Maxima_1300_MT_Parts_13_07_10

500 Carrier service stationsin Europe, Russia,

Middle East and Africa

© Carrier Corporation - Carrier Transicold Europe S.C.S. au cap i tal de 16 090 700 euros - R.C.S. Pontoise B 410 041 776 - Code APE 518 MVAT: FR52410041776 - The infor ma tion con tained in this doc u ment is not con trac tu al ly bind ing, and may not be repro duced with out pri or approv al. Printed in France (05/08) 62-61171-04

10

20

2595100

15.115.120

9780

25

30

MAXIMA 1000 / 1300 / 1300Mt°SPARE PARTS MANUAL

Carrier Transicold Europe S.C.S.L' Européen Bâtiment D4, rue Joseph Monier92500 Rueil-MalmaisonPhone: +33 (0)1 41 42 28 00Fax: +33 (0)1 41 42 28 28www.carrier-transicold-europe.com

Carrier Transicold Europe - L’ Européen Bâtiment D - 4, rue Joseph Monier92500 Rueil-Malmaison- FRANCE

© Carrier Refrigeration Operation 2010 - Imprimé en France 07-10

Carrier Transicold Division, Carrier Corporation, P.O. Box 4805, Syracuse, N.Y. 13221

62--61171--04

Service Parts ListMAXIMA 1000 Starting with S/N MB403109

MAXIMA 1300 / 1300 Mt_CONTENTS

Introduction iii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Ordering Instruction iii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .General Notes iii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Recommendation List xii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Preconisation List “M” xv. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Preconisation List “C” xvi. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Preconisation List “S” xvii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1. Frame and Skin Kit ( Front and Bottom ) 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2. Frame and Skin Kit ( Sides and Rear ) 4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3. Refrigeration kit 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4.1. Condenser kit ( Lower ) 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4.2. Condenser kit ( Upper ) 10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4.3. Ventilation box assy Prior To Serial Number MB820030 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4.4. Ventilation box assy Starting With Serial Number MB820030 14. . . . . . . . . . . . . . . . . . . . . . . . . .5.1 Evaporator kit ( Maxima 1000 / 1300 ) 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5.2 Evaporator kit ( Maxima 1300Mt_ ) 20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6. Accumulator kit 26. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7. Drive kit 28. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7.1 Belt 32. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8. Alternator kit 34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9. Fuel system kit 36. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10. Oil system kit 38. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11.1 Coolant kit: Standby 40. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11.2 Coolant kit: No standby 42. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12. Air cleaner kit 43. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13.1. Exhaust kit: Standard Version Prior to Serial Number MB922000 44. . . . . . . . . . . . . . . . . . . . .13.2. Exhaust kit: Standard Version Between Serial Number MB922000 & MC022083

All Other Versions Prior to Serial Number MC022083 45. . . . . . . . . . . . . . . . . . . . .13.3. Exhaust kit: Standard Version Starting with Serial Number MC022083

All Other Versions Starting With Serial Number MC022083 46. . . . . . . . . . . . . . . .14.1 Electrical kit ( Maxima 1000 ) 48. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14.2 Electrical kit ( Maxima 1300 / 1300Mt_ ) 50. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14.3 Control box Prior To Serial Number MB651006 ( Maxima 1000 / 1300 ) 52. . . . . . . . . . . . . .14.4 Control box Starting With Serial Number MB651006 ( Maxima 1000 / 1300 ) 56. . . . . . . . .14.5 Control box ( Maxima 1300Mt_ ) 60. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14.6 Harness, engine ( Maxima 1000 / 1300 ) 68. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14.7 Harness, engine ( Maxima 1300Mt_ ) 70. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14.8 Display assy 72. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15. Battery kit 74. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16. Decals kit 75. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17. Service Tools 78. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18. Mounting kit 79. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

MAXIMA 1000 starting with S/N MB 403109MAXIMA 1300 / 1300Mt_

ii

MODEL CHARTS

Type Part No. Refrigerant Engine Compressor

MAXIMA 1000 -- R -- Diesel only -- without tank -- withoutbulkhead 8002293

MAXIMA 1000 -- R -- Diesel only -- without tank -- withbulkhead ( factory installed ) 800229305161

MAXIMA 1000 -- S -- Diesel / electric -- phase detector --without tank -- without bulkhead 8002294

MAXIMA 1000 -- S -- Diesel / electric -- phase detector --without tank -- with bulkhead ( factory installed ) 800229405161

MAXIMA 1000 -- T -- Diesel / electric -- automatic phasereversal -- SAS -- without tank -- without bulkhead 8002295

MAXIMA 1000 -- T -- Diesel / electric -- automatic phasereversal -- SAS -- without tank -- with bulkhead ( factoryinstalled )

800229505161

MAXIMA 1300 -- R -- Diesel only -- without tank 8002296 R404a CT 4-91 TV 05 K4

MAXIMA 1300 -- R -- Diesel only -- without tank -- LowNoise 8002354

MAXIMA 1300 -- S -- Diesel / electric -- phase detector --without tank 8002297

MAXIMA 1300 -- S -- Diesel / electric -- phase detector --without tank -- Low Noise 8002355

MAXIMA 1300 -- T -- Diesel / electric -- automatic phasereversal -- SAS -- without tank 8002298

MAXIMA 1300 -- T -- Diesel / electric -- automatic phasereversal -- SAS -- without tank -- Low Noise 8002299

MAXIMA 1300Mt_ -- 2CPTS -- Diesel / electric --

phase detector -- without tank8002356

MAXIMA 1000 STARTING WITH SERIAL NUMBER MB403109

MAXIMA 1300 STARTING WITH SERIAL NUMBER MB403038

MAXIMA 1300Mt_ STARTING WITH SERIAL NUMBER MB426037


iii

INTRODUCTION

This parts lists identifies service replacement parts for the CARRIER TRANSICOLD MAXIMA 1000 Starting withS/N MB403109 / MAXIMA 1300 / 1300Mt_ refrigeration units. This unit is designed for medium temperature cooling,heating and defrost for truck application.

Detailed parts idnetification for these items may be found in the applicable parts lists.

ORDERING INSTRUCTION

All orders and inquiries for parts must include:

D Unit Serial Number D Part No.

D Description of part as shown on list D Quantity required

Address all correspondence for parts to the following address according to your living area.

You live in: EUROPE (East/West) C.T.E.AFRICA - MIDDLE EAST

AMERICA (North/Middle/South)N.A.O.

Address your orders to: CARRIER TRANSICOLD EUROPEL’ Européen Bâtiment D4, Rue Joseph Monier92500 Rueil---MalmaisonPhone : (33).1.41.42.28.00Fax : (33).1.41.42.28.28

CARRIER TRANSICOLD DivisionReplacement Components GroupTR-20P.O. Box 4805, Syracuse, NY 13221orFax to : (315) 432.3778

GENERAL NOTES

To find replacement parts, determine major group in which replacement part is located, consult table of con-tents for thye appropriate page for the illustrated breakdown of the replacement part.

The following letter designations are used to classify parts throughout this list.

A/R As Required. NSS Not Sold Separately - order next higherassembly or kit.

NLO No Longer Offered. PL Purchase Locally.

NS Not Shown in the illustration. SST Stainless Steel -300 Series unless otherwise specified.

NSA Non-Stock Assembly - order componentslisted under the assembly

SV - SK Suffix SV - SK added to part number refersto a spare parts kit.

NSI Non-Stock - may be available on specialorder

PL* Purchase locally. May be obtained underspecific conditions ( Multipack, delivery date,price...)


iv

INTRODUCTION

Ce manuel pièces de rechange rassemble toutes les pièces détachées du groupe CARRIER TRANSICOLDMAXIMA 1000 Starting with S/N MB403109 / MAXIMA 1300 / 1300Mt_. Ce groupe a été développé pour des applica-tions de réfrigération, chauffage et dégivrage des caisses frigorifiques.

Le détail des Pièces pour les moteurs et les compresseurs est à rechercher dans le manuel de pièces derechanges spécifique à ces éléments.

INSTRUCTION DE COMMANDE

Toutes les commandes et demandes de pièces détachées devront comporter :

D le N˚ de série du groupe D le N˚ de code

D la désignation de la pièce et son repère sur la planche D la quantité demandée

Adresser toute correspondance à l’adresse suivante suivant votre lieu de résidence.

Vous habitez : EUROPE (Est/Ouest) C.T.E.AFRIQUE - MOYEN ORIENT

AMERIQUE (Nord/Centre/Sud) N.A.O.

Adressez voscommandes à :

CARRIER TRANSICOLD EUROPEL’ Européen Bâtiment D4, Rue Joseph Monier92500 Rueil---MalmaisonPhone : (33).1.41.42.28.00Fax : (33).1.41.42.28.28


NOTES GENERALES

Pour trouver la pièce de rechange, déterminer l’ensemble principal dans lequel se trouve la pièce, consulter latable des matières pour trouver la page appropriée qui illustre l’ensemble contenant la pièce.

Les lettres suivantes sont utilisées pour classifier les pièces dans le manuel.

A/R Comme demandé. NSS Non vendu séparément. Commanderl’ensemble qui inclut la pièce

NLO Arrêté. PL A acheter localement.

NS Non représenté sur la vue. SST Acier InoxInox série 300 si non spécifié.

NSA Non stocké assemblé. Commander lescomposants listés sous l’ensemble

SV - SK Le suffixe SV SK ajouté au N˚ de codedésigne un kit de pièces de rechange.

NSI Non stocké. Peut être obtenu sur comman-de.spéciale

PL* A acheter localement. Peut être obtenu souscertaines conditions (Multipack, délai delivraison, prix...)


v

EINFÜHRUNG

Vorliegendes Erzatzteilhandbuch schlieβt alle in dem CARRIER TRANSICOLD Aggregat MAXIMA 1000 Startingwith S/N MB403109 / MAXIMA 1300 / 1300Mt_ enthaltenen Ersatzteile ein. Dieses Aggregat wurde Kühlen, Heizenund Abtau von Kälteaufbauten entwickelt.

Die Einzelheiten für die Ersatzteile der Motoren und Kompressoren sind den für diese Komprenenten spezifischausgearbeiten Ersatzteilhandbüchern zu entnehmen.

BESTELLANWEISUNG

Bei Bestellungen und Anfragen für Ersatzteile sind folgende Angaben zu machen:

D Serien N˚ des Gerätes D Kodenummer

D Die Bezeichnung des Teiles und sein Kennzeichen auf der Explosionszeichnung D Die gewünschte Menge

Richten Sie bitte Ihre Korrespondenz an folgende Adresse, je nach Ihrem Standort:

Ihr Standort EUROPA (Ost/West) C.T.E.AFRIKA - MITTL. OSTEN

Nord/Zentral/Südamerika N.A.O.

Richten Sie bitteIhre Bestellungen an :



ALLGEMEINES

Um das Ersatzteil zu finden, st das Haptbestandteil, in welchem dieses Teil sich befindet, zu bestimmen.Hierzu ist das Inhaltsverzeichnis vorzunehmen, um die entsprechende Seite mit der Explosionszeichnung zu fin-den.

Folgende Buchstaben werden zur Klassifizierung der Teile im Handbuch verwendet:

A/R Je nach Anfrage. NSS Nicht separat lieferbar. Bestellen Sie bitte diekomplette Einheit, die dieses Teil enthält.

NLO Nicht mehr lieferbar. PL Lokal kaufen.

NS Nicht auf der Zeichnung dargestellt. SST Rostfreier Stahl (Inoxserie 300, falls nichtanders spezifiziert).

NSA Nicht als Montagesatz gelagert. Bestellen Siedie Bestandeteile gemäß der detaillierten Liste.

SV-SK Das Suffix SV SK nach der Kodenummerkennzeichnet einen Erzatzteilkit.

NSI Nicht gelagert. Kann auf spezielle Bestellunggeliefert werden.

PL* Lokal kaufen. Bei Bestellung über Carrier istdieser Artikel nur in Verpackungseinheiten lief-erbar. (Lieferzeit und Preis bitte anfragen)


vi

INTODUCCIÓN

Este manual de recambios reune todas las piezas de recambio de los equipos CARRIER TRANSICOLDMAXIMA 1000 Starting with S/N MB403109 / MAXIMA 1300 / 1300Mt_. Este equipo se ha creado para aplicacionestales como la refrigeración, la calefacción y el descarche de las cajas frigorificas.

La descripción de los recambios para motores y compresores debe buscarse en el manual de recambios especi-fico para estos elementos.

INSTRUCCIÓNES PARA HACER UN PEDICO

En todos los pedidos de recambios habrá que especificar :

D el número de serie del equipo D el número de código

D el nombre de la pieza y su lugar en la tabla D la cantidad pedida

Enviar la correspondencia a la dirección siguiente segun el lugar de residencia.

Vd Vive en : EUROPA (Este/Oeste) C.T.E.AFRICA - Y MEDIO ORIENTE

AMERICA (Norte/Central/Súr) N.A.O.

Dirigir los pedidos a : CARRIER TRANSICOLD EUROPEL’ Européen Bâtiment D4, Rue Joseph Monier92500 Rueil---MalmaisonPhone : (33).1.41.42.28.00Fax : (33).1.41.42.28.28


NOTAS GENERALES

Para localizar el recambio, hay que determinar el conjunto principal al cual pertenece la pieza, consultar elindice para localizar la página correcta que ilustra el conjunto que incluye el recambio.

Las letras siguientes se utilizan para clasificar los recambios en el manual :

A/R Según pedido. NSS No se vende por separado. Pedir el conjuntoincluye la pieza.

NLO Fin de fabricación. PL Compra local.

NS No está representado en el dibujo. SST Acero Inoxidable -Inox Seria 300 si no se especifica.

NSA No se almacena montado. Pedir loscomponentes listados debajo del conjunto.

SV-SK El sufijo SV-SK añadido al n˚ de códigodesigna un kit de piezas de recambios.

NSI No existe en stock. Puede conseguirse con unpedido especial.

PL* Compras locales. Se pueden conseguir concondiciones especiales (Multipack, plazo deentrega, precio...)


vii

INTRODUZIONE

Questo manuale - parti di ricambio - raggruppa tutti i ricambi dei gruppi CARRIER TRANSICOLD MAXIMA 1000Starting with S/N MB403109 / MAXIMA 1300 / 1300Mt_ : si tratta di un gruppo le cui applicasioni comprendono la refrig-erazione, il riscaldamento e lo sbrinamento delle casse frigorifere.

Per questi ultimi é necessario consultare il manuale delle parti di ricambio specifico.

ISTRUZIONI PER LA COMPILAZIONE DELL’ORDINE

Tutti gli ordini e le richieste di parti di ricambio dovranno comprendere :

D il N˚ matricola del gruppo D il N˚ di codice

D la designazione del pezzo e il suo riferimento sull’esploso D la quantità richiesta

Indirizzare la corrispondenza all’indirizzo seguente, secondo il vostro luogo di residenza.

Voi abitate : EUROPA (Est/Ouest) C.T.E.AFRICA - MEDIO ORIENTE

AMERICA (Nord/Centro/Sud) N.A.O.

Indirizzate i vostriordini a :



NOTE GENERALI

Per cercare il pezzo di ricambio singolo, determinare l’insieme principale nel quale esso si trova, consultarel’indice per trovare la pagina corrispondente che illustra l’insieme che lo contiene.

Le lettere seguenti sono utilizzate per classificare i ricambi nel manuale :

A/R Come richiesto. NSS Non venduto separatamente : ordinare l’in-sieme che contiene il pezzo singolo.

NLO Fuori produzione. PL Da acquistare sul posto.

NS Non rappresentato sul disegno. SST Acciaio Inox. Inox serie 300 se non èspecificato.

NSA Non disponibile assemblato : ordinare icomponenti elencati sotto l’insieme.

SV-SK Il suffisso SV-SKaggiunto al n˚ di codiceindica un kit di parti di ricambio

NSI Non in stock : puo essere ottenuto con unordine speciale.

PL* Da acquistare sul posto. Può essere ottenutoa certe condizioni (Multipack, data di spedi-zione, prezzo...)


viii

INTRODUKTIE

Deze onderdelen lijst beschrijft service en vervangings onderdelen van de CARRIER TRANSICOLD MAXIMA1000 Starting with S/N MB403109 / MAXIMA 1300 / 1300Mt_ transportkoelmachine’s.

Deze onderdelen lijst bevat geen gedetaileerde onderdelen voor de dieselmotor en compressor welke in de tabelhieronder staan vermeld. Gedetaileerde gegevens voor deze onderdelen staan vermeld in de separate onderdelenboeken.

BESTEL INSTRUCTIES

Bij alle aanvragen van reserve onderdelen moeten vermeld zijn :

D Serienummer van de groep D Code nummer

D Onderdeelbeschrijving + nummeraanduiding D Gewenst aantal

Richt alle correspondentie aan het volgende adres :

U woont: EUROPA (Oost/West) C.T.E.AFRICA - MIDDEN OOSTEN

AMERIKA Noord/Centraal/Zuid)N.A.O.

Zend uw orders naar: CARRIER TRANSICOLD EUROPEL’ Européen Bâtiment D4, Rue Joseph Monier92500 Rueil---MalmaisonPhone : (33).1.41.42.28.00Fax : (33).1.41.42.28.28


ALGEMENE OPMERKINGEN

Om de benodigde onderdelen te localiseren, richt u tot de groep waar het specifieke onderdeel zich bevindt,en raadpleeg de inhoudstabel voor de juiste pagina.

De onderstaande afkortingen worden gebruikt :

A/R Zoals gewenst. NSS Niet apart leverbaar, bestel bovengenoemdeset.

NLO Niet meer gebruikt. PL Koop lokaal.

NS Niet aangegeven in tekening. SST Roestvaststaal .300 serie tenzij andersaangegeven.

NSA Niet als set leverbaar, bestel aparteonderdelen.

SV-SK Achter het onderdeel betekent serviceonderdeel

NSI Niet op voorraad, allen voor specialeorders leverbaar.

PL* Koop lokaal, alleen onder speciale voorwaar-den verkrijgbaar ( grote hoeveelheden, lever-tijd,prijs e.d.)


ix

INTRODUKTION

Denne reservedelsliste viser erstatning for service reservedele for CARRIER TRANSICOLD’S MAXIMA 1000Starting with S/N MB403109 / MAXIMA 1300 / 1300Mt_ køleanlæg. Dette anlæg er fremstillet til middel temperaturkøling, opvarmning og afrimning for truck biler.

En detaljeret identifikation af reservedele for disse kan findes i den tilhørende reservedelsliste.

BESTILLINGSVEJLEDNING

Alle ordrer og forespørgsler vedrørende reservedele skal indeholde :

D Anlæggets serienummer D Reservedelsnummer

D Beskrivelse af reservedel som vist på liste D Ønsket mængde

Al henvendelse vedrørende reservedele til følgende adresse alt efter lokalitet.

Du bor : EUROPA (Øst / Vest) C.T.E.AFRIKA -- MELLEMØSTEN

-- AMERIKA (Nord / Midt / Syd)N.A.O.



GENERELLE NOTATER

For at finde den ønskede reservedel, find hovedgruppen hvor reservedelen er lokaliseret, slå op på denpågældende side for at finde den ønskede reservedel.

Følgende betegnelser bruges for at klassificere reservedele gennem hele listen.

A/R Efter ønske. NSS Ikke solgt separat -- bestil ovenstående sæt.

NLO Udgået . PL Købes lokalt.

NS Ikke vist på illustrationen. SST Rustfri stål -- medmindre andet står skrevet.

NSA Ej solgt komplet -- bestil komponenter somer listet under delen.

SV - SK Er betegnelsen SV--SK tilføjet reservedels-numret refererer dette til et sæt.

NSI Ikke lagerført -- kan være tilgængelig vedspeciel bestilling.

PL* Købes lokalt. Kan muligvis fås med speciellebetingelser (multipak, leveringsdato, pris...).


x

INTRODUKTION

Denna reservdels bok identifierar vilka reservdelar som finns till kylaggregatet CARRIER TRANSICOLD MAXIMA1000 Starting with S/N MB403109 / MAXIMA 1300 / 1300Mt_

Detaljerad reservdels beskrivning finns i denna reservdels bok.

ORDER INSTRUKTIONER

Alla order och önskemål av delar måste innehålla:

D Serie nummer på aggregatet D Artikel.Nr.

D Beskrivning av delen som den visas i boken D Antal.

Adressera alla reservdelsförfrågningar till den adressen som tillhör din region.

Du bor i : EUROPA (ÖST / VÄST) C.T.E.AFRIKA -- MELLAN ÖSTERN

AMERIKA (NORD / MELLAN / SYD )N.A.O.



NOTERINGAR

För att hitta ersättningsdelar, bestäms av vilken grupp delarna tillhör, ett schema för denna sidan visar vilkadelar som finns tillgängliga.

Följande benämningar används för att klassa delarna i denna boken.

A/R Efter förfrågan. NSS Säljs inte enskilt -- beställ huvudprodukteneller kiten.

NLO Erbjuds inte längre. PL Köpes lokalt.

NS Visas inte på bilden. SST Rostfritt -- 300 serie om inget annat står.

NSA Ej lagerförd huvudprodukt -- beställ kompo-nenterna under huvudprodukten.

SV - SK Suffix SV--SK som tillförts reservdels numretrefererar till en kit.

NSI Ej lagerförda delar -- kan levereras vid spe-cial order.

PL* Köpes lokalt. Kan fås under speciellaförhållande ( Multipack, leveransdatum,pris...).


xi

Ââåäåíèå:

Äàííûé êàòàëîã ñîäåðæèò ïåðå÷åíü çàïàñíûx ÷àñòåé äëÿ xîëîäèëüíîãî àãðåãàòà MAXIMA 1000 Starting with S/N MB403109 /MAXIMA 1300 / 1300Mt_ êîìïàíèè CARRIER TRANSICOLD. Ýòîò àãðåãàò ïðeäíàçíà÷åí äëÿ ïîääåðæàíèÿ òåìïåðàòóðû âêóçîâàx ñðåäíèx è ìàëûx ãðóçîâèêîâ.

Ïîäðîáíûé ïåðå÷åíü çàïàñíûx ÷àñòåé äëÿ ýòèx óçëîâ íàxîäèòñÿ â ñîîòâåòñòâóþùèx êàòàëîãàx çàïàñíûx ÷àñòåé.

Èíñòðóêöèè ïî çàêàçó:

Âñå çàêàçû è çàïðîñû îòíîñèòåëüíî çàïàñíûõ ÷àñòåé äîëæíû ñîäåðæàòü :

D Ñåðèéíûé íîìåð àãðåãàòà. D Íîìåð çàïàñíîé ÷àñòè ïî êàòàëîãó .

D Íàèìåíîâàíèå çàïàñíîé ÷àñòè êàê â êàòàëîãå. D Òðåáóåìîå êîëè÷åñòâî.Íàïðàâëÿéòå âñþ ïåðåïèñêy ïî çàïàñíûì ÷àñòÿì ïî ñëåäóþùåìó àäðåñó â ñîîòâåòñòâèè ñ Âàøèì ìåñòîíàõîæäåíèåì.

Âû íàõîäèòåñü â: Åâðîïå(Âîñòî÷íîé/Çàïàäíîé)Àôðèêå—Áëèæíåì ÂîñòîêåC.T.E.

Àìåðèêå (Ñåâåðíîé/Öåíòðàëüíîé/Þæíîé)N.A.O.

Íàïðàâëÿéòå âàøè çàêàçû: CARRIER TRANSICOLD EUROPEL’ Européen Bâtiment D4, Rue Joseph Monier92500 Rueil---MalmaisonPhone : (33).1.41.42.28.00Fax : (33).1.41.42.28.28


Îáùèå óêàçàíèÿ:

Äëÿ ïîèñêà íîìåðà êîíêðåòíîé äåòàëé, îïðåäåëèòå ãðóïïó, â êîòîðîé îíà íàõîäèòñÿ, â îãëàâëåíèè íàéäèòå íóæíóþ ñòðàíèöó.

Äëÿ êëàññèôèêàöèè äåòàëåé â äàííîì êàòàëîãå èñïîëüçóþòñÿ ñëåäóþùèå ñîêðàùåíèÿ.

A/R Ïî ìåðå íåîáõîäèìîòñè. NSS îòäåëüíî Íå ïîñòàâëÿåòñÿ — çàêàçûâàéòå óçåë, âêîòîðûé âõîäèò äàííàÿ äåòàëü.

NLO Áîëåå íå ïîñòàâëÿåòñÿ. PL Ïðèîáðåòàéòå ñàìîñòîÿòåëüíî.

NS Íå ïîêàçàíî íà ðèñóíêå. SST Íåðæàâåþùàÿ ñòàëü ñåðèè 300, åñëè íå óêàçàíîäðóãîå.

NSA ÍÓçåë íå ïîñòàâëÿåòñÿ — çàêàýûâàéòå îòäåëüíûåêîìïîíåíòû, ïåðå÷èñëåííûå íèæå.

SV - SK Ñóôôèêñ SV - SK îòíîñèòñÿ ê ðåìêîìïëåêòàì.

NSI åò íà ñêëàäå — ìîæåò áûòü äîñòàâëåíî ïî îñîáîìóçàêàçó.

PL* Ïðèîáðåòàéòå ñàìîñòîÿòåëüíî. Ìîæåò áûòüçàêàçàíî íà îñîáûõ óñëîâèÿõ (êîëè÷åñòâî, ñðîêèïîñòàâêè, öåíû...)


xii

RECOMMENDATION LIST

To help you manage your stocks, a recommendation list is provided on the following page(s).

Item are classified into three categories.

M for maintenancee.g. Filter, Belt, Electric motor brushes, Drier, Fuse, etc...

C for Criticali.e. items without which the unit cannot restart.

S for SelectionSame level of necessity as C, but whose probability of requirement depends on the characteristics of the vehicle fleet,i.e. age of units and level of service provided to user (e.g. 24 hour a day service).

In the event of repair, only use original CARRIER PERFORMANCE PARTS.

LISTE DE RECOMMANDATION

Afin de vous aider dans la gestion de vos stocks, une liste de Préconisation vous est proposée page(s)suivante(s).

Les articles sont classés en trois catégories.

M pour MaintenanceEx : Filtre, Courroie, Balais de moteur électrique, Deshydrateur, Fusible, etc...

C pour CritiqueArticle sans lequel l’unité ne peut être remise en fonctionnement.

S pour SelectiveMême necessité que C mais dont la probalité du besoin est fonction de la population du parc, de l’age des unités et duniveau de service fourni à l’utilisateur ( ex: 24/24 ).

En cas de réparation, n’utilisez que des pièces de rechange CARRIER PERFORMANCE PARTS d’origine

VORSORGELISTE

Zur besseren Verwaltung Ihres Lagerbestands wird Ihnen auf der (den) folgenden Seite (n) eine Vorsorgeliste vor-geschlagen.

Die Artikel sind drei Kategorien zugeordnet.

M für die Wartungz.B.:Filter, Keilriemen, Bürsten des Elektromotors, Filtertrockner, Sicherungen, usw.

C für kritische Teile, ohne welche das Aggregat nicht in Stand gesetzt werden kann.

S für Auswahl, mit der gleichen Notwendigkeit wie C, wobei jedoch die Wahrscheinlichkeit des Bedarfs von derGröβe des Fahrzeugparks, vom Alter der Aggregate und von dem dem Benutzer gelieferten kundendienstniveauabhängt (z.B. 24 Stunden täglich).

Bei Reparaturarbeiten nur die Originalersatzteile CARRIER PERFORMANCE PARTS verwenden.


xiii

LISTA DE RECOMENDACIONES

Para ayudarle en la gestión de sus existencias, hemos incluido una lista de recomendaciones en las páginassiguientes.

Los articulos se ordenan en tres categorias:

M (como mantenimiento)Ej.:Filtro, Correa, Escobillas de motor eléctrico, Deshidratador, Fusible, etc...

C (como critico)Articulo sin el cual la unidad no puede volver a funcionar.

S (como selección)Mismo grado de criticidad que C, pero cuya probabilidad de llegar a ser necesario depende de la composición delparque de vehiculos, de la edad de las unidades y del nivel de servicio suministrado al usuario (Ej.: servicio las 24horasdel dia).

En caso de reparación, utilice únicamente piezas de repuesto CARRIER PERFORMANCE PARTS de origen.

LISTA DI RACCOMANDAZIONI

Per aiutarvi a gestire gli stock, una lista di raccomandazioni è proposta nella pagina successiva (nelle paginesuccessive).

M, corrispondente a Manutenzionees.: Filtro, Cinghia, Spazzola di motore elettrico, Disidratatore, Valvola, ecc...

C, corrispondente a CriticoArticolo senza il quale l’unità non puo essere rimessa in moto.

S, corrispondente a SelezioneStesso significato di C, ma la cui necessità dipende dalla quantità di apparecchi, dall’età di questi ultimi e dal livello diservizio offerto all’utente (es.: 24/24).

In caso di riparazione, utilizzare soltanto i pezzi di ricambio originali CARRIER PERFORMANCE PARTS.

AANBEVELINGSLIJST

Om u te helpen bij het beheer van uw voorraden hebben wij voor u een Aanbevelinglijst opgesdeld.

Volgende pagina(’s)

De artikelen zijn in drie categorieën ingedeeld:

M voor OnderhoudBijv.: Filter, Riem, Borstels van elektrische motor, Dehydratietoestel, Zekering enz...

C voor KritiekZonder dit artikel kan de unit niet opnieuw in werking worden gesteld.

S voor SelektieDezelfde noodzaak als voor K, maar waarbij de behoefte afhankelijk is van de parkgroep, de leeftijd van de units en hetdoor aan de gebruiker geboden serviniveau (bijv. 24 uurs--service).

Gebruik bij reparaties uitsluitend originele CARRIER PERFORMANCE PARTS--onderdelen.


xiv

ANBEFALET LAGERLISTE

For at hjælpe dig med lagerføring, forefindes en anbefalet lagerliste på følgende side(r).

Dele klassificeres i tre kategorier.

M = servicef.eks. Filter, Rem, Kul, Tørfilter, Sikringer, osv....

C = kritiskd.v.s. dele uden hvilke anlægget ikke kan starte.

S= udvælgelseSamme niveau som C, men sandsynligheden for forespørgsel afhænger af produktmix samt flådens størrelse ogalder.

Ved enhver reparation, bruges kun originale CARRIER PERFORMANCE PARTS.

REKOMMENDATIONS LISTA

För att hjälpa dig med lagerhållning, finns en rekommendations lista på följande sidor.

Delarna är klassade i 3 kategorier.

M för underhållT.ex. Filter, Kol för elmotorer, Torkfilter, Säkringar, ex....

C för kritiska delarUtan dessa delarna kan aggregatet inte starta.

S för urvalLika nödvändiga som C, men är mer beroende av hur kundkretsen ser ut, hur gamla aggregaten är och vilken servicekunden kräver (t.ex. 24 timmars service).

Vid reparationer skall endast original CARRIER TRANSICOLD delar användas.

Ñïèñîê ðåêîìåíäóåìûõ çàïàñíûõ ÷àñòåéÄëÿ òîãî, ÷òîáû:

Äëÿ òîãî, ÷òîáû îáëåã÷èòü âàìó ïðàâëåíèå ñêëàäîì, íà ñëåäóþùèõ ñòðàíèöàõ ïðèâåäåí ñïèñîê ðåêîìåíäóåìûõ çàïàñíûõ ÷àñòåé.

çàïàñíûå ÷àñòè ðàñïðåäåëåíû ïî òðåì êàòåãîðèÿì.

M — çàïàñíûå ÷àñòè äëÿ îáñëóæèâàíèÿÍàïðèìåð ôèëüòðû, ðåìíè, ùåòêè, îñóøèòåëèï, ðåäîõðàíèòåëì è ò.ï.....

C — Êðèòè÷åñêèå óçëûÒî åñòü äåòàëè, áåç êîòîðûõ àãðåãàò íå ñìîæåò ðàáîòàòü.

S — çàïàñíûå ÷àñòè ïî âûáîðóÒîò æå óðîâåíü âàæíîñòè, êàê è äëÿ Ñ, íî ïîòðåáíîñòü â ýòèõ äåòàëÿõ çàâèñèò îò ñîñòàâà ïàðêà ðåôðèæåðàòîðîâ, âîçðàñòà àãðåãàòîâ,óðîâíÿ ñåðâèñà.

Äëÿ ðåìîíòà èñïîëüçóéòåòîëüêî ïîäëèííûå çàïàñíûå ÷àñòè CARRIER PERFORMANCE PARTS.


xv

DESCRIPTIONPART NO. QTY LOCATION

PRECONISATION LIST “M”

42-60121-00 GASKET 1 442-60058-01 GASKET 1 414-00326-05 FILTER DRIER 1 642-00243-10 O--RING, 1/4” 1 6.842-00243-09 O--RING, 3/8” 3 614-00220-05 SIGHT GLASS, MOISTURE INDICATOR 1 614-00272-01 PRESSURE RELIEF VALVE 1 614-00360-10 REPAIR KIT 1 842-00243-07 O--RING, 1/4” 1 850-60329-07 BELT, 3PK 1 12.14.3204-60008-29 LOWER FAN SHAFT BEARING 2 12.1404-60008-19 UPPER FAN SHAFT BEARING 2 12.14.3404-60001-00 BEARING FRONT 1 16.2004-60008-09 BEARING REAR 1 1638-60016-00 GREASE KIT 1 16.2076-60386-00 REPAIR KIT 1 16.2046-00048-00 GREASE 1 16.2058-60391-00 GASKET 1 16.2042-00424-11 GASKET 1 16.2042-60042-01 GASKET 1 18.2404-60008-09 BEARING, REAR 1 OR 2 20.2817-10811-05 GASKET, SERVICE ONLY 1 2604-60011-39 BEARING 2 287103921 GLOW PLUG 1 3029-70157-00 QUICK GLOW PLUG 1 3030-60119-00 OIL FILTER 1 3050-60329-01 POLY V--BELT 3PK, WATER PUMP ENGINE 1 3050-50020-01 CLUTCH SERVICE KIT 1 3050-60288-07 BELT, VENTIL BOX / CLUTCH ELECTRO 1 3250-60411-00 BELT, VENTIL BOX / ELECTRIC MOTOR 1 3250-60288-00 BELT, ELECTRIC MOTOR / ALTERNATOR 1 32.3450-60288-23 BELT, ELECTRIC MOTOR / ALTERNATOR 1 32.3450-60289-61 BELT, ELECTRIC MOTOR / COMPRESSOR 2 3250-60289-50 BELT, ELECTRIC MOTOR / COMPRESSOR 2 3204-60008-04 BEARING, REAR 1 3450-01168-02 PULLEY, ∅ 3.48 1 3476-61263-00 ALTERNATOR ADAPTATION TERMINAL KIT 1 3448-60063-00 FILTER HEAD 1 36.3830-00302-00 FILTER FUEL 1 36.3830-00426-20 FILTER ELEMENT 1 4310-00286-04 RELAY 5 OR 10 54.58.6410-00385-02 RELAY 5 54.58.6422-02336-00 FUSE, 30A 3 54.5822-02336-05 FUSE, 25A 2 54.58.6422-02336-02 FUSE, 5A 2 54.58.6422-02336-06 FUSE, 15A 3 OR 4 54.58.6422-02336-08 FUSE, 7,5A 1 OR 2 54.58.6422-02336-50 FUSE, REMOVAL TOOL 1 54.58.6422-60340-02 FUSE, MIDIFUSE 60A 2 54.58.6422-02336-04 FUSE, 10A 4 6422-02336-07 FUSE, 2A 3 6422-02336-11 FUSE, 4A 1 6630-01108-20 FILTER, 80 MICRONS 1 7930-01108-22 GASKET 1 79


xvi


PRECONISATION LIST “C”

14-60026-01 CHECK VALVE, 3/8” 1 614-60026-00 CHECK VALVE, 1/4” 1 614-00360-00 MHV VALVE (NO) 1 814-01042-08 VALVE, SERVICE 7/8” 1 822-60590-00 COIL 1 8.24.2622-60734-00 COIL, MAIN HEAT VALVE 1 814-00329-00 VALVE, SOLENOID 1/4” 1 814-00269-10 REPAIR KIT 1 814-00181-04 CHECK VALVE, 7/8” 1 1038-60013-08 BLOWER 1 16.2012-01039-08 DEFROST AIR SWITCH 1 16.2014-60039-00 EXPANSION VALVE 1 2414-60009-06 ORIFICE 1 2412-00256-21 DTT THERMOSTAT 1 2414-60062-05 LSV VALVE 1 2414-60062-10 REPAIR KIT 1 2412-00283-00 SPT SUCTION PRESSURE TRANSDUCER 1 2612-60015-01 LP1 LOW PRESSURE SWITCH 1 2614-00303-02 BY--PASS VALVE (NC) 1 2614-00303-10 REPAIR KIT 1 2614-01042-06 VALVE, SERVICE 1--1/8” 1 2612-00572-00 LP LOW PRESSURE SWITCH 1 2604-60008-42 BEARING 2 2830-60050-22 DIODE BRIDGE 1 3430-60050-20 REGULATOR AND BRUSH 1 3454-00603-53 FAN 1 3454-00603-63 BEARING, REAR 1 3454-00603-62 BEARING, FRONT 1 3430-01114-07 ALTERNATOR, 14V 70A 1 3430-01114-56 BRUSH HOLDER ASSY 1 3412-00592-00 SWITCH, LOW PRESSURE OIL 1 3812-01145-05 WTS SENSOR 1 40.4230-60109-00 CHECK VALVE 1 40.4258-60059-00 CAP INSULATING 1 5210-00375-01 INDICATOR, BUZZER 1 52.56.6010-00473-06 OVERLOAD 1 54.58.6210-00433-00 CONTACTOR, 30A 1 OR 2 54.58.6212-60007-04 DETECTOR ( PHASE REVERSAL ) 1 54.5812-60021-02 DETECTOR ( PHASE DETECTION ) 1 54.58.6230-01108-11 PUMP, FUEL 1 79


xvii


PRECONISATION LIST “S”

50-60340-00 TENSIONER ASSY 1 1250-60164-01 PULLEY 1 1250-60339-00 NSI LOWER PULLEY, 3PK 1 1250-60338-00 UPPER PULLEY, 3PK 1 1250-60340-01 TENSIONER ASSY 1 1450-60164-02 PULLEY 1 1450-60409-00 LOWER PULLEY, 3PK 1 1450-60408-00 UPPER PULLEY, 3PK 1 1450-60224-00 CLUTCH, ELECTRO 1 16.2014-60052-02 CPR VALVE 1 2618-00063-32 COMPRESSOR 05K4, UNIVERSAL 1 2818-00063-31SV COMPRESSOR 05K4, REMAN R404A 1 2850-60225-00 BELT TENSIONER 1 2810-60018-00SV SPEED SOLENOID, 12V 1 3050-60196-00 CLUTCH ASSY 1 3030-60050-03 ALTERNATOR, 14V 50A 1 3454-00603-58 REAR COVER 1 3430-60083-00 MUFFLER 1 4430-60103-00 MUFFLER 1 45.4630-60107-00 MUFFLER 1 45.4630-60123-00 MUFFLER 1 46

MAXIMA 1000 starting with S/N MB403109MAXIMA 1300 / 1300Mt_

1

1. FRAME AND SKIN KIT ( FRONT AND BOTTOM )


2

DESCRIPTIONPART NO. QTYITEM

1. FRAME AND SKIN KIT ( FRONT AND BOTTOM )

60 67-60317-00 BRACKET 170 68-61845-00 GUARD PRIOR TO SERIAL NUMBER MB820030 171 68-70546-00 GUARD STARTING WITH SERIAL NUMBER MB820030 1

100 79-60663-00 NSI PANEL ASSY, BOTTOM ( MAXIMA 1300 / 1300Mt_ ONLY ) -- INCLUDES: 1101 58-60666-00 HOUSING 1102 42-60107-00 NSI FOAM 2185 34-01152-20 PL* SCREW, CAP HXHD M6 X 20MM 4230 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 6250 34-60044-00 SCREW, M6 X 20MM 17270 34-60068-20 SCREW, M6 X 20MM 14360 68-61830-00 PROTECTOR 1370 68-70323-00 PLATE, BOTTOM ( MAXIMA 1000 ONLY ) 1371 42-60115-00 NSI FOAM, LOW NOISE ( MAXIMA 1000 ONLY ) 1380 58-60302-06 GROMMET 2390 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 8450 42-60108-00 NSI FOAM ( LOW NOISE VERSION ) 1460 42-60109-00 FOAM ( LOW NOISE VERSION ) 1525 79-60616-02 NSI FRAME ASSY -- INCLUDES: 1530 67-60293-00 FRAME, BOTTOM ( REMOVE THIS ITEM FOR MAXIMA 1000 ) 1535 67-60294-00 FRAME, BOTTOM ( REMOVE THIS ITEM FOR MAXIMA 1000 ) 1540 86-60808-01 NSI CROSS BAR, UPPER FRONT 1545 86-60869-01 NSI CROSS BAR, LOWER FRONT 1550 34-00873-35 PL* SCREW, CAP HXHD M10 X 35MM 1555 34-60085-10 PL* WASHER, M10 X 22MM 2560 34-01184-60 PL* NUT, LOCK M10 2605 58-60525-01 TOP COVER 1620 58-60574-01 GRILLE ASSY 1635 79-60530-00 DOOR ASSY -- INCLUDES: 1

635A 58-60261-00 DOOR ASSY 1635B 44-60091-00 HINGE 2635C 34-00946-56 PL* NUT, HEX M6 X 1MM 1635D 34-60095-46 PL* WASHER, LOCK M6 X 18MM 1635E 34-60095-27 PL* WASHER, LOCK M6 X 14MM 4635F 34-01152-12 PL* SCREW, CAP HXHD M6 X 12MM 4635G 58-60214-01 NSI FOAM 1635H 79-60016-00 CABLE 1

640 79-60531-00 DOOR ASSY -- INCLUDES: 1641 58-60258-00 DOOR ASSY 1642 68-61111-00 NSI HINGE 2643 68-60400-00 BRACKET 1644 86-60813-00 ROD ASSY 1645 48-60313-00 SPACER 1646 73-60064-00 SPRING 1647 68-60398-00 HANDLE 1648 68-60397-00 BRACKET 1649 58-60187-00 BUMPER 2650 44-60086-00 LOCK, DOOR ZINC ALLOY 1650 44-60086-02 LOCK, DOOR POLYAMID 1651 34-60095-27 PL* WASHER, LOCK M6 X 14MM 6652 34-01152-12 PL* SCREW, CAP HXHD M6 X 12MM 5653 34-01197-10 PL* SCREW, CAP HXHD M4 X 10MM 1654 34-01197-20 PL* SCREW, CAP HXHD M6 X 20MM 1655 62-61451-00 DECAL, LOCK UNLOCK DOOR 1656 58-60214-01 NSI FOAM 1657 79-60016-00 CABLE 1675 68-60636-00 HINGE 1680 68-60637-00 HINGE 1690 86-60805-00 LATCH ASSY 2740 58-60188-00 BUMPER, RUBBER 2750 79-60623-10 BUMPER ASSY, RIGHT AND LEFT SIDE ( MAXIMA 1300 / 1300Mt_ ONLY ) 1770 34-60044-03 PL* SCREW, M6 X 20MM 6790 34-60095-27 PL* WASHER, LOCK M6 X 14MM 32800 34-60095-46 PL* WASHER, LOCK M6 X 18MM 2805 34-01152-16 PL* SCREW, CAP HXHD M6 X 16MM 20810 34-00946-56 PL* NUT, HEX M6 X 1MM ( MAXIMA 1300 / 1300Mt_ ONLY ) 3820 58-00836-04 SPACER 1


3

2. FRAME AND SKIN KIT ( SIDES AND REAR )


4


2. FRAME AND SKIN KIT ( SIDES AND REAR )

10 86-60373-00 BRACKET 140 73-60053-00 GRILLE 150 73-60033-00 SPRING GAS 1

150 48-60324-00 PIN 2160 34-60172-00 CLIP, SPRING 2170 42-60059-01 GASKET ( MAXIMA 1000 WITH BULKHEAD / 1300 / 1300Mt_ ONLY ) 1250 34-60044-00 SCREW, M6 X 20MM 17280 34-60095-46 PL* WASHER, LOCK M6 X 18MM 14310 34-60000-10 PL* SCREW, CAP HXHD M5 X 10MM 3320 34-60095-45 PL* WASHER, LOCK M5 X 16MM 5330 34-60000-20 PL* SCREW, CAP HXHD M5 X 20MM 2340 34-01152-25 PL* SCREW, CAP HXHD M6 X 25MM 9350 34-60028-00 PL* WASHER, FLAT M8 X 30MM 7410 42-60058-01 GASKET ( MAXIMA 1000 WITHOUT BULKHEAD ONLY ) 1420 58-60598-00 NSI SPACER ( MAXIMA 1000 WITHOUT BULKHEAD ONLY ) 4470 42-60110-00 NSI FOAM ( LOW NOISE VERSION ) 1480 42-60111-00 NSI FOAM ( LOW NOISE VERSION ) 1505 34-60014-05 NSI BOLT, T--HEAD 7510 48-60008-00 WASHER, SPACER M13 X 30MM 7515 34-00361-15 NSI NUT, SELF LOCK 7610 58-60578-01 GRILLE, CONDENSER 1615 58-60579-01 GRILLE ASSY 1630 79-60651-00 DOOR ASSY -- INCLUDES: 1

630A 58-60581-03 DOOR ASSY 1630B 44-60090-01 HINGE 2630C 34-01152-12 PL* SCREW, CAP HXHD M6 X 12MM 4630D 34-60095-27 PL* WASHER, LOCK M6 X 14MM 4630E 76-60819-01 LOCK, DOOR 2645 79-60652-00 DOOR ASSY -- INCLUDES: 1

645A 58-60580-00 DOOR ASSY 1645B 44-60090-00 HINGE 2645C 34-60095-27 PL* WASHER, LOCK M6 X 14MM 4645D 34-01152-12 PL* SCREW, CAP HXHD M6 X 12MM 4645E 76-60819-01 LOCK, DOOR 2670 44-60092-00 HINGE 2685 44-60093-01 HINGE 2695 44-60093-00 HINGE 2700 44-60094-00 HINGE 2760 58-60508-01 BULKHEAD KIT ( MAXIMA 1300Mt_ ONLY ) 1760 76-61060-00 BULKHEAD KIT ( MAXIMA 1300 ONLY ) 1760 76-61060-01 BULKHEAD KIT ( MAXIMA 1000 STANDBY ONLY ) 1790 34-60095-27 PL* WASHER, LOCK M6 X 14MM 32805 34-01152-16 PL* SCREW, CAP HXHD M6 X 16MM 20


5

3. REFRIGERATION KIT


6


3. REFRIGERATION KIT

10 14-60026-01 CHECK VALVE, 3/8” 120 14-60026-00 CHECK VALVE, 1/4” 130 14-00326-05 FILTER DRIER 140 42-00243-10 O--RING, 1/4” 150 42-00243-09 O--RING, 3/8” 360 44-60010-02 NSI CLAMP, TUBE 1/2” 270 44-60006-00 CLAMP, DOUBLE 180 PL TUBE, 1/2” 190 65-60055-02 RECEIVER -- INCLUDES: 191 14-00220-03 SIGHT GLASS, LIQUID INDICATOR 192 14-00220-05 SIGHT GLASS, MOISTURE INDICATOR 193 14-00272-01 PRESSURE RELIEF VALVE 1

100 68-61935-00 CLAMP, DRIER 1110 68-60284-00 PL* BRACKET 1120 PL TUBE, 3/8” -- INCLUDES: 1121 40-60009-02 NUT, 3/8” 1122 40-60008-02 SLEEVE, 3/8” 1130 PL TUBE, 3/8” -- INCLUDES: 1131 40-60009-02 NUT, 3/8” 1132 40-60008-02 SLEEVE, 3/8” 1133 40-60009-03 NUT, 1/2” 1134 40-60008-03 SLEEVE, 1/2” 1140 PL TUBE, 1/2” -- INCLUDES: 1141 40-60009-03 NUT, 1/2” 1142 40-60008-03 SLEEVE, 1/2” 1150 86-60924-00 BRACKET, DRIER 1160 34-01267-20 PL* SCREW, FLHD SKT M6 X 20MM 2170 34-60068-20 SCREW, M6 X 20MM 3180 34-60085-09 PL* WASHER, M8 X 22MM 2190 34-01184-58 PL* NUT, LOCK M8 2200 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 1210 34-01152-30 PL* SCREW, CAP HXHD M6 X 30MM 3220 34-01184-56 PL* NUT, LOCK M6 1230 34-60095-27 PL* WASHER, LOCK M6 X 14MM 3240 34-60095-46 PL* WASHER, LOCK M6 X 18MM 1


7

4.1. CONDENSER KIT ( LOWER )

270

790


8


4.1. CONDENSER KIT ( LOWER )

25 12-00309-04 HP1 SWITCH, HIGH PRESSURE -- INCLUDES: 1NS 22-01585-00SK CONNECTOR 2 WAYS ( MATES WITH 22--02392--00SK ) 130 14-00360-00 MHV VALVE (NO) 1

NS 14-00360-10 REPAIR KIT 140 14-01042-08 VALVE, SERVICE 7/8” 160 22-60590-00 COIL ( MATES WITH 22--01613--02SK ) 162 22-60734-00 COIL, MAIN HEAT VALVE 1

62A 22-60734-00 COIL, MAIN HEAT VALVE ( MAXIMA 1300Mt_ ONLY ) 175 40-60053-00 ADAPTOR, 7/16” PITCH 1.27--20FP 175 40-60053-01 ADAPTOR, 9/16” PITCH 1.411--18FP 180 40-60155-00 ELBOW, 90_ 195 42-00243-07 O--RING, 1/4” 1

100 42-00243-10 O--RING, 1/4” 1140 44-60027-07 PL* CLAMP 2190 PL TUBE, 1/2” 1210 68-70315-00 BRACKET 1270 73-60089-00 VIBRASORBER, DISCHARGE 7/8” ( MAXIMA 1000 / 1300 ) 1270 73-60089-01 VIBRASORBER, DISCHARGE 7/8” ( MAXIMA 1300Mt_ ) 1290 PL TUBE, 1/4” -- INCLUDES: 1291 40-00168-02 TEE, 1/4” ( MAXIMA 1300Mt_ ONLY ) 1292 40-60009-01 NUT, 1/4” 1293 40-60008-01 SLEEVE, 1/4” 1320 67-60396-00 BRACKET, VALVE 1330 34-00363-13 PL* NUT, HEX 2340 34-00944-10 PL* WASHER, FLAT M10 4350 34-01184-56 PL* NUT, LOCK M6 2370 34-60084-06 PL* WASHER, LOCK M6 X 10MM 8380 34-60082-40 PL* SCREW, M6 X 40MM 6390 34-60068-20 SCREW, M6 X 20MM 3400 34-60095-46 PL* WASHER, LOCK M6 X 18MM 8410 34-00302-14 PL* SCREW, CAP HXHD 5/16--18 X 1.75MM 2420 34-60082-45 PL* SCREW, CAP SKTHD M6 X 45MM 2460 34-60095-27 PL* WASHER, LOCK M6 X 14MM 3520 34-01152-35 PL* SCREW, CAP HXHD M6 X 35MM 3530 44-60010-00 CLAMP, TUBE 1/4” 1550 PL TUBE ASSY, 7/8” 1610 34-00876-16 PL* SCREW, CAP HXHD M8 X 16MM ( MAXIMA 1000 / 1300 ) 1610 34-00876-20 PL* SCREW, CAP HXHD M8 X 20MM ( MAXIMA 1300Mt_ ) 1620 34-60085-09 PL* WASHER, M8 X 22MM 1630 67-60400-00 BRACKET, VALVE 1640 14-60062-02 HGV1 VALVE, SOLENOID 1/2” (NC) 1NS 14-60062-10 REPAIR KIT 1650 PL TUBE ASSY, 1/2” -- INCLUDES: 1651 40-60009-03 NUT, 1/2” 1652 40-60008-03 SLEEVE, 1/2” 1660 44-60010-02 NSI CLAMP, TUBE 1/2” 2670 42-00243-04 O--RING, 1/2” 1680 40-60004-00 PLUG, 1/4” 1685 44-60061-00 BASE 1690 68-61906-00 BRACKET, VALVE ( MAXIMA 1300Mt_ ) 1700 PL TUBE, COPPER 1/4” ( MAXIMA 1300Mt_ ) 1710 PL TUBE ASSY, 1/4” ( MAXIMA 1300Mt_ ) 1720 14-00329-00 VALVE, SOLENOID 1/4” ( MAXIMA 1300Mt_ ) 1NS 14-00269-10 REPAIR KIT 1730 44-60041-11 PL* CLAMP ( MAXIMA 1300Mt_ ) 1740 34-01184-55 PL* NUT, LOCK M5 ( MAXIMA 1300Mt_ ) 1750 34-60095-25 PL* WASHER, LOCK M5 X 12MM ( MAXIMA 1300Mt_ ) 1760 34-01152-30 PL* SCREW, CAP HXHD M6 X 30MM ( MAXIMA 1300Mt_ ) 1790 48-60502-00 SPACER STARTING WITH SERIAL NUMBER MB801057 1


9

4.2. CONDENSER KIT ( UPPER )

770

780


10


4.2. CONDENSER KIT ( UPPER )

10 08-60025-01 CONDENSER VERTICAL, SIDE PRIOR TO S/N MB537089 110 08-60025-02 CONDENSER VERTICAL, SIDE STARTING WITH S/N MB537089 120 08-60061-01 CONDENSER HORIZONTAL, TOP 150 22-01637-01 ATS SENSOR -- INCLUDES: 1

NS 22-50078-01SK CONNECTOR 2 WAYS ( MATES WITH 22--50078--02SK ) 1120 44-00285-57 PL* CLAMP, TUBE 7/8” 2160 PL TUBE, 3/4” 1170 PL TUBE, 7/8” -- INCLUDES: 1171 40-60159-00 FITTING, 1/4” SCHRAEDER 1172 40-60004-00 PLUG, 1/4” 1180 PL TUBE, 7/8” 1230 68-70321-00 PLATE 1240 68-60896-00 SUPPORT 1250 68-70055-00 BRACKET, TUBE 1280 79-60574-02 NSI VENTILATION BOX ASSY ( SEE SECTION 4.3. ) 1280 79-60574-50 NSI VENTILATION BOX ASSY WITHOUT PULLEY ( SEE SECTION 4.3. ) 1280 79-60716-00 VENTILATION BOX ASSY ( SEE SECTION 4.4. ) 1310 86-61006-00 BOX ASSY, AIR DUCT 1350 34-01184-56 PL* NUT, LOCK M6 2360 34-01152-25 PL* SCREW, CAP HXHD M6 X 25MM 6370 34-60084-06 PL* WASHER, LOCK M6 X 10MM 8380 34-60082-40 PL* SCREW, M6 X 40MM 6390 34-60068-20 SCREW, M6 X 20MM 3400 34-60095-46 PL* WASHER, LOCK M6 X 18MM 8420 34-60082-45 PL* SCREW, CAP SKTHD M6 X 45MM 2430 34-01249-20 PL* SPACER, M6 X 25MM 3440 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 6450 34-01267-20 PL* SCREW, FLHD SKT M6 X 20MM 3460 34-60095-27 PL* WASHER, LOCK M6 X 14MM 3470 02-60000-00SAV ADHESIVE 1.8M480 42-00424-06 PL* GASKET 2490 42-60088-00 PL* GASKET 1510 42-60092-00 PL* FOAM 1570 34-01249-26 NSI SPACER, M10 X 25MM 1600 14-00181-04 CHECK VALVE, 7/8” 1770 68-70509-00 BRACKET SENSOR 1780 58-60154-00 GROMMET 1


11

4.3. VENTILATION BOX ASSY PRIOR TO SERIAL NUMBER MB820030

40

5

1

20


12


4.3. VENTILATION BOX ASSY PRIOR TO SERIAL NUMBER MB820030

1 79-60574-02 NSI VENTILATION BOX -- INCLUDES: 11 79-60574-50 NSI VENTILATION BOX WITHOUT PULLEY -- INCLUDES: 15 86-60967-00 EMPTY BOX 1

10 68-70050-00 COVER 115 34-60068-16 PL* SCREW, CAP HXHD M6 X 16MM 720 68-70047-00 UPPER AIR COLLECTOR 130 68-70048-00 LOWER AIR COLLECTOR 135 38-00576-00 BLOWER 240 50-60340-00 TENSIONER ASSY -- INCLUDES: 1

40A 50-60164-01 PULLEY 140B 04-60008-19 TENSIONNER BEARING 240C 34-00876-60 PL* SCREW, CAP HXHD M8 X 60MM 140D 34-01249-25 PL* SPACER, M8 X 25MM 240E 34-01184-58 PL* NUT, LOCK M8 140F 34-60086-40 RING, RETAINING 1

45 50-60329-07 BELT, 3PK ( EXCEPT 79--60574--50 ) ( SEE SECTION 7.1 ) 150 50-60339-00 NSI LOWER PULLEY, 3PK ( EXCEPT 79--60574--50 ) 155 34-60082-12 PL* SCREW, HEAD CHC M6--12MM 660 34-60084-06 PL* WASHER, LOCK M6 X 10MM 665 50-60338-00 UPPER PULLEY, 3PK ( EXCEPT 79--60574--50 ) 170 48-60382-00 LOWER HUB FAN BLOWER 175 34-60187-25 PL* SCREW 180 34-01249-32 PL* WASHER, M6 X 35 X 6MM 185 48-60355-00 UPPER HUB FAN BLOWER 190 34-60083-10 PL* NUT, LOCK M10 195 48-60011-03 SPACER 1

105 34-60068-20 SCREW, M6 X 20MM 8115 50-60342-00 LOWER FAN SHAFT -- INCLUDES: 1116 04-60008-29 LOWER FAN SHAFT BEARING 2117 34-60022-01 KEY, 8X7X30 1120 34-60186-16 PL* SCREW, M8 X 16MM 5125 50-60390-00 UPPER FAN SHAFT -- INCLUDES: 1126 04-60008-19 UPPER FAN SHAFT BEARING 2127 34-60022-11 KEY, 5X5X25 1130 34-60068-16 SCREW, M6 X 16MM 4


13

4.4. VENTILATION BOX ASSY STARTING WITH SERIAL NUMBER MB820030

180

200


14


4.4. VENTILATION BOX ASSY STARTING WITH SERIAL NUMBER MB820030

1 79-60716-00 VENTILATION BOX -- INCLUDES: 15 86-61245-00 EMPTY BOX 1

10 68-70545-00 COVER 130 34-60068-16 PL* SCREW, CAP HXHD M6 X 16MM 1940 38-00576-00 BLOWER 250 50-60340-01 TENSIONER ASSY -- INCLUDES: 1

50A 50-60164-02 PULLEY 150B 04-60008-19 TENSIONNER BEARING 250C 34-00876-60 PL* SCREW, CAP HXHD M8 X 60MM 150D 34-01249-25 PL* SPACER, M8 X 25MM 250E 34-01184-58 PL* NUT, LOCK M8 150F 34-60086-40 RING, RETAINING 1

60 50-60329-07 BELT, 3PK ( EXCEPT 79--60574--50 ) ( SEE SECTION 7.1 ) 170 50-60409-00 LOWER PULLEY, 3PK ( EXCEPT 79--60574--50 ) 180 34-60082-12 PL* SCREW, HEAD CHC M6--12MM 690 34-60084-06 PL* WASHER, LOCK M6 X 10MM 6

100 50-60408-00 UPPER PULLEY, 3PK ( EXCEPT 79--60574--50 ) 1110 48-60382-00 LOWER HUB FAN BLOWER 1120 34-60187-25 PL* SCREW 1130 34-01249-32 PL* WASHER, M6 X 35 X 6MM 1140 48-60355-00 UPPER HUB FAN BLOWER 1150 34-60083-10 PL* NUT, LOCK M10 1160 48-60011-03 SPACER 1180 50-60342-00 LOWER FAN SHAFT -- INCLUDES: 1181 04-60008-29 LOWER FAN SHAFT BEARING 2182 34-60022-01 KEY, 8X7X30 1190 34-60186-16 PL* SCREW, M8 X 16MM 5200 50-60390-00 UPPER FAN SHAFT -- INCLUDES: 1201 04-60008-19 UPPER FAN SHAFT BEARING 2202 34-60022-11 KEY, 5X5X25 1


15

5.1. EVAPORATOR KIT ( MAXIMA 1000 / 1300 )


16



20 58-60279-02 NSI HOSE, AIR RED 0.7M30 58-60279-01 NSI HOSE, AIR CLEAR 0.95M60 38-60013-08 BLOWER -- INCLUDES: 1

NS 04-60001-00 BEARING FRONT 1NS 04-60008-09 BEARING REAR 1NS 38-60016-00 GREASE KIT 1NS 76-60386-00 REPAIR KIT 1NS 50-60059-00 JACKSHAFT ASSY 1NS 46-00048-00 GREASE 165 68-60370-00 BRACKET 170 68-60371-00 BRACKET 175 86-60098-00 FRAME 195 79-60685-00 POD ASSY -- INCLUDES: 196 58-60345-10 DOOR 197 34-60202-25 PL* SCREW 498 42-60054-00 NSI GASKET 1

100 68-60622-00 GRILLE, EVAP 1105 34-01153-35 PL* SCREW, CAP HXHD M8 X 35MM 8110 34-60028-00 PL* WASHER, FLAT M8 X 30MM 8115 34-60095-30 PL* WASHER, LOCK M8 X 18MM 13120 68-60868-00 BRACKET 1135 79-60492-00 DUCT ASSY 1140 34-01153-20 PL* SCREW, CAP HXHD M8 X 20MM 5150 34-60068-20 SCREW, M6 X 20MM 10155 58-60298-02 GROMMET 1160 73-60079-00 GRILLE 1170 34-60095-27 PL* WASHER, LOCK M6 X 14MM 8175 34-01152-20 PL* SCREW, CAP HXHD M6 X 20MM 1180 48-60322-00 SPACER 1185 58-60391-00 GASKET 1190 34-60056-10 PL* SCREW, CHC M5 X 0.8MM 7200 34-60095-25 PL* WASHER, LOCK M5 X 12MM 10210 50-60224-00 CLUTCH, ELECTRO 1215 22-60378-00 NSI HARNESS CLUTCH -- INCLUDES: 1NS 22-50078-01SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-02SK ) 1220 12-01039-08 DEFROST AIR SWITCH 1235 34-01184-56 PL* NUT, LOCK M6 18260 34-00946-55 PL* NUT, HEX M5 2265 34-60085-09 PL* WASHER, M8 X 22MM 4270 34-01184-58 PL* NUT, LOCK M8 4275 34-60196-12 PL* WASHER, FLAT M12 4295 42-00424-11 GASKET 1331 08-60110-00 EVAP COIL 1340 34-60095-46 PL* WASHER, LOCK M6 X 18MM 3350 34-01249-20 NSI SPACER 9370 42-60090-00 FOAM, RIGHT AND LEFT SIDE 2380 42-60090-01 FOAM, LOW AND HIGH SIDE 2


17



18



10 58-60297-00 FITTING, AIR SENSING 215 68-60629-00 SUPPORT 125 68-60314-00 BRACKET EXPANSION VALVE 135 12-00566-55 RAS SENSOR -- INCLUDES: 1

NS 22-50078-01SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-02SK ) 155 44-60044-03 PL* CLAMP 180 42-60042-01 GASKET 185 58-60399-01 FITTING 190 58-60401-00 PL* NUT, M20 X 1.5MM 1

170 34-60095-27 PL* WASHER, LOCK M6 X 14MM 8200 34-60095-25 PL* WASHER, LOCK M5 X 12MM 10250 34-60000-16 PL* SCREW, CAP HXHD M5 X 16MM 1255 34-01184-55 PL* NUT, LOCK M5 1300 34-01152-35 PL* SCREW, CAP HXHD M6 X 35MM 1305 44-60010-00 PL* CLAMP, TUBE 1/4” 1310 58-01286-00 HOSE 2M320 44-60044-10 PL* CLAMP, 7/8” 1331 NSS PARTS INCLUDED IN EVAP COIL 1332 86-60966-00 BRACKET, HEAT EXCHANGER 1333 68-61297-00 CLAMP, HEAT EXCHANGER 1334 14-60039-00 EXPANSION VALVE 1335 14-60009-06 ORIFICE 1336 12-00256-21 DTT THERMOSTAT 1337 08-60180-00 HEAT EXCHANGER 1338 42-00243-10 O--RING 1339 40-00071-32 ELBOW, 90_ 1341 12-00256-24 BY--PASS THERMOSTAT FOR MAXIMA 1300 ONLY 1342 73-60084-00 GRILLE ASSY 1

342A 34-01184-56 PL* NUT, LOCK M6 4342B 34-60095-27 PL* WASHER, LOCK M6 X 14MM 9343 PL TUBE ASSY, 1/4” -- INCLUDES: 1344 40-60009-01 NUT, 1/4” 1345 40-60008-01 SLEEVE, 1/4” 1346 PL TUBE, COPPER 3/8” -- INCLUDES: 1

346A 40-60170-02 NUT, FLARE 3/8” STARTING WITH SERIAL NUMBER MB829103 1346B 40-60165-00 FITTING STARTING WITH SERIAL NUMBER MB829103 1347 81-60494-00 TUBE, SERPENTINE 1348 14-60007-00 ADAPTOR, 3/8” PRIOR TO SERIAL NUMBER MB829103 1349 44-60044-10 PL* CLAMP 1390 58-00836-18 NSI SPACER 1450 12-00566-00 SAS SENSOR -- INCLUDES: 1451 22-50078-02SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-01SK ) 1


19

5.2. EVAPORATOR KIT ( MAXIMA 1300MT_ )


20



20 58-60279-02 NSI HOSE, AIR 0.7M30 58-60279-01 NSI HOSE, AIR 0.95M60 38-60013-08 BLOWER -- INCLUDES: 1

NS 04-60001-00 BEARING, FRONT 1NS 04-60008-09 BEARING, REAR 1NS 38-60016-00 GREASE KIT 1NS 76-60386-00 REPAIR KIT 1NS 50-60059-00 JACKSHAFT ASSY 1NS 46-00048-00 GREASE 165 68-60370-00 BRACKET 170 68-60371-00 BRACKET 175 86-60098-00 FRAME 195 79-60685-00 POD ASSY -- INCLUDES: 196 58-60345-10 DOOR 197 34-60202-25 PL* SCREW 498 42-60054-00 NSI GASKET 1

100 68-60622-00 GRILLE, EVAP 1105 34-01153-35 PL* SCREW, CAP HXHD M8 X 35MM 8110 34-60028-00 PL* WASHER, FLAT M8 X 30MM 8115 34-60095-30 PL* WASHER, LOCK M8 X 18MM 13120 68-60868-00 BRACKET 1135 79-60492-00 DUCT ASSY 1140 34-01153-20 PL* SCREW, CAP HXHD M8 X 20MM 5150 34-60068-20 SCREW, M6 X 20MM 10155 58-60298-02 GROMMET 1160 73-60079-00 GRILLE 1170 34-60095-27 PL* WASHER, LOCK M6 X 14MM 11175 34-01152-20 PL* SCREW, CAP HXHD M6 X 20MM 4180 48-60322-00 SPACER 1185 58-60391-00 GASKET 1190 34-60056-10 PL* SCREW, CHC M5 X 0.8MM 7200 34-60095-25 PL* WASHER, LOCK M5 X 12MM 10210 50-60224-00 CLUTCH ELECTRO 1215 22-60378-00 NSI HARNESS CLUTCH -- INCLUDES: 1NS 22-50078-01SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-02SK ) 1220 12-01039-08 DEFROST AIR SWITCH 1235 34-01184-56 PL* NUT, LOCK M6 6260 34-00946-55 PL* NUT, HEX M5 2265 34-60085-09 PL* WASHER, M8 X 22MM 4270 34-01184-58 PL* NUT, LOCK M8 4275 34-60196-12 PL* WASHER, FLAT M12 4295 42-00424-11 GASKET 1331 08-60110-00 COIL 1354 58-60154-02 GROMMET 1420 68-60543-00 BRACKET 1430 86-61128-00 NSI BRACKET, TUBE 1490 34-60095-46 PL* WASHER, LOCK M6 X 18MM 3500 34-01249-20 NSI SPACER, M6 X 25MM 9570 42-60090-00 FOAM, RIGHT AND LEFT SIDE 2580 42-60090-01 FOAM, LOW AND HIGH SIDE 2

ADDITIONAL HEATING -- INCLUDES:

470 86-60423-00 NSI PROTECTOR 1475 68-60515-00 NSI BRACKET, HEATER 1480 24-60019-00 NSI HEATER, 1000W 260V 3485 12-00554-01 THERMOSTAT 1NS 22-60333-00 HARNESS, HEATER -- INCLUDES: 1NS 22-01613-16SK C6 CONNECTOR 6 WAYS ( MATES WITH 22-01613-18SK ) 1NS 62-03957-01 DECAL, WARNING HIGH VOLTAGE 1


21


550550


22



10 58-60297-00 FITTING, AIR SENSING 215 68-60629-00 SUPPORT 135 12-00566-52 RAS SENSOR -- INCLUDES: 1

NS 22-50078-01SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-02SK ) 1170 34-60095-27 PL* WASHER, LOCK M6 X 14MM 11200 34-60095-25 PL* WASHER, LOCK M5 X 12MM 13250 34-60000-16 PL* SCREW, CAP HXHD M5 X 16MM 2255 34-01184-55 PL* NUT, LOCK M5 2300 34-01152-35 PL* SCREW, CAP HXHD M6 X 35MM 1305 44-60010-00 PL* CLAMP, TUBE 1/4” 1325 08-60040-00 NSI HEAT EXCHANGER 1330 PL TUBE, COPPER 1” 1/8’ 0.13M332 86-60966-00 BRACKET, HEAT EXCHANGER 1337 08-60180-00 HEAT EXCHANGER 1339 40-00169-44 NSI TEE, REDUCING 1340 73-60084-00 GRILLE ASSY 1

340A 44-60044-01 CLAMP, GRILLE 1342 58-60308-00 FOAM, 15 X 3MM 1347 81-60494-00 TUBE, SERPENTINE 1349 40-00168-04 NSI TEE 1355 40-60010-03 PLUG, MODULE 8 1360 40-60007-21 FITTING, MODULE 14 1361 42-00243-16 O--RING 1362 40-60009-06 NUT, 7/8” 1363 40-60008-07 SLEEVE, 7/8” 1365 40-60007-17 FITTING, MODULE 8 1366 42-00243-04 O--RING 1367 40-60009-03 NUT, 1/2” 1368 40-60008-03 SLEEVE, 1/2” 1370 42-00243-15 O--RING, MODULE 14 1375 42-00243-04 O--RING, MODULE 8 1380 42-60041-00 NSI INSULATION, TUBE 1385 42-60007-15 NSI INSULATION, TUBE 1390 42-60009-00 NSI INSULATION, 5CM X 15M 1395 44-60009-03 NSI CLAMP, EXCHANGER 2400 PL TUBE, COPPER 1/2” 1405 44-00293-24 NSI CLAMP, STEPLESS 1--1/2” 3415 PL TUBE, COPPER 1” 1/8’ 1450 12-00566-00 SAS SENSOR -- INCLUDES: 1451 22-50078-02SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-01SK ) 1510 PL TUBE, COPPER 1/2” 0.02M520 40-60102-05 NUT, MODULE 14 1530 40-60102-06 NUT, MODULE 8 1540 40-60010-06 PLUG, MODULE 14 1550 58-60668-00 PROTECTOR, END OF HOSE CLAMPS 2590 58-00836-18 SPACER 1


23



24



5 68-60314-00 BRACKET, EXPANSION VALVE 125 58-01284-00 TUBE, HEAT SHRINK 155 44-60044-03 PL* CLAMP 180 42-60042-01 GASKET 185 58-60399-01 FITTING 190 58-60401-00 PL* NUT, M20 X 1.5MM 1

200 34-60095-25 PL* WASHER, LOCK M5 X 12MM 13250 34-60000-16 PL* SCREW, CAP HXHD M5 X 16MM 2255 34-01184-55 PL* NUT, LOCK M5 2280 34-01197-10 PL* SCREW, CAP HXHD M4 X 10MM 2285 34-60095-24 PL* WASHER, LOCK M4 X 10MM 2310 58-01286-00 HOSE 2M320 44-60044-10 PL* CLAMP, 7/8” 1330 PL TUBE, COPPER 1” 1/8’ 0.13M331 08-60110-00 COIL 1333 68-61297-00 CLAMP, HEAT EXCHANGER 1

334A 14-60039-00 EXPANSION VALVE 1334B 14-60009-06 ORIFICE 1335 44-60009-04 PL* CLAMP, HOSE 1336 12-00256-21 DTT THERMOSTAT 1337 08-60180-00 HEAT EXCHANGER 1338 42-00243-10 O--RING 1341 44-00293-24 CLAMP 2342 58-60308-00 FOAM, 15 X 3MM 1343 PL TUBE ASSY, 1/4” -- INCLUDES: 1344 40-60009-01 NUT, 1/4” 1345 40-60008-01 SLEEVE, 1/4” 1346 PL TUBE, 3/8” -- INCLUDES: 1

346A 40-60170-02 NUT, FLARE 3/8” STARTING WITH SERIAL NUMBER MB829074 1346B 40-60165-00 FITTING STARTING WITH SERIAL NUMBER MB829074 1347A PL TUBE ASSY, 1/2” -- INCLUDES: 1347B 40-60009-03 NUT, 1/2” 1347C 40-60008-03 SLEEVE, 1/2” 1348 14-60007-00 ADAPTOR, 3/8” PRIOR TO SERIAL NUMBER MB829074 1350 42-00243-09 O--RING 1351 14-60062-05 LSV VALVE 1NS 14-60062-10 REPAIR KIT 1352 22-60590-00 COIL, 12V 1353 68-70161-00 NSI BRACKET, VALVE 1


25

6. ACCUMULATOR KIT


26


6. ACCUMULATOR KIT

2 12-00283-00 SPT SUCTION PRESSURE TRANSDUCER (MATES WITH 22--50098--84SK)15 12-60015-01 LP1 LOW PRESSURE SWITCH -- INCLUDES: 1

NS 22-02392-00SK CONNECTOR 2 WAYS ( MATES WITH 22-01585-00SK ) 16 40-60193-01 FITTING, 1/4” 1

10 14-00303-02 BY--PASS VALVE (NC) 1NS 14-00303-10 REPAIR KIT 120 14-01042-06 VALVE, SERVICE 1--1/8” 130 14-60052-01* CPR VALVE PRIOR TO SERIAL NUMBER MB821035 130 14-60052-02 CPR VALVE STARTING WITH SERIAL NUMBER MB821035 140 17-10811-05 GASKET, SERVICE ONLY 150 40-60155-02 ELBOW, 90_ 1 OR 255 40-60004-00 PLUG, 1/4” 160 22-60590-00 COIL, 12V ( MATES WITH 22--01613--00SK ) 170 44-60027-13 PL* CLAMP 180 44-60027-19 PL* CLAMP, ID39 PRIOR TO SERIAL NUMBER MB821035 180 44-60027-18 PL* CLAMP, ID38 STARTING WITH SERIAL NUMBER MB821035 190 PL TUBE, COPPER 1--3/8” 1

100 65-60042-02 ACCUMULATOR ASSY, CAPACITY 5L 1110 68-61858-00 BRACKET ASSY 1120 68-60982-00 PL* BRACKET 1140 73-60076-00 VIBRASORBER, SUCTION 1--1/8” PRIOR TO S/N MB546036 1140 73-60090-00 VIBRASORBER, SUCTION 1--1/8” STARTING WITH S/N MB546036 1150 PL TUBE, COPPER 1--1/8” ( MAXIMA 1000 ) 1150 81-60060-01 TUBE, BY PASS 1--3/8” ( MAXIMA 1300Mt_ ) 1160 ELBOW, MODIFIED 1--1/8” -- 90_ -- INCLUDES: 1161 40-00072-20 PL* ELBOW, 90_ PRIOR TO SERIAL NUMBER MB546036 1161 40-00073-20 PL* ELBOW, 90_ STARTING WITH SERIAL NUMBER MB546036 1162 40-60004-00 PLUG, 1/4” 1163 40-60159-00 FITTING, 1/4” 1170 PL TUBE ASSY -- INCLUDES: 1171 40-60158-10 ADAPTER ( MAXIMA 1300Mt_ ) 1180 40-60041-00 ADAPTER, LP 1190 40-60042-00 ADAPTER, HP 1200 34-60082-60 PL* SCREW, CAP SKTHD M6 X 60MM 2210 34-60084-06 PL* WASHER, LOCK M6 X 10MM 4220 34-00302-14 PL* SCREW, CAP HXHD 5/16--18MM 2230 34-00876-20 PL* SCREW, HXHD M8 X 20MM 1240 34-01152-25 PL* SCREW, CAP HXHD M6 X 25MM 2250 34-01184-56 PL* NUT, LOCK M6 4260 34-01184-58 PL* NUT, LOCK M8 2270 34-01184-60 PL* NUT, LOCK M10 1280 34-01249-24 PL* WASHER, SPACER M14 X 40MM 1290 34-60085-09 PL* WASHER, M8 X 22MM 4300 34-60095-46 PL* WASHER, LOCK M6 X 18MM 6310 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 2320 34-60082-50 PL* SCREW, HEAD CHC M6--50MM 2330 12-00572-00 LP LOW PRESSURE SWITCH ( MAXIMA 1300Mt_ ) 1350 58-60373-00 HOSE, 1/4” ( MAXIMA 1300Mt_ ) 1360 68-61000-00 BRACKET ( MAXIMA 1300Mt_ ) 1370 34-60213-08 PL* SCREW, HXHD M4 X 8MM ( MAXIMA 1300Mt_ ) 2

* CPR VALVE 14-60052-01 IS NO LONGER OFFERED,ORDER CPR VALVE 14-60052-02 + CLAMP 44-60027-18 ITEM 80BE CAREFUL, CPR VALVE 14-60052-02 COULD BE ALREADY INSTALLED. IN THIS CASE,ORDER ONLY 14-60052-02


27

7. DRIVE KIT


28


7. DRIVE KIT

30 54-00581-00 MOTOR, AC 11KW WATER COOLING -- INCLUDES: 1NS 04-60008-42 BEARING 2NS 34-60022-00 KEY, 8 X 7 X 40 2BR 1NS 34-60022-01 KEY, 8 X 7 X 30 2BR 131 48-60154-00 JACKSHAFT, WITHOUT MOTOR VERSION ONLY -- INCLUDES: 1

NS 04-60011-39 BEARING 2NS 34-60022-01 KEY, 7X8X30 2BR 1NS 34-60022-00 KEY, 7X8X40 2BR 170 18-00063-32 COMPRESSOR 05K4, UNIVERSAL, NO UNLOADER -- INCLUDES: 170 18-00063-31SV COMPRESSOR 05K4, REMAN R404A, NO UNLOADER -- INCLUDES: 1

NS 17-44719-00 KEY 1120 34-00308-10 PL* SCREW, CAP HXHD 1/2--13 X 1.25MM 4130 34-00368-15 PL* WASHER, LOCK 4150 34-00740-45 PL* SCREW, CAP HXHD M12--1.75 X 45MM 2153 34-00740-80 PL* SCREW, CAP HXHD M12 X 80MM ( MAXIMA 1300 / 1300Mt_ ) 1160 34-00873-25 PL* SCREW, CAP HXHD M10 X 25MM 2180 34-00873-30 PL* SCREW, CAP HXHD M10 X 30MM 9200 34-00873-50 PL* SCREW, CAP HXHD M10 X 50MM 1220 34-00873-85 PL* SCREW, CAP HXHD M10 X 85MM 3240 34-00944-10 PL* WASHER, FLAT M10 8270 34-60196-12 PL* WASHER, FLAT M12 9280 34-00944-14 PL* WASHER, FLAT 14MM 4330 34-00946-14 PL* NUT, HEX M14 3410 34-01184-60 PL* NUT, LOCK M10 3440 34-01184-62 PL* NUT, LOCK M12 4450 34-01184-64 PL* NUT, LOCK M14 1470 34-01249-22 NSI SPACER, M10 X 50MM 6600 34-60085-10 PL* WASHER, M10 X 22MM 22740 34-60129-00 TIE ROD 2800 48-60075-01 NSI SPACER 1820 48-60188-05 NSI SPACER 1840 48-60231-00 PL* WASHER 1870 50-60324-00 PULLEY 1900 50-60325-00 PULLEY ( MAXIMA 1300 / 1300Mt_ ) 1900 50-60325-01 PULLEY ( MAXIMA 1000 ) 1910 50-60225-00 BELT TENSIONER -- INCLUDES: 1911 04-60008-09 BEARING 2930 68-70263-00 BRACKET 1960 68-61112-00 BRACKET 1980 73-00096-00 SHOCKMOUNT 3990 73-00154-02 SHOCKMOUNT 3996 86-60868-00 BRACKET ASSY, ELEC. MOTOR 1


29

7. DRIVE KIT


30


7. DRIVE KIT

20 48-60357-00 SPACER, COMPRESSOR 150 10-60018-00SV SPEED SOLENOID, 12V ( MAXIMA 1300 / 1300Mt_ ) -- INCLUDES: 151 22-50078-02SK CONNECTOR ( MATES WITH 22--50078--01SK ) 152 58-60201-00 BOOT 153 12-60041-00 PLUG ASSY 180 26-60004-03 ENGINE, CT 4.91 TV * -- INCLUDES: 1

NS 942193 GASKET, EXHAUST PIPE 1NS 7103921 GLOW PLUG 1NS 29-70157-00 QUICK GLOW PLUG 181 30-60119-00 OIL FILTER 182 945516 DIPSTICK PRIOR TO ENGINE SERIAL NUMBER WF5452 182 25-15014-00 DIPSTICK STARTING WITH ENGINE SERIAL NUMBER WG0001 183 29-70206-00 RUN & STOP SOLENOID -- INCLUDES: 1

NS 945690 SOLENOID GASKET 1NS 22-50078-08SK CONNECTOR 3 WAYS ( MATES WITH 22-50078-05SK ) 184 50-60329-01 POLY V--BELT 3PK, WATER PUMP ENGINE 1

100 73-60081-00 ROD, LINKAGE ( MAXIMA 1300 / 1300Mt_ ) 1110 34-00913-10 PL* SCREW, CAP HXHD 3/8” -- 16MM X 1.25MM 9140 34-60119-02 PL* SCREW, CAP HXHD 5/16--18 X 1MM 1180 34-00873-30 PL* SCREW, CAP HXHD M10 X 30MM 9220 34-00873-85 PL* SCREW, CAP HXHD M10 X 85MM 3230 34-00876-20 PL* SCREW, CAP HXHD M8 X 20MM 6235 34-00876-25 PL* SCREW, CAP HXHD M8 X 25MM 5290 34-00945-10 PL* WASHER, LOCK 10 WL 14350 34-00961-25 PL* SCREW, CAP HXHD M10 X 25MM 10410 34-01184-60 PL* NUT, LOCK M10 3420 34-01184-56 PL* NUT, LOCK M6 ( MAXIMA 1300 / 1300Mt_ ) 1455 34-01153-40 PL* SCREW, CAP HXHD M8 X 40MM 2470 34-01249-22 NSI SPACER, M10 X 50MM 6490 34-01249-26 NSI SPACER, M10 X 25MM 8570 34-60082-16 PL* SCREW, CAP SKTHD M6 X 16MM ( MAXIMA 1300 / 1300Mt_ ) 4590 34-60085-09 PL* WASHER, M8 X 22MM 6595 34-60085-08 PL* WASHER, M8 X 16MM 7600 34-60085-10 PL* WASHER, M10 X 22MM 22700 34-60095-27 PL* WASHER, LOCK M6 X 14MM ( MAXIMA 1300 / 1300Mt_ ) 5760 44-01049-00 CLIP, RETAINING ( MAXIMA 1300 / 1300Mt_ ) 1780 44-60013-00 CLIP, LINKAGE ROD ( MAXIMA 1300 / 1300Mt_ ) 1810 48-60172-01 SPACER 1830 48-60188-10 NSI SPACER 2880 50-60196-00 CLUTCH ASSY -- INCLUDES: 1881 50-60196-11 ROTOR ASSY -- INCLUDES: 1882 73-00112-00 SPRING 6883 50-60196-10 HOUSING CLUTCH 1NS 50-50020-01 CLUTCH SERVICE KIT 1920 68-70319-00 BRACKET ( MAXIMA 1300 / 1300Mt_ ) 1940 68-60631-00 GUARD 1980 73-00096-00 SHOCKMOUNT 3990 73-00154-02 SHOCKMOUNT 3994 86-61062-00 BRACKET, ENGINE 2992 86-61069-00 BRACKET, SOLENOID ( MAXIMA 1300 / 1300Mt_ ) 1

* SEE MANUAL 62-61723-01


31

7.1 BELT

5

10

15

20

25

21


32


7.1 BELT

5 50-60329-07 BELT, VENTILATION BOX 110 50-60288-07 BELT, VENTILATION BOX / CLUTCH ELECTRO 115 50-60411-00 BELT, VENTILATION BOX / ELECTRIC MOTOR 120 50-60288-00 BELT, ELECTRIC MOTOR / ALTERNATOR FOR MAXIMA 1000 / 1300 121 50-60288-23 BELT, ELECTRIC MOTOR / ALTERNATOR FOR MAXIMA 1300Mt_ 125 50-60289-61 BELT, ELECTRIC MOTOR / COMPRESSOR FOR MAXIMA 1000 125 50-60289-50 BELT, ELECTRIC MOTOR / COMPRESSOR FOR MAXIMA 1300 / 1300Mt_1


33

8. ALTERNATOR KIT

150B151B

152B


34


8. ALTERNATOR KIT

10 34-00876-20 PL* SCREW, CAP HXHD M8 X 20MM 120 34-00961-25 PL* SCREW, CAP HXHD M10 X 25MM 340 48-60451-00 SHAFT TENSIONER 150 34-01184-56 PL* NUT, LOCK M6 160 34-01184-58 PL* NUT, LOCK M8 180 34-60085-09 PL* WASHER, M8 X 22MM 285 34-60085-12 PL* WASHER, M12 X 24MM 190 86-61063-01 BRACKET ASSY 1

100 34-60085-10 PL* WASHER, M10 X 22MM 5110 34-60095-46 PL* WASHER, LOCK M6 X 18MM 1120 68-70522-00 STRAP, MOUNTING 1130 68-61107-00 BRACKET 1140 86-60774-00 PROTECTOR 1150 30-60050-03 ALTERNATOR, 14V 50A PRIOR TO S/N MC005021 -- INCLUDES: 1151 30-60050-22 DIODE BRIDGE 1152 04-60008-19 BEARING, FRONT 1153 04-60008-04 BEARING, REAR 1154 30-60050-20 REGULATOR AND BRUSH 1

150B 30-01114-07 ALTERNATOR 14V 70A STARTING WITH S/N MC005021 -- INCLUDES: 1151B 50-01168-02 PULLEY, ∅ 3.48 1152B 30-01114-53 NUT, M16 1

NS 30-01114-55 REAR PLASTIC COVER 1NS 34-01114-56 BRUSH HOLDER ASSY 1NS 76-61263-00 ALTERNATOR ADAPTATION TERMINAL KIT 1160 34-00873-70 PL* SCREW, CAP HXHD M10--70 1170 34-00944-10 PL* WASHER, FLAT M10 2180 73-60097-00 SHOCKMOUNT 1190 34-01184-60 PL* NUT, LOCK M10 2200 50-60288-00 BELT, ELECTRIC MOTOR / ALTERNATOR FOR MAXIMA 1000 / 1300

( SEE SECTION 7.1 ) 1201 50-60288-23 BELT, ELECTRIC MOTOR / ALTERNATOR FOR MAXIMA 1300Mt_

( SEE SECTION 7.1 ) 1210 34-00873-25 PL* SCREW, CAP HXHD M10 X 25MM 2220 34-00890-04 PL* WASHER, FLAT 1230 86-04325-00 PL* NUT ASSY 1240 48-60008-00 SPACER 1250 34-00740-80 PL* SCREW, CAP HXHD M12 X 80MM 1260 34-01152-60 PL* SCREW, CAP HXHD M6 X 60MM 1270 68-60505-00 BRACKET ( MAXIMA 1300Mt_ ) 1280 34-00945-10 PL* WASHER, LOCK M10 6290 34-01249-26 SPACER, M10 X 25MM 6300 34-00873-35 PL* SCREW, CAP HXHD M10 X 35MM 2310 04-00049-03 BUSHING, HUB ( MAXIMA 1300Mt_ ) 1320 50-60075-02 PULLEY ( MAXIMA 1300Mt_ ) 1330 54-00603-04 GENERATOR ( MAXIMA 1300Mt_ ) -- INCLUDES: 1NS 54-00603-58 REAR COVER 1NS 54-00603-53 FAN 1NS 54-00603-63 BEARING, REAR 1NS 54-00603-62 BEARING, FRONT 1NS 22-01613-16SK CONNECTOR 6 WAYS ( MATES WITH 22-01613-18SK ) 1NS 34-60022-00 KEY 8X7X40 2BR 1340 86-60468-00 NSI BRACKET ( MAXIMA 1300Mt_ ) 1


35

9. FUEL SYSTEM KIT

85

76


36


9. FUEL SYSTEM KIT

10 34-60082-25 PL* SCREW, HEAD CHC M6 X 25MM 330 34-60095-27 PL* WASHER, LOCK M6 X 14MM 340 48-60063-00 FILTER HEAD 170 79-60621-00 HOSE ASSY, QUICK CONNECT -- INCLUDES: 171 40-60260-01 NSS FITTING, 3 WAYS 272 58-00507-00 TUBE, BLACK 1/4” CUT TO LENGHT73 44-60042-03 COLLAR, TUBE 274 58-60588-05 HOSE CUT TO LENGHT75 40-60236-01 FITTING, BLACK FEMALE QUICK CONNECT 176 40-60235-10 FITTING, PURPLE MALE QUICK CONNECT 177 40-60259-01 FITTING, 90_ QUICK CONNECT 180 79-60512-01 BANJO ASSY, QUICK CONNECT -- INCLUDES: 181 40-60026-03 FITTING, BANJO 182 44-60042-01 PL* COLLAR, TUBE 183 58-00580-00 TUBE, RED 3/8” CUT TO LENGHT84 40-60236-00 FITTING, BLACK FEMALE QUICK CONNECT 185 40-60235-10 FITTING, PURPLE MALE QUICK CONNECT 190 30-60055-05 BOLT, BANJO 1

100 40-60266-00 SCREW HOLLOW 1110 42-60025-00 SEAL BONDED 4120 44-60042-03 PL* COLLAR, TUBE 2130 30-00302-00 FILTER FUEL 1140 79-60512-04 BANJO ASSY, QUICK CONNECT -- INCLUDES: 1141 40-60026-03 FITTING, BANJO 1142 44-60042-01 PL* COLLAR, TUBE 2143 58-00580-00 TUBE, RED 3/8” CUT TO LENGHT144 40-60261-00 FITTING 1160 44-60006-03 PL* CLAMP DOUBLE 1170 34-01152-35 PL* SCREW, CAP HXHD M6 X 35MM 1180 34-60095-46 PL* WASHER, LOCK M6 X 18MM 1


37

10. OIL SYSTEM KIT


38


10. OIL SYSTEM KIT

10 12-00592-00 SWITCH, LOW PRESSURE OIL -- INCLUDES: 111 22-50078-02SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-01SK ) 120 30-00302-00 FILTER OIL 130 30-60055-05 BOLT, BANJO 290 34-60095-27 PL* WASHER, LOCK M6 X 14MM 3

140 42-60025-00 SEAL BONDED ∅ 16.7 5220 48-60063-00 FILTER HEAD 1310 34-60082-25 PL* SCREW, HEAD CHC M6 X 25MM 3360 44-60044-04 PL* CLAMP 1370 42-60040-23 SEAL RING ∅ 22.7 2380 48-60125-03 BOLT, BANJO 1390 48-60126-00 SCREW, BANJO 1400 48-60127-00 PLUG, MALE M16 X 1.5MM 1420 79-60622-00 HOSE ASSY, OIL BLACK -- INCLUDES: 1421 58-00580-00 TUBE, RED 3/8” CUT TO LENGHT422 40-60026-03 FITTING, BANJO 1423 44-60042-01 COLLAR, TUBE 2424 48-60233-00 GASKET, 15 X 12 1425 40-60265-00 NSI TEE 1426 48-60233-01 GASKET, 11 X 8 1427 48-60232-00 PL* SCREW, M8 X 1.25MM 1430 79-60622-01 HOSE ASSY, OIL RED -- INCLUDES: 1431 58-00580-00 TUBE, RED 3/8” CUT TO LENGHT432 40-60026-03 FITTING, BANJO 1433 44-60042-01 COLLAR, TUBE 2NS 40-60120-14 FITTING, 1/8” 1


39

11.1 COOLANT KIT: STANDBY

580

620

630

270620

270620

580


40


11.1 COOLANT KIT: STANDBY

40 12-01145-05 WTS SENSOR -- INCLUDES: 1NS 22-50078-02SK CONNECTOR 2 WAYS ( MATES WITH 22-50078-01SK ) 150 58-60524-02SV COOLANT BOTTLE PRIOR TO SERIAL NUMBER MB431064 150 58-60524-03 COOLANT BOTTLE STARTING WITH SERIAL NUMBER MB431064 160 30-60014-00 CAP, BOTTLE COOLANT 180 30-60102-00 WATER PUMP ( MATES WITH CONNECTOR 2 WAYS 22-50098-72SK ) 1

110 34-01152-60 PL* SCREW, CAP HXHD M6 X 60MM 1130 34-01249-20 SPACER, M6 X 25MM 2140 34-60068-20 SCREW, M6 X 20MM 1170 34-60095-46 PL* WASHER, LOCK M6 X 18MM 7190 40-60162-00 FITTING, 3/8” -- 1/8” 1200 44-60009-03 PL* CLAMP, HOSE WORM TYPE 2230 44-60011-04 PL* CLAMP 4250 44-60011-10 PL* CLAMP 4260 44-60011-15 PL* CLAMP, HOSE 2270 44-60045-09 PL* CLAMP 1280 44-60061-00 BASE 4290 44-60042-08 PL* COLLAR, TUBE 1295 44-60042-13 PL* COLLAR, TUBE 1310 56-60941-01 NSI TUBE, WATER 1320 58-60039-00SAV HOSE, WATER 2330 58-60039-00SAV HOSE, LOWER COOLANT 1340 79-60624-01 HOSES, WATER -- INCLUDES: 1341 30-60109-00 CHECK VALVE 1342 44-60045-04 PL* CLAMP 2343 58-60668-00 PROTECTOR, END OF HOSE CLAMPS 2350 58-60067-01 HOSE, WATER ENGINE 2390 68-70724-00 BRACKET ASSY 1400 58-60671-00 HOSE, WATER 1410 86-60621-00 TUBE, WATER 1420 86-60631-00 TUBE, WATER 1440 58-60139-01 NSI TUBE 2450 44-00285-75 PL* CLAMP, TUBE ASSY 4460 34-60082-45 PL* SCREW, CAP SKTHD M6 X 45MM 8470 34-60084-06 PL* WASHER, LOCK M6 X 10MM 8480 34-01152-40 PL* SCREW, CAP HXHD M6 X 40MM 2490 34-01184-56 PL* NUT, LOCK M6 2500 58-60688-01 HOSE 1530 44-60072-00 PL* CLAMP 2550 44-60044-13 PL* CLAMP 1560 34-60082-70 PL* SCREW, CHC M6 X 70MM 1570 44-00285-101 PL* CLAMP 1580 44-60045-04 PL* CLAMP, HOSE 5600 30-60016-00 CAP 1610 42-60042-00 GASKET 1620 58-60668-01 PROTECTOR, END OF HOSE CLAMPS 4630 58-60668-00 PROTECTOR, END OF HOSE CLAMPS 2


41

11.2 COOLANT KIT: NO STANDBY

580

580

270

630

620

620

620


42


11.2 COOLANT KIT: NO STANDBY

40 12-01145-05 WTS SENSOR -- INCLUDES: 1NS 22-50078-02SK CONNECTOR 2 WAYS ( MATES WITH 22--50078--01SK ) 150 58-60524-02SV COOLANT BOTTLE PRIOR TO SERIAL NUMBER MB431064 150 58-60524-03 COOLANT BOTTLE STARTING WITH SERIAL NUMBER MB431064 160 30-60014-00 CAP, BOTTLE COOLANT 1

110 34-01152-60 PL* SCREW, CAP HXHD M6 X 60MM 1140 34-60068-20 SCREW, M6 X 20MM 2170 34-60095-46 PL* WASHER, LOCK M6 X 18MM 1190 40-60162-00 FITTING, 3/8” --1/8” 1200 44-60009-03 PL* CLAMP, HOSE WORM TYPE 2220 44-60045-07 PL* CLAMP, HOSE 1250 44-60011-10 PL* CLAMP 4260 44-60011-15 PL* CLAMP, HOSE 2270 44-60045-09 PL* CLAMP 1280 44-60061-00 BASE 1290 44-60042-08 PL* COLLAR, TUBE 2295 44-60042-13 PL* COLLAR 1320 58-60039-00SAV HOSE, WATER 2330 58-60039-00SAV HOSE, LOWER COOLANT 1340 79-60604-01 HOSES, WATER -- INCLUDES: 1341 30-60109-00 CHECK VALVE 1342 44-60045-04 PL* CLAMP 2343 58-60668-00 PROTECTOR, END OF HOSE CLAMPS 2350 58-60067-01 HOSE, WATER ENGINE 2390 68-70724-00 BRACKET ASSY 1400 58-60671-00 TUBE ASSY 1410 56-61269-00 TUBE, WATER 1420 86-60631-00 TUBE, WATER 1450 44-00285-75 PL* CLAMP, TUBE ASSY 4460 34-60082-45 PL* SCREW, CAP SKTHD M6 X 45MM 8470 34-60084-06 PL* WASHER, LOCK M6 X 10MM 10490 34-01184-56 PL* NUT, LOCK M6 1500 58-60688-01 HOSE, FUEL 0.8M550 44-60044-13 PL* CLAMP, 1--1/4” 1580 44-60045-04 PL* CLAMP, HOSE 2600 30-60016-00 CAP 1610 42-60042-00 GASKET 1620 58-60668-01 PROTECTOR, END OF HOSE CLAMPS 7630 58-60668-00 PROTECTOR, END OF HOSE CLAMPS 2


43


12. AIR CLEANER KIT

80

10 30-00426-01 AIR CLEANER, DRY WITHOUT SAFETY FILTER -- INCLUDES: 1NS 30-00426-20 FILTER ELEMENT 111 30-00426-22 NSI COVER 112 30-00426-23 NSI VACUATOR 120 30-60074-00 CLAMP, AIR CLEANER 130 44-60045-10 PL* CLAMP, HOSE 240 58-60583-00 HOSE, AIR 150 34-01152-30 PL* SCREW, CAP HXHD M6 X 30MM 260 34-60095-46 PL* WASHER, LOCK M6 X 18MM 470 34-01184-56 PL* NUT, LOCK M6 280 58-60668-01 PROTECTOR, END OF HOSE CLAMPS 2


44


13.1 EXHAUST KIT: STANDARD VERSION PRIOR TO SERIAL NUMBER MB922000

10 30-00210-00 SCHNORCKELL 115 30-60054-01 CLAMP, U--BOLT 120 44-60066-01 CLAMP 125 30-60048-01 EXHAUST PIPE 130 30-60089-00 EXHAUST PIPE 140 30-60083-00 MUFFLER 150 30-60084-00 EXHAUST PIPE 160 34-01153-45 PL* SCREW, CAP HXHD M8 X 45MM 270 34-60090-08 PL* NUT, SELF LOCK M8 380 34-60095-30 PL* WASHER, LOCK M8 X 18MM 290 68-61100-00 CLAMP 295 68-60800-00 PROTECTOR 1

100 73-60054-00 VIBRABSORBER 1110 34-00876-20 PL* SCREW, CAP HXHD M8 X 20MM 1120 34-00945-10 PL* WASHER, LOCK 10 WL 2130 34-00961-25 PL* SCREW, CAP HXHD M10 X 25MM 2140 34-60085-09 PL* WASHER, M8 X 22MM 2150 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 1160 942193 GASKET 1


45


13.2 EXHAUST KIT: STANDARD VERSION BETWEEN SERIAL NUMBER MB922000 & MC022083ALL OTHER VERSIONS PRIOR TO SERIAL NUMBER MC022083

20 44-60066-01 CLAMP 230 30-60104-00 EXHAUST PIPE 140 30-60103-00 MUFFLER ( LOW NOISE VERSION ONLY ) 140 30-60107-00 MUFFLER ( ALL OTHER VERSIONS ) 150 30-60084-00 EXHAUST PIPE 160 34-01153-45 PL* SCREW, CAP HXHD M8 X 45MM 270 34-60090-08 PL* NUT, SELF LOCK M8 380 34-60095-30 PL* WASHER, LOCK M8 X 18MM 290 68-61100-00 CLAMP 295 68-60800-00 PROTECTOR 1

100 73-60054-00 VIBRABSORBER 1120 34-00945-10 PL* WASHER, LOCK 10 WL 2130 34-00961-25 PL* SCREW, CAP HXHD 2140 34-60085-09 PL* WASHER, M8 X 22MM 2150 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 1160 68-70299-00 CLAMP ( LOW NOISE VERSION ONLY ) 2160 79-60640-00 CLAMP ( ALL OTHER VERSIONS ) 2170 34-00876-40 PL* SCREW, CAP HXHD M8 X 40MM 1200 942193 GASKET 1


46


13.3 EXHAUST KIT: STANDARD VERSION STARTING WITH SERIAL NUMBER MC022083ALL OTHER VERSIONS STARTING WITH SERIAL NUMBER MC022083

10 67-60783-00 BRACKET STARTING WITH SERIAL NUMBER MC026126 115 44-60066-01 CLAMP PRIOR TO SERIAL NUMBER MC026126 220 67-60782-00 BRACKET STARTING WITH SERIAL NUMBER MC026126 130 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 340 30-60122-00 EXHAUST PIPE 1

50A 30-60103-00 MUFFLER ( LOW NOISE VERSION ONLY ) PRIOR TO S/N MC026126 150A 30-60107-00 MUFFLER ( ALL OTHER VERSIONS ) PRIOR TO S/N MC026126 150B 30-60123-00 MUFFLER STARTING WITH SERIAL NUMBER MC026126 1

70 34-60090-08 PL* NUT, SELF LOCK M8 180 34-60095-30 PL* WASHER, LOCK M8 X 18MM PRIOR TO SERIAL NUMBER MC026126 295 68-60800-00 PROTECTOR 1

120 34-00945-10 PL* WASHER, LOCK 10 WL 2130 34-06188-00 PL* NUT, JAM M10 X 1.25MM 4140 34-60085-09 PL* WASHER, M8 X 22MM 1160 79-60640-00 CLAMP ( ALL OTHER VERSIONS ) PRIOR TO S/N MC026126 2170 34-00876-40 PL* SCREW, CAP HXHD M8 X 40MM PRIOR TO S/N MC026126 1


47

14.1 ELECTRICAL KIT ( MAXIMA 1000 )

300

310310

320 130.140 60

20

60.310

60.310

10.160.170.180

250.190

40.44

320

260

41.42

43

220230240250


48


14.1 ELECTRICAL KIT ( MAXIMA 1000 )

10 91-60267-20 NSA CONTROL BOX ASY, W/O STANDBY ( SEE SECTION 15.3 ) 110 91-60267-21 NSA CONTROL BOX ASY, PHASE DETECTION ( SEE SECTION 15.3 ) 110 91-60267-22 NSA CONTROL BOX ASY, PHASE REVERSAL ( SEE SECTION 15.3 ) 110 91-60284-20 NSA CONTROL BOX ASSY, W/O STANDBY ( SEE SECTION 15.4 ) 110 91-60284-21 NSA CONTROL BOX ASSY, PH DETECTION ( SEE SECTION 15.4 ) 110 91-60284-22 NSA CONTROL BOX ASSY, PH REVERSAL ( SEE SECTION 15.4 ) 120 91-60220-00 NSA DISPLAY ASSY, PH. DETECTION & REVERSAL ( SEE SECTION 15.8 ) 120 91-60220-01 NSA DISPLAY ASSY, W/O STANDBY ( SEE SECTION 15.8 ) 140 91-60227-00 NSA BOX, STANDBY -- INCLUDES: 141 34-01197-40 PL* SCREW, CAP HXHD M4 X 40MM 442 34-60095-24 PL* WASHER, LOCK M4 X 10MM 443 PL BRACKET 144 22-60389-01 RECEPTACLE ASSY, 380/5/32A 1

NS 62-03957-01 DECAL, WARNING HIGH VOLTAGE 1NS 62-60332-00 NSI DECAL, CHECK ROTATION 1NS 62-60280-00 NSI DECAL, STANDBY SAFETY 160 44-60061-00 FOOT 8

130 34-00946-58 PL* NUT, HEX M8--1.25MM 2140 34-60095-30 PL* WASHER, LOCK M8 X 18MM 2160 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 4170 34-60085-09 PL* WASHER, M8 X 22MM 2180 34-01184-58 PL* NUT, LOCK M8 2190 34-00946-56 PL* NUT, HEX M6 1220 44-60044-11 PL* CLAMP 6230 34-01184-56 PL* NUT, LOCK M6 5240 34-01152-16 PL* SCREW, CAP HEX M6 X 16MM 2250 34-60095-27 PL* WASHER, LOCK M6 X 14MM 3260 34-60068-20 SCREW, M6 X 20MM 3300 58-60215-07 TUBE, SLIT 0.35M310 58-60215-01 NSI TUBE, SLIT 0.4M320 42-00183-00 TRIM, FLEXIBLE 0.45M


49

14.2 ELECTRICAL KIT ( MAXIMA 1300 / 1300MT_ )

320

260

250.190

300

310

310

320

220.230.240.250

130.140

20

10.160.170.180

40

41.42

43

44


50


14.2 ELECTRICAL KIT ( MAXIMA 1300 / 1300MT_ )

10 91-60266-01 NSA CONTROL BOX ASY, PH. REVERSAL MAXIMA 1300Mt_ (SEE SECTION 15.5)110 91-60267-10 NSA CONTROL BOX ASY, W/O STANDBY MAXIMA 1300 ( SEE SECTION 15.3 )110 91-60267-11 NSA CONTROL BOX ASY, PH. DETECTION MAXIMA 1300 ( SEE SECTION 15.3 )110 91-60267-12 NSA CONTROL BOX ASY, PH. REVERSAL MAXIMA 1300 ( SEE SECTION 15.3 )110 91-60284-10 NSA CONTROL BOX ASSY, W/O STANDBY MAXIMA 1300 ( SEE SECTION 15.4 )110 91-60284-11 NSA CONTROL BOX ASSY, PH DETECTION MAXIMA 1300 ( SEE SECTION 15.4 )110 91-60284-12 NSA CONTROL BOX ASSY, PH REVERSAL MAXIMA 1300 ( SEE SECTION 15.4 )120 91-60217-00 NSA DISPLAY ASSY, PH. DETECT & REVERS MAXIMA 1300 (SEE SECTION 15.8)120 91-60217-01 NSA DISPLAY ASSY, W/O STANDBY MAXIMA 1300 ( SEE SECTION 15.8) 120 91-60269-00 NSA DISPLAY ASSY, PH. REVERSAL MAXIMA 1300Mt_ ( SEE SECTION 15.8 )140 91-60209-00 NSA BOX, STANDBY -- INCLUDES: 141 34-01197-40 PL* SCREW, CAP HXHD M4 X 40MM 442 34-60095-24 PL* WASHER, LOCK M4 X 10MM 443 PL BRACKET 144 22-60389-01 RECEPTACLE ASSY, 380/5/32A 1

NS 62-03957-01 DECAL, WARNING HIGH VOLTAGE 1NS 62-60332-00 NSI DECAL, CHECK ROTATION 1NS 62-60280-00 NSI DECAL, STANDBY SAFETY 1130 34-00946-58 PL* NUT, HEX M8--1.25 1140 34-60095-30 PL* WASHER, LOCK M8 X 18MM 2160 34-60152-00 PL* SCREW, HX WASHHD HM8 LENGHT 25MM 4170 34-60085-09 PL* WASHER, M8 X 22MM 2180 34-01184-58 PL* NUT, LOCK M8 2190 34-00946-56 PL* NUT, HEX M6 1200 34-00946-55 PL* NUT, HEX M5 3230 34-01184-56 PL* NUT, LOCK M6 3240 34-01152-16 PL* SCREW, CAP HXHD M6 X 16MM 1250 34-60095-27 PL* WASHER, LOCK M6 X 14MM 3300 58-60215-07 TUBE, SLIT 0.35M310 58-60215-01 NSI TUBE, SLIT 0.4M320 42-00183-00 TRIM, FLEXIBLE 0.45M


51

14.3 CONTROL BOX PRIOR TO SERIAL NUMBER MB651006 ( MAXIMA 1000 / 1300 )


52



91-60267-10 NSA CONTROL BOX ASSY, W/O STANDBY ( MAXIMA 1300 ) -- INCLUDES: 191-60267-11 NSA CONTROL BOX ASSY, PH DETECTION ( MAXIMA 1300 ) -- INCLUDES: 191-60267-12 NSA CONTROL BOX ASSY, PH REVERSAL ( MAXIMA 1300 ) -- INCLUDES: 191-60267-20 NSA CONTROL BOX ASSY, W/O STANDBY ( MAXIMA 1000 ) -- INCLUDES: 191-60267-21 NSA CONTROL BOX ASSY, PH DETECTION ( MAXIMA 1000 ) -- INCLUDES: 191-60267-22 NSA CONTROL BOX ASSY, PH REVERSAL ( MAXIMA 1000 ) -- INCLUDES: 1

5 79-60508-01 NSI BOX ASSY -- INCLUDES: 16 68-61828-00 NSI DOOR 1

7A 44-00356-00 HINGE 27B 44-00356-10 HINGE AXLE 2

8 34-60092-16 PL* SCREW, TF M5 -- 16MM 29 34-60002-05 PL* WASHER, M5 2

10 34-01184-05 PL* NUT, LOCK M5 211 34-01266-20 PL* SCREW, HXHD SEMS M6 X 20MM 212 58-60306-05 WASHER, M5 213 58-60306-06 WASHER, M6 225 58-60059-00 CAP INSULATING 130 58-60158-00 CAP, SEAL SWITCH 135 62-60413-00 NSI DECAL 140 10-00375-01 INDICATOR, BUZZER 180 34-60089-05 PL* NUT, LOCK M6 15 OR 2490 44-01139-01 PL* CABLE CLAMP 1

110 22-60799-00 NSI HARNESS, ENGINE ( SEE SECTION 15.6 ) 1115 42-60061-00 NSI GASKET, DOOR 1.23M125 58-60298-03 GROMMET 3 OR 6130 58-60298-02 GROMMET 3 OR 6140 62-60912-03 NSI DECAL, COMPONENTS LOCATION 1150 62-60180-00 NSI DECAL, GROUND 1155 62-03957-01 DECAL, WARNING HIGH VOLTAGE 1230 PL CABLE ASSY, MOTOR ( PHASE REVERSAL & DETECTION ) 1340 58-60631-00 GROMMET WITH SEAL ( SEE SECTION 15.6 ) 1350 58-60631-16 GROMMET ( SEE SECTION 15.6 ) 2


53



54




20 58-00836-11 SPACER, NYLON 845 12-00649-11 LOGIC BOARD ASSY 175 12-00530-04 RELAY CARD -- INCLUDES: 176 10-00286-04 SSR RR DR DER GPR RELAY 577 10-00385-03 HR1 SR RCR BPR BPVR RELAY 580 34-60089-05 PL* NUT, LOCK M5 15 OR 2485 68-61394-00 STRAP ( PHASE REVERSAL & DETECTION ) 1

145 62-60180-01 NSI DECAL, GROUND ( PHASE REVERSAL & DETECTION ) 1160 22-02336-00 F9 F10 FUSE, 30A 3165 22-02336-05 F3 FUSE, 25A 2170 22-02336-02 F8 FUSE, 5A 2175 22-02336-06 F4 F5 FUSE, 15A 4180 22-02336-08 F2 FUSE, 7,5A 2185 34-60089-06 PL* NUT, LOCK M6 5190 34-60095-24 PL* WASHER, LOCK M4 X 10MM 8195 34-01184-54 PL* NUT, LOCK M4 8210 22-02336-50 FUSE, REMOVAL TOOL 1215 22-60340-02 F1 FUSE, MIDIFUSE 60A 2265 PANEL ASSY, STANDBY -- INCLUDES: 1NS 22-60300-06SK C6 CONNECTOR 6 WAYS ( MATES WITH 22-60300-07SK ) 1266 67-60510-00 BRACKET 1267 10-60044-14 OVERLOAD RELAY ( Not available anymore, see SB 08/10 PROD

and order P/N here below ) 1267 10-00473-06 OVERLOAD RELAY 1268 10-00433-00 CONTACTOR, 30A 1 OR 2269 12-60007-04 DETECTOR ( PHASE REVERSAL ) 1270 12-60021-02 DETECTOR ( PHASE DETECTION ) 1271 62-60180-00 NSI DECAL, GROUND 1272 34-60210-16 PL* SCREW, CL M4 X 20MM 4273 34-01184-03 PL* NUT, LOCK M3 2274 22-60540-30 FUSE HOLDER 1275 68-70070-00 PL* RAIL CUT TO LENGHT276 22-60543-10 FUSE, 25A 400VAC 3277 34-60095-24 PL* WASHER, LOCK M4 X 10MM 2278 10-00433-50 REVERSAL CONNECTING KIT 1


55

14.4 CONTROL BOX STARTING WITH SERIAL NUMBER MB651006 ( MAXIMA 1000 / 1300 )

30


56




5 79-60691-00 BOX ASSY -- INCLUDES: 16 68-70460-00 DOOR 17 44-00356-00 HINGE 28 44-00356-10 HINGE AXLE 29 34-60236-16 PL* SCREW, M5 -- 16MM 2

10 34-60235-00 PL* NUT, LOCK M5 211 34-60068-20 SCREW, M6 X 20MM 212 58-60306-05 WASHER, M5 213 58-60306-06 WASHER, M6 230 58-60158-00 CAP, SEAL SWITCH 135 62-60413-00 NSI DECAL 140 10-00375-01 INDICATOR, BUZZER 180 34-60089-05 PL* NUT, LOCK M6 11 OR 2090 44-01139-01 PL* CABLE CLAMP 1

110 22-60799-01 HARNESS, ENGINE ( SEE SECTION 15.6 ) 1115 42-60061-00 NSI GASKET, DOOR 1.23M125 58-60298-03 GROMMET 3 OR 6130 58-60298-02 GROMMET 3 OR 6140 62-60912-05 NSI DECAL, COMPONENTS LOCATION 1150 62-60180-00 NSI DECAL, GROUND 1155 62-03957-01 DECAL, WARNING HIGH VOLTAGE 1220 34-60101-20 PL* SCREW, CAP SKTHD M5 X 20MM 4230 PL CABLE ASSY, MOTOR ( PHASE REVERSAL & DETECTION ) 1340 58-60631-00 GROMMET WITH SEAL ( SEE SECTION 15.6 ) 1350 58-60631-16 GROMMET ( SEE SECTION 15.6 ) 2


57



58




20 58-00836-18 PL* SPACER, NYLON 845 12-00649-11 LOGIC BOARD ASSY 175 12-00530-04 RELAY CARD -- INCLUDES: 176 10-00286-04 SSR RR DR DER GPR RELAY 577 10-00385-03 HR1 SR RCR BPR BPVR RELAY 580 34-60089-05 PL* NUT, LOCK M5 11 OR 2085 68-61394-00 STRAP ( PHASE REVERSAL & DETECTION ) 1

145 62-60180-01 NSI DECAL, GROUND ( PHASE REVERSAL & DETECTION ) 1160 22-02336-00 F9 F10 FUSE, 30A 3165 22-02336-05 F3 FUSE, 25A 2170 22-02336-02 F8 FUSE, 5A 2175 22-02336-06 F4 F5 FUSE, 15A 4180 22-02336-08 F2 FUSE, 7,5A 2185 34-60089-06 PL* NUT, LOCK M6 5190 34-60095-24 PL* WASHER, LOCK M4 X 10MM 8195 34-01184-54 PL* NUT, LOCK M4 8210 22-02336-50 FUSE, REMOVAL TOOL 1215 22-60340-02 F1 FUSE, MIDIFUSE 60A 2265 PANEL ASSY, STANDBY -- INCLUDES: 1NS 22-60300-06SK C6 CONNECTOR 6 WAYS ( MATES WITH 22-60300-07SK ) 1266 67-60510-00 BRACKET 1267 10-00473-06 OVERLOAD RELAY 1268 10-00433-00 CONTACTOR, 30A 1 OR 2269 12-60007-04 DETECTOR ( PHASE REVERSAL ) 1270 12-60021-02 DETECTOR ( PHASE DETECTION ) 1271 62-60180-00 NSI DECAL, GROUND 1272 34-60210-16 PL* SCREW, CL M4 X 20MM 4273 34-01184-03 PL* NUT, LOCK M3 2274 22-60540-30 FUSE HOLDER 1275 68-70070-00 PL* RAIL CUT TO LENGHT276 22-60543-10 FUSE, 25A 400VAC 3277 34-60095-24 PL* WASHER, LOCK M4 X 10MM 2278 10-00433-50 REVERSAL CONNECTING KIT 1


59

14.5 CONTROL BOX ( MAXIMA 1300 MT_ )

30

401 402403


60



91-60266-00 NSA CONTROL BOX ASSY, PHASE REVERSALPRIOR TO SERIAL NUMBER MB651031 -- INCLUDES: 1

91-60282-00 NSA CONTROL BOX ASSY, PHASE REVERSALSTARTING WITH SERIAL NUMBER MB651031 -- INCLUDES: 1

5 79-60625-00 NSI BOX ASSY PRIOR TO SERIAL NUMBER MB814170 -- INCLUDES: 15 79-60696-00 NSI BOX ASSY STARTING WITH S/N MB814170 -- INCLUDES: 16 68-70336-00 DOOR 1

7A 44-00356-00 HINGE 37B 44-00356-10 HINGE AXLE 3

8 34-60092-16 PL* SCREW, TF M5 -- 16MM 39 34-60002-05 PL* WASHER, M5 3

10 34-01184-05 PL* NUT, LOCK M5 311 34-01266-20 PL* SCREW, HXHD SEMS M6 X 20MM 312 58-60306-05 WASHER, M5 313 58-60306-06 WASHER, M6 330 58-60158-00 CAP, SEAL SWITCH 135 62-60413-00 NSI DECAL 140 10-00375-01 INDICATOR, BUZZER 155 10-60038-11 CAPACITOR, 6μFD 750V 260 10-60038-06 CAPACITOR, 25μFD 600V 380 34-60089-05 PL* NUT, LOCK M6 2795 68-70355-00 PL* BRACKET 1

110 22-60800-00 NSI HARNESS, ENGINE ( SEE SECTION 15.7 ) 1115 42-60061-00 NSI GASKET, DOOR 1.5M125 58-60298-03 GROMMET 5130 58-60298-02 GROMMET 1135 62-60912-04 DECAL, RELAY BOARD 1140 62-60912-03 NSI DECAL, COMPONENTS LOCATION 1150 62-60180-00 DECAL, GROUND 1155 62-03957-01 DECAL, WARNING HIGH VOLTAGE 1185 34-60089-06 PL* NUT, LOCK M6 5220 34-60101-20 PL* SCREW, CAP SKTHD M5 X 20MM 4225 22-60792-00 PL* HARNESS, EVAPORATOR CONNECTION -- INCLUDES: 1NS 22-50098-10SK 2C19 CONNECTOR 19 WAYS ( MATES WITH 22-50098-11SK) 1NS 22-60300-11SK C12 CONNECTOR 12 WAYS ( MATES WITH 22-60300-10SK ) 1NS 58-60298-04 GROMMET 1226 58-60298-03 GROMMET 1230 PL CABLE ASSY, MOTOR 1

330A 22-60791-00 NSI HARNESS, POWER PANEL ( SEE NEXT PAGE ) 1350 58-60631-00 GROMMET WITH SEAL ( SEE SECTION 15.7 ) 1355 58-60631-16 GROMMET ( SEE SECTION 15.7 ) 2401 86-61214-00 PROTECTOR STARTING WITH S/N MB814170 1402 34-60095-25 PL* WASHER, LOCK M5 X 12MM 4403 34-60000-16 PL* SCREW, MACH HXHD M5 X 16MM 4


61



62





20 58-00836-11 SPACER, NYLON 845 12-00649-11 LOGIC BOARD ASSY 150 10-01171-01 TIMER DEFROST 180 34-60089-05 PL* NUT, LOCK M6 2785 68-61394-00 STRAP 1

145 62-60180-01 NSI DECAL, GROUND 1190 34-60095-24 PL* WASHER, LOCK M4 X 10MM 8195 34-01184-54 PL* NUT, LOCK M4 8265 PANEL ASSY, STANDBY -- INCLUDES: 1NS 22-60300-06SK C6 CONNECTOR 6 WAYS ( MATES WITH 22-60300-07SK ) 1266 67-60510-00 BRACKET 1267 10-00473-06 OL OVERLOAD 1268 10-00433-00 CONTACTOR, 30A 1 OR 2269 12-60021-02 PHD DETECTOR ( PHASE DETECTION ) 1271 62-60180-00 NSI DECAL, GROUND 1272 34-60210-16 PL* SCREW, CL M4 X 20MM 4273 34-01184-03 PL* NUT, LOCK M3 2274 22-60540-30 FUSE HOLDER 1275 68-70070-00 PL* RAIL CUT TO LENGHT276 22-60543-10 FUSE, 25A 400VAC 3277 34-60095-24 PL* WASHER, LOCK M4 X 10MM 2278 34-01184-55 PL* NUT, LOCK M5 1279 34-60095-25 PL* WASHER, M5 1280 10-00433-50 REVERSAL CONNECTING KIT 1


63


215

180

165

170

175.235

210

160245


64





70 12-00530-11 AUXILIARY LOGIC CARD -- INCLUDES: 171 10-00286-04 HGR 2HR 2CRB HR4 2DR RELAY 572 10-00385-03 2RCR 2RR 2DRO 2CRA 2ER RELAY 575 12-00530-04 RELAY CARD -- INCLUDES: 176 10-00286-04 SSR RR DR DER GPR RELAY 577 10-00385-03 HR1 SR RCR BPR BPVR RELAY 580 34-60089-05 PL* NUT, LOCK M5 27

160 22-02336-04 F9 F10 F11 FUSE, 10A 4165 22-02336-05 F3 FUSE, 25A 2170 22-02336-02 F8 FUSE, 5A 2175 22-02336-06 F4 F5 FUSE, 15A 3180 22-02336-08 F2 FUSE, 7,5A 1185 34-60089-06 PL* NUT, LOCK M6 5210 22-02336-50 FUSE, REMOVAL TOOL 1215 22-60340-02 F1 FUSE, MIDIFUSE 60A 2235 22-02336-07 F13 F14 FUSE, 2A 3245 22-60102-08 FUSE, 5X20 4A 250V 6


65


330A

ALT

330C

HTR

DC

C9

330E

330D

330B

330F

347

335

336


66





80 34-60089-05 PL* NUT, LOCK M5 27330 PANEL ASSY -- INCLUDES: 1

330A 22-60791-00 NSI HARNESS, POWER PANEL / ALT / HEATER -- INCLUDES: 1330B 58-60298-03 GROMMET 1330C 22-01613-16SK ALT CONNECTOR 6 WAYS ( MATES WITH 22-01613-18SK ) 1330D 22-01613-18SK HTR CONNECTOR 6 WAYS ( MATES WITH 22-01613-16SK ) 1330E 22-01613-10SK DC CONNECTOR 4 WAYS ( MATES WITH 22-01613-08SK ) 1330F 22-60300-08SK C9 CONNECTOR 9 WAYS ( MATES WITH 22-60300-09SK ) 1331 PL PLATE ASSY 1332 12-60034-00 EFB MODULE, ELECTRIC FAN BOARD 1333 34-01184-54 PL* NUT, LOCK M4 10334 34-01151-04 PL* WASHER, FLAT M4 6335 10-00471-01 1HVR 2HVR CONTACTOR 2336 10-00471-99 DIODE ASSY 2337 10-00214-00 CAR RELAY, 12V 1338 10-01176-00 FLR RELAY, 30A FOR CONTROL BOX 91-60266-00 1338 10-01176-01 FLR RELAY, 30A FOR CONTROL BOX 91-60266-01 1339 22-60284-01 RE RESISTOR, 50W 10kΩ 1340 22-02606-00 SH RESISTOR 25W 5Ω 1341 34-00946-52 PL* NUT, HEX M3 4342 22-60776-00 JUNCTION BLOCK -- INCLUDES: 1343 NSS RAIL 1344 34-60095-27 PL* WASHER, LOCK M6 X 14MM 2345 34-00946-06 PL* NUT, HEX M6 X 1MM 2346 22-02336-11 FUSE, 4A 1347 22-60102-18 FUSE, 5X20 4A 250V 6


67

14.6 HARNESS, ENGINE ( MAXIMA 1000 / 1300 )

RAS

5

SAS

10

EWP

15

20

J1 FORHARNESS --00

J2

J3

MP

SP 30

LB 35

RS/SSW 25

WTS10

OP5

FS 30

SM 40

SCS 10

SPT HP LP

45 55

EFC 5ATS5

BPV60

7080

SS 42

HGS2

HGS1

65

DTT

20J1 FOR

HARNESS --01


68


14.6 HARNESS, ENGINE ( MAXIMA 1000 / 1300 )

22-60799-00 NSI HARNESS, ENGINE PRIOR TO S/N MB651006 -- INCLUDES: 122-60799-01 NSI HARNESS, ENGINE STARTING WITH S/N MB651006 -- INCLUDES: 1

5 22-50078-02SK RAS OP EFC ATS CONNECTOR 2W ( MATES WITH 22-50078-01SK ) 410 22-50078-01SK SAS WTS CONNECTOR 2 WAYS ( MATES WITH 22-50078-02SK ) 215 22-50098-72SK EWP CONNECTOR 2 WAYS 120 22-60300-12SK J1 J2 J3 CONNECTOR 15 WAYS ( MATES WITH 22-60300-13SK ) 325 22-50078-29SK RS / SSW CONNECTOR 6 WAYS ( MATES WITH 22-50078-28SK ) 130 22-50078-05SK SP CONNECTOR 3 WAYS ( MATES WITH 22-50078-08SK ) 135 22-50078-03SK LB CONNECTOR 8 WAYS ( MATES WITH 22-50078-04SK ) 140 22-50078-30SK SM CONNECTOR 1 WAY ( MATES WITH 22-50078-31SK ) 142 22-50098-06SK SS CONNECTOR 1 WAY 145 22-50098-84SK SPT CONNECTOR 3 WAYS 155 22-01585-00SK HP LP CONNECTOR 2 WAYS ( MATES WITH 22-02392-00SK ) 260 22-01613-02SK HGS1&2 BPV CONNECTOR 2W ( MATES WITH 22-01613-00SK ) 365 22-50099-01SK MP CONNECTOR 170 58-60631-00 GROMMET WITH SEAL 180 58-60631-16 GROMMET 2


69

14.7 HARNESS, ENGINE ( MAXIMA 1300 MT_ )

RAS

5

SAS

10

EWP

15

J1

J2

J3

MP

SP 30

LB 35

RS/SSW 25

WTS

20

OP5

FS 30

SM 40

SCS 10

SPT HP LP

45 55

EFC 5ATS5

BPV60

90.95

SS 42

HGV1

MHV

65

1LSVJ5

J4

60

DTT

OCJ2 80

HGV2

60

C1270C975


70


14.7 HARNESS, ENGINE ( MAXIMA 1300 MT_ )

22--60800--00 NSI HARNESS, ENGINE -- INCLUDES: 15 22-50078-02SK RAS OP EFC ATS CONNECTOR 2W ( MATES WITH 22-50078-01SK ) 4

10 22-50078-01SK SAS WTS CONNECTOR 2 WAYS ( MATES WITH 22-50078-02SK ) 215 22-50098-72SK EWP CONNECTOR 2 WAYS 120 22-60300-12SK J1 J2 J3 J4 J5 CONNECTOR 15W ( MATES WITH 22-60300-13SK ) 525 22-50078-29SK RS / SSW CONNECTOR 6 WAYS ( MATES WITH 22-50078-28SK ) 130 22-50078-05SK SP CONNECTOR 3 WAYS ( MATES WITH 22-50078-08SK ) 135 22-50078-03SK LB CONNECTOR 8 WAYS ( MATES WITH 22-50078-04SK ) 140 22-50078-30SK SM CONNECTOR 1 WAY ( MATES WITH 22-50078-31SK ) 142 22-50098-06SK SS CONNECTOR 1 WAY 145 22-50098-84SK SPT CONNECTOR 3 WAYS 155 22-01585-00SK HP LP CONNECTOR 2 WAYS ( MATES WITH 22-02392-00SK ) 260 22-01613-02SK HGV1&2 BPV 1LSV MHV CONNECTOR 2 WAYS

( MATES WITH 22-01613-00SK ) 565 22-50099-01SK MP CONNECTOR 170 22-60300-10SK C12 CONNECTOR 12 WAYS ( MATES WITH 22-60300-11SK ) 175 22-60300-09SK C9 CONNECTOR 9 WAYS ( MATES WITH 22-60300-08SK ) 180 22-50078-44SK OCJ2 CONNECTOR 10 WAYS ( MATES WITH 22-50078-45SK ) 190 58-60631-00 GROMMET WITH SEAL 195 58-60631-16 GROMMET 2


71

14.8 DISPLAY ASSY

100.110

90

30.40.75

30.40.75

70

20.150

61

60

50

25

160

80

120

29

8

7

6

3

5

4

14

10

13

12

11

26

1

35.40.75

62

51

9

15


72


14.8 DISPLAY ASSY

91-60217-00 NSA DISPLAY ASSY, PH. DETECT & REVERS ( MAXIMA 1300 ) -- INCLUDES: 191-60217-01 NSA DISPLAY ASSY, W/O STANDBY ( MAXIMA 1300 ) -- INCLUDES: 191-60220-00 NSA DISPLAY ASSY, PH. DETECT & REVERS ( MAXIMA 1000 ) -- INCLUDES: 191-60220-01 NSA DISPLAY ASSY, W/O STANDBY ( MAXIMA 1000 ) -- INCLUDES: 191-60269-00 NSA DISPLAY ASSY, PH. REVERSAL ( MAXIMA 1300Mt_ ) -- INCLUDES: 1

1 91-00333-03 DISPLAY , MICRO MODULE ( MAXIMA 1000 & 1300 ) -- INCLUDES: 11 91-00333-04 DISPLAY , MICRO MODULE ( MAXIMA 1300Mt_ ) -- INCLUDES: 12 58-04339-00 BEZEL, MICRO 13 42-00396-00 GASKET 14 58-04342-00SV WINDOW 15 42-00405-00 NSI GASKET 16 58-04341-02SV DOOR ASSY 17 58-04344-01SV LATCH 28 58-00660-00 WASHER, CONDENSATE DRAIN 19 34-00829-09 PL* WASHER, PLAIN 1

10 34-06196-11 PL* SCREW, TF PNHD M4.2 811 34-06129-06 PL* SCREW, TF PNHD 312 34-06196-10 PL* SCREW, TF PNHD M4.2 413 12-00515-00SV DISPLAY ASSY 114 12-00521-00SV KEY PAD ASSY ( MAXIMA 1000 & 1300 ) 114 12-00521-01SV KEY PAD ASSY ( MAXIMA 1300Mt_ ) 115 58-04385-00 PLUG, HOLE 216 58-04657-00 DEFLECTOR, MOISTURE 120 68-61844-00 COVER, DISPLAY ( MAXIMA 1000 ) 125 68-70379-00 BRACKET ( MAXIMA 1000 ) 126 67-60316-00 BRACKET ( MAXIMA 1300 ) PRIOR TO S/N MB513006 126 67-60316-01 BRACKET ( MAXIMA 1300Mt_ ) PRIOR TO S/N MB513006 126 67-60544-01 BRACKET ( MAXIMA 1300/1300Mt_ ) STARTING WITH S/N MB513006 130 10-01129-02SV SWITCH, TOGGLE 235 10-01129-04SV SWITCH, TOGGLE ( MAXIMA 1300Mt_ ) 140 58-60158-00 CAP, SEAL SWITCH 250 22-60667-00 HARNESS, MICRO / DISPLAY ( MAXIMA 1300 ) -- INCLUDES: 150 22-60667-01 HARNESS, MICRO / DISPLAY ( MAXIMA 1000 & 1300Mt_ ) -- INCLUDES:151 58-60298-02 GROMMET 260 22-60663-00 NSI HARNESS, SWITCH ( MAXIMA 1300 ) -- INCLUDES: 160 22-60663-01 NSI HARNESS, SWITCH ( MAXIMA 1000 ) -- INCLUDES: 160 22-60663-02 NSI HARNESS, SWITCH ( MAXIMA 1300Mt_ ) -- INCLUDES: 161 22-50078-28SK C6 CONNECTOR 6 WAYS ( MATES WITH 22-50078-29SK ) 162 58-60298-03 GROMMET 170 62-02448-05 DECAL, SWITCH START / RUN / STANDBY ( MAXIMA 1000 & 1300 ) 170 62-02448-13 DECAL, SWITCH START / RUN / STANDBY ( MAXIMA 1300Mt_ ) 175 58-60059-00 CAP, INSULATING W/O STANDBY 180 62-10353-01 DECAL LOGO EASYCOLD 190 42-00406-01 GASKET, DISPLAY PRIOR TO SERIAL NUMBER MB513006 190 42-60113-00 GASKET, DISPLAY STARTING WITH SERIAL NUMBER MB513006 1

100 34-60095-25 PL* WASHER, LOCK M5 X 12MM 4110 34-60000-20 PL* SCREW, CAP HXHD M5 X 20MM 4120 44-60061-00 BASE 1150 34-60044-02 PL* SCREW, M6 X 10MM ( MAXIMA 1000 ) 4160 58-60302-06 GROMMET ( MAXIMA 1000 ) 1


73

15. BATTERY KIT

8090100

120

5060

20

90100110

130

70

40

10

8090100

30


74


15. BATTERY KIT

10 22-60011-09 CABLE ASSY, -- BLACK 35MM@ 0.36M 120 22-60359-00 STRAP GROUND 130 22-60011-08 NSI CABLE ASSY, + RED 35MM@ 1.8M 140 30-60026-00 BATTERY, 12V 66A 150 34-01152-35 PL* SCREW, CAP HXHD M6 X 35MM 260 34-60095-46 PL* WASHER, LOCK M6 X 18MM 270 68-60500-00 CLAMP 180 34-00946-58 PL* NUT, HEX M8--1.25 290 34-60095-30 PL* WASHER, LOCK M8 X 18MM 3

100 34-60096-09 PL* WASHER, LOCK M8 X 16MM 3110 34-01153-25 PL* SCREW, CAP HXHD M8 X 25MM 1120 58-60279-01 NSI HOSE 0.5M130 44-60042-04 PL* COLLAR, TUBE 1


75

16. DECALS KIT

160 50

6020

70

100

150

90

110

112170

111

80


76


16. DECALS KIT

20 62-60063-00 NSI DECAL, R404A 350 62-60318-00 NSI DECAL, WARNING BURNING RISK 160 62-61477-00 NSI DECAL, WARNING CUTTING RISK 170 62-60388-00 NSI DECAL, WARNING AUTO START 180 62-10353-01 DECAL LOGO EASYCOLD 190 62-60764-00 DECAL, SERVICE 1

100 62-60787-00 NSI DECAL, ARROW 1110 62-60950-02 DECAL, MAXIMA 1000 2111 62-60950-03 DECAL, MAXIMA 1300 2112 62-60950-04 DECAL, MAXIMA 1300Mt_ 2150 62-60390-03 DECAL, CARRIER 1160 62-02143-01 DECAL, WARNING BEWARE OF FAN BLADES 2170 62-60407-00 DECAL, CARRIER 1


77

17. SERVICE TOOLS

2

4

3

1

6

5

7

8

12

119

10


78


17. SERVICE TOOLS

1 07-60030-00 CRIMPING PLIER FOR DEUTSCH CONNECTORS 12 07-60036-00 EXTRACTING TOOL SIZE 4 ( WHITE ) 12 07-60035-00 EXTRACTING TOOL SIZE 8 ( GREEN ) 12 07-60034-00 EXTRACTING TOOL SIZE 12 ( YELLOW ) 12 07-60031-00 EXTRACTING TOOL SIZE 16S ( BRIGHT BLUE ) 12 07-60033-00 EXTRACTING TOOL SIZE 16 ( DARK BLUE ) 12 07-60032-00 EXTRACTING TOOL SIZE 20 ( RED ) 13 07-60037-00 CRIMPING PLIER LM FOR PACKARD CONNECTORS 14 07-60038-00 CRIMPING PLIER GM FOR PACKARD CONNECTORS 15 07-60106-00 CRIMPING PLIER AMP 16 07-60107-00 EXTRACTOR AMP 17 07-60028-00 SCREW DRIVE VALVE 1/4” 18 07-60028-01 SCREW DRIVE VALVE 3/8” 19 07-00400-00 EXTRACTOR PIN PACKARDS TERMINALS 1

10 07-00329-00 EXTRACTOR PIN PACKARDS TERMINALS 111 990047 EXTRACTION TOOL 112 07-60113-00 ELECTRONIC BELT TENSIONER 1


79


18. MOUNTING KIT

2

3

5

4

1

FITTING FOR NYLON HOSES

FITTING FOR FLEXIBLE HOSES

7

8

9

6

1 30-01108-11 PUMP, FUEL -- INCLUDES: 12 22-02392-00SK CONNECTOR 2 WAYS ( MATES WITH 22-01585-00SK ) 13 30-01108-20 FILTER, 80 MICRONS 14 30-01108-23 BOWL 15 30-01108-22 GASKET 16 40-00342-02 90_ FITTING FOR NYLON HOSES 27 40-60157-00 STRAIGHT FITTING FOR NYLON HOSES 18 40-60120-11 STRAIGHT FITTING FOR FLEXIBLE HOSES 29 40-00060-01 90_ FITTING FOR FLEXIBLE HOSES 1

68-60343-00 BRACKET, FUEL PUMP 122-60287-01 HARNESS, FUEL PUMP -- INCLUDES: 122-01585-00SK FP+ & FP-- CONNECTOR 2 WAYS ( MATES WITH 22-02392-00SK ) 122-50078-64SV FP+ CONNECTOR 1 WAY ( MATES WITH 22-50078-63SV ) 134-60014-05 NSI BOLT, T--HEAD 748-60008-00 WASHER, SPACER M13 X 30MM 734-00361-15 NSI NUT, SELF LOCK 734-01152-25 SCREW, CAP HXHD M6 X 25MM 234-01184-56 PL* NUT, LOCK M6 234-60095-27 PL* WASHER, LOCK M6 X 14MM 479-60534-01 HOSE ASSY, FUEL RED -- INCLUDES: 158-00580-00 TUBE, RED 3/8” CUT TO LENGHT40-60235-00 FITTING, GREEN MALE QUICK CONNECT 179-60534-11 HOSE ASSY, FUEL BLACK -- INCLUDES: 158-00507-00 TUBE, BLACK 1/4” CUT TO LENGHT40-60235-01 FITTING, BLACK MALE QUICK CONNECT 168-61113-00 THERMIC SCREEN 140-00342-02 ELBOW, MALE 3/8” 140-00343-07 CONNECTOR, MALE 122-60329-01 REMOTE HARNESS, EVAPORATOR 18M (MAXIMA 1300Mt_) -- INCLUDES: 122-60329-02 REMOTE HARNESS, EVAPORATOR 5M (MAXIMA 1300Mt_) -- INCLUDES:122-50098-11SK CONNECTOR 19 WAYS ( MATES WITH 22--50098--10SK ) 162-61168-01 MANUAL, OPERATOR MAXIMA 162-60702-01 MANUAL, SERVICE CENTERS 122-01513-00 PLUG, 380--3--50HZ 1

500 Carrier service stationsin Europe, Russia,

Middle East and Africa

© Carrier Corporation - Carrier Transicold Europe S.C.S. au cap i tal de 16 090 700 euros - R.C.S. Pontoise B 410 041 776 - Code APE 518 MVAT: FR52410041776 - The infor ma tion con tained in this doc u ment is not con trac tu al ly bind ing, and may not be repro duced with out pri or approv al. Printed in France (05/08) 62-61171-04

10

20

2595100

15.115.120

9780

25

30

MAXIMA 1000 / 1300 / 1300Mt°SPARE PARTS MANUAL

Carrier Transicold Europe S.C.S.L' Européen Bâtiment D4, rue Joseph Monier92500 Rueil-MalmaisonPhone: +33 (0)1 41 42 28 00Fax: +33 (0)1 41 42 28 28www.carrier-transicold-europe.com

Maxima_1300_MT_Parts_13_07_10

Documents

electrical kit maxima

evaporator kit maxima

exhaust kit

coolant kit

refrigeration kit

drive kit

mounting kit

accumulator kit