“Micro Meets Macro,” Space Horizons 2013, Brown University Gravitational Reference Technologies for Precision Navigation and Control in Space Karthik Balakrishnan Department of Aeronautics and Astronautics Hansen Experimental Physics Labs Stanford University [email protected]
21
Embed
Gravitational Reference Technologies for Precision …...“Micro Meets Macro,” Space Horizons 2013, Brown University Gravitational Reference Technologies for Precision Navigation
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
“Micro Meets Macro,” Space Horizons 2013, Brown University
Gravitational Reference Technologies for Precision Navigation and Control in Space
Karthik Balakrishnan Department of Aeronautics and Astronautics
• 2 drag-free spacecraft differential between two geodesics – Geodesy, e.g. GRACE
• 3+ spacecraft – Gravity-waves
Triad I 1972 1st drag-free
GRACE, 2003 (non-drag-free)
LISA, ~2026
GP-B, 2004
“Micro Meets Macro,” Space Horizons 2013, Brown University
MGRS System: Full
Grating Angular Sensor
Grating Displacement Sensor
Proof Mass Caging
UV LED Charge Management
Full System
Differential Optical Shadow Sensor
Andreas Zoellner
Eric Hultgren, Chin-Yang Lui Karthik Balakrishnan
Graham Allen (alum)
• picometer sensing for science signal • High sensitivity, low dynamic range • Nanoradian level angular sensing
• nanometer sensing for drag free signal • Lower resolution, high dynamic range
• Solid state 255nm light source • Charge control of proof mass and housing potential
• 700 g clamping of proof mass during launch • Minimal residual velocity on release • No damage to proof mass surface
• 2.9 kg 70mm dia 70-30 Be-Cu sphere • Carbide coated sphere
“Micro Meets Macro,” Space Horizons 2013, Brown University
MGRS: simplified for smallsats
Spinning
spherical Test Mass
Housing
(metrology reference)
Drag-free error budget
“Micro Meets Macro,” Space Horizons 2013, Brown University
Charging sources and effects
• The spacecraft and housing protect the proof mass from many disturbances: solar, atmospheric, etc.
• However, direct and secondary charging of the proof mass is still possible leading to a potential imbalance between the proof mass and housing walls – Direct: High energy particles pass through the shielding and directly
accumulate on either proof mass or housing
– Secondary: High energy particles interact with spacecraft materials, knocking off electrons which then accumulate on the proof mass or housing
– Metals: Au (LISA/LP-F proof mass coating), Nb (GP-B)
SiC coated Al sphere
“Micro Meets Macro,” Space Horizons 2013, Brown University
Proof mass coating measurements • Measurements:
– Quantum efficiency (λcent =255 nm)
• Measured twice: 2 weeks after coating, and 16 months after coating
• Used an integrating sphere with 10 V bias between coated sample and sphere
• Samples isolated from ground via 1014 Ω Ultem tubes
• 50 µW UV incident power
• Current measured using Keithley 6485 Picoemmeter
– Reflectivity (λcent =255 nm, θ=45°)
• Used Newport 918D head connected to Newport 1931-C power meter
Material QE (2 wk) QE (16 mos) R (255 nm) φ (eV)*
Au 3.40E-07 4.4E-07 0.17 4.57
Nb 5.64E-07 2.4E-07 0.17 4.30
SiC 4.34E-07 1.4E-07 0.12 4.80
TiC 4.48E-07 1.3E-07 0.15 3.80
ZrC 3.85E-07 2.1E-07 0.11 3.70
MoC 6.82E-07 1.1E-07 0.15 4.74
TaC 6.35E-07 1.4E-07 0.13 5.0
Ir -- -- 0.6 -- QE measurement setup
“Micro Meets Macro,” Space Horizons 2013, Brown University
Differential Optical Shadow Sensor
• LED-diode Emitter-Detector pairs
– Differential common mode rejection
– Photon pressure balanced
• TM position sensor goals – ~nm/Hz1/2 position in 3 dof
– < 10–12 m/sec2 TM disturbance
“Micro Meets Macro,” Space Horizons 2013, Brown University
DOSS Sat
1nm
Previous setup (in-air)
• 2U CubeSat
• Raise Shadow Sensor TRL
• Test attitude control algorithms
• Completion: Late 2013
Courtesy A. Zoellner
“Micro Meets Macro,” Space Horizons 2013, Brown University
Proof Mass Caging System
• Clamp proof mass during launch with >200 N force
• 13.5:1 gear ratio
• Will be tested on NASA Zero-G flight at the end of April
Courtesy E. Hultgren
“Micro Meets Macro,” Space Horizons 2013, Brown University
Drag Free Cubesat
• 3U CubeSat
• Full MGRS demo
• Completion: mid 2015
• Research goals:
– Drag-free control algorithm
– On-orbit performance evaluation of MGRS
– Performance goal: 10–12 m/sec2Hz1/2 (for geodesy) Courtesy A. Zoellner
“Micro Meets Macro,” Space Horizons 2013, Brown University
Questions?
Construction of satellite engineering model ongoing at NASA Ames
1. B. Lange. “The Control and use of Drag-free Satellites”. PhD thesis, Stanford University, 1964.
2. D. B. DeBra and J. W. Conklin. “Measurement of drag and its cancellation”. Classical and Quantum Gravity, 28(9):094015, May 2011.
3. Ke-Xun Sun, Saps Buchman, Robert Byer, Dan DeBra, John Goebel, Graham Allen, John W Conklin, Domenico Gerardi, Sei Higuchi, Nick Leindecker, Patrick Lu, Aaron Swank, Edgar Torres, and Martin Trittler. “Modular gravitational reference sensor development”. Journal of Physics: Conference Series, 154:012026, 2009.
4. K.-X. Sun, A. Alfauwaz, M. Alrufaydah, H. Altwaijry, K. Balakrishnan, S. Buchman, R. L. Byer, J. W. Conklin, D. B. DeBra, J. Goebel, E. Hultgren, and A. Zoellner. “Modular Gravitational Reference Sensor (MGRS) Technology Development”. In Proceedings of the 8th International LISA Symposium, Journal of Physics Conference Series, 2011.
5. T J Sumner, DNA Shaul, M O Schulte, S Waschke, D Hollington, and H Araujo. “LISA and LISA Pathfinder charging”. Classical and Quantum Gravity, 26(9):094006, May 2009.
6. S. Buchman, T. Quinn, G. M. Keiser, D. Gill, and T. J. Sumner. “Charge measurement and control for the Gravity Probe B gyroscopes”. Review of Scientific Instruments, 66:120{129, January 1995
7. Ke-Xun Sun, Brett Allard, Saps Buchman, Scott Williams, and Robert L Byer. “LED deep UV source for charge management of gravitational reference sensors”. Classical and Quantum Gravity, 23(8):S141{S150, 2006.
8. Ke-Xun Sun, Nick Leindecker, Sei Higuchi, John Goebel, Sasha Buchman, and Robert L Byer. “UV LED operation lifetime and radiation hardness qualification for space flights”. Journal of Physics: Conference Series, 154:012028, 2009
9. K. Balakrishnan, E. Hultgren, J. Goebel, and K.-X. Sun. “Space Qualification Test Results of Deep UV LEDs for AC Charge Management”. In 11th Spacecraft Charging Technology Conference, poster presentation, September 2011.
“Micro Meets Macro,” Space Horizons 2013, Brown University
Error sources on proof mass orbit
B. Lange. The Drag Free Satellite. AIAA Journal, May 26, 1964.
“Micro Meets Macro,” Space Horizons 2013, Brown University
Coating adhesion test results - carbides
• Adhesion test procedure – Scotch tape pull test – Performed at two different speeds, once on each half of the sample
– (1) Tape put down, pressed firmly onto coating, and then slowly pulled off
– (2) Tape put down, pressed firmly onto coating, and then yanked off quickly
All carbides adhered well, with no pulloff during the test
“Micro Meets Macro,” Space Horizons 2013, Brown University
Coating adhesion test results – gold (E-beam)
• Same adhesion test was performed with the gold sample which was coated by e-beam dep
• Gold coating – significant section peeled off
• Not a significant issue for UV LED sat – the proof mass is clamped in place, with no chance for contacting walls, and no caging or uncaging
Issue for any future drag-free missions using a free-floating proof mass