HIM' GRAND

Key

HIM’ GRAND I—.,uup——aw’u.hI—I—

1969-70 ALL TYPICAL POWER-FLOW VENTILATION

Port Name

— PANEL, Shroud Side Trim

2— GRILLE, Air Inlet Panel

3 — CONTROL, Shroud Side Panel — Lower

4 — CONTROL, Shroud Side Panel — Upper

5 — DOOR, Outlet

6 — MOTOR, Vent

7 — GASKET, Motor Mounting

8 — SHIELD, Motor Beoring

9 — PLATE & BRACKET, Motor Mounting

10— IMPELLER, Vent Motor

ii — CASE, Power Vent Blower

12 — CLAMP, Wire

13 — SWITCH & WIRE, Power Flow Vent

14—CLIP, Swtch Retaining

15 — HARNESS, Power Flow Vent

Group No.

... 14.630

9.789

• . . 9.787

9.787

9.789

9.790

• . . 9.790

9.790

9.790

9.790

9.790

9.790

9.790

9.790

9.790

GROUP 9.000 ILLUSTRATION 1

TEMPESTGRAND PRIX

PARIS CATALO CUE

6-CYLINDER COMPRESSOR PARTS


GRAND PAIRIGMLM.:r.iPort Name

8 — HOUSING, Compressor9—GASKET, Oil Fitting Screw

10— SCREW, Oil Fitting11 — SHELL ASSY., Compressor12 — COIL, Clutch13— SNAP RING, Coil14— PULLEY, CompressorIS — REARING, Pulley16— RING, Pulley Bearing Ret.17 — PULLEY ASSY., Compressor18— SNAP RING, Searing to Head19— PLATE ASSY., Clutch20— SPACER, Clutch Hub21 — SNAP RING, Clutch Hub

— SEAL, “0’ Ring2 — HEAD, Compressor—Front3—SEAL, ‘0’ Ring (Port of #7)4 — SEAL, Shaft Oil (Part of #7)5 — SEAT, Oil Seal (Port of #7)6 — SNAP RING, Oil Seal Seat (Part of #7)7—SEAL P1CC., Shaft Oil (Inc

1. #3..4...5.4.60..6

(A)

1)

Retainer

22— NUT, Pulley S. Clutch to Shaft23 — “ Ring, Intake & Discharge Part (A)24 — NUT, Compressor Shell25— VALVE, Pressure Relief26— GASKET, Pressure Relief27— HEAD, Cylinder—Rear28-.- ‘0” RING, Cyiinder Head (A)29— SCREEN, Suction30—PUMP P1CC., Cornp. Oil31 — PLATE, Discharge Valve—Rear32 — REED, Suction Valve33— BUSHING, Discharge Tube34~ I(y• RING, Discharge Tube (A)35—CYLINDER &BEARINGASSY., (Includes Front &Reor Unit & No’s. 36—54—55)36 — BEARING, Shaft37 TUBE, Oil Inlet38— “0” RING, Oil Inlet Tube (A)39 — BEARING, Needle Thrust40 — RACE, Thrust Bearing41 — SHAFT ASS’?., Drive (No. 50 Included)42—RING, Piston43 — BALL, Piston Drive44—PISTON45—RING, Piston46 — BALL, Piston Drive47— DISC, Shoe48— TUBE PKG,, Crossover Discharge (No. 33 Included)49—SEARING, Needle Thrust50— KEY. Clutch HubSI — RACE, Thrust Bearing52 — COVER, Suction Passage (A)53 — SEAL, Suction PassageCover (See Note Group 9.170)54 BEARING, Shaft55 — CYLINDER &BEARINGASSY., (includes FrontS Rear ljnit & No’s. 35—36—54)56— “0’ RING, Discharge Tube (A)57 — BUSHING, Discharge Tube58—REED, Suction Valve59— PLATE, Discharge Valve — Front60 — SLEEVE, Seal — Felt (Port of #7)61 — RETAINER, Seal Sleeve (Port of #7) .

NOTE: Cylinder & Shaft Assembly Includes47-48-49-51—54—55.

The parts indicated with letters ore serviced in the following pacLagestA Parts Serviced in Compressor Overhaul Seal Pkg. — 9.170

6-CYLINDER COMPRESSOR PARTS

(A) N.S.9.174

N .5.N.S.N .5.

9.1759.175N .S.

9.1779.1779.1709.1869.175N .S.

9.1819.1819.1809.1819.1889.1819.1759.1709.2409.1709.1789.1789.174N.S.

9.1729.1729.1729.1729.172N.S.

9.1709.1729.172N.S.

9.1729.1729.1709.1729.1729.1729.1729.1729.1729.1729.1729.1889.1729.172N.5.

9.1729.170N .5.

9.1729.1729.172KS.

.... N.S.No’s. 35-36-39-40—41 ~42N3—44-45-46—

Key Group No.

GROUP acoc ILLUSTRATION 3

DULl GRANDP1UX I3’.JJ.V.L WUp

1969/242 AiR CONDITIONING — COMPRESSOR MOUNTING & DRIVE

Description Port Na. Group

Bolt — -lEx 1%

Washer — x ¾

Bolt — ¾-16x¾

Washer — x ¾

Brace, Campressar, Rear

Spacer. Corsipressor, Rear

Indicator, Oil Level — See Data

Bolt—¾16x’/e

Plate, Compressor, Rear

Balt—¾-16x1½

Pulley — See Data

Bait —~4s-24x¾

Bolt — K6.18 x ¾

Fan, Engine — See Data

Clutch Any., Engine Fan — See Data

Std. StIc.

537209

180120

502306

9786452

541191

454905

548412

435611

9.17 1

9.171

1.516

9.171

1.062

01>’.

AR

AR

AR

AR

AR

444684 AR

180075 AR

Description Part No. Ct>’. Group

5910495 1 9.170

Key

16 Campressor Ass>’., Air. CaM.

17 Balt—%.16x31A

19 Bolt — ¾.16x2V4 3933130

19 Washer — 1K2~ 1TA 538333

20 Support, Compressor — Front 9782661

21 Spacer, Compressor — Front 9782676

22 Bolt — Ks.24x1%

23 Bolt — K6 -24 x 2 9421948

24 Pulley, Crank Shaft — See Data

25 Bracket Compressor Mounting 9785787

26 Tube, Oil Level Indicator — See Data

27 BaIt—¾-16x1¾ 454467

28 Spacer NI..

29 Bracket, Spark Plug Wires ... . 9781948

30 Brace, Compressor Mounhing—Lwr. Rear 546231

1.064

1.062


Key

2

3

4

5

6

7

8

9

10

11

12

13

14

15

9.171

9.171

AR

1 9.171

1.5 16

AR

1 2.251

1 9.171

TEMPESTGRAND FEll

PARIS CA IALOGUE

1970 TEMPEST 6 CYL. ENGINE AIR CONDITIONING COMPRESSOR MOUNTING

Key Port Name

1 — BRACKET, Mounting - Rear.

2 — SHIM, Camp. to Bracket

3—BOLT (3/8—16 x 1)

4 — SUPPORT, Compressor

5 — BOLT (3/8”—16 x 1—1/8”)

6— LOCICWASHER (5/Id”)

7 — NUT (3/8”—.16)

8— PUU.EY, Water Pump

9—BOLT (3/8”—16 ~ z/r)

10 — LOCKWASHER (3/8”)

11 —WASHER (13/32” I.D. x 13/16’ 0.0.)

12 — BRACKET, Mounting — Front

13—BOLT (5/16—24 x 1)

14 — COMPRESSOR,Conditioner

Port No.

3843250

3850581

186678

3843248

435611

103320

124829

3995646

454905

120382

¶20394

3843249

186634

5910495

Group No.

9.17 1

9.17 1

8.900

9.17 1

8.900

8.931

8.9 15

1.062

8.900

8.93 1

8.929

9.171

8.900

9.170


Key

1 — BRACE, Compressor Mounting2 — SPACER, Plate to Supt3— BOLT (3/8”—16 x 3/4”)4— WASHER, Brkt. to Cyl. Head5— INDICATOR, Oil Level6— SCREW (1/4”—14 x 3/4”)7 — TUBE, Oil Level md8— BOLT (5/16”—24 x 2-1/4”) (1st type)

— BOLT (5/16”—24 x 5/8”) (2nd type)9 — BRACE, Comp. Front

10— NUT, (5/16”—18)11 — EXTENSION, Front Brace12— NUT, (3/8”—16) (1st type)13— BOLT (3/8”—16 x 3-1/2”) list type)

— BOLT (3/8”—16 x 1-7/8”) (2nd type)14— BOLT (3/8”—16 x 2-1/4”) list type)

— BOLT (3/8”—16 x 7/8”) (2nd type)15 — COMPRESSOR ASM., Conditioner16— PLATE, Pulley Reinforcement17— BOLT (5/16”—24 x 3/4”)18 — PULLEY, Crankshaft19— PULLEY,Crankshaft20—WASHER (13/32”,c1-1/4”) list type)

— WASHER (13/32”,c 1”) (2nd type)21 — SUPPORT, Compressor Front (1st type)22—WASHER (11/32” ,c3/4”)23—SPACER, Front Support24— BOLT (5/16”—24 x 1-5/8”) (1st type)

— BOLT (5/16”—24 x 1”) (2nd type)25— BOLT (5/16”—24 x 2”) (1st type)26— BOLT (3/8”—16 x 1-1/8”)27— BRACKET, Compressor Mounting (1st type)

— BRACKET, Compressor Mounting (2nd type)28— PLATE, Compressor Mounting Rear29— BOLT (3/8”—16 x 7/8”)30— BRACE, Compressor Lower Rear31 — BOLT (3/8”—16 x 1”) (1st type)32— SPACER, Brkt. to Manifold33— BOLT (3/8”—16 x 1-3/4”)34— BOLT (5/16”—18 x 1-3/8”)35 — SUPPORT,Compressor Front (2nd type)36— SPACER, Compressor Front37 — PULLEY, Water Pump & Fan38— BOLT (3/8”—16 x 3”)


MOUNTINGPart No.

9786452541191180120502306

9793341

9425451480843

9421949181593

478145120376

4781469413322

1801293833130454905

59104959780845

44468497908429790843

53833397993959782661

537209

9782676

1866349421948

4356119785787

477897548412454905546231186678539509454467

477898532161

See Data189304

1970 ALL 8-CYL. AIR CONDITIONING COMPRESSORPart Name Group No.

9.17 19.17 18.9002.2771.5 168.9771.5 168.9008.9009.17 18.9159.17 18.917N.S.

8.9008.9008.9009.1700.6608.9000.6590.6599.1739.1739.1719.1739.17 1N .S.

8.9008.9008.9009.1719.1719.1718.9009.1718,9009.1738.900N.S.9.17 19.1711.0628.900

CM’ S S II I ND fIX

Part No, Group No.

BRACE, Compressor—Rear See DataINDICATOR ASM., Engine Oil Level—Pont. Eng. 9793341

—Chev. Eng. 3886082NUT, Tube Asm., to Comp. Brace

..4t/4”.14 “U”) 9422619BOLT, Camp. Rear Brace to MtId.)

- 16 x5/a”) 9419051

BOLT, Camp. Front Brace to Supt.—4¾”-16x7/a”) 454905

6 SCREW,Camp. Brace to Tube Asm...41/~’% 14x¾” 9425451

7 BRACE, Compressor Front 4805228 BRACE, Compressor Front 1203769 BOLT, Camp. to Fr?. Supt. (X

6”.24 x5/a”) 181591

10 SUPPORT, Compressor-Front—1971 Pont. Eng 480527—1971 Chev. Eng 3932432—1972 Pont. Eng 485994—1972 Chev. Eng. 3997796

11 PULLEY, Water Pump & Fan-459(s” dia.)—Double Groove ... 481040

12 NUT, Camp. Lower Rear Brace to Head Bolt—4¾”-16) 9414034

13 COMPRESSOR ASM., Air Conditioning See Data14 BOLT, Comp. to Rear Mtg. Plate

~ 43561115 BOLT, Comp. Frt. Sup?. to Head

—(¾”-16x171e”) 18012916 WASHER,Camp. Fr?. Supt to Head

-413/32” ID.) 538333

9.1711.5161.5 16

8.921

8.900

8.900

8.9779.17 18.9158,900

9.1719.1719.1719.17 1

1.062

8.9159.170

8.900

8.900

9.173

Key Part Name Part No, Group No.

17 SPACER, Camp. Frt. Supt, to Head .. 978267638 BOLT, Crackshaft Pulley Plate

44468419 PLATE, Crackshaft Pulley Reinforcement 979084520 PULLEY, Crankshaft

-4734s” diaj—Double Groove 48103821 PULLEY, Crankshaft

—477;s” dia.)—Double Groove 48050922 SCREW, Oil Tube to Brace (l4s”. 12 x 5/e”) 942223223 TUBE ASM., Oil Level Indicator—Upper See Data24 INDICATOR ASM., Engine Oil Level (A- Body) 48376625 BOLT, Camp. MIg. Brkt. to Head

—43/a”.16x1t/s”) 942046226 Bracket, Compressor Mtg.

—1971-72 Pont. Eng. . . 480525—1971-72 Chev, Eng—Front . 3932433—1971-72 Chev. Eng—Rear 3998946

27 TUBE ASM., Engine Oil Level nd—Upper See Data28 PLATE, Compressor Mtg.—Rear 48052629 SPACER, Camp. Rear Brace to Camp

—1971-72 Pont. Eng 483338—1971-72 Chev. Eng 3841722

30 BRACE, Camp. Lower Rear—to Head See Data31 WASHER, Camp. Frt. (13/32” ID.) 50230633 BOLT, Camp. Rear Brace to Camp.

—43/e”- 16x2t/a”) 373313034 BOLT, Camp. Rear Brace to Mfld.

-4l~s”.18x it/a”) . ... 180080

I

Key Part Name

1971-72 8 CYL. A/C COMPRESSOR MOUNTING AND DRIVE PARTS

2

3

4

S

9.171

8.9000.660

0.659

0.6598.9771.5 161.516

8.900

9.17 19,1719.1711.5 169.171

9.1719.17 19.17 I9.173

8.900

8.900

GROUP 9.000 1 LLUSTRATION 7

I GM’ X’~1IX I

1973-74 A/C COMPRESSOR MOUNTINGKey Part Name Part No, Group No.

1 — BRACE, Camp. Rear - Upper See Data 9.17 12— BOLT (3/8”-16 x 5/8”) 9419051 8.9003—BRACE, Camp. Front 490334 9.1714— NUT (5/16”-1B) 120376 8.9155— BOLT (5/16”-24 x 3/4”) . 444684 8.9006— SUPPORT, Camp. Front - Pont. Eng. 489169 9.171

- Chey. Eng. 3997796 9.1717— NUT (3/8”-16) . . . .. 9414034 8.9158— COMPRESSOR, A.C ~6598423 9.1709—BOLT (3/8”-16x 1-1/8”) 435611 8.900

10— BOLT (3/8”-16 x 1-7/8”) 179846 8.90011 — WASHER, Supt. to Head (13/32” ID.) 538333 9.17312—SPACER,Supt.toHosa 9782676 9.17113—BOLT (5/16”-24x 1”) (“A”&”B”) . 186634 8.900

BOLT (5/16”-24 x 3/4”) (“F” & “X”l 444684 8.90014—BRACKET. Comp. Mounting - Pont. Eng. . . . - 491877 9.171

- Ohev. Eng. - Front .. 3923433 9.171-Rear .. 3998946 9.171

15— BOLT (3/8”-16 x 1-1/4”) 9420462 8.900lA — RRACP, Comp. Lower Rear . . . . See Data 9.171

17—PLATE,Comp.-Fteer -P~t. Eng. 480526 9.171- Ohev. Eng. 3028794 9.171

18— BOLT (3/8”-16 x 7/8”) 454905 8.90019— SPACER. Rear Brace to Comp. - Pont. Eng. 483338 9.171

- Chey. Eng. - 384172220— WASHER, Comp. Mtg, (13/32” ID, x 3/4” O.D.) . .... 502306 6.60621—BOLT(3/8”’16x2-1/8”) N.S.22— TUBE ASM., Indicator - Upper (455 S.D.) 97955B9 1.51623—INDICATOR ASM., Oil Level -Pont. Eng. 9793341 1.516

- Chev. Eng. 3951576 1.516

24—TUBE ASM., Indicator - Upper (Exa. 455 or Ram Air or Ohey. Eng.) 480843 1.516-Chev. Fng 3070870 1.516


law 0n I

NOTES

TEMPESTGRAND PAIl 1

PA H IS CATALO CUE

1969/242 CUSTOM AIR CONDITIONING — INTERIOR AIR SYSTEM

1969

GROUP 9.000 ILLUSTRAITON 10

S

1GM TEMPESTGRAND P31K

PARIS CA! A LU CUE

1969/242 CUSTOM AIR CONbITIONINGINTERIOR AIR SYSTEM

key D.,cdption Part No. Oty. Group

1 Adapter

2 Nut — #10.24.

3 Clip

4 Duct, Air Cond. Air Outlet—Outer Left

S Duct, Air Cond, Air Outlet—Inner Left

6 Duct, Air Cond. Air Outlet—Center

7 Retainer. Centre Outlet Valve Spring

8 Retainer, Center Outlet

9 Hose

10 Adapter, Outlet—Right

11 Deflector, Outer Air —Right

—Left

12 Retainer

13 Bezel

14 Screw

15 Insulator, Shroud Side Inner Panel—Right

16 Panel, Shroud Side Finish—See Data

17 Screw—#8-18x¾

18 Rivet

19 Adapter, Air Cand. Air Outlet—Center

20 Deflector, Air Cond. Center Air

21 Bearing, Heater Control Shaft Cam Roller

22 Cam Ass>’., Heater Temp. .

23 Valve Ass>’., Heater Temp.

24 Clip, Heater Temp. Valve Shaft Retaining

25 Housing, Heater Temp. Valve

26 Core, Heater — See Data

27 Clamp, Heater Core—S.c Data

23 Adapter, Heater to Distributor Duct

29 Screw — ‘/z-14x1

30 Seal, Distributor Duct t0 Heater

NI.

441239

NI..

9782386

9793918

9784395

9774974

9776399

NI..

9796598

477655

9799092

N.L.

N. L.

N.L.

8727895

AR

1 9.262

1 9.262

1 9.262

2 9.262

2 9.262

9.264

9.262

9.262

1 14.630

14.630

N.S.

NI..

9796881

9790417

3150822

3018775

3015583

3013531

3015581

9790131

451617

9790119

1 9,264

1 9.262

1 9.786

1 8.866

1 9.786

1 9.786

1 9.786

8.854

8.354

1 9.262

Key Description Part Na. Qty. Group

9.786131 Duct Ass>’., Heater Air Distributar . . 9796231

32 Screw — 5,4. 14x% N.L

33 Retainer, Distributor Duct Air Deflector . . 530067

34 Deflector, Distributor Duct Air . 9790400

35 Scr.w —‘A. 14x2 NI..

36 Retainer, Auxiliary Air Outlet 9795307

37 Screw — #8.18x¾ . . . N.L

38 Screw — #1O.2*x½ . . . 9420755

39 Case Ass>’., Heater . . 3014249

40 Clip, Air Valve Diaphragm Link 3158826

41 Baffle, Air Restrictor . 3016692

42 Diaphragm Ass>’., Defroster Air Valve 1998934

43 Spring, Defroster Air Valve Return 3146536

301425944 Valve Ass>’., Defroster ...

.45 Link, Heater Diverter Valve—Lower . 3015586

46 Diaphragm, Heater Diverter Valve—Upper 1998941

47 link, Heater Diverter Valve— Upper 3016883

48 Raffle, Heater Bi-Level . . 3018495

49 Valve and Seals, Heater Diverter—Upper. 3015554

50 Valve and Seals, Heater Diverter—Lower 3015555

51 Shaft, Heater Diverter Valve 3015114

52 Screw— #8.lBx%

53 Hose, Air Cond. Vacuum Contra1—3~2 l.D. (25 ft. roll) 3987362

54 Hose, Air Cand, Vacuum Control—%2 ID. (25 ft. roll) 3987363

55 Connector, Heater Vacuum Tubes 3003884

56 Bezel . . . . . N.L

57 Frame ,. . N.L

58 Frame .. . . . . N.j.59 Duct Air Cond. Air Outlet—Right 9796406

9.262

2 9.262

2 9.262

2 9.262

1 8.854

AR 8.845

1 9.786

1 9.779

1 9.779

1 9,779

1 9.786

1 8.850

1 9.786

1 9.786

1 9.786

1 9.786

1 9.786

AR 9.281

AR 9.281

1 8.850

1 9.262


1GM’ flMWUTGRAND P311 ~1

I-.I .E..l

1970-72 TEMPEST CUSTOM AIR CONDITIONING — INTERIOR AIR SYSTEM

U—.


IfltrIUMhW.iEhd

Key Port Name

1 — NOZZLE, Defroster.

2 — DUCT, Center Air

3— SCREW (IS~la x 5/8”)

4— RETAINER, Outlet Deflector

5 DEFLECTOR, Center Air

6—RETAINER, Center Air Deflector — R.H..

7— NUT, Deflector to Plate — U

$ — PAD, Inst. Panel

9— ADAPTER, Outer Air — R.H

IC — DEFLECTO%Outer Air — R.H

Ii — DUCT, Air Outlet — Outer — R.H

12—CASE & CORE ASM., Hiater & AC.

13—SCREW(1/4—14 x 1”)

14. SEAL, Duct to Heater §

15—DUCT, Diet. Main

16—SCREW (1/4—14x 5k’)

17—RETAINER, Deflector (Felt)

18 — DEFLECTOR, Mqin Air Duct

19 — SCREW(1/4—14 sc 2”)

20—WASHER(11/32” I.D. ~ 5/8,’ 0.0.).

21 — NUT (#10-16 U’)

22 — liTAINER, Mx. Outlet

23—SCREW(#8—18 x 5/8”)

24—SCREW(#10—16 x 1/2’)

25 — ADAflER, tut~ ‘Its ~Aeo¶ti

26 — DUCT, Air Outlet Inner — L.H

27— DEFLECTOR, Outer Air — L.H

26—DUCT, Air Outlet Outer — L.H

fl—NUT (#10—24)

30—RETAINER, Center Air Deflector — tN.

1970-72 TEMPEST CUSTOM AIR CONDITIONING — INTERIOR AIR SYSTEM

Port No.

9793821

9799623

9776399

9799463

6496)55

1234918

See Cat.

9796598

477655

9796406

3018033

451617

9790719

478518

530067

9790400

9422836

9795207

9428582

94)9303

9790131

478332

9799092

9782386

4.46059

6496754

Group No.

9.779

9.262

N.S.

9.262

9.262

9.262

9.262

14.655

9.264

9.262

9.262

8.854

8.977

9.262

9.786

N.5.

9.262

9.262

N .5.

N .5,

8.921

9.262

8.977

8.977

9.262

9.262

9.262

9.262

8.921

9.262

GROUP 9.000 ~LLUST~ATION13

TEMPESTGRAND PAIr

PARTS CATALOGUE

1g73-74 LEMANS & LUXURY (AD, AF & AG) AIR CONDITIONING — INTERIOR AIR SYSTEM

-t

% __

GROUP 9.000 ILLUSTRNTION \4

TEMPE8TGRAND P31K

PARTS CATALOGUE

Pert NoGroup No.

1 — NOZZLE, Defroster

2—SCREW(#10-16x3/4’)

3—DEFLECTOR, Outer Air-RH.

4 — SCREW(#8-18 x 5/B”)

6—DEFLECTOR,Center Air

6— CORE & CASE, Heater & Air Conditioning

7—SCREW(1/4”-14x1 1/2”)

8— OUTLET ASM., Heater Air

9—SCREW (#10-16 x 5/8”)

10— DIAPHRAGM. Diverter Valve

11 — DUCT. Center Air Outlet

12— DUCT, Air Outer - L.H

13— SCREW (#8-18,5/8’)

14— DUCT, Air Inner- L.H

15— SCREW (#10-16 x 5/8”)

16— DUCT, Air Distributor

17—SEAL, Air 01st. Dud to Neater

18— ADAPTER, Air Dist. Duct to Heater

19—NUT (#8-18 U’)

20— DEFLECTOR, Distributor Duct

21 — RETAINER, RH. Aux. Air Outlet or Distributor Deflector

22— DUCT, RH. Air Outer

23—TRIMPLATE, Inst. Panel

24— DEFLECTOR, Outer Air - L.H

25— DEFLECTOR,Aux. Air - L.H

26—SCREW(#1O-16x3/4’)

27 — COVER,Inst. Panel Lo~wr

28—PADASM.. Instrument Panel

484777 9.779

— NS.

484796 9.262

9416444 8.977

484684 9.262

3023818 8.854

— NS.

484662 9.788

189361 8.977

1998980 8.850

485300 9262

490997 9.262

9416444 8.977

484608 9.262

189361 8.977

485029 9.788

484421 9.786

484422 9.262

9417488 8.921

9790400 9.262

488238 9.262

484960 9.262

(See Cat.) 10.262

486674 9.262

487827 8.262

— N.S.

487795 6.760

(See Data) 14.655

1973-74 LEMANS & LUXURY (AD, AF & AQI AIR CONDITIONING — INTERIOR AIR SYSTEM

Key Part Name


TEMPESTGRAND FEll

PARTS CATALOGUE

1969-72 (TEMPEST CUSTOM AIR CONDITIONING — REFRIGERATION SYSTEM


TEMPESTGRAND PInK I

PARTS CATAIACUE

1969-72 TEMPEST CUSTOM AIR CONDITIONINGREFRIGERATION SYSTEM

Key Description Port No. Qty. Group

1 Case, Evaporator — Inlet

2 Screw

3 Baffle, Inlet Case

4 Nut—1/420

5 Grommet, Outlet Pipe

Bolt— 3/8-24,c 1

8 Lackwasher — 3/8

9 Compressor .

10 Seal, Evaporator Core

11 Clamp. Freon Hose —1969.70

—1971-72

12 Hose, Compressor Suction —5,8

13 Tube. Valve to Hose— 1969-72 Pont. Lop.

—1972 Chev. Eng.

14 Gasket — /o/ Ring — 3/4

15 Clamp, Suction Throttling Valve..

16 Valve, Suction Throttling

17 Insulation, Bulb

IS Gasket — /o/ Ring — 3/8

19 Core, Evaporator

20 Valve, Thermostatic Expans,on

21 Gasket — Ia! Ring — 3/8

22 Hose, Receiver to Evaporator

23 Case, Evaporator — Outlet

24 Clamp

25 Hose, Drain —1969-70

— 1971.72

28 Fittings, Compressor

—1969~72 6 Cyl. Eng

—1969.72 Pontiac V-S Eng.

—1971 Chey. 350 Eng

27 Bolt — 5/16-24 x 3/4

28 Support, Muffler to Compressor

—1970

—1971.72

29 Hose, Freon — 1/2

30 Clamp, Muffler to Support

31 washer — 5/iSs 5/8

32 Lockwasher — 5/16

3014159

N.L.

3014155

120375

30072??

454922

120382

SEE DATA

3014159

3909030

S%444SQ9798788

9797015

9797180

3140882

9779400

6910704

8526387

8526398

3014086

5910767

8526398

97 945 16

3014157

N.L.

3148473

3021960

479339

978 1240

736482

444684

546684

481590

9789793

9777203

N.S.

187119

1 9211

1 9.211

AR

AR

AR

AR

All

9.775

9170

9.211

9242

9242

9.229

1 9.229

1 9.229

AR 9.214

1 9196

1 9.198

AR 9.213

AR 9.214

1 9210

1 9.213

AR 9.214

AR 9.231

1 9.211

1 9.211

1 9.211

1 9.226

1 9226

1 9,226

1 9.242

1 9.242

S-S.

1 9.242

Key Description Part Na. Oty. Group

33 Bolt — 5/16-24 x 1-1/4

34 Support. See Key #28

35 Wire, Motor Ground

36 Condenser, Refrigerant — 1969-71

—1972

37 Screw — 1/4-l4x 5/8

38 Clamp, Receiver

39 Receiver, Air Conditioner

40 Screw — 1/4-14 x 3/4

41 Nut — 1/4-14

42 T,abe, ~eceWer43 Nut....1/4-14-U

44 Screw — 8~18 x 1/2

45 Motor, Blower —1969-70

— 1971.72

46 Hose, Discharge — 1/2

47 Seat, Inlet Pipe to Case

48 Impeller, A/C Heater Blower

49 Lockwasher

50 Nut — #10-32

51 Screw — 8-18 x 1/2

52 Elbow, Cooling Tube

53 Tube, Slower Motor Cooling

54 Screw—l/4-14x3/4

9427199

1 9216

1 9.190

1 9.190

1 9.206

1 9.195

3001 346

3018267

3025901

9791641

3015061

9425451

979074%

9422619

9419663

4194916

4960538

9798793

3003215

3144684

138479

120814

9419683

3013476

31588 17

9425451

AR

AR

1

1

9.215

9.215

S-S.

9.211

9216

9.2 16

9.218


TEMPESTGRAND PHIl I

PARTS CATALOGUE1GM

1073-74 LEMANS & LUXURY (“AD”, “AF”, & “AG”) AIR CONDITIONING —

REFRIGERATION SYSTEM


LAnanix1GM ErNST

]

— —

Key Part Name

I — REdISTOR. AC<Slower

3— GASKET AC. “0” Ring.

4 —MUFFLER &PrtTING.compressor.

5— CDMPRE~OR, AirCondhloning

B — VALVE, 1-istar Water

7—HOSE (3/4”xSOFt.)

8—CLAMP, Heflr Water Valve Hose.

9—HOSE (5/Si xSO Ftj

10—CLIP,Hosesoskitt .

11 — CLIP, Heater Outlet Wase~ Hose

12—HOSE,ComoresorOiscl~srqe (ls’2”x loFt)

— CLAMP, Refrirrsrrt I-lose (7(16” x 3(41

14— VALVEs-IN-RECEIVER, A.C

15— TuBe ASM

18— HOSE, Consp. SCJCflOI,Refripmrn

17— SPACEA, Comp I-lose to Skirt

18— BRACKET, V.l.R. to Case

19—SEAL, v.l.R. Inlet Line Gonrt. “0 Ring

20—BRACKET, Red. Suppers Mtg. Upper- (U-I

21 — BRACKET, Red. Support Mtg. Upper - LI-I

22— BRACKet Red. Support Mtg. Lower - L.H.

23— CONOEPJSER. A.C—POflk. Eng.—Ohs>’: Eng.

24— GASKET, AC. “0’ Ring (¾’)

25— BRACKET. Rid. Support Msg. Lower - R.H

26—GROMMET, Tube to Red. Baffle

27—TUBE ASM., Cond, to V’SS. - rror~s

26—RETAINER, Tube to Skirt

29—TUBE MM.. Coit to V.i.R. - Rear

30- MOTOR MM.. A.C. Blower

21 — ~MPELt.ER, Evap. 6lOwSr Mtr. (Plastic)

32— EVAPORATOR & BLOWER DUCT

Pert No, Group No.

481892 9.275

3140862 9.214

See Data 9.225

6588423 9770

41375 9.795

482420 &962

s-S.

462434 8.962

— N.5.

491945 9.260

— 8962

See Data 9.225

6599452 9.195

N.S.

230825 8.962

g791912 9.242

— NS.

8599463 9.229

488191 9.190

486192 9.190

488317 9.790

3024867 0.1903027875 91908526396 9.214

488316 9.190

2382296 9.775

SW Data 9227

— N.S.

See Data 9.227

3027939 9.216

3027082 9.218

.lusecorflponents) ItS.

1P3-74 LUMANS & LUXURY (“AD”, “Ar,, & “AG”) AIR CoNDrnoNING —

~IFI~IGKRATIONSYSTEM


TEMPESTGRAND FEll

PARTS CATALOGUL

Group No. Part Na. 1968

1 — GASKET, Ambient Switch2 — SWITCH, Ambient3—SCREW (#818 x 1/2”)4 — RESISTOR, Motor

RESISTOR, Motor (1972)5— RELAY, Hi Blower

RELAY, Hi-Blower (1972)6— SCREW (‘I0.—i6 x 1/2)7—WIRE, Control

8— HARNESS, Engine (6—Cyl.)9— FITTING ASM., Camp. (6—Cyl.)

(8-CyI. Pont. Erg.)(8-Cyl. Chev. Eng.)

10 — COMPRESSOR,Conditioner (Less Heat Switch)COMPRESSOR, Conditioner (With Neat Switch—1971-72)

— LOCKWASHER (5/16”)12— LOCKWASHER (3/8’)13 — CABLE, Ground (6—Cyl.)24— WIRE, Temperature Gauge Jumper (&Cyl.)IS — COVER TerminalIA — NUT (~12—24)17— LOCKWASHER (#12)18— CLIP, Wire19— CLIP, Wire20— SCREW (#10-16 x 5/8”)21 — SCREW (2/4—IA x 1”)22—WASHER (1/4” x 3/4”)23— LIMITER MM., Compressor Protection Thermal (1971-72)24 — WIRE MM., Compressor Protection25 — SWITCH KIT, Super Heat Shut—Off (1971-72)

+Exc. Rear Window Defogger

44w/Rear Window Defogger (Not Re~’d. jot 1971-72 use 62991151

GROUP 9.000 )UJJSThAT)ON 20

9.2759.2758.9779.2759.27502759.2758.9779.276

2.4809.226

9.1709.1708.9328.9322.34?2.4802.3238.915

2.482

8.9 778.9778.9779.1729.2 769.172

3917361979263894196639798125

4870899788001481974

941930362933036299115+8903 755 -t-

See Data479339

9781240736482

59104956598423

138485138489

See Data89036301483218

121743N .S.

See DataN.S.

9419321451627N.S -

65564.4089086516599306

x xx )( xx x

x xx

x xx

x x xx

K Kx

x x xK K KK K K

xK K X

KKK K

K KK KK Xx KK KK KKx xK KK Xx K

K K

KKK

KKKxKxx

hiM

Key

1968-12 TEMPEST CUSTOM AIR CONDITIONING — ELECTRICAL PARTS

Part Name 1969 1970-72

IGM TEMPESTLS2~K

Ccv Part Name

1 — CONTROL,Air Conditioner — With Water Valve on 1971

—1971 Without Water Valve —1972

2—VALVE, Heater Control Vacuum (Upper)

3—VALVE, Heater Control Vacuum (Lower)

4— CLIP, Vacuum Hose Retaining (Long)

5 — SWITCH, Heater Control — Vent

6—CLIP, Vacuum Hose Retaining (Short)

7—SWITCH. Master

B — HARNESS, Vacuum Hose — With Water Valve on 1971

— 1971 Without Water Valve —1972

9—GROMMET, Hose thru Dash

10— CLIP, Hose to Vacuum Line

11—VALVE, Vacuum Check

12—INLET & VALVE, Air

13—SCREW,Cableto Bracket (#l0—16x 1/2”)

14— CABLE, AC. & Heater Temp. Cant

IS — WIRE, AC. & Temperature Control

16— SWITCH, Blower Motor

17—SUPPORT,Control — Less Relay AttaChing Tab on 1972— 1972 with Relay Attaching Tab

Part No. Part No.1969 1970-72

7307822 7311882

— 7938562

7309067 7309067

7309068 7309068

545883 —

7308869 7308859

646884 —

7308868 7308858

9796776 9796776

— 486220

9798023 9798023

540029 —

9787802 9787802

3018596 3018596

9419303 9419303

9784763 9784763

6299116 6299116+— 8903756++

7308842 7311846

9797232 9797232— 487954 8.852

1969-72 TEMPEST GUSTOM AIR CONDITIONING — CONTROL PARTS

Group No.

9273

9.273

9.279

9279

9.28 1

9276

9.281

9.27 5

9.28 1

9281

9.776

3.162

9.28 1

9.789

8977

9281

9.27 69.275

9.275

6852

+Exc. RearwindowDefagger +-*w/RearWindowDefogger (Not Required for 1971-72 use 6299116)


TEMPESTGRAND PHIX ~1

PARTS CATALOGUE

1973-74 LEMANS & LUXURY (“AD”, “AF” & “AG”) CUSTOM AIR CONDITIONING — CONTROLS


TEMPESTGRAND P31K I

PARTS CATALOGUE

Key Pert Name

I — HARNESS, A.C. Oat Wire

2— HARNESS, A.C. Vacuum Has - Heater End

3—CAPACITOR, Radio Suppression

4— RETAINER. Vac. Hose Ham... to Diaphragm

5 — CABLE PKG., Control

6— HARNESS, A.C. Vacuum Hens - Control End

7 — VALVE, Heater Control Vacuum (9 Pan)

8— HARNESS, A.C. Control Wire

9—SWITCH, Compressor Ambient

10— RESISTOR, A.C. Blower

11 — RELAY, A.C. HI-Blower

12— BRACKET, Relay Mounting

IS—VALVE. Heater Water

14— FUSE, Comp. Proteotion Thermal

15— TANK, A.C. Vacuum Canal

16— CONTROL, Hemter & A.C

17—SWITCH.BIowsr

18— CAM, A.C. & Hflr Control Cable

19— VALVE, Hester Control Vacuum

Part No, Group No.

6910978 927W

486409 9.281

1960867 8.863

— N.S.

3862203 9.787

490156 9.281

7932346 9.278

8910977 9276

483326 9.275

487892 9.275

48i 794 9275

491372 9.278

481375 9.796

6666440 9172

385076 9.281

7935082 9273

7932131 9.275

7932804 9275

7932345 9.279

1973-74 LEMANS & LUXURY (“AD”, “AF” & “AG”) CUSTOM AIR CONDITIONING — CONTROLS


TEMPESTGRAND PRIK

PARTS CATALOGUE

1969-72 BLOWER AIR INLET & VALVE ASM.

Key Part Name

I — SCREW (#1016 ,c 3/4’)

2 — PIN & FLANGE, Mounting

3— DUCT, Inlet

.4— GASKET, Duct

5— INLET & VALVE, Air (Tempest)

(Grand Prix)6—SPRING, Valve

7 — DLAPNPAG~A,Air Inlet (tempest)

(Grand Prix)

8—SCREW(#I0-.16 x I’)

Group No. Part No.

9.2159.2159.799

9.789

9.7899.281

N.S.

30140713014866

3018642

301859630178423014068

19989421998943

N.S.

1GM

1

8

1969 1970-72

xxxxxxxxxx

xxxxxxKKx


Key

1GM TEMPESTGRAND FUJI

PARIS CA IALOCUE

Part Name

1 — VALVE, Vacuum Check

2—HOSE,Valve to Harness (5132’iD.)

3—CABLE,Control (to Heater)

4—RETAINER, Hose to Heater

5—SWITCH,Heater Cant. Vent

6—VALVE. Heater Cant. Vacuum

7—CLIP. Vac Hose Retaining (Long)

8 — CLAMP, Throttle Valve Brkt

9—VALVE,Suction Throttle

10—HARNESS, Vacuum Hose —1969-70, With Water Valve on 1971

—Without Water Valve—1971-72 .

11 — CONTROL, Air Conditioner —1969-70, With Water Valve on 1971— 1971 Without Water Valve—1972

12—CLIP, Harness Retaining

13—SWITCH, Master

14—SWITCH, Blower Motor

15—VALVE, Heater Coot. Vacuum

16—CLIP. Vac. $OSe ~Btaining~ShOT¶~

17—HARNESS, Temp. Cont.—1969-70 (EXC. Defogger)—1971-72 All(Wllh Defogger)—1969(With Defogger)—1970

18—CABLE. Control (to Control)

19 — CLIP, Wire to Duct

20— GROMMET,Hose & Wire Thru Dash

1969-72/276 CUSTOM AIR CONDITIONING — CONTROLSPart No.

978780239873639798961

7308374

7309768

545883

9779400

5910704

979,6664

9795670

730787 27938632

7936832

7308373

7308293

7309767

5468846299121

62992858903758

9798960361665997 98023

Group No.

t28 1

9.281

928 1

NE.

9.275

9.279

9.28 1

9.196

9.198

9.281

92819.273

9273

9.273NE.9275

9.275

9.279

9.281

9.276

9.2769.276

9.281

2.6599.775

GROUP 9.000 ILLUSTRATION 2S

TEMPESTGRAND Pull I

PARTS CATALOGUE

1973-74 GRAND AM & GRAND PRIX (“AH” & “GK”) CUSTOM AIR CONDITIONING — CONTROLS

1GM

GROUP 9000 ILLUSTRATION 26

TEMPESTGRAND P111K

PARTS CATALOGUE

Key Part Name

I — HARNESS, A.C. Dash Wire

2 — HARNESS, A.C. Vacuum Hose-Heeter End

3—CAPACITOR, Radio Suppression

4—RETAINER, Vac. Hose Harness to Diaphragm

5—CABLE PKG., Control

6—HARNESS, A.C.Vacuwn Hose-Control End

7—NUT (118” ID. x 7/16 O.D. Push On)

B — VALVE, Heater Control Vacuum (9 Pan)

9—HARNESS, KC. Control Wire

10— SWITCH, Compressor Ambient

11 —RESISTOR,A.C. Blower

12— RELAY. AC. Hi-Blower

13— BRACKET, Relay Mounting

14— VALVE, Heater Water

15— FUSE, Comp. Proteotion Thermal

16— TANK, A.C, Vacuum Control

17— CONTROL, Heater & A.C

¶6 —SWVTCH, Blows.

19—CAM. A.C& Hearer Control Cable

20— VALVE. Heater Control Vacuum

Part No, Group No.

8910978 9.276

488409 9.281

1960867 9.663

— s.S.

3682203 9.787

490156 9281

— 8.5.

7932348 9.279

8910977 9.276

483326 9.275

467892 9.275

481794 9.275

491372 9.279

481375 9.796

6566440 9.172

385076 9.281

7935182 9.273

7832131 8.275

7932904 9.275

7932345 9.279

S.3. - Standard Stock

1973-74 GRAND AM & GRAND PRIX (“AH” & “GK”) CUSTOM AIR CONDITIONING—CONTROLS


TEMPESTGRAND P111K

PARTS CATALOGUE

1969-72 GRAND PRIX CUSTOM AIR CONDITIONING — INTERIOR AIR SYSTEMPart No. Part No.2969 1970-72Key Part Name

1 — NOZZLE, Defroster Air2 — DUCT, Air Outlet — Center3 — NUT, Duct to Outlet4 — DEFLECTOR, Center5 — DUCT, Air Outlet - LH6 — CLIP, Duet to Outlet7 — DEFLECTOR, Outer — LH8 — PANEL, Finish9—INLET & VALVE, Air

10—SEAL, Auxiliary Outlet — R.H1! — NUT, Adapter to Pad12 — ADAPTER, Auxiliary13 — RETAINER, Deflector — R.H. (Felt)14 DEFLECTOR, Outlet — LowerIS — DUCT, Air Main . . - - . -

16—SCREW, Duct to Case (I 10:24x 5/8”) . - -

17 — SEAL, Auxiliary Outlet — LH18 — RETAINER, Deflector Spring19 — RETAINER, Deflector — L.H. (Felt)20 — BEZEL, Aux. Air Outlet (w/Console)

BEZEL, Aux. Air Outlet (Exe. Console) -

21 — SCREW, Bezel to Plate (‘8—18 x 5/8’)22— NUT, Inner Duct to Air Duct (#10~16 ‘U”).23 — SCREW, Duct to Air Duct (10—16 x 1/2”) -

24 — DUCT, Air Outlet — Inner — L.H25— DUCT, Air Outlet — Outer — L.H26— SCREW, Case to Dash (1/4” —14 x 1”) ...

27 — SEAL, Duct to Heater28 — CASE, Heater29 — SEAL, Tubes Thru Deal,30 — DEFLECTOR, Outer — L.H

9796008979579694228369796679979637524226989796680See Data3017842

54569597946369795908979467097904009795925

5456969796893530067481875481726

9422836941930397823969795789

4516179796501302046097923629796682

1GM

97960089795796942283697966799796375

4784409796680See Data3017842

4802259794-636979590897763999790400480254

4802269796893530067481875481726

9422836941930397823969795789

4516179796501302046097913629796681

Group No.

9.7799.2628.92 19.2629.2629.2629.262

24.63097899.2609.2759.2629.2629.2629.786N.S.9.2609.2629.2629.2649.264N.S.8.92183779.2629.2628.9779.2628.8646.6549.262


TEMPESTGRAND P321K

PARTS CATALOGUE

NOTES

TEMPESTGRAND P11K

PARTS CATALOGUE

4

1973-74 GRAND AM & GRAND PRIX AIR CONDITIONING — INTERIOR AIR SYSTEM


TEMPESTGRAND P1111

PARTS CATALOGUE

Key Part Name

1 — NOZZLE, Defroster

2—SCREW, (#10-16 x 3/4”)

3—COMPARTMENT,Instrument Panel

4 D~FL~CTOP, Outer Air flH

5— RETAINER Auxilliary Air Outlet

B — RETTAINEF, Center AIr Outlet Valve

7—DEFLECTOR, Distributor Duct

8— DEFLECTOR, Center Air

9— CORE & CASE, Healer & Air Conditioning — w Manual AC..w Auto AC.

1O—SCREWJ1/4”-14x1 1/2’)

11 — OUTLET ASM., Heater Air (Exc. Console)

12— SCREW. (#10-16 x 5/8”)

13— OUTLET ASM., Heater Air (w/Console)

14— DUCT, Center Air Outlet

15—SCREW, (#8-18x 5/8”)

16— DUCT, Air Outer-LA-I

17—NUT (#8-18 U’)

18— DUCT, Air Inner-L.H

19—SCREW(#10-16x 5/8”)

20—DuCt Inner Ext.-L.H

21 — DUCT, Air Distributor

22 — SEAL, Air Dist. Duct to Heater

23— ADAPTER, Air Dist. Duct to Heater

24 — SEAL, Air Distributor Duct

25— DUCT, Air Outer-RA-I

26— DEFLECTOR, Aux. Air Outlet-L.H

27—COVER, Inst. Panel-Lower

28— STUD, IP. Lower Cover to Lw’. Reint

29—WASHER, P. Lower Cover to Lower Reinf

30—TRIM PLATE, Instrument Panel

31 — SCREW (#8-18 x 5/8”)

32— DEFLECTOR, Inst. Panel Outer Air-L.H

33— CAM, P. Lower Cover to Lower Reinf -Locking

34—PAD ASM., Instrument Panel

1873-74 GRAND AM & GRAND PRIX AIR CONDITIONING — INTERIOR AIR SYSTEM

Part No.

484777

485633

$700020

481155

9776399

9790400

485087

30238183024642

484662

189361

484456

484332

9428582

484328

9417488

484331

189361

484330

484327

484421

484422

490065

484329

485660

487813

486238

486237

See Data

9428582

485085

486236

See Cat.

Group No.

9.779

N S.

10.260

0.202

9.262

9.262

9.262

9.262

8.8548.854

N S.

9.786

8.977

9.786

9.262

8.977

9.262

8.921

9.262

8.977

9.262

9786

9.786

9.262

9.262

9.262

9.262

6760

6.760

6.760

10.252

8.977

9262

6.760

14.655


Part Name Part Na. Part No, Part No, Group No.1969 1970 1971-72

1 — EVAPORATOR Conditioner 3018031 3022064 3023614 . 92102— TUBE, Valve to Hose 9797015 9797015 9797015 9.2293—GASKET. Valve 3/4”) 3140852 3140852 3140852 9.2144—CLAMP, Valve 9779400 9779400 9779400 9,1965—VALVE, Suction Throttle 5910704 5910704 5910704 9.1986— GASKET, Valve 13/16”l.D.) 8526645 8526645 8626645 91987—FITTINGS & MUFFLER, Compres 9781240 9781240 9781240 9.2268—SUPPORT, Muffler to Compressor 546654 546654 481590 9.2429—CLAMP, Muffler to Support 9777203 9777203 9777203 9.242

10— BOLT, Support to Compressor (5/16—24 x 3/4’) 444684 444684 444684 8.90011 — COMPRESSOR, Air Conditioner 5910495 5910496 See Data 9.17012— BOLT, Muffler to Compressor 13/8—24 ‘<1”) 454922 454922 454922 8.90013— LOCKWASHER, Muffler to Compressor 13/81 120382 120382 120382 8.93114— GASKET, Pipe to Receiver (3/SI 8526398 8526398 8526398 9.21015— CONDENSER, Refrigerant (For 1972 use 3025901) ... 3018267 3018267 3018267 9.19016— SCREW. Condenser to Baftle 11/4—14 x 3/4”) 9425451 9425451 9425451 &97717—CLAMP, ReceiverSupport 9791641 9791641 9791641 9.20618— RECEIVER, Refrigerant 3015061 3015061 3015061 9.19519— NUT, Condenser to Bafflet 1/4—20) 9419844 9419844 9419844 8.92120— TUBE, Receiver to Hose 9790748 9790748 9790748 923121 — HOSE & COUPLING, Receiver to Evaporator — — 9.23122— HOSE & COUPLING, Compressor Di~harge — — — 913123—SPACER, Hose 9797912 9797912 9797912 924224— SCREW, Motor to Case (48—18 x 3/41 — — NS.25— TUBE, Motor Cooling 9785473 9795473 9.785473 9.21826— MOTOR, Evaporator Blower 4914916 4914916 4960538 9.21527— IMPELLER, Blower Motor 9785483 9785483 3027062 9.21628— LOCKWASHER, Impeller to Motor (#101 120217 120217 120217 8.93129 — NUT, Impeller to Motor (~10—32) 120814 120614 120614 8,91530— HOSE, Compressor Suction 15/81 D x 23 I 9798788 9798788 9798788 8.96231 — CLAMP, Hose 3909030 3909030 3844490 9.24232— SPACER, Discharge Hose (Double) 480319 480319 480319 9.22533— TUBE, Discharge 480318 480318 480318 922534— SPACER, Discharge Hose (Singlel , 480317 480317 4803)7 9.225

PARTS CATALOGUE

1969-72 GRAND PRIX CUSTOM AIR CONDITIONING — REFRIGERANT SYSTEMKey


[GM TEMPESTGRAND P31K I

PARIS CATALOGUE

NOTES

TUMPUSTGRAND FUJI

PARTS CATALOGUE1GM

1’

1973-74 GRAND PRIX (“GK”) AIR CONDITIONING — REFRIGERATION SYSTEM

GROUP 9OOO ILLUSTRATION 34

riu.U GRAND PHIl

RiM’__TEMPESTwu!atwmaE.uE1EE1E

Key Part Name

I — RESISTOR, AC. Blower -

2 — PLATE, Resistor Hole Cover

3— TUBE ASM., POAto Suction Hose

4—GASKET, AC. ‘0” RING

5—HOSE, Freon (¾”x 15 ft.)

6— COMPRESSOR, A.C

7 — VALVE, Heater Water

8—HOSE (3/4” x5Oft.)

9—CLAMP, Heater Hose

10— HOSE (5/8” xSOft.)

11 — CLIP, Hose to Skirt

12— CLIP, Heater Outlet Water Hose

13— MUFFLER & FITTING, Compressor —Exo. VIR. System—With VIR, System

14— HOSE. Camp. Discharge (‘/2” x 15 ft.)

15— CLAMP, Refrigerant Hose (7/16” to 3/4”)

IS— BRACKET, Sad. Support Mtq. Upper - L.l-f

17— BRACKET, Red. Support Mtg. Lower - LH

18— CONDENSER, A.C

19 — VALVE, Thermo Expansion

20—GASKET, AC. 0” RING (¾”)

21 — TUBE ASM., Refrig. Hose to Evaporator

22 — HOSE, Freon (5/16”)

23— CLIP. Heater Outlet Water Hose

24 — BRACKET, Red. Support Mtg. Upper - R.H

25— BRACKET, Red. Support Mtg. Lower - R.H

26— GROMMET, Receiver Tube to Red. Baffle

27 — TUBE, Condenser to Receiver

28— SCREW (1/4”-14 )c 3/4”)

29— BRACKET, Receiver Mount

30—RECEIVER & LIQUID INDICATOR

31 — TUBE ASM., Refrig. Hose to Receiver

32 — MOTOR ASM., A. C. Evaporator Blower

33 — IMPELLER, Evap. Mtr, Blower - (Plastic)

34—EVAPORATOR & BLOWER DUCT (Use

Part No, Group No.

487892 9.275

489937 9275

9795513 9.229

3140652 9.214

230885 8.962

6598423 9.170

481315 9.795

482420 8.962

— S.s.

482434 8.962

— ItS.

491945 9.260

486065 9.226488808 9.226230884 B.962

486045 9225

488192 9.190

488317 9.190

3024887 9.190

5910786 9.213

8526398 9214

3015135 9.231

230882 . 8962

491945 9.260

488191 9190

488316 9.190

2389296 9.775

See Data 9.227

9425451 8.977

488435 9.206

30129~ 9.195

3015712 9.231

3027939 9.215

3027062 9.2 16

Components) N.S.

5910693 9.19835 — VALVE, Suction Throttle

1973-74 GRAND PRIX (“GK”) AIR CONDITIONING — REFRIGERATION SYSTEM


TEMPESTGRAND PHIl

PARTS CATALOGUE

Part Name

1 — GASKET, Switch to Evaporator

2—SCREW,Switch to Evaporator (t8~lB x 1/2’) , - -

3 — SWITCH, Compressor Asrbient

4 — RELAY, Defogger Interlock (w/Elec. Defogger)* -

S — RELAY, Hi—Blower (1969-71)

RELAY, Hi-Blower (1972)

6— SCREW,Relay to Dash (#10~16 x 1/2”) - -

7 WIRE, A.C. Jumper — Engine

8— CLIP, Wire to Strop

9— HARNESS, Eng. Compartment thro Dash—1969-7O

HARNESS, Eng. Compartment thru Dash (wfElec.

HARNESS, Eng. Compartment thru Dash (w/EIec.

10— RESISTOR, Blower Motor (1969-71)

RESISTOR, Blower Motor (1972)

— CLIP, Wire Harness

12— CLIP, Wires to Shroud

13 — SHIELD, Air Cond. Wiring (1971)

14— SWITCH KIT, Super I-feat Shut—Off (1971-72) - -

IS— WIRE MM., Compressor Protection (1971) -

(Exc. Elec. Defogger)—l 971-72 All

Defogger) (1969)

Defogger) (1970)*

— UMflER ASM., Compressor Protection Thermal (1971-72) -

*lte,,,s not req’d for 1971-72 defogger usage.

1GM

1969-72 GRAND PRIX CUSTOM AIR CONDITIONING —

Key Part No.

3917361

9419663

9792638

9792815978800!

481794

Group No.

9275

8.977

9175

9.778

9.275

9.275

9419303 8.977

6297482

62991206299284

8903757

9777412

479090

9782572

979775!

4040876599306

8908651

9.276

N.S.

9,276

9.276

9.276

9275

9275

9.28 1

2559

9276

9.172

9.276

6556440 9272


Key Port Name

— ASPIRATOR, In—Car Sensor

2 — RIVET, Aspirator to Case (1/8 x 3/8’)

S — HOSE, Sensor to Aspfrator (9 1/2 Long) - - . -

4 — CASE, Heater Core

S — LINK, Power Servo to Hooter

6-- SCREW. Link to Programmer (#8 - 32 x 3/8’)

7 — PROGRAMMER, A. C. Control

B — SWITCH, Dc-Ice

9 INLET & VALVE, Air

TO — CONTROL,Air Conditioner

1! — SWITCH, Blower Motor

12 — SWITCH, Master

13 — VALVE, Heater Control Vacuu,n

14— HARNESSr Vac. Hose

IS — VALVE, Heater Water Temperature

1969-72 GRAND PRIX AUTOMATIC TEMPERATURE AIR CONDITIONING — CONTROLS

Part No.2969

9787684

9796665

3018682

7311292

9419623

7310432

7320009

3017936

7938642

7320008

7308373

7310004

9797261

1231105

Part No.1970-72487308

9796665

3018682

7311192

942 9623

7323332

7310009

3017936

7938642

7310008

7308373

7310004

979Th”

1231105

Group Na.

9.275

N.S.

9.275

8.854

9.250

8.977

9.275

9.275

9,789

9.273

9175

9.275

9.279

9181

9,95


TEMPZBTGRAND Ems

PARTS CATALOGUE

1973-74 GRAND AM & GRAND PRIX (“AN” & “GK”) AUTOMATIC TEMPERATUREAIR CONDITIONING—CONTROLS

</

~O~W9.1?JOD flAUSTRAIION 38

TEMPESTGRAND P31K I

PARTS CATALOGUE

Key Part Name

1 — HARNESS, AC. Vacuum Hose - Heater End

2—HARNESS. AC. Dash Wire

3—ASPIRATOR& SHIELD, In-Car-Sensor

4—RETAINER,Htr. Link to Temp. Cant. Lever

S — LINK. Programmer

6—PROGRAMMER,A.C

7 — CAPACITOR, Radio Suppression

8— NUT, yea. Hose Harness

9 — BRACKET, Programmer Mtg.-Front

10— GRILLE. In-Car-Sensor

11 — HARNESS, AC. Control Wire - - -

12— HOSE, Sensor to Aspirator

13—SPACER, In-Car-Sensor

14—SENSOR, In-Car

15 — SWITCH, Comp. Ambient

16 — PLATE, Resistor Hole Cover - -,

17 — SENSOR, Camp. Ambient

18—RELAY, Purge

19—RELAY, Blower-on

20—RELAY, Hi-Blower

21 — VALVE. Heater Water

22 — SWITCH. Cold Temp. Override

23— FUSE, Corn p. Protection Thermal

24— TANK, A.C, Vacuum Control

25— CONTROL, Heater and AC

26 — VALVE, Heater Control Vacuum (9 Port)

27 — HOLDER, Light Guide

28— HARNESS, AC. Vacuum Hose-Control End

28 — BRACKEt Programmer Mtg-Rear

30—SWITCHKIT, Super Heat Shut Off

Part No, Group No.

488261 9.281

8910980 9.276

491419 9.275

1484109 9.786

7937452 9,275

7939192 9275

1960957 9.663

— es.

488589 9.275

1236060 9275

8910979 9.276

9796665 9.275

1243790 9.275

9340352 9.275

See Data 9.276

489937 9275

9340902 9.275

463694 9.275

483694 9.275

483694 9.275

487375 9.795

- 6490043 9.275

- - - 6555440 9.172

-. - 386076 9.281

- 7935282 9.273

- - See Data 9280

- 6294200 9.275

- 488267 9.281

- 488555 9.275

6599306 9172

1973-74 GRAND AM & GRAND PRIX (“AH” & “GK”) AUTOMATIC TEMPERATUREAIR CONDITIONING—CONTROLS

GROUP 9,000 ILLUSTRATION 39

LGM

Irm.I GRAND P111K

TEMPEST I

1969-72 GRAND AIR CONDITIONING — ELECTRICAL PARTSPart No. Part No.

Key Port Name 1969 1970-72 Group No.

I — SWITCH, De-Ice 7310009 72\000 9.275

2 — CONTROL, Air Conditioner 7938642 7938642 9.273

3— SWITCH, Blower Motor 7310008 7310008 9.275

4— SWITCH, Master 7308373 7308373 9,275

5— NUT, Sensor to Pod 9794636 9794636 9.275

6— SWITCH, Si—Level—On Case 7309762 7309762 9275

7— RELAY, Defogger Interlock (w/Elec. Defogger 9792%5 9792815 9.7788— RELAY, Master 9792815 9792815 9.275

9 RELAY, Hi—Blower 9788001 9788001 9.275RElAY Hi-Blower (1972) — 481794 9.275

10—HARNESS, Engine Compartment thru Desh (cxc. Defogger) 6299122 — 9276

HARNESS, Engine Co,rpertment thro Dash Iw/Defogger)’ 6299282 — 9.27612 — RESISTOR. Blower Motor 1969-70 (cxc. Defogger)—2971 All 9796513 9796513 9.275

RESISTOR, Blower Motor (w Defogger 9797559 479673 9.275RESISTOR. Blower Motor—1972 — 407090 9,275

12— CLIP, Wires to Shroud 9797751 9797751 2.559

13—SWITCH, Compressor Arbient 7320322 7310322 9275

14—GRILLE, Sensor 9797298 9797298 9.275

15—SENSOR, In Car 9797349 9797349 9.275

16— WIRE, Temperature Control—1969-70 (cxc. Defogger)—1971-72 All 6299123 6299123 9.276

WIRE, Temperoture Control (w/Defogger)* 6299283 8903759 9276

7— VALVE, Heater Vocouni 7310004 7310004 9.279

18— SHIELD, Air Conditioning Wiring (1971) — 484087 9.27619— FUSE., Compressor Protection Thermal (1971-72) — 6556440 9.172

20— WIRE ASM., Compressor Protection (1969-71) 8908651 8908651 9.276

21 — SWITCH KIT, Super Heot Shut—Off (1971-72) — 6599306 9.172

items Not Re~d for 197t-72 Defogger Usage

21

// ~<

1sf

yzt~ <I

1KI,

PRIX AUTOMATIC TEMPERATURE


IGM I TEMPESTGRAND PHIl I

AUTOMATIC TEMPERATURE AIR CONDITIONING PROGRAMMER ASM.1969-72 GRAND PRIX

Key Pert Name

1 — HOUSING, Upper2— BOARD, Amplifier

3— MOTOR, Programmer (IncI. Gear)

4—GEAR PKG.. Programmer

5—HOUSING, Lower

8—BOARD, Resistor

7—VALVE, Vacuum

8 — WHEEL& RESISTOR, Programmer

9 — BLOCK, Finger — Upper

Group No.

9.275

9.275

9275

9.275

9.275

9.275

9.275

9275

9.275

Part No.

7311517

1222981

5044682

12227201222918

7301502

7300343

1222721

7305935

1969

x

1970-72

Kx xx xx xK K

K K

K K

K K


I6M~ TEMPEST I

1073-74 “AN” & “GK” AUTOMATIC TEMPERATURE AIR CONDITIONING PROGRAMMER ASM.

Key Description Part Na, Group

1 COVER, Programmer2 VALVE ASM,, Programmer Vacuum

3 SPRING, Vacuum Valve

4 CIRCUIT BOARD, Programmer Resistor Blower

5 TRANSDUCER, Programmer

6 SHAFT, Mix Door Operating

7 SPRING, Programmer Power

8 BASE, Programmer

9 CLIP, l-Ieatsink Retainer

10 CIRCUIT BOARD PKG., Programmer AmplifIer

11 CONNECTOR,Programmer

12 RETAINER, Male Connector (Plastic Rib)

13 RELAY, Programmer Check

14 MOTOR, Programmer Vacuum

15 ARM MECHANISM, Feed-Back Potentiometer

16 SWITCH, Blower Motor—with Bearings

17 STUD, Vacuum Valve Mtg

18 INSULATOR Heatsink—N.S.S, Part of Key #10

19 RETAINER, Power Spring

7932554

9340126

7932535

7938836

7932545

9340130

7932552

7932516

1223 165

7939007

7935792

7930501

1 223462

7937916

1223114

7932544

7933230

9,275

9.2 75

9.2 75

9.275

9.2 75

9.2 75

9.275

N.S.

9.275

9.2 75

9.275

9.2 75

9.2 75

9.2 75

9.275

9.275

9.275

9.2 75


[GMGRAND PXIK

key Description Part t-4o. Group

I SCREW, Inlet Connector Shell 1973—1974—

2 SHELL ASM., inlet Connector3 SCREW AND WASHER, Capsule Retaining

1973—1974—

4 BAFFLE, Valve5 SEAL, Valve “0’ Ring6 VALVE, Suction Throttling7 SEAL, Connector Shell to Housing ...

8 HOUSING. VIR. Valve fInd. #10 & #12)9 SEAL, Sight Glass 1973—

1974—10 GLASS, Sight Kit11 CAP, Valve12 CORE, Evap. Corn. Vetve

65994526556487

6599443

65994666551143

655655965365246599444

6556526659944665004626536527

659945259117373027593

9.1959.195

9.195

9.2149.2 149.1989.1969.1989.196

9.1959.2029202

9.202

9.2269.210

Description Part Na. Groop

13 SEAL, Expansion Valve Center

14 VALVE, Expansion .

15 SEAL, Expansion Valve tower16 CORE, Bleed Valve17 SEAL, Pick-up Tube18 SEAL, Valve I-lag. to Shell29 TUBE, Pick-up Kit .~ 7973—

1974—20 RING, Pick’up Tube Retainer 1973—

1974—22 SCREEN, Pick-up lob.22 DESSICANT, Drier Kit 1973—

2974—23 SHELL KIT, Receiver Kit

24 SCREW. Receiver Shell Mounting 1973—

1974—

1973-74 VALVES-IN-RECEIVER UNIT (V.LR.)

6556523659944565565275914817

659946165565256599450

659883165994546556489659945565994496598832

659944865994526556481

9.2 149.2 23

9.2149.1989.296

9.1969.7959.1959.1959,959.1959.1959.1959.195

9.1959.195

GROUP 9.000 ILLUStRATION 43

GRAND PRIXTEMPEST I

Hose Fining Packages end Related Parts, Air Conditioning Refrigerant

ThREAD HOSETYPE SIZE I. 0.

A 11/16-16A 5/8-16A 3/4-18A 7/8-18A 1- 1/16-16A 5/8-18A 314-18

B 5/8-18B 3/418B 7/8-18B 1 1/16-168 5/8-18B 3/4-18

C 11/16-16C 5/8-18C 11/16-16C 3/4-18C 7/8-18C 1 1/16-16C 5/8-18C 3/4-18

D 5/8-18D 3/4.16D 7/8-14D 1 1/16-14fl 518-18D 3/4-16D 7/8-14

5/165/16

13/321/25/8

13/321/2

5/1613/32

1/25/8

13/321/2

5/165/16

13/3213/32

1/25/8

13/321/2

5/1613/32

1/25/8

13)221/25/8

PARTNO.

30236743023675302367600300~7302367830236793023680

3023657302366830236592023660302366130236623023663

30245343023711302371230237133023714

30236823023683302 3Q843023685

3024b363023GM302366530236663023667

THREAD HOSETYPE SIZE 1.0.

E 5/8-18E 3/4-16E 7/8-14C 1 1/10-14

E 5/8-18E 3/4-162 7/8-14

F 5/8-18F 3/4-16F 7/8-14

I 1MB-IAF 5/8-18F 3/4-16F 7/8-14

0 5/8-180 5/8-180 3/4-16G 7/8-140 1 1/16-14

H 5/8-18H 3/4-16H 7/8-14H 1- 1/16-14

5/8-18.1 5/8-18a 3M-IsJ 7/8-14J 1 1/16-14

5/1613/321/2c/a

13/321/26/8

5/1613/321/2BIB

13/321/25/8

5/1613/321/25/85/8

13/321/25/85/85/16

13/321/25/85/8

PANTNO.

3023686302368730236880020000

30237183023719

30247913023722

3023715

3023718

3023717

3023721

3023720¶3981880¶3923139¶3970641

30247883024789

FITTING

ThREAD HOSETYPE SIZE 1.0.

KKKK

LL

M

Ml

N

N0

P

aR

S

T

U

V

ONLY

5/1613/32

1/20/0

1/25/8

5/8-1S(Mal.) 5/161/16-14 (F.mal.)5/8

13/32

1/2

5/8

13/32-5/8

13/321/2

1/2-5/8

1/2-5/8

5/8

13/32

HOSE FITTINGS PACKAGES INCLUDE “0” RINGS AND CLAMPS REO*D. FOR INSTALLATION.

ifA

riflflrrPART

NO.

302463S30236913023692JUZJbYJ302369430236953023696

302366830236693023670302367130236723023673

30245373023651392575130236523023853302365430236553023656

3023697302369830236993023700202270130237093023710

HOSE, CLAMP, O’RINGS

230982 Hoae. RefrIg. (5/16” 1.0. xli’) 8526U8 O’plIng (3/8” LDJ230683 Hose, RefrIg. (13/32” I.D. xli’) 3140600 O’RIng (1/2” leO.)230684 Hose, RefrIg. (1/2” .0. xli’) 3140748 0’RIwq ~5/V’ I.Dj230685 Horn, Refrlg. (5/8” .0. xii’) 3140662 0’RIng (3/4” 1.0,)

8887097 O’RW.g, FIttIng to Cemp.0009030 Cbmp, Adi. Horn (v~Ith Locror Teb)


TEMPESTGRAND PHIl I

PARTS CATALOGUE

Key Part Name

—. DEFLECTOR, Shroud Centre Duct Panel Outlet (L.H. Only)

2 — OUTLET, Center Panel Duct—Outer—L.H

3—DOOR. Shroud Duct Air Outlet Ann. —LM

4 — DOOR, Center Duct Air Outlet Asm.—Cent.r

5—CLIP, Shroud Duct Outlet Doors (1” Long)

6 — OUTLET, Center Duct Air—Centyr

7—DOOR, Shroud Duct Air Outlet Asm—R.H8 — OUTLET, Center Panel DUct—R.H

9— DUCT, Upper Lava) Vent

10— BRACKET, Upper Level Vent Duct Mounting

11 — CLIP, R. & L. Cent. Cable to Shroud Duct Outlet Aim

12— BRACKET, Vent Control to Inst. Par,eI—R.H

13— CLIP, Control Cable to Fin. Panel—Inside14— CONTROL, Lower Vent—RH

16— PLATE, P. Outlet Opening Cover—R.H

16— DEFLECTOR. Center Air

17— BRACKET, Vent Control to Inst. Panel—LH

18 — CONTROL, Lower Vent—L.H

19—CABLE. Upper Level Vent (Use Cable Pkg.)

20— CONTROL. Shroud Side Air Duct Panel—Upper

21 — BRACKET, Upper Level Vent Control Cable Mounting

Group No.

918997899.7899.789

9.7879-79993899.7899.786

9.786

9.7879.78793879-797

10.2669282

9-787

9.78793879.7879.787

1073-74“AD”. “AF” & “AG” VENTILATION CONTROL (EXC. AC.)


TEMPESTGRAND PHIl I

PARTS CATALOGUE

Key Part Name Group No.

1 — GRILLE, Shroud Duct Air Outlet (L.H. Only)2— OUTLET, Center Panel Ducs—Outer—L.H

3 — DOOR, Shroud Duct Air Outlet Astm—LH.

4 — DOOR,Center Duct Air Outlet Asm.— Center

5—CLIP, Shroud Duct Outlet Doors (1” Long)

6 — OUTLET, Center Duct Air— Center ..

7 — DOOR,Shroud Duet Air Outlet Auti.—R.H,

8—OUTLET, Center Panel Duct—Outer—RH

9—DUCT, Upper Level Vent

10—CLIP, R. & L. Cant. Cable to Shroud Duct O~ Jet Aim

11 —CflNTROL, Lower Vent—R.H

12—CLIP, Control Cable to Fin, Panel—Inside

13—BRACKET,Vent Control to Inst. Panel—R.H

14—PLATE, P. Outlet Opening Cover—R.H

15—DEFLECTOR,Center Air

16—PLATE, Inst. Panel Trim

17—CONTROL,Shroud Side Air Duct Panel—Upper

18 — NUT, Cable to Control

19—SCREW,Cable to Control (~—18 x ~4”)

20 — CABLE, Upper Level Vent (Use Cable Pkgj

21 — BRACKET,Upper Level Vent Control Cable Mounting

22 — BRACKET,Vent Control to Inst. Panel—L.H

23 — CONTROL,Lower Vent—L,H

414

1973-74 “AN’ & “WV’ VENTILATION CONTROL (EXt A.C.)

9.7899.789

9389

9.789

9.787

2389

9,78997899.786

8,787

9.7879.787

9,78710.256

9.26210.252

t78 7

9-7798.977

9.7879.78793B79.787


GRAND II ‘ii”’

1969/242 ANTENNA — MANUAL

Des~riptian

Mast Assy., Antenna

Nut, Antenna — To Fender Mounting -

Adapter, Antenna to Front Fender - - -

Pad, Antenna

Lead-in Assy., Antenna —Includes Body -

1969/242 ANTENNA — ELECTRIC

Key Description

1 Antenna Assy., Radio

2 Nut Antenna — Mounting Upper Adapter

3 Gasket, Antenna Adapter to Nut ..

4 Pad, Antenna — To Rear Quarter

Panel Upper Adapter

S Seal, Antenna — Mounting Lower Adapter

Port No.

9779935

9779939

548287

9782911

9779667

120375

121753

9776357

97934409793553

6

7 Washer

A Clomp, Antenna Bracket

9 Bracket, Antenna to Body—All (-37)—All (-67)

10 Adapter, Antenna to Rear Fender—All (-37) 9793319—All (-67) 9793486

11 Adapter, Antenna to Rear Fender—Upper—All (-37)

—All (-67)

12 Bracket, Antenna Anti-Twist

13 Mast Assy., Antenna

9793318

9793434

575719

541963

Oty. Group

1 9.647

1 9.647

1 9.647

1 9.647

1 9.647

AR Cat9O7-A

AR Cot907-A

1 9.647

1 9.6471 9.647

-K

/ V

1 9.6471 9.647

1 9.6471 9.647

I 9.647

1 9.647

V2

3

4Key

2

3

4

5

Part No. Oty.

978//25 1

536343 1

9791580 1

9774043 1

9791616 1

Group

9.647

9.647

9.647

9.647

9.647

tx/sr/AG h~cS

0

1

>

LW~t.d .1

GROUP ~OQOILLUSTRATION 47

TEMPESTGRAND PHIl I

PARTS CATALOGUE

1989-72 TEMPEST STEREO TAPE PLAYER SYSTEM

Group No. Key

1 — PLAYER, Stereo Tape

2— RETAINER, Stereo Tape Player Upper Mtg. —

exa. Console3 — SCREW, Housing to Tape Player —

(#818 x 1/2”)4— HOUSING, Stereo Tape Player5—BEZEL, Stereo Tape Player Control Knob6 — NUT, Stereo Player to Knob Bezel7 — BEZEL, Stereo Tape Balance Control Knob8 — SPRI NG, Stereo Tape Control Knob9—KNOB ASM., Stereo Tape Control

10 — SCREW, Upper Bracket to Lower Bracket(#8 —18x 5/8”)

11 — NUT, Stereo Tape Player to Bracket — (PlO —24)..12—BRACKET, Stereo Tape Player Mtg. (Upper)

9,670 13 — SCREW, Lower Mtg. Bracket to Pan —

(1/4” — 24x5/8”)14 — NUT, Upper Bracket to Lower Bracket Mtg. —

9.670 (#8 — 18)IS — BRACKET. Stereo Tape Player Mtg. (Lower)—

8.977 16— SPACER, Stereo Tape Player Mtg. (Lower) —

9.670 w/Console9.620 17— BRACKET, Stereo Tape Player Mtg. (Lower) —

9.670 w/Console9.670 18 — BRACKET, Stereo Tape Player Mtg. (Lower) —

9.670 cxc. Console9670 19—SCREW,Stereo Tape Player Base to Brlct.

(#8 — 18 x 1/2”)

8.977 20 — BASE, Stereo Tape Player Hag. (Paint to match)...8.915 21 — WIRE ASM., Stereo Tape Player (AM—M4/FM) ...

9.670 22 — WIRE ASM., Stereo Tape Player (Atv%/FM Stereo) -

1GM

W/CONSOLE

18

p

TEMPESTEXC. CONSOLE

AM/FM STEREO&

TAPE PLAYER

Key Port Name Part Name Group No.

Ni

8.921

9.670.

9.670

9470

83779.6709.6709.670


GM TEMPESTI ax

EXC. CONSOLE

1969-72 GRAND PRIX STEREO TAPE PLAYER SYSTEM

Part Name Group No. Key Part Nome

1— WIRE, Rear Speaker Control Jumper (14” Long) - . -

2 — WIRE, Tape Player (Front) (w/Console)3 — WIRE, Tape Player (Rear) (w/Cansole)4 — SCREW,Player to Lower Mounting Brkt.

(#10—16x5/8”)5— NUT, Player to Lower Mounting Brkt.

(#1016 ‘U”)6 — PLAYER. Stereo Tape (Serviced in Accessory Pkg.7 — RETAINER, Player to Upper Mtg. BrlctS — SCREW, Housing to Brkt. (#8~18 x 1/2”)9—HOUSING,Stereo Tape Player

10—BEZEL, Control Knob11 — NUT, Player to Housing or Plote

9.665 12— BEZEL, Balance Control Knob9.670 13 — SPRING, Control Knob

9.670 14 — KNOB, Control15— BRACKET, Player Mounting — On Pan (w/Console).

8.977 16— BASE, Player Housing17— SCREW, Base to Bracket (~8—18 x 1/2”)

9670 18 — BRACKET. Player Mounting — LowerOnly) (Exc. Console).9.670 19— SCREW, Bracket to Pan (1/4—14 x 5/8’)N.S. 20 — BRACKET, Tape Player Upper Mtg9.6V 2? — NUT & LOCKWASI-IER, Player to Grid ~J10—24) - -

9.670 22 — SCREW, Upper BrLrt. to Lower Rdct.9.620 (#818 x 5/8”)

N

-N--

Key

WITH CONSOLE

Group No.

9.6709.6709.6709.6709670N.S.

9.670N.S.9.470NJ.

8.977


TEMPESTGRAND PHIl I

PAHIS CAfALU~UE

GRANDPRIXCONSOLE MOUNT

AM RECEIVER & TAPEPLAYER

AM/FM RECEIVER &TAPE PLAYER

1971-72 CASSETTE STEREO TAPE PLAYER

Group No. Key Part Name

1 — PLAYER, Stereo Tape Casette (Serviced inAccessosy Pkg. Only)

2 — OUTLET, Air Distributor — Center 8.8453—SCREW,Brict. to Pan (1/4—14 x 5/8”) N.S4— BRACKET, Player Mounting (Exc. Comole) ,... 94705—NUT, Player to Brkt. (24) N.S.6 — BRACKET, Player Mounting — Upper (w/Console). - 9.6707—SCREW, kkt. to Console (#8—18 x 5/8”) 8.9778—BRACKET, Player Mounting — Lower (w/Console). - 9.670

9 — BRACKET, Player Mounting — Upper (w/Coosole). -

10— SCREW, Cover to Brkt. (#8 — 18 x 1/2”)ii — COVER, Player Mounting Brkt. (w/Console)12— CAATRIDGE, Stereo Cossone13 — WIRE, Tape Player Ccssette (hc. Console)14 — WIRE, Reor Speaker Control — Jumper (14” Long) -

15— WIRE, Console Tap. Player Extension16— WIRE, Tape Player (w/Console)17—. COVER, Tape Player Mounting Brlct

N”. -

—-

‘—‘K> I

Key

GRAND PRIX WIRING-W/CONSOLE

Pert Name Group No.

9.6708.977%670947094709.670947094709.670

GROUP9.OOCILLUSTRATION 50

ItiM’_GRANDFBIK I

Key

1969-71 ALL TYPICAL REAR

Part Ncwne

I — SWITCH & WIRE, Defogger Blower

2 — CLIP, Defogge. Switch Retaining

3 — WIRE, Defegger Blower to Switch

4 — GRILLE, Defogger

S — RAM, ttcitv, %n~ei

6 — FAN, Defogger

7—NUT, Motor to Case (#8~32)

B — CASE, Blower

9 — OUTLET, Defogger

10 — MOTOR, Window Defogger

11 — SPACER, Motor Mounting

12 — GASKET, Mote. Mounting

IS — SCREW, Case to Plate (I8~—18 x VS’)

WINDOW DEFOGGER

Group No.

9.778

9,778

9.778

9.778

9.778

9.778

8.915

9.778

9.778

9.778

9.778

9.778

8.977

Li

I

I


IGM I GRAND PIUS I

1, 3527, 3537,3727, 3737, 4237

FF

B3369, 3569

3535, 3536, 3936

3539,

FC

CUSHION ASM.

399673 CUSHION

.3859708 WASHER1386144 BOLT

Combination A

4 t920809 CUSHIONASM.

399673 CUSHION

3859708 WASHER454950 BOLT

CombiAation o

9791996 CUSHION

9793029 CUSHION

Combination B Combination E

3859706 WASHER•454950 aOL

Combination G

CUSHION

Combination H

9711997 CUSHION ASM.

399673 CUSHION ASM.3859708 WASHER

3902231 BOLT

Combination C

4776763 NUT

4776763 NUT9791997 CUSHIONASM.

9791997 CUSHION ASM.399673 CUSHION 399873 CUSHION

3859708 WASHER 3859708 WASHER454950 BOLT 454950 BOLT

Combination F

1969 BODY TO FRAME MOUNTS

A

MODELS

3567, 3787, 4287

B

278

A

—7

C

E EAF

0

0

9793708

Combination J


TEMPESTGRAND PHIl

I £ 9

MODELS ‘i “2 -7

3567,3767,4287 F F CA H A 0

3327,3527,3537,3727, 3737, 4237

B F C H H A 0

3369,3569 C A H A 03535,3538,3736 F -w C A H A 035393739 E Cl-I H A 0276 BJCHHIAID

Combination A

9791987 CUSHIONASM.

CUSHION

.3859708 WASHER.1388144 BOLT

479055 CUSHION

3920809 CUSHIONASM.

399673 CUSHION

3859708 WASHER

3902232 BOLT

Combination 0

399673 CUSHION

Combination E

9793708 RESTRICTOR3920809 CUSHION ASM.

399673 CUSHION

3859708 WASHER3902232 BOLT

Combination G

I 9798420 CUSHION

Combination H

9424985 NUT


399673 CUSHION3859708 WASHER

3902232 BOLT

Combination J

Combination C



1GM’C

I

Combination B

9424985 NUT


399873 CUSHIONK 3859708 WASHER

3902232 BOLT

Combination F

9791997 CUSHION

3902231 BOLT

TEMPESTGRAND PRIX

MODELS 23456 7

3767,4267,3536,3546

G F C A H A 0

3527, 3537, 37374237 BF CHHAD

H HAD3327,3337 WV C H HH 0

276 BJCHHAD

483734 CUSHION ASM.

399673 CUSHION

WASHER

Combination A

Zt~ 479055 CUSHION

Combination B

43734 CUSHION ASM. I


3902231 BOLT

Combination C

Combination 0

Combination F

483734 CUSHIONASM.


3902232 BOLT

Combination G

9798420CUSHION

Combination H

9791997 CUSHIONASM.

-399673 CUSHION

-3859708 WASHER

399673 CU¶

3859708

3902232 BOLT-

Combination J



0

1GM’ I

483735 CUSHIONASM.

3902232 BOLT

NUT

9424985 NUT

PARTS CATALOGUE

MODELCUSHIONPOSITION #1 #2 #3 #4 #5 #6 #7

3527, ~Upper 479055 9791997 483734 9798420 9798420 9798420 483735Lower — 399673 399673 — — — 399673

37 Upper 479055 9791997 483734 9798420 9798420 9798420 483735

Lower — 399673 399673 — — — 399673

3536, 3546,3867

Upper 483734 9791997 483734 483734 9798420 483734 483735Lower 399673 399673 399673 399673 — 399673 399673

3569, 4439Upper 483734 9791997 9798420 9798420 9798420 483734 483735

Lower 399673 399673 — — — 399673 399673

276Upper 479055 9791997 483734 9798420 9798420 483734 483735

Lower — 399673 399673 — — 399673 399673


UPPER CUSHI

UPPER CUSHION

1972 BODY TO FRAME CUSHIONS

— .flflflflEWI~wI augurnax jlUM’


£3 £

MODELCUSHIONPOSITION #1 #2 #3 #4 #5 #6 #7

1-29/Upper 330947 330947 — 488610 488610 330951 330951Lower 330990 330990 — — — — 330991

1-371 Upper 330951 330951 — 488610 488610 330951 330951

Lower 330989 330991 — — — — 330989

9

Upper 330951 330942 330959 488610 488610 330951 330947

Lower 330990 330990 3993679 — — 330989 330989

GKS7 Upper 330951 330951 — 488610 488610 490724 490724Lovve 330969 330989 — — — — 330989


UPPER CUSHION

UPPER CUSHION

-LOWERCUSHION

-LOWERCUSHION

£ £ II GM’ NDPRIX I

MODELCUSHION

POSITION


#1 #2 #3 #4 #5 #6 #7

1-29/ Upper 330947 330985 330953 488610 488610 334905 330992

1-291 Lower 330991 330989 3993679 — — 494515 494515

1-37/ Upper 330951 330951 330955 488610 488810 334905 334905

1-37/ Lower 494515 330991 3993679 — — 494515 494515

Wagons Upper 330951 330942 330959 488610 488810 334905 334978

Wagons Lower 330990 330990 3993679 — — 494515 494515

OK Upper 34905 494909 330953 488610 488610 334905 334905

OK Lower 494515 330989 3993679 — — 494515 494515

GROUP 9.000 IllUSTRATION 57

UPPER WSIIION

UPPER WS4ION

•1LOER

OSIION

0J9411*d

HIM' GRAND

Documents