® P OLLUTION E QUIPMENT Water Wastewater Air Hazardous Waste News • Oil Skimmers • Water/Wastewater Treatment • Sensors • Gas Detection - Portable • Pumps • Air Pollution Control in the Natural Gas Industry www.pollutionequipment.com • 800/245-3182 PROVIDING ENVIRONMENTAL SOLUTIONS SINCE 1968 Dissolved Air Flotation Unit The Dissolved Air Flotation (DAF) system is versatile and effective for wastewater processing. As a sepa- ration device it generally will effect a high level of recovered solids under a wide range of flow condi- tions. Oil/grease, suspended solids and non-soluble BOD removal rates of greater than 95% are normal. Some sites report up to 99.9% removal. The DAF sys- tem is suitable for a wide range of industrial treatment needs. — Ellis Corporation, 630/250-9222, www.elliscorp.com Circle 2 on Card Clamp-On Flowmeter for Pipes Flow Pulse is a non-invasive, clamp-on flowmeter for use on all common pipe types, including corrugated or corroded pipes. It produces a wide ultrasonic beam and uses a spread spectrum analysis tech- nique. The Refracted Spread Spectrum Analysis plat- form analyzes and integrates received signals over a wide frequency range then slices them for real time analysis and flow rate calculation. — Pulsar Process Measurement Inc., 850/279-4882, www.pulsar-pm.com Circle 1 on Card OCTOBER 2013 All-Plastic Control Valve This 2" flanged plastic control valve is designed to handle corrosive fluids. The Model 2060 features a body of either PVDF or polypropylene and an actua- tor/yoke of glass-filled polypropylene, making it suitable for harsh fluids and/or corrosive environments. The valve accommodates 300 psi maximum oper- ating pressure at 73°F and is available with trim sizes up to Cv=38. — Collins Instrument Company, 979/849-8266, www.collinsinst.com Circle 4 on Card Personal Air Sampling Pump GilAir Plus is the compact, innovative, and highly capa- ble personal air sampling pump backed by the depend- ability of the Gilian name. GilAir Plus has a wide dynamic flow range that achieves 1-5000 cc/min in constant flow and constant pressure without using external flow adapters. — Sensidyne LP, 727/530-3602, www.sensidyne.com/gilairplus Circle 3 on Card Pumps for Corrosive Fluids The company’s pumps and systems solve fluid contain- ment, recirculating, dosing, collecting and transfer prob- lems encountered with the safe handling of corrosive, abrasive and ultrapure fluids. The products feature wet- end components construct- ed of thermoplastics, which are impervious to acids, caus- tics, salts, solvents, chlorides, halogens, and other aggres- sive, abrasive chemicals. Engineered to individual require- ments, the pumps are available in a variety of configura- tions including: ANSI, mag-drive, close-coupled, self-prim- ing, vertical to 20 feet and run-dry cantilevered. — Vanton Pump & Equipment Corp., 908/688-4216, www.vanton.com Circle 5 on Card ISSUE FEATURES
36
Embed
Pollution Equipment News - October 2013 · 6 Gas Detection - Portable 8 Chemicals for Wastewater 9 Water/Wastewater Treatment 11 Oil Skimmers 12 Air Cleaning Equipment 13 Air Pollution
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
®POLLUTIONEQUIPMENTWater Wastewater Air Hazardous Waste
New
s
• Oil Skimmers• Water/Wastewater Treatment• Sensors• Gas Detection - Portable• Pumps• Air Pollution Control in the
Natural Gas Industry
www.pollutionequipment.com • 800/245-3182
PROVIDING ENVIRONMENTAL SOLUTIONS SINCE 1968
Dissolved Air Flotation UnitThe Dissolved Air Flotation (DAF) system is versatileand effective for wastewater processing. As a sepa-ration device it generally will effect a high level ofrecovered solids under a wide range of flow condi-tions. Oil/grease, suspended solids and non-solubleBOD removal rates of greater than 95% are normal.Some sites report up to 99.9% removal. The DAF sys-tem is suitable for a wide range of industrial treatment needs. — Ellis Corporation,630/250-9222, www.elliscorp.com Circle 2 on Card
Clamp-On Flowmeter for PipesFlow Pulse is a non-invasive, clamp-on flowmeter foruse on all common pipe types, including corrugatedor corroded pipes. It produces a wide ultrasonicbeam and uses a spread spectrum analysis tech-nique. The Refracted Spread Spectrum Analysis plat-form analyzes and integrates received signals over awide frequency range then slices them for real timeanalysis and flow rate calculation. — Pulsar Process Measurement Inc., 850/279-4882, www.pulsar-pm.com Circle 1 on Card
OCTOBER 2013
All-Plastic Control ValveThis 2" flanged plastic control valve isdesigned to handle corrosive fluids. TheModel 2060 features a body of eitherPVDF or polypropylene and an actua-tor/yoke of glass-filled polypropylene,making it suitable for harsh fluids and/orcorrosive environments. The valveaccommodates 300 psi maximum oper-ating pressure at 73°F and is availablewith trim sizes up to Cv=38. — Collins Instrument Company,979/849-8266, www.collinsinst.com Circle 4 on Card
Personal Air Sampling PumpGilAir Plus is the compact, innovative, and highly capa-ble personal air sampling pump backed by the depend-ability of the Gilian name. GilAir Plus has a wide dynamicflow range that achieves 1-5000 cc/min in constant flowand constant pressure without using external flowadapters. — Sensidyne LP, 727/530-3602, www.sensidyne.com/gilairplus
Circle 3 on Card
Pumps for Corrosive FluidsThe company’s pumps andsystems solve fluid contain-ment, recirculating, dosing,collecting and transfer prob-lems encountered with thesafe handling of corrosive,abrasive and ultrapure fluids.The products feature wet-end components construct-ed of thermoplastics, which are impervious to acids, caus-tics, salts, solvents, chlorides, halogens, and other aggres-sive, abrasive chemicals. Engineered to individual require-ments, the pumps are available in a variety of configura-tions including: ANSI, mag-drive, close-coupled, self-prim-ing, vertical to 20 feet and run-dry cantilevered. — Vanton Pump & Equipment Corp., 908/688-4216,www.vanton.com Circle 5 on Card
ISSUE FEATURES
PEN October 2013_PEN New Size 2012 10/29/13 10:47 AM Page 1
• Titanium based PVD Coating• Stores up to 120,000 data points• Hastelloy pressure sensor• Improved temperature compensation and response time
The Levelogger Edge is a self contained water level datalogger, using infrared data transfer powered by a 10 year lithium battery, offering the flexibility of installing by use of a Direct Read Cable, wireline or Kevlar cord. The Levelogger Edge has a memory capacity of 40,000 temperature and water level data points, or up to 120,000 using the compression algorithm in linear sampling mode.
Levelogger Software Version 4.0, written to support the Levelogger Edge, Levelogger Junior Edge, LTC Levelogger Junior, Rainlogger, Leveloader and is backwards compatible to support the Levelogger Gold series. Version 4.0 offers many features, including the ability to barometrically compensate multiple Levelogger data files simultaneously.
Reduce Your Monitoring CostsThe Levelogger Junior Edge and LTC Levelogger Junior provide convenient low cost alternatives for datalogging water level and temperature. The Levelogger Junior Edge features 0.1% FS accuracy, a 5-year lithium battery and increased memory for 40,000 data points. The LTC Levelogger Junior has the added advantage of conductivity measurement. Featuring a 5-year battery, memory for 16,000 sets of data points, and 2% accuracy.
If you’re pumping corrosives, handling aggressive or ultrapure fluids,need to eliminate product contamination, or ensure compliance withenvironmental regulations, Vanton’s line of Thermoplastic Pumpsprovides solutions to answer virtually every concern.
Most questions are addressed in our Technical Library in scores of articles on a wide range of pumping issues. Just scan the QR Code below and we’ll transport you directly to our archives. Of course we’re always available
to discuss your specific situation.
Just call us at 908.688.4216…and think of it as another Vanton AdVantage.
vanton.com
The Vanton Pump Technical Library
Another Vanton AdVantage
Sump-Gard®
Vertical CentrifugalPumps
Chem-Gard®
Horizontal CentrifugalPumps
Flex-I-Liner®
Rotary PeristalticPumps
Pump/TankNon-metallic
Systems
PUMP & EQUIPMENT CORPORATION
Circle 7 on Card
PEN October 2013_PEN New Size 2012 10/29/13 3:55 PM Page 3
23 Solidification Products International: The Leader in Passive Oil Removal From Stormwater
24 Applications for Peristaltic Pumps in Water and Wastewater
26 Collaboration Results in a Breakthrough Design of Desorption Tube for Soil Vapor Intrusion
Analysis
27 Air Pollution Still Harming Health Across Europe
28 Natural Gas Industry Facing Midstream Production Compliance Issues
29 Mine Water Treatment Plant uses Zero Liquid Waste Process to Improve Water Quality of
Monongahela River Watershed
30 APPrO 2013 - 25 Years in the Power Sector
Inquire Online at www.POLLUTIONEQUIPMENT.com4
ARTICLES
TABLE OF CONTENTS
October 2013 • Volume 46 • Number 5
Pollution Equipment News makes every reasonable effort to verify information published. However, Pollution Equipment News and Rimbach Publishing Inc., assume no responsibility for validity of man-
ufacturer claims or statements in the news items, articles, selection charts and advertisements.
Pollution Equipment News (USPS 349-750, ISSN 0032-3659) is published print and digitally 6 times per year, February, April, June, August, October, December by Rimbach Publishing Inc.,8650 Babcock Blvd., Pittsburgh, PA 15237-5010
There is a shipping/handling fee of $75.00 per year for printed subscriptions outside of the UnitedStates and Canada. Periodicals postage paid at Pittsburgh, PA and at
additional offices.
POSTMASTER: send change of address to Pollution Equipment News, 8650 Babcock Blvd., Pittsburgh,PA 15237-5010.
Canada Post Publication Mail Sales Agreement No. 40065725Return Undeliverable Canadian Addresses to:
2744 Edna St Windsor ON N8Y 1V2
Advertising Sales Representatives
18 Groundwater Monitoring & Sampling
16 Newly Released Products
17 Product Showcase
22 Business News
34 Trade Shows
34 Advertisers Index
35 Searchlite Section
SELECTION CHART
PRODUCT EMPHASIS
SECTIONS
6 Gas Detection - Portable
8 Chemicals for Wastewater
9 Water/Wastewater Treatment
11 Oil Skimmers
12 Air Cleaning Equipment
13 Air Pollution Control for Natural
Gas/Shale Drilling Sites
15 Pumps
21 Sensors
23 Stormwater Management
Circle 9 on Card
Circle 8 on Card
Correction to “Real-Time Computer Training for Wastewater Treatment Plant OperatorExam” in August 2013 issue: Email address should be: [email protected]
PEN October 2013_PEN New Size 2012 10/29/13 3:56 PM Page 4
Gas Detection - PortableInquire Online at www.POLLUTIONEQUIPMENT.com6
Single Gas MonitorThe maintenance-free PS1 Series single gas monitor is light-weight and easy to use, and offers sensor options for monitor-ing hydrogen sulphide, oxygen, carbon monoxide, or sulphurdioxide. The self-monitoring device features on/off capabilityand field adjustable alarm settings. The instrument clips easilyonto a collar or vest. — Gas Measurement Instruments (GMI),+44 141 812 3211, www.gmiuk.com Circle 12 on Card
Detector for Confined SpacesThe Gas-Pro portable gas detector is a personal-use, multi-gas detector with features specific to confined space entrywork. They include its small size and a top-mount display thatcan be read at a glance without having to touch thedetector. The Gas-Pro’s alarm is more than 95 dB, and theunit has IP65 and IP67 ingress protection. An automated pre-entry check function walks a user through a confined space entry. — Crowcon Detection Instruments, 800/527-6926, www.crowcon.com
Circle 13 on Card
Portable Gas DetectorThe portable toxic gas or combustible gasesdetector with audio/visual alarms andmeter display is ideal for confined spacemonitoring. The built-in charger and Ni Cadbatteries allow the unit 10 hours of continu-ous operation. The hand held probe withthe sensor (no mechanical pump) and 5 feet of wire provideslocal area gas measuring. The detector uses a UL approvedsolid state sensor, and provides analog or digital readings forppm or % LEL. — RWC Testing & Lab Supplies, 915/852-3375, www.rwctesting.com Circle 15 on Card
Open Path Gas MonitorSpectra-1 is a portable lightweight openpath TDLAS gas monitor. The enclosure forSpectra-1 resists extreme shock and vibra-tion. RS232 serial communications are usedfor continuous data transfer. Spectra-1 hasinternal data logging with data download-ing via USB flash drive. Detectable gases include: HF, CH4,NH3, CO, CO2, HCN, HCI, C2H2, C2H4, C2H6, C3H8, CH2CHCI,H2O and H2S. — PKL Technologies Inc., 780/486-9564, www.pkltechnologies.com Circle 16 on Card
Detector Tube SystemThe complete line of Gastecpumps and detector tubesmeasures gases and vapors inover 600 applications. Gastec’spump with its one-stroke pistonaction provides reliable opera-tion with no partial samples.Gastec Detector Tubes areintrinsically safe and always ready to use. The Gastec 18thEdition Tube Guide is available for download on the compa-ny’s website. — Nextteq LLC, 877/312-2333,www.nextteq.com Circle 17 on Card
Gas MonitorThe Tango™ TX1 single gas monitor features a three-year run-time and DualSense™ Technology that includes two of thesame type sensor for the detection of a single gas. The Tangodetects carbon monoxide, hydrogen sulfide, sulfur dioxideand nitrogen dioxide. It is powered by one replaceable 2/3AA lithium battery, and is compatible with the company’s software-based service,iNet®. — Industrial Scientific Corp., 800/338-3287, www.indsci.com Circle 14 on Card
Portable Combustible Leak DetectorThe Model 7899 Gas Sniffer is equippedwith a tip to pin-point small leaks of anycombustible gases and hydrocarbons frompiping and/or appliances. The easy-to-use7899 has a 11" fully flexible probe for hard-to-reach places, auto zero-drift adjustment,and audio alarm. The large visual LCDincludes a bar graph display. The unit’srange is 0 to 10,000 ppm. — E Instruments International,215/750-1212, www.e-Inst.com
Circle 18 on Card
Personal Diffusive SamplersPersonal diffusive samplers that offer thebroadest range of OSHA-regulated chemi-cals including organic vapors, aldehydes,amines, anesthetics, and inorganic gases areavailable. Optional AIHA-accredited labservice is also available. These badges meet OSHA require-ments and are backed by 30 years of experience. Receive10% off all internet orders. — Assay Technology, 800/833-1258, www.assaytech.com
Circle 19 on Card
Circle 11 on Card
PEN October 2013_PEN New Size 2012 10/29/13 3:58 PM Page 6
Portable Leak DetectorThe C16 PortaSens II portable leak detectorchecks for gas leaks in storage areas,around process equipment and piping, andin confined spaces prior to entry. An internalsample pump and a flexible sampling wandallow pinpoint location of the leak. The C16can measure over 30 different gases by inserting the appropri-ate sensor into the detector. — Analytical Technology Inc.,800/959-0299, www.analyticaltechnology.com
Circle 20 on Card
Portable VOC MonitorThe TOX-BOX VOC Gas Monitor provides fixedsystem features packed in a rugged, weather-proof, portable analyzer. Hundreds of differenttoxic gases can be detected utilizing its PIDphotoionization sensor technology. The moni-tor features a rechargeable 12 DC sealedlead-acid battery or continuous AC adapter operation, an on-board pump that continuously draws gas samples across sen-sors, and alarm relays which are fully programmable. — Mil-Ram Technology Inc., 510/656-2001, www.mil-ram.com
Circle 21 on Card
Multi Gas DetectorThe Multi Gas Clip portable multi gas detectorfor confined space entry applications will runfor 2 months without having to recharge thebattery and requires calibration in 6 monthintervals. It utilizes low-power infrared sensortechnology for the detection of combustiblegases and uses electrochemical sensing tech-nology for H2S, CO and O2. One-button operation makes it easyto use and polymer coated housing can withstand normal fieldapplication abuse. — Gas Clip Technologies Inc., 972/775-7577,www.gascliptech.com Circle 22 on Card
Colorimetric Gas Detector TubesThe company’s Gas Detector Tube System fea-tures a detector tube pump with an antibacter-ial grip. Detector tubes are easy to use andprovide a low-cost method of routine or spot-sampling for gases and vapors. The companyoffers detector tubes for hundreds of gases forapplications where sampling is for a known tar-get gas. When the target gas or substance isunknown, their specialty HazMat kits provide quick identificationand measurement. — Sensidyne LP, 727/530-3602, www.sensidyne.com Circle 24 on Card
Portable Gas DetectionIQ Management System combines best-in-class portable gas monitors, docks and man-agement software into one solution — so youalways know the gas status in your facility.Want to track calibration records? Get statson all alarms? Easily update fleet settings?Prevent downtime? This system puts total visibility and control atyour fingertips — so you can lower costs, improve productivityand drive a culture of safety. — Honeywell Analytics, 888/749-8878, www.yoursafetyprogram.com Circle 23 on Card
Vapor Mercury Analyzer The Jerome® J505 Mercury Analyzer is a portable fluores-cence spectroscopy analyzer, which allows the detectioncell to be simpler, smaller, lighter weight and more durable.The optical cell requires less flow to purge the system, allow-ing the J505 to run at a lower flow rate, minimizing sampledilution. The Jerome® J505 features flexible data handling, achoice of two independently adjustable high limit alarms, a programmableauto sampling mode, and a choice of 3 units of measurement (nanograms,micrograms, milligrams). — Arizona Instrument LLC, 800/528-7411, www.azic.com
Circle 25 on Card
Gas Detection - Portable
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 7
Chemicals for Water/WastewaterInquire Online at www.POLLUTIONEQUIPMENT.com8
Liquid Polymer SystemThe dynaBLEND™ Liquid Polymer Dilution/Feed Systemeases the task of blending liquid polymers for waste-water processes because it has been designed toeffectively activate all types of liquid polymers. ThedynaBLEND system has a non-mechanical mixingchamber. The system also features an injection checkvalve designed with easy disassembly and inspection in mind. — Fluid Dynamics, 215/699-8700, www.fluiddynamics1.com
Circle 32 on Card
Configurable Dosing Tank StationsEquipped with a polyethylene tank and chemically resistantaccessories, this configurable dosing tank station (DTS) isdesigned for storing and dosing a wide variety of liquid chemi-cals such as biocides, inhibitors, alkalis, acids, coagulants,hypochlorites, disinfectants and neutralizing agents. The easy-to-install DTS features a wide range of chemical compatibility and fits a number ofapplication fields and dosing tasks. — Grundfos Pumps Corp., 913/302-3702www.grundfos.us Circle 33 on Card
Water Treatment ProgramsThe company offers municipal drinking water treatment pro-grams, corrosion and sterilization programs, cleaners, commoditychemicals, polymer applications, and boiler and cooling towerapplications. Their Aquadene™ products are used to reduce ironand manganese and for maintaining lead and copper levelsbelow national requirements. Also provided are products for improving water clari-ty, and for odor control. — Pristine Water Solutions Inc., 800/562-1537,www.pristinewatersolutions.com Circle 34 on Card
Single Layer PVDF DiaphragmThe Single Layer Injection Molded PVDF Diaphragm has beenintroduced for the Chem-Pro® Series C2 and C3 Metering Pumps.With zero breakdown or delamination, field maintenance anddowntime due to failure is reduced. The pump head consists ofonly one material, PVDF, reducing chemical compatibility issues of the wettedparts. The design is available in three sizes. New PVDF Diaphragms retro-fit onto cur-rent ProSeries® Chem-Pro® pumps, making this a simple, in-field upgrade. — Blue-White Industries, 714/893-8529, www.blue-white.com Circle 35 on Card
Water OptimizerRydall Wo is a biocatalyst that contains a mixture ofnutrients, vitamins and trace elements that reducehydrogen sulfide, chemical oxygen demand, biochem-ical oxygen demand, fats, oil, and grease, total dis-solved solids and total suspended solids. With no activebacteria or enzymes, this formula stimulates existing bacteria, enhanc-ing the natural biological process. Rydall Wo is non-toxic to humans,animals, fish and plants. There are no fumes of irritating vapors, and it isnon-corrosive to metals, concrete and plastics. — Apex Engineering Products Corporation, 630/820-8888, www.apexengineeringproducts.com Circle 30 on Card
TOXIC GAS SHUTOFF
www.halogenvalve.com
Emergency Valve Actuator Replaces Gas Scrubber • Gas Detector or Manual Activation
Fire Code Approved for Toxic Gases • Fail-Safe Battery Operated System(877)-476-4222
Circle 29 on Card
Hypochlorite Injection SystemThe Chloritrol™ valveless metering system providesaccurate, maintenance-free injection of sodiumand calcium hypochlorite for purification ofmunicipal drinking water. With its duplex pumpdesign, the first pump head is high pressure andinjects the sodium hypochlorite directly into thewater main. The second pump head functions toremove out-gas bubbles from the inlet side of the high-pressure pumphead. — Fluid Metering Inc., 800/223-3388, www.fmipump.com
Circle 31 on Card
Chemical Feed StationsThe Chemical Feed Station family with overflowbasins includes the 175, 200 and 250 galloncapacity feed stations. The compact feed sta-tions store small amounts of liquids and otherchemicals. Constructed from high density crosslink of corrosion-resistantFDA compliant linear polyethylene, they are lightweight, strong and easyto handle. — Assmann Corporation of America, 888/357-3181, www.assmann-usa.com Circle 37 on Card
Chlorine Residual AnalyzerThe REGAL Model CRA 5000 Chlorine ResidualAnalyzer continuously measures the level(s) ofFree and/or Total chlorine in the disinfectionprocess of water and wastewater. The CRA 5000may be used exclusively to monitor chlorine resid-ual levels or may be integrated with the REGALModel 7009/7010 SMARTVALVE™ for Compound Loop (Feedback) chlori-nation and/or Feed Forward dechlorination. — ChlorinatorsIncorporated, 772/288-4854, www.regalchlorinators.com
Circle 36 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 8
Collins plastic control valves arehighly responsive control valvesdesigned for use with corrosivemedia and/or corrosive atmos-pheres.
Collins valves feature all-plasticconstruction with bodies in PVDF,PP, PVC and Halar in various bodystyles from 1/2" - 2" with Globe,Angle or Corner configurations andmany trim sizes and materials.Valves may be furnished withoutpositioner for ON-OFF applications.
Call for more information on ourplastic control valves.
Flow Pulse Flow Monitor
Reliably monitor flowrates of liquids and slurries. Non invasive. Patent pending DSP technology ensures reliability.
PC configuration and calibration or remote set up and display option
Easy set up of parameters 4-20mA output/Modbus and relay alarm
Small-Diameter Well DeveloperThe QWater Well Developer utilizes the surge blockmethod and ball valve to develop small-diameter moni-toring and production water wells. The Well Developermaximizes the well yield and lowers water turbidity. TheQwater Well Developer will effectively develop a well andpurge clays and silt all in one step. — QWater WellDeveloper, 850/727-4427, www.welldeveloper.com Circle 38 on Card
Wastewater Consulting ServicesConsulting services are offered to WastewaterTreatment Facilities for decreasing chemical require-ments and reducing water influent and effluent. TheWastewater Wizard audits, analyzes and recom-mends operational efficiencies and also offers train-ing for Wastewater Treatment Plant Operators. — Wastewater Dan, 866/815-7819, www.conserve-on-water.com Circle 39 on Card
Emergency Gas ShutoffThis Terminator emergency shutoff system sequentially clos-es 150 lb cylinder valves containing toxic gas in less thanfive seconds when activated from remote sensors andswitches. The operator would then be required to correctthe condition, check the facility, and manually reset thevalve before restarting the gas system. The Gemini controller has a self-contained battery system that guarantees the operation of the motorizedclosing mechanism even during a power failure. — Halogen Valve Systems Inc., 877/476-4222, www.halogenvalve.com
Circle 40 on Card
9
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 9
Water/Wastewater TreatmentInquire Online at www.POLLUTIONEQUIPMENT.com10
Floating BafflesDirector™ I Floating Baffles produce hydraulic flowpatterns that increase the effective treatment area toover 95% of the lagoon. The extending treatment timereduces BOD and TSS, improves aeration and allowscontaminants and solids to settle. The floating baffle isdesigned to improve flow diversion, increase retentiontime and provide improved bottom anchoring and prevent short-circuit-ing. — Environetics Inc., 815/838-8331, www.environeticsinc.com
Circle 44 on Card
Solenoid ValvesType “A” and “AR” Bronze Solenoid Valves, for use inwater/wastewater and fuel oil applications, are avail-able for pipe sizes from 1/2" to 3". The valves featurecast bronze, globe pattern valve bodies with NPTends, and packless construction with continuous dutycoils for all voltages. The valves require no differentialpressure to open and are easily serviced while in the pipeline. — Magnatrol Valve Corporation, 973/427-4341, www.magnatrol.com
Circle 45 on Card
Activated CarbonActivated Carbon canisters, designed to treat variousaqueous applications, each contain 200 lbs of highquality liquid phase carbon, with an iodine numbergreater than 1000, for maximum carbon adsorptioncapacity. Features include a no-leak polyethyleneliner, a corrosion-resistant under-drain for treatedwater collection, and large internal piping that allows for low pressuredrop. — Carbtrol Corporation, 800/242-1150, www.carbtrol.com
Circle 46 on Card
Nitrogen Removal SystemThe DEMON® system runs a two-step, single stageprocess that leverages two types of bacteria in orderto first oxidize the ammonia in wastewater to nitriteand then convert a combination of this nitrite andremaining ammonia into harmless nitrogen gas. Itoffers benefits over traditional nitrification-denitrification systems, includ-ing: a 90% reduction in sludge handling volume, a 100% reduction inchemical demand, and a 60% lower energy requirement. — World Water Works Inc., 800/607-7873, www.worldwaterworks.com
Circle 47 on Card
Website on Grit ManagementThe company has launched a website to promote thephilosophy of Advanced Grit Management™. Thewebsite will provide a clearinghouse for science-based information on grit removal design which canbe used by engineers, operators and owners to selectthe best solution for their project’s needs — Hydro International, +44 1275 878371, www.hydro-int.com Circle 48 on Card
Chemical-Free Water TreatmentOzonix® technology has been used to treat over 3 bil-lion gallons of water in the U.S. hydraulic fracturingindustry since 2008. The broad-spectrum advancedoxidation process can also be licenced for use inindustries where chemicals (e.g. chlorine) are currentlybeing used to disinfect water. Ozonix® can be used to replace chemi-cals in industries and applications that include but are not limited toagriculture, energy, environmental, food and beverage, industrial, min-ing, marine, and municipal wastewater treatment. — Ecosphere Technologies Inc., 772/287-4846,www.ecospheretech.com Circle 52 on Card
Thickening CentrifugesTHK Series Thickening Centrifuges use Hydraulic AssistTechnology to discharge the thickened sludge moreefficiently. The centrifugal thickening process featuresa small footprint and under normal conditions (150SVI) requires zero polymer. The contained and airtightsystem provides minimum operator exposure toprocess liquids and vapors and eliminates odors and aerosols. — Centrisys, 877/339-5496, www.centrisys.us Circle 43 on Card
Process AnalyzersThe HANDYChem process analyzer can be used witheither automated dilution or very dirty sample streams.All NEXTChem analyzers are designed to operate FIL-TER-FREE. This sample system makes it possible to col-lect samples containing particles ≤6 mm. Two types ofmeasurement methods are used for almost allNEXTChem analyzers: titration and (ion selective) standard addition. —ASA Analytics, 262/717-9500, www.asaanalytics.com Circle 54 on Card
Multichannel Transmitter Controller In reverse osmosis systems, the MultiCELL Type 8619 multi-channel con-troller can be used for monitoring functions as aflow indicator, to measure the ORP value or per-centage retention value. It can also be used forcontrol tasks, such as regulation of the pH valueand the dosing of chemicals and ratio control.The modular controller is adapted at the factoryto the particular application and customer specifi-cations. — Burkert Fluid Control Systems, 949/223-3100, www.burkert-usa.com Circle 51on Card
Wastewater Treatment MaterialNa3T is a precipitating chemical of monovalent andbivalent heavy metals in waste water. It is suitable formercury, copper, cadmium, silver, lead, nickel, andtin. Na3T is less toxic and safer to use than compara-ble heavy metal remediation agents. Na3T is used inthe treatment of effluents and wastewater comingfrom power stations and hazardous waste treatment facilities, as well asin the metal finishing, chemical and chloralkali industries. — Kingsfield Inc., 201/767-0414, www.kingsfieldinc.comCircle 53 on Card
Orthophosphate AnalyzerThe YSI P 700 IQ Orthophosphate Analyzer can beused as a stand-alone analyzer or in conjunction withother sensors in a IQ SensorNet 2020 XT continuousmonitoring and control system. Because of its two measuring ranges,the P 700 can be used throughout a wastewater treatment plant. The P700 analyzer offers a compact design and features low reagent con-sumption. Exchange solutions on average every 4-8 months. — XylemAnalytics, 937/767-7241, www.xylemanalytics.com Circle 50 on Card
Well ManholeA 4” Monitor Well Manhole with small footprint accom-modates up to a 2 1/2” well. Polymer construction isH-20 road rated and all -weather. The Manhole fea-tures an 8” length skirt, Buna o-ring seal, stainless fas-teners, lifting groove and monitor well ID on the cover.The compact design and color keep installations professional and dis-creet. — Koby Environmental Inc., 716/741-2780, www.torquerplugs.com Circle 49 on Card
Continued on page 14
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 10
Removing oil early in the wastewater treatment process is the first step to efficiency and cost savings all the way down the line.
By skimming early, there’s little or no oil left to filter, which extends the life of your filters,
improves your treatment process, reduces maintenance costs, and saves you money.
FREE Whitepaper Download!
Scan QR Code with your smart phone to access the whitepaper.
1-800-200-4603
oilskim.com/pen
1-800-200-4603
oilskim.com/pen
White PaperRemoving oil early in the wastewater treatment process is the firststep to efficiency and cost savings. By skimming early, there is littleor no oil left to filter, which extends the life of your filters, improvesyour treatment process, and reduces maintenance costs. For moreinformation, download a free white paper, Challenges ofRemoving Surface (Free-Floating) Oil, from the website below. — Oil Skimmers Inc., 440/237-4600, www.oilskim.com/pen Circle 56 on Card
Oil SeparationThe V3 Vertical System and the CrossFlow System skim and sepa-rate floating oil and solids from industrial fluids. They remove freefloating and mechanically dispersed tramp oils from wash tanks,individual machine coolant sumps and many other manufacturingprocess fluids. Based on gravity flow and coalescence, these sys-tems can reduce tramp oils to less than 1% in a single pass. The“non-clogging” design allows for the separation of oils and settling of solids in onestep. — SmartSkim, 800/663-2167, www.smartskim.com Circle 58 on Card
Oil/Water SeparatorOS Series Oil Water Separators, available in steel and fiberglass, aredesigned to produce an effluent concentration of 10 mg/l or lessof oil droplets 30 micron and larger of non-emulsified, sheen free,free and dispersed oils. By virtue of the FLOPAK coalescing media,readily settable solids can be removed. Options include influentfeed, effluent pump out and oil pump-out packages, effluent/oillevel switches and more. — EPG Companies Inc., 800/443-7426, www.epgco.com
Circle 59 on Card
Adjustable Rate Belt Oil SkimmerThe MAXI-Skimmer™ Model SSV/5 is an adjustable collection rateskimmer. A knob controls the rpm of the upper drive pulley, reducingor increasing the speed of the 4” wide belt and the oil quantity pick-up. Oil is discharged through a 2” outlet below the 115V motor.Collection rates can vary from 1 to 20 gallons per hour. Belts areavailable in 1 foot increments from 1 to 25 feet down. MAXI-Skimmers™ are made of all stainless steel metal parts and various polymers. — Wayne Products Inc., 800/255-5665, www.wayneproducts.com
Circle 55 on Card
Stainless Steel SkimmerThe Alpha Stainless Steel Skimmer was designed to remove floatingoil from the surface of water bodies. Alpha has also been effec-tively utilized to remove grease, sewage scum and chemicalsequally well. — Megator Corporation, 412/963-9200, www.megator.com Circle 57 on Card
SkimmersGenie® skimmers are complete systems for removing floatingLNAPL layers from 2" and 4" diameter wells. The SPG and SOSAutoGenie skimmers are air-operated selective LNAPL removal sys-tems with a high suction pump and a floating inlet designed to fol-low the LNAPL layer as the groundwater level fluctuates. The SPGversion uses a specific gravity float, and the SOS version uses ahydrophobic screen to exclude water. — QED Environmental Systems Inc., 800/624-2026, www.qedenv.com Circle 60 on Card Circle 62 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 11
Air Cleaning Equipment Inquire Online at www.POLLUTIONEQUIPMENT.com12
Air CleanerThe Martin® Air Cleaner is an automatic, self-cleaning filter designed to remove dust fromthe air in conveyor loading and transfer points,silo vents, bucket elevators and screens. The filter elements areapproximately one-eighth the size of filter envelopes in the pre-ceding system, allowing a significant reduction in the air clean-er’s footprint. The design features mesh-like material filters thathelp to reduce power consumption. — Martin Engineering, 800/544-2947, www.martin-eng.com Circle 69 on Card
Clamp for Pulse Jet Filter BlowpipesThe MikroFix Clamp® is a “click-on” clampwhich connects the blowpipes to housingflanges. During dismantling, the clamps onlyneed to be pulled up and off, eliminating theuse of tools, eliminating connecting parts suchas swivel nuts and screws, and simplifyingaccess to filter bags and cages. — MikroPulLCC, 800/892-7278, www.mikropul.com Circle 71 on Card
Dust & Fume CollectorThe DFC Series dust collector product line, withits small footprint and direct drive fan (800 to1500 cfm) is suitable for the collection of weld-ing smoke and fumes, grinding dust, plasma smoke and othernuisance dusts. Pneumatic push button cleaning (requires com-pressed air) and a sealed dust tray make filter cleaning a snap.The system can be fitted with final carbon filter for removal ofgases or a HEPA 99.97% for control of hexavalent chromium.— Industrial Maid, 877/624-3247, www.industrial-maid.com
Circle 70 on Card
Thermal OxidizerOxidair™ Thermal Oxidizers are designed for off-gas treat-ment, soil remediation, and industrial applications. These unitsare engineered to fit your specific needs and are readilyavailable in two standard configurations with several modelsto choose from. Options include heat exchangers, catalyticoxidizer modules, vapor extraction blowers, and thermallyenhanced SVE systems with hot air-spargers. Skid or trailer mounted units areavailable. — EPG Companies Inc., 800/443-7426, www.epgco.com
Circle 64 on Card
Electrostatic PrecipitatorsThe company provides advanced gas cleaning and air pol-lution control for a broad spectrum of industrial processesand emissions requirements. Their Wet and Dry ElectrostaticPrecipitators are designed for effectiveness, efficiency, easeof operation, and maintenance. These multi-stage tubulardesign systems are able to control emissions at the submicronlevel, including gas mists, submicron particulates, and condensed organicsfrom industrial processing. — Beltran Technologies Inc., 718/338-3311,www.beltrantechnologies.com Circle 66 on Card
Transportable Equipmentfor VOC ControlThe company’s VAPOR-PAC® units are trans-portable adsorbers that contain granular acti-vated carbon for removal of VOCs from high volume air emis-sions. Suitable for removing low concentrations of VOCs, VAPOR-PAC units are offered in two sizes. The VAPOR-PAC 5 can treat upto 5000 cfm and the VAPOR-PAC 10 can treat up to 10,000 cfm. — Calgon Carbon Corporation, 412/787-6700, Circle 72 on Card
Air Emission Control SystemThis system, designed to treat an exhauststream comprised of VOCs, ammonia, andinorganic particulates, is capable of meetinghigh VOC removal with minimal formation of nitrogen oxides(NOx). The company also offers regenerative thermal oxidizers,catalytic oxidizers, thermal oxidizers, energy conservation sys-tems, heat exchangers, CO and NOx abatement, ammoniaabatement, and catalyst products. — Catalytic ProductsInternational Inc., 847/438-0334, www.cpilink.com
Circle 68 on Card
“Green” Tower PackingQ-PAC® is a plastic tower packing withadvanced design which has enabled scrub-ber manufacturers to build more effectivesystems and make them “greener”. As anexample, Q-PAC has been used in many new seawater FGDscrubbers, allowing for industrial facilities at coastal sites to beachieved in a greener and more economical fashion. Thisprocess uses the natural alkalinity of seawater to absorb andneutralize sulfur dioxide in exhaust gases. — Lantec ProductsInc., 617/302-3297, www.lantecp.com Circle 67 on Card
Personal Air Sampling PumpGilAir Plus is the compact, innovative, and highly capablepersonal air sampling pump backed by the dependabilityof the Gilian name. GilAir Plus has a wide dynamic flowrange that achieves 1-5000 cc/min in constant flow andconstant pressure without using external flow adapters. — Sensidyne LP, 727/530-3602, www.sensidyne.com/gilairplus Circl e 65 on Card
302-3269
Circle 63 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 12
Air Pollution Controlfor Natural Gas Drilling Sites
October 2013 13
Solar Powered Vent FlaresSolar Powered Vent Flares are easy to set up and pro-vide a solution for air quality, odor control, and gasmigration applications. These flares can be used tocontrol fugitive gas. Solar igniters provide continuousignition of combustible vapors. Solar or line powered blowers can assistwithdrawal of gases when necessary. The vent flares have a capacityrange of 2-750 scfm.— EPG Companies Inc., 800/443-7426,www.epgco.com Circle 81 on Card
Gas DetectorThe Model GD-1000 Premier Series Gas Detectordetects hazardous gases including methane and iscapable of responding to levels of gas in air over amultitude of ranges. The electro-chemical sensor canbe mounted in the area of potential leakage, while the monitor remainsin a safe area, protecting the operator from exposure to the gas leak.The operator is alerted to a leak by an audible alarm and flashing dis-play on the indicator.— Eagle Microsystems Inc., 610/323-2250,www.eaglemicrosystems.com Circle 76 on Card
Methane Gas DetectorThe 5100-28-IT Intelligent Methane Gas Detectors uti-lize IR sensor technology to monitor methane in the 0-100% LEL or 0-100% by volume range. It only requirescalibration every 12 months, and has a user-friendly, 8-character, fixed and scrolling LED display. The 5100-28-IT is network-enabled with a choice or combination ofoutputs: 4-20mA, RS-485 Modbus, HART, SentryBus, and optional 5-ampintegral relays. — Sierra Monitor Corporation, 800/727-4377, www.sierramonitor.com Circle 77 on Card
Hydrocarbon AnalyzersThe Series 9000 Hydrocarbon Analyzers offer a com-plete analysis of the hydrocarbons produced duringthe natural gas/oil exploration and drilling process. Theproduct family includes four versions: Total Hydrocarbon Analyzer,Methane/Non-Methane Analyzer, Heated Hydrocarbon Analyzer andTotal Carbon Analyzer. A flame ionization detector offers results withranges from ppb to ppm depending on the application.— Baseline Inc., 303/823-6661, www.baselineinc.com Circle 79 on Card
Personal Monitoring BadgesThe company’s organic vapor sampler is offered in twomodels. Both are used for collecting OVs, including ben-zene, toluene, xylene, ethylbenzene, and total hydrocar-bons. The X566 is for STEL or full shift sampling. The X521 istheir fastest sampler for short term or IAQ sampling.Monitors for ammonia, ozone, and a wide variety of othercontaminants are also offered. Optional AIHA-accredited lab service isavailable. — Assay Technology, 800/833-1258, www.assaytech.com
Circle 74 on Card
Manual-Inflating Sample BagThe VeriAir Flex™ manual-inflating sample bag allowsan atmospheric grab sample to be collected directlywithout any need for sampling pumps or other equip-ment. Simple, intrinsically safe, and made of durablemulti-layer foil, VeriAir Flex bags are reusable and are
designed for air shipment. The analytical grade inner polyolefin lining isrecommended for stable storage of most gases. — Nextteq LLC,877/312-2333, www.nextteq.com Circle 80 on Card
Thermal Combustor System Thermal Combustor Systems (TCS) are designed to safely burnor combust hydrocarbon vapor mixtures that have varyingenergy content where enclosed flares may fail. The TCS com-bines the simplicity of an enclosed flare with the performanceof a thermal oxidizer. Custom designed for your specificprocess, they can include forced draft or a normally draftedsystem along with a full complement of auxiliary devices to aidin performance and safety. — Catalytic Products International, 847/438-0334, www.cpilink.com Circle 82 on Card
Chemical ID SystemHAPSITE® ER is a person-portable GC/MS for immedi-ate, on-site investigation and analysis of volatileorganic compounds in air, water and soil at parts pertrillion for most analytes. Provides accurate chemicalseparation and identification in less than ten minutes. HAPSITE ER fea-tures low consumables usage and easy-to-use operation. Its color touchscreen displays complete analysis results, including chromatograms,spectra, library search results and quantitative data. — INFICON,315/434-1100, www.inficon.com Circle 83 on Card
Combustion Analyzer The E4400 portable flue gas analyzer features field-replace-able and pre-calibrated gas sensors, a dilution pump for COauto-range measurements up to 50,000 ppm, and Bluetoothwireless communication. Designed for emissions monitoringand maintenance and tuning of combustion processes, itincludes up to four gas sensors: O2, CO, NO, NO2, SO2, CxHy. It is LowNOx and True NOx capable. The E4400 has a built-in (non-thermal) print-er and internal data memory for 900 tests. — E Instruments International, 215/750-1212, www.e-inst.com Circle 84 on Card
Air Quality MonitorThe Haz-Scanner™ model HIM-6000 air quality monitoring sta-tion measures and documents trace level criteria air pollu-tants. The portable and expandable system simultaneouslymeasures PM 2.5 and PM 10. The HIM-6000 offers up to 12 sen-sors for toxic gases, sound, radiation, and meteorological airparameters. Options include solar power, 5-mile wireless datatransmission, and Ethernet/Internet data viewing.— Environmental Devices Corporation, 603/378-2112, www.environmentaldevices.com Circle 85 on Card
CO2 Gas DetectorThe company’s CO2 Gas Detector for monitoringnatural gas features an optically filtered NDIR dual-chamber infrared sensor element. The 3 or 4 wire,RS485/4-20mA detector includes self calibration,which adjusts span monthly, auto gas calibrationand hands-free magnetic switches. Temperaturesbetween -20°C to +50°C do not affect the detector. The CO2 GasDetector has a blacklit 12X2 LCD display and operates on 12 volts or 15-30 VDC. The detector is suitable for use in SIL 2 environments. — Mil-Ram Technology Inc., 510/656-2001, www.mil-ram.com
Circle 75 on Card
Combustible Point Gas DetectorSensAirCMB is a heavy duty combustible point gasdetector that uses advanced sensor technology tosignificantly reduce the effects of poisoning. This prod-uct is suitable for chemical and hydrocarbon process-ing and manufacturing facilities. SensAirCMB ishoused in an explosion-proof aluminum enclosure. Athree-wire, 4-20mA output enables easy installation in retrofit or newapplications with interface to common facility communication links. — Sensidyne LP, 727/530-3602, www.sensidyne.com Circle 78 on Card
PEN October 2013_PEN New Size 2012 10/29/13 4:20 PM Page 13
Nutrient RecoveryThe Pearl® Nutrient Recovery Process recovers nutri-ents from concentrated waste streams. Based on thechemical precipitation of struvite (magnesium ammo-nium phosphate hexahydrate), the process producesstruvite in the form of a slow release fertilizer. ThePearl® Process removes phosphorus and ammonialoads, prevents struvite scale formation, and recovers nutrient value. — Ostara Nutrient Recovery Technologies Inc., 604/408-6697,www.ostara.com Circle 95 on Card
Remote Monitoring & ControlRemote monitoring and control is offered on the com-pany’s line of vibrating fluid bed dryers, coolers,dewaterers, pellet classifiers, conveyors and otherequipment. Controlled remotely with a dedicatedPLC HMI, the remote desktop capability enables process engineers tostart and stop batch and continuous operations, adjust their parametersand check process conditions in real-time while away from the process-ing line. — Witte Company Inc., 908/689-6500, www.witte.com
Circle 96 on Card
Grease Receiving & Screening Mixing fats, oil, and grease with wastewater sludgecan increase the production of digester biogas. Thecompany has developed the Heavy Object Trap,model GRS, for grease receiving and screening. Alsoknown as the HOT, it features a variable bar screenwith spacings of 1/2" or 1" and comes in six differentsizes. It has a maximum flow rate of 600 gpm. — JWC Environmental, 800/331-2277, www.jwce.com
Circle 97 on Card
Clarification ProcessACTIFLO® is a sand-ballasted clarification process thatprovides high treatment efficiency in a very small foot-print for process water supply, drinking water, stormwater, wastewater treatment, or recycle and reuse systems. A proventechnology with more than 1000 installations worldwide, ACTIFLO® isavailable in field-erected tanks, package units or mobile solutions. —Veolia Water Solutions & Technologies, 800/337-0777, www.veoliawaterstna.com Circle 86 on Card
LiningsThe company offers seamless lining protection for sec-ondary containment, clarifiers, equalizers, basins,digesters, and walls with Stonchem lining systems. Theseamless systems protect underlying substrates from a broad range ofchemicals, including most fuels, salts, oils, alkalis, acids and petroleum.Stonchem can be applied over many substrates and on both horizontaland vertical surfaces. — Stonhard, 800/257-7953, www.stonhard.com
Circle 88 on Card
Load CellsThe company has introduced a series of waterproof,low profile load cells for wet or washdown applica-tions. The high accuracy LSHD has an all-stainless steelconstruction for harsh industrial environments with 1%interchangeability for scale applications. It features a9.8 foot (3 meter) waterproof cable. Longer lengthsare also available.— Omega Engineering Inc., 203/359-1660,www.omega.com Circle 87 on Card
Pump Control PanelSIM Simplex Pump Control Panels will control a120/208/24OV single phase pump or a 208/240/480OVthree phase pump in dewatering, sewage and waste-water pumping applications. The simplex panelsinclude integrated electronic control circuitry, an IECmotor contactor and two floats: pump on and pumpoff. The controls, housed in a NEMA 4X polycarbonate enclosure, fea-ture very low standby power. — See Water Inc., 888/733-9283, www.seewaterinc.com Circle 94 on Card
Water/Wastewater Treatment
Smoke GeneratorsSuperior® Smoke Generators find sources of surfaceinflow causing wet weather sanitary sewer overflows.The company offers both Classic Smoke Candles andSmoke Fluid Systems, plus Smoke Blowers engineeredfor smoke testing. Classic Smoke is available in sizesfrom 30 to 500,000 cubic feet. Superior® Smoke meetsWEF and NASSCO standards, and is used in tests to meet EPA, ASHRAE,OSHA and NFPA standards. — Superior Signal Company LLC, 800/945-8378, www.superiorsignal.com Circle 91 on Card
All-Plastic Control ValveThe 2" flanged plastic control valve Model 2060 features abody of either PVDF or polypropylene and anactuator/yoke of glass-filled polypropylene. The valvehandles fluids including hydrochloric acid, caustic, sulfuricacid, and many others that would ordinarily require anexotic alloy metal valve. The 2060 is available with trimsizes up to Cv = 38. — Collins Instrument Company, 979/849-8266,www.collinsinst.com Circle 90 on Card
Aerator with Rotating Water CannonThe Turbo X-Treme Magnum Water Cannon is a 50HP floating/surface aerator (which can pump up to12.5 million gallons of water per day) upgradedwith the addition of a rotating water cannon. Inoperation, the water cannon (powered by a sepa-rate 7.5 HP grinder pump) rotates 360 degrees in 1minute 35 seconds, spraying out over 100 gallons ofwater per minute in an approximate 230 feet diameter, achieving foamsuppression, aeration, evaporation, and cooling. — Airmaster AeratorInc., 888/813-3680, www.airmasteraerator.com Circle 89 on Card
Level Controller with RedundancyThe PSL 5.0 Pump Station Level Controller fea-tures redundant level sensing. It includes a non-contacting ultrasonic sensor and you can alsoconnect a loop-powered pressure sensor forredundant sensing in applications with foam orgrease. The PSL 5.0 will continuously recalibratethe pressure sensor and automatically switchback and forth from ultrasonic to the pressuresensor as required. — Greyline Instruments Inc., 888/473-9546,www.greyline.com Circle 92 on Card
Level LoggersThe DCX-ECO utilizes accumulator cell technolo-gy to provide a rechargeable autonomous levellogger. The power cell is charged via USB con-nection during data retrieval. The DCX-ECO fea-tures a small, 18mm (0.71 inch) diameter stainless steel housing. It is idealfor long and short term liquid level monitoring applications. The instru-ment is available in absolute, sealed, and vented versions. — KellerAmerica, 877/253-5537, www.kelleramerica.com Circle 93 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 14
Diaphragm Metering PumpsSeries 7000 pumps have been designed with waterand wastewater applications in mind. The mechanicaldesign of the Series 7000 eliminates the use of contourplates on the liquid side of the diaphragm while thesimple, straight-through valve and head design allows for improved flowcharacteristics. The Series 7000 is self-priming and has a maximumcapacity range up to 300 gph at 150 psi. — Neptune Chemical PumpCompany, 215/699-8700, www.neptune1.com Circle 106 on Card
Pumps for Corrosive FluidsThe company’s pumps and systems solve fluid con-tainment, recirculating, dosing, collecting and transferproblems encountered with the safe handling of cor-rosive, abrasive and ultrapure fluids. The products fea-ture wet-end components constructed of thermoplastics, which areimpervious to acids, caustics, salts, solvents, chlorides, halogens, andother aggressive, abrasive chemicals. Engineered to individual require-ments, the pumps are available in a variety of configurations including:ANSI, mag-drive, close-coupled, self-priming, vertical to 20 feet and run-dry cantilevered. — Vanton Pump & Equipment Corp., 908/688-4216,www.vanton.com Circle 108 on Card
Oil Spill Recovery PumpsModel 2500 Series Electric Double Diaphragm Pumpscombine the features of high vacuum, 23" hg, with analmost zero emulsifying pumping action. These pumpsremediate sites contaminated with Light Non-AqueousPhase Liquids (LNAPL), such as fuel oil. They work inboth mobile or fixed installation. Made of glass filled polypropylene, 316stainless hardware and reinforced Viton™ diaphragms, they pumpalmost all corrosive hydrocarbons. — Edson International, 800/393-8657,www.edsonpump.com Circle 112 on Card
Mini Peristaltic PumpModel TPT mini peristaltic pumps feature flow ratesfrom 1ml/min up to 30 ml/min by selecting from achoice of 4 different rpm drives (8,12,17 or 25 rpm)and a choice of tubing sizes. Direction of flow isreversible. The Motor is a continuous duty 24 VDCgear motor; brush style with internal permanent mag-net. An optional Power Supply can be ordered separately and anoptional Counter indicates the number of revolutions. — AALBORG Instruments, 800/866-3837, www.aalborg.com
Circle 105 on Card
Diaphragm PumpsThe E-Series Dia-Vac® diaphragm pump delivers 150standard liters per minute with just one pump head.The response time is quick, and there is minimal main-tenance required after installation. General purposeand explosion proof motor options are currently offered with heatedand elevated pump model options available soon. The E-Series featurescorrosion-resistant wetted materials. — Air Dimensions Inc., 954/428-7333, www.airdimensions.com Circle 111 on Card
Lift Station Backup SystemThis lift station backup system utilizes programmableelectronic controls, which make use of sensors thatmonitor levels in the wet well and initiate backuppumping as programmed. These permanently installedunits continue pumping despite power loss or primary pump failures. Thepumps include the Enviroprime System® which actively prevents sewagespills. SCADA-capable controls send an alarm to alert the operator. — Thompson Pump, 386/767-7310, www.thompsonpump.com
Circle 104 on Card
Laboratory Vacuum PumpThe piston-powered oil-free Rocker 300 LaboratoryVacuum Pump can provide vacuum and pressure injust one unit, and its noise level is 50 dB. The Rocker 300is equipped with a 1/8 hp motor and provides a maxi-mum 20 lpm (110 V/60 Hz) (17 lpm, 220 V/50 Hz) of freeair displacement and 650 mm Hg of maximum vacuum. A moisturetrap/vacuum regulator filters particles and moisture from the inlet air. TheRocker 300 is also suitable for stack or ambient gas sampling. — New Star Environmental, 770/509-7484,www.newstarenvironmental.com Circle 101 on Card
Submersible Shredder PumpsModel SK submersible shredder pumps are designed to“shred” soft solids and debris before pumping. Theshredding action is produced using a non-clog cuttingimpeller with integral tungsten carbide vane tips. TheSK series features hardened cast iron construction anda 304SS motor housing. There are SK Models from 2" - 6",from 1 - 20 horsepower, pumping up to 911 gpm, with heads to 101 feet.— BJM Pumps, 860/399-5937, www.bjmpumps.com Circle 107 on Card
Portable Pumping and Sampling SystemThe REEL E-Z® system is used in portable samplingand pumping applications in small diameter wells asdeep as 250 feet. When used with the HAPPY HOSE!®the system installs the pump in the well, locks it inplace, and allows for easy take up and cleaningwithout cable entanglement. The REEL E-Z canaccommodate both above and below grade well applications. — INW, 425/822-4434, www.inwusa.com Circle 110 on Card
Pump Control PanelSIM Simplex Pump Control Panels will control a120/208/24OV single phase pump or a 208/240/480Vthree phase pump in dewatering, sewage and waste-water pumping applications. The simplex panels include integratedelectronic control circuitry, an IEC motor contactor and two floats:pump on and pump off. The controls, housed in a NEMA 4X polycarbon-ate enclosure, feature very low standby power. — See Water Inc.,888/733-9283, www.seewaterinc.com Circle 103 on Card
Self-Priming PumpsThe Godwin Dri-Prime® NC Series features automaticself-priming from dry to 28 feet without operator assis-tance and Flygt N-technology with a self-cleaningimpeller. They feature a Hard-Iron™ (60 HRC) impellerand insert ring and a dry-running high-pressure oil bath mechanical sealwith abrasion-resistant silicon carbide faces. They are suitable forsewage and clean water applications. The series includes an NC80diesel pump and NC150 diesel pump with compressor clutch — Xylem Inc., 856/467-3636, www.godwinpumps.com Circle 102 on Card
Ball Valve PumpNow available 3" HV High-Volume Ball Valve Pump.This air-operated, dual-diaphragm pump has a flowrate of 417 gpm. These pumps are designed to handleabrasive, solid-laden and corrosive fluids. Key featuresand benefits include a long-life diaphragm and self-cleaning valve, large solids handling up to 1.3", andconductive plastic (FRASplas) safe for explosive environments, rated andcertified to ATEX M1. — Pumps 2000 America, 412/963-9200,www.pumps2000america.com Circle 109 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 15
Microbubble GeneratorThe STRATOJET® bubble generator utilizes a passiveacoustic resonance created by flow interaction withthe nozzle and upstream chambers to induce the for-mation of large vortical structure which break up cav-ities to generate very fine bubbles. The user can intro-duce air or other gases to enhance gas transfer. STRA-TOJET® bubble generators can generate high void fraction bubblyflows dominated by micro-sized bubbles. They are scalable and can becustom designed and fabricated. — Dynaflow Inc., 301/604-3688, www.dynaflow-inc.com Circle 113 on Card
Chemical-Free Water TreatmentThe company manufactures water treatment prod-ucts for the oil and gas industry. The SX PECO reactorsystem is a chemical-free biocide that can handle dif-ferent water types and flow rates with little or no oper-ator interaction. It can handle fresh, brackish and saltwater and can handle source, flowback and pro-duced water. Features include a scalable, modular design, low energyconsumption, and a compact footprint. — AquaMost Inc., 800/286-5841, www.aquamost.com
Circle 114 on Card
Fiberglass SheltersOrenco® Fiberglass Shelters are made of thick, foam-corefiberglass walls (typically 2"-4"). All surfaces are protectedwith a polyester gelcoat for continuous outdoor exposure.These lightweight, insulated structures are corrosion andweather resistant, and are easily transportable by truck,rail, cargo container, or aircraft. Shelters can be field- orfactory-assembled. Numerous sizes and custom options are available.— Orenco Systems Inc., 800/348-9843, www.orenco.com
Circle 119 on Card
Analytical Sensors with IntegratedTransmitterSMARTSENS is a family of 2-wire loop powered analyti-cal sensors with integrated transmitter technology.Offered for pH, oxidation-reduction potential (ORP)and conductivity, SMARTSENS sensors can be con-nected directly to the process control system, featur-ing direct communication via 4-20mA/HART. AllSMARTSENS sensors are digital and can be calibratedor recalibrated offline in a laboratory under controlled conditions. Alarge portfolio of SMARTSENS accessories is available. — KROHNE Inc.,800/356-9464, http://us.krohne.com Circle 118 on Card
Manual/Powered PumpThe Zelda PHD pump is a low rpm, high volume, posi-tive displacement pump that operates efficiently atlow rotational speeds in either pump or turbine mode.The low working speed allows operation by hand,kinetic power or by motor. The pump handles highand low viscosity fluids from thick heavy molasses, tosludge, fuel or freshwater. It can pump 90 gpm by hand and 250 gpmat 165 rpm. — Windtrans Systems Ltd., 519/527-2475, www.windtrans.ca
Circle 115 on Card
Clamp for Pulse Jet Filter BlowpipesThe MikroFix Clamp® is a “click-on” clamp which con-nects the blowpipes to housing flanges. During dis-mantling, the clamps only need to be pulled up andoff, eliminating the use of tools, eliminating connect-ing parts such as swivel nuts and screws, and simplify-ing access to filter bags and cages. — MikroPul LCC,800/892-7278, www.mikropul.com
Circle 116 on Card
Single Layer PVDF DiaphragmThe Single Layer Injection Molded PVDF Diaphragmhas been introduced for the Chem-Pro® Series C2 andC3 Metering Pumps. With zero breakdown or delami-nation, field maintenance and downtime due to fail-ure is reduced. The pump head consists of only one material, PVDF,reducing chemical compatibility issues of the wetted parts. The design isavailable in three sizes. New PVDF Diaphragms retro-fit onto currentProSeries® Chem-Pro® pumps, making this a simple, in-field upgrade. — Blue-White Industries, 714/893-8529, www.blue-white.com
Circle 122 on Card
Website on Grit ManagementThe company has launched a website to promote thephilosophy of Advanced Grit Management™. Thewebsite will provide a clearinghouse for science-based information on grit removal design which canbe used by engineers, operators and owners to selectthe best solution for their project’s needs — Hydro International, +44 1275 878371, www.hydro-int.com Circle 120 on Card
Configurable Dosing TankStationsEquipped with a polyethylene tank and chemicallyresistant accessories, this configurable dosing tank sta-tion (DTS) is designed for storing and dosing a widevariety of liquid chemicals such as biocides, inhibitors,alkalis, acids, coagulants, hypochlorites, disinfectants and neutralizingagents. The easy-to-install DTS features a wide range of chemical com-patibility and fits a number of application fields and dosing tasks. — Grundfos Pumps Corp., 913/302-3702 www.grundfos.us
Circle 121 on Card
Orthophosphate AnalyzerThe YSI P 700 IQ Orthophosphate Analyzer can beused as a stand-alone analyzer or in conjunction withother sensors in a IQ SensorNet 2020 XT continuousmonitoring and control system. Because of its two measuring ranges,the P 700 can be used throughout a wastewater treatment plant. The P700 analyzer offers a compact design and features low reagent con-sumption. Exchange solutions on average every 4-8 months. — XylemAnalytics, 937/767-7241, www.xylemanalytics.com Circle 117 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 16
E INSTRUMENTS provides the latest technology in NOx analysis with theNEW BTU 900-NOx analyzer that is ideal for boiler, burner, engine, furnace,and other combustion applications.
The E8500 is ideal for EPA level emissions monitoring for industrial combustion applications including boilers, engines,and furnaces.
• Real-Time PC Software Package including BlueTooth Module for Wireless Communications
• Wireless Remote Printer• Low NOx and True NOx Capable• Gas Velocity with Pitot Tube
E INSTRUMENTS provides the latesttechnology in combustion gas analysiswith the NEW E4400 analyzer that isideal for boiler, burner, engine, furnace,and other combustion applications.
E4400 features include:• Up to FOUR Gas Sensors:
O2, CO, NO, NO2 & SO2, CxHy• CO Dilution Pump For Auto-Range
Measurements Up To 50,000 ppm• Low NOx and Total NOx Capable• Field Replaceable & Pre-Calibrated
Sensors• Internal Non-Thermal Impact Printer• Software Package with BlueTooth &
USB
BTU 900-NOx features include:• 3 Gas Sensors Included:
O2, CO, NO (CO2 & NOx calculated)• High CO Range (0-8,000 ppm)• Memory & PC Software Included• Wireless BlueTooth Included• Field Replaceable & Pre-Calibrated
Sensors• Easy, One Button Operation
Circle 127 on Card
Circle 128 on Card
OIL SPILL ALARM
The unique float design monitors the changing water surface in sumps,
lagoons and tanks.
Any oil separation that
accumulates to 2mm of
surface oil will indicate an alarm
condition. Ideal for power sta-
tion sumps and vaults,
stormwater run-off in refineries
and factories.....anywhere a
small accumulation of oil on
water should be alerted. This
model is also offered
Intrinsically Safe for Hazardous
Rated areas.
(905) 829-2418www.arjayeng.com
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 17
Wireless Intrusion Detection SystemCNIguard™ intrusion detection system protectsaccess points in drinking water distribution systemsagainst the threat of intentional contamination. Itdetects tampering such as drilling, grinding and cut-ting. The computerized system has the ability to distin-guish between real threats and common occurrencessuch as heavy rain, hail, etc. and is rated for a maxi-mum of one false alarm per year. The system is suited for pumping sta-tions and wells in remote areas. Encrypted signals are used to communi-cate between the controller and the detectors. — The Bilco Company,203/934-6363, www.bilco.com Circle 129 on Card
Oxygen Diffuser The Waterloo Emitter™ is a simple, low cost devicedesigned for the bioremediation of contaminatedgroundwater. It enables oxygen, or other amend-ments, to diffuse through silicone or LDPE tubing in acontrolled uniform manner, with no ‘bubbling’ ofexcess oxygen. It is sized to fit 2", 4", and 6" (50, 100,and 150 mm) diameter wells. The Waterloo Emitter is ideal for aerobicbioremediation of MTBE and BTEX. — Solinst Canada Ltd., 905/873-2255,www.solinst.com Circle 131 on Card
Molded-in Full Drain OutletThe Full Drain Outlet (FDO) assembly, for 2500 gallontanks and larger, drains tanks without mechanicallyinstalled nozzles and can be utilized where heavysolids or salts may accumulate in the bottom. Thecompany’s linear polyethylene tanks are certified byNSF to NSF/ANSI Standard 61, while their high-densitycrosslink resin tanks have NSF 61 Certification. In addition, the compa-ny’s quality management system is ISO 9001:2008 Certified.— Assmann Corporation of America, 888/357-3181,
www.assmann-usa.com Circle 132 on Card
Tension Fabric BuildingsHercules Truss Arch Buildings are energy-efficient, cus-tomizable structures. The triple-galvanized structural steelframes and tension fabric covers ensure long life anddurability, making these buildings ideal for corrosive envi-ronments such as water treatment facilities, recyclingcenters, solid waste facilities and more. They Feature abundant naturallight and spacious interiors without support posts. — ClearSpan FabricStructures, 866/643-1010, www.clearspan.com Circle 130 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:48 AM Page 19
Environmental EnclosureThe company is offering the optional Dust Detective™environmental enclosure system that allows aMicrodust™ Pro monitor to be safely used for meas-urement applications where particulate concentra-tions must be monitored for eight hours or more. TheIP65-rated waterproof, self-contained Dust Detectivekit is optimized for field use. It comes complete with allnecessary items and is fitted with a Casella Tuff™ sam-pling pump to provide an autonomous measurement system that willrun continuously for up to 12 hours in the field. — Casella CEL Inc.,800/366-2966, www.casellausa.com Circle 140 on Card
Lubrication & Corrosion ProtectionVpCI®-328 is a ready-to-use vegetable oil/solvent-based corrosion pre-ventive compound, lubricant, and penetrant for universal corrosion pro-tection. It provides corrosion protection for ferrous metals, galvanizedsteel, aluminum, brass, copper, magnesium, zinc, and cadmium. It willalso loosen frozen and rusted metal parts. — Cortec Corporation,651/429-1100, www.cortecvci.com Circle 141 on Card
Nuclear Qualified Pressure TransmittersThe company offers a Class 1E nuclear qualified differentialpressure transmitter, designed for use in harsh nuclearpower applications. The instruments are Class 1E qualifiedto IEEE 323-1974 and IEEE 344-1987. The DTN2070 transmittercontains only analog electronics, utilizing a diaphragm iso-lated direct coupled strain gauge pressure sensor capsule.Features include advanced thin film metal strain gaugesensor technology, and all stainless steel housings. — Ultra Electronics,NSPI, 512/434-2989, www.ultra-nspi.com Circle 143 on Card
Water Cut MonitorWith the addition of a temperature compensation feature,the Universal IV™ CM Model Water Cut Monitor offersimproved accuracy and reliability for temperatures up to160°F. The monitor has water cut measurement accuracyin the low ranges (0-1%, 0-5%, 0-10% and 0-30% water),accuracy down to 0.03% water, and measurement resolu-tion down to 0.0002% water. It has a built-in LCD display and keypadand its Cote-Shield™ technology ignores coating buildup on the probe.— AMETEK Drexelbrook, 215/674-1234, www.drexelbrook.com
Circle 144 on Card
Cation ResinDOWEX™ MONOSPHERE™ 1400PC Cation Resin forpressurized water reactor nuclear power plants hasbeen introduced. This high capacity cation resin mini-mizes anion resin kinetic degradation associated withthe use of ethanolamine (ETA) which is used to mini-mize flow-assisted corrosion (FAC) and iron transport within the second-ary water systems. DOWEX MONSOPHERE 1400PC specifically addressesthe problems associated with ETA in condensate polishers and delivershigh-quality water to the steam generator. — Dow Water & ProcessSolutions, 800/447-4369, www.dowwaterandprocess.com
Circle 145 on Card
Humidification for Trace Gas MixturesThe FlexStream™ Humidification Module adds variablelevels of humidity to trace gas mixtures produced bythe FlexStream™ system. Typically, the unit can beused to add adjustable humidity levels between 20%and 90% RH (though not all levels can be achieved atall flows). The FlexStream™ internal computer setsboth the dilution flow and the proportion of wet gas.— KIN-TEK Laboratories Inc., 409/938-3627, www.kin-tek.com
Circle 134 on Card
Stainless Steel Vent FilterThe KPSI 811 Permanent Vent Filter provides a mini-mum of five years of moisture protection withoutmaintenance. The housing is constructed out of astainless steel body containing the desiccant, while aGore-Tex filter plug provides atmospheric referencewithout letting moisture into the casing. The vent filteris a compact package at 2.75 inches (70mm) long by 0.75 inch (19mm)in diameter. — Measurement Specialties Inc., 800/745-8008,www.meas-spec.com Circle 135 on Card
Remote Methane Leak DetectorThe intrinsically safe Remote Methane Leak Detector(RMLD-IS®) is an eye-safe laser-based natural gasdetector (methane) that can detect leaks up to onehundred feet away, allowing remote detection ofunderground piping, compressor stations, offshoreplatforms, plant/industrial inspections, gas processingplants, gas gathering, drilling sites, landfills, difficult terrains and more. — Heath Consultants Inc., 800/432-8487, www.heathus.com
Circle 136 on Card
Pressure ComparatorThe GaugeCalHP pressure comparator for test andcalibration applications up to 15,000 psi is suitable foruse with water or oil, either in the field or the laborato-ry. It is compatible with most large-size pressuregauges. The GaugeCalHP has a reservoir relief valve,and a self-venting weep hole alerts users before theydisconnect from a pressurized system. — Crystal Engineering, 800/444-1850, www.crystalengineering.net
Circle 137 on Card
Oxygen AnalyzerThe compact XZR200 is capable of measuring percentoxygen content to better than 1% of span. Easy toinstall and integrate into existing systems, the analyzeroffers four configuration options with two choices ofprobe length and two temperature ranges. Its RS232output can be directly accessed by a PC. A key fea-ture of the XZR200 is a 3.3 V DC logic output which is used to monitorthe sensor for diagnostic purposes. — Michell Instruments, 978/484-0005,www.michell.com/us Circle 138 on Card
Air/Gas Mass Flow MeterThe ST102A Air/Gas Thermal Mass Flow Meter featuresa dual-element averaging system, improving installa-tion repeatability and accuracy for larger diameterpipes and ducts. The transmitter electronics averagethe input from two independent flow elements into asingle output. Each flow element can be independ-ently configured for insertion length and process connection. — Fluid Components Intl. 800/854-1993, www.fluidcomponents.com
Circle 139 on Card
Non-Fouling Level TransmitterThe LevelRat for lift station level measurement features aKynar® diaphragm that combines the non-stick proper-ties of Teflon® with resistance to puncture and abrasion.The small, non-fouling level transmitter can be used in theworst environments, without the need for bulky andexpensive protective cages. Guaranteed lightning pro-tection is standard on all 4-20mA equipped LevelRats. — Keller America, 877/253-5537, www.kelleramerica.com
Circle 142 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:49 AM Page 20
Compact Weather StationThe WS600 Ultrasonic Weather Station provides an all-in-one platform. The intelligent measurement trans-ducer with digital interface features an integrateddesign and ventilated radiation protection.Measurements include relative humidity, precipitationintensity, type and quantity, as well as air pressure,wind direction and wind speed. — Lufft USA Inc., 888/519-8443,www.lufft.com Circle 146 on Card
Two-Wire MagmeterThe Proline Promag 200 electromagnetic flow meter isa two-wire magmeter that offers the same measuringperformance as four-wire magmeters. The PromagH200 is available in line sizes of 1/12 to 1 inch andPromag P200 is available in line sizes of 1/2 to 8 inchfor measuring the flow rates of conductive fluids. Theflowmeter operates in process temperatures from -40 to 304°F. A sepa-rate power source is not required, and the meter is intrinsically safe. — Endress+Hauser Inc., 888/363-7377, www.us.endress.com/two-wire-flow Circle 147 on Card
Measurement SystemDataStick™ measurement systems are configurableplug-and-play systems that easily integrate into PLCs.The DataStick’s digital communication system pro-vides universal conversion of sensor signals and canbe remotely configured, calibrated, and diagnosed.The intelligent DataStick sensor heads are pre-calibrat-ed and store all calibration data right in the sensor. The foul-resistantsensors are available in a broad range of measurement parameters.— Thermo Fisher Scientific, 800/225-1480,
www.thermoscientific.com/processwater Circle 148 on Card
Dissolved Oxygen SensorThe Triton DO80 Dissolved Oxygen Sensor features afluorescence quenching sensing element and an ultralong life membrane cap with no annual replacementrequired or recommended. The self-monitoring DO80stores calibration data within the sensor. The TritonDO80 Sensor features a maximum error of less than 2percent, repeatability of ±0.5 percent, and resolution of 0.01 ppm or0.01 percent saturation. — Electro-Chemical Devices, 800/729-1333,www.ecdi.com Circle 150 on Card
Thermocouple SensorA thermocouple version has been launched for theEL-WiFi series of remote data loggers. Supplied with K-type probe, the EL-WiFi-TC has a measurement rangeof 32°F (0°C) to 752° F (400°C), accuracy of ±1.5°Cand display resolution of 0.1° F/C. The sensor canaccept user selected J, K, N, and T-type thermocou-ple via its on-board mini thermocouple connector, pushing the potentialmeasurement range to -454 to +2372°F (-270 to +1300°C).— Lascar Electronics, 814/835-0621, www.lascarelectronics.com
Circle 151 on Card
Inductive Angle SensorsThese inductive angle sensors for rotary actuators fea-ture an open face design, analog or discrete outputsand flexible mounting options. They are able to moni-tor three-way valves, and are capable of detectingthe wear of seals. The sensors provide optimal per-formance in temperatures ranging from -25°C to 75°C. — Turck, 800/544-7769, www.turck.us Circle 156 on Card
Optical Dissolved Oxygen SensorThe Signet 2610 Optical Dissolved Oxygen Sensor utilizes optical technol-ogy that resists abrasion and bleaching. The optical sensor cap is facto-ry calibrated and requires no field calibration. Thesensor includes built-in Modbus RS485 and 4-20mAcurrent loop outputs. Operating capabilities include ameasurement range of 0 to 20mg/L, 0 to 200% satura-tion. — GF Piping Systems, 800/854-4090, www.gfpiping.com
Circle 149 on Card
Photoionization SensorsThe piD-TECH® plus family of Photoionization Sensorsis suitable for environmental, safety, industrial andcommercial applications. With a 4P plug-in cell pro-file compatibility, it is easily incorporated into existing gas analyzing ormonitoring instruments. The intrinsically safe sensors provide consistentlinearity and offer a broad range of sensitivities from 2 ppm to 10,000ppm. — Baseline Inc., 303/823-6661, www.baselineinc.com
Circle 153 on Card
Water Monitoring SystemThis multi-parameter water pollution monitoring sys-tem permits any combination of up to nine measure-ments in a single weatherproof assembly with localdisplay using submersible or inline sensors. Featuring solid-state sensortechnology, the system provides continuous measurement for waterquality parameters including pH, ORP, conductivity, dissolved oxygen,temperature as well as ammonia, fluoride, nitrite and more. —Advanced Sensor Technologies Inc., 714/978-2837, www.astisensor.com
Circle 152 on Card
Photoionization DetectorThe company’s 2020ComboPRO portablePhotoionization Detector (PID) provides overall volatileorganic compound (VOC) monitoring in emergencyresponse, environmental and industrial hygiene appli-cations. The 2020ComboPRO is small, lightweight, easyto use, and provides sample analysis and results in lessthan three seconds. It is certified as safe to North American UL and ATEXstandards for use in potentially explosive environments. — INFICON, 315/434-1100, www.inficon.com Circle 154 on Card
Analytical Sensors with IntegratedTransmitterSMARTSENS is a family of 2-wire loop powered analyti-cal sensors with integrated transmitter technology.Offered for pH, oxidation-reduction potential (ORP)and conductivity, SMARTSENS sensors can be con-nected directly to the process control system, featur-ing direct communication via 4-20mA/HART. AllSMARTSENS sensors are digital and can be calibratedor recalibrated offline in a laboratory under controlled conditions. Alarge portfolio of SMARTSENS accessories is available. — KROHNE Inc.,800/356-9464, http://us.krohne.com Circle 155 on Card
Sensors
PEN October 2013_PEN New Size 2012 10/29/13 10:49 AM Page 21
Centrifugal PumpsThe company’s Centrifugal Pumps feature a powerfuloverhead cam engine and heavy-duty construction.The PKX line of self-priming pumps includes 2-, 3- and4-inch models. The pumps have an abrasion-resistant, cast-iron three-blade impeller and a hardened cast-iron volute. The carbon ceramicseal is self-lubricating. — Subaru Industrial Power Products, 847/540-7300, www.subarupower.com Circle 166 on Card
Drain InsertThe PIG® Quick-Fit Drain Insert filters oil and sedimentout of wastewater before it reaches stormwater out-lets. Easily installed by one person, the fully adjustableinsert fits drain openings from 16" x 26" to 20" x 32". Thebelow-grate design has an 18"-deep accumulationpocket to collect sediment, debris and oil. Geotextilefabric lets stormwater flow through and high-flow storm ports help toavoid backups. — Newpig Corporation, 800/468-4647,www.newpig.com Circle 162 on Card
Low-Profile ChamberThe Contactor® 100HD underground stormwatermanagement chamber is a low-profile chamber. The12.5" (318 mm) high chamber holds 112 gallons, with nearly 30 cubicfeet of storage per unit when surrounded with stone. A side portalallows for internal lateral manifolding of the system. Manufactured withan open bottom, the Contactor 100HD features integrally formed end-walls and perforated sidewalls.. — CULTEC, 203/774-4416,www.cultec.com Circle 165 on CardIndustrial Vacuum
The Low Profile 33 Series features reduced operatingnoise levels and an all-hydraulic rear door that elimi-nates the need for external manual safety locks. Itopens fully so the operator can completely empty thecontents and clean out easier. The LP 33 Series canremove a variety of wet and dry materials. The LP isavailable either trailer-mounted or truck-mounted for mobility on thejobsite. — Vac-Tron Equipment, 888/822-8766, www.vactron.com
Circle 163 on Card
Flow Control for Pond OptimizationThirsty Duck Floating Outlets are used to optimize out-flow and depending on site specific hydrology andsystem hydraulics, storage volume can be reduced byup to 50%. The Thirsty Duck is self-skimming and doesnot have any detrimental effect on water quality. Thedevice does not have any active mechanical partsand design features allow easy access and make cleaning and routinemaintenance simple. — Thirsty Duck, 727/376-2400, www.thirsty-duck.com Circle 161 on Card
Monitor Oil in Stormwater InterceptorsThe capacitance sensing probe provides a mainte-nance-free approach to monitoring for oil accumu-lation in stormwater interceptors. The Teflon coatedprobe is easy to install and set up. The standarddesign is explosion proof and can handle harshconditions. The remote control unit is available withrelay control interface control as well as audio/visu-al alarms. — Arjay Engineering Ltd., 905/829-2418, www.arjayeng.com
Circle 164 on Card
Founded in 1991, SPI is a company dedicated to creating products
that protect the environment from oil and hydrocarbon contamina-
tion. Starting with specialized absorbents to solidify spills and
sludge or separate oil from water, SPI has evolved into a leader in
producing state-of-the-art spill containment products and systems.
SPI technology has led to the development of passive oil containment
systems that offer 24/7 protection from the release of oil, whether a
faint sheen or a full blown spill. These systems are particularly
important for unmanned containment areas where oil contaminated
stormwater could runoff or overflow into the environment. SPI’s
endeavors have resulted in being granted six U.S. and four Canadian
patents with other U.S. and foreign patents pending.
In addition to effectively trapping oil, the media in SPI products will
physically react with oil to instantaneously form a plug thus prevent-
ing any oil from being discharged from an SPI product or contain-
ment system. Many materials absorb oil but only SPI offers products
that guarantee maximum performance: No oil has ever escaped an
SPI product.
Over the years, thousands of SPI Petro-Plugs®, Petro-Pipes®, Petro-
Barriers™ and custom made oil absorbing products have been
installed across the United States, Canada and throughout the world.
All have performed up to or beyond expectations. SPI continues to
find solutions to even the most difficult environmental problems
related to contamination from oil, hydrocarbons and related materials.
Our capabilities range from retrofitting storm drains for 100% oil
spill containment to engineering and manufacturing custom products
for a multitude of applications that are
vital to all industries that seek to protect
the environment.
SPI continues to develop new products
and expand the capabilities of current
products. Recently SPI has added cus-
tom-sized heating blankets for its Petro-
Barriers and their external filters to
allow the Barriers to function in freez-
ing weather. With the aid of a sump
pump, SPI can now collect and treat subsurface water by pumping
the potentially contaminated water through a Petro-Barrier. This con-
figuration of a Petro-Barrier is designated as a Pump-Thru-Barrier
and is one of our most popular products.
For more information on the entire spectrum of SPI products
designed and manufactured for removing oil and hydrocarbon con-
tamination from stormwater, please visit our website: oilbarriers.com
or give us a call at 203 484-9494. Circle 160 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:49 AM Page 23
Water, in and of itself, is quite an amazing commodity. It is one of
the building blocks of life—organisms ranging from human to plants
to animals cannot survive without it. Municipalities could not exist
without a readily available supply of water, teamed with the munici-
pality’s ability to consistently deliver that water to a wide array of,
for example, residences, businesses , hospitals and community cen-
ters.
The operations in many of the world’s major industries would also
halt without water, which is used as an ingredient in thousands of fin-
ished products, from food to cosmetics. Water is also used as a clean-
ing or cooling agent for equipment in many heavy-duty industrial-
equipment applications. In instances like these, water often becomes
wastewater, which must either be treated or disposed of. With empha-
sis being placed on environmental responsibility in many industries,
this means that proper wastewater handling and treatment is becom-
ing more and more crucial.
So, with water playing such a critical role in the lives and industries
of Earth’s inhabitants, there is paramount need for pumping technolo-
gy that can efficiently, reliably and safely handle water, from its most
pristine state to the soiled variety that flows into a water-treatment
facility. Wastewater can be especially problematic for pumping
equipment because it can become fouled with abrasives or solids that
can harm pumps, or hazardous materials that must be contained in
order to protect the safety of plant personnel and the environment.
This white paper will highlight why one type of pumping technolo-
gy—positive displacement peristaltic (hose) pumps—can rise to the
challenges inherent in the handling and treatment of water and waste-
water in any of a wide variety of municipal and industrial applica-
tions.
The Challenge
The design and operational characteristics of peristaltic (hose) pump
technology, which was patented in 1925 in France, make it a wise
choice in a wide range of waterhandling applications—from moving
viscous and/or abrasive slurries to the transfer of water-thin, nonlu-
bricating fluids and shear-sensitive materials. These characteristics
make peristaltic (hose) pumps ideal for the full array of diverse oper-
ations within the water-and-wastewater industry.
Peristaltic (hose) pumps satisfy the requirements of such a wide
range of water-and-wastewater applica-
tions because their operation is based on
the alternating contraction and relaxation
of the hose, forcing the contents to move
through the pump and into the discharge
piping. A smooth-wall, flexible hose is
fitted in the pump casing and
is squeezed between shoes on the rotor
and the inside of the pump casing. This
rotating action moves the product
through the hose at a constant rate of
displacement. The hose restitution after
the squeeze produces an almost full vac-
uum that draws the product into the hose
from the intake piping. The pump casing
is lubricated to cool the pump and lengthen the service life of the
shoes and hose. Since the product only contacts the hose and not the
internal pump components, this pumping technology is very suitable
for abrasive and corrosive applications.
This pump style also maintains excellent volumetric consistency,
making it ideal for the strict dosing and 24/7 operating cycles that
can be required in wastewater treatment applications. The pump’s
seal-free design makes it dry-run, self-priming and low-slip capable,
and eliminates any potential leak or contamination points while
simultaneously providing superior suction lift. Finally, peristaltic
(hose) pumps are easy to operate and easy to maintain. The pump’s
reversible operation also allows for pumping in both directions.
In order to successfully handle the challenges of water-and-waste-
water handling and treatment, the peristaltic pump’s hose—which,
because of its seal-less design, is the only component to actually
come in contact with the pumped medium—needs to achieve the
highest level of material compatibility, while also being able to rel-
iably deliver the millions of pumping cycles that are required
during its lifetime.
Another consideration when selecting a hose material is its “fatigue
resistance.” This trait defines how resistant to failure the hose materi-
al is as it runs through its millions of pumping cycles. A hose materi-
al that is susceptible to developing cracks and holes relatively early
Whether handling pristinefreshwater or soiled waste-water, Abaque™ SeriesPeristaltic (Hose) Pumps area top choice for many in theindustry.
Complex water and wastewater treatment operations require reliable pumptechnology, like that offered by Abaque™ Series Peristaltic (Hose) Pumps(inset).
PEN October 2013_PEN New Size 2012 10/29/13 4:35 PM Page 24
You can find more information at www.psgdover.com.Circle 167 on Card
The Abaque pump’s hose restitution after the squeeze produces an almostfull vacuum that draws the product into the hose from the intake piping.
The simple design of the Abaque Series Peristaltic (Hose) Pumps features a seal-freedesign that eliminates leaks and product contamination, which enables them to handlethe waste and wastewater industry’s toughest pumping applications.
PEN October 2013_PEN New Size 2012 10/29/13 4:36 PM Page 25
Mine Water Treatment Plant uses Zero Liquid Waste Process to Improve Water Quality of Monongahela River Watershed
Veolia Water, a water and wastewater services and technologies com-
pany, has successfully commissioned and begun operational manage-
ment of the CONSOL Energy Inc. Northern West Virginia Water
Treatment Facility near Mannington, W.Va. The Zero Liquid Waste
(ZLW) facility designed and built by Veolia will treat 3,500 gallons
per minute of mine drainage. By employing a ZLW process, water of
low quality is extracted and treated, and clean water is returned to the
ecosystem, improving the water balance and condition of the
Monongahela River watershed.
Veolia will provide operational management of the facility for the
next 10 years, guaranteeing CONSOL continual performance and
optimization of the system. The ZLW treatment concept removes
contaminants in the mine water and reduces them to solid salts. The
process also uses a number of sustainable practices and technology
applications, reducing the carbon and energy footprint of the treat-
ment process.
This environmentally sustainable design and construction approach
was developed to help CONSOL meet discharge standards for chlo-
rides in West Virginia’s waterways. The facility will treat water from
CONSOL’s Blacksville #2, Loveridge and Robinson Run mining
operations.
“In partnering with Veolia on this first-of-its-kind in scale and scope
project, we were able to bring the water treatment plant online on
time, under budget, and in full compliance with our permits,” com-
mented Katharine Fredriksen, senior vice president environmental
strategy and regulatory affairs. “This demonstrates the success of
partnering with a company that shares our commitment to our core
values of Safety, Compliance, and Continuous Improvement.”
To quantify the benefits of the water treatment facility to the
Monongahela River, Veolia conducted a Water Impact Index (WIIX)
evaluation. Developed by Veolia, the WIIX measures not only water
volume, but the level of stress upon local water resources, overall
water quality and indirect water impacts from chemicals and electric-
ity. Measuring all these factors, the WIIX calculates the water impact
of the new treatment facility will be 1.3 billion gallons of high-quali-
ty water per year returned to the Monongahela River basin, validating
a positive environmental impact by the water treatment facility.
“Veolia is continually working to develop sustainable solutions to
meet the needs of our industrial customers while benefitting the envi-
ronment,” said Kirk Schwab, general manager of Veolia Water
Solutions & Technologies’ Pittsburgh office that designed and built
the facility. “We are pleased to deliver this state-of-the-art project for
CONSOL and believe that it will be the benchmark for mine water
treatment in the Appalachian region for years to come.”
Steve Hopper, executive vice president and chief operating officer for
Veolia Environnement North America’s Industrial business, said,
“The partnership with CONSOL goes beyond meeting new regulato-
ry requirements. It combines technical know-how with operational
expertise to implement a solution which positively impacts the envi-
ronment while meeting the production needs of CONSOL through
guaranteed performance.”
Veolia Water is the water division of Veolia Environnement.Veolia Water Solutions & Technologies is the Veolia Water sub-sidiary that specializes in technological solutions and design andbuild projects for water and wastewater treatment, serving industrialand municipal clients.www.veoliawaterst.com or www.veoliawaterstna.com
Circle 173 on Card
The high-quality water generated by CONSOL’s treatmentfacility will improve water quality in the Monongahela River.
C o m p l e t e l yRedesigned
Find all your equipment needs on our redesigned Online Buyer’s Guide...
www.PollutionEquipmentDirectory.com
PEN October 2013_PEN New Size 2012 10/29/13 10:49 AM Page 29
LEAR N MOR E: V IS IT CH E MSHOW.COM /VIS IT18 OR CALL 203.221.9232
See the latest products, systems, and solutions from 300+ exhibitors Meet product experts to increase efficiency and reduce energy costs Attend solutions-focused seminars at the AICHE Northeast Mfg. Conference
WHERE THE PROCESS INDUSTRIES COME TOGETHER to
INNOVATE, EXPLORE & GET INSPIRED
The 25th Anniversary Canadian Power Conference & Networking
Centre is the leading annual event spanning all technologies in the
power generation sector in Canada. It's where you need to be to tune
in and connect with the whole industry, from renewables to nuclear.
APPrO 2013 disseminates the information and unlocks discussion
and debate invaluable to informing your company's business deci-
sions and strategy.
The APPrO Conference is uniquely positioned to offer you top notch
speakers and session content, as well as designated opportunities to
connect and convene with your industry peers, while gathering valu-
able new contacts across the industry. APPrO is the destination event
for keeping abreast of the full range of power gen industry intelli-
gence.
Keynote Speakers:
• Bob Chiarelli, Ontario Minister of Energy
• Tim Hudak, Leader of the PC Party of Ontario
• Amir Shalaby, VP of Power System Planning, Ontario Power
Authority
• Bruce Campbell, President & CEO, IESO
• Heather Kleb, President & CEO, Canadian Nuclear Association
• Peter Hunt, Senior VP, Hill & Knowlton
Other notable speakers include:
• Adam Radwanski, Award-winning journalist from the Globe and
Mail, currently its Queens Park Columnist, in the APPrO Political
Issues Panel
• Peter Gregg, Chief Operating Officer, Hydro One, on his compa-
ny’s T&D development plans
• Steve Clark, Senior VP of Canadian and Eastern US pipelines,
TCPL, on the settlement agreement recently reached with the LDCs
• Michelle Branigan, CEO of EHRC, on ìSkill sets that power
companies need.
• Michael Nolan, AECOM's global leader in climate change adap-
tation, slated to speak on assessment and mitigation strategies for
electricity generators.
Program highlights:
• Fostering public engagement in the development and siting of new
generation projects
• Renewables Integration
• Financing issues at play in the current environment
• TransCanada PipeLines Mainline Tolls
• Nuclear industry developments
• Prospects for the next round of generation procurement
• Aboriginal and community-based power project development
• Transmission expansion and upgrading
• Distributed Generation and disruptive technology
.....and many more.
More information is available at
Circle 175 on Card
Circle 174 on Card
PEN October 2013_PEN New Size 2012 10/29/13 4:45 PM Page 30
Register to attend the Seattle meeting: http://www2.epa.gov/carbon-pollution-
standards/public-listening-session-registration
More information on these sessions: http://www2.epa.gov/carbon-pollution-stan-
dards/public-listening-sessions
Inquire Online at www.POLLUTIONEQUIPMENT.com32
SAVE THE DATE! Registration and housing open
2 December 2013.
The Iron & Steel Technology Conference and Exposition
5–7 May 2014
Explore AISTech.org for more details on attending and exhibiting.
USCC 22ndAnnual Conference& TradeshowCompost: Nature’sWay to Grow!January 26–29, 2014Oakland Marriott City CenterOakland, CA
Join us at the world’s largest conference and exhibition for the organics management industry.Hear industry leaders discuss meeting today’schallenges in composting, compost use andrenewable energy from organics.
Visit our tradeshow featuring over 100 exhibitors from every part of the industry. Choose from more than 80 speakersacross 3 days of workshops & technical sessions that coverorganics management from separation & collection throughmarketing & use. See “live” demonstrations of the latestequipment offerings at our expanded equipment show at the Redwood Landfi ll in Novato on January 29th.
More info & registration atwww.compostingcouncil.org | T. 301.897.2715Oa
klan
d 20
14
Circle 178 on Card
Circle 177 on Card
PEN October 2013_PEN New Size 2012 10/29/13 10:49 AM Page 32
6.Check the one item which best describes your primary business activity, or service performed at this location. (Check one only)
5.Check one job function most appropriate for your position. (Check one only)
3. For future renewals:May we e-mail you? q YES q No May we phone you? q YES q No May we fax you? q YES q No
o (5000) Municipal Water/Wastewater
o (5100) Industrial Water & Wastewater
o (5200) Manufacturing
o (5800) Oil/Gas
o (5300) Government: Local, State, National
o (5400) Utilities
o (5500) Research/Labs
o (5600) Contractors/Service Firms
o (4900) Manufacturer Representative
o (6000) Other__________________________
q Yes
(please specify)
q (A)Water/Wastewater
q (B)Air/Emissions
q (C)Water Quality
q (D)Environmental Remediation
q (E)Gas Detection
q (F)Groundwater
q (G)Stormwater
q (H)Solid Waste
q (I)Hazardous Waste
7.I am responsible for operation, maintenance, installation, selection and/or buying supplies and services for any of the following. (If more than one applies, check all that apply)
FREE PRODUCT INFORMATION www.pollutionequipment.com
Please fax back this form to 412-369-9720 or go to http://pen.hotims.com
Scan the QR codeabove with your phoneQR reader and selectthe correct issue for
more free product infor-mation.
1. Do you wish to receive/continue to receive Pollution Equipment News FREE? q No
2. Which version would you prefer? q Digital (e-mail required) ____________________________________________q Print (U.S. only)
Would you like to receive the PEN E-newsletter via e-mail? q YES q NoBy providing your email address and signature on this form you are agreeing to receive from Rimbach Publishing Inc., emails pertaining to subscriptionrenewals, and/or additional product advertising information. If you do not wish to receive business related 3rd party email offers please check here. q Name (print) First________________________________________Last____________________________________________Title______________________________________________________Company_____________________________________Address_______________________________________________________________________________________________Address__________________________________________________________City__________________________________State or Province _____________Zip (Postal Code) __________________________ Country___________________________ Telephone Number ______________________________________________FAX Number _____________________________Email________________________________________________________________________________________________
4.Signature(required)_________________________________________________________Today’s Date m_______d_________y_________
PEN October 2013_PEN New Size 2012 10/29/13 10:49 AM Page 33
Extent and Nature of Circulation Average No. Copies Each Issue During Preceding 12 Months
No. Copies of Single Issue Published Nearest to Filing Date
13. Publication Title
15.
14. Issue Date for Circulation Data Below
Pollution Equipment News August 2013
a. Total Number of Copies (Net press run)
In-County Paid/Requested Mail Subscriptions stated on PS Form 3541. (Include direct written request from recipient, telemarketing, and Internet re-quests from recipient, paid subscriptions including nominal rate subscriptions, employer requests, advertiser’s proof copies, and exchange copies.)
d. Nonre- quested Distribution (By Mail and Outside the Mail)
b. Legitimate Paid and/or Requested Distribution (By Mail and Outside the Mail)
c. Total Paid and/or Requested Circulation (Sum of 15b (1), (2), (3), and (4))
Outside County Paid/Requested Mail Subscriptions stated on PS Form 3541. (Include direct written request from recipient, telemarketing, and Internet re-quests from recipient, paid subscriptions including nominal rate subscriptions, employer requests, advertiser’s proof copies, and exchange copies.)
(1)
(2)
(4) Requested Copies Distributed by Other Mail Classes Through the USPS (e.g., First-Class Mail®)
Sales Through Dealers and Carriers, Street Vendors, Counter Sales, and Other Paid or Requested Distribution Outside USPS® (3)
Nonrequested Copies Distributed Outside the Mail (Include Pickup Stands, Trade Shows, Showrooms, and Other Sources) (4)
(1)Outside County Nonrequested Copies Stated on PS Form 3541 (in-clude Sample copies, Requests Over 3 years old, Requests induced by a Premium, Bulk Sales and Requests including Association Requests, Names obtained from Business Directories, Lists, and other sources)
(2)In-County Nonrequested Copies Stated on PS Form 3541 (include Sample copies, Requests Over 3 years old, Requests induced by a Premium, Bulk Sales and Requests including Association Requests, Names obtained from Business Directories, Lists, and other sources)
(3)Nonrequested Copies Distributed Through the USPS by Other Classes of Mail (e.g., First-Class Mail, Nonrequestor Copies mailed in excess of 10% Limit mailed at Standard Mail® or Package Services Rates)
67,990 67,895
52,287 44,739
2,244 2,220
54,531 46,959
Total Distribution (Sum of 15c and e)f.
Total Nonrequested Distribution (Sum of 15d (1), (2), (3) and (4))e.
Copies not Distributed (See Instructions to Publishers #4, (page #3))g.
Total (Sum of 15f and g)h.
Percent Paid and/or Requested Circulation (15c divided by f times 100)
i.
16. Total circulation includes electronic copies. Report circulation on PS Form 3526-X worksheet.
18. Signature and Title of Editor, Publisher, Business Manager, or Owner Date
I certify that all information furnished on this form is true and complete. I understand that anyone who furnishes false or misleading information on this form or who omits material or information requested on the form may be subject to criminal sanctions (including fines and imprisonment) and/or civil sanctions (including civil penalties).
17. Publication of Statement of Ownership for a Requester Publication is required and will be printed in the issue of this publication.
October 2013
10-30-13
12,357 19,898
425 750
12,782 20,648
67,313 67,607
677 28867,990 67,895
81% 69%
Inquire Online at www.POLLUTIONEQUIPMENT.com34
Association for Iron & Steel Technology www.aist.org ......................32Analytical Technology Inc www.analyticaltechnology.com ............36Arizona Instrument LLC www.azic.com ..............................................6Arjay Engineering www.arjayeng.com ............................................17ChemShow 2013 www.chemshow.com/visit18 ..............................30ClearSpan Fabric Structures www.clearspan.com/adpen ..............35Collins Instrument Co Inc www.collinsinst.com ..................................9The Dian Fossey Gorilla Fund Intl www.gorillafund.org ......................4E-Instruments International www.e-inst.com ....................................17Environmental Devices Corp www.environmentaldevices.com......35Halogen Valve Systems Inc www.halogenvalve.com........................8Keller America www.kelleramerica.com............................................5Koby Environmental www.torquerplugs.com ..................................35Lantec Products Inc www.lantecp.com ..........................................12Litchfield International www.litchfieldinternational.com ..................35Lufft USA www.lufft.com ....................................................................4Oil Skimmers Inc www.oilskim.com..................................................11PITTCON 2014 www.pittcon.org ......................................................31Pulsar Process Measurement Inc www.pulsar-pm.com ....................9Qwater Well Developer www.welldeveloper.com ............................35Sierra Monitor Corp www.sierramonitor.com......................................7Solinst Canada Ltd www.solinst.com ................................................2US Composting Council www.compostingcouncil.org....................32Vanton Pump & Equipment Corp www.vanton.com ........................3Water Wizard/Envtl Services www.conserve-on-water.com ..............35Wayne Products Inc www.wayneproducts.com ..............................35
This index is published as a service. Every care is taken to make it accu-rate, but Pollution Equipment News assumes no responsibility for errors or omissions.
National Groundwater Association Expo
December 3-6, 2013
Nashville, TN
www.ngwa.org
ChemShow 2013
December 10-12, 2013
New York, NY
www.chemshow.com
2014 Winter Conference on Plasma Spectrochemistry
January 6-11, 2014
Amelia Island, FL
http://icpinformation.org
11th Everything About Water Expo 2014
January 7-9, 2014
Delhi INDIA
www.ewgroup.in
Zero Waste Management Summit
January 19-20, 2014
Muscat, Oman
www.nispana.com
EcoWaste and WFES (World Future Energy Summit) and Intl.
Water Summit
January 20-22, 2014
Adu Dhabi UAE
www.internationalwatersummit.com
22nd Annual USCC Conference and Trade Show (US Composting
Council)
January 26-29, 2014
Oakland, CA
http://compostingcouncil.org/conference
For a complete list of tradeshows, visit
www.pollutionequipment.com
Statement of Ownership, Management, and Circulation (Requester Publications Only)
1. Publication Title 2. Publication Number 3. Filing Date
4. Issue Frequency 5. Number of Issues Published Annually 6. Annual Subscription Price (if any)
8. Complete Mailing Address of Headquarters or General Business Office of Publisher (Not printer)
9. Full Names and Complete Mailing Addresses of Publisher, Editor, and Managing Editor (Do not leave blank)Publisher (Name and complete mailing address)
Editor (Name and complete mailing address)
Managing Editor (Name and complete mailing address)
10. Owner (Do not leave blank. If the publication is owned by a corporation, give the name and address of the corporation immediately followed by the names and addresses of all stockholders owning or holding 1 percent or more of the total amount of stock. If not owned by a corporation, give the names and addresses of the individual owners. If owned by a partnership or other unincorporated firm, give its name and address as well as those of each individual owner. If the publication is published by a nonprofit organization, give its name and address.)
11. Known Bondholders, Mortgagees, and Other Security Holders Owning or Holding 1 Percent or More of Total Amount of Bonds, Mortgages, or Other Securities. If none, check box
PS Form 3526-R, August 2012 (Page 1 of 3 (Instructions Page 3)) PSN: 7530-09-000-8855
None
7. Complete Mailing Address of Known Office of Publication (Not printer) (Street, city, county, state, and ZIP+4®)
_
Contact PersonRaquel Rimbach
412-364-5366
Telephone (Include area code)
Full Name Complete Mailing Address
Complete Mailing AddressFull Name
12. Tax Status (For completion by nonprofit organizations authorized to mail at nonprofit rates) (Check one)
Has Not Changed During Preceding 12 MonthsHas Changed During Preceding 12 Months (Publisher must submit explanation of change with this statement)
The purpose, function, and nonprofit status of this organization and the exempt status for federal income tax purposes:
PRIVACY NOTICE: See our privacy policy on www.usps.com.
Pollution Equipment News 0 3 4 9 7 5 0 10-30-2013
6x 6
8650 Babcock Blvd., Pittsburgh PA 15237
8650 Babcock Blvd., Pittsburgh PA 15237
Norberta Rimbach 8650 Babcock Blvd., Pittsburgh PA 15237
Raquel Rimbach 8650 Babcock Blvd., Pittsburgh PA 15237
Raquel Rimbach 8650 Babcock Blvd., Pittsburgh PA 15237
Rimbach Publishing Inc
Norberta Rimbach
Raquel Rimbach
Renee Rimbach
8650 Babcock Blvd Pittsburgh PA 15237
8650 Babcock Blvd Pittsburgh PA 15237
8650 Babcock Blvd Pittsburgh PA 15237
8650 Babcock Blvd Pittsburgh PA 15237
PEN October 2013_PEN New Size 2012 10/30/13 10:11 AM Page 34
The Q46CT Monitor employs an inductive (toroidal) sensor that allows measurement in difficult samples with virtually no maintenance. The toroidal sensor is a molded assembly made from Noryl, an engineering thermoplastic with excellent resistance to both strong acids and strong bases.
FEATURESGood Performance in Dirty ApplicationsMultiple Monitoring ConfigurationsEasy Calibration
Proven Measurement Approach
The Q46N uses relative chemistry that converts ammonia in solutions to a stable monochloramine compound equivalent in concentration to the original ammonia level. The measurement is then made with a proven amperometric sensor.
FEATURESNew Approach to On-Line Ammonia MeasurementTotal Ammonia MeasurementOptional Free and Monochloramine Measurement
Internal Data Logger
Model D12 Gas Transmitters provide the ultimate in application flexibility.Loop-powered or 3-wire models with on-board relays are available, as are both combustible gas and universal toxic gas versions. Digital communication using HartTM or ModbusTM protocols are available.
PortaSens II C16 Detector provide a flexible tool for locating the source of toxic gas leaks from storage cylinders, process machinery, gas generation equipment or piping systems. Smart interchangeable sensors allow one instrument to be used for a variety of gas detection requirements. Data-logger come standard.
FEATURESInterchangeable “Smart Sensors” for Over 30 GasesInternal Sample Pump and External Sampling WandOne-hand Pistol Grip Design
Reliable D.O. measurement
FEATURESThe Q-Blast package includes the monitor and the cleaner air supply which are factory assembled for easy installationChoice of using either optical or galvanic membraned sensorsPower Options include Universal 100-240 VAC or 12-24 VDC
ATI's Sulfite Monitor Features:
Sulfite ion is measured selectively by conversion to sulfur dioxide.
Measurement is made without contact between sample and sensor, eliminating the potential for sensor fouling.
Power options include 115 or 230 VAC, 50/60 Hz.
Relays are programmable for setpoint, deadband, and time delay.
Internal sequencing and relay system for automated sample line cleaning.
Communication options for Profibus-DP, Modbus-RTU, or Ethernet-IP.
Amperometric Measurement
The Q46H/79 provides highly accurate measurement of total residual chlorine down into the parts per billion range. Total Chlorine is measured using EPA recommended method for reaction of the sample with buffer and KI.
FEATURESDirect Reading Membraned Amperometric Idodine SensorHigh Accuracy and Sensitivity Down to PPB2-Assignable 4-20 mA Outputs for Chlorine, Temp or PID
A Gas-Phase Approach to Sulfite Measurement
Keep Chemical Costs Under ControlATI’s Model - Q46S/66 Sulfite MonitorThe Q46S/66 Sulfite Monitor takes a unique approach to the measurement, employing a unique gas phase method to continuously monitor sulfite values without contact between the sensor and the water sample.
The Q-Blast System with reliable D.O. measurement uses either optical or membrane sensors. The Q-Blast D.O. System is ideal for aeration control systems, resulting in improved process performance and energy savings!
Circle 190 on Card Circle 194 on CardCircle 195 on Card
Circle 191 on Card
Circle 192 on Card
Circle 193 on Card
Circle 196 on Card
Circle 197 on Card
PEN October 2013_PEN New Size 2012 10/29/13 4:46 PM Page 36