Transcript
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
1
Magnetic Contactor
Selection guide
Tel: +86-577-62776000 Fax: +86-577-62776006
Contactor GLC1-F GLC1-D GCR1-F
Specifications
Products
Rated operationalcurrent A
Conventional thermal current thA
Maximum rated operationalvoltage V
Rated operationalpower AC3KW
Maximumoperatingpower AC1KW
Number of poles
ApplicationsStandard products, for categoriesof AC3, AC1.Widely used for controlof AC motors.
Standard products, for categories ofAC3, AC1. Widely used for control ofAC motors.
Permanent magnetic latching,power on in rush, power off sealed, power on release.For conditions require voltage shock prevetion, energy saving, noise free and no-power sealed contactors.
AC3 115-800 115-620 115-630
AC1 200-1600 200-800 200-800
200-1600 200-800 200-800
1000 1000690* , 1000
220V 30-220 30-200 30-200
400V 55-400 55-335 55-335
500V 75-450 75-400 75-400
690V 80-475 80-450 80-450
1000V 65-450 65-450 65-450
220V 80-550 80-350 80-350
400V 135-970 135-600 135-600
500V 170-1200 170-750 170-750 690V 235-1650 235-1000 235-1000
1000V 345-2400 345-1500 345-1500
2-4 3-4*. 2-4 3
115, 150, 185, 225,265, 330, 400, 500,630, 780, 800
115, 150, 170, 205, 245, 300, 410, 475, 620
115, 150, 185, 225, 265, 330, 400, 500, 630
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
2
Magnetic Contactor
Selection guide
Tel: +86-577-62776000 Fax: +86-577-62776006
Contactor CJX2R CJX2R-B CJ19
Specifications
Products
Rated operationalcurrent A
Conventional thermal current thA
Maximum rated operationalvoltage V
Rated operationalpower AC3KW
Maximumoperatingpower AC1KW
Number of poles
Applications
AC3 一 一 750 一 一
AC1 1000-3200 800-2750 AC-6b 90-130
1000-3200 800-2750 250
1000 660 1000
220V 220-500
400V 400-900
500V 500-900
690V 560-900
1000V 530-750
220V 350-1090 300-1000 Capacity of capacitor Kvar
400V 600-1890 330-1600
500V 740-2350 550-2100 690V 980-3100 800-2700
1000V 1490-4690 1100-4200
3 1-4 3
1000, 1250, 1450, 1700, 2100, 2600, 3200
750, 1000, 1500, 1800 115, 150, 170
For category AC1. For slightly inductive loads or slightly inductive distribution circuits eg. Standard electric stove, distribution circuits for workshop, power distribution in rural area and distribution for wind power distribution
Standard products, for high capacity AC3, AC1, AC4 loads, specially for large equipment in hoisting, construction andmetallur-gy industry
For making and breaking of capacitor. For making and breaking of reactive power compensation devices and appliances, to improve the power factor.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
3
Magnetic Contactor
GLC1-F Contactors From 115A to 800A
Tel: +86-577-62776000 Fax: +86-577-62776006
In circuit of AC 50/60Hz, voltage up to 1000V, Current up to 1600A, controlling motors of different types. Control resistance, inductive, capacitive loads: heating, lighting, power compensation and transformer. Contrlo distribution circuit, industrial distribution, green energy distribution. For harsh environment and frquent operations, quick operating coils are recommend.
Applications
Rated operational current A
Rated operational voltage V
Number of contacts(N/O)
Rated operational power KW AC-33,4Poles
(SCPD)Short-circuit protection by fuse
Optional parts
Type of product
Weight (kg)
Product No.
Ie max AC-3(Ue≤440V)
Ie max AC-1(θ≤40°C)
Max
220V/240V
380V/400V
415V
500V
660V/690V
1000V
440V
Model
Rated current
3Pole
4Pole
2Pole
115
200
1000
3 or 4
30
55
595975
80
65
RT16-2
250
GLC1-F115
3.6
0000
0012
150
250
1000
3 or 4
40
75
808090
100
65
RT16-2
355
GLC1-F150
3.7
0001
0013
185
275
1000
3 or 4
55
90
100100110
120
100
RT16-3
425
GLC1-F185
4.6
0002
0014
225
315
1000
3 or 4
63
100
110110129
129
140
RT16-3
500
GLC1-F225
4.7
0003
0015
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSR, GTCSS
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
4
Magnetic Contactor
GLC1-F Contactors From 115A to 800A
Tel: +86-577-62776000 Fax: +86-577-62776006
265
350
1000
3 or 4
75
132
140140
160
180
147
RT16-3
630
GLC1-F265
7.1
0004
0016
330
500
1000
2, 3 or 4
129
200
220220
257
280
185
RT16-3
800
GLC1-F400
8.5
0006
0018
265
400
1000
2, 3 or 4
100
160
180180
200
220
160
RT16-3
800
GLC1-F330
8.5
0005
0017
400
700
1000
2, 3 or 4
147
250
280280
335
355
335
RT16-3
1000
GLC1-F500
10.8
0007
0019
500
1000
1000
2, 3 or 4
200
335
375375
400
450
450
RT16-3
1250
GLC1-F630
17.8
0008
0020
630
1600
1000
2, 3 or 4
220
400
425425
450
475
450
RT16-3
1600
GLC1-F780
40.0
0009
0021
800
1000
1000
2, 3 or 4
220
400
425425
450
475
450
RT16-3
1250
GLC1-F800
19
0010
0025 00270026 0028 0029
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSR, GTCSS
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
5
Magnetic Contactor
GLC1-F Contactors From 115A to 800A/Control circuit AC/DC
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Type of product GLC1-F115
3 or 4
115
2001000
16⅔...200200
Marking current 10XIe(AC-3) or 12XIe(AC-4)
Marking current 8XIe(AC-3) or 10XIe(AC-4)
1100
640
520
400
320
0.37
5
15
220X3
95
95
ϕ6
10
2501000
16⅔...200250
1200
700
600
450
350
0.35
8
22
225X3
120
120
ϕ8
18
2751000
16⅔...200275
1500
920
740
500
400
0.33
12
25
225X3
150
150
ϕ8
18
3151000
16⅔...200315
1800
1000
850
560
440
0.32
16
32
232X3
185
185
ϕ10
35
150 185 225AAV
Hz
A
A
A
A
A
A
A
A
N.m
mΩ
w
w
3 or 4 3 or 4 3 or 4
GLC1-F150 GLC1-F185 GLC1-F225
Number of poles
Rated operational current (Ie)Ue≤400V
Rated operational voltage
Frequency limits
Conventional thermal current
Marking capacity
Breaking capacity I rms
Short time rating from cold state, no current in previous 60 mins θ≤40°C
Average impedance per pole
Power dissipation per pole for the above operational currents
Cabling θ≤55°C
Tightening torque Cable connetion
In AC-1 θ≤55°C
In AC-1 θ≤40°C
10 Secs
30 Secs
1 Min
3 Min
10 Min
Ith 50Hz
Cable with tabs
Cables with connectors
Bolt diameter
AC-3
AC-1
θ≤40°C
Frequency under operating current (I)
Irms conforming to GB14048.4
Irms conforming to GB14048.4
Max.
The maximum cross-sec-tional area number of cables dimension of cables
mm²
mm²
mm²
mm²
(1) Sinusoidal without interference
Characteristics
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
6
Magnetic Contactor
GLC1-F Contactors From 115A to 800A/Control circuit AC/DC
Tel: +86-577-62776000 Fax: +86-577-62776006
or
GLC1-F265
3 or 4
265
3501000
16⅔...200350
Marking current 10XIe(AC-3) or 12XIe(AC-4)
Marking current 8XIe(AC-3) or 10XIe(AC-4)
2200
1230
950
620
480
0.3
21
37
232X4
240
240
ϕ10
35
GLC1-F330
2, 3 or 4 2, 3 or 4 2, 3 or 4 2, 3 or 4 2, 3 or 4 2, 3 or 4
330
4001000
16⅔...200400
2650
1800
1300
900
750
0.28
30
45
230X5
240
---
ϕ10
35
GLC1-F400
400
5001000
16⅔...200500
3600
2400
1700
1200
1000
0.26
42
65
230X5
2X150
---
ϕ10
35
GLC1-F500
500
7001000
16⅔...200700
4200
3200
2400
1500
1200
0.18
45
88
240X5
2X240
---
ϕ10
35
GLC1-F630
630
8001000
16⅔...200900
5050
4400
3400
2200
1600
0.12
48
77
260X5
95
---
ϕ12
58
GLC1-F780
780
16001000
16⅔...2001600
6250
5600
4600
3000
2200
0.10
60
250
2100X5
95
---
ϕ12
58
GLC1-F800
800
10001000
16⅔...2001000
5500
4600
3600
2600
1700
0.12
77
120
260X5
95
---
ϕ12
58
Characteristics
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
7
Magnetic Contactor
GLC1-F Contactors From 115A to 800A/Control circuit AC/DC
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Characteristics
Type of product (Conforming to standards IEC60947) GLC1-F115 GLC1-F150 GLC1-F185 GLC1-F225
1000 1000 1000 1000
8 8 8 81000 1000 1000 1000
Environment Rate insulation voltage (Ui)
Rated impulse withstand voltage (Uimp)
Rated operational voltage (Ue) maxOperational current frequency rangeConforming to standards IEC60947, GB14048, EN60947
-60...+80°C
-5...+55°C
-40...+70°C
20003000
9gn 9gn 7gn 7gn
15gn 15gn 15gn 15gn2gn 2gn 2gn 2gn4gn 4gn 4gn 4gn
Maximum relative humidity less than 50% below 40°C, Maximum relative humidity less than 90% below 20°C
Ambient air temperatureStorage
Operation
Permissible for operation
Operating altitude allowed
Contactor opens
Contactor closes
Contactor opens
Contactor closes
Main circuit
Pollution degree III
Avoid direct contact with the finger (install terminal protection cap)
Avoid direct contact with the fingerCoil terminals
GLC1-780 EXP
Without derating
With deratingUse derating factors as follows:Operation voltage:0.75, drop-out voltage:0.9AC-1 category operating current:0.8
Use derating factors as follows:Operation voltage:1.15, drop-out voltage:1.1AC-1 category operating current:0.8
Forbidden
AC-1, AC-2, AC-3 1200
0.85-1.1Uc
0.2-0.75Uc
0.1-0.75Uc
1200 1200 1200
550 550 810 810
550 550 740 740
45 45 55 55
4 4 4.2 4.2
300 300 300 300AC-4
50/60Hz Please dpecify control voltage when placing orders,default voltage is 220V.
Operation voltage V
V
V
VA
VA
VA
VA
V
Cycles/h
Cycles/h
Drop-out voltage (AC)
Drop-out voltage (DC)
Inrush (AC)
Sealed (AC)
Inrush (DC)
Sealed (DC)
Maximum operating altitude
Humidity
Impact resistance capability1/2 sine wave=11ms
5...150Hz anti-seismic performanceanti-seismic performance
Degree of protection
Mounting method
Operating frequency
Control circuit characteristicsRated control voltage (Uc)
Control voltage limits (AC)θ≤55°C
Average power 50Hz
V
KV
VHz
°C°C
°C
m
m
25-400
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
8
Magnetic Contactor
GLC1-F Contactors From 115A to 800A/Control circuit AC/DC
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Characteristics
GLC1-F265 GLC1-F330
1000 1000
8 81000 1000
IEC60947, GB14048, EN60947-60...+80°C
-5...+55°C
-40...+70°C
20003000
6gn 6gn
15gn 15gn2gn 2gn5gn 5gnPollution degree III
Avoid direct contact with the finger (install terminal protection cap)
Avoid direct contact with the finger
1200
0.85-1.1Uc
Note: 1) Under these conditions, ZFWX9-F(LX9-F)coils are recommended for contactors from F115-F225 2) Separeate terminal covers could be provided for contactors GLC1-F115 to 630. 3) Under the circumstances, making and breaking capacity,electric and mechanic durability are not clear.
0.2-0.75Uc
0.1-0.75Uc1200
660
85
3.7
300
Please dpecify control voltage when placing orders,default voltage is 220V.
25-400
GLC1-F400 GLC1-F500
1000 1000
8 81000 1000
6gn 6gn
15gn 15gn2gn 2gn4gn 4gn
GLC1-F630 GLC1-F780
1000 1000
8 81000 1000
6gn 5gn
15gn 15gn2gn 2gn4gn 5.5gn
GLC1-F800
1000
81000
6gn
15gn2gn4gn
600
600
660
10
3.7
300
600
1000
920
12
4
300
600
1050
1000
16
4.5
300
600
1500
1420
20
6.5
300
600
1900
1960
45
42
300
600
1600
1450
22
7
300
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
9
Magnetic Contactor
GLC1-F Contactors From 115A to 800A
Tel: +86-577-62776000 Fax: +86-577-62776006
Scheme
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
10
Magnetic Contactor
GLC1-F Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
Selection guide
Type of product
115-630 115-630 115-630
200-900 200-900 200-900
200-900 200-900 200-900
1000 1000 1000
30-200 30-200 30-200
55-335 55-335 55-335
75-400 75-400 75-400
80-450 80-450 80-450
65-425 65-425 65-425
80-350 80-350 80-350
135-600 135-600 135-600
170-750 170-750 170-750
235-1000 235-1000 235-1000
345-1500 345-1500 345-1500
3,4 3,4 3,4
115, 150, 185, 225, 265, 330, 400, 500,630
115, 150, 185, 225, 265, 330, 400, 500,630
115, 150, 185, 225, 265, 330, 400, 500,630
GLC1-F***NSGLC1-F***4NS
GLC1-F***ZSGLC1-F***4ZS
GLC1-F***LSGLC1-F***4LS
Horizontally mountedreversing contactorpairs
Horizontally mountedchangeover contactorpairs
Horizontally mountedinterlocking contactorpairs
Specifications
220V
400V
500V
690V
1000V
220V
400V
500V
690V
1000V
Rated operational current AC3 A
Rated operational current AC1 A
Conventional thermal current Ith A
Maximum rated operational voltage V
Rated operational power AC3 KW
Maximum operatingpower AC1 KW
Number of poles
Applications
Parts
For reversing changeover of three-phase squirrel cage motors
Distribution circuit changeover
Circuits require interlocking
Connecting cables for reversing changeover circuit of distribution motors.Control circuit cables not provided.
Connecting cables for changeover circuit. Control circuit cables not provided.
Control circuit cables not provided.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
11
Magnetic Contactor
GLC1-F Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
Selection guide
115-630
200-900
200-900
1000
115, 150, 185, 225, 265, 330, 400, 500,630
GLC1-F***LcGLC1-F***4Lc
Vertically mounted interlocking contactorpairs
115-630
200-900
200-900
1000
115, 150, 185, 225, 265, 330, 400, 500,630
GLC1-F***3Lc
Vertically mounted interlocking threecontactor group
115-630
200-900
200-900
1000
115, 150, 185, 225, 265, 330, 400, 500,630
GLC1-F***Ys
Horizontally mountedstar-delta changeovercontactor group
115-630
200-900
200-900
1000
115, 150, 185, 225, 265, 330, 400, 500,630
GLC1-F***Yc
Vertically mounted star-delta changeovercontactor group
30-200
55-400
75-400
80-450
65-425
80-350
135-600
170-750
235-1000
345-1500
3,4
Circuits require interlocking
Control circuit cables not provided.
“ *** ” : Contactor model current specification. 1) When the three contactor has different specifications,indicate with rated current separately.
30-200
55-335
75-400
80-450
65-425
80-350
135-600
170-750
235-1000
345-1500
3,4For circuits require interlocking among three circuits, only one of them can make under any circumstances
Control circuit cables not provided.
63-295
110-500
150-600
160-670
3,4
Star-delta reduced voltage starting of three phase squirrel cage motors
Connecting cables for voltage starting of star-delta motors are provided.Control circuit cables not provided.
115-630
200-900
200-900
1000
3,4
Star-delta reduced voltage starting of three phase squirrel cage motors
Connecting cables for reduced voltage starting of star-delta motors are provided. Control circuit cables not provided.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
12
Magnetic Contactor
GLC1-F...Ns Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Three pole reversing contactors (horizontally mounted)(without control circuit, mainly for reversingchangeover of three-phase squirrel cage motors)
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
115Ns 115 200 30 55 59 59 75 80 65 7.70 0200150Ns 150 250 40 75 80 80 90 100 65 8.00 0201185Ns 185 275 55 90 100 100 110 120 100 9.90 0202225Ns 225 315 63 100 110 110 129 140 100 10.20 0203265Ns 265 350 75 132 140 140 160 180 147 15.30 0204330Ns 330 400 100 160 180 180 200 220 160 18.40 0205400Ns 400 500 129 200 220 220 257 280 185 18.70 0206500Ns 500 700 147 250 280 280 335 355 335 24.00 0207630Ns 630 900 200 335 375 375 400 450 425 38.80 0208800Ns 800 1000 220 450 450 450 450 475 450 44.20 0209
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
1154Ns 115 200 30 55 59 59 75 80 65 9.40 02131504Ns 150 250 40 75 80 80 90 100 65 10.10 02141854Ns 185 275 55 90 100 100 110 120 100 11.90 02152254Ns 225 315 63 100 110 110 129 140 100 12.90 02162654Ns 265 350 75 132 140 140 160 180 147 18.80 02173304Ns 330 400 100 160 180 180 200 220 160 22.30 02184004Ns 400 500 129 200 220 220 257 280 185 22.90 02195004Ns 500 700 147 250 280 280 335 355 335 29.60 02206304Ns 630 900 200 335 375 375 400 450 425 47.60 0221
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Four pole reversing contactors (horizontally mounted)(without control circuit, mainly for reversingchangeover of three-phase squirrel cage motors)
GLC1-F115Ns GLC1-F1154Ns
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
13
Magnetic Contactor
GLC1-F...Zs Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Three pole changeover contactor pairs (horizontally mounted)(without control circuit, mainly for changeover of distribution circuits.)
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
115Zs 115 200 30 55 59 59 75 80 65 7.60 0225150Zs 150 250 40 75 80 80 90 100 65 7.90 0226185Zs 185 275 55 90 100 100 110 120 100 9.70 0227225Zs 225 315 63 100 110 110 129 140 100 10.00 0228265Zs 265 350 75 132 140 140 160 180 147 15.00 0229330Zs 330 400 100 160 180 180 200 220 160 18.00 0230400Zs 400 500 129 200 220 220 257 280 185 18.10 0231500Zs 500 700 147 250 280 280 335 355 335 23.00 0232630Zs 630 900 200 335 375 375 400 450 425 38.00 0233800Zs 800 1000 220 450 450 450 450 475 450 41.70 0234
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
1154Zs 115 200 30 55 59 59 75 80 65 9.20 02371504Zs 150 250 40 75 80 80 90 100 65 9.70 02381854Zs 185 275 55 90 100 100 110 120 100 11.60 02392254Zs 225 315 63 100 110 110 129 140 100 12.40 02402654Zs 265 350 75 132 140 140 160 180 147 18.20 02413304Zs 330 400 100 160 180 180 200 220 160 21.50 02424004Zs 400 500 129 200 220 220 257 280 185 21.80 02435004Zs 500 700 147 250 280 280 335 355 335 28.10 02446304Zs 630 900 200 335 375 375 400 450 425 46.30 0245
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Four pole changeover contactor pairs (horizontally mounted)(without control circuit, mainly for changeoverof distribution circuits.)
GLC1-F115Zs GLC1-F1154Zs
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
14
Magnetic Contactor
GLC1-F...4Ls Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Three pole interlock contactor(horizontally mounted)(without control circuit, power connecting cables are not provided)
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
115Ls 115 200 30 55 59 59 75 80 65 7.30 0250150Ls 150 250 40 75 80 80 90 100 65 7.40 0251185Ls 185 275 55 90 100 100 110 120 100 9.20 0252225Ls 225 315 63 100 110 110 129 140 100 9.30 0253265Ls 265 350 75 132 140 140 160 180 147 14.30 0254330Ls 330 400 100 160 180 180 200 220 160 17.00 0255400Ls 400 500 129 200 220 220 257 280 185 17.00 0256500Ls 500 700 147 250 280 280 335 355 335 21.80 0257630Ls 630 900 200 335 375 375 400 450 425 35.00 0258800Ls 800 1000 220 450 450 450 450 475 450 38.00 0259
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
1154Ls 115 200 30 55 59 59 75 80 65 8.70 02621504Ls 150 250 40 75 80 80 90 100 65 9.10 02631854Ls 185 275 55 90 100 100 110 120 100 10.90 02642254Ls 225 315 63 100 110 110 129 140 100 11.50 02652654Ls 265 350 75 132 140 140 160 180 147 17.20 02663304Ls 330 400 100 160 180 180 200 220 160 20.20 02674004Ls 400 500 129 200 220 220 257 280 185 20.20 02685004Ls 500 700 147 250 280 280 335 355 335 26.00 02696304Ls 630 900 200 335 375 375 400 450 425 41.20 0270
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Four pole interlock contactor(horizontally mounted)(without control circuit, power connecting cables are not provided)
GLC1-F115Ls GLC1-F1154Ls
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
15
Magnetic Contactor
GLC1-F ...4Lc Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Three pole interlock contactor(Vertically mounted)(without control circuit, power connecting cables are not provided)
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
115Lc 115 200 30 55 59 59 75 80 65 7.60 0275150Lc 150 250 40 75 80 80 90 100 65 7.80 0276185Lc 185 275 55 90 100 100 110 120 100 9.60 0277225Lc 225 315 63 100 110 110 129 140 100 9.80 0278265Lc 265 350 75 132 140 140 160 180 147 15.40 0279330Lc 330 400 100 160 180 180 200 220 160 18.30 0280400Lc 400 500 129 200 220 220 257 280 185 18.30 0281500Lc 500 700 147 250 280 280 335 355 335 22.90 0282630Lc 630 900 200 335 375 375 400 450 425 36.10 0283780Lc 780 1600 220 400 425 425 450 475 450 80.00 0284
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
1154Lc 115 200 30 55 59 59 75 80 65 8.70 02881504Lc 150 250 40 75 80 80 90 100 65 9.00 02891854Lc 185 275 55 90 100 100 110 120 100 9.40 02902254Lc 225 315 63 100 110 110 129 140 100 11.20 02912654Lc 265 350 75 132 140 140 160 180 147 18.20 02923304Lc 330 400 100 160 180 180 200 220 160 21.20 02934004Lc 400 500 129 200 220 220 257 280 185 21.20 02945004Lc 500 700 147 250 280 280 335 355 335 27.00 02956304Lc 630 900 200 335 375 375 400 450 425 42.30 0296
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-F
Four pole interlock contactor(Vertically mounted)(without control circuit, power connecting cables are not provided)
GLC1-F115Lc GLC1-F1154Lc
800Lc 800 1000 220 450 450 450 450 475 450 39.30 0285
7804Lc 780 1600 220 450 450 450 450 475 450 48.00 0297
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
16
Magnetic Contactor
GLC1-F...Y Star-delta starter Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Star-delta contactors (without control circuit, for motors non-load starting or starting from a low torque and increasing)
GLC1-F185Y In-line mounted
GLC1-F115Y Right angle mounted
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
SerialNumber
220V 380V 660V In-line440V 230V 400V 415V 440V 500V 690V typeAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW Kg
115Y 115 200 65 110 110 129 140 160 11.50 0300 0312150Y 150 250 75 132 132 150 160 180 12.00 0301 0313185Y 185 275 90 160 160 180 200 220 14.70 0302 0314225Y 225 315 100 180 180 200 220 250 15.30 0303 0315265Y 265 350 110 220 220 250 280 295 22.80 0316330Y 330 400 150 265 265 300 335 355 27.40 0317400Y 400 500 190 315 315 355 400 450 27.80 0318500Y 500 700 220 400 400 450 500 560 35.40 0319630Y 630 800 295 500 500 560 600 670 57.40 0320
Rated power of standard three-phasemotors 50/60Hz (AC-3)
GLC1-F
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
17
Magnetic Contactor
GLC1-F...Ns/Zs/Ls Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Main circuit wiring schematic
Mechanical interlocking mechanism
Mechanical interlocking mechanism GLC1-F...Ns
Changeover contactors GLC1-F...Zs
Interlock contactors GLC1-F...Ls
Interlock contactor group (Vertically mounted)
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
18
Magnetic Contactor
Scheme main circuit wiring schematic
Tel: +86-577-62776000 Fax: +86-577-62776006
or
Scheme drawing
Wiring diagram
In line mounting drawing
In line mounting wiring diagram In line mounting wiring diagram Control circuit wiring diagram
Right angle mounting drawing
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
19
Magnetic Contactor
GLC1-F...Ns/Zs/Ls/Lc/Ys Interlock Contactors components
Tel: +86-577-62776000 Fax: +86-577-62776006
Components for reversing contactor pairs, power changeover contactors pairs, interlock congtactors and star-delta contactor groups.
ProductType
ContactorsType
Mechanicinterlock
Powerconnection
Fittings
GLC1-F115Ns GLC1-F115 2pcs GFJSF970 GFDL11582 GTJG9731GLC1-F150Ns GLC1-F150 2pcs GFJSF970 GFDL15082 GTJG9731GLC1-F185Ns GLC1-F185 2pcs GFJSG970 GFDL18582 GTJG9731GLC1-F225Ns GLC1-F225 2pcs GFJSG970 GFDL22582 GTJG9731GLC1-F265Ns GLC1-F265 2pcs GFJSJ970 GFDL26582 GTJG9732GLC1-F330Ns GLC1-F330 2pcs GFJSJ970 GFDL33082 GTJG9732GLC1-F400Ns GLC1-F400 2pcs GFJSJ970 GFDL40082 GTJG9734GLC1-F500Ns GLC1-F500 2pcs GFJSJ970 GFDL50082 GTJG9734GLC1-F630Ns GLC1-F630 2pcs GFJSL970 GFDL63082 GTJG9737
GLC1-F1154Ns GLC1-F1154 2pcs GFJSF970 GFDL11583 GTJG9732GLC1-F1504Ns GLC1-F1504 2pcs GFJSF970 GFDL15083 GTJG9732GLC1-F1854Ns GLC1-F1854 2pcs GFJSG970 GFDL18583 GTJG9732GLC1-F2254Ns GLC1-F2254 2pcs GFJSG970 GFDL22583 GTJG9732GLC1-F2654Ns GLC1-F2654 2pcs GFJSJ970 GFDL26583 GTJG9733GLC1-F3304Ns GLC1-F3304 2pcs GFJSJ970 GFDL33083 GTJG9733GLC1-F4004Ns GLC1-F4004 2pcs GFJSJ970 GFDL40083 GTJG9734GLC1-F5004Ns GLC1-F5004 2pcs GFJSJ970 GFDL50083 GTJG9736GLC1-F6304Ns GLC1-F6304 2pcs GFJSL970 GFDL63083 GTJG9740
GLC1-F115Zs GLC1-F115 2pcs GFJSF970 GFDL11582 GTJG9731GLC1-F150Zs GLC1-F150 2pcs GFJSF970 GFDL15082 GTJG9731GLC1-F185Zs GLC1-F185 2pcs GFJSG970 GFDL18582 GTJG9731GLC1-F225Zs GLC1-F225 2pcs GFJSG970 GFDL22582 GTJG9731GLC1-F265Zs GLC1-F265 2pcs GFJSJ970 GFDL26582 GTJG9732GLC1-F330Zs GLC1-F330 2pcs GFJSJ970 GFDL33082 GTJG9732GLC1-F400Zs GLC1-F400 2pcs GFJSJ970 GFDL40082 GTJG9734GLC1-F500Zs GLC1-F500 2pcs GFJSJ970 GFDL50082 GTJG9734GLC1-F630Zs GLC1-F630 2pcs GFJSL970 GFDL63082 GTJG9737
GLC1-F1154Zs GLC1-F1154 2pcs GFJSF970 GFDL11577 GTJG9732GLC1-F1504Zs GLC1-F1504 2pcs GFJSF970 GFDL15077 GTJG9732GLC1-F1854Zs GLC1-F1854 2pcs GFJSG970 GFDL18577 GTJG9732GLC1-F2254Zs GLC1-F2254 2pcs GFJSG970 GFDL22577 GTJG9732GLC1-F2654Zs GLC1-F2654 2pcs GFJSJ970 GFDL26577 GTJG9733GLC1-F3304Zs GLC1-F3304 2pcs GFJSJ970 GFDL33077 GTJG9733GLC1-F4004Zs GLC1-F4004 2pcs GFJSJ970 GFDL40077 GTJG9734GLC1-F5004Zs GLC1-F5004 2pcs GFJSJ970 GFDL50077 GTJG9736GLC1-F6304Zs GLC1-F6304 2pcs GFJSL970 GFDL63077 GTJG9740
Horizontally mountedreversing contactors
Horizontally mountedfour pole reversingcontactors
Horizontally mountedchangeover contactors
Horizontally mountedfour pole changeovercontactors
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
20
Magnetic Contactor
GLC1-F...Ns/Zs/Ls/Lc/Ys Interlock Contactors components
Tel: +86-577-62776000 Fax: +86-577-62776006
Star-delta contactors (without control circuit, for motors non-load starting or starting from a low torque and increasing)
Product TypeContactorsType
Mechanicinterlock
Fittings(lshort)
Fittings (long)
GLC1-F115Ls GLC1-F115 2pcs GFJSF970 GTJG9731GLC1-F150Ls GLC1-F150 2pcs GFJSF970 GTJG9731GLC1-F185Ls GLC1-F185 2pcs GFJSG970 GTJG9731GLC1-F225Ls GLC1-F225 2pcs GFJSG970 GTJG9731GLC1-F265Ls GLC1-F265 2pcs GFJSJ970 GTJG9732GLC1-F330Ls GLC1-F330 2pcs GFJSJ970 GTJG9732GLC1-F400Ls GLC1-F400 2pcs GFJSJ970 GTJG9734GLC1-F500Ls GLC1-F500 2pcs GFJSJ970 GTJG9734GLC1-F630Ls GLC1-F630 2pcs GFJSL970 GTJG9737
GLC1-F1154Ls GLC1-F1154 2pcs GFJSF970 GTJG9732GLC1-F1504Ls GLC1-F1504 2pcs GFJSF970 GTJG9732GLC1-F1854Ls GLC1-F1854 2pcs GFJSG970 GTJG9732GLC1-F2254Ls GLC1-F2254 2pcs GFJSG970 GTJG9732GLC1-F2654Ls GLC1-F2654 2pcs GFJSJ970 GTJG9733GLC1-F3304Ls GLC1-F3304 2pcs GFJSJ970 GTJG9733GLC1-F4004Ls GLC1-F4004 2pcs GFJSJ970 GTJG9734GLC1-F5004Ls GLC1-F5004 2pcs GFJSJ970 GTJG9736GLC1-F6304Ls GLC1-F6304 2pcs GFJSL970 GTJG9740
GLC1-F115Lc GLC1-F115 2pcs GFJSF4F GTJG9732 GTJG9733GLC1-F150Lc GLC1-F150 2pcs GFJSF4F GTJG9732 GTJG9733GLC1-F185Lc GLC1-F185 2pcs GFJSG4G GTJG9732 GTJG9733GLC1-F225Lc GLC1-F225 2pcs GFJSG4G GTJG9732 GTJG9733GLC1-F265Lc GLC1-F265 2pcs GFJSJ4H GTJG9732 GTJG9735GLC1-F330Lc GLC1-F330 2pcs GFJSJ4H GTJG9733 GTJG9735GLC1-F400Lc GLC1-F400 2pcs GFJSJ4J GTJG9736 GTJG9739GLC1-F500Lc GLC1-F500 2pcs GFJSJ4J GTJG9736 GTJG9739GLC1-F630Lc GLC1-F630 2pcs GFJSL4L GTJG9740GLC1-F780Lc GLC1-F780 2pcs GFJSX971 GTJG9743GLC1-F800Lc GLC1-F800 2pcs GFJSL4L GTJG9740
GLC1-F1154Lc GLC1-F1154 2pcs GFJSF4F GTJG9732 GTJG9733GLC1-F1504Lc GLC1-F1504 2pcs GFJSF4F GTJG9732 GTJG9733GLC1-F1854Lc GLC1-F1854 2pcs GFJSG4G GTJG9732 GTJG9733GLC1-F2254Lc GLC1-F2254 2pcs GFJSG4G GTJG9732 GTJG9733GLC1-F2654Lc GLC1-F2654 2pcs GFJSJ4H GTJG9732 GTJG9735GLC1-F3304Lc GLC1-F3304 2pcs GFJSJ4H GTJG9733 GTJG9735GLC1-F4004Lc GLC1-F4004 2pcs GFJSJ4J GTJG9736 GTJG9739GLC1-F5004Lc GLC1-F5004 2pcs GFJSJ4J GTJG9736 GTJG9739GLC1-F6304Lc GLC1-F6304 2pcs GFJSL4L GTJG9740GLC1-F7804Lc GLC1-F7804 2pcs GFJSX971 GTJG9743
Horizontally mountedinterlock contactors
Horizontally mountedfour pole interlockcontactors
Vertically mountedinterlock contactors
Vertically mountedfour pole interlockcontactors
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
21
Magnetic Contactor
GLC1-F Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
Components for reversing contactor pairs, power changeover contactors pairs, interlock congtactors and star-deltacontactor groups
Vertically mounted interlock contactors with three contactors of same specifications
Vertically mounted interlock contactors with three contactors of different specifications and different number of poles
Note:1. “*” 2 means 2pole, nil means 3 pole, 4means 4 pole, 115-330: 3-4 pole. 400-630: 2-4pole, 800: 2-3pole2. Three interlock contactors will be mounted on two fitting bars when delivery. Clients could use it to install as whole, however, it is not part of the products.
Note:1. “***” 2 means 2pole, nil means 3 pole, 4means 4 pole, 115-330: 3-4 pole. 400-630: 2-4pole, 800: 2-3pole2. Four vertically mounted interlock contactors could be supplied High current on the top. lower current in the below. Installation shall be conducted by clients.Details please consult to our local distributos.
ProductType
ContactorsType
Mechanicinterlock
Powerconnection
Fittings
GLC1-F115Ys GLC1-F115 3pcs GFJSF970 GFDL11585 GTJG9746GLC1-F150Ys GLC1-F150 3pcs GFJSF970 GFDL15085 GTJG9746GLC1-F185Ys GLC1-F185 3pcs GFJSG970 GFDL18585 GTJG9746GLC1-F225Ys GLC1-F225 3pcs GFJSG970 GFDL22585 GTJG9746GLC1-F265Ys GLC1-F265 3pcs GFJSJ970 GFDL26585 GTJG9748GLC1-F330Ys GLC1-F330 3pcs GFJSJ970 GFDL33085 GTJG9748GLC1-F400Ys GLC1-F400 3pcs GFJSJ970 GFDL40085 GTJG9749GLC1-F500Ys GLC1-F500 3pcs GFJSJ970 GFDL50085 GTJG9749GLC1-F630Ys GLC1-F630 3pcs GFJSL970 GFDL63085 GTJG9753
Horizontallymounted star-delta changeovercontactors
Product Type Contactors Type Mechanic interlock FittingsGLC1-F115...3Lc GLC1-F115 3pcs GFJSF4F4F GTJG9748GLC1-F150...3Lc GLC1-F150 3pcs GFJSF4F4F GTJG9748GLC1-F185...3Lc GLC1-F185 3pcs GFJSG4G4G GTJG9748GLC1-F225...3Lc GLC1-F225 3pcs GFJSG4G4G GTJG9748GLC1-F265...3Lc GLC1-F265 3pcs GFJSG4H4H GTJG9751GLC1-F330...3Lc GLC1-F330 3pcs GFJSG4H4H GTJG9751GLC1-F400...3Lc GLC1-F400 3pcs GFJSF4J4J GTJG9752GLC1-F500...3Lc GLC1-F500 3pcs GFJSF4K4K GTJG9752GLC1-F630...3Lc GLC1-F630 3pcs GFJSF4L4L GTJG9753GLC1-F800...3Lc GLC1-F800 3pcs GFJSF4L4L GTJG9753
Vertically mountedinterlock contactors
with three contactorsof same
specifications
Note:1. Interlock contactors will be mounted on two fitting bars when delivery. Clients could use it to install as a whole.however, it is not part of the products.2. Two different contactors with different specification and different number of poles (GLC1-F115-330, GLC1-F400-630, 2-4pole) could be vertically mounted into interlock contactor pairs, higher current contactor on the top, lower current contactor in the bottom. Installation is conducted by clients. Detalls please consult to our local distribu-tors.3. Right angle mounted star-delta changeover contactors are available in different specification. Installation is conducted by clients.
Interlock contactors 1/2 Contactor on the top Contactor in the middle Contactor at the bottom Mechanic interlock
GLC1***. ###. &&&.3Lc
GLC1***. ###. &&&.3Lc
*, #, &
GLC1-F***.
Code
115
F
150
F
185
G
225
G
265
H
330
H
400
J
500
K
630
L
800
FL
Contactor specifications (Rated current)
GLC1-F###. GLC1-F&&&. GLC1-F4#4&
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
22
Magnetic Contactor
GLC1-F...Ns/Zs/Ls/Lc/Y Interlock Contactors
Tel: +86-577-62776000 Fax: +86-577-62776006
Components for reversing contactor pairs, power changeover contactors pairs, interlock congtactors and star-deltacontactor groups
Width Length QTY M QTY DIM QTY NO. M QTY NO. QTYGTJG9731 25 S355 2 6 8 6 8 1 6 8 1 6GTJG9732 25 S425 2 6 8 6 8 1 6 8 1 6GTJG9733 34 S500 2 6 8 8 8 2 6 8 2 6GTJG9734 34 S500 2 8 8 8 8 3 8 8 2 6GTJG9735 34 S630 2 6 8 6 8 2 6 8 2 6GTJG9736 34 S630 2 8 8 8 8 3 8 8 2 6GTJG9737 34 S630 2 10 8 10 8 4 10 8 2 6GTJG9738 34 S800 2 6 8 6 8 2 6 8 2 6GTJG9739 34 S800 2 8 8 8 8 3 8 8 2 6GTJG9740 34 S800 2 10 8 10 8 4 10 8 2 6GTJG9741 34 S1000 2 6 8 6 8 2 6 8 2 6GTJG9742 34 S1000 2 8 8 8 8 3 8 8 2 6GTJG9743 34 S1000 2 10 8 10 8 4 10 8 2 6GTJG9746 34 F630 2 6 12 6 12 2 6 12 2 8GTJG9747 34 F630 2 8 12 8 12 3 8 12 2 8GTJG9748 34 F630 2 6 12 6 12 2 6 12 2 8GTJG9749 34 F800 2 8 12 8 12 3 8 12 2 8GTJG9750 34 F800 2 10 12 10 12 4 10 12 2 8GTJG9751 34 F1000 2 6 12 6 12 2 6 12 2 8GTJG9752 34 F1000 2 8 12 8 12 3 8 12 2 8GTJG9753 34 F1000 2 10 12 10 12 4 10 12 2 8GTJG9762 34 S630 3 8 12 8 12 3 8 12 2 9GTJG9763 34 S630 3 10 12 10 12 4 10 12 2 9GTJG9764 34 S800 3 8 12 8 12 3 8 12 2 9GTJG9765 34 S800 3 10 12 10 12 4 10 12 2 9GTJG9766 34 S1000 3 8 12 8 12 3 8 12 2 9GTJG9767 34 S1000 3 10 12 10 12 4 10 12 2 9
GTJG Fitting bars(2) BoltsWashergaskets
GTJGJM Squarenuts(3)
GTJGA n shapegasket(4)Fittings(1)
Note:1) Interlock contactors could be fitted on fitting bars in the workshop. Interlock contactors will be fitted on fitted on fitting bars when delivery. clients could install as a whole, however, it is not part of the products.2) Lengths: 3:three fitting holes; F:four fitting holes; Five fitting holes. Five fitting holes bar could replace three and four fitting holes bars.3) NO.: 1:15X20 M6; 2:20X30 M6; 3:20X30 M8; 420X30 M104) NO.: 1: inner width 26; 2: inner width 36.5) M10 could be replaced by M8 when delivery (bolts, gaskets, square nuts).
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
23
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
In circuit of AC 50/60Hz, voltage up to 1000V, Current up to 900A, controlling motors of different types. Control resistance, inductive, capacitive loads: heating, lighting, power compensation and transformer. Contrlo distribution circuit, industrial distribution, green energy distribution. For harsh environment and frquent operations, quick operating coils are recommend for GLC1-D300-620 contactors.
Applications
Rated operational current A
Rated operational voltage V
Number of contacts(N/O)
Rated operational power KW AC-33,4Poles
(SCPD)Short-circuit protection by fuse
Optional parts
Type of product
Weight (kg)
Product No.
Ie max AC-3(Ue≤440V)
Ie max AC-1(θ≤40°C)
Max
220V/240V
380V/400V
415V
500V
660V/690V
1000V
440V
Model
Rated current
3Pole
4Pole
2Pole
115
200
1000
3
30
55
595975
80
75
RT16-1
125
GLC1-D115
2.25
0050
150
200
1000
3
40
75
808090
100
90
RT16
160
GLC1-D150
2.25
0051
170
200
1000
3
55
90
100100110
120
100
RT16
180
GLC1-D170
2.25
0052
205
275
1000
3
63
100
110110129
140
100
RT16
250
GLC1-D205
4.70
0053
0063
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSR, GTCSSFlip auxiliary contacts: GTCF3D
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
24
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Applications
245
315
1000
3 or 4
75
132
140140
160
180
147
RT16-3
250
GLC1-D205
4.7
0054
0064
300
400
1000
2, 3 or 4
100
160
180180
200
220
160
RT16-3
400
GLC1-D300
8.2
0055
0065
0070
410
500
1000
2, 3 or 4
129
200
220220
257
280
185
RT16-3
500
GLC1-D410
8.5
0056
0066
475
700
1000
2, 3 or 4
147
250
280280
335
355
335
RT16-3
500
GLC1-D475
10.8
0057
0067
620
900
1000
2, 3 or 4
200
335
375375
400
450
425
RT16-3
630
GLC1-D620
17.4
0058
0068
00730071 0072
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSR, GTCSSFlip auxiliary contacts: GTCF3D
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
25
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Type of product
Characteristics
GLC1-D115
3
115
2001000
25-400200
Marking current 10XIe(AC-3) or 12XIe(AC-4)
Marking current 8XIe(AC-3) or 10XIe(AC-4)
950
720
550
340
200
0.6
7.9
24
218X3
120
120
ϕ8
18
2501000
25-400200
1200
820
580
350
250
0.6
13.5
24
218X3
120
120
ϕ8
18
2751000
25-400200
1200
820
580
350
250
0.6
17.5
24
218X3
120
120
ϕ8
18
3151000
16⅔...200275
1500
920
740
500
400
0.32
13.5
26
225X3
150
150
ϕ8
18
150 185 225AAV
Hz
A
A
A
A
A
A
A
A
N.m
mΩ
w
w
3 3 3 or 4
GLC1-D150 GLC1-D170 GLC1-D205
Number of poles
Rated operational current (Ie)Ue≤400V
Rated operational voltage
Frequency limits
Conventional thermal current
Marking capacity
Breaking capacity I rms
Short time rating from cold state, no current in previous 60 mins θ≤40°C
Average impedance per pole
Power dissipation per pole for the above operational currents
Cabling θ≤55°C
Tightening torque Cable connetion
In AC-1 θ≤55°C
In AC-1 θ≤40°C
10 Secs
30 Secs
1 Min
3 Min
10 Min
Ith 50Hz
Cable with tabs
Cables with connectors
Bolt diameter
AC-3
AC-1
θ≤40°C
Frequency under operating current (I)
Irms conforming to GB14048.4
Irms conforming to GB14048.4
Max.
The maximum cross-sec-tional area number of cables dimension of cables
mm²
mm²
mm²
mm²
(1) Sinusoidal without interference
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
26
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
GLC1-D245
3 or 4
245
3151000
16⅔...200315
Marking current 10XIe(AC-3) or 12XIe(AC-4)
Marking current 8XIe(AC-3) or 10XIe(AC-4)
1800
1000
850
560
440
0.3
18
32
230X4
185
185
ϕ10
35
GLC1-D300
3 or 4 2, 3 or 4 2, 3 or 4 3 or 4
330
4001000
16⅔...200400
2650
1800
1300
900
750
0.28
25
44
230X5
240
---
ϕ10
35
GLC1-D410
400
5001000
16⅔...200500
3600
2400
1700
1200
1000
0.24
40
70
230X5
2X150
---
ϕ10
35
GLC1-D475
500
7001000
16⅔...200700
4200
3200
2400
1500
1200
0.20
45
98
240X5
2X240
---
ϕ10
35
GLC1-D620
630
8001000
16⅔...200900
5050
4400
3400
2200
1600
0.12
48
120
260X5
---
---
ϕ12
58
Characteristics
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
27
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics
Type of product (Conforming to standards IEC60947) GLC1-D115 GLC1-D150 GLC1-D170 GLC1-D205
1000 1000 1000 1000
8 8 8 81000 1000 1000 1000
Environment Rate insulation voltage (Ui)
Rated impulse withstand voltage (Uimp)
Rated operational voltage (Ue) maxOperational current frequency rangeConforming to standards IEC60947, GB14048, EN60947
-60...+80°C
-5...+55°C
-40...+70°C
20003000
6gn 6gn 6gn 7gn
15gn 15gn 15gn 15gn2gn 2gn 2gn 2gn4gn 4gn 4gn 5gn
Maximum relative humidity less than 50% below 40°C, Maximum relative humidity less than 90% below 20°C
Ambient air temperatureStorage
Operation
Permissible for operation
Operating altitude allowed
Contactor opens
Contactor closes
Contactor opens
Contactor closes
Main circuit
Pollution degree III
Avoid direct contact with the finger (install terminal protection cap)
Avoid direct contact with the fingerCoil terminals
Without derating
With deratingUse derating factors as follows:Operation voltage:0.75, drop-out voltage:0.9AC-1 category operating current:0.8
Use derating factors as follows:Operation voltage:1.15, drop-out voltage:1.1AC-1 category operating current:0.8
Forbidden
AC-1, AC-2, AC-3 1200
0.85-1.1Uc
0.2-0.75Uc
0.1-0.75Uc
1200 1200 1200
450 450 450 810
740
22 22 22 55
4.2
300 300 300 300AC-4
50/60Hz Please dpecify control voltage when placing orders,default voltage is 220V.
Operation voltage V
V
V
VA
VA
VA
VA
V
Cycles/h
Cycles/h
Drop-out voltage (AC)
Drop-out voltage (DC)
Inrush (AC)
Sealed (AC)
Inrush (DC)
Sealed (DC)
Maximum operating altitude
Humidity
Impact resistance capability1/2 sine wave=11ms
5...150Hz anti-seismic performanceanti-seismic performance
Degree of protection
Mounting method
Operating frequency
Control circuit characteristicsRated control voltage (Uc)
Control voltage limits (AC)θ≤55°C
Average power 50Hz
V
KV
VHz
°C°C
°C
m
m
25-400
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
28
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics
GLC1-D245 GLC1-D300
1000 1000
8 81000 1000
IEC60947, GB14048, EN60947-60...+80°C
-5...+55°C
-40...+70°C
20003000
6gn 6gn
15gn 15gn2gn 2gn5gn 5gnPollution degree III
Avoid direct contact with the finger (install terminal protection cap)
Avoid direct contact with the finger
1200
0.85-1.1Uc
Note: 1) Under these conditions, GFWX9-F(LX9-F)coils are recommended for contactors from D205-D620 2) Separeate terminal covers could be provided for contactors GLC1-D205-D620 3) GLC1-D115-170 excluded
0.2-0.75Uc
0.1-0.75Uc810
740
55
4.2
300
Please dpecify control voltage when placing orders,default voltage is 220V.
25-400
GLC1-D410 GLC1-D475
1000 1000
8 81000 1000
6gn 9gn
15gn 15gn2gn 2gn4gn 4gn
GLC1-D620
1000
81000
6gn
15gn2gn4gn
600
600
660
10
3.7
300
600
1000
920
12
4
300
600
1050
1000
16
4.5
300
600
1500
1420
20
6.5
300
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
29
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Scheme drawing
GLC1-D115-170
GLC1-D205-620
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
30
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Three pole reversing contactors (horizontally mounted)(without control circuit, mainly for revers-ing changeover of three-phase squirrel cage motors)
Contactors Ratedoperationalcurrent
conventionalthermalcurrent
Weight SerialNumber
220V 380V 660V440V 230V 400V 415V 440V 500V 690V 1000VAC-3 AC-1Ie/A Ith/A kW kW kW kW kW kW kW Kg
115Ns 115 200 30 55 59 59 75 80 65 7.70 0350150Ns 150 250 40 75 80 80 90 100 65 8.00 0351170Ns 150 250 40 75 80 80 90 100 65 8.00 0352205Ns 185 275 55 90 100 100 110 120 100 9.90 0353245Ns 225 315 63 100 110 110 129 140 100 10.20 0354300Ns 330 400 100 160 180 180 200 220 160 18.40 0355410Ns 400 500 129 200 220 220 257 280 185 18.70 0356475Ns 500 700 147 250 280 280 335 355 335 24.00 0357620Ns 630 900 200 335 375 375 400 450 425 38.80 0358
Rated power of standard three-phase motors50/60Hz (AC-3)
GLC1-D
GLC1-D115-170Ns GLC1-D205-620Ns
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
31
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Components for reversing contactor pairs, power changeover contactors pairs
Note: 1) Interlock contactors will be mounted on two fitting bars when delivery, Clients could use it to install as a whole, however, it is not part of the products. 2) Interlock contactor pairs of different specifications and different number of poles could be supplied details please consult our local cistributor. 3) Two, Three contactors of different specifications and different number of poles (GLC1-D205-300:3-4pole, GLC1-D410-620:2-4pole) could be supplied for interlock contactor pairs vertically mounted. High current contactor on the top. lower one at the bottom, installation shall be conducted by clients. Details please consult our local distributors
ProductType
ContactorsType
Mechanicinterlock
Powerconnection Fittings
ProductNO.
GLC1-D115Ns GLC1-D115 2pcs GDJS11502 GDDL11569 GDJG9731 0350GLC1-D150Ns GLC1-D150 2pcs GDJS11502 GDDL15069 GDJG9731 0351GLC1-D170Ns GLC1-D170 2pcs GDJS11502 GDDL17069 GDJG9731 0352GLC1-D205Ns GLC1-D205 2pcs GFJSG970 GFDL18576 GTJG9731 0353GLC1-D245Ns GLC1-D245 2pcs GFJSJ970 GFDL22576 GTJG9732 0354GLC1-D300Ns GLC1-D300 2pcs GFJSJ970 GFDL30076 GTJG9732 0355GLC1-D410Ns GLC1-D410 2pcs GFJSJ970 GFDL41076 GTJG9734 0356GLC1-D475Ns GLC1-D475 2pcs GFJSJ970 GFDL47576 GTJG9734 0357GLC1-D620Ns GLC1-D620 2pcs GFJSL970 GFDL62076 GTJG9737 0358
GLC1-D2054NS GLC1-D2054 2pcs GFJSG970 GFDL18583 GTJG9732 0366GLC1-D2454NS GLC1-D2454 2pcs GFJSJ970 GFDL22583 GTJG9732 0367GLC1-D3004NS GLC1-D3004 2pcs GFJSJ970 GFDL30083 GTJG9733 0368GLC1-D4104NS GLC1-D4104 2pcs GFJSJ970 GFDL41083 GTJG9734 0369GLC1-D4754NS GLC1-D4754 2pcs GFJSJ970 GFDL47583 GTJG9736 0370GLC1-D6204NS GLC1-D6204 2pcs GFJSL970 GFDL62083 GTJG9740 0371
GLC1-D115Zs GLC1-D115 2pcs GDJS11502 GDDL11571 GDJG9731 0375GLC1-D150Zs GLC1-D150 2pcs GDJS11502 GDDL15071 GDJG9731 0376GLC1-D170Zs GLC1-D170 2pcs GDJS11502 GDDL17071 GDJG9731 0377GLC1-D205Zs GLC1-D205 2pcs GFJSG970 GFDL18582 GTJG9731 0378GLC1-D245Zs GLC1-D245 2pcs GFJSJ970 GFDL22582 GTJG9732 0379GLC1-D300Zs GLC1-D300 2pcs GFJSJ970 GFDL30082 GTJG9732 0380GLC1-D410Zs GLC1-D410 2pcs GFJSJ970 GFDL41082 GTJG9734 0381GLC1-D475Zs GLC1-D475 2pcs GFJSJ970 GFDL47582 GTJG9734 0382GLC1-D620Zs GLC1-D620 2pcs GFJSL970 GFDL62082 GTJG9737 0383
GLC1-D2054NS GLC1-D2054 2pcs GFJSG970 GFDL18577 GTJG9732 0390GLC1-D2454NS GLC1-D2454 2pcs GFJSJ970 GFDL22577 GTJG9732 0391GLC1-D3004NS GLC1-D3004 2pcs GFJSJ970 GFDL30077 GTJG9733 0392GLC1-D4104NS GLC1-D4104 2pcs GFJSJ970 GFDL41077 GTJG9734 0393GLC1-D4754NS GLC1-D4754 2pcs GFJSJ970 GFDL47577 GTJG9736 0394GLC1-D6204NS GLC1-D6204 2pcs GFJSL970 GFDL62077 GTJG9740 0395
Reversingcontactorshorizontallymounted
Four polereversingcontactorshorizontallymouted
Changeover contactorshorizontallymounted
Four poleChangeover contactorshorizontallymounted
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
32
Magnetic Contactor
GLC1-D Contactors From 115A to 620A
Tel: +86 577 62776000 Fax: +86 577 62776006
Scheme drawing
GLC1-D205-620NS
GLC1-D115-170NSIntegrated electrical interlock contacts
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
33
Magnetic Contactor
GCR1-F Permanent magnetic latching contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
Permanent magnetic latching, power on in rush, power off sealed, power on release. For conditions require voltage shock prevention energy saving, noise free and no-power sealed contactors.
Applications
Rated operational current A
Rated operational voltage V
Number of contacts(N/O)
Rated operational power KW AC-33,4Poles
(SCPD)Short-circuit protection by fuse
Optional parts
Type of product
Weight (kg)
Product No.
Ie max AC-3(Ue≤440V)
Ie max AC-1(θ≤40°C)
Max
220V/240V
380V/400V
415V
500V
660V/690V
1000V
440V
Model
Rated current
3Pole
4Pole
2Pole
115
200
1000
3 or 4
30
55
595975
80
65
RT16-2
200
GCR1-F115
3.6
0100
150
250
1000
3 or 4
40
75
808090
100
65
RT16-2
250
GCR1-F150
3.7
0101
185
275
1000
3 or 4
55
90
100100110
120
100
RT16-3
315
GCR1-F185
4.6
0102
0109 0110 0111
225
315
1000
3 or 4
63
100
110110129
140
100
RT16-3
315
GCR1-F225
4.7
0103
0112
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSR
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
34
Magnetic Contactor
GCR1-F Permanent magnetic latching contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
Applications
265
350
1000
3 or 4
75
132
140140
160
180
147
RT16-3
400
GCR1-F265
7.1
0104
0113
330
400
1000
2, 3 or 4
100
160
180180
200
220
160
RT16-4
500
GCR1-F330
8.5
0105
0114
0118
400
500
1000
2, 3 or 4
110
200
220220
257
280
185
RT16-4
500
GCR1-F400
8.5
0106
0115
500
700
1000
2, 3 or 4
147
250
280280
335
355
335
RT16-4
500
GCR1-F500
10.8
0107
0116
630
900
1000
2, 3 or 4
200
335
375375
400
450
425
RT16
630
GCR1-F630
17.4
0108
0117
01210119 0120
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSR
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
35
Magnetic Contactor
GCR1-F Permanent magnetic latching contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
Scheme drawing
SB1 contactors operation button SB2 contactors drop-out button
Wiring diagram
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
36
Magnetic Contactor
GLC1-F, GLC1-D, GCR1-F Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
DimensionsGLC1-F, GLC1-D, GCR1-F-330
GLC1-F, GLC1-D, GCR1-F-400~500
GLC1-D Contactor is not included
f: Minimum distance for extracting the coil; x1:Arc distance.
GLC1-F GLC1-D, GCR1-F
GLC1-F GLC1-D, GCR1-F
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
37
Magnetic Contactor
GLC1-F, GLC1-D, GCR1-F Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
DimensionsGLC1-F, GLC1-D, GCR1-F-620~800
GLC1-F780
GLC1-F GLC1-D, GCR1-F
GLC1-F
f: Minimum distance for extracting the coil; x1:Arc distance.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
38
Magnetic Contactor
GLC1-F, GLC1-D, GCR1-F Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
GLC1-D115~170
Dimensions
GLC1-D115~170 Ns\Zs\Ls horizontal mounting
GLC1-D
1) With terminal covers (default)
GLC1-D
1) With terminal covers (default)Interlock contactors are mounted on fitting bars when delivering.(Details please refer to “Interlock contactors-components”)
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
39
Magnetic Contactor
GLC1-F, GLC1-D Interlock Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
DimensionsGLC1-F, GLC1-D, GCR1-F 115~330 Ns\Zs\Ls Horizontally mounting
GLC1-F, GLC1-D, GCR1-F 400~500 Ns\Zs\Ls Horizontally mounting
GLC1-D Contactor is not included
f: Minimum distance for extracting the coil. X1:Arc distanceInterlock contactors are mounted on fitting bars when delivering.(Details please refer to “Interlock contactors-components”)
GLC1-F GLC1-D
GLC1-F GLC1-D
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
40
Magnetic Contactor
GLC1-F, GLC1-D Interlock Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
DimensionsGLC1-F, GLC1-D620~800 Ns\Zs\Ls Horizontally mounting
GLC1-F, GLC1-D 115~330Lc Vertical mounting
GLC1-F GLC1-D
GLC1-F GLC1-D
f: Minimum distance for extracting the coil. X1:Arc distanceInterlock contactors are mounted on fitting bars when delivering.(Details please refer to “Interlock contactors-components”)GLC1-D is not included
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
41
Magnetic Contactor
GLC1-F, GLC1-D Interlock Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
DimensionsGLC1-F, GLC1-D 400~500Lc Vertical mounting
GLC1-F, GLC1-D 620~800Lc Vertical mounting
GLC1-F
GLC1-F
f: Minimum distance for extracting the coil. X1:Arc distanceInterlock contactors are mounted on fitting bars when delivering.(Details please refer to “Interlock contactors-components”)GLC1-D is not included
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
42
Magnetic Contactor
GLC1-F, GLC1-D Interlock Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
DimensionsGLC1-F780Lc Vertical mounting
GLC1-Ys Vertical mounting
G1: Refer to dimensions of GLC1-F7804
f: Minimum distance for extracting the coil. X1:Arc distanceInterlock contactors are mounted on fitting bars when delivering.(Details please refer to “Interlock contactors-components”)
GLC1-F
GLC1-F
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
43
Magnetic Contactor
GLC1-F, GLC1-D, GCR1-F Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
MountingGLC1-F, GLC1-D, GCR1-F 115-800, 1154-6304
1) GLC1-D is not included 2) 115-3304 could be mounted with three screws.3) f: is the minimum distance of coil extraction when mounting on busbars, other specifications and dimensions along with mounting dimensions on plates refer for to dimensions for interlock contactors.
GLC1-D,CJ19 115-170
GLC1-FGLC1-D, GCR1-F
GLC1-D,CJ19
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
44
Magnetic Contactor
GLC1-F, GLC1-D Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
GLC1-F, GLC1-D Ns\Zs\Ls Interlock contactors horizontal mounting
Longer fitting bars could be mounted when delivering by demand.(no longer than 1000mm)
GLC1-F, GLC1-D
Mounting
1): GLC1-D is not included 2): 115-3304 could be mounted with three screws.3): f is the minimum distance of coil extraction when mounting on busbars, other specifications and dimensions along with mounting dimesions on plates refer to dimensions for interlock contactors. Mounting on fitting bars: Interlock contactors are ounted on fitting bars when delivering (except GLC1-D115-170) users can mount as a whole, however is not part of contactors.
GLC1-F, GLC1-D115...245L N Z s
GLC1-F, GLC1-D 620~800, 4754, 5004 L N Z s
GLC1-F, GLC1-D 620~800, 4754, 5004 L N Z s
GLC1-F, GLC1-D265...330, GLC1-F1154...1504GLC1-F, GLC1-D1854-2454 L N Z s
GLC1-F, GLC1-D400...500, 2654~3304 L N Z sGLC1-F, GLC1-D14004, 4104L N Z s
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
45
Magnetic Contactor
GLC1-F, GLC1-D, GCR1-F Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
MountingGLC1-F-Y Contactors sets horizontal mounting
GLC1-F-Y
1): GLC1-F115...330, 1154...3304 Y star delta contactors could be mounted with three screws.2): f is the minimum distance of coil extraction when mounting on busbars, other specifications and dimensions along with mounting dimesions on plates refer to dimensions for interlock contactors. Mounting on fitting bars: Star delta contactors are mounted on fitting bars when delivering, users can mount as a whole, however it is not part of contactors.
Longer fitting bars could be mounted when delivering by demand.(no longer than 1000mm)
GLC1-F115...225Y
GLC1-F265...330YGLC1-F400...500Y
GLC1-F630Y
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
46
Magnetic Contactor
GLC1-F, GLC1-D, GCR1-F Contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
Mounting
GLC1-D 115~170 Ns\Zs\Ls Interlock contactors horizontal mounting
GLC1-D
Contactors are fixed on two fitting bars (ZDJGT01) when delivery, users can mount can mount as a whole. When mounting on 15mm rail bars. fitting bars ZDJGT02 (by demand) should be applied.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
47
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
In circuit of AC 50/60Hz, voltage up to 1000V, Current up to 3200A, controlling motors of resistance, Non inductive, slightly inductive loads, distribution circuit.
Applications
Rated operational current A
Rated operational voltage V
Number of contacts(N/O)
Rated operational power KW AC-33,4Poles
(SCPD)Short-circuit protection by fuse Type-2
Optional parts
Type of product
Weight (kg)
Product No.
Ie max AC-1(Ue≤380V)
Ith θ≤40°C(Ue≤380V)
Max
220V/240V
380V/400V
415V
500V
660V/690V
1000V
440V
Model
Rated current
3Pole
4Pole
2Pole
700
700
1000
2,3
240
420
470470520
685
1035
RGS-3
1100
CJX2R-700
8.9
0141
850
850
1000
2,3
295
510
570570630
830
1260
RGS-3
1100
CJX2R-850
11.7
0142
1050
1050
1000
2,3
360
630
700700780
1030
1550
RGS-3
1100
CJX2R-1050
17.3
0143
1300
1300
1000
2,3
450
780
870870960
1270
1920
RGS-3
1500
CJX2R-1300
18.6
0144
0146 0147 0148 0149
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSRProtection from dust/moist: LADX
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
48
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Applications
1450
1450
1000
2, 3
500
870
980980
1080
1430
2150
RSG-3
1500
CJX2R-1450
26.7
0127
1700
1700
1000
2, 3
585
1000
11501150
1250
1650
2500
RSG-5
2000
CJX2R-1700
27.7
0128
2100
2100
1000
2, 3
730
1250
14001400
1550
2050
3100
RSG-5
2300
CJX2R-2100
28.7
0129
2600
2600
1000
2, 3
870
1500
16901690
1860
2460
3720
RSG-6
2800
CJX2R-2600
32.2
0130
3200
3200
1000
2, 3
1090
1890
21202120
2350
3100
4690
RSG-6
3200
CJX2R-3200
51
0131
0135 0136 0137 0138 0139
Auxiliary contact blocks: GTCF3 Air time delay auxiliary contacts: GTCST, GTCSR,Protection from dust/moist: LADX
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
49
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Type of product
Characteristics
CJX2R-700
2, 3
700
700
1050 1275 1575
1000
16-200
Marking current 1.5X I (AC-1)
4200
3360
2100
1680
1260
0.17
85
250x5
ϕ1-12
58
1000
16-200
5100
4080
2550
2040
1530
0.14
100
260x5
ϕ1-12
58
1000
16-200
6300
5040
3150
2520
1890
0.12
120
280x5
ϕ3-12
58
1000
16-200
7800
6240
3900
3120
2340
0.096
150
2100x5
ϕ3-12
58
850
850
1050 1300
1050 1300
1950
AAV
Hz
A
A
A
A
A
A
A
A
N.m
mΩ
w
2, 3 2, 3 2, 3
CJX2R-850 CJX2R-1050 CJX2R-1300
Number of poles
Rated operational current (Ie)Ue≤400V
Rated operational voltage
Frequency limits
Conventional thermal current
Marking capacity
Breaking capacity I rms
Short time rating from cold state, no current in previous 60 mins θ≤40°C
Average impedance per pole
Power dissipation per pole for the above operational currents
Cabling
Tightening torque Cable connetion
In AC-1 θ≤55°C
In AC-1 θ≤40°C
10 Secs
30 Secs
1 Min
3 Min
10 Min
Ith 50Hz
Bolt diameter
AC-1
θ≤40°C
Frequency under operating current (I)
Irms conforming to GB14048.4
Irms conforming to GB14048.4
Max.
The maximum cross-sec-tional area number of cables dimension of cables
mm²
mm²
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
50
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
CJX2R-1450
2, 3
1450
1000
16-2001450
Marking current 1.5X I (AC-1)
9000
6800
4900
3700
2700
0.083
175
2100X5 100X5 100X5 100X10 100X10
ϕ4-12
58
CJX2R-1700
2, 3 2, 3 2, 3 2, 3
1700
1000
16-2001700
10000
7500
5500
4200
3000
0.071
205
3
ϕ4-12
58
CJX2R-2100
2100
1000
16-2002100
3600
8500
6400
4800
3600
0.057
250
4
ϕ4-12
58
CJX2R-2600
2600
1000
16-2002600
4200
9950
7700
5800
4260
0.046
310
3
ϕ4-12
58
CJX2R-3200
3200
1000
16-2003200
2175 2550 3150 3900 4800
5050
11000
8950
6900
5100
0.037
380
3
ϕ4-12
58
Characteristics
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
51
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics
Type of product (Conforming to standards IEC60947) CJX2R-700 CJX2R-850 CJX2R-1050 CJX2R-1300
1000 1000 1000 1000
8 8 8 81000 1000 1000 1000
Environment Rate insulation voltage (Ui)
Rated impulse withstand voltage (Uimp)
Rated operational voltage (Ue) maxOperational current frequency rangeConforming to standards IEC60947, GB14048, EN60947
-60...+80°C
-5...+55°C
-40...+70°C
20003000
6gn 9gn 6gn 6gn
15gn 15gn 15gn 15gn1.5gn 2gn 2gn 2gn5gn 4gn 4gn 4gn
Maximum relative humidity less than 50% below 40°C, Maximum relative humidity less than 90% below 20°C
Ambient air temperatureStorage
Operation
Permissible for operation
Operating altitude allowed
Contactor opens
Contactor closes
Contactor opens
Contactor closes
Main circuit
Pollution degree III
IP00
IP20 Avoid direct contact with the fingerCoil terminals
600
0.85-1.1Uc
0.2-0.75Uc
0.1-0.75Uc
1150 1150 1730 1730
1920
18 20 25
1140 1220 19207.5 8 12.5
25
12.5
3 3 3 3operating cycles 10
AC
DC
50/60Hz Please dpecify control voltage when placing orders,default voltage is 220V.
Operation voltage V
V
V
VA
VA
W
W
V
V
ms
ms
ms
V
Cycles/h
6
Drop-out voltage (AC)
Drop-out voltage (DC)
Inrush (AC)
Sealed (AC)
Inrush (DC)
Closing
opening (AC)
opening (DC)
Sealed (DC)
Maximum operating altitude
Humidity
Impact resistance capability1/2 sine wave=11ms
5...150Hz anti-seismic performanceanti-seismic performance
Degree of protection
Rated control voltage
Operating time
Mechanical cruability (under Uc)
Operating frequency
Operating positions Without derating 30 In relation to normal mounting plane
110...660V
110...500V
40...75100...170
45...60
Control circuit characteristicsRated control voltage (Uc)
Control voltage limits (AC)θ≤55°C
Average power 50Hz
V
KV
VHz
°C°C
°C
m
m
16-200
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
52
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics
CJX2R-1450 CJX2R-1700
1000 1000
8 81000 1000
IEC60947, GB14048, EN60947-60...+80°C
-5...+55°C
-40...+70°C
20003000
6gn 6gn
15gn 15gn2gn 2gn4gn 4gnPollution degree III
IP00
IP20 Avoid direct contact with the finger
0.85-1.1Uc
0.2-0.75Uc
0.1-0.75Uc2200
2200
40
16
3
25-400
CJX2R-2100 CJX2R-2600
1000 1000
8 81000 1000
6gn 6gn
15gn 15gn2gn 2gn4gn 4gn
CJX2R-3200
1000
81000
6gn
15gn2gn4gn
2200
2200
40
16
3
2200
2200
40
16
3
3000
3000
50
20
2
3000
3000
50
20
2
600
30 In relation to normal mounting plane
110...660V
110...500V
40...75
100...170
45...60
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
53
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Scheme drawing
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
54
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Note:1.Vertical interlock CJX2R contactors are for interlock only, different from normal CJX2R contactors.2.Contactors center-to-center distance is 580mm
Three pole interlocked contactors (vertical mounting)
Contactors Ratedoperationalcurrent AC-1
Serialnumber
CJX2R 220V 380V 660V without bar with bar without bar1000Lc 1000 350 600 980 41 50 04751250Lc 1250 430 750 1230 43 54 04761450Lc 1450 500 870 1430 55 68 04771700Lc 1700 585 1000 1650 59 74 04782100Lc 2100 730 1250 2050 63 80 04792600Lc 2600 870 1500 2460 83 106 04803200Lc 3200 1090 1890 3100 103 138 0481
Maximum operational powerAC-1 3phases W
Weight (kg)
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
55
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Dimensions
Note: 1. Components are set to have center to center distance of 580mm by default.2. Optional default components have center-to-center distance of 580mm.3. Not part of products, supply along with products, need to be installed by users. Contactors could be fixed on two vertical. fitting bars (1000-2100Lc) or three vertical fitting bars (2600-3200Lc) or four horizontal fitting bars before final installation. or contactors could be fixed directly on fitting rack without fitting bars.
Product model contactors
CJX2R CJX2R interlockVertical fittingbar
Horizontal fittingbar
1000Lc 1000Lc 2pcs GRJSA GRDL10088 GTJG9743 GTJG97341250Lc 1250Lc 2pcs GRJSA GRDL12588 GTJG9743 GTJG97341450Lc 1450Lc 2pcs GRJSA GRDL14588 GTJG9743 GTJG97341700Lc 1700Lc 2pcs GRJSA GRDL17088 GTJG9743 GTJG97342100Lc 2100Lc 2pcs GRJSA GRDL21088 GTJG9743 GTJG97342600Lc 2600Lc 2pcs GRJSA GRDL26088 GTJG9767 GTJG97363200Lc 3200Lc 2pcs GRJSA GRDL32088 GTJG9767 GTJG9736
Fitting model
Interlock modelMounting bar
model
CJX2R-700, 850
CJX2R
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
56
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
Dimensions
CJX2R
CJX2R
CJX2R-1050, 1300
CJX2R-1450, 2600
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
57
Magnetic Contactor
CJX2R Contactors from 700A to 3200A
Tel: +86 577 62776000 Fax: +86 577 62776006
CJX2R 1000-3200 Lc Vertical mounting
CJX2R
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
58
Magnetic Contactor
CJX2B Contactors from 750A to 1800A
Tel: +86 577 62776000 Fax: +86 577 62776006
In circuit of AC 50/60Hz, voltage up to 1000V, Current up to 1800A, large capacity motor control, specially for large equipment as hoisting, construction, metallurgy etc.
Applications
Ie AC3 (Ue 380V) 750 1000 1500 1800
Ie AC1 (Ue 380V) 800 1250 2000 2750Rated ratedoperational voltage V Max 1000 1000 1000 1000
1,2,3,4 1,2,3,4 1,2,3,4 1,2,3,4
220/240V 220 280 425 500
380/400V 400 500 750 900
440V 450 560 800 900
500V 500 600 800 900
660/690V 560 620 750 900
1000V 530 580 670 750
220/240V 90 110 150 200
380/400V 160 160 220 250
440V 160 200 250 315
500V 180 200 250 355
660/690V 200 250 315 450
Model RSG-3 RSG-3 RSG-5 RSG-5
Specs 1250 1600 2000 2500
Auxiliary parts
CJX2B-750 CJX2B-1000 CJX2B-1500 CJX2B-1800
56 58 94 129
3P 0150 0154 0158/0159(S)** 0163/0164(S)**
1P 0151 0155 0160 0165
2P 0152 0156 0161 0166
4P 0153 0157 0162 0167
AC3 25A 6N/O or 4N/O 2N/C Two auxiliary contacts could be add on:Instantaneous contact: GTCF3;Time delay contact: GTCST, GTCSR;Dust and humidity proof: LADX
Product Type
Weight (3P) kg
Number of poles
Rated operationalcurrent A
Rated operationalpower KW 3-Phasesquirrel cage motor
40°C AC3 50Hz
Rated operationalpower KW 3-Phasesquirrel cage motor
40°C AC4 50Hz
Short circuitprotection by fuseType 2
Product No.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
59
Magnetic Contactor
CJX2B Contactors from 750A to 1800A
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics
Product Type CJX2B-750 CJX2B-1000 CJX2B-1500 CJX2B-1800
AC3 A 750 1000 1500 1800
AC4 A 700 800 1200 1450Rated operationalvoltage (Ue) Max. V 1000 1000 1000 1000
Frequency limitsof the operationalcurrent Hz
Conventionalthermal current 40°C A 800 1250 2000 2750
Making capacity I rms A 10000 10000 15000 18000
Breaking capacity GB14048.4 A
10/secs A 7000 8000 12000 14400
30/secs A 4600 5300 7900 9500
1/mins A 3600 4100 6100 7400
3/mins A 2500 2800 4100 5000
10/mins A 1900 2200 3250 3900
1 1 2 3
m 0.18 0.18 0.13 0.09
AC3 W 100 180 290 300
AC1 W 115 280 520 680
Number of bars 2 2 3 3
Dimension of bars mm 60x5 100x5 100x5 100x10
Bolt diameter Number mm 4-8 4-10 4-10 4-10
Tightening torque N.m 21 35 35 35
Power dissipationper pole for theabove operationalcurrents
Cabling
Making and breaking current: 10xIe
Without derating: 50/60Hz Derating coefficient:100Hz:0.9; 150Hz:0.8; 250Hz:0.7; 400Hz:0.5
Pole characteristicsRated operationalcurrent Ie Ue 400V
Short time ratingFrom cold state,
40°C
Number of paralleling contacts per pole
Average impedance per pole 50Hz
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
60
Magnetic Contactor
CJX2B Contactors from 750A to 1800A
Tel: +86 577 62776000 Fax: +86 577 62776006
CharacteristicsCJX2B-750 CJX2B-1000 CJX2B-1500 CJX2B-1800
V 1000 1000 1000 1000kV 8 8 8 8V 1000 1000 1000 1000Hz 25 400 25 400 25 400 25 400
Storage °C -60 +80 -60 +80 -60 +80 -60 +80Operation °C -5 +55 -5 +55 -5 +55 -5 +55Permissible foroperation(derating) °C -40 +60 -40 +60 -40 +60 -40 +60
m 2000 2000 2000 2000Maximum altitudefor no derating m 3000 3000 3000 3000StandardSpecial TH TH TH THEco-friendly RoHs RoHs RoHs RoHs
HumidityDegree of pollution
main circuitCoil terminalsAuxiliary contact
Operating positions Without deratingAC V 110...660 110...660 110...660 110...660
DCV 110 500 110 500 110 500 110 500
Operation voltage V 0.85-1.1Uc 0.85-1.1Uc 0.85-1.1Uc 0.85-1.1UcDrop-outvoltage(AC) V 0.2-0.75Uc 0.2-0.75Uc 0.2-0.75Uc 0.2-0.75UcDrop-outvoltage(DC) V 0.1-0.75Uc 0.1-0.75Uc 0.1-0.75Uc 0.1-0.75UcInrush (AC) VA 1200-2400 1200-2400 1200-2400 1200-2400Sealed (AC) VA 30-50 30-50 30-50 30-50Inrush (DC) W 1200-2400 1200-2400 1200-2400 1200-2400Sealed (DC) W 30-50 30-50 30-50 30-50Closing ms 100 150 100 150 100 150 100 150Opening (AC) ms 50 100 50 100 50 100 50 100Opening (DC) ms 20 40 20 40 20 40 20 40
10 1 1 1 1Cycles/h 120 120 120 120
Product Type
Averageconsumption
Rated insulation voltage (Ui)Rated impulse withstand voltage (Uimp)Rated operational voltage (Ue) maxOperational current frequency rangeConforming to standards
Ambient airtemperature
In relation to normal mounting plane
Operating time
Mechanical durability (under Uc)Operating cyclesOperating frequency
GB14048, IEC60947, EN60947
Maximum relative humidity less than 50% below 40°CMaximum relative humidity less than 90% below 20°CPollution degree IIIIP00Avoid direct contact with the fingerAvoid direct contact with the finger
Maximum operatingaltitude
Protective treatment
Degree of protection
Control circuitcharacteristicsRated controlvoltage
Control voltagelimits ( 55°C)
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
61
Magnetic Contactor
CJX2B Contactors from 750A to 1800A
Tel: +86 577 62776000 Fax: +86 577 62776006
Scheme
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
62
Magnetic Contactor
CJX2B Contactors from 750A to 1800A
Tel: +86 577 62776000 Fax: +86 577 62776006
Interlocked contactors CJX2B...Lc Contactors
CJX2B
Note: 1) CJX2B Contactors for vertically mounted interlocking are conventional CJX2B contactors. 2) Default contactor center-to-center distance is 600mm.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
63
Magnetic Contactor
CJX2B Contactors from 750A to 1800A
Tel: +86 577 62776000 Fax: +86 577 62776006
Dimensions
CJX2B750~1800
S type could be provided:specification is 30mm
CJX2B
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
64
Magnetic Contactor
CJX2B Contactors from 750A to 1800A
Tel: +86 577 62776000 Fax: +86 577 62776006
CJX2B-750~1800Lc Vertical mounting
CJX2B
Items with specifications of 30mm could be provided Dimensions of a1,a2,Q1,Q2,M,N,W,X1,X2refer to dimensions of CJX2B****4
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
65
Magnetic Contactor
Electrical durability
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics Curve
GLC
1-D
115
GLC
1-D
150
GLC
1-F1
15
GLC
1-F1
50
GLC
1-F1
85
GLC
1-F2
25
GLC
1-F2
65
GLC
1-F3
30
GLC
1-F4
00
GLC
1-F5
00
GLC
1-F6
30
GLC
1-F8
00
CJX
2B-7
50
CJX
2B-1
000
CJX
2B-1
500
CJX
2B-1
800
GLC
1-F7
80
GLC
1-D
115
GLC
1-D
150
GLC
1-F1
15
GLC
1-F1
50
GLC
1-F1
85
GLC
1-F2
25
GLC
1-F2
65
GLC
1-F3
30G
LC1-
F400
GLC
1-F5
00
GLC
1-F6
30G
LC1-
F800
CJX
2B-7
50
CJX
2B-1
000
CJX
2B-1
500
CJX
2B-1
800
GLC
1-F7
80
CJX
2R-1
000
CJX
2R-1
250
CJX
2R-1
450
CJX
2R-1
700
CJX
2R-2
100
Operating current of contactors should not be higher than rated thermal current.Breaking current:AC1: Non-inductive or slightly inductive loads. Breaking current equals rated operating current (Ie)AC2: Starting of slip-ring motors, breaking current equals 2.5 times of rated operating current (2.5Ie)AC3: Breaking current is the rated operating current Ie of three-phase squirrel-cage motors.AC4: Breaking current is the start current of three-phase squirrel-cage motors, six times of rated operating current (6Ie)Information of electrical durability of GLC1-R refer to GLC1-F…s, GLC1-D…s refer to GLC1-F contactors with similar specifications.These characteristic curves are for selection guild only, not as receiving inspection standard. Inspection standard is provided before delivery.
Greegoo Electric Co.,LtdAdd:No.6 Floor,Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
66
Magnetic Contactor
GLC1-F-Y Star delta contactors
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics CurveStar delta contactors with time relay, thermal relay and control circuit form star-delta starters.
Maximum operating frequency: GLC1-F115Y...400Y 12cycles/h, GLC1-F 500Y...630Y 8 cycles/h Maximum starting time: 20 Secs.
Starting current of star connection is around 1.8-2.6 times of motor rated current.Starting torque of star connection is 1/3 of delta direct starting torque, i.e. 50% of rated torque.Starting connection of motor is star connection, operating connection is delta connection. When starting, motor shifts from star connection to deltaconnection when rotate speed reaches 80% of rated rotate speed.Starting rated current of star-delta motor is the rated current of delta connection, maximum control motor power is the control power of delta connection;the category of star-delta motor starting load is AC3.
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
67
Magnetic Contactor
CJ19 Contactors from 115A to 170A
Tel: +86 577 62776000 Fax: +86 577 62776006
ApplicationsFor making and breaking power capacitors. In power systems of AC 50/60Hz, rated voltage up to 400V, current up to 170A, for automatic compensation of reactive power and power factor improvement.
400V 60 80 90230V 30 40 45
Capacity of the controlled capacitor C Mf µF 1200 1600 1800AC-6b 87 115 130AC3 1) 115 150 170
200 200 20020Ie 20Ie 20Ie
400 400 4003 3 3
220/240V 30 40 55380/400V 55 75 90Model RT16-1 RT16-1 RT16-1Specs 160 200 200
CJ19-115 CJ19-150 CJ19-1702.3 2.3 2.3
Controllable capacity Kvar Qe
1N/O.two auxiliary contacts could be add on
Conventional thermal current A Ith =40°Climit inrush current capacity (peak) IMaximum rated operational voltage VNumber of poles
Auxiliary contactContactors typeWeight kg
Rated operational current In A (Ue 400V)
Rated operationall power 3-phasesquirrel cagemotor
Short-circuit protection by fuse Type 2
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
68
Magnetic Contactor
CJ19 Contactors from 115A to 170A
Tel: +86 577 62776000 Fax: +86 577 62776006
Characteristics
Contactors CJ19-115 CJ19-150 CJ19-170
AC-6b A 87 115 130
AC3 A 115 150 170Rated operationalvoltage (Ue)
Max. V 400 400 400
Frequency limits of the operationalcurrent
Hz
Conventional thermalcurrent
=40°C A 200 200 200
Making capacity A
Breaking capacity A
10/Secs A 950 1200 1200
30/Secs A 720 820 820
1/Min A 550 580 580
3/Min A 340 350 350
10/Min A 250 250 250Average impedance perpole
50Hz m 0.6 0.6 0.6
AC-6b W 4.5 7.9 10
AC3 W 7.9 13.5 17.5
AC1 W 24 24 24
Number of bars 2 2 3
Dimensions of bars mm 18X3 18X3 18X3
Cable mm 120 120 120
Bolt diameter mm 8 8 8
Tightening torque N.M 18 18 18
Without derating:50/60 Derating coefficient:100Hz:0.9;150Hz:0.8;250Hz:0.7;400Hz:0.5
AC3 10Ie, AC-6b 60Ie (peak)
Making and breaking current:8XIe
Rated operational current(Ue 400V)
I rms conforming toGB14048.4
Short time rating Fromcold state =40°C
Power dissipation perpole for the aboveoperational currents
Cabling2
2
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
69
Magnetic Contactor
CJ19 Contactors from 115A to 170A
Tel: +86 577 62776000 Fax: +86 577 62776006
CJ19-115 CJ19-150 CJ19-170V 690 690 690kV 8 8 8V 400 400 400Hz 25 400 25 400 25 400
Storage °C -60 +80 -60 +80 -60 +80Operation °C -5 +55 -5 +55 -5 +55Permissible foroperation(derating) °C -40 +60 -40 +60 -40 +60
m 2000 2000 2000Maximum altitudefor no derating m 3000 3000 3000StandardSpecial TH TH THEco-friendly RoHs RoHs RoHs
HumidityDegree of pollution
main circuit
Coil terminalsAuxiliary contact
Operating positions Without deratingControl circuitcharacteristics Ratedcontrol voltage
AC V
Operation voltage V 0.85-1.1Uc 0.85-1.1Uc 0.85-1.1UcDrop-outvoltage(AC) V 0.2-0.75Uc 0.2-0.75Uc 0.2-0.75UcInrush (AC) VA 450 450 450Sealed (AC) VA 22 22 22Closing ms 100 150 100 150 100 150Opening (AC) ms 50 100 50 100 50 100
10 Operatingcycles 20 20 20
Electric life(AC-6b) 2 2 2Cycles/h 120 120 120
Maximum relative humidity less than 90%below 20°C
Product TypeRated insulation voltage (Ui)Rated impulse withstand voltage (Uimp)Rated operational voltage (Ue) maxOperational current frequency rangeConforming to standards GB14048, IEC60947, EN60947
Ambient air temperature
Maximum operatingaltitude
Protective treatment
Maximum relative humidity less than 50%below 40°C
Operating frequency
Degree of protection
Pollution degree III
Avoid direct contact with the finger (installterminal protection cap)Avoid direct contact with the finger IP20Avoid direct contact with the finger IP20In relation to normal mounting plane ±30°
24, 48, 110, 127, 220, 380
10 Operating cycles
Control voltage limits (55°C)
Average consumption
Operating time
Mechanical durability (under Uc) Operatingcycles
Characteristics
2
2
Greegoo Electric Co.,LtdAdd:Jinye Mansion, Lvzhuang, Liushi, Yueqing, Zhejiang, 325604 P.R. China
moc.oogeerg@retep :liam-E moc.oogeerg.www//:egapemoH
70
Magnetic Contactor
CJ19 Contactors from 115A to 170A
Tel: +86 577 62776000 Fax: +86 577 62776006
Contactor scheme
Precharge contact
Auxiliary contactContactor body
Resistor line
Terminal cover
Control circuit terminal
top related