Hallmark Southwest Corporation The Home of Craftsmanship Building Manufactured Homes Since 1977 at Manufacturing Facility in Loma Linda, CA. Hallmark Southwest.

Hallmark Southwest Corporation

“The Home of Craftsmanship”

Building Manufactured Homes Since 1977 at Manufacturing Facility in Loma Linda, CA.Hallmark Southwest Corp. is an Employee Owned Company and each of it’s Employee’s Take Pride in Building the Highest Quality Home Possible for it’s Home Owners.

Hallmark Southwest Corp. Loma Linda, CA.

Building a Solid Constructed Home beginswith a Solid Foundation. 12” I-Beam Frame

2” x 6” Floor Joists on 16” On Center with 2” x 6” Cross Buck Full Length of home, R-22 Insulation in Floor

Residential Flex Insulated Ducts Providing Efficient Heating and Cooling Throughout Entire Home

5/8” Hambro Cresdek Decking. Each Sheet is Full Width of the Floor to Minimize Joints in Decking

Electrical Wiring Installed in Floor to Allow Easy Access from Under the Home

2” x 6” Exterior Wall Construction with Vapor Barrier

Drywall Glued and Screwed to Wall Studs

2” x 4” Interior Walls with Stud Grade Lumber or better

CPVC Hard Plastic Plumbing

2” x 6” Exterior Wall Construction with R-19 Insulation: Note the Straightness of the Floor as a result of Solid Foundation

Taping of Electrical Receptacle and Squaring of Window

Use of Squares to Assure windows built Square

Roof is Built with Rafters 16” On Center. Strong Enough to Allow Workers to Walk on Ceilings

Ceiling Drywall Screwed to Rafters

R-38 Blown-In Insulation for Maximum Insulation Value and No Gaps in Insulation at Rafters

2” x 6” Top Plate with Beveled Rafter at Side Wall to Allow Wood To Wood Connection

Home is Set Up on Production Line To Assure Marriage of Two Halves

Eave Construction with 2” x 6” Lumber

Interior Drywall Finish Done Inside Factory

All Interior Drywall Completed Inside Factory Before Cabinets Installed

Vinyl Low ‘E’ Windows

Colonist Doors installed with Three Mortised Heavy Duty Stanley Hinges

Oak Material for Making Cabinets

Oak Face Framed Material with Dowel Pins

Glued Oak Face Frames with Dowel Pins

Oak Face Frames Glued and Clamped

Oak Face Frames in Power Belt Sander

Belt Sanded and Then Hand Sanded Cabinets

Oak Cabinet Door Framing

Oak Cabinet Door Before Staining

Natural Finish On Oak Cabinets

White Wash Stained Cabinet Doors

Staining of Oak Trim for Cabinets and Recessed Lights

Construction of Kitchen Base Cabinet

Construction of Kitchen Base Cabinets

Recessed Face Frame to Allow Inside of Cabinets to Breath

Lazy Susan Built into Base Cabinet

Finished Kitchen Base Cabinet with Recessed Area Below Kitchen Sink

Bull Nosed and Coved Kitchen Counter Tops

Detailing of Home and Installing of Cabinets

System Check of Water, Gas, Drain Lines and Electrical

Home in Yard Ready For Shipment Note Straightness of Floor