Top Banner
! "#$"%& "$"’( ")* "+", "-. /01&2333 (& %*45&&&&& 6789
146

Characterization of Crazing Properties of Polycarbonate

Jan 23, 2016

Download

Documents

5landers

Characterization of Crazing Properties of Polycarbonate.

CHARACTERIZATION OF CRAZING PROPERTIES
OF POLYCARBONATE

Stephen Brett Clay

(ABSTRACT)

The purpose of this study was to characterize the craze growth behavior of polycarbonate (PC) as a function of stress level, model the residual mechanical properties of PC at various craze levels and strain rates, and determine if the total surface area of crazing is the sole factor in residual properties or if the crazing stress plays a role. To obtain these goals, a new in-situ reflective imaging technique was developed to quantify the craze severity in transparent polymers.
To accomplish the goal of craze growth rate characterization, polycarbonate samples were placed under a creep load in a constant temperature, constant humidity environment. Using the new technique, the relative craze density was measured as a function of time under load at stresses of 40, 45, and 50 MPa. The craze growth rates were found to increase exponentially with stress level, and the times to 1% relative craze density were found to decrease exponentially with stress level. One exception to this behavior was found at a crazing stress of 50 MPa at which over half of the samples tested experienced delayed necking, indicating competitive mechanisms of crazing and shear yielding. The draw stress was found to be a lower bound below which delayed necking will not occur in a reasonable time frame.
The yield stress, elastic modulus, failure stress, and ductility were correlated to crazing stress, relative craze density, and strain rate using a Design of Experiments (DOE) approach. The yield stress was found to correlate only to the strain rate, appearing to be unaffected by the presence of crazes. No correlation was found between the elastic modulus and the experimental factors. The failure stress was found to decrease with an increase in relative craze density from 0 to 1%, increase with an increase in crazing stress from 40 to 45 MPa, and correlate to the interaction between the crazing stress and the strain rate. The ductility of polycarbonate was found to d
an increase in strain rate.
The craze microstructure was correlated to the magnitude of stress during craze formation. The area of a typical craze formed at 40 MPa was measured to be more than 2.5 times larger than the area of a typical craze formed at 45 MPa. The fewer, but larger, crazes formed at the lower stress level were found to decrease the failure strength and ductility of polycarbonate more severely than the large number of smaller crazes formed at the higher stress level.
Welcome message from author
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
Page 1: Characterization of Crazing Properties of Polycarbonate

���������������������� ����������

������������

���������������

����������������������������������� �������

����������� ������������������������������������

�������������������������������������������������������

������������������

��

����������!��������

�"�#������$"�%����&����

�"� ������$"�'����(�

�"�)�������*����

�"������+"�,���

�"������-����.�����

/������01&�2333

����(����&��������

%� *���4���5���&���� ��������&����������&��������������������&������������&����������

6���������7�8 9

Page 2: Characterization of Crazing Properties of Polycarbonate

���������������������� ����������

������������

���������������

����������

-���������������������� �*��������������5��������5����*����������������� ���������7�9���

�������������������������&��������������������������������������������������������5��������

��������������&�������������������������������������������5��������������������������������

��������������������5������������� �������"��-��������������������&�����*������������������

������������������*����������������������� �������5�������� ����������������� ���"

-���������������������������5����*���������������5�����&���� �����������������*���������

����������������������������������������&����������������� �����������"��������������*

���������&���������������5�������� �*��������������������������������������������������������

:3&�:1&�����13�!��"�-�����5����*��������*���������������������6���������� �*���������

�����&������������������0;�����������5�������� �*���������������������6���������� �*���������

�����"��8����6������������������������*����������������5�������������13�!������*�������������

�����������������������6������������� ������(���&�������������������������������������

��5������������� �������"��-�����*�������*�������������������*������������*�*��������� ��

���(����*�������������������������������������"

-��� ����������&����������������&�������������&������������� �*�����������������5���������&

����������5�������� &��������������������������������� 6���������7�8 9��������"��-��� ����

������*����������������������� �����������������&���������������������������� ���������������

��5��"��)������������*������������*���������������������������������6����������������"��-��

�������������*��������������������*����������������������������5�������� �����3����0;&

��������*��������������������5��������������:3����:1�!��&������������������������������

���*����������5���������������������������"��-����������� ������� ���������*�����������

Page 3: Characterization of Crazing Properties of Polycarbonate

���

�������������������� �*����������������������������5�������� &����������������5���������&����

�����������������������"

-�����5��������������*����������������������������������������������5����������"��-��

���������� ��������5�����������:3�!���*��������������������������2"1��������������������

���������� ��������5�����������:1�!��"��-�����*�&���������&���5������������������*�

������������*��������������������������������������������������� ������� ������������

������ ���������������������������������5���������������������������������"

Page 4: Characterization of Crazing Properties of Polycarbonate

��

������� �����

��*�������(���������(���������������*������������������������������������ ���������

����"������&�����(������������� ������� �����������*���������������"�#������$"�%����&

�"� ������$"�'����(�&��"�)�������*����&��"������+"�,���&������"������-����.�����"���

*�������������� ���(���������(��"�#������%����&�� ���������������� ��������&�������

����������������&��������������&��������������"

��*������������(���������(�����/�������#�������,������ &���������� �#�����!���

��������)�6��$���������-�������� �����������(������������������������������������&

����������������&�������������"���"�/�����!� ���������/�������#�������,������ ��������

��������(����������6���������������������������������������������� ���.�������������

���������"��������������(���������������(��������������6����������������������&���������� ���

���������&���������&�����������������������������"

������������*���������������������(�����������������������������������������������"

����������������������+��������(��&��"�+�������!����(&����������*��&����������(�&

��������������� ��&�+�����!����&��"�!��������+��(���&�+����������5�&����(�%���������&

������-���&�%��� �#�����*&��������� ���� "��������������(�������������"�������������5���

�����������*��������-$/&�%��� �#�����*������������������6������&��"�<�������%�����

���������$��������&�����+��������(���������������������� ������������������������"

������ &���*�������(���������(�� �,���+���������������� ����*������ ��

�������������� �������� �������������"��/���&�� �*���&�-� &������ �(���&�+���������

����������������(��������������&���������&����������������������������������������

������*�("

Page 5: Characterization of Crazing Properties of Polycarbonate

�������������

��������� ���� ��� �

��������! ���� � � "

2"0 !���������������5�������������������*�� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =

2"0"0 �5������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =

2"0"2 �5����*�� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =

2"2 �5����*��������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =

2"2"0 ��������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" >

2"2"2 ����������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00

2"2"? ������������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 02

2"2": ������������������*�����"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0:

2"2"1 ���������������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0=

2"? �5���������������<�������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0=

2": !�����������������������5���!������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0>

2"1 ��� �������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0>

2"1"0 ����������������������������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0>

2"1"2 -������������������ ���"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0@

2"1"? $������������������������ """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0@

2"= '������ ������ """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0@

��������# �$��������� !�

?"0 �������������������������������������������5�������� ����������������� ��� """""""" 20

?"2 ���������������������������������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2>

?"2"0 ,�������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2>

?"2"2 ' ������������������������� ���� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2A

?"2"? $�������� ���� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2A

?"2": �������������������� ����""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2@

?"? !�������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?0

?": '������ ������ """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?2

?"1 ������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?2

Page 6: Characterization of Crazing Properties of Polycarbonate

��

?"1"0 ����������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ??

?"1"2 �5���������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?:

?"1"? ���������� ��� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?1

?"1": #������������������������ �����������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?=

?"= ���������� 6���������7�8 9 """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?>

?"="0 ����������������������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?@

?"="2 �����������������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :0

?"="? �����������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :2

?"> ��� ������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :?

?">"0 ����������������������������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :?

?">"2 -������������������ ���"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :1

?">"? $������������������������ """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :1

��������% ��� ��� %&

:"0 ���������������6������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :>

:"0"0 #����������� �����������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :>

:"0"2 ���������*��������������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :A

:"0"? ,������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 13

:"2 !������������������ """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 10

:"? �5����*�������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 12

��������' ���� ��� "(

1"0 B��������������� ������������������������5���������&�����������5�������� &��������������

����������������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =3

1"0"0 ���������������������������������������������������������������C�������

������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =3

1"0"2 �������������������5�������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =1

1"0"? �����������5���������������C��5������ ��������"""""""""""""""""""""""""""""""""""""""""""""""" ==

1"0": ������������������������C��5������ �������� """"""""""""""""""""""""""""""""""""""""""""""""""""" >A

1"2 �������������������������������������������������������� 6���������7�8 9��������

*���������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A1

1"2"0 -�����������8 ������������������ ���������� """""""""""""""""""""""""""""""""""""""""""""""""""""" A=

1"2"2 -�����������8 ��������������������������������� """"""""""""""""""""""""""""""""""""""""""""""" AA

Page 7: Characterization of Crazing Properties of Polycarbonate

���

1"2"? -�����������8 ������������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""" @0

1"2": -�����������8 �������������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""" @1

1"? �������������������������������������������������������� 6���������7�8 9��������

*�����*��������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" @A

1"?"0 -*���������8 ������������������ ���������� """""""""""""""""""""""""""""""""""""""""""""""""""""""" @A

1"?"2 -*���������8 ��������������������������������� """"""""""""""""""""""""""""""""""""""""""""""" 030

1"?"? -*���������8 ������������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""" 032

1"?": -*���������8 �������������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""" 031

1": ���������������8 �!�����""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 03>

1":"0 ��������������������������8 ������ """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 03A

1":"2 ���������������*���������8 ������ """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00?

1"1 ��� �������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00=

1"1"0 ����������������������������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00=

1"1"2 -������������������ ���"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00A

1"1"? $������������������������ """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00@

��������" �)*+,-./)*. �!!

��������& �-�-����)�0 �!"

Page 8: Characterization of Crazing Properties of Polycarbonate

����

��������� ���

������04��������������������������� �������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0

������24�7�9�-���������������������������� �����7�9���������������������� """"""""""""""""""""""" 2

������?4�7�9�!���������������������5�������������������!!/��������������������������D1E&

����7�9����������������������� �� ������5��*��������� ����������������D=E""""""""""""""""""""" ?

������:4��/������������5��������4�7�9�����������&�7�9���5������������&�7�9�������&������������5�

��*��&�����7�9����(���5�������� ���*��"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :

������14�������������������������� �������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""" >

������=4��#������������������������ ������������������������������� �����������6�����

��������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A

������>4� �������������������������������������������� ������������������ ��������������

�������D1E """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 03

������A4��!����2"1��������������������������� ��(������������""""""""""""""""""""""""""""""""""""""""" 0?

������@4���������������������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 0A

������034��/�-!��=?A�� ������������������������������ �DE """"""""""""""""""""""""""""""""""""""""""""""""""" 22

������004��#��������������������5�������������� ����"""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2?

������024��- �����������������5������ ��������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2:

������0?4��- �����������������5������ ���������7�9�����������7�9����������������� """"""""""" 21

������0:4����������������������������������5�������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2=

������014��,���������7���������������9 """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2>

������0=4��������������������������� ������������������������� ���� """"""""""""""""""""""""""""""""""""""" 2A

������0>4��$��F�������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 2@

������0A4�� �������������������������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?3

������0@4������������������������������������������� ����""""""""""""""""""""""""""""""""""""""""""""""""" ?0

������234�- �����������C����������������� ��������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?=

������204����*�������/�-!����������������*�������(��������������� """"""""""""""""""""""""""""""""" ?>

������224������������������������������������������������ """""""""""""""""""""""""""""""""""""""""""""""""""""""" :0

������2?4������������������������������������������*����������������� """""""""""""""""""""""""""""""" :2

������2:4�����������������(��� ������������������>���*������������������DE """"""""""" ::

Page 9: Characterization of Crazing Properties of Polycarbonate

�6

������214������������������������������������������������������������������������������������

������������������� ���������� �������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :1

������2=4��#�������������������� ��������������� ����� �������������*������������������������

����� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :>

������2>4� ��������������������������5�������� ����������� """"""""""""""""""""""""""""""""""""""""""""""""""" :A

������2A4�� ������������������������������5�������������� ���������������������������

���������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" :@

������2@4�� ����������������������������5�������������� �������������������2A�!�������

���� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 13

������?34�#����������5�������� ����������������������������������������������������������

2:������A1;�� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 1?

������?04� ��������������������������5����*�������72:�&�A1;��9 """"""""""""""""""""""""""""""""""""""""" 1:

������?24��- ����������������5����*������������������������6������������� ������(���" 11

������??4�������C����������������C����������� �������������������3"0=>������&�2:�&�����A1;

�"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 1=

������?:4� ��������������������������5������������������72:�&�A1;��9 """"""""""""""""""""""""""""""""""""" 1>

������?14� ��������������������������������0;�����������5�������� �72:�&�A1;��9 """""""""""""""" 1A

������?=4���5����*���������������� ��������:C1�*�����6������������������:3&�:1&�����13

!�� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 1@

������?>4� �������������������������������� ����������������C����������� �������� """""""""""""" =0

������?A4� �����������������������������������������������������C����������� �������� """"""" =2

������?@4� ��������������������������������������������������C����������� ��������"""""""""""" =?

������:34� ���������������������������������������� ������C����������� ��������""""""""""""""""""" =:

������:04�� �������������������5�������� �����������������������������������?��������(

#����G�'������� �������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =1

������:24� �����������5������������������������5�������� �������� ����������������� ��������

����������7�9�3"2�����������7�9�2����

������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" =>

������:?4� �����������5������������������������5�������� ��������������������������

��� �������������������7�9�3"2�����������7�9�2����

�������������"""""""""""""""""""""""""""""""""""""""""" =@

������::4� �����������5������������������������5�������� �����������������������

��� �������������������7�9�3"2�����������7�9�2����

�������������"""""""""""""""""""""""""""""""""""""""""" >3

Page 10: Characterization of Crazing Properties of Polycarbonate

6

������:14� �����������5������������������������5�������� ���������������� ������� ��������

����������7�9�3"2�����������7�9�2����

������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" >2

������:=4��!������������ ��������5���������������5������7�9�:3�!�������7�9�:1�!��""""""""" >:

������:>4��!���������������������������������������������������*��*����7�9�����5�������������:3

!�����������2:���������������2;���5�������� &�7�9�����5�������������:3�!����������

033���������������03;���5�������� &�����7�9�����5�������������:1�!�����������2:���

�����������03;���5�������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" >=

������:A4�� �����������5����������������������5������72:�&�A1;��9 """""""""""""""""""""""""""""""""" >A

������:@4� ���������������������������������5�������� �������� ����������������� ��������

��5������7�9�:3�!��&�7�9�:1�!��&�����7�9�13�!��""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" >@

������134� ���������������������������������5�������� ������������������������������ ��������

��5������7�9�:3�!��&�7�9�:1�!�������7�9�13�!��"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A0

������104� ���������������������������������5�������� ��������������������������� ��������

��5������7�9�:3�!��&�7�9�:1�!��&�����7�9�13�!��""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A2

������124� ���������������������������������5�������� ���������������� ������� �����������5��

���7�9�:3�!��&�7�9�:1�!��&�����7�9�13�!�� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A:

������1?4�����������������*����������������������������������� ����������������""""""""""" AA

������1:4�����������������*����������������������������������������������������� """""""" @?

������114�������������������������������������������7�9�/�&�7�9�/&�����7�9�� """""""""""""""" @:

������1=4�����������������*������������������������������������������� ������ """"""""""""""" @>

������1>4�����������������*����������������������������������� ����������������""""""""" 033

������1A4�����������������*����������������������������������������������������� """""" 03:

������1@4�����������������*������������������������������������������� ������ """"""""""""" 03>

������=34���������������?C������ ����������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 03A

������=04����������� ���������C������������ """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 003

������=24���������������?C�������������� �������*���������������������������� �����������

��F�� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 002

������=?4���������������2C������ ����������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00?

������=:4���������������2C������������������������ """"""""""""""""""""""""""""""""""""""""""""""""""""""""""" 00:

������=14���������������2C�������������� ������ """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 001

������==4��������������C��������������5���7003��&�:3�!��9���� �������� """"""""""""""""""""" 00>

Page 11: Characterization of Crazing Properties of Polycarbonate

6�

������=>4��-$/�������������5���������C����������� �������� """"""""""""""""""""""""""""""""""""""""""""" 00A

������=A4�$������������������C��������������5������ ��������"""""""""""""""""""""""""""""""""" 023

������=@4�����6��������������������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 02>

������>34��-��������5���������?��������(�#��������'������� ��������������������������

2A�!������13;��"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 02A

Page 12: Characterization of Crazing Properties of Polycarbonate

6��

�������������

-�����04� ����������������������#'��������������������������D?>E"""""""""""""""""""""""""""""""""""""""""""""" 23

-�����24�����������6�������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" ?A

-�����?4������������6��������?�������C�2�������H������������������������6 """""""""""""""""""""""""""""""" ?@

-�����:4������������������8 ����������������������������������� """""""""""""""""""""""""""""""""""""""""""""""""""" :3

-�����14����������������������������������������������������������������������� ��������"""" 12

-�����=4������������������5������������:3�����:1�!�� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""" >1

-�����>4������������������8 �������""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A1

-�����A4���8 ������������������������ ���������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A=

-�����@4��8���������������� �����������*����������������������������������� """"""""""""""""""""""""" A>

-�����034��8 ��������������������������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" A@

-�����004�8��������������������������������*����������������������������������� """"""""""""""""" @3

-�����024��8 ������������������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" @0

-�����0?4�8�����������������������������*����������������������������������� """""""""""""""""""""" @2

-�����0:4��8 �������������������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" @1

-�����014�8������������������������ �*����������������������������������� """"""""""""""""""""""""""""" @=

-�����0=4�����������������8 �������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" @A

-�����0>4��8 ������������������������ ���������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" @@

-�����0A4�8���������������� �����������*����������������������������������� """""""""""""""""""""""" @@

-�����0@4��8 ��������������������������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 030

-�����234�8��������������������������������*����������������������������������� """"""""""""""" 032

-�����204��8 ������������������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 03?

-�����224�8�����������������������������*����������������������������������� """""""""""""""""""" 03?

-�����2?4��8 �������������������������������� """"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 031

-�����2:4�8������������������������ �*����������������������������������� """"""""""""""""""""""""""" 03=

-�����214����������������?C������������������������"""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 000

-�����2=4��/�������������������������������������C��������������5������ �������� """""" 00>

-�����2>4��-$/�����������������������C��������������5������ �������� """"""""""""""""""""""""""""" 00@

-�����2A4��)����������������*����������������������*������������C��������������5��

��� �������� """""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""""" 023

Page 13: Characterization of Crazing Properties of Polycarbonate

0

��������� �� �������

��� ���������7������09�����������������������������*�����6������������������*���

����*�������������������������������7-�9����0:1�"��8��������������������������6�������

������������������6����������������C-������������������������������������*����������������

���(����C033�������������������������� ���������������������������� ����D0E"

���

���

� �

�/1-����2�����*3��3��������-*/��)4��),5+��6)*���

�������0@>3I�&�������������������/������������������������������ ���������������

����������������������������������� �� ���������������������� ���������� ��������"��-��

����������*���������� ������������������������� ��������*�������������*����������������������

����������������(��"��8������� ���&���������������������������������������������������

��� ���������� ������*����6����������5���"

-���/�������#�������,������ �7/�#,9���������� ������������������������*���

����������5�������������������������������� ����������������*�����������������������"

-���)�6��$���������-�������� �7)$-9���������������������������������� ������.������

�����������(C*��������������� �������������������7������29"����������������������������

����������������� �����������(�������������� �����&�������*�� �����*����������������

������������������&�*������������������ ������������������������*������������������

����(����������"

� /��������)$-�*���� �������� ������������(����*������&���*������������&��������

������&����������������� �������������C��������&�������������������������������������*������6���

�������������������������������������*���������������������������6���������������

�������������������������� �� �����"��-�������*����������������������������������������

Page 14: Characterization of Crazing Properties of Polycarbonate

2

�����������������������.����*��������������������� ����������������������������������

�6��������������������� ������������������"��-���������������������������������������������

������������������������������������������������������������������������������ "��,�����������

�������������������������������������5���&�������5�������������������������(����������

��������"��-����������������*����������������*���������������6���������� ��������*����������

*�����6������������������������*������������5�����������������������������������������������

����������5���"

��� �6�

�/1-���!2��������3/�/)*�,�4��7�3��/�+��4��+�*)�5��*3��6��4��7�,�..��/�+��4��+�*)�5

�5��&�*�����������(C��(���������������� ��������6������ �3"1����*��������������

�����*����������� �������������������&����������������.���������������������������������?3

���"��8�����������������*�����������������������������������������������������(�� ���������

���(����������������������������������������������������*��������������� ��"���5�����������

������������������� ��������������*� �������������������*������� �������������������"

!�� ������������*������������������������������5�������������������������������������&�����

�������&����������������&��������������������"

�5����������������������5����������������������D2E"���5�����������������(�����

���(�����������������������������4����� �����������������������������������������������&

��� �������������� ������������������������������������&�������� ������������������������

����������������"��-�����.����������������*��������5�����������(������������*�4��������5�

���������������� ���*�����������������*�����������������5���������������������������5����

Page 15: Characterization of Crazing Properties of Polycarbonate

?

�� ����������&�������������������5�����������������*&�������������������������������������

.���������������D?E"���5���������������������������������������J������������������*�*�����

�������������������K�D?E&�J�������������������*������������������������������������K�D?E&

J����� ����C������������������5����K�D:E&�����J���������������������������������

������������� ���������6�������K�D2E"

-��������� ����*���5���&��*���������*�����(��������������������7������?9"�������

7�9��������������������*������5������������������������� 7���� �������� ����9�7�!!/9

�������������������������D1E&�*�����������7�9���������������������������������������

��� �� ����7��9���5��*��������� ����������������������������������*����5����������D=E"��-��

�������������5������������������������������������������������������ �����������������7�9"

���� ����

���� �6�

�/1-���#2�������+�).+)�/+�/7�1��)4�+��8/*1���)-*3��),��/*������.�7�,��,)�3�3�/*���*./)*

9':;��*3��6��7/+�)1�����)4�./*1,���),5.�5��*��+��8��</���+,���,5�3�4/*�3�4/6�/,.�9":

������������ ��������������������5�������������������������������������������������

������������������������������������� &���������� ������������ �������������*�������

�6����������������������������������������������������� �������������"��-�����������

�����������������������7�9���������5��������5����*����������������� ����������������������

Page 16: Characterization of Crazing Properties of Polycarbonate

:

��������������&�7�9��������������������������������������������� ���������������������5�

���������������������&�����7�9���������������������������������������5������������������������

����������������&������������5������������� �������"��-��������������������������������������

��4

0"� �������������������������������������������������5�������� �������������

��� ���&

2"� ��������5��������5����*����������������� ���������������������5�����������&

?"� ���������������������������������������������������������������������5��

��� ����������������������5����������&���5���������&��������������&����

:"� ������������������������5�������������"

!�� ��������������� �����5�������������������������������"��-�� �����������������

������:��������������&���5������������&�������C�����������5����*��&��������(���5��������

��*��"

��

��

��

��

7�9

7�9

7�9

7�9

�/1-���%2���.��+�.�)4�+��8����.���+�2�����+�=/���/)*;��6��+��8��/*/�/��/)*;��+��./*1,�;�/.),���3

+��8��1�)<��;��*3��3��6-,0�+��8��3�*./�5�1�)<��

Page 17: Characterization of Crazing Properties of Polycarbonate

1

-�����.��� ������������������������������������5�������������������*��&�����������������

7�9�����7�9"��-������������������������������������������������(���5�������� ������������������

��������������� ��������&������������������7�9"��-������(���5�������� ���*������

�6���������� ��������������������������������&�*�������������������������������5������������

����������6���������� �*�������������������"�������������������(���5�������� �������������

������������������������������������������������������ �������������"������6�����&����

�������������������������������*�����������������������������������5����*���������������

�������������������� ���������������������� �*���������������5���"

������2�������������������*������5�������������������*��&������������������������

�������������������������������5���&�������� �������������"��������?�������������

���������������������*��������������������� ���5��������������������������������������������

�������������������������������5���������&����������������� �����������&�����������

��������5�����"��-����6��������������������������5����*���������������������������������

������������������:"��������1���������������������������5���������������������������������

��� ��������&������������������������������������ 6��������������"��-������������������

������*�(�����������������������=�����>&����������� "

Page 18: Characterization of Crazing Properties of Polycarbonate

=

���������� ����� ����

���� ������ ��������������������������

-�������������������������������*�����������������������������������������������

������������������������������������������������5��"��-�����6������������������*�(�*���

�������������6��������������������������������������������������������������������"

���� ���������������

!�� ���������������������������������������������6��������������������������5���D>&�AE&

������������������������������ ���������������������������������"��8������������ �����������

������������������������������������������5�������������5��"������������������������������������������

������������������������������������������������������������������������5���D@E"��-����

�����������������������?3�������������������������������������������(������������*���

��������������������&������������������������*� �����������D>E"��-������������������������

�����������������������������������������5����������*�������������"�����������������������������

������������������������������������������������������������������������������������ &

���������������������6�����������������������������DAE"

����� ������������

�5����*���*���������������������������������������*�����������&��������������*���

�����������"��$�*������������(������������*������������4�709���5���������������������

729���5������(��������*��������D03E"���5������������������������ �����������������

�����������������������������������������������������������"���5������(������������������

��*���������5����������������(���� ���D00E"������������������������&�������� ������������

�����������������6�����������������������������������������������������D02E"��-�����������*���

������������������������������������6���������"

���� ������������������

-�����5�������������� ���������������������������������"��������������(��*��������

��������&����������&�������� &����������*�����&������������������������"��-�����������

Page 19: Characterization of Crazing Properties of Polycarbonate

>

*������������������������������������������� ��������������������&����������&������������ �*���

��������������6���������� "

����� ���������� ���

������������� �����������������5����������� �������������������������������������������"

-������������������������������������������������5���������"��-�������������5������������

���������*������������������&���(��������������������������� ���(�������D?E"��/���&������*

����������������������������&���*����5������&���������������������������*�����������5��"����

�������&����������������������������������������������������&���� ����������5�������D?E"��-�

������������������C����������������������������5�&��������������������������5����������������

������������������233;��������������D?E"

-��������������������������5������������������������� ��������������������������

��� ��6��������������������� ����������������&�������*�����������1�����*"��8�����������

�������������������������������������5����������������(���"��������������������������6����

��������������������������������� ������������6�����������������������������������

��������������*�������������������������� "��/��� ������������������������������������

*���������&������������������������"

� � ��������

�� ���

��

���)35*�7/+

�)�+�

�/1-���'2��)-�+�.�)4�.���..�)*�7/,/���5��/�+��4�����*.����*+/�.

/�������������������������������������������� ����������� �����������������������

���������������������������������������������������� �����������6���������������������

���*����������������� ������������������� "��-���������������������������������=�*����

������������������������������� ��������������*�������������������������"

Page 20: Characterization of Crazing Properties of Polycarbonate

A

��������

��������

��������

��������

�������

�������

�����������

������� �

������ � ����

�/1-���"2����1/)*.�)4�.���..�+�-.�3�65����,)�3/*1���4��7�,�..����*.����*+5��)��*.-��

�>���*�,�.�����+)*�/*-/�5

�����������������������������5���������������������������������������"���������������

8�������D0?E�����������������������������������������6����������������!!/"��-������5�

���������������������

���?������@�����A�� 72C09

*�������L����C��������������*��������������*����������6����������������*����������������

����������������"����L���M����M������������������������������&�����/�������������������C

��������������������D0?E"��8����������*��������������������������������������C��������������

��������������6���������������&�������5����������������������������6�������������

�����������"

$����D0:E���������������5�����������������������������������������������������

���������������������������*������������������������������������������������-�������������������

������������������������&���(�������������C������������������������������������������"

$���I������������������

��A#�?�9�����B����@��:�A�0 72C29

Page 21: Characterization of Crazing Properties of Polycarbonate

@

*�������������������������������������������&����������� �������������������������������-�&�-���

������������������&������������������� ���������������&�����(��������������������������������

�������������������������������������C����������������*����"

�5������������� �������������5�����������������������������������������(����������

���������6�������������������������������5����������������������������������(�����������"��/

���� ���������������������������������������������������������������6�����������������

������� ������������������������D1E"������������������������������� ���������������� ������5�

��*���������������������������������� �����������������������5������������&���� �����

������������"��-������� ��������*��������/���������������&�������*����� ��������2C?&�*����

������� ������������*���������������������������������� ����������� �������������������&

�������������������������"

��?�����>���B���A���� 72C?9

*�������������������� �������������������������&�����������������&��'�����������������������

������������������������������������ �����������������������&�#��������������������&����

-��������������������������"�������5���&��������� ������������������������������������

��� ���������������������������������������7������������9����������������������������

�������"

����������������/���������������&���������*����������������������������������������

�������������������������� ����������������������D1E"��-��������������������������������������

����������������������������� �����������*� ��������������������������������������������

���������������*&����������������������������������������������������� ������5���"��-��

����������������������������� ������������*�����������>"

Page 22: Characterization of Crazing Properties of Polycarbonate

03

�/1-���&2��44�+��)4����,/�3�.���..��)������)��*�/�,��*��15�6���/���)4�������7�,,5��+�/=���3

�������)+�..�9':

-��� �������������*������������������������������������������������������������

�������������������������� ����������������������������"��-��� �������������������������

*��������������F#-�����������

�� ����

��

��� �

��

�>�!

� 72C:9

*���� �� �����������������&���� ��������������&��������������������������&��'&�#�&�����-�����������

��������&���������������������������"��-�������������������������� ��������������������������

���� �����������������������������"

Page 23: Characterization of Crazing Properties of Polycarbonate

00

!������������������������*��������������������0@=3I������0@>3I�"��!���������������

�����5����������*����������������������������������������������������"��-����������������

�������������������������������&������&����������&����������*�����&������������������������ "

������ ����������!�� �"��

6�������������������������������������������������������������������6������������

��5���������������� ����D>&�03&�01�C�0>E"��-�������������� �����5��������������������������

�����������������������������������"��-*������������6��������������������������������������

�����������������������������������*��(������������������������������������ �������������

��������������� ������*�������������������������������D>&�0=�C�0@E&"��-���������������������

�������������6����������������������������������������������*��������������5���������� ��&���(���

���������������������������D23E"��������������������������6���������&���������������������

��*�������������������� ���(�����������������������D>E"

-��������*���� �������������� ������5�������������������*����������������������

����������������������������������������� ������"�����*�������������� �/���������������D@�C�00E"

-���������������������������������� ������������������������������*��������������������������

������� �����"���������5�&������������������������������������� ����������������������������������

������������������"��-�������������� ��������������������������������������� "��-�������������

����������� �����������������������������������5��������������������&�����������������������

���������������������5�������*���������������"��-�����6����������������*�����6���������

��������"

�5������(�������������������6��������*����������������������� D03E"��-��������

��������������������������������*���������������(����*��������������������������(���� ��"

/������������������������������������������������������� ����������������"��-����������

����������������������������������*��������"���5����*���(������������������������

������������������ ����������������"

-�������� �*��������������������� ��������������������������������������������� ������

D>&�03&�01�C�0>&�0@&�23E"��-�����������������������6������������������5����������������������

*�����������������������������&������������������������������� �*��������������"��-�������� �*���

���������������������������������������������5���������������� ���"��������������������

Page 24: Characterization of Crazing Properties of Polycarbonate

02

������������������������������������������������5���������������������������������&���������

������������D0=&�20&�22E"

/�����D0=E�����������������������*����������������������������������� 7���� �

������ ����9�7�!!/9"����������������������������������������������������������������

*���&��������������������������6������������ ������� ���"��/�������������������������

/�����*����������5�������������*�������������������������*��������������*������������

������������������������������"��-*������������������������������������������709����������

�������������������&�������������*������������������*�&���729��������������������� ���������

������������������&���(��������������������������5���������"

+�������&������"�D20E&�������������������������������������������������!!/"��-��

����������������������������*����������!!/������������� ����(I����*&���������������������������

����������������������������������������������������������������������������(���� ������������

��5��������������������������������C��C�����������"�������������� &�*��������������(���

��������5��� ���*�����������������������������������7-�9&����������������&����� ������������

���������� ��"��-�� ��������������������������������5�������������������*����*������������

���������������*���������������� ���"

)�����������"�D22E��������������������������������� ���F�� ���������7�/)9"��-��

�����������������������������������������������������������������������5���&��������

����������������������5���������������� ���� ���"

����#� ������������!�����"��

�������� ������������������� �����������������������������������������������������

�������5�"��!����� ���������������������������������*���������*��������� ������������

�6������"��/���&�������������&�������������� ��6����������6���������������������������

������������6����������� ���������������������������������� ������������������������

����������������"��/����������������������������������� ������!����2"1��������������*����

������A�����*"

Page 25: Characterization of Crazing Properties of Polycarbonate

0?

�/1-���C2����+��!D'�����7�,���)4/,��)4����*.����*+5�.0/*���7�����-��

������A����*�������������������������������3�������������6��������������??3��"

-����������������6������������������������������������� �����������-�������7�?33��9&����

������������� ���� ��6������������������������������� �������������������"��-�������

���*�������������������������������&��������������������������������"��-�����������������������

���� ����������������������������������������������� ���������������(�������������������

��������� "

���������������������������������������������������5�������������� ���"��������

����#����D2?E�������������������������������������������������5�������� �����������������5�����

��������������*�������������������-�"��-�������������*������������������7�������9�������

�����5���������������������������������������"

����������� ����*���������(��D23E��6�������������C�C��� ��������������������������

��� ����&����*�������������������������������������5����������������������������������

�������������"��N����������5������������������*����� �����&�������*����������������������

��5�������������������������������������������������������������"��-������������������������

������������ �*������������������������������������� �����������������������������

�������������������������*������������������������������������������������������&�-�&

*���������"��/�����-���������������������*�(�����������������"

Page 26: Characterization of Crazing Properties of Polycarbonate

0:

8��������������������*������������������������������������������(���������

��� ����������������������������������������������������������.����������������������������

��������������������������� ���������������������D2:�C�2=E"��-�������������������� ���������

������5���������������� �����������5�����������������������������������������"

����$� ����������!�%��"%���������

8�������������������������������������������5�������������������������

�������������"�� ��������������������������������������*������������ �������������*����

������������������� "�����������������������(���&�������� ����������������6�����������

������������������"��-��������� ��������� �������������������������������������������

*�����"�� ������� ���������������������������������������*������7!9&�����*�*��������

������������������������������"���������������������������� ���������������������F���������

�����������������������������������*�����&���������������������������������������������

���������*������������������������������������(����������*������D2E"��-���������������

������ ��������������������������������������������������������������"��������������

������������������� ������������������������������������������5�������������������������(����"

!�� ���������������������������������������������������� ���������������������5�

���������"��-�����������������������������5�&�������� ��������������������������������&

������� ����������������������������������D:E"������(�*������������������������������������������

��5������������� ������������������������*�����"��'������������������������������������������

������������� ����������*����������������������*������������������������������

������������������������"��'�������������������5���������������������������������������

��������������� ������������������������������������������������������D2E"

!�,�����D:E�������������������������������������� ������������5���������������������

�����������������*���������������������������*�*��������������5�������������"��-����

����������5�����������*����������������������������������������������������������

���������*�����"��-�������������������� �!�,���������������������������������������� ��

���������������������*������5�������"��/��������������*�&�������������������������������

������������������� ����������������������������������������"��-����6������������������������

����������*��

Page 27: Characterization of Crazing Properties of Polycarbonate

01

�����9����������A�������A���

�������:

��� 72C19

*�����������������(���5���������&������������ ���������������������������������������

���������*������!&�!�����������������*�����&���

�������������������������������������&����������

������������������������������������&�����������������������&�������������������������� �����

���������������C������������5�"������������������

���?���@�<�����A���

�����A�� ��3�� 72C=9

*��������������������N���������������� &�*�������������������������������������������������

����������������������������������&����������������������������� &�������������������������������

������(����������������"��-��������������������&��������������������������������������� &�����

��������������������! ��"

������������������D2>E&����(����������������������������5��������������*�������

�����������������������������0?3�"��-�� �������������������5���������������������

�����������5�����7�O9"��-�� ����������������*����������������4

709�/����������������OI�������5����������*�����������������������"

729�������������������5������������������������������������������"

7?9�-����OF��5�������������������������������� �������������������������"

7:9�-�������������5�����������������*�������������*���������������������������.���

�����������������������������"

719�-��������������������������������������������������*����������*��(� ����������

��������������������������������������"

7=9���������������������������*��������������������������5��������������������

�������������������"

-���������������������������5��������*����������*��������������������������������

��*��������������������-��� �����������(����������������������"��-�� ���������������5�

�6������������&������&�������������������������������������������������������5�"��-�� ����������

�������5��*�������&�*��������������������������������6�����������������&������������������

Page 28: Characterization of Crazing Properties of Polycarbonate

0=

��*�����������(���� ��������������� �����������"����������������������&�����������6�������

������������������������������*�������������� ���������������������*� �������������"��/���&

����&�*��������������������������������������*�����&��6����������������������*���

���������*����������������������5���"����������������������������6�������������������

���������*������*��������������������������������*�������&���� �����������������6������

���������������C������������5����*��"

����&� ����������!�%��"%��������������

������(������#����D2AE����������������� ���������������������������������������������

��5�������������� ��������"��-�� �������*����21��������(������������������������ �����C

�����������������������������(��������0����*�����������"��-���������������������������� ��

��������������������������������������������"��-��������������*�����������*����3;�����13;

��C����������&�������5�����������������������������6�����������������������������������*��

����������������������� ������*����C����������"���������������C��������>1;&������������

�����5����*�������"

��������������C������&��������C���������������6������������.������������������������

��� ����������������������������������������������������.������������������������������������

���*"��-������&�������������������6���������������.����������������������� ����������������

���� ������������"������������� &����������������������������������������������������*���������

���������������������*����5����������������������������������������������������"

���� �������������������������

-������������������������������������ ����������������� �������"������� �������

���������������������������������������������������������������*������������(���� ������(�

��*������������������� ���������������������������D1E"�������������������&���� ��������

������� ������������������6������ �003;����������������������"��������������������� �������&

��� ����������������5��&�*����������������� ��� �������5����������������������5�������

��������������"��/���5�C�����������������*�����6������������������������������� �����

���������������"���������������������������5������������� �������������������������������

������ �������������������*�����������������������������������������������D1&�=&�2@E"

Page 29: Characterization of Crazing Properties of Polycarbonate

0>

���� ����������������������������������

-�����5�������������������������������������������������*��������5��&�������

����������������������������������������������������5��������������������������������

��� ���"��8����������������������������������������������������������� ����������������������

�����������������������5������������ �����������"��������������������������������������

����������������������������������������������5������ ��������&�����������������������

����������������5����*����������������������������������?"

8�������������������������������������5������������������������������������� �� ���

7��9�*������������� �-����������*�(���D?3E"��-�� ��������������������������������7� !9���

������������������������������������5�����������������7 �9&�����������������������������������

�������������������7 �9&������������������7$��9&������������I�������7���9������5�����"

�������������&���� ���������� ���������������&���*������� ���5��������������*��

�����������"������������� &�-���&������"&��������������5������ �����������*���������������

��5������������*�������������������������� �����������������������(���� ��"��-�� ������

����� ����������������������� &���������$������������������� &����� ��*���������������"��-����

����������*����������������������������������������5�������������������&�*�������������

�6������"���������������&����������������������������������������������������������������

���������������������5���������"

�� � ���! ���"�������

-��������������������������������������������*���������� ��������������5����������

�������������� ����������������������� �������������������������������&���������������������

�������� �7��9&�������������������� ����7-$/9&������������������������������

7$�9��6���������*����������������������������������5����*��������"

��&�� �����������%� ����������%���!���'

�������������������������������� ��������������������������������� ������(�����

������������������������������������������������D?0E"�������������������������&

��� �������������������������������������*��������������������������������������0:1�"

-�������������������������������6������������ ������������������������� ������������

�����*���������������&�������������������������� �����������"��N������*�����������������

Page 30: Characterization of Crazing Properties of Polycarbonate

0A

�������������������������������� �*���������������������������������������������������

��� ���������������������������������������������������D1&�=&�?2E"��-���������������������

��� ������������������������������������������������������������������������*��������

�����������������������������������������"��-���&����������������-�����������������

��������������������������������� �����������&��������*��������������������������������-�"

/������������������������������������������������� �������������������������������

������������*���"��709�������� ��������������������������������������� �7�9"��729���������

����������������������������������������������&���(���������������������������������������

���������"��7?9���������������������������������������������(����������������������*�������

������������ ����������� ������������������������� ���������F�������������������D??E"

-���������������������������������������������.����������������������� "��-��������������

���������������� ������������ �������7������-�9������������������������������ ������������� ������

7����*�-�9"��-������������������������������� ����������������������������&�����������&����

���������������������������*��������������������������� ���� ��������������������������

�����������������������7������@9"��-�������������������������������� �����������������������

������������������*��������������������&������������������������������������� ����������������

�������������� ����������������*��������������������������������������������������������

���������D??E"

�/1-���E2���)*+���-�,�1�����)4�����.+�*

Page 31: Characterization of Crazing Properties of Polycarbonate

0@

��&��� ����!����(�!���������%' �

-$/����������������������������������� �����������������5����� ���"������������

�����&��������������������������������������-$/&���������������������������������������

�����������D=&�?:E"��/�-$/����� ���������������� ���������������� ������������������

����������������������������������*����������������������������������������������������

D?0E"��-����6��������������������*�����������������������������"��/����������������-$/

��������*����������C������������������������C����������������������*��������������������

�������������� �����������������������5���"

��&�#� ��%����!�����������!��������'

$���������5���6������������������������� �����������������5���������������

������������������ ���D=E"��-����������� ����$������������������������� ������������������

���������������������������������������������������������.�������������"��/�$���6�������

������������ �������������� �������������������������������� �������������������������

��5�������"��/��������� �������������������������&������������������������(���������������

������������������������������� ���������������������������� ����������������������������

������������������"��/�����������������������������������������������������������������

������������������������������"��-�������������������������������������������������*�����

������������������ ���������������������D=E"

/�����������������&�����������������������������������������������������������(�

������������������������������������"�������������������������*���������������������*���

������C����������������������������������������������������������������������(��������"

��#� $� ����!�������

8���������������������������������� ������������������������������������������������

����������"��-������������������������������������ �7#'9������������� � ��������2C>�������

���������������*������������� �������������������������������*��������������

����������D?1E"��/������������������������&����������������������������*���"��-������&

�������������������*����������������������&�����#'���������*������������������������"

Page 32: Characterization of Crazing Properties of Polycarbonate

23

�((����

��� 72C>9

/���������������������������*�����������������������������������#'��������������

�������������������������*��������*��������������������������������*���������������������

��*�"��-��������������������*������������������������*���������������������������������D?=E"

$��������D?>E������������6����������#'�����������2A�������������������������������

���� ������������������#'�����������?"?@;����@>"AA;����21�"��-*��������������� ��������

���������#'���������������������������700"?3;�#'����21�9��������������������7>1"2@;

#'����21�9�D?1E"

����������������������������������������������������������*������*�������������"��-��

��������������������������������� &�����&�����������������������������������&������������������

���#'�*������������������������&�������*�����-�����0"

��6,���2��44�+��)4���7�����-���)*����=�,-�.�)4�.�,��.),-�/)*.�9#&:

-���������7�9 ,��������������7;#'9 ��������������7;#'9

03 00"2@���3":0 >1"=>���3"22

01 00"?3���3"?1 >1"=0���3"0A

23 00"?0���3"?0 >1":>���3"0:

21 00"?3���3"2> >1"2@���3"02

?3 00"2A���3"2: >1"3@���3"00

-������� ������������������������������������������������������������������

����������*��������������������� �����������������&���������������������&����������#'

��������������������������������������������������������������"

Page 33: Characterization of Crazing Properties of Polycarbonate

20

��������#� �)*� +����,

���� "������ ������������%������ ��������������������!���

�����������! ���

�������� &���*��������� ������������������������������ ���������� ���5��������������

��� ���"��-�����������������������������������������������������������������������D?A�C�:3E"

-������������ �����������������������������6�������������5��������������������������6��������

�����������������������������������6������������������5���������������������������"��!��

���������������������������������������������������&��������������D:0�C�:?E���������C�����D2A&

?@&�::&�:1E"��-������������������������ ������ � �������������������������*���������������������C

���������������������������������5������������������������������"

'��(���������-��(�D:=&�:>E�������������� ��������������������� ����������������

��5����������� ����������������������������������������������������������� �������5����������"

-������������J��5������6K�������������*����������������������������������&������������

�����������������������5�������� "�����������������������������������������������������������

�����������*��������������5���������������������������������������������������������*�������

��������������������"���������������������������������������������������������������������

���������������������������������������������������������������������6������������������

��������������������� "

/���������������&�(��*�����J��������������K&������������������������� �������������5�

������������������������C��������������D:A&�:@E"�����������������������������������������*��

����������������������������������������"��-���������*�������������������������������������

������������*����������������������������������5������������"��/�������������������������������

������������5��������������������&���� ����������������������������5������������"

���0@@1&���� ��(���������(����D03E�����������������������(����������������������5���

������ ���"��8����������������� ������������� ����� ���5����*�������������������

�6������������������������������������������������������������������ �7- !9"��-�����.�

��*���(�*�������������������������������������- !����������������������������6�����

�������������73"1C0"3���9�*��������������������� ���������������������������(���� ��"

Page 34: Characterization of Crazing Properties of Polycarbonate

22

������������� ����������������*�������������������������������5������������

�������������*� ���������������������������������������������������5�������� ������������.���

��5������������"��-����������������������������������������� ��������������&�������������&����C

���.������&�������������������������������5�������� �7�������������������5�����������

����������9"����������������������������������������������������������������������������

������&�������� ������������������������������������������������������������������������

��������� "��-�������������������������������������������������������������������������������

�����5�������� �����������������������������������������"

-�����*����������������������������������� �������"��/���� ���������������&�������

����������/�-!��=?A�� ������������������7������039&����������������������������������

�������������������������������������� "��N��������������&�����������������������5�

������������ �����7������009�������������������������5�������������������������������C

����������������������"��-��������������� �������������������������������������*�����

!���6�!�������������������������������������������������*��"��-�����6����������

���������������&�*�����������������������������������������������������&�*���������������3"0

'5"��-�������������������������C����&������&��������� 5���������������"

&-�!!

�$.�!!

�/�!!/�!!

0.�!!

�/1-����(2��������"#C��5���������*./,��.��+/7�*�1�)7���5�9'(:

Page 35: Characterization of Crazing Properties of Polycarbonate

2?

�$�!

�..�!

�D"#�7

(D%'&�7

�DC(�7

������

������� ������

�����

������

���

�����

������

���

����

���

�������

�/1-�����2����4,�+�/=��/7�1/*1�+��8��7��.-��7�*��.5.��7

-�������������������������5���������������������������������� ��������������������

�����"��-��������������������������� ������������"��/�� �����������������5������ ��������

������*�����������02"

Page 36: Characterization of Crazing Properties of Polycarbonate

2:

��� �� �� �

� � � �� � � � �

���� � �� � �� �� �

�� � �� ��� �� � �

�� � �

� �� � �� �

� �� �� ��

��� �

�/1-����!2���5�/+�,�/7�1��)4�+��8�3��),5+��6)*���

/���������������������������&���� �������� 5��������������������������������� ���

����*����������������������5�������� ���������������������������������������"��/� �����������

���������� ��������*����� ��������"��-���������������������� &���������������J���(��K���

�����������������������(���������������7���*�����������029"��J!��(���K����������� �����

�������6��������������������������������������������� ����5��&�*������������(���������D10E"��)�6�&

�������������J����������K�7������0?9���������������������5�����������(���������������������

���������02>�C�211�D10E"�������� &���������������������������������������5�������� �������

������������������ ��������������������������������������5���������� ����������������"

Page 37: Characterization of Crazing Properties of Polycarbonate

21

7�9

7�9

�/1-����#2���5�/+�,�/7�1��)4�+��8�3��),5+��6)*��������6�4)����*3��6���4��������.�),3/*1

-��������� �������������������5�������� &������������������������ ������������0:���

�������������&������������3"03;����@":;"��-����������������������������������������������

�����������"������������������������������������������������&�������5������������*������

�����������������������������*�����������"

Page 38: Characterization of Crazing Properties of Polycarbonate

2=

���� � ������ ��� ������

���� ������ ��� ������

���� ������ ��� ������

���� ������ ��� ������

���� ������ ��� ������

���� ������ ��� ������

�/1-����%2��/+�)�/�,�3�.+�/��/)*�)4���,��/=��+��8��3�*./�5

Page 39: Characterization of Crazing Properties of Polycarbonate

2>

���� "��������&�����������%��� ��

-�����*���5����������������������������������������������������� ����������������

��.��������������������������������������*��(��������������������������������������&

����������������������������� "��-����������������������������&��������������*������

��������������������� �����*�������������������������"

#���� ,��1����!�

-�����������������������������������������*�������*���������������&���������

?K6?K60F:K�����������������/�-!�/133��"���������7������019"��-�������������*�����������

������������� �������� ����������������������������������������PK�����������������������

������������������"

��

�� ��

��

��

��

���

��

��

��

���

��

����

��

��

�/1-����'2���)�3�4��7���-*/�.�����/*+��.�

Page 40: Characterization of Crazing Properties of Polycarbonate

2A

#����� 2'1��"%���%��1����%�������� ' ��!

-�����6�������*�������������������������� ������������������������� ���������������

���������������������1333���"��/���������������������������������������������������������� ����

������*�����������0="

2'1��"%���

�'%��1��

,��1���%%������%����1�

3*�4

�%���������

��� "���

������%�

(�%(�

���"!"%����

*"!� +����

� ��(���

5"��%'

��"��

�/1-����"2���/7�,/4/�3�.+��7��/+�)4��53��-,/+�,)�3����,/+��/)*�.5.��7

-����������������������������� �������� �����������������������������������������

������������� ������"��-�����������������������C���������������������������7���9��������*

����7B��9�������������������"������������������ ����������������������������������������

�����������C����������������������"��-���� �����������*������������������������������������

��������������������������������������"��/������������&��������������������������������������

������"

#���#� ��������� ' ��!

-���/�-!����������*������������������������� �������� �����"��/��������������

���������������������������������������������� �����������*�����������0>"��-����������

������������������������������������*���������������������������������������������*�������

Page 41: Characterization of Crazing Properties of Polycarbonate

2@

��������������� ����������������"��8���������������&����������������������������������������

��������������"

��������

������

���

��������

���� ������ �

�����

������

�/1-����&2�� �/�A.�7�,���..�76,5

#���$� ��(����!����%�������%� ' ��!

-��������������� ���.���������������������������������������� ����"��/�#,������

�*�������������������CO�����������������������������������������������������������

��������������������������C>?����M0>>��7��0�9�����03����@1;���7��:;��9"��-����������

���������������5���������&��������������������������������������������������������������

�������� ������������������������*������������������� ������������������������� ����"��-��������

Page 42: Characterization of Crazing Properties of Polycarbonate

?3

�������������*�����������0A"��-����������*���������������� �#��������-����������������"

����������������*�������������������������������&��������������*�����7�*�������������9&������

���������������7��������������&������������������9&������������������������7�����������9&����

�*������������7��������O������9"

- /

&

-

&

$

$

.

0 $ . $ 0

��

6

6

�/

�- 6

/

/

$

�/1-����C2���*=/�)*7�*��,���.�/*1�+��76��

Page 43: Characterization of Crazing Properties of Polycarbonate

?0

-����6����������������*������������������*���������������������0@"��-���� ����

�����������������������������&�� ����������������������������&��������������������������

� ����&����������������������"

������������������������

������������

����

������������������

�������

!������

"�#�� ����

���������

����������

�������

�����������

$����

�/1-����E2����������.�����*3��*=/�)*7�*��,�+)*3/�/)*/*1�.5.��7

���� �������

-*�����������������������������C/���� ���������*���������������������������"������

���������*���������������������� ������������������������������������������������5��"

-�����*��������������������������������������������5�������� �*�������������*����������

�������� �����������������������������#��������'���&�(��*�����-����(�N"��/����������

������������������������������������������������������������������������������������

������������������������������������"��-�����������*���������������������?��������("��-��

�����������������*������������������ �������������������������� �7$�9�*���11&333

Page 44: Characterization of Crazing Properties of Polycarbonate

?2

�F���"��-�����������������������������������������������������!������!� D=E"��-��������

�����������������������������������������(������������������������� ����������������

���� ������������������������0�F����*���������������01=�"��-��� �����������*�������������

���=2�!���*�������������������������*���������������2"?�$���D12E"

-����������������*��������������������������������������*��������������������=

�������(���� ������������������������� �!�!������"��-������������������������

*������������������ �$��*���0@&:13��F����*��������� �������� �����6����2"2"��-��������

�������������������������������������*���������������0:>�"��-��� ����������������������

��������*�����������������=1�!�������2"?�$��&����������� "

���� $� ����!�������

����������������� ����������������������������������������� ����&��������������

������������������������������� ���������������������������������5���������"��/����������*��

�������������������������� �� ��������������������������������������������������������������

���������������#�������������������������������������������������2"�����*�����������������

���������������������*�������������������������������������������������������� &����������

�����������������������*����������������������� �*����� �����"��#���������������� ������

��������������� &�������������6���������*�����������������������������������������*��������

��������������������"��-���������� &������������������������������� �����������������033;&����

��������������������������� �*���A1�1;�����������������������������������������������"

/����������������*�����5����������������������&����*�������������������������

�������������00"?;������������������������������������"��-�����������*�����������������

������������������������������������������������������������������������"��-����������

��������������������*��������������������� ��������������������������������"

�� � �����������������������

����������������� ����������������������������6�������������*� �������������5�

������ ���������������������&��������������������6������� ��������������������������C� C����

����������������������������������������������������������"���������������������������������

�������������������������������������&���������� ������������������5������������&�*���

������������ �����������������������������5�����������"������������������������������������

Page 45: Characterization of Crazing Properties of Polycarbonate

??

�������������������������������������*�(�������������������������������������������������

�������������������"

#�&�� 5�!�%�������������

����������������������������������������������� ��������������������������������������&

������������"�������������������������������������������������������&�����������&��(������

�6�����&�������������������6�����������������������������5���������� ��������"��-��

�����*�������������������������������������������������4

709� '�������������������*������������������������������������������������5���(��

��������*���������������������������(��������������������5����*��"

729� N�������������*&�������??"1����6�2=>������������������������������������������

����������������-�����(�-�/�-!�������������������������"

7?9� ������������������������/�-!��=?A�- �������������������������7������039

*��������������&���������������*������6�������������������������(�����3":

���������������������*����(���������*���������Q�3"0��������"

7:9� #������������������������&��������������"

719� #������������������*����*���������������������������*����*����������������

�����"

7=9� ����������� ����������������*����033�������������"

7>9� #�C��������������������*����*����������&������������"

7A9� ���������������*����:33��������������������������"

7@9� #�C��������������������*����*����������&������������"

7039� !������������������������������������(���������*�������������������3"31���&

�������������������������������������"

7009� ��������������/�-!���������������������������������"

7029� ������������ ���������������7������0>9������������������(���������������*����

02�)C�"

Page 46: Characterization of Crazing Properties of Polycarbonate

?:

#�&��� �������� ����

-����������������5����������������������������*�4

709� ���������������������������������������������������������������"

729� ������������������������������������������������������J!���K�����������������

� ��������������������� �������������������>1����033��������������������

��������������������7����������0>����������������������������9"

7?9� !��������� ��������*��������*� ������������������������ �������������*�

������������������������������"��/������������&������������������������6������

223�)�*���������������� ������������������������"

7:9� ���������������5�����������������������C������������������������� ��*�������

�������F����������������������������������������������������������������������

�����������������&����������������������������"

719� ��������������������*����*���������������������������������������������"

-���������*���������� ������C�����������������������������������������"

7=9� -�������������������������������������������������������������������������

�����������������*�����������00"

7>9� -������������I����������.��������(�������������6���������������������������

��������������������������"

7A9� ������������������������������������������������������������������J�����K�����"

7@9� ���������J����K���������������������������*����*�������� ����������������������

����������������������"

7039� !�������������C��������������������������������*��������������� ���������

����(������������������������������������������"

7009� /���������������������������&�����������������.��������(�����������������������

����������������������"

7029� 8�������������������������������������5�������&����������J����K��������������

������������*����*������������������������"

Page 47: Characterization of Crazing Properties of Polycarbonate

?1

#�&�#� !�������%' �

-��������*�����������������������������������������������.������� ����������������

����������� �������� 5�������������������"

709� 8������������������������*�����������������D10E���������������������������

����"

729� �������������������������������(��*��*�������������������������������������

����������������7��6���4��9"

7?9� $�������� ���(�������������������������������������7��01���6�13���9"

7:9� !��(�����������*����������(�������D10E"

719� !����������������������(������"��-����������*��������������������������

���"

7=9� 8����������������������������� 5����������������������������

7>9� �� ���������������������������������������������������������������������

�����"

7A9� �� ������������������(��� ���������0������������������*�����������������

���� 5��"

7@9� !��(�������������������������� 5��"

7039� ��������J-��������H�,��(���-����K�����&���������������������

����������,�-�*��������� ����D10E"��-�������(�������������������� ���6��

*��������������� �����3����02=��������(�������� ���6���*��������������� ����

02>����211����*����"��-���*�������6�����������������������������5��"

7009� -������������������������������������������ ���������213C211"

7029� !������������5�������������������������������.�����*��������J-����C�!�����

�������K�����"

70?9� ���*���������������������������������������� ���������������*���������=���������

(� �����������������������5������7��(������������������������������9"

70:9� #�����������������&�������������&������������.����&��������������"

7019� �������������5������� �������������������������������������������������5��"

Page 48: Characterization of Crazing Properties of Polycarbonate

?=

#�&�$� � �1"�%�!��������%��������'�!�� "��!���

-��������*����������������������������������������������*����������������������

�������������������������5����������"

709� ����������������������������������������������������������������������������������

����6������������������"

729� !���������� ����������&�������������&���������������������������������������

������"

N����������������������������������7�������������� ���������������������������9������

�����������������7���������������������� ��������������������9&���� �����������������

�����������������������"�����������6�����������6�����������������������������������������

����������"��/���� ����������������������&���� �����������*��������������� ������������*

�����"��-��������������� ������������������������������������������������������ ������������

������� �������������������� ������������������6�������������������"��-��� ����������&

������������&������������������������*�����������23�����������������������������������

�������������������"

-

-

�-

#-

$-

&-

.-

0-

- -�� -�$ -�. -�6 ��

������������5������3!!7!!4

������������5��� �

3+*�4

����� ��� ���� � ���

��� � ����

�/1-���!(2��5�/+�,�.���..B.���/*�+-�=��4)���),5+��6)*���

Page 49: Characterization of Crazing Properties of Polycarbonate

?>

�������������������&����� �����������*�����(���������������6�����������������������

���������������������*���������"��-����������������*��������������������6����������

���������� �������� ���������.�����������������"��-�������������������*���������������

����������������������������������������������������������"��-��������������������� �*�����(��

���������������������������������(������������������������������������������������5���������

����������������13���"��-���������������������������������20"

���8�1

�����

,9

�/1-���!�2�����</*1�)4������3)16)*��.�7�,��</���*�+0�3�1�1��.�+�/)*

��#� "��������'(���� ����)"*'+

8����������������������������������� ����������������������������������������������

�����5������ ����������������������5���������&�����������5�������� &��������������"��,������

��������*�����������������������������(�����������������������������������������������������

��������������������������������������������������������"����������������������������������

����������������*����������������� ���(�����������������������������6��������*������

������������� ��������������������6"��-�������������6�����������������������������C

�6�������������������������������������������&����������������������������������������������

��������������������������������������������������������������������������*���������

��������"��-����������������������� ������������������� �����������6������������������*���

�����������D1?E"

Page 50: Characterization of Crazing Properties of Polycarbonate

?A

�����*�����������������������������������������&������������6�*��������������

��������&�����������������*��������&�*�����������"��-���������������������������*�����-�����2"

��6,��!2���./1*�3��>���/7�*��4�+�)�.��*3�,�=�,.

��+�)�. �)< �/1�

7/9�������7!��9 :3 :1

7�9�#���������5�������� �7;9 0 03

79�������#����7�����9 3"2 2

-��������������������������*�����-�����2�*������������*�������������������������"

-��������������*�����������������*���5������������������������������������������ ���������

� ������������������������ �����������������������������"��-�������������5�������� ��������

������*��������������������������������������������������������������"

N������������������������8 ��������&�����������������������������C������������������6&

�"�"&������������ ���������������������������������"��-���������������������������������A����"

�������������������*����������������������������������������2:��������������D1?E"���������

����������������&����J��������K��6����&�*���������������������*�C*� ���������C*� ������������

������������"��-�������������������������������*������*����-�����?"

Page 51: Characterization of Crazing Properties of Polycarbonate

?@

��6,��#2����./1*�3��>���/7�*��#�4�+�)��B�!�,�=�,�F�4-,,�4�+�)�/�,���.��7���/>

�-* ����..������ ��,��/=�����8�

��*./�5��G�

����/*�������7/*���

0 :3 0 3"2

2 :3 0 2

? :3 03 3"2

: :3 03 2

1 :1 0 3"2

= :1 0 2

> :1 03 3"2

A :1 03 2

���������������������������������� ����������������������������������������������

����6"��-������������ �������������������������������������������������������������������

����������������������������"��)�6�&����������������*��������������������������� ����*����

�����������������������"�������� &������������������*���������������������������������������

�� ����������������������*�����*��������"

#�.�� *��1����(���:"������1���(�����

/���������������������������������-�����:�������*�������&��*�������������������������������

���������������������������������������������������������"��-����*���6�������������������

��������/������"��-���M0I������H0I�������������������������*������������������/������"��-�

(�����������������6����������&�������������������������������������� �������� �����������/��

��������"

Page 52: Characterization of Crazing Properties of Polycarbonate

:3

��6,��%2��/+�/�/)-.�3�������3����.����)�/,,-.������+�,+-,��/)*.

#�� ������/ ������� �����������/6� /������#�������&�<���

0 C0 C0 M0 23

2 C0 M0 C0 0=

? M0 C0 C0 :3

: M0 M0 M0 ?:

-�����������������������������������������������������������������������������������

���������������������*����� ��������?C0"

����������?��!(�@��"�@�%(�@�#%��A�%�?�!&D' 7?C09

)�6�&������������������������������������������������������*�������������������������

���������"������6�����&���������������������������������/����������� ���������������������

���/����������������������������������������������������������/����������*��������&�������*����

��������?C2"

���?����������F�����

�����?�9(D'�>��%(�@�#%�:�F�9(D'�>��!(�@��"�:�?��E� 7?C29

*�����/������������������������������������/&�7/�9�����������������������������/������������

������������7/�9�����������������������������/����������*��������"��������� &����������������

�����������������������������������*����������/�������������7/6�9����������������H1�����C0&

���������� "

������ &��������������������������������������������������������������������������

���*����� ��������?C?"

���� ?�����������@����A!����@����A!����@�����A!����

?�!&D'�@�ED'���F�!D'���F�(D'��>� 7?C?9

Page 53: Characterization of Crazing Properties of Polycarbonate

:0

*����<���������������������������&�7<���9���������������������������������������&��/�������

����������������������������/&����������������������������������������&������/��������������������

�����������������������������*�����������/������"

#�.��� *������1�����!����!"%�����

-�����6�������������� ��������������������������������&���������� ����*�������

����������������������������������������������������������� ��������?C?"��-��������������������

���������������������������������������� �����������������������������������������������&���

���*�����������22"��'������������������������������������������������������������������������������

������������������������������������������������������������������������������������� �����

�����������������������������������6����������&�*���������������� �������������������������

��������������������������������������������������"��-���������������������*��������

�������������������7 ��������?C?9����������������������������������7�RF29"

��

� � � �

9�����

2�%��������

�/1-���!!2������)�3/�1��7�)4���,4��44�+�.�)4�.�7�,��3����.��

������������������������22������������������������������������/"�����������������������

�����������������*���������������/6����������������������������������������"��-��

����������������*������������������� �������������������������������������������������������� ���

Page 54: Characterization of Crazing Properties of Polycarbonate

:2

���������������������������������������������������"��-������������� �����������������������

����������*���������������������������������*"

�)*4/3�*+�����7�6�,)*1.�/*�7)3�,�?����F������ ���H��((G� 7?C:9

-��������������������������������������������������������������������������������������

�������������3"03���������������������������������������������"��-��������������������

�������������������������������������������������������������������������������������������

�������"

#�.�#� �����������1�����!�1�(�%��!���

8�����.����������������������8 ����� ����������������� ����������������������������

��������������*�����*�������������"��/����������������������������������*� ���������������

����������������������������"��-������������������������ ������������������������������������

����������������������������������������/"��-����������������������������������������������

-�����:�������*�����������2?"

� ����

�����

��

��

��

��

��

��

��

��

�� �� � � �

9�������

�(������ � ��� �

�/1-���!#2���*����+�/)*�3/�1��7�4)��.�7�,��3����.���.�)</*1�*)�/*����+�/)*

Page 55: Characterization of Crazing Properties of Polycarbonate

:?

������2?����*���������������������������������������������������������*������

�����������/&���� ����������������������������������������������*�������������������&��������

���������7C09��������6������ �������������������������7M09�����������������������������*���

�������/������"��-������������������� ��������� ��������?C?"��/��������������������*�����

��������������������*�����������/�������*��������*������������������&������������������"

��,� ���! �����������

/���������������������2&������������������������������ �7��9&���������������

���� ����7-$/9&������������������������������ �7$�9��6���������*������������������

���������������5����*������������������������������������������������������*����������

�������������5������������������������� ����������������������� ����������������������

��������"

#�0�� �����������%� ����������%���!���'

-����������������������� �*�������(��� ������������������>���*��������������

���7������2:9�*��������6�����������������������C0>3�����M>?3��7�3"0�9������������

���������3"0�����233�F����D1:E"

Page 56: Characterization of Crazing Properties of Polycarbonate

::

�/1-���!%2���+��7��/+�)4����0/*��,7�����,������/�.����&��)<���+)7��*.��/)*�����9'':

/�����������������������������������������������������������������5������*���

������(��� ������������������������������*�4

709� ��1����03����������������������������������������&�*������&���������������������

���&

729� ����������������������������������������������������������������&

7?9� ������������������������������������������������033����233��������������

�������03�F���&

7:9� ���������������������������� ��������������������������������������������������&

���������� &

719� ����-�������(������������������������������������*�����13;�����������������

������������������������ ������������D=E"

Page 57: Characterization of Crazing Properties of Polycarbonate

:1

#�0��� ����!����(�!���������%' �

-���-$/������������������ �*�������(��� ����-$/>�*�����������������������

�����������0333��7�3"0�9����������������������3"0����233�F����D1=E"��-��

�����������������������������������*������������������3"0����*������������� ����3"0;"��-��

�������������������5���������-$/>��������2����13���"

/������������������������������������*������������������������������������"��-����������

����������*���033��������������������������*���@33��*���������������������23�F���"

-������������5������������03����01���"��/���������*��������������������������������"

� -������������������������������������������������*�����������������������������������

���������"��/���6�����������������������*�����������21"

��

��

��

��

���

���

��� ��� ��� �� �� �� � �� � �� �� �� �� ��� ��� ��� �� ��� ��

��!�����"���3�4

;������<�3<4

�� � �� �� �

�/1-���!'2���)-6,����*1�*����+�*/I-���)�7��.-�������/*/�/�,��*3�4/*�,����*./�/)*

��7�����-��.�4)��������7)1��=/7���/+��*�,5./.�)4��),5+��6)*���

#�0�#� ��%����!�����������!��������'

-���$������������������� �*�����N�����2=@3��������������������������"��-��

�������������*��������*������������*��������������������������6������ �?���F�,&����*����

Page 58: Characterization of Crazing Properties of Polycarbonate

:=

���0"333��,F���&���.�����������������033"3��,&�����������������A@"0=3�%��&������������������

����6������ �3"?���"

-�����������������������������*�4

709� �������������� ����������������������&

729� ��.������������������������������������������&

7?9� ������������������������������������������������������*�������������������

��������������&���*����������������������&������������&

7:9� ���������������������������������������"�� 6�������������������������(���*���

���� 5��������������������$�"���������������������������������������������

���������D1>&�1AE"

�����*��������$����&�����������������&�*������������&�����5����������������

*�������*��������������*������������������������������������"

Page 59: Characterization of Crazing Properties of Polycarbonate

:>

��������$� �5�,�5

���� -�����������(���� ���������%��

���(��������������� ��������*������������������������������������������������������"

-����*��������������������������������*�����������������������������������������������

�6������������"��-������������������������������������� �*��������������������� ��������

(��*�����-����(�N"��-����������������������������������������2"

$��� ������=�%��'�� � !���

-������������������������ ������������������ �����������&��������5����*��������

*���������������������������������������������������*�������"��������2=����*������������

�����������������"

��

��

��

� � �� �� �� ��

��!��3��4

��������� ��'�3<4

��

���

���

���

���

��������"��

��� �

��� �

��� �

� �� � ���

�/1-���!"2����.-,�.�)4�/7�1���*�,5./.��������6/,/�5�.�-35�-./*1�.�7����<�/7�1�.���������

3/44���*���/7�.

-���������������� ������������2=����������������������������� ����������������

���������"�������������� &������������������5���*�������������������������� �����������������

���(����������5������������������������"��N�����������5�����6����������������5��������&

Page 60: Characterization of Crazing Properties of Polycarbonate

:A

����������������.������� ����������������������������������������������������������� �*���

��������������� "

���������������������������5�������������5�������� ����������������������������

����������������"��-�����*����������������&�������5�������� �*����������������6�����������

��������������������������"��������2>������� ����������������?"1&�>&�����0:�!��"

��

��

��

������

����

����

�����

���

���

������

����

����

�����

���

���

������

����

����

������ � ������� �� ����

������

�/1-���!&2��44�+��)4�.���..�,�=�,�)*�+��8��3�*./�5�7��.-��7�*�

������������������������������������������������������������5�������� ��������������

�� ������������*���5��������"��/���&������5�����������������������������&�����������������

�����������������������*����>�����0:�!��"���������������&��� ���5�������� �����������

��������������������������������������������������������������������������������"���������

����&�������5������������*��������������0:�!��������������*����������"

$���� ��!���� ������������������%�����1

�5���6���������*����������������� �����������������������������������������

2A�����?:�!����������������������������20������:=;���������������� "��-�����5�������� &

Page 61: Characterization of Crazing Properties of Polycarbonate

:@

���*��������������������������������������&�������*���������������������������������2A"��-��

������������������������������2A�!���������������������?:�!��"

����

���

��

���

� �� ���

��!��"�1���%��1�3��4

��������� ��'�3<4

�� ���

�� ���

�/1-���!C2���44�+��)4�.���..�,�=�,�)*�����+��8/*1������)4��),5+��6)*�������.��*3��3

,�6)���)�5�+)*3/�/)*.

/���6������&�������5������������������*������������������"��8��������*�������

�����������20�!��&�*���������5��������������133���������������"���-���������������*�����

����������������������������������20&�2A&�����?:�!������������������ ������������"

,��������������*���������������������������*�����������2A&�����������5��������

*������������������������������"��-��������������� �����������������������������������������5���

���������� ��������&�������������������������������5�������� �*���������������������"��-��

���������������������������������5�������� ����2A�!���*���������� ��6�����������������133

��*���������������������������:?3��"��-���?:�!��������������������������������������

���������5�������� �����0":���*���������������������������3"A1��"

-���������������������5�����������������������������&�������*������������������

�������������������&�(��*����������������������������������������������������� ��I�

��5��������D?E"������������*����������������?A�&�2A�!�������13;��&����������������*��

Page 62: Characterization of Crazing Properties of Polycarbonate

13

�����������1:�&�2A�!��&�����13;��"��������2@��������������������������������20&�?A&����

1:�"

����

���

��

���

����� ���� ��� � �� ���

��!��"�1���%��1�3��4

��������� ��'�3<4

�� �

� �

� �

�/1-���!E2���44�+��)4���7�����-���)*�����+��8/*1������)4��),5+��6)*������,3�-*3���!C����

+�����,)�3

������2@����*�������������������������������5�������������� ������������������

��������������������"��-��������� �����������&����������������*�������������������������

�����&�������������������������������������5�������� �*������������"���������20�������&����

����������������������������5�������� �*���������� ��6�����������������133���*�����

���������������������:?3��"��-�������������������������������5�������� ����?A��*��������

� �����������������������������*�����������������������������������"�������� &�����1:�

����������������������������5�������� �*���������� ��������������������3"33A���*�����

���������������������3"333?1��"�������������������������&����������������������������

����������������������5�������� ����������� �������������"

$��#� ,� �� �%�����1

-���������������������������&����������������*���������"��������5�������������

�������*�������������������*��������������� ����������"��-����������������(�������"�����*��

������������������������������*����6�������� �������������������������������5������������

�����������������������������*���(�������������(�������"��-����*����������������������

Page 63: Characterization of Crazing Properties of Polycarbonate

10

�6������������*��������������*���*������������������������������������ ����������� �������

���������"���������������������������(�������������������������5���������&�������������������

������� ���������������������"

-���������������5�����������������*���������������������������������&����������������

��������������������������&��������������"����������������������������������������*��

������������������������������������������������������������������������������������*����

������������������������"�����������������������������������������������������������������������5���

������"��-��������������������������������������������������5�������������� ��������

������"��/���&����*����������� ��������������������������������������������������������������

��������������������������������������*����&��������������������������&�*����������

���������������������������������������������"��-������������������&�������*������ ���������5�&

*�������������������5���������������������"

-�����5���������������������������*������������5������������������ ��������������

�������������*������������������������������"���������������&�����������������������������

��������������������(���� ����������������� �������� ����������������������������5�

���������"

���� �����������������

/���������������������2&����������������������������� ��������������������� ���������

�������������5����*��"���������������&�������������������������������������?��������=���

��� ���������������������������?�*�����������5��"��-������������������������5�����

��������������������*����������������������������������������������������������������

�������������������5������������������������������������������������5���������"��-���������

������*�����-�����1�*�������������������������������������������������5��������������"

Page 64: Characterization of Crazing Properties of Polycarbonate

12

��6,��'2��J�,-�.�)4��,�.�/+�7)3-,-.�)4�,)*1/�-3/*�,��*3����*.=��.��.�7�,�.�)4��),5+��6)*���

?��� =���

�������� /���!�������7!��9 �������7!��9 /���!�������7!��9 �������7!��9

,����������� 203: =3": 2222 1="@

-������� 20?2 ?>": 22?1 :0"?

,������������������������������������������� ������*�����������������������������

�������"�������������&����� ����������6������������������*��������������������������������

*��������������������������������������������������������*�����������������������������

�������������������"��-�����1����*�����������������������������������������5�����������������

�������������������������5�����������������������������&�*�������6����������������"��-���

�����������������������������������������������������������������������6���"

���� ����������������

-��������������������������������������������������*�������!�!�������=��������(

��� ���������������������������?"������������������������������������������������������

�������������������������5������ ��������&����������������*�����5������������������5�

������ ����03;"��-�������������5������������������*����������������������������������������

���C������������������?3"

Page 65: Characterization of Crazing Properties of Polycarbonate

1?

����

���

��

���

���� ��� � �� ���

���� ���

������

�� ���

�� ���

�� ���

�/1-���#(2���,��/=��+��8��3�*./�5��.���4-*+�/)*�)4��/7��-*3���,)�3�4)��=��/)-.�.���..�,�=�,.

���!%����*3�C'G���

����������������2A����������������������� &�����*��������������������*����5�������"

������?3����*�������������������:3&�:1&�����13�!������������������ ���������"��-����������

������� ������������&����*�����������������5������������������ ��������"��-���������������

�������������������������������5�������&�������*��������������������������������������?3�*��

��������� �������������������������������������������������5����*����������������������5�

��*���*��������������"��-�����������������������������������������������������?0�*������

�������*�������������������������"

Page 66: Characterization of Crazing Properties of Polycarbonate

1:

���� �� ��

������� ��� ��

� � �����������

��� ������

����

���

��

���

�� �� �� �� ��

������ ����

��������� ���������

�/1-���#�2��44�+��)4�.���..�,�=�,�)*�+��8��1�)<���������!%��;�C'G����

-*��������������������������������������4�709�������5����*���������������

�6���������� �*�������������2:������A1;��������*����� ��������:C0&�����729��������������

���*������5������������� ���������6������������5�������������13�!��"

�����?��!>�(������������� 7:C09

*����#7�9����������5����*����������;F�����������������5�������������!��"

-����������������������*������������������������������������������������������

��5����������������������������&���������������������� ���� �1�!��������������������

��5��������� ��������������������"��$�������������������5�����������������������������&

������������������������������������������������*�*�������5����*������������"

/���&����� ���������C�������� �������������������2����*������������5����������

���������������������� ���������������������&�����������������������������������5�������

*�������������������������

�� ����

��

��� �

��

�>�!

� 7:C29

Page 67: Characterization of Crazing Properties of Polycarbonate

11

������������ ���������:C0�����:C2����*���������� �������������������&�����������

����������������������*�������������(���5�������� ������������������� ����� ������������

������� ������������������������������������������6������ ��������������"

-��������������������������������������������������������2"��N�����������������

���� ��������6����&���������������������������������������������������� �������"��8�������

���������� ���������������������������13�!����������� ����*�������*��������6���������5�

��*������&�������������������������&���������������5�������� �����������������������

������������(�7������?29"��/������������������� ���*���5���������6������������������������

���� ������������������� ������������������������������ �����������5���������������������

����������������5���"��-��������������������������������������� �������������������������5�

��*����������������������5��������������������������������������������������� ����������5�"

/���������������������5���������&�������5���������������������������������� ���������

�����&������������������������������������������������5�������� "

�������� ���������

���

���

���

���

���

��

��

���

���

� �� � �� � ��

��!��3��4

<������

�/1-���#!2���5�/+�,�������*��+��8��1�)<���+-�=��4)��.�7�,��������>���/�*+�3�3�,�5�3

*�+0/*1D

Page 68: Characterization of Crazing Properties of Polycarbonate

1=

-��������C����������������������������6��������� �����������������=1�!���*����������

������������������3"2��������������*������*����������*����:=�����:A�!���������*����������

??"��-��������������������������������*�������������������*������������*�*��������� ��

���(����*����������������������������������������������� ��������13�!��������� ����������

������������:1�!������������"

-

-

�-

#-

$-

&-

.-

0-

- -�� -�$ -�. -�6 ��

5������3!!7!!4

5��� �3+*�4

����� ������

���� ������

�/1-���##2������..B.���/*�+-�=��)4��.B��+�/=�3��),5+��6)*������.��3����(D�"&�7/*��;�!%��;��*3

C'G���

��������������*������&���������������������������������������������������������5�

����������"��-��������������������5����*���*�������������������������������*�����������?3

��������������������������������������������������?:�*��������������*���������������

���������"

Page 69: Characterization of Crazing Properties of Polycarbonate

1>

���� �� ��

������� ��� �� � ������

�������

��� �����

�����

����

���

��

�� �� �� �� ��

������ ����

������������������������

�/1-���#%2��44�+��)4�.���..�,�=�,�)*�+��8��/*/�/��/)*��/7���!%��;�C'G����

/���6������&���������������5����������������������*�����������������������������2:�

����A1;��������������� ��������:C?"��8����6����������������������������������� ������(���

�����������*�����������5������������������*����������������������������������5����*�������

*�����*�����������?0"

�������?���;&#!����������� 7�:C?9

*�������7�9�������������������������5����*������������������&����������������5�������������!��"

������������������������?:��������������������������5������������������������������������

�������������� ��������:C?"��-���������������������������������������������������������������&

��5��������������������������� ����������������"���������������&������������������0;��������

��5�������� �*�������������������������������������?3��������������������������������5���

���������������?1�*��������������*�������������������������"

Page 70: Characterization of Crazing Properties of Polycarbonate

1A

���� �� ��

������� ��� ��

� � ���������

��� ������

����

���

��

�� �� �� �� ��

������ ����

�������������������

�/1-���#'2��44�+��)4�.���..�,�=�,�)*��/7���)��G���,��/=��+��8��3�*./�5��!%��;�C'G����

������?:������� ������������������������������������������������������5����������

��������������������5������������"�����������*�������������������0;�����������5�������� ���������

�6���������� �*������5�������������2:������A1;���*����������������������������

�������?��>�(������ ����� 7:C:9

*�������7�9����������������0;�����������5�������� ���������������������5�������������!��"

8���������&�������������������6������������� ������(�������������� � ��������:C:

��������������� ���������������������6����"��-�����������0;���5�������� �*����������������

����������������� ����������������������������������� ���5���������������������������������5�

����������������*�������������������5����*�������*�����*�"

!������������ &� ��������:C0���������������������������5����*��������*����� �������

:C:���������������������5����*�������"�� ��������:C1�������������������*���6���������������

�������������������������������������������������5����*��������������������������������

���������������������*����:3�����13�!��"

���;����?������9��F�������:�@�� 7:C19

Page 71: Characterization of Crazing Properties of Polycarbonate

1@

*�����7�&��9������������������5�������� ����;&�#7�9����������5����*�����������������������

������������*����� ��������:C0&������������������������������&��������7�9���������������������0;

����������5�������� ������������������������������*����� ��������:C:"��������?=����������

���*������������������������� ��������:C1"

-

&

-

&

�-

- & - & �-

��!��3��4

<������

$-�+*�

$&�+*�&-�+*�

�/1-���#"2�����8��1�)<������3/+�/)*�)4��I-��/)*�%B'�</����>���/7�*��,�3�������%(;�%';��*3

'(����

Page 72: Characterization of Crazing Properties of Polycarbonate

=3

��������&� �5��55��

��� .����������!����������������������������������/�������������

�����!/�������������� �����������������

-�������������������������������������������������������� ��������������������������

��5���������&���5����������&���������������������� ����������&����������������&�������������&

������������ ������� ��������"������&�������������������������������������������������������

��������������C����������� ���������������������"��-������������������������������������

������5�����������"��)�6�&����������������������5����������������5����������������������������

��������������� ������������������������"�������� &�������������������������������������

���������������������������������� ����������"��-�����6�������������������������������

������������������������������������������������������������������������5���������&���5���

������&������������������������������������������������ ��������"

&��� ����������!�� �"�����1� ������������������!��������%���������� ����� >

�����(�1� �!�%�

������?>��������������:3��������������������������������������������������������

����������� ����������&����������������&�������������&������������� ������C����������� ��������"

-������������*���������������������������������������������������������� �����������������

�������5����������������������������������������������5���������"��-�����������������������

��������*�������!�!�������=��������(���� ���������������������������������?"

'D�D�D�� �44�+��)4�7)/.�-����*3�.���/*������)*�����5/�,3�.���..�)4��.B��+�/=�3

�),5+��6)*���

/������������������� �������������������2&�����������������������5�������������

��� ���&�������������������������������������� �D=E"��N������������5�����������&����� ����

������������������������������ �������������������������������������������������������

����������������������������"

��������������������������������������� ����*����������������������������������

*����������������������������� ����������������������������������������"��#���6������������

Page 73: Characterization of Crazing Properties of Polycarbonate

=0

�������������� ����������������������������������������������"��N��������������������������

���� ���������&�������� �����������������������������������������������6&���������������

��������������� �����������D=E"��������?>����*������ �����������������"

-

-

�-

#-

$-

&-

.-

0-

6-

- �- $- .- 6- --

�%���(��2"!�1��'�3<4

?��%1�5��� �3+*�4

-���7!��

��7!��

��!����

-���!����

�/1-���#&2��44�+��)4�����*3�.���/*������)*�����5/�,3�.���..�)4��.B��+�/=�3��),5+��6)*���

-������ ���������������������������� ���������������������� ��������������������

��*������������?>���4

709����� ��������������������*�����������������������������&

729����� ��������������������*�����������������������&����

7?9��������������������*�������������6������ ������������������������������"

-����������������������*������������������������5�������������6����������"�����������

����������� �����00"?;������033;���������������� ���������������6������ �0�!��&�*����

����������������������������3"2����������2����

���������������� �������������������������?

!��"

Page 74: Characterization of Crazing Properties of Polycarbonate

=2

'D�D�D!� �44�+��)4�7)/.�-����*3�.���/*������)*������,�.�/+�7)3-,-.�)4��.B��+�/=�3

�),5+��6)*���

������?A����*������������������������������������������� �������������*������������

�����*������������"��

-

&--

---

&--

�---

�&--

#---

- �- $- .- 6- -- �-

�%���(��2"!�1��'�3<4

+�1"%" �3+*�4

-���7!��

��7!��

��!����

-���!����

�/1-���#C2��44�+��)4�����*3�.���/*������)*������,�.�/+�7)3-,-.�)4��.B��+�/=�3��),5+��6)*���

-�����������������������������*��������������������������������������������������

������������������4

709������������������������������*����������������������������&����

729�����������������������������������������������������3"2�����2��������������������"

-��������������������������������������������������������5�����&��������������� ����������

�������"�������������������������������&�����������5�����������*������6�������������������

������������������5������������������������������������������� "��-����*����������������

���������������"

Page 75: Characterization of Crazing Properties of Polycarbonate

=?

'D�D�D#� �44�+��)4�7)/.�-����*3�.���/*������)*�����4�/,-���.���..�)4��.B��+�/=�3

�),5+��6)*���

<���������������������������������������������������*���������������������������

�����������������������������"��-��� ��������������������������� ���������������*�����������

�������������������������������������������������������������������������������������

������������� �*������������������������ �����������������������������������*�"��������?@����*�

����������������������� �������������*������������������*������������"

-

-

�-

#-

$-

&-

.-

0-

- �- $- .- 6- --

�%���(��2"!�1��'�3<���4

9��%"���5��� �3+*�4

-���7!��

��7!��

��!����

-���!����

�/1-���#E2��44�+��)4�����*3�.���/*������)*�����4�/,-���.���..�)4��.B��+�/=�3��),5+��6)*���

-�����������������������������*��������������������������������������������������

������������������� �����������4

709������������������������������������*������������������00"?�����033;�����

����������&����

729������������������������������������*������������������3"2�����2��������������������"

Page 76: Characterization of Crazing Properties of Polycarbonate

=:

-��������������������*�������� ����������������������������������������������5��

���������������������������������*�����������������������5���"

'D�D�D%� �44�+��)4�7)/.�-����*3�.���/*������)*������,)*1��/)*�)4��.B��+�/=�3��),5+��6)*���

/�����������������&���������������������������� �������������������������� ����

������������������������ ������������������������������������"��-����������������������

���*������������������������������������ "��������:3����*������������������������������������

�����������(�������5������������������������������������������������������ ��������������"

-

#

$

- �- $- .- 6- -- �-

�%���(��2"!�1��'�3<���4

�%���������*���!�����

3!!7!

!4

��7!��

-���7!��

-���!����

��!����

�/1-���%(2��44�+��)4�����*3�.���/*������)*�����3-+�/,/�5�)4��.B��+�/=�3��),5+��6)*���

-*����������������������������*��������������������������������������������������

����������������������� �����������4

709����������������������������������������*������������������00"?�����033;�����

����������&����

7?9����������������������������������������*������������������3"2�����2���������

����������"

Page 77: Characterization of Crazing Properties of Polycarbonate

=1

-��������������������*�������� ��������������������������������������������������5��

���������������������������������*������������ �������5���"

&���� ������������%���(��������1�� ��'

-���������������������������������������������������*�������?��������(�����C���������

��� ����������������������#��������'����������������������?"��-�����������*����������

:0�*��������������������������5����������������������������������������������� ���

����������5������������7���������������03;9"��-������������������������������ �����������

���*�*������������������������������������������� ���5���"

��

��

��

��

���

���

���

�������� �������� �������� ������ ������ ������ ������

���������

��

�����������

��

����

���

����

���

���

���

��

� �� ��

� ��������

������

�/1-���%�2���44�+��)4���,��/=��+��8��3�*./�5�)*���./3-�,�7�+��*/+�,���)����/�.�)4�#�77���/+0

�)�7�K����.��),5+��6)*���

��������������������������������������������������������������������������������

�������� ������������� ���5�����������?��������(���� ����������������&�����������������

��������������������� "���������������&�������5������������������������� �������&������C��(�

������*������������������������� �����������.����������*�����������������"���������

�������&����������������������������������������������5��������� �������������������������

Page 78: Characterization of Crazing Properties of Polycarbonate

==

�����������"��/������ ���5������������������� �����������������������*���������

������� ��������������������(�&������*�������������� ���*���������"

-������������������������������� ����������������������������������=���

��� ������������������������������!�!����������������������������?"�����*����������*�

��������������������&�����������5�����������������������03;�������*�&������������&����������&

������������ ������������������ ���5�����������������6����"

&��#� ������������������ ��� �������>�����1���%'���=�����

-��������������������������:2��������������:A����������������5��������*� ����� ���

���*������������������������������������5������������������������5�������� ������������� ����

�����&����������������&�������������&������������� "��-�������������*���������������������������

���������������������5����������������������"

'D�D#D�� �44�+��)4�+��8/*1�.���..�)*�����5/�,3�.���..�)4����B+��8�3��),5+��6)*���

������:2����*�������������������������������������5������������������������5��������

������������ ����������������� ��������"��-�����������������*��������������������������������

����������������������������������������������5�����������������������"

Page 79: Characterization of Crazing Properties of Polycarbonate

=>

��

��

��

��

��

��

� � � � � �� ��

!��"�

������������� ��

�������� � � � � � � � �

� �� � �

� � �

���

��

��

��

� � � � ��

���

�����

�����

��

�������� � � � � � � � �

� �

� � �

� � �

�6�

�/1-���%!2��44�+��)4�+��8/*1�.���..��*3���,��/=��+��8��3�*./�5�)*�����5/�,3�.���..�)4

�),5+��6)*������.��3��������(D!�7/*����*3��6��!�7/*

���.���/*�����.

-���������������*���������� ������������������������������ ����������� �������5���������

������������5�������� �������������������"��/�������������������������� ����������������������

��������������&���������������������������������������*����4

709� ���� ��������������������������� �*����������������5�������� &����

729� ���� ��������������������*�����������������������������5���������"

-����������������������������*������������������� ����������������������5��

�������������������������������������"���������������������������������������������&����������������

������������5�������� ������*����0;��������3"2�����������"

Page 80: Characterization of Crazing Properties of Polycarbonate

=A

-�������������������������������������������������������������������������

�����������������������������6����������5���������"���������������&����� ���������������������

�������5�������������:3�!���������*�����������5�������������13�!��"

-���������������������������� �����������������������������������"���5��������������

����������*���������(��������� �����������������������������������������&�*��������� ����

������������������������� ������������������� ���������������� ��������������(�������"�����*�

��������������������������������������������������������������������������������*�"

'D�D#D!� �44�+��)4�+��8/*1�.���..�)*������,�.�/+�7)3-,-.�)4����B+��8�3��),5+��6)*���

������:?����*�������������������������������������5������������������������5��������

���������������������������������� ��������"��-�����������������*������������������������

������������������������������������������������������5�����������������������"

Page 81: Characterization of Crazing Properties of Polycarbonate

=@

��

��

��

��

��

� � � � ��

� �����

���������

�������� � � � � � � � �

� � � � � �

� �

����

����

����

����

����

����

����

����

����

� � � � � �� ��

���

��������

��

�������� � � � � � � � �

� � �

� �

� � �

�6�

�/1-���%#2��44�+��)4�+��8/*1�.���..��*3���,��/=��+��8��3�*./�5�)*������,�.�/+�7)3-,-.�)4

�),5+��6)*������.��3��������(D!�7/*����*3��6��!�7/*

���.���/*�����.

-�������������*�����������:?����*������������������������������������������� ����

���������������5������������������������5�������� "��8���������&���������������������������

��������������������������������������������� �����������������������������������������(

�����������*�����������5��������� ������������"

'D�D#D#� �44�+��)4�+��8/*1�.���..�)*�����4�/,-���.���..�)4����B+��8�3��),5+��6)*���

������::����*�������������������������������������5������������������������5��������

������������������������������� ��������"��-����������������*�����(���������������������

Page 82: Characterization of Crazing Properties of Polycarbonate

>3

��������������������������������������������?"�����������������������������������������

��5�����������������������&�������������������*�������������������������������������������

�����"

� � � � ��

���

������

�����

��

�������� � � � � � � � �

� �

� � � � �

���

� � � � ��

���

������

�����

��

� � � � � � � �

�6�

�/1-���%%2��44�+��)4�+��8/*1�.���..��*3���,��/=��+��8��3�*./�5�)*�����4�/,-���.���..�)4

�),5+��6)*������.��3��������(D!�7/*����*3��6��!�7/*

���.���/*�����.

������������������������������::������������������������������������ ���������

���������������5������������������������5�������� "��-*����������������������������*�����

���������������4

709���������������������������*����������������5���������&����

Page 83: Characterization of Crazing Properties of Polycarbonate

>0

729���������������������������������� �*���������������������������5���"

-�����������������������������������������������*��������������������������"��!��

�6�������������������������*���������������������*����������5����������������5�

�����������"

/�����������������&������������������ ��������������������������������� ���5���

������������������������"��-���������������������������*������������� "���������������������

���*�&��������������*��������������5�������� �����������������F����������*�"

'D�D#D%� �44�+��)4�+��8/*1�.���..�)*�����3-+�/,/�5�)4����B+��8�3��),5+��6)*���

������:1����*�������������������������������������5������������������������5��������

�������������������� ������� ��������"��-��������������������� �*�����(�������������������������

����������������� ������������(�������5���������������������"��-����������*��������������

�����;����������������������������������������������C������&��������������������(������������

�����C���������� ��������������������������6����� ������������������"��-���������������

�*�������������������������������������������������������������������������������5���������

�������������"

Page 84: Characterization of Crazing Properties of Polycarbonate

>2

� � � � ��

���

���������

������

�����

��

� �

� � �

� � �

���

� � � � ��

���

���������

������

�����

��

�������� � � � � � � � �� � �

� � �

� �

�6�

�/1-���%'2��44�+��)4�+��8/*1�.���..��*3���,��/=��+��8��3�*./�5�)*�����3-+�/,/�5�)4

�),5+��6)*������.��3��������(D!�7/*����*3��6��!�7/*

���.���/*�����.

-������������(����������������������� ��������������������������������� �7����C ����9

������������������������ "��/�����������������&���������������������6���������������������

� ���5���������������������6��������������������������"��-�������������*�����������:1����*

�����������6����������������������"��-*����������������������������*����4

709������������� ������� ������������������*��������������������������5���&����

729������������� ������� �����������5������:3�!�������������*������������������� ���

��� �����������5������:1���13�!��"

Page 85: Characterization of Crazing Properties of Polycarbonate

>?

-������������������������*������������������������������������������������ �����������

������*���������������*����*���������������������������� ����*���������������?���

��� �����������������7������:09"��/�������������������������?��������=��������(��������

���*����������?��������(������������*����������������������������������� &�������� �����

��������������������5�������� "��������������5�����������������������&�����������������������

��������������&�����������������������������������������������������������������������������(

��������������������� ����������������������������������� ������*�������������������"

/��������������������� ��������������������������������"��-���������������*��������

���������������� �*�����������������0;�����������5�������� ��������6������������� �������

��������������������������������������������������(�"��8��������������������������(����������������

*����������"��-�������(��������������������������� ������������������21���&�����6������

�����������������(������������������������������:1"

-���������������������������*���������������������������&�������������5�������������:3

!������������������������������������ ������� ������������������5�������������:1���13�!��"

-�����������������������������������&������������*������*���������������������������������

�����5��������������������������������������5��"

'D�D#D'� �44�+��)4�+��8/*1�.���..�)*�����7/+�).��-+�-���)4�+��8�.

������:=������������������������������� ��������5�����������:3�!���������������

���:1�!��"��������������*�����(������������������5�������� ����03;"��-����������������5�

���������:3�!���*������������2"1������������������������5�����������:1�!��"��������

���������������������������������������D?E"��-�����=����*�������������������������������� ����

������������������������"��-�����5�����������:3�!����������������*�����������������������

��5������������ �������21;�*���"

Page 86: Characterization of Crazing Properties of Polycarbonate

>:

����

7�9

����

7�9

�/1-���%"2���/+�)1�����)4��5�/+�,�+��8��)*�.�7�,�.�+��8�3��������%(������*3��6��%'����

Page 87: Characterization of Crazing Properties of Polycarbonate

>1

��6,��"2���/7�*./)*.�)4�+��8�.�4)�7�3����%(��*3�%'����

���8/*1�����..�� %(���� %'����

/���7���9 1">�C1 2"2�C1

,������7��9 3"00 3"31

N�����7��9 ="A�C: 1":�C:

/������#�����7,FN9 0=2 @?

8���������*� �������*�����������������*�&��������5�����������������������5��

���������������������������*���������������������������������"��/��������*����5���������&

����������*�����*����������������������������������������������������������������������5�

����������"����*����5���������������������������*����5��"��-����������������������������������

:>"

Page 88: Characterization of Crazing Properties of Polycarbonate

>=

��

��

7�9

��

��

7�9

��

��

7�9

�/1-���%&2���/+�).+)�/+�7)3�,�)4���.���/.�/+�,�3/.��/6-�/)*�)4�4,�<.�</���������+��8/*1�.���..

)4�%(�������,3�4)��!%���.�+)*��/*/*1�!G�+��8��3�*./�5;��6����+��8/*1�.���..�)4�%(�������,3

4)���((���.�+)*��/*/*1��(G�+��8��3�*./�5;��*3��+����+��8/*1�.���..�)4�%'�������,3�4)��!%���.

+)*��/*/*1��(G�+��8��3�*./�5D

������:>����*������������������������������� ��������&�*�����������������

�������������������������������*��*������������������������������*���������������5������:3

Page 89: Characterization of Crazing Properties of Polycarbonate

>>

!���������������������������������5������:1�!��"��-���������������������������������������

���*��*����������������������������������������5����������������:3�!��"��������:>7�9����*�����

�����������:3�!��������������������2:�����"��� ����������&���������������5�������� ����

�������2;&���������������������������������03;������������"��������:>7�9����*�����������

�����:3�!��������033���"��-��������������������������������������������������������������5�

����������&����������5���������������������������*��� �����&���(�������03;�����������5�

������ "

������:>7�9����*������������*���������������:1�!�����������2:���"��/����������������

��������&������������������������������������������������������������������������5��"��)�*����

����������������5�������� ���������������� �������5��&���������03;�����������"�����������

��5��������������&�������5����������������������*���������*�������������*��������:3�!��

������*����������"��-���������������������������*������� ��������������5������03;�*�����

���������:3�!��&�����������������������*�&��������5��������*���������������:1�!��"

������������������������������5������������:3�����:1�!������������������������

�������������������� �������������������*������������������5������������������*�������

������������������������������������������������������������������ ������� ��������"���������

*���&����*���5�������������������������������������������������� �����������������*�������� "

-�����5�������� ��������������������������������������������� ��������&�������������

������������������������������ �������5��"��-�����������������������5���*����������������

��������������5���������������������������������������?"��-���������������������

���������������������������5�������������������:A�*��������������*���������������

���������"

Page 90: Characterization of Crazing Properties of Polycarbonate

>A

� ��������# � �������

��� �������

����

����

����

����

���

����

����

����

����

�� �� �� �� ��

!��"�$% ������ ����

���������������

��

�/1-���%C2���44�+��)4�+��8/*1�.���..�)*��=���1��+��8��������!%��;�C'G����

�������������������������������������������������:A���������������������������

���������������������-�����=����*��������������������������������������������������������

��������������&����������*��������������������������������*����������������5���������"

-������������������������������������5��������������5�����������������������������

����������������������������������������

���?�B(D((E(!���@�(D%C& 71C09

*����/�����������������������������5������������������������5�������������!��"

&��$� ���������� �����������������>�����1���%'���=�����

-��������������������������:@��������������12����������������5��������*� ����� ���

���*���������������������������������������������5�������� ������������� ����������&��������

�������&�������������&������������� "��-����������������������������������������������������

����5������ ������������������ ���������*�����������?>��������������:3"��-������� ���

������������������������*������������������������� �������������������*���������������������

����������5�������� �����5���������"

Page 91: Characterization of Crazing Properties of Polycarbonate

>@

'D�D%D�� �44�+��)4�.���/*������)*�����5/�,3�.���..�)4����B+��8�3��),5+��6)*���

������:@����*�����������������������������������������������������������5��������

������������ ����������������� ��������"��-��������������������������������5��������������

��������������������������������������������������������������������5���������"

��

��

��

��

��

��

��

��

� � � � � �� ��

� �����

�����

�����

��

��� �����

� �����

����

��

��

��

��

��

� � � � �� ��

� �����

�����

���

��� �����

� �����

��6�

��

��

��

��

��

� � � � �� ��

� �����

�����

�����

�� � ���

��

��� �����

�+�

�/1-���%E2��44�+��)4�.���/*�������*3���,��/=��+��8��3�*./�5�)*�����5/�,3�.���..�)4

�),5+��6)*����+��8�3��������%(����;��6��%'����;��*3��+��'(����

Page 92: Characterization of Crazing Properties of Polycarbonate

A3

/���6�����������������?>�700"?;��9&����� ������������������������������������������

���������������������������5�������� �������5���������"��-����������������������������������

������������������������������ �����������*����������������5�������� "�����������������&����

��������������*�����������������0;�����������5�������� "

'D�D%D!� �44�+��)4�,)�3/*1������)*������,�.�/+�7)3-,-.�)4����B+��8�3��),5+��6)*���

������13����*�����������������������������������������������������������5��������

���������������������������������� ��������"��-��������������������������������5�����������

�����������������������������������������������������������������������5���������"

Page 93: Characterization of Crazing Properties of Polycarbonate

A0

���

����

����

����

����

����

� � � � �� ��

� �����

���������

��� ����

� ����

� �����

��� �����

����

���

����

����

����

����

���

� � � � �� ��

� �����

��������

��

��� ����

� ����

� �����

��� �����

��6�

���

����

����

����

����

���

� � � � �� ��

� �����

��������

��

��� ����

� ����

� �����

��� �����

�+�

�/1-���'(2��44�+��)4�.���/*�������*3���,��/=��+��8��3�*./�5�)*������,�.�/+�7)3-,-.�)4

�),5+��6)*����+��8�3��������%(����;��6��%'������*3��+��'(����

������13����*�������������������������������������5�������� �������������������������

����������������������������5������ ��������"��/���&����������������������������������*���

������������������������5�������� �*��������������������������������������������"

Page 94: Characterization of Crazing Properties of Polycarbonate

A2

'D�D%D#� �44�+��)4�.���/*������)*�����4�/,-���.���..�)4����B+��8�3��),5+��6)*���

������10����*�����������������������������������������������������������5��������

������������������������������� ��������"��-��������������������������������5��������������

��������������������������������������������������������������������5���������"

��

��

��

��

��

��

��

� � � � � �� ��

��� �

�������

�����

���

� �����

��� �����

���

��

��

��

��

��

��

��

� � � � � �� ��

��� �

� ����

��������

��� �����

� �����

�6�

��

��

��

��

��

��

��

� � � � � �� ��

��� �

�������

�����

��� ��� ���

��

� �����

�+�

�/1-���'�2��44�+��)4�.���/*�������*3���,��/=��+��8��3�*./�5�)*�����4�/,-���.���..�)4

�),5+��6)*����+��8�3��������%(����;��6��%'����;��*3��+��'(����

Page 95: Characterization of Crazing Properties of Polycarbonate

A?

-������������������������������������������������������5������������7:1�����13�!��9

����03;�����������5�������� �*������������������������72������9���������������������*�

������������������������*������������73"2������9"��/��������*������������5������������7�0;9&

����������������������������������������*���������������������������� ��������������"����������

��������������������������������������������5�����������������������������������������������

*����������������������������5������������������������� ����������������������������*���

������������������������5��"

'D�D%D%� �44�+��)4�.���/*������)*�����3-+�/,/�5�)4����B+��8�3��),5+��6)*���

������12����*�����������������������������������������������������������5��������

�������������������� ������� ��������"��-��������������������������������5��������������

��������������������������������������������������������������������5���������"��8���������&

���������������������������������� ������������(�������5����������������������*�����(��������

���������������������� "

Page 96: Characterization of Crazing Properties of Polycarbonate

A:

� � � � � �� ��

��� �

�������

��������

�����

��

��� �����

� �����

���

� � � � � �� ��

��� �

���� � ��

������

�����

��

��� �����

� �����

��6�

� � � � � �� ��

��� �

���� � ��

������

�����

��

��� �����

� �����

�+�

�/1-���'!2��44�+��)4�.���/*�������*3���,��/=��+��8��3�*./�5�)*�����3-+�/,/�5�)4��),5+��6)*���

+��8�3��������%(����;��6��%'����;��*3��+��'(����

-����������������������������12�����������������������������������������������

������������������� "������������������10&����������������������������������������������5���

��������7:1�����13�!��9�����03;�����������5�������� �*������������������������72������9

��������������������*���������� ������������*������������73"2������9"��/��������*���������

Page 97: Characterization of Crazing Properties of Polycarbonate

A1

��5������������7�0;9&������������������������ ���������*�������������������������������������&

����������������������������������������"

��� "������ �������%��������� ��������������"�������

'(���� ����)"*'+�������������������������

/����������� 6������������� ����*�������������������������������������������������

����������������������������������������������������5���������&�����������5�������� &����

���������"��/�����������������������8 �%����D1@E�*��������������� 5�������������������

��5�����������6"��-�����������������������������H0����������*�����������M0������������������

7-�����>9"������6�����&��������������������:3�!����������������H0�*�����:1�!������������

���M0"��-������������������������������������6�����*������������������������������������������

�����������������������������"

��6,��&2���)3�3�=�,-�.�4)�����7)3�,.

,�*�7C09 '����7M09

�5����������7!��9 :3 :1

#���������5�������� �7;9 0 03

������#����7�����9 3"2 2

-������������������������������8 �%����*���������������������������������������

������?��������*����� ��������1C2"

��?�+��@�+���@�+���@�+ ��@�+����@�+����@�+���� 71C29

*����<���������������������������������������������������������� &������I�����������������&

/��������������������������7C0&�M09&��������������������������5�������� �7C0&�M09&��������������

����������7C0&�M09&������������������������*�����������������������������������������*�������

�*�������������"

Page 98: Characterization of Crazing Properties of Polycarbonate

A=

&���� �����������������!�1�%������ �1"�%�'��%1� ���

-������������������������ ������5������ �������������������������*��� ����������"

-�����A����*��������������������������������������������������������������"��-�����������

������������������������������������������������������"

��6,��C2�������.����.-,�.�4)����./3-�,�5/�,3�.���..

3�4

�������

5���

3+*�4

3�4

�%���(�

�����

��� ��'�3<4

3�4

5�����

���

3!!7!��4

?

3+*�4

?�

3+*�4

?#

3+*�4

?��

3+*�4

5

3+*�4

�� � ��� ��� ��� ��� �� ����

�� � � ���� ���� ���� ���� ����

�� �� ��� ���� ��� ��� ��� ����

�� �� � ���� ���� ���� ��� ����

� � ��� ���� ��� ���� ���� ���

� � � ��� ���� ���� ���� ����

� �� ��� ��� ���� ���� ���� ���

� �� � ���� ���� ���� ���� ���

������������������-�����A&��������������������������������������������������������� ����

������*��������������� ���������������������*�������������������������*����� ���������?C0

����?C2"�� ����������������������������������������������������������������-�����@"�� ������

���������������������?����������������� �������������������������������������������������

������D1?E"��-����������������������������������������������������� ��������������������3"0�����

�����������������������D1?E"

Page 99: Characterization of Crazing Properties of Polycarbonate

A>

��6,��E2���/1/*�,�7)3�,�4)��5/�,3�.���..�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�����

��!���/,� ���������

���������

�����

������� ==": (D((((DC!(

7/9��5��������� C3"?13 3"00@ C3"0=0

7�9�#���������5�������� C3"2@1 3"0A: 3"202

79�������#��� 0"1A (D((( C3"231

/� 3"3?02 3"AA1 C3"?03

/ C3"2:: 3"2=A 3"203

� 3"310? 3"A02 C3"?1?

/� C3"0@0 3"?A0 3"0>?

#��L�3">@=

-������ ���������*�����-�����@����������� �������Q�3"0������������������������������

���"��-������&������������������������ ����������������5������ ���������*������� ��������

�������*������&�������*���

���?�""D%�@��D'C�� 71C?9

*������������� ��������������������5�������������!�������#�����������������������"

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*����������������������5��������������:3����:1�!��

����������������������������5�������� �����0����03;������������� ���������������&����

����������������������������������� ����������"��-��������������������������*�����������������

������������������3"2����2�������������������� �������������������������?�!��"�� ��������1C?

���������������������������������������������3"2����2�������*���������������� ������������ �?"0=

Page 100: Characterization of Crazing Properties of Polycarbonate

AA

!����������������������������*������������������������������"��-������&� ��������1C?����������

��������������������������������������������"

-�����������������������������������������*����������� ����������1?"��-�����������

���������������������������������������������������������������������������������������������

��������������������2"="2"

���

���

���

��

���

���

���

��

� �

!���

���

"�����

���

#�����$

� �� � ��

9�����

2�%������������9����� �

���?��%1�5��� �3+*�4

�/1-���'#2������)�3/�1��7�.�)</*1���,��/=��4�+�)��/7�)���*+��4)������5/�,3�.���..�7)3�,

-�������������������*����������� �����������������������������������������������

������� ���������������������������������������������"������������������������������������������

�����������������������������������&���������������������*������������� ������ ����������"

&����� �����������������!�1�%������ �1"�%��%� ����!�1"%"

-�����6������������������ ������5������ �������������������������*����������

�������"��-�����03����*��������������������������������������������������������������"��-�������

����������������������������������������������������������"

Page 101: Characterization of Crazing Properties of Polycarbonate

A@

��6,���(2������.����.-,�.�4)����./3-�,��,�.�/+�7)3-,-.

3�4

�������

5���

3+*�4

3�4�� �%���(�

�����

��� ��'�3<4

3�4

5�����

���

3!���4

?

3+*�4

?�

3+*�4

?#

3+*�4

?��

3+*�4

5

3+*�4

�� � ��� ���� ���� ���� ���� ����

�� � � ���� ���� �� �� ��

�� �� ��� ���� ���� ��� ��� ���

�� �� � ���� ���� ��� ��� ���

� � ��� ��� ��� ��� ���� ���

� � � ���� ��� ��� ��� ����

� �� ��� ��� ��� ��� �� ����

� �� � ���� ��� ��� ���� ���

������������������-�����03&��������������������������������������������������������

����������������*��������������������� �������� ����������������������������������������*����

-�����00"��-��� ���������������������������������������������������������������������������

���������������������"

Page 102: Characterization of Crazing Properties of Polycarbonate

@3

��6,����2��/1/*�,�7)3�,�4)���,�.�/+�7)3-,-.�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�����

��!���/,� ���������

���������

�����

������� 22=3 (D(((( 00:

7/9��5��������� :>"3 3"03@ C?@"@

7�9�#���������5�������� C2">1 3"@22 3"=A:

79�������#��� A":2 3">=1 ?A"?

/� C:":2 3"A>1 C23">

/ >":2 3">@2 C23">

� C23"1 3":>3 C="2>

/� 2"33 3"@:? ?A"0

#��L�3"0A1

-������ ��������*�����-�����00�����������72C����9�Q�3"0����������������"��-������&����

����������������������������������������5������ ���������*������� �������������������������&

������*����� ��������1C:"

��?�!!"(���� 71C:9

*���� ���������������������������������5���������"

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*����������������������5��������������:3����:1�!��

��������������������������������3"2����2������������������� ���������������&�����������

�������������������������������������������"��)������������*����������� ������*�����������

��5�������� ��������������������"��������������������������������������� ���������������������

�������������������������������������&�����������������*����������*���������������"

Page 103: Characterization of Crazing Properties of Polycarbonate

@0

&���#� �����������������!�1�%������ �1"�%����%"��� ���

-������������*������������������������ ��������������������������5���������&��������

��5�������� &��������������������������������������������� ��������"��-��������*�����*�

���������������������������������������������������5������ ��������"��/�����������������&

��5��������6������������������������������������������������������������������"��-�������

������������ ��������������������������������"��-�����02����*�����������������������������

��������������������������������"��-�������������������������������������������������������

����������"

��6,���!2������.����.-,�.�4)����./3-�,�4�/,-���.���..

3�4

�������

5���

3+*�4

3�4�� �%���(�

�����

��� ��'�3<4

3�4

5�����

���

3!���4

?

3+*�4

?�

3+*�4

?#

3+*�4

?��

3+*�4

5

3+*�4

�� � ��� ��� ���� ��� ���� ����

�� � � ���� ��� ��� ��� �����

�� �� ��� ��� ���� ���� ���� ����

�� �� � ���� ��� ��� �� ����

� � ��� ��� ���� ��� �� ��

� � � � ��� �� ��� ����

� �� ��� �� �� ��� �� ����

� �� � ��� �� ��� ��� ���

������������������-�����02&��������������������������������������������������������

�������������*��������������������� �������������������������������������*�����-�����0?"��-��

����������������������������������������������������������������������������������������

�����"

Page 104: Characterization of Crazing Properties of Polycarbonate

@2

��6,���#2��/1/*�,�7)3�,�4)��4�/,-���.���..�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�����

��!���/,� ���������

���������

�����

������� 12"A (D(((( 2"A>

7/9��5����������7!��9 ?"0@ (D(((! 3">>1

7�9�#���������5�������� �7;9 C3"13? 3":=3 3"32:3

79�������#����7�����9 C3"??1 3"=22 C3"@13

/� C3"21@ 3">32 C3"?01

/ C0"1> (D(#(C C3"=>0

� C3"203 3">1= 3":@1

/� C3"@?1 3"0>@ C3"2@>

#��L�3"==:

-������ ���������*�����-�����0?������������72C����9�Q�3"0����������������&�������5���

�����&�����������������������*����������5���������������������������"��-������&��������������

�������������������������������5������ ���������*������� ������������������������&�������*�

���?�'!DC�@�#D�E����F�D'&����� 71C19

*������������������������������������5�������������!��&���������������������������������5���

�����&��������#������������������������������������*����������������5�����������������������

���������"

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*���������������������������6�������*�����������

��5�������� �����������������������������"��-�� ���������*������������������������*���

��5��������������������������&�������������5�������������:3�!���������������������������

Page 105: Characterization of Crazing Properties of Polycarbonate

@?

������������ ���*�����������5�������������:1�!��"��/�����������������������������1"0�����

���������������� ������������(�����������*��������������������5��������������:3����:1�!��&

������������������������������������������������������������"��/��������*����5���������&���

����������������������������������������������&�*��������������������5���������&��������������

���������������������������������������"��-������&����������������6��������*������5���������

�������������"�� ��������1C1����������������������������������������������������������������

������"

-��������������������������������������-�����0?�������*����������� ����������1:"

-���������������������������������������������������������������������������������������"

���

���

���

���

���

"�����

� �� ���

#�����$

� �

!���

�� �

9�����

2�%������������9����� ����

9��%"���5��� �3+*�4

�/1-���'%2������)�3/�1��7�.�)</*1���,��/=��4�+�)��/7�)���*+��4)������4�/,-���.���..�7)3�,

-�������������������*����������� ������������5����������������������������*���

��5������������������������������������������������������������������������������������

�������������������������"�������������������������������������������������������������&

�������������������������*�����������11"

Page 106: Characterization of Crazing Properties of Polycarbonate

@:

��� ���� �� �� � ��

��� ���� �� �� � ���

��

��

��

��

��

��

��

��

�� �� �� �� �� ��

� ������ ������ ����

������������

�����

��

�7�9

��� ��� � ��� � ���

��� ��� � � � ���

��

��

��

��

��

��

��

��

�� �� �� �� �� ��

� ������ ������ ����

������������

�����

��

�7�9

��� ��� � ��� � ���

��� ��� � � � ���

��

��

��

��

��

��

��

��

� � � � � �� �� ��

�� �������� ����� ������� ��

������������

�����

��

7�9

�/1-���''2���/,-���.���..�/*����+�/)*�3/�1��7.�4)��4�+�)�.�������;��6����;��*3��+����

-��������������������������������11������������������������������������������������

��������������������*������5����������������5�������� ������*������5�������� ����������

Page 107: Characterization of Crazing Properties of Polycarbonate

@1

���"��-������������������������������11���������������������������������*������5�������������

���������"��-��������������������� ����� ��������������������������������������� ��������1C1"

&���$� �����������������!�1�%������ �1"�%�1"���%��'

-�����6�������������� �������������������������������� ����������������������������

������������������������������(��������������������������������������������������������������13

��"��-�����0:����*��������������������������������������������������������������"��-�����������

������������������������������������������������������"

��6,���%2������.����.-,�.�4)����./3-�,�3-+�/,/�5

3�4

�������

5���

3+*�4

3�4

�%���(�

�����

��� ��'

3<4

3�4

5�����

���

3!���4

?

�������

?�

�������

?#

�������

?��

�������

5

�������

�� � ��� ���� ��� ���� ��� ����

�� � � ���� ���� ���� ���� ���

�� �� ��� ��� ��� ���� ���� ���

�� �� � ��� ��� ���� ���� ����

� � ��� ��� �� ���� ���� ���

� � � ��� ���� ���� ���� ����

� �� ��� ��� ���� ���� ��� ����

� �� � ���� ��� ���� ���� ����

������������������-�����0:&������������������������������������������������������������

�������� ���������*��������������������� �������������������������������������*�����-����

01"��-��� ����������������������������������������������������������������������������

������������������������"

Page 108: Characterization of Crazing Properties of Polycarbonate

@=

��6,���'2��/1/*�,�7)3�,�4)��3-+�/,/�5�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�77A77�

��!���/,� ���������

���������

�77A77�

������� 0"A> (D(((( 3"113

7/9��5��������� 3">3= (D(((( C3"3>1:

7�9�#���������5�������� C3"3A3 3"1:0@ 3"013

79�������#��� C3"?0= (D(!'# C3"3?1:

/� C3"3@A: 3":11 C3"31@2

/ C3"3=0= 3"=?A 3"32?=

� C3"30=> 3"A@A 3"2?=

/� C3"232 3"0?= C3"3>32

#��L�3">0:

-������ ���������*�����-�����01����������� �������Q�3"0����������������&�������5���

�����&������������������"��-������&���������������������������������������������������(��

������������5����������������������*������� ������������������������&�������*���

��A���?��DC&�@�(D&("����F�(D#�"�� 71C=9

*����,��������������������������������(������������������5����������������&�,�������������

����������13���&���������������������������������5���������&�����#���������������������������

���������"

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*��������������������������6��������*�����������

��5�������� ����*����0�����03;������������� "��-�� ���������*������������������������*���

��5���������������������� &�������������5�������������:3�!��������������������������� ���*�

������������������ ����������5�������������:1�!��"��/�����������������*��������������������

Page 109: Characterization of Crazing Properties of Polycarbonate

@>

������ ������*�������������������������� "��-����������� �*�������������������*�������������

���������"�� ��������1C=����������������������������������������������������������������

������"

-��������������������������������������-�����01�������*����������� ����������1="

-���������������������������������������������������������������������������������������"

���

���

���

���

���

���

���

��

���

"�����

� �

!���

�� �� ���

#�����$

� �

9�����

2�%������������9����� ����

�"���%��'�3!!7!

!4

�/1-���'"2������)�3/�1��7�.�)</*1���,��/=��4�+�)��/7�)���*+��4)������3-+�/,/�5�7)3�,

-�������������������*����������� ������������5������������������������������

���������������������������������� �����������������������������������"��-�������C*�

������������������������������������������������������������� ������� ����������������3"0?="

���������������������������������������������������������������������������������&��������������

������*������������� �������������� "

Page 110: Characterization of Crazing Properties of Polycarbonate

@A

��� "������ �������%��������� ��������������"�������

'(���� ����)"*'+�����������������������

��������������� ���������1C?��������1C=����*������������������������������5�

������ �����0����03;�������������������������������������������������������������������5��

��� ��������"��8���������������&�����������������������������������1"0����*��������������������

���������������������������*����������������������������5�������� �����3����0;"���������

�����&����8 ��������������������������������������*�����������������5�������������:3

!��&�������������5�������� �����3����0;&���������������������3"2����2�������*������

�������������������� �����������������5���"��-����*�������&��*�����������������������������8

������������*�����-�����0="

��6,���"2��)3�3�=�,-�.�4)�����7)3�,.

,�*�7C09 '����7M09

#���������5�������� �7;9 3 0

������#����7�����9 3"2 2

��������������������������8 �������������&����������������������������������������

��������*�������������������� ����������&����������������&�������������&������������� "

&�#�� ���������������!�1�%������ �1"�%�'��%1� ���

-������������������������ ������5������ ���������������������������������*�������

������*��� ����������"��-�����0>����*��������������������������������������������������������

���"��-������������������������������������������������������������������"

Page 111: Characterization of Crazing Properties of Polycarbonate

@@

��6,���&2������.����.-,�.�4)����./3-�,�5/�,3�.���..

3�4

�%���(�

�����

��� ��'

3<4

3�4

5������ ���

3!���4

?

3+*�4

?�

3+*�4

?#

3+*�4

?��

3+*�4

5

3+*�4

� ��� �� ��� ��� ��� ����

� � ���� ��� ���� ���� ���

� ��� ��� ��� ��� �� ����

� � ���� ���� ���� ���� ���

������������������-�����0>&������������������������������������������������������������

����������������5������ ���������*��������������������� ���������������������������������

���*�����-�����0A"��-��� �������������������������������������������������������������������

������������������������"

��6,���C2��/1/*�,�7)3�,�4)��5/�,3�.���..�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�����

��!���/,� ���������

���������

�����

������� =>"3 (D(((( 3":3@

7/9�#���������5�������� 3"3@0> 3":>@1 3"32=A

7�9�������#��� 0":: (D(((( 3"02?

/� 3"0:2 3"2A1 C3"33A3

Page 112: Characterization of Crazing Properties of Polycarbonate

033

-������ ���������*�����-�����0A����������� �������Q�3"0������������������������������

���"��-������&���������������������������� ����������������5������ ���������*�������

���������������*������&�������*���

���?�"&D(�@��D%%�� 71C>9

*������������� ��������������!�������#�������������������������������������"

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*�����������������������������5�������� �����3����0;

��������������������� ������������ ����������"��-�� ���������*������������������������*���

�������������� ����������&������������������������2������������������������������� ������� ����

��������������������������3"2������"�� ��������1C>������������������������������������

��������������������������� �������"

-��������������������������������������-�����0A�������*����������� ����������1>"

-���������������������������������������������������������������������������������������"

���

���

���

��

���

���

���

��� !��� �� ��� #�����$

9�����

2�%������������9����� �

���?��%1�5��� �3+*�4

�/1-���'&2������)�3/�1��7�.�)</*1���,��/=��4�+�)��/7�)���*+��4)������5/�,3�.���..�7)3�,

Page 113: Characterization of Crazing Properties of Polycarbonate

030

-�������������������*����������� ���������������������������������3"2����2������

����������������������������������� ���������������������������������������5�������� ����

3����0;"�����������������������������������������������������������������������������&��������������

�����*������������� ������ ����������"

&�#��� ���������������!�1�%������ �1"�%��%� ����!�1"%"

-�����6������� ������5������ ���������������������������������*��������������*��

���������������"��-�����0@����*������������������������������������������������������������"

-������������������������������������������������������������������"

��6,���E2������.����.-,�.�4)����./3-�,��,�.�/+�7)3-,-.

3�4

�%���(�

�����

��� ��'

3<4

3�4

5������ ���

3!���4

?

3+*�4

?�

3+*�4

?#

3+*�4

?��

3+*�4

5

3+*�4

� ��� ���� ��� ���� ��� ���

� � ���� ���� ��� �� ���

� ��� ���� ���� ���� ���� ����

� � ���� ���� �� �� ��

������������������-�����0@&������������������������������������������������������������

���������������������5������ ���������*��������������������� ������������������������������

������*�����-�����23"��-��� ���������������������������������������������������������������

���������������������������������"

Page 114: Characterization of Crazing Properties of Polycarbonate

032

��6,��!(2��/1/*�,�7)3�,�4)���,�.�/+�7)3-,-.�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�����

��!���/,� ���������

���������

�����

������� 22>? (D(((( 0?2

7/9�#���������5�������� C=0"= 3"0@=@ 3"3@1

7�9�������#��� 01"@ 3">21: 1A

/� >"1A 3"A==> :=

��������������������������8 ������&�������� ��������*�����-�����23���������� ������

Q�3"0����������������"��-������&���������������������������������������������5��

��� ���������*������� �������������������������&�������*���

��?�!!&#���� 71CA9

*���� �����������������������"

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*�����������������������������5�������� �����3����0;

�������������������������������3"2����2��������������������������������������������������������

�������������� ��������"��������������������������������������� ����������������������������

������������������������������&�����������������������������������*����������*���������

�����"

&�#�#� ���������������!�1�%������ �1"�%����%"��� ���

-����������������*������*����������������������*�������������"�/��������������&

��5��������6������������� ���������������������������������������������������� �������������

������������������������������"��-�����20����*���������������������������������������������������

��������"��-������������������������������������������������������������������"

Page 115: Characterization of Crazing Properties of Polycarbonate

03?

��6,��!�2������.����.-,�.�4)����./3-�,�4�/,-���.���..

3�4

�%���(�

�����

��� ��'

3<4

3�4

5������ ���

3!���4

?

3+*�4

?�

3+*�4

?#

3+*�4

?��

3+*�4

5

3+*�4

� ��� ��� ��� ��� ��� ���

� � �� ��� ��� ��� ����

� ��� ��� ���� ��� ���� ����

� � ���� ��� ��� ��� ����

������������������-�����20&������������������������������������������������������������

������������������5������ ���������*��������������������� ���������������������������������

���*�����-�����22"��-��� �������������������������������������������������������������������

��������������������������"

��6,��!!2��/1/*�,�7)3�,�4)��4�/,-���.���..�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�����

��!���/,� ���������

���������

�����

������� 1?"0 (D(((( ?"0=

7/9�#���������5�������� C?"2: (D(�#' C0":3

7�9�������#��� 0"0: 3"2@A> C3"A3:

/� C3"=21 3"11@A C3"212

Page 116: Characterization of Crazing Properties of Polycarbonate

03:

-������ ���������*�����-�����22����������� �������Q�3"0������������������������

����������5�������� "��-������&����������������������������������������������5��

��� ���������*������� ����������������*������&�������*���

���?�'#D��F#D!%�� 71C@9

*������������������������������!����������������������������������������������5�������� "

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*�����������������������������5�������� �����3����0;

�������5�������������:3�!����������������������������������������� "��-�� ���������*�����

����������������������������3"2����2��������������������������������������������������������

������������ ��������"�� ��������1C@�������������������������������������������������������

�������� �������"

-��������������������������������������-�����22�������*����������� ����������1A"

-���������������������������������������������������������������������������������������"

���

���

���

���

��� #�����$ ��� !��� ��

9�����

2�%������������9����� ����

9��%"���5��� �3+*�4

�/1-���'C2������)�3/�1��7�.�)</*1���,��/=��4�+�)��/7�)���*+��4)������4�/,-���.���..�7)3�,

Page 117: Characterization of Crazing Properties of Polycarbonate

031

-�������������������*����������� �����������������������������5�������� �����3���

0;���������������������������������������������������������������������������������3"2���

2������"�����������������������������������������������������������������������������&��������������

�����*������������� ������������������"

&�#�$� ���������������!�1�%������ �1"�%�1"���%��'

-�����6������� ������5������ ���������������������������������*��������������*��

�������� "��-��������������������� �*������������������������������������������(���������������

����������� ���������������������������������������13���"��-�����2?����*��������������������

���������������������������������������"��-�����������������������������������������

������������������������"

��6,��!#2������.����.-,�.�4)����./3-�,�3-+�/,/�5

3�4

�%���(�

�����

��� ��'

3<4

3�4

5�����

���

3!���4

?

3!!7!!4

?�

3!!7!!4

?#

3!!7!!4

?��

3!!7!!4

5

3!!7!!4

� ��� �� ���� ���� ��� ���

� � ��� ��� ���� ���� ����

� ��� ���� ��� ���� ��� ����

� � ���� ���� ���� ���� ����

�������������������-�����2?&������������������������������������������������������������

�������� ������5������ ���������*��������������������� ���������������������������������

���*�����-�����2:"��-��� �������������������������������������������������������������������

�������� �������������������������"

Page 118: Characterization of Crazing Properties of Polycarbonate

03=

��6,��!%2��/1/*�,�7)3�,�4)��3-+�/,/�5�</����,,�4�+�)�.�/*+,-3�3�/*���1��../)*

����� ���������

���������

�77A77�

��!���/,� ���������

���������

�77A77�

������� 0"@2 (D(((( 3":=

7/9�#���������5�������� C3">= (D((�( C3"3:3

7�9�������#��� C3"0= 3"?3>? C3"22

/� C3"2A 3"03=> C3"0=

-������ ���������*�����-�����22����������� �������Q�3"0������������������������

����������5�������� "��-������&������������������������������������ ���������*�������

���������������*������&�������*���

��A���?��DE!�F�(D&"��� 71C039

*����,��������������������������������(����������������������������&�,������������������������13

��&��������������������������������������������5�������� "

-��������������������*����*������������������������������*�������������1"0"��-��

�������� ������������������������������*�����������������������������5�������� �����3����0;

�������5�������������:3�!������������������������ ������������� "��-�� ���������*�����

����������������������������3"2����2����������������������������������������������������������

������ ��������"�� ��������1C03�������������������������������������������������������

�������� �������"

-��������������������������������������-�����2:�������*����������� ����������1@"

-���������������������������������������������������������������������������������������"

Page 119: Characterization of Crazing Properties of Polycarbonate

03>

���

���

���

���

���

���

���

��

��� #�����$ �� ��� !���

9�����

2�%������������9����� ����

�"���%��'�*���!�����3!

!7!

!4

�/1-���'E2������)�3/�1��7�.�)</*1���,��/=��4�+�)��/7�)���*+��4)������3-+�/,/�5�7)3�,

-�������������������*����������� �����������������������������5�������� �����3���

0;�������������������������������������������� ���������������������������������3"2����2

�����"�����������������������������������������������������������������������������&��������������

�����*������������� ������������������"

��� ����� �������"*'�������

/��*������ ���*������������������&����������������������������� ����������������

������������C�������������������"���������������������&����������� ���������������������������

�����*���������8 ������������*����������������"������&�����������������8 �������*������

����������*���� �������������������������������������&���������������������������������5���������

�������������&������������� ��������������������5�����������������������"��)�6�&������*�������

�8 �������*�����������������*���� �������������������������������������&������������������

��������������5�������� &������������� ��������������������5�������� "��-�����������������*���

�����������������������������������������*���������������������������������������������8

�����"

Page 120: Characterization of Crazing Properties of Polycarbonate

03A

&�$�� ������!��������������������������!�1�%

-���������������8 �������*�������������������������������������������������

��� ���������*��������������5����������������0����03;&���5����������������:3����:1�!��&

�������������������3"2����2������"��-��������������������������*����������������������������

������ �������� ��������������������*����� ��������1C?"��-������ ��������������������������

�����������*������������"��������=3����*������ �������������������������������������&�*�������

�����������������������������������������������������������������������������������������������

�����������������"��-�����������������������������������������������������������������*������

�������*�������������������������������������������������������������"

��

��

��

��

��

��

� ��� � ��� � ���

5������ ����3!����4

?��%1�5��� �3+*�4

���%�&��'�

����(��%

�/1-���"(2��)*4/�7��/)*�)4�#B4�+�)��5/�,3�.���..�7)3�,

/���6������&�������������������*������������������������������������ �*����������������

���������"��-��� ��������������3":&�3"A&�����0"=�������������*����������������������������*���

������������������������*������������������������������������������������0�!��"��-����

����������*����������������������� ������������������� ����������&�*�������������������������

�������������"

Page 121: Characterization of Crazing Properties of Polycarbonate

03@

�������������������*��������������������������� ��������������������������������� ����

�����������5������ ��������&����� ���������C�������������������� ���������������������

���������*������*������������"��-��� ����������*���������������������2��������������

��������������������������������������������������������� ���������*���

�� ����

��

��� �

��

�>�!

� 71C009

*���� �� �����������������&���� ��������������&��������������������������&��'������������������

���� &�#��������������������&�-��������������������������&���������������������������"���������

������������ ��������1C00��������� ��������������������� ���������������������� ��������

�������

��

���

��

��

��

��

���

�!,*

� 71C029

*������������� ����������&�#��������������������&�-�����������������&��������������������������

�����������*���� �������&��'����������������������� ������������*���� �������&� �� �������������

���������������*���� �������&�������� ��������������"��/��������� ��������1C02�����������������

���������*�����������=0"

Page 122: Characterization of Crazing Properties of Polycarbonate

003

5������ ���

?��%1�5���

)$���* )+(���'�

,����� )�%�'��� -��

�/1-���"�2��������)4��5�/*1�.���..B������I-��/)*

������������������������������ ��������������*�����������=3�����������������������

���� ���������C�������������*�����������=0&����� �����������������*����������*����� ���

�����C�����������������������8 ����������������������6����������������������������������

����"����������������������5���������������� ���������������������� ��������&����� ���������

*�������������������������������������������������������5���&�������5����*����������*��������

��������������������� �������"

)�6�&�����������������8 ���������������������������������*����������������"������

��5��������������������������������*������5������������������������*����������������������

����������������&�������*����� ��������1C1"��-�����21����*�����������������������������

���������������������������������������������������������5��������������������������"��-��

��������������7:3�!��&�3"2������9&�7:3�!��&�2����

��9&�7:1�!��&�3"2����

��9&�����7:1�!��&�2����

��9

���������������������������������������������"

Page 123: Characterization of Crazing Properties of Polycarbonate

000

��6,��!'2���)*4/�7��/)*�)4�#B4�+�)��4�/,-���.���..�7)3�,

�5����������7!��9 ������#����7�����9 ���������������

������7!��9

!�������������

������7!��9

:3 3"2 :A"3 :=">

:3 2 10"2 10"3

:0 0"= 10": 12"?

:2"1 3"A 12"A 11"0

::"1 3": 1="? =3"3

:1 3"2 1>"= 1@"2

:1 2 1:": 1:"0

-�����������������������*������������������������������������������������������

-�����21�*�������������������6������ �0"1�!��"��/���&��������������������������������������

������������C������������������������������ �������������������������������&����*������

�����������������������������������������*����*��������������� ����������������"��8���������&

���������������������������������������������������������������������"

-��� ���������������������� ���������������������������������� ����D1E&����������

���� �����������������*�������"��������������&������������������������������*���������������������

�������5�����������������������&�������� ������������������*���������6����������������

�����������������������������������������������������8 ������"

-��������� ���������������� �������*������*�������������"��-����������� ���������*��

�������������������������������5���������������������������&�������*����� ��������1C="�������

=2����*�������������������������������������������������� �������������������������������

������"��-�������������(��������������������������:3�������������&����*��� ����������������"

-���������������������������������������������������������*����������������������������=2&

������*�����������C�������������������"

Page 124: Characterization of Crazing Properties of Polycarbonate

002

����

����

��������

���

�����������

��� �� ��� ��� � ��� �� ��� ��� �

5������ ����3!����4

��������5��� �3+*�4

�� � ��� ��.��

��� � ��� ��.��

��� � ��� ��.��

�/1-���"!2��)*4/�7��/)*�)4�#B4�+�)��3-+�/,/�5�7)3�,�</���4��7�3�=�,-�.�)4�3-+�/,/�5

����7�����/*�77A77

/���6������&�����������������������*����������������������������"��-����������C��������

�����������������*����������*���������������&��������������������������������������

������� �������������������������������"��-���������������*�����������������������

�����������������������������������������(��������������5������ ��������"��/��*����������*�

���������6�����������������������������&�*������������6�������������������� �������������������������

����������������������������*���5�����������������"��-����*�����������������������������������

��������������������������������*�����������=2"��/���&���(�������������������������� �������

������&��������������������������������C�������������������*���������6�����������������������

���������� ������������"��-��������������������������(���������������5���������������������

�����*������������������������������������������������������6�������������������������������

�������������������������������"��8���������&���������������������������������� ������������

������������������������������"

Page 125: Characterization of Crazing Properties of Polycarbonate

00?

&�$��� ������!������������������������!�1�%

-����*���������8 �������*�������������������������������������������������

��� ���������*��������������5����������������3����0;��������������������3"2����2������"

-��������������������������*����������������������������������� �������� ����������������

���*����� ��������1C>"��-�������������*���������� ������������������������*���� ����������"

������=?����*������ �������������������������������������&�*���������������������������������

���������������������������������������������������������������������������������������"��-��

��������������������������������������������������������������*��������������*�������

�����������������������������������������������������"

��

��

��

��

��

� ��� � ��� � ���

5������ ����3!����4

?��%1�5��� �3+*�4

���%�&��'�

����(��%

�/1-���"#2��)*4/�7��/)*�)4�!B4�+�)��5/�,3�.���..�7)3�,

/���6������&�������������������*������������������������������������ �*����������������

���������"��-��� ���������������������������������*����������������������������*�������

�������������*�������������������������������������������������3"A�!��"��-��������������

�6�������������*�������������C�������8 � ������������������������������*��������� �������

����������������������������������������*�����������=?"�-���������������*���������������

Page 126: Characterization of Crazing Properties of Polycarbonate

00:

�������������������������������� ����������������5������ �������������������������&�*�����

����������������������������C�������������������&�*���������������������������������������"

�)�6�&����������� ���������*�C�������8 �����������������������*����������������"��-��

��� �������������������������������������������������5������ ���������*�������������5�

������ &�������*����� ��������1C@"��������=:����*�������������������������������������������

��5�������� &�*�������������������������������������������������������������������������������

�����������������������������������������"��-������������������������������������������������

����������������*��������������*�������������������������������������������������������

�����"

��

��

��� ��� �� �� ��� ��� ���

!�����/� ��0� #�����$ �1�

�������

��������

��

���%�&��'�

����(��%

�/1-���"%2��)*4/�7��/)*�)4�!B4�+�)��4�/,-���.���..�7)3�,

������=:����*������������������������������������������������������� ������������

��������������������5�������� ��������������������������5������ ��������"��-���������������

�����������������������������������������������������*����*�����������������&������������������

�����������������*���������������������������������������������*������������������������

�����������������������"��-��������������������������������������������������������������������

������������������*��������������5���������������*�����������������*���������������5���&����

Page 127: Characterization of Crazing Properties of Polycarbonate

001

�������� �����������������������������"������������������������������ ���������������������

�����������������������������������*���������������������������������������������5�������������

������������������"���������������&���������������������������"

������ &����������� ���������*�C�������������� �������*����������������"��-������ ������

�������������������������������� ��������������5������ ���������*�������������5�������� &

������*����� ��������1C03"��������=1����*�������������� ����������������������������5�������� &

*������������������������������������������������������������������������������������������

������������������������������"��-����������������������������������������������������������

������*��������������*�������������������������������������������������������������"

���� ��� ��� ��� ��� �� ���

�%���(����������� ��'�3<4

�"���%��'�*���!�����3!

!7!

!4

���%�&��%

����(��%

�/1-���"'2��)*4/�7��/)*�)4�!B4�+�)��3-+�/,/�5�7)3�,

������=1����*������������������������������������������������������� ������������

��������������������5�������� ���������������� ������5������ ��������"��-������������������

��������������������������������������������������*����*�����������������&���������������������

��������������*������������������ �����������������������������������*�����������������

�������������������������� "����������������������������������&�����������������������������������

���������������������������������������� ���������������������������*�"�����������������������

Page 128: Characterization of Crazing Properties of Polycarbonate

00=

��(���*������������������������������������������� ������������������������������5���������

��������� "��-����������������������������������*����������������������������������������������

�������(��������������5������ ���������������������� �������������������C�����������

��������������"

� � ���! ���"�������

������*����(��*������������������������������������� ��������������������D=3�C�=2E"

�����������������������������������������������������������������������������������D=?E"

�������������������&������������������������������������������������������������� ��� ���

��������������� ���������������������������������� ���������������������������5���"��-��

��������*�����������5������������������������5�������������������������6���������

���������������������"��-�����������5�����������������*�����������������������

�������� �7��9&�������������������� ����7-$/9&������������������������������

7$�9"

&�&�� �����������%� ����������%���!���'

���*���������������������C����������� ������������������������ ��������

�������������*�����5������������003���������:3�!��"���� ����������������������������� �������

������������������(������������������������������"��������==����*�������������������*����C

���������������������*����5����������"

Page 129: Characterization of Crazing Properties of Polycarbonate

00>

��

����

��

����

��

����

��

��� ��� �� ��� �� ��� ���

��!"����#�� $�%

�� �������������

��

������

&� �����'��

�/1-���""2�����.+�*�)4��.B��+�/=�3��*3�+��8�3����(���;�%(�������),5+��6)*���

������==������������� ����*��������������������������������������������������

�������������5���������C����������� ��������"��-������������������� �������������������

������&��������������������������������*��������������� ��������������������������*���������

������������������������������ �*�����������"��-����������-�����������5�������������C

����������������������*�����-�����2="

��6,��!"2���=���1��1,�..����*./�/)*���7�����-���4)���.B��+�/=�3��*3�+��8�3��),5+��6)*���

/������-��7�9 ������������������7�9

/�C������� 0:>"31 3"@:>

�5�� 0:>"03 3"A0=

-������������������*������������������������������������(�����������������������������

���*����������� �����������������������*����������������������5�����"��-����������������

Page 130: Characterization of Crazing Properties of Polycarbonate

00A

�������������������������������5�����������:3�!��&�21�&�����A1;������������������ �����

�����������*��������������������������������������������������"

&�&��� ����!����(�!���������%' �

��������������������������������������-$/��������������*������C��������������5��

��� ���������*����������������� ����������������������5����������D=E"��-������������

������������������������������������������������������������������������������������������

����������� ���������������������������������*�����������?"��-�������������5������������

*����������������������� ����(���������������033�����������������"��-�������������������

����������&�-$/����� ����*���������������*��������������������������*��������������

*�����5������������003�����"��-����������������*�����������=>"

-

�-

$-

.-

6-

--

�-

- �-- $-- .-- 6-- ---

��!�����"���3�4

;������<�3<4

&� �����'��

������

�/1-���"&2��� ����.-,�.�)4�+��8�3��*3��.B��+�/=�3��),5+��6)*���

������=>������������� ����*������������������������������5������ ���������������������

��������������������������������������������C��������������"��-������������������������������

�����������*���������������*����C�������������*����5������������������*�����-�����2>"

Page 131: Characterization of Crazing Properties of Polycarbonate

00@

��6,��!&2��� �����*./�/)*���.-,�.�4)���.B��+�/=�3��*3�+��8�3��),5+��6)*���

��������-���������-��������

7�9

������-���������-��������

7�9

/�C������� 1?> 1AA

/�C������� 1?1 1>>

�5�� 1?1 1A2

�5�� 1?1 1@0

-������������������������� ����*�����������������������������5���������C���������������

�������������������������&�*�������6����������������"���������������������������������

����������������������������� ���������������������������������� �-$/"

&�&�#� ��%����!�����������!��������'

$���������5���6�������������������������������������������������������������� ���"

���������������������������������������������������������������������5�������&������

��������*��������*�������������������������������������������"��-��������������������

������������������C����������� ���������������� �����������5������003������������*����

������=A������������������������7������5��������9��������������������������"

Page 132: Characterization of Crazing Properties of Polycarbonate

023

��

��

��

��

��

��

��

���

� �� �� �� � � �� ��

���������@�%"!��3!,4

�%���(�� � ��� �

&� �����'��

������

�/1-���"C2� ���+��)7��)1��7�)4��.B��+�/=�3��*3�+��8�3��),5+��6)*���

������=A������������� ����*����������������������������� ������������������

���������������*����������C��������������5����������������*�������6�����������������������

$�"��-������������������� ���������������������������������&����������������������*�����

����������������*���������������������������������*�����������=A����������������������*���

���������������������"��-������������������*�����-�����2A"

��6,��!C2��-76����=���1���*3�<�/1����=���1��7),�+-,���<�/1��.�)4��.B��+�/=�3��*3

+��8�3��),5+��6)*���

!��7�F���9 !��7�F���9

/�C������� 0A&233 :2&:33

/�C������� 23&>33 ::&?33

�5�� 0>&?33 :2&?33

�5�� 0@&333 :?&233

Page 133: Characterization of Crazing Properties of Polycarbonate

020

-�����2A�������������� ����*���������������������������������������C�����������

��5����������������������&�*�������6����������������"��-���������������������*��������-$/

�������������������������������������5������������������������033�������:3�!��&�21�����

A1;�������������������� ���������������������� �������������������������������������"

-������&�����������������������������������������������������������������������������

���������������5����������������� �����������������������������������������������"

Page 134: Characterization of Crazing Properties of Polycarbonate

022

��������.� ����%" ���

��� ��������������(�� ������������������������������������������/�������#������

,������ I��)�6��$���������-�������� ����������*������������������ ���������

���������������.������������������&����C������������������ �����������������"���5��������

��������������*������� �������������������������������������������������� ������������� "

'��������� &���������������������������5���������� ���������������� ����������������5������

�������������������&������&����������&����������*�����&��������������6�����"���������� &

�� ��������*�(�������������������������������������������5����������������������������

��������������� ��������"

��������������(��������������5�����5��������������������������&�����*�����������*��

���������������������� �������������������&�������������&����C���.������&��������������������

����������5�������� "��-������*��������������������*���������������������������������

�����*���������������������������5����*���������������������������������"��/������������5�

���������������������0;&����*�������������������������������������5�������� �*���������*���

��(�����������������0:�!��������*������(������>�!��"��-��������������?"1�����>�!�����

���������� ���������"��/������������5����������������������0;&���������������������������������

��������"���������������&��� �������������������������*� ����������������������������������

�����������������*������������������5�������� "����������������������������������*

���������&����*��������������������6���������������������������������������������������������

�6��������������������� �����������������������5������������������������������(�����������

�������������5��"����������������&������ ������������������������� ������� ����������������

������������������������������������������������"��-������������������6�������������������

���������6���������������"

/����������*�����������*������������&�������6�������������������������������������5���

���������������������������������������� ���������*�������������������5����*�����������

�����������������������"��-������������������2:������A1;������*��������������5����*��

��������������6���������� ������������������������3":;F�����:3�!������2:;F�����13�!��"

-������������������������*����������*����� ���������C���������������������������������

Page 135: Characterization of Crazing Properties of Polycarbonate

02?

���������������� ������������������������������&����������������������������������5����*��

������ ��������������������� �����������������"

��������������������*���������������������5�����������������������������0;�����������5�

������ ���������*�������������������������"�������������������&����������������������������&����

��������0;�����������5�������� �����������������������������������������������������

��5�����������������������5������������"��-��������������������������������������������������������

�����������������������������������������������������*��������������������������������������

����"

-�����������������������������5����*������� �*�������������������������*������5���

��������� ���������6������������5�������������13�!����������������������"�����������������*�

�������������� ��������������5�������������������������������������� �������*������������

�������������������������*��������"��,����� &��������� �����������5�����������������

���� ���*����(���������������������������5���������������������������������C�6����������*�"

-������� ��������� �������������������� ������������������������������������(���������

�������������������������������"

-�����*����������������������������������������������C����������������������

������������������������������3"2�������*������������������*����:=�����:A�!��"��-������������

��������������������������*�������������������*������������*�*��������� ������(����*�������

�����������������������������"��-����������������������*��������������������������������

���� ������������������������������������� �����������������������"

)�6�&������������������������������������������C����������� ���������*������������&

����������������������������������5�������� "��-���������������*�������������������������������

����3"2����2�������������������� ������������ �?�!��������������������������� �������������������

�������&�������������&����������� "�����*�����������*������������������������������������ ����

00"?����033;�������������� ������������ �0�!��&������������������������������� �033�!��&

������������������������ ����������������������������������� "��-���������������*�����������������

��������������� �������������������������� �����������������������������������������"����

������������������������������������������������������� ������������������������������������������

������6�����������������&����������������������������������������������5�������������������

���������������� �*�����*����������������� ������������������������������"

Page 136: Characterization of Crazing Properties of Polycarbonate

02:

������ &��*���������������������6������������� ����*��������������������������

������������5������������������������������������� ��������"��-������������ ������������

�6����������������������5���������&�����������5�������� &��������������"

-*������������������������������*����������������"������&���5����������������������

��������������� ��������������������������������������� ����������������"��-��������������

���� ����������������������������������������������������������������������� ����������������

���������(��������������������������&����*�������5����������� ����������"��-���������

��������������������� �����������������������������������*�&�*��������������������������5��

�������������������5���������"

����������� &�����5�������������:3�!����������������������������������������� �����

�������������5�������������:1�!��"�������������������������������������5�������������&���

*��������������������5���������*����������*����5����������*������������2"1��������������

���������5������������������������5���������"�������������������������*���5��������������������

����������������������������� �����������������*�������� "

-������������������������������������������*����������������������������������5�

������ �����0����03;���������������������� �������������������������������"���������������&��

������������������6������������� ����*�����������*������� ��*��������4�����������5�

������ ��������������"�������������������� ���&���������������5�������� �*����������������3

���0;�������*������������������������������C���������������������5����������"

�������������������������������������������������5�������� �����3����0;�������������

������������������������������������������� "��-������������������*���������������������

��5��������������� ����������������� ����������������������������������������������������

������(�&�������������������� �����������������������(������������*�������*�����������

������"��-����������������� ������������������������������������������������ ���������������

��5��������������������������������������������������5������������������� ����������������

����������������� ������������&�����������5���������������������������03;�����������5�

������ "

�������������������������������*����������������������������8 ����������������������

�������������"��/� ����������������������������*�������������������������������������*����

��������� ���������&������6�������������������8 ����������������������������������������

���3"2����2�������*������(�� �������������������������������*����������������������������

Page 137: Characterization of Crazing Properties of Polycarbonate

021

������"��/���&�������������������6������������������������������������:1�!������������

���������������������������������*������������������5������������ �����������*����:1

����13�!��"��)��������������������������������*��������� �������6������������������*�:3

!���*�����������������������������"

/���������������������������������������������������������(��J������5���������

���������*�����������������������K&������������������������� �����������������������������

������������"���5�����������������������������&�������������6�����������C�����������������"

N������������� �������� �J��5���������K�����������������*���������������������������5������

�����J�������������� K����������������������"��-������������ ������5����������������������������

���������� ����������������������������"��������������������������������������������������

�������������������������������5������ �������������������5������������������������*�����������

��������������������������&����������&����������"���������������������������������������*�

�������������������*�*�������5����*������������"����������������������������������&���5���*���

��������� ���*�����������������5��"��-�����������������������*��������������5���*�����������

��*������������������5��*�����������������������������"�����������������������&���*���&�����

�������������������������������������*�����������������������5��������������� �������������"

Page 138: Characterization of Crazing Properties of Polycarbonate

02=

��������0� 9"�"���;��8

-���������������������������� ����������������������� �������������&���������*�(

������������������.������������������*� ������� ���*���������������������"��N��������������

������*� �������������5��������������������������&���5���������������*���������������5���

������������������.������5������������"���5����*����������������������������������������

���������������������������*�����6������������������������������&����������6�����&�����������

�6����������������� "��!���������������������������������*�����&�����������������&����

�����������������������������������������������6������������������"��/��������������������

����������������������������������������������5������������������� ��������"������������&

������������ ������������������������������������������������������� �����������*�������

���������"��8���������������������������������������������������������&������� ���������������

���������������������������������������� ��F��������� �����������*���������������������"

/�������������������������������������������5�����������������������������&�������

�����������.����*�����������������������6���������������������������������������������

�����������������������������������������"��/������������������������ �����������������5���������

���������������� �*�������C������������������������������������/������������������������

����������.��������������������������������������������������������� "

8�����&������������������������ ����*�������������������������������� �����������

��������� ����������� ���5���"��/��������5��������������������������������������� "��/��������

������������������&���5����������������������������� �������������������� �������������"��-�������

����� ���������������������������������������������� ������ ������������������������"��N���

������*����������&���������������5�������� �������������������������������������������

����������������� �������������������������� ������������������������ "��-�������������������������

����������������������������������*��������������������������� ���������"

/������������������� �*����������������������������������������6����������������

��5������������������� ������������������������ �*������������������6���������"��/���*���6���

��������� �������������������������������6������������������������������������������������6���

����������������������D=:E"��/��������������������������������6����������*�����������=@"

Page 139: Characterization of Crazing Properties of Polycarbonate

02>

�/1-���"E2���/�>/�,���.�/*1��������-.

������ &������������������������ ������������������������������������������5��������

���*������*����������>3"��-����������������3"0&�0&�03&�����033;���5�������� �*������������

������������������������������������������6������������������*�����������2@"

Page 140: Characterization of Crazing Properties of Polycarbonate

02A

�-

�&

#-

#&

$-

$&

&-

&&

-�-- -�- -� - -- --- ---- -----

��!��3��4

��!��3�4

-�< < -< --<

�/1-���&(2������7�,�+��8��7���)4�#�77���/+0��)�7��*3����.��),5+��6)*����-*3���+����

,)�3�)4�!C��������'(G���

-������������ �������������5���������(�����������������������������"�������������

�����������������������������������������������&�������� &����������6�����&�����������

�6�����&����"

Page 141: Characterization of Crazing Properties of Polycarbonate

02@

���������

������������������������������������������������

0� ,"�����������&���������������������������� ������������ ���������� ����������

����������������&�'��������������&�)<&�0=1&�70@@=9

2� !"�����(�*�&�<"�����&�����'"�'������&�J ������������������������������������������������

������������������� ���� ���&K� ������&�#&&��>&�00>>�70@@=9

?� #"��"�%�����&�J/�����*������5�������������������������������&K����������� ������

��������� ������������!�"��#�&�&&�0�70@>?9"

:� -"�"��"�!�,����&�"�+"�$"�������&�����/"�!"�������&�J�5����� ����������������4����C

������������������&K� ������&�#(&�0=10�70@A@9"

1� �"�!"�N��������"�N"�'���� &�$��%����&�������������� �������� �����������������&

�������&�+����N��� �G�����&����"&�)�*�<�(�70@@?9

=� ,"�'"��������&�%����&���������� ������� ��������������������&�����&�+����N��� �G�����&

���"&�)�*�<�(�70@@29

>� +""�/����&�J ���������������������(�������������������� ���� ���&K�����&����� ������

���������'(�&�%&��02&�:3?�70@@=9

A� !"�����(�*������'"�-�(������&�J�5����������������������������������������� &K�������

��� ��������������&�!"&�02@1�70@@09

@� +"�,�������/"�"�<��&�J ��������������������������������������������5���������������

��� �������������������������� �����6 ��������(����&K� ������������&�##&�0??A�723339

03� /","���� ��(�������)"�"���(���&����"������)������� �������&� ������&�)<�70@@19

00� $"+"���������&�!"/"������&�-"����������&�N"/"�����&�����!"�"�����&�J�����C������6C�

�������������� ������5���������������� �����������������������&K� ������������&�#!&

02=:�70@@@9

02� '"O"<"�'��&�-""�"�!�,����&�#"/"����(���&�)"+"�N��&�/"�"�+������&�/"!"�������&�����!"

�����&�J 6��������������������������������������������������������������� �����5���"

0"�-���������&K� ������������&�#�&�0?:A�70@@A9

0?� �"��"���������������,"�8������&�J<������������������������������������������ �����

��� ��������������������������&K� ������� ��������&�/��������������������� &���������

������ ��������� &��(&��2&�000>�70@=@9

Page 142: Characterization of Crazing Properties of Polycarbonate

0?3

������������������������������������������������������������������������������������������������������������������������������������������������������������

0:� /"�)"�$���&�J' ��������������������������5������������ ���������&K����������� ������

�������&�'&�@21�70@>39

01� +""�/���������+" "�-� ��&�J�������������� ������������������������������� �

�������������� ���������������� ����������6����&K�����������$�����&� ��������������

�'�$�&�&�&��0?&�2011�70@@@9

0=� +""�/����&�J-�������������������������������������������������(����������������!!/&K

���������� ����������������'(�&�##&��20&�10@?�70@@A9

0>� R"�B�������N"�"�����&�J-����������������������������� ����*��������� &���������� &����

����������5��������������� �����������&K�����������$&����������������&�����������

�*�������&��&��(&��03&�@=?�70@@=9

0A� #"��"�%�����&�J�5���&K������������������&����� ����������������&����������������"

+"���%����*��5&�N��� C�����������&�)<�70@@39�203C200

0@� !"�%�����&�J!������������������������ ����������������������������������5���&K

���������� ����������������'(�&�#�&��0?&�????�70@@=9

23� %"�����(�&�!"�'� ���&�����/"���(���&�J������������������������5����������������C/

��� ���������������������*�����������������������&K����������� �������������������

�� ���������!&&��:&�?A1�70@AA9"

20� ,"�+�������&�#"������&������"�������&�J�������������*����������(��������������

��� ���� �������� ����4���5��������������5����������������&K����������� ������

�������&�#(&�0>>2�70@@19

22� !"�)�����&�%"�%��������&�-"������ �&�����-"�%��5���&�J ������������������������������

��������������������� ��������C���������C�� ��������&K�����������$�����&� ������

�������&�&!&�:?1�70@@@9

2?� +"�"������������"�N"�#���&�J�5������������ ���� ����������C�����������������&K�+,-.

$�����!������������������������������%����������&�/���������� �������&�)�������

/����� ������������&�N���������&��""&�A=�70@>09

2:� !"�!"�B� �������+"�#"�N����&�JN��������������.������C������������� ���� ���4

�������������������������������������������&K����������� ��������������&�!(&�211>

70@A19

Page 143: Characterization of Crazing Properties of Polycarbonate

0?0

������������������������������������������������������������������������������������������������������������������������������������������������������������

21� /"�#��&�8"�O����&������"�%����&�J#������������������������������������ ��� �������������&K

��������������������&��������&�!'&�1>>�70@A19

2=� !"�!"�B� �������+"�#"�N����&�J ���������*���������������������������������������

��� �����������.���������������&K�����������$�����&� ��������������&�%#&�02@�70@@09

2>� "�+"�$"�������&�����/"�!"�������&�J-���������������������������� ���������������

��� ��������&K����������� ���������������� ���0�� ������� ������&�!&&�?21�70@A@9"

2A� $"�8"�������(�������"� "�#���&�J-������������������������������5���������� ��������&K

����������������&������������&����E&�2?0�70@A@9"

2@� �"/"�R�������""�-.���&�J-������������������������������������������������� ��������

*������� 7���� �������� ����9&K��������� ���������������'�$�&�#%&��A&�00:?�70@@A9

?3� "<"�-���&�,""����&�!"�+��&�����"'"�<�&�J�����������������������������5�����������

������������������������������� �� ����� �� !&K�(��������������� ������

��#��)����&�&��%'B�%E&��0&�2:@�70@@A9

?0� �"/"��(��������+"+"�,�� &� �������������%�����������$��������1����&2&��'����������

����������������&�)<&�1=A�70@@29

?2� �"�"�'�����5&� ����������������������0������������&�!�������((�&����"�)<�70@A:9

??� '"�!����&� �������������������� ��������������������723339

?:� �"�#��������� "N"�!����&� ����������������&�'����������N���������&���������&

$���� �70@A=9

?1� ����4FF***"������(�"���F���"����723339

?=� ����4FF***"������"�(F����F��F������F������"����723339

?>� ,"�$�������&�J'������ ���6����������������� ���������������������������&K����������

!��������������*������0�����������&�&��3�$2� ��������&����������&�C��&��0&�A@&

+��C����70@>>9

?A� �"�$"�,�����&�J-���������������������5�����������(��������������������&K����������

$�����&� ��������������&�'!&�0@??�70@@:9"

?@� '"���S��������#"�$"�%����&�J/���*�������������������������������������(���&K� ������

�������������&��������&�#"&���=&�A=@�70@@=9"

:3� $"!"�$���������$"�"�!�%����&�J-��������������� ���������������������5��������������

��� �� ���&K�$��� ������� ����������'�$�&�#"&��2&�=?�70@@19

Page 144: Characterization of Crazing Properties of Polycarbonate

0?2

������������������������������������������������������������������������������������������������������������������������������������������������������������

:0� "�+"�$"�������&�"�,"������&�"�R���&�+"�N�&�'"C'"�%�����&�����/"��"�<��&�J ��������

���������������������� �������� ��������������5������������������������C/���� ��������

����������&K� ������������&�!C&�>01>�70@@19"

:2� '"�%�*���&�<"�)������&�<"�'���&������"�)������&�J)��C����������������������������

����������������������������������������������������������������� ����� ������������C

*��������������������������&K����������� ��������������&�!E&�033:�70@@:9"

:?� '"R"<"�'��&�#"/"����(���&�-""�"�!�,����&�)"+"�N��&�����/"�"�+������&�J/���������

�����������5����������������������� ���� ���&K�/�������������� ��������� ������

���������&������������&�������!������&�������������&�&"&�21>�70@@>9

::� '"�/"�'�����&�/"��"�<��&������"�N"�$���� &�J����������5������������������� ��������4

���� �� ����������������������������� &K� ������&�#'&��0>&�?=3>�70@@:9"

:1� +"� "�-� �������+"�"�/����&�J ���������������������(���������� ��������������6��

�����������&K�(��������������� ������&���CB��E&�1@�70@@=9"

:=� "�'��(����&�J�5�������������������� ����������*����*��H�/�����������������&K

����������������/��-�������/��������������/������)��C�����������-�����������&

/���������&�)�*�!�6���&�)��"�0C?&�0@@:"

:>� '"�,"�-��(&��"��"��������T�1&11>&:3?�J� ������������������������������5��������

��������� &K�70@@=9"

:A� +"�"�/����&�J-���������������������������(���������������������������(������������

��� ���&K� ����������������&������������&���E&&�00@�70@@19"

:@� +"�"�/����&�J�5���������������������������������������������(���������� ���&K

���������� ����������������'(�&�#(&��?&�=11�70@@19"

13� /�-!����������=?AC@1&�J���������������������������������������������������&K�$����

0��4����$�� ����&�&�&�(CD(�&�:>�70@@=9

10� �������� ���'���5�� ���&�+��������������&�����#�����&�/�70@@19"

12� �"��"��� &��������6��'���"�������7�������6������/���������6�� ����������&�!����I�

-�����&������������ �����������������&�70@@19

1?� �"�#"�������������#"�$"�,����� &�'�&�����&����%�&�������/������&��7���������&�/�

/����� �����&��������������&��������70@@:9

Page 145: Characterization of Crazing Properties of Polycarbonate

0??

������������������������������������������������������������������������������������������������������������������������������������������������������������

1:� ����������������������/������������������$�������������&���(��� �������������&

)�*��(&�-

11� �����+�/�����������������������������&���(��� �������������,C0A@?&�)�*��(&�-

70@@19

1=� ��4���������/������������8$-������������!�����

1>� /"�/"�$�����������/"�!"��(������&�J������������*������������������

����������� &K� ���������������'��!&�#!&�1=>�70@@39

1A� �"�N"������&�J���������������������*�������������������������������������������

����������� ��������&K�����������9�:��&�������������&��"&�??>0�70@@?9

1@� /6��(�����(�����������������������������'���5��8��&�&�/��/����� �����&�������

������&��������70@@:9

=3� -"�#���������-"�,"������&�J#��������� ������������������ ������������������������������

�����&K����������� ���������������� ���0�� ������� ������&�!C&�10?�70@@39

=0� /"�+"�'���&�%"�+"�'����&�����"�!"�/��*��&�J-���������������� ��������������

��� ��������&K����������� ���������������� ���0�� ������� ������&�!C&�?A>�70@@39

=2� �"� "�)�(��������"� "������&�J/������������������������������ ��������������������(

���������&K�6������/��������&��%EE&�?@�70@@09

=?� +"��"��� &�;����������� ������������� �������&�+����N��� ���������&�)<�70@A39

=:� �"��"��� &��"��"��������T�1&@31&231�J���6��������������������&K�70@@=9"

Page 146: Characterization of Crazing Properties of Polycarbonate

0?:

������������������������������������������������������������������������������������������������������������������������������������������������������������

J���

��������������� �*����������+��������������� ������������02&�0@=@���

'���������&�N�����������"��'������������������������������0@AA����������������'���

���������������������&�N�����������"

������������������������������&�!"��� ������������N������������������������

-�������� ����!������� &�N�����������"��'�����������*���������������������������������

!���������� �������������0@@2"��'��*����������*�(�����)8�/��� �����������������

'���������&�N������������������������ ��������������������������������������������� "

���������������0@@?&�!"��� �������������������%������������������������������� �����

������������������/������"��N�����������������&�!"��� ���������!���������������������

��� ����������!������������������������ ������������������������������������ ����0@@1"��'�

*����������*�(��������/�������#�������,������ ����N��������������/��������������

�� ���&�8����������0@@A�*���������������������������� �����������������������������*�(���

����������!��������"

!"��� ����������������������-� �/�����,������������������&�N�����������"��'�

�����*��*���������������&�+����������������������$���"��-�� ����������������������� ���&

8��������*�������*��������������������������/�������#�������,������ ����N����

���������/�����������"

-���������������������������!"��� I����������$��"��/��������������+����������������

�������������&����������������������/�����������������������8��&�N�����������"��N����

����������&�����������������������$������$���*� ���������������������(����&��������"