-
ROOM AIR
CONDITIONERAW0690AAW0790AAW07FASAAAW07FASBAAW07FASEAAW0890AAW09FASBAAW09FASEAAW09FBSEA
AW1090AAW10FAJAAAW10FAJBAAW12FAJAAAW12FAJBAAW12FAJDAAW12FAJEAAW12FBJEA
AW1290AAW14FAMBAAW18FAMBAAW18FAMCAAW18FAMBBAWT18FAMDAAW18FAMEAAW18FBMEAAW24FAMBBAW24FAMBAAW24FAMCAAWT24FAMEA
AIR CONDITIONER CONTENTS
1. Precautions
2. Product Specifications
3. Installation and Operating Instructions
4. Disassembly and Reassembly
5. Troubleshooting
6. Exploded Views and Parts List
7. Block Diagram
8. PCB Diagram
9. Wiring Diagram
10. Schematic Diagrams
SERVICE Manual
Co-DB68-02477A(1) 6/28/01 11:32 AM Page 2
-
1. Precautions
Samsung Electronics 1-1
1. Warning: Prior to repair, disconnect thepower cord from the
circuit breaker.
2. Use proper parts: Use only exactreplacement parts. (Also, we
recommendreplacing parts rather than repairing them.)
3. Use the proper tools: Use the proper toolsand test equipment,
and know how to useequipment may cause problems later-intermittent
contact, for example.
4. Power Cord: Prior to repair, check thepower cord and replace
it if necessary.
5. Avoid using an extension cord, and avoidtapping into a power
cord. This practicemay result in malfunction or fire.
6. After completing repairs and reassembly,check the insulation
resistance.Procedure: Prior to applying power, measurethe
resistance between the power cord and theground terminal. The
resistance must begreater than 30 megohms.
7. Make sure that the grounds are adequate.
8. Make sure that the installation conditionsare satisfactory.
Relocate the unit if necessary.
9. Keep children away from the unit while it isbeing
repaired.
10. Be sure to clean the unit and its surroundingarea.
Fig. 1-1 Avoid Dangerous Contact
Fig. 1-2 No Tapping and No Extension Cords
Fig. 1-3 No Kids Nearby!
Fig. 1-4 Clean the Unit
1-DB68-02477A(1) 6/28/01 11:33 AM Page 1-1
-
1-2 Samsung Electronics
Type Model Name
A
B
C
: The symbol of model nameNotice
AW0690A
AW0790A
AW07FASAA
AW07FASBA
AW07FASEA
AW0890A
AW09FASBA
AW09FASEA
AW09FBSEA
AW1090A
AW10FAJAA
AW10FAJBA
AW12FAJAA
AW12FAJBA
AW12FAJDA
AW12FAJEA
AW12FBJEA
AW1290A
AW14FAMBA
AW18FAMBA
AW18FAMCA
AW18FAMBB
AWT18FAMDA
AW18FAMEA
AW18FBMEA
AW24FAMBB
AW24FAMBA
AW24FAMCA
AWT24FAMEA
1-DB68-02477A(1) 6/28/01 11:33 AM Page 1-2
-
Samsung Electronics 2-1
2. Product Specifications
2-1 Table
Item Unit of Measure
Type
Dimensions:
(Width X Height X Depth)
Voltage
Phase
Frequency
Operating Current
Power Consumption
Refrigerant Type
Refrigerant Charge
Capacity
EER
Net Weight
Condenser
Condenser Fan
Evaporator
Evaporator Fan
Fan Motor
Compressor(Rotary)
Overload Protect
Compressor Capacitor
Fan Motor Capacitor
Fan Speed
Thermo Control
Off Timer
-
mm
Volt
-
Hz
A
W
FREON
g
BTU/h
BTU/h.W
kg
Row
Type
Row
Type
Model
Model
-
F / VAC
F / VAC
RPM
-
hr
5.6
600
380
6000
10
29
IC-9630SWD6F
44A062HS1EB
MRA12040-12008
30/370
4.5/440
810/750/690
520 x 345 x 485
6.8
715
350
7000
9.8
28
2 x 15
2 x 14
IC-9630SWD6C
44A072HW1EB
MRA98706-12008
25/370
6/450
800/750/700
WINDOW
115
SINGLE
60
R-22
Propeller Fan
Blower
Thermistor
24
7.4
815
380
8000
9.8
29
IC-9630SWD6E
44A080HU1EB
MRA12083-12008
35/370
6/450
910/810/750
9.2
1020
485
10000
10
45
2 x 17
AFS095ZREA
44B102HU1EF
MRA12109-12007
40/370
8/440
920/820/770
12
1300
610
12300
9.4
45
3 x 17
AFS100ZREB
44B124HU1EL
MRA98693-12008
45/370
15/450
920/850/780
600 x 394 x 595
2 x 14
660 x 425 x 730
11.7
1250
580
12500
10
50
2 x 19
2 x 15
OSME-708SWC
44B124HU1EL
MRA98693-12007
45/370
8/440
800/750/700
RemarksAW0690A AW0790AAW07FASAA AW0890AAW1090A
AW10FAJAA AW12FAJAA AW1290A
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-1
-
2-2 Samsung Electronics
Table(cont.)
Item Unit of Measure
Type
Dimensions:
(Width X Height X Depth)
Voltage
Phase
Frequency
Operating Current
Power Consumption
Refrigerant Type
Refrigerant Charge
Capacity
EER
Net Weight
Condenser
Condenser Fan
Evaporator
Evaporator Fan
Fan Motor
Compressor(Rotary)
Overload Protect
Compressor Capacitor
Fan Motor Capacitor
Fan Speed Control
Thermo Control
Off Timer
-
mm
Volt
-
Hz
A
W
FREON
g
BTU/h
BTU/h.W
kg
Row
Type
Row
Type
Model
Model
-
F / VAC
F / VAC
RPM
-
hr
3.5
750
410
7000
9.3
2 x 15
IC-9630SWF6G
44A072IW1EB
MRA12043-12008
25/370
3/450
910/780/690
2 x 14
4.7
1000
420
9000
9
2 x 15
IC-9630SWF6G
44B092IW1EF
MRA12032-12008
20/370
3/450
910/780/690
5.2
1100
500
10000
9
43
2 x 17
AFS095ZTEA
44B102IU1EL
RAC12049-9622
20/450
2.5/450
800/720/650
6
1290
510
12000
9.3
45
2 x 17
AFS105ZUEA
44B124HU1EL
MRA12008-12008
30/450
3.5/450
900/840/780
520 x 345 x 485
29
600 x 394 x 595
WINDOW
220 (230-208)
SINGLE
60
R-22
Propeller Fan
Blower
Thermistor
24
6.5
1400
570
14000
10
53
2 x 19
2 x 15
OSME-906SWC
44B135IU1EL
RAC12074-9622
30/450
6/450
950/850/750
660 x 425 x 730
9.5
2000
1090
18000
9
61
3 x 16
3 x 15
AFS145ZUEA
48B175IV1EH
48B197IV1EH
MRA12107-12007
RAC12016-9622
35/450
40/450
6/450
1060/1010/970
12.5
11.5
2667
2500
1320
1280
24000
24000
8.8
8.2
71
3 x 16
4 x 15
3 x 15
AFS145ZUEA
48B220IV1EH
INTERNAL
MRA12068-12007
30/450
40/450
6/450
1060/1010/970
RemarksAW07FASBA AW09FASBA AW10FAJBA AW12FAJBA AW14FAMBA
AW18FAMBAAW18FAMBBAW24FAMBAAW24FAMBB
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-2
-
Samsung Electronics 2-3
Table(cont.)
Item Unit of Measure
Type
Dimensions:
(Width X Height X Depth)
Voltage
Phase
Frequency
Operating Current
Power Consumption
Refrigerant Type
Refrigerant Charge
Capacity
EER
Net Weight
Condenser
Condenser Fan
Evaporator
Evaporator Fan
Fan Motor
Compressor(Rotary)
Overload Protect
Compressor Capacitor
Fan Motor Capacitor
Fan Speed
Thermo Control
Off Timer
-
mm
Volt
-
Hz
A
W
FREON
g
BTU/h
BTU/h.W
kg
Row
Type
Row
Type
Model
Model
-
F / VAC
F / VAC
RPM
-
hr
8.5
1800
1090
18000
10
61
3 x 16
3 x 15
AFS145ZUEA
48B175IV1EH
MRA12107-12007
35/450
6/450
1060/1010/970
WINDOW
660 x 425 x 730
208-240
SINGLE
60
R-22
Propeller Fan
Blower
Thermistor
24
12.5
2695
1320
23700
8.8
71
3 x 16
4 x 15
AFS145ZUEA
EDB260211A
INTERNAL
30/450
6/450
1060/1010/970
RemarksAW18FAMCA AW24FAMCA
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-3
-
2-4 Samsung Electronics
Table(cont.)
Item Unit of Measure
Type
Dimensions:
(Width X Height X Depth)
Voltage
Phase
Frequency
Operating Current
Power Consumption
Refrigerant Type
Refrigerant Charge
Capacity
EER
Net Weight
Condenser
Condenser Fan
Evaporator
Evaporator Fan
Fan Motor
Compressor(Rotary)
Overload Protect
Compressor Capacitor
Fan Motor Capacitor
Fan Speed
Thermo Control
Off Timer
-
mm
Volt
-
Hz
A
W
FREON
g
BTU/h
BTU/h.W
kg
Row
Type
Row
Type
Model
Model
-
F / VAC
F / VAC
RPM
-
hr
600 x 394 x 595
6.8
1330
660
12000
9.0
45
2 x 14
2 x 14
AFS105AUEA
48A124MV1EL
MRA98706-12008
30/450
4/450
890/840/780
WINDOW
200-220
SINGLE
50
R-22
Propeller Fan
Blower
Thermistor
24
660 x 425 x 730
10.5
2050
1480
18000
8.8
71
4 x 16
3 x 15
OSME-1206SWC
48B180MT1EH
MRA12108-12007
40/450
6/450
930/880/830
RemarksAW12FAJDA AWT18FAMDA
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-4
-
Samsung Electronics 2-5
Table(cont.)
Item Unit of Measure
Type
Dimensions:
(Width X Height X Depth)
Voltage
Phase
Frequency
Operating Current
Power Consumption
Refrigerant Type
Refrigerant Charge
Capacity
EER
Net Weight
Condenser
Condenser Fan
Evaporator
Evaporator Fan
Fan Motor
Compressor(Rotary)
Overload Protect
Compressor Capacitor
Fan Motor Capacitor
Fan Speed
Thermo Control
Off Timer
-
mm
Volt
-
Hz
A
W
FREON
g
BTU/h
BTU/h.W
kg
Row
Type
Row
Type
Model
Model
-
F / VAC
F / VAC
RPM
-
hr
3.5
750
410
7000
9.3
28
44A070JW1EB
MST24AMN-12008
25/450
2.5/450
850/810/750
4.5
1000
390
9000
9.0
29
44B092JW1EF
MRA12056-12007
30/450
3/450
910/860/810
520 x 345 x 485
2 x 15
2 x 14
IC-9430SWJ5A
WINDOW
600 x 394 x 595
220-240
SINGLE
50
5.8
1330
R-22
660
12000
9.0
45
2 x 14
Propeller Fan
2 x 14
Blower
AFS105AUEA
48A124JV1EL
MRA12030-12008
30/450
3.5/450
890/840/780
Thermistor
24
9
2000
1160
18000
9.0
60
3 x 16
OSME-1404SAC
48B180JV1EH
MRA12016-12007
40/450
6/450
1060/1010/960
660 x 425 x 730
3 x 15
14
3000
980
24000
8.0
71
3 x 16
OSME-1256SWC
AWG5532EXC
INTERNAL
45/450
6/450
930/880/830
RemarksAW07FASEA AW09FASEAAW09FBSEAAW12FAJEAAW12FBJEA
AW18FAMEAAW18FBMEA AWT24FAMEA
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-5
-
2-6 Samsung Electronics
2-2 Dimensions
2-2-1 Main Unit (Type A)
520
345
345
485
Front view Side view
(Unit : mm)
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-6
-
Samsung Electronics 2-7
2-2-2 Main Unit (Type B)
600
394
394
595
(Unit : mm)
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-7
-
2-8 Samsung Electronics
2-2-3 Main Unit (Type C)
2-2-3 Remote Control
660
425
425
695
Front view Side view
(Unit : mm)
Timer setting button
Sleep timer setting button
Operating modeselection buttons
Energy Saver button
Air flow blade swing button
Temperature adjustmentbuttons
Fan speedadjustment buttons
ON/OFF button
1-DB68-02477A(1) 6/28/01 11:33 AM Page 2-8
-
Samsung Electronics 3-1
3. Installation and Operating Instructions
3-1 Installation
1. Make sure that you install the unit in an area thatprovides
good ventilation. The air conditioner must not be blocked by
anyobstacle affecting the air flow near the air inlet andair
outlet.
2. Make sure that you install the unit in an area whichcan
endure the weight and vibration of the unit.
3. Make sure that you install the unit away from heator
vapor.
4. Make sure that you install the unit in an area wherethe
cooled air can be evenly spread in a room.
5. Make sure that you install the unit in an area awayfrom TVs,
audio units, cordless phones, fluorescentlighting fixtures and
other electrical appliances.(obtain a clearance of at least one
meter)
6. Make sure that you install the unit in an area whichprovides
easy drainage for condensed water.
7. Make sure that you install the unit in an area notexposed to
rain or direct sunlight.(Install a separate sunblind if exposed to
direct sun-light.)
8. Do not install the unit in an area subjected to noiseor
vibration amplification which may affect yourneighbor.(Fix the unit
firmly if mounted in a high place.)
* When selecting the area for installing the unit, be sure to
obtain approval of the customer.
Caution:
Do not use the air conditioner in such areas as a greasy
area(including machine oil), saline area(sea side), or sulphuric
area(hot spring). When using the air conditioner in these
areas,special maintenance is required. Contact your local dealer or
our service center for advice.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-1
-
3-2 Samsung Electronics
3-2 Function Description
3-2-1 Cooling operation mode
Fan speed indicator(LOW, MED, HIGH)
Temperature/Timer settings
Temperature adjustment buttons
Operating mode indicators(COOL, FAN)
Remote control sensorAir flow blade swing
ON/OFF button
Fan Speed adjustment button(LOW, MED, HIGH)
Air flow blade swing indicator
Energy saver indicator
ON/OFF Timer adjustment button
Sleep mode adjustment button
Timer indicator
Energy saver ON/OFF button
Operating mode selection button(COOLING, FAN)
Operating on/off
The compressor is turned on and off according to the ambient
temperature and set temperature.1) Compressor on and off
control
Compressor on and off control according to the ambient
temperature
* The compressor is turned off when "ambient temperature = set
temperature* The compressor is turned on when "ambient temperature
= set temperature +1C"
2) Default value after power reset set temperature = 24C
(75F)Fan speed = High
3) Set temperature indicating (setting) range : 1C(1F) interval
from 18C to 30C. (64F to 86F)
3-2-2 Fan operation mode
1) If "Fan operation mode" signal is received from remocon or
panel. the compressor is immediately turned off and only fan motor
is operated at set blowing speed. it changes such as "High Med Low
High"(if Fan speed is selected).
2) The initial Fan motor speed is set to "High".3) The set
temperature can not be indicated and set.
3-2-3 Energy saver operation mode
* If the compressor turn off at the cooling operation, the fan
motor turn off after operation during the fixation time only,and
operation that energy saver by turn off the fixation time only, and
operation that energy saver by turn off the motorcontinuously
before the condition of the compressor on.
* The fan motor is not operated at flow wind operation.
* Energy saver operation specification at the cooling
operation.1) Fan motor control in compressor on : operate with
setting wind speed2) Fan motor control in compressor off : After
compressor off, the fan motor is operated breeze for 2 minutes and
then it
turn off.3) After the fan motor off, the compressor and fan
motor is operated normally when the compressor on.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-2
-
Samsung Electronics 3-3
3-2-5 Sleep operation mode
1) Enable to sleep operation only when cooling operation.2)
First, 7-SEG LED DISPLAY "SLEEP" while 15 second, Second, 7-SEG LED
DISPLAY "8Hr"
And, automatically SET OFF after operated while 8 Hour3) If
sleep operation, setting Temperature rise 1C after 1 Hour4) ON
TIMER operation, not operation, ENERGY SAVER operation, not sleep
operation.
3-2-4 Auto Restart (AWFBEA) : OPTION1) The operation mode, wind
volume of fan motor and the set temperature right before the
blackout are memorized in
EEPROM and so the operation can continue with the previous
operation mode, wind volume of fan motor and the set temperature
after the recover of blackout.
3-2-6 Air flow blade swing motor operation
1) The Air flow blade swing motor is turned on and off according
to Air flow blade swing operation in remocon or panel, if SET is
cooling or Fan operation mode.
2) If the operation mode is "ENERGY SAVER", in case of fan motor
being turned off Air flow blade swing motor is immediately turned
off.
3-2-7 LED display indication in case of error detection
ERROR OPERATION
ROOM THERMISTOR(OPEN or SHORT)
7-SEGLED DISPLAY
E1 displayed
1) Set operation in case of error occurrence. Malfunction of
each temperature sensor (open, short)
- Error mode display, warning sound.- The operation status is
off.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-3
-
Key operational function
POWER Operation start and stop* First ON = operation start,
second ON = operation stop
- Selected as "OFF > COOL or FAN". (DEFAULT=OFF)* Continuous
operation is not available.
Mode Operation mode change* at every ON
- Selected as "COOL > FAN". (Default=COOL)* If operation is
OFF, it is considered as an invalid key.* Continuous operation is
not available.
Fan speed Fan motor speed setting* at every ON
- Selected as HIGH > MED > LOW > HIGH.
(DEFAULT=HIGH)
Temperature Currently displayed set temperature
increase/decrease(, ) * At every pressing, the set temperature is
changed by 1C, (1F)
(increase() : 18C > 19C > ... > 29C > 30C), (64F
-> 65F -> ... -> 85F -> 86F)(decrease() : 24C > 23C
> ... > 17C > 18C), (86F ->84F -> ... -> 65F
-> 64F)
* In case of the set temperature of 30C(86F), when the increase
key is pressed temperature does not increase any more.
* In case of the set temperature of 18C(64F), when the decrease
key is pressed temperature does not decrease any more.
* In case of above situation, when increase/decrease key is
pressed by remocon, warning sound is generated.
* If operation is OFF, it is considered as an invalid key.* In
case of FAN mode operation, it is considered as an invalid key.*
Continuous operation is available.
Air Swing Circulaire motor operation and stop* Once
ON=Circulaire motor operation. Another ON-Circulaire motor stop.*
Continuous operation is not available.* In case of operation stop,
when the fan motor is turned off it is considered as an invalid
key.
Timer Setting the on/off timer(ON/OFF) * Can set OFF TIMER HOUR
if set is operation
* Can set ON TIMER HOUR if set is not operation* Once ON=standby
setting TIMER : displayed* In case of key pressing in status of
standby setting ON/OFF TIMER
(Hr > 1Hr > 2Hr > ... > 23Hr > 24Hr)* If press
TIMER key countinuosly operate such the lower part
(Hr > 1Hr > 2Hr > ... > 24Hr > --Hr)* Continuous
operation is available.
Sleep SLEEP mode on and off* Once ON=SLEEP mode on, Another
ON=SLEEP mode off
Continuous operation is not abailable Operation off, on timer
Operation, save operation , not key operation
* Not SLEEP operation is FAN mode
Energy Saver Power save mode on and off* Once ON=Power save mode
on, Another ON=Power save mode off* Continuous operation is not
available.* If operation is OFF, it is considered as an invalid
key.
3-2-8 Panel key operation
Key discriptionKey name
3-4 Samsung Electronics
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-4
-
3-2-9 LED lamp operation specifications
LAMP name Operations specifications
COOLING ( ) The mode is set to "COOL" > ONOthers > OFF
FAN ( ) The mode is set to "FAN" > ONOthers > OFF
HIGH ( ) The mode is set to "HIGH" > ONOthers > OFF
MED ( ) The mode is set to "MED" > ONOthers > OFF
LOW ( ) The fan speed is set to "LOW" > ONOthers > OFF
TIMER ( ) The mode is set to "TIMER" > ONOthers > OFF
ENERGY SAVER ( ) The mode is set to "ENERGY SAVER" > ONOthers
> OFF
AIR SWING ( ) The mode is set to "Air Swing" > ONOthers >
OFF
In case of set temperature display-> NO. (1) 7SEG LED DISPLAY
indicates temperature of the tens digit-> NO. (2) 7-SEG LED
DISPLAY indicates temperature of the units digitIn case of time
display-> NO. (1) 7SEG LED DISPLAY indicates time of the tens
digit -> NO. (2) 7SEG LED DISPLAY indicates time of the units
digit
In case of set temperature display-> NO. (3) 7SEG LED DISPLAY
indicates temperature unit()-> NO. (4) 7-SEG LED DISPLAY
indicates temperature unit(C), (F)In case of time display-> NO.
(3) 7SEG LED DISPLAY indicates time unit(H) of the tens digit ->
NO. (4) 7SEG LED DISPLAY indicates time unit(r) of the units
digit
First, 7SEG LED DISPLAY "SLEEP" while 15 second, Second, 7-SEG
LED DISPLAY "8Hr"
(1) (2)
(3)
(1) (2) (3) (4)
(4)
Samsung Electronics 3-5
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-5
-
3-6 Samsung Electronics
3-3 Remocon Control
3-3-1 Remocon key operation
11) In case of pressing POWER key, operation start and stop.12)
In case of pressing COOL key, cool mode operation start.13) In case
of pressing FAN key, fan mode operation start.14) In case of
pressing HIGH key, fan motor operates high speed.15) In case of
pressing MED key, fan motor operates mid speed.16) In case of
pressing LOW key, fan motor operates low speed.17) In case of
pressing ENERGY SAVER on/off key, set operates as power saving
mode.18) In case of pressing key, set temperature increase by
1C(18C ~ 30C), 1F(64F ~ 86F).19) In case of pressing key, set
temperature decrease by 1C(30C ~ 18C), 1F(86F ~ 64F).10) In case of
pressing TIMER key, the convenient reserve TIMER time increase by 1
Hr (1Hr ~ 24Hr).11) In case of pressing SLEEP key, SLEEP
operates.12) In case of power off, all keys except POWER key are
considered as an invalid key.
Timer setting button
Sleep timer setting button
Operating modeselection buttons
Energy Saver button
Air flow blade swing button
Temperature adjustmentbuttons
Fan speedadjustment buttons
ON/OFF button
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-6
-
Samsung Electronics 3-7
3-3-2 Resistor values table of ROOM THERMISTOR for each
temperature
Temperature[C]
THERMISTOR RESISTOR[Kohm] 1%
7069686766656463626160
59585756555453525150
49484746454443424140
39383736353433323130
2.2292.2962.3652.4372.5122.5892.6692.7522.8382.9283.021
3.1163.2163.3193.4263.5373.6523.7723.8974.0264.161
4.3004.4444.5944.7494.9125.0805.2565.4395.6305.828
6.0336.2466.4686.6996.9417.1927.4557.7298.0158.313
Temperature[C]
THERMISTOR RESISTOR[Kohm] 1%
29282726252423222120
19181716151413121110
9876543210
-1-2-3-4-5-6-7-8-9
8.6228.9449.2819.63210.00010.38010.78011.20011.63012.090
12.56013.06013.57014.12014.68015.28015.90016.55017.24017.960
18.70019.48020.29021.15022.05022.99023.90025.03026.13027.280
28.47029.72031.04032.43033.89035.43037.05038.76040.560
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-7
-
4-1 Samsung Electronics
4. Disassembly and Reassembly
4-1 Compressor Replacement Flow Chart
Locate cause of defect
Release refrigerant
Disconnect electrical wiringfrom compressor
Cut refrigerant lines from compressor
Plug disconnected lines
Replace compressor
Inspect electrical wiring for defects, and terminals forcorrect
and secure connections
Solder discharge line
Corrective actionCheck refrigerant oil level
Add oil as necessary
Solder suction line Use nitrogen gas
Perform soldering function
Fill system with nitrogen gas
Check for leakage
Pinch and braze filling tube
Recharge system
Evacuate system
Release nitrogen gas?
Problem?
Low oil level? NY
Y
N
N
YLeakage?
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-8
-
4-2 Disassembly and Reassembly Procedure
Stop operating the air conditioner, and pull out the power cord
before repair.
No. Part name Procedures Remarks
!
@
#
Ass'y Grill
Ass'y Cabinet
Ass'y Control
1. Pull the panel front and remove the screwon the grille.
2. Hold the lower part of grill with two handswhile pressing
down on both sides of thelower part of the cabinet, pull it forward
byabout 30, and the then lift it up for removal.
1. Remove the two screws both side cabinet.
2. Pull the front both side, and remove the unitfrom the
cabinet.
1. Remove the blade V and arm blade.
2. Remove 2 screws, and 2 earth wire screws.
3. Remove two lead wire assemblies.
4. Take out the control box forward.
!!
4-2-1 Type A
Samsung Electronics 4-2
*The type of front-paneldepends on models.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-9
-
4-3 Samsung Electronics
No. Part name Procedures Remarks
$
%
Frame Up
Case Cond & Propeller Fan
1. Remove 6 screws on the Frame upand remove the Frame up and
the reinffrom case cond.
1. Remove two screws on the bottom side,and 4 screws on the case
cond.
2. Pull up the case cond and separate thecond case from the
cond.
3. Remove the nut flange, and remove thepropeller fan
Disassembly and Reassembly
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-10
-
Samsung Electronics 4-4
No. Part name Procedures Remarks
^
&
Cond Casing
Blower & Motor
1. Remove the cond casing
1. Move the motor & blower toward theevap, and lift up the
motor & blower fromthe frame low.
Disassembly and Reassembly
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-11
-
4-5 Samsung Electronics
Disassembly and Reassembly
No. Part name Procedures Remarks
!
@
#
Ass'y Grill
Ass'y Cabinet
Ass'y Control
1. Pull the panel front and remove the screwon the grille.
2. Hold the lower part of grill with two handswhile pressing
down on both sides of thelower part of the cabinet, pull it forward
byabout 30, and the then lift it up for removal.
1. Remove the screws on both sides of the cabinet to disconnect
the cabinet and frame.
2. Pull the handle on the front side of thebottom, and remove
the unit from thecabinet.
1. Remove 6 screws, and earth wire screw.
2. Remove three lead wire assemblies.
3. Remove the blade V and arm blade.
4. Take out the control box forward.
4-2-2 Type B
Stop operating the air conditioner, and pull out the power cord
before repair.
*The type of front-paneldepends on models.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-12
-
Samsung Electronics 4-6
No. Part name Procedures Remarks
$
%
Frame Up
Case Cond & Propeller Fan
1. Remove 10 screws on the Frame Up.
1. Remove two screws on the bottom side, and 5 screws on the
case cond.
2. Remove the nut flange, and remove the propellr fan
Disassembly and Reassembly
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-13
-
4-7 Samsung Electronics
No. Part name Procedures Remarks
Blower & Motor
Cond Casing
1. Remove two screws on the clip motor,and remove the clip
motor.
2. Move the motor & blower toward theevap, and lift up the
motor & blowerfrom the frame low.
1. Remove the cond casing
Disassembly and Reassembly
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-14
-
Samsung Electronics 4-8
Disassembly and Reassembly
4-2-3 Type C
Stop operating the air conditioner, and pull out the power cord
before repair.
No. Part name Procedures Remarks
!
@
#
Ass'y Grille
Ass'y Cabinet
Ass'y Control
1. Pull the panel front and remove the screwon the grille.
2. Hold the lower part of grill with two handswhile pressing
down on both sides of thelower part of the cabinet, pull it forward
byabout 30, and the then lift it up for removal.
1. Remove the screws on both sides of thecabinet to disconnect
the cabinet and frame.
2. Pull the handle on the front side of thebottom, and remove
the unit from thecabinet.
1. Remove 10 screws, on the evap cover andearth wire screw.
*The type of front-paneldepends on models.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-15
-
4-9 Samsung Electronics
Disassembly and Reassembly
No. Part name Procedures Remarks
$
%
Assy - Evaporator
Plate - Evap Casing
2. Remove 3 screw on the control box andtwo lead wire
assemblies.
3. Take out the control box forward.
1. Remove for screws on the left and rightside of the
evaporator.
1. Lift up the evaporator, and remove the traydrain.
2. Remove two screws on the left side of theplate evap
casing.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-16
-
Samsung Electronics 4-10
Disassembly and Reassembly
No. Part name Procedures Remarks
^
&
*
Blower
Propeller Fan
Motor Supporte &Motor
1. Loosen the hexagon nut, and removethe blower.
1. Remove two screws on the bottomside, and 5 screws on the case
cond.
2. Loosen the hexagon nut, and removethe fan
1. Remove four hexagon nuts on the basepan.
2. Move the motor - assembly toward thecondenser, and lift up
the motor -assembly from the frame.
3. Remove the clips on both sides carefullyusing the (-)
driver.
1-DB68-02477A(1) 6/28/01 11:33 AM Page 3-17
-
4-11 Samsung Electronics
MEMO
1-DB68-02477A(1) 6/28/01 11:34 AM Page 3-18
-
Samsung Electronics 5-1
5. Troubleshooting
5-1 Basic Checkpoints for Troubleshooting
Check the basic checkpoints first to determine whether it is
machine trouble or a problem in theoperation method. When it is not
related to the basic checkpoints, perform checking in
accordancewith the procedures of troubleshooting by symptom.
1) Is the voltage of the power source appropriate ?(1) It should
be within the rating voltage 10% range. (2) The air conditioner may
not operate properly when the voltage is out of this range.
2) Is the connection with the fan motor, compressor wire, and
starting condenser appropriately made ?
3) The symptoms listed in the table below are not indicative of
machine trouble.
Symptom Cause and check
No operation Check whether there is power failure or the power
plug is pulled out. Check whether the unit is stopped as a result
of completion
of the sleep time. Pull out the power plug for ten seconds, and
then insert it again.
Air flows, but Check whether the Air filter is clogged with dust
or is dirty.no cooling Check whether the desired temperature is too
high. Set the desired
temperature to a lower level than the current temperature. Check
whether it is in "FAN" mode.
The remocon does Check whether battery is completely
depleted.not operate Check whether the battery is properly
inserted.
Check whether the receiving window of the remocon for the
assembly main PCB is blinded.
Check whether the remocon is affected by jamming due to a neon
sign.
No temperature Check whether the unit is in "FAN" mode.setting
(In "FAN" mode, only the current temperature is displayed, and
the
desired temperature is not set.)
Checking and Display of Fault Area
ERROR OPERATION
ROOM THERMISTOR (OPEN OR SHORT)
ERROR OPERATION
E1 displayed
2-DB68-02477A(1) 6/28/01 11:34 AM Page 5-1
-
5-2 Samsung Electronics
5-2 Troubleshooting by Symptom
5-2-1 No power
1) Check points
(1) Is the voltage of the power source normal ? (the rating
voltage 10% range.) (2) Is the electric wire in good contact ?(CN
71, RY 71)(3) Is the output voltage of the IC01(KA 7812) normal
?(DC 11.5V ~ DC 12.5V)(4) Is the output voltage of the IC02(KA
7805) normal ?(DC 4.5V ~ DC 5.5V)
Turn off the power, and then turn it on again fiveseconds
later.
Replace the assembly main PCB.
Dose the buzzer sound, when the power on?
Check whether the "COOLING ICON" LED lamp is on,and the
operation starts when pressing the ON/OFFbutton of the remocon.
Is the primary voltage of the transformer normal?(the rating
voltage 10% range.)
Is the secondary voltage of the transformer normal?(AC 13V ~ AC
17V)
Is the F701(3.15A) fuse blown?
Is the rectifier diode(D101~D104) normal?
Are the IC01(KA7812) and IC02(KA7805) normal?
- Is the voltage of DC 17V ~ DC 23V applied at both ends of the
C101 electrolytic condenser?
- Is the voltage of DC 12V applied at both ends of the C102
electrolytic condenser?
- Is the voltage of DC 5V applied at both ends ofthe C103
electrolytic condenser?
Normal operation.
Normal operation.
Replace the fuse.
Check the power cord and electric wire.
Check and replace the trans.
Check the D101 ~ D104 for cold soldering. Replace the rectifier
diode
Check both ends of the C101 for short and cold soldering.
Check the +12V for a short. Check the +5V for a short. Check and
replace the C101~104.
Check the IC01, and IC02 for cold soldering and a short.
Replace the IC01, and IC02.
N
N
N
Y
Y
Y
Y
Y
N
N
N
N
N
Y
Y
Y
2-DB68-02477A(1) 6/28/01 11:34 AM Page 5-2
-
Samsung Electronics 5-3
5-2-2 When the MEMBRANE KEY PAD AND LED DISPLAY
1) Check points
(1) Is the voltage of the power source normal ? (the rating
voltage 10% range.)(2) Is the electric wire in good contact ?(CN71,
RY71)(3) Is the connection of the assembly main PCB, and MEMBRANE
KEY PAD in good contact?
(CN91)
Check the micom(IC04) for a short,and replace it.
Check the micom(IC04) for a short,and replace it.
Check the Q901~Q905 for a short, and replace it.
Check the micom(IC04) for a short,and replace it.
Normal operation
Check the micom(IC04) for a short,and replace it.
Replace the MEMBRANE KEY PAD
Replace the MEMBRANEKEY PAD.
Y
N
Normal operationN N
N
N N
N
Y
Y Y
Y Y
Y
Y
Turn off the power, and then turn it on againfive seconds
later.
When the LED DISPLAY isnot operated.
When the MEMBRANE KEYis not operated.
Is the voltage of the micom(IC04) No.1, 2, 38~43 port asquare
wave?
Is the voltage of themicom (IC04) No.13, 14 port a square
wave?
Is the voltage of the micom(IC04) No.3, 4, 10, 11, 44 port a
square wave?
Is the voltage of the micom(IC04) No.3, 4, 10, 11, 44 port
asquare wave?
Is the voltage of theQ901 ~ Q905 square wave?
Check the IC07for a short, andreplace it.
N Is the voltage of theIC07 No. 10~16 a square value?
2-DB68-02477A(1) 6/28/01 11:34 AM Page 5-3
-
5-4 Samsung Electronics
5-2-3 When the remocon is not operated
1) Check points
(1) Is the voltage of the power source normal ? (the rating
voltage 10% range. )(2) Is the electric wire in good contact ?
(CN71, RY71)(3) Is the assembly main PCB in good contact with the
MEMBRANE KEY PAD(CN91)(4) Is the battery voltage of the remocon
above DC 2.7V?
Turn off the power, and then turn it onagain five seconds
later.
Replace the assembly main PCB.
Dose the Buzzer sound, when the power on?
Check whether the "COOLING ICON" LED lamp is onand th operation
starts when pressing theon/off button of the remocon.
Is the battery voltage of the remocon above DC 2.7V?
Is the collector voltage of the remocon QT1, QT2a square
wave?
Does the X-TAL(RJ 455JB) oscillate normally?
Is the input voltage of the micom(IC04) No. 15pin of the
assembly main PCB a aquare wave?
Go to the clause "No power".
The remocon is normally operated.
Replace the battery.
Check the X-TAL for cold soldering and ashort.
Replace relevant components.
Check the micom(ICT1) QT1, and QT2 for cold soldering and a
short.
Replace relevant components.
Check the R415 components. Check the assembly main PCB
micom(IC04).
N
Y
N
Y
Y
Y
Y
N
N
N
N
Y
2-DB68-02477A(1) 6/28/01 11:34 AM Page 5-4
-
Samsung Electronics 5-5
5-2-4 When the compressor is not operated
1) Check points
(1) Is the voltage of the power source normal ? (the rating
voltage 10% range. )(2) Is the desired temperature lower than the
indoor temperature in the COOL mode?
(Compressor stopped)(3) Is the starting condenser in good
contact?(4) Is the electric wire in good contact ? (CN71, RY71)(5)
Is the output voltage of the IC01(KA7812) and IC02(KA7805) normal
?
Turn off the power, and then turn it on again fiveseconds
later.
Replace the compressor.
Dose the Buzzer sound, when the power on?
Check whether the "COOLING ICON" LED lamp is onand the operation
starts when pressing the on/off button of the remocon.
Is the IC03 output normal?- When the compressor is ON, IC03
No. 15 pin > Low.
Does the relay(RY71) operate normally?- When the compressor is
ON, the RY71 should operate.
Is the compressor normal?
Go to the clause "No power".
Go to the clause "when he remocon does not operate".
Check the IC03 for short and cold soldering. Replace the
IC03.
Check the relay coil resistance.(resistance : About 15020)
Replace the relay.
Check the operation of the O.L.P,and replace it if
necessary.
Check the compressorresistance.(0 : short, : open)
N
Y
Y
Y
Y
Y
N
Normal operation.
N
Y
N
N
N
Check whether the compressor is activated in three minutes after
turning on the power with the "COOLINGICON" LED lamp being switched
on when selecting thecool mode of the remocon.
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-5
-
5-6 Samsung Electronics
5-2-5 When the air swing motor is not operated
1) Check points
(1) Is the voltage of the power source normal ? (the rating
voltage 10% range. )(2) Is the electric wire in good contact
?(CN71, RY71)(3) Is the swing motor connector in good
contact?(CN71)(4) Is the terminal connected to the swing motor in
good contact?(5) Is the output voltage of the IC01(KA7812) and
IC02(KA7805) normal?
Turn off the power, and then turn it on again fiveseconds
later.
Replace the air-swing motor.
Dose the buzzer sound, when the power on?
Does the air-swing motor operate whenpressing the air-swing
button of the remote control?
Is the IC03 output normal?- When the air-swing motor is on,
IC03
No. 11 pin Low
Does the relay(RY 75) operate normally?- When the air-swing
motor is operated, the
RY75 should be operated.
Go to the clause "No power".
Normal operation.
Check the IC03 for a short and cold soldering.
Replace the IC03.
Check the relay coil resistance.(Normal: About 400)
Replace the relay.
Check the air-swing motor resistance.(0 : short, : open)
N
Y
N
Y
Y
Is the air-swing motor normal?
Y
Y
N
Check whether the COOLING ICON LED lamp is on,and the operation
starts when pressing the ON/OFFbutton of the remocon?
Go to the clause of when the remocondose not operated
Y
N
N
N
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-6
-
Samsung Electronics 5-7
5-2-6 When the fan motor does not operated
1) Check points
(1) Is the voltage of the power source normal ? (the rating
voltage 10% range. )(2) Is the electric wire in good contact
?(CN71, RY71)(3) Is the starting condenser(FAN MOTOR) in good
contact?(4) Is the fan motor connector in good contact?(CN73)(5) Is
the output voltage of the IC01(KA7812) and IC02(KA7805) normal
?
Turn off the power, and then turn it on again five seconds
later.
Replace the fan motor.
Dose the buzzer sound, when the power on?
Check whether the "COOLING ICON" LED lamp is on andthe operation
starts when pressing the on/off button of the remocon.
Is the IC03 output normal?- When the fan motor is High, IC03 No.
13 pin > LOW. - When the fan motor is Med, IC03 NO. 14 pin >
LOW.- When the fan motor is Low, IC03 No. 16 pin > LOW.
Does the relay(RY 72, 73) operate normally?- When the fan motor
is High, RY72 should operate.- When the fan motor is Med, RY73
should operate.- When the fan motor is Low, RY76 should
operate.
Go to the clause "No power".
Go to the clause of "when the remocondoes not operated".
Check the IC03 for a short and cold soldering.
Replace the IC03.
Check the relay coil resistance.(Normal: About 400)
Replace the relay.
N
Y
Y
Y
Is the fan motor normal?
Y
Y
N
N
N
Check the fan motor resistance.(0 : short, : open)
Check the fan motor thermal fuse?(130C)
N
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-7
-
6-1 Samsung Electronics
6. Exploded View and Parts List
6-1 Main unit (Type A)
13
15
14
17
16
2322 24
18
2021
19
1
2-1
2-33
2
4
2-2
6
5
89
12
10
11
7
25
27
26
28
29
34
35
30-
11
30-
12
30-
10
30-
930
-8
30-
730
-1
30
-4 30
-3
30-
530
-6
3130
30-
2
33
2-DB68-02477A(1) 7/2/01 10:07 AM Page 5-8
-
Samsung Electronics 6-2
Part List (Type A)
No DescripitionCode No. SpecificationQty
AW0690A AW0790A AW07FASAA AW07FASBA AW07FASEA AW0890A AW09FASBA
AW09FASEA AW09FBSEA
1 DB64-10158A GRILLE-AIR INLET HIPS,2mm 1 1 - - - 1 - -
-DB64-00104A GRILLE-AIR INLET HIPS,2mm - - 1 - 1 - 1 1 1DB64-00104B
GRILLE-AIR INLET HIPS,2mm - - - 1 - - - - -
2 DB92-70096D ASS'Y PANEL- FRONT ASSY 1 1 - - - 1 - -
-DB92-00052A ASS'Y PANEL- FRONT ASSY - - 1 - 1 - 1 1 1DB92-00052B
ASS'Y PANEL- FRONT ASSY - - - 1 - - - - -
2-1 DB63-30158A FILTER-GUARD HIPS,2mm 1 1 - - - 1 - -
-DB74-00005C FILTER-GUARD ZENO BLUE - - 1 1 1 - 1 1 1
2-2 DB64-70093A PANEL-FRONT HIPS,2mm 1 1 - - - 1 - -
-DB64-00167A PANEL-FRONT HIPS,2mm - - 1 - 1 - 1 1 1DB64-00167B
PANEL-FRONT HIPS,2mm - - - 1 - - - - -
2-3 DB66-30191A BLADE-H HIPS 1 1 - - - 1 - - -DB66-00053A
BLADE-H HIPS - - 1 - 1 - 1 1 1DB66-00053B BLADE-H HIPS - - - 1 - -
- - -
3 DB96-00045C ASSY-EVAP 2R*14S 1 1 1 - - 1 - - -DB75-00001B
ASSY-EVAP 2R*14S - - - 1 1 - - - -DB96-00045B ASSY-EVAP 3R*14S - -
- - - - 1 - -DB96-00045A ASSY-EVAP 2R*14S - - - - - - - 1 1
4 DB90-00002D ASSY FRAME-LOWER AW07A1SB,- 1 1 1 1 1 1 1 1 15
DB66-30211B BLADE-V PP,SC-97525R 1 1 1 1 1 1 1 1 16 DB66-70030A
LEVER-DAMPER HIPS,SC-94445R 1 1 1 - 1 1 1 1 1
DB66-70030C LEVER-DAMPER HIPS,W9391 - - - 1 - - - - -7
DB67-50078A BLOWER ABS 1 1 1 1 1 1 1 1 18 DB31-00073A MOTOR FAN
IC-9630SWD6F 1 - - - - - - - -
DB31-00073E MOTOR FAN IC-9630SWD6C - 1 - - - - - - -DB31-00004P
MOTOR FAN IC-9630SWD6E - - 1 - - - - - -DB31-00073C MOTOR FAN
IC-9430SWJ5A - - - - 1 - - 1 1DB31-00073B MOTOR FAN IC-9630SWD6E -
- - - - 1 - - -DB31-00073D MOTOR FAN IC-9630SWD6G - - - 1 - - 1 -
-
9 DB67-50077A FAN-PROPELLER ABS 1 1 1 1 1 1 1 1 110 DB90-00013B
ASSY-CASE-COND ASSY 1 1 1 1 1 1 1 1 111 DB90-00014G ASSY
FRAME-UPPER ASSY 1 1 - 1 1 1 1 1 1
DB90-00014H ASSY FRAME-UPPER ASSY - - 1 - - - - - -12
DB61-00027B FRAME-REINF PP,GRAY 1 1 1 1 1 1 1 1 113 DB75-00002A
CONDENSER 2R,15S,GROOVE 1 1 - 1 - - - 1 1
DB75-00002B CONDENSER 2R,15S,GROOVE - - 1 - 1 - 1 - -DB75-00011B
CONDENSER 2R,15SGROOVED - - - - - 1 - - -
14 DB63-10388A CAP EPDM,BLK - - 1 1 1 - 1 1 115 DB90-20212F
ASSY-BASE SGCC-M,SC94445T 1 1 - - - 1 - - -
DB90-20212B ASSY-BASE SGCC-M,SC94445T - - 1 1 1 - 1 1 116
DB96-00260A ASSY-TUBE CAPILLARY 1.3*1100 1 - - - - - - - -
DB62-00372A ASSY-TUBE CAPILLARY C1220T-H - 1 1 - - - - -
-DB96-00077A ASSY-TUBE CAPILLARY AW0719 - - - 1 1 - - -
-DB96-00552A ASSY-TUBE CAPILLARY 1.42xL1200 - - - - - 1 - -
-DB96-00046A ASSY-TUBE CAPILLARY AW09A2SB - - - - - - 1 -
-DB96-00077B ASSY-TUBE CAPILLARY AW09G2SE - - - - - - - 1 1
17 DB96-00008B ASSY TUBE SUCTION AW07A2SB 1 1 - 1 1 1 - -
-DB62-00370A ASSY TUBE SUCTION C1220T-0,MEI-COMP - - 1 - - - - -
-DB96-10736A ASSY TUBE SUCTION AW09B0SB - - - - - - 1 -
-DB96-10736B ASSY TUBE SUCTION AW09G2SE - - - - - - - 1 1
18 DB62-00150C TUBE DISCHARGE C1220T-0,D7.94,T0.7 1 1 - 1 1 - -
- -DB62-00391A TUBE DISCHARGE C1220T-O,OD7.93,T0.7 - - 1 - - - - -
-DB62-00483A TUBE DISCHARGE C1220T-O,OD7.93,T0.7 - - - - - 1 - -
-DB62-00152A TUBE DISCHARGE C1220T-0,D7.94,T0.7 - - - - - - 1 1
-DB62-00440A TUBE DISCHARGE C1220T-0,D7.94,T0.7 - - - - - - - -
1
19 44A062HS1EB COMPRESSOR 115V,60Hz,R22,1Ph 1 - - - - - - -
-44A072HW1EB COMPRESSOR 1Ph,115V,R22,60Hz - 1 - - - - - -
-DB95-00113E COMPRESSOR 2R11S3R126-6,MATSUSHTA - - 1 - - - - -
-44A072IW1EB COMPRESSOR 208-230V,60Hz,1Ph,R-22 - - 1 - - - -
-44A070JW1EB COMPRESSOR 220-240V,50Hz,1Ph,R-22 - - - - 1 - - -
-44A080HU1EB COMPRESSOR 115V,60HZ,1PH,8.0K - - - - - 1 - -
-44B092IW1EF COMPRESSOR 208-239V,60Hz,1Ph,R-22 - - - - - - 1 -
-44B092JW1EF COMPRESSOR 1Ph,50Hz,R22,220-240V - - - - - - - 1 1
20 DB60-30028A NUT-WASHER HEX,2C,M8,ZPC 1 1 1 1 1 1 1 1 121
DB73-00070A GROMMET-ISOLATOR NR 35 1 1 1 1 1 1 1 1 122 DB63-10026A
COVER-TERMINAL NORYL,SEI-701 1 1 - 1 1 1 1 1 1
2-DB68-02477A(1) 7/2/01 10:07 AM Page 5-9
-
6-3 Samsung Electronics
Part List (Type A) (cont.)
No DescripitionCode No. SpecificationQty
AW0690A AW0790A AW07FASAA AW07FASBA AW07FASEA AW0890A AW09FASBA
AW09FASEA AW09FBSEA
22 DB63-00023A COVER-TERMINAL ME1 - - 1 - - - - - -23
DB60-30018A NUT-FLANGE PI0.8,M5,SM20C 1 1 1 1 1 1 1 1 124
DB47-20002F OLP MRA12040-12008 1 - - - - - - - -
DB47-20001V OLP MRA98706-12008 - 1 - - - - - - -DB35-00012B OLP
MRA98705 - - 1 - - - - - -DB47-20002J OLP MRA 12043-12008 - - 1 - -
- - -DB47-20001Y OLP MST24AMN-12008 - - - - 1 - - - -DB47-20066B
OLP 150/69,31.0 - - - - - 1 - - -DB47-20002A OLP MRA12032-12008 - -
- - - - 1 - -DB47-20002U OLP MRA12056-12007 - - - - - - - 1 1
25 DB64-00135H CABINET SGCC-M 1 1 - - - 1 - - -DB64-00135A
CABINET SECC-P,SC-94445T - - 1 1 1 - 1 1 1
26 DB64-00048B SHUTTER-ANGLE UP HIPS,T3.0,520 1 1 - - - 1 - -
-27 DB92-00113A ASSY SHUTTER-LF ASSY 1 1 - - - 1 - - -28
DB92-00112A ASSY SHUTTER-RH ASSY 1 1 - - - 1 - - -29 DB61-30219F
BRACKET-INSTALL SGCC-A,T1.6 1 1 - - - 1 - - -30 DB93-00465K ASSY
CONTROL-E ASSY 1 - - - - - - - -
DB93-00465Q ASSY CONTROL-E ASSY - 1 - - - - - - -DB93-00705A
ASSY CONTROL-E ASSY - - 1 - - - - - -DB93-00465L ASSY
CONTROL-E(TAIWAN) ASSY - - 1 - - - - - -DB93-00465M ASSY
CONTROL-E(TAIWAN) ASSY - - 1 - - - - -DB93-00465D ASSY CONTROL-E
ASSY - - - - 1 - - - -DB93-00465H ASSY CONTROL-E ASSY - - - - - 1 -
- -DB93-00465G ASSY CONTROL-E ASSY - - - - - - 1 - -DB93-00465C
ASSY CONTROL-E ASSY - - - - - - - 1 -DB93-00465P ASSY CONTROL-E
ASSY - - - - - - - - 1
31 DB93-00284K ASSY REMOCON ASSY 1 1 1 1 1 1 1 1 133 DB97-30156C
ASSY ACCESSORY ASSY 1 1 - - - 1 - - -34 DB60-30002A NUT-FLANGE M6 1
1 1 1 1 1 1 1 135 DB60-30004A NUT FLANGE M6,SM20C 1 1 1 1 1 1 1 1
1
2-DB68-02477A(1) 7/2/01 10:07 AM Page 5-10
-
Samsung Electronics 6-4
6-2 Main unit (Type B)
6
7
3
15
21
13
4
9
8
10
11
12
1716
20
18
19
14
5
22
2-1
2-2
2-3
1
24
23
2
25
25-
5 25-
11
25-
10
25-
7
25-
6
25-
8
25-
1
25-
2
25-
3
25-
4
25-
9
25-
13
25-
12
28
27
26
2-DB68-02477A(1) 7/2/01 10:07 AM Page 5-11
-
6-5 Samsung Electronics
Part List (Type B)
No Descripition Code No. SpecificationQty
AW1090A AW10FAJAA AW10FAJBA AW12FAJAA AW12FAJBA AW12FAJDA
AW12FAJEA AW12FBJEA
1 GRILLE-AIR INLET DB64-10145A HIPS,T2.5 1 - - - - - -
-GRILLE-AIR INLET DB64-00101A HIPS,T2.5 - 1 1 1 1 1 1 1
2 ASSY PANEL-FRONT DB92-00133A ASS'Y SC-94445R 1 - - - - - -
-ASSY PANEL-FRONT DB92-00072A ASS'Y SC-94445R - 1 1 1 1 1 1 1
2-1 PANEL-FRONT DB64-70080A HIPS 1 - - - - - - -PANEL-FRONT
DB64-00168A HIPS,T2.5 - 1 1 1 1 1 1 1
2-2 GUARD AIR-FILTER DB63-30142A HIPS,T2 1 - - - - - - -GUARD
AIR-FILTER DB63-00073B ABS,ZENO BLUE - 1 1 1 1 1 1 1
2-3 BLADE-H DB66-30169A PP,T2.5 1 - - - - - - -BLADE-H
DB66-00049A PP,T3 - 1 1 1 1 1 1 1
3 ASSY-BASE DB90-20184L SECC-P,T1 1 - - - - - - -ASSY-BASE
DB90-20184B SECC-P,T1 - 1 1 1 1 - - -ASSY-BASE DB90-20184A
SECC-P,T1 - - - - - 1 1 1
4 ASSY-COND DB96-00587A ASS'Y 1 - 1 - - - - -ASSY-COND
DB96-00587B ASS'Y - 1 - - 1 - - -ASSY-COND DB96-00250B ASS'Y - - -
1 - - - -ASSY-COND DB96-30279A ASS'Y - - - - - 1 1 1
5 ASSY-EVAP DB96-40203C ASS'Y 1 1 1 1 1 - - -ASSY-EVAP
DB96-40173A ASS'Y - - - - - 1 - -ASSY-EVAP DB96-40173B ASS'Y - - -
- - - 1 1
6 ASSY-FRAME LOW DB90-50133J ASS'Y 1 - - - - - - -ASSY-FRAME LOW
DB90-50133A ASS'Y - 1 1 1 1 1 1 1
7 BLOWER DB67-50078A ABS 1 1 - - - - - -BLOWER DB67-50073A ABS -
- 1 1 1 1 1 1
9 MOTOR FAN DB31-00074A AFS-095ZREA 1 1 - - - - - -MOTOR FAN
DB31-00074E AFS-095ZTEA - - 1 - - - - -MOTOR FAN DB31-00074B
AFS-100ZREB - - - 1 - - - -MOTOR FAN DB31-00074D AFS-105ZUEA - - -
- 1 - - -MOTOR FAN DB31-00074C AFS-105AUEA - - - - - 1 1 1
10 FAN-PROPELLER DB67-50072A AS,350 1 1 1 1 1 1 1 111
ASSY-CASE-COND DB61-10152A ASS'Y 1 - - - - - - -
ASSY-CASE-COND DB90-00142A ASS'Y - - - - - 1 1 1ASSY-CASE-COND
DB90-00142B ASS'Y - 1 1 1 1 - - -
12 ASSY FRAME-UP DB90-50142E ASS'Y 1 - - - - - - -ASSY FRAME-UP
DB90-50142F ASS'Y - 1 1 1 1 1 1 1
13 TUBE-CAPILLARY DB96-00387A - 1 1 - - - - - -TUBE-CAPILLARY
DB62-00649A - - - 1 - - - - -TUBE-CAPILLARY DB62-00510A - - - - 1 -
- - -TUBE-CAPILLARY DB62-00550A - - - - - 1 - - -TUBE-CAPILLARY
DB62-31741A - - - - - - 1 1 1
14 TUBE SUCTION DB96-00348B - 1 1 - 1 1 - - -TUBE SUCTION
DB96-00931A - - - 1 - - - - -TUBE SUCTION DB62-31742A - - - - - - 1
1 1
15 TUBE-DISCHARGE DB62-00327B - 1 1 1 1 1 - - -TUBE-DISCHARGE
DB62-31740A - - - - - - 1 1 1
16 NUT-WASHER DB60-30028A HEX,2C,M8,ZPC 1 1 1 1 1 1 1 117
GROMMET-ISOLATOR DB73-00070A NR 1 1 1 1 1 - - -
GROMMET-ISOLATOR DB73-00067A NR - - - - - 1 1 118 SPRING-OLP
DB67-60020A STS304-WPA 1 1 1 1 1 1 1 119 COVER-TERMINAL DB63-10026A
NORYL,-,SEI-701 1 1 1 1 1 1 1 120 OLP-POLYESTER DB35-00004Y
MRA12109-12007 1 1 - - - - - -
OLP-POLYESTER DB35-00015M RAC12049-9622 - - 1 - - - -
-OLP-POLYESTER DB47-20001U MRA98693-12007 - - - 1 - - -
-OLP-POLYESTER DB47-20001M MRA12008-12008 - - - - 1 - -
-OLP-POLYESTER DB47-20001V MRA12030-12008 - - - - - 1 -
-OLP-POLYESTER DB47-20001Z MRA98706-12008 - - - - - - 1 1
21 ROTARY COMPRESSOR:22 44B102HU1EF 115V,60Hz,1Ph,R-22 1 1 - - -
- - -ROTARY COMPRESSOR:22 44B102IU1EL 208-230V,60Hz,1Ph,R-22 - - 1
- - - - -ROTARY COMPRESSOR:22 44B124HU1EL 115V,60Hz,1Ph,R-22 - - -
1 - - - -ROTARY COMPRESSOR:22 44B124IU1EL 208-230V,60Hz,1Ph,R-22 -
- - - 1 - - -ROTARY COMPRESSOR:22 48A124MV1EL
200-220V,50Hz,1Ph,R-22 - - - - - 1 - -ROTARY COMPRESSOR:22
48A124JV1EL 220-240V,50Hz,1Ph,R-22 - - - - - - 1 1
22 ASSY CABI DB90-00364B ASS'Y 1 - - - - - - -ASSY CABI
DB90-00364A ASS'Y - 1 1 1 1 1 1 1
23 BLADE-V DB66-30170A PP,T3 1 1 1 1 1 1 1 124 LEVER-DAMPER
DB66-70024A HIPS,T2.5 1 1 1 1 1 1 1 125 ASSY CONTROL DB93-00558A
ASSY 1 - - - - - - -
ASSY CONTROL DB93-00559A ASSY - 1 - - - - - -ASSY CONTROL
DB93-00674H ASSY - - 1 - - - - -ASSY CONTROL DB93-00571A ASSY - - -
1 - - - -ASSY CONTROL DB93-00587A ASSY - - - - 1 - - -ASSY CONTROL
DB93-00674F ASSY - - - - - 1 - -ASSY CONTROL(VIETNAM) DB93-00674M
ASSY - - - - - 1 - -ASSY CONTROL DB93-00577A ASSY - - - - - - 1
-ASSY CONTROL DB93-00674L ASSY - - - - - - - 1
26 ASSY REMOCON DB93-00284K ASSY 1 1 - 1 1 1 1 1ASSY REMOCON
DB93-00284M ASSY - - 1 - - - - -
2-DB68-02477A(1) 7/2/01 10:07 AM Page 5-12
-
Samsung Electronics 6-6
6-3 Main unit (Type C)
4
1
3
6
5338
9
10
11
15
16
17 24
19 2
021
18
22 23
13
2
14
12
1-
4
1-
2
1-
3
1-
1
32
31
31-
6
31-
12
31-
11
31-
8
31-
7
31-
9
31-
131
-2
31-
4
25
31-
5
31-
10
9-1
14-
1
31-
14
31-
13
34
2-DB68-02477A(1) 7/2/01 10:07 AM Page 5-13
-
6-7 Samsung Electronics
Part List (Type C)
No DescripitionCode No. SpecificationQty
AW1290A AW14FAMBA AW18FAMBA AW18FAMBB AW18FAMCA AW18FAMEA
AW18FBMEA AWT18FAMDA AW24FAMBA AW24FAMBB AW24FAMCA WT24FAMEA
1 DB92-70101F ASSY PANEL-FRONT ASSY 1 - - - - - - - - - - -
DB92-00067A ASSY PANEL-FRONT ASSY - 1 1 1 1 1 1 1 1 1 1 1
DB92-00067B ASSY PANEL-FRONT(TAIWAN) ASSY - - 1 - - - - - - - -
-
1-1 DB64-10163A GRILLE-AIR INLET HIPS,T2.5 1 - - - - - - - - - -
-
DB64-00178A GRILLE-AIR INLET HIPS,M-P/J - 1 1 1 1 1 1 1 1 1 1
1
DB64-00178B GRILLE-AIR INLET(TAIWAN) HIPS,W9391 - - 1 - - - - -
- - - -
1-2 DB63-30167C GUARD AIR-FILTER ABS,T2,SC-94445R,- 1 - - - - -
- - - - - -
DB63-00100C GUARD AIR-FILTER ZENO BLUE,GREEN - 1 1 1 1 1 1 1 1 1
1 1
1-3 DB66-30205A BLADE-H PP 1 - - - - - - - - - - -
DB66-00120A BLADE-H C-PP,M-P/J - 1 1 1 1 1 1 1 1 1 1 1
DB66-00120B BLADE-H(TAIWAN) PP,W9391(WHT) - - 1 - - - - - - - -
-
1-4 DB64-70102A PANEL-FRONT HIPS,T2.5 1 - - - - - - - - - -
-
DB64-00177A PANEL-FRONT HIPS,M-P/J - 1 1 1 1 1 1 1 1 1 1 1
DB64-00177B PANEL-FRONT(TAIWAN) HIPS,W9391(WHT) - - 1 - - - - -
- - - -
2 DB90-00304A ASSY BASE M-P/J,44B FRAME 1 - - - - - - - - - -
-
DB90-00304G ASSY BASE M-P/J,44B DRAIN - 1 - - - - - - - - -
-
DB90-00304E ASSY BASE M-P/J,48B DRAIN - - 1 1 1 1 1 1 - 1 -
-
DB90-00304F ASSY BASE M-P/J,48/55DW DRAIN - - - - - - - - 1 - 1
-
DB90-20215A ASSY BASE - - - - - - - - - - - 1
3 DB63-40019A TRAY-DRAIN 30FOAM-PS 1 1 1 1 1 1 1 1 1 1 1 1
4 DB96-00654A ASSY EVAP M-P/J,2R*15S 1 1 - - - - - - - - - -
DB96-00254A ASSY EVAP M-P/J,3R*15S - - 1 1 1 1 1 - - - - -
DB96-40207B ASSY EVAP M-P/J,3R*15S - - - - - - - 1 - 1 - -
DB96-00253A ASSY EVAP M-P/J,4R*15S - - - - - - - - 1 - 1 -
DB96-40207A ASSY EVAP 1.7WAVE - - - - - - - - - - - 1
5 DB61-00440A MOUNT MOTOR SGCC-M,T1.2 1 1 1 1 1 1 1 1 1 1 1
1
6 DB31-00075A MOTOR FAN OSME-708SWC,M-P/J 1 - - - - - - - - - -
-
DB31-00075J MOTOR FAN OSME-906SWC,M-P/J - 1 - - - - - - - - -
-
DB31-00075E MOTOR FAN AFS145ZUEA,M-P/J - - 1 1 1 - - - 1 1 1
-
DB31-00075H MOTOR FAN OSME-1404SAC,M-P/J - - - - - 1 1 - - - -
-
DB31-00075F MOTOR FAN OSME-1206SWC,M-P/J - - - - - - - 1 - - -
-
DB31-00085A MOTOR FAN OSME-1256SWC,M-P/J - - - - - - - - - - -
1
8 DB96-00026A EVAP-PLATE CASING ASSY 1 1 1 1 1 1 1 1 - - - 1
DB96-00026B EVAP-PLATE CASING ASSY - - - - - - - - 1 1 1 -
9 DB67-00096A BLOWER ABS+G/F20%,M-P/J 1 1 1 1 1 1 1 1 1 1 1
1
9-1 DB60-30002A NUT-WASHER M6 1 1 1 1 1 1 1 1 1 1 1 1
10 DB61-00609A CASE EVAP 30FOAM-PS,WHT 1 1 - - - 1 1 1 - - -
-
DB61-10182A CASE EVAP 30FOAM-PS - - 1 1 1 - - - 1 1 1 1
11 DB63-10487A COVER-EVAP PP,T2.5 1 1 1 1 1 1 1 1 1 1 1 1
12 DB70-10679A PLATE-PARTITION SGCC-M,T0.8 1 1 1 1 1 1 1 1 1 1 1
1
13 DB61-00448A CASE COND PP(TALC),T2.5,BLK 1 1 1 1 1 1 1 1 1 1 1
-
DB61-10183A CASE COND PP,T2 - - - - - - - - - - - 1
14 DB67-00047A FAN-PROPELLER ABS,M-P/J 1 1 1 1 1 1 1 1 1 1 1
-
DB67-50028A FAN-PROPELLER ABS+GLASS-FIBER - - - - - - - - - - -
1
14-1 DB60-30004A NUT-WASHER M6,SM20C 1 1 1 1 1 1 1 1 1 1 1 1
15 DB96-00664A ASSY COND M-P/J,2R*19S*560 1 1 - - - - - - - - -
-
DB96-00328B ASSY COND 1.7 D,HEX,SF - - 1 1 1 - - - 1 1 1 -
DB96-00328A ASSY COND ASSY - - - - - 1 1 - - - - -
DB96-00092A ASSY COND 4X16,WAVE2.0 - - - - - - - 1 - - - -
DB96-00328B ASSY COND 1.7,D,HEX,SF - - - - - - - - 1 1 1 -
DB96-30358A ASSY COND 1.7WAVE - - - - - - - - - - - 1
16 DB62-00566A TUBE CAPILLARY 2.75 1 - - - - - - - - - - -
DB62-00596A TUBE CAPILLARY AW14FAMBA,-,-,- - 1 - - - - - - - - -
-
DB62-00519A TUBE CAPILLARY 2.75 - - 1 - 1 1 1 - - 1 - -
DB62-00588A TUBE CAPILLARY 2.75,22K - - - 1 - - - - - - - -
DB96-00283A TUBE CAPILLARY 1.2X1000X3 - - - - - - - 1 - - -
-
DB62-00516A TUBE CAPILLARY 2.75,24K - - - - - - - - 1 - 1 -
DB62-31988A TUBE CAPILLARY C1220T-H,1.3 - - - - - - - - - - -
1
17 DB62-00563A TUBE SUCTION 12K 1 1 - - - - - - - - - -
DB62-00518A TUBE SUCTION 18K - - 1 1 1 1 1 - - - - -
DB62-00518C TUBE SUCTION OD12.7,24K - - - - - - - 1 - 1 - -
DB62-00515A TUBE SUCTION 24K - - - - - - - - 1 - 1 -
DB62-31987B TUBE SUCTION C1220T-O,T0.8 - - - - - - - - - - -
1
18 DB62-00534B TUBE DISCHARGE OD9.52 1 1 - - - - - - - - - -
DB62-00457B TUBE DISCHARGE OD9.52 - - 1 1 1 - - 1 - 1 - -
DB62-00067C TUBE DISCHARGE C1220T-0,OD9.52,T0.7 - - - - - 1 1 -
- - - -
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-14
-
Samsung Electronics 6-8
Part List (Type C)
No DescripitionCode No. SpecificationQty
AW1290A AW14FAMBA AW18FAMBA AW18FAMBB AW18FAMCA AW18FAMEA
AW18FBMEA AWT18FAMDA AW24FAMBA AW24FAMBB AW24FAMCA WT24FAMEA
DB62-00514A TUBE DISCHARGE 9.52,24K - - - - - - - - 1 - 1 -
DB62-00025A TUBE DISCHARGE 24K - - - - - - - - - - - 1
19 DB60-30018A NUT-FLANGE PI0.8,M5,SM20C 1 1 1 1 1 1 1 1 1 1 1
-
20 DB63-10026A COVER-TERMINAL NORYL 1 1 1 1 1 1 1 1 - 1 - -
DB63-00038A COVER-TERMINAL NORYL,T2,BLK - - - - - - - - 1 - 1
-
21 DB47-20001U OLP MRA98693-12007 1 - - - - - - - - - - -
DB35-00015H OLP RAC12074-9622 - 1 - - - - - - - - - -
DB35-00004W OLP MRA12107-12007 - - 1 - 1 - - - - - - -
DB35-00015E OLP RAC12016-9622 - - - 1 - - - - - - - -
DB47-20001P OLP MRA12016-12007 - - - - - 1 1 - - - - -
DB35-00004X OLP MRA12108-12007 - - - - - - - 1 - - - -
DB47-20002Z OLP MRA12 - - - - - - - - - 1 - -
22 DB60-30028A NUT-WASHER HEX,2C,M8,ZPC,-,- 1 1 1 1 1 1 1 1 1 1
1 1
23 DB73-00070A GROMMET ISOLATOR NR 35 1 1 - - - - - - - - -
-DB73-00067A GROMMET ISOLATOR NR - - 1 1 1 1 1 1 - 1 - -
DB73-00041A GROMMET ISOLATOR EPDM,DAEWOO - - - - - - - - 1 - 1
-
24 44B124HU1EL COMPRESSOR 115V,60Hz 1 - - - - - - - - - - -
44B135IU1EL COMPRESSOR 208-230V,60HZ - 1 - - - - - - - - - -
48B175IV1EH COMPRESSOR 208-230V,60Hz - - 1 - 1 - - - - - - -
48B190IV1EH COMPRESSOR 208-230V,60Hz - - - 1 - - - - - - - -
48B180JV1EH COMPRESSOR 50Hz,220-240V - - - - - 1 1 - - - - -
48B180MT1EH COMPRESSOR 200-220V,50HZ - - - - - - - 1 - - - -
DB95-00113C COMPRESSOR EDB260211A,230V,60Hz - - - - - - - - 1 -
1 -
48B220IV1EH COMPRESSOR 60Hz,208-230V - - - - - - - - - 1 - -
DB95-10351B COMPRESSOR AWG5532EXC - - - - - - - - - - - 1
25 DB64-00138J CABINET SGCC-M,SC-94445T 1 - - - - - - - - - -
-
DB64-00138A CABINET SECC-P,SC-94445T - 1 1 1 1 1 1 1 1 1 1 1
31 DB93-00484P ASSY CONTROL-E ASSY 1 - - - - - - - - - - -
DB93-00484W ASSY CONTROL-E ASSY - 1 - - - - - - - - - -
DB93-00484H ASSY CONTROL-E ASSY - - 1 - 1 - - - - - - -
DB93-00484X ASSY CONTROL-E(TAIWAN) ASSY - - 1 - - - - - - - -
-
DB93-00484L ASSY CONTROL-E ASSY - - - 1 - - - - - 1 - -
DB93-00484N ASSY CONTROL-E ASSY - - - - - 1 - - - - - -
DB93-00774B ASSY CONTROL-E ASSY - - - - - - 1 - - - - -
DB93-00484M ASSY CONTROL-E ASSY - - - - - - - 1 - - - -
DB93-00774G ASSY CONTROL-E(VIETNAM) ASSY - - - - - - - 1 - - -
-
DB93-00484K ASSY CONTROL-E ASSY - - - - - - - - 1 - 1 -
DB93-00717A ASSY CONTROL-E ASSY - - - - - - - - - - - 1
32 DB66-70024A LEVER-DAMPER HIPS,T2.5 1 1 1 1 1 1 1 1 1 1 1
1
DB66-70024C LEVER-DAMPER(TAIWAN) HIPS,T2.5,W9391 - - 1 - - - - -
- - - -
33 DB61-60125A FRAME-BLADE HIPS,T2.5 1 1 1 1 1 1 1 1 1 1 1 1
34 DB93-00284K ASSY REMOCON W-RAC,ARC-709 1 - 1 1 1 1 1 1 1 1 1
1
DB93-00284M ASSY REMOCON W-RAC,ARC-710 - 1 - - - - - - - - -
-
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-15
-
6-9 Samsung Electronics
6-3 Assy Control
7
6
5
4
3
13
10
914
8
2
12
111
Part List (Type A)
No DescripitionCode No. SpecificationQty
AW0690A AW0790A AW07FASAA AW07FASAA(TAIWAN)
AW07FASBA(TAIWAN)
AW07FASEA AW0890A AW09FASBA AW09FASEA AW09FBSEA
1 DB61-00417A CASE CONTROL-LOW SGCC-M,T0.8 1 1 1 1 1 1 1 1 1 12
DB61-00419A CASE CONTROL-UP SM(E) SGCC-M,T0.8 1 1 1 1 1 1 1 1 1 13
2501-001227 C-OIL 30uF,400V 1 - - - - - - - - -
2501-001226 C-OIL 25uF,400V - 1 - 1 1 1 - - - -2501-001216 C-OIL
35/5uF,370V - - 1 - - - - - - -2501-001228 C-OIL 35uF,400V - - - -
- - 1 - - -2501-001225 C-OIL 20uF,400V - - - - - - - 1 -
-2501-001236 C-OIL 30uF,450V - - - - - - - - 1 1
4 DB65-10008B CLIP-CAPACITOR SGCC-M,T0.8 1 1 1 1 1 1 1 1 1 15
2301-001450 C-FILM,MPE-PPF 4500nF,440V 1 - - - - - - - - -
2301-001449 C-FILM,MPE-PPF 6000nF,440V - 1 - - - - 1 - -
-2301-001367 C-FILM,MPE-PPF 6000nF,450V - - - 1 - - - - -
-2301-001370 C-FILM,MPE-PPF 2500nF,450V - - - - - 1 - - -
-2301-001369 C-FILM,MPE-PPF 3000nF,450V - - - - 1 - - 1 1 1
6 DB26-00006B TRANS-POWER AC115V,50Hz/60Hz,DC17V 1 1 1 1 - - 1 -
- -DB26-00006A TRANS-POWER AC230V,50Hz/60Hz,DC17V - - - - 1 1 - 1 1
1
7 DB31-00084A MOTOR-SYNCHRONOUS M2CK59ZT79-H 1 1 1 1 - - 1 - -
-DB31-00084B MOTOR-SYNCHRONOUS M2LJ49ZV32 - - - - 1 1 - 1 1 1
8 DB93-00407A ASSY PCB MAIN ASSY 1 1 - - - - 1 - - -DB93-00407B
ASSY PCB MAIN ASSY - - 1 1 1 1 - 1 1 -DB93-00407D ASSY PCB MAIN
ASSY - - - - - - - - - 1
9 DB64-00259A PANEL CONTROL-S(E) HIPS,T2.0 1 1 1 1 1 1 1 1 1 110
DB34-00013B SWITCH MEMBRANE 99*134.5,PC 1 1 1 - - 1 1 1 1 1
DB34-00015B SWITCH MEMBRANE(TAIWAN) 99.1*134.5,PET - - - 1 1 - -
- - -11 DB32-10051A THERMISTOR 10K/25,3425K 1 1 1 1 1 1 1 1 1 112
DB39-00343A POWER CORD-ASS'Y 125V,13A,TANDEM 1 1 1 1 - - 1 - -
-
DB39-00342A POWER CORD-ASS'Y(TAIWAN) 250V,16A,TANDEM - - - - 1 -
- - - -DB39-00348A POWER CORD-ASS'Y HONG KONG,250V,15A - - - - - 1
- - 1 1DB39-00344A POWER CORD-ASS'Y 250V,13A,TANDEM - - - - - - - 1
- -
13 DB66-70031A ARM-BLADE PS 1 1 1 1 1 1 1 1 1 114 DB64-00321A
WINDOW REMOCON 1 1 1 1 1 1 1 1 1 1
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-16
-
Samsung Electronics 6-10
Part List (Type B)
No DescripitionCode No. SpecificationQty
AW1090A AW10FAJAA AW10FAJBA AW12FAJAA AW12FAJBA AW12FAJDA
AW12FAJEA AW12FBJEA
1 DB34-00013B SWITCH MEMBRANE 99x134,PC 1 1 - 1 1 1 1
1DB34-00015B SWITCH MEMBRANE 99.1x134.5,PET - - 1 - - - - -
2 DB64-00259A PANEL CONTROL-S(E) HIPS,T2.0 1 1 1 1 1 1 1 13
DB93-00407A ASSY PCB MAIN ASSY 1 - - - - - - -
DB93-00407B ASSY PCB MAIN ASSY - 1 1 1 1 1 1 -DB93-00407D ASSY
PCB MAIN ASSY - - - - - - - 1
4 DB61-00421A CASE CONTROL-UP J(E) SGCC-M,T0.8 1 1 1 1 1 1 1 15
DB31-00084A MOTOR-SYNCHRONOUS M2LJ49ZV32 1 1 - 1 - - - -
DB31-00084B MOTOR-SYNCHRONOUS M2LJ49ZV32 - - 1 - 1 1 1 16
2501-001229 C-OIL 40uF,400V 1 1 - - - - - -
2501-001234 C-OIL 20uF,450V - - 1 - - - - -2501-001230 C-OIL
45uF,400V - - - 1 - - - -2501-001236 C-OIL 30uF,450V - - - - 1 1 1
1
7 DB65-10008B CLIP-CAPACITOR SGCC-M,T0.8 1 1 1 1 1 1 1 18
DB66-70022D ARM-BLADE PS,SC-96527R 1 1 1 1 1 1 1 19 DB39-00343B
POWER CORD-ASS'Y 125V,15A,PARALLEL 1 1 - 1 - - - -
DB39-00342A POWER CORD-ASS'Y 250V,16A,TANDEM - - 1 - - - -
-DB39-00344A POWER CORD-ASS'Y 250V,13A,TANDEM - - - - 1 - -
-DB39-10089Q POWER CORD-ASS'Y 250V,15A - - - - - 1 - -DB39-00348A
POWER CORD-ASS'Y 250V,15A - - - - - 1(VIETNAM) 1 1
10 2301-001448 C-FILM,MPE-PPF 8000nF,440V 1 - - - - - -
-2301-001381 C-FILM,MPE-PPF 8000nF,450V - 1 - - - - - -2301-001370
C-FILM,MPE-PPF 2500nF,450V - - 1 - - - - -2301-001452
C-FILM,MPE-PPF 15000nF,250V - - - 1 - - - -2301-001378
C-FILM,MPE-PPF 3500nF,450V - - - - 1 - 1 12301-001379
C-FILM,MPE-PPF 4000nF,450V - - - - - 1 - -
11 DB26-00006B TRANS-POWER AC115V,50Hz/60Hz 1 1 - 1 - - -
-DB26-00006A TRANS-POWER AC230V,50Hz/60Hz - - 1 - 1 1 1 1
12 DB61-00417A CASE CONTROL-LOW SGCC-M,T0.8 1 1 1 1 1 1 1 113
DB32-10051A THERMISTOR 10K/25,-,3425K 1 1 1 1 1 1 1 114 DB64-00321A
WINDOW REMOCON 1 1 1 1 1 1 1 1
5
11
10
7
6
8
1
2
3
4
9
14
1312
Exploded View and Parts List
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-17
-
6-11 Samsung Electronics
6
127
8
11
9
1
215
4
5
10
1413
Exploded View and Parts List
Part List (Type C)
No DescripitionCode No. SpecificationQty
AW1290A AW14FAMBA AW18FAMBA AW18FAMBB AW18FAMCA AW18FAMEA
AW18FBMEA AWT18FAMDA AW24FAMBA AW24FAMBB AW24FAMCA AWT24FAMEA
1 DB34-00013A SWITCH MEMBRANE 99*144.2,PC 1 1 1 1 1 1 1 1 1 1 1
1DB34-00015A SWITCH MEMBRANE(TAIWAN) 99.1*144.2,PET - - 1 - - - - -
- - - -
2 DB64-00261A PANEL CONTROL-M(E) HIPS,T2 1 1 1 1 1 1 1 1 1 1 1
14 DB93-00407A ASSY PCB MAIN ASSY 1 - - - - - - - - - - -
DB93-00407B ASSY PCB MAIN ASSY - 1 1 1 1 1 - 1 1 1 1
1DB93-00407D ASSY PCB MAIN ASSY - - - - - - 1 - - - - -
5 DB61-00419A CASE CONTROL-UP SM(E) SGCC-M,T0.7 1 1 1 1 1 1 1 1
1 1 1 16 DB31-10152A ASSY-MOTOR SWING M2CK59ZT19-H 1 - - - - - - -
- - - -
DB95-20065F ASSY-MOTOR SWING M2LJ49ZU3 - 1 1 1 1 1 1 1 1 1 1 17
2301-001448 C-FILM,MPE-PPF 8000nF,440V 1 - - - - - - - - - - -
2301-001367 C-FILM,MPE-PPF 6000nF,450V - 1 1 1 1 1 1 1 1 1 1 18
DB65-10008B CLIP-CAPACITOR SGCC-M,T0.8 1 1 1 1 1 1 1 1 1 1 1 19
DB66-00186A ARM-BLADE POM,BLK 1 1 1 1 1 1 1 1 1 1 1 110 DB39-00343B
POWER CORD-ASS'Y 125V,15A,PARALLEL 1 - - - - - - - - - - -
DB39-00342A POWER CORD-ASS'Y 250V,16A,TANDEM - 1 1(TAIWAN) - - -
- - - - - -DB39-00344A POWER CORD-ASS'Y 250V,13A,TANDEM - - 1 - 1 -
- - - - - -DB39-00345A POWER CORD-ASS'Y 250V,15A,TANDEM - - - 1 - -
- - - 1 - -DB39-00348B POWER CORD-ASS'Y HONG KONG,250V,15A - - - -
- 1 1 1(VIETNAM) - - - -DB39-10089R POWER CORD-ASS'Y 250V,15A - - -
- - - - 1 - - - -DB39-00200B POWER CORD-ASS'Y SPT,250V,20A - - - -
- - - - 1 - 1 -DB39-10001K POWER CORD-ASS'Y 240V,60HZ,20A - - - - -
- - - - - - 1
11 2501-001230 C-OIL 45uF,400V,BK 1 - - - - - - - - - -
12501-001236 C-OIL 30uF,450V - 1 - - - - - - 1 - 1 -2501-001237
C-OIL 35uF,450V - - 1 - 1 - - - - - - -2501-001238 C-OIL 40uF,450V
- - - 1 - 1 1 - - 1 - -2501-001239 C-OIL 45uF,450V - - - - - - - 1
- - - -
12 DB26-00006B TRANS-POWER AC115V,50Hz/60Hz 1 - - - - - - - - -
- -DB26-00006A TRANS-POWER AC230V,50Hz/60Hz - 1 1 1 1 1 1 1 1 1 1
1
13 DB61-00417A CASE CONTROL-LOW SGCC-M 1 1 1 1 1 1 1 1 1 1 1 114
DB32-10051A THERMISTOR 10K/25,3425K 1 1 1 1 1 1 1 1 1 1 1 115
DB64-00321A WINDOW REMOCON 1 1 1 1 1 1 1 1 1 1 1 1
2-DB68-02477A(1) 6/28/01 11:35 AM Page 5-18
-
7. Block Diagram
7-1 Refrigerating Cycle Block Diagram
PINCH PIPE(SERVICE VALVE) SUCTION LINE
ACCUMULATOR/COMPRESSOR
EVAPORATOR
CAPILLARY TUBE
CONDENSER
DISCHARGE LINE
PINCH PIPE(SERVICE VALVE)
7-2 Basic Structure
7-2-1 Micom Control Diagram
A/D converter
Swing motor control
Compressor control
Buzzer control
Temperature control
Fan motor control
Reset Circuit
Led display control
Remocon SingleReceiving
Compressor
Fan motor
Power circuit (DC 5V)
Oscillation Circuit
Membrane Pad control
Energe saver Temp.set(, ) Operation, Mode Swing, Sleep Fan
select, Timer
Remocon single control
MAIN MICOM
Room Temperature sensor
Receiving Unit of Remocon
EEPROM
Swing motor
Powercircuit (DC 12V)
Down Trans (AC15V)
Power input (AC230V), (AC115V)
(Key operation)
(Remocon control)
Samsung Electronics 7-1
Operation
Swing
Timer
Sleep
Fan speed (high)
Fan speed (med)
Fan speed (low)
Fan
Cool
Energy saver
Temp.setting()
Temp.setting()
(Remote Control)
2-DB68-02477A(1) 6/28/01 11:35 AM Page 7-1
-
7-2 Samsung Electronics
7-2-2 Micom Pin Assignment
KS88C4716
GRID5
SEG-DATA(d)
SEG-DATA(e)
SEG-DATA(f)
SEG-DATA(g)
SEG-DATA(h)
SEG-DATA(a)
EEPROM CLK
EEPROM IN
EEPROM OUT
BUZZER
AUTO RESTART OPTION
JIG OUTPUT
OPTION
SENSOR THERMISTOR(103AT)
OPTION (HEAT PUMP)
OPTION (HEAT PUMP)
OPTION (HEAT PUMP)
OPTION (HEAT PUMP)
ENERGY SAVER OPTION
SWING MOTOR
GND
SEG-DATA(c)
SEG-DATA(b)
GRID4
GRID3
Vcc
Vss
10MHz RESONATOR
10MHz RESONATOR
TEST
GRID2
GRDI1
RESET
KEY-IN1
KEY-IN2
REMOCON SINGLE RECEIVE
EEPROM CS
LOW FAN
COMPERSSOR
MED FAN
HIGH FAN
OPTION (HEAT PUMP)
Vcc
1 P0.1 P4.4 44
2 P0.0 P0.2 43
3 P4.3 P0.3 42
4 P4.2 P0.4 41
5 VDD P0.5 40
6 VSS P0.6 39
7 Xout P0.7 38
8 Xin P1.0 37
9 TEST P1.1 36
10 P4.1 P1.2 35
11 P4.0 P1.3 34
12 RESET P1.4 33
13 P2.0 P1.5 32
14 P2.1 P3.7 31
15 P2.2 P3.6 30
16 P2.3 P3.5 29
17 P2.4 P3.4 28
18 P2.5 P3.3 27
19 P2.6 P3.2 26
20 P2.7 P3.1 25
21 P4.5 P3.0 24
22 AVref AVss 23
2-DB68-02477A(1) 6/28/01 11:35 AM Page 7-2
-
8. PCB Diagram
Samsung Electronics 8-1
8-1 ASSY Main PCB (Code No ; DB93-00407A, B, D)
DB93-00407A( I ) DB93-00407B( II ) DB93-00407D(III)
2-DB68-02477A(1) 6/28/01 11:35 AM Page 8-1
-
8-2 Samsung Electronics
Part List
NO. CODE-NO DESCRIPTION SPECIFICATION 1 2 3 REMAKRS
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
-
1405-000147
DE13-20017A
DE13-20009A
DE13-20016A
DE13-20008A
DE60-10100A
DE62-30031A
-
-
-
-
-
-
3711-003407
-
-
DE32-10037A
-
DE30-20016A
2001-001172
-
-
-
-
-
-
-
-
-
2004-001137
2004-000218
-
-
-
-
-
-
-
-
-
DB09-00091A
3501-001058
2802-000103
DB07-00010A
3501-000399
-
-
DIODE-RECTIFIER
VARISTOR
IC-DRIVE
IC
IC-VOLT REGU
IC-VOLT REGU
SCREW TAPPING
HEAT SINK
C-AL
C-AL
C-AL
C-AL
CONNECTOR WAFER
CONNECTOR WAFER
CONNECTOR WAFER
CONNECTOR WAFER
CONNECTOR WAFER
FUSE
FUSE HOLDER
BUZZER
R-CARBON
REMOCON MODULE
CONNECTOR WAFER
JUMPER WIRE
JUMPER WIRE
JUMPER WIRE
PCB-MAIN
R-CARBON
R-CARBON(2012)
R-CARBON(2012)
R-CARBON
R-CARBON
R-CARBON(2012)
R-CARBON(2012)
C-CERAMIC(2012)
C-CERAMIC(2012)
C-CERAMIC(2012)
C-CERAMIC(2012)
TRANSISTOR
TRANSISTOR
DIODE-SWITCHING(SMALL)
IC-MCU
RELAY-POWER
CERAMIC RESONATOR
LED DISPLAY
RELAY
R-CARBON
IC-MASK ROM
1T4
470V 4500A
KID65003AP
KA7533Z
KA7805A
KA7812A
PH-3 L6
A6063 L23.5 W30
2200F 25V
1000F 35V
100F 10V
22F 16V
YW396-03AV YEL
YW396-03AV WHT
YW396-05AV WHT
JSW250-02 RED
JSW250-03 RED
250V 3.15A
FB 58 20MM
CSB2220BA
620 OHM 1/2W
KSM713TE5
FCZ254-08S
PI0.6 52MM
PI0.6 52MM
3216 TYPE
FR-1 81.5*134.5
RD 1/4W 180-J
MCR10 330-J
MCR10 10K-J
RD 1/8W 6.8K-F
RD 1/8W 10K-F
MCR10 1K-J
MCR 100K-J
MCR21 2F 104Z
MCR21 2F 223Z
MCR21 2F 101Z
MCR21 2F 102Z
KRA226S
KRC246S
1N4148
KS88C4716
ID 1U
10MHz
ELF-316GWB
JQ1A 12V
MCR10 4.7K-J
P93LC56B
4
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
24
1
7
1
8
5
9
1
2
1
1
9
4
1
3
5
1
5
1
1
1
1
4
1
0
4
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
24
1
7
1
8
5
10
1
2
2
1
9
4
1
3
5
1
5
1
1
1
1
4
0
0
4
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
24
0
7
1
8
5
10
1
2
1
1
9
4
1
3
5
1
5
1
1
1
1
4
0
1
D101~D104
VA71
IC03, IC07
IC05
IC02
IC01
C102
C101
C103
C104
CN11
CN71
CN73
CN41
CN12
F701
F701
BZ61
R601
RM41
CN91
J1~J13, J15~J24, J32
OP01
J25~J31
R903~R910
R404~R406, R415, R902
R301, R407, R408, R410~R414, R501, R901(R411)
R403
R401, R402
R201, R202
R409
C105, C106, C401~C406, C410
C501, C502, C601, C901
C407
C408, C409, C902
Q901~Q905
Q906
D901~D905
IC04
RY71
X501
RY72, 73, 75, 76
R411
IC06
2-DB68-02477A(1) 6/28/01 11:35 AM Page 8-2
-
Samsung Electronics 9-1
9-1 AW0690A/AW0790A/AW07FASA/AW0890A/AW09FSA/AW1090A/AW10FAJA9-1
AW12FJA/AW1290/AW14FAMBA/AW18FAMA/AWT18FAMDA/AW24FAMBB
DIAGRAM - ELECTRIC DB68-02015A
9. Wiring Diagram
CN73
2-DB68-02477A(1) 6/28/01 11:35 AM Page 9-1
-
9-2 Samsung Electronics
9-2 AW24FAMBA/AW24FAMCA/AWT24FAMEA
DIAGRAM - ELECTRIC DB68-02053A
CN73
2-DB68-02477A(1) 6/28/01 11:35 AM Page 9-2
-
10. Schematic Diagrams
10-1 Main PCB
(AW0690A/AW0790A/AW07FASA/AW0890A/AW09FASA/AW1090A/AW10FAJA/AW12FAJA/AW1290A/AW14FAMBA/AW(T)18FAMA/AW(T)24FAMA)
Samsung Electronics 10-1
No. RESISTOR VALUE UNIT OF TEMP. OPTION
R41110K-J C
4.7K-J F
OPTION
-
10-2 Main PCB (AW09FBSEA/AW12FBJEA/AW18FBMEA)
10-2 Samsung Electronics
No. RESISTOR VALUE UNIT OF TEMP. OPTION
R41110K-J C
4.7K-J F
OPTION
-
Samsung Electronics 10-3
10-3 Remote Control
(KEY NAME)K29 : SAVEK37 : TIMERK39 : SLEEPK41 : AIR SWINGK49 :
TEMP. ()K50 : TEMP. ()K53 : LOW FANK54 : MED FANK55 : HIGH FANK57 :
FANK60 : COOLK63 : ON/OFF
2-DB68-02477A(1) 6/28/01 11:35 AM Page 9-3