Transcript
PART ! State Price Quote Specification Vendor: RWC Group ~ Wcshingt.oo omce, er SupeMtendenl cr
~ PUBLIC INSTRUCTION TYPE C77-B1D AS 71 PASSENGER, 2021-2022 ELECTRIC
Use this document to bid both non-lift and lift buses for 61-n capacity.
ITEM STATE-SUPPORTED SPECIFICATIONS
Vendor must meet or exceed these specifications. Item bid shall be s ecified in column to ri ht.
VENDOR SPECIFICALLY IDENTIFY ITEM BID Price of items bid will establish the state cost.
Seating Capacity 71 passenger based upon an average center-to-center seat spacing of at least 27S.
Capacity w/o lift _7_1 ___________ _
Capacity w/lift _6_0+_1 ___________ _
Auxiliary Fans
Axle-Front
2 fans, 6" maximum, mounted to right and left windshield and service door.
9,000 lb. minimum.
Mfr. Bergstrom
Mfr. Meritor
Capacity _1_0'-,0_00 _____________ _
Axle-Rear 19,000 lb. minimum. Mfr. Dana Spicer
Capacity _2_3'-,o_oo _____________ _
Axle Oil Seals Front and rear oil bath. Mfr. Conmet Preset
Axle Ratio
Back-up Lights
Must comply with power and gradeability formula. Refer to Washington State School Bus Specifications Manual.
All required backup lights to be LED (Light Emitting Diode}. Refer to Washington State School Bus Specification's Manual.
Mfr. Dana Spicer
Capacity _6_.8_3 _____________ _
Round: ~ Diameter _7_1n_c_h _______ _
Other: D Square inches
Battery(ies} Low Voltage
1200 CCA 12 volt minimum to be mounted in body battery compartment w/o lift. 1400 CCA 12 volt minimum to be mounted in body battery com artment w/lift.
Number of batteries _2 ____ _
CCA _2_30_0 ____ _
Battery(ies) Propulsion
Battery propulsion must meet a minimum of 130 kWh. Number of batteries _6 ____ _
kWh 210
FORM SPI 1394-5 {Rev. 7 / 21) Part I- Page 1
PART I (cont.)
State Price Quote Specification Vendor: RWC Group
TYPE C77-BID AS 71 PASSENGER, ELECTRIC
Use this document to bid both non-lift and lift buses for 61-77 capacity.
ST ATE-SUPPORTED SPECIFICATIONS VENDOR SPECIFICALLY IDENTIFY ITEM BID Vendor must meet or exceed these specifications. ITEM Price of items bid will establish the state cost
Item bid shall be s ecified in column to ri ht. Battery Battery storage tray must be large enough to accommodate D Swing out [iJ Roll out Com artment batteries as s ecified in chassis section.
Disc Front [iJ Rear [iJ A ir: Drum or Disc. Refer to Washington State School Bus
Drum Front D Rear D Brakes Specifications Manual.
Size Front 22.5 Rear 22.5
~ Air D Folding ~ Split, Outward opening D Electric Door, Service Power operated. D Other
Front B.T.U. _;.5_0.:....0______ _____ _
D Other
00 _
Center B.T.U. _ _ ,ooo __ _ 90'--___ _______ Minimum of 3 heaters; 1 front. 1 center, 1 rear. Shutoff valves at Heaters Rear B.T.U. 20,000 (convection-dispersed throughout)
Total B.T.U. 160,000
Hood
engine for all heaters. Two-speed motors.
[iJ Fiberglass D Metal
LED (Light Emitting Diode). Includes Clearance Lights, Stop
TIit.
Check if as specified [iJ Lights- T, Tail Lights, Turn Signals, Eight-Light System, and DomeLights If not, explain--------------Light System.
Engine Mfr. _D_a_na ____________ _
Model TM4 Sumo Motor 190 H.P. minimum.
Net torque 2355 Nm @ 1000 R.P.M.
Net H.P. 335 @ 1000 R.P.M.
Mfr. Adayo AM/FM/PA radio with 2 interior and 1 exterior speakers. P.A. System Model No. HA 1102D623A
FORM SPI 1394-5 (Rev. 7 /21) Part I-Page 2
PART I (cont.) State Price Quote Specification Vendor: RWC Group
TYPE C77-B1D AS 71 PASSENGER, ELECTRIC
Use this document to bid both non-lift and lrft buses for 61-77 capacity.
STATE-SUPPORTED SPECIFICATIONS VENDOR SPECIFICALLY IDENTIFY ITEM BID ITEM Vendor must meet or exceed these specifications. Price of items bid will establish the state cost. Item bid shall be s ecified in column to ri ht.
Inside measurement from rear of stepwell to appropriate point at rear of passenger
To permit specified passenger capacity based on an average seating area: w/o lift 355 w/lift _3_55 __ Seat Spacing
center-to-center seat spacing of at least 27.5n. Mfg. 's CIC seat measurement of vehicle (inches): w/o lift 27 w/lift _2_7 __
Steering Wheel Tilt and telescoping column. Check if as specified Ii] Step Tread Mfr. Koroseal
Mfr. Continental
Tires
Studded or pebbled top tread covering.
Size 11R22.5
Load range H
Toolbox
6 first quality, radial ply. No low profile tires.
Size (cubic feet) 2.88 Exterior, manufacturer standard. Mfr. ICOM Two-way
45-watt, VHF, mil. spec. Communications Model No. F-5011
Size _2_.2._s _______________ _ Wheels 6 to be compatible with tire size.
Rim width 8.25
SPECIAL NEEDS REQUIREMENTS-CHASSIS ANO BODY Mfr. Braun Gen2 Wheelchair Must meet state specification. Platform shall be a minimum of 32»
Lift- Installed X 52". Model No. NL919F1B
Wheelchair/ Mfr. Q-Straint Occupant Tie Must meet state specification. down System- Model No. Q-8100-A1-SC Installed
FORM SPI 1394-5 (Rev. 7/ 21} Part I- Page 3
PART I (cont.) State Price Quote Specification Vendor: RWC Group
TYPE C77-B1D AS 71 PASSENGER, ELECTRIC
Use this document to bid both non-lift and lift buses for 61-77 capacity.
ST ATE-SUPPORTED SPECIFICATIONS VENDOR SPECIFICALLY IDENTIFY ITEM BID Vendor must meet or exceed these specifications. ITEM
Price of items bid will establish the state cost. Item bid shall be specified in column to right.
ADDITIONAL REQUIREMENTS-CHASSIS AND BODY Legible copy of manufacturer's Line Setting Ticket will be
Line Setting Ticket delivered with each vendor's packet at the time of delivery of the Check if as specified ~ bus. One copy of the chassis manufacturer's owner's/operator's Owner's/Operator's handbook or manual will be furnished with each bus at time of Check if as specified ~ Handbook delive . A complete set of chassis, engine, transmission, and body repair manuals, including wiring diagram for all components, will be Repair Manuals Check if as specified ~ made available at time of delivery, with instructions available on accessin re air materials. Cleaning and service by vendor prior to delivery will include:
• Chassis lubrication. • Check fluid levels: verify all are at recommended full levels. • Cooling system protected at -20°F.
Service and Cleaning Check if as specified ~ • Interior and exterior will be clean (including glass). • All systems (electric, air, hydraulic, mechanical and manual)
be inspected to ensure proper operation at time of delivery. • All components and accessories will be installed and
o erational at time of delive .
A complete copy of all warranty agreements will be furnished at Warranty Check if as specified ~ time of delivery.
FORM SPI 1394-5 (Rev. 7/21) Part I- Page 4
I
STUDEITT TRANSPORT A TlON Old Capitol Buiding Washington Qtr,ee cl~-cl
POB0X47200 PUBLIC INSTRUCTION Olympia. WA 98504-7200
(360) 725-6120 TIY (360) 664-3631 2021-2022
VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE en- BID AS 71 PASSENGER ELECTRIC
VENDOR'S COMPANY NAME RWC Group
ADDRESS
600 North 75th Avenue Phoenix, AZ 85043
REPRESENTATIVE'S NAME I TELEPHQl'{E NUMBER Tom Hartman 602-377-4401
Estimated delivery date to school district from time purchase order is received: ___ _
12 Months
Firm where engine and chassis can be serviced or repaired and parts obtained: _ _ _
Any IC or International Dealer
Firm where body can be serviced or repaired and parts obtained: -------
RWC Group (4 locations in WA)
MAKE IC Corporation MODEL
PB10EOO
YEAR
2023
Warranty: BODY
Years _3 __ Inside measurement from rear of Equipped seating capacity: Miles 36k stepwell to appropriate point at w/o lift .l1__ w/lift 60+1
rear of passenger seating area: Seat color: Gray w/o lift 355 w/lift 355 Overall vehide length (inches): Floor color: Black w/o lift 463.9 w/lift 463.9
CHASSIS MOTOR MANUFACTURER MAKE Torque: 2355 @ 1000 RPM Warranty: Years _5 __ Dana IC Corporation H.P.: 335 @ 1000 RPM Miles Unlirr
MOOEL YEAR MODEL YEAR C.l.D. or Liters: Wheel base: 276 PB10EOO 2023 TM4 Sumo 2021 Fuel e: Warranty: Years _5 __
12 Volt Propulsion Miles 100k Number batteries: _6 __ Battery type/grp: .n.._
Number batteries: _2 __ Total kWh: 210
TotalCCA: 2300
QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax).
Electric Bid-w/o lift$ 361 ,846 Electric Bid-w/lift $ 365,944
DATE
FORM SPI 1394-5 (Rev. 7/ 21)
----------------
PART II State Price Quote Specification Vendor: RWC Group
DISTRICT -SUPPORTED OPTIONS [!] C77 0 D84 - ELECTRIC
Use this document to bid both non..Jift and lift buses.
VENDOR SPECIFICALLY IDENTlFY ITEM BID Vendor must meet or exceed these specifications. ITEM Price of items bid will establish the district cost. Item bid shall be s ecified in column to ri ht
Activity Passenger Capacity _NJ_A ________ _ 2-passenger position seats with lap-shoulder belts in all passenger
Securement Cost$ ______________ _ positions. Seatin
Mfr. ProAir To cool passenger compartment as required in the Washington State Air Conditioning
School Bus Specifications manual. Cost $ 26,425
Type C: Cost$ _ln_c_lu_d_ed ___ _____ _ Anti-spray Device Rubber fender extenders.
Type D: Cost $ 272
Mfr. Ecco Back-up Alarm Must meet state specification.
Cost$ 123
Brakes Cost$ N/A Deduct$ N/A
Disc Cost $ AIR STD
4-wheel hydraulic disk brake.
Disc Deduct $ AIR SID Air, Drum or Disc. Refer to Washington State School Bus Brakes
Specifications manual. Drum Cost $ _N_IA __ _ Drum Deduct $ NIA
Color Cost$ 776
Door Locks
Exterior white roof.
Cost$ _7_18 _____________ _ Vandal lock system on all exterior doors.
Air Non-Air Suspension type, 6---way adjustable, with lumbar adjustment. Cloth Mfr. National Mfr. Magnum Driver's Seat panel covers.
Cost$ 350
Jomarr VT -6-E-NAF, or equal engine compartment fire suppression
Cost$ 225
Mfr. NIA Fire Suppression system of appropriate size to be installed according to manufacturer Cost$ ______________ _ System recommendation.
Floor Color Cost$ 419
Headlights
Nonstandard color.
Cost $ Standard
Headlights
Halogen.
L.E.D. Cost $NIA
FORM SPJ 1394-5 (Rev. 7 /21) Part II- Page 1
PART II (cont.) State Price Quote Specification Vendor: RWC Group
DISTRICT -SUPPORTED OPTIONS 0 C77 0 D84 - ELECTRIC
Use this document to bid both non-lift and lift buses.
VENDOR SPECIFICALLY IDENTIFY ITEM BID Vendor must meet or exceed these specifications. ITEM Price of items bid will establish the district cost.
Brand: Webasto Model: Scholastic Item bid shall be s edfied in column to ri ht
Auxiliary fuel-fired heating systems. Refer to Washington State water) Heater (Auxiliary
School Bus Specifications Manual, page 27. Cost$ 5,100
Driver compartment Cost$ _N_IA ____ _
Noise Reduction Engine compartment Cost $ _N..:...____ _ /A
Full acoustical headliner Cost $ Std
Driveline D Cost$~-----Cost$ _____ _
Exceeding minimum specifications.
Exhaust D Transmission D Cost$
Seat Belt Ready
Retarder Manufacturer's standard.
3-passenger position seat with securement belts. Seat
2 by 2 Cost$ ..;;2-'-7!..:., 1.::.20:....__ _________ _
Capacity _4_8 ____ ________ _
3 by 2 Cost$ ..:..N..:.../A __________ _ Identical, non-lift bus with lap-shoulder seat belt system installed in all Seating System Capacity _NI_A ______ ______ _
3 by 3 Cost$ _2..:.. oo -----
positions.
8,:...:..8..:....'------
Capacity 71
Left-side _N_/A _________ cubic feet.
Cost$..:..N..:../A--'--------------~ Right-side _1_6._4_5 _______ cubic feet. Storage Largest available for unit bid. Cost$ _1~,4_0_1 ____________ _
Push-thru _N_IA ________ cubic feet.
Cost$ N/A
Mfr. Ecco
Model No. _6_55..:...0:....__ __________ _
Compartments
Strobe Light Exterior roof mounted white strobe light. Cost$ 21 7
FORM SPI 1394-5 (Rev. 7 / 21) Part II- Page 2
PART II (cont.) State Price Quote Specification Vendor: RWC Group
DISTRICT -SUPPORTED OPTIONS [!] C77 0 D84 - ELECTRIC
Use this document to bid both non-lift and lift buses.
'
ITEM
Student Protection System-Installed
Suspension
Toolbox
Traction Device
Traction Device
Vehicle Securement S stem
Video Camera SystemsInstalled
Video Camera Systems-Stop Sign CameraInstalled
Warning Light Monitor
VENDOR SPECIFICALLY IDENTIFY ITEM BID Price of items bid will establish the district cost.
Mfr. _IC ______________ _
Model No. Leave no student behind
Cost $ Included
Front Cost$ NIA
Cost$ 50
Mfr. On Spot Chains
Cost$ 3,100
Rear Cost $ Included
Deduct$ 62
Capacity _NJ_A ____________ _
Cost$
Mfr. SBS Cost$ _1..:....,0_02 ___ _
Mfr. Seon
Model No. _T_H_4 ____________ _
How many cameras _3__
16 light monitoring system.
Cost$ 2,646
Stand Alone System Mfr. Seen
Model No. TH4 -----Cost$_2..:....,4_3_9 ____ _
How many cameras _1 _ _
Incandescent
Cost$ 191
Added to Interior System Mfr. Seon
Model No. _T_H_4 ___ _ Cost$ _6_94 _____ _
How many cameras _1 _
LED Lights
Cost$ 217
Vendor must meet or exceed these specifications. Item bid shall be s ecified in column to ri ht.
Electronic system to insure driver post-trip inspection of passenger compartment.
Air ride (Air brake system only).
Interior, manufacturer standard.
Automatic chains.
Sanders.
Must meet state specification.
Digital audio/video system for monitoring the passenger compartment with more than two cameras.
Must meet state specification.
FORM SPI 1394-5 (Rev. 7 /21) Part II- Page 3
PART II (cont.) State Price Quote Specification Vendor: RWC Group
DISTRICT ..SUPPORTED OPTIONS [!] C77 0 D84 - ELECTRIC
Use this document to bid both non-lift and lift buses.
ITEM
, Additional Wheelchair/Occup ant Tie-down S stem-Installed
Windows
Windows
Windows
Vendor must meet or exceed these specifications. Item bid shall be s ecified in column to ri ht.
Must meet state specification.
Laminated passenger-compartment side or rear glass.
Tinted.
Thermal pane, left of driver and service door.
Price of items bid will establish the district cost. Mfr. 0-Straint
Model No. Q8107-A1-L2
Cost per station $ 670
Side Cost $ _1_,0_95 ___________ _ RearCost$_1_47 ___________ _
Both Cost $ 1,242
Cost$ 547
Cost$ 555
FORM SPI 1394-5 (Rev. 7 / 21) Part II-Page 4
top related