K. Adrjanowicz K. Adrjanowicz , Z. Wojnarowska, P. Wlodarczyk, , Z. Wojnarowska, P. Wlodarczyk, K. Grzybowska, K. Kaminski, M. Paluch K. Grzybowska, K. Kaminski, M. Paluch Institute of Physics, University Institute of Physics, University of Silelesia of Silelesia , Katowice, , Katowice, Poland Poland
16
Embed
K. Adrjanowicz , Z. Wojnarowska, P. Wlodarczyk, K. Grzybowska, K. Kaminski, M. Paluch
Molecular dynamics in pharmaceutically important hydrochloride salts studied by Dielectric Spectroscopy. K. Adrjanowicz , Z. Wojnarowska, P. Wlodarczyk, K. Grzybowska, K. Kaminski, M. Paluch Institute of Physics, University of Silelesia , Katowice, Poland. - PowerPoint PPT Presentation
Welcome message from author
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
K. AdrjanowiczK. Adrjanowicz, Z. Wojnarowska, P. Wlodarczyk,, Z. Wojnarowska, P. Wlodarczyk, K. Grzybowska, K. Kaminski, M. Paluch K. Grzybowska, K. Kaminski, M. Paluch Institute of Physics, UniversityInstitute of Physics, University of Silelesia of Silelesia, Katowice, Poland, Katowice, Poland
H3CO
OH
NCH3
CH3
HCl
Tramadol Tramadol hydrochloride
Verapamil hydrochlorideCrystalline VH is soluble in water (i.e. 82 mg/mL at pH 2.32, 0.44 mg/mL at pH=7.32). More than 90% of the oral administer dose is absorbed from the gastrointestinal track, where pH is roughly 2-4. However only 10-20% out of these 90% absorbed from the digestive track get into circulatory system (pH blood about 7.34 – 7.43).
for werapamil hydrochloride calculated from the CM
verpamil hydrochloride
KWW=0.61
M"
Freq.[Hz]
tramadol hydrochloride
KWW=0.65
tramadol hydrochlorideJGprocess
We link an opposite trend to crystallization of both pharmaceuticals with different local molecular mobility.
The ability of amorphous pharmaceuticals to crystallization might be correlate to the asymmetric distribution of structural relaxation time, described by the KWW parameter - Shamblin S.L., Hancock B.C., Dupuis Y., Pikal M.J., J.Pharm.Sci., 89, 417-427 (1999)
It was affirmed that amorphous tramadol hydrochloride compacted better than crystalline. Amorphous tramadol hydrochloride requires about 30% less pressure force than the drug in crystalline state to obtain tablets with similar physical parameters
No significant differences between amorphous and crystalline tramadol hydrochloride in intrinsic dissolution test rate were observed
Cooperation:Department of Pharmaceutical Technology, Medical University of Gdansk, Hallera 107, 80-416, Gdansk, PolandW. Sawicki , P. Lepek , R. Lunio, J. Mazgalski
Solubility
(mg/ml)
water phosphate buffer 6,8 0,1N HCl
cryst. amorph. cryst. amorph. cryst. amorph.
25º C
71.16 ±
3,41
260.92 ±
2,17
106.98 ±
2,48
385.14 ±
2,49
47.68 ±
3,58
228.59 ±
9,55
37º C
529.17 ±
19,09
589.78 ±
11,67
371.89 ±
15,84
411.86 ±
6,89
498.45 ±
18,97
581.18 ±
7,90
Solubility and intrinsic dissolution rate obtained for amorphous verapamil hydrochloride are much better than that derived for crystalline API.
It was found the statistically significant difference between IDR calculated for crystalline and amorphous form. The obtained results amounted to 7,61 and 8,89 mg*min-1*cm-1 for crystalline and amorphous form respectively.
Cooperation:Department of Pharmaceutical Technology, Medical University of Gdansk, Hallera 107, 80-416, Gdansk, PolandW. Sawicki , P. Lepek , R. Lunio, J. Mazgalski
2. Chemical transition of drug from monohydrate into hydrochloride salt results in significant increase of its glass transition. As a consequence it is possible to prepare its oral dosage form completely amorphous in the room temperature and even human body temperature.
1. We showed that dielectric spectroscopy can be satisfactorily used to follow dynamics of hydrochloride salts, despite theirs ionic character. Up to know BDS was used to measure only pure API’s, while in the case of their salts this experimental technique failed because of great contribution of the dc conductivity to the loss spectra.Presentation of the dielectric data in modulus representation enabled us to get valuable information about dynamics of the investigated system
4. Amorphous drugs can be alternative even for the well solved pharmaceuticals
3. Both analyzed by us compounds differ in separation of JG relaxation. Thus, we relate completly opposite trend to crystallization of both pharmaceuticals with different local molecular mobility.
The authors are deeply thankful for the financial support The authors are deeply thankful for the financial support of their research within the framework of the project of their research within the framework of the project entitled /From Study of Molecular Dynamics in entitled /From Study of Molecular Dynamics in Amorphous Medicines at Ambient and Elevated Amorphous Medicines at Ambient and Elevated Pressure to Novel Applications in Pharmacy/, which is Pressure to Novel Applications in Pharmacy/, which is operated within the Foundation for Polish Science Team operated within the Foundation for Polish Science Team Programme co-financed by the EU European Regional Programme co-financed by the EU European Regional Development Fund.Development Fund.