75157120-HCD-ZX80DZX100D

SERVICE MANUAL

DVD DECK RECEIVER

US ModelHCD-ZX80D

E ModelHCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

Ver. 1.1 2007.03

SPECIFICATIONS

9-887-251-022007C05-1© 2007.03

Sony CorporationHome Audio DivisionPublished by Sony Techno Create Corporation

• HCD-ZX80D is the amplifier, disc player, tape deckand tuner section in FST-ZX80D/LBT-ZX80D.

• HCD-ZX100D is the amplifier, disc player, tape deckand tuner section in FST-ZX100D/LBT-ZX100D.

DVDModel Name Using Similar Mechanism NEW

SectionDVD Mechanism Type CDM74HF-DVBU101

Optical Pick-up Block Name KHM-310CAB or KHM-313CAB

Tape deck Model Name Using Similar Mechanism NEW

Section Tape Transport Mechanism Type CWN42RR603

– Continued on next page –

Photo: HCD-ZX80D

This system incorporates Dolby* Digital, Dolby Pro Logic (II) adaptive matrix surround decoder, and the DTS** Digital Surround System.* Manufactured under license from Dolby

Laboratories.“Dolby”, “Pro Logic”, and the double-D symbol are trademarks of Dolby Laboratories.

**Manufactured under license from Digital Theater Systems, Inc. “DTS” and “ DTS Digital Surround” are registered trademarks of Digital Theater Systems, Inc.

Amplifier sectionHCD-ZX100DThe following are measured at AC 120, 127, 220, 240V 50/60 Hz DIN power output (rated): 130 W + 130 W

(6 ohms at 1 kHz, DIN)Continuous RMS power output (reference)

Front speaker: 170 W + 170 W(6 ohms at 1 kHz, 10% THD)

Center speaker: 80 W(16 ohms at 1 kHz, 10% THD)

Surround speaker: 170 W + 170 W(6 ohms at 1 kHz, 10% THD)

Subwoofer: 180 W (8 ohms at 100 Hz, 10% THD)

HCD-ZX80DThe following are measured at AC 120, 127, 220, 240V 50/60 HzDIN power output (rated):155 W + 155 W

(6 ohms at 1 kHz, DIN)Continuous RMS power output (reference)Front speaker: 200 W + 200 W

(6 ohms at 1 kHz, 10% THD)

Center speaker: 80 W(16 ohms at 1 kHz, 10% THD)

Surround speaker: 200 W + 200 W(6 ohms at 1 kHz, 10% THD)

InputsVIDEO INPUT (phono jacks):

VIDEO: 1 Vp-p, 75 ohmsAUDIO L/R: Voltage 250 mV, impedance 47 kilohms

TV/SAT AUDIO IN L/R (phono jacks):Voltage 250 mV/450 mV, impedance 47 kilohms

MIC 1 or 2 (phone jack): Sensitivity 1 mV, impedance 10 kilohms

OutputsAUDIO OUT (phono jacks):

Voltage 250 mV,impedance 1 kilohm

VIDEO OUT (phono jack):Max. output level 1 Vp-p,unbalanced, Sync. negative load impedance 75 ohms

COMPONENT VIDEO OUT:Y: 1 Vp-p, 75 ohmsPB/CB: 0.7 Vp-p, 75 ohmsPR/CR: 0.7 Vp-p, 75 ohms

AUDIO POWER SPECIFICATION(HCD-ZX80D USA model only)

POWER OUTPUT AND TOTAL HARMONIC DISTORTION:

With 6-ohm loads, both channels driven, from 120 Hz − 10 kHz; rates 160 watts per channel minimum RMS power, with no more than 10% total harmonic distortion from 250 milliwatts to rated output.

Continuous RMS power output (reference)Front speaker: 200 W + 200 W

(6 ohms at 1 kHz, 10% THD)Center speaker: 80 W

(16 ohms at 1 kHz, 10%

THD)Surround speaker: 200 W + 200 W

(6 ohms at 1 kHz, 10% THD)

2

HCD-ZX80D/ZX100D

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

Tuner sectionFM stereo, FM/AM superheterodyne tuner

FM tuner sectionTuning range 87.5 − 108.0 MHz

(50 kHz step)Antenna FM lead antennaAntenna terminals 75 ohms unbalanced Intermediate frequency 10.7 MHz

AM tuner sectionTuning range Pan American models: 530 − 1,710 kHz

(with the interval set at 10 kHz)531 − 1,710 kHz(with the interval set at 9 kHz)

Other models: 531 − 1,602 kHz (with the interval set at 9 kHz)530 − 1,710 kHz (with the interval set at 10 kHz)

Antenna AM loop antennaAntenna terminals External antenna terminal Intermediate frequency 450 kHz

GeneralPower requirements

Mexican model: 127 V AC, 60 Hz

US model: 120 V AC, 60 Hz

Other models: 120 V, 220 V or 230 − 240 V AC, 50/60 HzAdjustable with voltage selector

Power consumptionHCD-ZX100D 430 W

HCD-ZX80D 390 W

Dimensions (w/h/d) (Approx.)

281 × 379 × 404.5 mm

(11 1/8 × 15 × 16 in.)

Mass (Approx.) 16.3 kg(35 lb 15 oz)

Design and specifications are subject to change without notice.

Frequency response DVD (PCM 48 kHz):2 Hz − 22 kHz (±1dB)CD: 2 Hz − 20 kHz (±0.5 dB)

Video color system formatPan American models: NTSCOther models: NTSC and PAL

Tape deck sectionRecording system 4-track 2-channel stereo Frequency response 50 − 13,000 Hz (±3 dB),

using Sony TYPE I tape

Disc player section System Compact disc and digital

audio and video systemLaser Semiconductor laser

(DVD: λ = 650 nm, CD: λ = 790 nm)Emission duration:continuous

CENTER SPEAKER: Use only the supplied speaker

SUBWOOFER OUT:HCD-ZX100D: Use only the supplied

subwooferHCD-ZX80D (phono jacks):

Voltage 250 mV,impedance 1 kilohm

SURR SPEAKER: Use only the supplied speakers

PHONES (stereo mini jack):accepts headphones of 8 ohms or more

FRONT SPEAKER: Use only the supplied speakers

S VIDEO OUT (4-pin/mini-DIN jack):Y: 1 Vp-p, unbalanced,Sync. negativeC: 0.286 Vp-p, load impedance 75 ohms

Ver. 1.1

3

HCD-ZX80D/ZX100D

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

Flexible Circuit Board Repairing• Keep the temperature of the soldering iron around 270 ˚C

during repairing.• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering

or unsoldering.

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardous radiationexposure.

SELF DIAGNOSIS FUNCTION

(When letters/numbers appear in the display)

When the self-diagnosis function is activated to prevent the system from malfunctioning, a 5-character service number (e.g. C 13 50) with a combination of a letter and 4 digits appears on the TV screen and the front panel display. In this case, check the following table.

When displaying the version number on the TV screen

When you turn on the system, the version number [VER.X.XX] (X is a number) may appear on the TV screen. Although this is not a malfunction and for Sony service use only, normal system operation will not be possible. Turn off the system, and then turn on the system again to operate.

Self-diagnosis Function

First 3 characters of the service number

Cause and corrective action

C 13 This disc is dirty.

• Clean the disc with a soft cloth.

C 31 The disc is not inserted correctly.

• Restart the system, then re-insert the disc correctly.

E XX(XX is a number)

To prevent a malfunction, the system has performed the self-diagnosis function.

• Contact your nearest Sony dealer or local authorized Sony service facility and give the 5-character service number.Example: E 61 10

VER.X.XX

This appliance is classified as a CLASS 1 LASER product. This label is located on the rear exterior.

The following caution label is located inside the apparatus.

Ver. 1.1

SAFETY CHECK-OUTAfter correcting the original service problem, perform the followingsafety check before releasing the set to the customer:Check the antenna terminals, metal trim, “metallized” knobs, screws,and all other exposed metal parts for AC leakage.Check leakage as described below.

LEAKAGE TESTThe AC leakage from any exposed metal part to earth ground andfrom all exposed metal parts to any exposed metal part having areturn to chassis, must not exceed 0.5 mA (500 microamperes.).Leakage current can be measured by any one of three methods.

1. A commercial leakage tester, such as the Simpson 229 or RCAWT-540A. Follow the manufacturers’ instructions to use theseinstruments.

2. A battery-operated AC milliammeter. The Data Precision 245digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of aVOM or battery-operated AC voltmeter. The “limit” indicationis 0.75 V, so analog meters must have an accurate low-voltagescale. The Simpson 250 and Sanwa SH-63Trd are examplesof a passive VOM that is suitable. Nearly all battery operateddigital multimeters that have a 2 V AC range are suitable. (SeeFig. A)

Fig. A. Using an AC voltmeter to check AC leakage.

1.5 kΩ0.15 µFACvoltmeter(0.75 V)

To Exposed MetalParts on Set

Earth Ground

4

HCD-ZX80D/ZX100D

TABLE OF CONTENTS

1. SERVICING NOTES ............................................... 5

2. GENERAL ................................................................... 7

3. DISASSEMBLY3-1. Disassembly Flow ........................................................... 83-2. Case ................................................................................. 93-3. Escution Top Block ......................................................... 93-4. Loading Panel .................................................................. 103-5. Tuner (FM/AM) (TM10SE) ............................................ 103-6. DVD Mechanism Deck Block ......................................... 113-7. Front Panel Block ............................................................ 113-8. Back Panel Block ............................................................ 123-9. MAIN Board Block ......................................................... 123-10. MAIN Board .................................................................... 133-11. Cover (CDM)................................................................... 133-12. DRIVER Board, SW Board ............................................. 143-13. Optical Pick-Up Block

(KHM-310CAB or KHM-313CAB) ............................... 143-14. SENSOR Board ............................................................... 153-15. MOTOR (TB) Board ....................................................... 153-16. MOTOR (LD) Board ....................................................... 16

4. TEST MODE .............................................................. 17

5. MECHANICAL ADJUSTMENTS ....................... 21

6. ELECTRICAL ADJUSTMENTS ......................... 21

7. DIAGRAMS7-1. Block Diagram – RF SERVO/VIDEO Section – ............ 237-2. Block Diagram – MIC/EFFECTOR Section – ................ 247-3. Block Diagram – TUNER/TAPE Section – .................... 257-4. Block Diagram – AUDIO Section – ................................ 267-5. Block Diagram – AMP Section – .................................... 277-6. Block Diagram

– PANEL/POWER SUPPLY Section – ........................... 287-7. Printed Wiring Board – DMB15 Board (Side A) – ......... 307-8. Printed Wiring Board – DMB15 Board (Side B) – ......... 317-9. Schematic Diagram – DMB15 Board (1/4) – .................. 327-10. Schematic Diagram – DMB15 Board (2/4) – .................. 337-11. Schematic Diagram – DMB15 Board (3/4) – .................. 347-12. Schematic Diagram – DMB15 Board (4/4) – .................. 357-13. Printed Wiring Boards – CHANGER Section – .............. 367-14. Schematic Diagram – CHANGER Section – .................. 37

7-15. Printed Wiring Board – VIDEO Board – ......................... 387-16. Schematic Diagram – VIDEO Board – ........................... 397-17. Printed Wiring Board – MIC Board – ............................. 407-18. Schematic Diagram – MIC Board – ................................ 417-19. Printed Wiring Board – EFFECTOR Board – ................. 427-20. Schematic Diagram – EFFECTOR Board – .................... 437-21. Printed Wiring Board – KARAOKE Board – ................. 447-22. Schematic Diagram – KARAOKE Board – .................... 447-23. Printed Wiring Board – MAIN Board – .......................... 457-24. Schematic Diagram – MAIN Board (1/6) – .................... 467-25. Schematic Diagram – MAIN Board (2/6) – .................... 477-26. Schematic Diagram – MAIN Board (3/6) – .................... 487-27. Schematic Diagram – MAIN Board (4/6) – .................... 497-28. Schematic Diagram – MAIN Board (5/6) – .................... 507-29. Schematic Diagram – MAIN Board (6/6) – .................... 517-30. Printed Wiring Board – PA Board – ................................ 527-31. Schematic Diagram – PA Board – ................................... 537-32. Printed Wiring Board – SURROUND Board – ............... 557-33. Schematic Diagram – SURROUND Board (1/2) – ......... 567-34. Schematic Diagram – SURROUND Board (2/2) – ......... 577-35. Printed Wiring Board – PANEL Board – ........................ 587-36. Schematic Diagram – PANEL Board – ........................... 597-37. Printed Wiring Boards – FRONT KEY Section – ........... 607-38. Schematic Diagram – FRONT KEY Section – ............... 617-39. Printed Wiring Boards – TOP KEY Section – ................ 627-40. Schematic Diagram – TOP KEY Section – ..................... 637-41. Printed Wiring Board – TRANSFORMER Board – ....... 647-42. Printed Wiring Board – PRIMARY Board – ................... 657-43. Schematic Diagram – POWER SUPPLY Section – ........ 66

8. EXPLODED VIEWS8-1. Case, Escutcheon Top Section ......................................... 818-2. PANEL Board Section ..................................................... 828-3. Tape Mecha Deck Section ............................................... 838-4. Back Panel Section .......................................................... 848-5. DMB15/KARAOKE/VIDEO Boards Section ................. 858-6. MAIN/PA/SURROUND Boards Section ........................ 868-7. Power Transformer Section ............................................. 878-8. DVD Mechanism Deck Section-1

(CDM74HF-DVBU101) .................................................. 888-9. DVD Mechanism Deck Section-2

(CDM74HF-DVBU101) .................................................. 89

9. ELECTRICAL PARTS LIST ................................ 90

Note: Refer to SUPPLEMENT-1 for the MAIN board of printedwiring board, schematic diagram and electrical parts list ofUS model.

Ver. 1.1

5

HCD-ZX80D/ZX100D

MODEL IDENTIFICATION– Back Panel –

Label indication Model

2-661-760-5[] E2 ZX80D: E2

2-661-760-6[] E2 ZX100D: E2

2-661-761-3[] MX ZX100D: MX

2-661-761-4[] MX ZX80D: MX

2-672-142-0[] E3 ZX100D: E3

2-672-142-1[] E3 ZX80D: E3

2-675-973-2[] E51 ZX80D: E51

2-675-973-3[] E51 ZX100D: E51

2-686-974-1[] SP2/6 ZX100D: SP, MY

2-686-106-0[] E13 ZX80D: E3

2-899-693-0[] U2 ZX80D: US

• AbbreviationE2 : 120V AC area in E modelE3 : 240V AC area in E modelE13 : Russian model and 220V – 230V AC area in E modelE51 : Chilean and Peruvian modelsMX : Mexican modelMY : Malaysia modelSP : Singapore model

HOW TO IDENTIFY OPTICAL PICK-UP BLOCKThere are two kinds of OPTICAL PICK-UP BLOCK in this set.When replacing the OPTICAL PICK-UP BLOCK, make sure whichOPTICAL PICK-UP BLOCK it is following the “How to Identify”in the figure shown below.

SECTION 1SERVICING NOTES

NOTES ON HANDLING THE OPTICAL PICK-UPBLOCK OR BASE UNIT

The laser diode in the optical pick-up block may suffer electrostaticbreak-down because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission,observe from more than 30 cm away from the objective lens.

UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the lead-free mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARKUnleaded solder has the following characteristics.

• Unleaded solder melts at a temperature about 40 °C higherthan ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350 °C.Caution: The printed pattern (copper foil) may peel away if

the heated tip is applied for too long, so be careful!• Strong viscosity

Unleaded solder is more viscou-s (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

RELEASING THE DVD TRAY LOCKThe disc tray lock function for the antitheft of an demonstrationdisc in the store is equipped.

Releasing Procedure :1. Press the I/1 button to turn the power on.2. Press the DVD button to select “DVD”.3. While pressing the x button, press the Z OPEN/CLOSE button

until “UNLOCKED” displayed on the fluorescent indicatortube (around 5 seconds).

Note: When “LOCKED” is displayed, the disc tray lock is not released byturning power on/off with the I/1 button.

NOTES ON REPLACEMENT OF THE DMB15 BOARDNew part of EEPROM (IC103) on the DMB15 board cannot beused. Therefore, if the mounted DMB15 board is replaced, exchangenew EEPROM with that used before the replacement.

Model number label

Printed of KHM-310CAB or KHM-313CAB.

KHM-310CABor

KHM-313CAB

Ver. 1.1

6

HCD-ZX80D/ZX100D

You can play back the following discs on this system. Other discs cannot be played back.

List of playable discs

“DVD+RW”, “DVD-RW”, “DVD+R”, “DVD VIDEO”, and the “CD” logos are trademarks.

Notes on discs

The system can play back the following disc:• CD-ROMs/CD-Rs/CD-RWs recorded in the

following formats:

– VIDEO CD format

– AUDIO CD format

– CD Graphics (Latin American models only)

– DATA CD format which contains MP3 audio tracks, JPEG image files and DivX 1)

video files of format conforming to ISO 2)

9660 Level 1, Level 2 or Joliet in 3)

expansion format• DVD-ROMs/DVD-Rs/DVD-RWs/DVD+Rs/

DVD+RWs recorded in the following formats:

– DVD VIDEO format

– DATA DVD format which contains MP3 audio tracks, JPEG image files and DivX 1)

video files of format conforming to UDF 2)

(Universal Disk Format)

– VR (Video Recording) format (DVD-Rs/DVD-RWs only)

The system cannot play back the following discs:

1) MP3 audio tracks must be in MPEG 1 Audio Layer 3 format.

2) DivX video files must be recorded in DivX format with the extension “.AVI” or “.DIVX”. (Except US model)

3) ISO 9660 FormatA logical format of files and folders on CD-ROMs, defined by ISO (International Organization for Standardization).

Playable discs

Format of discs Disc logo

DVD VIDEO

DVD-RW/DVD-R

DVD+RW/DVD+R

VIDEO CD

AUDIO CD

CD Graphics (CDG) (Latin American models only)

CD-R/CD-RW

4) CD-Extra: This format records audio (AUDIO CD data) on the tracks in session 1 and data on the tracks in session 2.

5)Mixed CD: This format records data on the first track and audio (AUDIO CD data) on the second and subsequent tracks of a session.

Region code of DVD VIDEOs you can play back on this system

Your system has a region code printed on the back of the unit and will only play back DVD VIDEOs labeled with identical region code.DVD VIDEOs labeled will also be played back on this system.If you try to play back any other region code DVD VIDEO, the message “Playback prohibited by area limitations.” will appear on the TV screen. Depending on the DVD VIDEO, no region code indication may be labeled even though playing the DVD VIDEO is prohibited by area restrictions.

Example:

Note on DualDiscs

A DualDisc is a two sided disc product which mates DVD recorded material on one side with digital audio material on the other side. However, since the audio material side does not conform to Compact Disc (CD) standard, playback on this product is not guaranteed.

ALL

DVD DECK RECEIVER

MODELN0. HCD-ZX100D

SERIAL NO.

AC:120-127/220/230-240V 50/60Hz430W

Region code

Notes on CD-R/CD-RW/DVD-R/DVD-RW/DVD+R/DVD+RW

• In some cases, CD-Rs/CD-RWs/DVD-Rs/ DVD-RWs/DVD+Rs/DVD+RWs cannot be played back on this system due to the recording quality or physical condition of the disc, or the characteristics of the recording device and authoring software. The disc will not be played back if it has not been correctly finalized. For more information, see the operation instructions for the recording device.

• Note that some playback functions may not work with some DVD+RWs/DVD+Rs, even if they have been correctly finalized. In this case, view the disc by normal playback.

• A disc created in Packet Write format cannot be played back.

Note on playback operations of DVD VIDEOs and VIDEO CDs

Some playback operations of DVD VIDEOs and VIDEO CDs may be intentionally set by software producers. Since this system play back DVD VIDEOs and VIDEO CDs according to the disc contents the software producers designed, some playback features may not be available. Also, refer to the instructions supplied with the DVD VIDEOs or VIDEO CDs.

Note on PBC (Playback Control) (VIDEO CDs)

This system conforms to Ver. 1.1 and Ver. 2.0 of VIDEO CD standards. You can enjoy two kinds of playback depending on the disc type.

Disc type You can

VIDEO CDs without PBC functions (Ver. 1.1 discs)

Enjoy video playback (moving pictures) as well as music.

Music discs encoded with copyright protection technologies

This product is designed to play back discs that conform to the Compact Disc (CD) standard. Recently, various music discs encoded with copyright protection technologies are marketed by some record companies. Please be aware that among those discs, there are some that do not conform to the CD standard and may not be playable by this product.

Notes on Multi Session disc

• This system can play back Multi Session discs when an MP3 audio track is contained in the first session. Any subsequent MP3 audio tracks recorded in later sessions can also be played back.

• This system can play back Multi Session discs when a JPEG image file is contained in the first session. Any subsequent JPEG image files recorded in later sessions can also be played back.

• If the first session is recorded in AUDIO CD or VIDEO CD format, only the first session will be played back.

VIDEO CDs with PBC functions (Ver. 2.0 discs)

Play back interactive software using menu screens displayed on the TV screen (PBC Playback), in addition to the video playback functions of Ver. 1.1 discs. Moreover, you can play back high-resolution still pictures, if they are included on the disc.

Disc type You can

• The system will recognize a Multi Session disc as an AUDIO CD if there is a session recorded in AUDIO CD format on the disc. However, the system will only play back the disc if the first session is recorded in AUDIO CD format.

• With DATA CD or DATA DVD, the system will only play back DivX video files even if it contains MP3 audio tracks or JPEG image files.

• CD-ROMs recorded in PHOTO CD format• Data part of CD-Extras4)

• Data part of Mixed CDs5)

• Super Audio CDs• DVD Audio discs• DVD-RAMs• A DVD VIDEO with a different region code.• A disc that has a non-standard shape (e.g.,

heart, square, star).• A disc that has the adhesive cellophane tape

or a sticker still left on it.

Ver. 1.1

7

HCD-ZX80D/ZX100DSECTION 2GENERAL

This section is extracted frominstruction manual.

LOCATION OF CONTROLS

Remote control

ADVANCE wfALBUM +/– qa ANGLE q;AUDIO 8CLEAR wkDISC SKIP 3DISPLAY edENTER whFM MODE 7FUNCTION +/– 4 KARAOKE MODE eaKARAOKE PON e;KEY CONTROL #/2 es

MENU qsNumeric Buttons1)wl

PICTURE NAVI 6PRESET + qh PRESET – wd REPEAT 7 REPLAY wfSCORE 5SLEEP egSLOW qjSLOW wsSOUND FIELD qd

STEP C wf

SUBTITLE 9

THEATRE SYNC 1TIMER MENU ehTIME/TEXT efTOP MENU wjTUNING + qj TUNING – ws TV w;TV CH + qh TV CH – wd TV/VIDEO egTV VOL +/– qf1)

TV &/1 (on/standby) 2VOLUME +/– qf1)

?/1 (on/standby) 2

x (stop) qk

X (pause) qlH1) (play) wa

> (go forward) qh

. (go backward) wd

M (fast forward) qj m (rewind) ws V/v/B/b wh

10/0 wl-/-- wkO RETURN wg

DISPLAY qg

c STEP wf

1) The numeric button 5, TV VOL +, VOLUME + and Hbuttons have a tactile dot. Use the tactile dot as a reference when operating the system.

ALPHABETICAL ORDER

A – L

M – S

T – Z

NUMBERS AND SYMBOLS

Unit

AMP MENU e; BALANCE rhBEAT JUMP rsBEAT MAX raBEAT PAD r;CD SYNC q;CHORUS wlDeck A eaDeck B qkDELAY wkDIRECTION qlDISC 1 ~ 3 tsDisc tray 8

DISPLAY 2Display 6 DVD ej

ECHO LEVEL ws ENTER waEQ BAND w; EX-CHANGE/DISC SKIP t; FADER rgFLANGER 3GROOVE qhILLUMINATION 1IR Receptor ek

MASTER VOLUME wfMIC 1/2 (jack) wg MIC 1/2 LEVEL wdOPERATION DIAL taPHONES (jack) wj Power illuminator 5PRESET +/– qf PROGRESSIVE 7 RANDOM rdREC PAUSE/START 9

SOUND FIELD 4SPEAKERS rjTAPE A/B egTUNER/BAND eh

TUNING +/– qg TV/SAT efVIDEO INPUT (jacks) whVIDEO edX-ROUND JOG rkX-ROUND OFF rjWAVE rf

?/1 (on/standby) el

Z OPEN/CLOSE rl

nN (play) qa

.> (go backward/forward) qf

mM (rewind/fast forward) qg

X (pause) qsx (stop) qd A Z (Eject A) es B Z (Eject qj

ALPHABETICAL ORDER

A – D

E – L

M – R

S – Z

SYMBOLS

Front Panel

Top Panel

1234 5678

9q;qaqsqdqfqgqhqj

qk

wa

w;ql

wswdwfwgwhwj

e;

wl

wk

eaesedef

egeh

ejek

el

rgrfrdrsrar;

tsta t;rl

rjrh rk

7

5

q;

qh

qj

qk

ql

wa

wdwf

wh

wj

wk

wl

ea

es

edef

eg

eh

e;

qg

qf

qsqa

9

8

6

4

3

1

2

w;

ws

wg

qd

1 Press ?/1 to turn on the system.

2 Press TIMER MENU.

The hour indication flashes in the display.

3 Press V or v repeatedly to set the hour.

4 Press ENTER.

The minute indication flashes in the display.

5 Press V or v repeatedly to set the minute.

6 Press ENTER.

The clock starts functioning.

To adjust the clock

1 Press TIMER MENU.

“PLAY SET?” flashes in the display.

2 Press V or v repeatedly to select “CLOCK SET?”, then press ENTER.

The hour indication flashes in the display.

3 Do the same procedures as step 3 to 6 above.

Notes• The clock settings are canceled when you disconnect

the power cord or if a power failure occurs.

• You cannot set the clock in Power Saving Mode.

Setting the clock

8

HCD-ZX80D/ZX100DSECTION 3

DISASSEMBLY

• This set can be disassembled in the order shown below.

3-1. DISASSEMBLY FLOW

SET

3-2. CASE(Page 9)

3-3. ESCUTCHEON TOP BLOCK(Page 9)

3-4. LOADING PANEL(Page 10)

3-9. MAIN BOARD BLOCK(Page 12)

3-12. DRIVER BOARD, SW BOARD(Page 14)

3-13. OPTICAL PICK-UP BLOCK(KHM-310CAB or KHM-313CAB)(Page 14)

3-10. MAIN BOARD(Page 13)

3-15. MOTOR (TB) BOARD(Page 15)

3-16. MOTOR (LD) BOARD(Page 16)

3-7. FRONT PANEL BLOCK(Page 11)

3-5. TUNER (FM/AM) (TM10SE)(Page 10)

3-6. DVD MECHANISM DECK BLOCK(Page 11)

3-14. SENSOR BOARD(Page 15)

3-8. BACK PANEL BLOCK(Page 12)

3-11. COVER (CDM)(Page 13)

Note 1: The process described in can be performed in any order.

Note 2: Without completing the process described in , the next process can not be performed.

9

HCD-ZX80D/ZX100D

Note: Follow the disassembly procedure in the numerical order given.

3-2. CASE

3-3. ESCUTCHEON TOP BLOCK

3 screw (case 3 TP2)

5 case

2 two screws(BVTP 3 ×10)

1 three screws(BVTP 3 × 10)

3 screw (case 3 TP2)

2 two screws(BVTP 3 ×10)

4 two screws(case 3 TP2)

4 two screws(case 3 TP2)

3 wire (flat type) (7 core)(CN1153)

2 boss

4 escutcheon top block

2 boss

1 screw(BVTP 3 × 12)

1 screw(BVTP 3 × 12)

10

HCD-ZX80D/ZX100D

3-5. TUNER (FM/AM) (TM10SE)

3-4. LOADING PANEL

3 four claws

1 Turn the gear (loading A)to the direction of the arrow.

2

4 loading panel

3 tuner (FM/AM) (TM10SE)

2 two screws(BVTT 3 × 8)

1 wire (flat type) (9 core)

11

HCD-ZX80D/ZX100D

8 DVD mechanisim deck block


4 three connectors(CN401, CN800, NO2000)

4 connector(CN802) 1 wire (flat type) (13 core)

(CN106)

6

7


5 four screws(BVTT 3 × 10)

5 three screws(BVTT 3 × 10)

4 six screws(BVTP 3 × 8)

3 connector(CN1102)


2 ground wire

1 screw(BV3 (3-CR))


8 three connectors(CN100, CN503, CN504)

9 front panel block

5

3-6. DVD MECHANISM DECK BLOCK

3-7. FRONT PANEL BLOCK

12

HCD-ZX80D/ZX100D

3-8. BACK PANEL BLOCK

3-9. MAIN BOARD BLOCK

2 connector(CN1204)

2 connector(CN1202)

2 connector(CN1200)

5 connector(CN580)

4

3 screw(BVTT 3 × 10)

3 four screws(BVTT 3 × 10)



6 back panel block


3 three screws(BV3 (3-CR))

3 screw(BV3 (3-CR))

6 MAIN board block




2 ground wire

13

HCD-ZX80D/ZX100D

3-10. MAIN BOARD

3 MAIN board

2 two connectors(CN513, CN514)


2 two connectors(CN501, CN502)

3-11. COVER (CDM)

2 KARAOKE board



7 connector(CN201)

9 cover (CDM)




5 VIDEO board

14

HCD-ZX80D/ZX100D

3-12. DRIVER BOARD, SW BOARD

3-13. OPTICAL PICK-UP BLOCK (KHM-310CAB or KHM-313CAB)

3 connector(CN703)

4 DRIVER board

6 SW board


1 two screws(BTTP (M2.6))

5 screw(BTTP (M2.6))

1 floating screw(PTPWH M2.6)

5 connector

2 holder (310) assy

6 wire (flat type)(24 core)

7 optical pick-up block(KHM-310CAB or KHM-313CAB)

4 two insulators

3 two insulatorscrews

3 two insulatorscrews

4 two insulators

15

HCD-ZX80D/ZX100D

3-14. SENSOR BOARD

2 tray

3 belt (table)

5 pulley (table)

8 screw(BTTP (M2.6))

0 SENSOR board

7 gear (geneva)

9 connector(CN731)

1 floating screw (PTPWH M2.6)



3-15. MOTOR (TB) BOARD

6 Remove the two solderings of motor.

8 MOTOR (TB) board

7 table motor assy (M741)


4

3 wire (flat type) (5 core) (CN742)

1 stopper

2 stopper

16

HCD-ZX80D/ZX100D

3-16. MOTOR (LD) BOARD

3 Remove the two solderings of motor.

4 MOTOR (LD) board

1 belt (loading)

5 loading motor assy (M751)


17

HCD-ZX80D/ZX100D

PANEL TEST MODEThis mode is used to check the fluorescent indicator tube, LEDs,keys, MASTER VOLUME knob, OPERATION DIAL knob, X-ROUND JOG knob, model, destination, software version and VACSlevel.Procedure:

1. Press three buttons of x , [ENTER] and [DISC 2] simultaneously.2. All LEDs except I/1 LED (green color) and segments in

fluorescent indicator tube are lighted up.3. When you want to enter the software version display mode,

press the [DISC 1] button. The model information appears onthe fluorescent indicator tube.

4. Each time the [DISC 1] button is pressed, the display changesfrom destination information, MC version, GC version, SYSversion, DVD version, ST version, TC version, TA version,TM version in this order, and returns to the model informationdisplay.

5. When the [DISC 3] button is pressed while the version numbersare being displayed except model information and destinationinformation, the date of the software creation appears. Whenthe [DISC 3] button is pressed again, the display returns to thesoftware version display. When the [DISC 1] button is pressedwhile the date of the software creation is being displayed, thedate of the software creation is displayed in the same order ofsoftware version display.

6. Press the [DISC 2] button, the key check mode is activated.7. In the key check mode, the fluorescent indicator tube displays

“K 0 V0J0 X0”. Each time a button is pressed, “K 0” valueincreases. However, once a button has been pressed, it is nolonger taken into account.

8. “V” value increases in the manner of 0, 1, 2, 3 ... if the[MASTER VOLUME] knob is turned clockwise, or it decreasesin the manner of 0, 9, 8, 7 ... if the [MASTER VOLUME] knob isturned counterclockwise.“J” value increases in the manner of 0, 1, 2, 3 ... if the[OPERATION DIAL] knob is turned clockwise, or it decreasesin the manner of 0, 9, 8, 7 ... if the [OPERATION DIAL] knob isturned counterclockwise.“X” value increases in the manner of 0, 1, 2, 3 ... if the [X-

ROUND JOG] knob is turned clockwise, or it decreases in themanner of 0, 9, 8, 7 ... if the [X-ROUND JOG] knob is turnedcounterclockwise.

9. When the [DISC 3] button is pressed after all LEDs except I/1 LED(green color) and segments in fluorescent indicator tube lightup, the fluorescent indicator tube displays “VACS A+B FAPC”. A is conventional VACS level which is triggered bysignal level. B is thermal VACS level which is triggered bytemperature F is shown if the fan is turned in high speed andvice-versa. C is VACS level which is triggered by APVACS(Abuse Protection VACS). The signal level , which will triggerVACS A is shown in the center area of the fluorescentindicator tube.

10. When [EX-CHANGE/DISC SKIP] button is pressed after all LEDsexcept I/1 LED (green color) and segments in fluorescentindicator tube light up, alternate segments in fluorescentindicator tube and LEDs would light up. If you press [EX-

CHANGE/DISC SKIP] button again, another half of alternatesegments in fluorescent indicator tube and LEDs would lightup. Press [EX-CHANGE/DISC SKIP] button again would causeall LEDs except I/1 LED (green color) and segments influorescent indicator tube lights up.

11. To release from this mode, press three buttons in the samemanner as step 1 or disconnect the power cord.

SECTION 4TEST MODE

COMMON TEST MODEThis mode is used to check operations of the respective sections ofamplifier and tape.Procedure:• To enter common test mode

1. Press three buttons of x , [ENTER] and [DISC 3] simultaneously.2. The DVD ring indicators, tape A and B indicators and the line

below DVD ring indicators and tape A and B indicators flashsynchronously on the fluorescent indicator tube. The functionis changed to “TV”.

• Check of amplifier1. Press the [EQ BAND] button repeatedly until a message “GEQ

MAX” appears on the fluorescent indicator tube. GEQincreases to its maximum.

2. Press the [EQ BAND] button repeatedly until a message “GEQMIN” appears on the fluorescent indicator tube. GEQdecreases to its minimum.

3. Press the [EQ BAND] button repeatedly until a message “GEQFLAT” appears on the fluorescent indicator tube. GEQ is setto flat.

4. When the [MASTER VOLUME] knob is turned clockwise evenslightly, the sound volume increases to its maximum and amessage “VOLUME MAX” appears on the fluorescentindicator tube.

5. When the [MASTER VOLUME] knob is turned counterclockwiseeven slightly, the sound volume decreases to its minimum anda message “VOLUME MIN” appears on the fluorescentindicator tube.

• Tape function1. When a tape is inserted in deck-B and recording is started, the

function is changed to “TV” automatically. When the [CD

SYNC] button is pressed during recording in function, ALC(Automatic Logic Control) is turned on.

2. During recording, press the m button will stop the recordingand the function is changed to “TAPE B” and rewind the tapein deck-B until the recording start position and playback ofthe tape is started. If the [REC PAUSE/START] button is pressedfor a pause and pressed again to resume recording duringrecording time, when the tape is rewind, the tape will be rewinduntil the position where the pause is applied.

• To release common test mode1. To release from this mode, press the I/1 button.2. The cold reset is enforced at the same time.

COLD RESETThe cold reset clears all data including preset data stored in theRAM to initial conditions.Procedure:

1. Press the I/1 button to turn on the system.2. Press three buttons of x , [ENTER] and I/1 simultaneously.3. The message “COLD RESET“ appears on the fluorescent

indicator tube. Then, the fluorescent indicator tube becomesblink for a while , and the system is reset.

VACS ON/OFFThis mode is used to switch on and off the VACS (VariableAttenuation Control System).Procedure:

1. Press the I/1 button to turn on the system.2. Press two buttons of x and [ILLUMINATION] simultaneously.

The message “VACS OFF” or “VACS ON” appears on thefluorescent indicator tube.

18

HCD-ZX80D/ZX100D

TUNER STEP CHANGEThe step interval of AM channels can be toggled between 9 kHzand 10 kHz. This mode is not available for Russian model.Procedure:

1. Press the I/1 button to turn on the system.2. Press the [TUNER/BAND] button repeatedly to select the “AM”.3. Press the I/1 button to turn off the system.4. Press two buttons of [ENTER] and I/1 simultaneously. The

system will turn on automatically. The message “AM 9kSTEP” or AM 10k STEP” appears on the fluorescent indicatortube and thus the channel step is changed.

DVD SHIP MODE (WITH MEMORY CLEAR)This mode moves the optical pick-up to the position durable tovibration and clears all data including preset data stored in the RAMto initial conditions. Use this mode when returning the set to thecustomer after repair.Procedure:

1. Press the I/1 button to turn on the system.2. Press the [DVD] button to select the “DVD”.3. Press three buttons of x , [DELAY] and I/1 simultaneously

during “DVD No Disc” condition. The system will turn offautomatically.

4. After the “STANDBY” blinking display finishes, a message“MECHA LOCK” appears on the fluorescent indicator tubeand the DVD ship mode is set.

DVD SHIP MODE (WITHOUT MEMORY CLEAR)This mode moves the optical pick-up to the position durable tovibration.Procedure:

1. Press the I/1 button to turn on the system.2. Press the [DVD] button to select the “DVD”.3. Press two buttons of [DVD] and I/1 simultaneously during

“DVD No Disc” condition. The system will turn offautomatically.

4. After the “STANDBY” blinking display finishes, a message“MECHA LOCK” appears on the fluorescent indicator tubeand the DVD ship mode is set.

DVD TRAY LOCK MODEThis mode is used to lock the disc tray. When this mode is activated,the disc tray will not open when Z OPEN/CLOSE button or [EX-

CHANGE/DISC SKIP] button is pressed. The message “LOCKED”appears on the fluorescent indicator tube.Procedure:

1. Press the I/1 button to turn on the system.2. Press the [DVD] button to select the “DVD”.3. Press two buttons of x and Z OPEN/CLOSE simultaneously

and hold down until “LOCKED” or “UNLOCKED” appearson the fluorescent indicator tube (around 5 seconds).

TV/SAT SWITCHINGThis mode let you switch from TV to SAT and vice-versa.Procedure:

1. Press the I/1 button to turn on the system.2. Press the [TV/SAT] button to select the “TV”.3. Press two buttons of [TV/SAT] and I/1 simultaneously. The

function will changed to SAT. Press the same buttons again tochange from SAT to TV.

DVD COLOR SYSTEMThis mode let you change the color system of the video output fromPAL to NTSC or vice-versa. This mode is not available for LatinAmerican model and Russian models.Procedure:

1. Press the I/1 button to turn on the system.2. Press the [DVD] button to select the “DVD”.3. Press the I/1 button to turn off the system.4. Press two buttons of X and I/1 simultaneously. The system

will turn on automatically. The message “COLOR PAL” or“COLOR NTSC” appears on the fluorescent indicator tube.

REMOTE DISABLE MODEThis mode let you disable the remote commander reception. Whenthis mode is activated, the system will not response if the button onthe remote commander is pressed. The message “RemoteDisable”appears on the fluorescent indicator tube. This mode is essentialfor conducting test and repairing when no interruption from theother remote commander is expected. This mode is cancelledautomatically when the AC power supply is cutoff.Procedure:

1. Press the I/1 button to turn on the system.2. Press three buttons of x , [FLANGER] and [DISC 2]

simultaneously until “RemoteDisable” or “RemoteEnable”appears on the fluorescent indicator tube.

TCM OFFLINE MODEThis mode is used to prevent the system from turning offautomatically when TCM is not connected. Therefore, measurementscan be done even when TCM is not connected during production.Procedure:

1. When the system is turned off, press three buttons of [EQ

BAND], [TAPE A/B] and I/1 simultaneously. The system willturn on automatically.

2. The message “TCM OFFLINE” appears on the fluorescentindicator tube.

MTK FIRMWARE DISPLAYThis mode is used to display the MTK firmware version.Procedure:

1. Press the I/1 button to turn on the system.2. Press the [DVD] button to select the “DVD”.3. Press the I/1 button to turn off the system.4. Press two buttons of x and I/1 simultaneously. The system

will turn on automatically.5. The version of MTK firmware appears on the TV screen.

MTK OFFLINEThis mode is used to enable audio output from the function otherthan DVD function in order to check the audio output from thesystem without connecting MTK.Procedure:

1. Press the I/1 button to turn on the system.2. Press three buttons of x , [FLANGER] and [DISC 1]

simultaneously and the message “MTK OFFLINE” appearson the fluorescent indicator tube.

19

HCD-ZX80D/ZX100D

DVD SECTION

1. DVD SERVICE MODE GENERAL DESCRIPTIONThis mode let you make diagnosis and adjustment easily by usingthe remote commander and the TV screen. The instructions,diagnostic results, etc. are given on the on-screen display.

2. ENTERING DVD SERVICE MODEProcedure:

1. Press the I/1 button to turn on the system.2. Press the [DVD] button to select the “DVD”.3. Press two buttons x and Z OPEN/CLOSE simultaneously and

then turn the [MASTER VOLUME] knob clockwise.4. The message “SERVICE IN” appears on the fluorescent

indicator tube and top menu of the Remocon Diagnosis Menuappears on the on-screen display on the TV screen as follows.The model name, IF-con version and Syscon version aredisplayed at the bottom of the on-screen display.

Remocon Diagnosis Menu

0. External Chip Check1. Servo Parameter Check2. Drive Manual Operation3. Emergency History4. Version Information

Model Name :xxxxxxxxxxIF-con:Ver.xx.xx(xxxx)Syscon:Ver.x.xxx

5. To execute each function, press its number by using numericbutton on the remote commander.

6. To release from this mode, press the I/1 button to turn off thesystem.

3. EXECUTING IOP MEASUREMENTIn order to execute IOP measurement, the following standardprocedures must be followed.Procedure:

1. From the top menu of Remocon Diagnosis Menu, select “2Drive Manual Operation” by pressing the [2] button on theremote commander. The following screen appears on the on-screen display

Drive Manual Operation

1. Servo Control2. Track/Layer Jump3. Manual Adjustment4. Mecha Test Mode5. MIRR time Adjust0. Return to Top Menu

2. Select “3. Manual Adjustment” by pressing the [3] button onthe remote commander. The following screen appears on theon-screen display.

Manual Adjust1. Track Balance Adjust:2. Track Gain Adjust:3. Focus Balance Adjust:4. Focus Gain Adjust:5. Eq boost Adjust:6. Iop:7. TRV. Level:8. S curve(FE) Level:9. RFL(PI) Level:0. MIRR Time:V v Change Value[RETURN]Return to previous menu

3. Select “6. Iop:” by pressing [6] button on the remotecommander.

4. Wait until a hexadecimal number appear in the on-screendisplay as below.

Manual Adjust1. Track Balance Adjust:2. Track Gain Adjust:3. Focus Balance Adjust:4. Focus Gain Adjust:5. Eq boost Adjust:6. Iop: ED:7. TRV. Level:8. S curve(FE) Level:9. RFL(PI) Level:0. MIRR Time:V v Change Value[RETURN]Return to previous menu

5. Convert data from hexadecimal to decimal by using conversiontable.

6. If the value is smaller than 93 (decimal), then it is OK. Howeverif the value is higher than 93, then BU (base unit) is defectiveand need to be change.

7. Press the O RETURN button on the remote commander toreturn to previous menu.

8. Press the [0] button on the remote commander to return to thetop menu of Remocon Diagnosis Menu.

9. Press the I/1 button to turn off the system.

4. CHECKING EMERGENCY HISTORYTo check the emergency history, please follow the followingprocedure.Procedure:

1. From the top menu of Remocon Diagnosis Menu, select “3.Emergency History” by pressing the [3] button on the remotecommander. The following screen appears on the on-screendisplay.

Emg. History CheckLaser Hours CD 999h 59min DVD 999h 59min

01. 01 05 04 04 00 92 46 00 00 00 00 00 00 00 23 45

02. 02 02 01 01 00 A9 4B 00 00 00 00 00 00 00 23 45

[Next]Next page [Prev]Prev page[0]Return to Top Menu

20

HCD-ZX80D/ZX100D

2. You can check the total time when the laser is turned on duringplayback of DVD and CD from the above menu. The maximumtime, which can be displayed are 999h 59min.

3. You can check the error code of latest 10 emergency historyfrom the above menu. To view the previous or next page ofemergency history, press the . or > button on theremote commander. The error code consists of three kinds oferror codes.

A. Error code

Example of Error code

01. 01 05 04 04 00 92 46 00 00 00 00 00 00 00 23 45

The meaning of error code is as below:01: Communication error (No reply from syscon)02: Syscon hung up03: Power OFF request when syscon hung up19: Thermal shutdown24: MoveSledHome error25: Mechanical move error (5 changer)26: Mechanical move stack error30: DC motor adjustment error31: DPD offset adjustment error32: TE balance adjustment error33. TE sensor adjustment error34. TE loop gain adjustment error35. FE loop gain adjustment error36. Bad jitter after adjustment40. Focus NG42. Focus layer jump NG52. Open kick spindle error51: Spindle stop error60: Focus on error61: Seek fail error62: Read Q data/ID error70: Lead in data read fail71: TOC read time out (CD)80: Can’t buffering81: Unknown media type

B. Parameter of error codeThis is the detail of error code.


01. 01 05 04 04 00 92 46 00 00 00 00 00 00 00 23 45

C. Time of error codeThis is the laser time when an error occurred.


01. 01 05 04 04 00 92 46 00 00 00 00 00 00 00 23 45

To Clear the Laser HourPress the [ DISPLAY] button on the remote commander and thenpress the [CLEAR] button on the remote commander. The data forboth CD and DVD data are reset.


01. 01 05 04 04 00 92 46 00 00 00 00 00 00 00 23 45

02. 02 02 01 01 00 A9 4B 00 00 00 00 00 00 00 23 45


To Clear the Emergency HistoryPress the [MENU] button on the remote commander and then pressthe [CLEAR] button on the remote commander. The error code forall emergency history would be reset.


01. 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00

02. 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00


To Return to the Top Menu of Remocon DiagnosisMenuPress the [0] button on the remote commander.

5. CHECKING VERSION INFORMATIONTo check the version information, please follow the followingprocedure.Procedure:

1. From the top menu of Remocon Diagnosis Menu, select “4.Version Information” by pressing the [4] button on the remotecommander. The following screen appears on the on-screendisplay.

Version information

Firm(Main): Ver. X.XXXXFirm(Sub): XX.XXRISC: XXXXXX8032: XXXXXXAudio DSP: XX.XX.XX.XXServo DSP: XX.XX.XX.XX

[0]Return to Top Menu

2. To return to the top menu of Remocon Diagnosis Menu, pressthe [0] on the remote commander.

21

HCD-ZX80D/ZX100D

RECORD/PLAYBACK HEAD AZIMUTH ADJUSTMENTDECK A DECK B

Note : Perform this adjustment for both decks.Procedure:

1. Mode: Playback

2. Turn the adjustment screw and check output peaks. If the peaksdo not match for L-CH and R-CH, turn the adjustment screwso that outputs match within 1dB of peak.

3. Mode: Playback

SECTION 5MECHANICAL ADJUSTMENTS

PRECAUTION1. Clean the following parts with a denatured-alcohol-moistened

swab :record/playback head pinch rollererase head rubber beltscapstan idlers

2. Demagnetize the record/playback head with a headdemagnetizer.

3. Do not use a magnetized screwdriver for the adjustments.4. After the adjustments, appiy suitable locking compound to

the parts adjusted.5. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.

TORQUE MEASUREMENTMode Torque Meter Meter Reading

3.06 – 6.96 mN⋅mFWD CQ-102C (31 – 71 g⋅cm)

(0.43 – 0.98 oz⋅inch)

FWD0.19 – 0.58 mN⋅m

Back TensionCQ-102C (2.0 – 6.0 g⋅cm)

(0.02 – 0.08 oz⋅inch)

3.06 – 6.96 mN⋅mREV CQ-102RC (31 – 71 g⋅cm)

(0.43 – 0.98 oz⋅inch)

REV0.19 – 0.58 mN⋅m

Back TensionCQ-102RC (2.0 – 6.0 g⋅cm)

(0.02 – 0.08 oz⋅inch)

6.96 – 14.02 mN⋅mFF/REW CQ-201B (71 – 143 g⋅cm)

0.98 – 1.99 oz⋅inch)

9.80 mN⋅mFWD CQ-403A more than 100 g

(more than 3.53 oz)

9.80 mN⋅mREV CQ-403R more than 100 g

(more than 3.53 oz)

MAINboardCN510

test tapeP-4-A100(10 kHz, –10 dB)

pin 3

oscilloscope

L-CH

R-CH

V H

waveform of oscilloscope

in phase 45° 90° 135° 180°

good wrong

pin 2

pin 1

L

R

Screwposition

L-CHpeak

within1dB

Outputlevel

L-CHpeak

R-CHpeak

within1dB

Screwposition

R-CHpeak

SECTION 6ELECTRICAL ADJUSTMENTS

0 dB=0.775 VDECK SECTION

1. Demagnetize the record/playback head with a headdemagnetizer.

2. Do not use a magnetized screwdriver for the adjustments.3. After the adjustments, apply suitable locking compound to the

parts adjust.

TEST TAPETape Signal Used for

P-4-A100 10 kHz, -10 dB Azimuth Adjustment

set

MAIN boardCN510pin 1 (L-CH)pin 3 (R-CH)

MAIN boardCN510pin 2 (GND)

+–

level meter

test tapeP-4-A100(10 kHz, –10 dB)

22

HCD-ZX80D/ZX100D

4. After the adjustments, apply suitable locking compound tothe pats adjusted.

Adjustment Location: Playback Head (DECK-A)Record/Playback/Erase Head (DECK-B)

DVD SECTION

RFMON LEVEL CHECKConnection :

Procedure :1. Connect an oscilloscope to CN105 pin 6 (RFMON) and

CN105 pin 3 (GND) on the DMB15 board.2. Press the I/1 button to turn the power on, and press

the Z OPEN/CLOSE button to open the CD disc table.3. Set the test disc (DVD-SL (NTSC): HLX-503 (Part No. J-

6090-069-A, CD: YEDS-18 (Part No. 3-702-101-01) on thetray and press the Y button to playback.

4. Confirm that oscilloscope waveform is clear and checkRFMON signal level is correct or not.

Note: A clear RFMON signal waveform means that the shape “◊” can beclearly distinguished at the center of the waveform.

Connecting Location:

+–

DMB15 board

CN105 pin 6 (RFMON)CN105 pin 3 (GND)

oscilloscope

VOLT/DIV: 200 mVTIME/DIV: 500 ns

level:0.58 ± 1.23 Vp-p (DVD-SL)0.57 ± 1.1 Vp-p (CD)

IC102

– DMB15 Board (Side A) –

IC201

CN105

1 6

reverse

forward

2323

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-1. BLOCK DIAGRAM – RF SERVO/VIDEO SECTION –

DQ0 – DQ7

AD0 – AD7

A-1, A0 – A20

IOA0 – IOA21

D/A CONVERTERIC301

OPTICAL PICK-UPBLOCK RF AMP, SERVO DSP,

MPEG DECODERIC102

FOCUS/TRACKING COIL DRIVE,SPINDLE/SLED MOTOR DRIVE

IC201

AUTOMATIC POWERCONTROL (FOR CD)

Q102-1

DVDRFIP6

MA8MB9MC10MD11

RF

DVDA2

SDTI114

DVDB3DVDC4DVDD5

VOA/AVOB/BVOC/CVOD/D

TNI18VOE/E+GTPI19VOF/F+H

V2O29VC

LDO123LD (780)

AUTOMATIC POWERCONTROL (FOR DVD)

Q102-2LDO222LD (650)

FOO42

CD ONSWITCHQ101-1

DVD ONSWITCHQ101-2

VR (780)

MSW

LIMSW

50VR (650)

FCS+

MSW

MDI120MDI221

PD

176LIMIT

Q103

IOCS

CE

SD-RAMIC104

X10127MHz

FL

FR

B

36FCS– 37

1

TRO41TRK+ 35TRK– 34

4

FMO38SL+ 29SL– 30

10

DMO37SP+ 27SP– 28

3132

42

4647

13

SPFG4745

ASDATA0 217 LOUT1+ 2LOUT1– 1ROUT1+ 48ROUT1– 47

MCLK

ACLK

10ACLK 215BICK9ABCK 214LRCK17ALRCK 213

SDA20SDA 103

SPDATA 209

SCL19SCL 102

PDN8XRST 220

XTAL

I

229

VOIC

E

206

SMSC

K

208

XTAL

O

228

EEPROMIC103SD

A

6

SCL

5

MIX AMPIC3711

SDTI215 SL

SR

ASDATA1 218 LOUT2+ 46LOUT2– 45ROUT2+ 44

43ROUT2–

MIX AMPIC3731

SDTI316 FC

SW


39ROUT3–

MIX AMPIC3751

SDTI413 LT

RT


32ROUT4–

MIX AMPIC3771

FL, FR, SL, SR, FC, SW

CLT, RT

DANALOG-L

81 – 84,86 – 88, 91

29, 31, 33, 35,38, 40, 42, 44

93, 78, 53 – 59, 75, 74,72 – 67, 92, 60, 61, 76, 89

45, 25 – 18, 8 – 1,48, 17, 16, 9, 10

DQ0 – DQ15

RD0 – RD15

A0 – A11

RA0 – RA11

2, 4, 5, 7, 8, 10, 11, 13, 42,44, 45, 47, 48, 50, 51, 53

125 – 123, 121, 120, 118, 117,115, 135, 133 – 128, 126

147, 149 – 151, 166 – 164,162, 160, 159, 146, 158

23 – 26,29 – 34, 22, 35

77

26

IOOE

OE

79

28

IOW

RW

E

66

11

BA0

BA0

143

20

BA1

BA1

145

21

RCLK

CLK

156

38

CKE

CKE

157

37DQ

M0

LDQM

113

15DQ

M1

UDQM

137

39

RAS

/RAS

140

18

CAS

/CAS

139

17

RCS

/CS

142

19

RWE

/WE

138

WID

E

49

16

• SIGNAL PATH

: CD PLAY

: DVD PLAY

: AUDIO

: VIDEO

: Y

: CHROMA

: COMPONENT VIDEO

FOCUSCOIL DRIVE

TRACKINGCOIL DRIVE

SLEDMOTOR DRIVE

SPINDLEMOTOR DRIVE

REGULATOR

MUTE123MUTE12 21119

MUTEMUTE34 21020TSD_MTSD-M 17022

IOPMON4040

8

MUTE5 21

BUFFER

BUFFER

RF+3.3V

AU+5V

REGO2REGO1

MTK

-SOD

IFSD

O

32

98M

TK-X

IFCS

IXFC

S

24

100

MIC

STA

TUS

MIC

21

205

MTK

-KM

ODKR

MOD

22

207

MTK

-SIO

IFSD

I

31

101

MTK

-CLK

IFCK

33

99

MTK

-IFBS

YIF

BSY

23

105

MTK

-RES

ETPR

ST25

VMUT

E

88

VIDE

O-OU

T-SW

87

110

MASTER CONTROLLERIC401 (1/6)

CENTER VOLTAGEGENERATOR

Q3801

ABCK

ALRC

K

XVOI

CESC

ORE

SPDA

TA

196YUV2

194YUV1

198YUV3

202YUV5

200YUV4

203YUV6

VIDEO AMP, 75Ω DRIVERIC801

4 CVBSIN

2 CIN

6 YIN

10 CYIN

12 CBIN

14 CRIN

3

MUT

E1

13

MUT

E2

25

S1

: DIGITAL OUT

: VIDEO INPUT (VIDEO)

• R-ch is omitted due to same as L-ch.

KHM-310CABOR

KHM-313CAB

VIDEOOUT

J802

S VIDEOOUT

J801

VIDEO SWITCH, 75Ω DRIVERIC800

2

SW1

J800COMPONENTVIDEO OUT

Y

PB/CB

PR/CR

1 VIN1

3 VIN2

23CVBSOUT 7VOUT

26C OUT

21YOUT

20CYOUT

18CBOUT

16CROUT

27S-DCOUT

J1102 (1/2)VIDEO INPUT

VIDEO

C Y

FLASH ROMIC101

DISC TABLEADDRESS SENSOR

IC731

LOADING MOTOR DRIVEIC701

M751(LOADING)

7 FIN38LM-F 4OUT12OUT29 FIN39LM-R

TABLE MOTOR DRIVEIC712

M741(TABLE)

7 FIN36TM-F 4OUT12OUT29 FIN37TM-R

27TBL SENS LEVEL SHIFTQ731

S711ROTARY

ENCODER

35E1

26EJECT SW

34E228E3

M

M

DISC TABLEADDRESS DETECT

DISC TABLEOPEN/CLOSE DETECT

S751

OPEN

CLOSE

SPDATA

A/D CONVERTERIC3601

LIN

R-CHABCKABCK

ALRCK

1

RIN 2

12 DOUT15 SCKI11 BCK10 LRCK

AXVOICE, SCORE

SECTION 7DIAGRAMS

(Page 24)

(Page 26)

(Page 24)

(Page 26)

2424

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-2. BLOCK DIAGRAM – MIC/EFFECTOR SECTION –

EMUSIC L+R

RT

CLT, RT LT

J1100MIC 1

J1101MIC 2

MIC AMPIC1101

16 MC2P

15 MC1PPOOUT

1 0Y

Y COM

4 3Y

13

11

3D0

D150

3

D150

4

D150

5

COM

EFFE

CTOR

-CTR

1

57

EFFE

CTOR

-S0

19

MIC

-DET

ECT

85

EFFE

CTOR

-S1

43

EFFE

CTOR

-S2

44

EFFE

CTOR

-S3

45

EFFE

CTOR

-SEL

ECT

18


• SIGNAL PATH

: MIC INPUT

: AUDIO

6VOL2

MIC 1 LEVELRV1102

5VOL1

MIC 2 LEVELRV1101

7VOL3

21MCO

ECHO LEVELRV1100

29DIGITAL ECHOIC1100

AC/DCCONVERTERIC2000 (1/2)

COMPARATORIC2002

COMPARATORIC2001

XVOICE

SCORE

AXVOICE, SCORE

FMIC

AC/DCCONVERTERIC2000 (2/2)

DIGITAL ECHOIC1504

MIXERIC1505 (2/2)

SWITCHINGQ1505

A+9V

SWITCHINGQ1504

SWITCHINGQ1503

SWITCHINGQ1508

12 0X

11 3XDIGITAL ECHOIC1501

MIXERIC1505 (1/2)

SWITCHINGQ1502

LEVEL SHIFTQ1509, 1510

EFFE

CTOR

-CTR

2

63


EFFE

CTOR

-CTR

3

70


SWITCHINGQ1501

SWITCHINGQ1500

SWITCHINGQ1506

A10B

9C

D1506

D1507

D1508

MULTIPLEXERIC1502

11

3COM

A10B

9C

MULTIPLEXERIC1503

3

X COM 13

9A

10B

SIGNAL SELECTORIC1506

DM_L

DM_R

GDM_L, DM_R

(Page 26)

(Page 23)

(Page 26)

(Page 23)

(Page 26)

2525

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-3. BLOCK DIAGRAM – TUNER/TAPE SECTION –

T301BIAS OSC

BIAS OSCQ370

REC BIASSWITCH

Q378, 380A+9V

R-CH

TUNER (FM/AM)

AM

FM ANT

AM ANT

ST-LST-R

ST-DOUT/MC-DIN

TUNED

ST-DIN/MC-DOUTST-CLK

ST-CE

FM 75ΩCOAXIAL

ANTENNA

HRPE1(REC/PB/ERASE)

(DECK-B)

HP1(PB)

(DECK-A)

L-CH

L-CH

R-CH

R-CH

R-CH

R-CH

ERASE

R-CH

MUTINGQ325

MUTING CONTROLSWITCH

Q382, 383

R-CH

MUTINGQ321, 322


Q377, 379, 381

32

34

21 24EQ

28

14131115

27 26

DECK A/B SELECT SWITCH,REC/PB EQ AMP

IC301

CAPM+M

TAPE MECHANISMDECK BLOCK

ATRGM+

AHALFBHALF

A SHUTB SHUT

REC (FWD)REC (REV)

(DECK-A)

BTRGM+

(DECK-B)

(CAPSTAN/REEL)

6 ST-CE3 ST-CLK2 ST-DOUT5 ST-DIN

1 TUNED

71 TC-MUTE

54 REC MUTE

53 TC-RELAY

52 REC BIAS

47 A-HALF91 B-HALF

89 A-SHUT90 B-SHUT

48 A-TRIG

49 B-TRIG

50 CAPM

HST-L

KREC-L

JTC-L

MUTINGQ106

R-CH


Q509, 510

TRIGGER PLUNGERDRIVE (DECK-A)

Q340, 343

TRIGGER PLUNGERDRIVE (DECK-B)

Q342, 345

CAPSTAN/REELMOTOR DRIVE

Q341, 344


• SIGNAL PATH

: TAPE PLAY (DECK-B)

: REC

: TAPE PLAY (DECK-A)

: TUNER (FM/AM)


AIN1

REC-OUT1 REC-IN1

EQ-OUT1

REC MUTE ON/OFF56 ALCALC ON/OFF55 PB A/BA/B

MUTE ON/OFF

TAI1 PB-OUT1BIN1

(Page 26)

(Page 26)

(Page 26)

2626

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

32

GDM_L, DM_R

MUTINGQ204

MUTINGQ254

MUTINGQ203

MUTINGQ253

BFL, FR, SL,SR, FC, SW

JTC-L

FMIC

DM_R

FL

FR

DM_L

SR

FC

SW

SL

MUTINGQ202

MUTINGQ252

MUTINGQ200

MUTINGQ250

37

40

41

2

6

33

34

5

10 9 8

7

4

2314 24 22

39

38

R-CH

R-CH

+

15

AUTO GAINCONTROL

R-CH27

331

30

53

HST-L

R-CH

J201

TV/SATAUDIO IN

L

R4

J1102 (2/2)

R-CH

VIDEO INPUTAUDIO

L

R

SELE

CTOR

TONE

614 15 18+

7

2 42

8

+R-CH

+R-CH

BASSBOOST

24

1716


Q507, 508

77 DVD-A-MUTE VOL-

IC-D

ATA

I/F

17

81

VOL-

IC-C

LK

18

82

AUDI

O-IC

-DAT

A

79AU

DIO-

IC-C

LK

AUDIO-OUT-SW

80

FEED BACK SWITCHQ205

R-CH

R-CH

28

MUTINGQ117

FEED BACKSWITCH

Q101

R-CH

R-CH

IN-M

UTE

OUT-

MUT

E

I/F MCU

2221

83ANALOG-IN-MUTE

OUT-MUTEIN-MUTE

46

LINE-MUTE 76

SW-MUTE 75


Q516, 517

MUTINGQ206

SPEANA AMPIC304 (2/2)

BUFFERIC304 (1/2)


Q521, 522

MUTINGQ514, 564


Q505, 506

MUTINGQ750

MUTINGQ700

MUTINGQ740

MUTINGQ810

MUTINGQ208

MUTINGQ207


Q512, 515, 519


Q511

J203SUBWOFFER OUT

R-CH

FL, FR, SL, SR, CTRN

MUSIC L+RE

REC-LK

SPEANAL

SWP

AC4Q

SW-MUTES

DBFB F/B

ANALOG-L

M

D

FL

FR

SL

SR

CTR

29

26

25

13

11

12

J202

R-CH

J103

AUDIO OUT

D-LIGHTSYNC OUT

L

R


INPUT SELECT SWITCH,TONE CONTROL,ELECTRICAL VOLUME, BASS BOOST AMP

IC101

ELECTRICAL VOLUMEIC201

• SIGNAL PATH

: REC

: AUDIO OUT

: TV/SAT AUDIO IN

: MIC INPUT

: TAPE PLAY

: TUNER (FM/AM)

: AUDIO


: VIDEO INPUT (AUDIO) SAT-LST-LTC-L

VOLIN1

DVD-L

MIC

SUR1

DATA

CLOC

K

TOUT1

SWOUT

OUT1

BB_A1BB_B1RE

CB1

VIDE

O-L

(ZX100D)(ZX80D)

(ZX100D)

(ZX80D)(ZX100D)

FEED BACK SWITCHQ255

D511D510+

7-4. BLOCK DIAGRAM – AUDIO SECTION –

(Page 25)

(Page 25)

(Page 24)

(Page 24)

(Page 23)

(Page 28)

(Page 26)

(Page 23)

(Page 27)

(Page 24)

(Page 27)

(Page 27)

(Page 28)

(Page 27)

2727

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-5. BLOCK DIAGRAM – AMP SECTION –

NFL, FR, SL, SR, CTR

MDBFB F/B

PSW

FR

FL

SL

SR

CTR

POWER AMPIC600

18 11

14 8

12

POWER AMPIC702

18 11

14 8

19 21

STANDBY SWITCHQ604, 606, 610

STANDBY SWITCHQ720 – 722

+

+

+

+

+

+

DCDET 2

1

4

3 OVERLOAD

OVER CURRENT PROTECTORIC550

OVER LOADDETECT

Q618, 668

OVER LOADDETECT

Q730, 780

OVER LOADDETECT

Q800, 850

OVER LOADDETECT

Q770

THERMALDETECT

Q628, 630

TH629

TH630

D624

MUTINGQ640, 641


Q634, 682

FAN MOTORCONTROL SWITCH

Q587, 589

FAN MOTORSWITCH

Q588

D550

RY646 RELAY DRIVEQ644

PROTECTSWITCH

Q647

OVER LOADDETECT

Q648

–1

–2


PROTECTSWITCH

Q765


–1

–2

J1103PHONES

TM600

+––+

L

R

+––+

+–

D655

D654

+ +D764

D763

D765

AC CUT DETECTR

M502(FAN)M

FRONT SPEAKER

TM700

TM701

L

R

SURR SPEAKER

CENTER SPEAKER

+

–

TM101

SUBWOOFEROUT

CN102SYSTEM

CONTROL


PROT

ECT

67

STK-

MUT

E

60

CTR-

RELA

Y

65

SW-S

PK R

ELAY

51

REAR

-REL

AY

61FR

-REL

AY66

UNDE

R VO

LTAG

E

69

HP-D

ETEC

T

84

THER

MAL

VAC

S

94

HP-M

UTE

72

FAN

HI S

PEED

58

FAN

CONT

ROL

42


PROTECTSWITCH

Q815

–1

–2

• SIGNAL PATH

: AUDIO

AC CUTDETECT

Q504

Except US,Mexican

CT

OUT OCP

VP

(ZX100D)

(ZX100D)

(ZX100D)

(ZX100D)

(ZX80D)

(ZX80D)

(ZX100D)

(ZX80D)

(ZX100D)

(ZX100D)

SSW-MUTE

(ZX80D)

POWER AMPIC800

11 4

15 6

13

12

STANDBY SWITCHQ812

D812

UNREGB+


Q581, 582


Q578

FAN MOTOR SPEEDCONTROL SWITCH

Q579

FAN MOTORSWITCH

Q585

M501(FAN)MUNREG

B+

D582

D581

TOSS-WGV100D

SW-LEVEL-IN 95

SW-LED 100

(Page 26)

(Page 26)

(Page 26)

(Page 28)

(Page 26)

Ver. 1.1

2828

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

(AC IN)

(US, Mexican)

(Except US, Mexican)

VOLTAGESELECTOR

S1200

RESET SIGNALGENERATOR

IC501

RESETSWITCH

Q501

VFVF

AC2AC2

VP

STBY-LED 41

SIRCSREMOTE CONTROL

RECEIVERIC903

4

15

X4025MHz

X-IN

13

X-OU

T

10

X40132.768kHz

XC-IN

11

XC-O

UT

83

X9014MHz

XIN

82

XOUT

POWER ON/OFFRELAY DRIVE

Q1200

POWERSWITCHING

D1292–36VREGULATOR

Q1264

F1261

F1271

RECTD658

+VL–VL

AC1AC1

F1241

F1251

RECTD656

+VH–VH

AC4AC4

F1291RECTD561

AC3AC3

F1281RECTD560

VF1VF2

VP(–36V)

D660

D661

TO FLUORESCENTINDICATOR TUBE

FL901

+3.3VREGULATOR

IC559

+9VREGULATOR

IC507

+9VREGULATOR

IC561

+9VREGULATOR

IC560

B+ SWITCHQ513, 520

M+9V,LED+9V

SW+9V

AU+5V

A+9V

+5VREGULATOR

Q103

+3.3V

SW+3.3V

SW+5V

RF+1.8V

RF+3.3V

+3.3VREGULATOR

IC105

+3.3VREGULATOR

IC107

OVER VOLTAGEDETECT

Q550

RGRULATORCONTROL SWITCH

Q503, 518

UNREG B+

D551

RGRULATORCONTROL SWITCH

Q104

78MTK- POWER

68OVER VOLTAGE

20AC-CUT

7STBY-RELAY

12RESET

EVER+4V

D504

B+ SWITCHQ523, 524D+3.3V

EVER+3.3V

D505

D585, 586

D+4V+4V

REGULATORQ323

+5.6V+5.6V

REGULATORQ1507

D101, 102

LED DRIVEQ903

LED DRIVEQ917

74 POWER-KEY

S927I / 1

73 DISPLAY-KEY

2961 IIC-CLK

S928DISPLAY

I2C-CLOCK3060 IIC-DATAI2C-DATA

80LED SELECTOR

4077 GC-RESETRESET

SPEANAL

ROTARYENCODER

S970VOLUME74MASTER VOLUME

ROTARYENCODER

S1040X-JOG-ROUND73X-ROUND JOG

ROTARYENCODER

S1161OPERATION DIAL72OPERATION DIAL

FL901FLUORESCENT

INDICATOR TUBE

G1 –

G13

,G1

7 –

G24

8 –

1, 1

00 –

96,

92 –

85

P1 –

P36

9, 1

0, 1

2– 2

2,24

– 4

1, 4

3 –

4793

– 9

5

G14

– G1

6

GRID DRIVEQ901, 902, 914

KEY

0 –

KEY

2

S900 – 925,S1041 – 1047, 1049

(FRONT & TOP PANEL KEY) 64 –

66


52 –

59,

75,

76,

78,

79

LED-CD/DVD, TUNER,LED-TAPE, TV/SAT,

LED-VIDEO, (PAUSE, STOP),LED- (AMS+, AMS–), (FF, FR),

LED-VOLUME 1, 2,LED-VOLUME 3, 4,LED-VOLUME 5, 6,LED-VOLUME 7, 8,

LED- (BEAT JUMP, BEAT MAX),LED- (BALANCE, WAVE, FADER, RANDOM), DELAY,

LED-FLANGER, CHORUS,LED-PLAY

D908 – 911, 913 – 917, D919 – 926, 929, 930,

D1016, 1017, 1020, 1040,D1042, 1044, 1046, 1048,D1050, 1052, 1054, 1056,

D1058, 1145, 1153

LED DRIVEQ908 – 913, 915,918 – 921, 1041

LED ON/OFFCONTROL SWITCH

Q906

LED ON/OFFCONTROL SWITCH

Q907

B+ SWITCHQ904

B+ SWITCHQ905

SEL A B+

SEL B B+ LED+9V

DISPLAY CONTROLLERIC902

IN11

IN22

BPF2IN14BPF2IN25

3BUF1OUT15BPF3OUT

14BPF2OUT

13BPF1OUT

16BPF4OUT

17RECOUT

67ALL-BAND

BPF1IN1BPF1IN2

1918

20BUF2OUT

BPF3IN16BPF3IN27BPF4IN18BPF4IN29

REC68BF4

BPF469BF3

BPF370BF2

BPF271BF1

BPF1

REC

BPF4

BPF1

BPF2

BPF3

BAND-PASS FILTERIC904

AC CUT DETECTR

D507

D506

AC4Q

RY1200

T1200POWER

TRANSFORMER

(Except US, Mexican)

D927

(RED)I / 1

D928

(GRN)I / 1

+1.8VREGULATOR

IC106

+5VREGULATOR

IC558

M+9V

7-6. BLOCK DIAGRAM – PANEL/POWER SUPPLY SECTION –

(Page 26)

(Page 27)

(Page 26)

Ver. 1.1

2929

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

• Note for Printed Wiring Boards and Schematic Diagrams

C

B

These are omitted.

E

Q

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• f : internal component.• 2 : nonflammable resistor.• 5 : fusible resistor.• C : panel designation.

• A : B+ Line.• B : B– Line.• Voltages and waveforms are dc with respect to ground

under no-signal (detuned) conditions.– DMB15/VIDEO Boards –no mark : DVD PLAY

∗ : Impossible to measure– Other Boards –no mark : TUNER (FM/AM)( ) : DVD PLAY⟨⟨ ⟩⟩ : TAPE PLAY (DECK-A) : REC

∗ : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.J : CD PLAYc : DVD PLAYI : DIGITAL OUTF : AUDIOL : VIDEOE : Ya : CHROMAr : COMPONENT VIDEOf : TUNER (FM/AM)j : TAPE PLAY (DECK-A)d : TAPE PLAY (DECK-B)G : RECk : TV/SAT AUDIO INh : AUDIO OUTN : MIC INPUTg : VIDEO INPUT (AUDIO)p : VIDEO INPUT (VIDEO)

• AbbreviationE2 : 120V AC area in E modelE3 : 240V AC area in E modelE13 : Russian model and 220V – 230V AC area in E

modelE51 : Chilean and Peruvian modelsMX : Mexican modelMY : Malaysia modelSP : Singapore model

• Circuit Boards Location

Note on Printed Wiring Board:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• f : internal component.• : Pattern from the side which enables seeing.(The other layers' patterns are not indicated.)

• DMB15 board is multi-layer printed board.However, the patterns of intermediate layers have not beenincluded in diagrams.

• Indication of transistor

Caution:Pattern face side: Parts on the pattern face side seen from(Side B) the pattern face are indicated.Parts face side: Parts on the parts face side seen from(Side A) the parts face are indicated. Note: The components identified by mark 0 or dotted line

with mark 0 are critical for safety.Replace only with part number specified.

B

These are omitted.

C E

Q

MOTOR (LD) board

CD-SW board

JOG board

X-ROUND board

SW board VIDEO board

SENSOR board

DMB15 board

MOTOR (TB) board

TUNER (FM/AM)

KARAOKE board

DRIVER board

PANEL board

FUNCTION board

MIC board

POWER SWITCHING

EFFECTOR board

MAIN board

PRIMARY board

TRANS board

SURROUND board

PA board

3030

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-7. PRINTED WIRING BOARD – DMB15 Board (Side A) – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

New part of EEPROM (IC103) on the DMB15 board cannot be used.Therefore, if the mounted DMB15 board is replaced, exchange newEEPROM with that used before the replacement.

R3607

L3602

FB11

5

FB11

4

FB11

3FB

112

CN302

R3653

R3805

R319

Q103

R116R117

C224

R136

R142

FL101

C222

C221

R153R155

C220

C219

FL107

FL403

C218

RB107

RB108

RB113

CN101

RB112

C3804

Q3801

C215

C380

2R3803

R3804

FL401

C3803

C3805

C210

X101

R208

C208

CN105 CN106

CN201

CN40

1

R209

C206

C205

R210

R214

FB401

FB402

FB403FB404

D1001

FB405

FB406

R215

R216

R219

R224

FL40

2

C190

R233

R234

C180

C179

R161

R107

R101

R1527

C306

C102

C105

C402

C108

R189

C307

C305

R190

R191

C302

R192

R193

C153 C152

R1101

C117

R110

2

R1105

R1108

R3651

R1553

C138

C137

C135

R1129

C133

C132

R1168

C119

C118

C116

R195

C112

C101

R197

C167C170

C181

C217

C189

C177

R1544

C403

C129

R152

C3783

R1550R1549

C3782

C378

1

C377

4

C3773

C377

2C3

771

C3707

R3782R3781

R4706 R4705

R1543

C378

4

R377

3 R377

4

R3775

R377

6

R3777

R377

2

R377

1

R3768R3767

R376

6

R3765

R376

4

R376

3

R3758R3757

R3778

R378

3

R375

6

R378

4

R3785

R378

6

R3755

R375

4

R375

3

C376

4

R3787

C3763

C3762

C376

1

C375

4C3801

R3788

C3753

C375

2C3

751

C3705

R3762R3761

R3802R3801

C178

R371

6

R3752

R3717

R371

5

R375

1

R3748R3747

R374

6

R3714

R3745

R3744

R374

3

R3738

R371

3

R3737

R373

6

R373

5

R3734

R373

3

C374

4

R3718

R3721R3722

R372

3

C3743

C3742

C374

1

C373

4

R3712

R371

1

R3724

R3725

C3733

C373

2

C3731

C3703

D350

2

D350

1

C150

C372

4

C3723

C3722

C372

1

C371

4

R3742

CN301

R3741

C3713

C371

2

C3711

R3732

R373

1

C3701

C187

C3606

C3605

C3603R3728R3727

R372

6

R3603

R1557

R1559

C3608

C3609

IC102

IC201

IC104

IC103

IC101

IC106

DMB15 BOARD (SIDE A)

1-869-463- 11

E

1

5

E

1

220

21

(FOR CHECK)

OPTICALPICK-UPBLOCK

KHM-310CABOR

KHM-313CAB

BMAIN BOARD

NO523

A MAIN BOARDCN520

D MAIN BOARDCN521 C VIDEO BOARD

CN801

A

B

C

D

E

F

G

H

1 2 3 4 5 6 7 8 9• Semiconductor

Location

Ref. No. LocationD1001 E-3D3501 H-5D3502 H-5

IC101 C-7IC102 E-6IC103 E-4IC104 E-4IC106 E-3IC201 C-4

Q103 F-8Q3801 G-5

(Page 45)

(Page 45)

(Page 45) (Page 38)

3131

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

1 10

20 11

R5008

R5011

R5014

R5016

R5017

L3601

C114

C115

C120

C121

C122

C123 C124

C125

C126

FB111

C130

R109

C139

C140 C146

C147

C148

C149

C151

C154

C156C159 C161

C163

R3652

R105R106

R123

R3605

C171

C172

C173

R110 R1

18R1

20R1

21

R187

R127

C193C195

C301

R164R169

R1133

FL104

R204

R205

FL106

R146 R1

51

R206

R207

R212

R213

RB104

RB111

R220

R221

RB105

RB106

IC301

R223

FL10

5

RB103

R225

IC105

R226

R230

R231

R232

FL10

8R1109

Q102

R246

R247

R1110

R196

R1150

IC107

R115

1

R115

2

R153

0

R153

1Q101

C214

C213

C212

R108

C211

R154

0

R111

R112

R113

R114

R115

C209

R126

R124

C203

R1554 C191

R141

C188

R160

C184

C182

R1134

R1126

R112

5R1

124

R112

3

R112

2

R112

1

C176

C175

C174

R314

R110

4

R112

0

R110

3

C164

R1551

R2504

R1504

C106

C109

R1502

C113

C127

C128

C131C136

R104

C144 C155

C158

C160

C162

C3708

R154

8

R470

4

R470

3

R470

2

R470

1

R154

2

C192

R154

7

C233

IC3751

D3602

D3601

C196

R1546

R3719

R3729

R3739

R3749

R3759R3769

R3779

R3789

R3609

R152

4

C3706

R152

6

IC3731

R3606

R3611

IC3771

R362

1

C3704

IC3711IC3601

R321

C3601

R138

C3621C3702

C3611C3

610

C3607

C3602 R3601

R3602

R1161

R3505

R3504

DMB15 BOARD (SIDE B)

1-869-463- 11

1

3

5

4

1C1B

2E

1E2B2C

1D

5 4

1 3

2G2S

1S1G2D

(ZX100D:SP, MY)

(ZX80D:E3, E13/ZX100D:E3)

(ZX80D:US, E2, E51, MX/ZX100D:E2, E51, MX)

B

A

C

D

E

F

G

H

1 2 3 4 5 6 7 8 9

7-8. PRINTED WIRING BOARD – DMB15 Board (Side B) – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

• SemiconductorLocation

Ref. No. LocationD3601 H-8D3602 G-7

IC105 C-3IC107 F-3IC301 F-7IC3601 G-8IC3711 H-7IC3731 G-7IC3751 G-6IC3771 H-6

Q101 E-2Q102 E-2

Ver. 1.1

3232

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-9. SCHEMATIC DIAGRAM – DMB15 Board (1/4) – • See page 67 for IC Block Diagrams.

New part of EEPROM (IC103) on the DMB15 board cannot be used.Therefore, if the mounted DMB15 board is replaced, exchange newEEPROM with that used before the replacement.

C105

RB105

RB106

R124

FB111

FB112

FB113

FB114

FB115

C109

C101

R111

R117

R107

R114 R1129

R109

R110R112 R113 R115

Q102

R118 R120 R121

C113

C112

C195

R126

C192

CN105

C193

R1151

R1152

R1150

C108

C167

R1110

R193

C102

R104

C189C187

R1134

FL107

R187

C184

C182

R1133

R169

C191

C180

C179

C181

FL108

C106

R191

C178

R108

R101

IC107

FL101

Q103

IC103

R123

IC105

IC106

C190

IC101

C188

R1502

R1544CN106

CN101

R106

R105

D1001

Q101R116

IC104

R1546

476.3V

47

47

47k

0.001

0.01

100

47k

10k

100k 100k

0

47k22 22 22

QST8TR

22 22 22

0.01

476.3V

0.22

0

0.01

6P

0.22

3.3k

3.3k

3.3k

0.001

0.01

2.7k

1k

1

0

0.33474V

0

0

0.01

0.22

0

10k

0.1

0.1

0.1

0.1

0.01

1k

474V

1M

100

TK11133CSCL-G

DTC124EKA-T146

BR24L64F-WE2

0

TK11133CSCL-G

PQ018EN01ZPH

476.3V

0.22

0

013P

24P

10k

10k

RB501V-40TE-17

UM6K1N-TN1k

A2V64S40CTP-G75

3.3k

A4

A5

A6

A12

A9

A8

A11

A10

A7

A1

A2

A3

REG01

GND

SW+5V

SW+3.3V

TRK-

TRK+

FCS+

FCS-

IOP

MSW

V2REFO

SDA

REG02

MREQ

MIC

KRMOD

IFSDO

IFCK

XIFCS

IFSDI

SCL

IFBSY

RXD

TXD

PRST

RF

VC

PD

LDO1

RF1.8

LDO2

RF+3.3V

VOA

VOB

VOC

VOD

VOE

VOF

RA4

RA5

RA6

RA7

RA8

RA9

RA11

DRCKE

DRCLK

DQM1

RD0

RD1

RD2

RD3

RD4

RD5

RD6

RD7

DQM0

RWE

CAS

RAS

RCS

BA0

BA1

RA10

RA0

RA1

RA2

RA3

RD8

RD9

RD10

RD11

RD12

RD13

RD14

RD15

DVD_LD

CD_LD

DVD_LD

CD_LD

RFMON

SC

L

SD

A

A16

A15

A14

A13

A12

A11

A10

A9

A20

A21

A19

A18

A8

A7

A6

A5

A4

A3

A2

A17

A0

A1

XRD

XROMCS

XWR

HD0

HD1

HD2

HD3

HD4

HD5

HD6

HD7

MS

W

LD

O1

MREQ

MIC

KRMOD

RFMON

V2REFO

RXD

TXD

PRST

XIFCS

IFBSY

IFSDI

IFSDO

IFCK

RF

FCS-

FCS+

TRK+

TRK-

PD

MSW

VC

IOP

LDO2

PRST

LDO1

TXD

IFBSY

SDA

SCL

IDSDI

XIFCS

IFCK

IFSDO

MREQ

MIC

KRMOD

V2REFO

VOA

VOB

VOC

VOD

VOE

VOF

PD

VOE

VC

VOF

VOB

VOA

RF

VOD

VOC

TRK-

TRK+

FCS+

FCS-

RXD

IOP

LDO2

TXD

RXD

GND

+3.3V

RFMON

V2REFO

A0

A1

A2

GND

VCC

SCL

SDA

A15

A14

A13

A12

A11

A10

A9

A8

A19

WE

RESET

N.C.

N.C.

RY/BY

A18

A17

A7

A6

A5

A4

A3

A2

A1

A16

BYTE

VSS

DQ7

DQ14

DQ6

DQ13

DQ5

DQ12

DQ4

VCC

DQ11

DQ3

DQ10

DQ2

DQ9

DQ1

DQ8

DQ0

OE

VSS

CE

A0

RF

VOB/B

VOC/C

VOD/D

VOA/A

VOF/F+H

VC

VCC

VOE/E+G

NC

TRK-

FCS-

TRK+

FCS+

PD

NC

S S

NC

SYSRST

XIFCS

IFBSY

SIO

SCO

GND (LD)

LD (650)

LD (780)

VR (650)

VR (780)

GND (PDIC)

(LO:DVD.HI:CD)MSW

MIC

KRMOD

CONT

GND

NOISE

VIN

VOUT

NOISE

GND

CONT

VOUT

VIN

+3.3V REGULATOR

-1 -2

INVERTER

Q101-1

CD ON SWITCH

Q101-2

DVD ON SWITCH

EEPROM

Q102-1

Q102-2

AUTOMATIC POWER

CONTROL(FOR CD)

AUTOMATIC POWER

CONTROL(FOR DVD)

SD-RAM

VSS

A4

A5

A6

A7

A8

A9

A11

NC

CKE

CLK

UDQM

NC

VSS

DQ8

VDDQ

DQ9

DQ10

VSSQ

DQ11

DQ12

VDDQ

DQ13

DQ14

VSSQ

DQ15

VSS

VDDB

A3

A2

A1

A0

A10

BA1

BA0

LDQM

VDD

DQ7

DQ4

DQ3

VSSQ

DQ2

DQ1

VDDQ

DQ0

VDD

VSSQ

VDDQ

DQ6

DQ5

+3.3V REGULATOR

+1.8V REGULATOR

VOUT

CONT

VIN

NC

GND

A-1

FLASH ROM

OCSW1

3.3VMNT

SOO

M-REQ

DGND

VOICE

(1/4)

/CS

/RAS

/CAS

/WE

A20

MX29LV320CBTC70-CBA3-0604CE (ZX80D:E3,E13/ZX100D:E3)

MX29LV320CBTC70-CBA3-0604GA (ZX100D:SP,MY)

MX29LV320CBTC70-CBA3-0604UC (ZX80D:US,E2,E51/ZX100D:E2,E51)

S29AL032D70TF-CBA3-0601UC (ZX80D:MX/ZX100D:MX)

(FOR CHECK)

-2-1

WP

(Page 34)

(Page 33)

(Page 46)

(Page 33)

(Page 34)

(Page 34)

(Page 33)

(Page 34)

Ver. 1.1

3333

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-10. SCHEMATIC DIAGRAM – DMB15 Board (2/4) –

R233

C213

R214

C205

R208

R215

C206

R216

R213

C208

R205

R209

C203R207

R204

C214

C212

C233

R230

R221C209

C211

R2

26

R2

31

R2

32

R2

34

R225

R223

R220

R212

R219

R2

24

C210

C217

C218

C219

C220

C224

C221

C222

R246

IC201

C402

FL401

FL402

FB401

FB402

FB403

FB404

FB405

FB406

FL403

CN401

R247

CN201

C215

R2504

C403

R5008R5011 R5014

R5016

R5017

R206

R210

33k

0.01

15k

220p

33k

12k

220p

12k

6.8k

0.01

10k

33k

0.012.7k

1.2k

0.001

0.01

0.0047

82k

56k0.033

0.03356

k

15

k

18

k

10

k

100k

100k

10k

10k

27k 10

k

0.01

4716V

1016V

0.01

1016V

0.01

0.1

0.1

4.7k

FAN8036L

4716V

5P

1k

6P

0.01

4.7k

476.3V

00 0

0

0

10k

47k

GND

REG02

REG01

MUTE123

MUTE

TSD_M

SW+3.3V

LIMITSW

FCS-

FCS+

TRK+

TRK-

IOP

IOPMON

VREFO

SPFG

FOO

TRO

FMO

DMO

RF+3.3V

SW+5V

SW+3.3V

GND

SW+5V

SP+

SP-

SL+

SL-

SP-

SP+

SL-

SL+

VREFO

SPFG

FOO

TRO

FMO

MUTE123

DMO

MU

TE

TS

D_M

IOP

IOP

MO

N

LIMITSW

TRK-

TRK+

FCS+

FCS-

IOPMON

VREFO

SPFG

FOO

TRO

FMO

MUTE123

DMO

MUTE

TSD_M

FCS-

FCS+

TRK+

TRK-

IOP

LIMITSW

SP-

SP+

LIMIT

(GND)LIMIT

SL-

SL+

SW+5V

SW+3.3V

MGND

SW+9V

FOCUS/TRACKING COIL DRIVE,

SPINDLE/SLED MOTOR DRIVE

(2/4)

ZX80D:US,E2,E51,MX/

ZX100D:E2,E51,MX

(ZX80D:E3,E13/ZX100D:E3)

(ZX100D:SP,MY)

DGND

(Page 32)

(Page 32)

(Page 34)

(Page 51)

(Page 32)

(Page 35)

(Page 34)

Ver. 1.1

3434

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-11. SCHEMATIC DIAGRAM – DMB15 Board (3/4) – • See page 54 for Waveforms. • See page 71 for IC Pin Function Description.

R1108

C129

R1

53

0

R1

53

1R

15

57

R1

46

R1

51

R1

52

R1

53

R1

55

R1

60

R1

61

R1

64

C120

C121

C122

C123

C133

C1

38

R1

41

RB108

RB111

RB107

C1

54

R1

42

C151

C128

C125

C126

R127

C127

C196

R1554R1109

FL105

C1

31

C1

36

C1

44

C1

55

C1

58

C1

62

C1

64

C160

RB113

RB112

C177 FL106

C116

C118

C1

30

R1

36

C1

32

C1

35

C1

37

C1

39

C1

40

C1

46

C1

49

C1

50

R1

16

8

R1

54

7

C1

56

C152

C153C159

R1

54

0

R1

54

8

R1

54

9

R1

55

0

R1

10

3

R1

55

1

R1

10

4

C1

61

R138

IC102

R1553 R1101

RB103

R196

FL104

R1

12

5

R1

12

4

R1

12

3

R1

12

2

R1

12

1

R1

12

0

R1

52

4

R1

52

6

R1

52

7

R1

55

9

R1

54

3

R1

54

2

R1

10

2

R1

92

R1

90

R1

89

X101

R1

50

4

C147 C148

C119

C115

C117

C114

R1161 R1126

C124

R321

R4701

R4702

R4703

R4704

R4705

R4706

CN301

R1105

C173

C172

C171

C170

C176

C175 RB104

C174

R1

97

C163

R195

0

1016V

001

00

47

47

0

47

47

47

10

0

10

0

1

1

1

1

0.1

0.0

01

75

0k

22

0

22

0.1

10

0k

0.001

0.0015

0.1

0.1

100

0.01

0.0047

4.7k0

2.2

0.0

1

0.0

1

0.0

1

0.0

1

0.0

1

0.0

1

0.01

22

22

476.3V

0.1

10 16V

0.1

15

k

0.1

0.0

33

0.1

22

p

0.1

0.1

0.1

10

16

V

47

0

4.7

k

0.0

112p

12p0.01

4.7

k

4.7

k

4.7

k

4.7

k

10

k

4.7

k

10

k

0.0

1

100k

CXD9849R

0 2.2k

0

0

000000000

10

k

10

k

10

k

15

0

15

0

15

0

15

0

27MHz

0.047 0.047

1016V

0.1

10 16V

0.1

0 10k

1

0

0

0

0

0

0

0

13P

10k

0.01

0.01

0.01

0.01

0.01

0.01 0

0.01

15

0

0.01

150

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

MSW

MUTE123

MUTE

LIMITSW

ALRCK

ASDATA0

ASDATA1

ASDATA2

ASDATA4

XRST

VREFO

RF+3.3V

SPFG

IOPMON

DMO

FMO

TRO

FOO

V2REFO

TSD_M

SPDATA

KRMOD

MIC

MREQ

ABCK

ACLK

SCORE

XVOICE

IFSDO

IFCK

XIFCS

IFSDI

SCL

SDA

IFBSY

RXD

TXD

PRST

RF

VC

PD

LDO1

LDO2

RF1.8

SCL

SDA

RF+3.3V

VOA

VOB

VOC

VOD

VOE

VOF

RA4

RA5

RA6

RA7

RA8

RA9

RA11

RA0

RA1

RA2

RA3

RA10

BA0

BA1

DRCKE

DRCLK

RCS

RAS

CAS

RWE

DQM1

RD8

RD9

RD10

RD11

RD12

RD

0

RD

1

RD

2

RD

3

RD

4

RD

5

RD

6

RD

7

DQ

M0

A2

A3

A4

A5

A6

A7

A8

A18

A19

A0

A1

A9

A1

0

A11

A12

A1

3

A14

A1

5

A1

6

A17

A2

0

A2

1

HD

0

HD

1

HD

2

HD

3

HD

4

HD

5

HD

6

HD

7

XW

R

XR

OM

CS

XR

D

RD13

RD14

RD15

AS

DA

TA

4

XR

ST

AS

DA

TA

0

AS

DA

TA

1

AS

DA

TA

2

AC

LK

AB

CK

AL

RC

K

MU

TE

12

3

MU

TE

SP

DA

TA

SC

OR

E

KR

MO

D

MIC

XV

OIC

E

CR

/R

CB

/B

Y/G

V C Y

LIMITSW

TSD_M

V2REFO

VREFO

IOPMON

SPFG

DSEL

WIDE

MSW

IFS

DO

IFC

K

XIF

CS

IFS

DI

SC

L

SD

A

IFB

SY

RX

D

TX

D

PR

ST

MR

EQ

RF

VC

PD

LDO1

LDO2

Y

C

V

Y/G

CB/B

CR/R

XVOICE

MIC

KRMOD

SCORE

SPDATA

MUTE

MUTE123

ALRCK

ABCK

ACLK

ASDATA0

ASDATA1

ASDATA2

ASDATA4

XRST

LIMITSW

TSD_M

V2REFO

VREFO

IOPMON

MSW

WIDE

DSEL

SPFG

XIFCS

IFSDI

PRST

SCL

SDA

IFBSY

RXD

TXD

IFSDO

MREQ

RF

VC

PD

LDO1

LDO2

VOA

VOB

VOC

VOD

VOE

VOF

DMO

FMO

TRO

FO0

FOO

DMO

FMO

TRO

SCL

SDA

VOF

VOE

VOD

VOC

VOB

VOA

IFCK

(3/4)

RGBSEL

DSEL/DISCXEXT

WIDE

D-GND

D-GND

D-GND

D-GND

V

C

Y

Y/G

CR/R

CB/B

AGND

DVDA

DVDB

DVDC

DVDD

DVDRFIP

DVDRFIN

MC

MD

SA

SB

SC

SD

CDFON

CDFOP

MDI1

LDO2

LDO1

MDI2

SVDD3

CSD

RFLVL

SGND

V2REFO

V2O

VREFO

TEO

TEZISLV

OPOUT

OPIN

OPIN

DMO

FMO

TROPENPWM

IOPMON

TRO

FOO

DVSS

NC

NC

DVDD3

SPFG

DSEL

MSW

MAMUTE

DVDD18

IOA2

IOA3

IOA4

IOA5

IOA6

IOA7

IOA18

IOA19

DVSS

APLLCAP

APLLVSS

VD

D3

IOW

R

DV

DD

3

IOA

20

IOC

S

IOA

1

IOO

E

DV

DD

3

AD

0

AD

1

AD

2

AD

3

DV

SS

AD

4

AD

5

AD

6

IOA

21

ALE

AD

7

IOA

0

DV

SS

UR

D

DV

DD

18

IFS

DO

IFC

K

XIF

CS

SC

L

SD

A

TR

G-S

W

IFB

SY

RX

D

TX

D

DV

DD

3

ICE

PR

ST

IR INT

0

DQ

MO

MR

EQ

RD

7

DV

SS

RD

6

RD

5

DV

SS

RD

4

RD

3

IFS

DI

DV

DD

18

RD

2

RD

1

RD

0

RD

15

DV

DD

3

RD

14

RD13

RD12

RD11

RD10

RD9

DVSS

RD8

GPIO

DQM1

RWE

CAS

RAS

DVDD3

RCS

BA0

DVSS

RA10

RA0

DVSS

RA1

RA2

RA3

DVDD18

NC

NC

DVDD3

RCLK

CKE

RA11

RA9

RA8

DVSS

RA7

DVSS

RA6

RA5

RA4

DVDD3

DISC/X

RGB

TSD_M

NC

NC

DVDD18

FWD

NC

LIMSW

OCSW

CKSW

NC

NC

DVDD3

NC

NC

NC

NC

NC

NC

DAVCC

VREF

FS

YUV0

DA

VS

S

YU

V1

DA

VD

D

YU

V2

DA

VS

S

YU

V3

DA

VD

D

YU

V4

DA

VS

S

YU

V5

YU

V6

DV

DD

3

SM

SC

K

MU

TE

MU

TE123

DV

DD

3

AB

CK

AC

LK

DV

SS

AS

DA

TA

0

AS

DA

TA

1

AS

DA

TA

2

XR

ST

DV

DD

18

AL

RC

K

AS

DA

TA

4

DV

SS

DW

IDE

SD

PIF

RFG

ND

18

RFV

DD

18

XT

AL

O

XT

AL

I

JIT

FO

JIT

FN

PLLV

SS

IDA

C

PL

LV

DD

3

LP

FO

N

LP

FIP

LP

FIN

LP

FO

P

VD

D3

NC

VS

S

NC

NC

RFV

DD

3

RFR

PD

C

RFR

PA

C

HR

FZ

C

CR

TP

LP

RFG

ND

NC

NC

OS

P

RFG

C

IRE

F

AV

DD

3

OS

N

WIDE

SP

DA

TA

KR

MO

D

VO

ICE

MIC

REV

BA1

UW

R

IOA

7

MA

MB

TNI

TPI

RF AMP,SERVO DSP,MPEG DECODERFEO

IOA8

IOA

16

IOA

15

IOA

14

IOA

13

IOA

12

IOA

11

IOA

10

IOA

9

(Page32)

(Page 33)

(Page 32)

(Page39)

(Page33)

(Page35)

(Page32)

(Page 32)

3535

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-12. SCHEMATIC DIAGRAM – DMB15 Board (4/4) – • See page 67 for IC Block Diagrams.

CN302

R3504

R3505

D3501

D3502

R3789

R3779

R3778

C3774

R3777

R3776C3773

C3707

R3774

R3773C3771

R3772

R3771

IC3771

C3784

R3787

R3788

C3782

R3786

C3783

R3785

R3784

R3783

C3781

R3781

R3782

C3708

R3769

R3759

R3758R3757

C3754R3756C3753

C3705

R3755

C3752

R3754

R3753

R3752

R3751

C3706

IC3751

R3768

R3767

C3764

C3762

R3766

C3763

R3765

R3764

R3763

C3761R3762

R3761

IC3731

R3749

R3739

R3738

R3736

R3737

C3734C3733

C3703

R3735

C3732

R3734

R3733

R3732

R3731

C3704

R3748

C3744

R3747

R3746

C3743

R3745

C3742

R3743

R3744C3741

R3741

R3742

R3729

R3719

R3718

C3714R3716

R3717

C3701

C3713R3715

C3712

R3714

R3713

R3712

R3711

IC3711

C3702

R3727

C3724

C3722

R3726

C3723

R3725

R3723R3721

C3721R3722

C3805

C3803R3805

R3724

Q3801

R3803

C3802

C3804

R3801

C3801

C307

R3802

R3804

R319

R3611

R3621

C3611 C3621C3610

C3609

C3608

C3607

L3602

C3605C3606

C3603

R3607

C3601 C3602

R3603

D3601

D3602

IC3601

R3605

L3601 R3601

R3606

R3602

R3609

R314

R3653

R3652

C301

C306C305

IC301

C302

R3651

R3728

R3775

C3772

C3751

C3731

C3711

21P

100

100

1SS355TE-17

1SS355TE-17

1k

1k

4.7k

330p

1k

1k330p

0.1

3.9k

3.9k1800p

1.5k

1.5k

NJM3414AV

330p

1k

4.7k

2200p

1k

330p

4.7k

3.9k

3.9k

1800p

1.5k

1.5k

0.1

1k

1k

4.7k1k

330p1k330p

0.1

4.7k

2200p

3.9k

3.9k

1.5k

1.5k

0.1

NJM3414AV

4.7k

1k

330p

2200p

1k

330p

4.7k

3.9k

3.9k

1800p1.5k

1.5k

NJM3414AV

1k

1k

4.7k

1k

1k

330p330p

0.1

4.7k

2200p

3.9k

3.9k

1.5k

1.5k

0.1

4.7k

330p

1k

1k

330p

4.7k

2200p

3.9k

3.9k1800p

1.5k

1.5k

1k

1k

4.7k

330p1k

1k

0.1

330p4.7k

2200p

3.9k

3.9k

1.5k

1.5k

NJM3414AV

0.1

1k

330p

2200p

1k

330p

4.7k

3.9k1.5k

1800p1.5k

474V

1004V1k

3.9k

2SC2712

10k

10

476.3V

0

1006.3V

1006.3V

0

18k

0

100

100

1000p 1000p0.1

10 16V

10 16V

0.1

100µH

47 6.3V0.1

0.1

0

10 0.1

10k

1SS355TE-17

1SS355TE-17

PCM1803

0

100

0

100

0

100

0

0 0.01

1006.3V0.47

AK4358VQ-L

0.47

0

4.7k

4.7k

2200p

1800p

1800p

1800p

XRST

ASDATA4

ALRCK

ASDATA2

ASDATA1

ASDATA0

SDA

SCL

GND

SPDATA

SW+3.3V

SW+5V

ABCK

ACLK

XVOICE

SCORE

LO

UT1+

LO

UT1-

AR

T+

AR

T-

ART-

ART+

ALT+

ALT-

ROUT3-

ROUT3+

LOUT3+

LOUT3-

RT

FR

FL

SR

SL

RT

LT

SW

FC

SR

SL

FR

FL

XVOICE

SCORE

R-IN

L-IN

ROUT1+

ROUT1-

LOUT2+

LOUT2-

ROUT2+

ROUT2-

LOUT3+

LOUT3-

ROUT3+

ROUT3-

ALT+

ALT-

ROUT2-

ROUT2+

LOUT2+

LOUT2-

ROUT1-

ROUT1+

LOUT1+

LOUT1-

LT

SW

FC

SPDATA

XRST

ABCK

ACLK

ASDATA0

ASDATA1

ASDATA2

ASDATA4

ALRCK

SCL

SDAXVOICE

SCORE

XRST

ABCK

ACLK

ASDATA4

ASDATA0

ASDATA1

ASDATA2

ALRCK

SDA

SCL

SPDATA

L-IN

R-IN

DGND

RT

AGND

LT

AGND

SW(LFE)

FC

SR

SL

AGND

FR

AGND

AL

AU+5V

AGND

L-IN

AGND

R-IN

XVOICE

SCORE

MIX AMP

VDD

VSS

VDD

VSS

VDD

VSS

VDD

VSS

MIX AMP

MIX AMP

MIX AMP

A/D CONVERTER

(4/4)

D/A CONVERTER

MODE1

MODE0

FMT1

FMT0

OSR

SCKI

VDD

DGND

DOUT

BCK

LIN

RIN

V_REF_1

V_REF_2

VCC

AGND

BYPASS

FSYNC

LRCK

PDWN

ROUT1+

ROUT1-

LOUT2+

LOUT2-

ROUT2+

ROUT2-

LOUT3+

LOUT3-

ROUT3+

ROUT3-

LOUT4+

LOUT4-

LO

UT

1-

LO

UT

1+

DZF3(L

)

DZ

F2

(R)

DZ

F1

(SU

R)

CA

D0

AC

KS

N

PD

N

BIC

K

DV

DD

DV

SS

MC

LK

DS

DL

1

DS

DR

1

DS

DL

2

DS

DR

2

DS

DL

3

DS

DR

3

DIF

0

RO

UT

4-

RO

UT

4+

VR

EFH

AV

DD

AV

SS

SDTI4

SDTI1

SDTI2

SDTI3

LRCK

I2C

SCL

SDA

CAD1

DCLK

DSDL4

DSDR4 (DMIXR)(DMIXL)

(FL)

(FR)

(SL)

(SR)

(FC)

(SW)

AGND

CENTER VOLTAGE GENERATOR

10µH

(Page 48)

(Page34)

(Page 33)

3636

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-13. PRINTED WIRING BOARDS – CHANGER Section – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

JW702

JW703

JW704

JW705

JW706

JW707

JW70

8

JW711

CN705

JW712

JW701

JW70

9

JW713

JW714

JW710

R736

CN702

R751

C752

CN703

CN704

IC712

R713

Q731

C751

D711

D701

C737

R734

R733

R732

R723

R722

R721

R731

R712

R711

R702

R701

C736

C735

C741

C731

C715

IC701

CN701

CN721

M751

IC731

CN731

CN741

CN742

M741

CN751

S751

1-866-201-

12

(12)

1

2

E

DRIVER BOARD

FMAIN

BOARDCN511

1

9

1

9

1

4S711ROTARY ENCODER

DISC TABLEADDRESS DETECT

1 2

M

MOTOR (LD) BOARD

1-687-133-

12

(12)

(LOADING)

12

SENSOR BOARD

1-68

7-13

2-

12

(12)

E

C

A

K

MOTOR (TB) BOARD1-

687-

134-

12

(12)

1

3

(TABLE)

SW BOARD

1-687-669-

12

(12)

1

2

DISC TABLEOPEN/CLOSE

DETECTOPEN

CLOSE

A

B

C

D

E

F

G

H

1 2 3 4 5 6 7 8 9 10

M

(Page 45)


Ref. No. Location

D701 E-7D711 E-7

IC701 F-7IC712 F-8IC731 F-5

Q731 C-9

3737

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-14. SCHEMATIC DIAGRAM – CHANGER Section – • See page 67 for IC Block Diagrams.

C741

R702 R701

D701C751

R713

R712 R711

D711

CN721

R7

22

R7

21

R7

23

C7

36

C7

35

C7

37

R731

C731

R733

CN704

E3

E2

E1

CN703

CN742 CN702

CN741

IC731

CN751 CN705

C752 R751

CN731

Q731

M751

M741

IC701

IC712

R734 R732

CN701C715

R736

S751

0.01

100 470

MTZJ-T-775.1A0.01

22k

4.7k 1k

MTZJ-T-773.6B

2P

4.7

k

4.7

k

4.7

k

0.1

0.1

0.1

100

1050V

1k

2P

4P

5P 5P

3P

RPI-579N1

2P 2P

0.1 4.7k

3P

DTC114ESA

BA6956AN

BA6956AN

12k 10k

13P10016V

390

RN

FR

NF

TM-2

GND

TM-1

SENS-IN

SENS-OUT

GND

TM-1

TM-2

SENS-IN

SENS-OUT

GND

SENS-IN

SENS-OUT

GND

SENS-IN

SENS-OUT

GND GND

OPEN SW OPEN SW

LM-2

LM-1 LM-1

LM-2

GND

E-1

E-2

E-3

VC

C

OU

T2

GN

D

VR

EF

OU

T1

VM

FIN

RIN

VC

C

OU

T2

GN

D

VR

EF

OU

T1

VM

FIN

RIN

LM-R

TM-R

E-1

E-2

E-3

TBL ADDRESS SENS

OPEN SW

(LOADING)

ADDRESS DETECT

(TABLE)

OPEN

CLOSE

OPEN/CLOSE

DETECT

DRIVE

LOADING MOTOR

DRIVE

TABLE MOTOR

LEVEL

SHIFT

D+3.3V

M+9V

M-GND

M-GND

LM-F

TM-F

DISC TABLE

S711

DISC TABLE

DISC TABLE

ADDRESS SENSOR

ROTARY ENCODER

(Page 46)

Ver. 1.1

3838

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-15. PRINTED WIRING BOARD – VIDEO BOARD – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

JR802

R800

R802

R803

R804

R805 R806

R807

R808

R809

R810

R812

R813

R814

FB800

FB801

FB802

FB803

FB804 FB805

FB806

JR800

JR803

JR804

C818

C817

C816

C819

C820

C821

C822

C823

C824

C825

C831

C809

C804

C810

JW801

JW80

2

JW804

JW805

JW807

JW81

1

JW803

JW806

JW800

CN800

EPT800

C811

C812

C813

C814

C815

C800C801 C802

C803 C805

C806 C807

C808

C829

CN802

L801

C830

CN801

C826

C827IC800

IC801

1415

128

1

2

VIDEO BOARD

1 5

1-865-440-

11

(13)

1

4

8

5

Y

PB/CB

PR/CR

VIDEOOUT

J802

S VIDEOOUT

J801

(CHASSIS)

(CHASSIS)

YC

GG

(CHASSIS)

E MAIN BOARDNO503C DMB15 BOARD

CN301

TMIC

BOARDNO1100

COMPONENTVIDEO OUT

J800

(CHASSIS)

A

B

C

D

E

1 2 3 4 5 6 7

(Page 30) (Page 45)

(Page40)

3939

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-16. SCHEMATIC DIAGRAM – VIDEO Board – • See page 54 for IC Waveforms.

PR/CR

PB/CB

C827

L80110µH

R807

C800

C801

C802

C803

C804

C805

C806

C807

C808

R812

R809

C810

C815

C814

C813

C812

C811

R802

R803

R804

R805

R806

R808

C830

C831

R813

C816

C817

C818

C819

C820

C821

C822

CN802

CN800

CN801

C824

C823

C825 EPT800

J802

JR804

J801

FB800

FB801

FB802

FB803

FB804

FB805

JW800

IC801

VIDEO AMP, 75Ω DRIVER

IC800C826

C829

JR800

C809

JR802

J800

JR803R810

FB806

R800

R814

10 50V

100

1 50V

1 50V

1 50V

22 50V

0.1

1 50V

1 50V

1 50V

100 10V

1M

10k

0.1

10006.3V

10006.3V

10006.3V

10006.3V

10006.3V

75

75

75

75

0

75

10010V

0.01

100k

22p

22p

22p

0.01

22p

0.01

22p

2P

5P

13P

0.01

22p

0.01

1P

0

0

0

0

0

0

0

MM1623BF

NJM2244M1050V

10006.3V

0

0.1

0

3P

0.0168

0

100

10k

RGBSEL

DSEL/DISCXEXT

WIDE

D-GND

Y/G

D-GND

Y

D-GND

C

D-GND

V

+9V

V MUTE

VIDEO OUT SW

GND

+5V

VIDEO-GND

VIDEO-SIG

(CHASSIS)

(CHASSIS)

(CHASSIS)

Y

COMPONENT

VIDEO OUT

VIDEO

OUT

OUT

S VIDEO

GND2

CROUT

GND2

CBOUT

GND2

CYOUT

YOUT

GND2

S2

S1

S-DCOUT

VCC2

C OUT

CVBSOUT

CRIN

MUTE2

CLP

CYIN

I/P

BIAS

GND1

YIN

CVBSIN

MUTE1

CIN

VCC1

CBIN

YC MIX

VIN1

SW1

VIN2

SW2

GND

VOUT

VCC

VIN3

CB/B

CR/R

VIDEO SWITCH, 75Ω DRIVER

(Page 34)

(Page 47)

(Page 41)

4040

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-17. PRINTED WIRING BOARD – MIC BOARD – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

R1152

R1156

R1139

C1128

R111

3R111

9

C112

5

R1138

R1108R1102

R1110

C1100

R1126

R1103R1109

C1101

R1132

R110

7

R110

6

R110

5

R110

4

C111

3

D1102

IC1101

C110

4R1115

R1116

C1103

R1121

C1110

C1109

R1122R1123

C1124R1120

FB902

R1137

C1134

R1127

C1135

R1128

R1130

R1131

R1118

C1129

R1124R1114

FB1100

FB1101

C1142

IC1100

R1147

C113

3

C1139

R1140

R111

1

C1102

R110

0

C111

9

J1101

RV1102

RV1100

RV1101

J1100

J1102

J1103

CN1102

C1114

C1115

C1123

C1127

C1106

C1116

C1117

C1107

C1145 C1144

JW11

02

JW11

06

JW1108

JW1109

JW1110

JW1111

JW1112

JW1113

JW1114

JW1115

JW1116

JW1117

JW1118

JW11

19

JW11

20

JW11

21

JW11

22

JW1123

JW1124

JW1125

JW1126

JW11

27

JW1128

EPT1

103

EPT1104

JW11

07

JW11

32

JW11

34

NO1101

C1112C1108

C1111

C1121

C1105

JW11

01

C1126

JW1133NO1100

C113

6

1 31 2

1 4

1 15

30 168 5

1 9

MIC BOARD

1-868-673-

11

(13)

PHONES

R L VIDEOAUDIO

MIC 1MIC 2

MIC 1 LEVEL

VIDEO INPUT

H MAIN BOARDCN100 T VIDEO BOARD

CN802 U PA BOARDNO601

(CHASSIS)

(CHASSIS)

ECHO LEVEL

MIC 2 LEVEL

A

B

C

D

E

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

(Page 45) (Page 38) (Page 52)

Ver. 1.1

4141

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-18. SCHEMATIC DIAGRAM – MIC Board – • See page 67 for IC Block Diagrams.

CN1102

IC1100

C1108

R1152

C1115

C1116

R1107

R1105

R1106

R1104

C1113

C1106

R1137

R1138

R1126

C1104

C1103

D1102C1123

C1124

R1123

R1120

R1121

R1122

R1156

C1107

C1110

R1103

C1112

R1109

C1101

R1108

R1110

C1100

R1114 R1124

R1113

R1119

C1125

R1111

R1100

C1102

R1132

C1133 C1139

C1119

C1121R1118

EPT1103

EPT1104

NO1100

C1129NO1101

JW1102

FB902

C1109

JW1101

C1144

C1145

FB1101

FB1100

C1134

C1105

R1116R1115

C1114

R1139

R1147 R1140

C1117

R1130

R1131

C1142

C1127C1126

C1111

R1102J1100

J1101

J1102

J1103

RV1102

RV1101

RV1100

R1128 R1127 C1135

C1128

IC1101(1/2)IC1101(2/2)

3P

TC9488FG

1 50V

1.5k

4.7 50V

47 16V

100

100

100

5.6k

68p

4.750V

10k

10k

10k

0.1

0.1

UDZW-TE17-5.1B47

16V

0.0012

15k

3.9k

6.8k

12k

1.5k

4.750V

1

1k

1 50V

10k

0.01

10k

10k

0.01

10k 10k

12k

15k

0.0015

10k

15k

0.0015

0

0.1 0.1

C11360.1

47p

0.2250V

1k

2P

0.19P

0.0047

1050V

1050V

0

0

220p

0.1 50V

330330

4.750V

10k

15k 10k

4716V

15k

15k

0.1

1050V

22010V

0.2250V

1k

3P

50k

50k

50k

33k 33k 220p

47p

NJM4565MNJM4565M

MIC AGND

A+9V

H/P DETECT

VIDEO-SIG

VIDEO-GND

MIC ECHO

NC

OSCR

OSCC

VDD

NC

NC

VRO

VREF

VDA

ALC1

MC1N

MC1P

VSS

POOUT

TEST

VOLST

NC

DA OUT

NC

ADIN

PRIN

MCO

VSA

ALC2

NC

MC2N

MC2P

VOL2

(CHASSIS)

(CHASSIS)

VIDEO(A)-L

VIDEO(A)-GND

VIDEO(A)-R

MIC DETECT

MIC AMP

DIGITAL ECHO

MIC SCORE

HP-R

HP-GND

HP-L

VIDEO

L

R

AUDIO

VIDEO INPUT

PHONES

MIC 2 LEVEL

MIC 1 LEVEL

ECHO LEVEL

VOL3

VOL1

MIC 2

MIC 1

(Page 39)

(Page 46)

(Page 53)

Ver. 1.1

4242

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

Q1508

Q1509

Q1510

Q1511

Q1512

Q1513

Q1514

R1516

R151

7

R1596

R1597

R1598

R1599

C1511

Q1504

D1506

D1507

Q1505

D150

5

Q150

3

C153

3

R155

3

C153

4

R1561

R156

3

R1593

D1508

R1545

IC1502

D150

3R1

583

R1540

R1539R1541

C152

9

R1543

R157

7

R1605

R157

8

D150

4

IC1503

R153

5

R1534Q1502

R1592R1538

R1522

R1520

Q1501

R1519

Q1500

R153

2

R153

1

C1520

R151

1

R154

6

R151

2

C1517

R1604

R154

2

IC1501C1513

C1521

R1510

C1522

R151

4

R151

5

R1554

R153

3

R153

0

R155

6

R1552

IC1504

C1514

R155

5

C1574

C1536

C1547

C1527

C1518

R158

8

Q1506 R1594 R1589

R1570

R1590

R1566

R1557

R156

0

IC1506

R156

7

R1569

R1573

C154

8

C154

3

R1572

R1571

IC1505

R1558

R1549

R158

2

R1581

R1591

R1580R1595

R1579

R1574R1575

C1555R1576

R1565

R1568

C1568

D1502

Q150

7

R1547

R150

4

C1572

R150

0

R1550

R1525

R150

1R1

527

R160

6

R1607

R150

6

R150

7

R150

2

R154

4

R1564

R1536

C1571

R1602

R160

3

R1600

R1601

R1559

JW15

07

JW1520

JW15

24

JW15

25

JW1526

JW15

28

JW15

29

JW15

33

JW1537

JW15

42

JW1544

JW1545

JW15

47

JW1548

JW1549 JW1550 JW1551

JW1557

JW1558

JW15

08

JW1560

JW1527

JW1555

JW1552

JW1561

JW1531

JW1532

JW1538

JW1539

JW1505

JW1553

JW15

40

JW15

41

C153

7

C153

5

C1531

C1541

C154

0

C233

0

C233

1

JW1513

JW1517

JW1512

JW15

03

JW1502

JW1504

CN1502

C157

0

C1578

C160

2

C160

1

C155

4

C1584

C1524

C156

2

C1546

C1559

C154

5

C151

2

C1525

C151

9

C151

5

C1528

C156

1

C156

0

C1542

C152

6

C1544

C155

2

EP1500

C153

0

EP1501

JW15

22

JW15

34

JW1535

JW15

15 JW15

46

L1500

JW15

21

JW1559

JW1523

JW1536

JW1519

JW1556

JW1570

JW15

71

JW1518

JW1599

C1600

EFFECTOR BOARD

1-868-596-

11

(13)

M MAIN BOARDCN512

1

219

18

E

18

169

58

41

(CHASSIS)

(CHASSIS)

DG

S

D

GS

1 8

DG

S

DG

S

D

GS

1 8

16 9

1 8

16 9

DG

S

DG

S

D

GS

E

E

E

E

E

E

A

B

C

D

E

F

G

1 2 3 4 5 6 7

16 9

16

1 5 8

9

7-19. PRINTED WIRING BOARD – EFFECTOR Board – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

D1502 F-5D1503 B-5D1504 B-5D1505 B-6D1506 B-6D1507 B-6D1508 B-6

IC1501 C-2IC1502 B-4IC1503 B-3IC1504 D-5IC1505 F-3IC1506 F-4

Q1500 A-2Q1501 A-2Q1502 B-2Q1503 C-6Q1504 B-6Q1505 B-6Q1506 E-2Q1507 F-5Q1508 E-4Q1509 A-6Q1510 A-6Q1511 B-6Q1512 B-7Q1513 C-6Q1514 D-6


Ref. No. Location

(Page 45)

Ver. 1.1

4343

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-20. SCHEMATIC DIAGRAM – EFFECTOR Board – • See page 67 for IC Block Diagrams.

Q1509

R1504

R1525

R1502

R1501

R1500

R1569

R1567

C1545

R1571

R1572

R1568

C1548

R1566

C1554

R1570

R1574 R1575

C1555

R1589

C1559

R1579R1582

C1562

R1581

C1515

C1517

R1512

C1513

R1514

R1515

C1524

C1525

C1522

C1572

C1568

R1547

D1502

Q1507

C1571

C1552

C1578

R1557

R1549

R1558

R1550

C1570

C1529

R1559

R1507

Q1514

Q1513

R1517R1516 R1596 R1597 R1598 R1599

Q1512

Q1511

Q1510

CN1502

R1560

R1603R1601

R1602R1600

R1527

R1506

JW1513

R1576

C1560

R1573

R1594

C1546

C1561

Q1508

R1580R1595R1591C1544

C1584

IC1506

C1535

C1514C1537

R1588

R1554

C1533

C1531

C1543

R1552

C1534

R1553

IC1504

C1536

R1555

R1556

C1547

C1540

C1541

C1574

R1565

Q1506

R1590

C1542

C1519

R1546

C1520

R1511

C1518

L150010µH

IC1501

C1521

C1527

R1510

JW1507

C1512

R1519R1522R1538R1592C1530

C1526

Q1502 Q1501 Q1500

Q1503

Q1504

Q1505

C2330

C2331

R1593

R1564

R1563

R1561

D1506

D1507

D1508

R1577 R1578 R1583

D1505 D1504 D1503

C1511

R1540

R1539

R1541

R1532

R1531

R1530

R1533

IC1503

IC1502

R1542

R1543

R1534

R1536

R1535

R1544 R1545

IC1505(1/2)

IC1505(2/2)

C1528

DTC114EKA

100

100

100

100

100

100k

22k

1050V

100k

1k

22k

47p

2.2k

1050V

100k

100k 1k

47p

33

1050V

100k100k

1050V

22k

4710V

0.0015

18k

0.1

18k

18k

0.22 50V

0.22 50V

0.0015

0.1

0.1

10k

UDZW-TE17-6.2B

2SC5053

0.1

1050V

10 50V

100k

10k

100k

10k

1050V

0.01

100k

100

DTC114EKA

DTC114EKA

10k10k 10k 10k 10k 10k

STC114EKA

DTC1141EKA

DTC114EKA

19P

100k

100k100k

27k27k

100

100

4.7k

1050V

4.7k

0

1050V

1050V

C1602 10 50V

C1601 10 50V

2SK3378

22k047k

R160622k

R160722k

0.047

10010V

TC74LVX4052FT

0.033

0.10.1

18k

18k

330p

4710V0.068

18k

1500p

18k

M65850FP

330p

18k

18k

0.068

0.22 50V

0.22 50V

1500p

2.2k

2SK3378

47k

R160422k

0.0047

0.033

18k

330p

18k

0.068

M65850FP

330p

0.068

18k

0.1

39k027k00.033

C16000.1

0.1

2SK3378 2SK3378 2SK3378

2SK3378

2SK3378

2SK3378

0.1

0.033

0

27k

0

39k

MA111-TX

MA111-TX

MA111-TX

10k 10k 10k

MA111-TX MA111-TX MA111-TX

0.1

1.2k

1k

1.5k

560

510

470

680

TC74LVX4051FT

TC74LVX4051FT

1.8k

2.2k

750

910

820

18k 33k

NJM4565M

NJM4565M

10010V

CTRL2

CTRL1

CTRL3

S3

S0

S1

S2

CTRL1

R160522k

CTRL1

CTR

L1

CTR

L2

CTR

L3

S0

S1

S2

S3

CTR

L1

CTR

L2

CTR

L3

OP2OUT

VCC

CLOCK

REF

OP2IN

LPF2IN

LPF2OUTGND

CC2

CC1

OP1IN

OP1OUT

LPF1OUT

LPF1IN

NCNC

OP2OUT

VCC

CLOCK

REF

OP2IN

LPF2IN

LPF2OUTGND

CC2

CC1

OP1IN

OP1OUT

LPF1OUT

LPF1IN

NCNC

INPUT R

INPUT L

S0

S1

S2

OUTPUT R

OUTPUT L

AGND

AGND

AGND

AGND

SELECTOR

AGND

DGND

S3

A+9V

CTRL1

CTRL2

CTRL3

D4

D6

COM

D7

D5

INH

VEE

GND

VCC

D2

D1

D0

D3

A

B

C

GND

VEE

INH

D5

D7

COM

D6

D4VCC

D2

D1

D3

D0

B

A

C

VCC

2X

1X

0X

3X

A

B

0Y

2Y

3Y

1Y

INH

VEE

GND

Y COM

X COM

LEVEL SHIFT

LEVEL SHIFT

LEVEL SHIFT

LEVEL SHIFT

LEVEL SHIFT

LEVEL SHIFT

MIXER

SWITCHING

S

SIGNAL SELECTOR

DIGITAL ECHO

SWITCHING

S

DIGITAL ECHO

SWITCHINGSWITCHINGSWITCHING

S S S

SWITCHING

SWITCHING

SWITCHING

S

S

S

MULTIPLEXER

MULTIPLEXER

+5.6V REGULATOR

(Page 48)

Ver. 1.1

4444

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

IC2000

IC2001IC2002

R200

2

R2000

R2001

R2005

R2004

R2037R2007

R2010

R2009 R2012

C2008

R2014

D2000

D2001

R2008

R2011

C2007

R2015

D2002

D2003

R2016

C201

6

R201

7

R2019

R2022

R2021

D2006

D2008

R2020

R2025

R2024

C201

3

R2026

R2031

R2028R2029 R2030 R2036

R2034

R2032

R2035

C2015

D2007

C2001

C2000

C2002

C2004

C2006 C2009

C2005

C2010 C2011

JW20

08

JW2001JW2002

JW2003

JW2004

JW2005

JW2006

JW20

07

JW20

09

JW2010

JW20

11

JW2012

NO20

00

KARAOKE BOARD

1-869-677-

11

(11)

KMAIN

BOARDCN505

1

6

A

B

C

D

1 2 3 4 5

7-21. PRINTED WIRING BOARD – KARAOKE Board –• See page 29 for Circuit Boards Location. : Uses unleaded solder.

7-22. SCHEMATIC DIAGRAM – KARAOKE Board –

• SemiconductorLocation– KARAOKE Board –

Ref. No. LocationD2000 C-3D2001 C-3D2002 D-3D2003 D-3D2006 C-4D2007 C-4D2008 C-4

IC2000 C-3IC2001 B-4IC2002 B-3

R2001

R2017

C2008

R2035

R2036

R2030

C2016

R2005

C2000

C2005

R2008

C2007

R2012

R2011

C2010

R2007

C2011

R2019

R2020

R2024

R2026

C2013

C2009

R2025

R2016

R2009C2006

R2015

R2000

R2010

R2021

R2037

C2004

C2002

C2001

NO2000

R2022IC2000(1/2)IC2001(1/2)

IC2000(2/2)

IC2002(2/2)

R2034

R2031

R2029

IC2002(1/2)

C2015

R2002

R2032

R2028

R2004

R2014

D2002

D2001

D2000

D2003

D2008

D2007

IC2001(2/2)

D2006

4.7k

4.7k

470p

2.2k

0

0

0.01

47k

10010V

47 16V

47k

0.1

100k

0

2.250V

4.7k

4716V

4.7k

0

4.7k

0

0.1

4716V

4.7k

47k

1k1 50V

2.2k

4.7k

100k

0

0

2.250V

4716V

4716V

6P

10kNJM3414ANJM2903M-TE2

NJM3414A

NJM2903M-TE2

2.2k

22k

22k

NJM2903M-TE2

0.1

22k

1.2k

1.5k

2.2k

8.2k

MA111-TX

MA111-TX

MA111-TX

MA111-TX

MA111-TX

MA111-TXNJM2903M-TE2

MA111-TX

A+9V

MUSIC L+R

SCORE

XVOICE

MIC SCORE

AGND

COMPARATOR

COMPARATOR

AC/DC CONVERTER

Q522 L-10Q523 B-6Q524 C-6Q550 K-13Q564 L-11Q578 K-15Q579 L-15Q581 K-14Q582 K-14Q585 K-15Q587 F-6Q588 E-5Q589 F-5

D101 L-16D102 L-16D136 G-16D325 K-16D340 F-4D341 F-4D342 F-3D401 E-5D402 E-5D403 E-6D411 D-4D412 D-4D501 C-6D502 C-6D503 C-6D504 C-6D505 C-6D506 L-7

Ref. No. LocationRef. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location

• Semiconductor Location– MAIN Board –

D507 L-7D510 H-4D511 G-4D550 K-14D551 K-14D560 J-10D561 I-10D581 K-14D582 K-15D583 K-15D584 E-6D585 G-16D586 G-16

IC101 D-9IC201 D-14IC301 I-5IC304 G-6

IC401 C-3IC501 C-6IC507 J-14IC550 L-14IC558 H-10IC559 H-9IC560 H-14IC561 I-14

Q101 C-8Q103 G-15Q104 G-16Q106 D-11Q117 C-13Q151 D-8Q156 D-10Q167 C-12Q200 B-14

Q202 B-15Q203 B-15Q204 C-15Q205 E-14Q206 J-15Q207 I-15Q208 I-16Q250 C-14Q252 C-15Q253 B-15Q254 B-16Q255 E-13Q256 J-15Q321 K-5Q322 K-4Q323 L-16Q325 K-4Q340 F-4

Q504 F-3Q505 L-10Q506 L-10Q507 L-9Q508 L-9Q509 L-9Q510 L-9Q511 L-8Q512 L-8Q513 H-11Q514 L-11Q515 L-8Q516 L-10Q517 L-10Q518 J-14Q519 L-8Q520 H-10Q521 L-10

Q341 F-4Q342 F-3Q343 F-4Q344 F-4Q345 F-3Q370 L-4Q372 K-4Q373 K-4Q375 K-5Q377 K-5Q378 L-5Q379 K-5Q380 L-5Q381 J-5Q382 K-5Q383 K-5Q501 B-6Q503 J-14

(Page 45)

(Page 47)

Ver. 1.1

4545

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

C530

C233

R521

C235

JR510

D551 D583

JR218

JR21

9

Q550

Q579

R248

R250

R551

R549

R520

R103

R153

JR50

9

JR502

JR10

4

R540R538

Q208

R601

R602

JR514

D325

C156

C410

C411

C412

C464

JR400

D502

IC401

R494

IC501

JR40

4

Q504

R300

R406R410

R411

R412

R413

R414

R415

R417

R421

R420

R419

R423R424

R425

R426

R427

R428

R429

R430

R431

R623

JR430

C340

C360

JR500

JR50

5

C513

C515

C551

C564

C565

D403

C568C569

C580 C581

R432

R433

R434

R435

D340

D342

D341

D401

D402

D501

D503

D504

D505

D506

D507

D550 D581

D582

FB204

FB25

4

R436

R437

R438

R439

JR50

6

JR504

IC304

R335

JR52

0

R440

R441

R442

JR50

3

JR50

1

R443

R444

R445

R447

R451

R453

R454

Q206

Q207

R457

Q256

Q340

Q342

Q341

Q343

Q345

Q344

Q514

Q564

R525

R526

R527

R528

R575

R576

R577

Q501

Q503

Q505 Q506

Q507

Q508

Q509

Q510

Q511

Q512

Q513

Q515

Q516 Q517

Q518

Q519

Q521Q522

Q578

Q581

Q582

R450

R458

R466

R467

R468

R469

R378

C382

R337

Q321

R368

R303

R305

R339

R301

R355

R594

R314

R312

Q375

R595

R463

R448

R590

JR305

R589

Q587Q589

C335

R306

R380

C364

R311

R354

R318

R389

JR30

1

Q370

JR302

R392

R352

R338

R238

R239

Q372

R243

R244

R245

R246

R247

R251

R252

R253

Q382

JR35

9

R418

R370

Q379C333

R394

C377

C376

JR304

C326

R288

R289

R293

R294

R295

R296

R297

R578

JR507

R315

R316

R317

D101

IC550

R422

R585

R584

R340

R342

R345

R343 R344

R341

R348

R349

R346

R347

R350

R369

R357

R358

R359

R360

R361

R365

R366

R554

R553

R552

R539

R537

R536 R535

R534 R533

R381

R382

R530

R529

R524

R523

R522

R400 R401R402

R403

R404

R405

R407

R408

R409

JR544

JR100

JR508

C341

R593 R592

R574

R573

R502

R483

R493

R492

R491

R490

R489

R488R487

R486

R485

R484

R475

R474

R473

R472

R471

R501

R470

R503

R505

R506

R507

R508

R509R510

R511

R512

R513

R514R5

15

R516R517

R518

R519

JR43

5

R387

Q373

Q322

Q325

R336

R373

R388

R385

C332

Q383

R375

R325R371

R374

C314R319R310

C307

R309

R351

R395

R396

D584

Q380R386

R304

R353

R390

R308

R372

Q378

C385

R399

C372

JR300

IC301

R376

C371

R364

R379

Q377

JR30

3

R120

R377

Q381

C383

R302

C373

R101

R102

R104

R105

R106

R107

R108

R109

R110

R111

R112R113

R114

R115

R116

R117

R121

R122

R130R131 R132

R133

R150

R151

R152

R154

R155

R156

R157 R158

R159

R160

R161

R162

R163

R164

R165

R166

R167

R200

Q255

Q254

Q253

Q252Q250

Q205

Q204

Q203

Q202

Q200

Q167

Q156

Q151

Q117

Q106

Q101

D136

R205 R206

R207R208

R209 R210

R211

R212

R213

R214

R215

R216R2

17

R218R219

R220

R221

JR20

8

JR200

R586

C279

C274

C273

C270

C268

C264 C261

C260

C256

C242

C229

C223

C220

C218

C214

C212

C211

C210

C206

C115

R229

R222

R223

R224

JR204

R225

IC201

IC101

FB26

1

JR205

JR40

7

R299

R298R292

R273

FB260

R249

R242

R203

R202

R226

R582

R227

R581

JR202

R532

R531 R291R290

R287

R286

R285

R284

R228 R230

R231

R232

R233R234

R235

R236

R237

R283

R282

R240

R241

R281R280

R279

R278

R277

R276

R275

R274

R272

R271

R270

R269

R268

R267

R266

R265

R264

R263

R262

R261

R260

R259

R258 R257R256

R255

R254

R500

JR542

R383

R384

R391

Q523

Q524

R662

Q104

R135

Q103

C584

C583

D102

JR545

JR340

JR543

JR40

6

R499

R481

R482

R496

R329

R330

JR53

1

JR431

JR432

JR54

1

JR433

R322

JR102

JR22

2

R479

JR532

Q323

JR31

0

D412

D411

C414

JR515

JR51

3

R612R204

JR101

JR361

JR51

6

C413

C415

R321

R320

JR10

5

JR201

JR40

1

R478

NO40

1

NO603

NO402

NO503

JW50

2

JW50

3

JW50

4

JW50

5

JW50

6

JW50

8

JW50

9

JW51

0

JW51

1

JW51

2

JW513

JW514

JW515

JW51

7

JW518

JW51

9

JW52

0

JW52

2JW521

JW52

3

JW52

4

JW53

2

JW535

JW536

JW537

JW543JW

544

JW545

JW546JW547

JW548

JW549

JW55

1

JW554

JW555

JW556

JW558

JW560

JW562

JW579JW580

JW581

JW58

4

JW30

2

JW303

JW304

JW306

JW310

JW311 JW31

2

JW31

3

JW314

JW31

5

JW31

6

JW317

JW320

JW322

JW32

3

JW32

5

JW326

JW33

1

JW335 JW336

JW33

7

JW34

6

JW34

7

JW350

JW351

JW352

JW353

JW355

JW357

JW358

JW359

JW360

JW36

3

JW600

JW601

JW602

JW603

JW605

JW606

JW58

7

JW58

8

JW59

1

JW59

6

JW59

7 JW59

8

JW58

5

JW401

JW402

JW403

JW404

JW405

JW40

6

JW40

7

JW40

8

JW40

9

JW41

1

JW41

3

JW416

JW421

JW422

JW423

JW424

JW429

JW43

1

JW43

2

JW43

3

JW43

4

JW43

8

JW44

0

JW44

1

JW44

2

JW44

7

JW452

JW454

JW455

JW463

JW467

JW468

JW469

JW471

JW48

3

JW201JW203

JW204

JW210

JW21

6

JW220

JW228

JW229

JW230

JW231JW232

JW23

5

JW23

6

JW23

9

JW24

2

JW24

4

JW24

5

JW24

6

JW24

7

JW24

8

JW24

9

JW25

0

JW25

2

JW104

JW10

5

JW10

6

JW107

JW10

8

JW10

9

JW11

0

JW11

1

JW11

2

JW11

5

JW11

8

JW12

0

JW12

1

JW12

2

JW123

JW12

6

JW12

7

JW12

9

JW130

JW131

JW13

5

JW466

JW254

JW25

6

JW410

JW305

JW13

8

JW43

6

JW25

7

JW52

6

JW52

7

JW52

8

JW13

9

JW48

6JW

368

JW24

1

J203

C160

C110

JW400

JW539

JW541

JW55

7

JW22

4

NO523

C512

JW13

6

JW54

0

JW14

0

JW24

0

JW370

JW371

JW55

2

JW609

JW613

JW53

1

JW559

JW200

JW34

4

JW470

JW464

JW42

5

JW42

6

JW42

7

JW420

JW428

JW41

8

JW44

9

JW21

7

JW33

2

JW33

3

JW34

9

JW36

5

JW36

6

JW36

2

JW12

8

CN102

JW238

JW234

JW233

JW44

8

JW44

5

JW44

4

JW44

3

JW475

JW450

JW132

JW484

JW134

JW48

2

JW361

JW356

JW47

8

JW47

7

JW47

6

JW474

JW52

9

L101

L102

R598

R599

JW481

JW57

7

JW21

5

JW21

4

JW209

JW20

5

JW208

JW212

JW561

JW576

JW614

JW57

4

JW57

3

JW57

2

JW21

9

JW566

JW253

JW565

JW564

JW225

JW20

7

JW59

5

JW567

JW57

0

JW50

7

JW604

JW321

JW33

8

JW34

0

JW34

3

JW58

6 JW59

2

JW56

8 JW56

9

JW34

8

JW34

5

JW611

JW53

4

JW227

JW226

JW451

JW485

JW124JW459

JW575

JW563

JW615

JW52

5

JW34

1

JW44

6

JW13

7

JW38

0

JW38

2

JW383

JW384 JW385

JW386JW387

JW388

JW38

9

JW39

3

JW39

4

JW39

5

JW39

6

JW39

7

JW39

8

JW37

2

JW34

2

JW32

4

JW32

8

JW33

9JW

430

JW61

6

JW61

7

JW61

8

JW61

9

JW36

9

JW367

JW46

5

JW41

9

JW41

5

JW47

2

JW58

9

JW58

3

JW62

5

JW62

6

JW627

JW628

JW629

JW63

0

JW63

1

JW63

2

JW22

2

JW22

3

JW21

3

JW21

8

JW53

3

JW53

8

JW48

8

JW590

JW635

JW636

JW637

JW638

JW639

JW640

JW641

JW642

JW643

JW644

JW645

JW647

JW648

JW649

JW578

JW255

JW653

JW660

JW661

JW662

JW663

JW66

6

JW66

7

JW66

8

JW66

9

JW670

JW671

JW672

JW67

3

JW67

4

JW57

1

JW24

3

JW651

JW309

JW650

JW664JW610

JW680

JW68

1

JW68

2

JW683

JW685

JW686

JW687

JW688

JW689

JW690

JW69

1

JW69

2

JW694

JW69

6

JW69

7

JW69

8

JW593

J103

JW456

JW69

9

C416

C502

C503

CN402

C202

CN50

8

CN520

C234

C252

C352

D561

C357

C358

C374

D560

CN582

C501

C524

C511

C507

C365

C509

C517

C514

C516

C510

C519

C508

C523

C557C558

C562

C563

C566

C571C570

CN501

CN58

0

EPT560

IC558IC559

IC560

IC561

J202

C554

C506

C505

CN502

Q520

Q585

C306

C301

Q588

C309

C361

L372

L370

CN504

TM101

C370

L320

T301

C355

C553

IC507

C213

C356

C359

X402

C552

CN510

C328

C310

C311

C305

R307

L302

C303

C379

C354

C304

C378

C308

C353

C312

J201

C521

C226

C228

C164

C276

C222

C215

C267

C520

C114

C209

C259

C216

C207

C254

C253

C221

C277 C278C227

C258

C262

C251

C154

C266

C224

C265

C217

C269

C205

C257C255

C204C2

03

C201

C200

C225C163

C162

C161

C158

C157

C153

C155

C159

C504

C109

C150

C131

C111

C272

C113

C112C130

C105

C108 C107

C104

C103

C102

C101

C152

CN514

CN511

R480

C219C263

CN100

CN506

C462

C567

C525

C325

C166C167

C559

CN503

X401

C518

CN509

D585

D586

CN513

CN10

5

JW391

CN512

JW221

CN521

JW20

2

JW608

JW607

JW516

JW41

4

JW41

7

JW13

3

JW62

4

JW390

JW392

JW307 JW612

JW11

9

JW695

JW36

4

JW480

JW693

JW487

JW10

3

JW14

6

JW147

JW149

JW150

JW15

2

JW62

1

JW62

0

JW62

3

JW62

2

C431

JW330

JW14

5

JW684

CN505

JW461

JW462

C362

JW237JW

437

JW458

JW457

JW460

JW38

1

JW633

JW11

3

JW11

7

JW11

6

JW47

3

JW67

5

JW54

2

JW676

JW550

JW55

3

JW35

4

JW652

R579

C550

JW14

3

JW453

JW148

JW144

JW530

C106

JW100

JW14

1

JW14

2

C363

JW25

8

C116

C351

D510D511

1-868-862- 12

MAIN BOARD

14

85

EE

EE

E

E

E

E

E

1

1 8

3

E

EE

E

E

EE

E

E

E

E

E

E

E

113

E

E E E

E

E

E

E

E

E

E

E

E

E

E

EE

E

E

EE

E

E

E

E

EE

EE

E

E

E

1

3

E

B

C

1

4

1

3

1

3

1 8

E

E C B

E

E E

E

E

E E

EE E

E

E

E

E

1

3031

50

51

80 81

100

18

13

4 6

1 133

1 3

E

EE

1 1 104

1

8

1 4

1 4

1

3

13

54

11

1 6

1

42

21

22

1

1011

20

21

30 31

40

Q PA BOARDCN601 BDMB15 BOARD

CN401P PA BOARDCN600R TRANS BOARD

CN1213

ZX80D: E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY

M501(FAN)

M

D-LIGHTSYNC OUT

R

L

AUDIO OUT

R

L

TV/SATAUDIO IN

SYSTEMCONTROL

+

–SUBWOOFER

OUT

SUBWOFFEROUT

ABSURROUND

BOARDNO801

LSURROUND

BOARDCN701

(ZX100D)

(ZX100D)

(ZX80D)

TOSS-WGV100D

(ZX100D)

(ZX100D)

1

42

21

22

TUNER (FM/AM)SUPPLIED WITH THEASSEMBLED BLOCK

FM 75ΩCOAXIAL

ANTENNA

AM

D DMB15 BOARDCN302

H MIC BOARDNO1101K KARAOKE

BOARDNO2000

J PRIMARYBOARDCN1200

E VIDEOBOARDCN800

F DRIVER BOARDCN701A DMB15 BOARD

CN106 M EFFECTOR BOARDCN1502

1 9 1 5

(NC)

(NC)

1 3

GPANELBOARDCN902

NSURROUND

BOARDCN700

(EXCEPT ZX100D: SP, MY)

M502(FAN)

M

TAPEMECHANISMDECK BLOCKSUPPLIED WITHTHE ASSEMBLED

BLOCK

(ZX100D)

(ZX80D)


ZX80D: MX/ZX100D: MX

(FOR ADJUSTMENT)

1 3

4 6BIAS OSC

HRPE1(REC/PB/ERASE)

(DECK-B)

HP1(PB)

(DECK-A)

3

1

(CHASSIS)

1

5

E BC

1

2

3

4

5

A

B

C

D

E

F

G

H

I

J

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

K

L

1

4

(ZX80D)

(ZX80D)

(ZX100D)

7-23. PRINTED WIRING BOARD – MAIN Board – • See page 29 for Circuit Boards Location. • See page 44 for Semiconductor Location. : Uses unleaded solder.

(Page58)

(Page55)

(Page 64) (Page 52) (Page 52)(Page 30)

(Page 30) (Page 36)

(Page 44)(Page 65)

(Page 40) (Page 38)

(Page 30) (Page 42)

(Page 55)

(Page55)

Note: Refer to SUPPLEMENT-1 for the MAIN board of US model.

Ver. 1.1

4646

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-24. SCHEMATIC DIAGRAM – MAIN Board (1/6) – • See page 54 for Waveforms. • See page 71 for IC Pin Function Description.

Q523

R4

51

R4

53

R4

54

R4

57

R4

58

R4

63

R4

69

R4

70

R4

72

R4

73

R4

74

R4

75

R483

R488

R489

R490

R491

R494

R496

R499

R3

22

R4

00

R4

01

R4

02

R4

05

R4

06

R4

07

R4

08

R4

09

R4

11

R4

14

R4

15

R4

17

R4

18

R4

19

R4

20

R4

21

R4

22

R4

23

R4

24

R4

25

R4

26

R4

27

R4

28

R4

29

R431

R432

R433

R434

R435

R436

R4

37

R438

R439

R440

R441

R442

R443

R444

R445

R447

R448

R4

30

R413

R4

10

X402

C415

C416

X4

01

C411 C410

C412

R412

R4

03

R4

04

CN508

C462 C464

R479 R478

R487

R486

R485

R484

R593

D411

D412

C413

CN402

NO402

CN511

D503

R503 C503

C502

D502

R502 R501

D501

D504

Q524

D505

CN520

C518

R493

R4

66

R4

71

CN100

NO401R574

D401

R573

R468

D402 D403

C414

IC501

R467

R589

Q589

Q587

C583

C584

Q588

R594

R595

R590

CN582

M502

R492

R592

Q501

IC401

R4

50

JR222

C501

JW100

D584

DTA114EKA

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

100

100

100

100

100

100

100

100

47

k

10

k

10

0

10

0

10

0

10

0

10

0

10

0

10

0

33

0k

10

0

10

0

10

k

10

0

10

0

1k

10

0

10

0

10

0

10

0

10

0

10

01

0k

10

k1

00

100

100

100

100

100

10k

10

k

100

100

100

100

100

100

100

100

100

100

10

0

0

10

k

5MHz

0.1

22006.3V

32.7

68K

Hz

22p 22p

0.1

100k

10

k

10

k

17P

10010V 0.01

10k 1k

10k

100

100

10k

1SS355W

1SS355W

0.1

10P

4P

13P

1SS355W

0 0.1

0.1

1SS355W

1k 220

1SS355W

1SS355W

DTC124EKA

1SS355W

13P

100010V

10

k

10

k

9P

3P10k

1SS355W

10k

100

1SS355W 1SS355W

0.1

ICBD4929G

100

1k

2SC2712

2SC2712

0.1

0.1

2SD2525

4.7k

4.7k

100k

3P4.7k

DTC124EKA

M30622MEP-A78FPU0

10

0

0

1050V

UDZS-1713B

A1

A2

A3

A4

A5

A6

A7

A8

A9

B1

B2

C1

D3

D1

D2

D4C2

D5

D6

D7

C3

D8

D9

E1

E2

E3

E4

4

31

32

33

73

74

74

79

80

81

82

53

54

55

73

47

56

34

38

39

89

90

91

66

12356

35

36

37

48

49

50

52

58

60

61

65

67

72

71

75

78

77

76

83

42

70

63

57

45

44

43

19

18

46

51

32

33

34

31

34

35

36

37

38

39

25

24

23

22

21

32

31

22

21

33

32

31

23

24

25

100

95

94

30

29

9

12

26

27

28

26

27

28

29

30

9

12

12

33

40

41

40

4

41

∗

∗

∗

GC RESET

LED+9V

BPM LOW

VG

SPEANA GND

MIC DETECT

MIC SCORE

SPEANA

SIRCS

KEY INT DISPLAY

POWER LED

VF(1)

IIC-DATA

IIC-CLK

KEY INT POWER

VF(2)

GC DGND

EVER +4V

GC DGND

TBL ADDRESS SW

MGND

D+3.3V

M+9V

TM-R

TM-F

E-1

E-2

E-3

OPEN SW

D-GND

TXD1

RTS1

MCU VCC

CLK1

RXD1

CN VSS

RESET

GND

NC

D+3.3V

D-GND

IIC-CLK

IIC-DATA

RES

ET

X-O

UT

VS

S

X-I

N

VC

C

NM

I

IIC

-CL

K

IIC

-DA

TA

MODEL-IN

AVSS

VREF

AVCC

XC

-IN

XC

-OU

T

SIR

CS

DIS

PLA

Y-K

EY

PO

WER

-KEY

DEST-IN

AC

-CU

T

BY

TE

VC

C

VS

S

DATA

CLK

OCSW1

SYSRST

3.3VMNT

XIFCS

IFBSY

SIO

SOO

SCO

DGND

MIC

VOICE

KRMOD

TU

NE

D

ST

-CL

K

ST

-CE

TB

L S

EN

S

TM-F

TM-R

LM-F

LM-R

A-HALF

A-TRIG

B-TRIG

RE

C B

IAS

RE

C M

UT

E

PB

A/B

AL

C

OV

ER

VO

LT

AG

E

UN

DE

R V

OL

TA

GE

DA

TA

CAPM

M-REQ

MGND

SW-LEVEL-IN

THERMAL VACS

AUDIO-OUT-SW

VIDEO-OUT-SW

MTK

-PO

WER

EFFE

CT

OR

-CT

R3

EFFE

CT

OR

-CT

R2

EFFE

CT

OR

-CT

R1

EFFECTOR-S3

EFFECTOR-S2

EFFECTOR-S1

EFFE

CT

OR

-S0

FAN CONTROL

FA

N H

I S

PEED

FAN+

FAN-

MIC

ST

AT

US

EJEC

T S

WE3

E2

E1

NO USE

SW

-MU

TE

ANALOG-IN-MUTEM

TK

-KM

OD

EVER+4V

D-GND

STBY RLY

(1/6)

SIO

CN

VS

S

SW-LED

SW

-SP

KR

EL

AY

CLK

Q587,589

FAN MOTOR CONTROL SWITCH

FAN MOTOR

SWITCH

(FAN)

∗R593

150(ZX80D:E13)

(EXCEPT ZX100D:SP,MY) ∗R592

680(ZX80D)

1k(ZX100D)

ZX80D:E2,E51,MX/

ZX100D:E2,E51,MX

1k

4.7k

∗R493

0(ZX100D:SP,MY)

330(ZX80D:E3/ZX100D:E3)

4.7kZX80D:E2,E13,E51,MX/

ZX100D:E2,E51,MX

Q523,524

B+ SWITCH

RESET SIGNAL

GENERATOR

RESET SWITCH

MASTER CONTROLLER

H/P DETECT

A+9V

MIC ECHO

MIC AGND

VIDEO(A)-R

VIDEO(A)-GND

VIDEO(A)-L

(ZX80D:E3/ZX100D:E3)

LM-F

LM-R

(NC)

(NC)

MTK-

MTK-

MTK-SOD

CLK

GC-RESET

STBY-LED

TC

-RE

LA

Y

NO

US

E

ST

K-M

UT

E

RE

AR

-RE

LA

Y

CT

R-R

EL

AY

PR

OT

EC

T

TC

-MU

TE

HP

-MU

TE

LIN

E-M

UT

E

DV

D-A

-MU

TE

AU

DIO

-IC

-

AUDIO-IC-

VOL-IC-

VOL-IC-

HP-DETECT

MIC-DETECT

VMUTE

A-SHUT

B-SHUT

B-HALF

NO USE

ST

-DO

UT

ST

-DIN

ST

BY

-RE

LA

Y

EFFE

CT

OR

-SE

LE

CT

MTK

-IFB

SY

MT

K-X

IFC

S

FR

-RE

LA

Y

MTK

-RES

ET

(Page 32)

(Page 37)

(Page 59)

(Page 50)

(Page 49)

(Page 51)

(Page 48)

(Page 41)

(Page 47)

(Page 50)

(Page 66)


Ver. 1.1

4747

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-25. SCHEMATIC DIAGRAM – MAIN Board (2/6) –

R105

C121

C122

NO503

IC101

R121

R104

C103

C102

C150

C101

C105

R107

R150

C104

R116

C106

C111

C157

C109

C108

R152

R151

C130 R131

R106 R156

CN505

Q151

R122

R130

C131R132

C115

R111

Q156

Q106

R108

R158

R159R160

CN510

R360 R384

C358 R361 R383

R133

R110

R161

R109

C161

C158

C159

C156

R157

R166C155

R154 C154

C153

C152

C160

C357

Q101

R101

C107

R102

C431

C110

R155

C162

C163R153

C116

C112

C113

R103

47k

220p

220p

5P

M61529FP-60G

1k

1k

10 50V

10 50V

10 50V

100 10V

10 50V

100

2.2k

10 50V

100

0.022

1050V

0.022

150V 0.033

10k

2.2k

1050V 2.2k

10k 10k

6P

2SC2712

1k

2.2k

0.4750V1M

0.1

10k

2SD2114

2SD2114

6.8k

6.8k

3.3k10k

3P

27k 4.7k

4.750V

27k 4.7k

100k

10k

10k

3.3k

10 50V

0.033

1 50V

0.022

100

10010 50V

1k 10 50V

10 50V

10 50V

0.01

4.750V

2SC2712

2.2k

0.022

10k

1050V

0.01

47k

0.12

0.331k

33010V

0.12

0.33

1k

A1

A2

A3

A4

A5

A6

A7

A8

A9

F2

F3

F4

F5

F6

F7

F8

F9

G4

G3

G1

G2

G5

F10

G6

F11

H2

H1

H3

N1

FL

FR

SAT-R

DOWNMIX-R

79

R-OUT

80

L-OUT

LINK-L

REC-OUT-L

SAT-L

DOWNMIX-L

LINK-R

REC-OUT-R

XVOICE

SCORE

+9V

V MUTE

VIDEO OUT SW

+5V

A+9V

MUSIC L+R

SCORE

XVOICE

NC

MIC SCORE

L

GND

R

SUR1

SUR2

RECB2

TMI2

TMO2

TCA2

TCB2

TCC2

TOUT2

VOLIN2

BB_A2

BB_B2

OUT2

SWOUT

GND

CLOCK

REF

MIC

RECB1

TMI1

TMO1

TCA1

TCB1

TCC1

TOUT1

VOLIN1

BB_A1

BB_B1

OUT1

SAOUT

VCC

DATA

TC-L TC-R

SAT-RSAT-L

DVD-L DVD-R

ST-RST-L

VIDEO-L VIDEO-R

AGND

(2/6)

INPUT SELECT SWITCH,TONE CONTROL,

FEED BACK

SWITCH

MUTING

MUTING

FEED BACK

SWITCH

ELECTRICAL VOLUME,BASS BOOST AMP

ADJUSTMENT

FOR

(Page 46)

(Page 39)

(Page 49)

(Page 51)

(Page 48)

(Page 44)

(Page 48)

(Page 48)

(Page 50)

(Page 50)


Ver. 1.1

4848

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D


C223

C200

C214

R209

R210

C211

R258

C256

C257

R208

C206

C207

R207

C212

C205

C255

R225

R275

C210

R257

R211

C216

C259

R276

C209

R226

C263

R256

R206

C213

R263

R272

R254

R213

R231

R232

R230

Q203

R292

R283

R285

Q254

R284

R233 Q204

R234

R235

C228

R298

R299

C201

C264

R259C261

R260R261C266

R214

C218R217

R264

C268

R216

R282

R281

Q253

R227

Q202

R229

R280

R202

C277

R228

R203

C226

R265

R267R266C269

C219

C270

C220 R215

C215

R212

C265

R262

R277

R278C276

R242

Q252

R279

R204

C222R220

R218

R219C224

C242R270

Q200

R268

R249

C221

R269

C262R221

Q250

R222C251

R273

R271

C225

C273

R224

R223

C272

C260

CN514

D101

D102

R120 D325

R325

Q323

R329

R330

D586

R135

D136

R117C114

R114

R115

R112

R164

R165

R162

Q117

Q167

R163

R113

C166

C258

R623

R274

C274

R167 C164 C167

D585

C229

C279

R241

R291

R240

R290

CN506

R531

Q103

C267

JW530

CN512

C520

C521

FB260

FB261

C235

J201

R581

JR502

JR509

IC201

R237

R287

Q255

Q205

Q104

C217

JR104

JW258

C227

R582R532

CN521

C559

R612

R662

J103

C278

C254

C253

R236

R255

C204

C203

R286

R205

R200

0.001

0.1

220p

10k

470

220p

2.2k

0.0022

10 50V

2.2k

0.0022

10 50V

2.2k

0.001

100 10V

100 10V

10k

10k

0.001

2.2k

47k

10 50V

10 50V

22k

10 50V

22k

10 50V

47k

47k

10 50V

6.8k

3.3k

3.3k

6.8k

47k

10k

1k

2SD2114

10k

47k

10k

2SD2114

1k

47k 2SD2114

1k

10k

1 50V

10k

10k

0.1

220p

10k220p

47047k10

50V

47k

0.00110k

47k

0.001

2.2k

10k

47k

2SD2114

47k

2SD2114

10k

1k

10k

1 50V

1k

10k

1 50V

4.7k

10k2.2k10 50V

10 50V

0.001

0.001 4.7k

10 50V

8.2k

10 50V

8.2k

47k

1k1

50V

10k

2SD2114

10k

10k

1050V10k

4.7k

2.2k10 50V

0.00147k

2SD2114

1k

10k

1 50V

10k

10 50V47k

2SD2114

1k1 50V

10k

10k

150V

220p

1k

8.2k

22010V

0.1

8P

1SS355W

1SS355W

0 UDZSTE-174.7B

680

2SC5053

100k

1k

10EDB40

1.5k

UDZSTE-175.6B

01050V

10k

1k

47k

10k

1k

47k

2SD2114

2SD2114

10k

10k

10 50V

10 50V 6.8k

1k

220p

0 1050V 10 50V

10EDB40

220p

220p

33k

33k

15k

15k

9P

2SC5053

1050V

19P

1050V

1050V 0

0

100p

2P

0

0

M61530

47k

47k

2SC2412K

2SC2412K

DTC114EKA

1050V

0

150V

3.3k3.3k

21P

100010V

0

0

5P

1 50V

0.33

0.12

1k

0.33

0.12

1k

10k

B1

B2

F2

F3

F4

F5

F6

F7

F8

F9

F10

F11

I1

I2

I3

I4

J2

J3

FL

FR

70

63

45

44

43

19

18

57

SAT-L

SAT-R

1

2

3

5

6

MB_FL

LINK-L

DM_R

DM_L

81

82

LINK-R

SW

SW

SCORE

XVOICE

MB_FL

MB_FR

MB_SL

MB_SR

FC

LFE

DM_L

DM_R

LFE

FC

MB_SR

MB_SL

MB_FR

DOWNMIX-L

DOWNMIX-R

∗

∗

∗

∗

ST-CLK

ST-CE

ST-L

A-GND

ST-R

ST-DOUT/MC-DIN

ST-DIN /MC-DOUT

ST+9V

DGND

AGND

FC

SR

SL

AGND

FR

AGND

FL

AU+5V

AGND

L-IN

AGND

R-IN

AGND

SW(LFE)

AGND

AGND

CTR-IN

AGND

AGND

+9V

TUNED

LT

RT

SL-IN

SR-IN INPUT R

INPUT L

S0

S1

S2

OUTPUT R

OUTPUT L

AGND

AGND

AGND

AGND

SELECTOR

AGND

DGND

S3

IIC CLK

IIC DATA

DGND

D+4V

CTRL2

CTRL3

CTRL1

SCORE

XVOICE

L+R(SPEANA)

(3/6)

MUTING

MUTING

MUTING

AM

ANTENNA

COAXIALFM 75Ω

SUPPLIED WITH

THE ASSEMBLED

BLOCK

∗R531,581

6.8k

ZX80D:E3,E13,E51,MX/

ZX100D:E3,E51,MX,SP,MY

4.7k

(ZX80D:E2:ZX100D:E2)

ELECTRICAL VOLUME

FEED BACK

SWITCH

SWITCH

FEED BACK

MUTING

MUTING

+5V REGULATOR

REGULATOR CONTROL

SWITCH+4V REGULATOR

MUTING

MUTING

MUTING

MUTING

MUTING

TUNER (FM/AM)

A+9V

L

R

TV/SAT

AUDIO IN

D-LIGHT

SYNC OUT

L+R

∗R236,286

10k(ZX100D)

22k(ZX80D)

(Page47)

(Page 51)

(Page 50)

(Page 50)

(Page57)

(Page47)

(Page 35)

(Page 47)

(Page 46)

(Page 43)

(Page 51)


Ver. 1.1

4949

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-27. SCHEMATIC DIAGRAM – MAIN Board (4/6) – • See page 54 for Waveforms.

L320

Q380

T301

IC301

R308

R310

R311

R370

R374

R392

C378

C301

C303

C304

R303R319R302 R304

C306

R305

C311

C314

R306

R307

C307

R312

C308

C312

L302100µH

R309

C309

C359

R396

R399

Q377

Q379

Q322

Q321

Q372

Q373

R314

R338

C333C328

R364

R388

R380

C383

L370

L372

R395

R394

Q378

R376

R375

C373

R373

R372

C372

R371

C379

C377

R377

C374

C371

C370

R378

CN503

R352

R355R354

R369 R353 C356

C354

C353

C351 R391C361

C364

C355

R335

C305

C310

C382

C332

Q382

Q383

Q381

R390

C335

C385

C376

R379

CN504

HP1

HRPE1

C326

Q325

Q375

R368

R318

R336

R337

R387

R385

Q370

R386

R339

R301

R389

R351

27mH

DTC114EKA

HA12237 100

100

100

3.3k

4.7k

6.8k

120p

0.012

0.1

1050V

10k2.2k4.7k 2.2k

2.250V

47k

1050V

0.0022

22k

1M

1050V

100

47010V

10 50V 4.7k

47 16V

47 16V

10k

10k

2SA1162

DTC114EKA

2SD2704

2SD2704

2SD2704

2SD2704

2.2k

10k

330p120p

2.2k

10k

6.8k

330p

27mH

47k

4.7k

RT1P137P-TP-1

4.7k

0

0.001

4.7k

0

0.001

4.7k

0.0068

0.01

47

47 10V

0.0047

0.01100V

10k

8P

4.7k

47k2.2k

2.2k 10k 2.2 50V

10 50V

0.1

0.012 1k1050V

0.0022

150V

1k

150V

10 50V

1200p

1200p

DTA114EKA

DTC114EKA

DTC114EKA

10k

0.022

0.022

680p

10

3P

680p

2SD2704

2SD2704

2.2k

2.2k

2.2k

2.2k

2.2k

2.2k

2SD596

33

15k

1.5k

15k

1.5k

C1

C2

C3

K1

K2

L1

L2

H1

H2

H3

52

53

56

54

55

REC-OUT-R

REC-OUT-L

REC-OUT-L

REC-OUT-R

L-PB

L-REC

R-PB

E-HOT

R-REC

GND

GND

GND

L-PB

R-PB

GND

RE

C-O

UT

1

NC

AL

C1

RE

C-I

N1

NC

PB

-OU

T1

TA

I1

EQ

OU

T1

PB

-E

Q1

PB

-NF1

B

PB-NF1A

AIN1

RIP

BIN1

REC-RETN

GND

BIN2

NC

AIN2

PB-NF2A

PB

-EQ

2

EO

UT

2

TA

I2

PB

-OU

T2

NC

RE

C-I

N2

AL

C2

NC

RE

C-O

UT

2

PB

-NF2

B

ALC ON/OFF

MUTE ON/OFF

REC MUTE ON/OFF

I-REF

TEST

ALC DET

GND

VCC

A/B

NORMAL SPEEDHIGH/

(4/6)

Q382,383

MUTING CONTROL SWITCH

MUTING

MUTING


Q377,379,381

MUTING

MUTING

MUTING

MUTING

REC/PB EQ AMP

Q378,380

REC BIAS SWITCH

BIAS OSC

BIAS OSC

L-CH

R-CH

(PB)

(DECK-A)

R-CH

L-CH

ERASE

(DECK-B)

(REC/PB/ERASE)

DECK A/B SELECT SWITCH,

1

3

4

6

100µH

(Page 47)

(Page 50)

(Page 46)

(Page 51)


Ver. 1.1

5050

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D


R575

R513

R317

R320

R381

R300

R365

R350

R316

R315

R382

R366

C511

R518

Q519Q511

Q512

R533 R534

R519

Q515R517

Q509

Q510

R516

R515

C510

C517R552 R553

Q516

R514

Q508

Q507

CN501R512

C507

C508R511

Q522

Q521

R529

R530

Q506

Q505

R510

C524

C523

R508C506 C505

R509

C365R522

D506 R535

R536D507

R537

C341

Q344

R341 R345 R349

R346Q341

D341

R525

R526

R576

R527

R577

R528

Q514

C554

C504

C550

D550

C553

CN502

R358

R356

C352

R321C363

C362

R359

C325

C551

CN509

D340

Q517

Q343 Q345

D342

C509

C552

C360

Q564

R578

Q340 Q342

R347R343

R344 R348

R342

C525

R554

R540R521

R520

JR513

JR515

Q504

CN513

R538

C512

IC550

IC304(2/2)

R357

IC304(1/2)

R340C340

10k

15k

22k

33k

4.7k

4.7k

3.3k

4.7k

47k

3.3k

47k

10k

2.250V

10k

DTA124EKADTA124EKA

DTC114EKA

10k 10k

1k

DTC143TKA47k

DTA124EKA

DTC114EKA

15k

68k

2.250V

2.250V

68k 470k

DTA124EKA

470k

DTC114EKA

DTA124EKA

13P68k

2.2 50V

2.2 50V470k

DTA124EKA

DTC114EKA

15k

68k

DTC114EKA

DTA124EKA

8.2k

2.250V

2.250V

470k

JR5160

2.250V

2.250V

68k

150V 4.7k

1SS355W 10k

10k1SS355W

470k

0.0047

DTC114EKA

3.3k 3.3k 3.3k

6802SB1132

1SS355W

D5101SS355W

D5111SS355W

10k

1k

1k

47k

47k

10k

2SD2114

1050V

1050V

10016V

1SS355W

22025V

8P

33k

4.7k

4716V

33k4.7 50V

4.7 50V

33k

1050V

0.1

11P

1SS355W

DTC114EKA

DTC114EKA DTC114EKA

1SS355W

2.250V

2.250V

33p

2SD2114

10k

2SB1132 2SB1132

2.2k2.2k

680 680

2.2k

100010V

15k

10k0

10k

0

0

DTC143TKA

13P

5.6k

10 6.3V

RT8H015C-TH12-1

NJM4565M(TE2)

4.7k

NJM4565M(TE2)

2.2k0.0047

D1

D2

D3

D4

D5

D6

D7

D8

D9

G1

G2

G3

G4

G5

G6

I1

I2

I3

I4

K1

K2

M1

M2

M3

M4

M7

M8

M10

M11

M12

M5

M9

M6

R-OUT

L-OUT

48

50

49

89

47

90

91

46

75

60

76

77

83

65

51

60

61

DOWNMIX-L

94

60

72

DOWNMIX-R

67

66

71

FAN DET

POWER-GND

POWER-GND

UNREG

A+9V

DGND

LINK RELAY

AC CUT DETECT

FRONT RELAY

L-IN

R-IN

PREGND

DC DETECT

OVERLOAD DETECT

THERMAL VACS

STK MUTE

-VL

-VL

TCM MGND

B SHUT

CAPM+

BTRGM+

ATRGM+

REC(FWD)

A SHUT

BHALF

AHALF

TC DGND

REC(REV)

SW A-GND

SW LINE MUTE

SW SPK RY

STK MUTE

UNREG

UNREG

OVELOAD

DC DETECT

DVD LINE MUTE

CENTER RELAY

REAR RELAY

(5/6)

OVER CURRENT PROTECTOR

SPEANA AMP

BUFFER

MUTING

MUTING

Q342,345Q340,343

TRIGGER PLUNGER

DRIVE(DECK-A)

TRIGGER PLUNGER

DRIVE(DECK-B)

Q341,344

CAPSTAN/REEL

MOTOR DRIVE

Q521,522

MUTING CONTROL SWITCHMUTING CONTROL SWITCH

Q505,506


Q507,508


Q512,515,519

Q509,510

MUTING CONTROL

SWITCHMUTING

CONTROL

SWITCH

SWITCH

Q516,517

MUTING CONTROL

ZX80D:E2,E3,E13,E51/

ZX100D:E2,E3,E51,SP,MY

ZX80D:MX/

ZX100D:MX

(ZX100D)

(ZX80D)

H/P MUTE

FR RELAY PROTECT

DBFB F/B

CENTER-SPK-SWITCH

SW

SUPPLIED WITH

BLOCK

THE ASSEMBLED

DECK BLOCK

TAPE MECHANISM

(2/2)

(1/2)

AC CUT DETECT

(ZX80D)

(ZX100D)

(Page 51)

(Page 49)

(Page 46)

(Page 57)

(Page 53)

(Page 48)

(Page 47)

(Page 46)

(Page 53)

(Page 48)

(Page 51)

(Page 47)


Ver. 1.1

5151

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D


IC559

IC558

Q520

R243

R244

R294

CN580C581

C580

D581Q581

R586

D582

R585

R584Q585

Q513

R539 R523 R506 R500

R505

C567

C570

C571

C568C516

C569

Q503

Q518

R524

C515 C513

R507

C557

C558

C564C563

C565C562

R295

R245

Q256

Q206

R296

R246

R247

R297

R289

R239

C202R238

R288

NO523

NO603

C566

C514

EPT560

C530FB254R293

FB204

C252

C233

R248

Q208

R602

R250

Q207

R252

C234 R251 R601

R253

JR219

JR218

CN105

R598R599 L101L102

R482

R481

R480

IC507

JW550

M501

JW219

C519

D561

R579

Q582 Q579

Q578

D560

R549

Q550

R551

J203

CN102

JR514

J202

TM101

D583

IC561

IC560

D551

TA78033LS

TA7805LS

2SB1565F

1k

100k

100k

3P0.1

0.1

UDZSTE-176.8B2SC2712

1k

UDZSTE-176.2B

1k

10k2SD2525

DTC114EKA

4.7k 4.7k 4.7k 4.7k

2.7k

680025V

0.01

0.01

0.1220010V

0.1

DTC114EKA

DTC114EKA

10k

0.1 0.1

10k

0.01

0.01

0.147016V

0.147016V

10k

10k

2SD2114

2SD2114

47k

47k

1k

1k

10k

10k

1050V0

0

5P

8P

1000025V

220016V

100p01k

0

1050V

100p

100k

2SD2704K

10k

33k

2SD2114KT

10k

10 50V 2.2k 1k

10k

0

0

3P

1010

100

100

1

PQ09RD21

220010V

D5SBA20

3302W

2SC2712 2SC2712

DTC114EKA

D5SBA20

1.8k

DTC143TKA

56k

1P

4P

0

2P

HZU2.0BTRF

BA09T

BA09T

1SS355WTE-17

E1

E2

E3

E4

J2

J3

L1

L2

M1

M2

M3

M4

M5

M6

M7

M8

M9

M10

M11

M12

N1

42

58

78

95

100

DGND

VF

VF

AC3

AC3

AC4

AC4

FAN+

FAN-

MGND

DGND

SW+

SW-

SW-

SW+

GND

DGND

+9V

SW-LED

SW VOL

(6/6)

(CHASSIS)

MUTING

MUTING

MUTINGMUTING

(ZX80D)

(ZX100D)

Q503,518

CONTROL

SWITCH

+9V REGULATOR+9V REGULATOR

+9V REGULATOR

G IO

IO G

(FAN)

(ZX100D)

Q513,520

B+ SWITCH

O IG

O IG

+5V REGULATOR

+3.3V REGULATOR

1

2

3

4

FAN MOTOR SWITCH

Q581,582

FAN MOTOR SPEED


CONTROL SWITCH

FAN MOTOR CONTROL

SWITCH

1

2

4

3

ZX80D:E2,E3,D13,E51/


L

R

OUT

SUBWOOFER

OUT

SUBWOOFER

TO

SS-WGV100D

SYSTEM

CONTROL

VP

SW+5V

SW+3.3V

SW+9V

AUDIO OUT

REGULATOR

OVER VOLTAGE

DETECT

(Page 47)

(Page 49)

(Page 48)

(Page 48)

(Page 66)

(Page 50)

(Page 33)

(Page 50)

(Page 46)

(Page 56)


Ver. 1.1

5252

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-30. PRINTED WIRING BOARD – PA Board – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

D609 A-9D611 F-10D612 F-10D620 B-10D624 F-13D646 C-14D654 B-13D655 B-14D656 F-5D658 F-7D660 G-2D661 G-2D670 B-10

IC600 F-11

Q604 B-9Q606 B-9Q610 B-9Q618 B-10Q628 F-13Q630 F-13Q634 B-8Q640 B-8Q641 C-7Q644 I-2Q647 H-2Q648 F-2Q668 B-11Q682 A-8


Ref. No. Location

C603C653

JR603

R694

D611

R611

R610

R620

C654C604D612

R603R653

R602

R652

C601C651R601 R651

R600 R650

R617

R695

R696

R625R624

R674

C606

R628 R629

R630

R631

Q628Q630

C605

C683

C693

C682

C681

C691

C692

R676

R656

R657

R658

R660

R661

R677

R678

C660

D620

R621

D646

R609

R698

R608

R693

R606

R692

R607

Q634

R604R605

Q610

R642

R662

R640R635

R641

Q682

R643

R663

R639

R638

R697

R634

Q641

Q640

R683

R619

Q604

Q618

D609

R682

Q644

D661

D660

R649

Q648

R685

Q647

R645

R644

R648

R673

R623

R671

Q668

R669

R670

D670

D655D654

R655

R654

R633

JR602

JR601

JR600

R647

D624

JR612

L680

L690

JW62

6

R690

R680

JW62

7

JW60

0

JW60

2

JW604

JW605

JW606

JW608

JW61

4

JW617

JW618

JW619

JW620

JW62

1

JW62

2JW62

3

JW62

8

JW62

9

JW63

0

JW63

3

JW63

4

JW63

5

JW638

JW63

9

JW64

5

JW64

6

JW64

9

JW616

JW607

JW61

3

JW603

JW63

1

JW688

JW69

2

JW693

JW69

4

JW69

5

JW65

0

JW64

7

JW64

8

JW69

6

JW687

JW63

2

JW636

JW62

4

JW62

5

R668

RY646

EP690

CN601

TM600

R618

JWH603

JWH602

C602

C600

C650

C652

TH629

C617

C666R672

R622

C609

D658D656

C619

C610

C635C634

C636

C608

C655

R613

R614

R612

R615

R616

R691

R681

R665

JWH601

Q606

C667

C637C616

JWH600

TH630

R646

NO601JW

601

NO600

JW63

7JW

640

JW64

1

JW64

2

JW64

3

JW64

4

JW65

1

JW65

2

JW65

3

JW65

4

JW65

5

JW65

6

JW65

7

JW658

JW659

JW664

JW665

JW668

JW678

JW679

JW69

8

JW69

9JW70

0

JW667

JW669

JW682

JW683

JW67

4

JW67

5

JW670

JW671 JW672

JW673

JW68

0

JW68

4

NO604

C676

C656

C678

C658

CN600

CN60

7

C618

C648

C649

R636

R637

JW66

0

JW662

JW663

JW1285

JW1283

JW12

82JW

1284

CN60

2

EP660

IC600

E

E

E

E

E

E

E

E

E

E E

EE

E

1-864-930-

11

(22, 23)

PA BOARD

R

L

FRONT SPEAKER

+

–

+

–

(CHASSIS)(CHASSIS)

Q MAIN BOARDCN502P MAIN BOARD

CN501 U MIC BOARDCN1102

1 41 4

(ZX100D)

9

1

1

5

(ZX100D)

(ZX100D)

(ZX80D)

(ZX80D)

2

1 7

1

XSURROUND

BOARDNO800

WSURROUND

BOARDNO700

VTRANS BOARD

CN1212

S TRANS BOARDCN1215

A

B

C

D

E

F

G

H

I

J

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

1

3

-1-2

(ZX100D)

(Page55)

(Page55)

(Page 64)(Page 64)

(Page 45) (Page 40) (Page 45)

Ver. 1.1

5353

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-31. SCHEMATIC DIAGRAM – PA Board –

TH629

C600 C650

R655

R640

R645

R610

R616

NO604

NO600

C660

R658

R676 R677

R656 R657C656

R607

Q606

R692

R606Q604

R605

R604

R693

R608

R698 D609 R694

R609 C608R611

R612

R6

03

R619

R6

17

R6

95

R6

96

R6

53

C606

R630

D620

R669 D670

C601

R601

R600

C651

R651

R650

R682

R683

Q634

R697

R638 R639

R673

R623

R635

R641

R642 R662

R643R663

Q641

D655 D654

R654

R685

C648

C649R649

C693

R624

D624

NO601

R634C634

C635

CN600

CN601

C683

EP660

EP690

C667

R672R622

R615 TM600

Q630

R631

C655

R628

R629

R691C691 C692

L690

L680

R681 C681 C682

R690

R680

C605

R647

R660

D660

R661

D661

R646

Q644

Q628

RY646

R648

Q648

R644

D646

R633

JR612

TH630

Q647

IC600

C652

C654C604

C6

53

C6

03

R618 R668

C602

C617

C616 C666

R620

R670

C636

R636

C637

R637

Q668

R671R621

Q618

Q640

Q682

R613 R614

D656

D658

C676

C658

R678 C678

JW1285

JW1283

JW1

28

2

JW1

28

4

CN602

CN607

Q610

R6

02

R652C609

C618

C610

C619

D6

11

D6

12

R625

R674

4.750V

4.750V

47k

1k

10k

68k

1

2P

7P

0.1

100k

220k 220k

220k 220k3300100V

2.2k

2SA1207AA

47k

47k2SC3906K

T146E

10k

10k

100k

100k

100k MA111-TX 68k

68k 2250V 33k

100

47

k

1k

10

0k

10

0k

10

0k

47

k

0.1

100k

MA111-TX

1k MA111-TX

0.0022

47k

1k

0.0022

47k

1k

1k

4.7k

DTA124EKA

2.2k

100k 100k

56k

68k

10k

1k

150 150

150150

2SD2114KT146TB-E

MA111-TX MA111-TX

47k

10k

10010V

1050V 22k

0.1

22k

MA111-TX

3P

2.2k10025V

10025V

13P

8P

0.1

0.068

101/2W

101/2W

100

2SC2712-YG-TE85L

100k

1050V

22k

5.6k

101/2W 100000p 100000p

101/2W

100000p 100000p

101/2W

101/2W

0.1

1k

4.7k

MA111-TX

4.7k

MA111-TX

1001/2W

2SC2712-YG-TE85L

2SC2712-YG-TE85L

22k

2SC2712-YG-TE85L

2.2k

MA111-TX

0

0

2SC2712-YG-TE85L

22010V

100p100p

10

p

10

p

0.225W

0.225W

22010V

0.068

0.068 0.068

18k

18k

4.7100V

8202W

4.7100V

8202W

2SC3906KT146E

150k150k

2SC3906KT146E

2SD2114KT146TB-E

2SC2712-YG-TE85L

1k1W

1k1W

D25XB60

3300100V

470050V

100k 470050V

9P

5P

2SC3906KT146E

39

0

39010100V

22100V

10100V

22100V

MM

3Z18V

ST1

MM

3Z18V

ST1

22k

L-IN

L-I

N R-IN

R-I

N

DC-DETDC

-DET

OVERLOAD DET

OV

ER

LO

AD

DE

T

THERMAL VACS

TH

ER

MA

L V

AC

S

STK MUTE

ST

K M

UT

E H/P MUTE

H/P

MU

TE

FRONT RELAY

AC CUT DETECT

AC

CU

T D

ET

EC

T AC CUT DETECT

FAN DET

FA

N D

ET

FA

N D

ET

FR RELAY PROTECT

FR RELAY PROTECT

DBFB F/B

DB

FB

F/B

FR

ON

T R

EL

AY

∗+VH

+VL

-VL

-VH

SW RC GND

AC CUT DETECT

-VL

+VL

GND

GND

UNREG

FAN DET

A+9V

DBFB F/B

FR RELAY PROTECT

AC CUT DETECT

LINK RELAY

STK MUTE

L-IN

R-IN

FRONT RELAY

H/P MUTE

THERMAL VACS

HP-R

HP-L

-VL

-VL

SURR POWER GND

HP-GND

GND

REAR L GND

REAR R GND

CENTER GND

AC1

AC1

AC2

AC2

(CHASSIS)

(CHASSIS)

FRONT SPEAKER

Q628,630

THERMAL DETECT

-1

-2

RELAY DRIVE

PROTECT SWITCH

OVER LOAD DETECT

STK412-240(ZX80D)

STR412-230(ZX100D)

PREGND

DC DETECT

OVERLOAD DETECT

DGND

POWER AMP

OVER LOAD

DETECT

OVER LOAD

DETECT

Q604,606,610

STANDBY SWITCH

MUTING

MUTING

Q634,682


1

4

4

1

RBV1306(ZX80D)

D25XB60(ZX100D)

(ZX100D)

(ZX80D)

(ZX80D)

(ZX100D)

FAN DETECT

VIRTUAL GND

R

L

POWER-GND

POWER-GND

3

2

3

2

(ZX100D)

∗R625

2.2k(ZX80D)

22k(ZX100D)

(Page 66)

(Page 66)

(Page 57)

(Page 56)

(Page 41)

(Page 50)

(Page 50)

Ver. 1.1

5454

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

• Waveforms

– DMB15 Board – – VIDEO Board – – MAIN Board – – PANEL Board –

1 IC102 6 (DVDRFIP)(DVD play mode)

500 mV/DIV, 200 ns/DIV

1 Vp-p

7 IC102 <x/c (YUV6)(Color bar)

500 mV/DIV, 20 µs/DIV

H0.9 Vp-p

20.8 µs4 Vp-p

8 IC102 <xzc (ALRCK)

2 V/DIV, 10 µs/DIV

9 IC102 <xzv (ABCK)

2 V/DIV, 100 ns/DIV

326 ns4 Vp-p

2 IC102 <z.v (YUV1)(Color bar)


H

1.1 Vp-p

qa IC102 <xx, (XTALO)

500 mV/DIV, 10 ns/DIV

37 ns1.1 Vp-p

3 IC102 <z.n (YUV2)(Color bar)


H

1 Vp-p

4 IC102 <z., (YUV3)(Color bar)


H1.3 Vp-p

5 IC102 <x// (YUV4)(Color bar)


H

1.1 Vp-p

6 IC102 <x/x (YUV5)(Color bar)


H0.9 Vp-p

q; IC102 <xzb (ACLK)

2 V/DIV, 20 ns/DIV

40.6 ns4 Vp-p

wa IC801 qh (CROUT)(Color bar)


H1.5 Vp-p

ws IC801 qk (CBOUT)(Color bar)


H1.5 Vp-p

wd IC801 w; (CYOUT)(Color bar)

1 V/DIV, 20 µs/DIV

H

2 Vp-p

wf IC801 wa (YOUT)(Color bar)

1 V/DIV, 20 µs/DIV

H

2 Vp-p

wg IC801 wd (CVBSOUT)(Color bar)

1 V/DIV, 20 µs/DIV

H2.5 Vp-p

wh IC801 wh (C OUT)(Color bar)

1 V/DIV, 20 µs/DIV

H

1.8 Vp-p

ed Q370 (Base)(REC mode)

2 V/DIV, 5 µs/DIV

11.1 µs3.9 Vp-p

ef Q370 (Collector)(REC mode)

5 V/DIV, 5 µs/DIV

11.1 µs16 Vp-p

es IC401 qd (X-OUT)

1 V/DIV, 100 ns/DIV

200 ns2.9 Vp-p

ea IC401 qa (XC-OUT)

1 V/DIV, 10 µs/DIV

30.5 µs2.5 Vp-p

ra IC902 is (XOUT)

1 V/DIV, 100 ns/DIV

250 ns

3 Vp-p

5555

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

C743

C703C753

R711

R712

R778

C710

C712

C711

R710

C733

C772

C773

C782

C783

C732

D761

D710

R756

D711

Q700

R753

Q730

Q740

Q750

R703

R704

R705R7

00

R701

R702

R706

R750

R751

R752

R788

R754

R755

R740

R741

R742

R743

R744

R745

R746

Q720

Q722

R720

R721R722

R723R724

R725

R726R727

D762

Q763Q765

Q762

R792

R797

R798R768

R769

R766

R767

R762

R761

D720

R774

Q780

Q770

D730

D780

D770R771

R772

R773

R731R732

R733

R781 R782

R783

R784R734

C791

C792

R779

D763D764

D765

JR79

1

C803

C805

R860

C853

R800

C807

R807

R806

R801C801

R803

Q810

R851

R850

R802

Q800Q850

R841

R891

R890 R840

D800

D850

R839

D810

R817

R812

Q812

D812

R889R843

R861

Q814

R863

R864

R866

C804

R865

D811

C808

C858

R852R8

08

R858

C851

R814

JR797

JR700

JR792

NO800

JW801

JW80

3

JW828

C888

C889

JW80

6

JW80

2

NO801

JW80

4

JW81

1

JW80

7JW805

JW810

JW816

JW800

JW79

8

TM701

TM700

R780

R795

RY760

R793

R785

C780

C781

C730

C731

L770

L730

L780

R737

R787

R777

R786

R736

R776C794 C793

R799

C721

R764

Q721

R730

R796

R765

EP700

JW809

CN701CN700

JW79

0

JW796

JW813

JW701

JW709

JW715

JW716

JW717

JW72

5

JW734

JW74

1

JW742

JW74

3

JW74

4

JW745

JW747

JW751

JW75

2

JW75

3

JW75

4

JW702

JW72

7

JW73

6JW735

JW71

0

JW81

4

JW81

9

JW81

8

JW81

2

JW793

JW722

JW720

JW71

8

JW723

JW755

JW756

JW757

JW73

3

JW73

7

JW72

8

JW72

9JW73

1

RY862

R888

R862

C800

C806

C850

C852

C802

R827

R828

R804

R892

R842

C820

R805

C843

JW740

C839

C838

JW826

JW815

R794

R735

R775

C771

C770

C796

C742 R770

C795

C704

C754

C744

C700

C740

C750

C752

C702

JW808

JW73

8

JW74

9

JW750

JW748

JW726

JW739

R838

C825

C826

NO700

RY761

JW704

JW70

0

JW721

JW705

JW71

9

JW703

JW72

4 JW70

6

JW707

JW708

JW712

B791 B792

B790

JW79

7

JW759

JW77

1

JW820

JW772

NO701

JW79

1

JW79

5

JW746

JW77

3

IC702IC800

R747R748

Q815

E

E

E

9

1

E

E

E

E(ZX100D)

E

(ZX80D)115

E

E

E

E

E

E

5

1

E

EE

SURROUND BOARD

1-868-667-

11

(12)

3

(ZX80D)

(ZX100D)

(ZX100D)

(ZX100D)

1

(ZX100D)

(ZX100D)

(ZX100D)

(ZX80D)

C E B

(ZX100D)

(ZX100D)

13

XPA BOARD

CN607

W PA BOARDCN602L MAIN BOARD

CN514

NMAIN

BOARDCN513

ABMAIN

BOARDCN105

(CHASSIS)

(CHASSIS)

(CHASSIS)

(CHASSIS)

R

L

SURR SPEAKER

+

–

+

–

CENTER SPEAKER

+

–

A

B

C

D

E

F

G

H

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

(ZX80D)

(ZX100D)

-1 -2

-1

-2

-1 -2

7-32. PRINTED WIRING BOARD – SURROUND Board – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

Ref. No. LocationRef. No. Location

D710 C-11D711 C-10D720 G-10D730 D-9D761 E-13D762 H-13D763 H-13D764 G-13D765 D-14D770 D-9D780 E-11D800 E-5D810 E-2

• Semiconductor Location

Ref. No. Location

D811 G-4D812 F-5D850 F-5

IC702 C-9IC800 C-5

Q700 F-7Q720 G-11Q721 G-11Q722 F-10Q730 F-10Q740 D-7

Q750 E-7Q762 E-13Q763 H-13Q765 H-12Q770 F-9Q780 E-10Q800 E-5Q810 D-1Q812 E-3Q814 F-4Q815 F-4Q850 E-5

(Page52)

(Page 45)(Page 45)

(Page 45) (Page 52)

5656

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-33. SCHEMATIC DIAGRAM – SURROUND Board (1/2) –

D811

R863

R864

R866

R888

R805R804R828 C803 C853R827

C825

R850

C850R851 C851

R801

R807R806

C806

R802

C826

C804

R838

R814

R889R839

C843R843

C805

Q810

D800

R840

C820

D810R817

R812

D850 R890

R841

R891 D812

R861R860

Q814

NO801

R803

B791

IC800

R800C801C807

C800

C852 R852C802

R858

R808C808

C858

Q812

R842

C839

C838R892

Q800

Q850

C888

C889

NO800

Q815

RY862

R862

R865

MA111-TX

2.2k

22k

22k

0.225W

11100 100p 100p100

10050V

1k

4.750V

47k 0.01

47k

47k1k

2.250V

10050V

0.1

0.225W

10k

1k1k

4.750V47k

0.1

2SD2114

MA111-TX

22k

1050V

MA111-TX10k

2.2k

MA111-TX 22k

100k

100k MA111-TX

47k56k

2SC2712-YG-TE85L

5P

2.2k

(CHASSIS)

1k11

4.7 50V

10010V

27010010V

47k

47k8.2p

8.2p

2SC3906K

101/2W

0.068

0.068101/2W

2SC3906K

2SC3906K

0.068

0.068

5P

2SC2712-YG-TE85L

∗

1k

A1

A2

A3

A4

A5

A6

A7

A8

A9

∗

SW RC GND

AC CUT DETECT

-VL

+VL

SW +

SW -

VIRTUAL GND

(1/2)

POWER AMP

STK403-070(ZX80D)

STK403-100(ZX100D)

(ZX100D)

(ZX100D)

∗R802

MUTING

STANDBY SWITCH

OVER LOAD

DETECT

DETECT

OVER LOAD

RELAY DRIVE

PROTECT SWITCH

-1

-2

(ZX100D)

270(ZX100D)

1k(ZX80D)

(ZX80D)

(ZX100D)

ZX80D:US,E2,E3,E13,E51/


82 1/2W(ZX80D:MX/ZX100D:MX)

100 1/2W

∗R862

(Page 57)

(Page 53)

(Page 57)

(Page 51)

(Page 57)

(Page 57)

Ver. 1.1

5757

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-34. SCHEMATIC DIAGRAM – SURROUND Board (2/2) –

R783

R784

R797R798

R733

R734

Q700Q750

R794 R795

R793

C795

C796

C752

C794

C793

CN701

R756

R755R753

R706

R705

C701

R701

R700

C700

R703

C702

R751C751

R780

R781

R730

R731

R712

R711

R750C750

R768

Q765

C792

NO700

TM701

TM700

R777

C773

C772

JW746

JW791

EP700

R776R779R778R788

R787

C782

C783

R737

C732

C733R786

L730

R736

L770

L780

RY761

JR792

R766

R767

JR791

D762

RY760

JR797 JW790JW795

R796

R799

JW793

JW796

R725

R724

Q721

R723

R726

C703

C721

R727

C770

C771

R775

R774

R722

Q720

R721

R720

C781

C780

R785

R735

C730

C731

D730

D780

R732

R782

C711

C712

C753C743R710C710

R770

C741R741C742

R740

C740

R771

R7

92

R7

61

R7

62

R772

R773

JR700

R704R754

C754 C704

C791

Q740

R745R743

R744

JW797

C744

JW798

JW710

CN700

IC702

NO701

R765

R764

Q763

R769

Q780

D7

11

D7

10

Q7

22

R752R742

R702

Q770

R746

Q730

Q762

D764D763D765

D761

D720

D770

100k

47k

22k1k

100k

56k

2SD21142SD2114

100 100

1

22100V

22100V

22010V

100100V

100100V

8P

10k

47k1k

10k

47k

220p

47k

1k

4.750V

1k

22010V

47k220p

0.225W

1k

0.225W

1k

47k

47k

1k4.750V

2.2k

2SD2114

0.01

9P

101/2W

100000p

100000p101/2W

47k47k47k

101/2W

100000p

100000p

101/2W

100000p

100000p101/2W

101/2W

0

2.2k

22k

0

MA111-TX

03.3k

1W3.3k

1W

47k

33k

2SA1207

2.2k

33k

100p

2250V

33k

0.068

0.068

101/2W

68k

22k

2SC2712

10k

10k

0.068

0.068

101/2W

101/2W

0.068

0.068

MA111-TX

MA111-TX

27k

27k

12p

12p

100p100p47k12p

0.225W

220p47k22010V

1k

4.750V

1k

10

0k

10

0k

10

0k

27k

100k

0

10k10k

4.750V

4.750V

0.01

2SD2114

47k1k

10k

4.750V

13P

3P

∗

∗

2SC2712

22k

2SC3906K

UD

ZW

-TE

17-1

8B

UD

ZW

-TE

17-1

8B

2S

C3

90

6

7502SC3906K

10k

2SC3906K

2SC2712

MA111-TXMA111-TXMA111-TX

MA111-TX

MA111-TX

MA111-TX

A1

A2

A3

A4

A5

A6

A7

A8

A9

SW IN

STK MUTE

OVELOAD

DC DETECT

REAR RELAY

CENTER RELAY

CENTER

SL-IN

SR-IN

SR

-IN

SL-I

N

REAR RELAY CENTER RELAY

ST

K M

UT

E

DC DETECT

AC CUT DETECTCENTER OV

EL

OA

D

OVELOAD

DC DETECT

SW LINE MUTE

STK MUTE

OVELOAD

AC CUT DETECT

SW RY

SW IN

SW LINE MUTE

SW RY

∗

∗

L+R

SL-IN

SR-IN

+VH

+VL

-VL

-VH

SURR POWER GND

CENTER GND

DVD LINE MUTE

STK MUTE

CENTER RELAY

REAR RELAY

OVELOAD

DC DETECT

UNREG

REAR R GND

REAR L GND

FAN DETECT

UNREG

CENTER SPK SWITCH

SW A-GND

SW LINE MUTE

(2/2)

CENTER SPEAKER

L

R

SURR SPEAKER

(ZX100D)

(CHASSIS)

RELAY DRIVE

RELAY

DRIVE

PROTECT

SWITCH

-1

-2

-1

-2

(ZX100D)

(ZX100D)

POWER AMP

(ZX100D)

(ZX100D)

Q720-722

STANDBY SWITCH

(ZX100D)

OVER LOAD DETECT

OVER LOAD DETECT

OVER LOAD

DETECT

(ZX100D)

MUTINGMUTINGMUTING

(ZX100D)

(ZX80D)

+9V

AGND

AGND

AGND

CTR-IN

SW

SW SPK RY

STK412-240(ZX80D)

STK413-430(ZX100D)

∗R702,752

390(ZX100D)

430(ZX80D)

ZX80D:US,E2,E3,E13,E51/


82 1/2W(ZX80D:MX/ZX100D:MX)

100 1/2W

82 1/2W(ZX100D:MX)100 1/2W(ZX100D:E2,E3,E51,SP,MY)

∗R765

∗R764

(Page 56)

(Page 56)

(Page 56)

(Page 50)

(Page 48)

(Page 53)

(Page 56)

Ver. 1.1

5858

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-35. PRINTED WIRING BOARD – PANEL Board – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

JR904

R1021

C974

C977

C978

C979

C980

C926

C927

JR914

C928

C929

C930

C931

C932

C933

C934

C935

C936

C937

C938

C939

C981

C982 C9

83

C972

R942 R943R9

41 D905

C920

R922

C904

R901

R900

C940

C909

C903

C945

C947 R956

C946

C948

R947

R949

R950

R952

R953

C949

C951

C953

C955

C957

C950

C975

R902

C901

C902

C118

0

R905

R903

R904

R906

R907

C910

D932

C954

R948

C952

C958

C956

R951

C959 R954

R1022R102

3

R102

4

R1025

R102

6

R909

R102

7

R102

8

R1189R1187

C906

C925

C905

R912

C916

C908

D931

R1180

Q903

Q917

R908

R1178

R944

R968

R964

R965

R966

R967

R910

R987

Q908

R914

R990

Q909

R916

R974

Q907

Q910

R957

R997

R1135

R1136

Q918

Q919

R1141

R923

R100

7

R100

8

R1009

R1010

R1011

R1012

R1013

Q904

R979

R982

R980

R981

Q905

Q906

Q901 Q902Q914 R919

R920

R918

C961

IC904

D901

IC902

C973

JR925

R984

R983

R1181

C917

C964

JW90

4

JW90

3

NO904

D927D928

D908

D909

D910

D916

D917

D1145

D1153

D913

D914

D929

D930

S927

S925

S924

S923

S922

S921

S908

S909

S910

S911

S912

S913

CN902

C943

C922

C923C924

C900

C941

C942

CN900

C967

IC903

FL901

JW1105

JW90

0 JW90

6

JW90

7

JW908

JW909

JW911

JW912

JW913

JW914

JW915

JW916

JW917

JW918

JW919

JW920

JW921

JW92

2

JW923

JW924

JW92

5

JW926

JW927

JW928

JW929

JW931JW93

2

JW933

JW934

JW935

JW936

JW937

JW94

1

JW94

2

JW94

3

JW94

4

JW94

5

JW94

6

JW94

7

JW94

8

JW94

9

JW95

0

JW95

1

JW95

2

JW95

3

JW95

4

JW95

5

JW95

6

JW95

7

JW95

8

JW95

9

JW96

0

JW96

1

JW96

2 JW96

3

JW96

4

JW96

5

JW966

JW967

JW96

8

JW969

JW970

JW971

JW972

JW973

JW974

JW975

JW976

JW977

JW978

JW979

JW980

JW981

JW982

JW98

3

JW98

4

JW985

JW986

JW98

7

JW98

8

JW98

9

JW99

0

JW99

1

JW99

2

JW99

3

JW99

4

JW99

5

JW99

6

JW99

7JW

998

JW10

00

JW10

01

JW10

02

JW10

03

JW10

05

JW10

06

JW10

07

JW10

08

JW10

09JW

1010

JW10

11

JW10

12

JW10

13

JW10

14

JW10

15

JW10

16

JW10

17

JW10

19

JW10

20

JW10

21

JW10

22

JW10

23

JW10

26

JW10

27

JW10

29

JW10

30

JW10

31

JW10

32

JW10

33

JW10

34

JW10

35JW10

36

JW10

37

JW10

38

JW10

39

JW10

42

JW10

43

JW10

44

JW1046JW

1047

JW1049

JW1050

JW90

1

JW90

2

JW1051

JW10

52

JW10

53

JW10

54

JW1055

JW1056

JW1057

JW1058

JW10

59

JW1090

JW10

04

JW10

18

JW10

28

JW10

24

JW10

45

JW10

40

JW10

41

JW940

JW939

JW938

FB901

E

E

E

E

E

EE

E

E E E

E

E

E

11 20

10 1

1

3031

50

51

80 81

100

1-868-670-

11

(13)

PANEL BOARD

1

7

(RED)

13

(GRN)

1

D908,S925

DVD

D916,S922TV/SAT

D904,S924TUNER/BAND

D910,S923TAPEA/B

D917,S921VIDEO

70

65

646

71

FLUORESCENT INDICATOR TUBE

X901

ZFUNCTION

BOARDCN901

GMAIN

BOARDCN508

S907 – 913,S921 – 925, 927

N

N

X

S907

D1145,S908

D1153,S909

D913,S910

x

PRESET+

>

D929,S912

TUNING+

M y

D930,S913

TUNING-

m

D914,S911

PRESET-

.

y

YCD-SWBOARDNO1151

A

B

C

D

E

F

G

H

I

1 2 3 4 5 6 7 8 9 10 11 12 13 14

N

N

D911

N

N

D915(AMBER)

(GRN)

11

Ref. No. LocationRef. No. Location

D901 A-13D908 D-13D909 E-13D910 F-13D911 B-2D913 E-3D914 F-3D915 B-3D916 G-13D917 H-13D927 B-13D928 B-13D929 G-3

• Semiconductor Location

Ref. No. Location

D930 H-3D931 E-4D932 E-4D1145 C-3D1153 D-3

IC902 C-7IC903 C-13IC904 C-3

Q901 C-11Q902 C-12Q903 B-13

Q904 G-4Q905 G-4Q906 F-3Q907 H-3Q908 E-13Q909 G-12Q910 C-2Q914 C-11Q917 B-13Q918 E-3Q919 F-3

(Page62)

(Page 45) (Page 60)

Ver. 1.1

5959

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-36. SCHEMATIC DIAGRAM – PANEL Board – • See page 54 for Waveforms. • See page 67 for IC Block Diagrams. • See page 71 for IC Pin Function Description.

R941R942

R964

FL901

C943

R943

C967

CN902

R1136

R1135

R997

C961

C917

D931

R1013

R1012

R1011

R1010

R1009

R1008

R1007

R922 X901

D905

C1

18

0

C909

C9

01

C9

02

R9

03

R9

04

C9

10

R9

05

R9

06

R9

07

R1

02

1

R1

02

2

R1

02

3

R1

02

4

R1

02

5

R1

02

6

R1

02

7

R1

02

8

C906

C9

16

R9

09

C908

R9

02

C905

R9

12

CN900

Q918

D932

R900

C903

C942

C949

C948

C946

R947

R949

R950

R953

R952

IC904

R983

R984C945

C950

C952

C954

C956

C947

R948

R951

C958

R954C959

R956

R901C904

C900

C964

Q901

Q914

R918

R919

R920

C940

R908D901

Q917

Q903

R982

R980

Q908

R965R966

S922 S921S923

R967

R1181

S924

R968

CLP912

Q909

R957

Q919

JW903

JW904

JR914C974

FB901

C953

C955

C951

C957

IC903

JW1105

IC902

R1178 R1180

Q906

R910

R987

R914

R990

R974

R916

Q910

NO904

S925

C941

R9

44

C920

C922

C923

C924

C925

Q905

Q907

Q904

R1141

R923

S907

S908

S909

S910

S911

S912

S913

S927

C9

77

C9

78

C9

79

C980

C9

26

C9

27

C9

28

C9

29

C9

30

C9

31

C9

32

C9

34

C9

35

C936

C9

33

C9

37

C9

38

C939

C9

81

C9

82

C9

83

C9

72

C9

73

C9

75

Q902

D915

D928D927

R979

R981

D909

D908

D916

D910

D917

D1145

D1153

R1

18

7

R1

18

9

D930

D929 D914

D913

D911

1.5k1.5k

4.7k

1050V

10k

1050V

17P

680

680

680

0.1

0.1

MA111-TX

33k

22k

15k

10k

6.8k

4.7k

3.3k

1M

4MHz

0

22

0p

22

0p

22

0p

22

0p

10

0

10

0

0.1

15

k

15

k

15

k

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

22

0p

0.1

4.7

k

22

0p

10

k

0.1

10

0

17P

DTC123JKA

MA111-TX

10k

0.1

1050V

1

470p

470p

1k

1k

1k

1k

1k

NJM2760

56k

33k1

0.0047

0.0047

0.022

0.022

1

6.8k

5.6k

0.047

10k0.047

2.7k

10k0.1

4.750V

4710V

DTC143TKA

DTC143TKA

100k

100k

100k

0.1

100MA111-TX

DTC123JKA

RT1P237C-TP-1

470

1k

DTC123JKA

6.8k10k15k

270

22k

DTC123JKA

680

DTC123JKA

00.01

0

1

1

1

1

RPM7240-H9

MB90M407PF-G-149E1

22 82

DTC123JKA

680

680

680

680

680

680

DTC123JKA

7P 10 50V

47

0.1

4706.3V

4706.3V

4706.3V

0.01

2SB1132

DTC123JKA

2SB1132

680

680

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

47

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

10

0p

DTC143TKA

SEL5423E-TP15

SEL5423E-TP15SEL5223S

-TP15

120

1k

SELU5823C-TP15 SELU5823C

-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

10

k

4.7

k

SELU5823C-TP15

SELU5823C-TP15 SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

123456789

12

13

14

15

16

17

18

19

20

21

22

24

25

26

27

28

29

30

10

31

32

33

34

35

36

37

38

39

40

41

43

44

45

46

47

85

86

87

88

89

90

91

96

97

98

99

100

92

64

65

72

77

78

79

76

61

60

59

58

57

56

55

79

77

61

60

52

53

86

87

88

89

90

91

85

92

97

100

12345678 99

98

910

12

13

14

15

16

17

18

19

22

20

24

21

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

47

46

45

44

43

80

74

55

96

64

65

56

57

58

59

72

74

76

78

71

67

68

69

70

54

75

73

66

80

52

53

54

66

67

68

69

70

73

75

71

G1

G2

G3

G4

G5

G6

G7

G8

G9

G10

G11

G13

G14

G15

G16

G17

G18

G19

G20

G21

G12

G22

G23

G24

XIN

X0UT

LE

D-P

LA

Y

RES

ET

VO

LU

ME

OP

ER

AT

ION

AL

DIA

L

LE

D S

EL

EC

TO

R

BF1

BF4

BF3

BF2

AL

L-B

AN

D

KEY

2

KEY

1

KE

Y 0

AV

SS

AV

CC

12

C-C

LO

CK

12

C-D

AT

A

MD

2

LE

D-C

D/D

VD

,TU

NE

R

MD0

VKK

P36

P35

P34

P33

P32

VSS-IO

P21

P22

P23

P24

P25

P26

P27

P28

P29

P30

P31

P1

P2

VS

S-I

O

P3

P4

P5

P6

P7

P8

VD

D-F

IP P9

P1

0

P1

1

P12

P1

3

P14

P1

5

P1

6

P1

7

P1

8

P1

9

P20

GC RESET

EVER +4V

VG

SPEANA

BPM LOW

GNDVCC

NC

F1

NP

F2

P36

P35

P34

P33

P32

P31

P30

P29

P28

P27

P26

P25

P24

P23

P22

P21

P20

P1

9

P1

8

P1

7

P1

6

P1

5

P14

P1

3

P12

P1

1

P1

0

P9

P8

P7

P6

P5

P4

P3

P2

P1

G1

G1

8

G1

7

G1

6

G1

5

G1

4

G1

3

G1

2

G1

1

G1

0

G9

G8

G7

G6

G5

G4

G3

G2

NX

NX

NP

NX

NX

G1

9

G2

4

G23

G2

2

G2

1

G20

NP

NP

VF (2)

POWER LED

VF (1)

LED +9V

JO

G-X

-RO

UN

D

LE

D-T

AP

E,T

V/S

AT

LE

D-V

IDE

O,(

PA

US

E,S

TO

P)

LED

-(A

MS

+,A

MS

-),(

FF,F

R)

LE

D-F

LA

NG

ER

,CH

OR

US

LED-FLANGER,CHORUS

LE

D-(

BA

LA

NC

E,W

AV

E,F

AD

ER

,RA

ND

OM

),D

EL

AY

BUF2OUTIN1

IN2

BPF4IN2

BPF4IN1

BPF3IN2

BUF1OUT

BPF2IN1

BPF2IN2

BPF3IN1

BPF1IN1

BPF1IN2

RECOUT

KEY INT POWER

KEY INT DISPLAY

BPF1OUT

BPF2OUT

BPF3OUT

BPF4OUT

SIRCS

SEL B

SEL A

OPERATION DIAL

LED VOL 1,2

LED VOL 7,8

LED VOL 5,6

LED VOL 3,4

VOLUME

GND

KEY INT DISPLAY

JOG-X-ROUND

KEY 2

SEL B

SEL A

KEY 0 IN

KEY 1 IN

KEY 0 OUT

KEY 1 OUT

LED (BEAT JUMP,BEAT MAX)LED-BAL,WAVE,FADER,RAND

LED-(BAL,WAVE,FADER,RAND),DELAY

(CHASSIS)

FLUORESCENT INDICATOR TUBE

GRID DRIVE

GRID DRIVE

LED DRIVE

LED DRIVE

BAND-PASS FILTER

REMOTE CONTROL RECEIVER

VCC-CPU

VSS-CPU

DISPLAY CONTROLLER

LED DRIVE

LED DRIVE

B+ SWITCH

B+ SWITCH

LED ON/OFF

CONTROL SWITCH

CONTROL SWITCH

LED ON/OFF

LED DRIVE

LED DRIVE

LED DRIVE

IIC-CLK

IIC-DATA

GC GND

GC GND

SPEANA GND

TUNING

+

PRESET

PRESET

-

TUNING

+

-

PRESET

+

PRESET

-

TUNING

+

TUNING

-

DVDTUNER/

BAND

TAPE

A/BTV/SAT

VIDEO

LED (BALANCE,WAVE,FADER,RANDOM)

GC GND

VIDEODVD TV/SATTAPE

A/BBAND

TUNER/

GRID DRIVE

(AMBER)

(GRN)

MD1

LE

D-V

OL

UM

E 1

,2

LE

D-V

OL

UM

E 3

,4

LE

D-V

OL

UM

E 5

,6

LE

D-V

OL

UM

E 7

,8

LE

D-(

BE

AT

JU

MP

,BE

AT

MA

X)

(RED)(GRN)

(Page63)

(Page 46)

(Page 61)

Ver. 1.1

6060

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-37. PRINTED WIRING BOARDS – FRONT KEY Section – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

JR921

JR923

R1003

R1004

R1005

R1006

R963

R1001

R1002

R962

R961

R960

R959R958

R1014

R973C907

R972

R1018

R1019

Q921

R101

6

R101

5

Q920

R118

6

CNS902

JW1150

S916

S914

S904

S903

S902

S905

S906

S901 S918S928

S919

S917

S920

S915

CN901

D1017

D1016

D1020

JW10

60

JW10

61

JW1062

JW1064

JW10

65

JW10

66

JW10

67

JW10

68

JW1069

JW1070

JW10

72

JW10

73

JW1075

JW1063

JW10

78

JW10

74

JW10

71

S970

R1162

Q911

R1144

R1145

R1146

R1149

R1150

R1151

Q912

R1161 C1150

R1040

JR1096

D920

D919

CNS903

D922

JR1

JR922

R1165

R1164

Q915

Q913

JR4

R1163

R115

3

R115

4

R1155

JR5

JR3

R115

7

R115

8

R115

9

D924

D926

D923

S1161

JW1088

D925

D921

JR2

FUNCTION BOARD

1-868-671-

11

(13)

CD SYNC

ENTER

MASTER VOLUMEROTARY ENCODER

ZPANELBOARDCN900

1 8

PROGRESSIVE

REC/PAUSE/START

GROOVE

EQ BAND

DIRECTION

13 2

DELAY

D1016, S915

E

AMP MENU

CHORUS

D1017, S916

FLANGER

D1020, S917

E

ILLUMINATION

DISPLAY

SOUND FIELD

JOG BOARD

1-868-675-

11

(13)

1

1 8

3 2

E

E

E

E

OPERATION DIALROTARY ENCODER

VOLUMELEVEL 8

VOLUMELEVEL 1

VOLUMELEVEL 2

VOLUMELEVEL 3

VOLUMELEVEL 4

VOLUMELEVEL 5

VOLUMELEVEL 7

VOLUMELEVEL 6

S901 – 906,S914 – 920, 928

A

B

C

D

E

F

G

1 2 3 4 5 6 7 8 9 10 11


Ref. No. LocationD919 D-3D920 C-3D921 B-3D922 B-2D923 B-1D924 C-1D925 D-1D926 D-2D1016 F-10D1017 E-10D1020 D-10

Q911 D-3Q912 B-3Q913 C-1Q915 C-1Q920 F-9Q921 D-10

(Page 58)

6161

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-38. SCHEMATIC DIAGRAM – FRONT KEY Section –

CN901

R1014R958R959R960R961R962R963

R1006R1005R1004R1003R1002

R1186

R1001

R972

R973

C907

CNS902

JR1096

R1040

R1161

C1150

CNS903

CLP1151

R1144 R1145 R1146 R1162 R1149 R1150 R1151 R1163 R1164 R1159R1158R1157R1155R1154R1153

Q915Q913Q912Q911

D1020 D1017 D1016

Q920Q921

S970

R1165

S1161

S918S920S928 S919 S917 S916 S915 S914

S901 S902 S903 S904 S906S905

R1018

R1019

R1015

R1016

CLP1152

D919

D920

D921

D922

D923 D925

D926D924

17P

4706801k1.5k1.5k2.2k3.3k

2.2k1.5k1.5k1k680

270

470

1k

6.8k

0.001

8P

0

1k

1k

0.001

8P

1k 1k 1k 100 1k 1k 1k 100 100 1k1k1k1k1k1k

DTC123JKADTC123JKADTC123JKADTC123JKA

SLR-343DCT32 SLR-343DCT32 SLR-343DCT32

DTC123JKADTC123JKA

100

1k

1k

1k

1k

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15 SELU5823C-TP15

SELU5823C-TP15SELU5823C-TP15

KEY 0 IN

LED VOL 1,2

LED VOL 3,4

LED VOL 5,6

LED VOL 7,8

OPERATION DIAL

KEY 0 IN

LED VOL 1,2

LED VOL 3.4

LED VOL 5,6

LED VOL 7,8

OPERATION DIAL

LED-FLANGER,CHORUS

LED-BAL,WAVE,FADER,RAND

OPERATION DIAL

GC DGND

LED VOLUME 7,8

LED VOLUME 1,2

LED VOLUME 3,4

LED VOLUME 5,6

SEL A

SEL B

LED VOL 1,2

LED VOL 3,4

LED VOL 5,6

LED VOL 7,8

OPERATION DIAL

VOLUME

SEL A

SEL B

SEL A

SEL B

OPERATION DIAL

LED VOLUME 7,8

LED VOLUME 5,6

LED VOLUME 3,4

LED VOLUME 1,2

GND

KEY INT DISPLAY

KEY 0 OUT

KEY 1 OUT

KEY 1 IN

KEY 0 IN

LED-(BAL,WAVE,FADER,RAND),DELAY

(CHASSIS)

(CHASSIS)

ROTARY ENCODER

LED DRIVE LED DRIVE LED DRIVE LED DRIVE

LED DRIVELED DRIVE

ROTARY ENCODER

GN

D

2A

2B

VOLUME

LEVEL 8

VOLUME

VOLUMEVOLUMEVOLUME

VOLUME VOLUME VOLUME

LEVEL 7

LEVEL 6

LEVEL 5

LEVEL 4

LEVEL 3

LEVEL 2

LEVEL 1

OPERATION DIAL

DELAYCHORUSFLANGER

ENTERDELAYCHORUSFLANGERSOUND FIELDILLUMINATIONAMP MENUDISPLAY

CD SYNCDIRECTIONEQ BANDGROOVEPROGRESSIVE

PAUSE/START

REC

GC DGND

MASTER VOLUME

(Page 59)

6262

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-39. PRINTED WIRING BOARDS – TOP KEY Section – • See page 29 for Circuit Boards Location. : Uses unleaded solder.


Ref. No. Location

D1040 B-4D1042 B-6D1044 B-4D1046 B-8D1048 B-8D1050 B-9D1052 C-4D1054 C-5D1056 B-9D1058 B-7

Q1041 B-10

R104

1

R1042

R1043

R1044

R104

5

R104

6

R104

7

Q1041

C1040

R105

1

R1050

JR91

5

R1048

JR1041

R105

6

R105

7

R105

9

R105

8

R106

5

R106

4R1

060

R106

1

R106

3

R106

2

R105

4

R105

5

R105

3

R105

2

R106

7

R106

6

S1049

S1040

S1045

S1046

S104

4

S1042

S1043 S1041

D1044

D1040

D1052 D1054

D1042

D1046

D1048 D1050

D1056

D1058

JW10

81

S1047

CN1153

JW1077

JW10

79

JW11

51

JW1082

JW1083

JW1084

JW1085

R1166 R1167

R1168 R1169R1170

S1170S1169S1168S1167S1166

CN1152

JW1086NO1151 JW

1129

JW11

30

JW11

31

JW10

87

E

1-868-674-

11

(13)

X-ROUND BOARD

1

3

2

SPEAKERS/X-ROUND OFF

BEAT PAD

BEAT JUMP

D1048, 1050, S1043

BEAT MAX

D1046, 1056, S1042

BALANCE

D1052, 1054, S1047

FADER

D1040, S1046

WAVE

D1044, S1045

RANDOM

D1042, 1058, S1044

X-ROUND JOG

ROTARYENCODER

1-868-672-

11

(13)

CD-SW BOARD

17

Y PANEL BOARDNO904

S1041 – 1047,S1166 – 1170

DISC 1DISC 2DISC 3EX-CHANGE/DISC SKIP

Z OPEN/CLOSE

A

B

C

D

E

F

1 2 3 4 5 6 7 8 9 10 11

(Page 58)

6363

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-40. SCHEMATIC DIAGRAM – TOP KEY Section –

R1167R1168R1169R1170 R1166

NO1151

CN1152

CN1153

Q1041

R1050

R1051C1040

S1040

R1041R1042R1043R1044R1045R1046R1047R1048

R1052

R1053

R1066

R1067

R1062

R1063

R1059

R1058

R1054

R1055

R1064

R1057

R1056

R1065

R1060

R1061

S1166S1167S1168S1169S1170

S1041S1042S1043S1044S1045S1046S1047

S1049

D1048

D1046

D1050

D1056

D1044D1040

D1054

D1052

D1058

D1042

6801k1.5k1.5k 470

7P

7P

7P

DTC123JKA

1k

1k0.001

2.2k3.3k4.7k6.8k10k15k22k33k

1k

1k

1k

1k

1k

1k

1k

1k

1k

1k

1k

1k

1k

1k

1k

1k

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

SELU5823C-TP15

LED-BAL

LED-BEAT

JOG

JOG

LED-BEAT

LED-BAL

KEY2

JOG-X-ROUND

GC GND

JOG-X-ROUND

GC GND

SEL B

KEY 2

SEL A

SEL A

SEL B

KEY2

GC GND

SEL A

SEL B

JOG-X-ROUND

(CHASSIS)

LED DRIVE

ROTARY ENCODER

LED(BEAT JUMP,BEAT MAX)

OPEN/CLOSEEX-CHANGE/

DISC SKIP

DISC 3DISC 2DISC 1



X-ROUND JOG

BEAT PADBEAT MAXBEAT JUMPRANDOMWAVEFADERBALANCE

SPEAKERS/

X-ROUND OFF

D1048,1050

BEAT JUMP

D1046,1056

BEAT MAX

WAVE

D1042,1058

RANDOM

D1052,1054

BALANCE

FADER

LED-(BALANCE,WAVE,FADER,RAND)

LED(BALANCE,WAVE,FADER,RANDOM)

LED(BALANCE,WAVE,FADER,RANDOM)

(Page 59)

6464

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-41. PRINTED WIRING BOARD – TRANSFORMER Board – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

R126

2

R126

3

R126

4

D1264

NO1211

FH1291

F1291

FH1292

JW1202

JW1201

JW1206

JW1207

JW12

16

JW12

31

CN1215

JW1222

JW1223

JW1234

JW1233R1233

CN1212

R1292

C1263

Q1264

C1262

FH1241FH1242

FH1251

F1241

F1251

FH1261

FH1252

FH1262

FH1272

FH1282

CN1213C1292

D1292

JW1208

JW1209

JW1220

T1200POWER TRANSFORMER

JW1211

FH1271

F1261

F1271

FH1281

F1281

JW1221

1-864-931-

11

(22, 23)

TRANS BOARD

BCE

2

(ZX100D)

(ZX80D)

1(ZX80D:US, MX/ZX100D:MX)

(ZX80D:US)

1

4

ZX80D:E2, E3, E13, E51/ZX100D:E2, E3, E51, SP, MY

1 3 7

819

5

A

B

C

D

E

F

1 2 3 4 5 6 7 8 9 10 11 12 13 14

RMAIN

BOARDNO603

VPA

BOARDNO600

SPA

BOARDNO604

ACPRIMARY

BOARDCN1204

(Page 65)

(Page 52)

(Page 52)

(Page 45)

Ver. 1.1

6565

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-42. PRINTED WIRING BOARD – PRIMARY Board – • See page 29 for Circuit Boards Location. : Uses unleaded solder.

Q1200

C1204

R1200

R1201

C1202C1201 D1200 JR1202

JW12

04

NO1201

NO1203

JW12

14

JW12

12

JW1213

JW12

15

CN1204

CN1202

C1206

RY1200

S1200

EP1203

CN1200

L1201

C1200(ZX80D)

E

PRIMARY BOARD

1-864-932-

11

(22, 23)

POWERSWITCHING

1 2

1 2

1 2

(CHASSIS)

1

3

1

4

(AC IN)

VOLTAGESELECTOR

220V

120V

230 – 240V

JMAIN

BOARDNO401

ACTRANSBOARDNO1211


ZX80D: US, MX/ZX100D: MX



A

B

C

D

E

F

G

1 2 3 4 5 6

(Page 45)

(Page 64)

Ver. 1.1

6666

HCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D

7-43. SCHEMATIC DIAGRAM – POWER SUPPLY Section –

L120118µH

R1262

R1263

C1202C1201

R1200

C1206

CN1200

R1201

C1204EP1203

NO1201

CN1212

R1264

C1262

C1263

JR1202

RY1200

Q1200

JW1204

CN1204

JW1234

NO1211

F1251

F1261F1271

F1281

F1241

F1291

T1200

Q1264

D1264

JW1211

JW1222

JW1223

CN1213

CN1215

D1292

C1292

R1292

CN1202

NO1203

S1200

D12008.2k

R12333.3M 1/2W8.2k

0.10.1

3.3k

10006.3V

3P

100k

0.1

2P

7P

1k

10 50V

10050V

0

2SC2712KT-YG

∗

∗∗

∗

∗

∗

2SB1565E

HZU36BTRF

8P

2P

10EDB40-TB3

10063V

0.68

2P

2P

MA111-TX

AC3

AC4

AC4

VF

VF

AC3

VP

GND

GND

D-GND

N

L

N

L

EVER+4V

DGND

GND

AC1

AC1

AC2

AC2

EVER+4V

STBY RLY

D-GND

(CHASSIS)

(AC IN)

POWER ON/OFF

RELAY DRIVE

VOLTAGE

120V

220V

230-240V

ZX80D:US,MX/

ZX100D:MX

ZX100D:MX

ZX80D:US,MX/2P

4P

ZX80D:E2,E3,

E13,E51/

ZX100D:E2,E3,

E51,SP,MY

ZX80D:E2,E3,

E13,E51/

E51,SP,MY

ZX100D:E2,E3,

ZX80D:E2,E3,E13,E51/


2P(ZX80D:US,MX/ZX100D:MX)

4P

ZX80D:E2,E3,E13,E51/


POWER TRANSFORMER

-36V REGULATOR

(ZX80D)

(ZX100D)

POWER

SWITCHING

SELECTOR

∗ NOT REPLACEABLE:

BUILD IN TRANSFORMER

C1200(ZX80D)

(ZX80D:US)

0.0047250V

∗F1241,1251,1261,12718A 125V (ZX80D:US)8A 250V (EXCEPT ZX80D:US)

∗F1281, 12913.15A 125V (ZX80D:US)3.15A 250V (EXCEPT ZX80D:US)

(Page53)

(Page 53)

(Page 51)

(Page 46)

Ver. 1.1

67

HCD-ZX80D/ZX100D

• IC Block Diagrams– DMB15 Board –

IC105, 107 TK11133CSCL-G

1 2 3

5 4

VCON

T

GND NP

VIN

VOUT

CONTROLCIRCUIT

OVER HEAT &OVER CURRENT

PROTECTION

BANDGAPREFERENCE

SCF DAC DATT

SCF DAC DATT37LOUT4–38LOUT4+

SCF DAC DATT39ROUT3–40ROUT3+


SCF DAC DATT43ROUT2–44ROUT2+


SCF DAC DATT

SCF DAC DATT

47ROUT1–48ROUT1+

DSD

PCM

AUDIOI/F

8

PDN

5

DZF1

6

CAD0

3

DZF3

4

DZF2

1

LOUT

1–

2

LOUT

1+

9

BICK

10

MCL

K

11

DVDD

12

DVSS

13 SDTI414 SDTI115 SDTI216 SDTI317 LRCK

CONTROLREGISTER 18 I2C

25

DSDL

1

26

DSDR

1

33

ROUT

4+

32

ROUT

4–

27

DSDL

2

28

DSDR

2

29

DSDL

3

30

DSDR

3

19 CCLK/SCL

21 CSN/CAD120 CDTI/SDA

24 DSDR4

22 DCLK23 DSDL4

31

DIF0

7

ACKS

N

36

AVSS

35

AVDD

34

VREF

H

IC301 AK4358VQ-L

68

HCD-ZX80D/ZX100D

DELTA-SIGMAMODULATOR

DELTA-SIGMAMODULATOR

VINL 1

VINR 2

VREF1 3VREF2 4

VCCAGND

56

BYPAS 8

TEST 9

LRCK 10

REFERENCE

× 1/64, × 1/128DECIMATION

FILTERWITH

HIGH-PASSFILTER

SERIALINTERFACE

&MODE/FORMAT

CONTROL

MODE120MODE019FMT118FMT017OSR16SCKI15VDD14DGND13DOUT12BCK11

CLOCK & TIMING CONTROL

POWERSUPPLY

PDWN 7

IC3601 PCM1803DBR

– DRIVER Board –

IC701, 712 BA6956AN

1 2 3 4 5 6 7 8 9

CONTROL LOGIC

TSD

VREF

OUT2

OUT1

RNF

VM VCC

FIN

GND

RIN

2

OSC

ADPCMDECODE

DELAYDRAM

ADPCMENCODE ADC

DAC S/H POSTLPF

ALCVOLUME CONTROL

OSCC

1

VDD

3

OSCR

4

NC

5

VOL1

(CS)

6

VOL2

(SCL

)

7

VOL3

(SDA

)

8

NC

9

VRO

VREF

VDA NC

ALC1

MC1

N

MC1

P

15

16

1413121110

VREF

VREF

VREF

VREF

ALC

VREF

MC2

P

17

MC2

N

18

ALC1

19

NC

20

VSA

21

MCO

22

PRIN

23

ADIN

24

NC

25

DA O

UT

26

VOLS

T

27

NC

28

TEST

29

POOU

T

30

VSS

– MIC Board –

IC1100 TC9488FG

69

HCD-ZX80D/ZX100D

– EFFECTOR Board –

IC1501, 1504 M65850FP-E1

OSCILLATOR

1/2 VCC

AUTORESET

LPF1

MAINCONTROL

A/D

20KBITSRAM

LPF2D/A

2 3 4 5 6 7 8

9101115 14 13 12

CLOCK

RESETMO

MID1 DO0

DO1

VCC

16

NC CLOC

K

REF

OP2I

N

OP2O

UT

LPF2

IN

LPF2

OUT

LPF1

IN

1

NC

LPF1

OUT

OP1O

UT

OP1I

N

CC1

CC2

GND

1

D4

2

D6

3

COM

4

D7

5

D5

6

INH

7

VEE

8

GND

9

C

10

B

11

A

12

D3

13

D0

14

D1

15

D2

16

VCC

OUTCIN

OUTCIN

OUTCIN

OUTCIN

OUTCIN

OUTCIN

OUTCIN

OUTCIN

LOGI

C LE

VEL

CONV

ERTE

R

16 1315 11 910

2 3 6 7 8

A B3X

14

1X

12

0X2X X-CO

M

VCC

GND

VEE

INH

Y-CO

M2Y

LOGI

C LE

VEL

CONV

ERTO

R

COUT

IN

COUT

IN

COUT

IN

COUT

IN

COUT

IN

COUT

IN

COUT

IN

COUT

IN

1

0Y

4 5

1Y3Y

IC1502, 1503 TC74LVX4051FT

IC1506 TC74LVX4052FT

70

HCD-ZX80D/ZX100D

– PANEL Board –

IC904 NJM2760V-TE2

IN1 1

BPF2OUT15

BPF1OUT16

RECOUT17

BPF2OUT20

IN2 2

BUF1OUT 3

BPF2IN1 4BPF2IN2 5

BAND-PASSFILTER

BPF3IN1 6BPF3IN2 7

BAND-PASSFILTER

BPF4IN1 8BPF4IN2 9

GND 10

BAND-PASSFILTER

DET

DET

BPF1IN219BPF1IN118

BAND-PASSFILTERDET

BPF3OUT14DET

BPF4OUT13

N.C.12V+11

DET

71

HCD-ZX80D/ZX100D

• IC Pin Function Description

DMB15 BOARD IC102 CXD9849R (RF AMP, SERVO DSP, MPEG DECODER)

Pin No. Pin Name I/O Description

1 AGND - Ground terminal

2 DVDA I AC coupled input path A

3 DVDB I AC coupled input path B

4 DVDC I AC coupled input path C

5 DVDD I AC coupled input path D

6 DVDRFIP I AC coupled DVD RF signal input from the optical pick-up block

7 DVDRFIN I AC coupled DVD RF signal input terminal Not used

8 MA I DC coupled main-beam RF signal input A

9 MB I DC coupled main-beam RF signal input B

10 MC I DC coupled main-beam RF signal input C

11 MD I DC coupled main-beam RF signal input D

12 SA I DC coupled sub-beam RF signal input A Not used

13 SB I DC coupled sub-beam RF signal input B Not used

14 SC I DC coupled sub-beam RF signal input C Not used

15 SD I DC coupled sub-beam RF signal input D Not used

16 CDFON I CD focusing error negative input terminal Not used

17 CDFOP I CD focusing error positive input terminal Not used

18 TNI I 3 beam satellite PD signal negative input from the optical pick-up block

19 TPI I 3 beam satellite PD signal positive input from the optical pick-up block

20, 21 MDI1, MDI2 I Laser power monitor input from the optical pick-up block

22 LDO2 O Laser diode drive signal output to the optical pick-up block (for DVD)

23 LDO1 O Laser diode drive signal output to the optical pick-up block (for CD)

24 SVDD3 - Power supply terminal (+3.3V)

25 CSO O Central servo signal output terminal Not used

26 RFLVL O RFRP low pass output terminal Not used

27 SGND - Ground terminal

28 V2REFO O Reference voltage (+2.8V) output terminal Not used

29 V2O O Reference voltage (+2V) output to the optical pick-up block

30 VREFO O Reference voltage (+1.4V) output terminal

31 FEO O Focus error monitor output terminal Not used

32 TEO O Tracking error monitor output terminal Not used

33 TEZISLV O Slice level of tracking error signal output terminal Not used

34 OPOUT O Output from the internal operational amplifier Not used

35, 36 OPIN I Input to the internal operational amplifier Not used

37 DMO O Spindle motor control signal output to the motor driver

38 FMO O Sled motor control signal output to the motor driver

39 TROPENPWM O Loading motor control signal output terminal Not used

40 IOPMON I Power monitor terminal

41 TRO O Tracking coil control signal output to the coil driver

42 FOO O Focus coil control signal output to the coil driver

43 DVSS - Ground terminal

44, 45 NC - Not used

46 DVDD3 - Power supply terminal (+3.3V)

47 SPFG I Spindle motor hall sensor input from the motor driver

48 DSEL O Interlace/progressive selection signal output terminal Not used

72

HCD-ZX80D/ZX100D


49 WIDE ONormal/squeeze selection signal output to the video amplifier"L": normal, "H": squeeze

50 MSW O CD/DVD selection signal output terminal "L": CD, "H": DVD

51 MAMUTE - Muting control signal output terminal Not used


53 to 61IOA2 to IOA8,IOA18, IOA19

O Address signal output to the flash ROM


63 APLLCAP - Connection terminal for an external capacitor

64 APLLVSS - Ground terminal

65 VDD3 - Power supply terminal (+3.3V)

66 IOWR O Write enable signal output to the flash ROM

67 to 72 IOA16 to IOA11 O Address signal output to the flash ROM


74 to 76IOA10, IOA9,

IOA20O Address signal output to the flash ROM

77 IOCS O Chip select signal output to the flash ROM

78 IOA1 O Address signal output to the flash ROM

79 IOOE O Output enable signal output to the flash ROM


81 to 84 AD0 to AD3 I/O Data/address signal input/output terminal with the flash ROM


86 to 88 AD4 to AD6 I/O Data/address signal input/output terminal with the flash ROM

89 IOA21 O Address signal output to the flash ROM

90 ALE O Address latch enable signal output terminal Not used

91 AD7 I/O Data/address signal input/output terminal with the flash ROM

92, 93 IOA17, IOA0 O Address signal output to the flash ROM


95 UWR O Write enable signal output terminal Not used

96 URD O Data read enable signal output terminal Not used


98 IFSDO O Serial data output to the master controller

99 IFCK O Serial data transfer clock signal output to the master controller

100 XIFCS O Chip select signal output to the master controller

101 IFSDI I Serial data input from the master controller

102 SCL O Serial data transfer clock signal output to the EEPROM and D/A converter

103 SDA I/O Two-way data bus with the EEPROM and D/A converter

104 TRG-SW I Trigger detection switch input terminal Not used

105 IFBSY I Busy signal input from the master controller

106 RXD I Receive data input terminal for UART communication when data writing to flash memory

107 TXD O Transmit data output terminal for UART communication when data writing to flash memory


109 ICE I ICE mode enable signal input terminal Not used

110 PRST I Reset signal input from the master controller "L": reset

111 IR I IR control signal input terminal Not used

112 INT0 O Interrupt request signal output terminal Not used

113 DQM0 O Data mask signal output to the SD-RAM

114 MREQ O Muting request signal output terminal Not used

73

HCD-ZX80D/ZX100D


115 RD7 I/O Two-way data bus with the SD-RAM


117, 118 RD6, RD5 I/O Two-way data bus with the SD-RAM


120, 121 RD4, RD3 I/O Two-way data bus with the SD-RAM


123 to 126 RD2 to RD0, RD15 I/O Two-way data bus with the SD-RAM


128 to 133 RD14 to RD9 I/O Two-way data bus with the SD-RAM


135 RD8 I/O Two-way data bus with the SD-RAM

136 GPIO - Not used

137 DQM1 O Data mask signal output to the SD-RAM

138 RWE O Write enable signal output to the SD-RAM

139 CAS O Column address strobe signal output to the SD-RAM

140 RAS O Row address strobe signal output to the SD-RAM


142 RCS O Chip select signal output to the SD-RAM

143 BA0 O Bank address signal output to the SD-RAM


145 BA1 O Bank address signal output to the SD-RAM

146, 147 RA10, RA0 O Address signal output to the SD-RAM


149 to 151 RA1 to RA3 O Address signal output to the SD-RAM




156 RCLK O Serial data transfer clock signal output to the SD-RAM

157 CKE O Clock enable signal output to the SD-RAM

158 to 160 RA11, RA9, RA8 O Address signal output to the SD-RAM


162 RA7 O Address signal output to the SD-RAM


164 to 166 RA6 to RA4 O Address signal output to the SD-RAM


168 DISC/X - Not used

169 RGB - Not used

170 TSD_M O Thermal shut down signal output to the motor/coil driver



174 FWD O Loading motor drive signal output terminal (forward direction) Not used

175 NC - Not used

176 LIMSW I Limit detection switch input terminal

177 OCSW I Disc table open/close detection switch input terminal Not used

178 REV O Loading motor drive signal output terminal (reverse direction) Not used

179 CKSW I Chucking detection switch input terminal Not used


74

HCD-ZX80D/ZX100D



183 to 188 NC - Not used

189 DAVCC - Power supply terminal (+3.3V)

190 VREF - For bandgap reference voltage terminal

191 FS - Full scale adjustment terminal

192 YUV0 O Video data output terminal Not used

193 DAVSS - Ground terminal

194 YUV1 O Y signal output to the video amplifier

195 DAVDD - Power supply terminal (+3.3V)

196 YUV2 O Chroma signal output to the video amplifier


198 YUV3 O Video signal output to the video amplifier

199 DAVDD - Power supply terminal (+3.3V)

200 YUV4 O Chroma signal output to the video amplifier


202, 203 YUV5, YUV6 O Component video signal output to the video amplifier


205 MIC I Microphone detection signal input from the master controller "H": microphone in

206 VOICE I Voice signal input terminal

207 KRMOD O Karaoke mode selection signal output to the master controller "H": karaoke mode

208 SMSCK I Score signal input terminal

209 SPDATA I SPDIF digital audio data input from the A/D converter

210 MUTE O Muting signal output to the motor/coil driver

211 MUTE123 O Muting signal output to the motor/coil driver


213 ALRCK O L/R sampling clock signal output to the D/A converter and A/D converter

214 ABCK O Bit clock signal output to the D/A converter and A/D converter

215 ACLK O Master clock signal output to the D/A converter and A/D converter


217 to 219ASDATA0 to

ASDATA2O Audio serial data output to the D/A converter

220 XRST O Reset signal output to the D/A converter "L": reset


222 ASDATA4 O Audio serial data output to the D/A converter


224 DWIDE - Not used

225 SPDIF O SPDIF digital audio signal output terminal Not used

226 RFGND18 - Ground terminal

227 RFVDD18 - Power supply terminal (+1.8V)

228 XTALO O System clock output terminal (27 MHz)

229 XTALI I System clock input terminal (27 MHz)

230 JITFO O Output terminal of the RF jitter meter

231 JITFN I Input terminal of the RF jitter meter

232 PLLVSS - Ground terminal

233 IDAC - Not used

234 PLLVDD3 - Power supply terminal (+3.3V)

235 LPFON O Data PLL loop filter output terminal

236 LPFIP I Data PLL loop filter input terminal

75

HCD-ZX80D/ZX100D


237 LPFIN I Data PLL loop filter input terminal

238 LPFOP O Data PLL loop filter output terminal

239 VDD3 - Power supply terminal (+3.3V)

240 NC - Not used

241 VSS - Ground terminal


244 RFVDD3 - Power supply terminal (+3.3V)

245 RFRPDC O RF ripple detect output terminal

246 RFRPAC I RF ripple detect input terminal

247 HRFZC I High frequency RF ripple zero crossing terminal

248 CRTPLP O Defect level filter capacitor connecting terminal

249 RFGND - Ground terminal


252 OSP O RF offset cancellation capacitor connecting terminal

253 OSN O RF offset cancellation capacitor connecting terminal

254 RFGC O RF AGC loop capacitor connecting for DVD-ROM

255 IREF I Reference current input terminal

256 AVDD3 - Power supply terminal (+3.3V)

76

HCD-ZX80D/ZX100D

MAIN BOARD IC401 M30622MEP-A78FPU0 (MASTER CONTROLLER)


1 TUNED I Tuning detection signal input from the tuner (FM/AM) "L": tuned

2 ST-DOUT O PLL serial data output to the tuner (FM/AM)

3 ST-CLK O PLL serial data transfer clock signal output to the tuner (FM/AM)

4 SIRCS I Remote control signal input from the remote control receiver

5 ST-DIN I PLL serial data input from the tuner (FM/AM)

6 ST-CE O PLL serial chip enable signal output to the tuner (FM/AM)

7 STBY-RELAY O Relay drive signal output for the main power "H": power on

8 BYTE I External data bus width selection signal input terminal Fixed at "L" in this set

9 CNVSS I Processor mode switch input terminal (for test)

10 XC-IN I Sub system clock input terminal (32.768 kHz)

11 XC-OUT O Sub system clock output terminal (32.768 kHz)

12 RESET ISystem reset signal input from the reset signal generator "L": resetFor several hundreds msec. after the power supply rises, "L" is input, then it change to "H"

13 X-OUT O Main system clock output terminal (5 MHz)


15 X-IN I Main system clock input terminal (5 MHz)

16 VCC - Power supply terminal (+3.3V)

17 NMI I Non-maskable interrupt input terminal Fixed at "H" in this set

18EFFECTOR-

SELECTO Effector on/off control signal output to the signal selector "H": effector on

19 EFFECTOR-S0 O Effector circuit delay time selection signal output to the multiplexer

20 AC-CUT I AC cut on/off detection signal input from the reset signal generator "L": AC cut on

21 MIC STATUS O Microphone detection signal output to the servo DSP "H": microphone in

22 MTK-KMOD I Karaoke mode selection signal input from the servo DSP "H": karaoke mode

23 MTK-IFBSY O Busy signal output to the servo DSP

24 MTK-XIFCS I Chip select signal input from the servo DSP

25 MTK-RESET O Reset signal output to the servo DSP "L": reset

26 EJECT SW I Disc table open/close detection signal input terminal "L": open, "H": close

27 TBL SENS I Disc table address sensor input terminal

28 E3 I Disc table address detection signal input terminal

29 IIC-CLK I/O Two-way IIC clock bus with the display controller

30 IIC-DATA I/O Two-way I2C data bus with the display controller

31 MTK-SIO O Serial data output to the servo DSP

32 MTK-SOD I Serial data input from the servo DSP

33 MTK-CLK I Serial data transfer clock signal input from the servo DSP

34, 35 E2, E1 I Disc table address detection signal input terminal

36 TM-F O Table motor drive signal output terminal (forward direction)

37 TM-R O Table motor drive signal output terminal (reverse direction)

38 LM-F O Loading motor drive signal output terminal (forward direction)

39 LM-R O Loading motor drive signal output terminal (reverse direction)

40 GC-RESET O Reset signal output to the display controller "L": reset

41 STBY-LED OLED drive signal output terminal"L": red LED on (standby mode),"H": green LED on (power on mode)

42 FAN CONTROL O Fan motor on/off control signal output terminal "L": motor on

43 to 45EFFECTOR-S1 to

EFFECTOR-S3O Effector circuit delay time selection signal output to the multiplexer

77

HCD-ZX80D/ZX100D


46ANALOG-IN-

MUTEO Analog signal muting on/off control signal output terminal "H": muting on

47 A-HALF I Deck-A cassette detection signal input from the tape mechanism deck block "L": cassette in

48 A-TRIG O Deck-A side trigger plunger drive signal output terminal "H": plunger on

49 B-TRIG O Deck-B side trigger plunger drive signal output terminal "H": plunger on

50 CAPM O Capstan/reel motor drive signal output terminal "L": FWD/stop, "H": REV

51 SW-SPK RELAY ORelay drive signal output for the subwoofer (SS-WGV100D) "H": relay on(HCD-ZX100D only)

52 REC BIAS O Recording bias on/off control signal output terminal "H": bias on

53 TC-RELAY O Recording/playback selection signal output terminal "L": playback, "H": recording

54 REC MUTE O Recording muting on/off control signal output to the REC/PB EQ amplifier "L": muting on

55 PB A/B O DECK-A/B selection signal output to the REC/PB EQ amplifier "L": deck-B, "H": deck-A

56 ALC O Automatic limiter on/off control signal output to the REC/PB EQ amplifier "H": limiter on

57 EFFECTOR-CTR1 OEffector mode control signal output terminal"L": delay1, delay 2, effector off, "H": flanger 1, flanger 2, chorus 1, chorus 2

58 FAN HI SPEED O Fan motor speed control signal output terminal "L": hi speed

59 NO USE - Not used

60 STK-MUTE OSystem muting on/off control signal output terminal "L": muting on, "H": power amplifier onMuting on/off control signal output for subwoofer out "L": muting on (HCD-ZX80D only)

61 REAR-RELAY O Relay drive signal output for the surround (rear) speaker "H": relay on

62 VCC - Power supply terminal (+3.3V)

63 EFFECTOR-CTR2 OEffector mode control signal output terminal"L": delay 2, effector off, "H": flanger 1, flanger 2, chorus 1, chorus 2, delay1


65 CTR-RELAY O Relay drive signal output for the center speaker "H": relay on

66 FR-RELAY O Relay drive signal output for the front speaker "H": relay on

67 PROTECT I Speaker protect detection signal input terminal "L": protect on

68 OVER VOLTAGE IOver voltage detection signal input terminal "H": over voltage is detected(Except US and Mexican models only)

69 UNDER VOLTAGE IUnder voltage detection signal input terminal "L": under voltage is detected(Except US and Mexican models only)

70 EFFECTOR-CTR3 OEffector mode control signal output terminal"L": chorus 1, chorus 2, effector off, "H": flanger 1, flanger 2, delay1, delay 2

71 TC-MUTE O Playback muting on/off control signal output terminal "H": muting on

72 HP-MUTE O Headphone muting on/off control signal output terminal "H": muting on

73 DISPLAY-KEY I DISPLAY key input terminal (interrupt input)

74 POWER-KEY I POWER key input terminal (interrupt input)

75 SW-MUTE O Muting on/off control signal output for subwoofer out "L": muting on (HCD-ZX80D only)

76 LINE-MUTE O Line muting on/off control signal output terminal "H": muting on

77 DVD-A-MUTE O CD/DVD analog signal muting on/off control signal output terminal "H": muting on

78 MTK-POWER O Power on/off control signal output for the CD/DVD sections "H": power on

79 AUDIO-IC-DATA O Serial data output to the audio control

80 AUDIO-IC-CLK O Serial data transfer clock signal output to the audio control

81 VOL-IC-DATA O Serial data output to the electrical volume

82 VOL-IC-CLK O Serial data transfer clock signal output to the electrical volume

83 AUDIO-OUT-SW O Audio out muting on/off control signal output terminal "H": muting on

84 HP-DETECT I Headphone detection signal input terminal "H": headphone in

85 MIC-DETECT I Microphone detection signal input terminal "H": microphone in

Ver. 1.1

78

HCD-ZX80D/ZX100D



87 VIDEO-OUT-SW O Composite video out selection signal output to the video switch"L": DVD video output, "H": video input output

88 VMUTE O Video muting on/off control signal output to the video amplifier "L": muting on

89 A-SHUT I Deck-B tape reel rotating detection signal input from the tape mechanism deck block

90 B-SHUT I Deck-A tape reel rotating detection signal input from the tape mechanism deck block

91 B-HALF IDeck-B cassette detection signal, recording-proof (forward direction) detection signal andrecording-proof (reverse direction) detection signal input from the tape mechanism deck block(A/D input) "L": cassette in and recording possible

92 MODEL-IN I Model setting input terminal (A/D input)

93 DEST-IN I Destination setting input terminal (A/D input)

94 THERMAL VACS I Thermal VACS detection signal input from thermal sensor (A/D input)

95 SW-LEVEL-IN I Subwoofer volume level detection signal input from the SS-WGV100D (HCD-ZX100D only)

96 AVSS - Ground terminal (for A/D conversion)


98 VREF I Reference voltage (+3.3V) input terminal (for A/D converter)

99 AVCC - Power supply terminal (+3.3V) (for A/D conversion)

100 SW-LED O LED drive signal output to the SS-WGV100D for subwoofer on indicator "H": LED on(HCD-ZX100D only)

79

HCD-ZX80D/ZX100D

PANEL BOARD IC902 MB90M407PF-G-149E1 (DISPLAY CONTROLLER)


1 to 8 G8 to G1 O Grid drive signal output to the fluorescent indicator tube

9, 10 P1, P2 O Segment drive signal output to the fluorescent indicator tube

11 VSS-IO - Ground terminal (for I/O port)

12 to 22 P3 to P13 O Segment drive signal output to the fluorescent indicator tube

23 VDD-FIP - Power supply terminal (+3.3V) (for fluorescent indicator tube)


42 VSS-IO - Ground terminal (for I/O port)


48 VKK - Power supply terminal (-36V) (for fluorescent indicator tube)

49, 50 MD0, MD1 I Setting terminal for the CPU operation mode Fixed at "H" in this set

51 MD2 I Setting terminal for the CPU operation mode Fixed at "L" in this set

52LED-CD/DVD,

TUNERO LED drive signal output for the DVD and TUNER/BAND indicator "H": LED on

53LED-TAPE,

TV/SATO LED drive signal output for the TAPE A/B and TV/SAT indicator "H": LED on

54LED-VIDEO,

(PAUSE, STOP)O LED drive signal output for the VIDEO, pause and stop indicator "H": LED on

55LED-

(AMS+, AMS-),(FF, FR)

O LED drive signal output for the AMS+, AMS-, FF and FR indicator "H": LED on

56 LED-VOLUME 1, 2 O LED drive signal output for the volume level 1 and 2 indicator "H": LED on




60 I2C-DATA I/O Two-way I2C data bus with the master controller

61 I2C-CLOCK I/O Two-way I2C clock bus with the master controller

62 AVCC - Power supply terminal (+3.3V) (for A/D converter)

63 AVSS - Ground terminal (for A/D converter)

64 to 66 KEY 0 to KEY 2 I Front and top panel key input terminal (A/D input)

67 ALL-BAND I Spectrum analyzer drive signal input from the band-pass filter

68 BF4 I Spectrum analyzer drive signal input from the band-pass filter (for 80 Hz)

69 BF3 I Spectrum analyzer drive signal input from the band-pass filter (for 300 Hz)

70 BF2 I Spectrum analyzer drive signal input from the band-pass filter (for 1.2 kHz)

71 BF1 I Spectrum analyzer drive signal input from the band-pass filter (for 8 kHz)

72 OPERATION DIAL I Jog dial pulse input from the rotary encoder (OPERATION DIAL)

73 JOG-X-ROUND I Jog dial pulse input from the rotary encoder (X-ROUND JOG)

74 VOLUME I Jog dial pulse input from the rotary encoder (MASTER VOLUME)

75LED-

(BEAT JUMP,BEAT MAX)

O LED drive signal output for the BEAT JUMP and BEAT MAX indicator "H": LED on

76LED- (BALANCE,WAVE, FADER,

RANDOM), DELAYO

LED drive signal output for the BALANCE, WAVE, FADER, RANDOM and DELAY indicator"H": LED on

77 RESET I Reset signal input from the master controller "L": reset

78 LED-FLANGER,CHORUS

O LED drive signal output for the FLANGER and CHORUS indicator "H": LED on

79 LED-PLAY O LED drive signal output for the play indicator "H": LED on

80 LED SELECTOR O LED selection signal output terminal

80

HCD-ZX80D/ZX100D


81 VSS-CPU - Ground terminal (for CPU)

82 XOUT O System clock output terminal (4 MHz)

83 XIN I System clock input terminal (4 MHz)

84 VCC-CPU - Power supply terminal (+3.3V) (for CPU)

85 to 100 G24 to G9 O Grid drive signal output to the fluorescent indicator tube

81

HCD-ZX80D/ZX100D

1

#1

#4

#1 #1

#1

#4

#4not supplied

not supplied

not supplied

PANEL board section

back panel section

not supplied(X-ROUND board)

2211

10

2

34

5#2

#2

6

7

6

7

8

9

SECTION 8EXPLODED VIEWS

• Items marked “*” are not stocked since theyare seldom required for routine service. Somedelay should be anticipated when orderingthese items.

• The mechanical parts with no referencenumber in the exploded views are not supplied.

• Accessories are given in the last of theelectrical parts list.

NOTE:• -XX and -X mean standardized parts, so they

may have some difference from the originalone.

• Color Indication of Appearance PartsExample:KNOB, BALANCE (WHITE) . . . (RED)

↑ ↑Parts Color Cabinet's Color

The components identified by mark0 or dotted line with mark 0 arecritical for safety.Replace only with part numberspecified.

• AbbreviationE2 : 120V AC area in E modelE3 : 240V AC area in E modelE13 : Russian model and 220 – 230V AC area in E model

E51 : Chilean and Peruvian modelsMX : Mexican modelMY : Malaysia model

Ref. No. Part No. Description Remark

8-1. CASE, ESCUTCHEON TOP SECTION

Ref. No. Part No. Description Remark

1 2-655-708-51 PANEL, LOADING (ZX80D: US, E3, E13)1 2-655-708-61 PANEL, LOADING (ZX100D: E3, SP, MY)1 2-685-144-11 PANEL, LOADING (ZX80D: E2, MX)1 2-685-144-21 PANEL, LOADING (ZX100D: E2, MX)1 2-685-144-31 PANEL, LOADING (ZX80D: E51)

1 2-685-144-41 PANEL, LOADING (ZX100D: E51)2 3-087-053-01 +BVTP2.6 (3CR)3 2-662-067-01 BUTTON (SPEAKER)

(SPEAKERS/X-ROUND OFF)4 2-662-065-01 JOG (X-ROUND)5 X-2108-715-1 ESCUTCHEON TOP ASSY

(ZX80D: E2, E3, E13, E51, MX/ZX100D)

5 X-2177-645-1 ESCUTCHEON TOP ASSY (ZX80D: US)6 3-363-099-02 SCREW (CASE 3 TP2)7 3-363-099-32 SCREW (CASE 3 TP2)8 2-342-137-51 CASE9 4-225-252-21 CUSHION (FOOT)

10 3-077-331-01 +BV3 (3-CR)11 4-237-065-01 CLAMP (L35)#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3#2 7-685-648-79 SCREW +BVTP 3X12 TYPE2 IT-3#4 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3

SP : Singapore model

Ver. 1.1

82

HCD-ZX80D/ZX100D

8-2. PANEL BOARD SECTION

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

51 X-2108-713-1 KNOB VOLUME ASSY52 X-2108-714-1 KNOB JOG ASSY53 3-087-053-01 +BVTP2.6 (3CR)54 A-1174-314-A FUNCTION BOARD, COMPLETE55 1-828-991-11 WIRE (FLAT TYPE) (17 CORE)

56 A-1174-175-A PANEL BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

51

52

53

53

53

53

575353

53

58

54

55

56

not supplied(JOG board)

not supplied

tape mecha deck section

not supplied(CD-SW board)

not supplied

(ZX100D)

56 A-1174-312-A PANEL BOARD, COMPLETE (ZX80D: US, E2, E3,E13, E51/ZX100D: E2, E3, E51, SP, MY)

57 1-828-942-11 WIRE (FLAT TYPE) (7 CORE)58 1-828-992-11 WIRE (FLAT TYPE) (17 CORE)

Ver. 1.1

83

HCD-ZX80D/ZX100D

8-3. TAPE MECHA DECK SECTION


101 4-224-578-31 KNOB (MIC)102 2-655-724-21 LID (TC)103 4-224-104-11 DAMPER104 2-655-733-01 SPRING (L)105 2-655-732-01 SPRING (LID)

106 2-655-734-01 SPRING (R)107 3-087-053-01 +BVTP2.6 (3CR)108 4-252-578-11 HOLDER TC-L109 4-959-229-11 DETENT, CASSETTE110 4-252-579-11 HOLDER TC-R

111 4-244-092-01 SPRING (EJECT)

112 3-077-331-21 +BV3 (3-CR)113 1-417-658-11 MECHA DECK (CWN42RR603)114 A-1174-047-A MIC BOARD, COMPLETE115 1-828-964-11 WIRE (FLAT TYPE) (11 CORE)

116 4-225-252-21 CUSHION (FOOT)117 X-2108-712-1 FRONT PANEL ASSY

(ZX80D: E3, E13, E51/ZX100D: E3, E51, SP, MY)117 X-2109-461-1 FRONT PANEL ASSY

(ZX80D: E2, MX/ZX100D: E2, MX)117 X-2176-353-1 FRONT PANEL ASSY (ZX80D: US)

#5 7-685-853-04 SCREW +BVTT 2X6 (S)

101

not supplied

not supplied

not supplied

not supplied

not supplied#5

not supplied

not supplied

not suppliednot supplied

not supplied

116

116102

103

117

103

104

105

106

107115

107

107

107

112

107

107

107

108109

109

110

111

113

114

Ver. 1.1Ver. 1.1

84

HCD-ZX80D/ZX100D

8-4. BACK PANEL SECTION


0151 1-468-737-51 POWER SWITCHING(ZX80D: E2, E3, E13, E51, MX/ZX100D)

0151 1-468-737-61 POWER SWITCHING (ZX80D: US)152 1-693-702-11 TUNER (FM/AM) (TM10SE)

(ZX80D: E2, E3, E13, E51, MX/ZX100D)152 1-693-703-11 TUNER (FM/AM) (TM10SU) (ZX80D: US)153 3-378-109-12 CUSHION, SARANET

154 1-828-358-11 WIRE (FLAT TYPE) (19 CORE)155 A-1173-807-A EFFECTOR BOARD, COMPLETE

(ZX80D: US, E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

155 A-1174-198-A EFFECTOR BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

151

159

159

#1#1

#1

#1

#1

#2

#3

#4

#4

#4

#4

#4

#4

#4

#4

#4

not supplied

not supplied

not supplied


notsupplied

not supplied

DMB15/KARAOKE/VIDEOboards section

MAIN/PA/SURROUNDboards section

notsupplied

not supplied(PRIMARY board)

158

156

(ZX100D)

(ZX100D)

152

153

157

154

155

M501

156 1-828-973-11 WIRE (FLAT TYPE) (13 CORE)157 1-828-956-11 WIRE (FLAT TYPE) (9 CORE)

158 3-701-748-00 CLAMP159 4-237-065-01 CLAMP (L35)M501 1-787-400-11 D.C. FAN#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3#2 7-685-648-79 SCREW +BVTP 3X12 TYPE2 IT-3

#3 7-685-651-79 SCREW +BVTP 3X20 TYPE2 N-S#4 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3

Ver. 1.1

85

HCD-ZX80D/ZX100D

8-5. DMB15/KARAOKE/VIDEO BOARDS SECTION


201 A-1193-305-A KARAOKE BOARD, COMPLETE(ZX80D: US, E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

201 A-1193-346-A KARAOKE BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

202 A-1174-061-A VIDEO BOARD, COMPLETE(ZX80D: US, E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

202 A-1174-224-A VIDEO BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

203 1-828-326-11 WIRE (FLAT TYPE) (13 CORE)

204 A-1174-227-A DMB15 BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

204 A-1174-274-A DMB15 BOARD, COMPLETE(ZX80D: E3, E13/ZX100D: E3)

201

#4 #4

#4

#4

#4#4

not supplied

not supplied

DVD mechanism deck section-1(CDM74HF-DVBU101)

not supplied

not supplied

not supplied

202

203

208

206

209

210

210

209

205

207204

(ZX80D: US)

204 A-1193-183-A DMB15 BOARD, COMPLETE (ZX100D: SP, MY)204 A-1193-188-A DMB15 BOARD, COMPLETE

(ZX80D: E2, E51/ZX100D: E2, E51)204 A-1227-260-A DMB15 BOARD, COMPLETE (ZX80D: US)

205 1-828-332-11 WIRE (FLAT TYPE) (13 CORE)206 1-828-632-11 WIRE (FLAT TYPE) (21 CORE)207 1-828-252-11 WIRE (FLAT TYPE) (24 CORE)208 3-577-414-01 SPACER (ZX80D: US)

* 209 1-481-077-11 CORE, FERRITE (ZX80D: US)

210 3-381-709-01 CUSHION, SARANET (ZX80D: US)#4 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3

Note: Refer to the Servicing Notes “NOTES ON REPLACEMENT OFTHE DMB15 BOARD” (pagr 4), if replacing the Ref. No. 204.

Ver. 1.1

86

HCD-ZX80D/ZX100D

8-6. MAIN/PA/SURROUND BOARDS SECTION


251 4-225-252-01 CUSHION (FOOT)252 4-900-386-01 SCREW253 3-077-331-21 +BV3 (3-CR)254 A-1174-202-A PA BOARD, COMPLETE (ZX80D: MX)254 A-1174-267-A PA BOARD, COMPLETE (ZX100D: MX)

254 A-1174-326-A PA BOARD, COMPLETE (ZX80D: E3, E13)254 A-1174-337-A PA BOARD, COMPLETE (ZX100D: E3, SP, MY)254 A-1193-201-A PA BOARD, COMPLETE (ZX80D: US, E2, E51)254 A-1193-204-A PA BOARD, COMPLETE (ZX100D: E2, E51)255 3-905-609-31 SCREW (TRANSISTOR)

256 A-1174-185-A SURROUND BOARD, COMPLETE (ZX80D: MX)256 A-1174-262-A SURROUND BOARD, COMPLETE (ZX100D: MX)256 A-1174-323-A SURROUND BOARD, COMPLETE

(ZX80D: US, E2, E3, E13, E51)256 A-1174-333-A SURROUND BOARD, COMPLETE

(ZX100D: E2, E3, E51, SP, MY)257 A-1174-078-A MAIN BOARD, COMPLETE (ZX80D: E3)

257 A-1174-169-A MAIN BOARD, COMPLETE (ZX80D: MX)257 A-1174-256-A MAIN BOARD, COMPLETE (ZX100D: MX)257 A-1174-328-A MAIN BOARD, COMPLETE (ZX100D: E3)257 A-1193-164-A MAIN BOARD, COMPLETE (ZX80D: E13)257 A-1193-167-A MAIN BOARD, COMPLETE (ZX80D: E2)

257 A-1193-171-A MAIN BOARD, COMPLETE (ZX100D: SP, MY)257 A-1193-174-A MAIN BOARD, COMPLETE (ZX100D: E2)257 A-1193-435-A MAIN BOARD, COMPLETE (ZX80D: E51)257 A-1193-438-A MAIN BOARD, COMPLETE (ZX100D: E51)257 A-1227-251-A MAIN BOARD, COMPLETE (ZX80D: US)

0258 1-777-071-53 CORD, POWER (ZX80D: E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

0258 1-783-820-11 CORD, POWER (ZX80D: US)0258 1-829-627-31 POWER-SUPPLY CORD

(ZX80D: MX/ZX100D: MX)* 259 3-703-244-00 BUSHING (2104), CORD


259 3-703-571-11 BUSHING (S) (4516), CORD (ZX80D: MX/ZX100D: MX)

D656 8-719-073-32 DIODE D25XB60D658 8-719-066-42 DIODE RBV1306 (ZX80D)D658 8-719-073-32 DIODE D25XB60 (ZX100D)M502 1-787-400-11 D.C. FAN#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

#4 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3

251

#1

#1

#4

#4

#4

#4

#4

#4

#4

#4

not supplied

not supplied

M502

not supplied

not supplied

D656

D658

not supplied

not supplied


not supplied

POWER TRANSFORMER section

not supplied

251

252 252

252

253

253

253

253

253

253253

253

254

255

255

255

256

257

258

259

Ver. 1.1

87

HCD-ZX80D/ZX100D

8-7. POWER TRANSFORMER SECTION


301 A-1174-058-A TRANS BOARD, COMPLETE(ZX100D: E2, E3, E51, SP, MY)

301 A-1174-204-A TRANS BOARD, COMPLETE (ZX80D: MX)301 A-1174-927-A TRANS BOARD, COMPLETE

(ZX80D: E2, E3, E13, E51)301 A-1174-928-A TRANS BOARD, COMPLETE (ZX100D: MX)301 A-1227-256-A TRANS BOARD, COMPLETE (ZX80D: US)

0F1241 1-533-949-33 FUSE, CYLINDRICAL (TIME LUG) (8A/250V)(ZX80D: E2, E3, E13, E51, MX/ZX100D)

0F1241 1-576-537-12 FUSE, GLASS TUBE (DIA. 5) (8A/125V)(ZX80D: US)







0F1281 1-532-465-33 FUSE (3.15A/250V)(ZX80D: E2, E3, E13, E51, MX/ZX100D)

0F1281 1-533-451-12 FUSE, GLASS TUBE (DIA. 5) (3.15A/125V)(ZX80D: US)

0F1291 1-532-465-33 FUSE (3.15A/250V)(ZX80D: E2, E3, E13, E51, MX/ZX100D)


0T1200 1-443-977-11 POWER TRANSFORMER(ZX100D: E2, E3, E51, SP, MY)

0T1200 1-443-978-11 POWER TRANSFORMER (ZX100D: MX)0T1200 1-445-024-11 POWER TRANSFORMER

(ZX80D: E2, E3, E13, E51)

0T1200 1-445-025-11 POWER TRANSFORMER (ZX80D: MX)0T1200 1-445-153-11 POWER TRANSFORMER (ZX80D: US)

301

F1241

F1251F1261

F1271

F1281

F1291

T1200

Ver. 1.1

88

HCD-ZX80D/ZX100D

8-8. DVD MECHANISM DECK SECTION-1(CDM74HF-DVBU101)


501 4-218-253-42 SCREW (M2.6), +BTTP502 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)503 1-687-134-12 MOTOR (TB) BOARD504 4-243-815-11 TABLE (LOADING)505 4-245-571-02 GEAR (STOPPER)

506 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING507 4-245-570-01 GEAR (JOINT)508 4-245-572-01 BUSHING (GEAR)509 1-687-132-12 SENSOR BOARD

510 4-243-820-01 GEAR (TABLE)

511 4-243-819-01 GEAR (GENEVA)512 4-243-816-21 TRAY513 4-243-823-01 BELT (TABLE)514 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING515 4-243-821-01 PULLEY (TABLE)

516 3-231-598-01 SHEET (BA)M741 A-1108-965-A MOTOR ASSY, TABLE

504

505505

506506

507

507

508

508509

501

512

506

513514

515510511

514

DVD mechanism deck section-2(CDM74HF-DVBU101)

501

502

503

516

M741

89

HCD-ZX80D/ZX100D

8-9. DVD MECHANISM DECK SECTION-2(CDM74HF-DVBU101)


551 4-251-923-01 YOKE (310)552 4-218-253-32 SCREW (M2.6), +BTTP553 1-687-669-12 SW BOARD554 4-244-034-01 BELT (LOADING)555 4-218-252-52 SCREW (+PTPWH M2.6), FLOATING

556 4-225-844-01 GEAR (LOADING A)557 4-224-613-01 GEAR (SHAFT)558 1-687-133-12 MOTOR (LD) BOARD559 3-087-599-01 INSULATOR SCREW560 4-244-108-01 GEAR, SWING

561 4-224-609-01 GEAR (LOADING C)562 4-224-608-01 COLLAR, SWING563 3-016-533-11 WASHER (FR), STOPPER564 4-224-611-01 GEAR (LOADING B)

565 4-224-606-01 GEAR (RV)

566 4-243-818-01 GEAR (U/D)567 2-541-918-01 LEVER (LIFTER (H))568 2-345-982-01 PULLEY A (310), CHUCKING569 2-345-983-01 PULLEY B (310), CHUCKING570 2-634-618-01 INSULATOR

0571 8-820-291-02 OPTICAL PICK-UP BLOCK (KHM-310CAB/C2RP) (Including sled motor, spindle motor)


572 4-243-817-22 CHASSISM751 A-4737-553-A MOTOR ASSY, LOADING

S711 1-477-680-12 ENCODER, ROTARY(DISC TABLE ADDRESS DETECT)

551

552

552

552

553

554555

556

557

558

560

561

562

563

564

565

566

567

572 569

559

568

555

555

555

555

M751

S711

570

570

559

not supplied(DRIVER board)

not supplied

not supplied

571(including sled motor,spindle motor)

not supplied(spindle motor)

not supplied(sled motor)

Note: Refer to the Servicing Notes “HOW TO IDENTIFY OPTICALPICK-UP BLOCK” (pagr 4), if replacing the Ref. No. 571.

90

HCD-ZX80D/ZX100D

DMB15SECTION 9

ELECTRICAL PARTS LISTCD-SW


CD-SW BOARD*************

< CONNECTOR >

CN1152 1-568-850-11 SOCKET, CONNECTOR 7P

< RESISTOR >

R1166 1-216-817-11 METAL CHIP 470 5% 1/10WR1167 1-216-819-11 METAL CHIP 680 5% 1/10WR1168 1-216-821-11 METAL CHIP 1K 5% 1/10WR1169 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1170 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

< SWITCH >

S1166 1-762-875-21 SWITCH, KEYBOARD (Z OPEN/CLOSE)S1167 1-762-875-21 SWITCH, KEYBOARD (EX-CHANGE/DISC SKIP)S1168 1-762-875-21 SWITCH, KEYBOARD (DISC 3)S1169 1-762-875-21 SWITCH, KEYBOARD (DISC 2)S1170 1-762-875-21 SWITCH, KEYBOARD (DISC 1)

************************************************************

A-1174-227-A DMB15 BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

A-1174-274-A DMB15 BOARD, COMPLETE(ZX80D: E3, E13/ZX100D: E3)

A-1193-183-A DMB15 BOARD, COMPLETE (ZX100D: SP, MY)A-1193-188-A DMB15 BOARD, COMPLETE

(ZX80D: E2, E51/ZX100D: E2, E51)A-1227-260-A DMB15 BOARD, COMPLETE (ZX80D: US)

**********************

< CAPACITOR >

C101 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC102 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC105 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC106 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC108 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C109 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC112 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC113 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC114 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC115 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C116 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC117 1-124-779-00 ELECT CHIP 10uF 20% 16VC118 1-124-779-00 ELECT CHIP 10uF 20% 16VC119 1-124-779-00 ELECT CHIP 10uF 20% 16V

C120 1-165-908-11 CERAMIC CHIP 1uF 10% 10V

C121 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC122 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC123 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC124 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC125 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C126 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC127 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC128 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC129 1-124-779-00 ELECT CHIP 10uF 20% 16VC130 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C131 1-125-838-11 CERAMIC CHIP 2.2uF 10% 6.3VC132 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC133 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC135 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC136 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C137 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC138 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC139 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC140 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC144 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C146 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC147 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC148 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC149 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC150 1-124-779-00 ELECT CHIP 10uF 20% 16V

C151 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25VC152 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC153 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC154 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC155 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C156 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC158 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC159 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC160 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC161 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V


C171 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC172 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

NOTE:• Due to standardization, replacements in the

parts list may be different from the partsspecified in the diagrams or the componentsused on the set.

• -XX and -X mean standardized parts, so theymay have some difference from the originalone.

• RESISTORSAll resistors are in ohms.METAL: Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F: nonflammable

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.

• SEMICONDUCTORSIn each case, u: µ, for example:uA... : µA... uPA... : µPA...uPB... : µPB... uPC... : µPC...uPD... : µPD...

• CAPACITORSuF: µF

• COILSuH: µH


When indicating parts by referencenumber, please include the board.




New part of EEPROM (IC103) on the DMB15board cannot be used. Therefore, if the mountedDMB15 board is replaced, exchange newEEPROM with that used before the replacement.

Ver. 1.1


91

HCD-ZX80D/ZX100D

DMB15

C173 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC174 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC175 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C176 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC177 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC178 1-126-208-21 ELECT CHIP 47uF 20% 4VC179 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC180 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C181 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC182 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC184 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC187 1-126-208-21 ELECT CHIP 47uF 20% 4VC188 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16V

C189 1-128-934-11 CERAMIC CHIP 0.33uF 20% 10VC190 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC191 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC192 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC193 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16V

C195 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC196 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC203 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC205 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC206 1-164-230-11 CERAMIC CHIP 220PF 5% 50V


C213 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC214 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC215 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC217 1-126-204-11 ELECT CHIP 47uF 20% 16VC218 1-124-779-00 ELECT CHIP 10uF 20% 16V

C219 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC220 1-124-779-00 ELECT CHIP 10uF 20% 16VC221 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC222 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC224 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C233 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC301 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC302 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC305 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC306 1-126-206-11 ELECT CHIP 100uF 20% 6.3V

C307 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC402 1-126-204-11 ELECT CHIP 47uF 20% 16VC403 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC3601 1-117-370-11 CERAMIC CHIP 10uF 10VC3602 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C3603 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3605 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC3606 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3607 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3608 1-124-779-00 ELECT CHIP 10uF 20% 16V

C3609 1-124-779-00 ELECT CHIP 10uF 20% 16VC3610 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3611 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC3621 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC3701 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V


C3707 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3708 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3711 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3712 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3713 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C3714 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3721 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3722 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3723 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3724 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C3731 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3732 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3733 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3734 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3741 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50V

C3742 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3743 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3744 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3751 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3752 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C3753 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3754 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3761 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3762 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3763 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C3764 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3771 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3772 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3773 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3774 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C3781 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3782 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3783 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3784 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3801 1-126-206-11 ELECT CHIP 100uF 20% 6.3V

C3802 1-117-370-11 CERAMIC CHIP 10uF 10VC3803 1-126-209-11 ELECT CHIP 100uF 20% 4VC3804 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC3805 1-126-208-21 ELECT CHIP 47uF 20% 4V

< CONNECTOR >

CN101 1-815-763-32 CONNECTOR, FFC/FPC 24P* CN105 1-770-470-21 PIN, CONNECTOR (PC BOARD) 6P

CN106 1-784-372-51 CONNECTOR, FFC/FPC 13P* CN201 1-770-470-21 PIN, CONNECTOR (PC BOARD) 6P

CN301 1-784-372-51 CONNECTOR, FFC/FPC 13P

CN302 1-778-692-11 CONNECTOR, FFC/FPC 21PCN401 1-779-993-11 PIN, CONNECTOR (PWB) 5P

< DIODE >

D1001 8-719-058-24 DIODE RB501V-40TE-17D3501 8-719-988-61 DIODE 1SS355TE-17

Ver. 1.1


92

HCD-ZX80D/ZX100D

DMB15

D3502 8-719-988-61 DIODE 1SS355TE-17D3601 8-719-988-61 DIODE 1SS355TE-17D3602 8-719-988-61 DIODE 1SS355TE-17

< FERRITE BEAD >

FB111 1-414-226-21 INDUCTOR, FERRITE BEADFB112 1-414-226-21 INDUCTOR, FERRITE BEADFB113 1-414-226-21 INDUCTOR, FERRITE BEADFB114 1-414-226-21 INDUCTOR, FERRITE BEADFB115 1-414-226-21 INDUCTOR, FERRITE BEAD

FB401 1-469-324-21 FERRITE, EMI (SMD) (2012)FB402 1-469-324-21 FERRITE, EMI (SMD) (2012)FB403 1-469-324-21 FERRITE, EMI (SMD) (2012)FB404 1-469-324-21 FERRITE, EMI (SMD) (2012)FB405 1-469-324-21 FERRITE, EMI (SMD) (2012)

FB406 1-469-324-21 FERRITE, EMI (SMD) (2012)

< FILTER >

FL101 1-234-177-21 FILTER, CHIP EMIFL104 1-234-177-21 FILTER, CHIP EMIFL105 1-234-177-21 FILTER, CHIP EMIFL106 1-234-177-21 FILTER, CHIP EMIFL107 1-234-177-21 FILTER, CHIP EMI

FL108 1-234-177-21 FILTER, CHIP EMIFL401 1-234-177-21 FILTER, CHIP EMIFL402 1-233-893-21 FILTER, CHIP EMIFL403 1-234-177-21 FILTER, CHIP EMI

< IC >

IC101 6-806-614-01 IC S29AL032D70TF-CBA3-0601UC(ZX80D: MX/ZX100D: MX)

IC101 6-806-820-01 IC MX29LV320CBTC70-CBA3-0604UC(ZX80D: US, E2, E51/ZX100D: E2, E51)

IC101 6-806-821-01 IC MX29LV320CBTC70-CBA3-0604CE(ZX80D: E3, E13/ZX100D: E3)

IC101 6-806-822-01 IC MX29LV320CBTC70-CBA3-0604GA(ZX100D: SP, MY)

IC102 6-707-535-01 IC CXD9849R

IC103 (Not supplied) IC BR24L64F-WE2IC104 6-709-370-01 IC A2V64S40CTP-G75IC105 6-702-302-01 IC TK11133CSCL-GIC106 6-708-153-01 IC PQ018EN01ZPHIC107 6-702-302-01 IC TK11133CSCL-G

IC201 6-704-524-01 IC FAN8036LIC301 6-704-222-01 IC AK4358VQ-LIC3601 6-707-608-01 IC PCM1803DBRIC3711 8-759-359-49 IC NJM3414AV (TE2)IC3731 8-759-359-49 IC NJM3414AV (TE2)

IC3751 8-759-359-49 IC NJM3414AV (TE2)IC3771 8-759-359-49 IC NJM3414AV (TE2)

< COIL >

L3601 1-469-555-21 INDUCTOR 10uHL3602 1-469-555-21 INDUCTOR 10uH

< TRANSISTOR >

Q101 6-550-008-01 FET UM6K1N-TNQ102 6-550-653-01 TRANSISTOR QST8TR

Q103 8-729-027-52 TRANSISTOR DTC124EKA-T146Q3801 8-729-230-49 TRANSISTOR 2SC2712-YG

< RESISTOR/FERRITE BEAD >

R101 1-216-809-11 METAL CHIP 100 5% 1/10WR104 1-216-864-11 SHORT CHIP 0R105 1-216-833-11 METAL CHIP 10K 5% 1/10WR106 1-216-833-11 METAL CHIP 10K 5% 1/10WR107 1-216-833-11 METAL CHIP 10K 5% 1/10W

R108 1-216-857-11 METAL CHIP 1M 5% 1/10WR109 1-216-864-11 SHORT CHIP 0R110 1-216-841-11 METAL CHIP 47K 5% 1/10WR111 1-216-809-11 METAL CHIP 100 5% 1/10WR112 1-211-977-11 METAL CHIP 22 0.5% 1/10W

R113 1-211-977-11 METAL CHIP 22 0.5% 1/10WR114 1-216-845-11 METAL CHIP 100K 5% 1/10WR115 1-211-977-11 METAL CHIP 22 0.5% 1/10WR116 1-216-821-11 METAL CHIP 1K 5% 1/10WR117 1-216-841-11 METAL CHIP 47K 5% 1/10W

R118 1-216-801-11 METAL CHIP 22 5% 1/10WR120 1-216-801-11 METAL CHIP 22 5% 1/10WR121 1-216-801-11 METAL CHIP 22 5% 1/10WR123 1-216-864-11 SHORT CHIP 0R124 1-216-841-11 METAL CHIP 47K 5% 1/10W

R126 1-216-864-11 SHORT CHIP 0R127 1-216-809-11 METAL CHIP 100 5% 1/10WR136 1-216-835-11 METAL CHIP 15K 5% 1/10WR138 1-216-845-11 METAL CHIP 100K 5% 1/10WR141 1-218-916-11 METAL CHIP 750K 0.5% 1/10W

R142 1-216-845-11 METAL CHIP 100K 5% 1/10WR146 1-216-805-11 METAL CHIP 47 5% 1/10WR151 1-216-805-11 METAL CHIP 47 5% 1/10WR152 1-216-864-11 SHORT CHIP 0R153 1-216-805-11 METAL CHIP 47 5% 1/10W

R155 1-216-805-11 METAL CHIP 47 5% 1/10WR160 1-216-805-11 METAL CHIP 47 5% 1/10WR161 1-216-809-11 METAL CHIP 100 5% 1/10WR164 1-216-809-11 METAL CHIP 100 5% 1/10WR169 1-216-833-11 METAL CHIP 10K 5% 1/10W

R187 1-216-864-11 SHORT CHIP 0R189 1-218-827-11 METAL CHIP 150 0.5% 1/10WR190 1-218-827-11 METAL CHIP 150 0.5% 1/10WR191 1-216-821-11 METAL CHIP 1K 5% 1/10WR192 1-218-827-11 METAL CHIP 150 0.5% 1/10W

R193 1-216-821-11 METAL CHIP 1K 5% 1/10WR195 1-218-827-11 METAL CHIP 150 0.5% 1/10WR196 1-216-864-11 SHORT CHIP 0R197 1-218-827-11 METAL CHIP 150 0.5% 1/10WR204 1-216-822-11 METAL CHIP 1.2K 5% 1/10W

R205 1-216-833-11 METAL CHIP 10K 5% 1/10WR206 1-216-833-11 METAL CHIP 10K 5% 1/10WR207 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR208 1-216-839-11 METAL CHIP 33K 5% 1/10WR209 1-216-839-11 METAL CHIP 33K 5% 1/10W

R210 1-216-841-11 METAL CHIP 47K 5% 1/10WR212 1-216-833-11 METAL CHIP 10K 5% 1/10WR213 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR214 1-216-835-11 METAL CHIP 15K 5% 1/10W

New part of EEPROM (IC103) on the DMB15board cannot be used. Therefore, if the mountedDMB15 board is replaced, exchange newEEPROM with that used before the replacement.

Ver. 1.1


93

HCD-ZX80D/ZX100D

R215 1-216-834-11 METAL CHIP 12K 5% 1/10W

R216 1-216-834-11 METAL CHIP 12K 5% 1/10WR219 1-216-838-11 METAL CHIP 27K 5% 1/10WR220 1-216-833-11 METAL CHIP 10K 5% 1/10WR221 1-218-889-11 METAL CHIP 56K 0.5% 1/10WR223 1-218-895-11 METAL CHIP 100K 0.5% 1/10W

R224 1-216-833-11 METAL CHIP 10K 5% 1/10WR225 1-218-895-11 METAL CHIP 100K 0.5% 1/10WR226 1-218-889-11 METAL CHIP 56K 0.5% 1/10WR230 1-218-893-11 METAL CHIP 82K 0.5% 1/10WR231 1-218-875-11 METAL CHIP 15K 0.5% 1/10W

R232 1-218-877-11 METAL CHIP 18K 0.5% 1/10WR233 1-218-883-11 METAL CHIP 33K 0.5% 1/10WR234 1-216-833-11 METAL CHIP 10K 5% 1/10WR246 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR247 1-216-821-11 METAL CHIP 1K 5% 1/10W

R314 1-216-809-11 METAL CHIP 100 5% 1/10WR319 1-216-864-11 SHORT CHIP 0R321 1-216-864-11 SHORT CHIP 0R1101 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1102 1-218-827-11 METAL CHIP 150 0.5% 1/10W

R1103 1-216-833-11 METAL CHIP 10K 5% 1/10WR1104 1-216-833-11 METAL CHIP 10K 5% 1/10WR1105 1-216-833-11 METAL CHIP 10K 5% 1/10WR1108 1-216-864-11 SHORT CHIP 0R1109 1-216-864-11 SHORT CHIP 0

R1110 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR1120 1-216-864-11 SHORT CHIP 0R1121 1-216-864-11 SHORT CHIP 0R1122 1-216-864-11 SHORT CHIP 0R1123 1-216-864-11 SHORT CHIP 0

R1124 1-216-864-11 SHORT CHIP 0R1125 1-216-864-11 SHORT CHIP 0R1126 1-216-833-11 METAL CHIP 10K 5% 1/10WR1129 1-216-845-11 METAL CHIP 100K 5% 1/10WR1133 1-216-864-11 SHORT CHIP 0

R1134 1-216-864-11 SHORT CHIP 0R1150 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1151 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1152 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1161 1-216-864-11 SHORT CHIP 0

R1168 1-216-817-11 METAL CHIP 470 5% 1/10WR1502 1-216-864-11 SHORT CHIP 0R1504 1-400-244-11 BEAD, FERRITE (CHIP) (1608)R1524 1-216-864-11 SHORT CHIP 0R1526 1-216-864-11 SHORT CHIP 0

R1527 1-216-864-11 SHORT CHIP 0R1530 1-216-864-11 SHORT CHIP 0R1531 1-216-864-11 SHORT CHIP 0R1540 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1542 1-216-833-11 METAL CHIP 10K 5% 1/10W

R1543 1-216-833-11 METAL CHIP 10K 5% 1/10WR1544 1-216-864-11 SHORT CHIP 0R1546 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1547 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1548 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1549 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1550 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1551 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1553 1-216-864-11 SHORT CHIP 0R1554 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1557 1-216-809-11 METAL CHIP 100 5% 1/10WR1559 1-216-833-11 METAL CHIP 10K 5% 1/10WR2504 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3504 1-216-809-11 METAL CHIP 100 5% 1/10WR3505 1-216-809-11 METAL CHIP 100 5% 1/10W

R3601 1-216-809-11 METAL CHIP 100 5% 1/10WR3602 1-216-809-11 METAL CHIP 100 5% 1/10WR3603 1-216-833-11 METAL CHIP 10K 5% 1/10WR3605 1-216-864-11 SHORT CHIP 0R3606 1-216-864-11 SHORT CHIP 0

R3607 1-216-864-11 SHORT CHIP 0R3609 1-216-864-11 SHORT CHIP 0R3611 1-216-809-11 METAL CHIP 100 5% 1/10WR3621 1-216-809-11 METAL CHIP 100 5% 1/10WR3651 1-216-864-11 SHORT CHIP 0

R3652 1-216-864-11 SHORT CHIP 0R3653 1-216-864-11 SHORT CHIP 0R3711 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3712 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3713 1-216-828-11 METAL CHIP 3.9K 5% 1/10W

R3714 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3715 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3716 1-216-821-11 METAL CHIP 1K 5% 1/10WR3717 1-216-821-11 METAL CHIP 1K 5% 1/10WR3718 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R3719 1-216-821-11 METAL CHIP 1K 5% 1/10WR3721 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3722 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3723 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3724 1-216-828-11 METAL CHIP 3.9K 5% 1/10W

R3725 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3726 1-216-821-11 METAL CHIP 1K 5% 1/10WR3727 1-216-821-11 METAL CHIP 1K 5% 1/10WR3728 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3729 1-216-821-11 METAL CHIP 1K 5% 1/10W

R3731 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3732 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3733 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3734 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3735 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R3736 1-216-821-11 METAL CHIP 1K 5% 1/10WR3737 1-216-821-11 METAL CHIP 1K 5% 1/10WR3738 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3739 1-216-821-11 METAL CHIP 1K 5% 1/10WR3741 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R3742 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3743 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3744 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3745 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3746 1-216-821-11 METAL CHIP 1K 5% 1/10W

R3747 1-216-821-11 METAL CHIP 1K 5% 1/10WR3748 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3749 1-216-821-11 METAL CHIP 1K 5% 1/10WR3751 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

DMB15


94

HCD-ZX80D/ZX100D

R3752 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R3753 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3754 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3755 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3756 1-216-821-11 METAL CHIP 1K 5% 1/10WR3757 1-216-821-11 METAL CHIP 1K 5% 1/10W

R3758 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3759 1-216-821-11 METAL CHIP 1K 5% 1/10WR3761 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3762 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3763 1-216-828-11 METAL CHIP 3.9K 5% 1/10W



R3775 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3776 1-216-821-11 METAL CHIP 1K 5% 1/10WR3777 1-216-821-11 METAL CHIP 1K 5% 1/10WR3778 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3779 1-216-821-11 METAL CHIP 1K 5% 1/10W

R3781 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3782 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3783 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3784 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3785 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R3786 1-216-821-11 METAL CHIP 1K 5% 1/10WR3787 1-216-821-11 METAL CHIP 1K 5% 1/10WR3788 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3789 1-216-821-11 METAL CHIP 1K 5% 1/10WR3801 1-216-864-11 SHORT CHIP 0

R3802 1-216-864-11 SHORT CHIP 0R3803 1-216-833-11 METAL CHIP 10K 5% 1/10WR3804 1-216-836-11 METAL CHIP 18K 5% 1/10WR3805 1-216-821-11 METAL CHIP 1K 5% 1/10WR4701 1-216-864-11 SHORT CHIP 0

R4702 1-216-864-11 SHORT CHIP 0R4703 1-216-864-11 SHORT CHIP 0R4704 1-216-864-11 SHORT CHIP 0R4705 1-216-864-11 SHORT CHIP 0R4706 1-216-864-11 SHORT CHIP 0

R5008 1-216-864-11 SHORT CHIP 0R5011 1-216-864-11 SHORT CHIP 0R5014 1-216-864-11 SHORT CHIP 0

(ZX80D: US, E2, E51, MX/ZX100D: E2, E51, MX)R5016 1-216-864-11 SHORT CHIP 0

(ZX80D: E3, E13/ZX100D: E3)R5017 1-216-864-11 SHORT CHIP 0 (ZX100D: SP, MY)

< COMPOSITION CIRCUIT BLOCK >

RB103 1-234-795-21 RES, NETWORK 0X4 (2010)RB104 1-234-795-21 RES, NETWORK 0X4 (2010)RB105 1-234-371-21 RES, NETWORK 47 (1005X4)

RB106 1-234-371-21 RES, NETWORK 47 (1005X4)RB107 1-234-370-21 RES, NETWORK 22 (1005X4)

RB108 1-234-370-21 RES, NETWORK 22 (1005X4)RB111 1-234-795-21 RES, NETWORK 0X4 (2010)RB112 1-234-370-21 RES, NETWORK 22 (1005X4)RB113 1-234-370-21 RES, NETWORK 22 (1005X4)

< VIBRATOR >

X101 1-781-867-21 VIBRATOR, CRYSTAL (27MHz)************************************************************

DRIVER BOARD*************

< CAPACITOR >

C715 1-126-933-11 ELECT 100uF 20% 16VC731 1-126-964-11 ELECT 10uF 20% 50VC735 1-164-159-11 CERAMIC 0.1uF 50VC736 1-164-159-11 CERAMIC 0.1uF 50VC737 1-164-159-11 CERAMIC 0.1uF 50V

C741 1-162-306-11 CERAMIC 0.01uF 20% 16VC751 1-162-306-11 CERAMIC 0.01uF 20% 16VC752 1-164-159-11 CERAMIC 0.1uF 50V

< CONNECTOR >

CN701 1-784-735-11 CONNECTOR, FFC 13PCN702 1-784-766-11 CONNECTOR, FFC 5P

* CN703 1-564-720-11 PIN, CONNECTOR (SMALL TYPE) 4PCN704 1-785-328-11 PIN, CONNECTOR (LIGHT ANGRE) 2P

< DIODE >

D701 8-719-947-16 DIODE MTZJ-T-72-5.1AD711 8-719-983-66 DIODE MTZJ-T-72-3.6B

< IC >

IC701 8-759-598-69 IC BA6956ANIC712 8-759-598-69 IC BA6956AN

< TRANSISTOR >

Q731 8-729-029-66 TRANSISTOR DTC114ESA

< RESISTOR >

R701 1-249-413-11 CARBON 470 5% 1/4WR702 1-247-807-31 CARBON 100 5% 1/4WR711 1-249-417-11 CARBON 1K 5% 1/4WR712 1-247-847-11 CARBON 4.7K 5% 1/4WR713 1-247-863-11 CARBON 22K 5% 1/4W

R721 1-247-847-11 CARBON 4.7K 5% 1/4WR722 1-247-847-11 CARBON 4.7K 5% 1/4WR723 1-247-847-11 CARBON 4.7K 5% 1/4WR731 1-247-807-31 CARBON 100 5% 1/4WR732 1-249-429-11 CARBON 10K 5% 1/4W

R733 1-249-417-11 CARBON 1K 5% 1/4WR734 1-249-430-11 CARBON 12K 5% 1/4WR736 1-249-412-11 CARBON 390 5% 1/4WR751 1-247-847-11 CARBON 4.7K 5% 1/4W

************************************************************

DMB15 DRIVERVer. 1.1


95

HCD-ZX80D/ZX100D

A-1173-807-A EFFECTOR BOARD, COMPLETE (ZX80D: US, E2,E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

A-1174-198-A EFFECTOR BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

*************************

< CAPACITOR >

C1511 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1512 1-136-165-00 FILM 0.1uF 5% 50VC1513 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1514 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1515 1-126-947-11 ELECT 47uF 20% 35V

C1517 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC1518 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC1519 1-136-159-00 FILM 0.033uF 5% 50VC1520 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC1521 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C1522 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC1524 1-126-957-11 ELECT 0.22uF 20% 50VC1525 1-126-957-11 ELECT 0.22uF 20% 50VC1526 1-136-165-00 FILM 0.1uF 5% 50VC1527 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16V

C1528 1-104-665-11 ELECT 100uF 20% 25VC1529 1-107-726-91 CERAMIC CHIP 0.01uF 10% 16VC1530 1-136-159-00 FILM 0.033uF 5% 50VC1531 1-124-589-11 ELECT 47uF 20% 16VC1533 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C1534 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC1535 1-136-159-00 FILM 0.033uF 5% 50VC1536 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC1537 1-136-165-00 FILM 0.1uF 5% 50VC1540 1-126-957-11 ELECT 0.22uF 20% 50V

C1541 1-126-957-11 ELECT 0.22uF 20% 50VC1542 1-130-479-00 MYLAR 0.0047uF 5% 50VC1543 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC1544 1-130-479-00 MYLAR 0.0047uF 5% 50VC1545 1-126-964-11 ELECT 10uF 20% 50V

C1546 1-126-964-11 ELECT 10uF 20% 50VC1547 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC1548 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1552 1-126-964-11 ELECT 10uF 20% 50VC1554 1-126-964-11 ELECT 10uF 20% 50V

C1555 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1559 1-126-964-11 ELECT 10uF 20% 50VC1560 1-126-964-11 ELECT 10uF 20% 50VC1561 1-126-964-11 ELECT 10uF 20% 50VC1562 1-126-964-11 ELECT 10uF 20% 50V

C1568 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1570 1-126-964-11 ELECT 10uF 20% 50VC1571 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1572 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1574 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V

C1578 1-126-964-11 ELECT 10uF 20% 50VC1584 1-104-665-11 ELECT 100uF 20% 25VC1600 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1601 1-126-964-11 ELECT 10uF 20% 50VC1602 1-126-964-11 ELECT 10uF 20% 50V

C2330 1-136-165-00 FILM 0.1uF 5% 50V

C2331 1-136-159-00 FILM 0.033uF 5% 50V

< CONNECTOR >

CN1502 1-779-287-11 FFC CONNECTOR (LIF (NON-ZIF)) 19P

< DIODE >

D1502 6-501-169-01 DIODE UDZW-TE17-6.2BD1503 8-719-404-50 DIODE MA111-TXD1504 8-719-404-50 DIODE MA111-TXD1505 8-719-404-50 DIODE MA111-TXD1506 8-719-404-50 DIODE MA111-TX

D1507 8-719-404-50 DIODE MA111-TXD1508 8-719-404-50 DIODE MA111-TX

< IC >

IC1501 8-759-496-41 IC M65850FP-E1IC1502 6-709-217-01 IC TC74LVX4051FTIC1503 6-709-217-01 IC TC74LVX4051FTIC1504 8-759-496-41 IC M65850FP-E1IC1505 8-759-710-97 IC NJM4565M-D

IC1506 6-709-218-01 IC TC74LVX4052FT

< COIL >

L1500 1-414-183-41 INDUCTOR 10uH

< TRANSISTOR >

Q1500 8-729-055-10 FET 2SK3378ENTLQ1501 8-729-055-10 FET 2SK3378ENTLQ1502 8-729-055-10 FET 2SK3378ENTLQ1503 8-729-055-10 FET 2SK3378ENTLQ1504 8-729-055-10 FET 2SK3378ENTL

Q1505 8-729-055-10 FET 2SK3378ENTLQ1506 8-729-055-10 FET 2SK3378ENTLQ1507 8-729-056-46 TRANSISTOR 2SC5053T100QQ1508 8-729-055-10 FET 2SK3378ENTLQ1509 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q1510 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1511 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1512 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1513 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1514 8-729-027-43 TRANSISTOR DTC114EKA-T146

< RESISTOR >

R1500 1-216-809-11 METAL CHIP 100 5% 1/10WR1501 1-216-809-11 METAL CHIP 100 5% 1/10WR1502 1-216-809-11 METAL CHIP 100 5% 1/10WR1504 1-216-809-11 METAL CHIP 100 5% 1/10WR1506 1-216-809-11 METAL CHIP 100 5% 1/10W

R1507 1-216-809-11 METAL CHIP 100 5% 1/10WR1510 1-216-836-11 METAL CHIP 18K 5% 1/10WR1511 1-216-836-11 METAL CHIP 18K 5% 1/10WR1512 1-216-836-11 METAL CHIP 18K 5% 1/10WR1514 1-216-836-11 METAL CHIP 18K 5% 1/10W

R1515 1-216-836-11 METAL CHIP 18K 5% 1/10WR1516 1-216-833-11 METAL CHIP 10K 5% 1/10WR1517 1-216-833-11 METAL CHIP 10K 5% 1/10WR1519 1-216-840-11 METAL CHIP 39K 5% 1/10W

EFFECTORVer. 1.1


96

HCD-ZX80D/ZX100D

R1522 1-216-864-11 SHORT CHIP 0




R1544 1-216-836-11 METAL CHIP 18K 5% 1/10WR1545 1-216-839-11 METAL CHIP 33K 5% 1/10WR1546 1-216-836-11 METAL CHIP 18K 5% 1/10WR1547 1-216-833-11 METAL CHIP 10K 5% 1/10WR1549 1-216-833-11 METAL CHIP 10K 5% 1/10W



R1561 1-216-840-11 METAL CHIP 39K 5% 1/10WR1563 1-216-864-11 SHORT CHIP 0R1564 1-216-838-11 METAL CHIP 27K 5% 1/10WR1565 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1566 1-216-825-11 METAL CHIP 2.2K 5% 1/10W


R1572 1-216-821-11 METAL CHIP 1K 5% 1/10WR1573 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1574 1-216-845-11 METAL CHIP 100K 5% 1/10WR1575 1-216-821-11 METAL CHIP 1K 5% 1/10WR1576 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


R1582 1-216-845-11 METAL CHIP 100K 5% 1/10WR1583 1-216-833-11 METAL CHIP 10K 5% 1/10WR1588 1-216-836-11 METAL CHIP 18K 5% 1/10WR1589 1-216-803-11 METAL CHIP 33 5% 1/10WR1590 1-216-841-11 METAL CHIP 47K 5% 1/10W

R1591 1-216-841-11 METAL CHIP 47K 5% 1/10W

R1592 1-216-864-11 SHORT CHIP 0R1593 1-216-864-11 SHORT CHIP 0R1594 1-216-864-11 SHORT CHIP 0R1595 1-216-864-11 SHORT CHIP 0



R1606 1-216-837-11 METAL CHIP 22K 5% 1/10WR1607 1-216-837-11 METAL CHIP 22K 5% 1/10W

************************************************************

A-1174-314-A FUNCTION BOARD, COMPLETE*************************

< CAPACITOR >

C907 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

< CONNECTOR >

* CN901 1-569-934-11 SOCKET, CONNECTOR 17P

< HEADER >

CNS902 1-820-050-11 BOARD TO BOARD HEADER (8P)

< LED >

D1016 6-500-727-01 LED SLR-343DCT32 (DELAY)D1017 6-500-727-01 LED SLR-343DCT32 (CHORUS)D1020 6-500-727-01 LED SLR-343DCT32 (FLANGER)

< JUMPER RESISTOR >

JR921 1-216-864-11 SHORT CHIP 0JR923 1-216-864-11 SHORT CHIP 0

< TRANSISTOR >

Q920 8-729-027-50 TRANSISTOR DTC123JKA-T146Q921 8-729-027-50 TRANSISTOR DTC123JKA-T146

< RESISTOR >

R958 1-216-819-11 METAL CHIP 680 5% 1/10WR959 1-216-821-11 METAL CHIP 1K 5% 1/10WR960 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR961 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR962 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R963 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR972 1-216-821-11 METAL CHIP 1K 5% 1/10WR973 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR1001 1-216-817-11 METAL CHIP 470 5% 1/10WR1002 1-216-819-11 METAL CHIP 680 5% 1/10W

R1003 1-216-821-11 METAL CHIP 1K 5% 1/10WR1004 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1005 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

FUNCTIONEFFECTOR


97

HCD-ZX80D/ZX100D

JOG

R1006 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1014 1-216-817-11 METAL CHIP 470 5% 1/10W

R1015 1-216-821-11 METAL CHIP 1K 5% 1/10WR1016 1-216-821-11 METAL CHIP 1K 5% 1/10WR1018 1-216-821-11 METAL CHIP 1K 5% 1/10WR1019 1-216-821-11 METAL CHIP 1K 5% 1/10WR1186 1-216-814-11 METAL CHIP 270 5% 1/10W

< SWITCH/ROTARY ENCODER >

S901 1-762-875-21 SWITCH, KEYBOARD (PROGRESSIVE)S902 1-762-875-21 SWITCH, KEYBOARD (GROOVE)S903 1-762-875-21 SWITCH, KEYBOARD (EQ BAND)S904 1-762-875-21 SWITCH, KEYBOARD (DIRECTION)S905 1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)

S906 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)S914 1-762-875-21 SWITCH, KEYBOARD (ENTER)S915 1-762-875-21 SWITCH, KEYBOARD (DELAY)S916 1-762-875-21 SWITCH, KEYBOARD (CHORUS)S917 1-762-875-21 SWITCH, KEYBOARD (FLANGER)

S918 1-762-875-21 SWITCH, KEYBOARD (SOUND FIELD)S919 1-762-875-21 SWITCH, KEYBOARD (ILLUMINATION)S920 1-762-875-21 SWITCH, KEYBOARD (AMP MENU)S928 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)S970 1-418-725-51 ENCODER, ROTARY (12 TYPE)

(MASTER VOLUME)************************************************************

JOG BOARD**********

< CAPACITOR >


< CONNECTOR >

CNS903 1-562-573-31 SOCKET, CONNECTOR 8P

< LED >

D919 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 1)D920 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 2)D921 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 3)D922 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 4)D923 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 5)

D924 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 6)D925 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 7)D926 8-719-064-63 LED SELU5823C-TP15 (VOLUME LEVEL 8)

< JUMPER RESISTOR >

JR1 1-216-864-11 SHORT CHIP 0JR2 1-216-864-11 SHORT CHIP 0JR3 1-216-864-11 SHORT CHIP 0JR4 1-216-864-11 SHORT CHIP 0JR5 1-216-864-11 SHORT CHIP 0


< TRANSISTOR >



< RESISTOR >




R1163 1-216-809-11 METAL CHIP 100 5% 1/10WR1164 1-216-809-11 METAL CHIP 100 5% 1/10WR1165 1-216-809-11 METAL CHIP 100 5% 1/10W

< ROTARY ENCODER >

S1161 1-479-203-11 ENCODER (ROTARY) (OPERATION DIAL)************************************************************

A-1193-305-A KARAOKE BOARD, COMPLETE (ZX80D: US, E2,E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

A-1193-346-A KARAOKE BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

************************

< CAPACITOR >

C2000 1-104-665-11 ELECT 100uF 20% 25VC2001 1-126-947-11 ELECT 47uF 20% 35VC2002 1-126-947-11 ELECT 47uF 20% 35VC2004 1-126-961-11 ELECT 2.2uF 20% 50VC2005 1-126-947-11 ELECT 47uF 20% 35V

C2006 1-126-960-11 ELECT 1uF 20% 50VC2007 1-164-156-11 CERAMIC CHIP 0.1uF 25VC2008 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC2009 1-126-947-11 ELECT 47uF 20% 35VC2010 1-126-961-11 ELECT 2.2uF 20% 50V

C2011 1-126-947-11 ELECT 47uF 20% 35VC2013 1-164-156-11 CERAMIC CHIP 0.1uF 25VC2015 1-164-156-11 CERAMIC CHIP 0.1uF 25VC2016 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

< DIODE >

D2000 8-719-404-50 DIODE MA111-TXD2001 8-719-404-50 DIODE MA111-TXD2002 8-719-404-50 DIODE MA111-TXD2003 8-719-404-50 DIODE MA111-TXD2006 8-719-404-50 DIODE MA111-TX


FUNCTION KARAOKEVer. 1.1


98

HCD-ZX80D/ZX100D

MAIN

< IC >

IC2000 8-759-545-66 IC NJM3414AMP (TE2)IC2001 8-759-700-07 IC NJM2903MIC2002 8-759-700-07 IC NJM2903M

< RESISTOR >

R2000 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR2001 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR2002 1-216-837-11 METAL CHIP 22K 5% 1/10WR2004 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR2005 1-216-841-11 METAL CHIP 47K 5% 1/10W

R2007 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR2008 1-216-841-11 METAL CHIP 47K 5% 1/10WR2009 1-216-821-11 METAL CHIP 1K 5% 1/10WR2010 1-216-845-11 METAL CHIP 100K 5% 1/10WR2011 1-216-864-11 SHORT CHIP 0

R2012 1-216-845-11 METAL CHIP 100K 5% 1/10WR2014 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR2015 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR2016 1-216-841-11 METAL CHIP 47K 5% 1/10WR2017 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R2019 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR2020 1-216-864-11 SHORT CHIP 0R2021 1-216-864-11 SHORT CHIP 0R2022 1-216-833-11 METAL CHIP 10K 5% 1/10WR2024 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R2025 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR2026 1-216-864-11 SHORT CHIP 0R2028 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR2029 1-216-837-11 METAL CHIP 22K 5% 1/10WR2030 1-216-864-11 SHORT CHIP 0

R2031 1-216-837-11 METAL CHIP 22K 5% 1/10WR2032 1-216-822-11 METAL CHIP 1.2K 5% 1/10WR2034 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR2035 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR2036 1-216-864-11 SHORT CHIP 0

R2037 1-216-864-11 SHORT CHIP 0************************************************************

A-1174-078-A MAIN BOARD, COMPLETE (ZX80D: E3)A-1174-169-A MAIN BOARD, COMPLETE (ZX80D: MX)A-1174-256-A MAIN BOARD, COMPLETE (ZX100D: MX)A-1174-328-A MAIN BOARD, COMPLETE (ZX100D: E3)A-1193-164-A MAIN BOARD, COMPLETE (ZX80D: E13)

A-1193-167-A MAIN BOARD, COMPLETE (ZX80D: E2)A-1193-171-A MAIN BOARD, COMPLETE (ZX100D: SP, MY)A-1193-174-A MAIN BOARD, COMPLETE (ZX100D: E2)A-1193-435-A MAIN BOARD, COMPLETE (ZX80D: E51)A-1193-438-A MAIN BOARD, COMPLETE (ZX100D: E51)

*********************

7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

< CAPACITOR/RESISTOR >

C101 1-104-665-11 ELECT 100uF 20% 25VC102 1-126-964-11 ELECT 10uF 20% 50VC103 1-126-964-11 ELECT 10uF 20% 50VC104 1-126-964-11 ELECT 10uF 20% 50VC105 1-126-964-11 ELECT 10uF 20% 50V

C106 1-130-487-00 MYLAR 0.022uF 5% 50VC107 1-130-487-00 MYLAR 0.022uF 5% 50VC108 1-130-489-00 MYLAR 0.033uF 5% 50VC109 1-126-960-11 ELECT 1uF 20% 50VC110 1-137-150-11 FILM 0.01uF 5% 100V

(ZX100D)

C110 1-137-438-11 MYLAR 0.0082uF 5% 50V(ZX80D)

C111 1-126-964-11 ELECT 10uF 20% 50VC112 1-136-498-11 FILM 0.12uF 5% 50VC113 1-136-171-00 FILM 0.33uF 5% 50VC114 1-126-964-11 ELECT 10uF 20% 50V

C115 1-164-156-11 CERAMIC CHIP 0.1uF 25VC116 1-126-924-11 ELECT 330uF 20% 10VC130 1-126-964-11 ELECT 10uF 20% 50VC131 1-126-959-11 ELECT 0.47uF 20% 50VC150 1-126-964-11 ELECT 10uF 20% 50V

C152 1-126-964-11 ELECT 10uF 20% 50VC153 1-126-964-11 ELECT 10uF 20% 50VC154 1-126-964-11 ELECT 10uF 20% 50VC155 1-126-964-11 ELECT 10uF 20% 50VC156 1-130-487-00 MYLAR 0.022uF 5% 50V

C157 1-130-487-00 MYLAR 0.022uF 5% 50VC158 1-130-489-00 MYLAR 0.033uF 5% 50VC159 1-126-960-11 ELECT 1uF 20% 50VC160 1-137-150-11 FILM 0.01uF 5% 100V

(ZX100D)C160 1-137-438-11 MYLAR 0.0082uF 5% 50V

(ZX80D)

C161 1-126-964-11 ELECT 10uF 20% 50VC162 1-136-498-11 FILM 0.12uF 5% 50VC163 1-136-171-00 FILM 0.33uF 5% 50VC164 1-126-964-11 ELECT 10uF 20% 50VC166 1-126-964-11 ELECT 10uF 20% 50V

C167 1-126-964-11 ELECT 10uF 20% 50VC200 1-136-497-11 FILM 0.1uF 5% 50VC201 1-136-497-11 FILM 0.1uF 5% 50VC202 1-126-964-11 ELECT 10uF 20% 50VC203 1-136-498-11 FILM 0.12uF 5% 50V

C204 1-136-171-00 FILM 0.33uF 5% 50VC205 1-104-665-11 ELECT 100uF 20% 25VC206 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC207 1-124-261-00 ELECT 10uF 20% 50VC209 1-124-261-00 ELECT 10uF 20% 50V

C210 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC211 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC212 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC213 1-126-964-11 ELECT 10uF 20% 50VC214 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C215 1-126-964-11 ELECT 10uF 20% 50VC216 1-126-964-11 ELECT 10uF 20% 50VC217 1-126-964-11 ELECT 10uF 20% 50VC218 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC219 1-126-964-11 ELECT 10uF 20% 50V

C220 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC221 1-126-960-11 ELECT 1uF 20% 50VC222 1-126-964-11 ELECT 10uF 20% 50VC223 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

KARAOKE

Note: Refer to SUPPLEMENT-1 for the MAIN board of USmodel.

Ver. 1.1


99

HCD-ZX80D/ZX100D

C224 1-126-964-11 ELECT 10uF 20% 50V

C225 1-126-960-11 ELECT 1uF 20% 50VC226 1-126-960-11 ELECT 1uF 20% 50VC227 1-126-960-11 ELECT 1uF 20% 50VC228 1-126-960-11 ELECT 1uF 20% 50VC229 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C233 1-162-953-11 CERAMIC CHIP 100PF 5% 50V(ZX80D)

C234 1-126-964-11 ELECT 10uF 20% 50V(ZX80D)

C235 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC242 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC251 1-126-960-11 ELECT 1uF 20% 50V

C252 1-126-964-11 ELECT 10uF 20% 50VC253 1-136-498-11 FILM 0.12uF 5% 50VC254 1-136-171-00 FILM 0.33uF 5% 50VC255 1-104-665-11 ELECT 100uF 20% 25VC256 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C257 1-126-964-11 ELECT 10uF 20% 50VC258 1-126-964-11 ELECT 10uF 20% 50VC259 1-124-261-00 ELECT 10uF 20% 50VC260 1-164-156-11 CERAMIC CHIP 0.1uF 25VC261 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C262 1-126-964-11 ELECT 10uF 20% 50VC263 1-126-964-11 ELECT 10uF 20% 50VC264 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC265 1-126-964-11 ELECT 10uF 20% 50VC266 1-126-964-11 ELECT 10uF 20% 50V

C267 1-126-964-11 ELECT 10uF 20% 50VC268 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC269 1-126-964-11 ELECT 10uF 20% 50VC270 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC272 1-126-934-11 ELECT 220uF 20% 16V

C273 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC274 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC276 1-126-960-11 ELECT 1uF 20% 50VC277 1-126-960-11 ELECT 1uF 20% 50VC278 1-126-960-11 ELECT 1uF 20% 50V

C279 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC301 1-136-967-11 FILM 0.012uF 5% 100VC303 1-136-497-11 FILM 0.1uF 5% 50VC304 1-126-964-11 ELECT 10uF 20% 50VC305 1-126-960-11 ELECT 1uF 20% 50V

C306 1-126-961-11 ELECT 2.2uF 20% 50VC307 1-126-964-11 ELECT 10uF 20% 50VC308 1-126-935-11 ELECT 470uF 20% 16VC309 1-126-947-11 ELECT 47uF 20% 35VC310 1-126-964-11 ELECT 10uF 20% 50V

C311 1-126-964-11 ELECT 10uF 20% 50VC312 1-126-964-11 ELECT 10uF 20% 50VC314 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC325 1-126-964-11 ELECT 10uF 20% 50VC326 1-115-412-11 CERAMIC CHIP 680PF 5% 25V

C328 1-137-427-11 MYLAR 120PF 5% 50VC332 1-164-670-11 CERAMIC CHIP 1200PF 5% 16VC333 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC335 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC340 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V

C341 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC351 1-136-967-11 FILM 0.012uF 5% 100VC352 1-126-947-11 ELECT 47uF 20% 35VC353 1-136-497-11 FILM 0.1uF 5% 50VC354 1-126-964-11 ELECT 10uF 20% 50V

C355 1-126-960-11 ELECT 1uF 20% 50VC356 1-126-961-11 ELECT 2.2uF 20% 50VC357 1-126-963-11 ELECT 4.7uF 20% 50VC358 1-126-963-11 ELECT 4.7uF 20% 50VC359 1-126-947-11 ELECT 47uF 20% 35V

C360 1-162-921-11 CERAMIC CHIP 33PF 5% 50VC361 1-126-964-11 ELECT 10uF 20% 50VC362 1-126-963-11 ELECT 4.7uF 20% 50VC363 1-126-963-11 ELECT 4.7uF 20% 50VC364 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C365 1-126-960-11 ELECT 1uF 20% 50VC370 1-137-150-11 FILM 0.01uF 5% 100VC371 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC372 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC373 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C374 1-126-947-11 ELECT 47uF 20% 35VC376 1-115-412-11 CERAMIC CHIP 680PF 5% 25VC377 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC378 1-137-427-11 MYLAR 120PF 5% 50VC379 1-130-481-00 MYLAR 0.0068uF 5% 50V

C382 1-164-670-11 CERAMIC CHIP 1200PF 5% 16VC383 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC385 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC410 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC411 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C412 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC413 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC414 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC415 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC416 1-104-656-11 ELECT 2200uF 20% 6.3V

C431 1-126-964-11 ELECT 10uF 20% 50VC462 1-104-665-11 ELECT 100uF 20% 25VC464 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC501 1-126-964-11 ELECT 10uF 20% 50VC502 1-136-497-11 FILM 0.1uF 5% 50V

C503 1-136-497-11 FILM 0.1uF 5% 50VC504 1-126-964-11 ELECT 10uF 20% 50VC505 1-126-961-11 ELECT 2.2uF 20% 50VC506 1-126-961-11 ELECT 2.2uF 20% 50VC507 1-126-961-11 ELECT 2.2uF 20% 50V

C508 1-126-961-11 ELECT 2.2uF 20% 50VC509 1-126-961-11 ELECT 2.2uF 20% 50VC510 1-126-961-11 ELECT 2.2uF 20% 50VC511 1-126-961-11 ELECT 2.2uF 20% 50VC512 1-126-157-11 ELECT 10uF 20% 16V

(ZX80D: E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

C513 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC514 1-126-768-11 ELECT 2200uF 20% 16VC515 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC516 1-126-927-11 ELECT 2200uF 20% 10VC517 1-126-961-11 ELECT 2.2uF 20% 50V

MAIN


100

HCD-ZX80D/ZX100D

C518 1-126-926-11 ELECT 1000uF 20% 10VC519 1-126-927-11 ELECT 2200uF 20% 10VC520 1-126-964-11 ELECT 10uF 20% 50VC521 1-126-964-11 ELECT 10uF 20% 50VC523 1-126-961-11 ELECT 2.2uF 20% 50V

C524 1-126-961-11 ELECT 2.2uF 20% 50VC525 1-126-926-11 ELECT 1000uF 20% 10VC530 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC550 1-119-774-11 ELECT 100uF 20% 16VC551 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C552 1-126-961-11 ELECT 2.2uF 20% 50VC553 1-104-666-11 ELECT 220uF 20% 25VC554 1-126-964-11 ELECT 10uF 20% 50VC557 1-130-483-00 MYLAR 0.01uF 5% 50VC558 1-130-483-00 MYLAR 0.01uF 5% 50V

C559 1-126-926-11 ELECT 1000uF 20% 10VC562 1-126-935-11 ELECT 470uF 20% 16VC563 1-126-935-11 ELECT 470uF 20% 16VC564 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC565 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C566 1-111-235-61 ELECT 10000uF 20% 25VC567 1-126-946-11 ELECT 6800uF 20% 25VC568 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC569 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC570 1-130-483-00 MYLAR 0.01uF 5% 50V

C571 1-130-483-00 MYLAR 0.01uF 5% 50VC580 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC581 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC583 1-164-156-11 CERAMIC CHIP 0.1uF 25VC584 1-164-156-11 CERAMIC CHIP 0.1uF 25V

< CONNECTOR >

* CN100 1-564-711-11 PIN, CONNECTOR (SMALL TYPE) 9PCN102 1-820-049-11 CONNECTOR (SUBWOOFER)

(SYSTEM CONTROL ) (ZX100D)CN105 1-691-765-11 PLUG (MICRO CONNECTOR) 3P (ZX100D)CN402 1-785-336-11 PIN, CONNECTOR (LIGHT ANGLE) 10PCN501 1-573-845-11 CONNECTOR, BOARD TO BOARD13P

* CN502 1-774-876-21 CONNECTOR, BOARD TO BOARD 8P* CN503 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P

CN504 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P* CN505 1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6P

CN506 1-784-731-11 CONNECTOR, FFC 9P

* CN508 1-569-934-11 SOCKET, CONNECTOR 17PCN509 1-569-928-11 SOCKET, CONNECTOR 11P

* CN510 1-568-449-11 HOUSING, CONNECTOR (PC BOARD) 3PCN511 1-784-735-11 CONNECTOR, FFC 13PCN512 1-779-287-11 CONNECTOR, FFC (LIF (NON-ZIF)) 19P

CN513 1-573-845-11 CONNECTOR, BOARD TO BOARD 13P* CN514 1-774-876-21 CONNECTOR, BOARD TO BOARD 8P

CN520 1-779-281-11 CONNECTOR, FFC (LIF (NON-ZIF)) 13PCN521 1-779-289-11 CONNECTOR, FFC (LIF (NON-ZIF)) 21PCN580 1-564-506-11 PLUG, CONNECTOR 3P

CN582 1-564-506-11 PLUG, CONNECTOR 3P

< DIODE >

D101 6-501-193-01 DIODE 1SS355WTE-17D102 6-501-193-01 DIODE 1SS355WTE-17

D136 8-719-069-55 DIODE UDZSTE-175.6BD325 8-719-083-60 DIODE UDZSTE-174.7BD340 6-501-193-01 DIODE 1SS355WTE-17

D341 6-501-193-01 DIODE 1SS355WTE-17D342 6-501-193-01 DIODE 1SS355WTE-17D401 6-501-193-01 DIODE 1SS355WTE-17D402 6-501-193-01 DIODE 1SS355WTE-17D403 6-501-193-01 DIODE 1SS355WTE-17

D411 6-501-193-01 DIODE 1SS355WTE-17D412 6-501-193-01 DIODE 1SS355WTE-17D501 6-501-193-01 DIODE 1SS355WTE-17D502 6-501-193-01 DIODE 1SS355WTE-17D503 6-501-193-01 DIODE 1SS355WTE-17

D504 6-501-193-01 DIODE 1SS355WTE-17D505 6-501-193-01 DIODE 1SS355WTE-17D506 6-501-193-01 DIODE 1SS355WTE-17D507 6-501-193-01 DIODE 1SS355WTE-17D510 6-501-193-01 DIODE 1SS355WTE-17 (ZX80D)

D511 6-501-193-01 DIODE 1SS355WTE-17 (ZX80D)D550 6-501-193-01 DIODE 1SS355WTE-17D551 6-501-193-01 DIODE 1SS355WTE-17 (ZX80D: E2, E3, E13,

E51/ZX100D: E2, E3, E51, SP, MY)D560 8-719-500-60 DIODE D5SBA20D561 8-719-500-60 DIODE D5SBA20

D581 8-719-978-33 DIODE DTZ-TT11-6.8BD582 8-719-069-56 DIODE UDZSTE-176.2BD583 8-719-071-54 DIODE HZU2.0BTRFD584 8-719-083-63 DIODE UDZSTE-1713BD585 6-500-522-21 DIODE 10EDB40-TB3

D586 6-500-522-21 DIODE 10EDB40-TB3

< JUMPER RESISTOR >

FB204 1-216-864-11 SHORT CHIP 0FB254 1-216-864-11 SHORT CHIP 0FB260 1-216-864-11 SHORT CHIP 0FB261 1-216-864-11 SHORT CHIP 0

< IC >

IC101 6-703-650-11 IC M61529FP-D60GIC201 6-703-651-11 IC M61530FP-D60GIC301 6-702-130-01 IC HA12237FIC304 8-759-710-97 IC NJM4565M-DIC401 6-806-203-01 IC M30622MEP-A78FPU0

IC501 6-705-809-01 IC BD4929G-TRIC507 8-759-653-07 IC PQ09RD21J00HIC550 6-703-610-01 IC RT8H015C-T112-1IC558 6-703-547-01 IC TA7805LSIC559 6-702-771-01 IC TA78033LS

IC560 8-759-394-36 IC BA09TIC561 8-759-394-36 IC BA09T

< CONNECTOR/JACK >

J103 1-820-048-11 CONNECTOR (LIGHTING) (D-LIGHT SYNC OUT)J201 1-770-272-11 JACK, PIN 2P (TV/SAT AUDIO IN)J202 1-770-272-11 JACK, PIN 2P (AUDIO OUT)J203 1-770-377-31 JACK, PIN 1P (SUBWOOFER OUT) (ZX80D)

MAIN


101

HCD-ZX80D/ZX100D

< JUMPER RESISTOR >



JR208 1-216-864-11 SHORT CHIP 0JR218 1-216-864-11 SHORT CHIP 0JR219 1-216-864-11 SHORT CHIP 0 (ZX80D)JR222 1-216-864-11 SHORT CHIP 0JR300 1-216-296-11 SHORT CHIP 0







JR513 1-216-864-11 SHORT CHIP 0 (ZX100D)JR514 1-216-864-11 SHORT CHIP 0JR515 1-216-296-11 SHORT CHIP 0 (ZX80D)JR516 1-216-864-11 SHORT CHIP 0 (ZX100D)JR520 1-216-864-11 SHORT CHIP 0


JR544 1-216-296-11 SHORT CHIP 0

JR545 1-216-864-11 SHORT CHIP 0

< COIL >

L101 1-420-872-52 COIL, AIR-CORE (ZX100D)L102 1-420-872-52 COIL, AIR-CORE (ZX100D)L302 1-414-189-31 INDUCTOR 100uHL320 1-410-780-11 INDUCTOR 27mHL370 1-410-780-11 INDUCTOR 27mH

L372 1-414-189-31 INDUCTOR 100uH

< TRANSISTOR >

Q101 8-729-230-49 TRANSISTOR 2SC2712-YGQ103 8-729-056-46 TRANSISTOR 2SC5053T100QQ104 8-729-027-43 TRANSISTOR DTC114EKA-T146Q106 8-729-023-22 TRANSISTOR 2SD2114KQ117 8-729-023-22 TRANSISTOR 2SD2114K

Q151 8-729-230-49 TRANSISTOR 2SC2712-YGQ156 8-729-023-22 TRANSISTOR 2SD2114KQ167 8-729-023-22 TRANSISTOR 2SD2114KQ200 8-729-023-22 TRANSISTOR 2SD2114KQ202 8-729-023-22 TRANSISTOR 2SD2114K

Q203 8-729-023-22 TRANSISTOR 2SD2114KQ204 8-729-023-22 TRANSISTOR 2SD2114KQ205 8-729-901-81 TRANSISTOR 2SC2412K-T-146-RQ206 8-729-023-22 TRANSISTOR 2SD2114KQ207 8-729-023-22 TRANSISTOR 2SD2114K (ZX80D)

Q208 6-551-287-01 TRANSISTOR 2SD2704K-T146 (ZX80D)Q250 8-729-023-22 TRANSISTOR 2SD2114KQ252 8-729-023-22 TRANSISTOR 2SD2114KQ253 8-729-023-22 TRANSISTOR 2SD2114KQ254 8-729-023-22 TRANSISTOR 2SD2114K

Q255 8-729-901-81 TRANSISTOR 2SC2412K-T-146-RQ256 8-729-023-22 TRANSISTOR 2SD2114KQ321 6-551-287-01 TRANSISTOR 2SD2704K-T146Q322 6-551-287-01 TRANSISTOR 2SD2704K-T146Q323 8-729-056-46 TRANSISTOR 2SC5053T100Q

Q325 6-551-287-01 TRANSISTOR 2SD2704K-T146Q340 8-729-903-46 TRANSISTOR 2SB1132-PQ341 8-729-903-46 TRANSISTOR 2SB1132-PQ342 8-729-903-46 TRANSISTOR 2SB1132-PQ343 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q344 8-729-027-43 TRANSISTOR DTC114EKA-T146Q345 8-729-027-43 TRANSISTOR DTC114EKA-T146Q370 8-729-141-75 TRANSISTOR 2SD596DV345Q372 6-551-287-01 TRANSISTOR 2SD2704K-T146Q373 6-551-287-01 TRANSISTOR 2SD2704K-T146

Q375 6-551-287-01 TRANSISTOR 2SD2704K-T146Q377 8-729-216-22 TRANSISTOR 2SA1162-GQ378 6-550-185-01 TRANSISTOR RT1P137P-TP-1Q379 8-729-027-43 TRANSISTOR DTC114EKA-T146Q380 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q381 8-729-027-43 TRANSISTOR DTC114EKA-T146Q382 8-729-027-23 TRANSISTOR DTA114EKA-T146Q383 8-729-027-43 TRANSISTOR DTC114EKA-T146Q501 8-729-901-00 TRANSISTOR DTC124EKQ503 8-729-027-43 TRANSISTOR DTC114EKA-T146

MAIN


102

HCD-ZX80D/ZX100D

Q504 8-729-027-56 TRANSISTOR DTC143TKA-T146 (ZX80D:E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

Q505 8-729-027-31 TRANSISTOR DTA124EKA-T146Q506 8-729-027-43 TRANSISTOR DTC114EKA-T146Q507 8-729-027-31 TRANSISTOR DTA124EKA-T146Q508 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q509 8-729-027-31 TRANSISTOR DTA124EKA-T146Q510 8-729-027-43 TRANSISTOR DTC114EKA-T146Q511 8-729-027-31 TRANSISTOR DTA124EKA-T146Q512 8-729-027-43 TRANSISTOR DTC114EKA-T146Q513 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q514 8-729-023-22 TRANSISTOR 2SD2114KQ515 8-729-027-56 TRANSISTOR DTC143TKA-T146Q516 8-729-027-31 TRANSISTOR DTA124EKA-T146Q517 8-729-027-43 TRANSISTOR DTC114EKA-T146Q518 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q519 8-729-027-31 TRANSISTOR DTA124EKA-T146Q520 8-729-024-94 TRANSISTOR 2SB1565FQ521 8-729-027-43 TRANSISTOR DTC114EKA-T146Q522 8-729-027-31 TRANSISTOR DTA124EKA-T146Q523 8-729-027-23 TRANSISTOR DTA114EKA-T146

Q524 8-729-901-00 TRANSISTOR DTC124EKQ550 8-729-027-56 TRANSISTOR DTC143TKA-T146 (ZX80D:

E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)Q564 8-729-023-22 TRANSISTOR 2SD2114KQ578 8-729-027-43 TRANSISTOR DTC114EKA-T146Q579 8-729-230-49 TRANSISTOR 2SC2712-YG

Q581 8-729-230-49 TRANSISTOR 2SC2712-YGQ582 8-729-230-49 TRANSISTOR 2SC2712-YGQ585 8-729-026-68 TRANSISTOR 2SD2525 (TP)Q587 8-729-230-49 TRANSISTOR 2SC2712-YGQ588 8-729-026-68 TRANSISTOR 2SD2525 (TP)

Q589 8-729-230-49 TRANSISTOR 2SC2712-YG

< RESISTOR >

R101 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR102 1-216-833-11 METAL CHIP 10K 5% 1/10WR103 1-216-821-11 METAL CHIP 1K 5% 1/10WR104 1-216-821-11 METAL CHIP 1K 5% 1/10WR105 1-216-841-11 METAL CHIP 47K 5% 1/10W

R106 1-216-833-11 METAL CHIP 10K 5% 1/10WR107 1-216-809-11 METAL CHIP 100 5% 1/10WR108 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR109 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR110 1-216-833-11 METAL CHIP 10K 5% 1/10W


R116 1-216-809-11 METAL CHIP 100 5% 1/10WR117 1-216-864-11 SHORT CHIP 0R120 1-216-864-11 SHORT CHIP 0R121 1-216-833-11 METAL CHIP 10K 5% 1/10WR122 1-216-833-11 METAL CHIP 10K 5% 1/10W

R130 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR131 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR132 1-216-857-11 METAL CHIP 1M 5% 1/10W

R133 1-216-845-11 METAL CHIP 100K 5% 1/10WR135 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R150 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR151 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR152 1-216-833-11 METAL CHIP 10K 5% 1/10WR153 1-216-821-11 METAL CHIP 1K 5% 1/10WR154 1-216-821-11 METAL CHIP 1K 5% 1/10W

R155 1-216-841-11 METAL CHIP 47K 5% 1/10WR156 1-216-833-11 METAL CHIP 10K 5% 1/10WR157 1-216-809-11 METAL CHIP 100 5% 1/10WR158 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR159 1-216-827-11 METAL CHIP 3.3K 5% 1/10W


R165 1-216-821-11 METAL CHIP 1K 5% 1/10WR166 1-216-809-11 METAL CHIP 100 5% 1/10WR167 1-216-864-11 SHORT CHIP 0R200 1-216-833-11 METAL CHIP 10K 5% 1/10WR202 1-216-833-11 METAL CHIP 10K 5% 1/10W

R203 1-216-833-11 METAL CHIP 10K 5% 1/10WR204 1-216-833-11 METAL CHIP 10K 5% 1/10WR205 1-216-821-11 METAL CHIP 1K 5% 1/10WR206 1-216-841-11 METAL CHIP 47K 5% 1/10WR207 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R208 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR209 1-216-833-11 METAL CHIP 10K 5% 1/10WR210 1-216-817-11 METAL CHIP 470 5% 1/10WR211 1-216-841-11 METAL CHIP 47K 5% 1/10WR212 1-216-832-11 METAL CHIP 8.2K 5% 1/10W

R213 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR214 1-216-841-11 METAL CHIP 47K 5% 1/10WR215 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR216 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR217 1-216-833-11 METAL CHIP 10K 5% 1/10W





(ZX100D)

MAIN


103

HCD-ZX80D/ZX100D

R236 1-216-837-11 METAL CHIP 22K 5% 1/10W(ZX80D)

R237 1-216-841-11 METAL CHIP 47K 5% 1/10WR238 1-216-864-11 SHORT CHIP 0R239 1-216-833-11 METAL CHIP 10K 5% 1/10WR240 1-216-835-11 METAL CHIP 15K 5% 1/10WR241 1-216-839-11 METAL CHIP 33K 5% 1/10W



(ZX80D)R249 1-216-833-11 METAL CHIP 10K 5% 1/10WR250 1-216-839-11 METAL CHIP 33K 5% 1/10W

(ZX80D)R251 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

(ZX80D)



R254 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR255 1-216-821-11 METAL CHIP 1K 5% 1/10WR256 1-216-841-11 METAL CHIP 47K 5% 1/10W

R257 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR258 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR259 1-216-833-11 METAL CHIP 10K 5% 1/10WR260 1-216-817-11 METAL CHIP 470 5% 1/10WR261 1-216-841-11 METAL CHIP 47K 5% 1/10W

R262 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR263 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR264 1-216-841-11 METAL CHIP 47K 5% 1/10WR265 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR266 1-216-825-11 METAL CHIP 2.2K 5% 1/10W





(ZX100D)


R287 1-216-841-11 METAL CHIP 47K 5% 1/10WR288 1-216-864-11 SHORT CHIP 0R289 1-216-833-11 METAL CHIP 10K 5% 1/10WR290 1-216-835-11 METAL CHIP 15K 5% 1/10W




R306 1-216-837-11 METAL CHIP 22K 5% 1/10WR307 1-216-857-11 METAL CHIP 1M 5% 1/10WR308 1-216-809-11 METAL CHIP 100 5% 1/10WR309 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR310 1-216-809-11 METAL CHIP 100 5% 1/10W

R311 1-216-809-11 METAL CHIP 100 5% 1/10WR312 1-216-809-11 METAL CHIP 100 5% 1/10WR314 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR315 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR316 1-216-841-11 METAL CHIP 47K 5% 1/10W

R317 1-216-837-11 METAL CHIP 22K 5% 1/10WR318 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR319 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR320 1-216-839-11 METAL CHIP 33K 5% 1/10WR321 1-216-839-11 METAL CHIP 33K 5% 1/10W

R322 1-216-841-11 METAL CHIP 47K 5% 1/10WR325 1-216-819-11 METAL CHIP 680 5% 1/10WR329 1-216-845-11 METAL CHIP 100K 5% 1/10WR330 1-216-821-11 METAL CHIP 1K 5% 1/10WR335 1-216-821-11 METAL CHIP 1K 5% 1/10W


R341 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR342 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR343 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR344 1-216-819-11 METAL CHIP 680 5% 1/10WR345 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R346 1-216-819-11 METAL CHIP 680 5% 1/10WR347 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR348 1-216-819-11 METAL CHIP 680 5% 1/10WR349 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR350 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R351 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR352 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

MAIN


104

HCD-ZX80D/ZX100D

R353 1-216-833-11 METAL CHIP 10K 5% 1/10WR354 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR355 1-216-841-11 METAL CHIP 47K 5% 1/10W



R369 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR370 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR371 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR372 1-216-864-11 SHORT CHIP 0R373 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R374 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR375 1-216-864-11 SHORT CHIP 0R376 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR377 1-216-805-11 METAL CHIP 47 5% 1/10WR378 1-216-833-11 METAL CHIP 10K 5% 1/10W

R379 1-216-797-11 METAL CHIP 10 5% 1/10WR380 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR381 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR382 1-216-841-11 METAL CHIP 47K 5% 1/10WR383 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R384 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR385 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR386 1-216-803-11 METAL CHIP 33 5% 1/10WR387 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR388 1-216-833-11 METAL CHIP 10K 5% 1/10W

R389 1-216-835-11 METAL CHIP 15K 5% 1/10WR390 1-216-833-11 METAL CHIP 10K 5% 1/10WR391 1-216-821-11 METAL CHIP 1K 5% 1/10WR392 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR394 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


R402 1-216-809-11 METAL CHIP 100 5% 1/10WR403 1-216-833-11 METAL CHIP 10K 5% 1/10WR404 1-216-833-11 METAL CHIP 10K 5% 1/10WR405 1-216-809-11 METAL CHIP 100 5% 1/10WR406 1-216-809-11 METAL CHIP 100 5% 1/10W

R407 1-216-809-11 METAL CHIP 100 5% 1/10WR408 1-216-809-11 METAL CHIP 100 5% 1/10WR409 1-216-809-11 METAL CHIP 100 5% 1/10WR410 1-216-833-11 METAL CHIP 10K 5% 1/10WR411 1-216-851-11 METAL CHIP 330K 5% 1/10W

R412 1-216-845-11 METAL CHIP 100K 5% 1/10WR413 1-216-864-11 SHORT CHIP 0R414 1-216-809-11 METAL CHIP 100 5% 1/10WR415 1-216-809-11 METAL CHIP 100 5% 1/10WR417 1-216-833-11 METAL CHIP 10K 5% 1/10W

R418 1-216-809-11 METAL CHIP 100 5% 1/10WR419 1-216-809-11 METAL CHIP 100 5% 1/10WR420 1-216-821-11 METAL CHIP 1K 5% 1/10WR421 1-216-809-11 METAL CHIP 100 5% 1/10WR422 1-216-809-11 METAL CHIP 100 5% 1/10W


R428 1-216-833-11 METAL CHIP 10K 5% 1/10WR429 1-216-809-11 METAL CHIP 100 5% 1/10WR430 1-216-809-11 METAL CHIP 100 5% 1/10WR431 1-216-809-11 METAL CHIP 100 5% 1/10WR432 1-216-809-11 METAL CHIP 100 5% 1/10W







R474 1-216-809-11 METAL CHIP 100 5% 1/10WR475 1-216-809-11 METAL CHIP 100 5% 1/10WR478 1-216-821-11 METAL CHIP 1K 5% 1/10WR479 1-216-833-11 METAL CHIP 10K 5% 1/10W

0R480 1-217-637-00 FUSIBLE 1 5% 1/4W F(ZX100D)

R481 1-216-809-11 METAL CHIP 100 5% 1/10W(ZX100D)

R482 1-216-809-11 METAL CHIP 100 5% 1/10W(ZX100D)

R483 1-216-809-11 METAL CHIP 100 5% 1/10WR484 1-216-833-11 METAL CHIP 10K 5% 1/10WR485 1-216-809-11 METAL CHIP 100 5% 1/10W

MAIN


105

HCD-ZX80D/ZX100D

R486 1-216-809-11 METAL CHIP 100 5% 1/10WR487 1-216-833-11 METAL CHIP 10K 5% 1/10WR488 1-216-809-11 METAL CHIP 100 5% 1/10WR489 1-216-809-11 METAL CHIP 100 5% 1/10WR490 1-216-809-11 METAL CHIP 100 5% 1/10W

R491 1-216-809-11 METAL CHIP 100 5% 1/10WR492 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR493 1-216-815-11 METAL CHIP 330 5% 1/10W

(ZX80D: E3/ZX100D: E3)R493 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

(ZX80D: E2, E13, E51, MX/ZX100D: E2, E51, MX)R493 1-216-864-11 SHORT CHIP 0 (ZX100D: SP, MY)

R494 1-216-809-11 METAL CHIP 100 5% 1/10WR496 1-216-809-11 METAL CHIP 100 5% 1/10WR499 1-216-809-11 METAL CHIP 100 5% 1/10WR500 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR501 1-216-813-11 METAL CHIP 220 5% 1/10W

R502 1-216-821-11 METAL CHIP 1K 5% 1/10WR503 1-216-864-11 SHORT CHIP 0R505 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR506 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR507 1-216-833-11 METAL CHIP 10K 5% 1/10W



R518 1-216-833-11 METAL CHIP 10K 5% 1/10WR519 1-216-821-11 METAL CHIP 1K 5% 1/10WR520 1-216-833-11 METAL CHIP 10K 5% 1/10W


R521 1-216-864-11 SHORT CHIP 0 (ZX80D: MX/ZX100D: MX)R522 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


R528 1-216-833-11 METAL CHIP 10K 5% 1/10WR529 1-216-835-11 METAL CHIP 15K 5% 1/10WR530 1-216-843-11 METAL CHIP 68K 5% 1/10WR531 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

(ZX80D: E2/ZX100D: E2)R531 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W

(ZX80D: E3, E13, E51, MX/ZX100D: E3, E51, MX, SP, MY)


R537 1-216-853-11 METAL CHIP 470K 5% 1/10W

R538 1-216-830-11 METAL CHIP 5.6K 5% 1/10W(ZX80D: E2, E3, E13, E51/

ZX100D: E2, E3, E51, SP, MY)R539 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR540 1-216-833-11 METAL CHIP 10K 5% 1/10W


R549 1-216-824-11 METAL CHIP 1.8K 5% 1/10W

R551 1-216-842-11 METAL CHIP 56K 5% 1/10W(ZX80D: E3, E13, E51, MX/

ZX100D: E3, E51, MX, SP, MY)R552 1-216-843-11 METAL CHIP 68K 5% 1/10WR553 1-216-853-11 METAL CHIP 470K 5% 1/10WR554 1-216-835-11 METAL CHIP 15K 5% 1/10WR573 1-216-833-11 METAL CHIP 10K 5% 1/10W


0R579 1-215-889-00 METAL OXIDE 330 5% 2W FR581 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


(ZX80D: E3, E13, E51, MX/ZX100D: E3, E51, MX, SP, MY)

R582 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR584 1-216-833-11 METAL CHIP 10K 5% 1/10W


(ZX80D)


R593 1-216-811-11 METAL CHIP 150 5% 1/10W(ZX80D: E13)

R593 1-216-821-11 METAL CHIP 1K 5% 1/10W(ZX80D: E2, E51, MX/ZX100D: E2, E51, MX)

R593 1-216-829-11 METAL CHIP 4.7K 5% 1/10W(ZX80D: E3/ZX100D: E3)

R594 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R595 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR598 1-245-711-31 CARBON 10 5% 1/2W

(ZX100D)R599 1-245-711-31 CARBON 10 5% 1/2W

(ZX100D)R601 1-216-821-11 METAL CHIP 1K 5% 1/10W


(ZX80D)

R612 1-216-864-11 SHORT CHIP 0R623 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR662 1-216-864-11 SHORT CHIP 0

< TRANSFORMER >

T301 1-433-372-11 TRANSFORMER, BIAS OSCILLATION

MAIN


106

HCD-ZX80D/ZX100D

MIC

< TERMINAL >

TM101 1-780-170-21 TERMINAL BOARD (SPEAKER) (SUBWOOFER OUT) (ZX100D)

< VIBRATOR >

X401 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)X402 1-795-058-21 VIBRATOR, CERAMIC (5MHz)

************************************************************

A-1174-047-A MIC BOARD, COMPLETE********************

< CAPACITOR >

C1100 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1101 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1102 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC1103 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1104 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C1105 1-126-956-11 ELECT 0.1uF 20% 50VC1106 1-126-963-11 ELECT 4.7uF 20% 50VC1107 1-126-963-11 ELECT 4.7uF 20% 50VC1108 1-126-160-11 ELECT 1uF 20% 50VC1109 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V

C1110 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC1111 1-126-957-11 ELECT 0.22uF 20% 50VC1112 1-126-160-11 ELECT 1uF 20% 50VC1113 1-162-925-11 CERAMIC CHIP 68PF 5% 50VC1114 1-126-163-11 ELECT 4.7uF 20% 50V

C1115 1-126-963-11 ELECT 4.7uF 20% 50VC1116 1-126-947-11 ELECT 47uF 20% 35VC1117 1-126-947-11 ELECT 47uF 20% 35VC1119 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1121 1-126-957-11 ELECT 0.22uF 20% 50V

C1123 1-126-947-11 ELECT 47uF 20% 35VC1124 1-164-730-11 CERAMIC CHIP 0.0012uF 10% 50VC1125 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC1126 1-126-934-11 ELECT 220uF 20% 16VC1127 1-126-964-11 ELECT 10uF 20% 50V

C1128 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1129 1-100-566-11 CERAMIC CHIP 0.1uF 10% 25VC1133 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1134 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC1135 1-164-230-11 CERAMIC CHIP 220PF 5% 50V

C1136 1-100-566-11 CERAMIC CHIP 0.1uF 10% 25VC1139 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1142 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1144 1-124-261-00 ELECT 10uF 20% 50VC1145 1-124-261-00 ELECT 10uF 20% 50V

< CONNECTOR >

CN1102 1-785-329-11 PIN, CONNECTOR (LIGHT ANGLE) 3P

< DIODE >

D1102 6-501-167-01 DIODE UDZW-TE17-5.1B

< FERRITE BEAD/JUMPER RESISOR >

FB902 1-469-147-21 FERRITE, EMI (SMD) (2012)

FB1100 1-216-864-11 SHORT CHIP 0FB1101 1-216-864-11 SHORT CHIP 0

< IC >

IC1100 6-709-116-01 IC TC9488FGIC1101 8-759-710-97 IC NJM4565M-D

< JACK >

J1100 1-817-630-11 JACK (LARGE TYPE) (MIC 1)J1101 1-817-630-11 JACK (LARGE TYPE) (MIC 2)J1102 1-764-592-11 JACK 3P (VIDEO INPUT AUDIO/VIDEO)J1103 1-794-702-11 JACK, HEADPHONE (PHONES)

< RESISTOR >

R1100 1-216-835-11 METAL CHIP 15K 5% 1/10WR1102 1-216-821-11 METAL CHIP 1K 5% 1/10WR1103 1-216-821-11 METAL CHIP 1K 5% 1/10WR1104 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR1105 1-216-809-11 METAL CHIP 100 5% 1/10W

R1106 1-216-809-11 METAL CHIP 100 5% 1/10WR1107 1-216-809-11 METAL CHIP 100 5% 1/10WR1108 1-216-833-11 METAL CHIP 10K 5% 1/10WR1109 1-216-833-11 METAL CHIP 10K 5% 1/10WR1110 1-216-833-11 METAL CHIP 10K 5% 1/10W

R1111 1-216-833-11 METAL CHIP 10K 5% 1/10WR1113 1-216-834-11 METAL CHIP 12K 5% 1/10WR1114 1-216-833-11 METAL CHIP 10K 5% 1/10WR1115 1-216-815-11 METAL CHIP 330 5% 1/10WR1116 1-216-815-11 METAL CHIP 330 5% 1/10W

R1118 1-216-821-11 METAL CHIP 1K 5% 1/10WR1119 1-216-835-11 METAL CHIP 15K 5% 1/10WR1120 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR1121 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR1122 1-216-834-11 METAL CHIP 12K 5% 1/10W


R1130 1-216-835-11 METAL CHIP 15K 5% 1/10WR1131 1-216-835-11 METAL CHIP 15K 5% 1/10WR1132 1-216-864-11 SHORT CHIP 0R1137 1-216-833-11 METAL CHIP 10K 5% 1/10WR1138 1-216-833-11 METAL CHIP 10K 5% 1/10W

R1139 1-216-833-11 METAL CHIP 10K 5% 1/10WR1140 1-216-833-11 METAL CHIP 10K 5% 1/10WR1147 1-216-835-11 METAL CHIP 15K 5% 1/10WR1152 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1156 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

< VARIABLE RESISTOR >

RV1100 1-227-452-11 RES, VAR, CARBON 50K (ECHO LEVEL)RV1101 1-227-452-11 RES, VAR, CARBON 50K (MIC 2 LEVEL)RV1102 1-227-452-11 RES, VAR, CARBON 50K (MIC 1 LEVEL)

************************************************************

MAINVer. 1.1


107

HCD-ZX80D/ZX100D

1-687-133-12 MOTOR (LD) BOARD*****************

************************************************************

1-687-134-12 MOTOR (TB) BOARD*****************

< CONNECTOR >

CN742 1-784-727-11 CONNECTOR, FFC 5P************************************************************

A-1174-202-A PA BOARD, COMPLETE (ZX80D: MX)A-1174-267-A PA BOARD, COMPLETE (ZX100D: MX)A-1174-326-A PA BOARD, COMPLETE (ZX80D: E3, E13)A-1174-337-A PA BOARD, COMPLETE (ZX100D: E3, SP, MY)A-1193-201-A PA BOARD, COMPLETE (ZX80D: US, E2, E51)

A-1193-204-A PA BOARD, COMPLETE (ZX100D: E2, E51)*******************

< CAPACITOR >

C600 1-126-963-11 ELECT 4.7uF 20% 50VC601 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC602 1-126-934-11 ELECT 220uF 20% 16VC603 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC604 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C605 1-164-156-11 CERAMIC CHIP 0.1uF 25VC606 1-164-156-11 CERAMIC CHIP 0.1uF 25VC608 1-126-965-11 ELECT 22uF 20% 50VC609 1-128-582-11 ELECT 10uF 20% 100VC610 1-128-582-11 ELECT 10uF 20% 100V

C616 1-136-495-11 FILM 0.068uF 5% 50VC617 1-136-495-11 FILM 0.068uF 5% 50VC618 1-128-560-11 ELECT 22uF 20% 100VC619 1-128-560-11 ELECT 22uF 20% 100VC634 1-104-665-11 ELECT 100uF 20% 25V

C635 1-104-665-11 ELECT 100uF 20% 25VC636 1-107-721-11 ELECT 4.7uF 20% 100VC637 1-107-721-11 ELECT 4.7uF 20% 100VC648 1-104-665-11 ELECT 100uF 20% 25VC649 1-126-964-11 ELECT 10uF 20% 50V

C650 1-126-963-11 ELECT 4.7uF 20% 50VC651 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC652 1-126-934-11 ELECT 220uF 20% 16VC653 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC654 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C655 1-126-964-11 ELECT 10uF 20% 50VC656 1-127-815-11 ELECT (BLOCK) 3300uF 20% 100VC658 1-112-035-11 ELECT (BLOCK) 4700uF 20% 50VC660 1-164-156-11 CERAMIC CHIP 0.1uF 25VC666 1-136-495-11 FILM 0.068uF 5% 50V

C667 1-136-495-11 FILM 0.068uF 5% 50VC676 1-127-815-11 ELECT (BLOCK) 3300uF 20% 100VC678 1-112-035-11 ELECT (BLOCK) 4700uF 20% 50VC681 1-131-992-11 CERAMIC CHIP 100000PF 35VC682 1-131-992-11 CERAMIC CHIP 100000PF 35V

C683 1-164-156-11 CERAMIC CHIP 0.1uF 25VC691 1-131-992-11 CERAMIC CHIP 100000PF 35VC692 1-131-992-11 CERAMIC CHIP 100000PF 35V

C693 1-164-156-11 CERAMIC CHIP 0.1uF 25V

< CONNECTOR >

CN600 1-764-865-41 CONNECTOR, BOARD TO BOARD 13PCN601 1-784-031-41 CONNECTOR, BOARD TO BOARD 8P

* CN602 1-564-512-11 PLUG, CONNECTOR 9P* CN607 1-564-508-11 PLUG, CONNECTOR 5P

< DIODE >

D609 8-719-404-50 DIODE MA111-TXD611 8-719-056-93 DIODE UDZ-TE-17-18BD612 8-719-056-93 DIODE UDZ-TE-17-18BD620 8-719-404-50 DIODE MA111-TXD624 8-719-404-50 DIODE MA111-TX


D670 8-719-404-50 DIODE MA111-TX

< IC >

IC600 6-600-169-01 IC STK412-240M-E (ZX80D)IC600 6-600-171-01 IC STK412-230-E (ZX100D)

< JUMPER RESISTOR >


< COIL >

L680 1-420-872-52 COIL, AIR-COREL690 1-420-872-52 COIL, AIR-CORE

< TRANSISTOR >

Q604 8-729-924-99 TRANSISTOR 2SC3722K-EQ606 8-729-821-00 TRANSISTOR 2SA1207Q610 8-729-924-99 TRANSISTOR 2SC3722K-EQ618 8-729-924-99 TRANSISTOR 2SC3722K-EQ628 8-729-230-49 TRANSISTOR 2SC2712-YG

Q630 8-729-230-49 TRANSISTOR 2SC2712-YGQ634 8-729-027-31 TRANSISTOR DTA124EKA-T146Q640 8-729-023-22 TRANSISTOR 2SD2114KQ641 8-729-023-22 TRANSISTOR 2SD2114KQ644 8-729-230-49 TRANSISTOR 2SC2712-YG

Q647 8-729-230-49 TRANSISTOR 2SC2712-YGQ648 8-729-230-49 TRANSISTOR 2SC2712-YGQ668 8-729-924-99 TRANSISTOR 2SC3722K-EQ682 8-729-230-49 TRANSISTOR 2SC2712-YG

< RESISTOR >

R600 1-216-821-11 METAL CHIP 1K 5% 1/10WR601 1-216-841-11 METAL CHIP 47K 5% 1/10WR602 1-216-816-11 METAL CHIP 390 5% 1/10WR603 1-216-841-11 METAL CHIP 47K 5% 1/10WR604 1-216-833-11 METAL CHIP 10K 5% 1/10W

MOTOR (TB)MOTOR (LD) PAVer. 1.1


108

HCD-ZX80D/ZX100D

PA



0R612 1-245-605-51 FUSIBLE 100 5% 1/4W F0R613 1-215-869-11 METAL OXIDE 1K 5% 1W F0R614 1-215-869-11 METAL OXIDE 1K 5% 1W F

0R615 1-245-605-51 FUSIBLE 100 5% 1/4W F0R616 1-217-637-00 FUSIBLE 1 5% 1/4W F

R617 1-216-845-11 METAL CHIP 100K 5% 1/10W0R618 1-234-499-21 ENCAPSULATED COMPONENT 0.22 5W F

R619 1-216-821-11 METAL CHIP 1K 5% 1/10W

R620 1-216-836-11 METAL CHIP 18K 5% 1/10WR621 1-216-847-11 METAL CHIP 150K 5% 1/10WR622 1-245-711-31 CARBON 10 5% 1/2WR623 1-216-843-11 METAL CHIP 68K 5% 1/10WR624 1-216-837-11 METAL CHIP 22K 5% 1/10W

R625 1-216-825-11 METAL CHIP 2.2K 5% 1/10W(ZX80D)


R628 1-216-837-11 METAL CHIP 22K 5% 1/10WR629 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR630 1-216-845-11 METAL CHIP 100K 5% 1/10W

R631 1-216-845-11 METAL CHIP 100K 5% 1/10WR633 1-216-864-11 SHORT CHIP 0R634 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR635 1-216-833-11 METAL CHIP 10K 5% 1/10W

0R636 1-216-456-00 METAL OXIDE 820 5% 2W F

0R637 1-216-456-00 METAL OXIDE 820 5% 2W FR638 1-216-845-11 METAL CHIP 100K 5% 1/10WR639 1-216-845-11 METAL CHIP 100K 5% 1/10WR640 1-216-821-11 METAL CHIP 1K 5% 1/10WR641 1-216-821-11 METAL CHIP 1K 5% 1/10W

R642 1-216-811-11 METAL CHIP 150 5% 1/10WR643 1-216-811-11 METAL CHIP 150 5% 1/10WR644 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR645 1-216-833-11 METAL CHIP 10K 5% 1/10W

0R646 1-260-086-31 CARBON 82 5% 1/2W F(ZX100D)

0R646 1-260-087-11 CARBON 100 5% 1/2W F(ZX80D)




R661 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R662 1-216-811-11 METAL CHIP 150 5% 1/10WR663 1-216-811-11 METAL CHIP 150 5% 1/10W

0R668 1-234-499-21 ENCAPSULATED COMPONENT 0.22 5W FR669 1-216-821-11 METAL CHIP 1K 5% 1/10WR670 1-216-836-11 METAL CHIP 18K 5% 1/10W

R671 1-216-847-11 METAL CHIP 150K 5% 1/10WR672 1-245-711-31 CARBON 10 5% 1/2WR673 1-216-842-11 METAL CHIP 56K 5% 1/10WR674 1-216-837-11 METAL CHIP 22K 5% 1/10WR676 1-216-849-11 METAL CHIP 220K 5% 1/10W

R677 1-216-849-11 METAL CHIP 220K 5% 1/10WR678 1-216-845-11 METAL CHIP 100K 5% 1/10WR680 1-245-711-31 CARBON 10 5% 1/2WR681 1-245-711-31 CARBON 10 5% 1/2WR682 1-216-821-11 METAL CHIP 1K 5% 1/10W

R683 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR685 1-216-833-11 METAL CHIP 10K 5% 1/10WR690 1-245-711-31 CARBON 10 5% 1/2WR691 1-245-711-31 CARBON 10 5% 1/2WR692 1-216-841-11 METAL CHIP 47K 5% 1/10W


R698 1-216-845-11 METAL CHIP 100K 5% 1/10W

< RELAY >

RY646 1-755-500-11 RELAY

< THERMISTOR >

TH629 1-807-796-11 THERMISTORTH630 1-807-796-11 THERMISTOR

< TERMINAL >

TM600 1-780-001-21 TERMINAL BOARD (SPEAKER)(FRONT SPEAKER)

************************************************************

A-1174-175-A PANEL BOARD, COMPLETE (ZX80D: MX/ZX100D: MX)

A-1174-312-A PANEL BOARD, COMPLETE (ZX80D: US, E2, E3,E13, E51/ZX100D: E2, E3, E51, SP, MY)

**********************

< CAPACITOR >

C900 1-126-163-11 ELECT 4.7uF 20% 50VC901 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC902 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC903 1-164-156-11 CERAMIC CHIP 0.1uF 25VC904 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C905 1-164-156-11 CERAMIC CHIP 0.1uF 25VC906 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC908 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC909 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC910 1-164-156-11 CERAMIC CHIP 0.1uF 25V

PANELVer. 1.1


109

HCD-ZX80D/ZX100D

C916 1-164-156-11 CERAMIC CHIP 0.1uF 25VC917 1-164-156-11 CERAMIC CHIP 0.1uF 25VC920 1-164-156-11 CERAMIC CHIP 0.1uF 25VC922 1-119-941-11 ELECT 470uF 20% 6.3VC923 1-119-941-11 ELECT 470uF 20% 6.3V

C924 1-119-941-11 ELECT 470uF 20% 6.3VC925 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC926 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC927 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC928 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C929 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC930 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC931 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC932 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC933 1-162-962-11 CERAMIC CHIP 470PF 10% 50V


C939 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC940 1-164-156-11 CERAMIC CHIP 0.1uF 25VC941 1-126-964-11 ELECT 10uF 20% 50VC942 1-124-261-00 ELECT 10uF 20% 50VC943 1-126-964-11 ELECT 10uF 20% 50V

C945 1-115-156-11 CERAMIC CHIP 1uF 10VC946 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC947 1-115-156-11 CERAMIC CHIP 1uF 10VC948 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC949 1-115-156-11 CERAMIC CHIP 1uF 10V

C950 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC951 1-115-156-11 CERAMIC CHIP 1uF 10VC952 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC953 1-115-156-11 CERAMIC CHIP 1uF 10VC954 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V

C955 1-115-156-11 CERAMIC CHIP 1uF 10VC956 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC957 1-115-156-11 CERAMIC CHIP 1uF 10VC958 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC959 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V

C961 1-164-156-11 CERAMIC CHIP 0.1uF 25VC964 1-124-589-11 ELECT 47uF 20% 16VC967 1-124-261-00 ELECT 10uF 20% 50VC972 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC973 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C974 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC975 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC977 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC978 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC979 1-162-927-11 CERAMIC CHIP 100PF 5% 50V


< CONNECTOR >



< DIODE/JUMPER RESISTOR >

D901 8-719-404-50 DIODE MA111-TXD905 1-216-864-11 SHORT CHIP 0D908 8-719-064-63 LED SELU5823C-TP15 (DVD)D909 8-719-064-63 LED SELU5823C-TP15 (TUNER/BAND)D910 8-719-064-63 LED SELU5823C-TP15 (TAPE A/B)

D911 8-719-064-63 LED SELU5823C-TP15 (Y (AMBER))D913 8-719-064-63 LED SELU5823C-TP15 (PRESET + >)D914 8-719-064-63 LED SELU5823C-TP15 (PRESET – .)D915 8-719-058-03 LED SEL5423E-TP15 (Y (GRN))D916 8-719-064-63 LED SELU5823C-TP15 (TV/SAT)

D917 8-719-064-63 LED SELU5823C-TP15 (VIDEO)D927 8-719-058-04 LED SEL5223S-TP15 (I/1 (GRN))D928 8-719-058-03 LED SEL5423E-TP15 (I/1 (RED))D929 8-719-064-63 LED SELU5823C-TP15 (TUNING + M y)D930 8-719-064-63 LED SELU5823C-TP15 (TUNING – m y)

D931 8-719-404-50 DIODE MA111-TXD932 8-719-404-50 DIODE MA111-TXD1145 8-719-064-63 LED SELU5823C-TP15 (X)D1153 8-719-064-63 LED SELU5823C-TP15 (x)

< JUMPER RESISTOR >

FB901 1-216-864-11 SHORT CHIP 0

< FLUORESCENT INDICATOR TUBE >

FL901 1-519-794-21 VACUUM FLUORESCENT DISPLAYS

< IC >

IC902 6-806-206-01 IC MB90M407PF-G-149E1IC903 6-600-309-01 IC RPM7240-H9IC904 6-705-678-01 IC NJM2760V-TE2

< JUMPER RESISTOR >

JR904 1-216-864-11 SHORT CHIP 0JR914 1-216-864-11 SHORT CHIP 0JR925 1-216-296-11 SHORT CHIP 0

< TRANSISTOR >

Q901 8-729-027-56 TRANSISTOR DTC143TKA-T146Q902 8-729-027-56 TRANSISTOR DTC143TKA-T146Q903 6-550-262-01 TRANSISTOR RT1P237C-TP-1Q904 8-729-106-60 TRANSISTOR 2SB1115A-YQQ905 8-729-106-60 TRANSISTOR 2SB1115A-YQ

Q906 8-729-027-50 TRANSISTOR DTC123JKA-T146Q907 8-729-027-50 TRANSISTOR DTC123JKA-T146Q908 8-729-027-50 TRANSISTOR DTC123JKA-T146Q909 8-729-027-50 TRANSISTOR DTC123JKA-T146Q910 8-729-027-50 TRANSISTOR DTC123JKA-T146

Q914 8-729-027-56 TRANSISTOR DTC143TKA-T146Q917 8-729-027-50 TRANSISTOR DTC123JKA-T146Q918 8-729-027-50 TRANSISTOR DTC123JKA-T146Q919 8-729-027-50 TRANSISTOR DTC123JKA-T146

< RESISTOR >

R900 1-216-833-11 METAL CHIP 10K 5% 1/10W

PANELVer. 1.1


110

HCD-ZX80D/ZX100D

R901 1-216-833-11 METAL CHIP 10K 5% 1/10WR902 1-216-833-11 METAL CHIP 10K 5% 1/10WR903 1-216-809-11 METAL CHIP 100 5% 1/10WR904 1-216-809-11 METAL CHIP 100 5% 1/10W

R905 1-216-835-11 METAL CHIP 15K 5% 1/10WR906 1-216-835-11 METAL CHIP 15K 5% 1/10WR907 1-216-835-11 METAL CHIP 15K 5% 1/10WR908 1-216-809-11 METAL CHIP 100 5% 1/10WR909 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


R919 1-216-845-11 METAL CHIP 100K 5% 1/10WR920 1-216-845-11 METAL CHIP 100K 5% 1/10WR922 1-216-857-11 METAL CHIP 1M 5% 1/10WR923 1-216-819-11 METAL CHIP 680 5% 1/10WR941 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R942 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR943 1-216-833-11 METAL CHIP 10K 5% 1/10WR944 1-216-805-11 METAL CHIP 47 5% 1/10WR947 1-216-821-11 METAL CHIP 1K 5% 1/10WR948 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W


R954 1-216-833-11 METAL CHIP 10K 5% 1/10WR956 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR957 1-216-819-11 METAL CHIP 680 5% 1/10WR964 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR965 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W

R966 1-216-833-11 METAL CHIP 10K 5% 1/10WR967 1-216-835-11 METAL CHIP 15K 5% 1/10WR968 1-216-837-11 METAL CHIP 22K 5% 1/10WR974 1-216-819-11 METAL CHIP 680 5% 1/10WR979 1-216-810-11 METAL CHIP 120 5% 1/10W


R987 1-216-819-11 METAL CHIP 680 5% 1/10WR990 1-216-819-11 METAL CHIP 680 5% 1/10WR997 1-216-819-11 METAL CHIP 680 5% 1/10WR1007 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1008 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1009 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR1010 1-216-833-11 METAL CHIP 10K 5% 1/10WR1011 1-216-835-11 METAL CHIP 15K 5% 1/10WR1012 1-216-837-11 METAL CHIP 22K 5% 1/10WR1013 1-216-839-11 METAL CHIP 33K 5% 1/10W

R1021 1-216-809-11 METAL CHIP 100 5% 1/10WR1022 1-216-809-11 METAL CHIP 100 5% 1/10WR1023 1-216-809-11 METAL CHIP 100 5% 1/10WR1024 1-216-809-11 METAL CHIP 100 5% 1/10W

R1025 1-216-809-11 METAL CHIP 100 5% 1/10W



R1189 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

< SWITCH >

S907 1-762-875-21 SWITCH, KEYBOARD (Y)S908 1-762-875-21 SWITCH, KEYBOARD (X)S909 1-762-875-21 SWITCH, KEYBOARD (x)S910 1-762-875-21 SWITCH, KEYBOARD (PRESET + >)S911 1-762-875-21 SWITCH, KEYBOARD (PRESET – .)

S912 1-762-875-21 SWITCH, KEYBOARD (TUNING + M y)S913 1-762-875-21 SWITCH, KEYBOARD (TUNING – m y)S921 1-762-875-21 SWITCH, KEYBOARD (VIDEO)S922 1-762-875-21 SWITCH, KEYBOARD (TV/SAT)S923 1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)

S924 1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)S925 1-762-875-21 SWITCH, KEYBOARD (DVD)S927 1-762-875-21 SWITCH, KEYBOARD (I/1)

< VIBRATOR >

X901 1-781-282-51 VIBRATOR, CERAMIC (4MHz)************************************************************

PRIMARY BOARD**************

< CAPACITOR >

0C1200 1-113-924-11 CERAMIC 0.0047uF 20% 250V(ZX80D)

C1201 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1202 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1204 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1206 1-126-916-11 ELECT 1000uF 20% 6.3V

< CONNECTOR >

CN1200 1-785-329-11 PIN, CONNECTOR (LIGHT ANGLE) 3PCN1202 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2PCN1204 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P

(ZX80D: US, MX/ZX100D: MX)CN1204 1-568-106-11 PIN, CONNECTOR (3.96mm PITCH) 4P (ZX80D:

E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

< DIODE >

D1200 8-719-404-50 DIODE MA111-TX

< JUMPER RESISTOR >

JR1202 1-216-864-11 SHORT CHIP 0

PRIMARYPANELVer. 1.1


111

HCD-ZX80D/ZX100D

< COIL >

L1201 1-410-666-31 INDUCTOR 18uH

< TRANSISTOR >

Q1200 8-729-230-49 TRANSISTOR 2SC2712-YG

< RESISTOR >


< RELAY >

0RY1200 1-755-439-11 RELAY

< SWITCH >

0S1200 1-771-291-31 SWITCH, POWER (VOLTAGE SELECTOR)(ZX80D: E2, E3, E13, E51/

ZX100D: E2, E3, E51, SP, MY)************************************************************

1-687-132-12 SENSOR BOARD*************

< CONNECTOR >

CN731 1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P

< IC >

IC731 6-600-564-01 IC RPI-579N1************************************************************

A-1174-185-A SURROUND BOARD, COMPLETE (ZX80D: MX)A-1174-262-A SURROUND BOARD, COMPLETE (ZX100D: MX)A-1174-323-A SURROUND BOARD, COMPLETE

(ZX80D: US, E2, E3, E13, E51)A-1174-333-A SURROUND BOARD, COMPLETE

(ZX100D: E2, E3, E51, SP, MY)**************************

< CAPACITOR >

C700 1-126-963-11 ELECT 4.7uF 20% 50VC701 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC702 1-126-934-11 ELECT 220uF 20% 16VC703 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC704 1-126-963-11 ELECT 4.7uF 20% 50V


C711 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC712 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC721 1-126-965-11 ELECT 22uF 20% 50VC730 1-136-495-11 FILM 0.068uF 5% 50V

C731 1-136-495-11 FILM 0.068uF 5% 50VC732 1-131-992-11 CERAMIC CHIP 100000PF 35VC733 1-131-992-11 CERAMIC CHIP 100000PF 35VC740 1-126-963-11 ELECT 4.7uF 20% 50V

(ZX100D)C741 1-164-230-11 CERAMIC CHIP 220PF 5% 50V

(ZX100D)

C742 1-126-934-11 ELECT 220uF 20% 16V(ZX100D)


C744 1-126-963-11 ELECT 4.7uF 20% 50V(ZX100D)

C750 1-126-963-11 ELECT 4.7uF 20% 50VC751 1-164-230-11 CERAMIC CHIP 220PF 5% 50V

C752 1-126-934-11 ELECT 220uF 20% 16VC753 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC754 1-126-963-11 ELECT 4.7uF 20% 50VC770 1-136-495-11 FILM 0.068uF 5% 50V

(ZX100D)C771 1-136-495-11 FILM 0.068uF 5% 50V

(ZX100D)

C772 1-131-992-11 CERAMIC CHIP 100000PF 35V(ZX100D)

C773 1-131-992-11 CERAMIC CHIP 100000PF 35V(ZX100D)

C780 1-136-495-11 FILM 0.068uF 5% 50VC781 1-136-495-11 FILM 0.068uF 5% 50VC782 1-131-992-11 CERAMIC CHIP 100000PF 35V

C783 1-131-992-11 CERAMIC CHIP 100000PF 35VC791 1-162-974-11 CERAMIC CHIP 0.01uF 50V

(ZX100D)C792 1-162-974-11 CERAMIC CHIP 0.01uF 50VC793 1-128-563-11 ELECT 100uF 20% 100VC794 1-128-563-11 ELECT 100uF 20% 100V

C795 1-128-560-11 ELECT 22uF 20% 100VC796 1-128-560-11 ELECT 22uF 20% 100VC800 1-126-963-11 ELECT 4.7uF 20% 50VC801 1-100-717-11 CERAMIC CHIP 1uF 16V

(ZX100D)C802 1-104-665-11 ELECT 100uF 20% 25V

C803 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC804 1-164-156-11 CERAMIC CHIP 0.1uF 25VC805 1-164-156-11 CERAMIC CHIP 0.1uF 25VC806 1-126-961-11 ELECT 2.2uF 20% 50VC807 1-100-717-11 CERAMIC CHIP 1uF 16V

(ZX100D)

C808 1-131-749-11 CERAMIC CHIP 8.2PF 50VC820 1-126-964-11 ELECT 10uF 20% 50VC825 1-126-968-11 ELECT 100uF 20% 50VC826 1-126-968-11 ELECT 100uF 20% 50VC838 1-136-495-11 FILM 0.068uF 5% 50V

C839 1-136-495-11 FILM 0.068uF 5% 50VC843 1-126-963-11 ELECT 4.7uF 20% 50VC850 1-126-963-11 ELECT 4.7uF 20% 50VC851 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC852 1-104-665-11 ELECT 100uF 20% 25V

C853 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC858 1-131-749-11 CERAMIC CHIP 8.2PF 50VC888 1-136-495-11 FILM 0.068uF 5% 50VC889 1-136-495-11 FILM 0.068uF 5% 50V

< CONNECTOR >

CN700 1-764-865-41 CONNECTOR, BOARD TO BOARD 13PCN701 1-784-031-41 CONNECTOR, BOARD TO BOARD 8P

< DIODE >

D710 6-501-180-01 DIODE UDZW-TE17-18B

PRIMARY SENSOR SURROUNDVer. 1.1


112

HCD-ZX80D/ZX100D

D711 6-501-180-01 DIODE UDZW-TE17-18BD720 8-719-404-50 DIODE MA111-TXD730 8-719-404-50 DIODE MA111-TXD761 8-719-404-50 DIODE MA111-TX (ZX100D)

D762 8-719-404-50 DIODE MA111-TXD763 8-719-404-50 DIODE MA111-TXD764 8-719-404-50 DIODE MA111-TXD765 8-719-404-50 DIODE MA111-TX (ZX100D)D770 8-719-404-50 DIODE MA111-TX (ZX100D)


D850 8-719-404-50 DIODE MA111-TX

< IC >

IC702 6-600-169-01 IC STK412-240M-E (ZX80D)IC702 6-600-339-01 IC STK413-430 (ZX100D)IC800 6-600-089-01 IC STK403-070 (ZX80D)IC800 6-704-107-01 IC STK403-100-E (ZX100D)

< JUMPER RESISTOR >

JR700 1-216-296-11 SHORT CHIP 0JR791 1-216-864-11 SHORT CHIP 0 (ZX100D)JR792 1-216-296-11 SHORT CHIP 0 (ZX100D)JR797 1-216-296-11 SHORT CHIP 0

< COIL >

L730 1-420-872-52 COIL, AIR-COREL770 1-420-872-52 COIL, AIR-CORE (ZX100D)L780 1-420-872-52 COIL, AIR-CORE

< TRANSISTOR >

Q700 8-729-023-22 TRANSISTOR 2SD2114KQ720 8-729-230-49 TRANSISTOR 2SC2712-YGQ721 8-729-821-00 TRANSISTOR 2SA1207Q722 8-729-924-99 TRANSISTOR 2SC3722K-EQ730 8-729-924-99 TRANSISTOR 2SC3722K-E

Q740 8-729-023-22 TRANSISTOR 2SD2114K (ZX100D)Q750 8-729-023-22 TRANSISTOR 2SD2114KQ762 8-729-230-49 TRANSISTOR 2SC2712-YG (ZX100D)Q763 8-729-230-49 TRANSISTOR 2SC2712-YGQ765 8-729-023-22 TRANSISTOR 2SD2114K

Q770 8-729-924-99 TRANSISTOR 2SC3722K-E (ZX100D)Q780 8-729-924-99 TRANSISTOR 2SC3722K-EQ800 8-729-924-99 TRANSISTOR 2SC3722K-EQ810 8-729-023-22 TRANSISTOR 2SD2114KQ812 8-729-924-99 TRANSISTOR 2SC3722K-E

Q814 8-729-230-49 TRANSISTOR 2SC2712-YGQ815 8-729-230-49 TRANSISTOR 2SC2712-YGQ850 8-729-924-99 TRANSISTOR 2SC3722K-E

< RESISTOR >

R700 1-216-821-11 METAL CHIP 1K 5% 1/10WR701 1-216-841-11 METAL CHIP 47K 5% 1/10WR702 1-216-816-11 METAL CHIP 390 5% 1/10W

(ZX100D)

R702 1-218-482-11 METAL CHIP 430 5% 1/10W(ZX80D)

R703 1-216-821-11 METAL CHIP 1K 5% 1/10W





0R730 1-234-499-21 ENCAPSULATED COMPONENT 0.22 5W F

R731 1-216-821-11 METAL CHIP 1K 5% 1/10WR732 1-216-838-11 METAL CHIP 27K 5% 1/10WR733 1-216-845-11 METAL CHIP 100K 5% 1/10WR734 1-216-842-11 METAL CHIP 56K 5% 1/10WR735 1-245-711-31 CARBON 10 5% 1/2W

R736 1-245-711-31 CARBON 10 5% 1/2WR737 1-245-711-31 CARBON 10 5% 1/2WR740 1-216-821-11 METAL CHIP 1K 5% 1/10W


(ZX100D)R742 1-218-484-11 METAL CHIP 750 5% 1/10W

(ZX100D)





R750 1-216-821-11 METAL CHIP 1K 5% 1/10W

R751 1-216-841-11 METAL CHIP 47K 5% 1/10WR752 1-216-816-11 METAL CHIP 390 5% 1/10W

(ZX100D)R752 1-218-482-11 METAL CHIP 430 5% 1/10W



0R764 1-260-086-31 CARBON 82 5% 1/2W F(ZX80D: MX/ZX100D:MX)

0R764 1-260-087-11 CARBON 100 5% 1/2W(ZX80D: US, E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)

0R765 1-260-086-31 CARBON 82 5% 1/2W F(ZX100D: MX)

SURROUNDVer. 1.1


113

HCD-ZX80D/ZX100D

0R765 1-260-087-11 CARBON 100 5% 1/2W(ZX100D: E2, E3, E51, SP, MY)

R766 1-216-825-11 METAL CHIP 2.2K 5% 1/10W(ZX100D)



0R770 1-234-499-21 ENCAPSULATED COMPONENT 0.22 5W F(ZX100D)





R775 1-245-711-31 CARBON 10 5% 1/2W(ZX100D)

R776 1-245-711-31 CARBON 10 5% 1/2W(ZX100D)

R777 1-245-711-31 CARBON 10 5% 1/2W(ZX100D)


0R780 1-234-499-21 ENCAPSULATED COMPONENT 0.22 5W FR781 1-216-821-11 METAL CHIP 1K 5% 1/10WR782 1-216-838-11 METAL CHIP 27K 5% 1/10W

R783 1-216-845-11 METAL CHIP 100K 5% 1/10WR784 1-216-841-11 METAL CHIP 47K 5% 1/10WR785 1-245-711-31 CARBON 10 5% 1/2WR786 1-245-711-31 CARBON 10 5% 1/2WR787 1-245-711-31 CARBON 10 5% 1/2W


R792 1-216-845-11 METAL CHIP 100K 5% 1/10W0R793 1-217-637-00 FUSIBLE 1 5% 1/4W F0R794 1-245-605-51 FUSIBLE 100 5% 1/4W F0R795 1-245-605-51 FUSIBLE 100 5% 1/4W F

0R796 1-215-872-11 METAL OXIDE 3.3K 5% 1W FR797 1-216-837-11 METAL CHIP 22K 5% 1/10WR798 1-216-821-11 METAL CHIP 1K 5% 1/10W

0R799 1-215-872-11 METAL OXIDE 3.3K 5% 1W FR800 1-216-821-11 METAL CHIP 1K 5% 1/10W

R801 1-216-841-11 METAL CHIP 47K 5% 1/10WR802 1-216-814-11 METAL CHIP 270 5% 1/10W



0R804 1-217-637-00 FUSIBLE 1 5% 1/4W F

0R805 1-217-637-00 FUSIBLE 1 5% 1/4W FR806 1-216-821-11 METAL CHIP 1K 5% 1/10WR807 1-216-841-11 METAL CHIP 47K 5% 1/10WR808 1-216-841-11 METAL CHIP 47K 5% 1/10WR812 1-216-825-11 METAL CHIP 2.2K 5% 1/10W


0R827 1-245-605-51 FUSIBLE 100 5% 1/4W F

0R828 1-245-605-51 FUSIBLE 100 5% 1/4W F0R838 1-220-893-11 METAL 0.22 10% 5W F

R839 1-216-821-11 METAL CHIP 1K 5% 1/10WR840 1-216-837-11 METAL CHIP 22K 5% 1/10WR841 1-216-845-11 METAL CHIP 100K 5% 1/10WR842 1-245-711-31 CARBON 10 5% 1/2WR843 1-216-841-11 METAL CHIP 47K 5% 1/10W


R861 1-216-841-11 METAL CHIP 47K 5% 1/10W0R862 1-260-086-31 CARBON 82 5% 1/2W F

(ZX80D: MX/ZX100D: MX)0R862 1-260-087-11 CARBON 100 5% 1/2W




0R888 1-220-893-11 METAL 0.22 10% 5W FR889 1-216-821-11 METAL CHIP 1K 5% 1/10WR890 1-216-837-11 METAL CHIP 22K 5% 1/10W

R891 1-216-845-11 METAL CHIP 100K 5% 1/10WR892 1-245-711-31 CARBON 10 5% 1/2W

< RELAY >

RY760 1-755-500-11 RELAYRY761 1-755-170-11 RELAY (12V) (ZX100D)RY862 1-755-500-11 RELAY

< TERMINAL >

TM700 1-780-001-21 TERMINAL BOARD (SPEAKER)(CENTER SPEAKER)

TM701 1-780-170-21 TERMINAL BOARD (SPEAKER)(SURR SPEAKER)

************************************************************

1-687-669-12 SW BOARD*********

< SWITCH >

S751 1-786-514-11 SWITCH, LEVER (SLIDE)(DISC TABLE OPEN/CLOSE DETECT)

************************************************************

A-1174-058-A TRANS BOARD, COMPLETE(ZX100D: E2, E3, E51, SP, MY)

A-1174-204-A TRANS BOARD, COMPLETE (ZX80D: MX)A-1174-927-A TRANS BOARD, COMPLETE

(ZX80D: E2, E3, E13, E51)A-1174-928-A TRANS BOARD, COMPLETE (ZX100D: MX)A-1227-256-A TRANS BOARD, COMPLETE (ZX80D: US)

**********************

< CAPACITOR >

C1262 1-126-964-11 ELECT 10uF 20% 50VC1263 1-126-968-11 ELECT 100uF 20% 50V

SURROUND SW TRANSVer. 1.1


114

HCD-ZX80D/ZX100D

C1292 1-128-576-11 ELECT 100uF 20% 63V

< CONNECTOR >

* CN1212 1-564-522-11 PLUG, CONNECTOR 7P* CN1213 1-564-523-11 PLUG, CONNECTOR 8P

CN1215 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P(ZX100D)

< DIODE >

* D1264 8-719-071-83 DIODE HZU36BTRFD1292 6-500-522-21 DIODE 10EDB40-TB3

< FUSE HOLDER >

FH1241 1-533-217-41 HOLDER, FUSEFH1242 1-533-217-41 HOLDER, FUSEFH1251 1-533-217-41 HOLDER, FUSEFH1252 1-533-217-41 HOLDER, FUSEFH1261 1-533-217-41 HOLDER, FUSE

FH1262 1-533-217-41 HOLDER, FUSEFH1271 1-533-217-41 HOLDER, FUSEFH1272 1-533-217-41 HOLDER, FUSEFH1281 1-533-217-41 HOLDER, FUSEFH1282 1-533-217-41 HOLDER, FUSE

FH1291 1-533-217-41 HOLDER, FUSEFH1292 1-533-217-41 HOLDER, FUSE

< CONNECTOR >

NO1211 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P(ZX80D: US)

< TRANSISTOR >

Q1264 8-729-024-93 TRANSISTOR 2SB1565E

< RESISTOR >

0R1233 1-219-237-11 SOLID 3.3M 20% 1/2W F(ZX80D: US)

R1262 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR1263 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR1264 1-216-821-11 METAL CHIP 1K 5% 1/10W

0R1292 1-219-124-11 FUSIBLE 0.68 5% 1/4W F************************************************************

A-1174-061-A VIDEO BOARD, COMPLETE (ZX80D: US, E2, E3,E13, E51/ZX100D: E2, E3, E51, SP, MY)

A-1174-224-A VIDEO BOARD, COMPLETE(ZX80D: MX/ZX100D: MX)

**********************

< CAPACITOR >

C800 1-126-960-11 ELECT 1uF 20% 50VC801 1-126-960-11 ELECT 1uF 20% 50VC802 1-126-960-11 ELECT 1uF 20% 50VC803 1-126-965-11 ELECT 22uF 20% 50VC804 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C805 1-126-960-11 ELECT 1uF 20% 50VC806 1-126-960-11 ELECT 1uF 20% 50VC807 1-126-960-11 ELECT 1uF 20% 50VC808 1-104-665-11 ELECT 100uF 20% 25VC809 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C810 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC811 1-126-916-11 ELECT 1000uF 20% 6.3VC812 1-126-916-11 ELECT 1000uF 20% 6.3VC813 1-126-916-11 ELECT 1000uF 20% 6.3VC814 1-126-916-11 ELECT 1000uF 20% 6.3V

C815 1-126-916-11 ELECT 1000uF 20% 6.3VC816 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC817 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC818 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC819 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C820 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC821 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC822 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC823 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC824 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C825 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC826 1-126-964-11 ELECT 10uF 20% 50VC827 1-126-964-11 ELECT 10uF 20% 50VC829 1-126-916-11 ELECT 1000uF 20% 6.3VC830 1-104-665-11 ELECT 100uF 20% 25V


< CONNECTOR >

CN800 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5PCN801 (Not supplied) FFC CONNECTOR (LIF (NON-ZIF)) 13PCN802 1-785-328-11 PIN, CONNECTOR (LIGHT ANGRE) 2P

< JUMPER RESISTOR >

FB800 1-216-864-11 SHORT CHIP 0FB801 1-216-864-11 SHORT CHIP 0FB802 1-216-864-11 SHORT CHIP 0FB803 1-216-864-11 SHORT CHIP 0FB804 1-216-864-11 SHORT CHIP 0

FB805 1-216-864-11 SHORT CHIP 0FB806 1-216-864-11 SHORT CHIP 0

< IC >

IC800 8-759-295-90 IC NJM2244M-TE2IC801 6-705-602-01 IC MM1623BFBE

< JACK/TERMINAL >

J800 1-817-449-11 JACK, PIN 3P (COMPONET VIDEO OUT)J801 1-537-943-11 TERMINAL, S (S VIDEO OUT)J802 1-794-970-11 JACK, PIN 1P (VIDEO OUT)

< CAPACITOR/JUMPER RESISTOR >

JR800 1-216-864-11 SHORT CHIP 0JR802 1-216-864-11 SHORT CHIP 0JR803 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VJR804 1-216-864-11 SHORT CHIP 0

< COIL >

L801 1-414-183-41 INDUCTOR 10uH

< RESISTOR >

R800 1-216-809-11 METAL CHIP 100 5% 1/10W

TRANS VIDEOVer. 1.1


115

HCD-ZX80D/ZX100D

R802 1-218-285-11 METAL CHIP 75 5% 1/10WR803 1-218-285-11 METAL CHIP 75 5% 1/10WR804 1-218-285-11 METAL CHIP 75 5% 1/10WR805 1-218-285-11 METAL CHIP 75 5% 1/10W

R806 1-216-864-11 SHORT CHIP 0R807 1-216-809-11 METAL CHIP 100 5% 1/10WR808 1-218-285-11 METAL CHIP 75 5% 1/10WR809 1-216-833-11 METAL CHIP 10K 5% 1/10WR810 1-216-807-11 METAL CHIP 68 5% 1/10W

R812 1-216-857-11 METAL CHIP 1M 5% 1/10WR813 1-216-845-11 METAL CHIP 100K 5% 1/10WR814 1-216-833-11 METAL CHIP 10K 5% 1/10W

************************************************************

X-ROUND BOARD**************

< CAPACITOR >


< CONNECTOR >

CN1153 1-568-850-11 CONNECTOR, FFC 7P

< LED >

D1040 8-719-064-63 LED SELU5823C-TP15 (FADER)D1042 8-719-064-63 LED SELU5823C-TP15 (RANDOM)D1044 8-719-064-63 LED SELU5823C-TP15 (FADER)D1046 8-719-064-63 LED SELU5823C-TP15 (BEAT MAX)D1048 8-719-064-63 LED SELU5823C-TP15 (BEAT JUMP)

D1050 8-719-064-63 LED SELU5823C-TP15 (BEAT JUMP)D1052 8-719-064-63 LED SELU5823C-TP15 (BALANCE)D1054 8-719-064-63 LED SELU5823C-TP15 (BALANCE)D1056 8-719-064-63 LED SELU5823C-TP15 (BEAT MAX)D1058 8-719-064-63 LED SELU5823C-TP15 (RANDOM)

< JUMPER RESISTOR >


< TRANSISTOR >

Q1041 8-729-027-50 TRANSISTOR DTC123JKA-T146

< RESISTOR >

R1041 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1042 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1043 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1044 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR1045 1-216-833-11 METAL CHIP 10K 5% 1/10W



X-ROUND



R1067 1-216-821-11 METAL CHIP 1K 5% 1/10W

< SWITCH/ROTARY ENCODER >

S1040 1-479-203-11 ENCODER (ROTARY) (X-ROUND JOG)S1041 1-762-875-21 SWITCH, KEYBOARD (BEAT PAD)S1042 1-762-875-21 SWITCH, KEYBOARD (BEAT MAX)S1043 1-762-875-21 SWITCH, KEYBOARD (BEAT JUMP)S1044 1-762-875-21 SWITCH, KEYBOARD (RANDOM)

S1045 1-762-875-21 SWITCH, KEYBOARD (WAVE)S1046 1-762-875-21 SWITCH, KEYBOARD (FADER)S1047 1-762-875-21 SWITCH, KEYBOARD (BALANCE)S1049 1-786-967-11 SWITCH, TACTILE (SPEAKERS/X-ROUND OFF)

************************************************************

MISCELLANEOUS**************

55 1-828-991-11 WIRE (FLAT TYPE) (17 CORE)57 1-828-942-11 WIRE (FLAT TYPE) (7 CORE)58 1-828-992-11 WIRE (FLAT TYPE) (17 CORE)113 1-417-658-11 MECHA DECK (CWN42RR603)115 1-828-964-11 WIRE (FLAT TYPE) (11 CORE)

0151 1-468-737-51 POWER SWITCHING(ZX80D: E2, E3, E13, E51, MX/ZX100D)

0151 1-468-737-61 POWER SWITCHING (ZX80D: US)152 1-693-702-11 TUNER (FM/AM) (TM10SE)

(ZX80D: E2, E3, E13, E51, MX/ZX100D)152 1-693-703-11 TUNER (FM/AM) (TM10SU) (ZX80D: US)154 1-828-358-11 WIRE (FLAT TYPE) (19 CORE)

156 1-828-973-11 WIRE (FLAT TYPE) (13 CORE)157 1-828-956-11 WIRE (FLAT TYPE) (9 CORE)203 1-828-326-11 WIRE (FLAT TYPE) (13 CORE)205 1-828-332-11 WIRE (FLAT TYPE) (13 CORE)206 1-828-632-11 WIRE (FLAT TYPE) (21 CORE)

207 1-828-252-11 WIRE (FLAT TYPE) (24 CORE)0258 1-777-071-53 CORD, POWER (ZX80D: E2, E3, E13, E51/

ZX100D: E2, E3, E51, SP, MY)0258 1-783-820-11 CORD, POWER (ZX80D: US)0258 1-829-627-31 POWER-SUPPLY CORD

(ZX80D: MX/ZX100D: MX)502 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)



D656 8-719-073-32 DIODE D25XB60D658 8-719-066-42 DIODE RBV1306 (ZX80D)D658 8-719-073-32 DIODE D25XB60 (ZX100D)

Note: Refer to the Servicing Notes “HOW TO IDENTIFY OPTICALPICK-UP BLOCK” (pagr 4), if replacing the Ref. No.571.

VIDEOVer. 1.1


116

HCD-ZX80D/ZX100D

0F1241 1-533-949-33 FUSE, CYLINDRICAL (TIME LUG) (8A/250V)(ZX80D: E2, E3, E51, MX/ZX100D)








0F1281 1-532-465-33 FUSE (3.15A/250V)(ZX80D: E2, E3, E51, MX/ZX100D)


0F1291 1-532-465-33 FUSE (3.15A/250V)(ZX80D: E2, E3, E51, MX/ZX100D)


M501 1-787-400-11 D.C. FANM502 1-787-400-11 D.C. FANM741 A-1108-965-A MOTOR ASSY, TABLE

M751 A-4737-553-A MOTOR ASSY, LOADINGS711 1-477-680-12 ENCODER, ROTARY

(DISC TABLE ADDRESS DETECT)0T1200 1-443-977-11 POWER TRANSFORMER

(ZX100D: E2, E3, E51, SP, MY)0T1200 1-443-978-11 POWER TRANSFORMER (ZX100D: MX)0T1200 1-445-024-11 POWER TRANSFORMER

(ZX80D: E2, E3, E13, E51)

0T1200 1-445-025-11 POWER TRANSFORMER (ZX80D: MX)0T1200 1-445-153-11 POWER TRANSFORMER (ZX80D: US)************************************************************

ACCESSORIES************

0 1-569-008-21 ADAPTOR, CONVERSION 2P(ZX80D: E2, E3, E51/

ZX100D: E2, E3, E51, SP, MY)

Ver. 1.1

SERVICE MANUAL

HCD-ZX80D/ZX100D

1HCD-ZX80D/ZX100D

SUPPLEMENT-1File this supplement with the service manual.

9-887-251-81

Subject: Change of MAIN board (Suffix-13)

Ver. 1.1 2007.03

1. NEW/FORMER DISCRIMINATION

In this set, MAIN board has been changed in the midway of production.Printed wiring board, schematic diagram and electrical parts list of newtype are described in this supplement-1.Refer to original service manual for other information.

– MAIN Board (Component Side) –

FORMER : 1-868-862-12NEW : 1-868-862-13

US ModelHCD-ZX80D

E ModelHCD-ZX80D/ZX100D

HCD-ZX80D/ZX100D 2. DIAGRAMS

• Note for Printed Wiring Boards and Schematic Diagrams

• Indication of transistor

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• f : internal component.• 2 : nonflammable resistor.• 5 : fusible resistor.• C : panel designation.

Note: The components identified by mark 0 or dotted linewith mark 0 are critical for safety.Replace only with part number specified.

• A : B+ Line.• B : B– Line.• Voltages are dc with respect to ground under no-signal

(detuned) conditions.no mark : TUNER (FM/AM)( ) : DVD PLAY⟨⟨ ⟩⟩ : TAPE PLAY[ ] : REC

∗ : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Signal path.F : AUDIOf : TUNER (FM/AM)j : TAPE PLAY (DECK-A)d : TAPE PLAY (DECK-B)G : RECk : TV/SAT AUDIO INh : AUDIO OUTN : MIC INPUTg : VIDEO INPUT (AUDIO)

• AbbreviationE2 : 120V AC area in E modelE3 : 240V AC area in E modelE13 : Russian model and 220V – 230V AC area in E

modelE51 : Chilean and Peruvian modelsMX : Mexican modelMY : Malaysia modelSP : Singapore model

Note on Printed Wiring Board:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• f : internal component.• : Pattern from the side which enables seeing.(The other layers' patterns are not indicated.)

C

B

These are omitted.

E

Q

D101 L-16D102 L-16D136 G-16D325 K-16D340 F-4D341 F-4D342 F-3D401 E-5D402 E-5D403 E-6D411 D-4D412 D-4D501 C-6D502 C-6D503 C-6D504 C-6D505 C-6D506 L-7D507 L-7D510 H-4D511 G-4

Ref. No. LocationRef. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location

• Semiconductor Location– MAIN Board –

D550 K-14D551 K-14D560 J-10D561 I-10D581 K-14D582 K-15D583 K-15D584 E-6D585 G-16D586 G-16

IC101 D-9IC201 D-14IC301 I-5IC304 G-6IC401 C-3IC501 C-6IC507 J-14IC550 L-14IC558 H-10IC559 H-9

IC560 H-14IC561 I-14

Q101 C-8Q103 G-15Q104 G-16Q106 D-11Q117 C-13Q151 D-8Q156 D-10Q167 C-12Q200 B-14Q202 B-15Q203 B-15Q204 C-15Q205 E-14Q206 J-15Q207 I-15Q208 I-16Q250 C-14Q252 C-15

Q253 B-15Q254 B-16Q255 E-13Q256 J-15Q321 K-5Q322 K-4Q323 L-16Q325 K-4Q340 F-4Q341 F-4Q342 F-3Q343 F-4Q344 F-4Q345 F-3Q370 L-4Q372 K-4Q373 K-4Q375 K-5Q377 K-5Q378 L-5Q379 K-5

Q519 L-8Q520 H-10Q521 L-10Q522 L-10Q523 B-6Q524 C-6Q550 K-13Q564 L-11Q578 K-15Q579 L-15Q581 K-14Q582 K-14Q585 K-15Q587 F-6Q588 E-5Q589 F-5

Q380 L-5Q381 J-5Q382 K-5Q383 K-5Q501 B-6Q503 J-14Q504 F-3Q505 L-10Q506 L-10Q507 L-9Q508 L-9Q509 L-9Q510 L-9Q511 L-8Q512 L-8Q513 H-11Q514 L-11Q515 L-8Q516 L-10Q517 L-10Q518 J-14

HCD-ZX80D/ZX100D

22HCD-ZX80D/ZX100D

2-1. PRINTED WIRING BOARD – MAIN Board – • See page 1 for Semiconductor Location. :Uses unleaded solder.

C530

C233

R521

C235

JR510

D551 D583

JR218

JR21

9

Q550

Q579

R248

R250

R551

R549

R520

R103

R153

JR50

9

JR502

JR10

4

R540R538

Q208

R601

R602

JR514

D325

C410

C411

C412

C464

JR400

D502

IC401

R494

IC501

JR40

4

Q504

R300

R406R410

R411

R412

R413

R414

R415

R417

R421

R420

R419

R423R424

R425

R426

R427

R428

R429

R430

R623

JR430

C340

C360

JR500

JR50

5

C513

C515

C551

C564

C565

D403

C568C569

C580 C581

R432

R433

R434

R435

D340

D342

D341

D401

D402

D501

D503

D504

D505

D506

D507

D550 D581

D582

FB204

FB25

4

R436

R437

R438

R439

JR50

6

JR504

IC304

R335

JR52

0

R440

R441

R442

JR50

3

JR50

1

R443

R444

R445

R447

R451

R453

R454

Q206

Q207

R457

Q256

Q340

Q342

Q341

Q343

Q345

Q344

Q514

Q564

R525

R526

R527

R528

R575

R576

R577

Q501

Q503

Q505 Q506

Q507

Q508

Q509

Q510

Q511

Q512

Q513

Q515

Q516 Q517

Q518

Q519

Q521Q522

Q578

Q581

Q582

R450

R458

R466

R467

R468

R469

R378

C382

R337

Q321

R368

R303

R305

R339

R301

R355

R594

R314

R312

Q375

R595

R463

R448

R590

JR305

R589

Q587Q589

C335

R306

R380

C364

R311

R354

R318

R389

JR30

1

Q370

JR302

R392

R352

R338

R238

R239

Q372

R243

R244

R245

R246

R247

R251

R252

R253

Q382

JR35

9

R418

R370

Q379C333

R394

C377

C376

JR304

C326

R288

R289

R293

R294

R295

R296

R297

R578

JR507

R315

R316

R317

D101

IC550

R422

R585

R584

R340

R342

R345

R343 R344

R341

R348

R349

R346

R347

R350

R369

R357

R358

R359

R360

R361

R365

R366

R554

R553

R552

R539

R537

R536 R535

R534 R533

R381

R382

R530

R529

R524

R523

R522

R400 R401R402

R403

R404

R405

R407

R408

R409

JR544

JR100

JR508

C341

R593 R592

R574

R573

R502

R483

R493

R492

R491

R490

R489

R488R487

R486

R485

R484

R475

R474

R473

R472

R471

R501

R470

R503

R505

R506

R507

R508

R509R510

R511

R512

R513

R514R5

15

R516R517

R518

R519

JR43

5

R387

Q373

Q322

Q325

R336

R373

R388

R385

C332

Q383

R375

R325R371

R374

C314R319R310

C307

R309

R351

R395

R396

D584

Q380R386

R304

R353

R390

R308

R372

Q378

C385

R399

C372

JR300

IC301

R376

C371

R364

R379

Q377

JR30

3

R120

R377

Q381

C383

R302

C373

R101

R102

R104

R105

R106

R107

R108

R109

R110

R111

R112R113

R114

R115

R116

R117

R121

R122

R130R131 R132

R133

R150

R151

R152

R154

R155

R156

R157 R158

R159

R160

R161

R162

R163

R164

R165

R166

R167

R200

Q255

Q254

Q253

Q252Q250

Q205

Q204

Q203

Q202

Q200

Q167

Q156

Q151

Q117

Q106

Q101

D136

R205 R206

R207R208

R209 R210

R211

R212

R213

R214

R215

R216R2

17

R218R219

R220

R221

JR20

8

JR200

R586

C279

C274

C273

C270

C268

C264 C261

C260

C256

C242

C229

C223

C220

C218

C214

C212

C211

C210

C206

C172

C174

C175

C176

C173

C171

C115

R229

R222

R223

R224

JR204

R225

IC201

IC101

FB26

1

JR205

JR40

7

R299

R298R292

R273

FB260

R249

R242

R203

R202

R226

R582

R227

R581

JR202

R532

R531 R291R290

R287

R286

R285

R284

R228 R230

R231

R232

R233R234

R235

R236

R237

R283

R282

R240

R241

R281R280

R279

R278

R277

R276

R275

R274

R272

R271

R270

R269

R268

R267

R266

R265

R264

R263

R262

R261

R260

R259

R258 R257R256

R255

R254

R500

JR542

R383

R384

R391

Q523

Q524

R662

Q104

R135

Q103

C584

C583

D102

JR545

JR340

JR543

JR40

6

R499

R481

R482

R496

R329

R330

JR53

1

JR431

JR432

JR54

1

JR433

R322

JR102

JR22

2

R479

JR532

Q323

JR31

0

D412

D411

C414

JR515

JR51

3

R612R204

JR101

JR361

JR51

6

C413

C415

R321

R320

JR10

5

JR201

JR40

1

R478

NO40

1

NO603

NO402

NO503

JW50

2

JW50

3

JW50

4

JW50

5

JW50

6

JW50

8

JW50

9

JW51

0

JW51

1

JW51

2

JW513

JW514

JW515

JW51

7

JW518

JW51

9

JW52

0

JW52

2JW521JW

523

JW52

4

JW53

2

JW535

JW536

JW537

JW543

JW54

4

JW545

JW546JW547

JW548

JW549

JW55

1

JW554

JW555

JW556

JW558

JW560

JW562

JW579JW580

JW581

JW58

4

JW30

2

JW303

JW304

JW306

JW310

JW311 JW31

2

JW31

3

JW314

JW31

5

JW31

6

JW317

JW320

JW322

JW32

3

JW32

5

JW326

JW33

1

JW335 JW336

JW33

7

JW34

6

JW34

7

JW350

JW351

JW352

JW353

JW355

JW357

JW358

JW359

JW360

JW36

3

JW600

JW601

JW602

JW603

JW605

JW606

JW58

7

JW58

8

JW59

1

JW59

6

JW59

7 JW59

8

JW58

5

JW401

JW402

JW403

JW404

JW405

JW40

6

JW40

7

JW40

8

JW40

9

JW41

1

JW41

3

JW416

JW421

JW422

JW423

JW424

JW429

JW43

1

JW43

2

JW43

3

JW43

4

JW43

8

JW44

0

JW44

1

JW44

2

JW44

7

JW452

JW454

JW455

JW463

JW467

JW468

JW469

JW471

JW48

3

JW201JW203

JW204

JW210

JW21

6

JW220

JW228

JW229

JW230

JW231JW232

JW23

5

JW23

6

JW23

9

JW24

2

JW24

4

JW24

5

JW24

6

JW24

7

JW24

8

JW24

9

JW25

0

JW25

2

JW104

JW10

5

JW10

6

JW107

JW10

8

JW10

9

JW11

0

JW11

1

JW11

2

JW11

5

JW11

8

JW12

0

JW12

1

JW12

2

JW123

JW12

6

JW12

7

JW12

9

JW130

JW131

JW13

5

JW466

JW254

JW25

6

JW410

JW305

JW13

8

JW43

6

JW25

7

JW52

6

JW52

7

JW52

8

JW13

9

JW48

6JW

368

JW24

1

J203

C160

C110

JW400

JW539

JW541

JW55

7

JW22

4

NO523

C512

JW13

6

JW54

0

JW14

0

JW24

0

JW370

JW371

JW55

2

JW609

JW613

JW53

1

JW559

JW200

JW34

4

JW470

JW464JW

425

JW42

6

JW42

7

JW420

JW428

JW41

8

JW44

9

JW21

7

JW33

2

JW33

3

JW34

9

JW36

5

JW36

6

JW36

2

JW12

8

CN102

JW238

JW234

JW233

JW44

8

JW44

5

JW44

4

JW44

3

JW475

JW450

JW132

JW484

JW134

JW48

2JW361

JW356

JW47

8

JW47

7

JW47

6

JW474

JW52

9

JW481

JW57

7

JW21

5

JW21

4

JW209

JW20

5

JW208

JW212

JW561

JW576

JW614

JW57

4

JW57

3

JW57

2

JW21

9

JW566

JW253

JW565

JW564

JW225

JW20

7

JW59

5

JW567

JW57

0

JW50

7

JW604

JW321

JW33

8

JW34

0

JW34

3

JW58

6 JW59

2

JW56

8 JW56

9

JW34

8

JW34

5

JW611

JW53

4

JW227

JW226

JW451

JW485

JW124JW459

JW575

JW563

JW615

JW52

5

JW34

1

JW44

6

JW13

7

JW38

0

JW38

2

JW383

JW384 JW385

JW386JW387

JW388

JW38

9

JW39

3

JW39

4

JW39

5

JW39

6

JW39

7

JW39

8

JW37

2

JW34

2

JW32

4

JW32

8

JW33

9JW

430

JW61

6

JW61

7

JW61

8

JW61

9

JW36

9

JW367

JW46

5

JW41

9

JW41

5

JW47

2

JW58

9

JW58

3

JW62

5

JW62

6

JW627

JW628

JW629

JW63

0

JW63

1

JW63

2

JW22

2

JW22

3

JW21

3

JW21

8

JW53

3

JW53

8

JW48

8

JW590

JW635

JW636

JW637

JW638

JW639

JW640

JW641

JW642

JW643

JW644

JW645

JW647

JW648

JW649

JW578

JW255

JW102

JW101

JW653

JW660

JW661

JW662

JW663

JW66

6

JW66

7

JW66

8

JW66

9

JW670

JW671

JW672

JW67

3

JW67

4

JW57

1

JW24

3

JW651

JW309

JW650

JW664JW610

JW680

JW68

1

JW68

2

JW683

JW685

JW686

JW687

JW688

JW689

JW690

JW69

1

JW69

2

JW694

JW69

6

JW69

7

JW69

8

JW593

J103

JW456

JW69

9

C416

C502

C503

C202

CN50

8

CN520

C234

C252

C352

D561

C357

C358

C374

D560

CN582

C501

C524

C511

C507

C365

C509

C517

C514

C516

C510

C519

C508

C523

C557C558

C562

C563

C566

C571C570

CN501

CN58

0

EPT560

IC558IC559

IC560

IC561

J202

C554

C506

C505

CN502

Q520

Q585

C306

C301

Q588

C309

C361

L372

L370

CN504

TM101

C370

L320

T301

C355

C553

IC507

C213

C356

C359

X402

C552

CN510

C328

C310

C311

C305

R307

L302

C303

C379

C354

C304

C378

C308

C353

C312

J201

C521

C226

C228

C164

C276

C222

C215

C267

C520

C114

C209

C259

C216

C207

C254

C253

C221

C277 C278C227

C258

C262

C251

C154

C266

C224

C265

C217

C269

C205

C257C255

C204C2

03

C201

C200

C225C163

C162

C161

C153

C155

C159

C504

C109

C150

C131

C111

C272

C113

C112C130

C105

C104

C103

C102

C101

C152

CN514

CN511

R480

C219C263

CN100

CN506

C462

C567

C525

C325

C166C167

C559

CN503

X401

C518

CN509

D585

D586

CN513

CN10

5

JW391

CN512

JW221

CN521

JW20

2

JW608

JW607

JW516

JW41

4

JW41

7

JW13

3

JW62

4

JW390

JW392

JW307 JW612

JW11

9

JW695

JW36

4

JW480

JW693

JW487

JW10

3

JW14

6

JW147

JW149

JW150

JW15

2

JW62

1

JW62

0

JW62

3

JW62

2

C431

JW330

JW14

5

JW684

CN505

JW461

JW462

C362

JW237

JW43

7

JW458

JW457

JW460

JW38

1

JW633

JW11

3

JW11

7

JW11

6

JW47

3

JW67

5

JW54

2

JW676

JW550

JW55

3

JW35

4

JW652

R579

C550

JW14

3

JW453

JW148

JW144

JW530

JW100

JW14

1

JW14

2

C363

JW25

8

C116

C351

D510D511

1-868-862- 13

MAIN BOARD

14

85

EE

EE

E

E

E

E

E

1

1 8

3

E

EE

E

E

EE

E

E

E

E

E

E

E

113

E

E E E

E

E

E

E

E

E

E

E

E

E

E

EE

E

E

EE

E

E

E

E

EE

EE

E

E

E

1

3

E

B

C

1

4

1

3

1

3

1 8

E

E C B

E

E E

E

E

E E

EE E

E

E

E

E

1

3031

50

51

80 81

100

18

13

4 6

1 133

1 3

E

EE

14

1

8

1 4

1 4

1

3

13

54

11

1 6

1

42

21

22

1

1011

20

21

30 31

40

Q PA BOARDCN601 B DMB15 BOARD

CN401P PA BOARDCN600R TRANS BOARD

CN1213


M501(FAN)

M

D-LIGHTSYNC OUT

R

L

AUDIO OUT

R

L

TV/SATAUDIO IN

SYSTEMCONTROL

+

–SUBWOOFER

OUT

SUBWOFFEROUT

ABSURROUND

BOARDNO801

LSURROUND

BOARDCN701

(ZX100D)

(ZX100D)

(ZX80D)

TOSS-WGV100D

(ZX100D)

(ZX100D)

1

42

21

22

TUNER (FM/AM)SUPPLIED WITH THEASSEMBLED BLOCK

FM 75ΩCOAXIAL

ANTENNA

AM

D DMB15 BOARDCN302

H MIC BOARDNO1101K KARAOKE

BOARDNO2000

J PRIMARYBOARDCN1200

E VIDEOBOARDCN800

F DRIVER BOARDCN701A DMB15 BOARD

CN106 M EFFECTOR BOARDCN1502

1 9 1 5

(NC)

1 3

GPANELBOARDCN902

NSURROUND

BOARDCN700

(Refer to page 55on original

service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)


service manual)

(EXCEPT ZX100D: SP, MY)

M502(FAN)

M

TAPEMECHANISMDECK BLOCKSUPPLIED WITHTHE ASSEMBLED

BLOCK

(ZX100D)

(ZX80D)



(FOR ADJUSTMENT)

1 3

4 6BIAS OSC

HRPE1(REC/PB/ERASE)

(DECK-B)

HP1(PB)

(DECK-A)

3

1

(CHASSIS)

1

5

E BC

1

2

3

4

5

A

B

C

D

E

F

G

H

I

J

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

K

L

1

4

(ZX80D)

(ZX80D)

(ZX100D)

HCD-ZX80D/ZX100D

33HCD-ZX80D/ZX100D

(Page 7)


Q523

R4

51

R4

53

R4

54

R4

57

R4

58

R4

63

R4

69

R4

70

R4

72

R4

73

R4

74

R4

75

R483

R488

R489

R490

R491

R494

R496

R499

R3

22

R4

00

R4

01

R4

02

R4

05

R4

06

R4

07

R4

08

R4

09

R4

11

R4

14

R4

15

R4

17

R4

18

R4

19

R4

20

R4

21

R4

22

R4

23

R4

24

R4

25

R4

26

R4

27

R4

28

R4

29

R431

R432

R433

R434

R435

R436

R4

37

R438

R439

R440

R441

R442

R443

R444

R445

R447

R448

R4

30

R413

R4

10

X402

C415

C416

X4

01

C411 C410

C412

R412

R4

03

R4

04

CN508

C462 C464

R479 R478

R487

R486

R485

R484

R593

D411

D412

C413

NO402

CN511

D503

R503 C503

C502

D502

R502 R501

D501

D504

Q524

D505

CN520

C518

R493

R4

66

R4

71

CN100

NO401R574

D401

R573

R468

D402 D403

C414

IC501

R467

R589

Q589

Q587

C583

C584

Q588

R594

R595

R590

CN582

M502

R492

R592

Q501

IC401

R4

50

JR222

C501

JW100

D584

DTA114EKA

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

10

0

100

100

100

100

100

100

100

100

47

k

10

k

10

0

10

0

10

0

10

0

10

0

10

0

10

0

33

0k

10

0

10

0

10

k

10

0

10

0

1k

10

0

10

0

10

0

10

0

10

0

10

01

0k

10

k1

00

100

100

100

100

100

10k

10

k

100

100

100

100

100

100

100

100

100

100

10

0

0

10

k

5MHz

0.1

22006.3V

32.7

68K

Hz

22p 22p

0.1

100k

10

k

10

k

17P

10010V 0.01

10k 1k

10k

100

100

10k

MA111-TX

MA111-TX

0.1

4P

13P

MA111-TX

0 0.1

0.1

MA111-TX

1k 220

MA111-TX

MA111-TX

DTC124EKA

MA111-TX

13P

100010V

10

k

10

k

9P

3P10k

MA111-TX

10k

100

MA111-TX MA111-TX

0.1

ICBD4929G

100

1k

2SC2712

2SC2712

0.1

0.1

2SD2525

4.7k

4.7k

100k

3P4.7k

DTC124EKA

M30622MEP-A78FPU0

10

0

0

1050V

UDZS-1713B

A1

A2

A3

A4

A5

A6

A7

A8

A9

B1

B2

C1

D3

D1

D2

D4C2

D5

D6

D7

C3

D8

D9

E1

E2

E3

E4

4

73

74

74

79

80

81

82

53

54

55

73

47

56

34

38

39

89

90

91

66

12356

35

36

37

48

49

50

52

58

60

61

65

67

72

71

75

78

77

76

83

42

70

63

57

45

44

43

19

18

46

51

34

35

36

37

38

39

25

24

23

22

21

32

31

22

21

33

32

31

23

24

25

100

95

94

30

29

12

26

27

28

26

27

28

29

30

12

33

40

41

40

4

41

∗

∗

∗

GC RESET

LED+9V

BPM LOW

VG

SPEANA GND

MIC DETECT

MIC SCORE

SPEANA

SIRCS

KEY INT DISPLAY

POWER LED

VF(1)

IIC-DATA

IIC-CLK

KEY INT POWER

VF(2)

GC DGND

EVER +4V

GC DGND

TBL ADDRESS SW

MGND

D+3.3V

M+9V

TM-R

TM-F

E-1

E-2

E-3

OPEN SW

D+3.3V

D-GND

IIC-CLK

IIC-DATA

RES

ET

X-O

UT

VS

S

X-I

N

VC

C

NM

I

IIC

-CL

K

IIC

-DA

TA

MODEL-IN

AVSS

VREF

AVCC

XC

-IN

XC

-OU

T

SIR

CS

DIS

PLA

Y-K

EY

PO

WER

-KEY

DEST-INA

C-C

UT

BY

TE

VC

C

VS

S

DATA

CLK

OCSW1

SYSRST

3.3VMNT

XIFCS

IFBSY

SIO

SOO

SCO

DGND

MIC

VOICE

KRMOD

TU

NE

D

ST

-CL

K

ST

-CE

TB

L S

EN

S

TM-F

TM-R

LM-F

LM-R

A-HALF

A-TRIG

B-TRIG

RE

C B

IAS

RE

C M

UT

E

PB

A/B

AL

C

OV

ER

VO

LT

AG

E

UN

DE

R V

OL

TA

GE

DA

TA

CAPM

M-REQ

MGND

SW-LEVEL-IN

THERMAL VACS

AUDIO-OUT-SW

VIDEO-OUT-SW

MTK

-PO

WER

EFFE

CT

OR

-CT

R3

EFFE

CT

OR

-CT

R2

EFFE

CT

OR

-CT

R1

EFFECTOR-S3

EFFECTOR-S2

EFFECTOR-S1

EFFE

CT

OR

-S0

FAN CONTROL

FA

N H

I S

PEED

FAN+

FAN-

MIC

ST

AT

US

EJEC

T S

WE3

E2

E1

NO USE

SW

-MU

TE

ANALOG-IN-MUTE

MTK

-KM

OD

EVER+4V

D-GND

STBY RLY

(1/6)

SIO

CN

VS

S

SW-LED

SW

-SP

KR

EL

AY

CLK

Q587,589


FAN MOTOR

SWITCH

(FAN)

∗ R593

150(ZX80D:E13)

(EXCEPT ZX100D:SP,MY) ∗ R592

680(ZX80D)

1k(ZX100D)

ZX80D:E2,E51,MX/

ZX100D:E2,E51,MX

1k

4.7k

∗ R493

0(ZX100D:SP,MY)

330(ZX80D:E3/ZX100D:E3)

4.7kZX80D:US,E2,E13,E51,MX/

ZX100D:E2,E51,MX

Q523,524

B+ SWITCH

RESET SIGNAL

GENERATOR

RESET SWITCH

MASTER CONTROLLER

H/P DETECT

A+9V

MIC ECHO

MIC AGND

VIDEO(A)-R

VIDEO(A)-GND

VIDEO(A)-L

(ZX80D:E3/ZX100D:E3)

2.2k

(ZX80D:US)

LM-F

LM-R

(NC)

MTK-

MTK-

MTK-SOD

CLK

GC-RESET

STBY-LED

TC

-RE

LA

Y

NO

US

E

ST

K-M

UT

E

RE

AR

-RE

LA

Y

CT

R-R

EL

AY

PR

OT

EC

T

TC

-MU

TE

HP

-MU

TE

LIN

E-M

UT

E

DV

D-A

-MU

TE

AU

DIO

-IC

-

AUDIO-IC-

VOL-IC-

VOL-IC-

HP-DETECT

MIC-DETECT

VMUTE

A-SHUT

B-SHUT

B-HALF

NO USE

ST

-DO

UT

ST

-DIN

ST

BY

-RE

LA

Y

EFFE

CT

OR

-SE

LE

CT

MTK

-IFB

SY

MT

K-X

IFC

S

FR

-RE

LA

Y

MTK

-RES

ET

(Refer to page 41 on original service manual)





(Page 6)

(Page 8)

(Page 5)

(Page 4)

(Page 7)

HCD-ZX80D/ZX100D

44HCD-ZX80D/ZX100D

(Page 7)


R105

C121

C122

NO503

IC101

R121

R104

C103

C102

C150

C101

C105

R107

R150

C104

R116

C174

C111

C172

C109

C176

R152

R151

C130 R131

R106 R156

CN505

Q151

R122

R130

C131R132

C115

R111

Q156

Q106

R108

R158

R159R160

CN510

R360 R384

C358 R361 R383

R133

R110

R161

R109

C161

C173

C159

C171

R157

R166C155

R154 C154

C153

C152

C160

C357

Q101

R101

C175

R102

C431

C110

R155

C162

C163R153

C116

C112

C113

R103

47k

220p

220p

5P

M61529FP-60G

1k

1k

10 50V

10 50V

10 50V

100 10V

10 50V

100

2.2k

10 50V

100

0.022

1050V

0.022

150V 0.033

10k

2.2k

1050V 2.2k

10k 10k

6P

2SC2712

1k

2.2k

0.4750V1M

0.1

10k

2SD2114

2SD2114

6.8k

6.8k

3.3k10k

3P

27k 4.7k

4.750V

27k 4.7k

100k

10k

10k

3.3k

10 50V

0.033

1 50V

0.022

100

10010 50V

1k 10 50V

10 50V

10 50V

0.01

4.750V

2SC2712

2.2k

0.022

10k

1050V

0.01

47k

0.12

0.331k

33010V

0.12

0.33

1k

A1

A2

A3

A4

A5

A6

A7

A8

A9

F2

F3

F4

F5

F6

F7

F8

F9

G4

G3

G1

G2

G5

F10

G6

F11

H2

H1

H3

N1

FL

FR

SAT-R

DOWNMIX-R

79

R-OUT

80

L-OUT

LINK-L

REC-OUT-L

SAT-L

DOWNMIX-L

LINK-R

REC-OUT-R

XVOICE

SCORE

+9V

V MUTE

VIDEO OUT SW

+5V

A+9V

MUSIC L+R

SCORE

XVOICE

NC

MIC SCORE

L

GND

R

SUR1

SUR2

RECB2

TMI2

TMO2

TCA2

TCB2

TCC2

TOUT2

VOLIN2

BB_A2

BB_B2

OUT2

SWOUT

GND

CLOCK

REF

MIC

RECB1

TMI1

TMO1

TCA1

TCB1

TCC1

TOUT1

VOLIN1

BB_A1

BB_B1

OUT1

SAOUT

VCC

DATA

TC-L TC-R

SAT-RSAT-L

DVD-L DVD-R

ST-RST-L

VIDEO-L VIDEO-R

AGND

(2/6)

INPUT SELECT SWITCH,TONE CONTROL,

FEED BACK

SWITCH

MUTING

MUTING

FEED BACK

SWITCH

ELECTRICAL VOLUME,BASS BOOST AMP

ADJUSTMENT

FOR



(Page 3)

(Page 6)(Page 7)

(Page 5)

(Page 5)

(Page 5)

(Page 8)

HCD-ZX80D/ZX100D

55HCD-ZX80D/ZX100D


C223

C200

C214

R209

R210

C211

R258

C256

C257

R208

C206

C207

R207

C212

C205

C255

R225

R275

C210

R257

R211

C216

C259

R276

C209

R226

C263

R256

R206

C213

R263

R272

R254

R213

R231

R232

R230

Q203

R292

R283

R285

Q254

R284

R233 Q204

R234

R235

C228

R298

R299

C201

C264

R259C261

R260R261C266

R214

C218R217

R264

C268

R216

R282

R281

Q253

R227

Q202

R229

R280

R202

C277

R228

R203

C226

R265

R267R266C269

C219

C270

C220 R215

C215

R212

C265

R262

R277

R278C276

R242

Q252

R279

R204

C222R220

R218

R219C224

C242R270

Q200

R268

R249

C221

R269

C262R221

Q250

R222C251

R273

R271

C225

C273

R224

R223

C272

C260

CN514

D101

D102

R120 D325

R325

Q323

R329

R330

D586

R135

D136

R117C114

R114

R115

R112

R164

R165

R162

Q117

Q167

R163

R113

C166

C258

R623

R274

C274

R167 C164 C167

D585

C229

C279

R241

R291

R240

R290

CN506

R531

Q103

C267

JW530

CN512

C520

C521

FB260

FB261

C235

J201

R581

JR502

JR509

IC201

R237

R287

Q255

Q205

Q104

C217

JR104

JW258

C227

R582R532

CN521

C559

R612

R662

J103

C278

C254

C253

R236

R255

C204

C203

R286

R205

R200

0.001

0.1

220p

10k

470

220p

2.2k

0.0022

10 50V

2.2k

0.0022

10 50V

2.2k

0.001

100 10V

100 10V

10k

10k

0.001

2.2k

47k

10 50V

10 50V

22k

10 50V

22k

10 50V

47k

47k

10 50V

6.8k

3.3k

3.3k

6.8k

47k

10k

1k

2SD2114

10k

47k

10k

2SD2114

1k

47k 2SD2114

1k

10k

1 50V

10k

10k

0.1

220p

10k220p

47047k10

50V

47k

0.00110k

47k

0.001

2.2k

10k

47k

2SD2114

47k

2SD2114

10k

1k

10k

1 50V

1k

10k

1 50V

4.7k

10k2.2k10 50V

10 50V

0.001

0.001 4.7k

10 50V

8.2k

10 50V

8.2k

47k

1k1

50V

10k

2SD2114

10k

10k

1050V10k

4.7k

2.2k10 50V

0.00147k

2SD2114

1k

10k

1 50V

10k

10 50V47k

2SD2114

1k1 50V

10k

10k

150V

220p

1k

8.2k

22010V

0.1

8P

MA111-TX

MA111-TX

0 UDZW-TE17-4.7B

680

2SC5053

100k

1k

10EDB40

1.5k

UDZW-TE17-5.6B

01050V

10k

1k

47k

10k

1k

47k

2SD2114

2SD2114

10k

10k

10 50V

10 50V 6.8k

1k

220p

0 1050V 10 50V

10EDB40

220p

220p

33k

33k

15k

15k

9P

2SC5053

1050V

19P

1050V

1050V 0

0

100p (EXCEPT ZX80D:US)

0.1 (ZX80D:US)

2P

0

0

M61530

47k

47k

DTC114EKA

1050V

0

150V

3.3k3.3k

21P

100010V

0

0

5P

1 50V

0.33

0.12

1k

0.33

0.12

1k

10k

B1

B2

F2

F3

F4

F5

F6

F7

F8

F9

F10

F11

I1

I2

I3

I4

J2

J3

FL

FR

70

63

45

44

43

19

18

57

SAT-L

SAT-R

1

2

3

5

6

MB_FL

LINK-L

DM_R

DM_L

81

82

LINK-R

SW

SW

SCORE

XVOICE

MB_FL

MB_FR

MB_SL

MB_SR

FC

LFE

DM_L

DM_R

LFE

FC

MB_SR

MB_SL

MB_FR

DOWNMIX-L

DOWNMIX-R

∗

∗

∗

∗

∗

∗

ST-CLK

ST-CE

ST-L

A-GND

ST-R

ST-DOUT/MC-DIN

ST-DIN /MC-DOUT

ST+9V

DGND

AGND

FC

SR

SL

AGND

FR

AGND

FL

AU+5V

AGND

L-IN

AGND

R-IN

AGND

SW(LFE)

AGND

AGND

CTR-IN

AGND

AGND

+9V

TUNED

LT

RT

SL-IN

SR-IN INPUT R

INPUT L

S0

S1

S2

OUTPUT R

OUTPUT L

AGND

AGND

AGND

AGND

SELECTOR

AGND

DGND

S3

IIC CLK

IIC DATA

DGND

D+4V

CTRL2

CTRL3

CTRL1

SCORE

XVOICE

L+R(SPEANA)

(3/6)

MUTING

MUTING

MUTING

AM

ANTENNA

COAXIALFM 75Ω

SUPPLIED WITH

THE ASSEMBLED

BLOCK

∗ R531,581

6.8k

ZX80D:US,E3,E13,E51,MX/

ZX100D:E3,E51,MX,SP,MY

4.7k

∗ Q205,255

2SC2412K (ZX80D:US,MX/ZX100D:MX)2SC2712 (ZX80D:E2,E3,E13,E51/ZX100D:E2,E3,E51,SP,MY)

(ZX80D:E2:ZX100D:E2)

ELECTRICAL VOLUME

FEED BACK

SWITCH

SWITCH

FEED BACK

MUTING

MUTING

+5V REGULATOR

REGULATOR CONTROL

SWITCH+4V REGULATOR

MUTING

MUTING

MUTING

MUTING

MUTING

TUNER (FM/AM)

A+9V

L

R

TV/SAT

AUDIO IN

D-LIGHT

SYNC OUT

L+R

∗ R236,286

10k(ZX100D)

22k(ZX80D)




(Page 4)

(Page 8)

(Page 7)

(Page 7)

(Page 4)(Page 8)

(Page 3)

(Page 4)

HCD-ZX80D/ZX100D

66HCD-ZX80D/ZX100D


L320

Q380

T301

IC301

R308

R310

R311

R370

R374

R392

C378

C301

C303

C304

R303R319R302 R304

C306

R305

C311

C314

R306

R307

C307

R312

C308

C312

L302100µH

R309

C309

C359

R396

R399

Q377

Q379

Q322

Q321

Q372

Q373

R314

R338

C333C328

R364

R388

R380

C383

L370

L372

R395

R394

Q378

R376

R375

C373

R373

R372

C372

R371

C379

C377

R377

C374

C371

C370

R378

CN503

R352

R355R354

R369 R353 C356

C354

C353

C351 R391C361

C364

C355

R335

C305

C310

C382

C332

Q382

Q383

Q381

R390

C335

C385

C376

R379

CN504

HP1

HRPE1

C326

Q325

Q375

R368

R318

R336

R337

R387

R385

Q370

R386

R339

R301

R389

R351

27mH

DTC114EKA

HA12237 100

100

100

3.3k

4.7k

6.8k

120p

0.012

0.1

1050V

10k2.2k4.7k 2.2k

2.250V

47k

1050V

0.0022

22k

1M

1050V

100

47010V

10 50V 4.7k

47 16V

47 16V

10k

10k

2SA1162

DTC114EKA

2SD2704

2SD2704

2SD2704

2SD2704

2.2k

10k

330p120p

2.2k

10k

6.8k

330p

27mH

47k

4.7k

RT1P137P-TP-1

4.7k

0

0.001

4.7k

0

0.001

4.7k

0.0068

0.01

47

47 10V

0.0047

0.01100V

10k

8P

4.7k

47k2.2k

2.2k 10k 2.2 50V

10 50V

0.1

0.012 1k1050V

0.0022

150V

1k

150V

10 50V

1200p

1200p

DTA114EKA

DTC114EKA

DTC114EKA

10k

0.022

0.022

680p

10

3P

680p

2SD2704

2SD2704

2.2k

2.2k

2.2k

2.2k

2.2k

2.2k

2SD596

33

15k

1.5k

15k

1.5k

C1

C2

C3

K1

K2

L1

L2

H1

H2

H3

52

53

56

54

55

REC-OUT-R

REC-OUT-L

REC-OUT-L

REC-OUT-R

L-PB

L-REC

R-PB

E-HOT

R-REC

GND

GND

GND

L-PB

R-PB

GND

RE

C-O

UT

1

NC

AL

C1

RE

C-I

N1

NC

PB

-OU

T1

TA

I1

EQ

OU

T1

PB

-E

Q1

PB

-NF1

B

PB-NF1A

AIN1

RIP

BIN1

REC-RETN

GND

BIN2

NC

AIN2

PB-NF2A

PB

-EQ

2

EO

UT

2

TA

I2

PB

-OU

T2

NC

RE

C-I

N2

AL

C2

NC

RE

C-O

UT

2

PB

-NF2

B

ALC ON/OFF

MUTE ON/OFF

REC MUTE ON/OFF

I-REF

TEST

ALC DET

GND

VCC

A/B

NORMAL SPEEDHIGH/

(4/6)

Q382,383


MUTING

MUTING


Q377,379,381

MUTING

MUTING

MUTING

MUTING

REC/PB EQ AMP

Q378,380

REC BIAS SWITCH

BIAS OSC

BIAS OSC

L-CH

R-CH

(PB)

(DECK-A)

R-CH

L-CH

ERASE

(DECK-B)

(REC/PB/ERASE)

DECK A/B SELECT SWITCH,

1

3

4

6

100µH

(Page 8)

(Page 3)

(Page 4)

(Page 7)

HCD-ZX80D/ZX100D

77HCD-ZX80D/ZX100D


R575

R513

R317

R320

R381

R300

R365

R350

R316

R315

R382

R366

C511

R518

Q519Q511

Q512

R533 R534

R519

Q515R517

Q509

Q510

R516

R515

C510

C517R552 R553

Q516

R514

Q508

Q507

CN501R512

C507

C508R511

Q522

Q521

R529

R530

Q506

Q505

R510

C524

C523

R508C506 C505

R509

C365R522

D506 R535

R536D507

R537

C341

Q344

R341 R345 R349

R346Q341

D341

R525

R526

R576

R527

R577

R528

Q514

C554

C504

C550

D550

C553

CN502

R358

R356

C352

R321C363

C362

R359

C325

C551

CN509

D340

Q517

Q343 Q345

D342

C509

C552

C360

Q564

R578

Q340 Q342

R347R343

R344 R348

R342

C525

R554

R540R521

R520

JR513

JR515

Q504

CN513

R538

C512

IC550

IC304(2/2)

R357

IC304(1/2)

R340C340

10k

15k

22k

33k

4.7k

4.7k

3.3k

4.7k

47k

3.3k

47k

10k

2.250V

10k

DTA124EKADTA124EKA

DTC114EKA

10k 10k

1k

DTC143TKA47k

DTA124EKA

DTC114EKA

15k

68k

2.250V

2.250V

68k 470k

DTA124EKA

470k

DTC114EKA

DTA124EKA

13P68k

2.2 50V

2.2 50V470k

DTA124EKA

DTC114EKA

15k

68k

DTC114EKA

DTA124EKA

8.2k

2.250V

2.250V

470k

JR5160

2.250V

2.250V

68k

150V 4.7k

MA111-TX 10k

10kMA111-TX

470k

0.0047

DTC114EKA

3.3k 3.3k 3.3k

6802SB1132

MA111-TX

D510MA111-TX

D511MA111-TX

10k

1k

1k

47k

47k

10k

2SD2114

1050V

1050V

10016V

MA111-TX

22025V

8P

33k

4.7k

4716V

33k4.7 50V

4.7 50V

33k

1050V

0.1

11P

MA111-TX

DTC114EKA

DTC114EKA DTC114EKA

MA111-TX

2.250V

2.250V

33p

2SD2114

10k

2SB1132 2SB1132

2.2k2.2k

680 680

2.2k

100010V

15k

10k0

10k

0

0

DTC143TKA

13P

5.6k

10 50V

RT8H015C-TH12-1

NJM4565M(TE2)

4.7k

NJM4565M(TE2)

2.2k0.0047

D1

D2

D3

D4

D5

D6

D7

D8

D9

G1

G2

G3

G4

G5

G6

I1

I2

I3

I4

K1

K2

M1

M2

M3

M4

M7

M8

M10

M11

M12

M5

M9

M6

R-OUT

L-OUT

48

50

49

89

47

90

91

46

75

60

76

77

83

65

51

60

61

DOWNMIX-L

94

60

72

DOWNMIX-R

67

66

71

FAN DET

POWER-GND

POWER-GND

UNREG

A+9V

DGND

LINK RELAY

AC CUT DETECT

FRONT RELAY

L-IN

R-IN

PREGND

DC DETECT

OVERLOAD DETECT

THERMAL VACS

STK MUTE

-VL

-VL

TCM MGND

B SHUT

CAPM+

BTRGM+

ATRGM+

REC(FWD)

A SHUT

BHALF

AHALF

TC DGND

REC(REV)

SW A-GND

SW LINE MUTE

SW SPK RY

STK MUTE

UNREG

UNREG

OVELOAD

DC DETECT

DVD LINE MUTE

CENTER RELAY

REAR RELAY

(5/6)

OVER CURRENT PROTECTOR

SPEANA AMP

BUFFER

MUTING

MUTING

Q342,345Q340,343

TRIGGER PLUNGER

DRIVE(DECK-A)

TRIGGER PLUNGER

DRIVE(DECK-B)

Q341,344

CAPSTAN/REEL

MOTOR DRIVE

Q521,522

MUTING CONTROL SWITCHMUTING CONTROL SWITCH

Q505,506


Q507,508


Q512,515,519

Q509,510

MUTING CONTROL

SWITCHMUTING

CONTROL

SWITCH

SWITCH

Q516,517

MUTING CONTROL

ZX80D:E2,E3,E13,E51/


ZX80D:US,MX/

ZX100D:MX

(ZX100D)

(ZX80D)

H/P MUTE

FR RELAY PROTECT

DBFB F/B

CENTER-SPK-SWITCH

SW

SUPPLIED WITH

BLOCK

THE ASSEMBLED

DECK BLOCK

TAPE MECHANISM

(2/2)

(1/2)

AC CUT DETECT

(ZX80D)

(ZX100D)




(Page 8)

(Page 6)

(Page 3)

(Page 4)

(Page 8)

(Page 5)

(Page 3)

(Page 5)

(Page 4)

HCD-ZX80D/ZX100D

88HCD-ZX80D/ZX100D


IC559

IC558

Q520

R243

R244

R294

CN580C581

C580

D581Q581

R586

D582

R585

R584Q585

Q513

R539 R523 R506 R500

R505

C567

C570

C571

C568C516

C569

Q503

Q518

R524

C515 C513

R507

C557

C558

C564C563

C565C562

R295

R245

Q256

Q206

R296

R246

R247

R297

R289

R239

C202R238

R288

NO523

NO603

C566

C514

EPT560

C530FB254R293

FB204

C252

C233

R248

Q208

R602

R250

Q207

R252

C234 R251 R601

R253

JR219

JR218

CN105

R482

R481

R480

IC507

JW550

M501

JW219

C519

D561

R579

Q582 Q579

Q578

D560

R549

Q550

R551

J203

CN102

JR514

J202

TM101

D583

IC561

IC560

D551

TA78033LS

TA7805LS

2SB1565F

1k

100k

100k

3P0.1

0.1

UDZW-TE17-6.8B2SC2712

1k

UDZW-TE17-6.2B

1k

10k2SD2525

DTC114EKA

4.7k 4.7k 4.7k 4.7k

2.7k

680025V

0.01

0.01

0.1220010V

0.1

DTC114EKA

DTC114EKA

10k

0.1 0.1

10k

0.01

0.01

0.147016V

0.147016V

10k

10k

2SD2114

2SD2114

47k

47k

1k

1k

10k

10k

1050V0

0

5P

8P

1000025V

220016V

100p (EXCEPT ZX80D:US)0.1 (ZX80D:US)01k

0

1050V

100p

100k

2SD2704K

10k

33k

2SD2114KT

10k

10 50V 2.2k 1k

10k

0

0

3P

100

100

1

PQ09RD21

220010V

D5SBA20

3302W

2SC2712 2SC2712

RT1N430C

D5SBA20

1.8k

DTC143TKA

56k

1P

4P

0

2P

HZU2.0BTRF

BA09T

BA09T

MA111-TX

E1

E2

E3

E4

J2

J3

L1

L2

M1

M2

M3

M4

M5

M6

M7

M8

M9

M10

M11

M12

N1

42

58

78

95

100

DGND

VF

VF

AC3

AC3

AC4

AC4

FAN+

FAN-

MGND

DGND

SW+

SW-

SW-

SW+

GND

DGND

+9V

SW-LED

SW VOL

(6/6)

(CHASSIS)

MUTING

MUTING

MUTINGMUTING

(ZX80D)

(ZX100D)

Q503,518

CONTROL

SWITCH

+9V REGULATOR+9V REGULATOR

+9V REGULATOR

G IO

IO G

(FAN)

(ZX100D)

Q513,520

B+ SWITCH

O IG

O IG

+5V REGULATOR

+3.3V REGULATOR

1

2

3

4

FAN MOTOR SWITCH

Q581,582

FAN MOTOR SPEED


CONTROL SWITCH

FAN MOTOR CONTROL

SWITCH

1

2

4

3

ZX80D:E2,E3,D13,E51/


L

R

OUT

SUBWOOFER

OUT

SUBWOOFER

TO

SS-WGV100D

SYSTEM

CONTROL

VP

SW+5V

SW+3.3V

SW+9V

AUDIO OUT

REGULATOR

OVER VOLTAGE

DETECT




(Page 4)

(Page 6)

(Page 5)

(Page 5)

(Page 7)

(Page 7)

(Page 3)

9

HCD-ZX80D/ZX100D


A-1174-078-A MAIN BOARD, COMPLETE (ZX80D: E3)A-1174-169-A MAIN BOARD, COMPLETE (ZX80D: MX)A-1174-256-A MAIN BOARD, COMPLETE (ZX100D: MX)A-1174-328-A MAIN BOARD, COMPLETE (ZX100D: E3)A-1193-164-A MAIN BOARD, COMPLETE (ZX80D: E13)

A-1193-167-A MAIN BOARD, COMPLETE (ZX80D: E2)A-1193-171-A MAIN BOARD, COMPLETE (ZX100D: SP, MY)A-1193-174-A MAIN BOARD, COMPLETE (ZX100D: E2)A-1193-435-A MAIN BOARD, COMPLETE (ZX80D: E51)A-1193-438-A MAIN BOARD, COMPLETE (ZX100D: E51)A-1227-251-A MAIN BOARD, COMPLETE (ZX80D: US)

*********************

7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

< CAPACITOR/RESISTOR >

C101 1-104-665-11 ELECT 100uF 20% 25VC102 1-126-964-11 ELECT 10uF 20% 50VC103 1-126-964-11 ELECT 10uF 20% 50VC104 1-126-964-11 ELECT 10uF 20% 50VC105 1-126-964-11 ELECT 10uF 20% 50V

C109 1-126-960-11 ELECT 1uF 20% 50VC110 1-137-150-11 FILM 0.01uF 5% 100V

(ZX100D)C110 1-137-438-11 MYLAR 0.0082uF 5% 50V

(ZX80D)C111 1-126-964-11 ELECT 10uF 20% 50VC112 1-136-498-11 FILM 0.12uF 5% 50V

C113 1-136-171-00 FILM 0.33uF 5% 50VC114 1-126-964-11 ELECT 10uF 20% 50VC115 1-164-156-11 CERAMIC CHIP 0.1uF 25VC116 1-126-924-11 ELECT 330uF 20% 10VC130 1-126-964-11 ELECT 10uF 20% 50V


C155 1-126-964-11 ELECT 10uF 20% 50VC159 1-126-960-11 ELECT 1uF 20% 50VC160 1-137-150-11 FILM 0.01uF 5% 100V

(ZX100D)C160 1-137-438-11 MYLAR 0.0082uF 5% 50V

(ZX80D)C161 1-126-964-11 ELECT 10uF 20% 50V

C162 1-136-498-11 FILM 0.12uF 5% 50VC163 1-136-171-00 FILM 0.33uF 5% 50VC164 1-126-964-11 ELECT 10uF 20% 50VC166 1-126-964-11 ELECT 10uF 20% 50VC167 1-126-964-11 ELECT 10uF 20% 50V


C176 1-164-677-11 CERAMIC CHIP 0.0033uF 10% 16VC200 1-136-497-11 FILM 0.1uF 5% 50VC201 1-136-497-11 FILM 0.1uF 5% 50VC202 1-126-964-11 ELECT 10uF 20% 50VC203 1-136-498-11 FILM 0.12uF 5% 50V

C204 1-136-171-00 FILM 0.33uF 5% 50VC205 1-104-665-11 ELECT 100uF 20% 25VC206 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC207 1-124-261-00 ELECT 10uF 20% 50VC209 1-124-261-00 ELECT 10uF 20% 50V

C210 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC211 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC212 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC213 1-126-964-11 ELECT 10uF 20% 50VC214 1-162-960-11 CERAMIC CHIP 220PF 10% 50V


C220 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC221 1-126-960-11 ELECT 1uF 20% 50VC222 1-126-964-11 ELECT 10uF 20% 50VC223 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC224 1-126-964-11 ELECT 10uF 20% 50V

C225 1-126-960-11 ELECT 1uF 20% 50VC226 1-126-960-11 ELECT 1uF 20% 50VC227 1-126-960-11 ELECT 1uF 20% 50VC228 1-126-960-11 ELECT 1uF 20% 50VC229 1-162-960-11 CERAMIC CHIP 220PF 10% 50V


C234 1-126-964-11 ELECT 10uF 20% 50V(ZX80D)

3. ELECTRICAL PARTS LIST MAIN

NOTE:• Due to standardization, replacements in the

parts list may be different from the partsspecified in the diagrams or the componentsused on the set.

• -XX and -X mean standardized parts, so theymay have some difference from the originalone.

• RESISTORSAll resistors are in ohms.METAL: Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F: nonflammable

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.

• SEMICONDUCTORSIn each case, u: µ, for example:uA... : µA... uPA... : µPA...uPB... : µPB... uPC... : µPC...uPD... : µPD...

• CAPACITORSuF: µF

• COILSuH: µH


When indicating parts by referencenumber, please include the board.





10

HCD-ZX80D/ZX100D

C235 1-100-566-11 CERAMIC CHIP 0.1uF 10% 25V(ZX80D: US)

C235 1-162-953-11 CERAMIC CHIP 100PF 5% 50V(EXCEPT ZX80D: US)


C251 1-126-160-11 ELECT 1uF 20% 50VC252 1-126-964-11 ELECT 10uF 20% 50VC253 1-136-498-11 FILM 0.12uF 5% 50VC254 1-136-171-00 FILM 0.33uF 5% 50VC255 1-104-665-11 ELECT 100uF 20% 25V

C256 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC257 1-126-964-11 ELECT 10uF 20% 50VC258 1-126-964-11 ELECT 10uF 20% 50VC259 1-124-261-00 ELECT 10uF 20% 50VC260 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C261 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC262 1-126-964-11 ELECT 10uF 20% 50VC263 1-126-964-11 ELECT 10uF 20% 50VC264 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC265 1-126-964-11 ELECT 10uF 20% 50V

C266 1-126-964-11 ELECT 10uF 20% 50VC267 1-126-964-11 ELECT 10uF 20% 50VC268 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC269 1-126-964-11 ELECT 10uF 20% 50VC270 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C272 1-126-934-11 ELECT 220uF 20% 16VC273 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC274 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC276 1-126-960-11 ELECT 1uF 20% 50VC277 1-126-960-11 ELECT 1uF 20% 50V

C278 1-126-960-11 ELECT 1uF 20% 50VC279 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC301 1-136-967-11 FILM 0.012uF 5% 100VC303 1-136-497-11 FILM 0.1uF 5% 50VC304 1-126-964-11 ELECT 10uF 20% 50V

C305 1-112-096-11 ELECT 1uF 20% 50VC306 1-126-961-11 ELECT 2.2uF 20% 50VC307 1-126-964-11 ELECT 10uF 20% 50VC308 1-126-935-11 ELECT 470uF 20% 16VC309 1-126-947-11 ELECT 47uF 20% 35V


C326 1-115-412-11 CERAMIC CHIP 680PF 5% 25VC328 1-137-427-11 MYLAR 120PF 5% 50VC332 1-164-670-11 CERAMIC CHIP 1200PF 5% 16VC333 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC335 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V

C340 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC341 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC351 1-136-967-11 FILM 0.012uF 5% 100VC352 1-126-947-11 ELECT 47uF 20% 35VC353 1-136-497-11 FILM 0.1uF 5% 50V

C354 1-126-964-11 ELECT 10uF 20% 50VC355 1-112-096-11 ELECT 1uF 20% 50VC356 1-126-961-11 ELECT 2.2uF 20% 50V

C357 1-126-963-11 ELECT 4.7uF 20% 50VC358 1-126-963-11 ELECT 4.7uF 20% 50V

C359 1-126-947-11 ELECT 47uF 20% 35VC360 1-162-921-11 CERAMIC CHIP 33PF 5% 50VC361 1-126-964-11 ELECT 10uF 20% 50VC362 1-126-963-11 ELECT 4.7uF 20% 50VC363 1-126-963-11 ELECT 4.7uF 20% 50V

C364 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC365 1-126-960-11 ELECT 1uF 20% 50VC370 1-137-150-11 FILM 0.01uF 5% 100VC371 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC372 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C373 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC374 1-126-947-11 ELECT 47uF 20% 35VC376 1-115-412-11 CERAMIC CHIP 680PF 5% 25VC377 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC378 1-137-427-11 MYLAR 120PF 5% 50V

C379 1-130-481-00 MYLAR 0.0068uF 5% 50VC382 1-164-670-11 CERAMIC CHIP 1200PF 5% 16VC383 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC385 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC410 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C411 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC412 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC413 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC414 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC415 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C416 1-104-656-11 ELECT 2200uF 20% 6.3VC431 1-126-964-11 ELECT 10uF 20% 50VC462 1-104-665-11 ELECT 100uF 20% 25VC464 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC501 1-126-964-11 ELECT 10uF 20% 50V

C502 1-136-497-11 FILM 0.1uF 5% 50VC503 1-136-497-11 FILM 0.1uF 5% 50VC504 1-126-964-11 ELECT 10uF 20% 50VC505 1-126-961-11 ELECT 2.2uF 20% 50VC506 1-126-961-11 ELECT 2.2uF 20% 50V

C507 1-126-961-11 ELECT 2.2uF 20% 50VC508 1-126-961-11 ELECT 2.2uF 20% 50VC509 1-126-961-11 ELECT 2.2uF 20% 50VC510 1-126-961-11 ELECT 2.2uF 20% 50VC511 1-126-961-11 ELECT 2.2uF 20% 50V

C512 1-126-964-11 ELECT 10uF 20% 50V (ZX80D: E2, E3, E13, E51/

ZX100D: E2, E3, E51, SP, MY)C513 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC514 1-126-768-11 ELECT 2200uF 20% 16VC515 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC516 1-126-927-11 ELECT 2200uF 20% 10V


C523 1-126-961-11 ELECT 2.2uF 20% 50VC524 1-126-961-11 ELECT 2.2uF 20% 50VC525 1-126-926-11 ELECT 1000uF 20% 10V

MAIN


11

HCD-ZX80D/ZX100D

C530 1-100-566-11 CERAMIC CHIP 0.1uF 10% 25V(ZX80D: US)

C530 1-162-953-11 CERAMIC CHIP 100PF 5% 50V(EXCEPT ZX80D: US)

C550 1-119-774-11 ELECT 100uF 20% 16VC551 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC552 1-126-961-11 ELECT 2.2uF 20% 50VC553 1-104-666-11 ELECT 220uF 20% 25VC554 1-126-964-11 ELECT 10uF 20% 50V

C557 1-130-483-00 MYLAR 0.01uF 5% 50VC558 1-130-483-00 MYLAR 0.01uF 5% 50VC559 1-126-926-11 ELECT 1000uF 20% 10VC562 1-126-935-11 ELECT 470uF 20% 16VC563 1-126-935-11 ELECT 470uF 20% 16V

C564 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC565 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC566 1-111-235-61 ELECT 10000uF 20% 25VC567 1-126-946-11 ELECT 6800uF 20% 25VC568 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C569 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC570 1-130-483-00 MYLAR 0.01uF 5% 50VC571 1-130-483-00 MYLAR 0.01uF 5% 50VC580 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC581 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C583 1-164-156-11 CERAMIC CHIP 0.1uF 25VC584 1-164-156-11 CERAMIC CHIP 0.1uF 25V

< CONNECTOR >

* CN100 1-564-711-11 PIN, CONNECTOR (SMALL TYPE) 9PCN102 1-820-049-11 CONNECTOR (SUBWOOFER)

(SYSTEM CONTROL ) (ZX100D)CN105 1-691-765-11 PLUG (MICRO CONNECTOR) 3P (ZX100D)CN501 1-573-845-11 CONNECTOR, BOARD TO BOARD 13P

* CN502 1-774-876-21 CONNECTOR, BOARD TO BOARD 8P

* CN503 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8PCN504 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P

* CN505 1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6PCN506 1-784-731-11 CONNECTOR, FFC 9P

* CN508 1-569-934-11 SOCKET, CONNECTOR 17P

CN509 1-569-928-11 SOCKET, CONNECTOR 11P* CN510 1-568-449-11 HOUSING, CONNECTOR (PC BOARD) 3P

CN511 1-565-937-11 SOCKET, CONNECTOR 13PCN512 1-779-287-11 CONNECTOR, FFC (LIF (NON-ZIF)) 19PCN513 1-573-845-11 CONNECTOR, BOARD TO BOARD 13P

* CN514 1-774-876-21 CONNECTOR, BOARD TO BOARD 8PCN520 (Not supplied) CONNECTOR, FPC/FFC 13PCN521 1-815-149-11 CONNECTOR, FPC/FFC (1mm PIC) 21PCN580 1-564-506-11 PLUG, CONNECTOR 3PCN582 1-564-506-11 PLUG, CONNECTOR 3P

< DIODE >

D101 8-719-404-50 DIODE MA111-TXD102 8-719-404-50 DIODE MA111-TXD136 6-501-168-01 DIODE UDZW-TE17-5.6BD325 6-501-166-01 DIODE UDZW-TE17-4.7BD340 8-719-404-50 DIODE MA111-TX


D401 8-719-404-50 DIODE MA111-TXD402 8-719-404-50 DIODE MA111-TXD403 8-719-404-50 DIODE MA111-TX


D504 8-719-404-50 DIODE MA111-TXD505 8-719-404-50 DIODE MA111-TXD506 8-719-404-50 DIODE MA111-TXD507 8-719-404-50 DIODE MA111-TXD510 8-719-404-50 DIODE MA111-TX (ZX80D)

D511 8-719-404-50 DIODE MA111-TX (ZX80D)D550 8-719-404-50 DIODE MA111-TXD551 8-719-404-50 DIODE MA111-TX (ZX80D: E2, E3, E13, E51/

ZX100D: E2, E3, E51, SP, MY)D560 8-719-500-60 DIODE D5SBA20D561 8-719-500-60 DIODE D5SBA20

D581 6-501-170-01 DIODE UDZW-TE17-6.8BD582 6-501-169-01 DIODE UDZW-TE17-6.2BD583 8-719-071-54 DIODE HZU2.0BTRFD584 8-719-083-63 DIODE UDZSTE-1713BD585 6-500-522-21 DIODE 10EDB40-TB3

D586 6-500-522-21 DIODE 10EDB40-TB3

< JUMPER RESISTOR >

FB204 1-216-864-11 SHORT CHIP 0FB254 1-216-864-11 SHORT CHIP 0FB260 1-216-864-11 SHORT CHIP 0FB261 1-216-864-11 SHORT CHIP 0

< IC >

IC101 6-703-650-11 IC M61529FP-D60GIC201 6-703-651-11 IC M61530FP-D60GIC301 6-702-130-01 IC HA12237FIC304 8-759-710-97 IC NJM4565M-DIC401 6-806-203-01 IC M30622MEP-A78FPU0

IC501 6-705-809-01 IC BD4929G-TRIC507 8-759-653-07 IC PQ09RD21J00HIC550 6-703-610-01 IC RT8H015C-T112-1IC558 6-703-547-01 IC TA7805LSIC559 6-702-771-01 IC TA78033LS

IC560 8-759-394-36 IC BA09TIC561 8-759-394-36 IC BA09T

< CONNECTOR/JACK >

J103 1-820-048-11 CONNECTOR (LIGHTING) (D-LIGHT SYNC OUT)J201 1-815-045-11 JACK, PIN 2P (TV/SAT AUDIO IN)J202 1-815-045-11 JACK, PIN 2P (AUDIO OUT)J203 1-770-377-31 JACK, PIN 1P (SUBWOOFER OUT) (ZX80D)

< JUMPER RESISTOR >


MAIN


12

HCD-ZX80D/ZX100D


JR208 1-216-864-11 SHORT CHIP 0JR218 1-216-864-11 SHORT CHIP 0JR219 1-216-864-11 SHORT CHIP 0 (ZX80D)JR222 1-216-864-11 SHORT CHIP 0JR300 1-216-296-11 SHORT CHIP 0







JR513 1-216-864-11 SHORT CHIP 0 (ZX100D)JR514 1-216-864-11 SHORT CHIP 0JR515 1-216-296-11 SHORT CHIP 0 (ZX80D)JR516 1-216-864-11 SHORT CHIP 0 (ZX100D)JR520 1-216-864-11 SHORT CHIP 0



< COIL >

L302 1-414-189-31 INDUCTOR 100uHL320 1-410-780-11 INDUCTOR 27mHL370 1-410-780-11 INDUCTOR 27mH

MAIN

L372 1-414-189-31 INDUCTOR 100uH

< TRANSISTOR >

Q101 8-729-230-49 TRANSISTOR 2SC2712-YGQ103 8-729-056-46 TRANSISTOR 2SC5053T100QQ104 8-729-027-43 TRANSISTOR DTC114EKA-T146Q106 8-729-023-22 TRANSISTOR 2SD2114KQ117 8-729-023-22 TRANSISTOR 2SD2114K

Q151 8-729-230-49 TRANSISTOR 2SC2712-YGQ156 8-729-023-22 TRANSISTOR 2SD2114KQ167 8-729-023-22 TRANSISTOR 2SD2114KQ200 8-729-023-22 TRANSISTOR 2SD2114KQ202 8-729-023-22 TRANSISTOR 2SD2114K

Q203 8-729-023-22 TRANSISTOR 2SD2114KQ204 8-729-023-22 TRANSISTOR 2SD2114KQ205 8-729-230-49 TRANSISTOR 2SC2712-YG (ZX80D: E2, E3,

E13, E51/ZX100D: E2, E3, E51, SP, MY)Q205 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R

(ZX80D: US, MX/ZX100D: MX)Q206 8-729-023-22 TRANSISTOR 2SD2114K

Q207 8-729-023-22 TRANSISTOR 2SD2114K (ZX80D)Q208 6-551-287-01 TRANSISTOR 2SD2704K-T146 (ZX80D)Q250 8-729-023-22 TRANSISTOR 2SD2114KQ252 8-729-023-22 TRANSISTOR 2SD2114KQ253 8-729-023-22 TRANSISTOR 2SD2114K

Q254 8-729-023-22 TRANSISTOR 2SD2114KQ255 8-729-230-49 TRANSISTOR 2SC2712-YG (ZX80D: E2, E3,

E13, E51/ZX100D: E2, E3, E51, SP, MY)Q255 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R

(ZX80D: US, MX/ZX100D: MX)Q256 8-729-023-22 TRANSISTOR 2SD2114KQ321 6-551-287-01 TRANSISTOR 2SD2704K-T146

Q322 6-551-287-01 TRANSISTOR 2SD2704K-T146Q323 8-729-056-46 TRANSISTOR 2SC5053T100QQ325 6-551-287-01 TRANSISTOR 2SD2704K-T146Q340 8-729-920-79 TRANSISTOR 2SB1132-T100-QRQ341 8-729-920-79 TRANSISTOR 2SB1132-T100-QR

Q342 8-729-920-79 TRANSISTOR 2SB1132-T100-QRQ343 8-729-027-43 TRANSISTOR DTC114EKA-T146Q344 8-729-027-43 TRANSISTOR DTC114EKA-T146Q345 8-729-027-43 TRANSISTOR DTC114EKA-T146Q370 8-729-141-75 TRANSISTOR 2SD596DV345

Q372 6-551-287-01 TRANSISTOR 2SD2704K-T146Q373 6-551-287-01 TRANSISTOR 2SD2704K-T146Q375 6-551-287-01 TRANSISTOR 2SD2704K-T146Q377 8-729-216-22 TRANSISTOR 2SA1162-GQ378 6-550-185-01 TRANSISTOR RT1P137P-TP-1

Q379 8-729-027-43 TRANSISTOR DTC114EKA-T146Q380 8-729-027-43 TRANSISTOR DTC114EKA-T146Q381 8-729-027-43 TRANSISTOR DTC114EKA-T146Q382 8-729-027-23 TRANSISTOR DTA114EKA-T146Q383 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q501 8-729-901-00 TRANSISTOR DTC124EKQ503 8-729-027-43 TRANSISTOR DTC114EKA-T146Q504 8-729-027-56 TRANSISTOR DTC143TKA-T146 (ZX80D:

E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)Q505 8-729-027-31 TRANSISTOR DTA124EKA-T146Q506 8-729-027-43 TRANSISTOR DTC114EKA-T146


13

HCD-ZX80D/ZX100D

Q507 8-729-027-31 TRANSISTOR DTA124EKA-T146Q508 8-729-027-43 TRANSISTOR DTC114EKA-T146Q509 8-729-027-31 TRANSISTOR DTA124EKA-T146Q510 8-729-027-43 TRANSISTOR DTC114EKA-T146Q511 8-729-027-31 TRANSISTOR DTA124EKA-T146

Q512 8-729-027-43 TRANSISTOR DTC114EKA-T146Q513 8-729-027-43 TRANSISTOR DTC114EKA-T146Q514 8-729-023-22 TRANSISTOR 2SD2114KQ515 8-729-027-56 TRANSISTOR DTC143TKA-T146Q516 8-729-027-31 TRANSISTOR DTA124EKA-T146

Q517 8-729-027-43 TRANSISTOR DTC114EKA-T146Q518 8-729-027-43 TRANSISTOR DTC114EKA-T146Q519 8-729-027-31 TRANSISTOR DTA124EKA-T146Q520 8-729-024-94 TRANSISTOR 2SB1565FQ521 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q522 8-729-027-31 TRANSISTOR DTA124EKA-T146Q523 8-729-027-23 TRANSISTOR DTA114EKA-T146Q524 8-729-901-00 TRANSISTOR DTC124EKQ550 8-729-027-56 TRANSISTOR DTC143TKA-T146 (ZX80D:

E2, E3, E13, E51/ZX100D: E2, E3, E51, SP, MY)Q564 8-729-023-22 TRANSISTOR 2SD2114K

Q578 8-729-027-56 TRANSISTOR DTC143TKA-T146Q579 8-729-230-49 TRANSISTOR 2SC2712-YGQ581 8-729-230-49 TRANSISTOR 2SC2712-YGQ582 8-729-230-49 TRANSISTOR 2SC2712-YGQ585 8-729-026-68 TRANSISTOR 2SD2525 (TP)

Q587 8-729-230-49 TRANSISTOR 2SC2712-YGQ588 8-729-026-68 TRANSISTOR 2SD2525 (TP)Q589 8-729-230-49 TRANSISTOR 2SC2712-YG

< RESISTOR >


R106 1-216-833-11 METAL CHIP 10K 5% 1/10WR107 1-216-809-11 METAL CHIP 100 5% 1/10WR108 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR109 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR110 1-216-833-11 METAL CHIP 10K 5% 1/10W


R116 1-216-809-11 METAL CHIP 100 5% 1/10WR117 1-216-864-11 SHORT CHIP 0R120 1-216-864-11 SHORT CHIP 0R121 1-216-833-11 METAL CHIP 10K 5% 1/10WR122 1-216-833-11 METAL CHIP 10K 5% 1/10W

R130 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR131 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR132 1-216-857-11 METAL CHIP 1M 5% 1/10WR133 1-216-845-11 METAL CHIP 100K 5% 1/10WR135 1-216-823-11 METAL CHIP 1.5K 5% 1/10W



R155 1-216-841-11 METAL CHIP 47K 5% 1/10WR156 1-216-833-11 METAL CHIP 10K 5% 1/10WR157 1-216-809-11 METAL CHIP 100 5% 1/10WR158 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR159 1-216-827-11 METAL CHIP 3.3K 5% 1/10W


R165 1-216-821-11 METAL CHIP 1K 5% 1/10WR166 1-216-809-11 METAL CHIP 100 5% 1/10WR167 1-216-864-11 SHORT CHIP 0R200 1-216-833-11 METAL CHIP 10K 5% 1/10WR202 1-216-833-11 METAL CHIP 10K 5% 1/10W


R208 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR209 1-216-833-11 METAL CHIP 10K 5% 1/10WR210 1-216-817-11 METAL CHIP 470 5% 1/10WR211 1-216-841-11 METAL CHIP 47K 5% 1/10WR212 1-216-832-11 METAL CHIP 8.2K 5% 1/10W

R213 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR214 1-216-841-11 METAL CHIP 47K 5% 1/10WR215 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR216 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR217 1-216-833-11 METAL CHIP 10K 5% 1/10W






(ZX80D)

R237 1-216-841-11 METAL CHIP 47K 5% 1/10WR238 1-216-864-11 SHORT CHIP 0R239 1-216-833-11 METAL CHIP 10K 5% 1/10W

MAIN


14

HCD-ZX80D/ZX100D






(ZX80D)



R254 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR255 1-216-821-11 METAL CHIP 1K 5% 1/10WR256 1-216-841-11 METAL CHIP 47K 5% 1/10W

R257 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR258 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR259 1-216-833-11 METAL CHIP 10K 5% 1/10WR260 1-216-817-11 METAL CHIP 470 5% 1/10WR261 1-216-841-11 METAL CHIP 47K 5% 1/10W

R262 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR263 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR264 1-216-841-11 METAL CHIP 47K 5% 1/10WR265 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR266 1-216-825-11 METAL CHIP 2.2K 5% 1/10W





(ZX100D)


R287 1-216-841-11 METAL CHIP 47K 5% 1/10WR288 1-216-864-11 SHORT CHIP 0R289 1-216-833-11 METAL CHIP 10K 5% 1/10WR290 1-216-835-11 METAL CHIP 15K 5% 1/10W




R306 1-216-837-11 METAL CHIP 22K 5% 1/10WR307 1-216-857-11 METAL CHIP 1M 5% 1/10WR308 1-216-809-11 METAL CHIP 100 5% 1/10WR309 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR310 1-216-809-11 METAL CHIP 100 5% 1/10W

R311 1-216-809-11 METAL CHIP 100 5% 1/10WR312 1-216-809-11 METAL CHIP 100 5% 1/10WR314 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR315 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR316 1-216-841-11 METAL CHIP 47K 5% 1/10W

R317 1-216-837-11 METAL CHIP 22K 5% 1/10WR318 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR319 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR320 1-216-839-11 METAL CHIP 33K 5% 1/10WR321 1-216-839-11 METAL CHIP 33K 5% 1/10W



R341 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR342 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR343 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR344 1-216-819-11 METAL CHIP 680 5% 1/10WR345 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R346 1-216-819-11 METAL CHIP 680 5% 1/10WR347 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR348 1-216-819-11 METAL CHIP 680 5% 1/10WR349 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR350 1-216-829-11 METAL CHIP 4.7K 5% 1/10W



MAIN


15

HCD-ZX80D/ZX100D



R369 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR370 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR371 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR372 1-216-864-11 SHORT CHIP 0R373 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R374 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR375 1-216-864-11 SHORT CHIP 0R376 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR377 1-216-805-11 METAL CHIP 47 5% 1/10WR378 1-216-833-11 METAL CHIP 10K 5% 1/10W

R379 1-216-797-11 METAL CHIP 10 5% 1/10WR380 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR381 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR382 1-216-841-11 METAL CHIP 47K 5% 1/10WR383 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R384 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR385 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR386 1-216-803-11 METAL CHIP 33 5% 1/10WR387 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR388 1-216-833-11 METAL CHIP 10K 5% 1/10W

R389 1-216-835-11 METAL CHIP 15K 5% 1/10WR390 1-216-833-11 METAL CHIP 10K 5% 1/10WR391 1-216-821-11 METAL CHIP 1K 5% 1/10WR392 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR394 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


R402 1-216-809-11 METAL CHIP 100 5% 1/10WR403 1-216-833-11 METAL CHIP 10K 5% 1/10WR404 1-216-833-11 METAL CHIP 10K 5% 1/10WR405 1-216-809-11 METAL CHIP 100 5% 1/10WR406 1-216-809-11 METAL CHIP 100 5% 1/10W


R412 1-216-845-11 METAL CHIP 100K 5% 1/10WR413 1-216-864-11 SHORT CHIP 0R414 1-216-809-11 METAL CHIP 100 5% 1/10WR415 1-216-809-11 METAL CHIP 100 5% 1/10WR417 1-216-833-11 METAL CHIP 10K 5% 1/10W



R428 1-216-833-11 METAL CHIP 10K 5% 1/10WR429 1-216-809-11 METAL CHIP 100 5% 1/10WR430 1-216-809-11 METAL CHIP 100 5% 1/10WR431 1-216-809-11 METAL CHIP 100 5% 1/10WR432 1-216-809-11 METAL CHIP 100 5% 1/10W







R474 1-216-809-11 METAL CHIP 100 5% 1/10WR475 1-216-809-11 METAL CHIP 100 5% 1/10WR478 1-216-821-11 METAL CHIP 1K 5% 1/10WR479 1-216-833-11 METAL CHIP 10K 5% 1/10W

0R480 1-217-637-00 FUSIBLE 1 5% 1/4W F(ZX100D)

R481 1-216-809-11 METAL CHIP 100 5% 1/10W(ZX100D)

R482 1-216-809-11 METAL CHIP 100 5% 1/10W(ZX100D)

R483 1-216-809-11 METAL CHIP 100 5% 1/10WR484 1-216-833-11 METAL CHIP 10K 5% 1/10WR485 1-216-809-11 METAL CHIP 100 5% 1/10W

R486 1-216-809-11 METAL CHIP 100 5% 1/10WR487 1-216-833-11 METAL CHIP 10K 5% 1/10WR488 1-216-809-11 METAL CHIP 100 5% 1/10WR489 1-216-809-11 METAL CHIP 100 5% 1/10WR490 1-216-809-11 METAL CHIP 100 5% 1/10W

MAIN


16

HCD-ZX80D/ZX100D

R491 1-216-809-11 METAL CHIP 100 5% 1/10WR492 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR493 1-216-815-11 METAL CHIP 330 5% 1/10W

(ZX80D: E3/ZX100D: E3)R493 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

(ZX80D: US, E2, E13, E51, MX/ZX100D: E2, E51, MX)

R493 1-216-864-11 SHORT CHIP 0 (ZX100D: SP, MY)

R494 1-216-809-11 METAL CHIP 100 5% 1/10WR496 1-216-809-11 METAL CHIP 100 5% 1/10WR499 1-216-809-11 METAL CHIP 100 5% 1/10WR500 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR501 1-216-813-11 METAL CHIP 220 5% 1/10W

R502 1-216-821-11 METAL CHIP 1K 5% 1/10WR503 1-216-864-11 SHORT CHIP 0R505 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR506 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR507 1-216-833-11 METAL CHIP 10K 5% 1/10W





R521 1-216-864-11 SHORT CHIP 0(ZX80D: US, MX/ZX100D: MX)

R522 1-216-829-11 METAL CHIP 4.7K 5% 1/10W




(ZX80D: US, E3, E13, E51, MX/ZX100D: E3, E51, MX, SP, MY)


R537 1-216-853-11 METAL CHIP 470K 5% 1/10WR538 1-216-830-11 METAL CHIP 5.6K 5% 1/10W


R539 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R540 1-216-833-11 METAL CHIP 10K 5% 1/10W(ZX80D: E2, E3, E13, E51/

ZX100D: E2, E3, E51, SP, MY)R549 1-216-824-11 METAL CHIP 1.8K 5% 1/10W


R551 1-216-842-11 METAL CHIP 56K 5% 1/10W(ZX80D: E3, E13, E51, MX/

ZX100D: E3, E51, MX, SP, MY)R552 1-216-843-11 METAL CHIP 68K 5% 1/10WR553 1-216-853-11 METAL CHIP 470K 5% 1/10WR554 1-216-835-11 METAL CHIP 15K 5% 1/10WR573 1-216-833-11 METAL CHIP 10K 5% 1/10W


0R579 1-215-889-00 METAL OXIDE 330 5% 2W FR581 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


(ZX80D: US, E3, E13, E51, MX/ZX100D: E3, E51, MX, SP, MY)



(ZX80D)


R593 1-216-811-11 METAL CHIP 150 5% 1/10W(ZX80D: E13)

R593 1-216-821-11 METAL CHIP 1K 5% 1/10W(ZX80D: E2, E51, MX/ZX100D: E2, E51, MX)

R593 1-216-825-11 METAL CHIP 2.2K 5% 1/10W(ZX80D: US)

R593 1-216-829-11 METAL CHIP 4.7K 5% 1/10W(ZX80D: E3/ZX100D: E3)

R594 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR595 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR601 1-216-821-11 METAL CHIP 1K 5% 1/10W


(ZX80D)R612 1-216-864-11 SHORT CHIP 0

R623 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR662 1-216-864-11 SHORT CHIP 0

< TRANSFORMER >

T301 1-433-372-11 TRANSFORMER, BIAS OSCILLATION

< TERMINAL >

TM101 1-780-170-21 TERMINAL BOARD (SPEAKER) (SUBWOOFER OUT) (ZX100D)

MAIN


17

HCD-ZX80D/ZX100D

< VIBRATOR >

X401 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)X402 1-795-058-21 VIBRATOR, CERAMIC (5MHz)

MAIN

HCD-ZX80D/ZX100D

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.

Ver. Date Description of Revision

1.0 2006.05 New

1.1 2007.03 Addition of US model (HCD-ZX80D)

Change of PA, PRIMARY and TRANS boards (Suffix-23)

Revision of EXPLODED VIEWS

Revision of electrical parts

Change of MAIN board (Suffix-13) (SUPPLEMENT-1)

(ECN-ECB93496/ECC02609/ENG-07001)

75157120-HCD-ZX80DZX100D

Documents

fluorescent

jpeg image

master controller

digital theater

circuit boards

focus gain

120v ac area

240v ac area