Edition: June 9, 2009
Lexmark T650, T650n, T652dn, & T654dn Printer 4062-XXX
Table of contents Start diagnostics Safety and notices
Trademarks Index
Lexmark and Lexmark with diamond design are trademarks of
Lexmark International, Inc., registered in the United States and/or
other countries.
4062-XXX
Edition: June 9, 2009 The following paragraph does not apply to
any country where such provisions are inconsistent with local law:
LEXMARK INTERNATIONAL, INC. PROVIDES THIS PUBLICATION AS IS WITHOUT
WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT
LIMITED TO, THE IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS
FOR A PARTICULAR PURPOSE. Some states do not allow disclaimer of
express or implied warranties in certain transactions; therefore,
this statement may not apply to you. This publication could include
technical inaccuracies or typographical errors. Changes are
periodically made to the information herein; these changes will be
incorporated in later editions. Improvements or changes in the
products or the programs described may be made at any time.
Comments may be addressed to Lexmark International, Inc.,
Department D22X/002-1, 740 West New Circle Road, Lexington,
Kentucky 40550, U.S.A or e-mail at
[email protected]. Lexmark may use or distribute
any of the information you supply in any way it believes
appropriate without incurring any obligation to you. References in
this publication to products, programs, or services do not imply
that the manufacturer intends to make these available in all
countries in which it operates. Any reference to a product,
program, or service is not intended to state or imply that only
that product, program, or service may be used. Any functionally
equivalent product, program, or service that does not infringe any
existing intellectual property right may be used instead.
Evaluation and verification of operation in conjunction with other
products, programs, or services, except those expressly designated
by the manufacturer, are the users responsibility. Lexmark, Lexmark
with diamond design, and MarkNet are trademarks of Lexmark
International, Inc., registered in the United States and/or other
countries. PCL is a registered trademark of the Hewlett-Packard
Company. All other trademarks are the property of their respective
owners. 2008 Lexmark International, Inc. All rights reserved.
UNITED STATES GOVERNMENT RIGHTS This software and any accompanying
documentation provided under this agreement are commercial computer
software and documentation developed exclusively at private
expense.
P/N 12G9824
4062-XXX
Table of contentsTable of contents . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . iii Notices and safety information . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
xiiiLaser notice . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . xiii Lithium warning . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . ii-xix Safety
information. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . xix
Preface . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
xxiiConventions. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . xxii
General information
....................................................................
1-11-1 1-2 1-2 1-2 1-3 1-3 1-4 1-6 1-6 1-7 1-7 1-8 1-9
Maintenance approach . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . Options . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . Available internal options .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . Media handling options
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . Printer
configurations . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Basic model . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . Fully configured model . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . Supported paper sizes, types, and weights . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Paper sizes supported by the printer . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Paper
types and weights supported by the printer . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . Paper types and
weights supported by the output bins . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . Tools required . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . Acronyms . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . .
Diagnostic information . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 2-1Start . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 Confirm the
installation status . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2-2 Power-on Reset sequence . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 2-2 Entering Diagnostics mode . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 2-2 User attendance messages . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 2-3 Error code table 1 . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 2-16 Service
checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 2-144 Sensor (input) service check . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 2-144 Sensor (fuser output) service check . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 2-144 Sensor (narrow media) service check . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 2-145 Sensor (duplex input) service check . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2-145 Sensor (duplex input) service check (external duplex only) .
. . . . . . . . . . . . . . . . . . . . . . . . . 2-146 Sensor
(duplex exit) service check (external duplex only) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 2-147 Sensor (pass through)
service check . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 2-147 Sensor (envelope feeder
empty) service check . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 2-148 Sensor (input) late jam service
check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 2-148 Sensor (input) lingering jam
service check. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 2-151 Sensor (input) early jam service
check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 2-152 Sensor (input) static jam service
check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 2-154 Sensor (fuser output) late jam
service check. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 2-154 Sensor (fuser output) lingering jam
service check. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 2-156 Sensor (fuser output) static jam service check
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 2-157 Sensor (narrow media) late jam service check. . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2-158 Sensor (narrow media) static jam service check . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-159
Sensor (duplex input) late jam service check. . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 2-160 Sensor
(duplex input) lingering jam service check. . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . 2-161 Sensor (duplex
input) static jam service check. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 2-163 Sensor (pass through)
late jam service check . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 2-164
Table of contents
iii
4062-XXX
Sensor (pass through) lingering jam service check. . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .2-165 Sensor
(pass through) static jam service check . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .2-166 Sensor (stapler
pass through) late jam service check . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .2-167 Sensor (stapler pass
through) lingering jam service check . . . . . . . . . . . . . . .
. . . . . . . . . . . .2-168 Sensor (stapler pass through) static
jam service check . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . .2-169 Sensor (output pass through) late jam service
check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.2-169 Sensor (output pass through) lingering jam service check . .
. . . . . . . . . . . . . . . . . . . . . . . . .2-170 Sensor
(output pass through) static jam service check . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .2-171 Sensor (mailbox
empty) late jam service check . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .2-172 Sensor (mailbox empty)
lingering jam service check . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .2-173 Sensor (mailbox empty) static jam
service check . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .2-174 Sensor (toner empty) service check . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . .2-174 NVRAM mismatch failure (950.00 through 950.29)
service check . . . . . . . . . . . . . . . . . . . . . . .2-175 .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . .2-176 Image quality trouble . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .2-177 Printer Related
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .2-177 Image quality
symptoms . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .2-177 Image
Quality . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.2-178 Faint print (Low contrast) . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. .2-178 Blank print (no print) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . .2-180 Solid black . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .2-182 Vertical lines and bands (process direction)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . .2-183 Horizontal white stripes or bands (side to side
direction) . . . . . . . . . . . . . . . . . . . . . . . . . .
.2-184 Vertical stripes (process direction) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.2-185 Horizontal stripes (side to side direction) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.2-187 Partial lack . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . .2-189 Spots . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . .2-190 After image . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .2-192 Background (fog) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .2-193 Skew . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .2-194 Media damage . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .2-195 No fuse . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .2-197 Network
service check . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.2-198
Diagnostic aids . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 3-1Understanding the printer control
panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .3-1 Accessing service menus .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .3-2
Diagnostics mode . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .3-3 Entering Diagnostics mode . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .3-3 Available tests . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .3-3 Exiting Diagnostics
mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .3-5 REGISTRATION
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-5
Quick Test . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . .3-6 PRINT TESTS . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .3-7 Input source tests . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .3-7 Print quality pages (Prt Quality
Pgs) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .3-7 HARDWARE TESTS . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .3-8 Panel Test . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .3-8 Button Test . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-8 DRAM
Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.3-8 USB HS Test Mode . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. .3-9 RFID Option Test . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . .3-10 DUPLEX TESTS . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . .3-13 Quick Test (duplex) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .3-13 Top Margin (duplex) . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .3-13 Sensor Test (duplex) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .3-13 Motor Test (duplex) . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .3-14 Duplex Feed 1 . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .3-14 Duplex Feed 2 . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .3-14
iv Service Manual
4062-XXX
INPUT TRAY TESTS . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . Feed Tests (input tray) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . Sensor Test (input tray) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . OUTPUT BIN TESTS . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . Feed Tests (output bins) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . Feed To All Bins . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . Sensor Test (standard output bin) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sensor Test (Output Expander) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Sensor
Test (high capacity output stacker) . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . Sensor Tests (5-bin
mailbox) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . Deflector Test . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . StapleSmart FINISHER
TESTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . Staple Test . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . Feed Tests (finisher)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . Sensor Test
(finisher) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . BASE SENSOR
TEST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . PRINTER
SETUP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defaults . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Printed Page Count . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Perm Page Count (permanent page count) . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Serial
Number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Setting 1 through 16 . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Model
Name . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Configuration ID . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Edge to Edge . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . EP SETUP . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . EP Defaults . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . Fuser Temperature (Fuser Temp) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . Fuser Page Count . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . Warm Up Time . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . Transfer . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . Print Contrast . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . Charge Roll . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . Gap Adjust . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . Auto Dark Adj . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . REPORTS . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . EVENT LOG . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . Display Log . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . Print Log . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Clear
Log . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EXIT DIAGNOSTICS . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . Configuration menu (CONFIG MENU) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Entering Configuration Menu . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Available menus . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . Maintenance page count (Maint Cnt Value) . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance page counter reset (Reset Cnt) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . Print
quality pages (Prt Quality Pgs) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Reports .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . SIZE SENSING . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . Panel Menus . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . PPDS Emulation . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . Demo Mode . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . Factory Defaults . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . LES Applications .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . Energy
Conserve . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Paper Prompts . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Env Prompts . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . Action for Prompts . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . Font Sharpening . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
3-15 3-15 3-16 3-16 3-16 3-17 3-17 3-17 3-18 3-18 3-18 3-19 3-19
3-19 3-19 3-20 3-20 3-20 3-20 3-20 3-20 3-21 3-21 3-21 3-21 3-22
3-22 3-22 3-22 3-22 3-22 3-22 3-22 3-22 3-22 3-23 3-23 3-23 3-23
3-24 3-24 3-25 3-25 3-25 3-25 3-26 3-26 3-26 3-28 3-28 3-28 3-28
3-28 3-29 3-29 3-29 3-29 3-29 3-29
Table of contents
v
4062-XXX
Wiper Messages . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . .3-29 Clear Custom Status . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . .3-29 Best Speed . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .3-29 Exit Config Menu . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .3-30 Printer
overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . .3-31 Basic model . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . .3-31 Printer theory . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .3-32 Model T650 with
duplex, paper path, rolls, and sensors . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .3-32 Models T652 and T654 paper
path rolls and sensors . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .3-33 Functions of main components . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . .3-33 Media tray assembly . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .3-33 Rear media guide . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .3-33 Side guide . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .3-34 Wear strips . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .3-34 Media
tray assembly . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.3-34 Detection of media size . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. .3-35 Pick arm assembly . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . .3-35 Switch (media size) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . .3-36 Sensor (media empty) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . .3-36 Sensor (media low) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .3-37 Multi-purpose feeder (MPF) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .3-37 MPF feed roll . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .3-37 MPF pick solenoid . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .3-37 Sensor (MPF media empty) .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .3-38 Supported paper sizes, types,
and weights . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .3-38 Paper sizes supported by the
printer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .3-38 Registration . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .3-40 Sensor (input)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-40
Aligner assembly . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.3-40 Transfer . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .3-41 Transfer roll assembly . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . .3-41 Polygon printhead assembly . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .3-42 Oscillating printhead assembly .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .3-44 Fuser . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .3-45 Fuser
components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.3-45 Heat roll . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . .3-46 Pressure roll . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .3-46 Heater lamp . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .3-46 Thermal cutoff . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .3-46 Thermistor . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .3-46 Sensor (fuser
output) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .3-46 Sensor
(narrow media) . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-46
Fuser unit assembly (type 1 and type 2) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-47
Type 1 fuser unit assembly . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-47
Type 2 fuser unit assembly . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-47
Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .3-48 Sensor (standard bin full) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .3-48 Drive . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .3-48 Main drive motor
assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .3-48 Redrive motor
assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .3-48 Electrical
components and controller . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .3-49 Switch
(printer front door interlock) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .3-49 Main
cooling fan . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.3-50 Print cartridge cooling fan . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . .3-50 Duplex cooling fan . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . .3-50 LVPS card assembly . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . .3-50 HVPS card assembly . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . .3-50 System card assembly . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .3-51 Control . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .3-51
vi Service Manual
4062-XXX
Printhead control . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . Rotation of printhead motor . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Determination of printhead ready . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Printhead reference value . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fuser
control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . Fuser control method . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Fuser lamp on/off control . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuser warm-up . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Xerographic and print cartridge components . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . Charge . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exposure . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . Development . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Transfer . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . Cleaning . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . Auto density sensing . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . High Capacity Input Tray (HCIT) tray assembly
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . 250-sheet/550-sheet tray assembly . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Media size sensing . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Media level sensing . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Pick arm assembly . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch (media size) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sensor (media empty) . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sensor (media low) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sensor (pass-thru) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Media transport path . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model T650 paper path, rolls, and sensors . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Models
T652 and T654 paper path, rolls, and sensors . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . Functions of main
components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . Media tray assembly . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . Rear media guide . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . Side guide . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . Wear strips . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . Media tray
assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Detection of media size . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pick arm assembly . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch (media size) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sensor (media empty) . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sensor (media low) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Duplex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . Layout of media transport path . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . Model T650 duplex paper path . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . Models T652 and T654 duplex paper path . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Functions of main components . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sensor (duplex input) . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Duplex drive motor assembly . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Understanding jam numbers and locations . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 200
and 201 paper jams . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
202 and 203 paper jams . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 230 paper jam . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . Rear paper jams . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . Front paper jams . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 231-239 paper jams (optional external duplex unit) .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear paper jams . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front paper jams . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 241245 paper jams . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 250 paper jam . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . 260 paper jam . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 271279 paper jams . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 280 paper jam . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
3-51 3-51 3-51 3-51 3-51 3-51 3-51 3-52 3-52 3-53 3-53 3-54 3-55
3-56 3-57 3-58 3-59 3-59 3-60 3-60 3-62 3-62 3-62 3-62 3-64 3-64
3-65 3-65 3-65 3-65 3-65 3-65 3-66 3-66 3-66 3-67 3-67 3-67 3-68
3-68 3-68 3-69 3-69 3-69 3-70 3-71 3-71 3-72 3-73 3-73 3-74 3-75
3-75 3-75 3-76 3-77 3-78 3-78 3-79
Table of contents
vii
4062-XXX
281 paper jam . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . .3-80 282 paper jam . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .3-80 283 staple jam . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .3-81 Security Reset
Jumper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.3-83 Security Reset Jumper . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . .3-83
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .Repair information
4-1Handling ESD-sensitive parts . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . .4-1 Adjustments . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .4-2 Polygon and Oscillating
printhead mechanical registration adjustment . . . . . . . . . . .
. . . . . . . .4-2 Oscillating printhead assembly electronic
adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . .4-3 Alignment assembly adjustment . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .4-4 Fuser solenoid adjustment . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .4-6 Gap adjustment . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .4-6 Removals . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-7 Charge roll assembly removal (T650, T652, T654) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-7
Duplex assembly removal (T652, T654) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-8
Duplex cooling fan removal (T652, T654) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-9
Duplex drive motor assembly removal (T652, T654) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .4-10 Duplex
input sensor assembly removal (T652, T654) . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .4-11 Duplex guide
assembly, front removal (T652, T654) . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .4-12 Media turn guide
removal (T650, T652, T654) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .4-13 Fuser access door
assembly removal (T650, T652, T654) . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .4-14 Main cooling fan removal (T650,
T652, T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . .4-15 Fuser drive release linkage removal
(T650, T652, T654) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . .4-16 Fuser unit assembly removal (T650, T652, T654)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . .4-16 Fuser wiper cover assembly removal (T650, T652, T654) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-17 HVPS
card assembly removal (T650, T652, T654) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .4-18 Inner deflector
removal (T650, T652, T654) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .4-18 LCD screen bezel
removal (T650, T652, T654) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .4-19 Laser cover removal
(T650, T652, T654) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .4-20 Side cover, left
removal (T650) . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .4-21 Side cover,
left removal (T652 and T654) . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .4-22 Option drive
shaft removal (T650, T652, T654) . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .4-23 Main drive motor
assembly removal (T650, T652, T654) . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .4-24 Alignment assembly removal
(T650, T652, T654) . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . .4-25 Output cover assembly removal (T650,
T652, T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . .4-28 Media out actuator removal (T650, T652, T654) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . .4-28 Media support removal (T650, T652, T654) . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-29 Tray roller catch assembly removal (T650, T652, T654) . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .4-29 MPF cam
gear removal (T650, T652, T654) . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .4-30 MPF lift
plate assembly removal (T650, T652, T654) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .4-30 MPF media out
actuator removal (T650, T652, T654) . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .4-31 MPF pick roll assembly
removal (T650, T652, T654) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .4-31 MPF pick solenoid assembly
removal (T650, T652, T654) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . .4-32 MPF tray door assembly removal (T650, T652,
T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . .4-34 Operator panel latch assembly removal (T650, T652, T654)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-36
Operator panel door assembly removal (T650, T652, T654) . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .4-37 Operator panel
hinge assembly, left removal (T650, T652, T654) . . . . . . . . . .
. . . . . . . . . . . . . .4-38 Operator panel hinge assembly,
right removal (T650, T652, T654) . . . . . . . . . . . . . . . . .
. . . . . .4-40 Pick arm assembly removal (T650, T652, T654) . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. .4-42 Pick roll assembly removal (T650, T652, T654) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-44
Print cartridge cooling fan removal (T650, T652, T654) . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .4-44 Print
cartridge clamp assembly removal (T650, T652, T654) . . . . . . . .
. . . . . . . . . . . . . . . . . . . .4-45 Print cartridge ID
connector assembly removal (T650, T652, T654) . . . . . . . . . . .
. . . . . . . . . . .4-46 Printhead assembly removal (T650) . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . .4-47 Printhead assembly removal (T652, T654) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . .4-48 Connection access cover, rear removal (T650,
T652, T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-50 Connection bezel assembly, rear removal (T650) . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-50
viii Service Manual
4062-XXX
Connection bezel assembly, rear removal (T652, T654) . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 4-51 Door
assembly, rear removal (T650, T652, T654) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . 4-52 Duplex guide
assembly, rear removal (T652, T654) . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 4-52 Cover assembly, rear
lower removal (T650) . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 4-54 Cover assembly, rear lower
(T652, T654) . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 4-54 Redrive motor assembly removal
(T652, T654) . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 4-55 Side cover, right removal (T650) . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 4-57 Side cover, right removal (T652, T654)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 4-58 Sensor (duplex input) removal (T652,
T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . 4-58 Sensor (media level) removal (T650, T652,
T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . 4-59 Sensor (media out) removal (T650, T652, T654) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 4-59 Sensor (toner empty) removal (T650, T652, T654) . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-60
Sensor (input) removal (T650, T652, T654) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-60
Sensor shield assembly removal (T650, T652, T654) . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 4-61 Standard bin
actuator assembly removal (T650, T652, T654) . . . . . . . . . . .
. . . . . . . . . . . . . . . . 4-61 Sensor (standard bin exit)
removal (T650, T652, T654) . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 4-62 Sensor (toner density) removal (T650,
T652, T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 4-62 Switch (media size) assembly removal (T650,
T652, T654) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 4-62 LVPS card assembly removal (T650) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-64 LVPS card assembly removal (T652, T654) . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-66
Access door removal (T650, T652, T654) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-68
System card assembly removal (T650, T652, T654) . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 4-69 Transfer
roll assembly removal (T650, T652, T654) . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 4-71 Transfer roll
bracket assembly, left removal (T650, T652, T654) . . . . . . . . .
. . . . . . . . . . . . . . . 4-72 Transfer roll bracket assembly,
right removal (T650, T652, T654) . . . . . . . . . . . . . . . . .
. . . . . . 4-73 Transfer deflector removal (T650, T652, T654) . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . 4-73 Redrive assembly removal (T650, T652, T654) . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-74 Option removals . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 4-75 High capacity input tray (HCIT) . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 4-75 High capacity input tray (HCIT)
media tray assembly removal . . . . . . . . . . . . . . . . . . . .
. . . . . . 4-76 High capacity input tray (HCIT) tray cover, front
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-77 High capacity input tray (HCIT) cover, rear removal . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-79 High
capacity input tray (HCIT) cover, right removal . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . 4-81 High capacity
input tray (HCIT) cover, left removal . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 4-83 High capacity input
tray (HCIT) anti-tip latch assembly removal . . . . . . . . . . . .
. . . . . . . . . . . . 4-84 High capacity input tray (HCIT) drawer
slide assembly removal . . . . . . . . . . . . . . . . . . . . . .
. . 4-85 High capacity input tray (HCIT) tray lift drive motor
assembly removal . . . . . . . . . . . . . . . . . . 4-86 High
capacity input tray (HCIT) controller card assembly removal . . . .
. . . . . . . . . . . . . . . . . . 4-87 High capacity input tray
(HCIT) media size actuator assembly removal . . . . . . . . . . . .
. . . . . . 4-88 Sensor (HCIT tray raised HP) with cable assembly
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-90 Sensor (HCIT pass through) with cable removal . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-92 High
capacity input tray (HCIT) pick arm bracket assembly removal . . .
. . . . . . . . . . . . . . . . . 4-93 High capacity input tray
(HCIT) tray closed latch with spring removal . . . . . . . . . . .
. . . . . . . . 4-95 250-sheet option tray assembly . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 4-96 250-sheet media tray assembly removal . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 4-97 250-sheet pick arm bracket assembly removal . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 4-97 250-sheet media out actuator removal . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-99 Anti-tip latch assembly removal . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 4-99 250-sheet frame assembly removal . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-100 Sensor (pass through) with cable removal . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-101
250-sheet controller card assembly removal . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 4-101 Media
size actuator removal . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-102
Media tray catch spring removal . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-104
Tray roller catch assembly removal . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-104
550-sheet option tray assembly . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-105 550-sheet media tray assembly removal . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-106
550-sheet pick arm bracket assembly removal . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . 4-107 550-sheet
bellcrank recoil spring removal . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 4-108 Media out
actuator removal (models T652 and T654) . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 4-108
Table of contents
ix
4062-XXX
Anti-tip latch assembly removal . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-109 550-sheet frame assembly removal . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-109 Upper interface cable assembly removal . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-112 Lower interface cable assembly removal . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-112 Sensor (pass through) with cable removal . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-113
550-sheet controller card assembly removal . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .4-113 Media
size actuator removal . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-115
550-sheet option drive shaft with spring removal . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .4-116 Media
tray catch spring removal . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-117
Media tray roller catch assembly removal . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-117 SFP
stapler assembly rear door assembly removal . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .4-118 SFP stapler
assembly right cover removal . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .4-118 SFP stapler
assembly left cover removal . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .4-119 SFP stapler
assembly top cover removal . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .4-120 SFP stapler
assembly handle cover removal . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .4-121 SFP stapler assembly
LED sensor cover removal . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .4-122 SFP stapler assembly sensor
(finisher bin media present) removal . . . . . . . . . . . . . . .
. . . . . .4-123 SFP stapler assembly standard output bin LED and
LED clear lens removal . . . . . . . . . . . . .4-124 SFP stapler
assembly tamper drive belt removal . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .4-125 SFP stapler assembly
tamper drive motor assembly removal . . . . . . . . . . . . . . . .
. . . . . . . . . .4-126 SFP stapler assembly media stack flap and
media stack flap actuator removal . . . . . . . . . . .4-127 SFP
stapler assembly stapler unit assembly removal . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .4-128 Stapler/stacker
controller card assembly removal . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .4-129 SFP stapler assembly
paddle drive motor assembly removal . . . . . . . . . . . . . . . .
. . . . . . . . . .4-130 SFP stapler assembly sensor (media stack)
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . .4-131 SFP stapler assembly sensor (paddle HP) removal . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-132
SFP stapler assembly sensor (stapler access door interlock) removal
. . . . . . . . . . . . . . . . . .4-133 SFP stapler assembly
sensor (tamper HP left and right) removal . . . . . . . . . . . . .
. . . . . . . . . .4-134 SFP stapler assembly sensor (bin full
send) removal . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . .4-135 SFP stapler assembly sensor (bin full receive)
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-136 SFP stapler assembly sensor (media in stapler) removal . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .4-136 SFP
stapler assembly sensor (deflector HP) removal . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .4-137 High capacity
stacker rear door assembly removal . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .4-138 High capacity stacker
right cover removal . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .4-139 High capacity stacker left
cover removal . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .4-140 High capacity stacker media
output bin assembly removal . . . . . . . . . . . . . . . . . . . .
. . . . . . . .4-141 High capacity stacker controller card cover
panel removal . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-142 High capacity stacker switch (media bin HP) removal . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .4-143 High
capacity stacker sensor (media bin full) assembly removal . . . . .
. . . . . . . . . . . . . . . . . .4-144 High capacity stacker
sensor (media bin full) bracket assembly removal . . . . . . . . .
. . . . . . .4-144 High capacity stacker controller card assembly
(upper and lower) removal . . . . . . . . . . . . . .4-145 High
capacity stacker right frame removal . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .4-146 High
capacity stacker left frame removal . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .4-147 High
capacity stacker upper deflector gate removal . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .4-147 High capacity
stacker sensor (pass through) removal . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .4-149 High capacity stacker left
mounting bracket removal . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .4-150 High capacity stacker sensor
(deflector gate HP) removal . . . . . . . . . . . . . . . . . . . .
. . . . . . . .4-151 5-bin mailbox rear door assembly removal . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . .4-152 5-bin mailbox left outer cover removal . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . .4-153 5-bin mailbox left inner cover removal . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. .4-153 5-bin mailbox right outer cover removal . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-154 5-bin mailbox right inner cover removal . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-155 5-bin mailbox top cover removal . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. .4-156 5-bin mailbox media bin full actuator removal . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.4-157 5-bin mailbox sensor (pass through) removal . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-158
5-bin mailbox sensor (media bin empty) removal . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .4-159 5-bin
mailbox controller card assembly removal . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .4-160 5-bin mailbox
static brush mylar assembly removal . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .4-161 5-bin mailbox media bin
fifth deflector removal . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .4-162
x Service Manual
4062-XXX
5-bin mailbox media bin first through fourth deflector removal .
. . . . . . . . . . . . . . . . . . . . . . . 5-bin mailbox media
bin extension assembly removal . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 5-bin mailbox deflector gate solenoid
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 5-bin mailbox transport solenoid removal . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. 5-bin mailbox sensor (deflector gate HP) removal . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . Output
expander rear door assembly removal . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . Output expander left
outer cover removal . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . Output expander left inner cover
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . Output expander right outer cover removal . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Output expander right inner cover removal . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Output expander media bin latch (left and right) removal . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . Output expander
media output bin assembly removal . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . Output expander media bin full actuator
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . Output expander sensors (media bin full) assembly removal
. . . . . . . . . . . . . . . . . . . . . . . . . Output expander
sensor (media bin full) bracket assembly removal . . . . . . . . .
. . . . . . . . . . . Output expander controller card cover panel
removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. Output expander controller card removal . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Output
expander sensor (pass through) removal . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . Output expander deflector
gate removal . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . Output expander sensor (deflector
gate HP) removal . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . Installing / Removing the RFID UHF option . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
4-163 4-164 4-164 4-166 4-167 4-170 4-170 4-171 4-171 4-172
4-172 4-173 4-173 4-174 4-175 4-175 4-177 4-178 4-179 4-180
4-181
Connector locations and connections . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5-1Connections . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 5-1
Preventive maintenance . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . 6-1Safety inspection guide . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . Lubrication specifications . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . Individual
maintenance part expected life . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Scheduled
maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance kit . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 6-1 6-1 6-1 6-2 6-2
Parts catalog
...........................................................................
7-1
How to use this parts catalog . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 7-1 Assembly 1: Covers . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 7-2 Assembly 2: Operator panel . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 7-4 Assembly 3: Drive motor
assemblies and duplex . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 7-6 Assembly 4: Media path and
ducts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 7-8 Assembly 5:
Printhead, charge, and transfer . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 7-10 Assembly 6: Pick
arm assembly, trays, and MPF . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . 7-12 Assembly 7: LVPS,
fuser and electrical cables 1 . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . 7-14 Assembly 8: HVPS, system
card, and electrical cables 2 . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . 7-16 Assembly 9: 250 Sheet option tray
assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 7-18 Assembly 10: 550 Sheet option tray
assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 7-20 Assembly 11: HCIT Sheet option tray
assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . 7-22 Assembly 12: SFP stapler assembly #1 . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 7-24 Assembly 13: SFP stapler assembly #2 .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 7-26 Assembly 14: SFP stapler assembly #3 .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . 7-28 Assembly 15: SFP stapler assembly #4 .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 7-30 Assembly 16: 5-bin mailbox #1 . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 7-32 Assembly 17: 5-bin mailbox
#2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . 7-34 Assembly 18:
High capacity stacker . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . 7-36 Assembly
19: Output expander. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-38
Assembly 20: Envelope feeder and external duplex . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-40
Assembly 21: RFID UHF Option assembly. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-42
Assembly 22: Miscellaneous . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . 7-43 Assembly 23: Power cords . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . 7-45 Assembly 24: Universal trays and accessories . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . 7-46
Table of contents
xi
4062-XXX
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. .I-1 Part number index. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.I-5
xii Service Manual
4062-XXX
Notices and safety informationThe following laser notice labels
may be affixed to this printer.
Laser noticeThe printer is certified in the U.S. to conform to
the requirements of DHHS 21 CFR Subchapter J for Class I (1) laser
products, and elsewhere is certified as a Class I laser product
conforming to the requirements of IEC 60825-1. Class I laser
products are not considered to be hazardous. The printer contains
internally a Class IIIb (3b) laser that is nominally a 5 milliwatt
gallium arsenide laser operating in the wavelength region of
770-795 nanometers. The laser system and printer are designed so
there is never any human access to laser radiation above a Class I
level during normal operation, user maintenance, or prescribed
service condition.
LaserDer Drucker erfllt gem amtlicher Besttigung der USA die
Anforderungen der Bestimmung DHHS (Department of Health and Human
Services) 21 CFR Teil J fr Laserprodukte der Klasse I (1). In
anderen Lndern gilt der Drucker als Laserprodukt der Klasse I, der
die Anforderungen der IEC (International Electrotechnical
Commission) 60825-1 gem amtlicher Besttigung erfllt. Laserprodukte
der Klasse I gelten als unschdlich. Im Inneren des Druckers
befindet sich ein Laser der Klasse IIIb (3b), bei dem es sich um
einen Galliumarsenlaser mit 5 Milliwatt handelt, der Wellen der
Lnge 770-795 Nanometer ausstrahlt. Das Lasersystem und der Drucker
sind so konzipiert, da im Normalbetrieb, bei der Wartung durch den
Benutzer oder bei ordnungsgemer Wartung durch den Kundendienst
Laserbestrahlung, die Klasse I bersteigen wrde, Menschen
keinesfalls erreicht.
Avis relatif lutilisation de laserPour les Etats-Unis : cette
imprimante est certifie conforme aux provisions DHHS 21 CFR alina J
concernant les produits laser de Classe I (1). Pour les autres pays
: cette imprimante rpond aux normes IEC 60825-1 relatives aux
produits laser de Classe I. Les produits laser de Classe I sont
considrs comme des produits non dangereux. Cette imprimante est
quipe dun laser de Classe IIIb (3b) (arsniure de gallium dune
puissance nominale de 5 milliwatts) mettant sur des longueurs donde
comprises entre 770 et 795 nanomtres. Limprimante et son systme
laser sont conus pour impossible, dans des conditions normales
dutilisation, dentretien par lutilisateur ou de rvision,
lexposition des rayonnements laser suprieurs des rayonnements de
Classe I .
Avvertenze sui prodotti laserQuesta stampante certificata negli
Stati Uniti per essere conforme ai requisiti del DHHS 21 CFR
Sottocapitolo J per i prodotti laser di classe 1 ed certificata
negli altri Paesi come prodotto laser di classe 1 conforme ai
requisiti della norma CEI 60825-1. I prodotti laser di classe non
sono considerati pericolosi. La stampante contiene al suo interno
un laser di classe IIIb (3b) allarseniuro di gallio della potenza
di 5mW che opera sulla lunghezza donda compresa tra 770 e 795
nanometri. Il sistema laser e la stampante sono stati progettati in
modo tale che le persone a contatto con la stampante, durante il
normale funzionamento, le operazioni di servizio o quelle di
assistenza tecnica, non ricevano radiazioni laser superiori al
livello della classe 1.
Notices and safety information
xiii
4062-XXX
Avisos sobre el lserSe certifica que, en los EE.UU., esta
impresora cumple los requisitos para los productos lser de Clase I
(1) establecidos en el subcaptulo J de la norma CFR 21 del DHHS
(Departamento de Sanidad y Servicios) y, en los dems pases, rene
todas las condiciones expuestas en la norma IEC 60825-1 para
productos lser de Clase I (1). Los productos lser de Clase I no se
consideran peligrosos. La impresora contiene en su interior un lser
de Clase IIIb (3b) de arseniuro de galio de funcionamiento nominal
a 5 milivatios en una longitud de onda de 770 a 795 nanmetros. El
sistema lser y la impresora estn diseados de forma que ninguna
persona pueda verse afectada por ningn tipo de radiacin lser
superior al nivel de la Clase I durante su uso normal, el
mantenimiento realizado por el usuario o cualquier otra situacin de
servicio tcnico.
Declarao sobre LaserA impressora est certificada nos E.U.A. em
conformidade com os requisitos da regulamentao DHHS 21 CFR
Subcaptulo J para a Classe I (1) de produtos laser. Em outros
locais, est certificada como um produto laser da Classe I, em
conformidade com os requisitos da norma IEC 60825-1. Os produtos
laser da Classe I no so considerados perigosos. Internamente, a
impressora contm um produto laser da Classe IIIb (3b), designado
laser de arseneto de potssio, de 5 milliwatts ,operando numa faixa
de comprimento de onda entre 770 e 795 nanmetros. O sistema e a
impressora laser foram concebidos de forma a nunca existir qualquer
possiblidade de acesso humano a radiao laser superior a um nvel de
Classe I durante a operao normal, a manuteno feita pelo utilizador
ou condies de assistncia prescritas.
LaserinformatieDe printer voldoet aan de eisen die gesteld
worden aan een laserprodukt van klasse I. Voor de Verenigde Staten
zijn deze eisen vastgelegd in DHHS 21 CFR Subchapter J, voor andere
landen in IEC 60825-1. Laserprodukten van klasse I worden niet als
ongevaarlijk aangemerkt. De printer is voorzien van een laser van
klasse IIIb (3b), dat wil zeggen een gallium arsenide-laser van 5
milliwatt met een golflengte van 770-795 nanometer. Het
lasergedeelte en de printer zijn zo ontworpen dat bij normaal
gebruik, bij onderhoud of reparatie conform de voorschriften, nooit
blootstelling mogelijk is aan laserstraling boven een niveau zoals
voorgeschreven is voor klasse 1.
LasermeddelelsePrinteren er godkendt som et Klasse
I-laserprodukt, i overenstemmelse med kravene i IEC 60825-1. Klasse
I-laserprodukter betragtes ikke som farlige. Printeren indeholder
internt en Klasse IIIB (3b)-laser, der nominelt er en 5 milliwatt
galliumarsenid laser, som arbejder p blgelngdeomrdet 770-795
nanometer. Lasersystemet og printeren er udformet sledes, at
mennesker aldrig udsttes for en laserstrling over Klasse I-niveau
ved normal drift, brugervedligeholdelse eller obligatoriske
servicebetingelser.
xiv Service Manual
4062-XXX
LaserilmoitusTm tulostin on sertifioitu Yhdysvalloissa DHHS 21
CFR Subchapter J -standardin mukaiseksi luokan I (1)
lasertuotteeksi ja muualla IEC 60825-1 -standardin mukaiseksi
luokan I lasertuotteeksi. Luokan I lasertuotteita ei pidet
haitallisina. Tulostimen sisll on luokan IIIb (3b) laser, joka on
nimellisteholtaan 5 mW:n galliumarsenidilaser ja toimii 770 - 795
nanometrin aallonpituuksilla. Laserjrjestelm ja tulostin ovat
rakenteeltaan sellaisia, ett kyttj ei joudu alttiiksi luokkaa 1
suuremmalle steilylle normaalin kytn, yllpidon tai huollon
aikana.
Huomautus laserlaitteestaTm kirjoitin on Yhdysvalloissa luokan I
(1) laserlaitteiden DHHS 21 CFR Subchapter J -mrityksen mukainen ja
muualla luokan I laserlaitteiden IEC 60825-1 -mrityksen mukainen.
Luokan I laserlaitteiden ei katsota olevan vaarallisia kyttjlle.
Kirjoittimessa on sisinen luokan IIIb (3b) 5 milliwatin
galliumarsenidilaser, joka toimii aaltoalueella 770 - 795
nanometri. Laserjrjestelm ja kirjoitin on suunniteltu siten, ett
kyttj ei altistu luokan I mrityksi voimakkaammalle steilylle
kirjoittimen normaalin toiminnan, kyttjn tekemien huoltotoimien tai
muiden huoltotoimien yhteydess. VARO! Avattaessa ja suojalukitus
ohitettaessa olet alttiina nkymttmlle lasersteilylle. l katso
steeseen. VARNING! Osynlig laserstrlning nr denna del r ppnad och
sprren r urkopplad. Betrakta ej strlen.
Laser-notisDenna skrivare r i USA certifierad att motsvara
kraven i DHHS 21 CFR, underparagraf J fr laserprodukter av Klass I
(1). I andra lnder uppfyller skrivaren kraven fr laserprodukter av
Klass I enligt kraven i IEC 60825-1. Laserprodukter i Klass I anses
ej hlsovdliga. Skrivaren har en inbyggd laser av Klass IIIb (3b)
som bestr av en laserenhet av gallium-arsenid p 5 milliwatt som
arbetar i vglngdsomrdet 770-795 nanometer. Lasersystemet och
skrivaren r utformade s att det aldrig finns risk fr att ngon
person utstts fr laserstrlning ver Klass I-niv vid normal
anvndning, underhll som utfrs av anvndaren eller annan freskriven
servicetgrd.
Laser-meldingSkriveren er godkjent i USA etter kravene i DHHS 21
CFR, underkapittel J, for klasse I (1) laserprodukter, og er i
andre land godkjent som et Klasse I-laserprodukt i samsvar med
kravene i IEC 60825-1. Klasse I-laserprodukter er ikke betrakte som
farlige. Skriveren inneholder internt en klasse IIIb (3b)-laser,
som bestr av en gallium-arsenlaserenhet som avgir strling i
blgelengdeomrdet 770-795 nanometer. Lasersystemet og skriveren er
utformet slik at personer aldri utsettes for laserstrling ut over
klasse I-niv under vanlig bruk, vedlikehold som utfres av brukeren,
eller foreskrevne serviceoperasjoner.
Notices and safety information
xv
4062-XXX
Avs sobre el LserSegons ha estat certificat als Estats Units,
aquesta impressora compleix els requisits de DHHS 21 CFR, apartat
J, pels productes lser de classe I (1), i segons ha estat
certificat en altres llocs, s un producte lser de classe I que
compleix els requisits dIEC 60825-1. Els productes lser de classe I
no es consideren perillosos. Aquesta impressora cont un lser de
classe IIIb (3b) darsenir de gal.li, nominalment de 5 mil.liwats, i
funciona a la regi de longitud dona de 770-795 nanmetres. El
sistema lser i la impressora han sigut concebuts de manera que mai
hi hagi exposici a la radiaci lser per sobre dun nivell de classe I
durant una operaci normal, durant les tasques de manteniment
dusuari ni durant els serveis que satisfacin les condicions
prescrites.
xvi Service Manual
4062-XXX
Notices and safety information
xvii
4062-XXX
xviii Service Manual
4062-XXX
Lithium warningCAUTION This product contains a lithium battery.
THERE IS A RISK OF EXPLOSION IF THE BATTERY IS REPLACED BY AN
INCORRECT TYPE. Discard used batteries according to the battery
manufacturers instructions and local regulations.
Safety information The safety of this product is based on
testing and approvals of the original design and specific
components. The manufacturer is not responsible for safety in the
event of use of unauthorized replacement parts. The maintenance
information for this product has been prepared for use by a
professional service person and is not intended to be used by
others. There may be an increased risk of electric shock and
personal injury during disassembly and servicing of this product.
Professional service personnel should understand this and take
necessary precautions. CAUTION: When you see this symbol, there is
a danger from hazardous voltage in the area of the product where
you are working. Unplug the product before you begin, or use
caution if the product must receive power in order to perform the
task.
Consignes de scurit La scurit de ce produit repose sur des tests
et des agrations portant sur sa conception d'origine et sur des
composants particuliers. Le fabricant n'assume aucune responsabilit
concernant la scurit en cas d'utilisation de pices de rechange non
agres. Les consignes d'entretien et de rparation de ce produit
s'adressent uniquement un personnel de maintenance qualifi. Le
dmontage et l'entretien de ce produit pouvant prsenter certains
risques lectriques, le personnel d'entretien qualifi devra prendre
toutes les prcautions ncessaires. ATTENTION : Ce symbole indique la
prsence d'une tension dangereuse dans la partie du produit sur
laquelle vous travaillez. Dbranchez le produit avant de commencer
ou faites preuve de vigilance si l'excution de la tche exige que le
produit reste sous tension.
Norme di sicurezza La sicurezza del prodotto si basa sui test e
sull'approvazione del progetto originale e dei componenti
specifici. Il produttore non responsabile per la sicurezza in caso
di sostituzione non autorizzata delle parti. Le informazioni
riguardanti la manutenzione di questo prodotto sono indirizzate
soltanto al personale di assistenza autorizzato. Durante lo
smontaggio e la manutenzione di questo prodotto, il rischio di
subire scosse elettriche e danni alla persona pi elevato. Il
personale di assistenza autorizzato deve, quindi, adottare le
precauzioni necessarie. ATTENZIONE: Questo simbolo indica la
presenza di tensione pericolosa nell'area del prodotto. Scollegare
il prodotto prima di iniziare o usare cautela se il prodotto deve
essere alimentato per eseguire l'intervento.
Safety information
xix
4062-XXX
Sicherheitshinweise Die Sicherheit dieses Produkts basiert auf
Tests und Zulassungen des ursprnglichen Modells und bestimmter
Bauteile. Bei Verwendung nicht genehmigter Ersatzteile wird vom
Hersteller keine Verantwortung oder Haftung fr die Sicherheit
bernommen. Die Wartungsinformationen fr dieses Produkt sind
ausschlielich fr die Verwendung durch einen Wartungsfachmann
bestimmt. Whrend des Auseinandernehmens und der Wartung des Gerts
besteht ein zustzliches Risiko eines elektrischen Schlags und
krperlicher Verletzung. Das zustndige Fachpersonal sollte
entsprechende Vorsichtsmanahmen treffen. ACHTUNG: Dieses Symbol
weist auf eine gefhrliche elektrische Spannung hin, die in diesem
Bereich des Produkts auftreten kann. Ziehen Sie vor den Arbeiten am
Gert den Netzstecker des Gerts, bzw. arbeiten Sie mit groer
Vorsicht, wenn das Produkt fr die Ausfhrung der Arbeiten an den
Strom angeschlossen sein mu.
Pautas de Seguridad La seguridad de este producto se basa en
pruebas y aprobaciones del diseo original y componentes especficos.
El fabricante no es responsable de la seguridad en caso de uso de
piezas de repuesto no autorizadas. La informacin sobre el
mantenimiento de este producto est dirigida exclusivamente al
personal cualificado de mantenimiento. Existe mayor riesgo de
descarga elctrica y de daos personales durante el desmontaje y la
reparacin de la mquina. El personal cualificado debe ser consciente
de este peligro y tomar las precauciones necesarias. PRECAUCIN:
este smbolo indica que el voltaje de la parte del equipo con la que
est trabajando es peligroso. Antes de empezar, desenchufe el equipo
o tenga cuidado si, para trabajar con l, debe conectarlo.
Informaes de Segurana A segurana deste produto baseia-se em
testes e aprovaes do modelo original e de componentes especficos. O
fabricante no responsvel pela segunrana, no caso de uso de peas de
substituio no autorizadas. As informaes de segurana relativas a
este produto destinam-se a profissionais destes servios e no devem
ser utilizadas por outras pessoas. Risco de choques elctricos e
ferimentos graves durante a desmontagem e manuteno deste produto.
Os profissionais destes servios devem estar avisados deste facto e
tomar os cuidados necessrios. CUIDADO: Quando vir este smbolo,
existe a possvel presena de uma potencial tenso perigosa na zona do
produto em que est a trabalhar. Antes de comear, desligue o produto
da tomada elctrica ou seja cuidadoso caso o produto tenha de estar
ligado corrente elctrica para realizar a tarefa necessria.
xx Service Manual
4062-XXX
Informaci de Seguretat La seguretat d'aquest producte es basa en
l'avaluaci i aprovaci del disseny original i els
componentsespecfics. El fabricant no es fa responsable de les
qestions de seguretat si s'utilitzen peces de recanvi no
autoritzades. La informaci pel manteniment daquest producte est
orientada exclusivament a professionals i no est destinada a ning
que no ho sigui. El risc de xoc elctric i de danys personals pot
augmentar durant el procs de desmuntatge i de servei daquest
producte. El personal professional ha destar-ne assabentat i
prendre les mesures convenients. PRECAUCI: aquest smbol indica que
el voltatge de la part de l'equip amb la qual esteu treballant s
perills. Abans de comenar, desendolleu l'equip o extremeu les
precaucions si, per treballar amb l'equip, l'heu de connectar.
Safety information
xxi
4062-XXX
PrefaceThis manual contains maintenance procedures for service
personnel. It is divided into the following chapters:
1. General information contains a general description of the
printer and the maintenance approach used to 2. 3. 4. 5. 6.
7.repair it. Special tools and test equipment, as well as general
environmental and safety instructions, are discussed. Diagnostic
information contains an error indicator table, symptom tables, and
service checks used to isolate failing field replaceable units
(FRUs). Diagnostic aids contains tests and checks used to locate or
repeat symptoms of printer problems. Repair information provides
instructions for making printer adjustments and removing and
installing FRUs. Connector locations uses illustrations to identify
the connector locations and test points on the printer. Preventive
maintenance contains the lubric