253 OUTBOARD OUTBOARD OUTBOARD OUTBOARD OUTBOARD MERCURY/MARINER Ignition/Electrical Systems MP41070 IGNITION SWITCH Push to Choke — 3 Position — 6 Wire Sealed Polyester Replaces: 87-17009A2, 87-17009A5 MP41000 AP# 1948 IGNITION SWITCH Push to Choke — 3 Position — 6 Terminal Replaces: 87-88107, A5 18-5511 WIRING HARNESS Replaces: 84-822253A20, 45876-20, 84-822253T20 18-6763 TRIM & TILT MOTOR Replaces: 92975A28, A32 To 1984 for Most Mercury Outboards (Motor and Reservoir Only) 18-5101 AP# 13347 MAGNATUNE TM IGNITION KIT For 2 Cylinder Outboards —CONTAINS— Two Magnatune TM Ignition Modules solid state electronic replacement for mechanical contact sets and condensers in Mercury outboards with dual point magneto systems. In- cludes installation instructions and necessary hardware. Not for engines with charging systems. 18-6773 AP# 3118 TRIM MOTOR Replaces: 828708, 878265A4 For most late model Mercury/Mariner 1996 & UP (135,150, XR6 Mag III, 175, 200, 225, 250 HP — 105 - 140 HP Jet 18-6784 TRIM MOTOR Replaces: Mercury Assembly 824051 2 wire motor with conversion kit including harness & relays. For: Single ram 3-wire systems 18-6251 OUTBOARD STARTER REPAIR KIT Prestolite 4 Brush 18-6250 OUTBOARD STARTER REPAIR KIT Prestolite 2 Brush 18-6778 RESERVOIR Replaces: 88316A1 For: Motors with 4 screw attachments 18-6774 TRIM MOTOR Replaces: 811628, 828708A1, 878265A6 High-performance cartridge, replaceable motor. Design1, Ram 3, 3 wire, tilt/trim units. Squared style Eaton, round-style Prestolite 18-6771 TRIM & TILT RESERVOIR Replaces: 18525A1 18-6273 Tilt/Trim Assembly High Performance Cartridge Pump w/Replaceable Motor Replaces: 99186, 99186-1, 99186-T Fits : 35-220 HP Mercury/Mariner Outboards w/ Design I, 3 Ram, # Wire Tilt/Trim Units w/ Side Fill Reservoir. Square style Eaton: Round style Prestolite b 18-5107-1 IGNITION MODULE Replaces: 811637001 For: 3.0 (1999 & up), 4.3 (1999), 5.7 (1997-01) 500 (1999-02), 7.4 (1998-00)
12
Embed
MERCURY/MARINER · TRIM & TILT MOTOR Replaces: 92975A28, A32 To 1984 for Most Mercury Outboards (Motor and Reservoir Only) 18-5101 ... of the necessary related components to complete
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
253
OUTBOARDOUTBOARDOUTBOARDOUTBOARDOUTBOARD
MERCURY/MARINERIgnition/Electrical Systems
MP41070IGNITION SWITCH
Push to Choke — 3 Position — 6 Wire Sealed Polyester
Replaces: 87-17009A2, 87-17009A5
MP41000AP# 1948
IGNITION SWITCHPush to Choke — 3 Position — 6 Terminal
Replaces: 87-88107, A5
18-5511WIRING HARNESS
Replaces: 84-822253A20,45876-20, 84-822253T20
18-6763TRIM & TILT MOTOR
Replaces: 92975A28, A32To 1984 for Most Mercury Outboards
(Motor and Reservoir Only)
18-5101AP# 13347
MAGNATUNETM IGNITION KITFor 2 Cylinder Outboards
—CONTAINS—Two MagnatuneTM Ignition Modules solid state electronicreplacement for mechanical contact sets and condensers inMercury outboards with dual point magneto systems. In-cludes installation instructions and necessary hardware. Notfor engines with charging systems.
18-6773AP# 3118
TRIM MOTORReplaces: 828708, 878265A4
For most late model Mercury/Mariner1996 & UP (135,150, XR6 Mag III,
175, 200, 225, 250 HP — 105 - 140 HP Jet
18-6784TRIM MOTOR
Replaces: MercuryAssembly 824051
2 wire motor with conversion kitincluding harness & relays.
For: Single ram 3-wire systems
18-6251OUTBOARD STARTER
REPAIR KITPrestolite4 Brush
18-6250OUTBOARD STARTER REPAIR KIT
Prestolite2 Brush
18-6778RESERVOIR
Replaces: 88316A1For: Motors with 4 screw attachments
High Performance CartridgePump w/Replaceable MotorReplaces: 99186, 99186-1,
99186-TFits : 35-220 HP Mercury/Mariner
Outboards w/ Design I, 3 Ram, # WireTilt/Trim Units w/ Side Fill Reservoir.
Square style Eaton: Round style Prestolite
b
18-5107-1IGNITION MODULEReplaces: 811637001
For: 3.0 (1999 & up), 4.3 (1999), 5.7 (1997-01)
500 (1999-02), 7.4 (1998-00)
254
OUTBOARD
OUTBOARD
OUTBOARD
OUTBOARD
OUTBOARD
Part No. Size Color Gauge
BATTERY CABLESGauge Cable with soldered lug terminals on each end to accept a 3/8" stud.
18-9801MULTI METER/DVA TESTERReplaces: 91-99750A1A must for testing Mercury ignition systems.
18-9802TIMING LIGHTReplaces: 91-99379Self-powered accurate up to 10,000 RPM‘s.
18-9800COMPRESSION TESTER
Perfect for hard to reach bottom spark plug holes on older Mercury models.
BC88523 2' red 4BC88533 2' black 4BC88543 4' red 2BC88553 4' black 2
BC88563 6' red 2BC88573 6' black 2BC88583 8' red 1BC88593 8' black 1
Part No. Size Color Gauge
18-6775TRIM & TILT MOTORReference OE reservoir 811673 1Contains: All parts necessary, a new 3- wiremotor/reservoir, drive shaft coupler, oil seal,O-ring and hardware.For:
If you have this 3-wire single ramsystem, use 18-6775
Models60 3-Cyl., Bigfoot65 Jet75 3-Cyl.75 4-Stroke80 Jet90 3-Cyl.90 4-Stroke100 4-Cyl.115 4-Cyl.125 4-Cyl.If you have any of the 2-wire single systems, use 18-6777
MERCURY/MARINERIgnition/Electrical Systems
255
OUTBOARDOUTBOARDOUTBOARDOUTBOARDOUTBOARD
18-5863STATOR & KITReplaces: 86617A17For: 15-25 HP
18-5865STATOR & KITReplaces: 398-5704A7For: 50-70 HP
Features…Features…Features…Features…Features…★ Fully encapsulated windings (where applicable) for better reliability.★ Engine specific products, unlike competitors, that offer “universal kits”
that require modifications. Sierra offers precision parts for professional repairs.★ Red Stator Kits are a Sierra exclusive in the aftermarket and come with all
of the necessary related components to complete the job right the first time.★ Precise lead lengths eliminate the concern of excess wire getting in the way of moving parts.★ Best warranty in the industry.
18-5864STATOR & KIT
Replaces: 86617A20For: 6-25 HP
APPLICATION BEGINS ON PAGE 256
MERCURY/MARINER
256
OUTBOARD
OUTBOARD
OUTBOARD
OUTBOARD
OUTBOARD
MERCURY/MARINERElectrical System
APPLICATION ON NEXT PAGE
18-5854AP# 13409STATOR
Replaces: 398-5454A17
18-5855AP# 13410STATOR
Replaces: 336-3996A7
18-5856AP# 13411STATOR
Replaces: 398-5255
18-5857AP# 13412STATOR
Replaces: 398-5454A7
18-5859AP# 13413STATOR
Replaces: 398-5454A26
18-5860AP# 13414STATOR
Replaces: 398-5454A35
18-5876STATOR
Replaces: 398-9610A19For: 135 -200 HP
18-5871STATOR & KIT
Replaces: 398-5454A32For: 135-300 V6
18-5873STATOR & KIT
Replaces:398-832075A6For: 100, 115, 125 HP
18-5874STATOR & KIT
Replaces: 398-832075A14For: 30-50 HP
18-5875STATOR & KIT
Replaces: 398-9610A5For: 135-200 HP
257
OUTBOARDOUTBOARDOUTBOARDOUTBOARDOUTBOARD
STATOR & TRIGGER APPLICATIONS
18-5798TRIGGER
Replaces: 96455A9For: 6 cyl.
18-5795TRIGGERReplaces: 96455A11For: 90-220 HP 1979-92, 135-220 HP 1993-97
18-5796TRIGGER
Replaces: 96455A15For: 6 cyl.
Features…Features…Features…Features…Features…★ Pick-up coils are potted under vacuum to eliminate air
pockets in the potting material.★ Our triggers are designed for each specific engine
to assure peak performance and easy installation.★ Diagnostics are performed to OEM specifications for easy testing and troubleshooting.
Starter Power Trim Power TrimHP Beg. S/N End. S/N Solenoid Solenoid Relay
SOLENOID APPLICATION (Cont.)
➀ Use 18-5817/AP# 2718 for applications with circuit breaker and fuse.➁ For units with 8-32, 1\4-20 terminals.➂ For units with 10-32, 5\16-18 terminals.
➃ Use 18-5818 if off white solenoid is needed.➄ For design II applications use 18-5820.➅ w/rubber bushing solenoid
Starter Power Trim Power TrimHP Beg. S/N End. S/N Solenoid Solenoid Relay
SOLENOID APPLICATION (Cont.)
➀ Use 18-5817/AP# 2718 for applications with circuit breaker and fuse.➁ For units with 8-32, 1\4-20 terminals.➂ For units with 10-32, 5\16-18 terminals.
➃ Use 18-5818 if off white solenoid is needed.➄ For design II applications use 18-5820.➅ w/rubber bushing solenoid