10K 5% 1/4WR357 1-249-576-11 CARBON 10K 5% 1/4W

AMPLIFIER

23


R401 1-208-518-61 RES,CHIP 22K 2% 1/10W

R402 1-208-518-61 RES,CHIP 22K 2% 1/10WR403 1-208-291-11 RES,CHIP 4.7M 5% 1/10WR404 1-208-518-61 RES,CHIP 22K 2% 1/10WR405 1-208-518-61 RES,CHIP 22K 2% 1/10WR406 1-216-631-11 METAL CHIP 150 0.5% 1/10W

R407 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR408 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR409 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR410 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR411 1-216-647-11 METAL CHIP 680 0.5% 1/10W

R412 1-208-518-61 RES,CHIP 22K 2% 1/10WR413 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR414 1-208-510-61 RES,CHIP 10K 2% 1/8WR415 1-208-510-61 RES,CHIP 10K 2% 1/8WR416 1-208-462-61 RES,CHIP 10K 2% 1/10W

R417 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR418 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR419 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR420 1-216-238-00 RES,CHIP 47K 2% 1/8WR421 1-216-238-00 RES,CHIP 47K 2% 1/8W

R424 1-216-635-11 METAL CHIP 220 0.5% 1/10WR425 1-216-635-11 METAL CHIP 220 0.5% 1/10WR426 1-208-449-61 RES,CHIP 3.3K 2% 1/10WR427 1-208-437-61 RES,CHIP 1K 2% 1/10WR428 1-249-955-11 CARBON 22K 5% 1/4W

R429 1-249-955-11 CARBON 22K 5% 1/4WR430 1-208-534-61 RES,CHIP 100K 2% 1/10WR431 1-208-534-61 RES,CHIP 100K 2% 1/10WR432 1-211-960-11 RES,CHIP 22 2% 1/10WR433 1-211-960-11 RES,CHIP 22 2% 1/10W



R450 1-208-462-61 RES,CHIP 10K 2% 1/10WR451 1-208-462-61 RES,CHIP 10K 2% 1/10WR452 1-208-550-61 RES,CHIP 470K 2% 1/10WR453 1-217-784-11 FUSIBLE 10 5% 5W FR454 1-249-568-11 CARBON 4.7K 5% 1/4W

R455 1-249-943-11 CARBON 6.8K 5% 1/4WR456 1-249-576-11 CARBON 10K 5% 1/4WR457 1-249-576-11 CARBON 10K 5% 1/4WR851 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR852 1-208-486-61 RES,CHIP 1K 2% 1/8W

R853 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR854 1-208-486-61 RES,CHIP 1K 2% 1/8WR855 1-208-462-61 RES,CHIP 10K 2% 1/10WR856 1-208-462-61 RES,CHIP 10K 2% 1/10WR857 1-208-441-61 RES,CHIP 1.5K 2% 1/10W

R858 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR859 1-208-462-61 RES,CHIP 10K 2% 1/10WR860 1-208-539-11 RES,CHIP 160K 2% 1/10WR861 1-208-539-11 RES,CHIP 160K 2% 1/10WR862 1-208-774-11 RES,CHIP 470 2% 1/10W

R863 1-208-518-61 RES,CHIP 22K 2% 1/10WR864 1-208-526-61 RES,CHIP 47K 2% 1/10WR866 1-216-659-11 METAL CHIP 2.2K 0.5% 1/10WR867 1-208-437-61 RES,CHIP 1K 2% 1/10WR868 1-208-437-61 RES,CHIP 1K 2% 1/10W

R870 1-208-462-61 RES,CHIP 10K 2% 1/10WR871 1-208-462-61 RES,CHIP 10K 2% 1/10WR872 1-208-462-61 RES,CHIP 10K 2% 1/10WR873 1-208-462-61 RES,CHIP 10K 2% 1/10WR874 1-216-121-91 RES,CHIP 1M 5% 1/10W

R875 1-208-462-61 RES,CHIP 10K 2% 1/10WR876 1-208-462-61 RES,CHIP 10K 2% 1/10WR877 1-216-121-00 RES,CHIP 1M 5% 1/10WR878 1-216-603-11 METAL CHIP 10 0.5% 1/10WR879 1-216-603-11 METAL CHIP 10 0.5% 1/10W

R880 1-216-603-11 METAL CHIP 10 0.5% 1/10WR881 1-216-603-11 METAL CHIP 10 0.5% 1/10WR882 1-216-121-00 RES,CHIP 1M 5% 1/10WR883 1-208-462-61 RES,CHIP 10K 2% 1/10WR884 1-208-462-61 RES,CHIP 10K 2% 1/10W

R885 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR886 1-216-665-11 METAL CHIP 3.9K 0.5% 1/10WR887 1-216-665-11 METAL CHIP 3.9K 0.5% 1/10W

< RELAY >

RY801 1-755-353-11 RELAYRY802 1-755-353-11 RELAY

< SWITCH >

S805 1-692-721-11 SWITCH, SLIDE (DIRECT/ON˜OFF)S806 1-692-721-11 SWITCH, SLIDE (DIRECT/ON˜OFF)S851 1-771-802-11 SWITCH (TEST TONE)

< TRANSFORMER >

T851 1-435-149-11 TRANSFORMER, DC-DC CONVERTER

< THERMISTOR >

TH851 1-809-664-51 THERMISTOR, POSITIVE

< VARIABLE RESISTOR >

VR101 1-241-760-11 RES, ADJ, CERMET 470 (IDLING)VR201 1-241-760-11 RES, ADJ, CERMET 470 (IDLING)VR301 1-241-760-11 RES, ADJ, CERMET 470 (IDLING)VR401 1-241-760-11 RES, ADJ, CERMET 470 (IDLING)VR801 1-225-648-11 RES, VAR 5K/5K (LEVEL/MIN-MAX)

VR802 1-225-648-11 RES, VAR 5K/5K (LEVEL/MIN-MAX)VR803 1-225-648-11 RES, VAR 5K/5K (LOW BOOST/0dB-+10dB)VR804 1-225-648-11 RES, VAR 5K/5K (LOW BOOST/0dB-+10dB)

**************************************************************

AMPLIFIER

24


LEDFILTER

1-675-246-11 FILTER (4CH) BOARD*****************

< CAPACITOR >

C151 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC152 1-136-167-00 FILM 0.15uF 5% 50VC153 1-136-155-00 FILM 0.015uF 5% 50VC154 1-136-167-00 FILM 0.15uF 5% 50VC155 1-136-155-00 FILM 0.015uF 5% 50V

C156 1-126-008-51 ELECT 47uF 20% 16VC157 1-126-008-51 ELECT 47uF 20% 16VC251 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC252 1-136-167-00 FILM 0.15uF 5% 50VC253 1-136-155-00 FILM 0.015uF 5% 50V

C254 1-136-167-00 FILM 0.15uF 5% 50VC255 1-136-155-00 FILM 0.015uF 5% 50VC256 1-126-008-51 ELECT 47uF 20% 16VC257 1-126-008-51 ELECT 47uF 20% 16V

C351 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC352 1-136-167-00 FILM 0.15uF 5% 50VC353 1-136-155-00 FILM 0.015uF 5% 50VC354 1-136-167-00 FILM 0.15uF 5% 50VC355 1-136-155-00 FILM 0.015uF 5% 50V

C356 1-126-008-51 ELECT 47uF 20% 16VC357 1-126-008-51 ELECT 47uF 20% 16VC451 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC452 1-136-167-00 FILM 0.15uF 5% 50VC453 1-136-155-00 FILM 0.015uF 5% 50V

C454 1-136-167-00 FILM 0.15uF 5% 50VC455 1-136-155-00 FILM 0.015uF 5% 50VC456 1-126-008-51 ELECT 47uF 20% 16VC457 1-126-008-51 ELECT 47uF 20% 16VC751 1-164-001-11 CERAMIC CHIP 0.1uF 10% 25V

C752 1-164-001-11 CERAMIC CHIP 0.1uF 10% 25VC753 1-164-001-11 CERAMIC CHIP 0.1uF 10% 25VC754 1-164-001-11 CERAMIC CHIP 0.1uF 10% 25V

< JACK >

CNJ808 1-784-916-11 CONNECTOR, BOARD TO BOARD 9PCNJ809 1-784-916-11 CONNECTOR, BOARD TO BOARD 9P

< IC >

IC803 8-759-711-82 IC NJM4580E(T1)IC804 8-759-711-82 IC NJM4580E(T1)IC805 8-759-711-82 IC NJM4580E(T1)IC809 8-759-711-82 IC NJM4580E(T1)IC810 8-759-711-82 IC NJM4580E(T1)

IC811 8-759-711-82 IC NJM4580E(T1)

< RESISTOR >

R181 1-208-462-61 RES,CHIP 10K 2% 1/10WR182 1-208-518-61 RES,CHIP 22K 2% 1/10WR183 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR184 1-208-462-61 RES,CHIP 10K 2% 1/10WR185 1-208-462-61 RES,CHIP 10K 2% 1/10W

R186 1-216-057-61 RES,CHIP 2.2K 5% 1/10W

R187 1-216-057-61 RES,CHIP 2.2K 5% 1/10WR189 1-208-462-61 RES,CHIP 10K 2% 1/10WR190 1-208-462-61 RES,CHIP 10K 2% 1/10WR281 1-208-462-61 RES,CHIP 10K 2% 1/10W

R282 1-208-518-61 RES,CHIP 22K 2% 1/10WR283 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR284 1-208-462-61 RES,CHIP 10K 2% 1/10WR285 1-208-462-61 RES,CHIP 10K 2% 1/10WR286 1-216-057-61 RES,CHIP 2.2K 5% 1/10W

R287 1-216-057-61 RES,CHIP 2.2K 5% 1/10WR289 1-208-462-61 RES,CHIP 10K 2% 1/10WR290 1-208-462-61 RES,CHIP 10K 2% 1/10WR381 1-208-462-61 RES,CHIP 10K 2% 1/10WR382 1-208-518-61 RES,CHIP 22K 2% 1/10W

R383 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR384 1-208-462-61 RES,CHIP 10K 2% 1/10WR385 1-208-462-61 RES,CHIP 10K 2% 1/10WR386 1-216-057-61 RES,CHIP 2.2K 5% 1/10WR387 1-216-057-61 RES,CHIP 2.2K 5% 1/10W

R389 1-208-462-61 RES,CHIP 10K 2% 1/10WR390 1-208-462-61 RES,CHIP 10K 2% 1/10WR481 1-208-462-61 RES,CHIP 10K 2% 1/10WR482 1-208-518-61 RES,CHIP 22K 2% 1/10WR483 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10W

R484 1-208-462-61 RES,CHIP 10K 2% 1/10WR485 1-208-462-61 RES,CHIP 10K 2% 1/10WR486 1-216-057-61 RES,CHIP 2.2K 5% 1/10WR487 1-216-057-61 RES,CHIP 2.2K 5% 1/10WR489 1-208-462-61 RES,CHIP 10K 2% 1/10W

R490 1-208-462-61 RES,CHIP 10K 2% 1/10W

< SWITCH >

S801 1-571-658-11 SWITCH, SLIDE (FILTER, X1/X10)S802 1-571-658-11 SWITCH, SLIDE (FILTER, X1/X10)S803 1-762-191-11 SWITCH, SLIDE (FILTER, LPF/OFF/HPF)S804 1-762-191-11 SWITCH, SLIDE (FILTER, LPF/OFF/HPF)

< VARIABLE RESISTOR >

VR805 1-225-921-11 RES, VAR 20K/20K/20K/20K(FILTER/50Hz-400Hz)

VR806 1-225-921-11 RES, VAR 20K/20K/20K/20K(FILTER/50Hz-400Hz)

**************************************************************

* 1-675-245-11 LED (4CH) BOARD**************

< DIODE >

D801 8-719-076-62 DIODE GL-5ED60 (HI-VOLTAGE)D802 8-719-076-62 DIODE GL-5ED60 (HI-CURRENT)D803 8-719-076-62 DIODE GL-5ED60 (OFFSET)D804 8-719-076-62 DIODE GL-5ED60 (OVER CURRENT)D805 8-719-076-62 DIODE GL-5ED60 (THERMAL)

< TRANSISTOR >

Q801 8-729-230-49 TRANSISTOR 2SC2712-YQ802 8-729-230-49 TRANSISTOR 2SC2712-Y

25


Q803 8-729-230-49 TRANSISTOR 2SC2712-Y

< RESISTOR >

R801 1-216-194-00 METAL CHIP 680 5% 1/8WR802 1-216-194-00 METAL CHIP 680 5% 1/8WR803 1-216-190-00 RES,CHIP 470 2% 1/8WR804 1-216-190-00 RES,CHIP 470 2% 1/8WR805 1-216-194-00 METAL CHIP 680 5% 1/8W

R806 1-216-194-00 METAL CHIP 680 5% 1/8WR807 1-216-190-00 RES,CHIP 470 2% 1/8WR808 1-216-190-00 RES,CHIP 470 2% 1/8WR809 1-216-194-00 METAL CHIP 680 5% 1/8WR810 1-216-194-00 METAL CHIP 680 5% 1/8W

R811 1-216-190-00 RES,CHIP 470 2% 1/8WR812 1-216-190-00 RES,CHIP 470 2% 1/8WR813 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR814 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR815 1-216-057-00 METAL CHIP 2.2K 5% 1/10W

**************************************************************

* A-3317-933-A POWER BOARD, COMPLETE****************************

< CAPACITOR >

C801 1-163-133-00 CERAMIC CHIP 470PF 5% 50VC802 1-126-006-11 ELECT 22uF 20% 16VC803 1-126-006-11 ELECT 22uF 20% 16VC804 1-163-133-00 CERAMIC CHIP 470PF 5% 50VC805 1-107-715-11 ELECT 22uF 20% 16V

C806 1-126-006-11 ELECT 22uF 20% 16VC902 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50VC904 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50VC905 1-126-009-81 ELECT 100uF 20% 16VC906 1-126-006-11 ELECT 22uF 20% 16V

C907 1-124-993-11 ELECT 47uF 20% 10VC908 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC909 1-107-715-11 ELECT 22uF 20% 16VC910 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50VC911 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C913 1-131-731-11 ELECT 2200uF 16VC914 1-131-731-11 ELECT 2200uF 16VC915 1-131-731-11 ELECT 2200uF 16VC916 1-131-731-11 ELECT 2200uF 16VC917 1-104-829-11 ELECT 220uF 20% 35V

C918 1-104-829-11 ELECT 220uF 20% 35VC919 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC921 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50VC922 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC923 1-126-009-81 ELECT 100uF 20% 16V

C924 1-126-006-11 ELECT 22uF 20% 16VC925 1-124-993-11 ELECT 47uF 20% 10VC926 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC927 1-107-715-11 ELECT 22uF 20% 16VC928 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V

C929 1-131-731-11 ELECT 2200uF 16VC930 1-131-731-11 ELECT 2200uF 16VC931 1-131-731-11 ELECT 2200uF 16VC932 1-131-731-11 ELECT 2200uF 16V

C935 1-104-829-11 ELECT 220uF 20% 35V

C936 1-104-829-11 ELECT 220uF 20% 35VC937 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC944 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC945 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V

< CONNECTOR >

CN802 1-694-620-11 TERMINAL BOARD 3P (+12V, GND, +12V)

< JACK >

CNJ801 1-793-279-11 CONNECTOR 1P (REMOTE)

< CONNECTOR >

* CNP804 1-564-709-11 PIN, CONNECTOR (SMALL TYPE) 7P

< DIODE >

D806 8-719-801-78 DIODE 1SS184-TE85LD807 8-719-801-78 DIODE 1SS184-TE85LD808 8-719-025-34 DIODE 02CZ6.8-TE85LD809 8-719-160-56 DIODE RD12FB2D901 8-719-025-50 DIODE 02CZ16-TE85L

D902 8-719-043-82 DIODE 02CZ5.1Y-TE85LD903 8-719-160-90 DIODE RD36FB2D904 8-719-025-49 DIODE 02CZ15-TE85LD905 8-719-076-60 DIODE FCH20A15D906 8-719-076-61 DIODE FRH20A15

D907 8-719-801-78 DIODE 1SS184-TE85LD908 8-719-801-78 DIODE 1SS184-TE85LD909 8-719-801-78 DIODE 1SS184-TE85LD910 8-719-160-90 DIODE RD36FB2D911 8-719-025-49 DIODE 02CZ15-TE85L

D912 8-719-076-60 DIODE FCH20A15D913 8-719-076-61 DIODE FRH20A15

< FUSE >

F901 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE)(25A)F902 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE)(25A)F903 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE)(25A)F904 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE)(25A)

< IC >

IC813 8-719-156-72 PHOTO COUPLER PS2501-1-KIC901 8-719-156-72 PHOTO COUPLER PS2501-1-KIC902 8-759-144-88 IC uPC494GS-T1IC903 8-719-156-72 PHOTO COUPLER PS2501-1-KIC904 8-759-144-88 IC uPC494GS-T1

< COIL >

L902 1-410-396-71 INDUCTOR 0.45uHL904 1-410-396-71 INDUCTOR 0.45uH

< PILOT LAMP >

PL901 1-518-540-00 LAMP, PILOT

< TRANSISTOR >

Q804 8-729-230-49 TRANSISTOR 2SC2712-Y

LED POWER

26


Q805 8-729-230-49 TRANSISTOR 2SC2712-YQ806 8-729-230-49 TRANSISTOR 2SC2712-YQ807 8-729-230-49 TRANSISTOR 2SC2712-YQ808 8-729-216-21 TRANSISTOR 2SA1162-Y

Q809 8-729-230-49 TRANSISTOR 2SC2712-YQ810 8-729-216-21 TRANSISTOR 2SA1162-YQ811 8-729-230-49 TRANSISTOR 2SC2712-YQ812 8-729-216-21 TRANSISTOR 2SA1162-YQ901 8-729-046-13 TRANSISTOR 2SB1243-QR-TV2

Q902 8-729-216-21 TRANSISTOR 2SA1162-YQ903 8-729-230-49 TRANSISTOR 2SC2712-YQ904 8-729-230-49 TRANSISTOR 2SC2712-YQ905 8-729-230-49 TRANSISTOR 2SC2712-YQ906 8-729-230-49 TRANSISTOR 2SC2712-Y

Q907 8-729-030-89 TRANSISTOR 2SA1680-TPE6Q908 8-729-030-89 TRANSISTOR 2SA1680-TPE6Q909 8-729-030-90 TRANSISTOR 2SC4408-TPE6Q910 8-729-030-90 TRANSISTOR 2SC4408-TPE6Q911 8-729-035-83 TRANSISTOR MTP75N06HD

Q912 8-729-035-83 TRANSISTOR MTP75N06HDQ913 8-729-035-83 TRANSISTOR MTP75N06HDQ914 8-729-035-83 TRANSISTOR MTP75N06HDQ915 8-729-035-83 TRANSISTOR MTP75N06HDQ916 8-729-035-83 TRANSISTOR MTP75N06HD

Q917 8-729-216-21 TRANSISTOR 2SA1162-YQ918 8-729-230-49 TRANSISTOR 2SC2712-YQ919 8-729-230-49 TRANSISTOR 2SC2712-YQ920 8-729-030-89 TRANSISTOR 2SA1680-TPE6Q921 8-729-030-89 TRANSISTOR 2SA1680-TPE6

Q922 8-729-030-90 TRANSISTOR 2SC4408-TPE6Q923 8-729-030-90 TRANSISTOR 2SC4408-TPE6Q924 8-729-035-83 TRANSISTOR MTP75N06HDQ925 8-729-035-83 TRANSISTOR MTP75N06HDQ926 8-729-035-83 TRANSISTOR MTP75N06HD

Q927 8-729-035-83 TRANSISTOR MTP75N06HDQ928 8-729-035-83 TRANSISTOR MTP75N06HDQ929 8-729-035-83 TRANSISTOR MTP75N06HD

< RESISTOR >

R816 1-216-190-00 RES,CHIP 470 2% 1/8WR817 1-216-190-00 RES,CHIP 470 2% 1/8WR818 1-216-190-00 RES,CHIP 470 2% 1/8WR819 1-216-190-00 RES,CHIP 470 2% 1/8WR820 1-208-462-61 RES,CHIP 10K 2% 1/10W


R826 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR827 1-208-462-61 RES,CHIP 10K 2% 1/10WR828 1-208-462-61 RES,CHIP 10K 2% 1/10WR829 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR830 1-208-462-61 RES,CHIP 10K 2% 1/10W

R831 1-208-462-61 RES,CHIP 10K 2% 1/10WR832 1-208-526-61 RES,CHIP 47K 2% 1/10WR833 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR834 1-216-234-00 RES,CHIP 33K 2% 1/8W

R835 1-216-698-11 METAL CHIP 91K 0.5% 1/10W

R836 1-208-437-61 RES,CHIP 1K 2% 1/10WR837 1-208-510-61 RES,CHIP 10K 2% 1/8WR838 1-249-405-11 CARBON 100 5% 1/4WR901 1-249-576-11 CARBON 10K 5% 1/4WR902 1-208-474-61 RES,CHIP 330 2% 1/8W

R903 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR904 1-208-486-61 RES,CHIP 1K 2% 1/8WR905 1-216-214-00 RES,CHIP 4.7K 2% 1/8WR906 1-208-441-61 RES,CHIP 1.5K 2% 1/10WR907 1-249-568-11 CARBON 4.7K 5% 1/4W

R909 1-216-429-11 RES,CHIP 470 2% 1/10WR910 1-218-760-11 RES,CHIP 220K 2% 1/10WR911 1-216-635-11 METAL CHIP 220 0.5% 1/10WR912 1-208-462-61 RES,CHIP 10K 2% 1/10WR913 1-208-462-61 RES,CHIP 10K 2% 1/10W

R914 1-208-466-61 RES,CHIP 15K 2% 1/10WR915 1-216-677-11 METAL CHIP 12K 0.5% 1/10WR916 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR917 1-216-635-11 METAL CHIP 220 0.5% 1/10WR918 1-208-437-61 RES,CHIP 1K 2% 1/10W

R919 1-208-437-61 RES,CHIP 1K 2% 1/10WR920 1-216-631-11 METAL CHIP 150 0.5% 1/10WR921 1-216-631-11 METAL CHIP 150 0.5% 1/10WR922 1-215-886-11 METAL OXIDE 100 5% 2W FR923 1-215-886-11 METAL OXIDE 100 5% 2W F

R924 1-208-437-61 RES,CHIP 1K 2% 1/10WR925 1-208-437-61 RES,CHIP 1K 2% 1/10WR926 1-208-397-61 RES,CHIP 22 2% 1/8WR927 1-208-437-61 RES,CHIP 1K 2% 1/10WR928 1-208-437-61 RES,CHIP 1K 2% 1/10W

R929 1-208-397-61 RES,CHIP 22 2% 1/8WR930 1-259-033-51 CARBON 1 5% 1/4WR931 1-259-033-51 CARBON 1 5% 1/4WR932 1-259-033-51 CARBON 1 5% 1/4WR933 1-259-033-51 CARBON 1 5% 1/4W

R934 1-259-033-51 CARBON 1 5% 1/4WR935 1-259-033-51 CARBON 1 5% 1/4WR936 1-208-462-61 RES,CHIP 10K 2% 1/10WR937 1-208-462-61 RES,CHIP 10K 2% 1/10WR938 1-208-550-61 RES,CHIP 470K 2% 1/10W

R939 1-208-462-61 RES,CHIP 10K 2% 1/10WR940 1-208-526-61 RES,CHIP 47K 2% 1/10WR941 1-208-441-61 RES,CHIP 1.5K 2% 1/10WR942 1-216-429-61 RES,CHIP 470 2% 1/10WR943 1-216-210-61 RES,CHIP 3.3K 2% 1/10W

R944 1-208-534-61 RES,CHIP 100K 2% 1/10WR945 1-218-760-11 RES,CHIP 220K 2% 1/10WR946 1-216-635-11 METAL CHIP 220 0.5% 1/10WR947 1-208-462-61 RES,CHIP 10K 2% 1/10WR948 1-208-462-61 RES,CHIP 10K 2% 1/10W

R949 1-208-466-61 RES,CHIP 15K 2% 1/10WR950 1-216-677-11 METAL CHIP 12K 0.5% 1/10WR951 1-208-453-61 RES,CHIP 4.7K 2% 1/10WR952 1-216-635-11 METAL CHIP 220 0.5% 1/10WR953 1-208-437-61 RES,CHIP 1K 2% 1/10W

R954 1-208-437-61 RES,CHIP 1K 2% 1/10W

POWER

27

Ref. No. Part No. Description Remark

R955 1-216-631-11 METAL CHIP 150 0.5% 1/10WR956 1-216-631-11 METAL CHIP 150 0.5% 1/10WR957 1-215-886-11 METAL OXIDE 100 5% 2W FR958 1-215-886-11 METAL OXIDE 100 5% 2W F

R959 1-208-437-61 RES,CHIP 1K 2% 1/10WR960 1-208-437-61 RES,CHIP 1K 2% 1/10WR961 1-208-397-61 RES,CHIP 22 2% 1/8WR962 1-208-437-61 RES,CHIP 1K 2% 1/10WR963 1-208-437-61 RES,CHIP 1K 2% 1/10W

R964 1-208-397-61 RES,CHIP 22 2% 1/8WR965 1-259-033-51 CARBON 1 5% 1/4WR966 1-259-033-51 CARBON 1 5% 1/4WR967 1-259-033-51 CARBON 1 5% 1/4WR968 1-259-033-51 CARBON 1 5% 1/4W

R969 1-259-033-51 CARBON 1 5% 1/4WR970 1-259-033-51 CARBON 1 5% 1/4W

< SWITCH >

S801 1-571-658-11 SWITCH, SLIDE (MODE, HI-C/HI-V)S802 1-692-721-11 SWITCH, SLIDE (NFB, ON/OFF)

< TRANSFORMER >

T901 1-435-148-11 TRANSFORMER, DC-DC CONVERTERT902 1-435-148-11 TRANSFORMER, DC-DC CONVERTER

< THERMISTOR >

TH901 1-810-506-11 THERMISTOR NTH5G39B223K01TH902 1-810-506-11 THERMISTOR NTH5G39B223K01TH903 1-810-506-11 THERMISTOR NTH5G39B223K01TH904 1-810-506-11 THERMISTOR NTH5G39B223K01TH905 1-810-506-11 THERMISTOR NTH5G39B223K01

**************************************************************

MISCELLANEOUS*************

F901 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)F902 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)F903 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)F904 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A)FN801 1-763-107-11 MOTOR, FAN

**************************************************************

Ref. No. Part No. Description Remark

ACCESSORIES************

3-867-641-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)3-867-641-21 MANUAL, INSTRUCTION

(GERMAN,ITALIAN)(AEP,UK,E)3-867-641-31 MANUAL, INSTRUCTION

(SPANISH,PORTUGUESE)(AEP,UK,E)3-867-641-41 MANUAL, INSTRUCTION

(DUTCH,SWEDISH)(AEP,UK,E)3-867-641-51 MANUAL, INSTRUCTION (RUSSIAN)(AEP,UK,E)

**************************************************************

HARDWARE LIST*************

#1 7-685-546-19 SCREW (+BTP3X8) TYPE2 N-S#2 7-685-548-19 SCREW (+BTP3X12) TYPE2 N-S#3 7-685-145-19 SCREW (+P3X6) TYPE2 NON-SLIT#4 7-685-147-11 SCREW (+P3X10) TYPE2 NON-SLIT#5 7-685-146-19 SCREW (+P3X8) TYPE2 NON-SLIT

#6 7-685-647-79 SCREW (+BVTP3X10) TYPE2 IT-3#7 7-685-106-11 SCREW (+P2X10) TYPE2 NON-SLIT#8 7-685-649-79 SCREW (+BVTP3X14) TYPE2 IT-3#9 7-685-168-11 SCREW (+P4X40) TYPE2 NON-SLIT#10 7-685-149-11 SCREW (+P3X14) TYPE2 NON-SLIT

#11 7-685-797-01 SCREW +PTT2.6X16 (S)

POWER

28

XM-7547

Sony CorporationMobile Electronics Company

9-926-591-1199F09278-1

Printed in Japan © 1999. 6Published by Quality Assurance Dept.

SERVICE MANUAL US Model Canadian Model AEP Model UK … - XM-7547_Car Power Amplifier SM.pdf · 2020. 10. 27. · XM-7547 10 10 5-4. PRINTED WIRING BOARD – LED/FILTER SECTION –

Documents