2004 FJR1300(S) FJR1300A(S) 5JW1-AE5 SUPPLEMENTARY SERVICE MANUAL
2004
FJR1300(S)FJR1300A(S)
5JW1-AE5
SUPPLEMENTARYSERVICE MANUAL
FOREWORD
This Supplementary Service Manual has been prepared to introduce new service and data for theFJR1300(S)/FJR1300A(S) 2004. For complete service information procedures it is necessary touse this Supplementary Service Manual together with the following manuals.
FJR1300(N) 2001 SERVICE MANUAL: 5JW1-AE1FJR1300(P) 2002 SUPPLEMENTARY SERVICE MANUAL: 5JW1-AE2
FJR1300(R)/FJR1300A(R) 2003 SUPPLEMENTARY SERVICE MANUAL: 5JW1-AE4
FJR1300(S)/FJR1300A(S) 2004SUPPLEMENTARY SERVICE MANUAL
© 2003 by Yamaha Motor Co., Ltd.First edition, September 2003
All rights reserved. Any reproduction or unauthorized use
without the written permission of Yamaha Motor Co., Ltd.is expressly prohibited.
EAS00002
NOTICEThis manual was produced by the Yamaha Motor Company, Ltd. primarily for use by Yamaha deal-ers and their qualified mechanics. It is not possible to include all the knowledge of a mechanic inone manual. Therefore, anyone who uses this book to perform maintenance and repairs on Yamahavehicles should have a basic understanding of mechanics and the techniques to repair these typesof vehicles. Repair and maintenance work attempted by anyone without this knowledge is likely torender the vehicle unsafe and unfit for use.
Yamaha Motor Company, Ltd. is continually striving to improve all of its models. Modifications andsignificant changes in specifications or procedures will be forwarded to all authorized Yamaha deal-ers and will appear in future editions of this manual where applicable.
NOTE:@
Designs and specifications are subject to change without notice.
EAS00004
IMPORTANT MANUAL INFORMATIONParticularly important information is distinguished in this manual by the following.
The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOURSAFETY IS INVOLVED!
Failure to follow WARNING instructions could result in severe injury or death tothe motorcycle operator, a bystander or a person checking or repairing themotorcycle.
A CAUTION indicates special precautions that must be taken to avoid damageto the motorcycle.
A NOTE provides key information to make procedures easier or clearer.
WARNING
CAUTION:
NOTE:
EAS00007
HOW TO USE THIS MANUALThis manual is intended as a handy, easy-to-read reference book for the mechanic. Comprehensiveexplanations of all installation, removal, disassembly, assembly, repair and check procedures arelaid out with the individual steps in sequential order.1 The manual is divided into chapters. An abbreviation and symbol in the upper right corner of
each page indicate the current chapter. Refer to “SYMBOLS”.
2 Each chapter is divided into sections. The current section title is shown at the top of each page,except in chapter 3 (“PERIODIC CHECKS AND ADJUSTMENTS”), where the sub-section title(s)appears.
3 Sub-section titles appear in smaller print than the section title.
4 To help identify parts and clarify procedure steps, there are exploded diagrams at the start ofeach removal and disassembly section.
5 Numbers are given in the order of the jobs in the exploded diagram. A circled number indicates adisassembly step.
6 Symbols indicate parts to be lubricated or replaced. Refer to “SYMBOLS”.
7 A job instruction chart accompanies the exploded diagram, providing the order of jobs, names ofparts, notes in jobs, etc.
8 Jobs requiring more information (such as special tools and technical data) are described sequen-tially.
EAS00008
SYMBOLSThe following symbols are not relevant toevery vehicle. Symbols 1 to 9 indicate the subject of eachchapter.
1 General information 2 Specifications 3 Periodic checks and adjustments 4 Chassis 5 Engine 6 Cooling system 7 Fuel injection system8 Electrical system 9 Troubleshooting
Symbols 0 to G indicate the following.
0 Serviceable with engine mounted A Filling fluid B Lubricant C Special tool D Tightening torque E Wear limit, clearance F Engine speed G Electrical data
Symbols H to M in the exploded diagramsindicate the types of lubricants and lubricationpoints.
H Engine oil I Gear oil J Molybdenum disulfide oilK Wheel bearing greaseL Lithium soap base greaseM Molybdenum disulfide grease
Symbols N to O in the exploded diagramsindicate the following.
N Apply locking agent (LOCTITE®) O Replace the part
1 2
3 4
5 6
7 8
9 0
A B
C D
E F G
H I J
K L M
N O
GENINFO SPEC
CHKADJ CHAS
ENG COOL
FI – +ELEC
TRBLSHTG
T R..
E G M
B LS M
LTNew
CONTENTS
GENERAL INFORMATION ..............................................................................1FEATURES ...............................................................................................1
OUTLINE ...............................................................................................1FI SYSTEM ...........................................................................................2
SPECIFICATIONS ............................................................................................3GENERAL SPECIFICATIONS ..................................................................3ENGINE SPECIFICATIONS ......................................................................3ELECTRICAL SPECIFICATIONS .............................................................4
PERIODIC CHECKS AND ADJUSTMENTS ....................................................5INTRODUCTION .......................................................................................5PERIODIC MAINTENANCE AND LUBRICATION CHART .......................5SEATS AND FUEL TANK .........................................................................7
FUEL TANK ..........................................................................................7REMOVING THE FUEL TANK ..............................................................9
AIR FILTER CASE ..................................................................................10
FUEL INJECTION SYSTEM ...........................................................................12FUEL INJECTION SYSTEM ...................................................................12
WIRING DIAGRAM (FJR1300) ...........................................................13WIRING DIAGRAM (FJR1300A) .........................................................14SUBSTITUTE CHARACTERISTICS OPERATION CONTROL (FAIL-SAFE ACTION) .........................................................................16THROTTLE BODIES ...........................................................................21
AIR INDUCTION SYSTEM ......................................................................25INSTALLING THE REED VALVES .....................................................25
ELECTRICAL .................................................................................................26ELECTRICAL COMPONENTS ...............................................................26FUEL INJECTION SYSTEM ...................................................................28
CIRCUIT DIAGRAM (FJR1300) ..........................................................28CIRCUIT DIAGRAM (FJR1300A) .......................................................29CHECKING THE FUEL PUMP ...........................................................30
FJR1300 WIRING DIAGRAM
FJR1300A WIRING DIAGRAM
– 1 –
GENINFOFEATURES
GENERAL INFORMATIONFEATURESOUTLINEThe main function of a fuel supply system is to provide fuel to the combustion chamber at the opti-mum air-fuel ratio in accordance with the engine operating conditions and the atmospheric tempera-ture.In the conventional carburetor system, the air-fuel ratio of the mixture that is supplied to the com-bustion chamber is created by the volume of the intake air and the fuel that is metered by the jet thatis used in the respective carburetor.Despite the same volume of intake air, the fuel volume requirement varies by the engine operatingconditions, such as acceleration, deceleration, or operating under a heavy load. Carburetors thatmeter the fuel through the use of jets have been provided with various auxiliary devices, so that anoptimum air-fuel ratio can be achieved to accommodate the constant changes in the operating con-ditions of the engine.As the requirements for the engine to deliver more performance and cleaner exhaust gasesincrease, it becomes necessary to control the air-fuel ratio in a more precise and finely tuned man-ner. To accommodate this need, this model has adopted an electronically controlled fuel injection(FI) system, in place of the conventional carburetor system. This system can achieve an optimumair-fuel ratio required by the engine at all times by using a microprocessor that regulates the fuelinjection volume according to the engine operating conditions detected by various sensors.The adoption of the FI system has resulted in a highly precise fuel supply, improved engineresponse, better fuel economy, and reduced exhaust emissions. Furthermore, the air induction sys-tem (AI system) has been placed under computer control together with the FI system in order torealize cleaner exhaust gases.
1 Ignition coil 2 Air filter case3 Intake air tempera-
ture sensor4 Fuel delivery hose5 Fuel tank6 Fuel pump
7 Intake air pressure sensor
8 Throttle position sensor9 Fuel injector0 O2 sensorA Catalytic converterB Crankshaft position
sensor
C Coolant temperature sensor
D Spark plugE Cylinder identifica-
tion sensorF BatteryG ECU
H Fuel injection system relay
I Engine trouble warn-ing light
J Lean angle cut-off switch
K Air cut-off valve
6
8
4523G
HJ
7
A9 0BDCK
1
IF
E
– 2 –
GENINFOFEATURES
FI SYSTEMThe fuel pump delivers fuel to the injector via the fuel filter. The fuel pump maintains the fuel pres-sure that is applied to the injector at only 324 kPa (3.24 kg/cm2, 46.08 psi). Accordingly, when theenergizing signal from the ECU energizes the injector, the fuel passage opens, causing the fuel tobe injected into the intake manifold only during the time the passage remains open. Therefore, thelonger the length of time the injector is energized (injection duration), the greater the volume of fuelthat is supplied. Conversely, the shorter the length of time the injector is energized (injection dura-tion), the lesser the volume of fuel that is supplied.
The injection duration and the injection timing are controlled by the ECU. Signals that are input fromthe throttle position sensor, crankshaft position sensor, intake air pressure sensor, intake air tem-perature sensor, coolant temperature sensor, and O2 sensor enable the ECU to determine theinjection duration. The injection timing is determined through the signals from the crankshaft posi-tion sensor and the cylinder identification sensor. As a result, the volume of fuel that is required bythe engine can be supplied at all times in accordance with the driving conditions.
1 Fuel pump2 Fuel injector3 Throttle body4 Intake air temperature
sensor5 Throttle position sen-
sor
6 Intake air pressure sensor
7 ECU8 Coolant temperature
sensor9 O2 sensor
0 Cylinder identification sensor
A Crankshaft position sensor
È Fuel systemÉ Control system
Illustration is for reference only.
#4 #3 #2 #11
57
4
63
A8
20
9
È
É
– 3 –
SPEC
SPECIFICATIONSGENERAL SPECIFICATIONS
ENGINE SPECIFICATIONS
Item Standard Limit
Model code FJR1300: 5JWG (for Europe)5JWH (for F)5JWJ (for Oceania)
FJR1300A: 5VS7 (for Europe)5VS8 (for F)5VS9 (for Oceania)
------------------------
Item Standard Limit
Fuel pumpPump type Electric ----Model (manufacturer) 5JW 21 (DENSO) ----Maximum consumption amperage 6.0 A ----Output pressure 324 kPa (3.24 kg/cm2, 46.08 psi) ----
Throttle bodiesModel (manufacturer) × quantity 42EHS (MIKUNI) × 4 ----Intake vacuum pressure 33.3 kPa (250 mmHg, 9.8 inHg) ----Throttle cable free play (at the flange of the throttle grip)
3 ~ 5 mm (0.12 ~ 0.20 in) ----
ID mark 5JW1 50 ----Fuel injectors
Model INP-151 ----Manufacturer NIPPON INJECTOR ----Quantity 4 ----
GENERAL SPECIFICATIONS/ENGINE SPECIFICATIONS
– 4 –
SPECELECTRICAL SPECIFICATIONS
ELECTRICAL SPECIFICATIONS
Item Standard Limit
Ignition systemIgnition system type Transistorized coil ignition (digital) ----Ignition timing 5° BTDC at 1,050 r/min ----Advancer type Electric ----Pickup coil resistance/color 420.8 ~ 569.3 Ω/Gy–B ----Transistorized coil ignition unit model(manufacturer)
F8T818 (MITSUBISHI)F8T819 (MITSUBISHI) (for F)
--------
Starting circuit cut-off relayModel (manufacturer) G8R-30Y-R (OMRON) ----Coil resistance 180 Ω ----
Fuel injection system relay Model (manufacturer) G8R-30Y-R (OMRON) ----
– 5 –
CHKADJ
INTRODUCTION/PERIODIC MAINTENANCE AND LUBRICATION CHART
EAS00036
PERIODIC CHECKS AND ADJUSTMENTSINTRODUCTIONThis chapter includes all information necessary to perform recommended checks and adjustments.If followed, these preventive maintenance procedures will ensure more reliable vehicle operation, alonger service life and reduce the need for costly overhaul work. This information applies to vehiclesalready in service as well as to new vehicles that are being prepared for sale. All service techniciansshould be familiar with this entire chapter.
PERIODIC MAINTENANCE AND LUBRICATION CHARTNOTE:• The annual checks must be performed every year, except if a kilometer-based maintenance
is performed instead.• From 50,000 km, repeat the maintenance intervals starting from 10,000 km. • Items marked with an asterisk should be performed by a Yamaha dealer as they require special
tools, data and technical skills.
No. ITEM CHECK OR MAINTENANCE JOBODOMETER READING (× 1,000 km) ANNUAL
CHECK1 10 20 30 40
1 * Fuel line • Check fuel hoses for cracks or damage. √ √ √ √ √
2 * Spark plugs
• Check condition.• Clean and regap.
√ √
• Replace. √ √
3 * Valves• Check valve clearance.• Adjust.
Every 40,000 km
4 Air filter element• Clean. √ √
• Replace. √ √
5 * Clutch• Check operation, fluid level and vehicle for fluid
leakage.√ √ √ √ √
6 * Front brake
• Check operation, fluid level and vehicle for fluid leakage.
√ √ √ √ √ √
• Replace brake pads. Whenever worn to the limit
7 * Rear brake
• Check operation, fluid level and vehicle for fluid leakage.
√ √ √ √ √ √
• Replace brake pads. Whenever worn to the limit
8 * Brake hoses• Check for cracks or damage. √ √ √ √ √
• Replace. Every 4 years
9 * Wheels • Check runout and for damage. √ √ √ √
10 * Tires
• Check tread depth and for damage.• Replace if necessary.• Check air pressure.• Correct if necessary.
√ √ √ √ √
11 * Wheel bearings • Check bearing for looseness or damage. √ √ √ √
12 * Swingarm• Check operation and for excessive play. √ √ √ √
• Lubricate with lithium-soap-based grease. Every 50,000 km
13 * Steering bearings• Check bearing play and steering for roughness. √ √ √ √ √
• Lubricate with lithium-soap-based grease. Every 20,000 km
14 * Chassis fasteners• Make sure that all nuts, bolts and screws are
properly tightened.√ √ √ √ √
– 6 –
CHKADJPERIODIC MAINTENANCE AND LUBRICATION CHART
NOTE:• The air filter needs more frequent service if you are riding in unusually wet or dusty areas.• Hydraulic brake and clutch service• Regularly check and, if necessary, correct the brake and clutch fluid levels.• Every two years replace the internal components of the brake master cylinders and calipers as
well as the clutch master and release cylinders, and change the brake and clutch fluids.• Replace the brake and clutch hoses every four years and if cracked or damaged.
15Sidestand, center-stand
• Check operation.• Lubricate.
√ √ √ √ √
16 * Sidestand switch • Check operation. √ √ √ √ √ √
17 * Front fork • Check operation and for oil leakage. √ √ √ √
18 *Shock absorber assembly
• Check operation and shock absorber for oil leak-age.
√ √ √ √
19 *
Rear suspension relay arm and con-necting arm pivot-ing points
• Check operation. √ √ √ √
• Lubricate with lithium-soap-based grease. √ √
20 *Electronic fuel injection
• Adjust engine idling speed and synchronization. √ √ √ √ √ √
21 Engine oil• Change.• Check oil level and vehicle for oil leakage.
√ √ √ √ √ √
22Engine oil filter cartridge
• Replace. √ √ √
23 * Cooling system
• Check coolant level and vehicle for coolant leak-age.
√ √ √ √ √
• Change. Every 3 years
24 Final gear oil• Check oil level and vehicle for oil leakage.• Change.
√ √ √ √ √
25 *Front and rear brake switches
• Check operation. √ √ √ √ √ √
26Moving parts and cables
• Lubricate. √ √ √ √ √
27 *Throttle grip hous-ing and cable
• Check operation and free play.• Adjust the throttle cable free play if necessary.• Lubricate the throttle grip housing and cable.
√ √ √ √ √
28 *Muffler and exhaust pipe
• Check the screw clamp for looseness. √ √ √ √ √
29 *Lights, signals and switches
• Check operation.• Adjust headlight beam.
√ √ √ √ √ √
No. ITEM CHECK OR MAINTENANCE JOBODOMETER READING (× 1,000 km) ANNUAL
CHECK1 10 20 30 40
– 7 –
CHKADJSEATS AND FUEL TANK
SEATS AND FUEL TANKEAS00040
FUEL TANK
Order Job/Part Q’ty RemarksRemoving the fuel tank Remove the parts in the order listed.Rider seat Refer to “SEATS AND FUEL TANK” in
chapter 3. (Manual No.: 5JW1-AE1)Fuel Drain.
1 Fuel tank side panel (left and right) 1/12 Bolt 23 Nut 14 Fuel sender coupler 15 Fuel pump coupler 16 Fuel tank overflow hose 17 Fuel tank breather hose 18 Hose holder 19 Fuel hose holder 1
– 8 –
CHKADJSEATS AND FUEL TANK
Order Job/Part Q’ty Remarks10 Fuel hose 1 Refer to “REMOVING THE FUEL TANK”.
Refer to “INSTALLING THE FUEL HOSE” in chapter 3. (Manual No.: 5JW1-AE1)
11 Bolt 112 Fuel tank 1 Refer to “REMOVING THE FUEL TANK”.
For installation, reverse the removal procedure.
– 9 –
CHKADJ
REMOVING THE FUEL TANK1. Remove the fuel in the fuel tank through the
fuel tank filler hole with a pump.2. Remove:• fuel hose
CAUTION:
Although the fuel has been removed fromthe fuel tank, be careful when removing thefuel hose since there may be fuel remainingin it.
NOTE:• To remove the fuel hose from the fuel injec-
tion pipe, slide the cover a on the end of thehose in the direction of the arrow shown, andthen remove the hose.
• Before removing the hose, place a few ragsin the area under the hose.
3. Remove:• fuel tank
NOTE:Do not set the fuel tank down on the installa-tion surface of the fuel pump. Be sure to leanthe fuel tank up against a wall, etc., in anupright position.
a
SEATS AND FUEL TANK
– 10 –
CHKADJ
EAS00043
AIR FILTER CASE
Order Job/Part Q’ty RemarksRemoving the air filter case Remove the parts in the order listed.Seats Refer to “SEATS AND FUEL TANK” in
chapter 3. (Manual No.: 5JW1-AE1)Fuel tank Refer to “SEATS AND FUEL TANK”.Side covers (left and right) Refer to “COWLINGS AND COVERS”.
(Manual No.: 5JW1-AE2)1 Air shroud 12 Air filter case cover 13 Air filter element 14 Tray 15 Fuel tank bracket 16 Plastic locking tie 17 Intake air temperature sensor coupler 18 Bypass air unit inlet hose 1 Disconnect.9 Crankcase breather hose 1 Disconnect.
AIR FILTER CASE
– 11 –
CHKADJ
Order Job/Part Q’ty Remarks10 Air induction system hose 5 1 Disconnect.11 Clamp screw 4 Loosen.12 Air filter case 113 Air filter case breather hose 1
For installation, reverse the removal procedure.
AIR FILTER CASE
– 12 –
FIFUEL INJECTION SYSTEM
FUEL INJECTION SYSTEMFUEL INJECTION SYSTEM1 Ignition coil 2 Air filter case3 Intake air tempera-
ture sensor4 Fuel delivery hose5 Fuel tank6 Fuel pump
7 Intake air pressure sensor
8 Throttle position sensor9 Fuel injector0 O2 sensorA Catalytic converterB Crankshaft position
sensor
C Coolant temperature sensor
D Spark plugE Cylinder identifica-
tion sensorF BatteryG ECUH Fuel injection system
relay
I Engine trouble warn-ing light
J Lean angle cut-off switch
K Air cut-off valve
6
8
4523 G
HJ
7
A9 0BDCK
1
I
F
E
– 13 –
FIFUEL INJECTION SYSTEM
WIRING DIAGRAM (FJR1300)
ON
OF
FP
R
RR
Br/
L Br/
R
BB
1B
B2
BB
4B
B3
G/Y
Br
BL Y
Ch
Dg
Y Dg
BL/
R
Ch
Dg
Ch
Br/W
Br/W Ch
Dg
Br/W
Br/G
B/R
R/B
B/R
R/B
R/B
B/R
BB
L/Y
B/Y
B/Y
L/Y
(BLA
CK
)(B
LAC
K)
R
R R
R Br/
LB
r/L
Br/R
Br/R
(BLA
CK
)
(GR
AY
)
WW
W
BG
/W
BR
/L
RB
BBRR
R
R
R
Br/
LB
r/Y
BBBRR
R
B
L/W
R/G
BB
R/W
R/W
R L/W
B
R B
R
B
B
B
B
WWW
WWW
R
B
R/Y
G/L
G/LR
/Y
Y/B Y
/BY
/BA
R/Y
R/Y
A
A
L/W
Lg
L/G
L/G
Sb
Sb
Sb
Sb
B/Y
B
R/B
LgR
/BB
/RL/
WL/
WW
/LR
/LR
/WL/
GL/
YS
bB
/YR
R/Y
BB
B2
Br/
R
L/R
L/R
Br/
G
Br/
LR
/W
Br/
LR
/Y
W/L
Br/
LB
r/B
Br/
B
Br/
B
B
Sb/W
Sb/W
Sb/W
O/W
O/W
O/W
O/W
Br
Br
O/W
Sb/
W
Br
Br
AB
r/G
Br/
G
AB
r/W
Br/
W
AG/B
G/B
LgS
bD
gC
h
BrP
Br/
W
Br/
R
R/W
R/G
G/W
Y/L
Y/L
LB/L
Gy/
RW/Y
B2
B2
B2
Y/L
G/B
Br/
G
Br/
W
ALL
R
L
AG/Y
R/B
B/R
B/R
L/R
L/R
G/B
R/B
G/Y
G/Y
B
B
B
B
B
Br/
Y
Br/
Y
Br/
YB
r/R
L B
R
BLgSb
LgSb
LgSb
Br/
B
YBr
B
BB
A Y
P
Y
Y
R/W
R/W
G/Y
LBr/B
G/B
BY GG/L
Y/B
G/L
R/Y
R/Y
LBLB
(BLA
CK
)(B
LAC
K)
Gy
B/L BGy
(BLU
E)
(DA
RK
GR
AY
)(D
AR
K G
RA
Y)
(BLA
CK
)
B
BLg
Br/R
Sb
Br/Y
RLg
Br/R
BR
Br
Sb
LgY
/LR
/GR
/GG
/LR
/WR
/WB
Y/LB
BB
B2
L/R
Ch
Dg
Y
L/R
Br/
W
Gy/
G
Gy/
R
Br/
RB
r/W
W/Y
P/W
W/B
G/W
Y/GB/L
B/L
L/R
YG
Y
BB
BYG
B
B
G
P
G
BY
G
BY
G/W
R/L
O/B
O/B
O/B
B/L
(BLA
CK
)
(BLA
CK
)
G/W
R/L
B Dg
Dg
C W WW
W Y Ch
Dg
Lg
A LgLg
C A
C R/G
R/G
B
G/W
G/W
B Ch
Ch
BL/
R
Br/W
B/L
R/LO
/B
BL/
R
Br
UP
DO
WN
ON
OFF
DgB
r/W C
h
DL
L
EY
Y
E
D
R/W
Br/
R
E
B/W
R/W
B3
YGy
O/B
Y/B
G/Y
Y/L
R/B
G/B
L/B
L
O
O
L
R/L
R/LD
B/L
B/L
E
WL
B1
BB
B2
B2
B/L
W/B
W/B
W/B
EP
/WP
/W
B/LGy
B/L Y LB
/L
Gy/
G
Gy/
GG
y/G
WL/
Y
B/L
LW
/B
B/L
WL/
Y
B/L
LW
/Y
B/L
LY
B/L
(BLA
CK
)
(DA
RK
GR
EE
N)
L B/L
P/W
P/W
B/L
L
(BLA
CK
)
L
O/W
B
(BLA
CK
)
Y/G B/L
Br/R
R/W
Br
Br/R
(GR
AY)
R/L
L/B
L/B
L/B
R/L
L/B
D
(GR
AY)
R/L
G/B
G/B
G/B
R/LG
/B
D
(GR
AY)
R/L
R/B
R/B
R/B
R/LR
/B
D
(GR
AY)
R/B
R/G
B2Br
/RR/
WG
/WY
/LG
/LLg
YL
Ch
W Dg
(BLA
CK
)
(BLU
E)
(BLU
E)
(BLU
E)
L/G
B
BB
BB
1B
B2
BB
4B
B3
BBBB
R/W
R/B
L/W
G/Y
Br
BR
/WR
/BW
/LG
/YB
rB
C
B/L
P/W
Gy/
GY
W/B
B/L
P/W
W/B
YG
y/G
E
(BLA
CK
)(B
LAC
K)
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
L/B
O/B
LR
/LR
/BG
/BO
/BL
L/B
G/B
R/B
R/L
D
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
C
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
1
R/G
G/L
G/L
O/W
O/W
WY
/LR
/GY
/LW
WIR
E H
AR
NE
SS
B
SU
B-W
IRE
H
AR
NE
SS
1
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
A
SU
B-W
IRE
H
AR
NE
SS
1W
IRE
HA
RN
ES
S
Y/B
Br/B
YLg
Br/W
R/W
R/W
B2
B2
LBr
/B LG
/YY
/BG
/YBr
/GLg Br
/GG
/BY G/B
R/Y
Br/W
R/Y
PB
Lg Sb
Br/W
L/B
Ch
Dg
B/Y
YR
/YL/
YP
BS
bLgBr
/WG
/BC
h
Dg
B/Y
YR
/YB
/R
B/R
B/Y
Br
R/W
R/W
A
L
LY
/GB
/L
B/R
G/Y
Y/G
B/Y
B/L
Y/B
Gy
L/Y
R/W
Y/L
R/L
Br/R
L/W
YW
/YR/
WG
/WP/
WBr
/WB/
WW
/BGy
/GR
/BL
G/B
L/B
B3
O/B
OGy
/R
(BLA
CK
)
B/R
L/Y
R/L
BY
/LR
/WG
/LR
/G
L/W
R/W
W/L
G/L
R/B
R/W
BB
rB
r
G/W
B/L
Gy/G
B/L
R/B
OF
F
(BR
OW
N)
(BR
OW
N)
Br
YB
B
Ch B
Dg BF Dg
Dg
G Ch
Ch
F BBG BB
BC
hD
gB
LB
Br/G
G
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
ChB
LB
Br/G
F
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
DgB
2
65
3
1
4
=
AB
8
9
7
D
E
C
J
K
GF
L M
I
N O
W
Q
U VTSR
YZ
XZ
d ecb f
[\ ^
a
ww
nm
s
t
vv
r
kl
i
g
j
oo
†
å
~
¢
ß
®
¶
£•
™
µ¥
©H
ç
§
|
x
y
z
h
u
P
qp
]
R/W B/Y
L/Y
R/L
B/R
L/W
2M
ain
switc
h 6
Mai
n fu
se
7B
atte
ry
8F
uel i
njec
tion
syst
em fu
seC
Fue
l inj
ectio
n sy
stem
rel
ayH
Fue
l pum
pI
O2
sens
orJ
Cyl
inde
r id
entif
icat
ion
sens
orK
Thr
ottle
pos
ition
sen
sor
LIn
take
air
pres
sure
sen
sor
MLe
an a
ngle
cut
-off
switc
hN
Inta
ke a
ir te
mpe
ratu
re s
enso
r
OC
oola
nt te
mpe
ratu
re s
enso
rP
Cra
nksh
aft p
ositi
on s
enso
rQ
EC
U (
engi
ne)
RC
ylin
der
#1 -
inje
ctor
SC
ylin
der
#2 -
inje
ctor
TC
ylin
der
#3 -
inje
ctor
UC
ylin
der
#4 -
inje
ctor
VA
ir in
duct
ion
syst
em s
olen
oid
WS
peed
sen
sor
£Ig
nitio
n fu
se¥
Eng
ine
stop
sw
itch
– 14 –
FIFUEL INJECTION SYSTEM
WIRING DIAGRAM (FJR1300A)
ON
OF
FP
R
RR
Br/
L Br/
R
BB
1B
B2
BB
4B
B3
G/Y
Br
BL Y
Ch
Dg
Y Dg
BL/
R
Ch
Dg
Ch
Br/W
Br/W Ch
Dg
Br/W
Br/G
B/R
R/B
B/R
R/B
R/B
B/R
BB
L/Y
B/Y
B/Y
L/Y
(BLA
CK
)(B
LAC
K)
R
R R
R Br/
LB
r/L
B B/W
R R/L
BB
/W
R R/L
Br/R
Br/R
(BLA
CK
)
(GR
AY
)
WW
W
BG
/W
BR
/L
RB
BBRR
R
R
R
Br/
LB
r/Y
BBBRRR
L/W
BB
R/W
R/W
R L/W
B
B
B
B
WWW
WWW
R
B
R/Y
G/L
G/LR
/Y
Y/B Y
/BY
/BA
R/Y
R/Y
A
A
L/W
Lg
L/G
L/G
Sb
Sb
Sb
Sb
B/Y
B
R/B
R/Y
BB
B2
Br/
R
L/R
L/R
Br/
G
Br/
LR
/W
Br/
LR
/Y
W/L
Br/
LB
r/B
Br/
B
Br/
B
B
Sb/W
Sb/W
Sb/W
O/W
O/W
O/W
O/W
Br
Br
O/W
Sb/
W
Br
Br
AB
r/G
Br/
G
AB
r/W
Br/
W
AG/B
G/B
LgS
bD
gC
h
BrP
Br/
W
Br/
R
R/W
R/G
G/W
Y/L
LB/L
Gy/
R
W/Y
B2
B2
B2
G/B
Br/
G
Br/
W
ALL
R
L
AG/Y
R/B
B/R
B/R
L/R
L/R
G/B
R/B
G/Y
G/Y
B
B
B
B
B
Br/
Y
Br/
Y
Br/
YB
r/R
L B
R
BLgSb
LgSb
LgSb
Br/
B
YBr
B
BB
A Y
P
Y
Y
R/W
R/W
G/Y
LBr/B
G/B
BY GG/L
Y/B
G/L
R/Y
R/Y
LBLB
(BLA
CK
)(B
LAC
K)
(BR
OW
N)
(BR
OW
N)
Gy
B/L BGy
(BLU
E)
(DA
RK
GR
AY
)(D
AR
K G
RA
Y)
(BLA
CK
)
B
BLg
Br/R
Sb
Br/Y
RLg
Br/R
BR
Br
Sb
LgY
/LR
/GR
/GG
/LR
/WR
/WB
Y/LB
BB
B2
L/R
Ch
Dg
Y
L/R
Br/
W
Gy/
G
Gy/
R
Br/
RB
r/W
W/Y
P/W
W/B
R/W
G/W
Y/GB/L
B/Y
L/Y
R/L
B/L
L/R
YG
Y
BB
Ch B
BYG
B
B
G
P
G
BY
G
BY
G/W
R/L
O/B
O/B
O/B
B/L
(BLA
CK
)
(BLA
CK
)
G/W
R/L
Dg BB Dg
Dg
C W WW
W Y Ch
Dg
Lg
A LgLg
Y/L
Y/L
C A
C R/G
R/G
B
G/W
G/W
B Ch
Ch
F Dg
Dg
G Ch
Ch
F BBG BB
BL/
R
Br/W
B/L
R/LO
/B
BL/
R
Br
UP
DO
WN
ON
OFF
DgB
r/W C
h
DL
L
EY
Y
E
D
R/W
Br/
R
E
B/W
R/W
B3
YGy
O/B
Y/B
G/Y
Y/L
R/B
G/B
L/B
L
O
O
L
R/L
R/LD
B/L
B/L
E
WL
B1
BB
B2
B2
B/L
W/B
W/B
W/B
EP
/WP
/W
B/LGy
B/L
Y LB/L
Gy/
G
Gy/
GG
y/G
WL/
Y
B/L
LW
/B
B/L
WL/
Y
B/L
LW
/Y
B/L
LY
B/L
(BLA
CK
)
(DA
RK
GR
EE
N)
L B/L
P/W
P/W
B/L
L
(BLA
CK
)
L
O/W
B
(BLA
CK
)
Y/G B/L
Br/R
R/W
Br
Br/R
(GR
AY)
R/L
L/B
L/B
L/B
R/L
L/B
D
(GR
AY)
R/L
G/B
G/B
G/B
R/LG
/B
D
(GR
AY)
R/L
R/B
R/B
R/B
R/LR
/B
D
(GR
AY)
R/B
R/G
B2Br
/RR/
WG
/WY
/LG
/LG
/RLg
YL
Ch
W Dg
(BLA
CK
)
(BLU
E)
(BLU
E)
(BLU
E)
L/G
B
BB
Br
YB
B
Gy
W
BB
1B
B2
BB
4B
B3
BBBB
R/W
R/B
L/W
G/Y
Br
BR
/WR
/BW
/LG
/YB
rB
B/W R/L
B R/L
YBr
/WL/
W
B1
LgSb
B2
W1
G/R
LgSb
B1
B2
W1
G/R
R GR W
RB
WWR R
YBr
/WL/
W
LB
Br/G
C
B/L
P/W
Gy/
GY
W/B
B/L
P/W
W/B
YG
y/G
E
(BLA
CK
)(B
LAC
K)
(BLA
CK
)(B
LAC
K)
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
L/B
O/B
LR
/LR
/BG
/BO
/BL
L/B
G/B
R/B
R/L
D
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
G
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
C
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
1
R/G
G/L
G/R
G/R
G/L
O/W
O/W
WY
/LR
/GY
/LW
WIR
E H
AR
NE
SS
B
SU
B-W
IRE
H
AR
NE
SS
1
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
A
SU
B-W
IRE
H
AR
NE
SS
1W
IRE
HA
RN
ES
SY/B
Br/B
YLg
Br/W
R/W
R/W
B2
B2
LBr
/B LG
/YY
/BG
/YBr
/GLg Br
/GG
/BY G/B
R/Y
Br/W
R/Y
PB
Lg Sb
Br/W
L/B
Ch
Dg
B/Y
YR
/YL/
Y
BC
hD
gB
PB
SbLg
Br/W
G/B
Ch
Dg
B/Y
YR
/YB
/R
B/R
B/Y
Br
R/W
R/W
A
L
LY
/GB
/L
B/R
L/W
B/R
L/Y
R/L
BY
/LR
/WG
/LR
/G
L/W
R/W
W/L
G/L G/R
G/R
R/B
R/W
BB
rB
r
G/W
B/L
Gy/G
B/L
R/B
Br/W
Br/L
LgR
/BB
/RL/
WL/
WW
/LR
/LR
/WL/
GL/
YS
bB
/YR
B/R
G/Y
Y/G
B/Y
B/L
Y/B
Gy
L/Y
R/W
Y/L
R/L
Br/R
L/W
YW
/YR/
WG
/WP/
WBr
/WB/
WW
/BGy
/GR
/BL
G/B
L/B
B3
O/B
OGy
/R
(BLA
CK
)
B1
B2 Y
Y
W1
B2
W1
B1
W1
W1
B1
Sb
Sb
LgS
bLg
Sb
Lg
B3
W2
Lg
R/L
B/W
R/L
B/W
R/W
W/R
L/W
Br/
W
G/R
L/W
W/R
W/B
W/B
Br/
WL/
WB
r/W
Br/
W
B
R/L
R/G
B/W
B
G/R
G/R
C
OF
F
B1
GG
B
B
R RR
Y
B4
B5
B2
W1
B1
P/W
P/W
G/R
R/L
B
R/W
R/W
R/W
W2
B3
Gy
W
WW
B4B5Sb
WY
GR/
W
RB
R/W
W/B
R/L
G/R
P/W
Br/W
Br/W
B2B1
B3W
1W
2Lg
L/W
P/W
W/B
W/R
Sb
LgB W/R
ChB
LB
Br/G
F
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
DgB
2
6 75
3
1
4
B
CD
0
A
9
8
F
G
E
\
Z[
]
^
L
M
IH
N O
K
P QY
S
W
X
VUT
de
ce
bn oml p
fg i
k
††
xw
~
çç
|
z
uv
s
q
t
yyß
¥
©
®
µ
¬
…
¡
ºø
¤
›‹
ÕJ
™
æ
¶
¢
£
§•
ah j
r
R
å
2M
ain
switc
h 7
Mai
n fu
se
9B
atte
ry
0F
uel i
njec
tion
syst
em fu
seE
Fue
l inj
ectio
n sy
stem
rel
ayJ
Fue
l pum
pK
O2
sens
orL
Cyl
inde
r id
entif
icat
ion
sens
orM
Thr
ottle
pos
ition
sen
sor
NIn
take
air
pres
sure
sen
sor
OLe
an a
ngle
cut
-off
switc
hP
Inta
ke a
ir te
mpe
ratu
re s
enso
r
QC
oola
nt te
mpe
ratu
re s
enso
rR
Cra
nksh
aft p
ositi
on s
enso
rS
EC
U (
engi
ne)
TC
ylin
der
#1 -
inje
ctor
UC
ylin
der
#2 -
inje
ctor
VC
ylin
der
#3 -
inje
ctor
WC
ylin
der
#4 -
inje
ctor
XA
ir in
duct
ion
syst
em s
olen
oid
YS
peed
sen
sor
ºIg
nitio
n fu
se‹
Eng
ine
stop
sw
itch
– 15 –
FIFUEL INJECTION SYSTEM
* Table of self-diagnostic fault code numbers displayed on meter
• How to erase the self-diagnostic fault code from memory:If the ECU detects a normal signal upon the completion of the repair of the malfunction, the self-diagnostic fault code disappears from the meter and is replaced by the normal clock display. How-ever, the self-diagnostic fault code of the previous malfunction remains in the ECU memory aspart of the malfunction history. To erase the self-diagnostic fault code from the malfunction history,the operation for diagnostic code 62 must be performed in the diagnosis mode.
No. SymptomAble/
unable to start
Able/unable to
driveNo. Symptom
Able/unable to
start
Able/unable to
drive
11No normal signals are received from the cylinder identification sensor.
Able Able 30The motorcycle has overturned.
Unable Unable
12
No normal signals are received from the crankshaft position sen-sor.
Unable Unable 31
The amount of air-fuel ratio feed-back compensation is maintained continuously in the vicinity of the upper limit (lean air-fuel ratio).
Able Able
13
Intake air pressure sensor - open or short circuit detected.
Able Able 32
The amount of air-fuel ratio feed-back compensation is maintained continuously in the vicinity of the lower limit (rich air-fuel ratio).
Able Able
14Faulty intake air pressure sensor pipe system; a hose is detached or clogged.
Able Able 33Open circuit detected in the pri-mary wire of the ignition coil (#1,4).
Able Able
15Throttle position sensor - open or short circuit detected.
Able Able 34Open circuit detected in the pri-mary wire of the ignition coil (#2, 3).
Able Able
16A stuck throttle position sensor is detected.
Able Able 41Lean angle cut-off switch - open or short circuit detected.
Unable Unable
19
A break or disconnection of the black/red lead of the ECU is detected.
Unable Unable 42
No normal signals are received from the speed sensor; or, an open or short circuit is detected in the neutral switch.
Able Able
21Coolant temperature sensor - open or short circuit detected. Able Able 43
The ECU is unable to monitor the battery voltage (an open circuit in the line to the ECU).
Able Able
22Intake air temperature sensor - open or short circuit detected. Able Able 44
An error is detected while reading or writing on EEPROM (CO adjustment value).
Able Able
24
No normal signals are received from the O2 sensor.
Able Able 50
Faulty ECU memory. When this malfunction is detected, the code number might not appear on the meter.
Unable Unable
– 16 –
FIFUEL INJECTION SYSTEM
SUBSTITUTE CHARACTERISTICS OPERATION CONTROL (FAIL-SAFE ACTION)If the ECU detects an abnormal signal from a sensor while the motorcycle is being driven, the ECUilluminates the engine trouble warning light and provides the engine with substitute characteristicoperation instructions that are appropriate for the type of the malfunction.When an abnormal signal is received from a sensor, the ECU processes the specified values thatare programmed for every sensor, in order to provide the engine with substitute characteristicsoperation instructions that enable the engine to continue to operate (or to stop its operation,depending on circumstances).The ECU takes fail-safe actions in two ways: one in which the sensor output is set to a prescribedvalue, and the other in which the ECU directly operates an actuator. Details on the fail-safe actionsare given in the table below.
Table of substitute characteristic operation control by self-diagnostic fault code
Code No. Item Fail-safe actionAble/unable to
startAble/unable to
drive
11Cylinder identification sensor
Continues to operate the engine based on the results of the cylinder identification that existed up to that point.
Able Able
12Crankshaft position sen-sor
• Stops the engine (by stopping the injection and ignition).
Unable Unable
1314
Intake air pressure sensor (open or short circuit) (pipe system)
• Fixes the intake air pressure to 760 mmHg.Able Able
1516
Throttle position sensor (open or short circuit) (stuck)
• Fixes the throttle position sensor to fully open.Able Able
19Broken or disconnected black/red lead of the ECU.
-- (No start)Unable Unable
21Coolant temperature sen-sor
• Fixes the coolant temperature to 60 °C.Able Able
22Intake air temperature sensor
• Fixes the intake temperature to 20 °C.Able Able
243132
O2 sensor (inactive) (compensation stuck to upper limit) (compensation stuck to lower limit)
--
Able Able
3334
Faulty ignition • Fuel is cut off only to the cylinder in which a mal-function is detected.
Able(depending on the number of
faulty cylinders)
Able(depending on the number of
faulty cylinders)
3041
Lean angle cut-off switch (latch up detected) (open or short circuit)
• Turns OFF the fuel injection system relay of the fuel system. Unable Unable
42Speed sensor, neutral switch
• Fixes the gear to the top gear.Able Able
43Fuel system voltage (monitor voltage)
• Fixes the battery voltage to 12 V.Able Able
44Error in writing the amount of CO adjust-ment on EEPROM
--Able Able
50ECU internal malfunction (memory check error)
--Unable Unable
– 17 –
FIFUEL INJECTION SYSTEM
Self-diagnostic fault codes, symptoms, and probable causesDiagnostic code indication
Code No. Symptom Probable cause of malfunction Diagnostic code
11
No normal signals are received from the cylinder identification sensor.
• Open or short circuit in wiring sub lead.• Open or short circuit in wiring harness.• Defective cylinder identification sensor.• Malfunction in ECU.• Improperly installed sensor.
—
12
No normal signals are received from the crankshaft position sensor.
• Open or short circuit in wiring harness.• Defective crankshaft position sensor.• Malfunction in pickup rotor.• Malfunction in ECU.• Improperly installed sensor.
—
13
Intake air pressure sensor - open or short circuit detected.
• Open or short circuit in wiring sub lead.• Open or short circuit in wiring harness.• Defective intake air pressure sensor.• Malfunction in ECU.
03
14
Faulty intake air pressure sensor pipe system; a hose is detached or clogged.
• Intake air pressure sensor hose is detached, clogged, kinked, or pinched.
• Malfunction of the intake air pressure sensor in the interme-diate electrical potential.
• Malfunction in ECU.
03
Or, intake air pressure sensor - open or short circuit detected.
• Open or short circuit in wiring sub lead.• Open or short circuit in wiring harness.• Defective intake air pressure sensor.• Malfunction in ECU.
03
Or, a stuck throttle position sensor is detected.
• Open or short circuit in wiring sub lead.• Open or short circuit in wiring harness.• Defective sensor (stuck throttle position sensor).
01
15
Throttle position sensor - open or short circuit detected.
• Open or short circuit in wiring sub lead.• Open or short circuit in wiring harness.• Defective throttle position sensor.• Malfunction in ECU.• Improperly installed throttle position sensor.
01
16
A stuck throttle position sensor is detected.Or,Faulty intake air pressure sensor pipe system; a hose is detached or clogged.
• Open or short circuit in wiring sub lead.• Open or short circuit in wiring harness.• Defective sensor (stuck throttle position sensor).• Intake air pressure sensor hose is detached, clogged,
kinked, or pinched.• Malfunction of the intake air pressure sensor in the interme-
diate electrical potential.• Malfunction in ECU.
0103
19A break or disconnection of the black/red of the ECU is detected when the start switch is pressed.
• Open circuit in wiring harness.• Malfunction in ECU.• Defective ECU coupler.
20
21
Coolant temperature sensor - open or short circuit detected.
• Open or short circuit in wiring harness.• Defective coolant temperature sensor.• Malfunction in ECU.• Improperly installed sensor.
06
22
Intake air temperature sensor - open or short circuit detected.
• Open or short circuit in wiring harness.• Defective intake air temperature sensor.• Malfunction in ECU.• Improperly installed sensor.
05
– 18 –
FIFUEL INJECTION SYSTEM
24
No normal signals are received from the O2 sensor.
• Open or short circuit in wiring harness.• Defective O2 sensor.• Malfunction in ECU.• Improperly installed sensor.
—
30The motorcycle has overturned. • Overturned.
• Malfunction in ECU.08
31
The amount of air-fuel ratio feedback compensation is maintained continu-ously in the vicinity of the upper limit (lean air-fuel ratio).
• Open or short circuit in wiring harness.• Fuel pressure too low.• Clogged injectors.• Defective O2 sensor (unable to output a rich signal).• Malfunction in ECU.• Malfunction in other areas of the fuel system.
—
32
The amount of air-fuel ratio feedback compensation is maintained continu-ously in the vicinity of the lower limit (rich air-fuel ratio).
• Open or short circuit in wiring harness.• Fuel pressure too high.• Faulty injectors (excessive injection volume).• Defective O2 sensor (unable to output a lean signal).• Malfunction in ECU.• Malfunction in other areas of the fuel system.
—
33
Open circuit is detected in the primary wire of the ignition coil (#1, 4).
• Open or short circuit in wiring harness.• Malfunction in ignition coil.• Malfunction in ECU.• Malfunction in a component of ignition cutoff circuit system.
30
34
Open circuit is detected in the primary wire of the ignition coil (#2, 3).
• Open or short circuit in wiring harness.• Malfunction in ignition coil.• Malfunction in ECU.• Malfunction in a component of ignition cutoff circuit system.
31
41Lean angle cut-off switch - open or short circuit detected.
• Open or short circuit in wiring harness.• Defective lean angle cut-off switch.• Malfunction in ECU.
08
42
No normal signals are received from the speed sensor; or, an open or short circuit is detected in the neutral switch.
• Open or short circuit in wiring harness.• Defective speed sensor.• Malfunction in vehicle speed sensor detected unit.• Defective neutral switch.• Malfunction in the engine side of the neutral switch.• Malfunction in ECU.
0721
43The ECU is unable to monitor the bat-tery voltage (an open circuit in the monitor line to the ECU).
• Open circuit in wiring harness.• Malfunction in ECU. —
44An error is detected while reading or writing on EEPROM.
• Malfunction in ECU. (The CO adjustment value is not prop-erly written on or read from the internal memory).
60
50Faulty ECU memory. When this mal-function is detected, the code number might not appear on the meter.
• Malfunction in ECU. (The program and data are not properly written on or read from the internal memory.) —
Code No. Symptom Probable cause of malfunction Diagnostic code
– 19 –
FIFUEL INJECTION SYSTEM
Sensor operation data display verification table
NOTE:• Check the intake air temperature and coolant temperature as close as possible to the area in
which the respective sensor is mounted.• If it is not possible to check the intake temperature, use the ambient temperature as reference
(use the compared values for reference).
Diag code Item Description of actionData displayed on meter
(reference value)
01Throttle angle Displays the throttle angle.
• Check with throttle fully closed.• Check with throttle fully open.
0 ~ 125 degrees• Fully closed position (15 ~ 17)• Fully open position (97 ~ 100)
03
Pressure difference (atmospheric pres-sure - intake air pres-sure)
Displays the pressure difference (atmospheric pressure - intake air pressure).Engine stop switch is on.* Generate the pressure difference by cranking the engine
with the starter, without actually starting the engine.
Before cranking: Atmospheric pressure (standard pressure is 760 mmHg)After cranking: Value is lower than the atmospheric pressure
05Intake air tempera-ture
Displays the intake air temperature.* Check the temperature in the air cleaner case.
Compare it to the value dis-played on the meter.
06Coolant temperature Displays the coolant temperature.
* Check the temperature of the coolant.Compare it to the value dis-played on the meter.
07Vehicle speed pulse Displays the accumulation of the vehicle pulses that are gen-
erated when the tire is spun.(0 ~ 999; resets to 0 after 999)OK if the numbers appear on the meter.
08Lean angle cut-off switch
Displays the lean angle cut-off switch values. Upright: 0.4 ~ 1.4 VOverturned: 3.8 ~ 4.2 V
09Fuel system voltage (battery voltage)
Displays the fuel system voltage (battery voltage).Engine stop switch is on.
0 ~ 18.7 VNormally, approximately 12.0 V
20Sidestand switch Displays that the switch is ON or OFF. (When the gear is in a
position other than neutral.)Stand retracted: ONStand extended: OFF
21Neutral switch Displays that the switch is ON or OFF. Neutral: ON
In gear: OFF
60
E2PROM fault code display
• Transmits the abnormal portion of the data in the E2PROM that has been detected as a self-diagnostic fault code 44.
• If multiple malfunctions have been detected, different codes are displayed at 2-second intervals, and this process is repeated.
(01 ~ 04) Displays the cylinder number.(00) Displays when there is no malfunction.
61
Malfunction history code display
• Displays the codes of the history of the self-diagnosis mal-functions (i.e., a code of a malfunction that occurred once and which has been corrected).
• If multiple malfunctions have been detected, different codes are displayed at 2-second intervals, and this process is repeated.
11 ~ 50(00) Displays when there is no malfunction.
62
Malfunction history code erasure
• Displays the total number of codes that are being detected through self diagnosis and the fault codes in the past his-tory.
• Erases only the history codes when the engine stop switch is turned from OFF to ON. If the engine stop switch is ON, turn it OFF once, and then turn it back ON.
00 ~ 21(00) Displays when there is no malfunction.
70 Control number • Displays the program control number. 00 ~ 255
– 20 –
FIFUEL INJECTION SYSTEM
Troubleshooting detailsTroubleshooting the self-diagnostic fault code
Code No. 19 Symptom A break or disconnection of the black/red lead of the ECU is detected.Used diagnostic code No. 20 (sidestand switch)Inspection operation item and probable cause Operation item and countermeasure Reinstatement
methodDefective sidestand switch Replace if defective.
Refer to “CHECKING THE SWITCHES” in chapter 8. (Manual No.: 5JW1-AE1)
If the transmission is in gear, it is rein-stated by retracting the sidestand.If the transmission is in neutral, it is reinstated by reconnecting the wiring.
Open circuit in wiring harness or sub lead. Repair or replace if there is an open circuit.(Between ECU and black/red lead)
Connected state of connectorInspect the coupler for any pins that may have pulled out.Check the locking condition of the coupler.
If there is a malfunction, repair it and connect it securely.Main wiring harness ECU coupler
(black/red)
– 21 –
FIFUEL INJECTION SYSTEM
THROTTLE BODIES
8
9
2 4
1
5
5
5
5
10
10
3
7
7
6
10
10
Order Job/Part Q’ty RemarksRemoving the throttle bodies Remove the parts in the order listed.Seats/T-bar/rubber sheet Refer to “SEATS AND FUEL TANK” in
chapter 3. (Manual No.: 5JW1-AE1)Fuel tank Refer to “SEATS AND FUEL TANK”.Air filter case Refer to “AIR FILTER CASE”.Coolant Drain.
Refer to “CHANGING THE COOLANT” inchapter 3. (Manual No.: 5JW1-AE1)
1 O2 sensor coupler 1 Disconnect.2 Cylinder identification sensor coupler 1 Disconnect.3 Sub-wire harness 2 coupler 2 Disconnect.4 Throttle stop screw 15 Throttle body joint clamp screw 86 Throttle bodies 1
– 22 –
FIFUEL INJECTION SYSTEM
8
9
2 4
1
5
5
5
5
10
10
3
7
7
6
10
10
Order Job/Part Q’ty Remarks7 Throttle cable 2 Disconnect.8 Plunger control unit hose 1 1 Disconnect.9 Plunger control unit hose 2 1 Disconnect.
10 Throttle body joint 4For installation, reverse the removal procedure.
– 23 –
FIFUEL INJECTION SYSTEM
11
3
4
5
61
7
2
8
12
1314
10
10
10
9
Order Job/Part Q’ty RemarksRemoving the injectors Remove the parts in the order listed.
1 Throttle position sensor coupler 1 Disconnect.2 Intake air pressure sensor coupler 1 Disconnect.3 Cylinder #1-injector coupler 1 Disconnect.4 Cylinder #2-injector coupler 1 Disconnect.5 Cylinder #3-injector coupler 1 Disconnect.6 Cylinder #4-injector coupler 1 Disconnect.7 Sub-wire harness 2 18 Negative pressure hose 1 Disconnect.9 Bypass air unit 1
10 Bypass air unit outlet hose 4
– 24 –
FIFUEL INJECTION SYSTEM
11
3
4
5
61
7
2
8
12
1314
10
10
10
9
Order Job/Part Q’ty Remarks11 Intake air pressure sensor 112 Fuel injection pipe 113 Injector 414 Throttle position sensor 1
For installation, reverse the removal procedure.
– 25 –
FIAIR INDUCTION SYSTEM
AIR INDUCTION SYSTEMINSTALLING THE REED VALVES1. Install: • plate 1
NOTE:Align the notch a in each plate with the pro-jection b of each reed valve seat on the cylin-der head cover.
b
a
1
– 26 –
– +ELECELECTRICAL COMPONENTSEAS00729
ELECTRICALELECTRICAL COMPONENTS1 Windshield drive unit2 Battery3 Starter relay4 Fuel injection system fuse5 Front brake light switch 6 Clutch switch7 Fuse box
8 Radiator fan motor9 Wire harness 0 Neutral switchA Sidestand switchB Oil level switchC Rear brake light switchD Horn
E Ignition coilF Main fuseG ABS motor fuse (FJR1300A)
– 27 –
– +ELECELECTRICAL COMPONENTS
1 Coolant temperature sensor2 Intake air pressure sensor3 Intake air temperature sensor4 Relay unit5 Lean angle cut-off switch6 Hydraulic unit (FJR1300A)7 Fail-safe relay (FJR1300A)
8 ECU (engine)9 ECU (ABS) (FJR1300A)0 Speed sensorA Cylinder identification sensorB O2 sensorC Crankshaft position sensor
D Accessory box solenoidE Accessory box relayF Headlight relay 1G Radiator fan motor relayH Turn signal relayI Headlight relay 2
– 28 –
– +ELECFUEL INJECTION SYSTEM
FUEL INJECTION SYSTEMCIRCUIT DIAGRAM (FJR1300)
ON
OF
FP
R
RR
Br/
L Br/
R
BB
1B
B2
BB
4B
B3
G/Y
Br
BL Y
Ch
Dg
Y Dg
BL/
R
Ch
Dg
Ch
Br/W
Br/W Ch
Dg
Br/W
Br/G
B/R
R/B
B/R
R/B
R/B
B/R
BB
L/Y
B/Y
B/Y
L/Y
(BLA
CK
)(B
LAC
K)
R
R R
R Br/
LB
r/L
Br/R
Br/R
(BLA
CK
)
(GR
AY
)
WW
W
BG
/W
BR
/L
RB
BBRR
R
R
R
Br/
LB
r/Y
BBBRR
R
B
L/W
R/G
BB
R/W
R/W
R L/W
B
R B
R
B
B
B
B
WWW
WWW
R
B
R/Y
G/L
G/LR
/Y
Y/B Y
/BY
/BA
R/Y
R/Y
A
A
L/W
Lg
L/G
L/G
Sb
Sb
Sb
Sb
B/Y
B
R/B
LgR
/BB
/RL/
WL/
WW
/LR
/LR
/WL/
GL/
YS
bB
/YR
R/Y
BB
B2
Br/
R
L/R
L/R
Br/
G
Br/
LR
/W
Br/
LR
/Y
W/L
Br/
LB
r/B
Br/
B
Br/
B
B
Sb/W
Sb/W
Sb/W
O/W
O/W
O/W
O/W
Br
Br
O/W
Sb/
W
Br
Br
AB
r/G
Br/
G
AB
r/W
Br/
W
AG/B
G/B
LgS
bD
gC
h
BrP
Br/
W
Br/
R
R/W
R/G
G/W
Y/L
Y/L
LB/L
Gy/
RW/Y
B2
B2
B2
Y/L
G/B
Br/
G
Br/
W
ALL
R
L
AG/Y
R/B
B/R
B/R
L/R
L/R
G/B
R/B
G/Y
G/Y
B
B
B
B
B
Br/
Y
Br/
Y
Br/
YB
r/R
L B
R
BLgSb
LgSb
LgSb
Br/
B
YBr
B
BB
A Y
P
Y
Y
R/W
R/W
G/Y
LBr/B
G/B
BY GG/L
Y/B
G/L
R/Y
R/Y
LBLB
(BLA
CK
)(B
LAC
K)
Gy
B/L BGy
(BLU
E)
(DA
RK
GR
AY
)(D
AR
K G
RA
Y)
(BLA
CK
)
B
BLg
Br/R
Sb
Br/Y
RLg
Br/R
BR
Br
Sb
LgY
/LR
/GR
/GG
/LR
/WR
/WB
Y/LB
BB
B2
L/R
Ch
Dg
Y
L/R
Br/
W
Gy/
G
Gy/
R
Br/
RB
r/W
W/Y
P/W
W/B
G/W
Y/GB/L
B/L
L/R
YG
Y
BB
BYG
B
B
G
P
G
BY
G
BY
G/W
R/L
O/B
O/B
O/B
B/L
(BLA
CK
)
(BLA
CK
)
G/W
R/L
B Dg
Dg
C W WW
W Y Ch
Dg
Lg
A LgLg
C A
C R/G
R/G
B
G/W
G/W
B Ch
Ch
BL/
R
Br/W
B/L
R/LO
/B
BL/
R
Br
UP
DO
WN
ON
OFF
DgB
r/W C
h
DL
L
EY
Y
E
D
R/W
Br/
R
E
B/W
R/W
B3
YGy
O/B
Y/B
G/Y
Y/L
R/B
G/B
L/B
L
O
O
L
R/L
R/LD
B/L
B/L
E
WL
B1
BB
B2
B2
B/L
W/B
W/B
W/B
EP
/WP
/W
B/LGy
B/L Y LB
/L
Gy/
G
Gy/
GG
y/G
WL/
Y
B/L
LW
/B
B/L
WL/
Y
B/L
LW
/Y
B/L
LY
B/L
(BLA
CK
)
(DA
RK
GR
EE
N)
L B/L
P/W
P/W
B/L
L
(BLA
CK
)
L
O/W
B
(BLA
CK
)
Y/G B/L
Br/R
R/W
Br
Br/R
(GR
AY)
R/L
L/B
L/B
L/B
R/L
L/B
D
(GR
AY)
R/L
G/B
G/B
G/B
R/LG
/B
D
(GR
AY)
R/L
R/B
R/B
R/B
R/LR
/B
D
(GR
AY)
R/B
R/G
B2Br
/RR/
WG
/WY
/LG
/LLg
YL
Ch
W Dg
(BLA
CK
)
(BLU
E)
(BLU
E)
(BLU
E)
L/G
B
BB
BB
1B
B2
BB
4B
B3
BBBB
R/W
R/B
L/W
G/Y
Br
BR
/WR
/BW
/LG
/YB
rB
C
B/L
P/W
Gy/
GY
W/B
B/L
P/W
W/B
YG
y/G
E
(BLA
CK
)(B
LAC
K)
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
L/B
O/B
LR
/LR
/BG
/BO
/BL
L/B
G/B
R/B
R/L
D
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
C
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
1
R/G
G/L
G/L
O/W
O/W
WY
/LR
/GY
/LW
WIR
E H
AR
NE
SS
B
SU
B-W
IRE
H
AR
NE
SS
1
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
A
SU
B-W
IRE
H
AR
NE
SS
1W
IRE
HA
RN
ES
S
Y/B
Br/B
YLg
Br/W
R/W
R/W
B2
B2
LBr
/B LG
/YY
/BG
/YBr
/GLg Br
/GG
/BY G/B
R/Y
Br/W
R/Y
PB
Lg Sb
Br/W
L/B
Ch
Dg
B/Y
YR
/YL/
YP
BS
bLgBr
/WG
/BC
h
Dg
B/Y
YR
/YB
/R
B/R
B/Y
Br
R/W
R/W
A
L
LY
/GB
/L
B/R
G/Y
Y/G
B/Y
B/L
Y/B
Gy
L/Y
R/W
Y/L
R/L
Br/R
L/W
YW
/YR/
WG
/WP/
WBr
/WB/
WW
/BGy
/GR
/BL
G/B
L/B
B3
O/B
OGy
/R
(BLA
CK
)
B/R
L/Y
R/L
BY
/LR
/WG
/LR
/G
L/W
R/W
W/L
G/L
R/B
R/W
BB
rB
r
G/W
B/L
Gy/G
B/L
R/B
OF
F
(BR
OW
N)
(BR
OW
N)
Br
YB
B
Ch B
Dg BF Dg
Dg
G Ch
Ch
F BBG BB
BC
hD
gB
LB
Br/G
G
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
ChB
LB
Br/G
F
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
DgB
2
65
3
1
4
=
AB
8
9
7
D
E
C
J
K
GF
L M
I
N O
W
Q
U VTSR
YZ
XZ
d ecb f
[\ ^
a
ww
nm
s
t
vv
r
kl
i
g
j
oo
†
å
~
¢
ß
®
¶
£•
™
µ¥
©H
ç
§
|
x
y
z
h
u
P
qp
]
R/W B/Y
L/Y
R/L
B/R
L/W
2M
ain
switc
h 6
Mai
n fu
se
7B
atte
ry
8F
uel i
njec
tion
syst
em fu
seC
Fue
l inj
ectio
n sy
stem
rel
ayH
Fue
l pum
pI
O2
sens
orJ
Cyl
inde
r id
entif
icat
ion
sens
orK
Thr
ottle
pos
ition
sen
sor
LIn
take
air
pres
sure
sen
sor
MLe
an a
ngle
cut
-off
switc
hN
Inta
ke a
ir te
mpe
ratu
re s
enso
r
OC
oola
nt te
mpe
ratu
re s
enso
rP
Cra
nksh
aft p
ositi
on s
enso
rQ
EC
U (
engi
ne)
RC
ylin
der
#1 -
inje
ctor
SC
ylin
der
#2 -
inje
ctor
TC
ylin
der
#3 -
inje
ctor
UC
ylin
der
#4 -
inje
ctor
VA
ir in
duct
ion
syst
em s
olen
oid
WS
peed
sen
sor
£Ig
nitio
n fu
se¥
Eng
ine
stop
sw
itch
– 29 –
– +ELECFUEL INJECTION SYSTEM
CIRCUIT DIAGRAM (FJR1300A)
ON
OF
FP
R
RR
Br/
L Br/
R
BB
1B
B2
BB
4B
B3
G/Y
Br
BL Y
Ch
Dg
Y Dg
BL/
R
Ch
Dg
Ch
Br/W
Br/W Ch
Dg
Br/W
Br/G
B/R
R/B
B/R
R/B
R/B
B/R
BB
L/Y
B/Y
B/Y
L/Y
(BLA
CK
)(B
LAC
K)
R
R R
R Br/
LB
r/L
B B/W
R R/L
BB
/W
R R/L
Br/R
Br/R
(BLA
CK
)
(GR
AY
)
WW
W
BG
/W
BR
/L
RB
BBRR
R
R
R
Br/
LB
r/Y
BBBRRR
L/W
BB
R/W
R/W
R L/W
B
B
B
B
WWW
WWW
R
B
R/Y
G/L
G/LR
/Y
Y/B Y
/BY
/BA
R/Y
R/Y
A
A
L/W
Lg
L/G
L/G
Sb
Sb
Sb
Sb
B/Y
B
R/B
R/Y
BB
B2
Br/
R
L/R
L/R
Br/
G
Br/
LR
/W
Br/
LR
/Y
W/L
Br/
LB
r/B
Br/
B
Br/
B
B
Sb/W
Sb/W
Sb/W
O/W
O/W
O/W
O/W
Br
Br
O/W
Sb/
W
Br
Br
AB
r/G
Br/
G
AB
r/W
Br/
W
AG/B
G/B
LgS
bD
gC
h
BrP
Br/
W
Br/
R
R/W
R/G
G/W
Y/L
LB/L
Gy/
R
W/Y
B2
B2
B2
G/B
Br/
G
Br/
W
ALL
R
L
AG/Y
R/B
B/R
B/R
L/R
L/R
G/B
R/B
G/Y
G/Y
B
B
B
B
B
Br/
Y
Br/
Y
Br/
YB
r/R
L B
R
BLgSb
LgSb
LgSb
Br/
B
YBr
B
BB
A Y
P
Y
Y
R/W
R/W
G/Y
LBr/B
G/B
BY GG/L
Y/B
G/L
R/Y
R/Y
LBLB
(BLA
CK
)(B
LAC
K)
(BR
OW
N)
(BR
OW
N)
Gy
B/L BGy
(BLU
E)
(DA
RK
GR
AY
)(D
AR
K G
RA
Y)
(BLA
CK
)
B
BLg
Br/R
Sb
Br/Y
RLg
Br/R
BR
Br
Sb
LgY
/LR
/GR
/GG
/LR
/WR
/WB
Y/LB
BB
B2
L/R
Ch
Dg
Y
L/R
Br/
W
Gy/
G
Gy/
R
Br/
RB
r/W
W/Y
P/W
W/B
R/W
G/W
Y/GB/L
B/Y
L/Y
R/L
B/L
L/R
YG
Y
BB
Ch B
BYG
B
B
G
P
G
BY
G
BY
G/W
R/L
O/B
O/B
O/B
B/L
(BLA
CK
)
(BLA
CK
)
G/W
R/L
Dg BB Dg
Dg
C W WW
W Y Ch
Dg
Lg
A LgLg
Y/L
Y/L
C A
C R/G
R/G
B
G/W
G/W
B Ch
Ch
F Dg
Dg
G Ch
Ch
F BBG BB
BL/
R
Br/W
B/L
R/LO
/B
BL/
R
Br
UP
DO
WN
ON
OFF
DgB
r/W C
h
DL
L
EY
Y
E
D
R/W
Br/
R
E
B/W
R/W
B3
YGy
O/B
Y/B
G/Y
Y/L
R/B
G/B
L/B
L
O
O
L
R/L
R/LD
B/L
B/L
E
WL
B1
BB
B2
B2
B/L
W/B
W/B
W/B
EP
/WP
/W
B/LGy
B/L
Y LB/L
Gy/
G
Gy/
GG
y/G
WL/
Y
B/L
LW
/B
B/L
WL/
Y
B/L
LW
/Y
B/L
LY
B/L
(BLA
CK
)
(DA
RK
GR
EE
N)
L B/L
P/W
P/W
B/L
L
(BLA
CK
)
L
O/W
B
(BLA
CK
)
Y/G B/L
Br/R
R/W
Br
Br/R
(GR
AY)
R/L
L/B
L/B
L/B
R/L
L/B
D
(GR
AY)
R/L
G/B
G/B
G/B
R/LG
/B
D
(GR
AY)
R/L
R/B
R/B
R/B
R/LR
/B
D
(GR
AY)
R/B
R/G
B2Br
/RR/
WG
/WY
/LG
/LG
/RLg
YL
Ch
W Dg
(BLA
CK
)
(BLU
E)
(BLU
E)
(BLU
E)
L/G
B
BB
Br
YB
B
Gy
W
BB
1B
B2
BB
4B
B3
BBBB
R/W
R/B
L/W
G/Y
Br
BR
/WR
/BW
/LG
/YB
rB
B/W R/L
B R/L
YBr
/WL/
W
B1
LgSb
B2
W1
G/R
LgSb
B1
B2
W1
G/R
R GR W
RB
WWR R
YBr
/WL/
W
LB
Br/G
C
B/L
P/W
Gy/
GY
W/B
B/L
P/W
W/B
YG
y/G
E
(BLA
CK
)(B
LAC
K)
(BLA
CK
)(B
LAC
K)
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
L/B
O/B
LR
/LR
/BG
/BO
/BL
L/B
G/B
R/B
R/L
D
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
2
G
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
C
WIR
E H
AR
NE
SS
SU
B-W
IRE
H
AR
NE
SS
1
R/G
G/L
G/R
G/R
G/L
O/W
O/W
WY
/LR
/GY
/LW
WIR
E H
AR
NE
SS
B
SU
B-W
IRE
H
AR
NE
SS
1
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
L/R
G/W
Sb
Ch
LgB
rD
gBr
/YSb
/WB
A
SU
B-W
IRE
H
AR
NE
SS
1W
IRE
HA
RN
ES
SY/B
Br/B
YLg
Br/W
R/W
R/W
B2
B2
LBr
/B LG
/YY
/BG
/YBr
/GLg Br
/GG
/BY G/B
R/Y
Br/W
R/Y
PB
Lg Sb
Br/W
L/B
Ch
Dg
B/Y
YR
/YL/
Y
BC
hD
gB
PB
SbLg
Br/W
G/B
Ch
Dg
B/Y
YR
/YB
/R
B/R
B/Y
Br
R/W
R/W
A
L
LY
/GB
/L
B/R
L/W
B/R
L/Y
R/L
BY
/LR
/WG
/LR
/G
L/W
R/W
W/L
G/L G/R
G/R
R/B
R/W
BB
rB
r
G/W
B/L
Gy/G
B/L
R/B
Br/W
Br/L
LgR
/BB
/RL/
WL/
WW
/LR
/LR
/WL/
GL/
YS
bB
/YR
B/R
G/Y
Y/G
B/Y
B/L
Y/B
Gy
L/Y
R/W
Y/L
R/L
Br/R
L/W
YW
/YR/
WG
/WP/
WBr
/WB/
WW
/BGy
/GR
/BL
G/B
L/B
B3
O/B
OGy
/R
(BLA
CK
)
B1
B2 Y
Y
W1
B2
W1
B1
W1
W1
B1
Sb
Sb
LgS
bLg
Sb
Lg
B3
W2
Lg
R/L
B/W
R/L
B/W
R/W
W/R
L/W
Br/
W
G/R
L/W
W/R
W/B
W/B
Br/
WL/
WB
r/W
Br/
W
B
R/L
R/G
B/W
B
G/R
G/R
C
OF
F
B1
GG
B
B
R RR
Y
B4
B5
B2
W1
B1
P/W
P/W
G/R
R/L
B
R/W
R/W
R/W
W2
B3
Gy
W
WW
B4B5Sb
WY
GR/
W
RB
R/W
W/B
R/L
G/R
P/W
Br/W
Br/W
B2B1
B3W
1W
2Lg
L/W
P/W
W/B
W/R
Sb
LgB W/R
ChB
LB
Br/G
F
SU
B-W
IRE
H
AR
NE
SS
3S
UB
-WIR
E
HA
RN
ES
S 1
DgB
2
6 75
3
1
4
B
CD
0
A
9
8
F
G
E
\
Z[
]
^
L
M
IH
N O
K
P QY
S
W
X
VUT
de
ce
bn oml p
fg i
k
††
xw
~
çç
|
z
uv
s
q
t
yyß
¥
©
®
µ
¬
…
¡
ºø
¤
›‹
ÕJ
™
æ
¶
¢
£
§•
ah j
r
R
å
2M
ain
switc
h 7
Mai
n fu
se
9B
atte
ry
0F
uel i
njec
tion
syst
em fu
seE
Fue
l inj
ectio
n sy
stem
rel
ayJ
Fue
l pum
pK
O2
sens
orL
Cyl
inde
r id
entif
icat
ion
sens
orM
Thr
ottle
pos
ition
sen
sor
NIn
take
air
pres
sure
sen
sor
OLe
an a
ngle
cut
-off
switc
hP
Inta
ke a
ir te
mpe
ratu
re s
enso
r
QC
oola
nt te
mpe
ratu
re s
enso
rR
Cra
nksh
aft p
ositi
on s
enso
rS
EC
U (
engi
ne)
TC
ylin
der
#1 -
inje
ctor
UC
ylin
der
#2 -
inje
ctor
VC
ylin
der
#3 -
inje
ctor
WC
ylin
der
#4 -
inje
ctor
XA
ir in
duct
ion
syst
em s
olen
oid
YS
peed
sen
sor
ºIg
nitio
n fu
se‹
Eng
ine
stop
sw
itch
– 30 –
– +ELECFUEL INJECTION SYSTEMEAS00819
CHECKING THE FUEL PUMP
WARNING@
Gasoline is extremely flammable and undercertain circumstances there can be a dan-ger of an explosion or fire. Be extremelycareful and note the following points: • Stop the engine before refueling. • Do not smoke, and keep away from open
flames, sparks, or any other source offire.
• If you do accidentally spill gasoline, wipeit up immediately with dry rags.
• If gasoline touches the engine when it ishot, a fire may occur. Therefore, makesure the engine is completely cool beforeperforming the following test.
1. Check: • fuel pump operation
a. Fill the fuel tank. b. Put the end of the fuel hose into an open
container. c. Connect the battery (12 V) to the fuel pump
terminals as shown.
d. If fuel flows out of the fuel hose, the fuelpump is OK. If fuel does not flow, replacethe fuel pump.
Battery positive lead → red/blue 1 Battery negative lead → black 2
G/W B
B R/L
+
1 2
FJR1300 WIRING DIAGRAM1 Immobilizer unit2 Main switch 3 Rectifier/regulator4 Generator5 Backup fuse (odometer, clock and windshield)6 Main fuse7 Battery8 Fuel injection system fuse9 Starter relay0 Starter motor A Relay unitB Starting circuit cut-off relay C Fuel injection system relayD Neutral switch E Sidestand switch F Accessory box solenoidG Accessory box relayH Fuel pump I O2 sensorJ Cylinder identification sensor K Throttle position sensorL Intake air pressure sensorM Lean angle cut-off switchN Intake air temperature sensorO Coolant temperature sensorP Crankshaft position sensorQ ECU (engine)R Cylinder #1 - injectorS Cylinder #2 - injectorT Cylinder #3 - injectorU Cylinder #4 - injectorV Air induction system solenoidW Speed sensorX Cylinders #1, #4 - ignition coil Y Cylinders #2, #3 - ignition coilZ Spark plug [ Meter assembly\ Immobilizer system indicator light] Oil level warning light _ Neutral indicator lighta Multifunction meterb Engine trouble warning lightc High beam indicator lightd Left turn signal indicator light e Right turn signal indicator light f Meter light g Oil level switchh Left handlebar switchi Clutch switchj Pass switchk Dimmer switchl Windshield position switchm Turn signal switchn Horn switcho Horn p Front turn signal light (left)q Front turn signal light (right)r Hazard switchs Headlight relay 1t Headlight relay 2u Headlight assemblyv Auxiliary lightw Headlightx Taillight assemblyy Tail/brake lightz Rear turn signal light (left) Rear turn signal light (right)| Rear brake light switch Turn signal relay~ Windshield drive unitå Radiator fan motorç Radiator fan motor relay† Parking lighting fuse¢ Hazard lighting fuse£ Ignition fuse
§ Headlight fuse• Signaling system fuse¶ Radiator fan motor fuseß Windshield motor fuse® CYCLELOCK© Right handlebar switch™ Front brake light switch¥ Engine stop switchµ Start switch
COLOR CODEB.............BlackBr............BrownCh...........ChocolateDg...........Dark greenG.............GreenGy...........GrayL .............BlueLg ...........Light greenO.............OrangeP.............PinkR.............RedSb...........Sky blueW............WhiteY.............YellowB/L ..........Black/BlueB/R .........Black/RedB/W.........Black/WhiteB/Y..........Black/YellowBr/B ........Brown/BlackBr/G........Brown/GreenBr/L.........Brown/BlueBr/R ........Brown/RedBr/W .......Brown/WhiteBr/Y ........Brown/YellowG/B .........Green/BlackG/L..........Green/BlueG/W ........Green/WhiteG/Y .........Green/YellowGy/G.......Gray/GreenGy/R .......Gray/RedL/B..........Blue/BlackL/G..........Blue/GreenL/R..........Blue/RedL/W.........Blue/WhiteL/Y..........Blue/YellowO/B .........Orange/BlackP/W.........Pink/WhiteR/B .........Red/BlackR/G.........Red/GreenR/L..........Red/BlueR/W ........Red/WhiteR/Y .........Red/YellowW/B.........White/BlackW/Y.........White/YellowY/B..........Yellow/BlackY/G .........Yellow/GreenY/L ..........Yellow/Blue
FJR1300A WIRING DIAGRAM1 Immobilizer unit2 Main switch 3 Rectifier/regulator4 Generator5 ABS fuse6 Backup fuse (odometer, clock and windshield)7 Main fuse8 ABS motor fuse9 Battery0 Fuel injection system fuseA Starter relayB Starter motor C Relay unitD Starting circuit cut-off relay E Fuel injection system relayF Neutral switch G Sidestand switch H Accessory box solenoidI Accessory box relayJ Fuel pump K O2 sensorL Cylinder identification sensor M Throttle position sensorN Intake air pressure sensorO Lean angle cut-off switchP Intake air temperature sensorQ Coolant temperature sensorR Crankshaft position sensorS ECU (engine)T Cylinder #1 - injectorU Cylinder #2 - injectorV Cylinder #3 - injectorW Cylinder #4 - injectorX Air induction system solenoidY Speed sensorZ Sub-wire harness (ABS)[ ECU (ABS)\ Rear wheel sensor] Fail-safe relay_ Hydraulic unita ABS test couplerb Front wheel sensorc Cylinders #1, #4 - ignition coild Cylinders #2, #3 - ignition coile Spark plug f Meter assemblyg Immobilizer system indicator lighth Oil level warning light i Neutral indicator lightj ABS warning lightk Multifunction meterl Engine trouble warning lightm High beam indicator lightn Left turn signal indicator light o Right turn signal indicator light p Meter light q Oil level switchr Left handlebar switchs Clutch switcht Pass switchu Dimmer switchv Windshield position switchw Turn signal switchx Horn switchy Horn z Front turn signal light (left) Front turn signal light (right)| Hazard switch Headlight relay 1~ Headlight relay 2å Headlight assemblyç Auxiliary light† Headlight¢ Taillight assembly£ Tail/brake light
§ Rear turn signal light (left)• Rear turn signal light (right)¶ Rear brake light switchß Turn signal relay® Windshield drive unit© Radiator fan motor™ Radiator fan motor relay¥ Parking lighting fuseµ Hazard lighting fuseº Ignition fuseæ Headlight fuseø Signaling system fuse¡ Radiator fan motor fuse¬ Windshield motor fuse… CYCLELOCKÕ Right handlebar switch¤ Front brake light switch‹ Engine stop switch› Start switch
COLOR CODEB.............BlackBr............BrownCh...........ChocolateDg...........Dark greenG.............GreenGy...........GrayL .............BlueLg ...........Light greenO.............OrangeP.............PinkR.............RedSb...........Sky blueW............WhiteY.............YellowB/L ..........Black/BlueB/R .........Black/RedB/W.........Black/WhiteB/Y..........Black/YellowBr/B ........Brown/BlackBr/G........Brown/GreenBr/L.........Brown/BlueBr/R ........Brown/RedBr/W .......Brown/WhiteBr/Y ........Brown/YellowG/B .........Green/BlackG/L..........Green/BlueG/W ........Green/WhiteG/Y .........Green/YellowGy/G.......Gray/GreenGy/R .......Gray/RedL/B..........Blue/BlackL/G..........Blue/GreenL/R..........Blue/RedL/W.........Blue/WhiteL/Y..........Blue/YellowO/B .........Orange/BlackP/W.........Pink/WhiteR/B .........Red/BlackR/G.........Red/GreenR/L..........Red/BlueR/W ........Red/WhiteR/Y .........Red/YellowW/B.........White/BlackW/Y.........White/YellowY/B..........Yellow/BlackY/G .........Yellow/GreenY/L ..........Yellow/Blue
YAMAHA MOTOR CO., LTD.2500 SHINGAI IWATA SHIZUOKA JAPAN
ONOFF
P
R
R R
Br/L
Br/R
BB1BB2
BB4BB3
G/Y Br
B LY
Ch DgY
Dg
BL/R
Ch
Dg
ChBr/WBr/W
Ch
Dg
Br/WBr/G
B/RR/B
B/RR/B
R/BB/R B
B
L/Y
B/YB/Y
L/Y
(BLACK) (BLACK)
R
RR
RBr/LBr/L
Br/R Br/R
(BLACK)
(GRAY)
W WW
BG/W
BR/L
RB
B
B
R
R
R
R
R
Br/LBr/Y
B
B
B
R
R
R
B
L/W
R/G
BB
R/W
R/W
R
L/W
B
R
B
R
B
B
B
B
WWW
WWW
R
B
R/Y
G/L
G/L
R/Y
Y/B
Y/B Y/BA
R/Y R/YA
A
L/W Lg
L/G
L/G
Sb
Sb
Sb
Sb
B/Y
B
R/B
LgR/B
B/RL/W
L/WW/L R/L
R/WL/GL/Y Sb B/YR
R/Y
BB
B2
Br/R
L/R
L/R
Br/G
Br/L R/W
Br/L R/Y
W/L
Br/LBr/BBr/B
Br/B
B
Sb/W
Sb/W
Sb/W
O/W O/W
O/WO/W
Br Br
O/WSb/W
BrBr
ABr/G
Br/G
ABr/W
Br/W
A
G/B
G/B Lg Sb Dg Ch
Br
P
Br/W
Br/R
R/W
R/GG/W
Y/L Y/L
L
B/L
Gy/R
W/Y
B2 B2 B2
Y/LG/B
Br/G
Br/W
AL
L
R
L
AG/Y
R/BB/R
B/R
L/R L/R
G/B
R/B
G/Y
G/Y
B
B
B
B
B
Br/Y
Br/Y
Br/Y Br/R
L
B
R
B
LgSb
LgSb
LgSb
Br/B
Y
Br
B
B
B
A
Y
P
Y
Y
R/W
R/W G/YL
Br/B
G/B BYG
G/L
Y/BG/LR/Y
R/Y
LB
LB
(BLACK) (BLACK)
GyB/L
BGy
(BLUE)
(DARK GRAY) (DARK GRAY)
(BLACK)
B
B Lg Br/RSb Br/Y R
LgBr/R BR Br Sb
LgY/LR/G R/G
G/L R/W R/WB
Y/LBBB B2
L/R Ch Dg
Y
L/R
Br/W
Gy/G
Gy/R
Br/RBr/W
W/Y
P/W
W/B
R/W
G/WY/G
B/L
B/Y
L/YR/L
B/L
L/R Y G Y
BBB
Y GB
B
G
P
G
BY
G
BY
G/W
R/LO/BO/BO/B
B/L
(BLACK)
(BLACK)
G/WR/L
B
Dg
Dg
C
W
W
W
W
Y
Ch
Dg
Lg
A
Lg
Lg
C
A
C
R/G
R/G
B
G/W
G/W
B
Ch
Ch
B L/R
Br/W B/L
R/LO/B
B L/R
Br
UP
DOWN
ONOFF
DgBr/W
Ch
DL L
EY Y
E
D
R/WBr/R
E
B/W R/WB3
Y
Gy
O/B
Y/BG/Y
Y/L
R/BG/BL/B
L
O
O
L
R/L
R/L
D
B/L B/LE
W L
B1
BB
B2
B2
B/L
W/BW/B W/B
EP/W P/W
B/L
Gy
B/L
YL
B/L
Gy/G
Gy/G Gy/G
W L/Y
B/L
L W/B
B/L
W L/Y
B/L
L W/Y
B/L
L Y B/L
(BLACK)
(DARK GREEN)
LB/LP/W
P/W B/L L
(BLACK)
L
O/W B
(BLACK)
Y/GB/L
Br/R R/W
Br Br/R
(GRAY)
R/LL/BL/BL/B
R/L L/B
D
(GRAY)
R/LG/BG/BG/B
R/LG/B
D
(GRAY)
R/LR/BR/BR/B
R/LR/B
D
(GRAY)
R/B
R/G B2 Br/RR/W G/W Y/L
G/LLg Y LCh
WDg
(BLACK)
(BLUE)
(BLUE) (BLUE)
L/G B
B B
BB1BB2
BB4BB3
BB
BB
R/WR/B
L/W G/YBr B
R/WR/B
W/LG/YBrB
C
B/L P/WGy/G Y W/B
B/LP/WW/B Y Gy/G
E
(BLACK) (BLACK)
WIRE HARNESS SUB-WIRE HARNESS 2
L/B O/B LR/L R/B G/B
O/BL L/BG/B R/B R/L
D
WIRE HARNESS SUB-WIRE HARNESS 2
C
WIRE HARNESSSUB-WIRE HARNESS 1
R/G G/L G/LO/WO/WW Y/L
R/GY/L W
WIRE HARNESS
B
SUB-WIRE HARNESS 1
L/RG/W
SbCh LgBrDg Br/YSb/W B
L/RG/W
Sb ChLg BrDgBr/Y Sb/WB
A
SUB-WIRE HARNESS 1WIRE HARNESS
Y/B Br/BY LgBr/W R/W R/WB2 B2L
Br/BLG/Y
Y/BG/YBr/G
LgBr/GG/B
YG/B
R/YBr/WR/Y
PB Lg
SbBr/W
L/B Ch
Dg
B/Y
Y R/YL/Y
PB
Sb
LgBr/WG/BCh
Dg
B/Y
YR/YB/R
B/RB/Y
Br
R/W R/WA
L
L Y/G B/L
B/RL/W
B/R G/YY/G B/Y B/L Y/B GyL/YR/W Y/L R/L Br/RL/W Y W/Y R/W
G/WP/W Br/W B/W W/B Gy/G R/BL G/B L/B B3O/B O Gy/R
(BLACK)
B/R L/Y
R/L
BY/LR/W
G/LR/G
L/W
R/W W/L
G/L
R/BR/W
BBr Br
G/W B/L
Gy/G B/L
R/B
OFF
(BROWN)(BROWN)
Br Y B B
Ch
B
Dg
B
F
Dg
DgG
Ch
Ch
F
B
BG
B
B
B ChDgB
L BBr/G
G
SUB-WIRE HARNESS 3
SUB-WIRE HARNESS 1
ChB L BBr/G
F
SUB-WIRE HARNESS 3
SUB-WIRE HARNESS 1
DgB
2
6
5
3
1
4
=
A B
8
9
7
D
E
C
J
K
GF
L
M
I
N
O
W
Q
U
V
T
S
R
Y Z
X Z
d
e
c
b
f
[ \
^
a
w w
nm
s
t
vv
r
k l
i
g
j
o
o
†
å
~
¢
ß
®
¶
£
•
™
µ¥
© H
ç
§
|
x
y
z
h
u
P
q p
]
FJR1300 WIRING DIAGRAM
FJR1300A WIRING DIAGRAM
ONOFF
P
R
R R
Br/L
Br/R
BB1BB2
BB4BB3
G/Y Br
B LY
Ch DgY
Dg
BL/R
Ch
Dg
ChBr/WBr/W
Ch
Dg
Br/WBr/G
B/RR/B
B/RR/B
R/BB/R B
B
L/Y
B/YB/Y
L/Y
(BLACK) (BLACK)
R
RR
RBr/LBr/L
BB/W
RR/L
BB/W
RR/L
Br/R Br/R
(BLACK)
(GRAY)
W WW
BG/W
BR/L
RB
B
B
R
R
R
R
R
Br/LBr/Y
B
B
B
R
R
R
L/W
BB
R/W
R/W
R
L/W
B
B
B
B
WWW
WWW
R
B
R/Y
G/L
G/L
R/Y
Y/B
Y/B Y/BA
R/Y R/YA
A
L/W Lg
L/G
L/G
Sb
Sb
Sb
Sb
B/Y
B
R/B
R/Y
BB
B2
Br/R
L/R
L/R
Br/G
Br/L R/W
Br/L R/Y
W/L
Br/LBr/BBr/B
Br/B
B
Sb/W
Sb/W
Sb/W
O/W O/W
O/WO/W
Br Br
O/WSb/W
BrBr
ABr/G
Br/G
ABr/W
Br/W
A
G/B
G/B Lg Sb Dg Ch
Br
P
Br/W
Br/R
R/W
R/GG/W
Y/L
L
B/L
Gy/R
W/Y
B2 B2 B2
G/B
Br/G
Br/W
AL
L
R
L
AG/Y
R/BB/R
B/R
L/R L/R
G/B
R/B
G/Y
G/Y
B
B
B
B
B
Br/Y
Br/Y
Br/Y Br/R
L
B
R
B
LgSb
LgSb
LgSb
Br/B
Y
Br
B
B
B
A
Y
P
Y
Y
R/W
R/W G/YL
Br/B
G/B BYG
G/L
Y/BG/LR/Y
R/Y
LB
LB
(BLACK) (BLACK)
(BROWN)(BROWN)
GyB/L
BGy
(BLUE)
(DARK GRAY) (DARK GRAY)
(BLACK)
B
B Lg Br/RSb Br/Y R
LgBr/R BR Br Sb
LgY/LR/G R/G
G/L R/W R/WB
Y/LBBB B2
L/R Ch Dg
Y
L/R
Br/W
Gy/G
Gy/R
Br/RBr/W
W/Y
P/W
W/B
R/W
G/WY/G
B/L
B/Y
L/YR/L
B/L
L/R Y G Y
BB
Ch
BB
Y GB
B
G
P
G
BY
G
BY
G/W
R/LO/BO/BO/B
B/L
(BLACK)
(BLACK)
G/WR/L
Dg
B
B
Dg
Dg
C
W
W
W
W
Y
Ch
Dg
Lg
A
Lg
Lg
Y/L Y/LC
A
C
R/G
R/G
B
G/W
G/W
B
Ch
Ch
F
Dg
DgG
Ch
Ch
F
B
BG
B
BB L/R
Br/W B/L
R/LO/B
B L/R
Br
UP
DOWN
ONOFF
DgBr/W
Ch
DL L
EY Y
E
D
R/WBr/R
E
B/W R/WB3
Y
Gy
O/B
Y/BG/Y
Y/L
R/BG/BL/B
L
O
O
L
R/L
R/L
D
B/L B/LE
W L
B1
BB
B2
B2
B/L
W/BW/B W/B
EP/W P/W
B/L
Gy
B/L
YL
B/L
Gy/G
Gy/G Gy/G
W L/Y
B/L
L W/B
B/L
W L/Y
B/L
L W/Y
B/L
L Y B/L
(BLACK)
(DARK GREEN)
LB/LP/W
P/W B/L L
(BLACK)
L
O/W B
(BLACK)
Y/GB/L
Br/R R/W
Br Br/R
(GRAY)
R/LL/BL/BL/B
R/L L/B
D
(GRAY)
R/LG/BG/BG/B
R/LG/B
D
(GRAY)
R/LR/BR/BR/B
R/LR/B
D
(GRAY)
R/B
R/G B2 Br/RR/W G/W Y/L
G/LG/RLg Y LCh
WDg
(BLACK)
(BLUE)
(BLUE) (BLUE)
L/G B
B B
Br Y B B
Gy W
BB1BB2
BB4BB3
BB
BB
R/WR/B
L/W G/YBr B
R/WR/B
W/LG/YBrB
B/WR/L
BR/L
Y Br/WL/W
B1 LgSbB2 W1
G/R LgSb
B1B2W1
G/R
RG
RW
R B
WW R
R
YBr/W L/W
L BBr/G
C
B/L P/WGy/G Y W/B
B/LP/WW/B Y Gy/G
E
(BLACK) (BLACK) (BLACK) (BLACK)
WIRE HARNESSSUB-WIRE HARNESS 2
L/B O/B LR/L R/B G/B
O/BL L/BG/B R/B R/L
D
WIRE HARNESS SUB-WIRE HARNESS 2
G
SUB-WIRE HARNESS 3
SUB-WIRE HARNESS 1
C
WIRE HARNESS SUB-WIRE HARNESS 1
R/G G/LG/R G/RG/LO/WO/WW Y/L
R/GY/L W
WIRE HARNESS
B
SUB-WIRE HARNESS 1
L/RG/W
SbCh LgBrDg Br/YSb/W B
L/RG/W
Sb ChLg BrDgBr/Y Sb/WB
A
SUB-WIRE HARNESS 1WIRE HARNESS
Y/B Br/BY LgBr/W R/W R/WB2 B2L
Br/BLG/Y
Y/BG/YBr/G
LgBr/GG/B
YG/B
R/YBr/WR/Y
PB Lg
SbBr/W
L/B Ch
Dg
B/Y
Y R/YL/Y
B ChDgB
PB
Sb
LgBr/WG/BCh
Dg
B/Y
YR/YB/R
B/RB/Y
Br
R/W R/WA
L
L Y/G B/L
B/RL/W
B/R L/Y
R/L
BY/LR/W
G/LR/G
L/W
R/W W/L
G/L
G/R G/R
R/BR/W
BBr Br
G/W B/L
Gy/G B/L
R/B
Br/WBr/L
LgR/B
B/RL/W
L/WW/L R/L
R/WL/GL/Y Sb B/YR
B/R G/YY/G B/Y B/L Y/B GyL/YR/W Y/L R/L Br/RL/W Y W/Y R/W
G/WP/W Br/W B/W W/B Gy/G R/BL G/B L/B B3O/B O Gy/R
(BLACK)
B1
B2
Y Y
W1B2W1
B1W1
W1 B1
Sb
Sb
LgSbLg
SbLg
B3W2Lg
R/LB/W
R/LB/W
R/WW/R
L/WBr/W
G/R
L/W
W/R
W/B
W/BBr/WL/WBr/W
Br/W
B
R/L
R/G
B/W B
G/R G/RC
OFF
B1
GG
B
B
R
R R
Y
B4B5
B2W1B1
P/WP/W
G/R R/L
B
R/W
R/W
R/W
W2 B3Gy W
W W
B4B5
SbWYG
R/W
R B R/W W/BR/LG/RP/W Br/W
Br/WB2
B1 B3W1 W2Lg
L/W P/WW/B W/R
SbLg
BW/R
ChB L BBr/G
F
SUB-WIRE HARNESS 3
SUB-WIRE HARNESS 1
DgB
2
6
7
5
3
1
4
B
C D
0
A
9
8
F
G
E
\
Z [
]
^
L
M
IH
N
O
K
P
QY
S
W
X
V
U
T
d e
c e
bn
o
m
l
p
f g
i
k
† †
xw
~
çç
|
z
u vs
q
t
y
yß
¥
©
®
µ
¬
…
¡
º
ø
¤
›‹
ÕJ
™
æ
¶
¢
£
§•
ah
j
r
R
å