Global Advanced Technology Group
Global AdvancedTechnology
Group
T & Z GmbH
Your partner
Global AdvancedTechnology Group
The product
H2X Container System
The patented H2X systemenables in the first place
the use of Methanol Water or Ethanol Water mixture.
It is applicable for all engines.
What does the H2X
system mean?
* Engine unit Type Turbine 50 H2X
* Generator type 3.5 MW (Siemens Morelli Motors or Elin)
* Tank system Incl. Fuel pump
* Computerized control systems incl. GPS or GSM
* Tariff strategy
* Container modules (sound and heat insulated)
* Connection device for the net link
Components of the H2X Container
A) The sequence of the erection for the
container begins with its base plate.
It is the floor of the container, a so called double floor, which contains all fixtures necessary for the erection of the turbine and the generator. This base plate with adequate fixtures enables a transportation with a fork lift.
These fixations are important, because they constitute a rigid connection to the container itself on one side, and on the other side guarantee a firm connection between the engine and the generator, thus enabling a smooth operation.
All supply pipes are also laid in the base plate for the fuel, the cables, the control system and the cable bus, thus protected.
The base plate is then covered. This cover serves as a protection for all pipes and cables and can be used as a floor.
Technical Description of the H2X Container
B) The next step is to fix the Generator with the erection fixtures in the base plate.
The generator is a three-phase generator with a
power output of 3.5 MW (an increase of the
capacity is being considered). The tension is
between 4 and 6 KV. The possible number of
revolutions is at 1500 R/min.
Because of the high speed of the turbine, a
gear is placed between the generator and
the turbine.
Due to the reduction of the speed of the
turbine down to the permissible rotations of
the generator, the torque output increases.
Technical Description of the H2X Container
C) The turbine being the power engine of the generator, is then erected.
The capacity of the turbine is appr. 5 000 PS/3 650 KW at a speed of appr. 20 000 R/min. The continuous output is 3 200 KW. The shaft to the gear operates on ceramic bearings. The pressure is indicated at 04 bar. The values of the waste gas reach a temperature of 390°C.
The injection system is manufactured by the company Bosch.
A gear is installed between the generator and the turbine, as already mentioned, to balance the different speed frequency of the 2 aggregates. This increases and strengthens the speed torque.At normal operation the turbine has a speed frequency of appr. 18 000 R/min
Technical Description of the H2X Container
D) Near the mechanical erection devices installed
on the foundation, there is the fuel tank with a
capacity of appr. 40 000 litres. The fuel is a
methanol-water mixture or an ethanol-water
mixture. It is also possible to use natural gas.
E) The container consists of an insulated sound
absorbing outer shell, sandwich type of
dimensions L 12m B 2.75m H 3m. Exterior
coating according to wish of customer.
Technical Description of the H2X Container
Technical Description of the drive unit Type Turbine 50 H2X
• Type turbine 50 H2X• Length 215 cm• Diameter 147 cm• Revolutions 18000 1/min• Pressure rate 04• Capacity 3650 KW• Temperature of waste gas appr. 390°C• Ball Bearing – Ceramic• Shaft alley – Sp. steel• Conductor equipment – Sp. cast iron• Injection system – H.2.X System• Casing – Special steel casting
Fuel mixtures
• Methanol-Water mixture
• Ethanol-Water mixture• Natural gas
Current Generator Type 3.5 MW
• Continuous output – 3200 KW
• Nominal output – 3500 KVA• Voltage – 6 KV• Tension uniformity - +/- 1 per cent• Tension adjustment range - +/- 5 per cent• Frequency – 50 Hz• Rotation speed – 1500 1/min• Over speed• Insulation class – F• Radio interference suppression degree – N
Tank system incl. fuel pump
• Out of Special steel
• Volume – 40 000 litres• Fuel pump – Type Bosch• Quantity sensor – Type Bosch• Exhauster• Fuel sensor
Computerized Control system incl. GPS or GSM
• Computer (LCU, LCD)
• Processor 1000 Hz• Display – 2x15“ TFT SXGA• Tension – 12 Volt• Radio facility • GSM or GPS• Control equipment H2X• Control generator Rate strategist• Rate strategist
Container modules
• Casing – Steel frame
• Side walls – Sandwich type
Aluminium synthetic material
• Insulation
• Door – 1
• Ventilation – 1 / max. 100 m³/ H
• Deaeration – 1/ max. 100 m³ /H
• Lights – 2 neon strips
• Antenna – 1 suitable for SAT
• Hoisting device – 2 hoists on rail
Turbine H2X System
The construction of the H2X Turbine has been
specially conceived for the power plant container. The
advantage compared to already existing turbines
are also highlighted.
2. Efficiency close to 70 % compared to other turbines at max. 45%
1. Half the weight compared to existing engines
3. One third in size of a conventional turbine
4. Fuel consumption reduced by 50% (150 litre/hourPower 5000 hp)
5. High quality materials guarantee a longer servicelife.
Advantages
TURBINE H2X
Why is this engine so powerful?
The turbine H2X system is by nature so powerful.
The injection system HIGS, patented world wide,
and the special construction and conception of
the combustor chamber upon this turbine guarantee an
usually high power output.
Small and powerfulLow fuel consumptionClean and environmentally friendly combustion
TURBINE H2X INJECTION SYSTEM
Explanation:
Through the patented HIGS Injection System, a new
generation of turbines has been born. The water fuel
mixture is injected into the combustor chamber under
a very high pressure( 173psi). This triggers the ignition
of the mixture through an ignition plug. An explosive
force arises. Compared to the one flame of the
conventional turbine, the H2X System experiences a
double power impact.
As a result the world wide protected H2X Turbine
1.) has a low fuel consumption2.) is very powerful
TURBINE H2X compared to DIESEL ENGINE
A comparison between H2X and a Diesel engine reveals.
A Power Plant Container with the H2X System has the
following dimensions. L 12m, W 2,6 m, H 3 m. The weight
is approximately. 15 tons.
In a Power Plant Container with a Diesel Engine of the
same capacity, the Diesel Engine alone would weigh 30
to 35 tons, and measure a lenght of the 6 to 8 m.
Hence unsuitable for a container.
The turbine has a very low noise level (26 db).
In contrast is the diesel engine very noisy (over 100 db).
ADVANTAGE OF THE INSTALLATION
** INSTALLATION:
The container is only connected to the net
coupling point. Following this points we
recommend our customers to lay the cables
underground. So damages due to storm,
hurricane or floods are impossible.
** CONSTRUCTION:
The only civil activity comprises the construction
of a concrete foundation slab, according to data
of the company. No supply roads and no
expensive high voltage over headlines are
needed.
** TRANSPORT:
On trucks, by ship, on trains and in some
countries, if necessary, by a helicopter.
** INTERCONNECTION:
In the cities with more than one power container,
the demand for electricity is controlled by a rating
communication equipment. In case of a
breakdown of one container, the loss is
equalized by this equipment.
NO MORE BLACK OUT
** NOISE:To the construction of the container wall
which is isolated against head and
noise, the outside perceptible noise level
is very low therefore, 26 db.
** ENVIRONMENT:
Though the use of ethanol-water and methanol-
water mixture, there is no emission of pollutants
following combustion. This means that the power
plant container is clean and can be placed
anywhere, even in front of the house door.
** INSTALLATION POSSIBILITIES
Military Areas
Residential Compounds
Hospital and Social Institutions
Harbor (Port Facilities )
Big Factories
Timber Industry
for all Communities
PRODUCTION COSTS PER kW/H
Nuclear Power 22 Cent 440%
Caloric Power 18 Cent 360%
Hydroelectric
Power 14 Cent 280%
H2X Container 05 Cent 100%
CONSTRUCTION COSTS PER kW/H
Nuclear Power Euro 3.100,-- 280%
Caloric Power Euro 2.100,-- 190%
Hydroelectric
Power Euro 4.400,-- 400%
H2X Container Euro 1.380,-- 100%
PLANNING PERIOD UP TO INITIAL GENERATION OF ELECTRICITY
Nuclear Power 4 Years
Caloric Power 2-3 Years
Hydroelectric 3-4 Years
Power
H2X Container 8-12 MONTH
COMPARISON
DIESELENGINE
TURBINE CONVENTIONALTURBINE H2X
WEIGHT
Diesel Engine 30.000 Kg
Turbine conventional 4.500 Kg
Turbine H2X 2.100 Kg
COMPARISON
DIESELENGINE
TURBINE CONVENTIONALTURBINE H2X
EFFICIENCY
Diesel Engine 47 %
Turbine conventional 48 %
Turbine H2X 70 %
COMPARISON
DIESELENGINE
TURBINE CONVENTIONALTURBINE H2X
FUELCONSUMPTION
Diesel Engine 770 Liter / h
Turbine conventional 450 Liter / h
Turbine H2X 150 Liter / h
COMPARISON
DIESELENGINE
TURBINE CONVENTIONALTURBINE H2X
SERVICE
Diesel Engine 1.000 - 1.500 /h
Turbine conventional 2.000 - 2.500 /h
Turbine H2X 4.000 - 4.500 /hafter 2.250 hrs. Inspection of Plant through GPS
and the Control System (total check up )
COMPARISON
DIESELENGINE
TURBINE CONVENTIONALTURBINE H2X
SHUTDOWN TIME DURING SERVICE
Diesel Engine 24 - 48 /h
Turbine conventional 12 - 18 /h
Turbine H2X 2 - 3 /h
COMPARISON
DIESELENGINE
TURBINE CONVENTIONALTURBINE H2X
SERVICE COSTS
Diesel Engine 10.000 - 200.000,-- Euro
Turbine conventional 10.000 - 150.000,-- Euro
Turbine H2X 4.000 - 5.000,-- Euro