-
(732) 938-2000 / 800-LAB-VOLT, FAX: (732) 774-8573, E-MAIL:
[email protected](418) 849-1000 / 800-LAB-VOLT, FAX: (418) 849-1666,
E-MAIL: [email protected]
INTERNET: http://www.labvolt.com
System shown with optional equipment.
AInstrumentation and Process Control INSTRUMENTATION AND
PROCESS CONTROL TRAINING SYSTEMSERIES 3531
GENERAL DESCRIPTIONThe Lab-Volt Instrumentation and Process
ControlTraining System introduces students to a wide range
ofindustrial processes (temperature, pressure, flow, andlevel) as
well as with their instruments and control. Theuse of modern
equipment coupled with a completetraining program helps students to
get the theoretical andpractical knowledge that is mandatory to
work in theprocess control industry.
The modularity of this energy-efficient system allowsthe
instructor to select specific equipment as a functionof the
training objectives without going over budget.Several
configurations are available for a singleworkstation. Adding
optional equipment can increase thenumber of these
configurations.
The Instrumentation and Process Control TrainingSystem features
two workstations: the ProcessWorkstation and the Instrumentation
Workstation. Thesystem can accomodate a single team of students for
thetemperature experiments and up to two teams for thepressure,
flow, and level experiments if the second-teamadd-on is used.
One controller from the 3539 Series is required foreach team
working on the system. A wide choice ofoptional equipment is
available. Refer to the charts belowfor details on the general
structure of the Instrumentationand Process Control Training
System.
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
2
Structure of the Instrumentation and Process Control Training
System
TABLE OF CONTENTSGeneral Description . . . . . . . . . . . . . .
. . . . . . . . . . . 1List of Student Manuals . . . . . . . . . .
. . . . . . . . . . . . 7List of Equipment Pressure/Flow/Level
Basic System 3531-A or -B . . . . . . . . . . . . . . . . . . . . .
. 10List of Equipment Temperature Basic System 3531-0 or -1 . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 16List of
Equipment Controllers . . . . . . . . . . . . . . . 21Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . 22Module
Description . . . . . . . . . . . . . . . . . . . . . . . . .
27Personal Computer Minimum Requirements . . . . . 56
-
3Structure of the Instrumentation and Process Control Training
System
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
4
Process Workstation shown with optional equipment.
Instrumentation Workstation shown with optional equipment.
Process WorkstationThe Process Workstation is the hub of the
differentprocesses to be investigated by the students. It
consistsof a double-sided mobile workstation equipped with
two60-liter (16-gal) tanks, up to four centrifugal pumps,
aRotameter, a Drip Tray (Front), an InstrumentationMounting Pipe,
Ball Valves, and Process Supports.
Up to two groups of students can work at the sametime on
Pressure/Flow/Level experiments, one group oneach side of the
Process Workstation. This can be doneif the Pressure/Flow/Level
option is selected and if theSecond Team Add-on, Model 3530-H or -K
(HART) isordered (3530-J or - L for FOUNDATION Fieldbus).
To configure the system for hands-on training, thestudents have
to install the appropriate instruments asdescribed in the student
manuals. The student manualscover both the theory and practice of
measurement,control, and troubleshooting of temperature,
pressure,flow, and level processes.
The dimensions of the Process Workstation(excluding any device
installed on it) are: 1.73 m x 0.80 mx 1.83 m (5'8'' x 2'8'' x
6'0'').
Instrumentation WorkstationThe Instrumentation Workstation is
designed to house theElectrical Unit and the Pneumatic Unit as well
as otherelectrical equipment such as the variable speed
drives.Devices such as controllers, PLCs, Color PaperlessRecorder,
and Touch Screen Graphic Terminals must be
installed on the Instrumentation Workstation. Theworkstation
aims to recreate the widespread industrialpractice of separating
the process environment from theinstruments and controllers and it
limits the risk ofexposing such equipment to contact with
water.
The Electrical Unit provides power for the instrumentsused on
the Instrumentation and Process Control TrainingSystem. It includes
a lockable power switch and a 24 Vdc power supply. The design of
the Electrical Unit allowscutoff of both the electric and pneumatic
power usingeither an emergency button or the lockable power
switch.The teaching material includes a complete
lockout/tagoutprocedure explaining how to lock the power switch.
Thisprocedure is similar to the procedure used in industry tolock
and unlock electrical equipment.
Like the Process Workstation, the InstrumentationWorkstation is
a double-sided mobile workstation. Twogroups of students can work
at the same time on thesystem, one group on each side.
The Instrumentation Workstation also features aretractable
shelf.
The dimensions of the Instrumentation Workstation(excluding any
device installed on it) are: 0.68 m x 1.18 mx 1.89 m (2'3'' x
3'10'' x 6'2'').
-
5Temperature Process SystemThis system is designed to feature
the equipmentrequired to complete the measurement, control,
andtroubleshooting exercises for temperature processes. Itincludes
a Heating/Cooling Unit, a Brazed Plate HeatExchanger, a three-way
control valve, a thermocouple,an RTD (Resistance Temperature
Detector), and atemperature transmitter. The temperature
transmitter cansupport either the HART or the FOUNDATION
Fieldbuscommunication protocols.
A variety of optional heat exchangers is available foradvanced
training in temperature process control:C a Gasketed Plate Heat
ExchangerC a Shell and Tube Heat Exchanger (1 pass)C a Shell and
Tube Heat Exchanger (4 pass)
Pressure, Flow, and Level Process SystemThis system includes the
equipment required to completethe measurement, control, and
troubleshooting exercisesfor the pressure, flow, and level
processes.
This system features two differential-pressure trans-mitters
supporting the HART communication protocol, adigital pressure
gauge, a pneumatic control valve, a colorpaperless recorder, a
rotameter, and a Venturi tube.Transmitters supporting other
communication protocolssuch as FOUNDATION Fieldbus are available on
request.
A wide variety of optional equipment is available foradvanced
training in pressure, flow, and level processcontrol:C a Column
(Small Diameter)C an Orifice PlateC a Pitot TubeC an
Electromagnetic Flow Transmitter (HART)C a Vortex Flow Transmitter
(HART)C a Coriolis Flow Transmitter (HART)C a Paddle Wheel Flow
TransmitterC an Ultrasonic Level Transmitter (HART)C an Ultrasonic
Flow Transmitter (HART)C a Radar Level Transmitter (HART)C a
Guided-Radar Level Transmitter (HART)C a Vibrating Fork Level
SwitchC a Conductivity Level SwitchC a Capacitive Level Transmitter
(HART)C a Float SwitchC a Pressure Switch (with Analog Output)C a
Pressure Transmitter (HART)
Most models are also available in a FOUNDATIONFieldbus-compliant
version. Consult the descriptions fordetails.
Optional ValvesLab-Volt offers a selection of pneumatic control
valves toupgrade your system. The valves come with a
current-to-pressure converter (if required). Among the
valvesavailable are:C Pneumatic Control Valves with different
Digital Posi-
tioners (Three-Way Valve versions also available)C a Pneumatic
Control Valve with Positioner (Three-Way
Valve version also available)C Electric Control Valve (Three-Way
Valve version also
available)C a Vee-Ball Control ValveC a Solenoid ValveC a Ball
Valve
ControllersLab-Volt also offers a wide selection of controllers
suchas:C Industrial PID Controllers (Ethernet or Modbus)C
Programmable Logic Controllers (with Ethernet
communications, Analog I/O, programming software,and
Communication Cable)
SCADA / DCS SoftwareTwo SCADA software programs are available
for thesystem: Wonderware Development Studio (includingInTouch) and
FactoryTalk View Studio (from RockwellSoftware). Both software
programs come with aninterface specially designed for the
Instrumentation andProcess Control Training System. An OPC server
for theFoxboro controller is also available.
Calibration InstrumentationAn accurate calibration device is an
essential addition tothe system. It allows calibration and
maintenance of thetransmitters, current to pressure converter,
gauges, andcontrol valves. Four different calibration packages
areavailable. A basic version makes it possible to performthe
required calibration and a second version includesmore advanced
equipment.
Three other calibration kits are each designed to actas
configurator and sophisticated tools to calibrate thesmart devices
over the HART and/or the FOUNDATIONFieldbus communication
protocols.
Other devicesOther devices are also available to enhance the
system.These devices allow the students to explore moretechnologies
and communication protocols used in theindustry. Among the optional
devices available are:C a Signal TowerC Touch Screen Graphic
Terminal (available in two sizes)C an additional Pumping Unit
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
6
Simulation of boiling water in the Process Column.
Smart devices: HART and FOUNDATIONFieldbusMany components of the
Instrumentation and ProcessControl Training System feature a
transmitter which isable to communicate via one of two
communicationprotocols: HART or FOUNDATION Fieldbus.
The HART protocol enables communication betweendevices by
superimposing digital signals on top of theexisting 4-20 mA
outputs. The Fieldbus protocol is like aLocal Area Network (LAN)
for smart devices.
Most of these devices can usually be configuredmanually via
their alphanumeric display and/or push-buttons, but it is much
quicker and more efficient to usea communication link to configure
them remotely from acomputer. The HART apparatuses can be connected
toa computer using the HART Software Configurator (Model46982-0 or
-B). Fieldbus devices can be configured froma computer with the
FOUNDATION Fieldbus SoftwareConfigurator (Model 46982-A or -B).
Calibration kits areavailable for each of the two communication
protocols.
A Software Configurator compatible with the
selectedcommunication protocol is strongly suggested and is
evenmandatory for some specific transmitters.
TroubleshootingTroubleshooting of industrial process equipment
is anintegral part of the learning process. This is why
theInstrumentation and Process Control Training Systemfeatures many
tools to help instructors devisetroubleshooting exercises for the
students. Faults can beinserted in most devices: Controllers, PLCs,
Valves,Transmitters, etc.Three different methods to insert faults
exist:C Local Fault Insertion is done by accessing the fault
panel on a particular device to activate faults asrequired.
C Remote Calibration Fault is performed by changing
thecalibration parameters of a device from the instructor'scomputer
over either the HART or the Fieldbus commu-nication protocol
(requires the appropriate modules).
C Remote Fault Insertion is done by remotely modifyingthe state
of I/O relays on a controller or a PLC from acomputer or from a
Touch Screen Terminal.
Pressure and Flow Compressed AirAn instrumentation and process
control system forcompressed air is also available as an add-on to
the 3531system. Measurement and control experiments relatedto
pressure and flow of compressed air can be done withthe following
devices:C Air TanksC Air RotameterC Orifice Plate for airC Solenoid
Valve for airC Pneumatic Control Valve for air
Boiler Simulation (Water / Air)The Boiler Simulation system is
an inherently safe boilersimulator which is not pressurized and
works with waterat room temperature. The key features of a
boilingprocess are replicated with a controlled flow of air
injectedat the base of a process column containing a
controllablelevel of water. Up to three elements and three
controlloops (2 PID loops and 1 calibrator) are involved in
thecontrol of the level of water in the drum of the boiler.
The boiling process is recreated by regulating theflow of air
injected in the column while operating a secondpump which drains
the column to simulate evaporationof water. The Boiler Simulation
system is a synthesis ofmany industrial control notions and
involves multiplecontrol loops as well as feedforward and cascade
control.
The Boiler Simulation is an add-on to the Instrumen-tation and
Process Control Training System and mayinclude a pump and a drive
if required. The boiler systemcan only be used by one team at a
time. A controller witha minimum of three inputs and two PID loops
capable ofboth cascade and feedforward control and a 4-20
mAcalibrator are also necessary.
As both cascade and feedforward control schemesare used, the
advanced P/F/L add-on (Model 3530-M0)is required and it is assumed
that the students are familiarwith these topics beforehand.
Advanced Process Control - TemperatureThe inclusion of this
add-on (Model 3531-2 or -3) to theProcess Control Training system
offers the possibility toperform a set of advanced temperature
controlexperiments. The main feature resides in the use of
-
7electromagnetic flowmeters and RTDs coupled to theenergy
manager to obtain precise energy balances.
Advanced Process Control - Pressure/Flow/LevelThe inclusion of
this add-on (Model 3530-M) to theProcess Control Training system
offers the capability toperform a set of advanced process control
experiments.The experiments include feedforward control,
ratiocontrol, split-range control, and the control ofsecond-order
processes. The add-on includes asmall-diameter column, an upper
tank, an orifice plate,a pneumatic control valve, and some
accessories.
Air requirementsThe Instrumentation and Process Control
TrainingSystem requires a reliable source of compressed air
fromeither a central air supply or a portable unit. Your centralair
supply or your portable unit must be able to deliver airat a
minimal flow of 110 l/min (4 CFM) with a pressure of620 kPa (90
PSI).
Compressed air units are available from yourLab-Volt
representative. Model 6410-BX is a portable unitwhich is well
suited to the system.
Optional system add-onsThe Instrumentation and Process Control
TrainingSystem can also be equipped with optional add-ons suchas:C
pH and Conductivity add-ons. To obtain information
on the capabilities and models available, please referto the
companion datasheet for the 3532 system(88164).
LIST OF STUDENT MANUALSCORE MANUALS - TemperatureThe four core
manuals on temperature processes coverthe following topics: Basic
use of the system and itsdevices, introduction to temperature
measurement andinstruments, RTDs and thermocouples, basics
ofthermodynamics and heat transfer mechanisms, heatexchangers,
temperature process control, and energybalances.
Familiarization with the Instrumentation and ProcessControl
Training System - Temperature (86008-E0)C Process WorkstationC
Instrumentation WorkstationC Electrical UnitC AC Drive and PumpsC
Emergency Push-ButtonC Pneumatic UnitC Trend RecorderC
Heating/Cooling UnitC Temperature Probes and TransmitterC Brazed
Plate Heat ExchangerC Three-Way Pneumatic ValveC AccessoriesC Basic
SetupC I.S.A. Standard and Instrument Symbols
Temperature Process Measurement (86009)C Introduction to
MeasurementC Measuring InstrumentsC Temperature Measurement
Definitions of Temperature, Energy, Scales,
andThermodynamics
RTDs and ThermocouplesC Heat Exchanges
Heat Transfer Mechanisms Basic Thermal Energy Transfer Setup
Temperature Process Control (86010)C Dynamic Characteristics of
a ProcessC Feedback Control
Tuning and Control of a Temperature Loop Trial and Error Method
Ultimate Period Method Ziegler-Nichols Method
C Troubleshooting Guided Process Troubleshooting
Heat Exchangers and Advanced TemperatureMeasurement (86011)C
Familiarization with the Energy ManagerC Heat Exchangers
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
8
Brazed Plate Heat Exchanger Gasketed Plate Heat Exchanger -
Optional Shell-and-Tube Heat Exchanger (Single Pass) -
Optional Shell-and-Tube Heat Exchanger (Four Passes) -
Optional
An optional CD-ROM (85980-A0) includes the coretemperature
manuals and many other manuals. See thecomplete content of the CD
in the list of equipment.
CORE MANUALS - Pressure, Flow, and Level
Familiarization with the Instrumentation and ProcessControl
Training System - Pressure, Flow, and Level(86004-E0)C Process
WorkstationC Instrumentation WorkstationC Electrical UnitC AC
DriveC Emergency Push-ButtonC Pneumatic UnitC Trend RecorderC
Process Column, Wet Reference Leg, and BubblerC Digital Pressure
GaugeC Differential-Pressure TransmitterC Three-Valve ManifoldC
Solenoid ValveC Pneumatic Control ValveC Venturi TubeC RotameterC
AccessoriesC Basic SetupC I.S.A. Standard and Instrument
Symbols
Measurement - Pressure, Flow, and Level (86005)C Introduction to
MeasurementC Measuring InstrumentsC Pressure Measurement
Pressure Measurement Pressure Loss
C Flow Measurement Flowmeters Centrifugal Pumps
C Level Measurement Differential-Pressure Level Meters Bubblers
Wet Reference Leg
Process Control - Pressure, Flow, and Level(86006)C Dynamic
characteristics of a processC Process control
Tuning and control of a pressure loop (trial and
errormethod)
Tuning and control of a flow loop (ultimate periodmethod)
Tuning and control of a level loop (Ziegler-Nicholsmethod)
Cascade control, level-flowC Troubleshooting
Guided Process Troubleshooting (Typical plantstartup after a
shutdown)
Non-Guided Process Troubleshooting
Advanced Process Control - Pressure, Flow, andLevel (86007)C
Feed forward controlC Ratio controlC Split range controlC 2nd order
interacting processesC 2nd order non-interacting processes
An optional CD-ROM (85980-A0) includes the
corepressure/flow/level manuals and many other manuals.See the
complete content of the CD in the list ofequipment.
CORE MANUALS - AIR - Pressure and Flow
The three core manuals on air processes cover thefollowing
topics: Basic use of the system and its devices,introduction to the
measurement of air pressure and flow,introduction to the associated
instruments, air tanks,control of air pressure and flow.
Familiarization with the Instrumentation and ProcessControl
Training System - Air (85987-E0)C Introduction to the Training
SystemC Electrical UnitC Emergency Push-ButtonC Pneumatic UnitC
Trend RecorderC RotameterC Digital Pressure GaugeC
Differential-Pressure TransmittersC Orifice (Air)C Solenoid ValveC
Pneumatic Control ValveC Air TanksC Muffler AssemblyC AccessoriesC
I.S.A. Standard and Instrument Symbols
-
9Measurement - Air (85988)C Introduction to MeasurementC
Measuring InstrumentsC Pressure Measurement
Introduction to Fluid Mechanics Pressure Sensing devices
Pressure Loss
C Flow Measurement Elements of Fluid Dynamics Flowmeters
Process Control - Air (85989)C Dynamic Characteristics of a
ProcessC Feedback Control
Tuning and Control of a Pressure Loop and a FlowLoop
Trial and Error Method Ultimate Period Method Ziegler-Nichols
Method
C Troubleshooting Guided Process Troubleshooting
An optional CD-ROM (85980-A0) includes the core airmanuals and
many other manuals. See the completecontent of the CD in the list
of equipment.
CORE MANUALS pH and Conductivity
The three core manuals on pH and conductivityprocesses cover the
following topics: Basic use of thesystem and its devices,
introduction to pH andconductivity measurement, pH probes,
conductivityprobes, ion-exchange resins, basics chemistry, as
wellas pH and conductivity process control. The
optionalConductivity Process Add-On System is required tocomplete
the conductivity exercises of the core manuals.
Familiarization with the Instrumentation and ProcessControl
Training System pH and Conductivity(86012-E0)
Measurement pH and Conductivity (86013)
Process Control pH and Conductivity (86014)
OPTIONAL MANUALS
Calibration Package (85984)Human-Machine Interfaces -
FactoryTalk View(85985-E0)Human-Machine Interface - InTouch
(85986-E0)Electromagnetic Flow Transmitter (85990)Ultrasonic Level
Elements (85991)Radar and Guided-Radar Level
Transmitters(85992)Boiler Simulation (85993)Vortex Flow Transmitter
(85994)Coriolis Flow Transmitter (85995)Primary Flow Elements
(85996)Ultrasonic Flow Transmitter (85997)Paddlewheel Flow
Transmitter (85998)Capacitive Level Transmitter (85999)Switches
(86000)Control Valves (86001-E0)FOUNDATION Fieldbus Device
Configuration(86002)ControlLogix and CompactLogix ProgrammableLogic
Controllers (86030-E0)PLC MicroLogix 1100 (86032)PID Controller
Foxboro (86033)PID Controller Honeywell (86034)HART Device
Configuration (86050)FOUNDATION Fieldbus Networking (89454-E0)
An optional CD-ROM (85990-A0) includes many optionalmanuals. See
the complete content of the CD in the listof equipment.
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
1 This model needs a controller Model 3539-XX to be fully
functional.2 The ordering numbers showm apply to the English 120-V
version. Other versions are available.
10
Content dependency structure of the Lab-Volt manuals for the
3531 system
LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or
-BPRESSURE/FLOW/LEVEL PROCESS HART, MODEL 3531-A1
QTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46761-B01 Process Workstation . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 46801-F01 Instrumentation Workstation . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46900-F01 Column (Large Diameter)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46911-001 Differential-Pressure Transmitter
(HART, High Range) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 46920-001 Differential-Pressure Transmitter
(HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 46921-001 Pneumatic Control Valve . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . 46951-001
Electrical Unit . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46970-B01 Pneumatic Unit . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46971-A01 Color Paperless Recorder . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46972-001 AC Drive
(Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46975-A01 Instrumentation Mounting Pipe . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46990-001 Process Supports Pressure/Flow/Level/Temperature
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46991-C01 Drip Tray (Front) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 46992-B01 Piping and Accessories -
Pressure/Flow/Level Basic System . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 46993-E01 Familiarization with the
Instrumentation and Process Control System -
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
-
3 This model needs a PLC controller Model 3539-XX and the
FOUNDATION Fieldbus PLC add-on (3539-9) to be fully functional.
11
LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B
(contd)PRESSURE/FLOW/LEVEL PROCESS FOUNDATION FIELDBUS, MODEL
3531-B3
QTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46761-B01 Process Workstation . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 46801-F01 Instrumentation Workstation . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46900-F01 Column (Large Diameter)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46911-001 Differential-Pressure Transmitter
(FOUNDATION Fieldbus, High Range) . . . . . . . . . . . . . . . . .
. . 46920-A01 Differential-Pressure Transmitter (FOUNDATION
Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . .
46921-A01 Pneumatic Control Valve . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46951-001 Electrical Unit . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46970-B01
Pneumatic Unit . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46971-A01 Color Paperless Recorder . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46972-001 AC Drive (Ethernet) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 46975-A01 Instrumentation
Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process
Supports Pressure/Flow/Level/Temperature . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46991-C01 Drip Tray (Front)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-B01
Piping and Accessories - Pressure/Flow/Level Basic System . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . 46993-E01
Familiarization with the Instrumentation and Process Control System
-
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-A HART,
MODEL 3530-KQTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46911-001 Differential-Pressure Transmitter (HART, High Range) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46920-001 Differential-Pressure Transmitter (HART, Low Range) . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46921-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46951-001 Color Paperless Recorder .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . 46972-001 Instrumentation
Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process
Supports Pressure/Flow/Level Add-on, 2nd team . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 46991-G01 Drip Tray (Back) .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-C01
Piping and Accessories (2nd team) . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46993-A01 Familiarization with the Instrumentation and Process
Control System -
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
12
LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B
(contd)PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-B
FOUNDATION FIELDBUS,MODEL 3530-L
QTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46911-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus,
High Range) . . . . . . . . . . . . . . . . . . . 46920-A01
Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range)
. . . . . . . . . . . . . . . . . . . . 46921-A01 Pneumatic Control
Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01
Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46951-001 Color Paperless Recorder . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46972-001 Instrumentation Mounting Pipe . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46990-001 Process Supports
Pressure/Flow/Level Add-on, 2nd team . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46991-G01 Drip Tray (Back) . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . 46992-C01 Piping
and Accessories (2nd team) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-A01
Familiarization with the Instrumentation and Process Control System
-
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL ADD-ON, MODEL
3530-MQTY DESCRIPTION ORDERING NUMBER2
1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46902-001 Upper Tank . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46903-001 Orifice Plate . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46912-001 Pneumatic
Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46950-B01 Ball Valve . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46952-001 Piping and Accessories (Advanced) .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46993-G01 Advanced Process Control -
Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . .
. . . . . . 86007-001 Advanced Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . 86007-10
PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL SECOND TEAM ADD-ON,
MODEL 3530-NQTY DESCRIPTION ORDERING NUMBER2
1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46902-001 Orifice Plate . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46912-001 Pneumatic Control Valve . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 46950-B01 Ball Valve . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46952-001 Piping and Accessories (Advanced) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 46993-G01 Advanced Process Control - Pressure/Flow/Level
Student Manual . . . . . . . . . . . . . . . . . . . . . .
86007-001 Advanced Process Control - Pressure/Flow/Level Instructor
Guide . . . . . . . . . . . . . . . . . . . . . . 86007-10
-
13
LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B
(contd)TEMPERATURE PROCESS ADD-ON HART, MODEL 3531-C
QTY DESCRIPTION ORDERING NUMBER2
1 Pumps Add-on . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46904-A01 Pumping Unit (Add-on) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46904-B01 Brazed Plate Heat Exchanger . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46905-001 Heating/Cooling Unit . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46908-001 J-Type
Thermocouple . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46916-001 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46917-001 Temperature Transmitter (HART) . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46940-001 Three-Way Pneumatic Control Valve .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 46955-B01 AC Drive (Ethernet) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46975-C02 AC Drive . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46975-D01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 46992-C01 Piping and Accessories Temperature
Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 46993-J01 Electrical Distribution Box . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 46997-001 Familiarization with the
Instrumentation and Process Control System - Temperature User Guide
86008-E01 Measurement - Temperature Student Manual . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86009-001 Measurement - Temperature Instructor Guide . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86009-101 Process Control - Temperature Student Manual . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86010-001 Process Control - Temperature Instructor Guide . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86010-10
TEMPERATURE PROCESS ADD-ON FOUNDATION FIELDBUS, MODEL 3531-DQTY
DESCRIPTION ORDERING NUMBER2
1 Pumps Add-on . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46904-A01 Pumping Unit (Add-on) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46904-B01 Brazed Plate Heat Exchanger . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46905-001 Heating/Cooling Unit . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46908-001 J-Type
Thermocouple . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46916-001 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46917-001 Temperature Transmitter (FOUNDATION
Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 46940-A01 Three-Way Pneumatic Control Valve . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46955-B01 AC Drive (Ethernet) . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 46975-C02 AC Drive . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-D01
Drip Tray (Back) . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46992-C01 Piping and Accessories Temperature Add-on . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 46993-J01 Electrical Distribution Box . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46997-001 Familiarization with the Instrumentation
and Process Control System - Temperature User Guide 86008-E01
Measurement - Temperature Student Manual . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 86009-001
Measurement - Temperature Instructor Guide . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-101
Process Control - Temperature Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 86010-001
Process Control - Temperature Instructor Guide . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-10
ADVANCED TEMPERATURE PROCESS ADD-ON HART, MODEL 3531-2QTY
DESCRIPTION ORDERING NUMBER2
3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46917-001 Electromagnetic Flow Transmitter (HART) . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46922-001 Electromagnetic Flow Transmitter (HART, 2nd
Transmitter for Advanced Temperature) . . . . . . . . . 46922-101
Energy Manager . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46974-001 Accessories (Temperature, Advanced) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46993-D01 Heat Exchangers and Advanced Temperature
Measurement - Temperature Student Manual . . 86011-001 Heat
Exchangers and Advanced Temperature Measurement - Temperature
Instructor Guide . . 86011-10
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
14
LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B
(contd)ADVANCED TEMPERATURE PROCESS ADD-ON FOUNDATION FIELDBUS,
MODEL 3531-3
QTY DESCRIPTION ORDERING NUMBER2
3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46917-001 Electromagnetic Flow Transmitter (FOUNDATION
Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46922-A01 Electromagnetic Flow Transmitter (FOUNDATION Fieldbus,
2nd Transmitter for
Advanced Temperature) . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 46922-B01 Energy Manager . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46974-001 Accessories (Temperature, Advanced) .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46993-D01 Heat Exchangers and Advanced
Temperature Measurement - Temperature Student Manual . . 86011-001
Heat Exchangers and Advanced Temperature Measurement - Temperature
Instructor Guide . . 86011-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) HART,
MODEL 3531-KQTY DESCRIPTION ORDERING NUMBER2
1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46904-B01 Orifice Plate (Air) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46915-001
Differential-Pressure Transmitter (HART, Low Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001
Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46953-001 AC Drive (Ethernet) . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 46975-A01 Boiler Simulation Student
Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation
Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON)
FOUNDATION FIELDBUS, MODEL3531-L
QTY DESCRIPTION ORDERING NUMBER2
1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46904-B01 Orifice Plate (Air) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46915-001
Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range)
. . . . . . . . . . . . . . . . . . . . 46921-A01 Solenoid Valve
(Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01
Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46953-001 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46975-A01 Boiler Simulation Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) HART,
MODEL 3531-MQTY DESCRIPTION ORDERING NUMBER2
1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure
Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46921-001 Solenoid Valve (Air) . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic
Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001
Boiler Simulation Student Manual . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 85993-10
-
15
LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B
(contd)BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON)
FOUNDATION FIELDBUS, MODEL3531-N
QTY DESCRIPTION ORDERING NUMBER2
1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure
Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . .
. . . . . . . . . 46921-A01 Solenoid Valve (Air) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve
(Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 46953-001 Boiler
Simulation Student Manual . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001
Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) HART,
MODEL 3531-PQTY DESCRIPTION ORDERING NUMBER2
1 Differential-Pressure Transmitter (HART, Low Range) . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001
Boiler Simulation Student Manual . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON)
FOUNDATION FIELDBUS, MODEL 3531-QQTY DESCRIPTION ORDERING
NUMBER2
1 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low
Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Boiler
Simulation Student Manual . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001
Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) HART,
MODEL 3531-RQTY DESCRIPTION ORDERING NUMBER2
1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46904-B01 Differential-Pressure Transmitter (HART, Low
Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46921-001 AC Drive (Ethernet) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 46975-A01 Boiler Simulation Student Manual
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor
Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON)
FOUNDATION FIELDBUS, MODEL 3531-SQTY DESCRIPTION ORDERING
NUMBER2
1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46904-B01 Differential-Pressure Transmitter (FOUNDATION
Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . .
46921-A01 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46975-A01 Boiler Simulation Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 85993-10
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
4 This model needs a controller Model 3539-XX to be fully
functional.
16
LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B
(contd)PRESSURE/FLOW AIR PROCESS ADD-ON, MODEL 3533-A
QTY DESCRIPTION ORDERING NUMBER2
1 Air Tank (Large) . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 46906-001 Air Tank (Small) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46906-A01 Muffler Assembly . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . 46907-001 Orifice
Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46915-001 Solenoid Valve (Air) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control
Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46953-001
Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46990-001 Piping and Accessories (Air) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 46993-B01 Familiarization with the Instrumentation and
Process Control System - Air User Guide . . . . . . . 85987-E01
Measurement - Air Student Manual . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85988-001 Measurement - Air Instructor Guide . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 85988-101 Process Control - Air Student Manual . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 85989-001 Process Control - Air Instructor Guide . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 85989-10
LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or
-1TEMPERATURE PROCESS HART, MODEL 3531-04
QTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Process Workstation . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46801-E01 Instrumentation Workstation with
Heating/Cooling Unit . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46900-D01 Brazed Plate Heat Exchanger . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46905-001 J-Type Thermocouple . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . 46916-001 Platinum RTD
100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46917-001 Temperature Transmitter (HART) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46940-001 Three-Way Pneumatic Control Valve . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46955-B01 Electrical Unit . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46970-B01 Pneumatic Unit . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46971-A01 Color
Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46972-002 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46975-C02 AC Drive . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 46975-D01 Instrumentation
Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process
Supports Temperature . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-D01
Drip Tray (Front) . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46992-B01 Drip Tray (Back) . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46992-C01 Piping and Accessories
Temperature Basic System . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46993-C01 Electrical Distribution Box . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46997-001 Familiarization
with the Instrumentation and Process Control System - Temperature
User Guide 86008-E01 Measurement - Temperature Student Manual . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 86009-001 Measurement - Temperature Instructor Guide . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86009-101 Process Control - Temperature Student Manual . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86010-001 Process Control - Temperature Instructor Guide . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86010-10
-
5 This model needs a PLC controller Model 3539-XX and the
FOUNDATION Fieldbus PLC add-on (3539-9) to be fully functional.
17
LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1
(cont'd)TEMPERATURE PROCESS FOUNDATION FIELDBUS, MODEL 3531-15
QTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Process Workstation . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46801-E01 Instrumentation Workstation with
Heating/Cooling Unit . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46900-D01 Brazed Plate Heat Exchanger . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46905-001 J-Type Thermocouple . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . 46916-001 Platinum RTD
100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46917-001 Temperature Transmitter (FOUNDATION Fieldbus) . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46940-A01 Three-Way Pneumatic Control Valve . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 46955-B01 Electrical Unit . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46970-B01 Pneumatic Unit . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46971-A01 Color Paperless
Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-002 AC
Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 46975-C02 AC Drive . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46975-D01 Instrumentation Mounting Pipe .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46990-001 Process Supports
Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 46991-D01 Drip Tray
(Front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46992-B01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 46992-C01 Piping and Accessories Temperature
Basic System . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 46993-C01 Electrical Distribution Box . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46997-001 Familiarization with the
Instrumentation and Process Control System - Temperature User Guide
86008-E01 Measurement - Temperature Student Manual . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86009-001 Measurement - Temperature Instructor Guide . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86009-101 Process Control - Temperature Student Manual . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86010-001 Process Control - Temperature Instructor Guide . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86010-10
ADVANCED TEMPERATURE PROCESS ADD-ON HART, MODEL 3531-2QTY
DESCRIPTION ORDERING NUMBER2
3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46917-001 Electromagnetic Flow Transmitter (HART) . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46922-001 Electromagnetic Flow Transmitter (HART, 2nd
Transmitter for Advanced Temperature) . . . . . . . . . 46922-101
Energy Manager . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46974-001 Accessories (Temperature, Advanced) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46993-D01 Heat Exchangers and Advanced Temperature
Measurement - Temperature Student Manual . . 86011-001 Heat
Exchangers and Advanced Temperature Measurement - Temperature
Instructor Guide . . 86011-10
ADVANCED TEMPERATURE PROCESS ADD-ON FOUNDATION FIELDBUS, MODEL
3531-3QTY DESCRIPTION ORDERING NUMBER2
3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46917-001 Electromagnetic Flow Transmitter (FOUNDATION
Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46922-A01 Electromagnetic Flow Transmitter (FOUNDATION Fieldbus,
2nd Transmitter for
Advanced Temperature) . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 46922-B01 Energy Manager . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46974-001 Accessories (Temperature, Advanced) .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46993-D01 Heat Exchangers and Advanced
Temperature Measurement - Temperature Student Manual . . 86011-001
Heat Exchangers and Advanced Temperature Measurement - Temperature
Instructor Guide . . 86011-10
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
18
LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1
(cont'd)PRESSURE/FLOW/LEVEL PROCESS ADD-ON HART, MODEL 3530-F
QTY DESCRIPTION ORDERING NUMBER2
1 Digital Pressure Gauge (High Range) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46911-001
Differential-Pressure Transmitter (HART, High Range) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 46920-001
Differential-Pressure Transmitter (HART, Low Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001
Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46951-001 Process Supports Pressure/Flow/Level
Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46991-E01 Piping and Accessories
Pressure/Flow/Level Add-on . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46993-F01 Familiarization with the
Instrumentation and Process Control System -
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
PRESSURE/FLOW/LEVEL PROCESS ADD-ON FOUNDATION FIELDBUS, MODEL
3530-GQTY DESCRIPTION ORDERING NUMBER2
1 Digital Pressure Gauge (High Range) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46911-001
Differential-Pressure Transmitter (FOUNDATION Fieldbus, High Range)
. . . . . . . . . . . . . . . . . . . 46920-A01
Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range)
. . . . . . . . . . . . . . . . . . . . 46921-A01 Pneumatic Control
Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01
Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46951-001 Process Supports Pressure/Flow/Level Add-on . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 46991-E01 Piping and Accessories Pressure/Flow/Level Add-on . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46993-F01 Familiarization with the Instrumentation and Process
Control System -
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-0 HART,
MODEL 3530-HQTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46911-001 Differential-Pressure Transmitter (HART, High Range) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46920-001 Differential-Pressure Transmitter (HART, Low Range) . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46921-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46951-001 Color Paperless Recorder .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . 46972-001 Instrumentation
Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46990-00
-
19
LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1
(cont'd)PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-0
HART, MODEL 3530-H (cont'd)
QTY DESCRIPTION ORDERING NUMBER2
1 Process Supports Pressure/Flow/Level Add-on, 2nd team . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 46991-G01
Piping and Accessories (2nd team) . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46993-A01 Familiarization with the Instrumentation and Process
Control System -
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-1
FOUNDATION FIELDBUS,MODEL 3530-J
QTY DESCRIPTION ORDERING NUMBER2
1 Emergency Switch Station . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46911-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus,
High Range) . . . . . . . . . . . . . . . . . . . 46920-A01
Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range)
. . . . . . . . . . . . . . . . . . . . 46921-A01 Pneumatic Control
Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01
Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46951-001 Color Paperless Recorder . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46972-001 Instrumentation Mounting Pipe . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46990-001 Process Supports
Pressure/Flow/Level Add-on, 2nd team . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46991-G01 Piping and Accessories (2nd
team) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 46993-A01 Familiarization with
the Instrumentation and Process Control System -
Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001
Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process
Control - Pressure/Flow/Level Student Manual . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 86006-001 Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 86006-10
PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL ADD-ON, MODEL
3530-MQTY DESCRIPTION ORDERING NUMBER2
1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46902-001 Upper Tank . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46903-001 Orifice Plate . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46912-001 Pneumatic
Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46950-B01 Ball Valve . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 46952-001 Piping and Accessories (Advanced) .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46993-G01 Advanced Process Control -
Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . .
. . . . . . . 86007-001 Advanced Process Control -
Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . .
. . . . . . . . 86007-10
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
20
LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1
(cont'd)PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL SECOND TEAM
ADD-ON, MODEL 3530-N
QTY DESCRIPTION ORDERING NUMBER2
1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46902-001 Orifice Plate . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 46912-001 Pneumatic Control Valve . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 46950-B01 Ball Valve . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46952-001 Piping and Accessories (Advanced) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 46993-G01 Advanced Process Control - Pressure/Flow/Level
Student Manual . . . . . . . . . . . . . . . . . . . . . .
86007-001 Advanced Process Control - Pressure/Flow/Level Instructor
Guide . . . . . . . . . . . . . . . . . . . . . . 86007-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) HART,
MODEL 3531-MQTY DESCRIPTION ORDERING NUMBER2
1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure
Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46921-001 Solenoid Valve (Air) . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic
Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001
Boiler Simulation Student Manual . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON)
FOUNDATION FIELDBUS, MODEL3531-N
QTY DESCRIPTION ORDERING NUMBER2
1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure
Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . .
. . . . . . . . . 46921-A01 Solenoid Valve (Air) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve
(Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 46953-001 Boiler
Simulation Student Manual . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001
Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) HART,
MODEL 3531-PQTY DESCRIPTION ORDERING NUMBER2
1 Differential-Pressure Transmitter (HART, Low Range) . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001
Boiler Simulation Student Manual . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 85993-10
BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON)
FOUNDATION FIELDBUS, MODEL 3531-QQTY DESCRIPTION ORDERING
NUMBER2
1 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low
Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Boiler
Simulation Student Manual . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001
Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85993-10
-
21
LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1
(cont'd)PRESSURE/FLOW AIR PROCESS ADD-ON, MODEL 3533-A
QTY DESCRIPTION ORDERING NUMBER2
1 Air Tank (Large) . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 46906-001 Air Tank (Small) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 46906-A01 Muffler Assembly . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . 46907-001 Orifice
Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 46915-001 Solenoid Valve (Air) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control
Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 46953-001
Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46990-001 Piping and Accessories (Air) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 46993-B01 Familiarization with the Instrumentation and
Process Control System - Air User Guide . . . . . . . 85987-E01
Measurement - Air Student Manual . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
85988-001 Measurement - Air Instructor Guide . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 85988-101 Process Control - Air Student Manual . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 85989-001 Process Control - Air Instructor Guide . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 85989-10
LIST OF EQUIPMENT CONTROLLERSFOXBORO 762 CONTROLLER BUNDLE,
MODEL 3539
QTY DESCRIPTION ORDERING NUMBER2
1 PID Controller (Foxboro) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46960-001 Foxboro Controller User Guide . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 86033-E0
HONEYWELL UDC3500 CONTROLLER BUNDLE, MODEL 3539-1QTY DESCRIPTION
ORDERING NUMBER2
1 PID Controller (Honeywell) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 46961-001 Honeywell Controller User Guide . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 86034-E0
CONTROLLOGIX PLC BUNDLE EDUCATIONAL, MODEL 3539-5QTY DESCRIPTION
ORDERING NUMBER1
1 RSLogix 5000 Full Edition . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 5935-101 Programmable Logic Controller (ControlLogix) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46965-001 ControlLogix and CompactLogix Programmable Logic
Controllers User Guide . . . . . . . . . . . . . . 86030-E0
CONTROLLOGIX PLC BUNDLE COMMERCIAL, MODEL 3539-AQTY DESCRIPTION
ORDERING NUMBER2
1 RSLogix 5000 Full Edition (Commercial) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5935-B01 Programmable Logic Controller (ControlLogix) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46965-001 ControlLogix and CompactLogix Programmable Logic
Controllers User Guide . . . . . . . . . . . . . . 86030-E0
-
INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES
3531
22
LIST OF EQUIPMENT CONTROLLERS (cont'd)MICROLOGIX PLC BUNDLE
EDUCATIONAL, MODEL 3539-7
QTY DESCRIPTION ORDERING NUMBER2
1 RSLogix Micro . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 3245-A01 Communication Cable . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 3246-401 Programmable Logic
Controller (MicroLogix) . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 46964-001 MicroLogix1100
Programmable Logic Controller User Guide . . . . . . . . . . . . .
. . . . . . . . . . . . . . 86032-E0
MICROLOGIX PLC BUNDLE COMMERCIAL, MODEL 3539-CQTY DESCRIPTION
ORDERING NUMBER2
1 RSLogix Micro (Commercial) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 3245-B01 Communication Cable . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 3246-401 Programmable Logic Controller
(MicroLogix) . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46964-001 MicroLogix1100 Programmable
Logic Controller User Guide . . . . . . . . . . . . . . . . . . . .
. . . . . . . 86032-E0
COMPACTLOGIX PLC BUNDLE EDUCATIONAL, MODEL 3539-8QTY DESCRIPTION
ORDERING NUMBER2
1 RSLogix 5000 Lite Edition . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 5935-001 Programmable Logic Controller (CompactLogix) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 46966-001 ControlLogix and CompactLogix Programmable Logic
Controllers User Guide . . . . . . . . . . . . . . 86030-E0
COMPACTLOGIX PLC BUNDLE COMMERCIAL, MODEL 3539-DQTY DESCRIPTION
ORDERING NUMBER2
1 RSLogix 5000 Lite Edition (Commercial) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5935-A01 Programmable Logic Controller (CompactLogix) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46966-001 ControlLogix and CompactLogix Programmable Logic
Controllers User Guide . . . . . . . . . . . . . . 86030-E0
FOUNDATION FIELDBUS PLC ADD-ON, MODEL 3539-9QTY DESCRIPTION
ORDERING NUMBER2
1 FOUNDATION Fieldbus Junction Box . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46978-A01 FOUNDATION Fieldbus Bridge . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 46979-101 FOUNDATION Fieldbus Networking User Guide . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
89454-E0
OPTIONAL EQUIPMENTPROCESS OPTIONS PRESSURE
DESCRIPTION ORDERING NUMBER2
Digital Pressure Gauge (Low Range) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 46761-C0Pressure Switch with Analog Output . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 46926-00Pressure Transmitter (HART) . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . 46928-00Pressure
Transmitter (FOUNDATION Fieldbus) . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
46928-A0
-
23
OPTIONAL EQUIPMENT (cont'd)PROCESS OPTIONS FLOW
DESCRIPTION ORDERING NUMBER2
Orifice Plate . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 46912-00Pitot Tube . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
46913-00Electromagnetic Flow Transmitter (HART) . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 46922-00Electromagnetic Flow Transmitter (HART, 2nd
Transmitter for Advanced Temperature) . . . . . . . . . . . . . . .
46922-10Electromagnetic Flow Transmitter (FOUNDATION Fieldbus) . .
. . . . . . . . . . . . . . . . . . . . . .