2014 Clean Snowmobile Challenge Northern Illinois University
Feb 23, 2016
2014 Clean Snowmobile Challenge
Northern Illinois University
NIU CSC
2011 Polaris Rush 600What we set out to improve:• Exhaust Emissions• 2-Stroke Engine Capabilities• Fuel Efficiency• Ability to run on Isobutanol
blend
Snowmobile Selection
2/27/2014
NIU CSC
Rush Performance Enhancements
Engine-Cooling-Drivetrain
• Dynojet Power Commander V
• Electric Start
• O2 sensor/ Air fuel ratio gauge.
Handling
• Woody’s Trail Blazer Carbides
• Woody’s Carbide Studs
• Hayes Trail Trac 1.0
2/27/2014
NIU CSC
• Allows for fuel map adjustment, while retaining factory ECU calibration
• Mode Switch can be added to switch between two fuel maps. Ex: Economy or Performance mode
• Easily returned to factory settings
Power Commander V Fuel Injection Module
2/27/2014
NIU CSC
Dynamometer Testing
Peak Power: 100.3 Hp @ 6251 RPMPeak Torque: 84.76 Ft Lbs
Factory Advertised Specs: 120 Hp 2/27/2014
NIU CSC
HandlingWoody’s Carbides
• Reduces darting
• Allows for more steering grip in turns
Woody’s Carbides Studs
• Improves traction in most icy/snow conditions
• Decreases skidding while braking
2/27/2014
NIU CSC
Hayes Trail Trac 1.0
• ABS style braking system
• Reduces skidding while braking
• Helps keep the rear end in a straight line while braking
Handling Cont.
2/27/2014
NIU CSC
HAYES Trail Track Testing
Conditions: little snow cover with layer of ice underneath. Unpicked trackTests measured both stopping distance and timeTests were also done with picks installed.
Post-Install Test
Stop Distance (feet) Run 1 Run 2 Run 310 MPH 8.2 7.1 8.830 MPH 46.6 43.4 36.545 MPH 92 96 9750 MPH 126.5 117
Deceleration Time (Sec)Run 1 Run 2 Run 310 MPH 1.3 1.2 1.630 MPH 2.9 3.3 3.545 MPH 3.7 4.2 4.550 MPH 4.5 4.8
Pre-Install Test
Stop Distance (feet) Run 1 Run 2 Run 310 MPH 9.7 8.7 1030 MPH 51 55 58.545 MPH 97 106 127.550 MPH 135 135
Deceleration Time (Sec)Run 1 Run 2 Run 310 MPH 1.5 1.2 130 MPH 2.8 1.8 2.845 MPH 3.6 3.6 3.250 MPH 4.2 4.2
2/27/2014
NIU CSC
Sound Emissions Sound test was performed using SAE J192 Standard test
The machine accelerates for 150 feet after 150 feet of constant speed
Sound measurement is taken 50 feet perpendicular to the path of travel.
Sound levels were found to be 76.9 dB, also a full throttle full speed pass performed, which produced a 81 dB sound reading
Conditions of the test dayTemperature: 19 Degrees FahrenheitWind: 0 M.P.H.Pressure: 30.23 inHg 2/27/2014
NIU CSC
Isobutanol Conversion
Power Commander V• Allows for complete adjustment of fuel
table off of AFR readings
O2 Sensor• Reads air-fuel ratio (AFR)
Dynojet Autotune• Allows for AFR data logging while the
vehicle is being ridden (only when enabled)
2/27/2014
NIU CSC
Emissions Testing
%O2 %CO %CO2 %PPM Hc's PPM NO PPM NO2MODE 1 16.62 1.95 1.97 4469 0 0.5MODE 2 18.38 1.07 1.28 1783 0 2.5MODE 3 20.33 0.27 0.5 795 0 0MODE 4 16.07 0.53 3.4 2732 0 5MODE 5 19.27 0.83 0.72 2133 0 0
Emissions For Each Mode
Emissions measurements were taken using a Nova 5 Gas Analyzer.
Values are averages taken from the collection period. Engine was running 91 octane pump gasoline.
2/27/2014
NIU CSC
Dealer Benefits
• This sled offers many desirable features and performance levels compared to equally priced and equipped snowmobiles
• The current comparable model to our sled is a 2014 Polaris Rush 600 Pro-r
• The MSRP for the Polaris Rush 600 Pro-r is $10,799, our sled’s MSRP is $12,956
• The addition of these parts does not call for any additional maintenance, difficult installations and are readily available for any consumer as over the counter parts
2/27/2014
NIU CSC
Consumer Appeal
• The snowmobile offers both performance and efficient adjustable modes
• The 2-stroke motor is cheaper and easier to work on than 4-stroke motors
• The chassis is highly adjustable to meet many types of riders and riding styles
• Replacement parts are readily available over the counter
2/27/2014
NIU CSC
Questions?
2/27/2014