CHEVROLET M & M CHEVROLET CHASSIS GROUP 5.000 CHEVROLET BRAKES — REAR AXLE — PROPELLER SHAFT — WHEELS ALPHABETICAL INDEX A D ADAPTER, Tire Traction ..................................... 5.885 DAMPER ASSY., Propeller Shaft Damper ....... 5.544A ARM ASSY., Rear Axle Control ............................ 5.382 DAMPER UNIT, Rear Axle Control Arm ............ 5.383 ARM, Rear Axle Control Arm ................................ 5.380 DAMPER UNIT, Universal Joint ........................... 5.555 DEFLECTOR, Propeller Shaft Pinion .................. 5.545 DISC, Front and Rear Wheel Brake ................... 5.809 DISPENSER ASSY., Tire Traction ........................ 5.885 B DRUM ASSY., Front and Rear Wheel Brake... 5.809 BALL UNIT, Universal .............................................. 5.548 BEARING and CUP UNIT, Universal .................. 5.548 E BEARING ASSY., Drive Pinion Rear................... 5.484 BEARING ASSY., Drive Pinion-Front .................. 5.447 BEARING ASSY., Rear Wheel ............................... 5.855 EMBLEM, Wheel Cover Appearance ................. 5.871 BEARING, Differential Side ................................... 5.536 EXTENSION, Tire Valve ........................................... 5.875 BEARING, Rear Axle Shaft Bearing or Hub .... 5.822 BEARING, Universal Joint Yoke Trunnion ...... 5.566 BOLT, Brake Shoe Anchor Pin ..................... ....... 5.056 BOLT, Differential Carrier Cap ............................. 5.506 F BOLT, Flange Plate ................................................... 5.002 BOLT, Hub or Drum (Front and Rear Wheel).. 5.812 BOLT, Propeller Shaft Damper ............................. 5.544A FLANGE, Propeller Shaft Pinion .......................... 5.545 BOLT, Rear Axle U Joint ......................................... 5.428 BOLT, Rear Axle Control Arm ............................... 5.383 BOLT, Rear Axle Tie Rod ........................................ 5.418 BOLT, Ring Gear ................. ....................................... 5.531 G BOLT, 'U' Joint Trunnion and Yoke ................... 5.586 BRACKET, Brake Flange Front............................. 5.001 BRACKET, Rear Axle Control Arm ..................... 5.380 GASKET, Axle Filler and Drain ............................. 5.400 BRACKET, Rear Axle Tie Rod ............................... 5.418 GASKET, Axle Housing to Differential Carrier BRACKET, Rear Axle ................................................ 5.395 (paper) ................................................................... 5.508 BUMPER, Rear Axle .................................................. 5.395 GASKET, Axle Housing Cover (Cork)................. 5.399 BUSHING ASSY., Rear Axle Control Arm ...... 5.381 GASKET, Axle Housing Flange ............................. 5.819 BUSHING ASSY., Rear Axle .................................. 5.417 GASKET, Flange Plate ............................................. 5.002 BUSHING UNIT, Rear Axle Control Arm. 5.380 GEAR ASSEMBLY, Ring and Pinion (not sold separately) .................... : ...................................... 5.529 GEAR, Differential Pinion ....................................... 5.526 GEAR, Differential Side ........................................... 5.528 c GEAR UNIT, Differential Side with Pinion ...... 5.527 GREASE CAP, W heel ............................................... 5.858 GUIDE, Differential Clutch (Positraction) ........ 5.511 CABLE ASSY., Rear Axle Lateral Movement-(Stop) ................................................ 5.410 CAGE, Differential Clutch (Positraction) ........... 5.511 . CAP, Tire Valve ........................................................... 5.875 H CASE, Differential and Planet ............................... 5.510 CLAMP, Rear Axle Control Arm ........................... 5.383 CLAMP, Rear Axle ..................................................... 5.638 HARNESS ASSY., Tire Traction ........................... 5.885 CLIP, Brake Shoe Anchor Pin ............................... 5.056 HOSE, Tire Traction .................................................. 5.885 CLIP, Wheel Cover Appearance .... 5.871 HOUSING, Rear Axle ................................................ 5.387 CLUTCH UNIT, Differential Clutch HUB CAP, Wheel ....................................................... 5.858 (Positraction) ........................................................ 5.511 HUB, Wheel Cover Appearance ........................... 5.871 CONTAINER ASSY., Tire Traction ...................... 5.885 COVER, Axle Housing with Filler Plug.............. 5.398 COVER, Brake Adjusting Hole .............................. 5.117 ■ COVER, W heel ............................................................ 5.858 1 CUP, Differential Clutch (Positraction) .............. 5.511 CUSHION, Rear Axle ................................................ 5.395 INFLATER ASSY ......................................................... 5.880 INSERT, Wheel Cover Appearance .................... 5.871 INSULATOR UNIT, Brake Shoe ........................... 5.018 GM PARTS DIVISION, GENERAL MOTORS CORPORATION—CHEVROLET—11 5-1 A INDEX
64
Embed
BRAKES — REAR AXLE — PROPELLER SHAFT — WHEELSwildaboutcarsonline.com/members/AardvarkPublisherAttachments/... · BRAKES—REAR AXLE AND DRIVE The axles for Chevrolet will be
This document is posted to help you gain knowledge. Please leave a comment to let me know what you think about it! Share it to your friends and learn new things together.
Transcript
CHEVROLET M & M
CHEVROLET CHASSIS GROUP 5.000 CHEVROLET
BRAKES — REAR AXLE — PROPELLER SHAFT — WHEELS
ALPHABETICAL INDEX
A D
ADAPTER, Tire Traction ..................................... 5 .885 DAMPER ASSY., Propeller Shaft Dam per....... 5 .5 44 AARM ASSY., Rear Axle C ontro l............................ 5 .382 DAMPER UNIT, Rear Axle Control A rm ............ 5 .383ARM, Rear Axle Control A rm ................................ 5 .3 80 DAMPER UNIT, Universal J o in t........................... 5 .555
DEFLECTOR, Propeller Shaft Pinion.................. 5 .545DISC, Front and Rear W heel Brake................... 5 .809DISPENSER ASSY., Tire Traction........................ 5 .885
B DRUM ASSY., Front and Rear W heel Brake... 5 .809
BALL UNIT, Universal.............................................. 5 .5 48BEARING and CUP UNIT, Universal.................. 5 .548 EBEARING ASSY., Drive Pinion Rear................... 5 .484BEARING ASSY., Drive Pinion-Front.................. 5 .447BEARING ASSY., Rear W h eel............................... 5 .855 EMBLEM, W heel Cover Appearance................. 5 .871BEARING, Differential S id e ................................... 5 .5 36 EXTENSION, Tire Valve........................................... 5 .875BEARING, Rear Axle Shaft Bearing or Hub.... 5 .8 22BEARING, Universal Joint Yoke Trunnion...... 5 .566BOLT, Brake Shoe Anchor P in ..................... ....... 5 .056BOLT, Differential Carrier C a p ............................. 5 .506 FBOLT, Flange P late ................................................... 5 .002BOLT, Hub or Drum (Front and Rear Wheel).. 5 .8 12BOLT, Propeller Shaft Dam per............................. 5 .544A FLANGE, Propeller Shaft P in ion.......................... 5 .545BOLT, Rear Axle U Jo in t......................................... 5 .428BOLT, Rear Axle Control Arm ............................... 5 .383BOLT, Rear Axle Tie Rod........................................ 5 .418BOLT, Ring Gear................. ....................................... 5 .531 GBOLT, 'U' Joint Trunnion and Y oke................... 5 .5 86BRACKET, Brake Flange Front............................. 5.001BRACKET, Rear Axle Control A rm ..................... 5 .3 80 GASKET, Axle Filler and Drain............................. 5 .4 00BRACKET, Rear Axle Tie Rod............................... 5 .418 GASKET, Axle Housing to Differential CarrierBRACKET, Rear A xle ................................................ 5 .395 (paper)................................................................... 5 .508BUMPER, Rear Axle.................................................. 5 .395 GASKET, Axle Housing Cover (Cork)................. 5 .399BUSHING ASSY., Rear Axle Control A rm ...... 5.381 GASKET, Axle Housing Flange............................. 5 .819BUSHING ASSY., Rear A xle .................................. 5 .417 GASKET, Flange P la te ............................................. 5 .0 02BUSHING UNIT, Rear Axle Control Arm. 5 .3 80 GEAR ASSEMBLY, Ring and Pinion (not sold
separately).................... :...................................... 5 .529GEAR, Differential Pinion....................................... 5 .5 26GEAR, Differential S id e ........................................... 5 .528
c GEAR UNIT, Differential Side with Pinion...... 5 .527GREASE CAP, W h e e l............................................... 5 .858GUIDE, Differential Clutch (Positraction)........ 5 .511
CAGE, Differential Clutch (Positraction)........... 5 .511 .CAP, Tire Va lve ........................................................... 5 .875 HCASE, Differential and Planet............................... 5 .510CLAMP, Rear Axle Control A rm ........................... 5 .383CLAMP, Rear Axle..................................................... 5 .638 HARNESS ASSY., Tire Traction ........................... 5 .885CLIP, Brake Shoe Anchor Pin............................... 5 .056 HOSE, Tire Traction.................................................. 5 .885CLIP, W heel Cover Appearance.... 5 .871 HOUSING, Rear A xle ................................................ 5 .387CLUTCH UNIT, Differential Clutch HUB CAP, W h ee l....................................................... 5 .858
(Positraction)........................................................ 5 .511 HUB, W heel Cover Appearance........................... 5 .871CONTAINER ASSY., Tire Traction...................... 5 .885COVER, Axle Housing with Filler Plug.............. 5 .398COVER, Brake Adjusting Hole.............................. 5 .117 ■COVER, W h e e l............................................................ 5 .858 1CUP, Differential Clutch (Positraction).............. 5 .511CUSHION, Rear A x le ................................................ 5 .395
INFLATER ASSY......................................................... 5 .880INSERT, W heel Cover Appearance.................... 5 .871INSULATOR UNIT, Brake S h oe ........................... 5 .018
GM PARTS DIVISION, GENERAL MOTORS CORPORATION—CHEVROLET—115-1 A INDEX
ALPHABETICAL INDEX
INSULATOR, Whpel Cover A ppearance........... 5 .871
L
LEVER, Brake Shoe Automatic A djusting....... 5 .103LEVER, Parking Brake Shoe.................................. 5 .149LINING UNIT, Brake Shoe.................................... 5 .018LINK, Brake Shoe Automatic Adjusting Lever 5 .105LOCK, Axle Shaft........................................................ 5 .4 22LOCK, Brake Shoe Anchor Pin............................. 5 .056LOCK RING, 'U' Joint Trunnion and Y o ke...... 5 .5 86LUBRICANT, Hypoid G ear..................................... 5 .535
M
MEMBER, Rear Axle Control A rm ....................... 5 .3 8 0
N
NUT ASSY., W heel Cover Appearance............. 5 .871NUT, Brake Shoe Anchor P in ............................... 5 .0 56NUT, Brake Shoe Hold D ow n............................... 5 .043ANUT, Flange P late ...................................................... 5 .002NUT, Hub-Front and R ear....................................... 5 .813NUT, Propeller Shaft Dam per............................... 5 .544ANUT, Propeller Shaft Pinion Flange................... 5 .595NUT, Rear Axle Control A rm ................................. 5 .3 83NUT, Rear Axle Tie R od .......................................... 5 .418NUT, 'U' Joint Trunnion and Y o ke ..................... 5 .5 86
o
ORNAMENT, W heel Cover Appearance........... 5 .871
p
PIN, Brake Shoe A nchor......................................... 5 .055PIN, Brake Shoe.......................................................... 5 .043PIN UNIT, Brake Shoe Hold D o w n .................... 5 .043APIVOT, Brake Shoe Automatic A d justing ....... 5 .103PLATE ASSEMBLY, Brake Flange F ront......... 5 .001PLATE, Brake Shoe G uide..................................... 5 .045PLATE, Differential Clutch (Positraction)........ 5 .511PLUG, Axle Filler and D rain .................................. 5 .4 00
R
REINFORCEMENT, Rear Axle Control Arm..... 5 .3 80REINFORCEMENT, Rear Axle Control............... 5 .382REINFORCEMENT, W heel Cover Appearance 5.871REPAIR KIT, Rear Axle U J o in t............................ 5 .428REPAIR KIT, Universal............................................. 5 .548RETAINER...................................................................... 5 .880RETAINER, Brake S h o e ........................................... 5 .043RETAINER, Rear Axle Bumper.............................. 5 .394RETAINER, Rear Axle Shaft B earing................. 5 .816RETAINER, W heel Cover A p pearance.............. 5 .87 1RING ASSY., W heel Cover A ppearance........... 5 .87 1RING, Differential Clutch (Positraction)............ 5.51 1ROD ASSY., Rear A x le ............................................. 5 .415ROLLER, Rear Axle U J o in t................................... 5 .428ROLLER, Universal Joint Yoke Trunnion.......... 5 .5 66
sSCREW, Axle Filler and D ra in .............................. 5 .4 00SCREW, Axle Housing with Filler Plug............. 5 .398SCREW, Brake Shoe Adjusting............................ 5 .1 10SCREW, Pinion Shaft Lock.................................... 5.5 18SCREW, W heel Cover Appearance.................... 5 .871SEAL ASSY., Drive Pinion...................................... 5 .469SEAL, Propeller Shaft Universal Joint
Trunnion................................................................ 5 .5 6 0SEAL, Rear Axle Shaft Bearing or H u b ............ 5 .822SHAFT, Axle................................................................. 5 .4 20SHAFT, Differential Pinion..................................... 5 .517SHAFT, Rear Propeller (Shaft attaches to
rear axle)............................................................... 5 .441SHAFT, Rear Propeller (Shaft attaches to
rear axle).... .......................................................... 5 .544SHIELD, Flange Plate............................................... 5 .002SHIELD, Pinion Flange............................................. 5 .468SHIM , Differential Clutch (Positraction)........... 5.511SHIM , Pinion Shaft Bearing.................................. 5 .460SHIM , Rear Axle Control Arm............................... 5 .380SHIM UNIT, Differential Bearing Adjusting.... 5 .537SHOE 8i LINING PACKAGE, Brakes................... 5 .017SHOE UNIT, Brake W ith Facing, M e ta llic ...... 5 .017SLEEVE, W heel Cover A ppearance................... 5 .871SLINGER, Propeller Shaft P inion........................ 5 .545SOCKET, Brake Shoe Adjusting Screw ............ 5 .111SPACER, Differential Bearing A d justing .......... 5 .537SPACER, Differential Clutch (Positraction)..... 5 .511SPACER, Flange Plate.............................................. 5 .002SPACER, Pinion Shaft Bearing............................. 5 .453SPACER, Rear Axle Bumper................................. 5 .394SPACER, Rear Axle Control A rm ....................... 5 .383SPACER, Rear Axle Lateral Movement-(Stop). 5 .4 10SPACER, Rear Axle Tie Rod................................ 5 .418SPACER, Universal Joint Yoke Trunn ion ......... 5 .5 66SPACER, W heel Cover A ppearance.................. 5 .87 1SPOKE ASSY., W heel Cover Appearance....... 5 .871SPRING, Brake Drum................................................ 5 .810SPRING, Brake Shoe Automatic Adjusting
Lever....................................................................... 5 .107SPRING, Brake Shoe Hold D o w n ....................... 5 .043ASPRING, Brake S h oe ................................................ 5 .0 26SPRING, Differential Clutch (Positraction)...... 5 .511SPRING KIT, Brake Shoe Hold D o w n............... 5 .043ASPRING, Parking Brake Shoe Lever.................. 5 .151STEM ASSY., Tire V a lv e ......................................... 5 .875STOP, Rear A x le ......................................................... 5 .395STRAP, 'U ' Joint Trunnion and Y o k e ................ 5 .586STRUT, Parking Brake Shoe Lever.................... 5 .1 50STUD, Hub or Drum (Front and Rear W h e e l). 5 .8 12STUD, Rear Axle Tie Rod....................................... 5 .418SUPPORT M O UNTING , Rear Axle Control
A rm .......................................................................... 5 .3 80SW ITCH ASSY., Tire T raction .............................. 5 .885
T
TAG, Axle Filler and Drain..................................... 5 .4 00
axle)......................................................................... 5 .544UNIT, Rear Wheel S p acer..................................... 5 .811
vVENTILATOR, Rear A x le ........................................ 5 .387
INDEXGM PARTS DIVISION, GENERAL MOTORS CORPORATION—CHEVROLET—11
5-2 A
ALPHABETICAL INDEX
W
W ASHER, Brake Shoe Adjusting......................... 5 .1 10WASHER, Brake Shoe Anchor Pin..................... 5 .056W ASHER, Differential Pinion T hrus t................. 5 .542W ASHER, Differential Side with P in ion ........... 5 .527W ASHER, Differential Side Gear Thrust.......... 5 .543WASHER, Parking Brake Lever Anchor............ 5 .158WASHER, Pinion Shaft Bearing........................... 5 .4 53W ASHER, Pinion Shaft Lock................................. 5 .518WASHER, Propeller Shaft Dam per..................... 5 .544AWASHER, Propeller Shaft Pinion F lange......... 5 .595W ASHER, Propeller Shaft P in ion ....................... 5 .545W ASHER, Rear Axle Control A rm ...................... 5 .381WASHER, Rear Axle Control A rm ...................... 5 .383W ASHER, Rear Axle Tie Rod................................ 5 .418W EIGHT, W heel B alance....................................... 5 .805WHEEL, Front or Rear.............................................. 5 .803
Y
YOKE, Universal Jo in t.............................................. 5 .555
GM PARTS DIVISION, GENERAL MOTORS CORPORATION—CHEVROLET—115-3 A INDEX
BRAKES—REAR AXLE AND DRIVE
The axles for Chevrolet will be built by Chevrolet Buffalo, Chevrolet Gear and Axle, Buick, Oldsmobile and McKinnon. Divisional Manufacturer code letters will be metal stamped on the axle tube adjacent to the carrier for field identification. (See Example). Metal stamp on left rear axle tube on rear side, letters and numerals 3/16" high, 3" outboard of carrier.
FIELD IDENTIFICATION
-M IN IM U M REQUIREMENT FOR IDENTO-PLATE
N K B 218 D W
L P/TRAC. IDENTIFICATIONW-BOR G WARNER E - EATON O - OLDS G - CHEV
D FOR DAY SHIFT N FOR NIGHT SHIFT
DAY OF YEAR AXLE BUILT (218 = THURSDAY, AUGUST 6, 1970)
MANUFACTURER IDENTITY
MANUFACTURER IDENTITY
B — Buick0 - OLDSMOBILE P - PONTIACG - CHEVROLET GEAR AND AXLE C - CHEVROLET BUFFALO K - GM OF CANADA, ST. CATHARINES M - GM OF CANADA
MANUFACTURERS IDENTIFICATION WILL APPEAR IN THE DESCRIPTION COLUMN.
Brakes),73-74 Nova (exc. Disc Brakes) ...............68 -70 Pass. w /D isc B ra k e ..........................
69-71 Chevy, Chevelle, Camaro w /D iscBrk.,
72 Chevelle, Nova w /D isc Brake,73 -74 Nova w /D isc B ra k e s .......................
69-71 Chevy, Chevelle, Camaro w /D isc Brk.,
72 Chevelle, Nova w /D isc Brake,73 -74 Nova w /D isc B ra k e s .......................
64 -70 Chevy, Chevelle, Camaro (exc.Disc Brakes),
71 -72 Chevelle, Nova, Camaro,73 -75 Nova, C a m a ro ....................................64 -70 Chevy, Chevelle, Camaro (exc.
Disc Brks.),71 -72 Chevelle, Nova, Camaro,73 -75 Nova, C a m a ro ....................................65 Chevelle (396),65 -70 Pass.........................................................65 Chevelle (396),65-70 Pass.........................................................70 Monte Carlo w / 10 bolt cut out
cover,73-75 Chevelle (exc. Sta. W ag.) .............70 Monte Carlo w /1 0 bolt cut out
cover,73-75 Chevelle (exc. Sta. W ag.) .............
N O T E 1: See i l lu s t ra t io n p re c e d in g 71 -74 Pass, w /2 .7 3 , 3 .08 ratio (exc.
Sta. W ag.) ......................................71 -74 Pass, w /2 .7 3 , 3 .08 , 3 .4 2 ratio
(exc. Sta. W ag., Taxi, Police),73 -74 Chevelle (Sta. W a g .) .......................71 -74 Pass, w /2 .7 3 , 3 .08 ratio (exc.
Sta. W ag.) ......................................71 -74 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio
(exc. Sta. W ag., Taxi, Police),7 3 -7 4 Chevelle (Sta. W a g .) .......................71-72 Pass. (Sta. W ag.) w /2 .7 3 , 3 .08 ,
ratio ...................................................71-75 Vega, M o n z a ......................................71-75 Vega, M o n z a ......................................73-75 Pass. (Sta. W ag.),73-75 Police, T a x i .........................................73 -75 Pass. (Sta. W ag.),73-75 Police, T a x i .........................................75 Chevelle,75 Pass, w /2 .7 3 , 3 .08 ratio (exc.
Sta. W ag.) ......................................
2 6 2 0 5 6 4 R.H. 11.35 right (Note 1 ) ...........................................................G ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
(type G, K, C ) ......
5 4 7 2 3 2 4 L.H. 15 .50 (type B, O, P, M) ....
(type G, K, C ) ......
5 4 7 2 3 2 5 R.H. 15 .50 (type B, O, P, M) ...................................................
NUT, rear brk. to axle housing (Note 2) N O T E 2 See i l lu s tra t io n p re c e d in g G ro u p 5 .3 9 8 fo r id e n t if ic a t io n o f a x le cover.
_________- GM PARTS DIVISION, GENERAL MOTORS CORPORATIONREV. 4 76 5-3
Vega, M o n z a ...............................Vega, M o n z a ...............................Camaro,Pass.,Pass., Chevelle, Camaro,Nova ..............................................Camaro,Pass.,Pass., Chevelle, Camaro,Nova ..............................................Chevelle w /D isc Brakes, Chevy w /D isc Brakes,Camaro w /D isc Brakes (exc.
Front and Rear),Nova w /D isc B ra k e s ...............Chevelle w /D isc Brakes, Chevy w /D isc Brakes, Camaro w /D isc Brakes (exc.
Front and Rear),Nova w /D isc Brakes . . . . . . .Pass. . ............................................Pass..................................................
1 3 8 1 7 2 3 L.H. 4.05 SHIELD, w /deflector, front brake discsplash .......................................................... ~...........
3 9 5 3 4 2 2 R.H. 3.69 SHIELD, fro n t right disc splash (SinglePiston D es ign )........................................................
3 9 5 3 4 2 1 L.H. 3 .69 SHIELD, front, left disc splash (SinglePiston D es ign )........................................................
3 2 6 8 9 7 L.H. 3.85 SHIELD, frt. brk. disc s p la s h ...............................3 2 6 8 9 8 R.H 3.85 SHIELD, frt. brk. disc s p la s h ..............................
N O T E 3 : U se d u n d e r u n u s u a l o r h e a v y d u ty ro a d c o n d it io n s . Camaro w /D isc Brakes-Front
and R e a r ........................................... 3 9 4 5 1 8 9 A .R . 5 .05 SPACER, rear brake caliper
64-67
64-67
65-67
65-67
5.017 SHOE UNIT, Brake With Facing, MetallicN O T E M e ta ll ic l in in g s a re d o u b le s in te re d as c o m p a re d to th e s in g le a n d m u c h la rg e r s in te re d c e ra m e ta lix
l in in g s .Chevy, Chevelle, Camaro
w /M eta llic L in in g s ....................... 3 8 4 5 2 9 1 1Chevelle, Camaro, Chevy w /H .D .
5.017 SHOE & LINING PACKAGE, BrakesN O TE : In n o ca se s h o u ld a b ra k e d ru m b e tu rn e d d o w n m o re th a n . 0 3 0 / 0 6 0 o n d ia .The G M M e rc h a n d is in g L in e o f T une-U p K its , S h o c k A b s o r b e rs /a n d B ra k e S e ts a re s h ip p e d d ir e c t to d e a le rs
fro m th e so u rce , a n d a re n o t s to c k e d a t G M P a rts D iv is io n D is tr ib u t io n C enters .There is a re q u ire d m in im u m o rd e r q u a n tity . C o m b in a tio n T une-U p K its , B ra k e S e ts a n d S h o c k s o rd e rs m a y
q u a l i fy b a s e d on w e ig h t.A l l o rd e rs a re s h ip p e d f r e ig h t p re p a id .O rd e rs m u s t b e w r it te n o n a s p e c ia l o rd e r fo rm w h ic h a llo w s s c h e d u lin g o f fo u r d e a le r s h ip m e n ts . S p e c if ic
w e ig h ts a n d q tys . a re s p e c if ie d on o rd e r fo rm .A l l p u rc h a s e s a c c ru e to w a rd D e a le r 's p a r ts re tu rn reserve .P u rch a se s a re n o t e l ig ib le fo r w h o le s a le c o m p e n s a tio n o r s to c k o rd e r a llo w a n c e .G M M e rc h a n d is in g L in e P a rts a re n o t re tu rn a b le to G M P a rts D iv is io n .M e rc h a n d is in g L in e P a rts a re w a rra n te d in a c c o rd a n c e w ith c u r re n t G M P a rts D iv is io n p a r ts p o lic y .
3 .55 axles),70 Pol., T a x i .............................................. N.A.A.R. 3 8 5 2 2 2 0 (rr.) b o n d e d .......... ...........................68 -69 Camaro w /D isc Brk. (frt. & rr.) . . 1 1 5 4 1 2 2 A.R. N.L. 2 6 2 1 6 0 9 (frt. 8i rr.) r iv e te d .................................70 Monte Carlo w /1 0 bolt cut out . 1 1 5 4 1 2 0 A.R. N.L. 2 6 2 1 3 3 9 (std.) riveted (Note 2) .......................
N O T E 2 : S ee i l lu s t r a t io n p re c e d in g Grp. 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cvr.71-75 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio
(exc. Sta. W gn.),73 -75 Chevelle (Sta. W g n .) ............... 1 1 5 43 9 1 A.R. 5 4 7 2 1 8 2 (rr.) riveted (11 x 2) .........................71 -75 Pass. (Sta. W gn.) ............................ 1 1 5 4 3 9 2 A.R. 5 4 7 2 3 2 0 (rr) std. (12 x 2) riveted ..................71-75 Pass. w /H .D . Disc Brks.................... N.A.A.R. 2 6 2 1 6 0 7 ( f r t . ) ...................................... ...............71-75 Vega, M o n z a ...................................... 1 1 5 41 4 1 A.R. N.L. 3 9 8 7 3 8 5 (rr.) .......... ................................................71 -75 Vega (D is c ) ......................................... 1 1 5 4 1 2 5 A.R. N.L. 3451 16 (frt.) (std. lining) ....................................71 -75 Vega (Premium L in in g ).................. 1 1 5 4 3 9 8 A.R. i 8 0 0 1 5 2 1 . . . ' ..........................................................72 Chevelle (exc. Disc B r k .) ............... 1 1 5 4 1 1 9 A.R. N.L.73 -74 Nova (exc. Disc B rk s .) .................... 1 1 5 4 1 1 9 A.R. N .L 3 3 8 3 1 8 (frt.) (riveted) (repl. 5 4 6 0 7 3 2 ) ..........73 -75 Chevelle . ......................................... 1 1 5 4 3 9 3 A.R. 2 6 2 0 5 5 4 (rr.) (91/ 2 x 2") . . . ______ _ . .............73 -75 Chevelle, Cabiaro (Man. Disc) . . 1 1 5 4 3 9 5 A.R. 2 6 2 0 5 6 0 ( f r t . ) .................................... ..................74-75 Chevelle, Camaro w /D isc Brks.
(exc. P.B.),75 Nova w /D isc Brks. (exc. P.B.) . . . 1 1 5 4 3 9 5 A.R. 2 6 2 1 6 0 6 ( f r t . ) ...........................................................75 Monza (D is c ) ............................ N.A.A.R. 3 6 1 0 9 4 (frt) . . - I .................... .. . . .......................75 Camaro, N o v a .................................... 1 1 5 4 3 9 3 A.R. 3 5 7 3 9 7 (rr.) (b o n d e d )...........................................75 Chevelle, Camaro, Nova (P.B. - 1
w /D isc B r k . ) .................................... 1 1 5 4121 A.R. N.L. 2 6 2 1 6 0 5 (frt.) ........................................................N O T E 1: U s e d on N o va w /H .D . B rks . fo r Y ear 1 9 7 0 a n d 1972 .N O T E 3 : U s e d o n N o va (exc. H.Q. B rks.).
5.018 LINING UNIT— INSULATOR UNIT, Brake Shoe70 Monte Carlo w /1 0 bolt cover . . . 2 6 2 1 3 4 5 1 14.95 standard (riveted) (Note 2) . . . . . . .
N O T E 2 : See I l lu s t r a t io n p re c e d in g G ro u p 5 .3 9 8 fo r id e n t if ic a t io n o f a x le cove r.72-74 All w /D isc B r k . ................................. 2 3 1 4 7 4 1 .96 INSU LA TO R UNIT , front (Note 1) ..................
N O T E 1: U n it c o n ta in s a n a n ti-s q u e a k m a te r ia l w h ic h is c e m e n te d to th e m e ta l b a c k o f e a ch b ra k e p a d a n din c lu d e s in s ta lla t io n in s tru c t io n s .
5.026 SPRING, Brake Shoe62 Chevy ................................................... rear, pull back (p rim ary ),......................................63 Chevy (exc. Metallic Linings,
327) ................................................... 3 7 9 0 2 3 9 A.R. .44 front and rear pull back (primary) ( IO V 2"coils— 35/ i6" free length) (yellow) ...............
and R e a r ............................................ 5 4 6 5 9 4 4 271 -7 5 Vega, M o n z a ..................................... 3 9 8 7 3 8 4 17 3 Chevelle, Camaro,73 Nova (exc. Disc B rk .) ......................73 -75 Camaro, Chevelle ........................... 5 4 6 4 6 9 5 263-70 Pass........................................................
65 -67 Pass. w /M eta llic Linings,65-69 Police, T a x i ........................................ 3 9 8 19 8 8 A .R .63 Chevy .................................................. 3 9 8 1 9 9 1 26 4 -70 Chevy, Chevelle, Camaro,71 Chevelle, Nova,72 All (exc. Pass ),73 -75 Chevelle (exc. Sta. W ag.),73 -75 Nova (exc. Disc Brk.),73-75 C a m a ro ............................................... 3 9 8 1 9 8 7 A.R.
71-75 Pass. (Sta. W ag.) w /2 .7 3 , 3 .08,3 .42 ratio,
71-75 Police, Taxi w /3 .0 8 , 3 .42 ratio . 5 4 7 2 5 2 0 1
71-75 Pass. (exc. Sta. W a g .) ................... 5 4 7 2 5 2 5 1
73-75 Chevelle (Sta. W ag.),73-75 Pass. (exc. Sta. W ag., Taxi,
P o lic e )...................................... 2 6 2 0 5 8 7 1
.38
.55
.88
2.452.35
2.35
4.44
3.75
4 .72
park brake adj. screw spring rear, pull back (Note 3 ) ..........
frt. adjusting screw, ....................................rear brk. shoe adjusting s c r e w ...............SPRING U N IT , pull back front and rear
Monte Carlo w /1 0 bolt cut out c o v e r........................................... ..
SPRING U N IT , pull back, front and rear secondary (325/ 32ff O.L.-green) (Note 3) . . . .
SPRING U N IT , rr. brake (12 x 2) (type P, M)(Note 4 ) .....................................................................
SPRING U N IT , rear brake (primary and secondary) (type B, 0 , C, G, K, W ) (Note 4)
SPRING U N IT , rear brake ( 1 1 x 2 ) (primary and secondary) (Note 4) . * ...............................
70
7375
Nova, C a m a ro ...............Chevelle, Nova, Camaro 5 4 7 2 8 4 0 1 4 .78
secondary pull back (front and rear) (Note1)............ ................................................ ......................
frt. pull back (seco nd ary ),...................................SPRING UN IT , rear brk. (91/ 2" x 2) (repl.
5 4 6 2 9 5 8 ) ................................................................N O T E 1 C o n s is ts o f 4 e a ch P u ll B a c k S p rin g s , H o ld D o w n P ins , a n d S p rin g s , H o ld D o w n S p r in g C ups, 2 A d j.
H o le C overs.N O T E 3 : E ach u n it c o n ta in s m a te r ia l fo r o n e w hee l.N O T E 4: E ach u n it c o n ta in s m a te r ia l f o r on e ax le .
and re a r ) ............................................ 5 4 6 7 8 1 5 2 .95 front and rear retaining (s/ , 6" x 327/ 32") ..........
5.043A PIN UNIT— NUT--SPRING KIT—SPRING, Brake Shoe Hold Down62 Chevy w /m etallic linings, 6 5 -72 Pass.,65-71 Chevelle, Nova,67 -69 C a m a r o .................................63 -64 Chevy (exc. metallic linings)72 -7570
A l l ...........................................................Monte Carlo w /1 0 bolt cut out
71-75 Vega, M o n z a ...................................... 3 9 8 2 2 1 6 4 .92
front and rear w /spring ,r e a r , ......................................w /spring, frt. axle__̂ .
rear (Note 1) .............................................................NUT, anchor pin, rear— ( 8 .9 1 5 ) .......................SPRING KIT, brake shoe hold down (91/ 2" x
2 ) ............... '.................................................................S P R IN G .......................................................................
N O T E 1 S ee i l lu s t ra t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
front (2 17/ 64m O.L. w / 9/ i6"— 18 x n/ i 6" thds)
rear (223/ 64w O.L. w /9/ , 6"— 18 x 3A" thds.) front (229/ 64" O.L. W /V 2 "— 20 thds) ..........
rear (229/ 64" O.L. w /V 8"— 18 x 21/ 32" thds) f r o n t ..........................................................................
front (229/ 64w O.L. w /V 8"— 18 thds.)
f r o n t ............................................................................front brake (11/a" O.D. w /19/ 32w hole— hook
e n d ) ............................ , ...........................................f r o n t ............................................................................
BOLT, parking (1/ 2"— 20 x 2) . . . .
CLIP, lever pivot pin ..........................
LOCK, front brake (hole dia. 25/ 32")
LOCK, front brake (hole dia. 11/ i 6") . . . NUT, rear brake pin (9/ i6"— 18 hex.)—
Disc Brakes),73 -75 Nova, C a m a ro ..................................70-71 Camaro,70-71 Nova, Chevelle (exc. Disc Brks.) .7 0 Nova, Chevelle, Camaro w /round
c o v e r................................................... 3 8 2 3 3 6 3 L.H. .7163-69 Chevy, Chevelle, Camaro (exc.
Spl. Spt. Cpe.),72 Chevelle, Nova, Camaro (exc.
Disc Brakes),73-75 Nova, C a m a ro ..................................70-71 Camaro,70-71 Nova, Chevelle (exc. Disc Brks.) .70 Nova, Chevelle, Camaro w /round
Disc B ra k e s ).................................... 5 4 6 2 5 2 6 L.H.64 -72 Chevy, Chevelle, Camaro,73 -75 Chevelle, Camaro, Nova (exc.
Disc B ra k e s ).................................... 5 4 6 2 5 2 7 R.H.65 -69 Pass. (exc. Disc B r a k e ) ......... 5 4 6 1 1 5 6 L.H.65 -69 Pass. (exc. Disc B r a k e ) ......... 5 4 6 1 1 5 7 R.H.
3 .99 LEVER U N IT , w /p aw l (type P, M) (12 x 2)
LEVER UNIT , w /p aw l (type P, M) (12 x 2)
PIVO T, front and rear lever ...............................
P IVO T, front and rear lever ...............................
P IVO T, left, front and rear .................................
P IV O T, right, front and r e a r ...............................
.95 front and rear
.921.13
.94
front and rear ....................................left, front and rear (515/ie" O.L.) right, front and rear (515/ie" O.L.)
5.107 SPRING, Brake Shoe Automatic Adjusting LeverR e fe r to G ro u p 5 .0 2 6 fo r S p r in g U n it.
65 -67 Pass. w /M eta llic Brakes,65 -69 Taxi, Police (exc. Metallic
front and rear override (24V y ' coils— 37/ a" free length) (b lu e ) ..............................................
.27 front and rear return (71/ 2" coils— 11/ 2" free length) (red) ...........................................................
B ra k e s )................................. .. 5 4 6 4 5 0 7 A.R. .63 front and rear override (221/ 32" O.L.— green)(18 coils— 25/ 8" free length) ....................
74 -75 Nova (exc. Disc B rk .)....................... frt. and rear brk. shoe automatic adjusting lever re tu rn ,.............................................................
W /V 2"— 20 x 145/ 64" thds) (Bendix 2 9 4 91 )68-69 Camaro w /D isc Brakes-Front
and R e a r ........................................... 5 4 6 7 2 9 7 2 1.62 SC R EW ASSY., w /n u t adj. pivot ....................63 Chevy ................................................... 3 9 8 1 9 8 1 L.H. 1.30 U NIT , left (Note 1) ................................................64-75 Chevy, Chevelle, Nova,67-69 C a m a ro ................................................. 5 4 7 2 8 4 5 L.H. 3 .06 UN IT , left (Note 1) ....................... ........................64-75 Chevy, Chevelle, Nova,67-69 C a m a ro ................................................. 3 9 8 1 9 8 6 R.H. 2 .20 U N IT , right (Note 1) ..............................................65-70 Pass.......................................................... 3 9 9 7 3 9 9 L.H. 1.30 U N IT , left (Note 1) ................................................65-70 Pass.......................................................... 3 9 9 7 4 0 0 R.H. 1.30 U N IT, right (Note 1) ..............................................71 -75 Pass.,73-75 Chevelle (Sta. W a g .) ....................... 5 4 7 2 6 3 8 L.H. 3 .59 U N IT (type C, G, K, B, 0 , P, M) (Note 1 ) ------71-75 Pass.,73-75 Chevelle (Sta. W a g .) ....................... 5 4 7 2 6 3 9 R.H. 3.59 U N IT (type C, G, K, B, 0 , P, M) (Note 1 ) ------
N O T E 1 U n it c o n ta in s s c re w , n u t, s o c k e t f o r o n e w hee l.75 Chevelle .............................................. 5 4 7 2 8 4 6 R.H. 3 .06 U N IT (9 V 2" brk.) adj. screw rr.............................75 A l l ........................................................... 5 4 6 2 4 9 6 2 .33 W A S H ER , rear brk. shoe adjusting screw
socket
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 ____________5.103-5.110 5-8 REV. 4-76
5.111 SOCKET, Brake Shoe Adjusting ScrewCamaro w /D isc Brakes-Front
5 4 6 5 9 4 8 2 .80and Rear ......................................Monte Carlo w /1 0 bolt cut out
cover,Chevelle, Camaro, Nova . ; . . . . . 5 4 6 7 2 0 4 1 .82 rear (Note 1) .N O T E 1 S ee i l lu s t r a t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.Pass........................................Nova, Camaro, Chevelle
3 8 4 2 9 8 55 4 6 2 9 4 6
.43
.61 rear
62 -6368-6969
5.117 COVER, Brake Adjusting HoleA l l .................................... ...................... 5 4 6 4 8 0 3 2
5.149 LEVER, Parking Brake ShoePass.......................................................... 3 3 8 2 9 9 1Pass.......................................................... 3 3 8 3 0 0 1Vega, M o n z a ...................................... 3 9 8 2 2 2 7 L.H.Vega, M o n z a ..................................... 3 9 8 2 2 2 8 R.H.Pass. (exc. Sta. W ag.),Chevelle (Sta. W a g .) ....................... 2 6 2 0 5 6 9 L.H.Pass. (exc. Sta. W ag.),Chevelle (Sta. W a g .) ....................... 2 6 2 0 5 7 0 R.H.Chevy, Chevelle,Camaro (exc. Disc Brakes, front
and rear),Camaro,Chevelle, Nova (exc. Sta. W ag.) . 2 6 2 0 5 6 5 L.H.Chevy, Chevelle,Camaro (exc. Disc Brakes, front
and rear),Camaro,Chevelle, Nova (exc. Sta. W ag.) . 2 6 2 0 5 6 6 R.H.Pass, w/2.73, 3.08 ratio (exc.
Sta. W ag.) ....................................... 5 4 7 2 5 3 0 L.H.Pass, w/2.73, 3.08 ratio (exc.
Sta. W ag.) ...................................... 5 4 7 2 5 3 1 R.H.Pass. (Sta. W ag.) w/2.73, 3.08,
3.42 ratio,Police, Taxi w/2.73, 3.08, 3.42
ratio .................... .......................... 5 4 7 2 5 2 3 L.H.Pass. (Sta. W ag.) w/2.73, 3.08,
5.150 STRUT, Parking Brake Shoe Lever6 .2 0 LEVER U N IT , w /s tru t (type P, M)
62 -64 Chevy .......... .......................... 6 2 5 6 5 4 1 2 .53 (515/ 32" O .L .) ................................................................65 Chevelle (Spl. Spt. Cpe.),65 -70 Pass. (exc. H.D. chassis, Taxi) . . . 3 8 2 5 5 0 0 A.R. .7165-70 Taxi, P o l ic e ............... ......................... 3 8 4 9 7 6 8 2 .7168-69 Camaro w /D isc Brakes front and
r e a r .................................... ................. 5 4 6 3 5 3 8 R.H. .6271-75 Vega, M o n z a ...................................... 3 9 8 2 2 2 9 L.H. 1.75 includes lock & r o d ................................................71-75 Vega, M o n z a ...................................... 3 9 8 2 2 3 0 R.H. 1.75 includes lock & r o d ................................................
Pass. (exc. Sta. W a g .) ..................... 3 9 8 1 2 3 5 L.H.Pass. (exc. Sta. W a g .) ..................... 3 9 8 1 2 3 6 R.H.Pass. (exc. Sta. W a g .) .................... 3 9 8 1 2 3 7 2Chevelle (exc. Sta. W ag., El
Camino),Chevelle (exc. Sta. W ag., El
Camino, Monte Carlo) ............... 3 9 9 4 3 5 5 L.H.Chevelle (exc. Sta. W ag., El
Camino)Chevelle (exc. Sta. W ag., El
Camino, Monte Carlo) ............... 3 9 9 4 3 5 6 R.H.Chevelle (Sta. W ag.) El Camino,Chevelle (Sta. W ag.), El Camino,
Monte C a r lo .................................... 6 2 7 1 6 1 3 L.H.Chevelle (Sta. W ag.), El Camino,Chevelle (Sta. W ag,), El Camino,
Monte C a r lo .................................... 6 2 7 1 6 1 4 R .H .Monza (140) w /4-S pd . (exc.
N o tc h b a c k )...................................... 3 5 3 9 1 5 1Monza (140) w /5 -S p d ...................... 3 4 6 5 4 1 1Monza (140) (262),Vega (122)
4 .35 BRACKET, rear axle lower control armfr a m e ................................................................
6 .40 BRACKET, rear axle lower control arm6 .40 BRACKET, rear axle lower control arm3 .4 0 BRACKET, rear axle upper control arm
Pass, w /para lle l e d g e s .................. 3 9 5 3 5 8 1 L.H.Pass, w /para lle l e d g e s .................. 3 9 5 3 5 8 2 R.H.Pass. (exc. Sta. W a g .) ..................... 3 9 8 2 8 1 9 A.R.Vega (122),Monza (exc. N o tc h b a c k )............... 3 5 8 0 5 9Pass, w /para lle l e d g e s .................. 3 8 8 1 6 6 0Pass. (exc. Sta. W a g .) ..................... 3 2 5 8 1 0
7 .903.25
4 .40 3.75
1 1.05 1 1.05
3 .40
5.152 2 .7517.402 1 .1 018.25
BRACKET,BRACKET,
rear axle torque arm rear axle torque arm
BRACKET, rear axle torque arm . . ................BRACKET ASSY., upper control arm (333/ 64w
x 3V2") .................................................BRACKET ASSY., left, lower f r a m e .............BRACKET ASSY., right, lower f r a m e ............BRACKET ASSY., upper control a r m ............
Pass, w /ang led edges . ............. 3 9 5 0 2 2 4Pass, w /para lle l e d g e s .................. 3 9 5 0 2 2 2N O T E 2 : W h e n u s e d in p la c e o f 3 9 0 1 6 6 0 o n p a s t m o d e ls re w o rk as fo l lo w s -a n d o n e Vie
V3 2 " d ia . h o le o n e a ch s id e o f m e m b e r to a tta c h , m u ff, t a i l p ip e frt. h a n g e r assy.
BUSHING U N IT , rear axle torque arm . . . . .M EM B ER , upper cross— ( 7 . 0 1 2 ) ....................M EM B ER , rear axle upper control arm crossM EM B ER A SSY., upper cross .........................M EM B ER A SSY., upper (Note 2) , ..................
REINFO RCEM EN T, lo w e r .................................REINFO RCEM EN T, upper control arm..........REIN FO R C EM EN T ( 7 .0 3 9 ) .........................REIN FO R C EM EN T, mounting support left .SUPPO RT M O U N TIN G ....................................SUPPO RT M O U N TIN G ....................................SUPPO RT M O U N TIN G , reinforcement left S H IM , rear suspension torq. control arm,
Chevelle ............................................Chevelle w /round cover, Chevelle (exc. spec. perf. susp.)Chevelle ...........................................Pass.......................................................Pass.,Pass. (6 cyl.) ....................................Pass. (327) (exc. Sta. W ag., H.D
Susp),Pass. w /2B C (350) (exc. A.T.,
Sta. W ag., Taxi, Police)Monte Carlo w /1 0 bolt cut out
cover ...........................................Pass.,Pass. (exc. Sta. W a g .) ..................
1 .90 upper (151/64" fia.) lo w e r ,.......................
3 9 9 7 9 7 3 23 8 6 9 8 5 7 43 9 6 4 0 4 3 A.R.
3 9 5 3 5 9 3 1
2 .60 upper (Note 1 ) .............2 .35 lo w e r ...............................3 .85 lower rear, upper rear
3 .95 lower front (2 Vie* O.D.— 2Vz" long)
3 9 5 3 9 5 9
3 8 8 2 6 5
3.95 rear axle upper
3.55 upper (Note 1) .
4 8 0 5 5 4 1
71-75 Pass, w /2 .7 3 , 3 .0 8 , 3 .42 ratio (exc. Sta. W ag.),
3.85 rear axle upper and lower control arm to frame bracket assy...........................................
75 Nova ............................................ 4 8 2 0 2 6 2 3 .85 (type P, B, 0 , M) rr. axle upper control arm .71-75 Pass. (exc. Sta. W a g .) .................. 4 8 3 1 0 2 2 3.85 rr. axle upper control arm (type G, C, K) . . . .71 -72 Chevelle w /spec. perf. susp. . . . 1 3 7 1 3 6 8 2 3 .1 5 rear axle upper control arm ..............................71 -74 V e g a ............................ ....................... 3 9 7 8 0 6 0 4 1.65 upper control a r m ...................................................71-75 Vega, M o n z a ............................ 3 9 9 7 9 7 3 2 2 .60 upper control arm (rear) ......................................71-75 Vega, M o n z a .................................... 3 9 8 8 0 6 4 2 2 .10 lower control arm (rear) ......................................73-75 Chevelle ............................................ rear axle lower control arm, ..............................
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 ____________5.380-5.381 5-10 REV. 4-76
BRAKES—REAR AXLE AND DRIVE
5.381 BUSHING ASSY.-— WASHER, Rear Axle Control Arm (Con't)73-75 Chevelle (exc. Sta. W ag., Monte
Carlo) ................................................. 4 8 4 3 7 3 1 3.95 rear axle upper control arm ..........................73 Pass.,73 -75 Chevelle (Sta. W a g .) ....................... 4 8 9 0 9 2 1 3 .25 rear axle upper control arm ...............................73 Monte Carlo ...................................... 4 9 0 5 3 1 2 3 .90 rear axle upper control arm ...............................74 Chevelle (exc. Sta. W ag., S.S.,
H D Susp.) . . 4 9 0 5 2 6 1 4 .20 rear axle upper control arm ...............................75 Pass. (exc. Sta. W a g .) .................... 4 9 8 8 2 7 2 3 .90 upper control arm to c a r r ie r ...............................75 Vega (122),75 M o n z a ................................................... 3 4 6 5 6 2 2 .52 W A S H ER , rear axle torque arm bushing . . .
N O T E 1 S ee i l lu s t ra t io n p re c e d in g G ro up 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
5.382 ARM ASSY.— REINFORCEMENT, Rear Axle Control64-67 Chevelle .............................................. 3 8 6 9 8 5 3 A.R. 8 .90 upper, left or r ig h t ...................................................64 -68 Chevelle,69-71 Chevelle (exc. Spec. Per. Susp ),70 -72 Monte Carlo (exc. 454 ),72 Chevelle (exc. Spec. Perf. Susp.) 9 7 9 1 7 7 3 2 20 .1565 Chevelle (spec. Spt. Coupe)
Sta. W ag., H.D. Susp.),66 Pass. w /H .D . Suspension,66 Pass, w /3 arm Suspension . . . . . 3 8 5 6 3 8 6 A.R. 9 .1066 Sta. W ag.,65-68 Pass.,69-70 Pass. (6 c y l . ) ...................................... 3 9 5 3 5 9 2 2 12.75 lower (Note 3 ) ...........................................................
N O T E 3 W h e n u s in g fo r S p e c ia l P e rfo rm a n c e S u s p e n s io n , d r i l l 3 h o le s fo r s ta b il iz e r b a r a tta c h m e n t.67-70 Pass.......................................................... 3 9 0 0 5 4 3 A.R 9 .1 068-72 Chevelle (exc. Spec. Perf. Susp.) 9 7 9 0 9 7 9 A.R. 8 .9069-72 Chevelle w /S pec. Perf. Susp.,70 -72 Monte Carlo (454 ) .......................... 3 9 3 7 8 7 7 2 2 0 .6 069 Pass. (327) (exc. Taxi, Police,
Sta. W ag.),70 Pass. w /2B C (350) (exc. A.T.,
Sta. W ag., Taxi, Police) ............. 3 9 5 3 9 5 7 1 9.2569 -70 Pass. (8 c y l . ) ...................................... 3 9 5 3 9 6 4 2 12.7571 -72 Chevelle w /spec. perf. susp.......... 9 7 8 9 3 3 2 R.H. 8 .3071-72 Chevelle w /spec. perf. susp.......... 9 7 8 9 3 3 3 L.H. 8 .3071-75 Pass. (exc. Sta. W a g .) ..................... 4 9 4 4 1 7 2 14.7071-75 Pass. (exc. Sta. W a g .) ..................... 4 8 3 1 0 6 2 13.90 upper ............................................................................71 -75 Vega,75 M o n z a ................................................... 3 4 9 56 1 2 12.00 lower control (repl. 3 9 7 8 0 3 4 ) .........................71 -75 V e g a ...................................................... 3 9 7 8 0 5 8 2 11.05 upper c o n tro l............................ .................................73 Monte Carlo,74 -75 Chevelle (exc. Sta. W ag., S.S.,
.46 (Vie"— 12 x 4") (hex.) ........................rear suspension upper control a r m ..................hex. red body (Vie*"— 12 x 65/ 8") rear axle
to r q u e .......... .............................................................C LA M P , rr. axle lower control arm spring . . D A M PE R U N IT (rear axle noise) (less yoke)
(Note 1 ) .....................................................................a rm d a m p e r w e ig h ts , 2 ta p p in g p la te s 2 V 16" x 1s/ 8 " b o lts , 2 s/ i 6 ,f lo c k
3 7 9 1 8 5 5 2 .34 N UT (n/ i 6" x '18)— ( 6 . 1 7 2 ) ...................................3 6 9 1 5 3 0 A.R. .16 NUT, lower end (V2"— 2 0 ) ...................................
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 _____ _______REV. 4-76 5-11 5.381-5.383
BRAKES—REAR AXLE AND DRIVE
5.383 BOLT— CLAMP— DAMPER UNIT— NUT— SPACER— WASHER, Rear Axle Control Arm (Con't)
65-69 3 8 6 6 7 6 6 A.R. .12 N UT (Vs"— 24)— ( 0 .6 2 6 ) ....................................66 9 4 2 2 3 0 4 2 .22 N UT (Vie"— 18)— (8.917) .................................66 -69 Pass. w /H .D . Suspension ............. 3 8 8 8 7 2 7 2 .70 SPACER, lo w e r ........................................................68 Impala w /H .D . Suspension (exc.
Conv., Sta. W ag.) .......................... 3 8 8 8 7 2 5 8 .16 SPACER ( 7 .2 4 3 ) .....................................................70 Pass. w /3-S pd . (350) ..................... 3 9 8 1 2 9 7 1 .16 W A S H E R , lower control arm bolt right front
5.387 HOUSING— VENTILATOR, Rear Axle65-70 Pass, w /1 2 bolt cover .................. 3 9 8 1 6 6 7 1 159 .0066-70 Pass, w /1 0 bolt cover .................. 3 9 8 1 6 6 6 1 159 .0067-69 Camaro,68-69 Chevy,70-71 Chevy w /sing le leaf s p r in g .......... 3 9 8 1 6 7 0 1 1 27 .00 (w /1 0 bolt cover) ...................................................67 C a m a ro ................................................. 3 9 2 1 1 8 9 1 124 .00 (w /1 2 bolt cover) ...................................................68-71 Chevy,68-69 Camaro (exc. Disc Brks. front
and re a r ) ............................................ 3 9 8 1 6 7 2 1 127 .0 0 (w /1 2 bolt cover) ............................ ......................68-72 Chevelle .............................................. 3 9 8 1 6 6 9 i 127 .00 (w /1 2 bolt cover) w /spacer ...............................68-69 Camaro w /D isc Brks. (front and
rear) ................................................... 3 9 6 1 3 4 0 1 131 .00 (w /1 2 bolt cover) ...................................................68 -72 Chevelle w /1 0 bolt round c o v e r. 3 9 8 1 6 6 8 1 127.00 w /spacer (Note 1) .....................................................69 Chevy, Camaro w /m u lti leaf
s p r in g ................................................. 3 9 8 1 9 0 0 1 112 .00 (w /1 0 bolt cover) ...................................................70 Monte Cario w /1 0 bolt cut out
cover ................................................... 4 7 9 7 2 4 1 122 .00 (Note 1 ) .......................................................................N O T E 1 See i l lu s t ra t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cover.
70-71 Nova w /1 0 bolt cover .................. 3 9 8 1 6 7 1 1 1 27 .00 (multi leaf spring) (Note 2) ................................N O T E 2 U s e d w /H .D . a x le w /s m a ll r in g g e a r. A ls o u s e d o n 1 9 6 9 C hevy, C am aro .
70 Camaro (multi-leaf spring w /1 0bolt cover) ................................. 3 9 8 1 9 7 1 1 135 .00
70 Camaro w /1 2 bolt cover ............. 3 9 8 1 9 7 2 1 127 .0071-75 C a m a ro ................................................. 3 9 9 7 5 7 3 1 134 .0071-75 Pass, w /2 .7 3 , 3 .08 , 3 .4 2 ratio
(exc. Sta. W ag.) ............................ 1 2 3 5 2 7 4 A.R. 2 1 7 .0 0 (type B, O) (8 V 2" dia. ring gear) .......................71-75 Pass, w /2 .7 3 , 3 .08, ratio (exc.
Sta. Wag.) ...................................... 3 9 9 3 4 6 2 A.R. 165 .00 diff. housing and axle tube assy, (type G, C,K) (8 V 2" dia. ring g e a r ) ......................................
71 -75 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio(exc. Sta. W ag.) ............................ 4 9 5 9 0 4 1 122 .00 w /d iff. carrier (type P, M) (coil s p r in g ) ..........
71-75 Pass. (Sta. W ag.) w /2 .7 3 , 3 .08 ,3 .42 r a t io ......................................... 4 9 5 9 0 5 1 127 .00 w /d iff. carrier (type P, M) (leaf s p r in g )..........
71-75 Vega (140) ......................................... 6 2 7 2 1 7 2 1 155 .00 w /spacer (6 V 2" dia. ring gear) ..........................72 Nova ...................................................... 1 2 3 8 0 7 0 1 127 .00 w /spacer (mono-leaf s p r in g ) ...............................72-73 Nova ...................................... .............. 1 2 3 80 7 1 1 127 .00 w /spacer (multi-leaf spring) ...............................73 -75 Chevelle (Sta. W a g .) ....................... 4 9 5 9 0 6 1 115 .0 0 diff. housing and axle tube assy, (type P, M)73-75 Chevelle, Monte Carlo (exc. Sta.
W ag.) ................................................. 1 2 3 8 0 6 8 1 2 0 4 .0 0 diff. housing and axle tube assy, (type C, K,G, W ) (round cover) ...........................................
74-75 Nova ...................................................... 1 2 4 5 2 6 0 1 1 27 .0074 Vega (122) ......................................... 3 4 5 6 0 6 1 173 .00 w /spacer .....................................................................75 Vega (122), M o n z a .......................... 2 3 1 9 5 6 1 160.00 (7 V 2" dia. ring gear w /torque arm)
w /s p a c e r .................... r ................................75 Vega (122), M o n z a .......................... 2 3 1 9 5 7 1 156 .00 w /spacer (7 V 2" dia. ring gear w /4 link) . . . .62 -70 All,71 Chevelle, Nova,71-75 Vega, Monza,72-75 Chevelle .............................................. 3 8 2 0 8 4 0 1 .36 VENTILATO R (6 1/ 2\ 7 V 2", 87/a" ring gear) .71 Pass., Camaro,72-75 Pass., Camaro, Nova, Chevelle . . 1 2 3 6 3 1 7 1 .43 VENTILATO R, diff. carrier (8 1/ 2" ring gear) .
5.394 SPACER— RETAINER, Rear Axle Bumper64-70 Chevelle (Sta. W ag., El Camino) . 9 7 9 3 6 3 7 L.H. 1.5074 Nova (exc. P / S ) ................................. 3 4 4 6 5 5 2 .8774-75 Pass. (exc. Sta. W a g .) ..................... 4 8 3 4 3 2 R.H. 2 .6574-75 Pass. (exc. Sta. W a g .) ..................... 4 8 3 4 3 3 L.H. 2.6575 Vega (122) ......................................... 3 6 0 3 5 4 2 2 .00 RETAINER, rear a x le ..............................................
Chevelle (exc. Monte Carlo, Sta.W ag.) ..............................................
Pass.,Chevelle (Sta. W a g .) .....................Pass.......................................................Pass.,Chevelle,Chevelle (exc. Monte Carlo) . . .Pass. (exc. Sta. W a g .) ..................Pass. (Sta. W ag.) ..........................Monte Carlo,Chevelle (Sta. W ag.),Chevelle ............................................Pass. (Sta. W ag.),Chevelle ............................................Camaro,Chevy,Nova, Camaro,Vega (122) ___Camaro w /4-S pd .
9 7 7 3 0 7 3 2
9 7 7 0 7 8 03 8 6 9 8 4 5
5 3 5 7 5 7 14 8 2 0 2 2 24 8 1 8 6 0 2
3 9 8 7 8 1 9 2
4 8 5 1 2 8 2
4 8 1 8 3 4 1
1.00
.57 pinion nose
.98
1.25 pinion nose (3 V 64" O.L.).92 rear axle ............................
5.398 COVER— SCREW, Axle Housing with I6 4-72 All w /1 0 bolt round cover,73 -75 Pass., Chevelle, Camaro,75 Nova ...................................................... 4 1 0 9 1 7 1 2.85
65 -70 All w /1 2 bolt cover,7 1 -72 Chevelle, Nova w /1 2 bolt cover . 3 9 7 6 8 5 7 1 2 .807 0 Monte Carlo w /c u t out cover . . . 9 7 7 7 0 3 5 1 3 .5571-75 Pass, w /2 .7 3 * 3 .0 8 , 3 .4 2 ratio,73 -75 Chevelle (Sta. W a g .) ....................... 9 7 9 0 5 3 8 1 4.8571 -74 Vega (140) ......................................... 3 9 7 4 8 7 8 1 2.3574 Vega (122) ......................................... 3 4 5 6 3 8 1 4.9075 Monza, Vega ( 1 2 2 ) .......................... 5 5 1 6 1 9 1 4.0570 Monte Carlo w /cu t out cover,71-75 Chevelle, Camaro,71-75 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio,72-75 Nova,75 Vega (122) Monza .......................... 3 8 4 95 1 10 .1 1
BUMPER ASSY., radius rod s to p ..................BUMPER ASSY., torque control arm (213/ 32"
high x 151/ 64w wide), .........................................pinion nose .............................................................
BUMPER ASSY., pinion nose (special) . . .BUMPER ASSY., p in io n ....................................BUMPER ASSY., pinion n o s e .........................BUM PER A SSY., pinion n o s e ..........................BUM PER A SSY., pinion n o s e ..........................
BRACKET, pinion nose bumper support(type P, M) ........................................................
C U S H IO N , under body to fram e— (9.023)
STOP, radius rod
(type C, G, K, B, O) (Note 1) (8 W ' dia. ring gear) .......................................................................
Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio, Chevelle (Sta. W a g .) .................... 1 4 8 0 2 9 4 1
6 5 0 5 1 6 10
.38
.16Vega (122) ......................................N O T E 1 S ee i l lu s t ra t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t if ic a t io n o f a x le cove r.
SCR EW (5/ , 6"— 18 x 15/ i6") (type G, K, B, 0 ) (Note 1) diff. carrier cover (7 V 2", 8 V 2" dia. ring gear) ................................................................
SCR EW , diff. carrier cover assy, oil filler(type P, M) (87/ b" dia. ring g e a r ) ....................
SCR EW , diff. carrier c o v e r .................................
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 ____________REV. 4-76 5-13 5.395-5.398
5.399 GASKET, Axle Housing Cover (Cork)All w /1 0 bolt round cover,Chevelle w /1 0 bolt round cover,Nova w /1 0 bolt round cover . . .All w /1 2 bolt cover,Chevelle w /1 2 bolt cover,Nova w /1 2 bolt cover ..................Monte Carlo w /c u t out cover . . .Pass, w /2 .7 3 , 3 .08 , 3 .4 2 ratio,Chevelle (Sta. W a g .) .......................Pass, w /2 .7 3 , 3 .08 r a t io ............... 1 2 3 4 4 8 2Camaro,Camaro, Nova, Chevelle,Pass, w /2 .7 3 , 3 .08 ra t io ..........
3 9 3 1 1 5 1 1
3 9 3 1 1 5 2 19 7 7 5 6 8 3 1
9 7 7 8 1 9 2 11
3 9 9 3 5 9 3 1
.80 (Note 1)
Vega (140)Vega (122)Vega (122), Monza
3 9 7 4 8 7 93 4 5 6 3 23 4 4 1 7 2
.80
.97
1.401.10
1.10
.70
.70
.76
(Note 1)
(type P, M) (87/a" dia. ring gear) (type B, 0 ) (plain) .........................
(61/ 2" dia. ring gear) ...........................................
(71/ 2" dia. ring gear)N O T E 1: S ee i l lu s tra t io n p re c e d in g G ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
5.400 PLUG— GASKET— SCREW— TAG, Axle Filler and DrainChevy .............All w /P /T rac . All w /P /T rac . Pass...................
Pass. w /P /T rac . (exc. Sta. W ag.), Chevelle, Nova, Camaro
w /P /T rac .,Pass. w /P /T rac .,All w /P /T ra c ........................................All (exc. P /T ra c .) ...............................Vega (122) .........................................A l l ...........................................................
Chevy ...................................................Pass, w /2 .7 3 , 3.08, 3 .42 ratio,Chevelle (Sta. W a g .) .......................A l l ...........................................................All w /P /T ra c ........................................
GASKET, drain screw (V 2" I.D. x 15/ , 6"O.D.)— (1 .456) ...................................................
GASKET, filler (leather) (1" I.D. x 10" O.D.)
GASKET (type P, M ) .......................SCR EW , drain (1/ 2 20 x 13/ i6")- TA G , axle lub. ident..........................
(1 .453)
5.410 CABLE ASSY.— SPACER, Rear Axle Lateral Movement-(Stop)Vega (122) ......................................... 3 3 9 0 8 9 2 4 .00 re s tra in t.....................................
5.415 ROD ASSY., Rear AxlePass.......................................................... 3 8 5 6 3 9 6 1 19 .00 tie w /bushings (Note 1) . .N O T E 1: I t m a y b e n e c e s s a ry to use s tu d 3 9 0 1 7 3 6 , lo c a te d in G ro u p 5 .4 1 8 .Vega (122), M o n z a .......................... 3 4 6 5 7 7 1 2 0 .4 0
Chevy ....................... ............................ 3 7 9 06 0 4 R .H .ChevyChevelle ..............................................Chevelle, Camaro w /1 0 bolt
cover,Chevy, Camaro w /1 0 bolt cover,Nova w /1 0 bolt cover ..................Chevy w /1 0 bolt c o v e r ..................Chevy w /1 2 bolt c o v e r ..................Chevelle w /1 2 bolt cover,Camaro w /1 2 bolt cover (exc.
Disc Brks. frt. and rear),Chevy w /1 2 bolt c o v e r ..................Pass, w /1 2 bolt cover ..................Pass, w /1 0 bolt cover ..................Pass, w /1 0 bolt cover ..................Chevelle w /1 0 bolt round cover,Camaro w /1 0 bolt cover .............Chevelle w /1 2 bolt round cover,Camaro w /1 2 bolt cover .............Camaro w /D isc Brakes front and
rear (12 bolt cover) ....................Monte Carlo w /c u t out cover . . . Pass, w /2 .7 3 , 3 .0 8 , 3 .4 2 ratio . . Pass, w /2 .7 3 , 3 .0 8 , 3 .4 2 ratio
(exc. Sta. W ag.) ............................Pass, w /2 .7 3 , 3 .08 , 3 .23 ratio
(exc. Sta. W ag.) ............................Vega (140) .........................................Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio . . Chevelle (Sta. W ag.) w /2 .7 3 ,
3 .08, 3 .42 ratio ............................Chevelle w /2 .7 3 , 3 .08 , 3 .42
ratio (exc. Sta. W ag.) ..................Chevelle ..............................................Vega (122) .........................................Vega (122), M o n z a ..........................Nova w /1 0 bolt cover ..................Camaro w /1 0 bolt cover .............N O T E 7; S ee i l lu s t ra t io n p re c e d in g
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 ---------------------REV. 4-76 5-15 5.417-5.420
BRAKES—REAR AXLE AND DRIVE
5.422 LOCK, Axle Shaft64-75 A l l ........................................................70 -75 A l l ........................................................70-75 A l l ........................................................71 -75 Vega (140) ......................................75 Vega (122), M o n z a .......................
N O TE 1 C o n ta in s t ru n n io n assy., 4 b e a r in g assys., 4 U - jo in t s n a p r in g s , 2 b o lts , 4 nu ts , 4 w a s h e r a n d 2 sea ls .
62-69 A l l ........................................................... 1 3 5 8 9 3 8 4 .55
.12 ROLLER, differential carrier (13/ 32" O.L. x V 32" dia.) (black oxide coated)— (5 .566)
62-7271-7273-7562-68
65-7069-7269-7270-7271-75 74
62-65
65-70
7171-7266-70 7171-7270 75
71-7571-72
72-7573-75 71-75 71-75 66-707171-7266-707171-72
7.81 (Hy A -200248-Z )
w /ro ller (Hy A -200233-Z ) drive pinion, f r o n t .............
.40 (1 15/64w I.D. x 13/ 8" O.D.)
SHAFT, Rear Propeller (Shaft attaches to rear axle)N O T E A H th e p a r ts fo rm e r ly in th is g ro u p h a ve b e e n re lo c a te d a n d re g ro u p e d in to 5 .5 4 4 . S ee G ro u p 5 .5 4 4
bolt cover,Pass, w /1 0 bolt cover,Camaro w /1 0 bolt cover,Chevelle w /1 0 bolt cover,Nova w /1 0 bolt cover,Vega, M o n z a ...................................... 7 4 5 1 2 0 2 A .R . 7 .55Vega (122) ......................................... 9 4 3 6 1 2 7 1 11.90
5.453 SPACER— WASHER, Pinion Shaft BearingAll (3 arm suspension, w /1 0
bolt cover) ...................................... 3 8 4 9 4 1 4 A.R.All (4 arm suspension w /1 2 bolt
cover),Nova w /1 2 bolt cover,Chevelle w /1 2 bolt c o v e r ........... 3 9 5 4 4 8 0 A.R.All w /1 0 bolt round cover,Nova w /1 0 bolt cover,Chevelle w /1 0 bolt c o v e r ............. 3 9 5 4 4 7 8 A .R . .93 (Note 1) . . . .Monte Carlo w /c u t out cover,Vega 122, M o n z a ............................ 9 7 8 5 7 9 2 1 .63 (Note 1 ) ___N O T E 1 S ee i l lu s t ra t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.Camaro,Pass, w /2 .7 3 , 3 .08 ratio (exc.
Sta. Wag.),Nova, Chevelle,Pass, w /2 .7 3 , 3 .08 , 3 .23 ratio . .Pass, w /2 .7 3 , 3 .08, 3 .42 ratio . . 1 2 3 4 7 2 6 1V e g a ...................................................... 3 9 7 4 8 9 8 1All w /1 2 bolt cover,Nova w /1 2 bolt cover,Chevelle w /1 2 bolt c o v e r ............. 3 8 8 6 3 1 8 A .R .All w /1 0 bolt cover,Nova w /1 0 bolt cover,Chevelle w /1 0 bolt cover . . . .
1.05 (221/64" O.L.)
.61
.87
(type G, K, B, 0 ),(type P, M ) ..................(6V 2" dia. ring gear)
front (.003) front (.005) front (.010) front (.030) rear (.003) . rear (.005) . rear (.010) .
SHIM UNIT (.021 -.026 ) O.D. x 129/ 6<I.D.) .......................................................................
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 ____________5.422-5.460 5-16 REV. 4-76
BRAKES—REAR AXLE AND DRIVE5.460 SHIMf Pinion Shaft Bearing (Con't)
64-70 All w / 10 bolt round cover,71 Nova w /1 0 bolt cover,71 -72 Chevelle w /1 0 bolt c o v e r ............. 3 8 9 3 5 8 5 A.R. 1.70 S H IM U N IT (.027-.032) (2 V 64" O.D. x 129/ 64w
I.D.) ........................................... .................................64 -70 All w /1 0 bolt round cover,71 Nova w /1 0 bolt cover,71 -72 Chevelle w /1 0 bolt c o v e r ............. 3 8 9 3 5 8 3 A.R. 1.35 S H IM U N IT (.033 -.037 ) (2 V M" O.D. x 129/e4”
I.D.) ............................................................................65 -70 All w /1 2 bolt round cover,71 Nova w /1 2 bolt cover,71 Chevelle w /1 2 bolt c o v e r ............. 3 8 9 3 5 8 2 A.R. 1.70 S H IM U N IT (.021 -.026 ) (224/ M" O.D. x 141/ 64"
l-D.) ............................................................................65 -70 All w /1 2 bolt round cover,71 Nova w /1 2 bolt cover,71 -72 Chevelle w /1 2 bolt c o v e r ............. 3 8 9 3 5 8 7 A.R. 1.70 S H IM U N IT (.027 -.032 ) (2M/« " O.D. x 14l/„ "
I.D.) ............................................................................65 -70 All w /1 2 bolt round cover,71 Nova w /1 2 bolt cover,71-72 Chevelle w /1 2 bolt c o v e r ............. 3 8 9 3 5 8 6 A.R. 2 .00 S H IM U N IT (.033-.037) (224/ 64" O.D. x V V M"
l-D.) .............................................................................70 Monte Carlo w /c u t out cover,71-75 Camaro,71 -72 Pass, w /2 .7 3 , 3 .08 , 3 .4 2 ratio
ratio ................................................... 1 3 9 4 8 9 2 A.R. .57 S H IM U N IT (.020 -.024) (type C, B, 0 , G, K) .70 Monte Carlo,71 -75 Camaro,71 -72 Pass, w /2 .7 3 , 3 .0 8 , 3 .4 2 ratio
ratio ................................................... 1 3 9 4 8 9 3 A.R. .57 S H IM U N IT (.025-.029) (type C, B, 0 , G, K) .70 Monte Carlo,71 -75 Camaro,7 1 -72 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio
ratio ................................................... 1 3 9 4 8 9 4 A.R. .84 S H IM U N IT (.030-.034 ) (type C, B, 0 , G, K) .7 0 Monte Carlo,71 -75 Camaro,71 -72 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio
ratio ................................................... 1 3 9 4 8 9 5 A.R. .82 S H IM U N IT (.035-.039) (type B, 0 , G, K)71-75 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio,73-75 Chevelle (Sta. W a g .) ....................... 4 8 4 3 6 5 A.R. .78 S H IM U N IT (.020 -.028 ) (type P, M) ...............71 -75 Pass, w /2 .7 3 , 3 .0 8 , 3 .42 ratio,73 -75 Chevelle (Sta. W a g .) ....................... 4 8 4 3 6 6 A.R. 1.20 S H IM U N IT (.030-.038) (type P, M) ...............71 -75 Vega (140) .................................... 3 9 8 7 3 5 0 A.R. 1.60 S H IM UN IT , pinion shaft bearing
(.021 -.026) (6 V 2" dia. ring gear) ..................71 -75 Vega (140) ......................................... 3 9 8 7 3 5 1 A.R. 1.60 S H IM UN IT , pinion shaft bearing
(.027-.032) (6V 2" dia. ring gear) .............71 -75 Vega (140) ................................. 3 9 8 7 3 5 2 A.R. 1.60 S H IM UN IT , pinion shaft bearing
(.033 -.037 ) (61/ 2" dia. ring gear) ..................75 Vega (122), M o n z a .......................... 3 5 8 8 0 9 A.R. 1.35 S H IM U N IT (.020 -.024 ) (7 V 2" dia. ring gear)75 Vega (122), M o n z a ......................... 3 5 8 8 1 0 A.R. 1.35 S H IM U N IT (.025-.029) (7 V 2" dia. ring gear)75 Vega (122), M o n z a .......................... 3 5 8 81 1 A.R. 1.35 S H IM U N IT (.030-.034) (71/ 2" dia. ring gear)75 Vega (122), M o n z a .......................... 3 5 8 8 1 2 A.R. 1.55 S H IM U N IT (.035-.040) (7 V 2" dia. ring gear)
N O TE : S ee i l lu s t ra t io n p re c e d in g G ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cover.75 Vega (122), M o n z a .......................... 3 5 8 8 1 0 A.R. 1.35 S H IM U N IT (.0 2 5 -0 2 9 ) (7 V 2" dia. ring gear)
5.468 SHIELD, Pinion Flange7 0 Monte Carlo w /c u t out cover . . . 5 4 3 3 1 9 1 .27 (Note 1) . . . .
N O T E 1 S ee i l lu s t ra t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
5 2 2 4 3 3 ) .............................................................N O T E 1 S ee i l lu s t ra t io n p re c e d in g G ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
5.484 BEARING ASSY., Drive Pinion Rear
74 Vega (122)
1 2 4 2 0 6 8
3 9 7 9 6 1 6
62-63 Chevy ................................................... 7 4 5 1 2 0 3 1 10.0264-70 All w /1 0 bolt cover, •71 Nova w /1 0 bolt cover,71-72 Chevelle w /1 0 bolt c o v e r ............. 7 4 5 0 3 7 1 1 11.5664-71 All w /1 2 bolt cover,71 Pass., Camaro (exc. Sta. W ag.),72 Pass. (exc. Sta. W ag.),72 Nova, Camaro,72 Chevelle w /1 2 bolt cover,73 -75 Pass.,73-75 Nova, Camaro,73-75 Chevelle (exc. Sta. W ag.) ............. 7 4 5 1 1 5 5 1 1 1.20 (type G, C, K, B, 0 ) (81/ 2" dia. ring gear) . . .71-75 Pass.,73-75 Chevelle (Sta. W a g .) ....................... 7 4 5 1 4 0 9 1 20 .44 (type P, M) (87/s" dia. ring g e a r ) .......................71 -75 Vega (140) ......................................... 7 4 5 0 9 8 4 1 7.81 pinion gear (6 V 2" dia. ring gear) ....................74 Vega (122) ......................................... 9 4 1 7 7 8 1 1 15.00 pinion gear ................................................................75 Vega (122), M o n z a .......................... 7 4 5 1 9 7 3 1 9 .90 pinion gear (71/ 2" dia. ring gear) ....................
5.506 BOLT, Differential Carrier Cap64-72 All w /round cover,73 -75 A l l ........................................................... 3 8 1 8 7 6 4 4 .27 (bearing cap to carrier) (Note 1 ) .......................70 Monte Carlo w /c u t out cover . . . 9 7 8 3 1 9 7 4 .32 (Note 1 ) .......................................................................74 Vega (122) ......................................... 3 4 5 6 3 6 2 .26
N O T E 1 S ee i l lu s t ra t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
5.508 GASKET, Axle Housing to Differential Carrier (paper)62-63 Chevy ................................................... 3 7 6 9 8 7 0 1 .66 (9 ,3/ V x 1 1V 8")
5.510 CASE, Differential and PlanetN O T E D if fe re n t ia l ca se h a lv e s a re n o t s o ld s e p a ra te ly .
Differential Assy. (Case with internal gears)Chevy, Chevelle w /P /T ra c . 3 .0 8 ,
68 -69 Camaro w /d isc brks. (front and rear) (3 .07 , 3 .3 1 , 3 .5 5 , 3 .73r a t io ) ................................................... 3 9 4 7 2 8 0 1
71-72 Chevelle w /P /T ra c ........................... 3 9 9 3 5 1 8 1
7 1 -72 Pass. (P/Trac. w /2 .7 3 , 3 .08ratio),
7 1 -72 Police, Taxi (P/Trac. w /3 .0 8r a t io ) ................................................... 4 8 8 3 7 3 1
71 Pass. (P/Trac. w /3 .42 ratio),71 Police, Taxi (P/Trac. w /3 .42
ra t io ) ................................................... 4 8 2 1 5 6 171-75 Vega (140) w /P /T ra c ...................... 3 9 9 7 9 9 0 1
71-72 Pass., Camaro w /P /T rac . (exc.Sta. W ag.),
71-75 Camaro w /P /T rac .,72-75 Nova w /P /T rac .,73-75 Chevelle w /P /T rac .,73-75 Pass. w /P /T ra c ................................... 4 0 7 8 9 1 1
72 Pass. (P/Trac. w /3 .42 ratio),72 Police, Taxi (P/Trac. w /3 .42
ra t io ) ................................................... 4 8 8 3 7 4 173-75 Chevelle (Sta. W ag.) w /P /T rac . .73 -75 Pass. w /P /T ra c ................................... 4 9 0 7 7 6 1
73-75 Chevelle (Sta. W ag.) w /P /T rac . .73 -75 Pass. w /P /T ra c ................................... 4 9 0 7 7 7 1
7 4 Vega (122) w /P /T ra c ...................... 3 4 5 6 0 4 175 Vega (122), Monza (P/Trac.
w /3 .42 , 3 .73 ra t io )....................... 3 4 5 9 3 8 1
145 .0 0 w /3 .0 7 , 3 .31 , 3 .55 , 3 .73 ratio (Eaton12666-7) use w /1 2 bolt cover (Note 2)
170 .00 (type P, M ) ..................................................................w /2 .7 3 , 3 .08 ratio (type P, M ) , .........................
1 70 .00 w /2 .7 3 , 3 .08 ratio (type P, M) (87/ a" dia.ring gear) ............. ............................
w /3 .42 ratio (type P, M ) , ......................................170 .00 w /3 .42 ratio (type P, M) (87/ 8" dia. ring
gear) .....................................................................151 .00 diff. and planet, w /internal gears (Note 1) . .
126 .00 diff. and planet, w /internal gears (71/ 2" dia.ring gear) (Note 1) ........................ .....................
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 _________REV. 4-76 5-19 5.510-5.510
BRAKES—REAR AXLE AND DRIVE
75
7575
75
64-70
71
72
65-69
65
67
68-69
70
71-72
65-69
65-6665-69
6565
66-6866-67
67-69
69
70
70
71
72
65-70
65-70
67-70
67-69
71
72
65-70
65-70
5.510 CASE, Differential and Planet (Con't)Vega (122), Monza (P/Trac.
w /2 .2 9 , 2 .56 , 2 .93 r a t io ) ........... 3 5 2 9 5 2 1 1 2 6 .0 0 diff. and planet, w /internal gears (71/ 2" dia.ring gear) (Note 1) ..............................................
Pass. w /P /T rac .,Chevelle (Sta. Wag.) w /P /T ra c . . 4 9 6 9 4 0 1 1 41 .00 w /2 .56 ratio (type P, M) (87/ 8" dia. ring
gear) ..........................................................................All w /P /T ra c ....................... .............. 4 0 7 8 9 0 1 1 7 2 .0 0 w /2 .5 6 ratio (type C, G, K, W , B, 0 ) (8 W '
dia. ring g e a r ) ........................................................N O T E 1: In te rn a l p o s it ra c t io n p a r ts n o t s e rv ic e d s e p a ra te ly .N O T E 1 U se w ith 10 b o l t cove r.N O T E 2 U se w ith 12 b o lt cove r.N O T E 3 S ee i l lu s t ra t io n p re c e d in g g ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
Differential Case (Case less internal gears)All (3 .08 , 3 .36 , 3 .55 , 3 .7 0 ratio)
(exc. P/Trac.),All w /3 .0 8 , 3 .3 6 ratio (exc.
Pass., P/Trac.),Chevelle w /3 .3 6 ratio (exc. t
P /T ra c .) .............................................. 3 9 5 8 1 0 9 1 3 3 .5 0 w /1 0 bolt round cover (8 V a" dia. ring gear)(Note 1 ) .....................................................................
5.510 CASE, Differential and Planet71-72 Pass, w /2 .7 3 , 3 .08 , 3 .4 2 ratio
(exc. Sta. W ag. P/Trac.),73 -75 All w /2 .7 3 , 3 .0 8 , 3 .42 ratio (exc.
P /T ra c .).............................................. 1 2 3 4 4 9 5 172-74 Pass. (2 .73 , 3 .08 ratio
w /P /Trac.),73-74 Chevelle (Sta. W ag.) (2 .73 , 3 .08
ratio w /P /T rac .) ............................ 9 7 9 2 7 1 3 172-74 Pass. (3 .42 ratio w /P /T rac .),73 -74 Chevelle (Sta. W ag.) (3 .42 ratio
w /P /T rac .) ...................................... 9 7 9 2 7 1 4 172-75 All w /P /T ra c ......................................... 4 0 7 7 2 5 1
(Con't)
54 .75 (type G, C, K, B, 0 , W ) (8 V 2" dia. ring gear)
64 .75 (type P, M) (87/ a" dia. ring gear)
7474
74
74
74
75 75
75
75
75
75
75
75
75
75
7575
75
75
Vega (122) (exc. P/Trac.) Chevelle (Sta. W ag.) (exc.
P/Trac.),Pass. (exc. P /T ra c .) ..........
Chevelle (Sta. W ag.) (exc.P/Trac.),
Pass. (exc. P /T ra c .) ..........
3 4 5 6 2 0 1
4 9 1 0 8 7 1
4 9 1 0 8 8 1
Pass. (2 .56 ratio w /P /T rac .), Chevelle (Sta. W ag.) (2 .56 ratio
w /P /T rac .) ....................................All w /P /T rac . (exc. P a s s .) ..........
9 7 9 2 7 1 22 3 1 2 6 2
All (exc. P/Trac.)
Chevelle (Sta. W ag.) (exc.P/Trac.),
Pass. (exc. P /T ra c .) ..........
Chevelle (Sta. W ag.) (exc.P/Trac.),
Pass. (exc. P /T r a c .) ..........
Pass. (2 .73 , 3 .08 ratio w /P /Trac .),
Chevelle (Sta. W ag.) (2 .73 , 3 .08ratio w /P /T rac .) ............................
Pass. (3 .42 ratio w /P /T rac .), Chevelle (Sta. W ag.) (3 .42 ratio
w /P /T rac .) ......................................Vega (122 ) Monza w /3 .4 2 , 3 .73
ratio (exc. P/Trac.) .......................Vega (122 ) Monza w /2 .2 9 , 2 .56,
2.93 ratio (exc. P/Trac.) . . . .
1 2 3 4 4 9 4 1
4 8 8 7 9 3 1
4 8 8 7 9 2 1
4 8 8 3 7 3 1
64 .756 9 .0 0
44 .25
7 3 .50
7 3 .50
1 0 1 .001 5 2 .00
5 2 .00
61 .25
61 .25
(type P, M) (87/ a" dia. ring g e a r ) .......................(Olds, type) (type B, 0 ) (81/ 2" dia. ring gear)
(exc. 2 .56 ra t io ).....................................................less internal g e a rs ...................................................
w /2 .7 3 , 3 .08 ratio (type P, M) (87/ a" dia. ring gear) ........................................................
w /3 .4 2 ratio (type P, M) (87/ a" dia. ring gear) ................................................................
(type P, M) (87/ a" dia. ring g e a r ) ....................w /2 .5 6 ratio (type B, 0 , C, G, K, W ) (8 V 2"
dia. ring g e a r ) .....................................................w /2 .5 6 ratio) (type B, 0 , C, G, K, W ) (8 V 2"
dia. ring g e a r ) .....................................................
w /3 .4 2 ratio (type P, M) (87/ a" dia. ring gear) ..................................................."...........
w /2 .7 3 , 3 .08 ratio (type P, M) (87/ a" dia. ring gear) ........................................................
17 0 .0 0 (type P, M) (87/ a" dia. ring gear)
4 8 8 3 7 4
3 4 4 1 6 3
3 5 2 9 5 1 1
17 0 .0 0 (type P, M) (87/ a" dia. ring g e a r ) .......................
4 0 .0 0 less internal gears (71/ 2" dia. ring gear) . . . .
4 0 .0 0 less internal gears (71/ 2" dia. ring gear)N O TE 1 S ee i l lu s t ra t io n p re c e d in g G ro u p 5 .3 9 8 fo r id e n t if ic a t io n o f a x le cove r.
Pass., Nova, Chevelle,All (exc. Pass.),Pass. (exc. Sta. W ag.),All w /Eaton type d iff........................ 4 8 3 7 2 2 1 26 .75 PLATE UNIT, w /discs (Eaton type diff.)
(type C, G, K, P, M) (Note 2 ) ..................N O T E 2 : C o n s is ts o f 10 e a re d d is c s a n d 8 s p l in e d d is c s a n d 4 g u id e s .Pass, w /3 .0 8 , 3 .36 , 3 .5 5 , 3 .70
(2nd design),Chevy, Camaro w /3 .0 8 , 3 .36 ,
3 .55 ratio (3rd design),Chevelle w /3 .0 8 , 3 .3 6 , 3 .7 0
ratio (3rd d e s ig n ) ....................
Vega (122 ) w /P /T ra c ....................Chevy, Chevelle,Pass, w /3 .0 8 , 3 .36 , 3 .5 5 , 3 .7 0
ratio .................................................Chevy, Chevelle ............................Pass, w /2 .7 3 , 3 .08 ratio,All w /O lds type d iff........... ............
3 8 8 8 0 7 0
3 4 5 6 0 2
39 .75
2 7 .0 0
3 8 3 0 7 4 63 8 3 0 7 4 0
2 3 1 1 2 7 1
2 .902 1 .60
2 6 .5 0
N O T E 3 : C o n s is ts o f 8 F ix e d D iscs a n d 6 S p / in e d D iscs. All w /3 .0 8 , 3 .36 , 3 .5 5 , 3 .7 0
ratio ............................................Chevy, Chevelle, Camaro
Nova, Camaro,All w /Eaton type a x le .............
All w /O lds. type d iff..................All w /O lds. type d iff..................All w /O lds. type diff..................All w /O lds. type d iff..................All w /O lds. type d iff..................All w /O lds. type d iff..................All w /O lds. type d iff..................All w /O lds. type d iff..................All w /O lds. type d iff..................All w /O lds. type diff..................All w /O lds. type d iff..................All w /Olds. type diff..................All w/Olds. type diff..................All w /O lds. type diff..................All w /3 .0 8 , 3 .3 6 , 3 .55, 3 .70
ratio ...........................................Chevy, Chevelle .......................Chevy, Chevelle, Camaro, Pass.,Pass., Chevelle, Nova,All w /Eaton type d iff................
and r e a r ) .........................................Pass., Camaro (exc. Sta. W ag.), Pass. (2 .73 , 3 .08 ratio w /P.T.)
(exc. Sta. W ag.),Nova, Camaro w /P .T .,All (2 .73 , 3 .08 ratio w /P .T.) . . .
72 Nova, Camaro,71 -72 Pass, w /2 .7 3 , 3 .08 ratio (exc.
Sta. W ag.),73 -75 All w /2 .7 3 , 3 .08 , 3 .23 ratio (exc.
Sta. W ag.) ......................................
71 -757 3-75
71-7573 -7571-75747475
62-70707172
Pass, (exc, P/Trac.),Chevelle (Sta. W ag.) (exc.
P /T ra c .) ..............................................Pass. w /P /T rac .,Chevelle (Sta. W ag.) w /P /T rac . .Vega (140) (exc. P /T r a c .) .............Vega (122) (exc. P /T ra c .) .............Vega (122) w /P /T ra c .......................Vega (122) Monza (exc. P/Trac.)
3 8 6 9 3 0 8 A.R.
3 9 6 0 3 4 9 1
3 9 9 5 8 9 6 1
1 2 3 4 3 7 6 1
9 7 7 8 1 8 4 1
9 7 9 2 7 1 83 8 5 55 1 1
3 4 5 62 13 4 5 6 3 03 4 4 1 6 8
3.15 (w /1 0 bolt cover)
4.15
3 .50
9 .20
2.95
5 .60
5 .30 2.00 2.10
11.35 4.35
2 .40 (Dana 3 2 2 6 6 )
2 .8 0 (w /1 2 bolt cover)
(3/ 4" O.D. x 45V 64" O.L.) (Eaton ED 6960) (w /1 0 bolt cover) .........................................
(type B, O, C, G, K) (Olds, type) (8V 2" dia. ring gear) . . . ...................................................
4 .35 (type P, M) (Olds, type) (87/ a" dia. ring gear)
(type P, M) (87/a" dia. ring gear) (61/ 2" dia. ring gear) ....................
5.518 SCREW— WASHER, Pinion Shaft LockAll (exc. P/Trac.),Monte Carlo w /c u t out cover,Chevelle, Nova (exc. P/Trac.),Chevelle (exc. P/Trac.) .................. 4 7 2 5 4 6 1 .32
(7 V 2" dia. ring gear)
(Vie"— 18— 2) (round cover) (Note 1)
REV. 4-76GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—1 1 ____________
5-25 5.517-5.518
BRAKES—REAR AXLE AND DRIVE
3 8 3 0 7 4 3 1 1.45 (Dana 3 2 2 6 7 )
2 4 6 2 9 0 6 1 .48 (Dana 3 2 8 4 5 )
5.518 SCREW— WASHER, Pinion Shaft Lock (Con't)Chevy, Chevelle w /P /T ra c . (1st
design) ..............................................Chevy, Chevelle w /P /T rac . (2nd
design),Chevy w /P /T rac ., 3 .08 , 3 .36,
3 .55 ratio,Chevelle, Camaro (P/Trac.
w /3 .0 8 , 3 .36 , 3 .70 ratio),Pass. w /P /T ra c ...................................Pass. w /P /T ra c . (12 bolt ring
gear),Chevelle w /3 .0 7 , 3.31 ratio (8
cyl-),El Camino w /3 .0 7 , 3 .31 , 3 .73
ratio (8 cyl.),Camaro, Chevy (P/Trac. w /3 .0 7 ,
3 .31 , 3 .55 , 3 .73 ratio),All (exc. P/Trac.),Pass., Chevelle w /P /T ra c . (12
bolt cover),Nova (P/Trac. w /2 .7 3 , 3 .07,
3 .31 , 3 .55 ratio),Pass, w /2 .7 3 , 3 .08, 3 .4 2 ratio,Chevelle, Nova w /P /T rac .,Pass. (2.73, 3 .08 , 3 .42 ratio
w /P.T.),Chevelle w /P /T ra c .............................
65 -68 Chevy, Chevelle, Camaro(P/Trac. w /2 .7 3 , 3 .0 8 , 3 .36 ,3 .55 , 3 .70 ra t io ) .......................
66 -67 Pass. w /P /T rac . (273 ratio) (8c y l . ) ................................................
3 8 3 0 6 7 2 1
3 8 6 9 3 1 9 1
3 8 4 9 9 1 2 1
.38 (Eaton ED 9 2 9 9 4 ) (type P, M) (w /1 2 bolt cover) ..................................................................
71 Camaro (exc. P/Trac.),71 -72 Pass, w /2 .7 3 , 3 .08 ratio (exc.
Sta. W ag., P /T ra c .) ..................71 -72 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio
(exc. P/Trac.) ..........................Pass, w /2 .7 3 , 3 .08 r a t io ..........Camaro, Nova,A l l ......................................................
Vega (140) .........................................Vega w /P /T ra c ...................................Vega (122) (exc. P /T r a c .) .............Vega (122) w /P /T ra c .......................Vega (122) Monza (exc. P/Trac.)Pass. (P/Trac. w /2 .7 3 , 3 .08 ,
3 .42 ratio) ......................................N O T E 1 See i l lu s t ra t io n p re c e d in g
P/Trac.),Pass. (exc. P/Trac.),All w /1 0 bolt round cover (exc.
P/Trac.),Chevelle, Nova (exc. P/Trac.),Chevelle (exc. P/Trac.) ...............Chevy, Chevelle w /P /T ra c ...........Chevy, Chevelle w /P /T rac .,Chevy (P/Trac. w /3 .0 8 , 3 .36 ,
Monte Carlo w /c u t out cover(exc. P/Trac.) .................................
Chevelle, Nova w /P /T ra c . (2nd design),
Chevelle w /P /T ra c . (2nd design)Pass., Camaro w /P /T ra c . (exc.
Sta. W ag.),Nova w /P /T rac .,All w /P /T rac . (exc. Sta. W ag.) . .
Vega (140) (exc. P/Trac.) Chevelle w /P /T ra c .............
3 8 8 0 1 4 0 2 6 .05
9 7 7 8 3 4 3 2 9.95
9 7 8 3 0 0 5 1 6.25
3 9 9 5 8 4 2 2 10.70
3 9 9 5 8 9 5 2 10.70
3 9 7 4 9 4 9 2 6.053 9 9 5 8 4 3 2 10.70
3 4 5 6 2 2 1 4.953 4 5 6 2 7 1 6 .20
6 2 7 0 9 7 7 1 7 .603 4 4 1 6 6 2 6.55
6.05 (10 teeth) 12 bolt cover
teeth on side gear (Note 1)
10 .70 (17 teeth on side gear)
(81/ 2" dia. ring gear) (B-0 type)(7 1/ 2" dia. ring gear) ..................
G ro u p 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
Vega (122) (exc. P /T r a c .) .............Vega (122) w /P /T ra c .......................All w /P /T ra c ........................................Vega (122) Monza (exc. P/Trac.)N O T E 1 S ee i l lu s t r a t io n p re c e d in g
5.527 GEAR UNIT— WASHER, Differential Side with PinionN O T E : U n it c o n ta in s 2 -s id e g e a rs -2 p in io n g e a rs - th ru s t w a s h e rs -p in io n sh a ft.Pass, w /2 .7 3 , 3 .0 8 , 3 .42 ratio
(exc. P/Trac., Sta. W ag.),Pass. (Sta. W ag.) w /2 .7 3 , 3 .08
Pass. (2 .73 , 3 .08 , 3 .4 2 ratio w /P /T rac .) (exc. Sta. W ag.),
Pass. (Sta. W ag.) (2 .73 , 3 .08 ratio w /P /T rac .) ....................
diff. side gear, pinion & pinion shaft (type P,M) ...............................................................................
4 8 4 6 6 6 1 89 .75
Camaro w /2 .7 3 , 3 .0 8 , 3 .4 2 ratio (exc. P/Trac.),
Pass, w /2 .7 3 , 3 .08 ratio (exc.Sta. W ag., P/Trac.),
Nova w /2 .7 3 , 3 .08 , 3 .42 ratio (exc. P/Trac.),
All (exc. P /T ra c .) ............................... 1 3 9 7 6 4 7Pass. w /P /T rac .,Chevelle (Sta. W ag.) w /P /T ra c . . 4 9 0 7 7 8
d iff side gear, pinion & pinion shaft (type P, M) ...............................................................................
Pass. (exc. P/Trac.), Chevelle (Sta. W ag.) (exc.
P /T ra c .) ...............................
Pass. (exc. P/Trac.), Chevelle (Sta. W ag.) (exc.
P /T ra c .) ...............................
4 9 1 9 4 1 1
4 9 1 2 3 7 1
59 .75
7 9 .50
4 8 .00
4 8 .00
(type G, C, K, B, 0 )
pinion & side gear (type P, M) (87/ 8" dia. ring gear) ........................................................
side gear pinion & pinion shaft (type P, M) (87/ 8" dia. ring g e a r ) .........................................
side gear pinion & pinion shaft (type P, M) (87/ s" dia. ring g e a r ) .........................................
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 ____________REV. 4-76 5-27 5.526-5.527
BRAKES—REAR AXLE AND DRIVE
73-75
73-75
71
6565
66-67
65-70
65-68
70
5.527 GEAR UNIT— WASHER, Differential Side with PinionChevelle (exc. Sta. W ag.,
P/Trac.),Pass, w /2 .7 3 , 3 .08 ratio (exc.
Sta. W ag., P /T ra c .) .....................
(Con't)
3 9 3 1 4 0 .16 W A S H E R , diff. pinion thrust (type B, 0 ) (8V 2" dia. ring g e a r ) ....................................
5.528 GEAR, Differential Side62-6362-63646 4
65-6665-69
65-67
65
6566-6967-6970
717265-68
65-68
65-68
65-69
65-6965-6767-68
68-69
70
7172
65-69
65-69
65-69
65-6970
N O TE : D if fe re n t ia l S id e G e a r fo rChevy w /P /T ra c ..................................Chevy (exc. P/Trac.) .......................Chevy, Chevelle (exc. P/Trac.) . . Chevy, Chevelle w /P /T rac ., 3 .08 ,
3 .36 r a t io ........................................Sta. W ag. (exc. P/Trac.),Pass, w /1 2 bolt cover (exc.
P/Trac.),Chevy w /3 .0 7 , 3 .31 , 3 .55 ratio
(327),Chevelle w /2 .7 3 , 3 .07 , 3.31
ratio (327) (exc. Sp. H/Per.),El Camino w /3 .73 ratio (8 cyl.), Chevelle, Camaro (exc. P/Trac.), Chevy (exc. P/Trac.),All w /1 2 bolt cover (exc.
P/Trac.),Chevelle, Nova (exc. P/Trac.),Chevelle (exc. P/Trac.) ..................Pass. w /P /T ra c . (3 .08, 3 .36 ,
71 -75 Vega (140) (exc. P /T r a c .) ..........72 Chevelle w /P /T ra c ...........................72 Chevelle w /P /T ra c ...........................72 Pass., Camaro, Nova w /P /T ra c .
(exc. Sta. W ag.),73-75 All w /P /T ra c ......................................
747475
Vega (122) (exc. P/Trac.)Vega (122) w /P /T ra c . . .Vega (122) Monza (exc. P/Trac.)
N O T E 1 S ee i l lu s t ra t io n p re c e d in g G ro up 5 .3 9 8 fo r id e n t i f ic a t io n o f a x le cove r.
5.529 GEAR ASSEMBLY, Ring and Pinion (not sold separately)N O TE: A x le ra t io is e q u a l to r in g g e a r d iv id e d b y p in io n , 3 7 d iv id e d b y 10 is e q u a l to 3 .7 0 to N O T E P a rt n u m b e rs in p a re n th e s e s a re s ta m p e d on r in g g e a r a n d p in io n re s p e c tive ly .
3 7 9 0 9 0 03 7 9 09 0 1
3 9 6 1 4 1 2 1
3 9 6 1 4 1 4 1
3 9 6 1 4 1 33 9 6 14 1 13 9 6 1 4 0 4
3 9 6 1 4 0 5 1
ChevyChevy .................................................Chevy, Chevelle, (3 .36 ratio),Pass. (3 .36 ratio w /1 0 bolt
cover),All (3 .36 ratio w /1 0 bolt cover),Chevelle, Nova (3.36 w /1 0 bolt
cover) ..............................................Chevelle (3 .70 ratio),Pass. (3 .70 ratio w /1 0 bolt
cover) ..............................................All (3 .08 ratio w /1 0 bolt round
cover),All (3 .08 ratio w /1 0 bolt cover)
(exc. Pass.),Chevelle (3.08 ratio w /1 0 bolt
cover) ..............................................All (3.55 ratio w /1 0 bolt cover)All (4.88 ratio w /1 2 bolt cover)All (3.31 ratio w /1 2 bolt cover),Chevelle, Nova (3.31 w /1 2 bolt
cover),Chevelle (3.31 ratio w /1 2 bolt
cover) ..............................................Pass. (3.55 ratio w /1 2 bolt
cover),Chevy, Chevelle, Camaro (3.55
ratio),Chevelle,All (3.55 ratio w /1 2 bolt cover)All (3.07 ratio w /1 2 bolt cover),Nova (3.07 w /1 2 bolt cover) . .All (3.73 ratio w /1 2 bolt cover),C a m a ro ................................................. 3 9 6 1 4 0 8All (4 .10 ratio w /1 2 bolt cover),Chevelle, Camaro (4.10 ratio
_____________ GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET—11 ____________REV. 4-76 5-29 5.528-5.529
72
6768-706968-70
68-7069-71 68-70
71
68-69
70
70
70
71-75
71-75
72-75
73-75
71-72
71-7573-75
71-7573-75
71-7573-75
71-75
71-7471-7571-7471-75
72-7573-7572-7573-757475
7475
757575
7575
62-7070-7171-75
727071-7572-7573-75
BRAKES—REAR AXLE AND DRIVE
5.529 GEAR ASSEMBLY, Ring and Pinion (not sold separately)Chevelle (2 .73 ratio w /1 0 bolt
cover)Chevelle w /A .I.R .,Chevelle, Camaro,Chevy (2.56 ratio),Pass. (2.56 ratio w /1 2 bolt
cover) .................................................Chevy, Camaro,Chevelle (2 .56 ratio),Pass. (2.56 ratio w /1 0 bolt
cover),Nova (2.56 ratio w /1 0 bolt
cover) .........................................Pass. (2.29 ratio w /1 2 bolt
cover) .................................................Monte Carlo (2.78 ratio w /c u t
out c o v e r ) .........................................Monte Carlo (3.08 ratio w /cu t
out cover) .........................................Monte Carlo (3.23 ratio w /cu t
out c o v e r ) .........................................Camaro (3.73 ratio w /1 0 bolt
cover) .................................................Camaro (3.42 ratio w /1 0 bolt
cover),Nova (3.42 ratio w /1 0 bolt
cover),Chevelle (3.42 ratio w /1 0 bolt
cover) .................................................Camaro (4 .10 ratio w /1 0 bolt
cover) .................................................Pass, w /2 .7 3 ratio,Chevelle (Sta. W ag.) w /2 .7 3
ratio ...................................................Pass, w /3 .0 8 ratio,Chevelle (Sta. Wag.) w /3 .0 8
ratio ...................................................Pass. w /3 .42 ratio,Chevelle (Sta. Wag.) w /3 .42
ratio ...................................................Pass, w /2 .7 3 ratio (exc. Sta.
Wag.) .................................................Vega (140) w /2 .53 ratio .............Vega (140) w /2 .92 ratio .............Vega (140) w /3 .3 6 ratio .............Camaro, Pass, w /3 .0 8 ratio (exc.
Sta. Wag.),Nova w /3 .0 8 ratio,Chevelle w /3 .0 8 r a t io .....................Nova w /2 .7 3 ratio,Chevelle, Camaro w /2 .7 3 ratio, Nova, Camaro w /2 .5 6 ratio,All w /2 .5 6 ratio ...............................
Vega (122) w /3 .73 ratio .............Monza w /2 .29 ratio (exc.
N o tc h b a c k ).................... .................Vega (122 ) Monza w /3 .42 ratio Vega (122) w /3 .73 ratio,Monza w /3 .73 ratio (exc.
N o tc h b a c k )......................................Vega (122 ) Monza w /2 .5 6 ratio Vega (122) Monza w /2 .93 ratio
Pass, w /2 .73 , 3.08, 3.42 ratio,Chevelle (Sta. Wag.) w /2 .73 ,
3.08, 3.42 ratio .......................... 9778193 12
10
.16
.18
.22
.15
hypoid drive gear (type G, C, K, B, 0) (8 V 2"dia. ring g e a r ) .................................................
(type P, M) (Vie"— 20 x 7/ 8" ) ..........................
Vega (122) ...................................... 2402525NOTE 1 See Illustration preceding group 5.398 for identification of axle cover.
5.535 LUBRICANT, Hypoid GearA l l ....................................................... 1050081A l l ....................................................... 1050527
5.536 BEARING, Differential Side
rear flange plate and brake (type G, K, B, 0)(7/ 16"— 1 4 X 1 7/ i e " ) ..........................................................
rear axle ring gear to case bolt (type P, M) (8 7/ a" dia. ring g e a r ) ......................................
1.25DR/.52
special hypoid ( 1 quart container)— (8.800) special hypoid (15 gal.)— (8.800) ................
Chevy, Chevelle .........All w /1 0 bolt cover, Pass. (exc. Sta. Wag.), A l l ....................................
All w /1 2 bolt cover,Pass., Nova, Chevelle w /1 2 bolt
cover,Nova w /1 2 bolt cover,Chevelle w /1 2 bolt cover,Pass, w /2 .73 , 3.08 ratio,Pass, w /2 .73, 3.08, 3.42 ratio,A l l ......................................................Vega (140) ......................................
7451226
7451281
7.37
7.73 (15/a" x 257/64" O.D.) (type G, C, K, B, O, W) (w /7V 2", 8 V 2" dia. ring g e a r ) .....................
74511407451897
9.308.04
(type P, M) (w /8 7/a" dia. ring gear) (6 V 2 " dia. ring gear) ........................
5.537 SHIM UNIT— SPACER, Differential Bearing AdjustingAll w /1 0 bolt cover,Pass, w /2 .73 , 3.08 ratio (exc.
Sta. Wag.) ....................................All w /1 0 bolt cover (exc. Pass.) . 3853759 A.R. 1.70All w /1 0 bolt cover,Pass, w /2 .73 , 3.08 ratio (exc.
Sta. Wag.) ....................................All w /1 0 bolt cover (exc. Pass.) . 3853760A .R . 1.70All w /1 0 bolt cover,Pass, w /2 .73 , 3.08 ratio (exc.
Sta. Wag.) ! .................................All w /1 0 bolt cover (exc. Pass.) . 3853761 A.R. 1.55All w /1 0 bolt round c o v e r ......Pass, w /2 .73 , 3.08 ratio (exc.
Sta. Wag.) ....................................All w /1 0 bolt cover (exc. Pass.) . 38 53762 A.R. 1.65All w /1 0 bolt cover,Camaro,Pass, w /2 .73 , 3.08 ratio (exc.
Sta. Wag.),Nova,Chevelle,
Vega (122) Monza ........................ 3853912A .R .All w /1 2 bolt cover,Pass, w /2 .73 , 3.08, 3.42 ratio .Chevelle, Nova w /1 2 bolt cover,Chevelle w /1 2 bolt cover,Chevelle ........................................... 3 8 5 1 4 8 0 A.R.All w /1 2 bolt cover,Pass, w /2 .73 , 3.08, 3.42 ratio . .Chevelle, Nova w /1 2 bolt cover,Chevelle w /1 2 bolt cover,Chevelle ........................................... 3851481 A.R.All w /1 2 bolt cover,Pass, w /2 .73 , 3.08, 3.42 ratio . .Chevelle, Nova w /1 2 bolt cover,Chevelle w /1 2 bolt cover,Chevelle ........................................... 3 8 5 1 4 8 2 A.R.All w /1 2 bolt cover,
1.40
1.70
1.55
(.096, .098, .100) (type C, G, K, B, 0)
(type P, M), .............................................
(.064, .066, .068)
(type P, M), .........
(.070, .072, .074)
(type P, M), .........
1.85 (.076, .078, .080)
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ________________REV. 4-76 5-31 5.531-5.537
BRAKES—REAR AXLE AND DRIVE
5.537 SHIM UNIT— SPACER, Differential Bearing Adjusting (Con't)71-75 Pass, w /2 .73, 3.08, 3.42 ratio . . (type P, M), ...........................................................71 Chevelle, Nova w /1 2 bolt cover,72 Chevelle w /1 2 bolt cover,73-75 Chevelle ........................................... 3851483 A.R. , 1.70 (.082, .084, .086) ...............................................65-70 All w /1 2 bolt cover,71-75 Pass, w /2 .73 , 3.08, 3.42 ratio . . (type P, M), ...........................................................71 Chevelle, Nova w /1 2 bolt cover,72 Chevelle w /1 2 bolt cover,73-75 Chevelle ........................................... 3851484 A.R. 1.85 (.088, .090, .092, .0 9 4 ) ......................................65-69 All w /1 2 bolt cover,70 Pass., Nova, Chevelle w /12 bolt
cover,71-75 Pass, w /2 .73, 3.08, 3.42 ratio . . (type P, M), ...........................................................71 Chevelle, Nova w /12 bolt cover,73-75 Chevelle (Sta. Wag.) w /2 .73,
3.08, 3.42 ratio .......................... 3876174 A.R. 1.70 (.096, .098, .100) ...............................................67-70 All w /1 0 bolt cover,71-75 Pass, w /2 .73, 3.08 ratio (exc.
Sta. Wag.) .................................... (type G, C, K, B, 0 )................................................71-75 All w /1 0 bolt cover (exc. Pass.) . 3907088 A.R. 1.85 (.052, .054, .056) ...............................................67-69 All w /1 0 bolt cover,72-75 Pass, w /2 .73, 3.08 ratio,72-75 Chevelle, Nova, Camaro w /1 0
bolt c o v e r...................................... 3907089 A.R. 1.85 (.058, .060, .062) (type G, C, K, B, 0) . .70 Monte Carlo w/cut out cover,71-75 Camaro,71-75 Pass, w /2 .73, 3.08 ratio,72-75 Nova,73-75 Chevelle,75 Vega (122) Monza ........................ 3995792 A.R. 2.15 (.046, .048, .050) (type C, G, K, B, 0) (Note
1 \71-75 Camaro,71-75 Pass, w /2 .73, 3.08 ratio,72-75 Nova,73-75 Chevelle,75 Vega (122) Monza ........................ 3995791 A.R. 2.15 (.040, .042, .044) (type C, G, K, B, 0)71-75 Pass, w /2 .73, 3.08, 3.42 ratio,73-75 Chevelle ........................................... 3996610 A.R. 2.15 (.040, .042, .044, .046) (type P, M) ..............71-75 Pass, w /2 .73, 3.08, 3.42 ratio,72 Chevelle w /1 2 bolt cover,73-75 Chevelle ........................................... 3996611 A.R. 2.15 (.048, .050, .052, .054) (type P, M) ..............71-75 Pass, w /2 .73, 3.08, 3.42 ratio,72 Chevelle w /1 2 bolt cover,73-75 Chevelle ........................................... 3996612 A.R. 2.15 (.056, .058, .060, .062) (type P, M) ..............71-75 Vega ( 1 4 0 ) ...................................... 3988980 A.R. 4.05 (.064-.068) (6 1/ 2" dia. ring g e a r).....................71-75 Vega (140) ...................................... 3988981 A.R. 1.95 (.070-.074) (6 V 2 " dia. ring g e a r).....................71-75 Vega ( 1 4 0 ) ...................................... 3988982 A.R. 1.95 (.076-.080) (6 V 2 " dia. ring g e a r).....................71-75 Vega (140) ...................................... 3988983 A.R. 1.95 (.082-.086) (6 V 2" dia. ring g e a r).....................71-74 Vega ( 1 4 0 ) ...................................... 3988984 A.R. 1.95 (.088-.094) (6 V 2" dia. ring g e a r ) .....................71-74 Veqa (140) ...................................... 3988985 A.R. 1.95 (.096-. 100) (6 V 2" dia. ring g e a r).....................74 Vega (122) ...................................... 345607 A.R. .15 SHIM (.003) ........................................................74 Vega (122) ...................................... 345608 A.R. .15 SHIM (.005) .........................................................74 Vega (122) ...................................... 345609 A.R. .15 SHIM (.010) .............................................74 Vega (122) ...................................... 345610 A.R. .15 SHIM (.030) .........................................................67-69 Chevy, Chevelle, Camaro w /10
bolt cover, '70-71 All w /1 0 bolt cover,72-75 Pass, w /2 .73, 3.08 ratio,72-75 Chevelle, Nova, Camaro w /1 0
bolt cover,75 Vega (122), M o n za ........................ 9775809 A.R. .92 SPACER, diff. bearing (.170 x 227/ 32" O.D.)
(type G, C, K, B, 0) (Note 2 ) ..........................67-70 All w /1 2 bolt cover,71-73 Pass, w /2 .73, 3.08, 3.42 ratio . . SPACER (type P, M ) ..........................................71 Chevelle, Nova w /12 bolt cover,72 Chevelle w /12 bolt cover,73 Chevelle,75 Pass, w /2 .73 , 3.08, 3.42 ratio,75 Chevelle ........................................... 9780883 A.R. 1.25 (.170" thk.) (type G, C, K, B, 0) (Note 1,2) .71-75 Vega .................................................. 3988534 A.R. 1.25 SPACER, diff. brg. (6 V 2 " dia. ring gear) . . . .
NOTE 1 See illustration preceding group 5.398 for identification of axle cover.NOTE 2 Used with matching shim units, to replace prod, cast iron type adjustment.
_________________ GM PARTS D IVIS ION , GENERAL MOTORS CORPORATION — CHEVROLET— 1 15.537-5.537 5-32 REV. 4-76
BRAKES—REAR AXLE AND DRIVE
64
65-68
65-68
65-68
64-656565-70
65-70
65-70
66-70
67-69
7171-72
65
65
656565-69
65-69
70
7172
6565-66
65-67
66-69
66-69
66-6970
71
71-72
66-6966-69
7071
71-72
7071
71
7273-75
5.542 WASHER, Differential Pinion ThrustChevy, Chevelle w /P/Trac., (2nd
design),Chevy (P/Trac., w /3 .08 , 3.36,
3.55 ratio) ( 1 st design),Chevelle, Camaro (P/Trac.,
w /3 .08 , 3.36, 3.55, 3.70 ratio)( 1 st design),
Pass. w/P/Trac., 3.08, 3.36,3.55, 3.70 ratio .......................... 2346848 2
Chevy, Chevelle (exc. P/Trac.),Pass. (exc. P /T ra c .)........................ 3843266 2Pass, w /3 .07 , 3.31, 3.55, 3.73,
4.10, 4.56, 4.88,Chevelle (P/Trac., w /3 .07 , 3.31
ratio) ( 8 cyl.),El Camino (P/Trac., w /3 .73
ratio) ( 8 cyl.),Chevy (P/Trac., w /3 .07 , 3.31,
3.35, 3, 73 ratio),Camaro w /P/Trac. (exc. 3.08,
3.36, 3.70 ratio),Nova (P/Trac. w /1 2 bolt cover),Chevelle (P/Trac. w /1 2 bolt
cover) ............................................. 3957940 2Chevy, C.A.C., 3.07, 3:31 ratio
(327),Chevelle w /P/Trac. (2.73, 3.07,
3.31 ratio, w /P .G ) (327),El Camino w /3 .73 ratio,Pass. (exc. P /T ra c .)........................ 3852991 2Pass. w/P/Trac., 3.08, 3.36,
P /Trac .)........................................... 481510 2 .34 (type P, M ) .............................................................71-72 Camaro (exc. P/Trac.),72 Nova (exc. P /T ra c .)........................ (2.73, 3.08, 3.42 ratio) (C, G, K).......................71 Pass. (exc. Sta. Wag., P/Trac.),72 Pass..................................................... (2.73, 3.08 ratio) (type B, 0, G, K)...................73-75 Camaro, Nova, C h eve lle .............. (2.73, 3.08, 3.42 ratio)........................................73-75 All w /P /T rac...................................... (2.73, 3.08 ratio) (type B, 0), ..........................73-75 All (exc. P /T rac .)..................... 3984818 2 .36 (2.73, 3.08, 3.23 ratio) (type G, C, K ) ............71-72 Camaro w/P/Trac.,72 Nova w/P/Trac.,71-72 Pass. w /P/Trac. (exc. Sta. Wag ),73-74 All w /P /Trac..................................... 3995997 2 .98 (type G, C, K) (Eaton type) ...............................71-75 Vega (140) (exc. P /T ra c .) ............ 3974899 2 . 1 2 (6 V 2" dia. ring gear) ..........................................73-75 All (exc. P /T ra c .)............................. (type B, 0 )................................................................73-75 All w /P /T rac ..................................... 393140 2 .16 (type O) ..................................................................73-74 Pass. w /P/Trac.,73-74 Chevelle (Sta. Wag.) w /P/Trac. . 97 92620 2 .98 (type P, M ) .................................................... .........73-75 All (exc. P /T ra c .)............................. (type B, 0 )................................................................74 Vega (122) (exc. P /T ra c .)............ 345629 2 .3975 Vega (122) Monza (exc. P/Trac.) 344167 2 . 2 2 (7V 2" dia. ring gear) ..........................................
62-707172
65-707172
71-7271-72
7273-7571-75
73-75
71-757475
.34 (w /10 bolt cover)
NOTE 1 See illustration preceding group 5.398 for identification of axle cover.
5.543 WASHER, Differential Side Gear ThrustAll,Chevelle, Nova w /1 0 bolt cover,Chevelle w /1 0 bolt cover (exc.
P /Trac .)........................................... 97 89002 2All,Chevelle, Nova,Chevelle w /1 2 bolt cover (exc.
P/Trac.),Camaro (exc. P/Trac.),Pass, w /2 .73 , 3.08 ratio (exc.
Sta. Wag.),Nova (exc. P/Trac.),All (exc. P /T rac .).............................Pass, w /2 .73 , 3.08, 3.42 ratio
(exc. P/Trac.),Chevelle (Sta. Wag.) (exc.
P /Trac .)........................................... 39 35 78 2Vega (140) (exc. P /T ra c .).......... 6257691 2Vega (122) (exc. P /T ra c .).......... 345628 2Vega (122) Monza (exc. P/Trac.) 344165 2
(w /12 bolt cover) (type G, K, B, 0),
.46
.31
.56
.33
(type P, M ) .................(6 1/ 2" dia. ring gear)
(71/ 2" dia. ring gear)
5.544 SHAFT— UNIT, Rear Propeller (Shaft attaches to rear axle)NOTE: The 1971 passenger car constant velocity design production propshafts for all models (except Police)
are not serviced. The service replacement propshaft is identical to the production version with the exception that the slip yoke has been removed. The two U-joint bearing assemblies at this location are then held together using two dips with a special retaining strap. These parts are to be discarded when assembling the new propshaft for installation. Two snap rings part number 1456507 must be used to retain the bearing assemblies in the slip yoke.
Do not use the parts shipped with the service propshaft.NOTE: See Dealer Price Schedule for applicable prices.
3 5 0 2BC),69-70 Police, Taxi,70 Pass. w /T .H . 3 5 0 (400 ),70 Pass. (T.H. 3 5 0 w /4B C )
( 3 5 0 ) .................................... n - 3 9 6 1 4 7 7 1(7) Length 6 1 1/ 2" center line to center line of brgs. use w/strap retained rear trunnion.
(12) Length 6 0 1/ 8" centerline to centerline of brgs.(') Tube length.(2) Complete shaft assy, including front and rear U-Joints and trans. sleeve yoke.(3) For U-Joint repair kits use 1-5677659 (frt.) and 1-5698221 (rear).
71 Pass. w /P.G ., 3-Spd. (exc. Sta. W ag.),
72 Pass. w /3-S pd ., P.G.,73-75 Pass. w /3-S pd . (exc. Sta. W ag.) . 7816189 1 147 .00 w /s lip yoke ................................................................71 Pass. w /T .H . 3 5 0 ,72 Pass. w /T .H . 3 5 0 (exc. Sta.
(exc. Police) .................................... 7810447 1 119 .0072 Pass. (Sta. W ag.) w /T .H . 4 0 0
(exc. Police),73-75 Pass. (Sta. W ag.) w /T .H . 4 0 0
(454) (exc. Police) ....................... 7813402 1 147 .00NOTE 3 It will be necessary to purchase two (2) 1456507 snap rings and install to retain slip yoke.
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ________________REV. 4-76 5-35 5.544-5.544
BRAKES—REAR AXLE AND DRIVE
I
735.544 SHAFT— UNIT, Rear Propeller (Shaft attaches to rear axle) (Con't)Police w/T.H. 400 (exc. Sta.
400, close ratio 4 -S p d .)............ 7812622 1 97.7573-74 Chevelle (Spt. Cpe.) w/close
ratio 4-Spd...................................... 7812623 1 97.7573-74 El Camino w/close ratio 4-Spd. . 7812626 1 130.0073-74 Chevelle w/T.H. 400 (exc. Monte
Carlo, Spt. C p e .).......................... 7812627 1 107.0073-74 Chevelle (Spt. Cpe.) Monte Carlo
w/T.H. 400 ................................... 78 12 62 8 1 121.0075 Chevelle (Spt. Cpe.) Monte Carlo
402) ...............................................Camaro (exc. Close Ratio 4-Spd.) Camaro w/Close Ratio 4-Spd. . .
39141903917578
39501943970521
398193139501963981929
3981930 1
3981932 1
7811094 1
7811095 1
399753978193447819345
48.5094.00
65.2566.50
66.5067.0061.50
66.50
66.50
(w/damper)
1
97.00 (3.42 ratio)
97.00
6 6 .0 084.0090.25
VEGA— MONZAVega w /A .T .............................Vega w /3-Spd.........................Vega w /4-Spd.........................Vega (140) ............................Vega (122) ............................Monza (Rotary) (exc. 5-Spd.]Monza ( 2 6 2 ) ..........................Monza (140) (exc. 5-Spd.), Vega (122) ..........................
3987346399100839910107814793781693378176137818594
43.0051.5051.5069.7563.7583.5083.50
propeller, tube and trunnion ........................propeller, tube and trunnion ........................propeller, tube and trunnion ........................propeller, tube and trunnion w /2 .92 ratiopropeller, tube and trunnion ........................propeller, tube and trunnion ........................propeller, tube and trunnion ........................
N O T E 1: U n it co n ta ins 1 d a m p e r yo ke -2 c o n tro l arm d a m p e r w e ig h ts -2 ta p p in g p la te s -2 5/ i 6 " x 1V8 " bolts- 2 s/ i e " lo ck w ashers , instruction sheet.
2 V 4")— ( 3 .2 7 5 ) ................................................NUT, prop, shaft damper— (5 .586) ..........W A S H E R , prop, shaft damper— (4.037) . W A S H E R , prop, shaft damper "U" bolt . .
5.545 FLANGE— DEFLECTOR— SLINGERAll w /1 0 bolt round cover,Chevelle, Nova w /1 0 bolt cover,Vega (140),Chevelle w /1 0 bolt c o v e r ........... 3997957 1 14.95 w /deflector (Note 1-2-3)N O T E 1: S ee illu s tra tio n p rec ed in g Group 5 .3 9 8 fo r id en tifica tio n o f ax le cover.N O T E 2 : I t w ill be necessary to use (2 ) 3 8 8 2 9 7 9 s trap (4 ) 3 8 8 7 3 4 8 bo lts on re a r axle. N O T E 3: S tra p type attach ing .All w /1 0 bolt round cover,Chevelle, Nova w /1 0 bolt cover,Vega, Monza,Chevelle w /1 0 bolt c o v e r ........... 3878968 1N O T E 4: "U " b o lt a ttach ing .All w /1 2 bolt cover (exc. 1330
U -J o in t) .............................................. 3878972 1Pass. (T.H.) w /1 3 3 0 U-Joint,Pass, w /1 3 3 0 U-joint,Chevelle, w /T .H .,Camaro,Chevelle (12 bolt cover w /1 3 3 0
U - jo in t ) ........................................ .. . 3879208 1 13.30
10.80 w /deflector (Note 4)
12.30 w /deflector (327/ 32" dia.)
All w /1 2 bolt cover,Nova w /1 2 bolt cover,Chevelle (12 bolt cover w /1 2 8 0 ,
13 1 0 U-joint) .................................Monte Carlo w /c u t out cover . . . Camaro w /1 0 bolt cover,Nova ......................................................Camaro,Pass. (Sta. W ag.) w /2 .7 3 , 3 .08,
3 .42 ratio,Chevelle,C a m a ro .................................................Pass, w /2 .7 3 , 3 .08 , 3 .23 , 3 .42
ratio (exc. Sta. W ag.) ..................Vega (122 ) .........................................All w /1 0 bolt cover,Chevelle, Nova w /1 0 bolt cover, Camaro,Nova,Chevelle,Vega, Monza,Chevelle w /1 0 bolt c o v e r .............
w /deflector (45/is" dia.) (12 bolt cover) (H.D. u -jo in t).......................................................................
39961189783530
14.9512.95
w /deflector (standard u-joint) (Note 1 ) .........................................
39 88 52 4 1
7812565 1
13.90 w /deflector, strap-type spring attaching
14.95 (type P, M)
78086712403641
15.7513.25
(type B, O, P, G, C, K) w /deflector ..................
3832398 1
All w /1 2 bolt cover,Chevelle, Nova w /1 2 bolt cover,Chevelle w /1 2 bolt c o v e r ..........Vega (122) ......................................Pass, w /2 .7 3 , 3 .08 , 3 .23 ratio . Pass, w /2 .7 3 , 3 .08 , 3 .4 2 ratio . All,Chevelle, Nova ...............................
38194151784583
543319 1
.65
.43
.31
.27
DEFLECTOR, flange (35/ 32" O.D. x 141/ 6< I.D.) ................................................................
W A S H ER , flange (67/ 64" thk.).................................
I.D. x 17/ i6" x V 4
Camaro,Nova,Pass, w /2 .7 8 , 3 .08 r a t io ...............Pass, w /2 .7 8 , 3 .08 , 3 .42 ratio . .Pass, w /2 .7 8 , 3 .08 r a t io ............... 3714792Vega (122) ......................................... 345619
.90
.44
(type B, O).............................................(type P, M ) ..............................................(type G, K ) ..............................................W A SH ER , pinion rear brg. spacer
5.548 REPAIR KIT— BALL UNIT— BEARING and CUP UNIT, UniversalN O TE : N um bers fo llo w in g m o d e l usages a re fo rg ed on the frt. a n d re a r yokes respectively. A l l see Groups
4 .4 0 4 a n d 4 .4 0 5 fo r U n iversa l J o in t a ttach in g parts.65-69 Pass.1, ' >
_________________ GM PARTS DIV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 _____________ ___REV. 4-76 5-39 5.544-5.548
BRAKES—REAR AXLE AND DRIVE
5.548 REPAIR KIT— BALL UNIT— BEARING and CUP UNIT, Universal (Con't)66 Pass. (exc. T .H .) ............................. front and in te r . , .......................................................62 -68 Chevy,64 -68 Chevelle, Camaro,72 Chevelle (250 , 307 ),72 Camaro (exc. 3 5 0 , 402 ),72 Camaro w /2B C (350) (exc. T.H.
66-68 Pass. w /T.H .,67-68 Chevelle, Camaro w /T.H .,70 Caprice, Kingswood (Estate
Wag.) w /T .H . 4 0 0 (454),70 Monte Carlo (T.H. 4 0 0 w /4 5 4 ),71-72 Chevelle (454),71 Camaro (T.H. 3 5 0 w /2B C ) (307 ,
350),71 Camaro (4-Spd. w /4B C ) (350),71 Camaro w /4 B C (400),71-75 Pass.,73-75 Chevelle,75 C a m a ro ................................................. 7 8 0 6 1 4 0 1 18.35 front U-joint (Note 4-5) ......................................66 -68 Pass. w /T .H .,67-68 Chevelle, Camaro w /T .H .,70 Caprice, Kingswood (Estate
W ag.) w /T .H . 4 0 0 (454),70 Monte Carlo (T.H. 4 0 0 w /4 5 4 ) ,71 -72 Chevelle (454) ................................. 5 6 9 8 2 2 1 1 15.45 rear U-joint (Note 2, 4 and 5 ) .........................
N O T E 2 : Consists o f 1 trunnion, 4 brgs., 4 snap rings, 2 "U" bolts, 4 w ashers a n d 4 nuts.69-70 Chevelle, Pass.,70 Nova, Camaro w /4B C ,71 Chevelle w /4B C (exc. 454 ),71 Nova (350),71 Camaro w /T .H . 3 5 0 (350 ) (exc.
Sp. H/Per., 3 .4 2 ratio),71 Camaro w /S p . H/Per. 3 5 0 ,71-75 Vega, Monza,72 Chevelle (350 , 402),72 Camaro w /4 B C ,72-74 Camaro (2BC w /T .H . 350 ) (350),72 Nova w /T .H . 3 5 0 (350),73 Camaro (exc. 350),73 Camaro w /2 B C (350) (exc. T.H.
350 ),73 Nova (exc. T.H. 350 ),73 -74 Camaro w /4 B C ,7 3-75 Nova ...................................................... 3 8 6 4 5 1 A.R. 16 .70 "U"-joint (Nbte 6) ................................................73-75 Pass. (exc. Sta. W ag.) . . . . . . . . 7 8 1 5 8 4 8 1 11 .30 BALL UNIT, prop, shaft re p la c e m e n t..........73-75 Pass. (exc. Sta. W a g .) .................... 7 8 1 5 8 5 1 1 10 .50 BEARING AND CUP UNIT, prop, shaft
trunnion ................................................................N O T E 1: Consists o f 1 trunnion, 2 snap rings, 2 "U " bolts, 4 nuts, 4 washers, 4 seals, a n d 4 bearings.N O TE 4: Use o n ly w ith p ro p s h a ft assy. 5 6 7 8 7 1 fo r 1966.N O T E 5: U sed on "U " jo in ts w hich have p las tic in je c te d o r in n e r p o s ition "U " jo in t bearin g lo ck rings.N O T E 6: Do n o t use on "U" b o lt type.
GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 115.548-5.548 5-40 REV. 4-76
BRAKES—REAR AXLE AND DRIVE
5.555 YOKE— DAMPER UNIT, Universal Joint
37070593868649
39677245699832
3967726
3871115 39677573967729
3986415 7812558
7815849 7809057 78015515-65
62 -63 Chevy (exc. 4 -S p d .) ......................... 3 7 0 7 0 5 9 A .R .71 -75 Pass. (exc. Sta. W a g .) .................... 7 8 0 9 0 5 7 163 Chevy w /M uncie 4-Spd.,64 -68 Chevy, Chevelle, Camaro,65-66 Pass. (exc. T.H.),67 -69 Pass. (exc. Caprice, T.H.),67 -69 Caprice (exc. A.T.),71 -72 Vega ..................................................... 3 8 6 8 6 4 9 1
Camaro (exc. Sp. H /Per.),Nova,Vega, Monza (exc. damper) . . . . 3967732 1Pass. w /T .H . (307),Pass. w /T .H . (327 ) (2nd design),Camaro w /T .H . (396),Caprice, Sta. W ag. w /T .H . 400 ,Caprice, Monte Carlo w /T .H .
4 00 (400),(Concours Estate W ag.) w /T .H .
400 ,Monte Carlo w /T .H . 4 0 0 (400 ,
4BC),Monte Carlo w /T .H . 4 0 0 (402) . 3 9 67 72 4 1Caprice w /T .H . 400 ,Caprice w /T .H . (327) (1st
Design),Caprice, Kingswood (Estate
W ag.) w /T .H . 4 0 0 (454),Monte Carlo (T.H. 4 0 0 w /4 5 4 ) ,Monte Carlo w /T .H . 4 0 0 (454 ) . 5699832 1
16 .20 YOKE ASSY., front U-joint
5 1 .0 0
7812557 1
7812 55 8 1
N O T E 2 : W ith dam per. P lastic in jec tio n o r in n e r p o s ition U -jo in t Pass. w /T .H . 3 5 0 ,Pass. (Sta. W ag.) w /3 -S pd .,Pass. w /P .G ., 3-Spd. (exc. Sta.
Wag.),Pass. (exc. T.H. 400),Chevelle (exc. 4-Spd., T.H. 400),Camaro (exc. close ratio 4-Spd.)Pass. w /T .H . 4 0 0 (exc. Police,
Sta. W ag.),Police w /T .H . 400 ,Pass. w /T .H . 4 0 0 ............................Chevelle w /4-S pd . (exc. H.D.),Camaro w /S p . H/Per. 3 50 ,Nova w /4 B C (350) (exc. T.H.
350),Camaro w /4 B C ,Camaro (2BC w /T .H . 350 ) (350),Camaro w /S p . H /Per. (350 ) . . . .Chevelle w /H .D . 4-Spd.,Camaro (4-Spd. w /4B C ) (350),Camaro w /4 B C (400),Chevelle w /H .D . 4-Spd. (454),Chevelle (4-Dr.-EI Camino) (exc.
T.H. 400),Camaro w /close ratio 4-Spd. . . .Kingswood Estate (exc. T.H.
71-72 V e g a ............................................. 3993015 1 1.5575 Pass.................................. .............. 1245509 4 .18
O.D. x V i . " thick), (black oxide on rollers) .
ROLLER, U-joint yoke trunnion brg.
USPACER, trunnion brg. (Dana 2300727-1)
" Joint Trunnion and Yoke
all locations (finger dia. 596)
U-joint yoke trunnion bearing snap
BOLT, shaft and U-joint assy, strap (Vie"— 24 x 1Vi6ff) ......................................................
BOLT, rr. wheel drive shaft strip (17/e4 " head r thickness) (1/Y'— 2 0 x 3/ 4" ) ............................
BOLT, U-joint (5/ V — 18 x 1% *) ...................BOLT, U-joint trunnion brg. (5/ i 6"— 18 x
13/ i 6") ................................. ......................................BOLT# prop, shaft and "U" joint (hex. (7/ i 6" x
1 W ) .......................................................................BOLT, prop, shaft damper (" U " ) .....................BOLT, prop, shaft and "U" jo in t .....................
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS C O R PO R A TIO N —CHEVROLET— 11 ________________5.560-5.586 5-44 REV. 4-76
Vega .................................................. 3993018 2 .84 NUT, prop, shaft damper ............Pass. w/T.H.,All,Nova, C am aro ................................. 3882979 2 .12 STRAP, prop, s h a ft ........................Pass. (Sta. Wag.),Chevelle ........................................... 7810416 2 .24 STRAP, prop, s h a ft........................
5.595 NUT— WASHER, Propeller Shaft Pinion FlangeAll w/round cover,Chevelle, Nova w/round cover,Vega, Monza,Chevelle ........................................... 3736464A.R .Camaro,Pass, w /2 .73 , 3.08, 3.42 ratio,Nova,A l l ...................................................... 9783762 1
.81 (7/ 8w— 16) (Note 1)
Vega (122) ...................................... 2346852A l l ....................................................... 3714792
70-75 All 517900 1
.76
.57
.90
.40
(type C, G, B, 0 , K, P, M) (7/ 8"— 14 I.D. x 17/ 16" O.D. x 3/ i 6") (p la in)..........................
WASHER (15/ 8" O.D.) (10 bolt cover).........N O T E 1 S ee illu s tra tio n p rec ed in g gro u p 5 .3 9 8 fo r id en tifica tio n o f ax le cover.
5.638 CLAMP, Rear Axle62-69 A l l ....................................................... 2494772 A.R. .65 (W '— s/ 8" diameters)— (1.166)
5.803 WHEEL, Front or RearThis section co nta ins M o d e l U sag e a n d Prices fo r Passenger, C hevy II, C hevelle a n d C am aro w heels fo r
W h ee l size. Tire size a n d o th e r a d d e d descrip tion , see the fo llo w in g charts.These tw o sections sh o u ld be used in co n ju nction w ith one an o th er to de term ine the co rrec t wheel.
WHEEL RIMS
SPOKEHOLES
6 STUD STAMPED DISC WHEEL
NOTE: Offset is determined by measuring the distance from the centerline of the rim to the inner side of the wheel disc.
ONE PIECEOne-piece rims: 5.25" cr larger rims have a 15" taper bead seat, and are used for tubeless tires. Smaller rims have a 5° taper bead seat, and are used for both tubeless and tube tires.
62-63 Chevy w /6 .5 0 x 14 tire s .............. 3793396A .R . 19.85 (14 x 5 J ) ............................62-63 Chevy w /6 .0 0 x 13 tire s .............. 3790690A .R . 15.90 (13 x 4J) ..........................62-63 Chevy w /6 .50 , 7.00 x 13 tires . . 3 7 9 0 6 9 3 A.R. 16.95 (13 x 5V 2") .................*.
GM PARTS DIVISION, GENERAL MOTORS CORPORATION —CHEVROLET— 11REV. 4-76 5-45 5.586-5.803
BRAKES—REAR AXLE AND DRIVE
69 646464-6665
68-6965-67 65-69 6768-6970
71-7271-72
65-6665-6966-69 68-69
64-68
67-68
67-68 6768-69 70
67-69
67-68 67 67
68-69676868-7068-69
6868
68
68-69
68-69
68-69
7068-69
68697068-69
68-69
68-697069
6970-7574-75
69
5.803 WHEEL, Front or Rear (Con't)Chevy, Chevelle (exc. S.S. disc
(14 x 5JJ) ..................................................(15 x 5.5K) ...............................................(14 x 6 J K ) .................................................
(14 x 6 J K ) ..................................................
(14 x 5.00J) (V2" offset) (stamped XA)
(14 x 6.00JJ) (stamped XB)
(14 x 6.00JK) ........................(15 x 6 .0 0 JK) ........................
( 1 4 x 5 ) ......................................
(15 x 6 JK) (5 slotted rim holes) (stamped FI) (15 x 5JJ) (stamped X H ) ...................................
18.45 (14 x 5.00J)
23.50 * (1/ 2" offset) (14 x 6.00JJ) (stamped XG)
21.35 (14 x 6 .0 0 J J ).................................................
25.25 (14 x 6.00JK) (1/ 4" offset) (stamped XN)
28.00 (15 x 6 J K ) ......................................................
34.50 (15 x 7JJ) (stamped FW)
_________________ GM PARTS D IVIS ION , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ________________5.803-5.80 3 5-46 REV. 4-76
BRAKES—REAR AXLE AND DRIVE
5.803 WHEEL, Front or Rear (Con't)70 Nova (S.S.) (exc. mag. type
70 Nova (S.S.) w /ra lly w h e e l ............. 3 9 7 0 5 3 0 A.R. 38 .25 (14 x 7 .00JJ) (stamped YJ) ..............................69 -70 Pass. (exc. Sta. W a g .) .................... 3 9 6 4 0 7 1 A.R. 27 .75 (15 x 5JJ) ..................................................................70 -72 Chevelle .............................................. 4 0 9 8 7 9 A.R. 26 .25 (14 x 6JJ) (stamped MH) ....................................70 -72 Monte Carlo ...................................... 3 9 9 0 5 0 2 A.R. 24 .35 (15 x 6JK) (stamped XX) ....................................70 Monte Carlo ...................................... 3 9 7 7 9 6 8 A.R. 3 1 .5 0 (15 x 7JJ) (stamped A F ) ......................................70 Chevelle (Sta. W ag.) w /ra lly
wheel ................................................. 3 9 7 2 6 3 5 A.R. 2 6 .25 (14 x 6JJ) (stamped A E ) ......................................70 Camaro (exc. 4BC, rally wheel),70 -75 Camaro w /S p . H /Per. (350),71 -72 Chevelle w /D isc Brake (454)
(exc. Monte Carlo) ....................... 3 9 9 8 5 3 2 A.R. 5 3 .5 0 (15 x 7JJ) (stamped AU) (Note 1) ..................NOTE 1: Used with options Z-28 or Z-86.
70-75 Camaro w /ra lly wheel,71-75 Nova (Spt. Cpe.) w /ra lly wheel,73 -74 Chevelle w /ra lly wheels . ............. 3 6 2 0 5 5 A.R. 25 .75 (14 x 7JJ) (stamped UD) (Note 2) ..................
NOTE 2: Part # 3 6 2 0 5 5 is also used for the "Spirit of America". Paint as reqd.71-74 Nova w /ra lly wheel,71-72 Chevelle w /ra lly wheel (exc.
Deluxe),73 -74 Camaro w /ra lly wheel (250) . . . 3 3 4 3 2 9 A.R. 24 .45 (14 x 6JJ) (stamped D E ) ......................................71 -72 Monte Carlo,73 Monte Carlo (exc. rally wheel,
Custom wheels),74 -75 Chevelle, Monte Carlo (exc. Sta.
W ag., rally wheels, Customw h e e ls ) .............................................. 3 2 6 8 7 5 2 6 .50 ( 1 5 x 7 ) (stamped A E ) .............................
wheel, G.T. wheel) ....................... 3 3 3 2 7 4 A.R. 2 5 .5 0 (14 x 6JJ) (stamped XJ or U A ) .........................7 3 -74 Chevelle, Camaro w /G .T. wheel
(RPO PE 1) ......................................... 3 2 6 8 8 7 A.R. 52 .75 ( 1 4 x 7 ) (ident. blue strip) (stamped AN)
73 Monte Carlo w /Custom wheel(RPO P E 2 ) ......................................... 32 6 89 1 A.R. 5 3 .50 ( 1 5 x 7 ) (stamped AG) (u re th an e )....................
7 4 -75 Chevelle (exc. Monte Carlo, Laguna, rally wheels, Customw h e e ls ) .............................................. 3 4 4 0 0 3 A.R. 2 6 .50 (15 x 7) (stamped F N ) ...........................................
74 -75 Monte Carlo w /Custom W heel(RPO P E 2 ) ......................................... 3 4 5 9 4 0 A.R. 5 3 .50 ( 1 5 x 7 ) (urethane) (stamped C B ) ....................
74 -75 Chevelle, Monte Carlo (exc. Sta.W ag.) ................................................. 3 3 1 4 2 7 A.R. 2 6 .5 0 (15 x 6) (p r im e d ).....................................................
74 Pass, w /sp irit of A m e r ic a ............. 3 5 2 9 1 1 A.R. 4 4 .50 ( 1 5 x 6 ) .......................................................................74 -7575
Cosworth (122) 3 3 9 6 1 9 A.R 85 .25 (alum, wheel) (1 3 x 6 ) ...........................................Chevelle, Camaro, Nova w /G .T.
wheel (RPO PE 1) .......................... 3 6 2 0 5 6 A.R. 52 .75 (14 x 7) (urethane) (stamped UF) ....................75 Nova, Camaro (exc. rally wheel) . 3 6 2 0 5 2 A.R. 25 .00 ( 1 4 x 7 ) (stamped U C ) ...........................................75 Camaro w /ra lly wheel (250),75 Nova w /ra lly wheel ....................... 3 6 2 0 5 9 A.R. 2 5 .00 ( 1 4 x 6 ) (stamped U B ) ...........................................75 Monza w /R PO N 7 7 .......................... 3 5 5 8 2 0 A.R. 108 .00 (alumn. wheel) ( 1 3 x 6 ) .........................................
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ________________REV. 4-76 5-47 5.803-5.803
BRAKES—REAR AXLE AND DRIVE
5.803 WHEEL, Front or Rear (Con't)NOTE 1: Letters stamped on rim approx. 2" clockwise from valve hole.NOTE 2: Part #3978191 is also used for the "Spirit of America." Paint as required.
ConstructionWheelSize Offset Tire Size
No. Hub Cap Attach.
Clips or
Proj.TireType
No.Lug
Holes WheelClampRing
SideRing
No.Spoke
orHandHoles
1 Piece (Welded) 14 x 6.00JK 1 7.00 x 1 4 .............................. 0 Tubeless 5 38719191 Piece (Welded) 14 x 6JK 1/16 8.25 x 14,8.55 x 1 4 ........... 9 Both 5 39603471 Piece (Riveted) 15 x 15K 9/16 6.70 x 15,7.10 x 1 5 ........... 0 Both 5 3834956 41 Piece (Welded) 14 x 5JJ 19/32 7.00 x 14, 7.50 x 14,
7.75 x 14,8.25 x 1 4 ............ 4 Tubeless 5 736365 41 Piece (Welded) 14 x 6J J 1 7.00 x 1 4 .............................. 0 Tubeless 5 409879 51 Piece (Welded) 14 x 6J J 1/2 E78 x 1 4 ,F78 x 14 ............ 4 Tubeless 5 333274 41 Piece (Welded) 14 x 7JJ 11/32 E78 x 14, F78 x 1 4 ............ 4 Tubeless 5 3975667 41 Piece (Welded) 15 x 6JK 27/32 F70 x 15 .............................. 4 Tubeless 5 3990502 41 Piece (Welded) 15 x 7JJ 9/32 F60 x 15 .............................. 4 Tubeless 5 3998532 41 Piece (Welded) 14 x 6J J 1/2 F78 x 14 ........... .................. 5 Tubeless 5 334329 61 Piece (Welded) 15 x 7 5/16 G78 x 1 5 .............................. 4 Tubeless 5 326875 41 Piece (Welded) 15 x 6J J 11/32 G78 x 1 5 .............................. 4 Tubeless 5 3997997 41 Piece (Welded) 15 x 7 19/32 G78 x 1 5 .............................. 4 Tubeless 5 3997899 51 Piece (Welded) 15 x 5JJ 1/4 7.75 x 15,8.15 x 15 ............ 5 Both 5 3901696 51 Piece (Riveted) 15 x 5.5K 7/16 6.70 x 15, 7.10 x 1 5 ............ 0 Tube 5 3838080 41 Piece (Welded) 15 x 5 J J 8.00 x 1 5 .............................. 3 Both 5 3928262 41 Piece (Welded) 15 x 5JJ 2-29/32 8.25 x 1 4 .............................. 0 Tubeless 5 3964071 41 Piece (Welded) 15 x 6JK 1/16 7.75 x 15,8.15 x 15(INT.). 3 Both 5 3968773 51 Piece (Welded) 15 x 6JK 1/16 8.15 x 15 (EXT.) .............. 3 Tubeless 5 3984792 41 Piece (Welded) 1 4 x 5 13/64 E 7 8 x 14, F78 x 1 4 ........... 4 Tubeless 5 326843 41 Piece (Welded) 14 x 7JJ 11/32 E78 x 14, F78 x 1 4 ............ 4 Tubeless 5 334397 41 Piece (Welded) 1 4 x 7 11/32 F70x 1 4 .............................. 5 Tubeless 5 362055 51 Piece (Welded) 14 x 7 11/32 E78 x 14, F78 x 14 _____ 4 Tubeless 5 362052 41 Piece (Welded) 14 x 6 1/2 E78 x 14, F78 x 1 4 ............ 4 Tubeless 5 362059 41 Piece (Welded) 15 x 7 9/32 G78 x 1 5 .............................. 4 Tubeless 5 344003 4
94 21 50 2 50 .24 ( 1 V 2 oz.) (size cast on weight)94 21 50 4 5 .24 ( 1 oz.) (size cast on weight) .9421506 5 .24 (V* oz.) (size cast on weight) .94 21 50 8 5 .31 ( 2 oz.) (size cast on weight) .94 21 51 0 5 .31 (2 V 2 oz.) (size cast on weight)97 72 18 2 A.R. .18 ( 1/ 4 oz.) (size cast on weight) ,9 421512 A.R. .42 (3 oz.) (size cast on weight) .
331451 A.R. .24 (5 oz.) (size cast on weight) .331452 A.R. .24 ( 1 oz.) (size cast on weight) .331453 A.R. .24 ( IV 2 oz.) (size cast on weight)3 3 1454 A.R. .31 ( 2 oz.) (size cast on weight) .331455 A.R. .31 (2 V 2 oz.) (size cast on weight)331456 A.R. .41 (3 oz.) (size cast on weight) .
All (exc. Vega All (exc. Vega All (exc. Vega All (exc. Vega All (exc. Vega All (exc. Vega All (exc. Vega Vega, Monza Vega, Monza Vega, Monza Vega, Monza Vega, Monza Vega, Monza
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 1 1 ________________5.803-5.809 5-48 REV. 4-76
BRAKES—REAR AXLE AND DRIVE
64-67
65-70 65-70 65-67 6765-66
6768-70
71
72
73-7470-72 74 7073-7571-72 73-75
71-7271-7573-7573-7575
6768
67-70
67-69
71-7273-7468
68-70
68-70
70-75 73-75 7571-75 71-75
65-6869-70
71-75
62-7071-7571-7273-7565-70696970717273-7567-706970
38452823985944387232638 72384
3869537 A.R.
2 34.502 31.752 33.352 34.50
front and rear, .
32.75 rear
5.809 DRUM ASSY.— DISC, Front and Rear Wheel Brake (Con't)Chevy, Chevelle, Camaro
w/metallic lin ings...................Pass. (exc. metallic linings) . . .Pass. (exc. metallic brakes)Pass, w/metallic b ra k e s .........Pass, w/metallic lin in g s .........Pass, w/metallic linings (exc.
Sp./H/Per.),Pass, w/metallic lin in g s .........Chevy, Chevelle, Camaro
w/finned front brk. drums,Chevelle, Nova (exc. Monte
Carlo),Nova, Chevelle (exc. Frt. Disc
Brk.),Nova (exc. Frt. Disc Brk.) . . . .Chevelle w/finned brk. drum,Nova .............................................Monte Carlo w /cut out cover,Chevelle (exc. Sta. Wag.) . . . .Pass, w /2 .73 , 3.08 ratio,Pass, w /2 .73 , 3.08, 3.23 ratio
(exc. Sta. Wag.) .....................
Pass. (Sta. Wag., Police, Taxi) . .Vega, M o n za ....................................Pass. (Sta. Wag.) ..........................Chevelle (Sta. W a g .) .....................Camaro, N o v a .................................NOTE 1 See illustration preceding Pass. w/Disc Brakes,Pass. w/Disc Brakes (four piston
5.811 UNIT, Rear Wheel SpacerH ......................................................... 369011 1NOTE 1: Consists of 1 spacer-4 studs and instruction sheet used for field fix only.
5.812 BOLT— STUD, Hub or Drum (Front and Rear Wheel)All,Vega, Monza,Camaro, Nova, Chevelle,Nova, C am aro ................................. re a r ,...................Pass.,Nova, Camaro (exc. Disc Brake),Chevelle w/Disc Brake,Pass., Nova, Chevelle,Chevelle, Nova (exc. Disc Brk.),Chevelle, Nova, Camaro,Nova (exc. Disc Brk.)......... 3980406 A.R. .73Pass. w/Disc B rakes..................... 3961225 A.R. .16Camaro (Disc Brake w/P.S.) . . . . 39 10 34 0 10 .24Camaro,
front wheel (Vie"— 2 0 x 1 3/a") ..................(front and rear) . . ...........................................(Vi6"— 20 x IV 4") (frt. and re a r )............
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ________________REV. 4-76 5 -49 5.809-5.812
BRAKES—REAR AXLE AND DRIVE
5.812 BOLT—STUD, Hub or Drum (Front and Rear Wheel) (Con't)71-75 Vega, Monza,71 Chevelle, Nova, Camaro w/disc
brakes,73-75 Chevelle, Nova, Camaro w/Disc
Brk..................................................... 39 61272 A.R. .73 fro n t.........................................................................71-75 Pass. w/Disc B rakes..................... 3961258 A.R. .64 fro n t.........................................................................71-75 Pass, w /2 .73 , 3.08, 3.42, 3.23
ratio ............................................... 1235137 10 .34 (type B, 0, P, G, K, M) r e a r ...............................73-7571-75
Chevelle ........................................... 1235136 A.R. . 2 2 rear .........................................................................Vega, M o nza.................................... 369095 A.R. .71 STUD, rr. wheel (used for field fix only)
Sta. W ag.) .......................................65 Chevelle (Spec. Spt. Cpe.) (396),65 Pass, w /1 2 bolt cover,6 6 -75 Pass.,73 -75 Chevelle (Sta. W ag.) w /2 .7 3 ,
3 .08 , 3 .42 ratio ............................70 Monte Carlo w /c u t out cover . . .71 -75 Pass, w /2 .7 3 , 3 .08 ra t io ...............73 -75 Chevelle (exc. Sta. W ag.) .............7 4 Vega (122) .........................................7 4 Vega (122) .........................................
N O T E 1 S ee illu stra tion p rec ed in g group 5 .3 9 8 fo r id en tifica tio n o f axle cover.
and 12 bolt round cover,65 Pass, w /1 0 bolt cover,73 -75 Chevelle, Camaro, Nova (exc.
Sta. W ag.),71 -75 Vega, M o n z a .......................................65 -7 0 Pass, w /1 0 , 12 bolt cover,65 Chevelle (Spec. Spt. Cpe.) (396), 65 Pass, w /1 2 bolt,71 -75 Pass, w /2 .7 3 , 3 .08 , 3 .42 ratio, 73-75 Chevelle (Sta. W ag.) . . J ...............70 Monte Carlo w /c u t out cover,7 3 -75 Chevelle ..............................................71 Pass, w /2 .7 3 , 3 .08 r a t io ...............71 -75 Pass, w /2 .7 3 , 3 .08 r a t io ...............
9 0 7 3 7 0
7 4 5 1 7 8 5
7 4 5 1 8 0 9 2
16 .00 w /seal and retaining ring (ND 9 0 7 7 2 7 9 )
wheel w /D isc Brakes) ...............Pass. (exc. Caprice, Disc Brakes,
sim. w ire wheel, sim. mag. wheel trim cover),
Pass. (exc. Caprice, Sta. W ag.rally wheel),
Pass. (exc. Caprice, Estate W ag., sim. wire wheel, sim. mag. wheel, wheel trim cover, rallywheel, mag. wheel) ....................
Pass. w /D isc Brk., rally wheel,Pass, w /ra lly wheel .......................Pass..........................................................Pass. w /S p irit of A m e ric a .............
3 8 7 1 1 0 8 A.R. 3 8 7 5 0 2 7 43 9 0 1 7 1 2 4
3 8 9 3 3 3 6 4
3 9 0 8 6 7 2 A.R.
3 9 1 6 4 0 2
3 9 2 5 8 0 13 3 7 2 8 13 4 9 0 7 2
7.85 w /pain ted emblem 8 .707 .15 1 (2-piece) w i . . . ; t .
8 .75 (14" wheel) ............., '■ ' ,,,U'
9 .15 (bow tie 8 Vi")
8.75 (bow; tie TO3/*")
17.75 (15" w h e e l )____8.95 (bow tie design)
14.25
WHEEL COVER— COVER UNIT (Full Wheel)Pass. (exc. S.S., Caprice, wire,
mag. wheels) ................................. 3 8 6 0 2 0 4 4Pass, w /1 4" mag. w h e e ls ............. 3 8 7 2 8 6 1 4Pass, w /w ire w h e e ls ....................... 3 8 3 4 9 0 4 4
1 8 .504 1 .7548 .75 w /ornam ent
REV. 4-76GM PARTS DIVIS ION GENERAL MOTORS CORPORATION
Pass. w/PO-1 (exc. Caprice) . . . Pass, w /sim . 15" w ire wheel
(2nd d e s ig n ).................................Caprice (exc. deluxe wheel trim
c o v e r ) ............................ ..............Pass. (RPO P01) ............................Pass, w /1 5" sim. w ire wheel . Caprice (exc. sim. wire wheel) .Pass...............................................Pass. w /S im . 15" mag wheel
(exc. fender skirts)
3968761 4 2 1 .5 0 (15" wheel) (bow tie design)
3982876
39881716264291
341332327767327764
3968716
52 .75
17.3517.55 49 .00 17.1017.55
(15(15
wheel) (bow tie design) wheel) ...............................
use w /insert 3 2 7 7 5 9 ..........(15" wheel) (bow tie design)
4 4 .0 0 (Note 2)NOTE 2: Part # 3 9 6 8 7 1 6 is identified by 2 15" dia. flange entering wheel.Caprice (exc. sim. w ire wheel) Caprice (exc. sim. w ire wheel) Pass. w /PO-1 (exc. Caprice) . .
75 Impala, Caprice w /Z 0 371 Pass, w /1 5" sim. wire wheel
(exc. rear wheel skirts), 72-75 Pass, w /1 5" sim. w ire wheel
339609348158345978
363753
18.35 (Caprice emblem) ..............................................2 0 .1 0 use w /insert 3 2 7 7 5 9 ......................................19 .80 (15" wheel) (bow tie design) use w /insert
W h e e l ................................................. 329368 4 15.70 use w /com b. 9 1 1 -9 2 4 -9 4 4 -9 5 6 -9 6 0 -9 6 4 -981 (dark s ilv e r ) ...................................................
73-75 Monte Carlo w /Custom W heelsRPO P E 2 ............................................ 329392 4 8.25 (15" wheel) (turbine wheel) w / in s e r t .............
73-75 Chevelle w /G .T . wheels (RPOPE1) (exc. Monte C a r lo ) ............. 329389 4 5.45 (14" wheel) (turbine wheel) .......... ................
w h e e ls ) .............................................. 3849435 4 2 9 .5064 Chevelle w /1 4 " wheels (exc.
S.S., wire w h e e ls ) .......................... 3840900 4 18.0564-66 Chevelle w /1 4 " wire wheels . . . 3834904 4 48 .7565 Malibu (S.S.) (exc. w ire, mag.
w h e e ls ) .............................................. 3867968 4 17.8065 Chevelle (exc. S.S., w ire, mag.
w h e e ls ) .............................................. 38 60 20 9 4 18.4065-66 Chevelle w /1 4 " mag. wheels . . . 3872861 4 4 1 .756 6 Chevelle w /1 4 " wheels (exc.
w ire, mag. w h e e ls ) ............... 3875041 4 18.0567 Chevelle (exc. S.S., Concours) . . 3890691 4 15.2067 C oncours.............................................. 3895852 4 15.2067 Chevelle (S .S .) .................................... 3893342 4 15.4567-68 Chevelle w /1 4 " wire wheels . . . 3908761 4 5 0 .0067-72 Chevelle w /1 4 " mag. wheels
73-74 Chevelle w /sim . 14" mag. wheel(exc. Monte Carlo) ....................... 39 63 43 4 4 4 4 .0 0 (flat black f in is h ) .....................................................
70-72 Monte Carlo (exc. Special W heelTrim Cover, rally wheel),
72 Chevelle (Sed.) (exc. Spt. Sed.,rally w h e e l) ...................................... 3972645 4 16.35 (chrome) (15" wheel) .................. ..........
70 Monte Carlo ...................................... 3972748 4 2 0 .35 (15" wheel) ...............................................................70-72 Chevelle (exc. Monte Carlo) . . . . 3972260 4 4 7 .75 w /insert (crossed flag type) (14" wheel) . . .70 Chevelle (exc. Monte Carlo) . . . . 3983390 4 16.4570 Monte Carlo w /sim . wire wheel
(1st design) .................................... 3957059 4 5 2 .50 (15" wheel) ...............................................................70-72 Monte Carlo,73-74 Monte Carlo w /sim . 15" m ag ..
wheel (exc. fender s k ir ts ) .......... 3968716 4 44 .00 (15" wheel) (mag. type) (flat black paint) . .70-72 Monte Carlo w /deluxe wheel
trim c o v e r ......................................... 3963405 4 4 6 .50 (15" wheel) (use w /6 " rim) (use w /hub3 9 7 2 7 9 4 ) (flat o rnam ent)............................
_________________ GM PARTS DIV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ________________REV. 4-76 5-53 5.858-5.858
BRAKES—REAR AXLE AND DRIVE
WHEEL COVER— COVER UNIT (Full Wheel) (Con't)71-72 Monte Carlo (exc. deluxe wheel
trim cover) ......................................71-75 Monte Carlo w /1 5" sim. w ire
wheel ................................................71-72 Chevelle (exc. Monte Carlo)71-75 Chevelle w /1 4" sim. w ire wheel 73-75 Monte Carlo (exc. Deluxe W heel
trim cover, Rally W heel,Custom W h e e l) ............................... 3 2 7 7 6 1 4 2 0 .5 0
71 Monte Carlo w /1 5" sim. w ire wheel (2nd d es ig n )....................... 3 9 8 2 8 7 6 4 52 .75
73 Monte Carlo w /D eluxe W heel trim cover (RPO P A 3 ) .................. 3 2 7 7 7 0 4 17.10
73-74 Chevelle w /PO-1 (exc. Monte Carlo) ................................................ 3 9 6 8 7 6 1 4 2 1 .5 0
Disc B ra k e s )................................. 3 8 9 0 6 7 9 4 8 .3067 Chevy w /R ally W h e e ls ............... 3 9 0 1 7 1 2 4 7.1568-69 Chevy (exc. sim. wire mag.
wheels, rally wheel),68-70 Nova w /ra lly wheel .................... 3 9 2 5 8 0 1 4 f 17.75 (15" wheel) ................................. ..............................68-70 Nova (exc. rally wheel, wheel
trim cover) ................................. 3 9 1 6 4 3 4 4 8.1569-70 Nova ................................................. 3 9 6 3 4 4 4 4 15.5571-73 Nova (exc. rally wheel, wheel
trim cover) ................................. 6 2 7 4 2 9 2 4 9 .3071-74 Nova w /ra lly wheel (RPO ZJ7) 3 5 2 9 3 3 4 10.30 (bow tie design) .....................................................73-75 Nova (S.S.) (RPO Z26) ............. 3 2 9 3 6 2 4 15.70 (C h evro le t)............... ..................................................74-75 Nova ................................................. 3 3 7 2 8 3 4 9 .3074 Nova (RPO Z5 1) ......................... 3 4 8 1 9 1 A. R. 12 .70 w /insert (Spirit of America) ..............................75 Nova w /G .T. w h e e ls .................. 3 2 9 3 8 9 4 5.45 (14" wheel) (turbine wheel) ..............................
WHEEL COVER— COVER UNIT (FULL WHEEL)62 Chevy w /1 3" wheels (exc. wire
w h e e ls ) ......................................... 3 7 9 3 1 3 6 4 13.5062 Chevy F.C. w /1 4" wheels (exc.
w h e e ls ) ......................................... 3 7 9 3 3 6 0 4 14.65
5.858-5.858GM PARTS DIV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11
5-54 REV. 4-76
BRAKES—REAR AXLE AND DRIVE
63-64
64
64-66 64-6665
65
65
65-6665-6966 66 66
67
6767-6867-72
68 68
68-69
3821121 4 18.25
3849126 4 13.503855383 4 47 .75 w /ornam ent38 34904 4 48 .75 w /ornam ent
3840301 4 18.25
WHEEL COVER— COVER UNIT {Full Wheel) (Con't)Chevy w /1 4 " wheels (exc. S.S.,
w ire w h e e ls ).................................Chevy w /1 3" wheels (exc. w ire
w h e e ls ) ............................................Chevy w /1 3" w ire wheels . . . .Chevy w /1 4 " w ire wheels . . . .Chevy w /1 3" wheels (exc. w ire,
mag. wheels) ...............................NOTE 6: To utilize production surplus some wheel covers include emblems. When using on 1965 models
wire, mag. w h e e ls ) .....................Chevy w /1 4 " mag. wheels . . . .Chevy w /1 3" mag. wheels . . . .Chevy w /1 3" wheel (exc. S.S.) .Chevy w /1 4 " wheels (exc. S.S.)Nova (S.S.) (exc. wire, mag.
w h e e ls ) ............................................Chevy (S.S.) (exc. wire, mag.
w h e e ls ) ............................ ...............Chevy (exc. S.S.) w /1 4 " wheels Chevy w /1 4 " w ire wheels . . . .Nova w /1 4 " mag. wheels (1st
design) ............................................Chevy w /1 4" wheels ..................Chevy .................................................NOTE 3: On S.S. models it will be necessary to order emblem 3925880.Nova w /1 4 " sim. mag. wheels
(1st design) ................................. 3918080 4 42 .7569-70 Nova w /1 4 " wire w h e e ls .......... 3957061 4 5 2 .5069-74 Nova w /sim . 14" mag. wheel
(2nd d e s ig n ) ................................. 39 63434 4 4 4 .0 069 Nova w /1 4 " sim. mag. wheels
(2nd d e s ig n ) ................................. 3963436 4 4 4 .0 0<59-70 Chevy w /1 4" wheels .................. 39 62 72 4 4 16.1570-72 N o v a ................................................... 3972260 4 47 .7571-73 Nova ................................................... 3990555 4 17.5571-75 Nova w /1 4 " sim. wire wheel . . 3998506 4 5 3 ,0073-75 Nova w /1 4 " sim. wire wheel . . 3998506 4 5 3 .0073-74 Nova ................................................... 3997992 4 16.1575 Nova ................................................... 349032 4 17.5575 Nova Custom w /LN pkg............... 361026 4 23 .7575 Nova Custom w /L N pkg............... 361027 4 23 .7575 Nova Custom w /LN pkg............... 361028 4 23 .7575 Nova Custom w /L N pkg............... 361029 4 23 .7575 Nova Custom w /L N pkg............... 361030 4 23 .7575 Nova Custom w /L N pkg............... 361031 4 23 .7575 Nova Custom w /L N pkg............... 361032 4 23 .7575 Nova Custom w /L N pkg............... 361033 4 23 .7575 Nova Custom w /L N pkg............... 361034 4 23 .7575 Nova Custom w /L N pkg............... 361035 4 23 .7575 Nova ................................................... 994688 1 N.L.
(charcoal) (6 ornament lugs)
NOTE 5 Consists of four covers (full wheel).
(flat black finish)
(dark argent)
w /insert (crossed flag type) (14" wheel) . . (14" wheel) (Chevrolet Motor Div.) w /insert
(14" wheel) (bow tie d es ig n )............................(14" wheel) (bow tie d es ig n )............................( w h ite ) .......................................................................(silver met.) .............................................................(It. graystone) ........................................................(med. blue m e t.) ...................................................(dk. blue m e t . ) ........................................................(dk. green met.) . . . ..............................................(cream beige) ........................................................(sandstone) ............................................................(dk. sandstone) .....................................................(red m e t .) .............................. .................................COVER U N IT (14" wheel) (bow tie design)
Camaro w /ra lly wheel .................. 3901712 4Camaro w /ra lly wheels ............... 3925801 4Camaro (exc. sim. w ire mag.
wheels, rally w h e e l ) .................... 3 9 16 43 4 4C a m a r o ................................................ 3963444 4Camaro (exc. Rally W heel,
W heel Trim Cover, 3 5 0 Sp.H/Per.) .............................................. 6274292 4
Camaro w /ra lly wheel (RPO ZJ7) 352933 4Camaro w /S p . H/Per. ( 3 5 0 ) ____ 3989479 4
8 .307.15
17.75
8.15 15.55
9 .3010.30
5 .60
(bow tie design) ................................................(bow tie design) ....................... ....................(bow tie design) (use w /w heel 3 9 9 8 5 3 2 )
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ---------------------------REV. 4-76 5-55 5.868-5.858
BRAKES—REAR AXLE AND DRIVE
WHEEL COVER— COVER UNIT (Full Wheel) (Con't)N O T E 6: U sed w ith RPO Z -2 8 o r Z 8 6 .
74-75 C a m a ro ............................................... 337283 4 9 .3073-75 Camaro w /G .T. Wheels ...... 329389 4 5.45 (14” wheel) (turbine wheel)
COVER— COVER UNIT (FULL WHEEL)67 Camaro w /1 4" mag. wheels . .67 Camaro w /1 4" wheels (exc. w ire
mag. wheels) Camaro w /trim Camaro w /1 4" Camaro w /1 4" Camaro w /1 4" Camaro w /1 4" Camaro w /1 4" Camaro w /1 4" Camaro w /sim . Camaro w /1 4"C a m a ro ............C a m a ro ..........Camaro w /1 4"C a m a ro ..........C a m a ro ..........C a m a ro ..........
cover (350 , 396 ) wire wheels . . mag. wheels . . sim. mag. wheelsw h e e l ...............sim. mag. wheels wire wheels . . . 14" mag. wheel
w h e e ls ...............
sim. w ire wheel
3872861 4 41 .75
3888699 4 15.203871174 4 27 ,753908761 4 5 0 .0 03903086 4 41 .75 matt f in is h ...............................................................3918080 4 42 .75 (charcoal) (6 ornament lu g s ) ............................3925886 4 14.85 w /in s e r t .....................................................................3963436 4 4 4 .00 (dark argent) .................. .................................3957061 4 52 .503963434 4 44 .00 (flat black f in is h ) ...................................................3980992 4 15.253972260 4 47 .75 (14" wheel) (crossed flag ty p e ) .......................3990555 4 17.55 (14" wheel) (Chevrolet Motor Div.) w /insert3998506 4 5 3 .003997992 4 16.15 (14" wheel) (bow tie d es ig n )............................
349032 4 17.55 (14" wheel) (bow tie d es ig n )............................994688 1 N.L. COVER U N IT (14" wheel) (bow tie design)
75 Monza w /RPO N77 .......................... 349091N O T E 5: Consists o f fo u r covers (fu ll wheel).
4 8 .10
COVER (less emblem) use w /em blem3 8 4 0 3 0 6 ................................................................
COVER, wheel trim use clip 3 6 7 5 7 5 ..........HUB CAP ................................................................HUB CAP, wheel w /reta iner (use w /w heel
3 9 7 8 1 9 1 ) .............................................................HUB CAP (alum.) ( 1 3 x 6 ) ..............................
73-75 Camaro, Nova w /R ally wheel . . 3 9 2 3 5 2 2 4 13.40 wheel trim (155/ 8" O.D.) (1.86" offset) 4 clipattachment ( 1 4 x 6 ) ............................... . . .
68 -69 Nova (Spt. Cpe.) w /ra lly wheel (350),
68-71 Chevy, Camaro w /ra lly wheel (2nd design),
69 Pass, w /1 4" wheels (exc. Caprice, Sta. W ag.),
72 -75 Nova (4BC) (350 ) w /ra lly wheel,72 -75 Camaro w /R ally wheel,7 3 -74 Malibu (S.S.) w /R a lly wheel . . . 3 9 3 4 8 9 2 4 13.65 wheel trim (2.24" offset) ( 1 4 x 7 ) ....................69 -70 Chevy, Chevelle, Camaro (S.S.) . 9 7 9 6 9 1 9 A.R. 15.1570-75 Camaro w /S p . H/Per. (350),71 -7 4 Chevelle (S .S .) ................................. 3 9 8 4 5 2 4 4 14.20 wheel trim (15 x 7) (use w /Z 2 8 or Z 86
option for Camaro only) ....................................71 -75 Vega, M o n z a .................................... 3 9 7 8 1 1 0 4 13.3073 Monte Carlo w /Custom wheels 3 3 7 2 6 2 1 13.60 ( 1 5 x 7 ) (turbine wheel) (Note 3) ....................
NOTE 3: Retainer dips attaches into wheel slots.73-75 Chevelle, Camaro, Nova w /G .T .
wheels ........................................... 4 8 3 2 5 0 1 17.40 ( 1 4 x 7 ) (turbine wheel) ......................................73 Monte Carlo w /custom wheels,75 Monte Carlo w /Custom wheels 3 4 8 1 8 8 1 13.20 ( 1 5 x 7 ) (turbine wheel) (Note 4) ....................
NOTE 4: Retainerdips attaches to outer edge of wheel rim.74 Monte Carlo w /custom wheels 4 9 0 7 7 1 4 16.20 (15 x 7) turbine w hl........................ ............. ...........75 Monza (exc. Alumn., Notchback) 3 6 7 5 7 5 6 .38 CLIP, wheel trim c o v e r .........................................6 3 -64 Chevy w /1 4" wheels (exc. S.S.) 3 8 2 1 1 2 3 4 1.50 EM BLEM , wheel c o v e r .........................................65 Chevy w /1 3" wheels .................. 3 8 6 3 5 1 1 4 3 .45 EM BLEM , wheel cover .................. ......................65 Chevy w /1 4" wheels (exc. S.S.) 3 8 6 6 2 1 2 4 3 .2 0 EM BLEM , wheel c o v e r .........................................65 -66 S.S.......................................................... 3 8 6 0 2 1 7 4 1.05 EM BLEM (S.S.) ........................................................65 Pass. (exc. S .S .) ............................... 3 8 6 0 2 0 6 4 3.45 E M B L E M .....................................................................66 Pass. (exc. S.S., Caprice) .......... 3 8 7 5 0 3 1 A.R. 3 .45 E M B L E M ...................................... ..............................66 Chevy w /1 3" wheels .................. 3 8 7 6 9 5 4 4 3.45 EM BLEM , wheel cover .........................................66 Chevy w /1 4" wheels (exc. S.S.) 3 8 7 6 9 5 7 4 3.05 EM BLEM , wheel cover ......................................66 Chevelle ............................................ 3 8 7 5 0 4 3 4 2.75 EM BLEM , wheel c o v e r ..................67 Chevy (exc. S.S.) (w /1 4 x 6 .95) 3 8 9 5 2 2 0 4 3 .20 EM BLEM , wheel c o v e r .................... ....................68 -69 Chevy (exc. 3 5 0 , 39 6 ) .......... 3 9 2 3 5 5 8 A.R. 3 .8 0 EM BLEM , trim c o v e r ..............................................73 -75 Vega, Monza (Notchback)
w /P 0 2 .................... ....................... 3 8 4 0 3 0 6 A.R. 3 .00 EM BLEM , wheel trim cover (use w /CoverAssy. 3 8 4 0 3 0 1 ) ...................................... ............
69 Pass. (1st d e s ig n ) .......................... 3 9 2 3 6 3 1 4 14.90 HUB, wheel cover (convex emblem) (usew /w heel cover 3 9 2 3 6 3 0 ) .................................
70 Monte Carlo,69 -70 Pass. (2nd design),71 -72 Pass., Monte Carlo,73 Pass.,73 -74 Nova, C a m a ro ................................. 3 9 7 2 7 9 4 4 6 .30 HUB, wheel cover (flat emblem) (cross flag
type) (use w /w heel cover 3 ,963405) ..........64 Malibu (exc. w ire wheel),65 Nova (S.S.) ....................................... 3 8 4 1 1 9 2 4 5.80 HUB ASSY., wheel cover ...................................67 Pass. (exc. S.S., Caprice) .......... 3 8 9 3 3 6 2 4 3.05 INSERT, trim c o v e r ....................... .........................67 S.S. (exc. wire, mag., disc
68-69 C a m a ro ................................................. 3 9 2 5 8 8 7 4 2.95 INSERT (bow tie design w /vert. bar) .............69 Pass. (exc. Caprice, Estate W ag.) 3 9 3 9 2 7 5 4 3.45 INSERT, trim c o v e r ................................................69 All w /sim . mag. wheel .................. 3 9 2 4 4 7 8 A.R. 12.40 INSERT, outer cover (Note 1 ) ............................
NOTE 1: It will be necessary to use Retainer Part No. 3931884.69 Chevelle, Nova, Camaro,71 Chevelle (S.S.) w /disc brake . . . 3 9 5 6 7 7 2 4 1.20 INSERT (S.S.) ..........................................................71-72 Pass. (exc. deluxe wheel trim *
cover) ................................................. 3 9 9 2 3 5 4 4 2 .90 INSERT (bow tie design) (35/ i 6" dia.) use w /6 2 6 4 2 9 1 , 3 9 6 8 7 6 1 cover assy.................
NOTE 5: Use w/cover assy. 327767 for year 1973. Use w/cover assy. 348158 for year 1975.74 Nova (RPO Z 51) ............................... 3 4 8 1 9 2 A.R. 2 .95 INSERT, hub cap (use w /cap 34 8 1 9 1 )74-75 Malibu Classic (Spt. Cpe.) (RPO
75 Nova, Custom w /R P 0Z 1 1 .......... 3 4 9 0 6 9 4 2.75 INSERT, w /LN pkg...................................................75 Pass., Chevelle w /RPO PO-1
(exc. Caprice, Monte Carlo) . . . 3 4 5 9 7 6 4 2.75 INSERT, wheel trim cover (bow tie design) use w /w heel cover 3 4 5 9 7 8 ............................
75 Impala, Caprice w /Z 0 3 ............... 3 6 6 3 7 1 4 2.65 INSERT, use w /cover assy. 3 6 3 7 5 3 (Landau e q u ip .) .....................................................
75 Chevelle w /P E 2 ............................... 3 9 9 7 9 9 4 4 2.85 INSERT, turbine wheel .........................................65 -68 Pass, w /sim ulated w ire wheels . 3 7 8 2 3 0 2 A.R. .16 INSULATO R (13/ 4" x 33/ a"— V 32" thk.)—
(3 .704) .....................................................................69 Chevy, Chevelle, Camaro,70 Nova, C a m a ro .................................... 3 9 6 3 4 4 5 A.R. 1.50 N U T ASSY. ( 1 4 x 6 w h e e l) .................................69 Chevy, Chevelle, Camaro (exc.
Sta. W ag.),70 Nova,70 Chevelle (exc. Sta. W ag., Monte
Carlo) ................................................. 3 9 6 3 4 4 9 A.R. 1.50 N U T ASSY. ( 1 4 x 5 w h e e l) .................................62 -63 Chevy ................................................... 3 9 6 4 5 1 4 4 O R N A M E N T, wire wheel cover (spinner) . . .63 Nova (Super Sport),65 Nova (Super Sport),67-68 Camaro (350 , 3 9 6 ) .......................... 3 8 2 7 3 9 4 4 3 .40 O R N A M EN T, wheel cover .................................64 Malibu,64 Nova (S.S.) ......................................... 3 8 4 0 9 7 4 4 6.15 O R N A M EN T, wheel cover .................................64 -68 All w /w ire wheels,65-69 Pass, w /w ire w h e e ls ....................... 3 9 0 8 7 6 2 4 3 .80 O R N A M E N T (Note 2 ) ...........................................
NOTE 2: Due to motor vehicle safety standards it is necessary to replace open end winged spinner on 1964-1966 models.
65-66 Caprice, S.S. (exc. w ire whl. cvr.),
66 Chevelle,67 Nova (S.S.) (exc. mag. wheels,
disc brakes) .................... ............... 3 9 6 4 5 2 2 4 5 .20 O R N A M E N T .............................................................67 All w /D isc Brakes (exc.
aluminum, Sta. W a g .) .................. 3 9 0 1 7 1 5 4 3.55 O R N A M E N T , hub c a p ...........................................67-69 Chevy, Chevelle, Camaro w /w ire
wheels,65 El Camino Custom,65 Malibu (S.S.) (exc. w ire wheels) . 3 8 6 0 2 4 3 4 5 .80 O R N A M E N T , wheel cover . ...............................68 Chevy, Chevelle, Camaro (S.S.),70 Nova, Chevelle (S.S.) (1st
design) .............................................. 3 9 5 6 7 7 0 4 3.85 O R N A M EN T (23/ 4" dia. with S.S. emblem) . .70 Nova, Chevelle w /w heel trim
cover,71-72 Chevelle, Nova, Camaro
w /deluxe wheel trim cover(exc. Monte Carlo) ....................... 3 9 8 0 9 8 4 4 2 4 .10 O R N A M E N T (cross flag ty p e ) ............................
70 Nova, Chevelle (S.S.) (2nddesign) .............................................. 3 9 8 3 3 2 3 A.R. 4.85 O R N A M EN T (23/ 4" dia. with S.S. emblem)
(3 attaching holes) ..............................................65 Nova (Super Sport),67-68 Camaro (350 , 3 9 6 ) .......................... 3 8 2 7 3 9 3 4 10.60 O R N A M EN T ASSY., w /hub wheel cover . . .68-69 Pass, w /m ag. wheel (exc. fender
s k ir t ) ................................................... 3 9 1 3 1 2 5 A.R. .73 O R N A M EN T A S S Y..................................................68-69 All w /D isc Brake, spec, wheel,70 All w /R ally W heel (exc. Camaro),71-75 Chevelle w /ra lly w h e e l .................. 3 9 2 5 8 0 5 4 4 .90 O R N A M E N T ASSY., hub type ornament
marked (Chev. Motor Div.) ..............................6 4 Malibu (exc. w ire wheel),
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ________________5.871-5.871 5 -58 REV. 4-76
65 Nova (S.S.) w ire w h e e l .................. 3 8 4 0 9 7 6 4 .24 REINFO RCEM EN T, wheel c o v e r.......................6 5 -66 Caprice, S.S. (exc. w ire wheel
cover),66 M alibu (El Camino) (S.S.) (exc.
wire w h e e ls ) ............................ 3 8 6 0 2 1 6 4 .24 R EINFO RCEM EN T ................................................68 -69 All w /sim . mag. wheels ............... 3 9 3 1 8 8 4 1 1.50 RETAINER, outer cover insert .........................69 Pass, w /w hee l trim c o v e r ............. 3 9 5 4 6 3 0 4 .24 RETAINER, s p rin g ...................................................69 Chevy, Chevelle (S.S.),70 Nova, Chevelle, Camaro (S.S.) . . 3 9 3 7 9 9 4 1.10 R E T A IN E R ..................................................................64 -66 Malibu (S.S.) El Camino Deluxe
(exc. wire wheel c o v e r)............... 9 4 2 2 2 0 7 12 .13 SCR EW , wheel trim cover hub (8— 18 xV 8")— ( 8 .9 7 7 ) ........................................................
65 -66 Pass.,67 -69 Chevy, Camaro, Chevelle w /D isc
Brakes, w ire wheels,67 -69 Pass. w /D isc Brakes,68 -69 Pass, w /m ag. wheel,70 All w /R a lly W heel (exc. Camaro),71 -75 Chevelle w /ra lly w h e e l .................. 3 8 2 4 1 9 5 16 .11 SCREW , wire wheel cover ornament (8-18 x
Vie") (hex. hd.-spherical f a c e ) .........................65 -68 All w /sim ulated wire wheel . . . . 3 8 5 9 5 8 16 .13 SCR EW , trim spinner ornament (8-18 x 7/ 8")65 -68 Chevy, Camaro, Chevelle w /1 4"
wire wheels,65 -6665-66
Pass w /1 4" wire wheels 3 8 7 4 6 8 6 A.R. .80 SPOKE ASSY., outer ...........................................Chevy w /1 3" w ire wheels .......... 3 8 8 8 8 3 0 A.R. .80 SPOKE ASSY., in h e r.......... ...............................
5.875 STEM ASSY.— CAP— EXTENSIONI, Tire Valve62-74 A l l ........................................................... 2 7 4 0 8 3 5 1.10 tubeless tire, snap in type w /cap (1V 4" O.L.)62 A l l ........................................................... 2 7 4 2 8 8 5 1.20 (1Vz in. snap in type) w /c a p ...............................62 -70 Pass.,65 -70 Chevelle,71 -73 El Camino, Monte C a r lo ............... 3 1 7 1 5 9 8 5 .18 CAP (type "F"— 3/ 8" O.D. x 37/ 64" lo n g ) ..........62 Chevy w /1 4" wheels,6 3 -69 Chevy,6 4 -69 Chevelle,65 S.S.,65 -69 Pass. (exc. w ire wheel covers),69 Camaro,70 Pass., Nova, Chevelle,71 -74 Chevelle,7 2 -74 Nova ...................................................... 9 4 1 7 7 4 5 4 .63 E XTENSIO N, tubeless tire valve stem (7/ 8"
O .L .)............................................................................63 Chevy w /1 4" wheels,64 Chevelle,68-72 All,73 -74 All w /RPO Pol..................................... 9 4 2 2 8 7 2 A.R. .58 EXTEN SIO N , tubeless tire valve stem
( 127/ 32") .....................................................................64 -69 All,70 Pass., Nova, Chevelle,71 -75 A l l ...........................................................
5.880 INFLATER ASSY.9 4 2 2 2 1 2 4
— RETAINER.58 EXTENSIO N, valve stem (1n/ 32" O .L .) .............
62 -7 4 A l l ........................................................... 3 8 9 1 4 4 1 1 7 .25 tire w /sealer .............................................................67 -69 Camaro w /space saver wheel,73 -75 All w /space saver wheel ............. 4 8 6 5 0 8 1 8.45 tire (16 .9 oz.) (2 .96 dia. can) (8.06 height)
(use W /E 78-14, F78-14 w /6 " rim) (F78-14 w /5 " rim, w /G 7 8 -1 4 w /6 " rim) (repl. 4 9 4 6 0 7 ) ..................................................................
75 Vega, Monza w /space saver tire 4 8 6 5 0 6 1 7 .00 (13 .60Z) .....................................................................67 -69 Camaro w /space saver wheel . . 3 9 3 4 1 8 4 1 .70 RETAINER, in f la to r ....................... .f ......................
_________________ GM PARTS D IV IS IO N , GENERAL MOTORS CORPORATION — CHEVROLET— 11 ---------------------------REV. 4-76 5-59 5.871-5.880
69-70 All (exc. Sta. W a g .) ......................... 1550521 2
70 All (exc. Sta. W a g .) ......................... 3963229 169-70 All (exc. Sta. W a g .) ......................... 1378545 169-70 All (exc. Sta. W a g .) ......................... 94 33 15 3 1
1.23 CONTAINER ASSY., compound aerosol (24per c a s e )....................................................