SERVICE MANUAL - ELECTRONICA MARINA MANUAL GENERAL ... schematic diagrams, ... supplied on a CD-ROM. This software runs under Windows 98, ME, Windows 2000 or XP on an IBM-PC or compatible
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
A personal computer (IBM PC or compatible), programminginterface (KPG-22), and programming software (KPG-87D)are required for programming.(The frequency, TX power HI/LOW, and signalling data are programmed for the transceiver.)
YES
NO
KMC-17 or KMC-21Speaker microphone
(Option)
Are you using the optional antenna?YES
NO
KRA-22 or KRA-26Optional antenna
TX/RX 136~174 5.0WTK-2202 (K,M)TK-2206 (M)
Frequency range (MHz) RF power Type
Unit Model TX-RX Unit Frequency range Remarks & destinationTK-2202 K,M
X57-6870-20 136~174MHzIF1 : 38.85MHz
TK-2206 M LOC : 38.4MHz
INTRODUCTION
SCOPE OF THIS MANUAL
This manual is intended for use by experienced techniciansfamiliar with similar types of commercial grade communicationsequipment. It contains all required service information for theequipment and is current as of the publication date. Changeswhich may occur after publication are covered by either ServiceBulletins or Manual Revisions. These are issued as required.
ORDERING REPLACEMENT PARTS
When ordering replacement parts or equipment information,the full part identification number should be included. Thisapplies to all parts, components, kits, or chassis. If the partnumber is not known, include the chassis or kit number ofwhich it is a part, and a sufficient description of the requiredcomponent for proper identification.
PERSONAL SAFETY
The following precautions are recommended for personalsafety: DO NOT transmit until all RF connectors are verified secure
and any open connectors are properly terminated. SHUT OFF and DO NOT operate this equipment near
electrical blasting caps or in an explosive atmosphere. This equipment should be serviced by a qualified technician
only.
SERVICE
This radio is designed for easy servicing. Refer to theschematic diagrams, printed circuit board views, and alignmentprocedures contained within.
TK-2202/2206
3
2. How to Enter Each Mode
Mode Operation
User mode Power ONPC mode Received commands from PCClone mode [PTT]+[Side2]+Power ON (Two seconds)
Mode Function
User mode For normal use.PC mode Used for communication between the
radio and PC (IBM compatible).Data programming Used to read and write frequency datamode and other features to and from the radio.PC test mode Used to check the radio using the PC.
This feature is included in the KPG-87D.
Clone mode Used to transfer programming datafrom one radio to another.
REALIGNMENT
1. Modes
User mode
PC mode
PC test mode
Data programmingmode
PC tuning mode
REALIGNMENT
3. PC Mode
3-1. Preface
The TK-2202/2206 transceivers are programmed using apersonal computer, a programming interface (KPG-22) andprogramming software (KPG-87D).
The programming software can be used with an IBM PCor compatible. Figure 1 shows the setup of an IBM PC forprogramming.
3-2. Connection procedure
1. Connect the TK-2202/2206 to the personal computer withthe interface cable.
2. When the POWER is switched on, user mode can beentered immediately. When the PC sends a command,the radio enters PC mode.When data is transmitting from the transceiver, the redLED lights.When data is received by the transceiver, the green LEDlights.
Notes:
• The data stored in the personal computer must match themodel type when it is written into the EEPROM.
• Change the TK-2202/2206 to PC mode, then attach theinterface cable.
3-3. KPG-22 description
(PC programming interface cable: Option)
The KPG-22 is required to interface the TK-2202/2206 withthe computer. It has a circuit in its D-subconnector (25-pin)case that converts the RS-232C logic level to the TTL level.
The KPG-22 connects the SP/MIC connector of the TK-2202/2206 to the computer’s RS-232C serial port.
3-4. Programming software description
KPG-87D is the programming software for TK-2202/2206supplied on a CD-ROM. This software runs under Windows98, ME, Windows 2000 or XP on an IBM-PC or compatiblemachine.
The data can be input to or read from TK-2202/2206 andedited on the screen. The programmed or edited data can beprinted out. It is also possible to tune the transceiver.
Tuning cable(E30-3216-05)
RF Power meteror SSG
Gray +Gray/Black –1.5D-XV Lead wire +1.5D-XV Shield wire –
SP
MIC
KPG-22
KPG-87D
IBM-PC
Fig. 1
Clone mode
4. Clone Mode
4-1. Outline
"Clone Mode" copies the transceiver data to anothertransceiver.
The dealer can copy the transceiver data to anothertransceiver even without the use of a personal computer.
4-2. Example
The transceiver can copy the programming data to one ormore transceivers via RF communication.
The clone master and clone slave/s must be in Clone mode.
4-3. Operation
1. To switch the clone slave/s to Clone mode, press and holdthe [PTT] and [side2] keys while turning the transceiverpower ON.
2. Wait for 2 seconds. The LED will light orange and thetransceiver will announce "Clone".
3. Select a channel table number using Side1(incrementchannel table) and Side2(decrement channnel table) keys.
4. To switch the clone master to Clone mode, press and holdthe [PTT] and [side2] keys while turning the transceiverpower ON.
5. Wait for 2 seconds. The LED will light orange and thetransceiver will announce "Clone".
6. Select the same channel table number as the clone slave/s.7. Press [PTT] on the clone master to begin data transmission.
When the clone slave starts to receive data, the LED willlight green.When the clone master finishes sending data, a"confirmation" tone will sound.If data transmission fails while cloning, an "error" tone willsound from the Slave unit.
8. If the cloning fails, no data will be available in the Slave unitwhen it is returned to User mode.
9. When the cloning is successful, the Slave unit's "Scan" and"Key lock" functions will return to their default values (Scan= OFF, Key lock = OFF).
Notes:
• The dealer can clone data to two or more transceivers byrepeating the above procedures.
• If the transceivers Clone Mode is configured as "Disabled",the transceiver cannot enter Clone mode.
• The table shown below will cover the frequency tables usedfor wireless cloning.
• Clone mode cannot be entered in battery low state.• A unit cannot be a "Master Unit" if it is unprogrammed. If
[PTT] is pressed, an "error" tone will sound.• The language used in cloning depends on the "Model type"
setting, not the FPU setting. C, C2, C5 and C6 typeTK-3207 transceivers will use Chinese. Other types English.
• Once a unit is set to be the Master, it cannot be a slaveafter the data has been transmitted. This protects the datain the Master unit.
• Electronic interface may cause a failure in data transferduring Wireless Clone, such as when waveforms orelectromagnetics are being performed at the workbench.
• Clone mode can be used ONLY by the authorized servicepersonnel.
• The Clone mode setting must be configured as "Disable"before being delivered to the end-user.
• To clone, replace the antenna from both the mastertransceiver and the slave transceiver with a dummyload.
• The transmit output power is automatically set to Lowin Clone mode.
1. Remove the volume knob z and channel knob x.2. Remove the two screws c.3. Lift and remove the chassis from the case assembly v.
(Use a flat-blade screwdriver to easily lift the chassis.)
Removing the TX-RX unit from the chassis.
1. Remove the packing b from the SP / MIC jack of the TX-RX unit.
2. Remove the eleven screws n fixing the TX-RX unit.3. Remove the fixing bracket m of the SP / MIC.4. Remove the solder of the antenna terminal with a soldering
iron ,.5. Remove the solder of the positive terminal with a soldering
iron ..Note: You can remove the TX-RX unit from the chassis without
removing the solder at the positive terminal. However,in this case, you can not attach the packing (G53-1605-03) that is on the positive terminal to the chassis inassembling. So, it is advisable to remove the solder onthe positive terminal first.
6. Remove the FPC from the flat cable connector /.7. Lift and remove the TX-RX unit from the chassis Ω.
1
3
3
4
2
9
6 6 66
6
11
5
6
6
6
7
8
10
Removing the battery release lever from the case
assembly.
1. Press the upper part of the lever toward the inside of thecase assembly. One side of the shaft will be removed z.
2. Lift and remove the battery release lever from the caseassembly x.
Attaching the battery release lever to the case
assembly.
1. Insert one side of the shaft into the hole at the lever fittingsection on the case assembly z.
Caution : The thin spring (G01-4543-04) should be positionedabove the two tabs of the lever.
2. Tilt the battery release lever slightly forward x, so that thethick spring (G01-4542-04) is positioned below the casesurface.
3. With the thick spring positioned below the case surface,attach the other side of the shaft to the case assembly bypressing the battery release lever c until it snaps into placev.
Caution : Be careful not to tilt the battery release lever tooforward.If the battery release lever is pushed in this statewhere the two tabs come below the case surface,there is a possibility of damaging the two tabs.
2
1
1
3
2
4
A thin spring
ShaftTwo tabs
A thick spring
TK-2202/2206
6
Cautions for assembly
1. Attaching the positive terminal to the chassis.Always attach the positive terminal to the chassis, usingthe following procedures, before mounting the TX-RX unitonto the chassis.
1. Remove the holder assembly x from the packing z ofthe positive terminal.
2. Mount the packing of the positive terminal into the chassishole c.
3. Mount the holder assembly into the packing of the positiveterminal v.
DISASSEMBLY FOR REPAIR
Assembling the battery release lever
1. Place the lever x onto the stopper z.2. Place the thick spring c onto the lever.3. Hook the right and left ends of the thin spring v onto the
tabs of the stopper, then place the thin spring onto thelever b.
4. Slide the shaft through the hole of the stopper and levern.
2
1
3
4
2. Mounting the chassis to the case assembly.1. Confirm that the waterproof packing attached to the
circumference of the chassis is securely inserted in thegroove of the chassis z.
2. Attach the speaker to the speaker recess of the caseassembly x. Make sure the speaker is securely inserted.
4
5
3
1
6
2
3. Insert the upper part of the chassis into the case assemblyc.
Caution: Take care that the speaker lead wire is not caughtby the microphone element.
4. Press the chassis v and the case assembly together toattach them.
Caution: If the packing of the SP / MIC does not come to thecorrect position after attaching the chassis to thecase assembly, reposition the packing with yourfingers.
Confirm that thewaterproof packing issecurely inserted in thegroove of the chassis.
1
2
3
4
4
TK-2202/2206
7
3. Attaching the antenna receptacle to thechassis.Screw the antenna receptacle to the chassis in the ordershown in the drawing so that the antenna receptacle comesto the center of the case hole.
Tighten this screw first.
Tighten this screw second.
DISASSEMBLY FOR REPAIR
4. The nuts of the volume knob and channelknobNote that the shapes, colors and heights of nuts of thevolume knob and channel knob are different from oneanother. (The nut of volume knob is silver, and the nut ofchannel knob is gold)Use the following jig when removing the nuts of thevolume knob and channel knob.
Jig (Part No. : W05-1012-00)
Volume Knob(Silver)
Channel Knob(Gold)
TK-2202/2206
8
5) Audio Amplifier CircuitThe demodulated signal from IC201 goes to AF amplifierthrough IC301.The signal then goes through an AF volume control , andis routed to an audio power amplifier (IC302) where it isamplified and output to the speaker.
Fig. 3 Wide/Narrow switching circuit
CIRCUIT DESCRIPTION
1. Frequency Configuration
The receiver utilizes double conversion. The first IF is 38.85MHz and the second IF is 450 kHz. The first local oscillatorsignal is supplied from the PLL circuit.
The PLL circuit in the transmitter generates the necessaryfrequencies. Fig. 1 shows the frequencies.
Fig. 1 Frequency configuration
1) Front End (RF AMP)The signal coming from the antenna passes through thetransmit/receive switching diode circuit, (D103,D104,D105and D106) passes through a BPF (L214 and L213), and isamplified by the RF amplifier (Q205).The resulting signal passes through a BPF (L209 and L211)and goes to the mixer. These BPFs are adjusted by variablecapacitors (D203,D204,D205 and D206). The input voltageto the variable capacitor is regulated by voltage output fromthe microprocessor (IC405).
2) First MixerThe signal from the front end is mixed with the first localoscillator signal generated in the PLL circuit by Q1 toproduce a first IF frequency of 38.85 MHz.The resulting signal passes through the XF201 MCF to cutthe adjacent spurious and provide the opit imuncharacteristics, such as adjacent frequency selectivity.
Fig. 2 Receiver section
2. Receiver
The frequency configuration of the receiver is shown in Fig. 2.
3) IF Amplifier Circuit
The first IF signal is passed through a four-pole monolithiccrystal filter (XF201) to remove the adjacent channel signal.The filtered first IF signal is amplified by the first IF amplifier(Q203) and then applied to the lF system IC (IC201). TheIF system IC provides a second mixer, second localoscillator, limiting amplifier, quadrature detector and RSSI(Received Signal Strength Indicator). The second mixermixes the first IF signal with the 38.4MHz of the secondlocal oscillator output (TCXO X1) and produces the secondIF signal of 450kHz.The second IF signal is passed through the ceramic filter(CF201) to remove the adjacent channel signal. The filteredsecond IF signal is amplified by the limiting amplifier anddemodulated by the quadrature detector with the ceramicdiscriminator (CD201). The demodulated signal is routedto the audio circuit.
4) Wide/Narrow Switching Circuit
Narrow and Wide settings can be made for each channelby switching the demodulation level.The WIDE (low level) and NARROW (high level) data isoutput from IC405, pin 45.When a WIDE (low level) data is received, Q202 turn on.When a NARROW (high level) data is received, Q202 turn off.Q202 turns on/off with the Wide/Narrow data and theIC201 detector output level is switched to maintain aconstant output level during wide or narrow signals.
SP
BPF
IC301 IC302AF PA
IC201 IF,MIX,DET
ANT
AQUA
CF201
TCXO
TUNE
Q1 X3 multiply
TUNE
ANT SW
BPFMCF
1st Local
RF AMP Q205
MIXERQ204 XF201
IF AMPQ203
AF VOL
X1
12.8MHz
2nd Local
Q202
L : WideH : Narrow
C214
RX_W/N(IC405)
R211
R213 CD201
QUAD
IC201FM IF SYSTEM
5R
AFOUT
Q203
IFOUT
SP
TX: 136 ~ 174MHz(TK-2202(K,M) TK-2206(M))
PLLVCO
IF SYSTEM
ANT
TCXO
X3 multiply
38.85MHz
MCF AFAMP
MIC
MICAMP
TXAMP
RFAMP
38.4MHz
CF450kHz
RX: 174.85 ~ 212.85MHz (TK-2202(K,M) TK-2206(M))
TX/RX: 136 ~ 174MHz (TK-2202(K,M) TK-2206(M))
12.8MHz
RFAMPANT SW
1/2
TK-2202/2206
9
CIRCUIT DESCRIPTION
6) SquelchPart of the AF signal from the IC enters the FM IC (IC201)again, and the noise component is amplified and rectifiedby a filter and an amplifier to produce a DC voltagecorresponding to the noise level.The DC signal from the FM IC goes to the analog port ofthe microprocessor (IC405). IC405 determines whetherto output sounds from the speaker by checking whetherthe input voltage is higher or lower than the preset value.To output sounds from the speaker, IC405 sends a highsignal to the SP MUTE line and turns IC302 on throughQ303,Q304,Q305,Q306 and Q316. (See Fig. 4)
7) Receive Signalling(1) QT/DQTThe output signal from FM IC(IC201) enters themicroprocessor(IC405) through IC301. IC405 determineswhether the QT or DQT matches the preset value, andcontrols the SP MUTE and the speaker output soundsaccording to the squelch results.
(2) MSK (Fleet Sync)The MSK input signal from the FM IC goes to pin 31 of IC 301.The signal is demodulated by MSK demodulator in IC 301.The demodulated data goes to the CPU for processing.
3) Unlock Detector
If a pulse signal appears at the LD pin of IC1, an unlockcondition occurs, and the DC voltage obtained from C4,R5and D1 causes the voltage applied to the microprocessorto go low. When the microprocessor detects this condition,the transmitter is disabled, ignoring the push-to-talk switchinput signal.
4. Transmitter System
1) Microphone Amplifier
The signal from the microphone passes through the IC301.When encoding DTMF, it is turned OFF for muting themicrophone input signal by IC301.The signal passes through the Audio processor (IC301) forthe maximum deviation adjustment, and goes to the VCOmodulation input.
RECEIVE SIGNALLINGRECEIVE SIGNALLING
SPQ306,316 SW
IF Amp
FM IF IC201 IC301
IC302AF PA
IC405
Q303,304,305SW
QT/DQT
DTMF
CLK,DATA,STD,LOADN
SIGNAL
CPU
AQUA
AF CONT
QT/DQT INBUSY
Fig. 4 AF amplifier and squelch
(3) DTMFThe DTMF input signal from the FM IC (IC201) goes toIC301. The decoded information is then processed by theCPU.
3. PLL Frequency SynthesizerThe PLL circuit generates the first local oscillator signal for
reception and the RF signal for transmission.
1) PLLThe frequency step of the PLL circuit is 2.5,5,6.25 or 7.5kHz.A 12.8MHz reference oscillator signal is divided at IC1 by afixed counter to produce an oscillator (VCO) output signalwhich is buffer amplified by Q2 then divided in IC1 by aprogrammable counter. The divided signal is compared inphase with the 5 or 6.25kHz reference signal from the phasecomparator in IC1. The output signal from the phasecomparator is filtered through a low-pass filter and passedto the VCO to control the oscillator frequency. (See Fig. 5)
2) VCOThe operating frequency is generated by Q4 in transmitmode and Q3 in receive mode. The oscillator frequency iscontrolled by applying the VCO control voltage, obtainedfrom the phase comparator, to the varactor diodes (D4 andD7 in transmit mode and D5 and D9 in receive mode). TheRX pin is set high in receive mode causing Q5 turn on.The TX pin is set high in transmit mode. The outputs fromQ3 and Q4 are amplified by Q6 and sent to the RF amplifiers.
PLL DATA
X112.8MHz
REF OSC
1M
1N
PLL IC IC1
PHASECOMPARATOR
CHARGEPUMP
LPF
5kHz/6.25kHz
D4, 7
D5, 9
Q4TX VCO
Q3RX VCO
Q6BUFF AMP IC2
1/2
Q2BUFFER
Q5, 7T/R SW
5kHz/6.25kHz
LPF
RX
TX
Fig. 5 PLL circuit
TK-2202/2206
10
CIRCUIT DESCRIPTION
Fig. 6 Microphone amplifier
Fig. 7 Drive and final amplifier and APC circuit
3) APC Circuit
The APC circuit always monitors the current flowing throughthe RF power amplifier (Q106) and keeps a constant current.The voltage drop at R127, R128 and R129 is caused by thecurrent flowing through the RF power amplifier and thisvoltage is applied to the differential amplifier IC101(1/2).IC101(2/2) compares the output voltage of IC101(1/2) withthe reference voltage from IC405. The output of IC101(2/2)controls the VG of the RF power amplifier, drive amplifierand pre-drive amplifier to make both voltages the same.The change of power high/low is carried out by the changeof the reference voltage.
4) Encode Signalling
(1) QT/DQTQT,DQT data of the QTTCXO Line is output from pin 28 ofthe CPU. The signal passes through a low-pass CR filterand goes to the TCXO(X1).
2) Drive and Final Amplifier
The signal from the T/R switch (D101 is on) is amplified bythe pre-drive (Q102) and the drive amplifier (Q103) to 50mW.The output of the drive amplifier is amplified by the RF poweramplifier (Q106) to 5.0W (1W when the power is low). TheRF power amplifier consists of two MOS FET stages. Theoutput of the RF power amplifier is then passed throughthe harmonic filter (LPF) and antenna switch (D103 andD104) and applied to the antenna terminal.
FromT/R SW(D101)
DRIVEAMP
RFPOWER AMP LPFANT
SW
D103D104
ANT
VGVGVD
Q103 Q106Pre-DRIVE
AMP
Q102
VDD
5T
R127
R128
R129
+B
IC101(2/2)
IC101(1/2)
PCTV(IC405)
IC301
IC405
LPFDTMF
QTTCXO
QTVCO
CPU
AGC
VCO
MIC
X1
TCXOLPF
LPF
AQUA
The QT,DQT data of the QTVCO Line is output from pin 24of the CPU. The signal passes through a low pass CR filter,mixes with the audio signal, and goes to the VCO modulationinput. TX deviation is adjusted by the CPU.
(2) DTMFHigh-speed data is output from pin 2 of the CPU. The signalpasses through a low-pass CR filter, and provides a TX andSP out tone, and is then applied to the audio processor(IC301). The signal is mixed with the audio signal and goesto the VCO.TX deviation is adjusted by the CPU.
(3) MSK (Fleet Sync)Fleet Sync utilizes 1200bps and 2400bps MSK signal isoutput from pin 6 of IC301. And is routed to the VCO.When encoding MSK, the microphone input signal is muted.
5. Power Supply
There are four 5V power supplies for the microprocessor:5M,5C,5R, and 5T. 5M for microprocessor is always outputwhile the power is on. 5M is always output, but turns off whenthe power is turned off to prevent malfunction of themicroprocessor.
5C is a common 5V and is output when SAVE is not set toOFF.
5R is 5V for reception and output during reception.5T is 5V for transmission and output during transmission.
6. Control Circuit
The control circuit consists of a microprocessor (IC405) andits peripheral circuits. It controls the TX-RX unit. IC405 mainlyperforms the following:
(1) Switching between transmission and reception by thePTT signal input.
(2) Reading system, group, frequency, and program datafrom the memory circuit.
(3) Sending frequency program data to the PLL.(4) Controlling squelch on/off by the DC voltage from the
squelch circuit.(5) Controlling the audio mute circuit by the decode data input.(6) Transmitting tone and encode data.
1) Frequency Shift Circuit
The microprocessor (IC405) operates at a clock of7.3728MHz. This oscillator has a circuit that shifts thefrequency by BEAT SHIFT SW (Q407,Q408).A beat sound may be able to be evaded from generation if“Beat Shift” is set to ON when it is generated in the internalspurious transmission modulated sound of a transceiver.
TK-2202/2206
11
Fig. 11 Control system
CIRCUIT DESCRIPTION
Channel selector
CPUIC405
SIDE 2
EN4EN3EN2EN1
47484950
PTT PTT SW
SIDE 1
27
74
75
SW1
SW2
EN546
X2XOUT
IC405
Q407Q408
Hi: OFFLOW: ON
BSHIFT
Fig. 8 Frequency shift circuit
Fig. 9 Memory circuit
IC405
CPU
IC406
EEPROM
SB R404
R406
88
IC405
CPU
Fig. 10 Low battery warning
2) Memory Circuit
Memory circuit consists of the CPU (IC405) and an EEPROM(IC406). An EEPROM has a capacity of 64k bits that containsthe transceiver control program for the CPU and data suchas transceiver channels and operating features.
3) Low Battery Warning
The battery voltage is checked using by the microprocessor.The transceiver generates a warning tone when it falls belowthe warning voltage shown in the table.
(1) The red LED blinks when the battery voltage falls belowthe voltage (1) shown in the table during transmission.
Note:
The transceiver checks the battery voltage during receptioneven when, in the FPU, the Battery Warning status functionis set to “On TX” (default setting).However, the LED does not blink during reception. Duringtransmission, the LED blinks to generate the warning toneof a low battery voltage.
(2) The transceiver immediately stops transmission whenthe battery voltage falls below the voltage (2) shown inthe table. A message tone beeps while the PTT switchis released.
7. Control System
Keys and channel selector circuit.The signal from the keys and channel selector are directly
input to the microprocessor, as shown in fig. 11.
Ni-Cd Battery Ni-MH Battery
(1) 6.2[V] 6.2[V]
(2) 5.9[V] 5.9[V]
TK-2202/2206
12
Microprocessor : 30622MAA-B89GP (TX-RX UNIT : IC405)
Pin function
1 PCTV O APC/BPF control data output2 DTMF O DTMF/ Beep output3 NC - NC4 EEPDAT I/O EEPROM data input/output5 EEPCLK O EEPROM clock output6 BYTE - GND7 GND - GND8 BSHIFT O Beat shift switch9 NC - NC10 RESET I CPU reset11 XOUT O CPU clock (7.3728MHz)12 VSS - GND13 XIN I CPU clock (7.3728MHz)
14-15 VCC - +5V16 INT I Battery voltage monitor input17 TCLK/DTRDO I Base band IC data input18 RDF/FD I Base band IC data input19 SCLK O Base band IC clock output20 D I/O I/O Base band IC data input / output21 TDATA/DTRCLK O Base band IC data output22 DIR O Base band IC data output23 STD I Base band IC data input24 QT VCO O QT/DQT output25 DTRLOADN O Base band IC data output26 1/2 OSC O 3.6864 MHz (7.3728 MHz/2)27 PTT I PTT switch input28 QT TCXO O QT/DQT output29 TXD O Serial data (FPU/FLASH)30 RXD I Serial data (FPU/FLASH)31 GND - GND32 APCSW O APC switch
33-34 NC - NC35 DCSW O APC voltage discharge switch36 TX_W/N O TX Wide/Narrow switch37 RX_SW O RX VCO switch38 TX_SW O TX VCO switch39 GND - GND40 PLL_UL I PLL unlock detect input41 PLL_STB O PLL strobe output42 PLL_DAT O PLL data output43 PLL_CLK O PLL clock output
Pin Port Name I/O FunctionNo.Pin Port Name I/O FunctionNo.44 VCC - +5V45 RX_W/N O RX Wide/Narrow switch46 EN5 I Channel selector input47 EN4 I Channel selector input48 EN3 I Channel selector input49 EN2 I Channel selector input50 EN1 I Channel selector input51 OPTDET I Headset input detect52 AF_CONT O Speaker mute
53-59 NC - NC60 VCC - +5V61 NC - NC62 VSS - GND
63-64 GND - GND65-71 NC - NC
72 LEDTX O Red LED lights control output73 LEDRX O Green LED lights control output74 PF1 I SIDE1 key input75 PF2 I SIDE2 key input76 SIM1 - GND77 SIM2 - GND
78-79 NC - NC80 5T_C O 5T control output81 5R_C O 5R control output82 5C_C O 5C control output
83-87 NC - NC88 BATT I Battery voltage input
89 RSSI IReceived Signal StrengthIndicator input
90 BUSY I Busy level input91 VOX I VOX level input92 QT/DQT_IN I QT/DQT input93 TH_DET I Thermistor input94 AVSS - GND95 NC - NC96 VREF - +5V97 AVCC - +5V98 NC - NC99 MIC_MUTE O MIC mute100 NC - NC
CN401
1 B I B (Battery Voltage)2 SB O Switched B3 SP1 I Audio input4 SP2 O Audio output5 GND - GND6 EN1 I Encoder pulse input
Pin Name I/O FunctionNo.Pin Name I/O FunctionNo.7 EN2 I Encoder pulse input8 GND - GND9 EN3 I Encoder pulse input10 EN4 I Encoder pulse input11 EN5 I Encoder pulse input
SEMICONDUCTOR DATA
TERMINAL FUNCTION / SEMICONDUCTOR DATATERMINAL FUNCTION
TK-2202/2206
13
COMPONENTS DESCRIPTION
IC1 IC PLL systemIC2 IC VCO 1/2 Divider
IC101 IC Comparator (APC)IC201 IC FM IF systemIC301 IC Audio processorIC302 IC AF AMPIC401 IC Voltage regulator/ 5VIC402 IC Voltage regulator/ 5VIC403 IC Voltage detector / ResetIC404 IC Voltage detector / INTIC405 IC MicroprocessorIC406 IC EEPROM
Q1 Transistor TriplerQ2 Transistor PLL IC f_in AMPQ3 FET VCO / RXQ4 FET VCO / TXQ5 Transistor DC switch / TX VCOQ6 FET RF Buffer AMPQ7 Transistor DC switch / RX VCOQ8 FET Ripple filterQ9 Transistor RF AMP
Q102 Transistor RF AMPQ103 FET TX Drive AMPQ104 Transistor APC switchQ105 FET APC switchQ106 FET TX Final AMPQ107 Transistor APC switchQ108 FET APC switchQ109 Transistor APC switchQ202 Transistor W/N switch / RXQ203 Transistor IF AMPQ204 FET MixerQ205 FET RF AMPQ301 Transistor W/N switch / TXQ302 Transistor MIC AGCQ303 Transistor DC switch / SP MuteQ304 Transistor DC switchQ305 Transistor DC switch / SP MuteQ306 FET SP Mute switchQ316 FET SP Mute switchQ401 Transistor LED switch / RedQ402 Transistor LED switch / GreenQ403 FET 5T switchQ404 FET 5R switchQ405 Transistor 5C switchQ407 FET Beat Shift switchQ408 FET Beat Shift switch
D11 Diode Current steeringD101 Diode TX/RX RF switchD102 Zener diode APC protectD103 Diode ANT switchD104 Diode ANT switchD105 Diode ANT switchD106 Diode ANT switchD202 Diode TX/RX RF switch
D203Variable
RF BPF tuningcapacitance diode
D204Variable
RF BPF tuningcapacitance diode
D205Variable
RF BPF tuningcapacitance diode
D206Variable
RF BPF tuningcapacitance diode
D301 Diode DetectorD302 Diode DetectorD303 Diode IsolationD401 Diode 5V ProtectionD402 Diode Reverse ProtectionD403 LED LED/ RedD404 LED LED/ Green
Ref. No. Use/Function Operation/ConditionQ901 FET W/N Switch/ TX
ADDITIONAL PCB
TK-2202/2206PARTS LIST
14
∗ New Parts. indicates safety critical components.Parts without Parts No. are not supplied.Les articles non mentionnes dans le Parts No. ne sont pas fournis.Teile ohne Parts No. werden nicht geliefert.
L: Scandinavia K: USA P: CanadaY: PX (Far East, Hawaii) T: England E: EuropeY: AAFES (Europe) X: Australia M: Other Areas
Parts No. DescriptionAddressNewpartsDestination Destination
TK-2202/2206
Ref. No. Parts No. DescriptionAddressNewparts
TK-2202/2206 (Y50-5890-XX)TX-RX UNIT (X57-6870-20)
Ref. No.
AK : TK-2202 (K) AM : TK-2202 (M) BM : TK-2206 (M)
A 2B ∗ N14-0808-04 CIRCULAR NUT(CH KNOB)B 2B ∗ N14-0812-04 CIRCULAR NUT(VOL KNOB)C 2A,2B N30-2604-46 PAN HEAD MACHINE SCREW(SMA)D 3A N30-2606-46 PAN HEAD MACHINE SCREW(CHASSIS)E 2A,2B,3B N83-2005-46 PAN HEAD TAPTITE SCREW(PCB)
C1 CK73HB1H332K CHIP C 3300PF KC2 CK73HB1C682K CHIP C 6800PF KC3 CK73GB1A105K CHIP C 1.0UF KC4 CK73HB1C103K CHIP C 0.010UF KC5 CK73HB1H102K CHIP C 1000PF K
C6 CK73HB1A104K CHIP C 0.10UF KC7 ,8 CC73HCH1H101J CHIP C 100PF JC9 CC73HCH1H100D CHIP C 10PF DC10 C92-0713-05 CHIP-TAN 10UF 6.3WVC11 CC73HCH1H101J CHIP C 100PF J
C12 CK73HB1H102K CHIP C 1000PF KC13 CK73HB1A104K CHIP C 0.10UF KC14 CK73HB1C103K CHIP C 0.010UF KC15 CC73HCH1H100D CHIP C 10PF DC16 CK73HB1H102K CHIP C 1000PF K
C17 CC73HCH1H470J CHIP C 47PF JC18 CC73HCH1H180J CHIP C 18PF JC19 CK73HB1A104K CHIP C 0.10UF KC21 C92-0713-05 CHIP-TAN 10UF 6.3WVC22 C92-0502-05 CHIP-TAN 0.33UF 35WV
C24 CK73HB1H102K CHIP C 1000PF KC25 CC73HCH1H020B CHIP C 2.0PF BC26 CC73HCH1H300J CHIP C 30PF JC27 C92-0697-05 CHIP-TAN 3.3UF 16WVC29 ,30 CK73HB1H471K CHIP C 470PF K
C32 C92-0001-05 CHIP C 0.1UF 35WVC33 ,34 CK73HB1H102K CHIP C 1000PF KC35 CC73HCH1H270J CHIP C 27PF J
TX-RX UNIT (X57-6870-20)
TK-2202/2206PARTS LIST
15
TX-RX UNIT (X57-6870-20)
DestinationRef. No. Parts No. DescriptionAddressNewparts DestinationRef. No. Parts No. DescriptionAddress
Newparts
AK : TK-2202 (K) AM : TK-2202 (M) BM : TK-2206 (M)
C38 CC73HCH1H060B CHIP C 6.0PF BC39 CK73GB1H332K CHIP C 3300PF KC40 CC73HCH1H040B CHIP C 4.0PF BC41 CK73GB1H682K CHIP C 6800PF KC42 CC73HCH1H060B CHIP C 6.0PF B
C43 CC73HCH1H150J CHIP C 15PF JC44 CK73HB1H471K CHIP C 470PF KC45 CK73GB1A105K CHIP C 1.0UF KC47 CC73HCH1H101J CHIP C 100PF JC48 CK73HB1H471K CHIP C 470PF K
C49 CC73HCH1H101J CHIP C 100PF JC50 CC73HCH1H100D CHIP C 10PF DC51 CK73HB1H102K CHIP C 1000PF KC52 CC73HCH1H181J CHIP C 180PF JC53 CC73HCH1H0R5B CHIP C 0.5PF B
C54 CC73HCH1H040B CHIP C 4.0PF BC55 CC73HCH1H121J CHIP C 120PF JC57 CC73HCH1H1R5B CHIP C 1.5PF BC58 CC73HCH1H060B CHIP C 6.0PF BC59 CC73HCH1H1R5B CHIP C 1.5PF B
C60 CC73HCH1H010B CHIP C 1.0PF BC61 CC73HCH1H040B CHIP C 4.0PF BC62 CC73HCH1H050B CHIP C 5.0PF BC63 CC73HCH1H101J CHIP C 100PF JC64 CC73HCH1H040B CHIP C 4.0PF B
C65 -67 CC73HCH1H050B CHIP C 5.0PF BC68 -70 CK73HB1H471K CHIP C 470PF KC71 ,72 CK73HB1A104K CHIP C 0.10UF KC73 ,74 CC73HCH1H0R5B CHIP C 0.5PF BC75 ,76 CK73HB1H102K CHIP C 1000PF K
C77 CK73HB1H471K CHIP C 470PF KC78 CC73HCH1H330J CHIP C 33PF JC79 C92-0713-05 CHIP-TAN 10UF 6.3WVC80 CK73HB1H471K CHIP C 470PF KC81 CC73HCH1H150J CHIP C 15PF J
C82 -86 CK73HB1H102K CHIP C 1000PF KC87 CC73HCH1H100D CHIP C 10PF DC90 CK73HB1H102K CHIP C 1000PF KC101 CK73HB1H102K CHIP C 1000PF KC104 CC73GCH1H390J CHIP C 39PF J
C105 CK73HB1H102K CHIP C 1000PF KC107 CK73HB1H102K CHIP C 1000PF KC108 CC73GCH1H390J CHIP C 39PF JC109 CK73GB1C104K CHIP C 0.10UF KC110,111 CK73HB1H102K CHIP C 1000PF K
C115 CK73HB1H102K CHIP C 1000PF KC116 CC73GCH1H220J CHIP C 22PF JC117 CC73GCH1H100D CHIP C 10PF DC118 CC73GCH1H101J CHIP C 100PF JC119 CC73GCH1H270J CHIP C 27PF J
C120 CK73GB1H102K CHIP C 1000PF KC121 CC73GCH1H100D CHIP C 10PF DC123 CK73GB1A105K CHIP C 1.0UF KC124,125 CK73HB1H102K CHIP C 1000PF KC126 C92-0565-05 CHIP-TAN 6.8UF 10WV
C128 CK73HB1H102K CHIP C 1000PF KC130 CC73GCH1H100D CHIP C 10PF DC132 CK73HB1H102K CHIP C 1000PF KC133 CK73GB1H103K CHIP C 0.010UF KC134 CK73GB1C104K CHIP C 0.10UF K
C135 CK73GB1A105K CHIP C 1.0UF KC136 CC73GCH1H270J CHIP C 27PF JC137 CK73GB1H103K CHIP C 0.010UF KC138 CK73GB1H102K CHIP C 1000PF KC139 CC73GCH1H680J CHIP C 68PF J
C140 CC73GCH1H101J CHIP C 100PF JC141 CC73GCH1H220J CHIP C 22PF JC142 CC73GCH1H150J CHIP C 15PF JC143 CC73GCH1H100D CHIP C 10PF DC144 CC73GCH1H820J CHIP C 82PF J
C146 CK73GB1H102K CHIP C 1000PF KC147 CK73HB1H102K CHIP C 1000PF KC148 CK73GB1H102K CHIP C 1000PF KC149 CC73GCH1H220G CHIP C 22PF GC150 CC73GCH1H220J CHIP C 22PF J
C151 CK73GB1H102K CHIP C 1000PF KC153 CC73GCH1H100C CHIP C 10PF CC154 CC73GCH1H100D CHIP C 10PF DC155 CC73GCH1H180J CHIP C 18PF JC156 CC73GCH1H120J CHIP C 12PF J
C157 CC73GCH1H150J CHIP C 15PF JC158 CC73GCH1H220J CHIP C 22PF JC159 CC73GCH1H070D CHIP C 7.0PF DC160 CC73GCH1H330J CHIP C 33PF JC201 CK73GB1A224K CHIP C 0.22UF K
C206 CK73HB1H102K CHIP C 1000PF KC207 CK73HB1H182K CHIP C 1800PF KC208 CK73HB1H471K CHIP C 470PF KC209 C92-0713-05 CHIP-TAN 10UF 6.3WVC210 CK73HB1H471K CHIP C 470PF K
C211 CK73HB1C103K CHIP C 0.010UF KC213 CK73HB1A104K CHIP C 0.10UF KC214 CC73HCH1H680J CHIP C 68PF JC215 CK73HB1H102K CHIP C 1000PF KC216 CK73GB1C104K CHIP C 0.10UF K
C217 CK73HB1A104K CHIP C 0.10UF KC218 CK73GB1C104K CHIP C 0.10UF KC219 CC73HCH1H330J CHIP C 33PF JC220 CK73HB1H102K CHIP C 1000PF KC221 CK73GB1C104K CHIP C 0.10UF K
C222 CK73HB1H102K CHIP C 1000PF KC224,225 CK73HB1C103K CHIP C 0.010UF KC227 CK73HB1H102K CHIP C 1000PF KC228 CC73GCH1H100C CHIP C 10PF CC230 CC73HCH1H080B CHIP C 8.0PF B
C231,232 CK73GB1H103K CHIP C 0.010UF KC233 CC73HCH1H020B CHIP C 2.0PF BC234 CK73HB1C103K CHIP C 0.010UF KC235 CC73HCH1H090B CHIP C 9.0PF BC236 CK73GB1H102K CHIP C 1000PF K
C237 CC73HCH1H050B CHIP C 5.0PF BC238 CC73GCH1H120J CHIP C 12PF JC239 CC73HCH1H060B CHIP C 6.0PF BC241 CK73HB1H102K CHIP C 1000PF KC242 CK73GB1C104K CHIP C 0.10UF K
C243 CK73HB1H102K CHIP C 1000PF KC244 CC73HCH1H040B CHIP C 4.0PF BC245 CK73HB1H471K CHIP C 470PF KC247 CC73GCH1H040B CHIP C 4.0PF BC248 CC73GCH1H270J CHIP C 27PF J
TK-2202/2206PARTS LIST
16
TX-RX UNIT (X57-6870-20)
DestinationRef. No. Parts No. DescriptionAddressNewparts DestinationRef. No. Parts No. DescriptionAddress
Newparts
AK : TK-2202 (K) AM : TK-2202 (M) BM : TK-2206 (M)
C249 CK73HB1H102K CHIP C 1000PF KC250 CC73GCH1H040B CHIP C 4.0PF BC251 C92-0714-05 CHIP-TAN 4.7UF 6.3WVC252 CK73HB1H102K CHIP C 1000PF KC253 CC73GCH1H4R5B CHIP C 4.5PF B
C254 CC73GCH1H270J CHIP C 27PF JC255 CC73GCH1H4R5B CHIP C 4.5PF BC256 CK73HB1H102K CHIP C 1000PF KC258 CK73HB1H102K CHIP C 1000PF KC260 CK73HB1H102K CHIP C 1000PF K
C262 CK73HB1H102K CHIP C 1000PF KC263 CC73GCH1H100C CHIP C 10PF CC264 CC73GCH1H040B CHIP C 4.0PF BC265 CC73GCH1H330J CHIP C 33PF JC266 CK73HB1H102K CHIP C 1000PF K
C267,268 CC73GCH1H030B CHIP C 3.0PF BC269 CC73GCH1H330J CHIP C 33PF JC270 CC73GCH1H040B CHIP C 4.0PF BC271 CC73GCH1H110J CHIP C 11PF JC280 CK73HB1H102K CHIP C 1000PF K
C302 CK73HB1C103K CHIP C 0.010UF KC304 CK73GB1A224K CHIP C 0.22UF KC306 C92-0714-05 CHIP-TAN 4.7UF 6.3WVC307,308 CK73HB1A104K CHIP C 0.10UF KC309 CC73GCH1H820J CHIP C 82PF J
C310 CK73HB1A683K CHIP C 0.068UF KC311 CK73GB1A105K CHIP C 1.0UF KC312 CC73GCH1H120J CHIP C 12PF JC313 CC73GCH1H121J CHIP C 120PF JC314 CK73HB1A104K CHIP C 0.10UF K
C315 CK73GB1A105K CHIP C 1.0UF KC316 CK73GB1C104K CHIP C 0.10UF KC317 CK73HB1A104K CHIP C 0.10UF KC318 C92-0714-05 CHIP-TAN 4.7UF 6.3WVC319 CC73GCH1H271J CHIP C 270PF J
C320 CK73HB1C103K CHIP C 0.010UF KC321 CK73GB1A105K CHIP C 1.0UF KC322 CK73HB1C153K CHIP C 0.015UF KC323 CC73GCH1H820J CHIP C 82PF JC324 CC73HCH1H820J CHIP C 82PF J
C325 CK73HB1A104K CHIP C 0.10UF KC326 CK73HB1H102K CHIP C 1000PF KC327 CC73HCH1H101J CHIP C 100PF JC328 CK73HB1H391K CHIP C 390PF KC329,330 CK73GB1A105K CHIP C 1.0UF K
C331 CK73HB1A104K CHIP C 0.10UF KC332 CK73HB1H471K CHIP C 470PF KC333,334 CK73GB1C104K CHIP C 0.10UF KC335 CC73GCH1H221J CHIP C 220PF JC336 CK73FB1C474K CHIP C 0.47UF K
C338 CC73GCH1H101J CHIP C 100PF JC339 C92-0560-05 CHIP-TAN 10UF 6.3WVC340 CK73GB1C104K CHIP C 0.10UF KC341 CK73GB1C473K CHIP C 0.047UF KC342 C92-0560-05 CHIP-TAN 10UF 6.3WV
C343 CK73GB1C473K CHIP C 0.047UF KC344 CC73GCH1H221J CHIP C 220PF JC345 C92-0665-05 TANTAL 100UF 6.3WVC346 CK73GB1H102K CHIP C 1000PF KC348 CK73HB1H471K CHIP C 470PF K
C351,352 CK73HB1C103K CHIP C 0.010UF KC354 CK73HB1A104K CHIP C 0.10UF KC370 CK73HB1A104K CHIP C 0.10UF KC401 CC73GCH1H471J CHIP C 470PF JC402 CK73HB1H102K CHIP C 1000PF K
C403 CK73GB1C104K CHIP C 0.10UF KC405 CC73GCH1H101J CHIP C 100PF JC407 CK73HB1H102K CHIP C 1000PF KC409,410 CK73GB1A105K CHIP C 1.0UF KC411 CK73HB1H102K CHIP C 1000PF K
C415 CK73HB1H471K CHIP C 470PF KC417 CK73GB1A105K CHIP C 1.0UF KC418,419 CK73HB1H102K CHIP C 1000PF KC421 CK73GB1A105K CHIP C 1.0UF KC426,427 CK73GB1A105K CHIP C 1.0UF K
C428,429 CK73HB1H102K CHIP C 1000PF KC430 CK73GB1H103K CHIP C 0.010UF KC431 CK73HB1C103K CHIP C 0.010UF KC432 CC73HCH1H050B CHIP C 5.0PF BC433,434 CC73HCH1H030B CHIP C 3.0PF B
C435 CC73HCH1H050B CHIP C 5.0PF BC440 CC73GCH1H1R5B CHIP C 1.5PF BC443 CK73GB1A474K CHIP C 0.47UF KTC1 ,2 C05-0384-05 CERAMIC TRIMMER CAP(10PF)
L202 L40-3975-92 SMALL FIXED INDUCTOR(39NH)L203 L92-0138-05 FERRITE CHIPL204 L40-5685-85 SMALL FIXED INDUCTOR(0.56UH)L205 L40-6875-92 SMALL FIXED INDUCTOR(68NH)L206 L40-1885-92 SMALL FIXED INDUCTOR(180NH)
L207 L40-1585-92 SMALL FIXED INDUCTOR(150NH)L209 L41-5678-14 SMALL FIXED INDUCTORL210 L92-0138-05 FERRITE CHIPL211 L41-5678-14 SMALL FIXED INDUCTORL213 L41-5678-14 SMALL FIXED INDUCTOR
CP404 RK75HA1J473J CHIP-COM 47K J 1/16WCP405 RK75HA1J102J CHIP-COM 1.0K J 1/16WR1 RK73HB1J223J CHIP R 22K J 1/16WR2 RK73HB1J103J CHIP R 10K J 1/16WR3 RK73HB1J333J CHIP R 33K J 1/16W
R4 RK73HB1J563J CHIP R 56K J 1/16WR5 RK73HB1J104J CHIP R 100K J 1/16WR6 RK73HB1J823J CHIP R 82K J 1/16WR7 RK73HB1J101J CHIP R 100 J 1/16WR8 -11 R92-1368-05 CHIP R 0 OHM
R12 RK73HB1J222J CHIP R 2.2K J 1/16WR13 R92-1252-05 CHIP R 0 OHM J 1/16WR14 RK73HB1J334J CHIP R 330K J 1/16WR15 RK73GB1J221J CHIP R 220 J 1/16WR16 RK73GB1J561J CHIP R 560 J 1/16W
R17 RK73HB1J101J CHIP R 100 J 1/16WR18 R92-1252-05 CHIP R 0 OHM J 1/16WR19 RK73GB1J152J CHIP R 1.5K J 1/16WR20 RK73HB1J100J CHIP R 10 J 1/16WR21 RK73GB1J681J CHIP R 680 J 1/16W
R22 R92-1252-05 CHIP R 0 OHM J 1/16WR23 RK73GB1J103J CHIP R 10K J 1/16WR25 RK73HB1J223J CHIP R 22K J 1/16WR26 RK73HB1J103J CHIP R 10K J 1/16WR27 RK73HB1J220J CHIP R 22 J 1/16W
R30 RK73HB1J123J CHIP R 12K J 1/16WR31 RK73HB1J564J CHIP R 560K J 1/16WR32 RK73HB1J102J CHIP R 1.0K J 1/16WR33 RK73HB1J154J CHIP R 150K J 1/16WR34 RK73HB1J472J CHIP R 4.7K J 1/16W
R35 ,36 RK73HB1J274J CHIP R 270K J 1/16W
R37 RK73HB1J101J CHIP R 100 J 1/16WR38 RK73HB1J181J CHIP R 180 J 1/16WR39 RK73HB1J151J CHIP R 150 J 1/16WR40 RK73HB1J101J CHIP R 100 J 1/16WR41 RK73HB1J154J CHIP R 150K J 1/16W
R42 RK73HB1J472J CHIP R 4.7K J 1/16WR43 RK73HB1J101J CHIP R 100 J 1/16WR44 RK73HB1J102J CHIP R 1.0K J 1/16WR45 ,46 RK73HB1J332J CHIP R 3.3K J 1/16WR47 RK73HB1J470J CHIP R 47 J 1/16W
R48 RK73HB1J331J CHIP R 330 J 1/16WR49 RK73HB1J222J CHIP R 2.2K J 1/16WR50 RK73HB1J472J CHIP R 4.7K J 1/16WR51 RK73HB1J100J CHIP R 10 J 1/16WR101 RK73HB1J123J CHIP R 12K J 1/16W
R103 R92-1252-05 CHIP R 0 OHM J 1/16WR107 RK73GB1J561J CHIP R 560 J 1/16WR108 RK73GB1J152J CHIP R 1.5K J 1/16WR109 RK73GB1J150J CHIP R 15 J 1/16WR110,111 RK73GB1J331J CHIP R 330 J 1/16W
R112 RK73GB1J180J CHIP R 18 J 1/16WR113 RK73GB1J331J CHIP R 330 J 1/16WR114 RK73GB1J473J CHIP R 47K J 1/16WR115 RK73GB1J103J CHIP R 10K J 1/16WR116 RK73GB1J150J CHIP R 15 J 1/16W
R117 RK73GB1J683J CHIP R 68K J 1/16WR119 RK73GB1J331J CHIP R 330 J 1/16WR120 R92-1252-05 CHIP R 0 OHM J 1/16WR121 RK73GB1J561J CHIP R 560 J 1/16WR122 RK73GB1J473J CHIP R 47K J 1/16W
R123 RK73GB1J820J CHIP R 82 J 1/16WR124 RK73GB1J123J CHIP R 12K J 1/16WR126 RK73GB1J222J CHIP R 2.2K J 1/16WR127-129 RK73EB2ER39K CHIP R 0.39 K 1/4WR130-135 RK73GH1J154D CHIP R 150K D 1/16W
R136,137 RK73GB1J271J CHIP R 270 J 1/16WR138 RK73GB1J105J CHIP R 1.0M J 1/16WR139 RK73GB1J473J CHIP R 47K J 1/16WR140 RK73GB1J563J CHIP R 56K J 1/16WR141 RK73GB1J104J CHIP R 100K J 1/16W
R142 R92-1252-05 CHIP R 0 OHM J 1/16WR143 RK73GB1J104J CHIP R 100K J 1/16WR203 RK73HB1J184J CHIP R 180K J 1/16WR206 RK73GB1J100J CHIP R 10 J 1/16WR207 RK73HB1J472J CHIP R 4.7K J 1/16W
R208 RK73HB1J823J CHIP R 82K J 1/16WR209 RK73HB1J272J CHIP R 2.7K J 1/16WR210,211 RK73HB1J332J CHIP R 3.3K J 1/16WR212 RK73HB1J823J CHIP R 82K J 1/16WR213 RK73HB1J392J CHIP R 3.9K J 1/16W
R215 RK73HB1J101J CHIP R 100 J 1/16WR216 RK73HB1J124J CHIP R 120K J 1/16WR217 RK73HB1J472J CHIP R 4.7K J 1/16WR218 RK73HB1J561J CHIP R 560 J 1/16WR219,220 RK73GB1J561J CHIP R 560 J 1/16W
R221 RK73GB1J102J CHIP R 1.0K J 1/16WR222 RK73GB1J221J CHIP R 220 J 1/16WR223-226 RK73HB1J823J CHIP R 82K J 1/16WR227 R92-1252-05 CHIP R 0 OHM J 1/16WR228,229 RK73HB1J105J CHIP R 1.0M J 1/16W
TK-2202/2206PARTS LIST
18
TX-RX UNIT (X57-6870-20)
DestinationRef. No. Parts No. DescriptionAddressNewparts DestinationRef. No. Parts No. DescriptionAddress
Newparts
AK : TK-2202 (K) AM : TK-2202 (M) BM : TK-2206 (M)
R230 RK73GB1J222J CHIP R 2.2K J 1/16WR231 RK73GB1J470J CHIP R 47 J 1/16WR233 RK73GB1J221J CHIP R 220 J 1/16WR234 RK73GB1J104J CHIP R 100K J 1/16WR237 RK73GB1J184J CHIP R 180K J 1/16W
R238 RK73GB1J104J CHIP R 100K J 1/16WR239 RK73GB1J470J CHIP R 47 J 1/16WR240 R92-1252-05 CHIP R 0 OHM J 1/16WR241,242 RK73HB1J105J CHIP R 1.0M J 1/16WR243 R92-0670-05 CHIP R 0 OHM
R291 R92-1252-05 CHIP R 0 OHM J 1/16WR301 RK73HB1J473J CHIP R 47K J 1/16WR304 RK73HB1J564J CHIP R 560K J 1/16WR305 RK73HB1J104J CHIP R 100K J 1/16WR306 RK73HB1J102J CHIP R 1.0K J 1/16W
R307,308 R92-1368-05 CHIP R 0 OHMR310 RK73GB1J394J CHIP R 390K J 1/16WR311 RK73HB1J123J CHIP R 12K J 1/16WR312 RK73GB1J334J CHIP R 330K J 1/16WR313 RK73GB1J104J CHIP R 100K J 1/16W
R314 RK73GB1J103J CHIP R 10K J 1/16WR315 RK73GB1J334J CHIP R 330K J 1/16WR316 RK73GB1J124J CHIP R 120K J 1/16WR317 RK73GB1J474J CHIP R 470K J 1/16WR318 RK73GB1J122J CHIP R 1.2K J 1/16W
R319 RK73HB1J563J CHIP R 56K J 1/16WR320 RK73HB1J332J CHIP R 3.3K J 1/16WR321 RK73HB1J224J CHIP R 220K J 1/16WR322 RK73HB1J184J CHIP R 180K J 1/16WR323 RK73HB1J563J CHIP R 56K J 1/16W
R324,325 RK73GB1J104J CHIP R 100K J 1/16WR326 R92-1252-05 CHIP R 0 OHM J 1/16WR327 RK73GB1J184J CHIP R 180K J 1/16WR328 RK73GB1J103J CHIP R 10K J 1/16WR329 RK73GB1J823J CHIP R 82K J 1/16W
R330 RK73HB1J332J CHIP R 3.3K J 1/16WR331 RK73GB1J393J CHIP R 39K J 1/16WR332 RK73GB1J153J CHIP R 15K J 1/16WR334 RK73GB1J473J CHIP R 47K J 1/16WR335 RK73GB1J222J CHIP R 2.2K J 1/16W
R336 RK73GB1J102J CHIP R 1.0K J 1/16WR337 RK73GB1J101J CHIP R 100 J 1/16WR338 RK73GB1J222J CHIP R 2.2K J 1/16WR339 RK73GB1J471J CHIP R 470 J 1/16WR340 RK73GB1J182J CHIP R 1.8K J 1/16W
R341 RK73GB1J103J CHIP R 10K J 1/16WR342 RK73GB1J100J CHIP R 10 J 1/16WR343 RK73GB1J474J CHIP R 470K J 1/16WR344 RK73GB1J102J CHIP R 1.0K J 1/16WR345,346 RK73GB1J101J CHIP R 100 J 1/16W
R347 RK73GB1J104J CHIP R 100K J 1/16WR348 RK73GB1J563J CHIP R 56K J 1/16WR349 RK73GB1J333J CHIP R 33K J 1/16WR350 R92-1368-05 CHIP R 0 OHMR354,355 RK73HB1J103J CHIP R 10K J 1/16W
R357 R92-1368-05 CHIP R 0 OHMR360 R92-1368-05 CHIP R 0 OHMR365 RK73HB1J473J CHIP R 47K J 1/16WR403 RK73GB1J101J CHIP R 100 J 1/16WR404 RK73HH1J474D CHIP R 470K D 1/16W
R405 RK73GB1J334J CHIP R 330K J 1/16WR406 RK73HH1J474D CHIP R 470K D 1/16WR407 RK73HB1J334J CHIP R 330K J 1/16WR408-412 RK73HB1J473J CHIP R 47K J 1/16WR413,414 RK73GB1J331J CHIP R 330 J 1/16W
R415,416 RK73GB1J473J CHIP R 47K J 1/16WR417-420 RK73HB1J473J CHIP R 47K J 1/16WR421,422 RK73HB1J102J CHIP R 1.0K J 1/16WR423 R92-1368-05 CHIP R 0 OHMR424,425 RK73HB1J473J CHIP R 47K J 1/16W
R426 R92-1368-05 CHIP R 0 OHMR435 RK73HB1J473J CHIP R 47K J 1/16WR436 R92-1252-05 CHIP R 0 OHM J 1/16WR437,438 RK73HB1J473J CHIP R 47K J 1/16WR445,446 R92-1252-05 CHIP R 0 OHM J 1/16W
R447 RK73HB1J472J CHIP R 4.7K J 1/16WVR1 R12-7491-05 TRIMMING POT.(68K)
22 Parts with the exploded numbers larger than 700 are not supplied.
PACKING (TK-2206)E F
1
2
3
10.INSTRUCTION MANUAL(B62-1763-00)
47.ITEM CARTON CASE(H52-2034-02)
48.HOLDER(SP/MIC)(J19-5472-03)
60.SCREW SET(N99-2043-05)
6. CAP(SP/MIC)(B09-0680-03)
52.BELT CLIP(J29-0713-05)
43.PACKING FIXTURE(H12-3158-05)
45.PROTECTION BAG(H25-0085-04)
TK-2202/2206
23
ADJUSTMENT
Connect the power cable properly between the battery jiginstalled in the transceiver and the power supply, and be sureoutput voltage and the power supply polarity prior to switchingthe power supply ON, otherwise over voltage and reverseconnection may damage the transceiver, or the power supplyor both.
Note: When using the battery jig, you must measure thevoltage at the terminals of the battery jig. Otherwise, a slightvoltage drop may occur within the power cable, between thepower supply and the battery jig, especially while thetransceiver transmits.
+ Terminal(Red)
– Terminal(Black)
C3
100
/25V
C2
470P
/25V
C1
100P
/25V
R1
1.8M
–
S
+
Powersupply
Power cable
SCHEMATIC DIAGRAM
2. Repair Jig (Chassis)Use jig (part No.: A10-4086-03) for repairing the TK-2202/
2206. Place the TX-RX unit on the jig and fit it with screws.
The jig facilitates the voltage check and protects the finalamplifier FET when the voltage on the flow side of the TX-RXunit is checked during repairs.
3. Battery Jig (W05-1011-00)
Test Equipment Required for AlignmentTest Equipment Major Specifications
1. Standard Signal Generator Frequency Range 136 to 174MHz.(SSG) Modulation Frequency modulation and external modulation.
Output -127dBm/0.1µV to greater than -47dBm/1mV2. Power Meter Input Impedance 50Ω.
Operation Frequency 136 to 174MHz.Measurement Range Vicinity of 10W
3. Deviation Meter Frequency Range 136 to 174MHz.4. Digital Volt Meter Measuring Range 10mV to 10V DC
(DVM) Input Impedance High input impedance for minimum circuit loading.5. Oscilloscope DC through 30MHz.6. High Sensitivity Frequency Range 10Hz to 1000MHz.
Frequency Counter Frequency Stability 0.2ppm or less.7. Ammeter 5A.8. AF Volt Meter Frequency Range 50Hz to 10kHz.
(AF VTVM) Voltage Range 1mV to 10V.9. Audio Generator (AG) Frequency Range 50Hz to 5kHz or more.
Output 0 to 1V.10. Distortion Meter Capability 3% or less at 1kHz.
Input Level 50mV to 10Vrms.11. Spectrum Analyzer Measuring Range DC to 1GHz or more12. Tracking Generator Center frequency 50kHz to 600MHz
Output Voltage 100mV or more13. 8Ω Dummy Load Approx. 8Ω, 3W.14. Regulated Power Supply 5V to 10V, approx. 3A
Useful if ammeter equipped.
The following parts are required for
adjustment
1. Antenna connector adapterThe antenna connector of this radio uses an SMA terminal.Use an antenna connector adapter [SMA(f) – BNC(f) or
SMA(f) – N(f)] for adjustment. (The adapter is not provided asan option, so buy a commercially-available one.)
+ Terminal (Red)
– Terminal (Black)
TK-2202/2206
24
Frequency and signalling
The set has been adjusted for the frequencies shown inthe following table. When required. re-adjust them followingthe adjustment procedure to obtain the frequencies you wantin actual operation.
Before attempting to tune the transceiver, connect the unitto a suitable power supply.
Whenever the transmitter is tuned, the unit must beconnected to a suitable dummy load (i.e. power meter).
The speaker output connector must be terminated with a8Ω dummy load and connected to an AC voltmeter and anaudio distortion meter or a SINAD measurement meter at alltimes during tuning.
VR1
BATT+
5R
5T
5M
5C
PCTV
RSSI
CV
BPF
B
SP– SP+
SB
CN13ANT
MICIMICO
TX-RX UNIT
Component side view
S401PTT
S402SW2
S403SW1
RXAFIRXAFO
TC1 TC2
MICIMICO
CVJ301
EXT. SP/EXT. MIC
TX-RX UNIT
Foil side view
TK-2202/2206
25
1.Frequency 1) CH:High Frequency counter ANT VR1 173.900MHz ±50HzAdjust 2) PTT:ON
2.High power TEST CH: Low Power meter Programming 5.0W ±0.1WAdjust Low’ Ammeter Software:KPG-87D 1.9 A or less
CenterHigh’High(5 points)
BATT terminal voltage:7.5VPTT:ON
3.Low power TEST CH: Low 1.0W ±0.1WAdjust Low’ 0.9 A or less
CenterHigh’High(5 points)
BATT terminal voltage:7.5VPTT:ON
4.Max deviation TEST CH: Center Power meter ANT 4.2kHz ±50HzAdjust Low Deviation meter SP/MIC connector (According to[Wide] High Oscilloscope the lager +,–)
(3 points)AG:1kHz/150mV AGDeviation meter filter AF VTVMLPF:15kHzHPF:OFFPTT:ON
[Narrow] TEST CH:Center 2.2kHz ±50HzPTT:ON (According to
Center 136MHz#Res BW 300kHz #VBW 10kHz #Sweep100ms (401pts)
Span 50MHz
PeakLog5dB/
W1 S2S3 FC
AA
Atten 5 dB
1
-31.86 dBmMkrl 136.0 MHz
Ref -23 dBm
Center 155MHz#Res BW 300kHz #VBW 10kHz #Sweep100ms (401pts)
Span 50MHz
PeakLog5dB/
W1 S2S3 FC
AA
Atten 5 dB
1
-33.5 dBmMkrl 155.0 MHz
Ref -23 dBm
Center 174MHz#Res BW 300kHz #VBW 10kHz #Sweep100ms (401pts)
Span 50MHz
PeakLog5dB/
W1 S2S3 FC
AA
Atten 5 dB -34.06 dBmMkrl 174.0 MHz
1
ADJUSTMENT
28
JIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Black
Brown
Red
White
ADDITIONAL PCB
ADDITIONAL PCB
Q901
DGS
R901
GND MOD IN
MOD OUTRX-W/N
R902
C901
C902
GND MOD IN
RX-W/N MOD OUT
C21
C22
R404
R211
R405
R406
R213
R407
C27
C32
C33
R415
R416
R419
C39
C41
R422
R423
R424
R425
C45
R426
C201
TH203
C401
C402
C405
C214
R445
C215
R446
C217
C410
C411
C415
C418
C419
C77C79
C80
C430
C431
C432
C433 C434
C435
C1
C2
C3
C4
C6
C7
C8
D1
Q301
Q302 IC403
IC404
IC405IC
406
145 8
CP404
CP405
D11
R301
R304
R305
R306R307
R308
R310
R311
R312
R313
R314
R315
R316
R317
R318
R319
L6
R320
R321 R322
R323
R324
R325
R326
R327
R328
MIC301
+ –
R329
L12
R330
R331
R332
C302
C304
IC1
C306
C307
C308
C309
C310
C311 C312
C313
R10C
314
R350
R11
C315
C316
C317
R354
C318
R355
R15
C319
R16
R357
R18
R19
C320
C321
C322
C323C324
R20
R360
C325
R21
C326
R22
C327
C328
C329
R25
R365
R26
F401
Q8
C330
C331
C332
C333
R30
R31
R1
R2
R3
R4
R5
R6
R8
R9
R42
VR
1
C351
C352
C354
Q202
D301
D302
D303
Q407
Q408
GG
D
D
S
S
L401
L402
L403
L404
IC301
X2
C10
C11
C13
R203
C19
R206
BATT+
5R
5T
5M
1
1
3
3
4
4
5
5
+
1
91016
17
2526 32
1100
2526
505175
76
+
+
5C
PCTV
RSSI
1
11
20
10
++
+
+
CV
+
BPF
MICI
MICO
TK-2202/2206 PC BOARD
TX-RX UNIT (X57-6870-20) Component side view (J72-0912-09)
Ref. No. Address
IC1 8I
IC101 4M
IC301 9D
IC302 8P
IC403 8B
IC404 7B
IC405 5D
IC406 9F
Q8 8J
Ref. No. Address
Q104 5L
Q105 4K
Q107 4L
Q108 4L
Q109 5L
Q202 4F
Q301 10E
Q302 8B
Q303 7P
Ref. No. Address
Q304 7P
Q305 8O
Q306 9P
Q316 9O
Q401 8R
Q402 8R
Q407 8D
Q408 7D
D1 8H
Ref. No. Address
D11 7J
D102 4M
D301 9B
D302 9B
D303 8A
D403 8R
D404 8R
29
J K L M N O P Q R S
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R403R
408
1 11
R409
R410
R411
R412
R413
R414
C39
CN401
R421
C41
R436
R437
R438
C403
C77C79
C80
Q104
Q105 DS
G
Q107
Q108S
GD
Q109
Q303
Q304
Q305
Q306
D403
D404
L301
Q316
L302
L111
D11
R121R126
R127
R128
R129
R130
R131
R132
R133
R134
MIC301
+ –
R135
R138
R139
L12
R334
R140
R335
R141
R336
R142
R143
R338
R339 R340
R341
R342
R344
R345
R346
R347
R348
R349
C126
R25R26
C138
Q8
C334
C140
R30
C335
R31
C336
C146
C148
C340
C341
C342
C343
C344
C345
C346
R42
D102
Q401
Q402
IC101
IC302
156 10
+
BPF
+
+
1
45
8
B
SP– SP+
+
DD
G
GS
S
SB
CN13ANT
J72-0912-09
TXD
AESPI
SPO
NC
5MS OPTDETMIC
PTT/RXD
MICIN
PC BOARD TK-2202/2206
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
TX-RX UNIT (X57-6870-20) Component side view (J72-0912-09)
30
JIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
J72-0912-09
R221
R222
R223R224
R225
R226
R227
R228
R229
R230
R231
R233
R234
R237 R238
R239
C52C53
C54
R240
R241
R242
R243
C57
C59
C60
C62
C64
C69
C70
C72
C75
C227
C2
S401PTT
S402SW2
S403SW1
C233
C2
C86
C237
C87
C239
C241C242
C243 C
244
C245C
247
C248
C249
TC1
C250
C251C252
C253
C254
R291
C255
C256
C258
Q102
Q103
G
CE B
E
SD
D4
Q106
D7
C260
D202C
262
D203
C263
C264
D204
D205
C265
D206
C266
C267
C268
C269
L102
L103
C270
L104L105
C271
L106
L107
L108
L109
L110
L112
L113L114
C280
L115
L116
L117
L118
L119
R101R103
R107
D10
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R119
R120
R122
R123
R124
R136
R137
L13
C101
L16
C104
TH101
L19
C105
C107
R337
C108
C109
L22
C110
C111
L25
R343
C115
C116
C117
C118
C119
C120
C121
C123
C124
C125
C128
C130
C132
C133
C134
C135
C136
C137
Q4
G
D
Q5
C139
C141
R32
C142
C143
C338
R34
C144
C339
R35
R36
C147
C149
R40
C150
C151
C153
C154
C348
C155
C156
C157
R47
C158C
159
C160
R50
D101
D103
D104
D105
D106
Q204
1 234
Q205
L202
L205
L207
L209
L210
L211
L213
L214
J301EXT. SP/EXT. MIC
+
1
23
4
+
GD
TXD
AE
SPI
SPO
NC
5MSOPTDETMIC
PTT/RXD
MICIN
TK-2202/2206 PC BOARD
TX-RX UNIT (X57-6870-20) Foil side view (J72-0912-09)
Ref. No. Address
IC2 6L
IC201 5N
IC401 9R
IC402 8R
Q1 7O
Q2 8L
Q3 9M
Q4 8J
Ref. No. Address
Q5 8I
Q6 8K
Q7 9L
Q9 6K
Q102 7H
Q103 7H
Q106 7F
Q203 4N
Ref. No. Address
Q204 4I
Q205 3F
Q403 8R
Q404 7R
Q405 9R
D4 9J
D5 10L
D7 9J
Ref. No. Address
D9 10L
D10 8J
D101 6J
D103 4D
D104 4C
D105 3C
D106 3C
D202 6J
Ref. No. Address
D203 5G
D204 5G
D205 4E
D206 4E
D401 7R
D402 4R
31
J K L M N O P Q R S
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R210
C24
XF201
C25
R212
C26
R215
C29
R216
R217
R218R
219
C30
CN201
C34
R220
C35
R221
R417
C38
R418R224
R420
C40
C42
C43
C44
C47C
48
C49
C50
C51
C53
C54
R435
C55
C206
C207
C57
C208
C58
CD201
C209
C59
C210
C60
C211
C61
C62
C407
C213
C63
C64
C409C65
C216
C66
R447
C67
C218
C68
C219 C220
C70
C221
C71
C222
C417
C73
C224
C74
C225
C76
C227
C228
CF201
C78
C421
C230
C231
C81
S402SW2
C426
C232
C82
C233
C427
C83
C428
C234
C84
C429
RXAFIRXAFO
C85
C235
C236
C86
C237
C87
C238
C239
C90
C244
C440
TC1
C5
TC2
MICI
MICO
C443
C9
D4
D5
D7
D9
D202
D401
D402
IC201
1 8916
IC401
IC402
R101103
D10
L1
L3
L5
L7
L8
L9
L10
L11
L13L14
CV
C101
L17L18
L19
L20
L21
L22
L23
L24L25
IC2
R12
R13
R14
R17
R23
Q1
Q2
Q3R
27
Q4
S
G
D Q6
Q7
L50
Q9
R32
R33
R34
R35
R36
R37
R38
R39
R7
R41
R43
C348
R44
R45
R46
R47
R48
R49
R50
D101
R51
Q2032
3
Q403
D
SG
D
SG
Q404
Q405
L201
L202
L203
L204
C370
L205
L206
X1
C12
C14
C15
C16
C17
C18
R207
R208
R209
1
45
8
S
D
G
+
1
34
5
1
34
5
TX-RX UNIT (X57-6870-20) Foil side view (J72-0912-09)
PC BOARD TK-2202/2206
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
28 29
J K L M N O P Q R SIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Black
Brown
Red
White
ADDITIONAL PCB
ADDITIONAL PCB
Q901
DGS
R901
GND MOD IN
MOD OUTRX-W/N
R902
C901
C902
GND MOD IN
RX-W/N MOD OUT
C21
C22
R403
R404
R211
R405
R406
R213
R407
C27
R408
1 11
R409
R410
R411
R412
C32
R413
C33
R414
R415
R416
R419
C39
CN401
R421
C41
R422
R423
R424
R425
C45
R426
C201
R436
R437TH203
R438
C401
C402C403
C405
C214
R445
C215
R446
C217
C410
C411
C415
C418
C419
C77C79
C80
C430
C431
C432
C433 C434
C435
C1
C2
C3
C4
C6
C7
C8
D1
Q104
Q105 DS
G
Q107
Q108S
GD
Q109
Q301
Q302
Q303
Q304
Q305
Q306
D403
D404
L301
Q316
L302
L111
IC403
IC404
IC405
IC406
145 8
CP404
CP405
D11
R301
R304
R305
R306R307
R308
R310
R311
R312
R313
R314
R315
R121
R316
R317
R318
R319
R126
L6
R127
R128
R129
R320
R321 R322
R323
R324
R130
R325
R131
R326
R132
R327
R133
R328
R134
MIC301
+ –
R329
R135
R138
R139
L12
R330
R331
R332
R334
R140
R335
R141
R336
R142
R143
R338
R339
C302
C304
R340
IC1
R341
C306
R342
C307
C308
R344
C309
R345
R346
R347
R348
R349
C310
C311 C312
C313
R10
C314
R350
R11
C315
C316
C317
R354
C318
R355
R15
C319
R16
C126
R357
R18
R19
C320
C321
C322
C323C324
R20
R360
C325
R21
C326
R22
C327
C328
C329
R25
R365
R26
C138
F401
Q8
C330
C331
C332
C333
C334
C140
R30
C335
R31
C336
R1
R2
C146
R3
R4
C148
R5
R6
R8
C340
R9C341
C342
C343
C344
C345
C346
R42
VR
1
C351
C352
C354
D102
Q202
D301
D302
D303
Q401
Q402Q407
Q408
GG
D
D
S
S
IC101L401
L402
L403
L404
IC301
IC302
156 10
X2
C10
C11
C13
R203
C19
R206
BATT+
5R
5T
5M
1
1
3
3
4
4
5
5
+
1
91016
17
2526 32
1100
2526
505175
76
+
+
5C
PCTV
RSSI
1
11
20
10
++
+
+
CV
+
BPF
+
+
1
45
8
B
SP– SP+
+
DD
G
GS
S
SB
CN13ANT
J72-0912-09
TXD
AESPI
SPO
NC
5MS OPTDETMIC
PTT/RXD
MICIN
MICI
MICO
TK-2202/2206 PC BOARD PC BOARD TK-2202/2206
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
TX-RX UNIT (X57-6870-20) Component side view (J72-0912-09) TX-RX UNIT (X57-6870-20) Component side view (J72-0912-09)
Ref. No. Address
IC1 8I
IC101 4M
IC301 9D
IC302 8P
IC403 8B
IC404 7B
IC405 5D
IC406 9F
Q8 8J
Ref. No. Address
Q104 5L
Q105 4K
Q107 4L
Q108 4L
Q109 5L
Q202 4F
Q301 10E
Q302 8B
Q303 7P
Ref. No. Address
Q304 7P
Q305 8O
Q306 9P
Q316 9O
Q401 8R
Q402 8R
Q407 8D
Q408 7D
D1 8H
Ref. No. Address
D11 7J
D102 4M
D301 9B
D302 9B
D303 8A
D403 8R
D404 8R
30 31
J K L M N O P Q R SIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
J72-0912-09
R210
C24
XF201
C25
R212
C26
R215
C29
R216
R217
R218R
219
C30
CN201
C34
R220
C35
R221
R222
R417
R223
C38
R418R224
R225
R226
R227
R228
R229
R420
C40
C42
C43
C44
R230
R231
R233
C47C
48
R234
C49
R237 R238
R239
C50
C51
C52C53
C54
R240
R435
R241
C55
C206
R242
C207
R243
C57
C208
C58
CD201
C209
C59
C210
C60
C211
C61
C62
C407
C213
C63
C64
C409C65
C216
C66
R447
C67
C218
C68
C219
C69
C220
C70
C221
C71
C222
C72
C417
C73
C224
C74
C75
C225
C76
C227
C228
CF201
C78
C421
C230
S401PTT
C231
C81
S402SW2
C426
C232
C82
S403SW1
C233
C427
C83
C428
C234
C84
C429
RXAFIRXAFO
C85
C235
C236
C86
C237
C87
C238
C239
C90
C241C242
C243 C
244
C245
C247
C248
C249
C440
TC1
C5
TC2
MICI
MICO
C443
C250
C9
C251C252
C253
C254
R291
C255
C256
C258
Q102
Q103
G
CE B
E
SD
D4
D5
Q106
D7
C260
D9
D202
C262
D203
C263
C264
D204
D205
C265
D206
C266
C267
C268
C269
D401
D402
L102
L103
C270
L104L105
C271
L106
L107
L108
L109
L110
L112
L113
L114
C280
IC201
1 8916
L115
L116
L117
L118
L119
IC401
IC402
R101R103
R107
D10
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R119
R120
L1
R122
L3
R123
R124
L5
L7
L8
L9
R136
R137
L10
L11
L13L14
CV
C101
L16
L17
L18
C104
TH101
L19
C105
C107
R337
C108
C109
L20
L21
L22
L23
C110
L24
C111
L25
IC2
R343
C115
C116
C117
C118
C119
C120
C121
R12
R13
C123
R14
C124
C125
R17
C128
C130
C132
C133
R23
C134
C135
Q1
C136
Q2
C137
Q3R
27
Q4
S
G
D
Q5
C139
Q6Q
7
L50
Q9
C141
R32
C142
R33
C143
C338
R34
C144
C339
R35
R36
R37
C147
R38
R39
C149
R7
R40
C150
C151
R41
R43
C153
C154
C348
R44
R45
C155
C156
R46
C157
R47
C158
R48
C159
R49
C160
R50
D101
R51
D103
D104
D105
D106
Q203Q
2041 2
34
Q205
Q403
D
SG
D
SG
Q404
Q405
L201
L202
L203
L204
C370
L205
L206
L207
L209
L210
L211
L213
L214
X1
J301EXT. SP/EXT. MIC
C12
C14
C15
C16
C17
C18
R207
R208
R209
+
1
23
4
+
GD
1
45
8
S
D
G
+
1
34
5
1
34
5
TXD
AE
SPI
SPO
NC
5MSOPTDETMIC
PTT/RXD
MICIN
TK-2202/2206 PC BOARD
TX-RX UNIT (X57-6870-20) Foil side view (J72-0912-09) TX-RX UNIT (X57-6870-20) Foil side view (J72-0912-09)
PC BOARD TK-2202/2206
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
Ref. No. Address
IC2 6L
IC201 5N
IC401 9R
IC402 8R
Q1 7O
Q2 8L
Q3 9M
Q4 8J
Ref. No. Address
Q5 8I
Q6 8K
Q7 9L
Q9 6K
Q102 7H
Q103 7H
Q106 7F
Q203 4N
Ref. No. Address
Q204 4I
Q205 3F
Q403 8R
Q404 7R
Q405 9R
D4 9J
D5 10L
D7 9J
Ref. No. Address
D9 10L
D10 8J
D101 6J
D103 4D
D104 4C
D105 3C
D106 3C
D202 6J
Ref. No. Address
D203 5G
D204 5G
D205 4E
D206 4E
D401 7R
D402 4R
32
TK-2202/2206 SCHEMATIC DIAGRAM
A B C D E
1
2
3
4
5
6
7
X57-687 1/4
C41
1
1000
p
C41
9
1000
p
C42
9
1000
p
D401RB521S-30
R407
330k
C42
6
1u
C40
7
1000
p
C42
1
1u
C21
10u6
.3
C18
18p
C22
0.33
u35
C26
30p
C12
1000
p
R16
560
R20 10
C11
100p
R15
220
R32 1k
R5
100k
R17
100
L6
R7
100
C9
10p
C14
0.01
u
C34
1000p
C5
1000
p
L3
560n
C25
2p
C6
0.1u
C8
100p
R12
2.2k
R13 0
C17
47p
C16
1000
p
C15 10p
R33
150k
C19
0.1u
R21
680
C7
100p
C24
1000
pC
35 27p
R19
1.5k
C33
1000
p
C50
10p
R14
330k
C13
0.1u
R41
4
330
R1
22k
R41
3
330
L401 F401
C40
3
0.1u
C40
1
470p
D40
2
1SR
154-
400
C40
5
100p
C430
0.01u
L402
C4
0.01u
C29
470p
C40
9
1u
C42
7
1u
R6
82k
R4
56k
C1
3300
p
C2
6800
p
R2
10k
R3
33k
C27
3.3u
16
C10
10u6
.3
D403B30-2156-05
D404B30-2157-05
C3
1u
R403
100
R404
470k(D)
R40
6
470k
(D)
R405
330k
R8
0
D1
MA2S111
Q401DTC114EE
Q402DTC114EE
C41
0
1u
C41
7
1u
R9 0
R10 0
R11 0
R41
247
k
R40
947
k
R40
847
k
C42
8
1000
p
S40
1
S40
3
S40
2
C40
2
1000
p
C44
470p
R27 22
L9
33n
C48
470p
C42 6pC38 6p
L8
18n
C40
4pC43
15p
IC1MB15A02
1O
SC
IN2
NC
13
OS
CO
UT
4V
P5
VC
C6
DO
7G
ND
8LD
9N
C2
10F
IN11121314151617181920
R41
047
k
R41
147
k
C30
470p
X1
12.8MHz
L77-1931-05
1VC
2GND
3
4
R18 0
R436
0R
437
47k
R43
8
47k
VR1R12-7491-05
CP404
47Kx2
CN4011 B
2 SB
3 SP1
4 SP2
5 GND
6 EN1
7 EN2
8 GND
9 EN3
10 EN4
11 EN5
IC403 BD4840FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC404BD4845FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC402XC6204B502MR
1VIN
2VSS
3CE
4
5
IC401XC6204B502MR
1VIN
2VSS
3CE
4
5
C41
5
470p
KTC4082Q1
L5
560n
CPH3317Q403
C44
3
0.47
u
L1
4.7u
L7
CPH3317Q404
Q405DTA123JE
2SC5108(Y)Q2
C41
8
1000
p
RXAFO
5C
SW1 SW2
LED/RED
PTT
BATT
TX-RX UNIT (X57-6870-20)
TXCO
LED/GREEN
LED SW/GREEN
LED SW/RED
5C SW
VOLTAGEREGULATOR/5V
IC401,402
VOLTAGE DETECTOR/RESET
VOLTAGEDETECTOR/INT
5T SW
5R SW
REVERSEPROTECTION
TRIPLER
PLL SYSTEM
RIPPLEFILTER
PLL IC F_IN AMP
BATT
5V PROTECTION
NC
VoUT
NC
VoUT
oUTPUT
VCC
CLK
NC
3
DA
TALEFC
NC
4
FO
UTP
NC
5R
LEDTX
LEDRX
SIDE1
SIDE2
5M
5C_C5R_C5T_CBATT
RESETINT
PTTSWSB
VCC
VSS
VCCVSS
RXAFO
QTTCXO
OSCIN
EN1
EN5
PLL_UL
5RSP2
EN4
PLL_STB
5T
EN3
PLL_DAT
5C
EN2
PLL_CLKB
SP1
ON:4.92VOFF:0.01V
ON:4.92VOFF:0.01V
4.96V
5.00V
R:7.28VT:6.80V
R:7.56VT:7.26V
R:3.70VT:3.57V
R:5.01V
T:4.99V
R:4.83V
4.72V
4.84V
4.76V
4.95V
2.73V
0.7V
4.83V
TK-2202/2206SCHEMATIC DIAGRAM
L22
C32
0.1u
35
2SC4617(S)Q8
TC
2
10p
C74
0.5p
C54 4p
C73
0.5p(B)
R40
100
D5
1SV
325
L23
39n
C66 5p
C76
1000
pC
79
10u6
.3
C57
1.5p
C67 5p
C80
470p
C55
120p
R39
150
R22
0
R34
4.7k
R42
4.7k
D9
1SV325
D7
1SV325
R36
270k
C59
1.5p
TC
1
10p
C61 4pC49
100p
C58 6p
C47
100p
R23
10k
C78
33p
R38
180
D10
1SV
278
2SK508NV(K52)Q4
C52
180p
R43
100
D4
1SV
325
L24
C69
470p
D11
MA
2S11
1
R30
12k
C45
1u
C30
4
0.22
u
R308
0
D301RB706F-40
R30
5
100k
R31
560k
C302
0.01u
R304
560k
R301
47k
C39
3300
p
C41
6800
p
L404
L403
C431
0.01u
C43
3
3p
2SK1830Q408
C432
5p
R422
1k R423
0
C435
5p
R33
8
2.2k
R415
47k
R25
22k
R26
10k
R421
1k
R420
47k
R419
47k
R41
150k
R35
270k
C62 5p
R42447k
R42547k
L12
L10
180n
L13
220n
L16
39n
C60 1p
C77
470p
L21
3.3u
C644p
C70
470p
C72
0.1u
L19
220n
C75
1000
p
L11
100n
L14
220n
L17
27n
C655p
L20
3.3u
C71
0.1u
L18
220n
C68
470p
C63
100p
R37
100
2SK1830Q407
C43
4
3p
R416
47kR354
10k
C35
1
0.01
u
C35
2
0.01
u
R355
10k
R357
0
C354
0.1u
R41
8
47k
R41
7
47k
R43
5
47k
IC406BR24L08F-W
1A0
2A1
3A2
4GND
5
6
7
8
C53
0.5p
X2
7.3MHzL78-1411-05
R44 1k
C51
1000
p
C83
1000p
C84
1000
p
C8115p
R45
3.3k
R51 10
R46
3.3k
IC2UPB1509GV
1VCC1
2IN
3IN
4GND
5
6
7
8
R47 47
C82
1000p
C90
1000
p
R447
4.7k
L50
CP
405
1Kx2
Q5DTA143TE
Q7DTA143TE
R36
5
47k
IC40530622MAA-B89GP
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
261/
2OS
C
272829303132333435363738394041424344454647484950
51
52
53
54
55
56
5758
59
60
6162
63
64
65
66
67
6869
7071
72
73
74
75
76S
IM1
77S
IM2
78 79 805T
_C81
5R_C
825C
_C83 84 85 86 87 88
BA
TT
89R
SS
I90
BU
SY
91V
OX
92Q
T/D
QT
_IN
93T
H_D
ET
94A
VS
S95 96
VR
EF
97A
VC
C98 99
MIC
_MU
TE
100
2SC5108(Y)Q6
R426
0
2SK1824Q901
R901
4.7k
C902
1u
C90
1
1u
R90
2
4.7k
CV
3.6864 MHz CLK
VCO OSCILLATION (TX)
VCO OSCILLATION (RX)
TX MODULATION
VCO 1/2 DIVIDER
EEPROM
BEAT SHIFT SW
BEAT SHIFT SW
SIDE1
LEDTX
LEDRX
SIDE2
VCC
BATT5T_C5R_C5C_C DETECTOR
AF_CONTOPTDET
MICROPROCESSOR
VCO/TX
FREQUENCYCONTROL/RX VCO
D5,9
VCO/RX
RF BUFFER AMP
DC SW/TX VCO
DC SW/RX VCO
RIPPLE FILTER
FREQUENCYCONTROL/TX VCO
D4,7
MODULATOR
CURRENTSTEERING
5M
RESETINT
PTTSWSB
VSS
RXAFO
ADDITIONAL PCB
MOD OUT
RX_W/N GND
MOD IN
PCTV
DTMF
EEPDAT
EEPCLK
BYTE
GND
BSHIFT
RESET
XOUT
VSS
XINVCC
VCCINT
TCLK/DTRDO
RDF/FD
SCLK
DI/O
TDATA/DTRCLK
DIRSTD
OPTDET
AF_CONT
VCC
VSS
GND
GND
LEDTX
LEDRX
PF1
PF2
PT
T
QT
TC
XO
TX
D
RX
D
GN
D
AP
CS
W
DC
SW
TX
_W/N
RX
_SW
TX
_SW
GN
D
PLL
_UL
PLL
_ST
B
PLL
_DA
T
PLL
_CLK
VC
C
RX
_W/N
EN
5
EN
4
EN
3
EN
2
EN
1
QTVCODTRLOADN
PLL_CLKPLL_DATPLL_STBPLL_ULQTTCXO
OSCIN
5T
SP2
EN1
EN2
EN3
EN4
EN5
5R5C
B
SP1
VSSVCC
SDA
SCL
WP
VCC
2SK508NV(K52)Q3
SW1
SW2
OUT
VCC2
TDATA/DTRCLK
DI/O
TCLK/DTRDO
MOD
RDF/FD
XIN
DIR
SCLK
DTRLOADN
STD
BUSY
PTTSW
OPTDET
RSSI
QT/DQT_INMIC_MUTE
5M
TXDPCTV
SB
AF_CONT
EXTLIMIN
AMP3O
RX_W/NTX_W/N
RXAFO
OSCIN
5T
5R5C
B
APCSW
TH_DETSP2
SP1
DCSW
4.96V
R:3.46V
T:3.42V
0.72V
3.74V
R:4.97VT:0.59V
4.0V
4.74V
R:0.60VT:4.95V
BSHIFT ON:4.95VOFF:0V
F G H I J
TX-RX UNIT (X57-6870-20)
X57-687 2/4
TK-2202/2206 SCHEMATIC DIAGRAM
-t
-t
C32
1
1u
C20
9
10u6
.3
C12
6
6.8u
10
R130
150k(D)
R21
3
3.9k
R21
8
560
R14
0
56k
C22
4
0.01
u
R13
9
47k
C20
6
1000
p
R13
3
150k
(D)
R13
8
1M
R21
2
82k
C20
7
1800
p
TH
101
100k
R216
120k
C219
33p
C13
8
1000
p
C317
0.1u
C140
100p
Q109DTA144EE
R131
150k(D)
Q104DTC114EE
D10
2
HZ
U5C
LL
R14
3
100k
C210
470p
C22
0
1000
p
C231
0.01u
C21
5
1000
p
R12
7
0.39
R12
9
0.39
R12
8
0.39
R21
5
100
R141
100k
R135150k (D)
C213
0.1u
C14
8
1000
p
C22
5
0.01
u
Q107DTC114EE
IC201TA31136FN
123456789
AF
OU
T
10Q
UA
D
11IF
OU
T
12R
SS
I
13N
-DE
T
14N
-RE
C
15G
ND
16M
IXIN
C20
1
0.22
u
R134
150k (D)
C21
7
0.1u
C20
8
470p
R210
3.3k
R13
2
150k
(D)
R12
6
2.2k
R11
5
10k
C21
4
68p
R20
7
4.7k
R208
82k
2SC4649(N,P)Q203
2SK1824Q108
C146
1000p
C22
1
0.1u
C21
1
0.01
u
R20
9
2.7k
C326
1000p
R31
2
330k
R316120k
C309
82p
R324
100k
C30
80.
1u
R32
7
180k
R31
5
330k
C312
12p
C325
0.1uC331
0.1u
C30
64.
7u6.
3
C322
0.015u
R329
82k
C328
390p
R325
100k
C32
4
82p
C3200.01u
C30
7
0.1u
C310
0.068u
R332
15k
C31
9
270p
C32
3
82p
C316
0.1u
C333
0.1u
C311
1u
C313
120p
R314
10k
R318
1.2kR328
10k
R313
100k
R311
12k
R211
3.3k
R310
390k
C330
1u
IC301AQUA
12345678
DTRLOADN
9
STD
10TCLK/DTRDO
11TDATA/DTRCLK
12DI/O
13RDF/FD
14SCLK
15DIR
16XOUT
17X
IN18
VS
S
19A
MP
3P
20A
MP
3N
21A
MP
3O
22A
MP
4P
23A
MP
4N
24A
MP
4O
25D
TR
AIN
26
27
28
29
30
31
32
R20
3
180k
CD
201
Q202DTA144EE
C21
6
0.1u
C21
8
0.1u
C31
40.
1u
C329
1u
2SK879(Y)Q105
R326
0
R321
220k
R331
39k
R12
156
0
R30
7
0
R330
3.3k
2SC4919Q302
L201 1u
C315
1u
IC101TA75W01FU
1OUT1
2IN1-
3IN1+
4VEE
5
6
7
8
R14
2
0
C44
0
1.5p
C22
810
p
R306
1k
R31
7
470k
Q301DTA114EE
R319
56k
R32
03.
3k R32356k
C32
710
0p
R322
180k
D302RB706F-40
D303DAN222
TH
203
1
IN
2
oUT
6543
C31
8
4.7u
6.3
R445
0
R446
0
R360
0
C33
2
470p
R219
560
R103
0
C12
3
1u
R48
330
2SK2595Q106
C10
7
1000
p
L105
150n
L104
27n
R50
4.7k
C86
1000
p
L103
R11
0
330
L25
82n
C101
1000p
L107
27n
C22
7
1000
p
C12
1
10p
C10
510
00p
L102
100n
C11
6
22p
D20
2
HS
C27
7 C11
5
1000
p
C11
8
100p
R11
7
68k
C104
39p
C12
8
1000
p
C12
4
1000
p
R49
2.2k
C11
7
10pD101
HSC277
L106
R120
02SK2596
Q103C108
39p
R11
3
330C87
10p R12
3
82
R12
2
47k
2SC5108(Y)Q9
R10
915
C11
9
27p
R10
7
560
R11
4
47k
C12
5
1000
p
C85
1000
p
C120
1000p
C110
1000p
R10
1
12k
R12
4
12k
R11
1
330
R112
18
C11
1
1000
p
R11
9
330
R11
6
15
R108
1.5k
C13
3
0.01
u
C10
9
0.1u
R21
7
4.7k
C22
2
1000
p
C233
2p(B)
C23
0
8p
C23
5
9p
C237
5p(B)
L202
39n
C23
9
6p(B
)
L205
68n
2SC4926YDQ102
R20
6
10
MICO MICI
RXAFIRXAFO
C37
0
0.1u
38.4
MH
z
TX DRIVE AMP
W/N SW/RX
TDATA/DTRCLK
TCLK/DTRDO
DI/O
RDF/FD
SCLK
DIR
XIN
STD
DTRLOADN
MOD
OSCIN
5T
5R
SB
W/N SW/TX
DETECTOR
OPTDETAF_CONT
TXD
5M
RSSI
PTTSW
FM IFSYSTEM
MIC AGCISOLATION
IF AMP
PCTV
APC SW
APC SW
RF AMP
RF AMP
APC SW
APC SW
QT/DQT_INMIC_MUTE
BUSY
COMPARATOR(APC)
AUDIO PROCESSOR
TX FINAL AMP
APC SW
TX/RXRF SW
APC PROTECT
5C
B
D101,202
5T
EXTLIMIN
AMP3O
APCSW
TH_DETSP2
SP1
DCSW
RX_W/NTX_W/N
RXAFO
RX LO1
AG
ND
IN
TX
IN
TX
INO
LIM
LV
EX
TLI
MIN
MO
D
VD
D
RXAF
RXAFIN
EXPOUT
FILTERO
RXINO
RXIN
AGND
IN2+
IN2-
OUT-B
VCC
XF201L71-0619-0538.85 MHz
MCF
CF201L72-0973-05
OS
CIN
OS
CO
UT
MIX
OU
T
VC
C
IFIN
DE
C
FIL
OU
T
FIL
IN
5R
PTTSW
5M
TXD
PCTV
SB
SP2
AF_CONTOPTDET
2.2VR:1.65VT:1.05V
4.6V
R:2.84VT:0.03V
R:0.1VT:1.88V
T:1.11V
T:4.9VT:1.88V R:7.68V
T:7.30V
T:2.7V(H) 1.99V(L)
W:0.011VN:4.98V
K L M N O
X57-687 3/4
TX-RX UNIT (X57-6870-20)
35
TK-2202/2206SCHEMATIC DIAGRAM
TSRQP
1
2
3
4
5
6
7
R337
100
R345
100
R33
9
470
C34
4
220p
R334
47k
C34
2
10u6
.3
R33
5
2.2k
2SA1362(GR)Q304
C339
10u6.3
C33
6
0.47
u
R34
0
1.8k
J301
C334
0.1u
R346 100
L301
C34
1
0.04
7u
C338 100p
R34
9
33kC33
5
220p
R34
2
10
R344 1k
L302
R336
1k
C340
0.1u
C345
100u6.3
R35
0
0
C34
3
0.04
7u
R34
8
56k
R343
470k
IC302TA7368F
11
2VCC
33
4VIN
5RIPPLE
6
7
8
9
10
Q305DTC144EE
MIC301
R34
7
100k
CPH3413Q306
R341 10k
Q303DTC144EE
C34
6
1000
pC
348
470p
C144
82p
C15
5
18p
L119
6T
L108
C15
7
15p
C14
9
22p
C13
2
1000
p
C15
0
22p
L110
56n
C14
2
15p
L109
2.2u
C159
7p
C14
3
10p
L112 9TC13
0
10p
C14
1
22p
C13
4
0.1u
C15
3
10p
L116 8T
L113
3T
C13
9
68p
C13
7
0.01
u
L117
7T
D10
5
HV
C13
1
D10
6
HV
C13
1
C151
1000p
L114
5T
R13
7
270
L115
3T
C15
8
22p
D103
HVC131
L111
1u
D104
HVC131
C13
5
1u
C156
12p
C154
10p
L118
7T
C14
7
1000
p
C13
6
27p
C160
33p
R13
6
270
L209
56n
D20
6
1SV
305
R22
9
1.0M
R220
560
L206
180n
C24
8
27p
R22
8
1.0M
D20
3
1SV
305
L210
C24
9
1000
p
R240
0
L211
56n
R22
3
82k
C26
9
33p
C253
4.5p(B)
R23
3
220
C250
4p(B)
C24
1
1000
p R24
2
1.0M
L204
0.56
u
R24
1
1.0M
C25
4
27p
C26
4
4p
C26
0
1000
p
R239
47
R22
1
1k
C23
2
0.01
u
C263
10p
C24
2
0.1u
R22
5
82k
L213 56n
C25
2
1000
p
R23
4
100k
C24
7
4p(B
)
C245
470p
C271
11p
C268
3p(B)
C26
5
33p
C27
0
4p
C238
12pC267
3p(B)C
236
1000
p
D20
5
1SV
305
R231
47
R23
7
180k
L214
47n
C25
5
4.5p
(B)
L207
150n
C24
4
4p(B
)
R22
2
220
C25
1
4.7u
6.3
C2431000p
R23
8
100k
3SK318Q204
C23
4
0.01
u
C26
2
1000
p
D20
4
1SV
305
R23
0
2.2k
C25
6
1000
p
R227
0C
266
1000
p
R24
3
0
R22
4
82k
BPF
R22
6
82k
C25
8
1000
p
R291
0
CPH3413Q316
C28
0
1000
p
CN201
L203
ANTCN13
ANT SW
DC SW
AF AMP
SP MUTE SW
SP MUTE SW
DC SW/SP MUTE
5R
MIXER
DC SW/SP MUTE
PTTSW
5M
SB
TXD
PCTV
RF AMP
ANT SW
ANT SW ANT SW
RF BPF TUNING
D203,204 D205,206
RF BPF TUNING
5T
SP2
OPTDETAF_CONT
RX LO1
PTT/RXDMIC
MICINOPTDET
5MSAE
TXDNC
SPOSPI
3SK318Q205
NF
PHASE
PRE-GND
PW-GND
PoUT
R:0.99V
R:4.98V
R:2.48V
R:2.48V
R:0.75V
R:4.8V R:4.92V
R:1.76V
R:7.52VT:7.31V
R:0.3V(MUTE ON) 7.3V(MUTE OFF)T:0.3V
R:7.3V(MUTE ON) 0.3V(MUTE OFF)T:7.3V
X57-687 4/4
TX-RX UNIT (X57-6870-20)Note :The components marked with a dot ( ) are parts of layer1.
TK-2202/2206 SCHEMATIC DIAGRAM
-t
-t
C41
1
1000
p
C41
9
1000
p
C42
9
1000
p
D401RB521S-30
R407
330k
C42
6
1u
C32
1
1u
C40
7
1000
p
C42
1
1u
C20
9
10u6
.3
C12
6
6.8u
10
C21
10u6
.3
R130
150k(D)
L22
R21
3
3.9k
R21
8
560
C32
0.1u
35
2SC4617(S)Q8
TC
2
10p
C74
0.5p
C18
18p
C54 4p
R14
0
56k
C22
4
0.01
u
R13
9
47k
C73
0.5p(B)
R40
100
C20
6
1000
p
R13
3
150k
(D)
D5
1SV
325
L23
39n
C22
0.33
u35
C66 5p
R13
8
1M
R21
2
82k
C26
30p
C12
1000
p
C76
1000
p
R16
560
C20
7
1800
p
TH
101
100k
C79
10u6
.3
R216
120k
R20 10
C11
100p
C57
1.5p
C67 5p
C219
33p
C13
8
1000
p
C80
470p
C317
0.1u
C140
100p
R15
220
Q109DTA144EE
R131
150k(D)
C55
120p
Q104DTC114EE
R39
150
D10
2
HZ
U5C
LL
R22
0
R32 1k
R34
4.7k
R42
4.7k
R14
3
100k
C210
470p
C22
0
1000
p
C231
0.01u
C21
5
1000
p
D9
1SV325
R12
7
0.39
R12
9
0.39
R5
100k
R17
100
L6
R7
100
R12
8
0.39
R21
5
100
D7
1SV325
C9
10p
R36
270k
R141
100k
C14
0.01
u
C59
1.5p
R135150k (D)
C213
0.1u
TC
1
10p
C14
8
1000
pC34
1000p
C61 4p
C22
5
0.01
u
C5
1000
p
L3
560n
C25
2p
Q107DTC114EE
C49
100p
C6
0.1u
C8
100p
R12
2.2k
IC201TA31136FN
123456789
AF
OU
T
10Q
UA
D
11IF
OU
T
12R
SS
I
13N
-DE
T
14N
-RE
C
15G
ND
16M
IXIN
C58 6p
C20
1
0.22
u
C47
100p
R13 0
R23
10k
R134
150k (D)
C21
7
0.1u
C20
8
470p
R210
3.3k
C78
33p
R13
2
150k
(D)
R38
180
D10
1SV
278
R12
6
2.2k
2SK508NV(K52)Q4
C17
47p
R11
5
10k
C16
1000
p
C52
180p
C15 10p
R33
150k
C21
4
68p
R43
100
C19
0.1u
R21
680
R20
7
4.7k
R208
82k
D4
1SV
325
L24C7
100p
2SC4649(N,P)Q203
2SK1824Q108
C146
1000p
C22
1
0.1u
C69
470p
C21
1
0.01
u
C24
1000
p
D11
MA
2S11
1
C35 27p
R20
9
2.7k
R30
12kR19
1.5k
C33
1000
p
C50
10p
R14
330k
C326
1000p
R31
2
330k
R316120k
C45
1u
C13
0.1u
C309
82p
R324
100k
C30
80.
1u
R32
7
180k
R31
5
330k
C312
12p
C325
0.1uC331
0.1u
C30
64.
7u6.
3
C322
0.015u
R329
82k
C328
390p
R325
100k
C32
4
82p
C3200.01u
C30
7
0.1u
C310
0.068u
R332
15k
C31
9
270p
C32
3
82p
C316
0.1u
R337
100
C30
4
0.22
u
R345
100
R33
9
470
C34
4
220p
R334
47k
R308
0
C34
2
10u6
.3
R33
5
2.2k
2SA1362(GR)Q304
C339
10u6.3
R41
4
330
C33
6
0.47
u
R34
0
1.8k
J301
C334
0.1u
D301RB706F-40
R346 100
C333
0.1u
L301
C34
1
0.04
7u
C338 100p
R34
9
33kC33
5
220p
R34
2
10
R344 1k
L302
R336
1k
C340
0.1u
C345
100u6.3
R35
0
0
C34
3
0.04
7u
C311
1u
R34
8
56k
R343
470k
R1
22k
IC302TA7368F
11
2VCC
33
4VIN
5RIPPLE
6
7
8
9
10
R30
5
100k
Q305DTC144EE
MIC301
R41
3
330
L401 F401
C40
3
0.1u
C40
1
470p
D40
2
1SR
154-
400
C40
5
100p
R31
560k
C302
0.01u C313
120p
R314
10k
R304
560k
R301
47k
R318
1.2kR328
10k
C39
3300
p
C41
6800
p
R313
100k
L404
C430
0.01u
L402
R311
12k
L403
C431
0.01u
R211
3.3k
R310
390k
C4
0.01u
C330
1u
IC301AQUA
12345678
DTRLOADN
9
STD
10TCLK/DTRDO
11TDATA/DTRCLK
12DI/O
13RDF/FD
14SCLK
15DIR
16XOUT
17X
IN18
VS
S
19A
MP
3P
20A
MP
3N
21A
MP
3O
22A
MP
4P
23A
MP
4N
24A
MP
4O
25D
TR
AIN
26
27
28
29
30
31
32
C29
470p
C40
9
1u
C42
7
1u
C43
3
3p
2SK1830Q408
C432
5p
R422
1k R423
0
C435
5p
R6
82k
R4
56k
C1
3300
p
C2
6800
p
R2
10k
R3
33k
C27
3.3u
16
R20
3
180k
R33
8
2.2k
CD
201
C10
10u6
.3
R415
47k
D403B30-2156-05
D404B30-2157-05
C3
1u
Q202DTA144EE
C21
6
0.1u
C21
8
0.1u
C31
40.
1u
C329
1u
2SK879(Y)Q105
R403
100
R34
7
100k
R25
22k
R26
10k
R326
0
R321
220k
R331
39k
R404
470k(D)
R40
6
470k
(D)
R405
330k
R8
0
R421
1k
R12
156
0
R420
47k
D1
MA2S111
Q401DTC114EE
Q402DTC114EE
CPH3413Q306
C41
0
1u
R30
7
0
R330
3.3k
R341 10k
2SC4919Q302
L201 1u
Q303DTC144EE
C41
7
1u
C315
1u
IC101TA75W01FU
1OUT1
2IN1-
3IN1+
4VEE
5
6
7
8
R14
2
0
R9 0
R10 0
R11 0
R419
47k
R41
150k
R35
270k
C62 5p
R41
247
k
R40
947
k
R42447k
R40
847
k
R42547k
C42
8
1000
p
C44
0
1.5p
C22
810
p
S40
1
S40
3
S40
2
C40
2
1000
p
C34
6
1000
p
L12
L10
180n
L13
220n
L16
39n
C60 1p
C77
470p
L21
3.3u
C644p
C70
470p
C72
0.1u
L19
220n
C75
1000
p
L11
100n
L14
220n
L17
27n
C655p
L20
3.3u
C71
0.1u
L18
220n
C68
470p
C63
100p
R37
100
C44
470p
R27 22
L9
33n
C48
470p
C42 6pC38 6p
L8
18n
C40
4pC43
15p
2SK1830Q407
C43
4
3p
R306
1k
R31
7
470k
Q301DTA114EE
R319
56k
R32
03.
3k R32356k
C32
710
0p
R322
180k
D302RB706F-40
D303DAN222
TH
203
IC1MB15A02
1O
SC
IN2
NC
13
OS
CO
UT
4V
P5
VC
C6
DO
7G
ND
8LD
9N
C2
10F
IN11121314151617181920
1
IN
2
oUT
6543
R41
047
k
R41
147
k
C31
8
4.7u
6.3
R416
47k
C30
470p
X1
12.8MHz
L77-1931-05
1VC
2GND
3
4
R354
10k
C35
1
0.01
u
C35
2
0.01
u
R355
10k
R357
0
C354
0.1u
R41
8
47k
R41
7
47k
R18 0
R43
5
47k
R436
0
R43
7
47k
R43
8
47k
VR1R12-7491-05
R445
0
R446
0
CP404
47Kx2
CN4011 B
2 SB
3 SP1
4 SP2
5 GND
6 EN1
7 EN2
8 GND
9 EN3
10 EN4
11 EN5
R360
0
IC403 BD4840FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC404BD4845FVE
1VoUT
2SUB
3NC
4GND
5VDD
IC402XC6204B502MR
1VIN
2VSS
3CE
4
5
IC401XC6204B502MR
1VIN
2VSS
3CE
4
5
IC406BR24L08F-W
1A0
2A1
3A2
4GND
5
6
7
8
C41
5
470p
C33
2
470p
C34
8
470p
C53
0.5p
R219
560
X2
7.3MHzL78-1411-05
C144
82p
R103
0
C12
3
1u
R44 1k
R48
330
2SK2595Q106
C10
7
1000
p
L105
150n
C15
5
18p
C51
1000
p
L104
27n
L119
6T
R50
4.7k
C83
1000p
L108
C15
7
15p
C86
1000
p
C14
9
22p
L103
R11
0
330
C13
2
1000
p
C15
0
22p
L110
56n
L25
82n
C14
2
15p
C84
1000
p
C101
1000p
L107
27n
C22
7
1000
p
C12
1
10p
C10
510
00p
L109
2.2uC81
15p L102
100n
C159
7p
C14
3
10p
L112 9TC13
0
10p
C11
6
22p
R45
3.3k
D20
2
HS
C27
7
C14
1
22p
C13
4
0.1u
C11
5
1000
p
C11
8
100p
C15
3
10p
R11
7
68k
R51 10
C104
39p
L116 8T
C12
8
1000
p
L113
3T
C13
9
68p
C13
7
0.01
u
L117
7T
C12
4
1000
p
R49
2.2k
C11
7
10pD101
HSC277
D10
5
HV
C13
1
D10
6
HV
C13
1
R46
3.3k
C151
1000p
L106
R120
0
L114
5T
R13
7
270
2SK2596Q103 L115
3T
C108
39p
R11
3
330C87
10p
IC2UPB1509GV
1VCC1
2IN
3IN
4GND
5
6
7
8
R47 47
C15
8
22p
R12
3
82
R12
2
47k
D103
HVC131
2SC5108(Y)Q9
R10
915
L111
1uC11
9
27p
D104
HVC131
C13
5
1u
R10
7
560
R11
4
47k
C12
5
1000
p
C85
1000
p
C156
12p
C154
10p
L118
7T
C82
1000p
C120
1000p
C14
7
1000
p
C110
1000p
R10
1
12k
C13
6
27p
C160
33p
R12
4
12k
R11
1
330
R112
18
R13
6
270
C11
1
1000
p
R11
9
330
R11
6
15
R108
1.5k
C13
3
0.01
u
C10
9
0.1u
R21
7
4.7k
C22
2
1000
p
C233
2p(B)
C23
0
8p
C23
5
9p
C237
5p(B)
L202
39n
C23
9
6p(B
)
L205
68n
L209
56n
D20
6
1SV
305
R22
9
1.0M
R220
560
L206
180n
C24
8
27p
R22
8
1.0M
D20
3
1SV
305
L210
C24
9
1000
p
R240
0
L211
56n
R22
3
82k
C26
9
33p
C253
4.5p(B)
R23
3
220
C250
4p(B)
C24
1
1000
p R24
2
1.0M
L204
0.56
u
R24
1
1.0M
C25
4
27p
C26
4
4p
C26
0
1000
p
R239
47
R22
1
1k
C23
2
0.01
u
C263
10p
C24
2
0.1u
R22
5
82k
L213 56n
C25
2
1000
p
R23
4
100k
C24
7
4p(B
)
C245
470p
C271
11p
C268
3p(B)
C26
5
33p
C27
0
4p
C238
12pC267
3p(B)C
236
1000
p
D20
5
1SV
305
R231
47
R23
7
180k
L214
47n
C25
5
4.5p
(B)
L207
150n
C24
4
4p(B
)
R22
2
220
C25
1
4.7u
6.3
C2431000p
R23
8
100k
3SK318Q204
C23
4
0.01
u
C26
2
1000
p
D20
4
1SV
305
R23
0
2.2k
C25
6
1000
p
R227
0
C26
6
1000
p
R24
3
0
R22
4
82k
BPF
R22
6
82k
C25
8
1000
p
KTC4082Q1
2SC4926YDQ102
C90
1000
p
R447
4.7k
L5
560n
CPH3317Q403
R291
0
C44
3
0.47
u
L1
4.7u
L7
L50
CP
405
1Kx2
CPH3317Q404
CPH3413Q316
Q405DTA123JE
C28
0
1000
p
Q5DTA143TE
Q7DTA143TE
R36
5
47k
CN201
IC40530622MAA-B89GP
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
261/
2OS
C
272829303132333435363738394041424344454647484950
51
52
53
54
55
56
5758
59
60
6162
63
64
65
66
67
6869
7071
72
73
74
75
76S
IM1
77S
IM2
78 79 805T
_C81
5R_C
825C
_C83 84 85 86 87 88
BA
TT
89R
SS
I90
BU
SY
91V
OX
92Q
T/D
QT
_IN
93T
H_D
ET
94A
VS
S95 96
VR
EF
97A
VC
C98 99
MIC
_MU
TE
100
R20
6
10
2SC5108(Y)Q2
2SC5108(Y)Q6
C41
8
1000
p
R426
0
MICO MICI
RXAFIRXAFO
L203
C37
0
0.1u
RXAFO
5C
2SK1824Q901
R901
4.7k
C902
1u
C90
1
1u
R90
2
4.7k
ANTCV
SW1 SW2
LED/RED
PTT
BATT
TX-RX UNIT (X57-6870-20)
CN13
TXCO
3.6864 MHz CLK
38.4
MH
z
VCO OSCILLATION (TX)
VCO OSCILLATION (RX)
TX MODULATION
TX DRIVE AMP
VCO 1/2 DIVIDER
EEPROM
W/N SW/RX
ANT SW
LED/GREEN
LED SW/GREEN
LED SW/RED
5C SW
VOLTAGEREGULATOR/5V
IC401,402
VOLTAGE DETECTOR/RESET
VOLTAGEDETECTOR/INT
5T SW
5R SW
BEAT SHIFT SW
BEAT SHIFT SW
REVERSEPROTECTION
SIDE1
LEDTX
LEDRX
SIDE2
TRIPLER
PLL SYSTEM
RIPPLEFILTER
PLL IC F_IN AMP
TDATA/DTRCLK
TCLK/DTRDO
DI/O
RDF/FD
SCLK
DIR
XIN
STD
DTRLOADN
MOD
VCC
BATT
OSCIN
5T
5R
BATT5T_C5R_C5C_C
SB
W/N SW/TX
DETECTOR
DETECTOR
AF_CONTOPTDET OPTDET
AF_CONT
TXD
5M
RSSI
PTTSW
DC SW
FM IFSYSTEM
MIC AGCISOLATION
IF AMP
AF AMP
SP MUTE SW
SP MUTE SW
DC SW/SP MUTE
PCTV
5R
MICROPROCESSOR
VCO/TX
FREQUENCYCONTROL/RX VCO
D5,9
VCO/RX
APC SW
MIXER
APC SW
RF AMP
RF BUFFER AMP
DC SW/TX VCO
DC SW/RX VCO
RIPPLE FILTER
RF AMP
APC SW
APC SW
DC SW/SP MUTE
PTTSW
5M
SB
TXDQT/DQT_INMIC_MUTE
BUSY
PCTV
COMPARATOR(APC)
AUDIO PROCESSOR
TX FINAL AMP
APC SW
RF AMP
FREQUENCYCONTROL/TX VCO
D4,7
MODULATOR
CURRENTSTEERING
TX/RXRF SW
APC PROTECT
5C
B
ANT SW
ANT SW ANT SW
D101,202
RF BPF TUNING
D203,204 D205,206
RF BPF TUNING
5V PROTECTION
5T5T
5M
RESETINT
EXTLIMIN
AMP3O
APCSW
TH_DET
PTTSWSB
SP2
SP1
SP2
DCSW
RX_W/NTX_W/N
VSS
RXAFO RXAFO
OPTDETAF_CONT
ADDITIONAL PCB
MOD OUT
RX_W/N GND
MOD IN
RX LO1 RX LO1
PCTV
DTMF
EEPDAT
EEPCLK
BYTE
GND
BSHIFT
RESET
XOUT
VSS
XINVCC
VCCINT
TCLK/DTRDO
RDF/FD
SCLK
DI/O
TDATA/DTRCLK
DIRSTD
OPTDET
AF_CONT
VCC
VSS
GND
GND
LEDTX
LEDRX
PF1
PF2
PT
T
QT
TC
XO
TX
D
RX
D
GN
D
AP
CS
W
DC
SW
TX
_W/N
RX
_SW
TX
_SW
GN
D
PLL
_UL
PLL
_ST
B
PLL
_DA
T
PLL
_CLK
VC
C
RX
_W/N
EN
5
EN
4
EN
3
EN
2
EN
1
QTVCODTRLOADN
NC
VoUT
NC
VoUT
oUTPUT
VCC
CLK
NC
3
DA
TALEFC
NC
4
FO
UTP
NC
5R
LEDTX
LEDRX
SIDE1
SIDE2
5M
5C_C5R_C5T_CBATT
RESETINT
PTTSWSB
VCC
VSS
VCCVSS
RXAFO
QTTCXO
OSCIN
EN1
EN5
PLL_UL
5RSP2
EN4
PLL_STB
5T
EN3
PLL_DAT
5C
EN2
PLL_CLKB
SP1
PLL_CLKPLL_DATPLL_STBPLL_ULQTTCXO
OSCIN
5T
SP2
EN1
EN2
EN3
EN4
EN5
5R5C
B
SP1
VSSVCC
SDA
SCL
WP
VCC
2SK508NV(K52)Q3
SW1
SW2
OUT
VCC2
TDATA/DTRCLK
DI/O
TCLK/DTRDO
MOD
RDF/FD
XIN
DIR
SCLK
DTRLOADN
STD
BUSY
PTTSW
OPTDET
RSSI
QT/DQT_INMIC_MUTE
5M
TXDPCTV
SB
AF_CONT
EXTLIMIN
AMP3O
RX_W/NTX_W/N
RXAFO
OSCIN
5T
5R5C
B
APCSW
TH_DETSP2
SP1
DCSW
AG
ND
IN
TX
IN
TX
INO
LIM
LV
EX
TLI
MIN
MO
D
VD
D
RXAF
RXAFIN
EXPOUT
FILTERO
RXINO
RXIN
AGND
IN2+
IN2-
OUT-B
VCC
XF201L71-0619-0538.85 MHz
MCF
CF201L72-0973-05
OS
CIN
OS
CO
UT
MIX
OU
T
VC
C
IFIN
DE
C
FIL
OU
T
FIL
IN
5R
PTTSW
5M
TXD
PCTV
SB
SP2
AF_CONTOPTDET
PTT/RXDMIC
MICINOPTDET
5MSAE
TXDNC
SPOSPI
3SK318Q205
NF
PHASE
PRE-GND
PW-GND
PoUT
ON:4.92VOFF:0.01V
ON:4.92VOFF:0.01V
4.96V
5.00V
R:7.28VT:6.80V
R:7.56VT:7.26V
R:3.70VT:3.57V
R:5.01V
T:4.99V
R:4.83V
4.72V
4.84V
4.76V
4.95V
4.96V
R:3.46V
R:0.99V
R:4.98V
R:2.48V
R:2.48V
R:0.75V
R:4.8V R:4.92V
R:1.76V
T:3.42V
2.73V
0.72V
3.74V
R:4.97VT:0.59V
4.0V
0.7V
4.83V
4.74V
2.2VR:1.65VT:1.05V
4.6V
R:2.84VT:0.03V
R:0.1VT:1.88V
T:1.11V
T:4.9VT:1.88V R:7.68V
T:7.30V
T:2.7V(H) 1.99V(L)
R:7.52VT:7.31V
R:0.3V(MUTE ON) 7.3V(MUTE OFF)T:0.3V
R:7.3V(MUTE ON) 0.3V(MUTE OFF)T:7.3V
R:0.60VT:4.95V
W:0.011VN:4.98V
BSHIFT ON:4.95VOFF:0V
TK-2202/2206
36
BLOCK DIAGRAM
TXVCO
RXVCO
5CRIPPLEFILTER
DCSW
DCSW
Q4 2SK508NV(K52)D4,D7 1SV325D10 1SV278
Q5DTA143TE
Q7 DTA143TE
Q3 2SK508NV(K52)D5,D9 1SV325
RX
TX
Q8 2SC4617(S)
PLL
IC1 MB15A02
X1L77-1931-05
12.8MHz
38.4MHz
Q1 KTC4082
5R
PLL_DATPLL_CLK
RX_W/N
5R
FM IFSYSTEM
CD201L79-1582-05
450kHz
SW
5R
IC201TA31136FN
RSSI
BUSY
IC301 AQUA
AUDIO
PROCESSOR
AFAMP
MUTESW
DCSW
DCSW
DCSW
SBSB
AFCONT
SB
Q306, Q316 CPH3413 IC302
TA7368F
Q305 DTC144EE Q304 2SA1362(GR)
Q303 DTC144EE
AGC
DET
Q302 2SC4919D303 DAN222D302 RB706F-40
D301 RB706F-40
VOX
MOD
DTMF
DTRLOADNTDATA/DTRCLK
STD
TCLK/DTRDO
DI/O
RDF/FDSCLKDIR
5M
EN1
EN2
EN3
EN4
LPF
QTVCO
LPFQTTCXO
Q202DTA144EE
5R
INT
IC404 BD4845FVE
INT
PROTECT
D402 1SR154-400
SB PROTECT
D401 RB521S-30
RESETRESET
AVR
IC401 XC6204B502MR
5CDCSW
Q405 DTA123JE
AVR
DC5RSW
5R_C
X2 L78-1411-057.3MHz
EEPROM
SW
Q407 2SK1830
IC406 BR24L08F-W
D11 MA2S111
PLL_STB
5C
5C
EN5
IC403 BD4845FVE
5C_C
IC402 XC6204B502MR
Q403 CPH3317
5T
5T_C
DCSW
Q404 CPH3317
RXAF0XIN
5M
TRIPLER
Det.Batt.
BATT
FilterLoop
CH SW
PWR SW
/ VOL
SP
MIC
BATT +
-
X57-687
TK-2202/2206
37
BLOCK DIAGRAM
LPF
BPFBPFRFAMP
1stMIXER
5RPCTV PCTV5R
MCF
XF201L71-0619-05
38.85MHz
AMPIF
5R
D205,D2061SV305
D203,D2041SV305
Q2043SK318
Q2032SC4649(N,P)
BUFFAMP
Q62SC5108(Y)
5C
Q22SC5108(Y)
CF
CF201 L72-0973-05
450kHz
PLL_CLKPLL_DAT
APCSWDCSW TX_SW
QTTCXOQTVCO
1/2OSC5T_C5C_C5R_C
EN1
EN4EN3EN2
QT/DQT INRSSI
VOX
DIRSCLK
DI/O
TCLK/DTRDO
TDATA/DTRCLKDTRLOADN
DTMFTXD
MIC MUTE
AFCONT
INTRESET
PTT
SW1
SW2
EEPDAT
EEPCLK
PF2PF1PTT
BSHIFT
LEDTXLEDRX
BATT
XIN
XOUT
PF2
PF1
PTT
5M
MICROPROCESSOR
IC405 30622MAA-XXXGP
LED
(GREEN)
LED
(RED)
SBSB
SWDC
SWDC
D404 B30-2157-05D403 B30-2156-05
Q401 DTC114EE
LEDTX LEDRX
TH_DET
APCSW
Q1032SK2596
D101,D202HSC277
SW
SW
Q1052SK879(Y)
PCTV
AMP AMP
SW
Q108 2SK1824
SW
5C 5R
IC101TA75W01FU
CURRENT
Q92SC5108(Y)
D103,D104,D105,D106HVC131
DC
AMP
Q107 DTC114EE
AMPANT
5T5T
DCSW
DET
Q109DTA144EE
RFSW
Q1022SC4926YD
SW
Q1062SK2595
RF
5T
APCSW
Q104DTC114EE
T/R
DC
B
RF RF
DC DC
IC2UPB1509GV
DIVIDER
5C
Q2053SK318
5C
Q402 DTC114EE
PCTV
RXD
RX_SW
TX_W/N
PLL_STB
RX_W/N
EN5BUSY
AMPRF
TX/RX:136.00~174.00MHz
ANT
RDF/FD
PLL_ULSTDOPTDET
TK-2202/2206
38
RX
TX
RF
(Cen
ter
Freq
uen
cy)
FM IF
SY
ST
EM
AQ
UA
AQ
UA
IC30
2
500m
WC
330
IC30
1C
329
IC20
1C
219
C22
4X
F201
C24
1L2
11C
266
C15
8L2
24Q
205
IC30
1IC
2C
60
VC
O
PLL
C81
Q9
C87
D10
1
RX
LO
C10
1Q
102
C10
8Q
103
Q10
6C
151
D20
2
MIC
SP
-119
.5d
Bm
-119
.5d
Bm
-120
.0d
Bm
-104
.0d
Bm
-110
.0d
Bm
-104
.0d
Bm
290m
V29
mV
16m
Vrm
s
129m
Vrm
s-3
.0d
Bm
14.6
dB
m31
.8d
Bm
5.0W
4.5d
Bm
IF1
(38.
85M
Hz)
AF
(1kH
z)
AF
(1kH
z)R
F (C
ente
r Fr
equ
ency
)R
F (C
ente
r Fr
equ
ency
)
L224
Q20
3L2
28
IF2
(450
kHz)
LEVEL DIAGRAM
To m
ake
mea
sure
men
ts in
the
AF
sect
ion,
con
nect
the
AC
leve
l met
er. (
AN
T in
put:
-53d
Bm
, 1kH
z FM
,3k
Hz
DE
V (W
IDE
).)In
the
RF
sect
ion,
use
1000
pF c
oupl
ing
capa
cito
r.(T
he d
ispl
ay s
how
s th
e S
SG
inpu
t val
ue re
quire
d to
obta
in 1
2dB
SIN
AD
with
out
Loca
l Lev
el.)
AG
is s
et t
o th
e M
IC In
put
beco
mes
3kH
z D
EV.
at1k
Hz
MO
D.(W
IDE
)To
mak
e m
easu
rem
ents
in th
e A
F se
ctio
n, c
onne
ctth
e A
C le
vel m
eter
.In
the
RF
sect
ion,
use
1000
pF c
oupl
ing
capa
cito
r.
TK-2202/2206
39
KSC-31 (RAPID CHARGER)
Charging current ................. 850mA ±5%Charging time ..................... KNB-29N : Approx.180 minutes
KNB-30A : Approx.120 minutesDimensions (Charger only) .... 86.3W x 46.2H x 100.0D (mm)
3-3/8W x 1-7/8H x 4D (inches)Weight (Charger only) ............ Approx.100g / 0.22 lbs
Specifications
KNB-29N (Ni-MH BATTERY PACK)
KSC-31 / KNB-29N / KNB-30A / KBH-10
External View External View
Schematic Diagram
(4N)Breaker(75ºC)
DISCHARGING TERMINALS
CHARGING TERMINALS
Thermistor
AXIAL LEADEDINDUCTOR
Diode
(2N)
Voltage ................ 7.2V (1.2V x 6)Battery capacity ... 1500mAh
Specifications
KNB-30A (Ni-Cd BATTERY PACK) External View
Schematic Diagram
(4N)Breaker(75ºC)
DISCHARGING TERMINALS
CHARGING TERMINALS
Thermistor
AXIAL LEADEDINDUCTOR
Diode
(2N)
Voltage ................ 7.2V (1.2V x 6)Battery capacity ... 1100mAh
Specifications
KBH-10 (BELT CLIP) External View
TK-2202/2206
GeneralFrequency Range ............................................................. 136~174MHz (TK-2202(K, M) TK-2206(M) )Number of channels ......................................................... Max. 8 (TK-2202) Max. 16 (TK-2206)Number of groups ............................................................ Max. 16Channel Spacing............................................................... 25kHz, 30kHz (Wide) 12.5kHz, 15kHz (Narrow)PLL Channel Stepping ...................................................... 2.5kHz, 5kHz, 6.25kHz, 7.5kHzOperating Voltage ............................................................ 7.5 V DC±20%Battery Life ....................................................................... More than 14 hours at 5 watts (5-5-90 duty cycle with KNB-29N battery)
More than 9 hours at 5 watts (5-5-90 duty cycle with KNB-30A battery)Operating Temperature range .......................................... –30˚C to +60˚C (–22 ˚F to +140 ˚F)Frequency Stability ........................................................... ±2.5ppm (–30˚C to +60˚C)Channel Frequency Spread .............................................. 38MHzDimensions and Weight Radio Only ...................................................................... 54 (2-1/8) W x 122 (4-13/16) H x 21.1 (13/16) D mm (inches)
160g (0.35lbs) With KNB-29N (1500mAh battery) ................................. 54 (2-1/8) W x 122 (4-13/16) H x 33 (1-5/16) D mm (inches)
360g (0.79lbs) With KNB-30A (1100mAh battery) ................................. 54 (2-1/8) W x 122 (4-13/16) H x 33 (1-5/16) D mm (inches) (Dimensions not including protrusions) 340g (0.75lbs)