AVR9900_HTR9900_Eur_sm_3139-785-34871_d1_2009-5-25

Published by AN-KC 0920 AV System Printed in the Netherlands Subject to modifcation EN 3139 785 34871AVR9900/12 & HTR9900/12 HD AV Receiver System1 Technical Specifcations and Connection Facilities LocationofPCBoards 2 Technical Specifcations 32 Measurements Setup, General Notes & Safety Information 5 Lead Free Requirement 83 Directions For Use 94 Mechanical Disassembly Instructions 115 Upgrade Program Installation & Firmware Upgrading 14 Default setting (or Reset) 216 Block Diagram and Wiring Diagram Main Unit Block Diagram 22 Main Unit Wiring Diagram 26 Subwoofer Block Diagram 277 Circuit Diagram and PWB Layout Main Unit - Front PCB Panel 28 Main Unit - MCU PCB 32 Main Unit - Input PCB 36 Main Unit - HDMI PCB 39 Main Unit - Amplifer PCB 45 Main Unit - Video PCB 49 Subwoofer -Amp. PCB 51Copyright 2009 Philips Consumer Electronics B.V. Eindhoven, The Netherlands.All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.Version 1.1Contents Page Contents Page8 Alignments & Trouble-shooting 549 IC Internal Block Diagram FrontPCBPanel 60 MCU Board 62 Input Board 76 HDMI Board 83 Video Board 12110 Exploded View & Spare Parts List Exploded View & Parts List 130 Electrical PCBA Parts List 13711 Revision List 147AVR9900 HTR9900EN 3139 785 34870 1. Technical Specifcations and Connection FacilitiesLocation Of PC BoardsHTR9900 Internal constructionTuner Module Video PCB HDMI PCBMCU PCBInput PCBHeatsinkAmplifier PCBFront Video PCB *Power PCB * Power TransVFD PCB * Phones & Optical PCB *STBY PCB *Front B PCB ** Belongs to Front PCB PanelMain Unit Internal constructionAmplifier PCB Assyw/Back PanelSubwoofer Internal ConstructionEN 3 339 785 34870 Technical Specifcations and Connection Facilities .1.2 Receiver Unit (AVR9900/12):1.2.1 General: Mains voltage : 230V, 50Hz Power consumption : 435W Standby Power consumption : < 1.8W Dimensions (W x H x D) : 435 x 167 x 394mm Set weight : 13.3kg1.2.2 Amplifer: Output Power (RMS) at 1kHz, 0.08% THD, 8: Stereo mode : 2 x 115W Surroung mode : 7 x 60WTHD at rated power : 0.08%Input sensitivity : 300mV / 47kFrequency response ( 0.5dB) : 20Hz 20kHzSignal to Noise ratio, A-weighted: : > 100dB (ref. rated power 8) > 90dB (ref. 1W 8)1.2.3 Tuner (AM Band, at ref. 990kHz):Tuning Range : 522 1620kHzUsable Sensitivity : 60dBSignal to Noise ratio : > 35dBTHD : < 2%Selectivity ( 10kHz) : > 18%IF Rejection (450kHz) : > 45dBImage Rejection : > 20dB1.2.4 Tuner (FM Band, at ref. 100.1MHz):Tuning Range : 87.5 108MHzUsable Sensitivity, Mono : 10dBfSignal to Noise ratio : > 60dBTHD : < 0.4% (Mono) 60dBImage Rejection : > 25dBChannel Separation : > 25dB1. TechnicalSpecifcationsandConnectionFacilities1.1 Matrix TableType/versionParts in UseAVR9900/12 HTR9900/12Main Unit X XSubwoofer Box - XTall-boy Speaker Box (Front & Surround) - XSatellite Speaker Box (Rear or Back) - XCenter Speaker Box - XX = in use1.2.5 Analog Inputs / Outputs:1.2.5.1 Audio/Video InputsAudio L/R CinchInput voltage : 220mV 50mVInput impedance : > 10k7.1 Channel Input CinchFront L/R Input : 220mV 50mV / 10kSurround L/R Input : 220mV 50mV / 10kSurround B (Rear) L/R Input : 220mV 50mV / 10kCenter Input : 220mV 30mV / 10kSubwoofer Input : 220mV 30mV / 10kComposite Video CinchInput voltage : 1Vpp 0.15VInput impedance : 75S-Video YC (Hosiden)Input voltage Y : 1Vpp 0.15VInput impedance Y : 75Input voltage C : 0.286Vpp 0.07VInput impedance C : 75Component Video CinchInput voltage : 1.0Vpp 0.15VInput impedance : 75EN 4 339 785 34870 . Technical Specifcations and Connection Facilities1.2.5.2 Audio/Video OutputsHeadphoneOutput voltage (at input = 220mV) : 1.5V 0.5VOutput impedance : 32 loadAudio L/R CinchOutput Voltage : 220mV 50mVOutput Impedance : > 10kAudio Pre-Out CinchFront L/R Output : 1.2V 0.5VSurround L/R Output 1.2V 0.5VSurround B (Rear) L/R Output : 1.2V 0.5VCenter Output : 1.2V 0.5VSubwoofer Output : 2.6V 0.5VComposite Video CinchOutput voltage : 1Vpp 0.15VOutput impedance : 75S-Video YC (Hosiden)Input voltage Y : 1Vpp 0.15VInput impedance Y : 75Input voltage C : 0.286Vpp 0.07VInput impedance C : 75Component Video CinchInput voltage (Y/Pb/Pr) : 1.0Vpp 0.15VInput impedance : 751.2.6 Digital Inputs / Outputs:1.2.6.1 Digital / Coaxial Output For connection to S/PDIF digital input of compatible Device1.2.7 HDMIHDMI 1 ~ 4 : For connection to External DevicesHDMI Monitor Out : For connection to HDTV1.3 7.1 Speaker System (HTR9900/12 additional portion):1.3.1 Active Subwoofer:Mains voltage : 220 - 240V, 50Hz Power consumption : 200W Standby Power consumption : < 0.8W (Normal) < 0.3W (Low standby) Input Sensitivity : 850mV Impedance : 4 8 cone woofer Frequency response : 27Hz 160Hz (Adjustable) Dimensions (W x H x D) : 345 x 468 x 370mm Set weight : 20.5kg1.3.2 Speakers:System : Full range satelliteSpeaker Impedance : 8Frequency response : 70Hz 20kHzSpeaker drivers: Tall-boy Speaker (Front & Surround) : 2 x 4 woofer + 1 tweeter Satellite Speaker (Surround Rear) : 2 x 4 woofer + 1 tweeter Center Speaker : 2 x 4 woofer + 1 tweeter Dimensions (W x H x D): Tall-boy Speaker (Front & Surround) : 177 x 1062 x 214mm Satellite Speaker (Surround Rear) : 177 x 456 x 214mm Center Speaker : 435 x 162 x 149mm Weight: Tall-boy Speaker (Front & Surround) : 15.9kg Satellite Speaker (Surround Rear) : 7.1kg Center Speaker : 5.3kgEN 3139 78 34870 Measurements Setup, General Notes & Safety Information 2.LF Generator e.g. PM5110RecorderUse Universal Test Cassette CrO2 SBC419 4822 397 30069LEVEL METERe.g. Sennheiser UPM550with FF-filterS/N and distortion metere.g. Sound Technology ST1700BLRDUTor Universal Test Cassette Fe SBC420 4822 397 30071LEVEL METERe.g. Sennheiser UPM550with FF-filterS/N and distortion metere.g. Sound Technology ST1700BLRDUTCDUse Audio Signal Disc(replaces test disc 3)SBC429 4822 397 30184Bandpass250Hz-15kHze.g. 7122 707 48001LF Voltmeter e.g. PM2534DUTS/N and distortion meter e.g. Sound Technology ST1700BFrame aeriale.g. 7122 707 89001Tuner AM (MW,LW)To avoid atmospheric interference all AM-measurements have to be carried out in a Faradays cage.Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).RF Generator e.g. PM5326Ri=50Bandpass250Hz-15kHze.g. 7122 707 48001LF Voltmeter e.g. PM2534DUTRF Generator e.g. PM5326S/N and distortion meter e.g. Sound Technology ST1700BUse a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).Ri=50Tuner FMMEASUREMENT SETUP2.MeasurementsSetup,GeneralNotes&SafetyInformationEN 3139 78 34870 2. Measurements Setup, General Notes & Safety InformationHANDLING CHIP COMPONENTSSERVICE AIDSService Tools:Universal Torx driver holder .................................. 4822 395 91019Torx bit T10 150mm ............................................. 4822 395 50456Torx driver set T6 - T20......................................... 4822 395 50145Torx driver T10 extended ...................................... 4822 395 50423Compact Disc:SBC426/426A Test disc 5 + 5A ............................ 4822 397 30096SBC442 Audio Burn-in Test disc 1kHz ................. 4822 397 30155SBC429 Audio Signals disc .................................. 4822 397 30184Dolby Pro-logic Test Disc ...................................... 4822 395 10216EN 7 3139 78 34870 Measurements Setup, General Notes & Safety Information 2.GB WARNINGAll ICs and many other semi-conductors aresusceptible to electrostatic discharges (ESD).Careless handling during repair can reduce lifedrastically.When repairing, make sure that you areconnected with the same potential as the massof the set via a wrist wrap with resistance.Keep components and tools also at thispotential.F ATTENTIONTous les IC et beaucoup dautressemi-conducteurs sont sensibles auxdcharges statiques (ESD).Leur longvit pourrait tre considrablementcourte par le fait quaucune prcaution nestprise leur manipulation.Lors de rparations, sassurer de bien tre reliau mme potentiel que la masse de lappareil etenfiler le bracelet serti dune rsistance descurit.Veiller ce que les composants ainsi que lesoutils que lon utilise soient galement cepotentiel.ESDD WARNUNGAlle ICs und viele andere Halbleiter sindempfindlich gegenber elektrostatischenEntladungen (ESD).Unsorgfltige Behandlung im Reparaturfall kandie Lebensdauer drastisch reduzieren.Veranlassen Sie, dass Sie im Reparaturfall berein Pulsarmband mit Widerstand verbundensind mit dem gleichen Potential wie die Massedes Gertes.Bauteile und Hilfsmittel auch auf dieses gleichePotential halten.NL WAARSCHUWINGAlle ICs en vele andere halfgeleiders zijngevoelig voor electrostatische ontladingen (ESD).Onzorgvuldig behandelen tijdens reparatie kande levensduur drastisch doen verminderen.Zorg ervoor dat u tijdens reparatie via eenpolsband met weerstand verbonden bent methetzelfde potentiaal als de massa van hetapparaat.Houd componenten en hulpmiddelen ook opditzelfde potentiaal.I AVVERTIMENTOTutti IC e parecchi semi-conduttori sonosensibili alle scariche statiche (ESD).La loro longevit potrebbe essere fortementeridatta in caso di non osservazione della pigrande cauzione alla loro manipolazione.Durante le riparazioni occorre quindi esserecollegato allo stesso potenziale che quello dellamassa dellapparecchio tramite un braccialettoa resistenza.Assicurarsi che i componenti e anche gli utensilicon quali si lavora siano anche a questopotenziale.GB ESD PROTECTION EQUIPMENT:Complete Kit ESD3 (small tablemat, wristband,connection box, extention cable and earth cable) ........... 4822 310 10671Wristband tester .................................................................... 4822 344 13999CLASS 1LASER PRODUCTGB Warning !Invisible laser radiation when open.Avoid direct exposure to beam.S Varning !Osynlig laserstrlning nr apparaten r ppnad och sprrenr urkopplad. Betrakta ej strlen.SF Varoitus !Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiinankymttmlle laseristeilylle. l katso steeseen!DK Advarse !Usynlig laserstrling ved bning nr sikkerhedsafbrydere erude af funktion. Undg udsaettelse for strling.F"Pour votre scurit, ces documents doivent tre utiliss pardes spcialistes agrs, seuls habilits rparer votreappareil en panne".GBSafety regulations require that the set be restored to its originalcondition and that parts which are identical with those specified,be usedSafety components are marked by the symbol !.NLVeiligheidsbepalingen vereisen, dat het apparaat bij reparatie inzijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,identiek aan de gespecificeerde, worden toegepast.De Veiligheidsonderdelen zijn aangeduid met het symbool !FLes normes de scurit exigent que lappareil soit remis ltatdorigine et que soient utiliss les pices de rechange identiques celles spcifies.Less composants de scurit sont marqus !DBei jeder Reparatur sind die geltenden Sicherheitsvorschriften zubeachten. Der Original zustand des Gerts darf nicht verndert werden;fr Reparaturen sind Original-Ersatzteile zu verwenden.Sicherheitsbauteile sind durch das Symbol ! markiert.I Le norme di sicurezza esigono che lapparecchio venga rimessonelle condizioni originali e che siano utilizzati i pezzi di ricambioidentici a quelli specificati.Componenty di sicurezza sono marcati con !GBAfter servicing and before returning set to customer perform a leakagecurrent measurement test from all exposed metal parts to earth ground toassure no shock hazard exist. The leakage current must not exceed0.5mA.EN 8 3139 78 34870 2. Measurements Setup, General Notes & Safety Information2.1 LeadFreeRequirementsPb(Lead)FreeSolderWhensoldering,besuretousethepbfreesolder.INDENTIFICATION:Regardless of special logo (not always indicated) one must treat all sets from1Jan2005 onwards, according next rules:Important note: In fact also products of year 2004 must be treated in this way as long as you avoid mixing solder-alloys (leaded/ lead-free). So best to always use SAC30 and the higher temperatures belong to this.Due to lead-free technology some rules have to be respected by the workshop during a repair: Use only lead-free solder alloy Philips SAC30 with order code 022 149 0010. If lead-free solder-paste is required, please contact the manufacturer of your solder-equipment. In general use of solder-paste within workshops should be avoided because paste is not easy to store and to handle. Use only adequate solder tools applicable for lead-free solder alloy. The solder tool must be able o To reach at least a solder-temperature of 400C, o To stabilize the adjusted temperature at the solder-tip o To exchange solder-tips for different applications. Adjust your solder tool so that a temperature around 30C 380C is reached and stabilized at the solder joint. Heating-time of the solder-joint should not exceed ~ 4 sec. Avoid temperatures above 400C otherwise wear-out of tips will rise drastically and fux-fuid will be destroyed. To avoid wear-out of tips switch off un-used equipment, or reduce heat. Mix of lead-free solder alloy / parts with leaded solder alloy / parts is possible but PHILIPS recommends strongly to avoid mixed solder alloy types (leaded and lead-free). If one cannot avoid or does not know whether product is lead-free, clean carefully the solder-joint from old solder alloy and re-solder with new solder alloy (SAC30). Use only original spare-parts listed in the Service-Manuals. Not listed standard-material (commodities) has to be purchased at external companies. Special information for BGA-ICs: - always use the 12nc-recognizable soldering temperature profle of the specifc BGA (for de-soldering always use the lead-free temperature profle, in case of doubt) - lead free BGA-ICs will be delivered in so-called dry-packaging (sealed pack including a silica gel pack) to protect the IC against moisture. After opening, dependent of MSL-level seen on indicator-label in the bag, the BGA-IC possibly still has to be baked dry. (MSL=Moisture Sensitivity Level). This will be communicated via AYS-website. Do not re-use BGAs at all. For sets produced before 1.1.200 (except products of 2004), containing leaded solder-alloy and components, all needed spare-parts will be available till the end of the service-period. For repair of such sets nothing changes. On our website www.atyourservice.ce.Philips.comyou fnd more information to: BGA-de-/soldering (+ baking instructions) Heating-profles of BGAs and other ICs used in Philips-sets You will fnd this and more technical information within the magazine, chapter workshop news.For additional questions please contact your local repair-helpdesk.EN 313 785 34870 Directions for Use 3.3.1.DirectionsForUseThe following excerpt of the Quick Use Guide serves as an introduction to the set.The Complete Direction for the Use can be downloaded in different languages from the internet site of Philips Customer care Center: www.p4c.philips.comRegister your product and get support atwww.philips.com/welcomeHTR9900AVR9900 2009 Koninklijke Philips Electronics N.V.All rights reserved.sgpjp_911/12/v1CONNECTORS /OPEN2HDTVMONITOR OUTBlu-rayTV1x2xBLU-RAYBlu-ray1xTV3OTHER DEVICESCONNECTORS/ OPENSettings menuListening Mode setupLanguage setupSpeaker setupSource setupTrigger setupVideo setupSource setup (Normal View)Analog Audio : Audio 1Digital Audio : HDMI 1Source : 1Name : Source 1Source setup (Normal View)Gain : 0dBVideo : HDMI 1Trigger Out : NoneSettings menuAudio synchListening modeTone controlsPower cableMicrophone(for HTR9900 only)FM antenna cableAM loop antenna(for HTR9900 only)12DIGITALAUDIO OUTHDMI INTVHDMI OUTAM LOOP ANTENNAFM ANTENNAMONITOR OUTBlu-rayINSURROUNDBACK LEFTFRONTRIGHTSURROUNDRIGHTSURROUNDLEFTFRONTLEFTSURROUNDBACK RIGHTSUBWOOFERCENTERRECEIVERCONNECTORS /OPENSettings menuSpeaker Configuration Speaker LevelsSpeaker DistanceListening Mode setupLanguage setupSpeaker setupSource setupTrigger setupVideo setupSmartEQSettings menuAudio synchListening modeTone controlsPosition the microphone in the main listening to the HTR9900Please Connect the measurement microphone SmartEQposition at ear height.5.17.1EN 10 313 785 34870 3. Directions for UseRegister your product and get support atwww.philips.com/welcomeHTR9900AVR9900 2009 Koninklijke Philips Electronics N.V.All rights reserved.sgpjp_911/12/v1CONNECTORS /OPEN2HDTVMONITOR OUTBlu-rayTV1x2xBLU-RAYBlu-ray1xTV3OTHER DEVICESCONNECTORS/ OPENSettings menuListening Mode setupLanguage setupSpeaker setupSource setupTrigger setupVideo setupSource setup (Normal View)Analog Audio : Audio 1Digital Audio : HDMI 1Source : 1Name : Source 1Source setup (Normal View)Gain : 0dBVideo : HDMI 1Trigger Out : NoneSettings menuAudio synchListening modeTone controlsPower cableMicrophone(for HTR9900 only)FM antenna cableAM loop antenna(for HTR9900 only)12DIGITALAUDIO OUTHDMI INTVHDMI OUTAM LOOP ANTENNAFM ANTENNAMONITOR OUTBlu-rayINSURROUNDBACK LEFTFRONTRIGHTSURROUNDRIGHTSURROUNDLEFTFRONTLEFTSURROUNDBACK RIGHTSUBWOOFERCENTERRECEIVERCONNECTORS /OPENSettings menuSpeaker Configuration Speaker LevelsSpeaker DistanceListening Mode setupLanguage setupSpeaker setupSource setupTrigger setupVideo setupSmartEQSettings menuAudio synchListening modeTone controlsPosition the microphone in the main listening to the HTR9900Please Connect the measurement microphone SmartEQposition at ear height.5.17.1EN 11 3139 785 34870 Mechanical Disassembly Instructions 4.4. MechanicalDisassemblyInstructions MainUnitDisassemblyInstructionEN 12 3139 785 34870 4. Mechanical Disassembly Instructions EN 13 3139 785 34870 Mechanical Disassembly Instructions 4. DisassemblyoftheSubwooferBox1. Place the subwoofer to its horizontal position as shown below (care should be taken to protect the Front from damage or scratches). 2. Loosen the 10 pieces of screws on the Rear Panel to remove the Amp. PCB Assy w/back Panel as shown below. EN 14 3139 785 34870 5. Upgrade Program Installation & Firmware Upgrading A.InstallationofFlashProgrammer(HostMainFirmware)toPC 1. Unzipthecontentinthefle:ProgramforHostMicom.zipintoafolder 2. RuntheFlashProgrammerbyclickingfle:FlashProg.exe 3. IgnorethefollowingerrormessagebyclickingtheOKbutton 4. IntheFlashProgrammermenuselectSetupFile 5. UpgradeProgramInstallation&FirmwareUpgrading5.1. FlashProgrammer&Gprobe5ProgramInstallationEN 15 3139 785 34870 Upgrade Program Installation & Firmware Upgrading 5.5. TheSetupScreenwillappearasbelow,bydefaultitwillpointtotheUpgradeProgramfolderotherwise usetheBrowserbuttontoselectthefolder&flename:FlashProg.ini 6. UsetheDevicetabconfrmtheSeries&Deviceasbelow,otherwiseselectaccordingly 7. UsetheObjectFiletab&BrowserbuttontosetthefolderwheretheUpgradeFirmwareislocated. EN 16 3139 785 34870 5. Upgrade Program Installation & Firmware Upgrading8. Use the Communication tab to set the Com port & Data rate. EN 17 3139 785 34870 Upgrade Program Installation & Firmware Upgrading 5.B.InstallationofGProbe5Program(VideoFirmware)toPC1. Extractthefle:GProbe5.7.0.1.exefromthezipfle:ProgramforHDMIMicom.zip2. RuntheautoSetupGProbe5Programbyclickingfle:GProbe5.7.0.1.exe3. BydefaultitwillinstalltheGProbe5Programinthefollowingfolderbyfollowingtheinstallationwizard Screens. 4. Programisfullyinstalledafterthefnishbuttonisclickinthelastscreenbelow. EN 18 3139 785 34870 5. Upgrade Program Installation & Firmware UpgradingC.FirmwareUpgradeforMCU(T5CC1)MainFirmware1. InstalltheFlashProgrammerintoPC(seeA.InstallationofFlashProgrammer)2. ConnectthePCSerialPorttoAVR9900/HTR9900MainUnitRS232connectorontherearpanelby usingstandardRS232Serialcable.3. CopytheFirmwareupgradefle:xxxxxxxxxxxxxxx.s24intoPC(example:D\UpgradeProgram\Firmware)4. PutAVR9900/HTR9900MainunittoStandbystate.5. Useapintodepress(inposition)theMCUUploadpushswitchviatheUploadholelocatedonthe bottomleftsideofRearPaneltoenableMCUupload. Note:EnsureHDMIuploadpushswitchisdisabled(switchisnotdepressed).6. RuntheFlashProgrammerbyopeningthefle:FlashProg.exefromtheUpgradeProgramfolderinPC.7. GotoSetup->ObjectFiletabBrowsertoselecttheupgradeFirmwarefle:xxxxxxxxxxxxxxxxxxxx.s24 fromtheFirmwarefolderandclickOK. 8. PressResetbuttoninRearPanelonceandthefashprogrammerwillgointoconnectedstateand request to Erase content as shown below. Click Yes to proceed. 9. SelectPinthescreenbelowtostartprogramming. 10. Onceprogrammingisdone,proceedtodisabletheMCUUpload(Pushswitchnotdepress)11. PerformaresetbypressingResetbuttonatRearPaneltocompletethefrmwareprocedure.EN 19 3139 785 34870 Upgrade Program Installation & Firmware Upgrading 5.D.FirmwareUpgradeforVideoFirmware(HDMI)1. InstalltheGProbe5ProgramintoPC(seeB.InstallationofGProbe5Program)2. ConnectthePCSerialPorttoAVR9900/HTR9900MainUnitRS232connectorontherearpanelbyusing standardRS232Serialcable.3. CopytheFirmwareupgradeflesintofolderinthePC(example:D:\HDMI)4. PoweruptheAVR9900/HTR9900Mainunit.5. Useapintodepress(inposition)theHDMIUploadpushswitchviatheUploadholelocatedonthe bottomleftsideofRearPaneltoenableHDMIupload. Note:EnsureMCUuploadpushswitchisdisabled(switchisnotdepressed).6. RunGprobe5programbyopeningthefle:GProbe.exe(ortheshortcutkeyontheDesktop).7. SelectOption>ConnectionSetupandensurethatitisonSerialconnectionasshownbelow.Youmay savethisProfleviatheSaveAs..button. 8. SelectCommands>BatchintheProgramtoshowthebelowBatchscreen.Browsetothefolderthat containstheupgradefles,selectthetextfle:Release_HTR9900.txtandclickOK.EN 20 3139 785 34870 5. Upgrade Program Installation & Firmware Upgrading9. Theupgradeprocessstartsandbelowshowsthecompletionscreenoftheupgradingprocess. 10. WhentheupgradeiscompleteddisabletheHDMIUpload(HDMIUploadpushswitchintheoutposition or not depress.11. DoaMainspowerOFF/ONforAVR9900/HTR9900MainUnit.EN 21 3139 785 34870 Upgrade Program Installation & Firmware Upgrading 5.E. Verifcation/Confrmation of Firmware versionToconfrmthattheFirmwarehadbeupgradeddoasfollows: 1. TurnontheMainUnitandgotoTunerAMMode. 2. HoldtheSurroundbuttonontheFrontPaneldownformorethan3seconds 3. TheFirmwareversionisdisplayedontheFrontDisplayofAVR9900/HTR9900Mainunit. Example: 1) H03241,D1.2.0 2) V0.19F. Default setting/Reset buttonThesetcanberesettoFactorydefaultbytomethods:1. UseapintopresstheResetbuttonviatheResetholeatthebottomleftsideoftheRearPanelwhenthe MainUnitison.2. Resetprocedureasgivenbelow: a. TurnontheMainUnitandgotoTunerFMmode. b. HoldtheSurroundbuttonontheFrontPaneldownformorethan3seconds c. TheFrontDisplaywillFactoryresetNote:AllusersettingswillbelostafterResetEN 22 3139 785 34870Main Unit Block Diagram - Audio Part6. Block Diagram and Wiring DiagramEN 23 3139 785 34870 6. Block Diagram and Wiring DiagramMain Unit Block Diagram - MCU & DSP PartEN 24 3139 785 34870Main Unit Block Diagram - HDMI Part6. Block Diagram and Wiring DiagramEN 25 3139 785 34870 6. Block Diagram and Wiring DiagramMain Unit Block Diagram - Video PartEN 26 3139 785 34870Main Unit Wiring Diagram51 5150494244MAINS SOCKET21VFD486. Block Diagram and Wiring DiagramEN 27 3139 785 34870 6. Block Diagram and Wiring DiagramSubwoofer Block Diagram1 2 3 4ABCD4 3 2 1DCBA TitleNumber Revision SizeA4Date: 5-Feb-2009 Sheet oIFile: E:\philips\htr9900\BLOCK.DDB Drawn By:INPUTRCAJACK OPIC U1B 4558ALCIC U6 RY2715CONTROLPHASE SWHPFIC U4A4558LPFIC U4B 4558IC U1A4558OPQ3-Q11 PWR AMPQ12-Q15(2SD1047 ,2SB817)PROTECT SPEAKERPOWER SUPPLYVCC VEE -15V 15VVCC VEE-15V 15V -15V 15V VCC VEE-15V 15V -15V 15V 15V CONTROLVOL FREQUENCYEN 28 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - Front Board: Circuit Diagram (Part 1)AVR9900_CUP12193Z(FRONT)_090302.sch-1 - Tue Mar 03 14:58:25 200 9EN 29 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - Front Board: Circuit Diagram (Part 2)AVR9900_CUP12193Z(FRONT)_090302.sch-2 - Tue Mar 03 14:59:09 200 9EN 30 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: Front Board (Top view)EN 31 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: Front Board (Bottom view)EN 32 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - MCU Board: Circuit Diagram (Part 1)EN 33 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - MCU Board: Circuit Diagram (Part 2)EN 34 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: MCU Board (Top view)EN 35 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: MCU Board (Bottom view)EN 36 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - Input Board: Circuit Diagram (Part 1)EN 37 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - Input Board: Circuit Diagram (Part 2)EN 38 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: Input Board (Top view)2118PCDZ(INPUT)_081119_WED MAR 04 14:57:02 2009EN 39 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - HDMI Board: Circuit Diagram (Part 1)EN 40 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - HDMI Board: Circuit Diagram (Part 2)EN 41 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - HDMI Board: Circuit Diagram (Part 3)EN 42 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - HDMI Board: Circuit Diagram (Part 4)EN 43 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: HDMI Board (Top view)T747_HDMI(CUP12120Z)_11_Tue Mar 03 21:48:14 2009EN 44 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: HDMI Board (Bottom view)T747_HDMI(CUP12120Z)_11_Tue Mar 03 21:51:45 2009EN 45 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - Amplifer Board: Circuit Diagram (Part 1)AVR9900_CUP12121Y(AMP)_090302.sch-1 - Tue Mar 03 14:22:31 2009EN 46 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - Amplifer Board: Circuit Diagram (Part 2)AVR9900_CUP12121Y(AMP)_090302.sch-2 - Tue Mar 03 14:23:20 2009EN 47 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: Amplifer Board (Top view)EN 48 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: Amplifer Board (Bottom view)EN 49 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - Video Board: Circuit Diagram EN 50 3139 785 34870 7. Circuit Diagrams and PWB LayoutMain Unit - PWB Layout: Video Board (Top view)EN 51 3139 785 34870 7. Circuit Diagrams and PWB Layout1 2 3 4ABCD4 3 2 1DCBAFUSEF4A-250VACINPUT POWER SW2200P/275VY10.1UF/275VX2123 SW9900-POWER2009/03/10APPROVEDDESIGNAUDITING12335V035V13V013VT121345678AC IN2AC IN11234D168A123AC IN2 C284700U/63VC294700U/63VC304700U/63VC314700U/63VC32104/100VC33104/100V-VSS+VCCC34104FUSE1F6.3A/250VACFUSE2F6.3A/250VACC43104/100VC44104/100VC41103/100VC42103/100VD184001D194148R1412KR125K6Q245551C394.7UR134K7123AC IN1D94001D124001D104001D114001C181000UC191000UC22104C23104R542K2R532K2 C24100UC20100UD1312VD1412V-12V+12VQ17D669C21100UQ18B649C25100UGNDGNDC45103C46103+12VARD-SCH-SW9900-1-2/V2.0PDF "pdfFactory Pro" www.fineprint.cnSubwoofer-Amplifer Board: Circuit Diagram (Part 1)MR1MR1MR2IN4007EN 52 3139 785 34870 7. Circuit Diagrams and PWB LayoutSubwoofer-Amplifer Board: Circuit Diagram (Part 2)1 2 3 4ABCD4 3 2 1DCBAR710K3BASSAB20KC5104C3101PR222KR5220KC14.7U R11K321U1B4558321U4B4558567+-84U1A4558 567+-84U4A4558R633KC214101PC4104R918KR8180KR1012KR1112KC7683*C6104*C94.7UC16104C17100UQ35551Q12C5200R272.2KQ10C2073Q45551R2510KR29680R3551R261K-VSS+VCCR511KR52 10KR333K9R504.7/1WR3251Q75401Q11A940R370.22/5WR390.22/5WR30680C10101R241KQ55551R2822KQ95551R342K2Q85551R454K7R36220 1/2WR31680SW- OUTD54148C11104C12101Q65401Q13C5200R4310R4410Q14A1943 Q15A1943R4110R4210R400.22/5WR380.22/5WD74001D84001R464K7R471K R481K Q165551Q215551 Q225551Q235551C152U2C2647UR5910KR60220 R5833KR643K3R492K2D64148Q245401Q255401+12VR633K3R613K3R57100KC2747U1 122 3 3445 566K2RELAY-DPSTR551K/1WQ205551Q19D669D174001C14104 C13101R39.1KR233K3D3LEDD45V1D155V1-12V+12V-12V+12V12SWOUT2P12SWIN6EQBB10K 3EQAB10KC3547U213SW1AR6310K*88Hz-160Hz28HzC4047U12345109876U6SJ1359C24.7UC36333C37224C38224GND +15VGND GND+12VR6610M HTR9900-AMP2009/03/10APPROVEDDESIGNAUDITINGARD-SCH-HTR9900-1-1/V2.0SW270PDF "pdfFactory Pro" www.fineprint.cnEN 53 3139 785 34870 7. Circuit Diagrams and PWB LayoutPWB Layout: Subwoofer-Amplifer BoardPDF "pdfFactory Pro" www.fineprint.cnEN 54 3139 785 34870 8. Alignments & Test Procedures 8. Alignments&TestProceduresAlignment of Idle Current for Power Amplifer Transistors1. Power up the Main Unit and set the volume setting to minimum. 2. Connect a voltmeter across the connector CN410.3. Tune VR410 for DC Voltage value of 1.4mV ~ 1.6mV4. Repeat procedure for the other Channels with other presets & connection as given in the table below.Note: ForoptimizePowerAmpliferperformancetheIdlecurrentforthetransistorizedPower AmplifermustbeadjustedtothecorrectvalueafterrepairisdoneonAmpliferBoardChannel Presetforadjusment Connector for measurementFront Left, FL VR410 CN410Front Right, FR VR420 CN420Center, CEN VR430 CN430Surround Left, SL VR440 CN440Surround Right, SR VR450 CN450RearSatelliteLeft,BSL VR460 CN460RearSatelliteRight,BSR VR470 CN470Connector&PresetsEN 55 3139 785 34870 8. Alignments & Test ProceduresFLOW CHART NO.1FLT or ST-BY LED cannot be turned on.ls the Fuse normal? No See FLOW CHART No.2 (the fuse blows out)Yesls normal state restored when once unplugged power cord is plugged again after several seconds? No Check if there is any leak or short-circuiting on the primary connector, circuit component, and service it if defective. (CN572, CN571, CN502, BN504, CN501)Yesls the ST-By switch normal? See FLOW CHART No.3 (Key is working disorderly). YesCheck the +40V at VFD lC and +3.3V and service it if defective. YesCheck the VDF data and clock pulse and service it if defective. (lC201 pin No. 4,5,6,7)FLOW CHART NO.2The fuse blows out. (F5701/F5501/F5502/5702)ls transformer normal? NoYesls AMP drive transistor (POWER TR) normal? NoYesls AMP drive lC (POWER lC) normal? NoYesls Voltage( B+50V, B-50V) normal? NoYesAfter servicing, replace the fuse.FLOW CHART NO.3Key is working disorderly. ls the ST-By switch normal? No Check S5001, and service it if defective.Yesls Key data normal? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (Pin No.3,4 at CN501).YesCheck whether 3.3V at u-COM (lC201) is normal. No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (Pin No.3, 24, 25, 29, 63, 64, 89 at lC201).YesCheck clock pulse of u-COM(lC201) No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (Pin No.92, 93 at lC201).TROUBLESHOOTlNGCheck if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (Q4115, Q4215, Q4315, Q4415,Q4515, Q4615, Q4715, Q4116, Q4216, Q4316, Q4416, Q4516, Q4616, Q4716)EN 56 3139 785 34870 8. Alignments & Test Procedures FLOW CHART NO.4Power is turned off automatically in a couple of seconds after turned power on. ls regulator lC normal? NoYesls signal lN/OUT normal? NoYesls power T.R normal? NoYesCheck whether protection circuit is normal.Yesls output DC normal? No Check if there is any leak or short-circuiting on lC301 PlN No(3,5,9,11,15,17,21,23), and service it if defective. Yesls u-COM lC protection terminal normal? No Check if there is any leak or short-circuiting on lC201 PlN No(51), and service it if defective. Yesls connector(BN490, BN491) normal? No Check if there is any leak or short-circuiting on BN491, BN490, and service it if defective. YesCheck whether "SLEEP MODE" is selected. FLOW CHART NO.5Bump sound can be hear when changing input-select switch. ls front mute transistor(Q3100, Q3101) normal? No Check if there is any leak or short-circuiting on u-COM (lC201 pin No.58), and service it if defective. Yesls center mute transistor(Q3099) normal? No Check if there is any leak or short-circuiting on u-COM (lC201 pin No.58), and service it if defective. Yesls surround mute transisotr(Q3097, Q3098) normal? No Check if there is any leak or short-circuiting on u-COM (lC201 pin No.58), and service it if defective. Yesls surround back mute transisotr(Q3095, Q3096) normal? No Check if there is any leak or short-circuiting on u-COM (lC201 pin No.58) and lC302(pin No.5) ,and service it if defective. FLOW CHART NO.6Sound from speaker can be hear when Headphone is connected ls Headphone Jack (CN492) connected? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (CN492)Yesls lC201(u-COM) normal? No Check if there is any leak or short-circuiting on the lC201, and service it if defective. (H/P RLY control PORT-PlN No.88)Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (Q4115, Q4215, Q4315, Q4415,Q4515, Q4615, Q4715, Q4116, Q4216, Q4316, Q4416, Q4516, Q4616, Q4716)EN 57 3139 785 34870 8. Alignments & Test ProceduresFLOW CHART NO.7Bass/ Treble Control are not working. ls bass volume normal? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (RES, CAP, bass VR)Yesls lC301(TONE l.C) Signal lN/OUT termainal normal? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective.Yesls voltage(+7V, -7V) of lC301 normal? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (lC201 PlN No.(30, 52)YesCheck wheter CLK/DATA/MUTE(PlN No.49,50,51) OF lC301 is normal. FLOW CHART NO.8Sound from AMP is dead. ls signal mute transistor(Q3301, Q3302) normal? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective.Yesls connector(BN301, CN301) normal? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective.Yesls speaker wire connected well?Yesls lC301's voltage +7V, -7V? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (lC301 pin No.30,52)Yesls lC301 data normal? No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (lC301 pin No.49,50,51)FLOW CHART NO.9When the Video is not outputed. No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (L1303, L1302, L1301)ls video DC voltage B+5V, B-5V, and +9V?Yes No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (lC 131 pin No.1,7,9,20,35,37,41,45)ls lC131' DC voltage +9V?Yes No Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (lC 131 pin No.15,16)ls lC131's u-COM control data normal?YesCheck CV, SV, COMPONENT-V output connector (CN131)EN 58 3139 785 34870 8. Alignments & Test Procedures CHECK AT POWER SUPPLYCHECK AT BN146 WIRE ASS'Y & INPUT PCB REGULATOR & IC REPLAECHECK AT BN146 PIN1(+9V), PIN2(-5V), PIN4,5(+1.8V),PIN8,9(+5V)CHECK AT IC149, IC150, IC168, IC171, IC170, IC163, IC166, IC161, IC162, IC169, IC164, IC165, IC167CHECK AT POWER SUPPLY CIRCUIT & IC REPLAEN.G.N.G.OKNO HDMI AUDIO OUT(VIDEO OK)REPLACE VIDEO JACK or CONNECT THE VIDEO CABLE INTO THE JACK SECURELYCHECK VIDEO JACKIS POWER APPLIED CORRECTLY TO EACH POINT?CHECK AT BN141 PIN 2,3,4,5,7,8,10,CHECK ATBN141 PIN 13,14,15 BN142 PIN 1CHECK AT R1586,R1587, 1593, R1594, R1595CHECK POWER SUPPLY CIRCUIT (CHECK IC POWER PIN)CHECK OPEN CIRCUIT or SHORT CIRCUITCHECK OPEN CIRCUIT or SHORT CIRCUITCHECK OPEN CIRCUIT or SHORT CIRCUITCHECK AT IC173 PIN5~PIN11CHECK OPEN CIRCUIT or SHORT CIRCUIT & IC173 REPLACEN.G.N.G.N.G.N.G.N.G.N.G.OKOKOKOKOKEN 59 3139 785 34870 8. Alignments & Test Procedures ANALOG OK, NO HDMI OUTREPLACE VIDEO JACK or CONNECT THE VIDEO CABLE INTO THE JACK SECURELYCHECK VIDEO JACKIS POWER APPLIED CORRECTLY TO EACH POINT?CHECK VIDEO DATA AT IC141 PIN14, 15, R1456,R1457, R1485, R1486 , R1617, R1618CHECK ATHDMI JACK(JK141~JK144) PIN18 (5V), PIN19(INPUT SELECT 5V) CHECK AT RN156,RN157,RN158,RN159,RN160,RN161,RN162,RN163,RN164,CHECK POWER SUPPLY CIRCUIT (CHECK IC POWER PIN)CHECK OPEN CIRCUIT or SHORT CIRCUITHDMI INPUT 1 : IC141 PIN 56 "H"HDMI INPUT 2 : IC141 PIN 36 "H"HDMI INPUT 3 : IC141 PIN 16 "H"HDMI INPUT 4 : R1616 "H"CHECK AT INTERFACEBETWEEN IC151 AND IC173 , & IC151 REPLACECHECK AT IC173 PIN30,31,33,34,36,37,39,40(3.3V) IC173 REPLACEN.GN.G.N.G.N.G.N.G.N.G.OKOKOKOKOK HDMI OK , NO ANALOG OUTREPLACE VIDEO JACK or CONNECT THE VIDEO CABLE INTO THE JACK SECURELYCHECK VIDEO JACKIS POWER APPLIED CORRECTLY TO EACH POINT?CHECK VIDEO DATA AT IC141 PIN14, 15, R1456,R1457, R1485, R1486 , R1617, R1618CHECK AT CN144 PIN 1, R1522, C1538, CN144 PIN 3, 4 R1521, C1537, 1504, C1520 CN144 PIN 6,7,8,10,11,12,14,15,16R1505 ~ R1520, C1520 ~ C1536CHECK AT RN187,RN188,RN190,RN189,RN191,RN192,RN193CHECK POWER SUPPLY CIRCUIT (CHECK IC POWER PIN)CHECK OPEN CIRCUIT or SHORT CIRCUITCHECK OPEN CIRCUIT or SHORT CIRCUITCHECK AT INTERFACE BETWEEN IC151 AND IC158 , CHECK OPEN CIRCUIT or SHORT CIRCUIT & IC151 REPLACEIC159 PIN 2, 6, 8, 10, 14, 16CHECK INTERFACE BETWEEN IC158 AND IC159 CIRCUIT ,IC158,IC 159 POWER PIN , IC158 REPLACECN145 PIN 1, 3, 4, 6, 8, 9CHECK OPEN CIRCUIT or SHORT CIRCUITCHECK VIDEO OUPUT JACK PINCHECK OPEN CIRCUIT or SHORT CIRCUITN.G.N.G.N.G.N.G.N.G.N.G.N.G.N.G.OKOKOKOKOKOKOKEN 60 3139 785 34870 9. IC Internal Block Diagrams 9.1 FrontPCBPanel FLP51:CFLHCA16S201TVFDDisplay9. ICInternalBlockDiagramsEN 61 3139 785 34870 9. IC Internal Block Diagrams FLP51:CFLHCA16S201TVFDDisplayEN 62 3139 785 34870 9. IC Internal Block Diagrams 9.2 MCUBoard IC201:T5CC1FlashMicrocontrollerEN 63 3139 785 34870 9. IC Internal Block Diagrams IC201:T5CC1FlashMicrocontrollerBlockDiagram EN 64 3139 785 34870 9. IC Internal Block Diagrams IC201:T5CC1FlashMicrocontrollerPortAssignmentBack Up St/By Pwr On Active1 VREFL GND2 AVSS GND3 AVCC 3.3V4 P70/TA0lN l/O O Serial Data VFD_CS5 P71/TA1OUT l/O O Serial Data VFD_CLK6 P72/TA3OUT l/O O Serial Data VFD_DATA7 P73/TA4lN l/O O Serial Data(LOW) VFD_RST8 P74/TA5OUT l/O l O H Low HP_lN9 P75/TA7OUT l/O O Serial Data UART1_RESET10 P80/TB0lN0/lNT5 l/O l Serial Data URAT1_lRQ11 P81/TB0lN1/lNT6 l/O O Serial Data UART1_CLK12 P82/TB0OUT0 l/O O Serial Data UART1_CS13 P83/TB0OUT1 l/O l Serial Data UART1_DATA_lN14 P84/TB1lN0/lNT7 l/O O Serial Data UART1_DATA_OUT15 P85/TB1lN1/lNT8 l/O l O H TORlNO_MUTE_lN16 P86/TB1OUT0 l/O O O H HDMl_SW117 P87/TB1OUT1 l/O O O H HDMl_SW218 P90/TXD0 l/O O O H Serial Data TORlNO_TX19 P91/RXD0 l/O l O H Serial Data TORlNO_RX20 P92/SCLK0/CTS0 l/O O Serial Data TORlNO_RESET21 P93/TXD1 l/O O Serial Data UART_TX22 P94/RXD1 l/O l Serial Data UART_RX23 P95/SCLK1/CTS1 l/O l High DSP_MODE_SEL24 AM0 3.3V25 DVCC 3.3V26 X2 l/O O X_TAL_OUT27 DVSS GND28 X1 l/O l X_TAL_lN29 AM1 3.3V30 RESET l/O l Low RESET31 P96/XT1 l/O l EXP_CE332 P97/XT2 l/O l EXP_CE433 EMU0 OPEN34 EMU1 OPEN35 PA0/lNT1 REMOTE_lN36 PA1/lNT2 MULTl_lR_lN37 PA2/lNT3 Serial Data RDS_CLK38 PA3/lNT4 l/O l Low BACK_UP39 PA4 l/O O Serial Data PLL-CE40 PA5 l/O l Serial Data PLL_DATA_lN41 PA6 l/O O Serial Data PLL_CLK42 PA7 l/O O Serial Data PLL_DATA_OUT43 ALE OPEN44 P00/AD0 l/O l O H Serial Data TUNED45 P01/AD1 l/O l O H Serial Data STEREO46 P02/AD2 l/O l Serial Data RDS_DATA47 P03/AD3 l/O l O(X) OPTlON48 P04/AD4 l/O l O(X) High / Low OPTlON49 P05/AD5 l/O O Serial Data SCL(EEPROM)50 P06/AD6 l/O l/O Serial Data SDA(EEPROM)51 P07/AD7 l/O l Low PROTECT_lN52 P10/AD8/A8 l/O O SUB_VOL_STB53 P11/AD9/A9 l/O O SUB_VOL_CLK54 P12/AD10/A10 l/O O SUB_VOL_DATA55 P13/AD11/A11 l/O O Serial Data MAlN_VOL_MUTE56 P14/AD12/A12 l/O O Serial Data MAlN_VOL_CLK57 P15/AD13/A13 l/O O Serial Data MAlN_VOL_DATA58 P16/AD14/A14 l/O O Low FUNCTlON_MUTE59 P17/AD15/A15 l/O O Serial Data EXP_CE260 P20/A0/A16 l/O O Serial Data DlR_RESET61 P21/A1/A17 l/O O Serial Data DlR_CS62 DVSS GND63 NMl 3.3V 64 DVCC 3.3V65 P22/A2/A18 l/O l Serial Data DlR_D_OUT66 P23/A3/A19 l/O l Serial Data DSP_SPCl_lRQ67 P24/A4/A20 l/O O Serial Data DSP_DlR_CLK68 P25/A5/A21 l/O l Serial Data DSP_DATA69 P26/A6/A22 l/O O Serial Data DSP_CS 70 P27/A7/A23 l/O O Serial Data DSP_DlR_DATA71 P30/RD l/O O High HDMl_SW172 P31/WR l/O O High HDMl_SW273 P32/HWR l/O l Serial Data DSP_PCP_BSY74 P33/WAlT l/O O Serial Data DSP_RESET75 P34/BUSRQ l/O O Serial Data EXP_CE176 P35/BUSAK l/O O Serial Data EXP_CLK77 P36/R/W l/O O Serial Data EXP_DATA78 P37/BOOT l/O l O H Low BOOT_MODE79 P40/CS0 l/O l Serial Data URAT2_lRQ80 P41/CS1 l/O O Serial Data UART2_CLK81 P42/CS2 l/O O Serial Data UART2_CS82 P43/CS3 l/O l Serial Data UART2_DATA_lN83 P60/SCK l/O O Serial Data UART2_DATA_OUT84 P61/SO/SDA l/O O Serial Data UART2_RESET85 P62/Sl/SCL l/O O Serial Data VlDEO_SDA86 P63/lNT0 Serial Data VlDEO_SCL87 P64/SCOUT l/O O High POWER_ON88 P65 l/O O High MlC_ON89 DVCC 3.3V90 P66 l/O l High lPOD_DETECT91 DVSS GND92 P50/AN0 l/O l O H KEY193 P51/AN1 l/O l O H KEY294 P52/AN2 l/O l O H KEY395 P53/AN3/ADTRG l/O l O H VOL_EN196 P54/AN4 l/O l O H VOL_EN297 P55/AN5 O H FUNC EN198 P56/AN6 O H FUNC EN299 P57/AN7 O HDMl_lNT100 VREFH 3.3VPlN No Port Name l/O USE(l/O) OpenDrain OutsidePull UP State NoteEN 65 3139 785 34870 9. IC Internal Block Diagrams IC202:M24C32WMN6TPEepromEN 66 3139 785 34870 9. IC Internal Block Diagrams IC205/IC206:XR20M1170IG1612C/SPIUARTBlockDiagramEN 67 3139 785 34870 9. IC Internal Block Diagrams IC205/IC206:XR20M1170IG1612C/SPIUARTPinDescriptionEN 68 3139 785 34870 9. IC Internal Block Diagrams IC205/IC206:XR20M1170IG1612C/SPIUARTPinDescriptionEN 69 3139 785 34870 9. IC Internal Block Diagrams IC205/IC206:XR20M1170IG1612C/SPIUARTPinDescriptionEN 70 3139 785 34870 9. IC Internal Block Diagrams IC240:CS497004CQZDSPICEN 71 3139 785 34870 9. IC Internal Block Diagrams IC241:TC74VCX541FTOCTALBusBufferEN 72 3139 785 34870 9. IC Internal Block Diagrams IC250:ST25VF080B8MbitSPISerialFlashEN 73 3139 785 34870 9. IC Internal Block Diagrams IC260:HY57V161610ET716MBSDRAMEN 74 3139 785 34870 9. IC Internal Block Diagrams IC280:CS42528CQCODEC+DIREN 75 3139 785 34870 9. IC Internal Block Diagrams IC281:TC74HCU04AFNGInverterIC282:TC74VHC157FT2-ChannelMUXEN 76 3139 785 34870 9. IC Internal Block Diagrams 9.3 InputBoard IC301:R2A15218FP8CHE.Volume,11InputSelector&ToneControlEN 77 3139 785 34870 9. IC Internal Block Diagrams IC301:R2A15218FP8CHE.Volume,11InputSelector&ToneControlEN 78 3139 785 34870 9. IC Internal Block Diagrams IC301:R2A15218FP8CHE.Volume,11InputSelector&ToneControlPinDescriptionEN 79 3139 785 34870 9. IC Internal Block Diagrams IC302:CD4094BPWRShiftRegisterEN 80 3139 785 34870 9. IC Internal Block Diagrams IC302:CD4094BPWRShiftRegisterEN 81 3139 785 34870 9. IC Internal Block Diagrams IC352:LC72723MRDSEN 82 3139 785 34870 9. IC Internal Block Diagrams IC352:LC72723MRDSEN 83 3139 785 34870 9. IC Internal Block Diagrams 9.4 HDMIBoard IC141:SII9185ACTUHDMITXSWSiI9185APin MappingPin MappingEN 84 3139 785 34870 9. IC Internal Block Diagrams IC141:SII9185ACTUHDMITXSWFunctional Block DiagramEN 85 3139 785 34870 9. IC Internal Block Diagrams IC141:SII9185ACTUHDMITXSWPin Descriptions System Switching PinsPin Name Pin # Type Dir DescriptionDSDA0,DSDA1,DSDA230,50,70LVTTL,Schmitt trigger,Open drain,5-V tolerantInput/Output DDC I2C Data for respective port. These signals are true open drain,and do not pull to ground when power is not applied to the device.These pins require an external pull-up resistor.DSCL0,DSCL1,DSCL231,51,71LVTTL,Schmitt trigger,Open drain,5-V tolerantInput DDC I2C Clock for respective port. These signals are true opendrain, and do not pull to ground when power is not applied to thedevice. These pins require an external pull-up resistor.RPWR0,RPWR1,RPWR232,52,72LVTTL,5 V tolerant Input 5 V Port detection input for respective port.Connect to 5 V signal from HDMI input connector.HPD0,HDP1,HPD216,36,56LVTTL, 2 mA,5-V tolerant Output Hot Plug Detect Output for respective port.Connect to HOTPLUG of HDMI input connector.HPDIN 76 LVTTL,5-V tolerant Input Hot Plug Detect Input.TSCL 78 LVTTL,Schmitt trigger,Open drain,5-V tolerantOutput Master DDC I2C Clock (Open Drain Output) to HDMI receiver. I2Ctransactions required for HDCP operation are performed over thisI2C bus. These signals are true open drain, and do not pull to groundwhen power is not applied to the device. These pins require anexternal pull-up resistor.TSDA 77 LVTTL,Schmitt trigger,Open drain,5-V tolerantInput/Output Master DDC Data (Open drain output.) to HDMI receiver. I2Ctransactions required for HDCP operation are performed over thisI2C bus. These signals are true open drain, and do not pull to groundwhen power is not applied to the device. These pins require anexternal pull-up resistor.Configuration PinsPin Name Pin # Type Dir DescriptionI2CADDR/TPWR 79 LVTTL,4 mA,5-V tolerantInput/Output I2C Slave Address input / Transmit Power Sense Output.When RESET# is LOW, this pin is used as an input to latch the I2Csub-address. The level on this pin is latched when the RESET# pintransitions from LOW to HIGH.When RESET# is HIGH, this pin is used as the TPWR output,indicating that the receive port has 5 V present.Refer to page 9 for more information.I2CSEL/INT# 35 Schmitt trigger,Open drain,4 mA,5-V tolerantInput/Output Interrupt Output.For information about the use of this dual-purpose pin, refer to theI2CSEL/INT section on page 8.This is an open-drain output and requires an external pull-up resistor.Standalone mode is supported only up to 165 MHz. Above that limit,I2C Control mode must be used.RSVDL 75 Input Reserved for use by Silicon Image and must be tied LOW.EN 86 3139 785 34870 9. IC Internal Block Diagrams IC141:SII9185ACTUHDMITXSWControl PinsPin Name Pin # Type Dir DescriptionRESET# 13 LVTTL,Schmitt trigger,5-V tolerantInput Reset Pin (Active LOW). Certain configuration inputs are latchedwhen RESET# transitions from LOW to HIGH. Refer to page 8 formore information.LSCL/EPSEL1 15 Schmitt trigger,Open drain,5-V tolerantInput Local I2C Clock / External Port Select 1. When I2CSEL is HIGH,this is the Local I2C bus clock pin, LSCL. When I2CSEL is LOW,this is the external port select pin, EPSEL1. This pin is true opendrain, so it does not pull to ground if power is not applied. Anexternal pull-up resistor is required.Refer to page 8 for more information.LSDA/EPSEL0 14 LVTTL,Schmitt trigger,Open drain,5-V tolerantInput/Output Local I2C Data / External Port Select 0. When I2CSEL is HIGH, thisis the Local I2C bus data pin, LSDA. When I2CSEL is LOW, this isthe external port select pin, EPSEL0. This pin is true open drain, soit does not pull to ground if power is not applied. An external pull-upresistor is required.Refer to page 8 for more information.CEC PinsPin Name Pin # Type Direction DescriptionCEC_A 54 CEC Compliant,5-V tolerant Input/Output HDMI compliant CEC I/O used to interface to CEC devices. CECelectrically compliant signal. This pin connects to the CEC signal ofall HDMI connectors in the system.As an input, the pin acts as a LVTTL Schmitt triggered input and is5 V tolerant. As an output, the pin acts as an NMOS driver withresistive pull-up. This pin has an internal pull-up resistor.CEC_D 53 LVTTL,Schmitt trigger,Open drain,5-V tolerantInput/Output CEC interface to local system. This pin is a true open-drain and anexternal pull-up resistor is required. This pin typically connects tothe local CPU.EN 87 3139 785 34870 9. IC Internal Block Diagrams IC141:SII9185ACTUHDMITXSWDifferential Signal Data Pins Pin Name Pin # Type Dir DescriptionR0X0+ 22 TMDS InputR0X0 21 TMDS InputR0X1+ 25 TMDS InputR0X1 24 TMDS InputR0X2+ 28 TMDS InputR0X2 27 TMDS InputTMDS input Port 0 data pairs.R0C+ 19 TMDS InputR0C 18 TMDS Input TMDS input Port 0 clock pair.R1X0+ 42 TMDS InputR1X0 41 TMDS InputR1X1+ 45 TMDS InputR1X1 44 TMDS InputR1X2+ 48 TMDS InputR1X2 47 TMDS InputTMDS input Port 1 data pairs.R1C+ 39 TMDS InputR1C 38 TMDS Input TMDS input Port 1 clock pair.R2X0+ 62 TMDS InputR2X0 61 TMDS InputR2X1+ 65 TMDS InputR2X1 64 TMDS InputR2X2+ 68 TMDS InputR2X2 67 TMDS InputTMDS input Port 2 data pairs.R2C+ 59 TMDS InputR2C 58 TMDS Input TMDS input Port 2 clock pair.TX0+ 7 TMDS OutputTX0 8 TMDS OutputTX1+ 4 TMDS OutputTX1 5 TMDS OutputTX2+ 1 TMDS OutputTX2 2 TMDS OutputTMDS output data pairs.TXC+ 10 TMDS OutputTXC 11 TMDS Output TMDS output clock pair.EXT_SWING 12 Analog Input Voltage Swing Adjust. A resistor tied from this pin to AVCC18determines the amplitude of the voltage swing. Silicon Imagerecommends a value of 750 ohms.Power and Ground PinsPin Name Pin # Type DescriptionAVCC33 23, 43, 55, 63 Power Analog VCC. Connect to 3.3 V supply.AVCC18 6, 17, 29, 37, 49, 57,69 Power Analog VCC. Connect to 1.8 V supply.AGND 3, 9, 20, 26, 40,46, 60, 66, 80 Ground Analog GND.DVCC18 33, 73 Power Digital VCC. Connect to 1.8 V supply.DGND 34, 74 Ground Digital GND.EN 88 3139 785 34870 9. IC Internal Block Diagrams IC142:TC7MZ4052FK4CHMUXX:Dontcare,*:ExceptMZ4052FKEN 89 3139 785 34870 9. IC Internal Block Diagrams IC142:TC7MZ4052FK4CHMUXEN 90 3139 785 34870 9. IC Internal Block Diagrams IC143:AT24C02NEepromPin ConfigurationPin Name FunctionA0 - A2 Address InputsSDA Serial DataSCL Serial Clock InputWP Write ProtectNC No ConnectGND GroundVCC Power Supply12348765A0A1A2GNDVCCWPSCLSDABlock DiagramEN 91 3139 785 34870 9. IC Internal Block Diagrams IC144/IC145:TC74VHCT14AFTHEXSchmittInverterTruth TableEN 92 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXPinDiagramEN 93 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXBlockDiagramEN 94 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXFunctionalBlockDiagramEN 95 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXPinDescriptionEN 96 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXDigitalAudiooutPinEN 97 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXDigitalAudiooutPinEN 98 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXDigitalAudiooutPinEN 99 3139 785 34870 9. IC Internal Block Diagrams IC146:SII9135CTUHDMIRXDigitalAudiooutPinEN 100 3139 785 34870 9. IC Internal Block Diagrams IC147:TC74VCX541FTOCTALBusBufferEN 101 3139 785 34870 9. IC Internal Block Diagrams IC151:CVIFL130336ACVideoProcessorFLI30336FUNCTIONALBLOCKDIAGRAM DisplayEngine I2SControllerDDDSIRGPIOPWMI2CMaster64KSRAM64KROMJTAGBridgeExtRAM/ROMI/FFSBridgeI2CSlaveddc2bix186BUSHostRegisterInterfaceRESETCONTROLLERTurbo186JTAGCodePatchAddressGeneratorFRCControllerArbiterDDRMemory InterfaceLVDSInterfacePIP/MAINBlenderResponseTimeEnhancementVideoLUTGamma(DIP)Digital InputPort4:2:2-4:4:4PanelPowerCTRL(OCM)OnChipMicrocontrollerOutputDisplayProcessor(MC)MemoryControllerLowBandWidthADCEdgeEnhancement4:2:2-4:4:4ACC+ACM-3D(BlueStretch)3x3MatrixRGB2YUVOSDBlenderDisplayTimingGeneratorTTLInterfaceDIPCLKMUXPortSelect656decoderPIPIFMMAINIFMTableAccessBridgeRCLKPLLIPCLK0IPCLK1IPCLK2IPCLK3DIG_PORTB[23:0]BODDBHSYNCBVSYNCDIG_PORTA[23:0]AODDOSCOSC bootstrap20MHz(19.6608MHz)TCLKODDSFDDSEDDSSDDSAHS_CS_RAWAEXT_CLAMPAEXT_COASTTCLKRCLKECLKFCLKDCLKOCLKSCLKiAVS_CLK(MVF)MainVertical FilterDCDiMADiVertical ScalerMPEGNoiseReduction(MHF)MainHorizontal FilterHorizontalScaler(PHF)PIPHorizontalFilter(PVF)PIPVertical FilterTNR+3:2PullDown+CCSOSDCTRL(IPP) InputPIPProcessor3x3MatrixInputSelectMuxDIP_PIP_CLKDIP_MAIN_CLKDIP_CSYNCAVSYNCAHSYNCPIPBusSwapMAINBusSwapPIPBusFlipMAINBusFlip656decoderHSVSV1_ADCAA n a l o g M u xA1A2A3A4A_RETURNC1C2C3C4C_RETURNB1B2B3B4B_RETURNSV1SV2SV3SV4SV_RETURNVOUTV1_DecimationFilterClockGenUPDATECONTROLLERIRQCONTROLLERTPGI2Cddc2biIBDPXLGrabSumDiffFeatDetLTRBoxWSSIWCMeasWinRGB2YUV4:4:4-4:2:2(IMP) InputMainProcessorTPGIBDPXLGrabSumDiffFeatDetLTRBoxWSSIVPMeasWinRGB2YUV4:4:4-4:2:2PXLGrabHWengineMasterSlaveSyncP o r t C o n f i g u r a t i o nPeakingFilterSDDS2EDDS2JTAGBoundaryScanECLK2SCLK2SyncProcessorLVDSmappingMainChannelDataRouterPeakingFilterPIPChannelDataRouterDCDiVerticalScalerHorizontalScalerPeakingFilterPeakingFilterDitherMAINChannelPIPChannelV1_ADCBV1_ADCCV1_DecimationFilterV1_DecimationFilterV1_SyncADCV1_SyncSlicerV2_ADCAV2_DecimationFilterV2_ADCBV2_ADCCV2_DecimationFilterV2_DecimationFilterV2_SyncADCV2_SyncSlicer3DVideoDecoderVBISlicertoMCfromMCDWORDCo-processorIFM3MultipipEngineDynamicScalerControllerSCARTOverlaySyncProcessorEN 102 3139 785 34870 9. IC Internal Block Diagrams IC152:ES29LV320ET-70TGFlashROM32MBitCommandRegisterAnalog BiasGeneratorAddressLatchBYTE#CE#OE#ARESET#VccVssChip EnableOutput EnableLogicVcc Detector Timer/CounterY-DecoderX-DecoderY-DecoderCell ArrayData Latch/Sense AmpsInput/OutputBuffersSector SwitchesDQ0-DQ15(A-1)RY/BY#WriteStateMachineWE#FUNCTION BLOCK DIAGRAMEN 103 3139 785 34870 9. IC Internal Block Diagrams IC152:ES29LV320ET-70TGFlashROM32MBitPIN DESCRIPTIONPin DescriptionA0-A20 21 AddressesDQ0-DQ14 15 Data Inputs/OutputsDQ15/A-1DQ15 (Data Input/Output, Word Mode)A-1 (LSB Address Input, Byte Mode)CE# Chip EnableOE# Output EnableWE# Write EnableWP#/ACC Hardware Write Protect/Acceleration PinRESET# Hardware Reset Pin, Active LowBYTE# Selects 8-bit or 16-bit modeRY/BY# Ready/Busy OutputVcc3.0 volt-only single power supply(see Product Selector Guide for speed options and voltage supply tolerances)Vss Device GroundNC Pin Not Connected InternallyCONNECTION DIAGRAMA15A14A13A12A11A10A9A8A19A20WE#RESET#NCWP#/ACCRY/BY#A18A17A7A6A5A4A3A2A1A16BYTE#VssDQ15/A-1DQ7DQ14DQ6DQ13DQ5DQ12DQ4VccDQ11DQ3DQ10DQ2DQ9DQ1DQ8DQ0OE#VssCE#A012345678910111213141516171819202122232448474645444342414039383736353433323130292827262548-Pin Standard TSOPES29LV320EEN 104 3139 785 34870 9. IC Internal Block Diagrams IC153/IC154:A3S56D40ETP-G5SDRAMPin Assignment (Top View) 66-pin TSOP123456789101112131415161718192021222324252627282930313233666564636261605958575655545352515049484746454443424140393837363534VDDDQ0VDDQDQ1DQ2VSSQDQ3DQ4VDDQDQ5DQ6VSSQDQ7NCVDDQLDQSNCVDDNCLDM/WE/CAS/RAS/CSNCBA0BA1A10/APA0A1A2A3VDDVSSDQ15VSSQDQ14DQ13VDDQDQ12DQ11VSSQDQ10DQ9VDDQDQ8NCVSSQUDQSNCVREFVSSUDM/CLKCLKCKENCA12A11A9A8A7A6A5A4VSS66pin TSOP(II)400mil widthx875mil length0.65mmLead PitchRowA0-12ColumnA0-9 (x8)A0-8 (x16)x16EN 105 3139 785 34870 9. IC Internal Block Diagrams IC153/IC154:A3S56D40ETP-G5SDRAMPIN FUNCTIONCLK, /CLK InputClock: CLK and /CLK are differential clock inputs. All address and controlinput signals are sampled on the crossing of the positive edge of CLK andnegative edge of /CLK. Output (read) data is referenced to the crossings ofCLK and /CLK (both directions of crossing).CKE Input Clock Enable: CKE controls internal clock. When CKE is low, internal clockfor the following cycle is ceased. CKE is also used to select auto / self refresh.After self refresh mode is started, CKE becomes asynchronous input. Self refreshis maintained as long as CKE is low./CS Input Chip Select: When /CS is high, any command means No Operation./RAS, /CAS, /WE Input Combination of /RAS, /CAS, /WE defines basic commands.A0-12 InputA0-12 specify the Row / Column Address in conjunction with BA0,1. TheRow Address is specified by A0-12. The Column Address is specified byA0-9(x8) and A0-8(x16). A10 is also used to indicate prechargeoption. When A10 is high at a read / write command, an auto precharge isperformed. When A10 is high at a precharge command, all banks areprecharged.BA0,1 InputDQ0-7 (x8),DQ0-15 (x16), Input / OutputDQS (x8)Vdd, Vss Power Supply Power Supply for the memory array and peripheral circuitry.VddQ, VssQ Power Supply VddQ and VssQ are supplied to the Output Buffers only.Bank Address: BA0,1 specifies one of four banks to which a command isapplied. BA0,1 must be set with ACT, PRE, READ, WRITE commands.Data Input/Output: Data busData Strobe: Output with read data, input with write data. Edge-alignedwith read data, centered in write data. Used to capture write data.For the x16, LDQS corresponds to the data on DQ0-DQ7; UDQScorrespond to the data on DQ8-DQ15SYMBOL TYPE DESCRIPTIONDM (x8) InputInput Data Mask: DM is an input mask signal for write data. Input datais masked when DM is sampled HIGH along with that input dataduring a WRITE access. DM is sampled on both edges of DQS.Although DM pins are input only, the DM loading matches the DQand DQS loading. For the x16, LDM corresponds to the data on DQ0-DQ7;UDM corresponds to the data on DQ8-DQ15.Input / OutputVref Input SSTL_2 reference voltage.UDQS, LDQS (x16)UDM, LDM (x16)EN 106 3139 785 34870 9. IC Internal Block Diagrams IC153/IC154:A3S56D40ETP-G5SDRAMBLOCK DIAGRAM/CS /RAS /CAS /WE UDM,LDMMemoryArrayBank #0DQ0 - 15I/O BufferMemoryArrayBank #1MemoryArrayBank #2MemoryArrayBank #3Mode RegisterControl CircuitryAddress BufferA0-12 BA0,1Clock BufferCLK CKEControl Signal BufferDQS BufferUDQS, LDQSDLL/CLKA3S56D40ETPEN 107 3139 785 34870 9. IC Internal Block Diagrams IC156:M24C32WMN6TPEeprom32kBitEN 108 3139 785 34870 9. IC Internal Block Diagrams IC158:ADV7342BSTZVideoEncoderFunctionalBlockDiagramEN 109 3139 785 34870 9. IC Internal Block Diagrams IC158:ADV7342BSTZVideoEncoderEN 110 3139 785 34870 9. IC Internal Block Diagrams IC159:NJM2566VEN 111 3139 785 34870 9. IC Internal Block Diagrams IC159:NJM2566VPin ConfgurationEN 112 3139 785 34870 9. IC Internal Block Diagrams IC160:CVIMK2302S01TBufferBlock DiagramPhaseDetector,ChargePump,and LoopFilterdivideby NCLK1External feedback can come from CLK1 or CLK2ICLKFBINS1:0VCOCLK2/2EN 113 3139 785 34870 9. IC Internal Block Diagrams Pin AssignmentClock Multiplier Decoding Table(Multiplies Input clock by shown amount)Pin DescriptionsFBINICLKGNDVDDS0CLK1CLK2 12348765GNDS1123487658 pin (150 mil) SOICFBIN S1 S0 CLK1 CLK2CLK1 0 0 2 X ICLK ICLKCLK1 0 1 4 X ICLK 2 X ICLKCLK1 1 0 ICLK ICLK/2CLK1 1 1 8 X ICLK 4 X ICLKCLK2 0 0 4 X ICLK 2 X ICLKCLK2 0 1 8 X ICLK 4 X ICLKCLK2 1 0 2 X ICLK ICLKCLK2 1 1 16 X ICLK 8 XICLKPinNumberPinNamePinType Pin Description1 FBIN Input Feedback clock input.2 ICLK Input Reference clock input.3 GND Power Connect to ground.4 S0 Input Select 0 for output clock per decoding table above. Pull-up.5 S1 Input Select 1 for output clock per decoding table above. Pull up.6 CLK1 Output Clock output per table above.7 VDD Power Connect to +3.3 V or +5.0 V.8 CLK2 Output Clock output per table above. Low skew divide by two of pin 6 clock.IC160:CVIMK2302S01TBufferEN 114 3139 785 34870 9. IC Internal Block Diagrams IC173:SII9134CTUHDMITXEN 115 3139 785 34870 9. IC Internal Block Diagrams IC173:SII9134CTUHDMITXBlockDiagramEN 116 3139 785 34870 9. IC Internal Block Diagrams IC173:SII9134CTUHDMITXEN 117 3139 785 34870 9. IC Internal Block Diagrams IC173:SII9134CTUHDMITXEN 118 3139 785 34870 9. IC Internal Block Diagrams IC173:SII9134CTUHDMITXEN 119 3139 785 34870 9. IC Internal Block Diagrams IC173:SII9134CTUHDMITXEN 120 3139 785 34870 9. IC Internal Block Diagrams IC173:SII9134CTUHDMITXEN 121 3139 785 34870 9. IC Internal Block Diagrams 9.5 VideoBoard IC131:NJW1321FP1VideoS/WBlockDiagramEN 122 3139 785 34870 9. IC Internal Block Diagrams Pin ConfgurationIC131:NJW1321FP1VideoS/WEN 123 3139 785 34870 9. IC Internal Block Diagrams IC131:NJW1321FP1VideoS/WEN 124 3139 785 34870 9. IC Internal Block Diagrams IC131:NJW1321FP1VideoS/WEN 125 3139 785 34870 9. IC Internal Block Diagrams IC133:NJM2581MTE1EN 126 3139 785 34870 9. IC Internal Block Diagrams IC133:NJM2581MTE1EN 127 3139 785 34870 9. IC Internal Block Diagrams IC134:NJM2285MTE1VideoSwitchEN 128 3139 785 34870 9. IC Internal Block Diagrams IC134:NJM2285MTE1VideoSwitchEN 129 3139 785 34870 9. IC Internal Block Diagrams IC135:NJM2586AEN 130 3139 785 3487010 MainUnitExplodedView10. Exploded View & Spare Parts ListPCB 5PCB 4PCB 3PCB 6PCB 2PCB1= Loc. 14+15+16+17+25+2648514950EN 131 3139 785 34870 10. Exploded View & Spare Parts ListMAIN UNIT MECHANICAL & ACCESSORIES PARTS LIST1 996510024387 WINDOW,FIP2 996510024349 VOLUMEKNOBASSY3 996510024342 PANEL,AL4 996510024321 DOOR,JACK5 996510024233 RUBBER,DOOR6 996510024367 PLATE,MAGNET8 996510024204 PANEL,FRONT9 996510024397 ORNAMENT,STRIP10 996510024262 KNOB,POWER11 996510024216 FUNCTIONKNOBASSY12 996510024377 MAGNET,BASE13 996510024285 GEAR,DAMPER18 996510024257 CHASSIS,BOTTOM19 996510024253 FOOT20 996510024273 CUSHION,FOOT21 996510024376 TRANS,POWERT74723 996510024368 HOLDER,PCB24 996500013206 RUBBER29 996510024247 FAN(60X60X10)30 996510024318 SUPPORT,PCB4833 996510024332 SUPPORT,PCB3135 996510024379 SUPPORT,PCB4441 996510024237 FAN,DCBRUSHLESS (80X80X25mm)42 996510024211 MODULE,TUNERKSE43 996510024297 PANEL,REAR44 996510024417 ACSocket+2PWIREASSY 10CM45 996510024205 CABINET,TOP48 996510024337 CABLE,CARD (21P,1.25MM,180MM,B,10MM)49 996510024277 CABLE,CARD (15P,1.25MM,80MM,B,10MM)50 996510024214 CABLE,CARD (13P,120MM,1.25MM)51 996510024289 FFCCABLEASSY17P15CMPCB1 996510024416 HTR9900FRONTPCBPANEL ASSY(COMPLETE)PCB2 996510024241 HTR9900MCUPCBASSY (COMPLETE)PCB3 996510024198 HTR9900INPUTPCBASSY (COMPLETE)PCB4 996510024307 HTR9900VIDEOPCBASSY (COMPLETE)PCB5 996510024308 HTR9900HDMIPCBASSY (COMPLETE)PCB6 996510024296 HTR9900AMPPCBASSY (COMPLETE)FE101 996510024221 FERRITE,COREACCORD 996510024228 CORD,POWER (DETACHABLE/EUR)AMANT 996510024245 ANT,AMLOOPAVCABLE 996510024512 RCACABLE3M1185#24BLACKFMANT 996500016106 FM1POLEANTENNAMIC 996510024226 MICROPHONEASSY (FORCALIBRATION)RC 312814721721 REMOTECONTROLEN 132 3139 785 34870Tall-boySpeakerBoxJKJK3812191825TALL-BOY SPEAKER BOX (FRONT & SURROUND) - MECHANICAL PARTS LIST1996510024497 SPEAKER DRIVE 1 4OHM 75W2996510024487 SPEAKER DRIVE 4 4OHM 37.5W3996510024498 TB XOVER PCB ASSY8996510024495 SPIKE FEET18996510024513 TALL-BOY CLOTH FRAME ASSY19996510024509 GROMMET D12.5XD5.3X10.3H BLACK25996510024493 RUBBER, FRAME D10.5XT3.5 GREYTBFL 996510024502 TALL-BOY FRONT LEFT BOX (COMPLETE)TBFR 996510024506 TALL-BOY FRONT RIGHT BOX (COMPLETE)TBSL 996510024508 TALL-BOY SURROUND LEFT BOX (COMPLETE)TBSR 996510024504 TALL-BOY SURROUND RIGHT BOX (COMPLETE)TBFL WIRE 996510024481 CABLE 4M 2464#18 BLK W/WHITETBFR WIRE 996510024479 CABLE 4M 2464#18 BLK W/REDTBSL WIRE 996510024489 CABLE 10M 2464#18 BLK W/BLUETBSR WIRE 996510024496 CABLE 10M 2464#18 BLK W/GREY10. Exploded View & Spare Parts ListEN 133 3139 785 34870SatelliteSpeakerBox31520121921SATELLITE SPEAKER BOX (REAR OR BACK) - MECHANICAL PARTS LIST1996510024497 SPEAKER DRIVE 1 4OHM 75W2996510024487 SPEAKER DRIVE 4 4OHM 37.5W3996510024478 SB XOVER PCB ASSY12996510024483 SB CLOTH FRAME ASSY15996510024509 GROMMET D12.5XD5.3X10.3H BLACK19996510024501 RUBBER FOOT D20XT3.020996510024493 RUBBER, FRAME D10.5XT3.5 GREYSBL 996510024484 SATELLITE SPEAKER BOX - LEFT (COMPLETE)SBR 996510024485 SATELLITE SPEAKER BOX - RIGHT (COMPLETE)SBL WIRE 996510024507 CABLE 10M 2464#18 BLK SBLSBR WIRE 996510024491 CABLE 10M 2464#18 BLK SBR10. Exploded View & Spare Parts ListEN 134 3139 785 34870CenterSpeakerBox23521151014CENTER SPEAKER BOX - MECHANICAL PARTS LIST1996510024497 SPEAKER DRIVE 1 4OHM 75W2996510024487 SPEAKER DRIVE 4 4OHM 37.5W3996510024499 CB XOVER PCB ASSY5996510024509 GROMMET D12.5XD5.3X10.3H BLACK10 996510024503 CB CLOTH FRAME ASSY14 996510024501 RUBBER FOOT D20XT3.015 996510024493 RUBBER, FRAME D10.5XT3.5 GREYCB 996510024488 CENTER SPEAKER BOX (COMPLETE)CB WIRE 996510024505 CABLE 3M 2464#18 BLK CB10. Exploded View & Spare Parts ListEN 135 3139 785 34870SubwooferBoxAO2AO110. Exploded View & Spare Parts ListSUBWOOFER BOX - MECHANICAL PARTS LISTA01 996510025695 SUBWOOFERHOUSINGW/SPEAKERA02 996510024549 AMPLIFIERPCBW/REARPANELASSY59 996510024494 RUBBERFOOTEN 136 3139 785 34870Subwoofer - Amplifer PCB w/ Rear Panel10. Exploded View & Spare Parts List201918171615141312311091187661234RUBBER FELTT133 32 RUBBER FELTRUBBER FELTPAPER WASHERSUBWOOFER BOX AMPLIFIER PCB ASSY W/REAR PANEL PARTS6 996510025685 ROTARYKNOB7 996500020091 BUSHING8 996510025694 POWERCORD9 996510025717 POWERSWITCH11 996510025962 BACKPANEL19 996510025954 SPEAKERWIRE2P31 996510025949 L/RRUBBERFELT195X12X1,5MM32 996510025953 RCARUBBERFELT 101X25X1,5MM33 996510025955 T/BRUBBERFELT228X12X1,5MMFUSE 996510025948 FUSEF4A-250VSHTUBE1 -- SHRINKINSULATIONTUBED5,0MMSHTUBE2 -- SHRINKINSULATIONTUBED30,0MMX2 996510025692 CAP0.1uF275V+/-5%Y1 996510025722 CAP2200PF400V+/-20%SHTUBE2SHTUBE1 Y1X2 FUSEEN 137 3139 785 34870 10. Exploded View & Spare Parts ListMAIN UINT - FRONT PCB PANEL ASSEMBLY ELECTRICAL PARTS LIST:MISCELLANEOUSPCB1 996510024416 HTR9900FRONTPCBPANELASSY (COMPLETE)BN501 996510024261 WIREASSY(SHIELD,13PIN,2mm, 400mm,STRAIGHT,#26)BN502 996510024256 WIREASSY(LOCKINGTYPE, 2.5MM,5PIN,100MM)BN504 996510024249 WIREASSY(2.5MM,120MM,7PIN, DUAL-DIPPINGTYPE)BN521 996510024242 WIREASSY(7PIN,2mm,100mm, ANGLE,#26)BN561 996510024234 WIREASSY(15PIN,2.5mm,350mm, STRAIGHT,#22)BN562 996510024224 WAFER15P CN501 996510024218 WAFER,CARDCABLE(21P,1.25mm, ANGLE)CN550 996510024208 WAFER3P CN551 996510024201 WAFER,STRAIGHT(7PIN)CN571 996510024404 WAFER2P CN572 996510024409 WAFER2P F5501 996510024351 FUSET5A250V F5502 996510024351 FUSET5A250V F5701 996510024338 FUSET6.3A250V F5702 996510024314 FUSET2.5A250V FIP51 996510024347 V.F.DDISPLAY JK501 996510024209 JACK,BOARD(3PSILVER)JK502 996510024271 JACK,S-VHS(SILVER)JK521 996510024246 JACK,HEADPHONE(SILVERPLATE)JK522 996510024388 MODULE,OPTICAL(RX)OL570 996510024317 JACK,ACOUTLETRC501 996510024295 SENSOR,REMOCONRY521 996510024373 RELAY,12V2C2PRY571 996500002031 RELAYSDT-S-112DMRS5001 996500013548 TACTSWITCH S5002 996500013548 TACTSWITCH S5003 996500013548 TACTSWITCH S5004 996500013548 TACTSWITCH S5005 996500013548 TACTSWITCH S5006 996500013548 TACTSWITCH S5007 996500013548 TACTSWITCH S5008 996500013548 TACTSWITCH S5009 996500013548 TACTSWITCH S5010 996500013548 TACTSWITCH T5701 996510024311 TRANS,SUBVR502 996510024282 ENCODERVR CAPACITORSC5303 996510024407 CAP,METALLIZEDFILM0.15UF100VC5403 996510024407 CAP,METALLIZEDFILM0.15UF100VC5409 996510024415 CAP,ELECT10000UF16VC5501 996510024407 CAP,METALLIZEDFILM0.15UF100VC5502 996510024407 CAP,METALLIZEDFILM0.15UF100VC5503 996510024407 CAP,METALLIZEDFILM0.15UF100VC5504 996510024407 CAP,METALLIZEDFILM0.15UF100VC5505 996510024415 CAP,ELECT10000UF16VC5509 996510024415 CAP,ELECT10000UF16VC5701 996500013356 CAP,0.0047UF/2.5KVC5713 996500013356 CAP,0.0047UF/2.5KVRESISTORSR5304 996500013495 RES,FUSE0.15OHM,1WJR5305 996500013495 RES,FUSE0.15OHM,1WJR5405 996500013495 RES,FUSE0.15OHM,1WJR5406 996500013495 RES,FUSE0.15OHM,1WJR5707 996510024239 RES,METALOXIDE10OHM1WJDIODESD5032 996510024424 L.E.D,REDDIFFUSED(3.2PIE,5MM PITCH)D5044 996510024413 DIODE,ZENERZJ27B1/2WD5053 996510024393 DIODE,ZENERZJ13B1/2WD5055 996510024403 1N4003 D5056 996510024378 DIODE,ZENERZJ8.2B1/2WD5111 996510024423 DIODE,CHIP1SS355TD5112 996510024423 DIODE,CHIP1SS355TD5113 996510024423 DIODE,CHIP1SS355TD5114 996510024423 DIODE,CHIP1SS355TD5115 482213032778 1SS133 D5116 482213032778 1SS133 D5201 482213032778 1SS133 D5304 996510024372 DIODE,SCHOTTKYDSB2100D5305 996510024372 DIODE,SCHOTTKYDSB2100D5306 996510024403 1N4003 D5307 996510024403 1N4003 D5310 996510024365 1N4003 D5311 996510024365 1N4003 D5312 996510024365 1N4003 D5313 996510024365 1N4003 D5404 996510024372 DIODE,SCHOTTKYDSB2100D5405 996510024372 DIODE,SCHOTTKYDSB2100D5407 996510024403 1N4003 D5408 996510024403 1N4003 D5501 996510024391 DIODE,BRIDGEGBJ806D5601 996500013362 DIODE,RECT(2A)D5602 996500013362 DIODE,RECT(2A)D5701 996510024403 1N4003 D5702 996510024403 1N4003 D5703 996510024403 1N4003 D5704 996510024403 1N4003 D5707 482213032778 1SS133 D5710 996510024396 1N5819 D5713 482213032778 1SS133 D5721 996510024403 1N4003 D5722 996510024403 1N4003 D5723 996510024345 DIODE,ZENERZJ6.8B1/2WEN 138 3139 785 34870 10. Exploded View & Spare Parts ListTRANSISTORSQ5031 996510024319 KRA102M Q5036 996510024304 KRC102M Q5037 996510024304 KRC102M Q5051 482213011617 KSC2316Y Q5201 996510024304 KRC102M Q5703 996510024294 KRC107M Q5705 996510024272 KSC2785Y Q5705 996510024266 KTC3199Y Q5716 996510024294 KRC107M INTEGRATED CIRCUITSIC537 996510024348 REGULATOR(12VOUTPUTLOW DROP)KIA278R12PIIC538 996510024357 I.C,REGULATORKIA7912PIIC576 996510024364 I.C,REGULATOR(250mA,TO220IS-3)MAIN UNIT - MCU PCB ASSEMBLY ELECTRICAL PARTS LIST:MISCELLANEOUSPCB2 996510024241 HTR9900MCUPCBASSY (COMPLETE) BN490 996510024224 WAFER15P BN491 996510024399 WAFER5P CN501 996510024218 WAFER,CARDCABLE(21P,1.25mm, ANGLE)JK241 996510024383 JACK,BOARDJK242 996510024388 MODULE,OPTICAL(RX)JK243 996510024388 MODULE,OPTICAL(RX)JK244 996510024235 MODULE,OPTICAL(TX)SW201 996510024225 PUSHSWITCH SW202 996510024225 PUSHSWITCH X2003 996500013570 CRYSTAL,CHIP(27MHZ,SMD)X2055 996510024414 CRYSTAL,CHIP(24MHZ,HC-49/ SMD)X2075 996510024414 CRYSTAL,CHIP(24MHZ,HC-49/ SMD)X2427 996510024217 CRYSTAL,24.576MHzRESISTORSRN201 996510024194 RES,ARRAY,10K(1608)RN202 996510024194 RES,ARRAY,10K(1608)RN211 996510024358 RES,CHIPNETWORK(1/16W, 100ohm,1608X4)RN212 996510024358 RES,CHIPNETWORK(1/16W, 100ohm,1608X4)RN213 996510024358 RES,CHIPNETWORK(1/16W, 100ohm,1608X4)RN214 996510024358 RES,CHIPNETWORK(1/16W, 100ohm,1608X4)RN215 996510024358 RES,CHIPNETWORK(1/16W, 100ohm,1608X4)RN216 996510024194 RES,ARRAY,10K(1608)RN217 996510024194 RES,ARRAY,10K(1608)RN241 996510024194 RES,ARRAY,10K(1608)RN242 996510024329 RES,4ARRAY33OHM/1608*4RN243 996510024329 RES,4ARRAY33OHM/1608*4RN244 996510024329 RES,4ARRAY33OHM/1608*4RN245 996510024329 RES,4ARRAY33OHM/1608*4RN246 996510024329 RES,4ARRAY33OHM/1608*4RN247 996510024329 RES,4ARRAY33OHM/1608*4RN248 996510024329 RES,4ARRAY33OHM/1608*4RN249 996510024329 RES,4ARRAY33OHM/1608*4RN250 996510024329 RES,4ARRAY33OHM/1608*4RN251 996510024329 RES,4ARRAY33OHM/1608*4RN252 996510024329 RES,4ARRAY33OHM/1608*4RN253 996510024329 RES,4ARRAY33OHM/1608*4RN254 996510024194 RES,ARRAY,10K(1608)RN255 996510024194 RES,ARRAY,10K(1608)RN256 996510024194 RES,ARRAY,10K(1608)RN257 996510024329 RES,4ARRAY33OHM/1608*4RN258 996510024329 RES,4ARRAY33OHM/1608*4EN 139 3139 785 34870 10. Exploded View & Spare Parts ListDIODESD2011 996510024423 DIODE,CHIP1SS355TD2511 996510024323 SCHOTTKEYBARRIER1SR159-200D2512 996510024323 SCHOTTKEYBARRIER1SR159-200TRANSISTORSQ2008 996510024305 KRC102S Q2011 996510024343 KRA102S Q2025 996510024305 KRC102S Q2028 996510024305 KRC102S Q2107 996510024343 KRA102S Q2108 996510024305 KRC102S Q2461 996510024305 KRC102S INTEGRATED CIRCUITSIC201 996510024293 I.C,U-COMM80(T5CC1/TOSHIBA)IC201* 996510024196 I.C,FLASHU-COMT5CC1IC202 996510024419 I.C,EEPROM(32Kbit) M24C32WMN6TPIC203 996510024355 I.C,RESETRICOH1.8VRH5VT18CIC204 996510024385 I.CTC74HC7007AFELIC205 996510024395 I.C,I2C/SPIUARTXR20M1170IG16IC206 996510024395 I.C,I2C/SPIUARTXR20M1170IG16IC207 996500010595 I.C,ANDGATE(QUAD/2INL/V) 74LCX08MXIC208 996500010595 I.C,ANDGATE(QUAD/2INL/V) 74LCX08MXIC210 996510024392 I.C,REGULATOR(SOT-223) KIA1117S/F33IC240 996510024288 I.C,DSPCS497004CQZIC241 996510024333 I,C,OCTALBUSBUFFER TC74VCX541FTIC250 996510024375 I.C,8MbitSPISerialFlash CVIST25VF080B504CS2FIC251 996510024284 I.C,CHIPREGULATOR(+3.3V) NJM2391DL133IC252 996510024335 I.C,REGULATOR(SOT-223) KIA1117S/F18IC260 996510024264 I.C,16MBSDRAMM12L16161A5TGIC280 996510024324 I.C,CODEC+DIRCS42528-CQIC281 996510024422 I.C,INVERTERTC74HCU04AFNGIC282 996510024202 I.C,2-CHANNELMUX TC74VHC157FTIC291 996500013228 I.C,OPAMPNJM2068MD-TE1IC292 996500013228 I.C,OPAMPNJM2068MD-TE1IC293 996500013228 I.C,OPAMPNJM2068MD-TE1IC294 996500013228 I.C,OPAMPNJM2068MD-TE1MAIN UNIT - INPUT PCB ASSEMBLY ELECTRICAL PARTS LIST:MICELLANEOUSPCB3 996510024198 HTR9900INPUTPCBASSY (COMPLETE)BN301 996510024224 WAFER15P BN302 996510024224 WAFER15P BN303 996510024224 WAFER15P BN311 996510024339 WIREASSY(SHIELD,9PIN,2mm, 100mm,STRAIGH#26)CN312 996510024251 WAFER,CARDCABLECN401 996510024252 WAFER,CARDCABLEJK301 996510024346 TERMINAL,IN/OUTJK302 996510024263 JACK,IN/OUTJK304 996510024346 TERMINAL,IN/OUTJK305 996510024371 JACKIN/OUT JK306 996510024382 JACKIN/OUT JK307 996510024371 JACKIN/OUT JK308 996510024382 JACKIN/OUT JW366 996510024192 WIREASSY(3PIN,3.96mm,120mm, STRAIGHTLUG,#18)X3501 996500016116 CRYSTAL CAPACITORSC3073 996510024407 CAP,METALLIZEDFILM0.15UF100VC3076 996510024407 CAP,METALLIZEDFILM0.15UF100VRESISTORSR3321 996510024197 RES,METALOXIDEFILM(1W/68 OHM)R3322 996510024197 RES,METALOXIDEFILM(1W/68 OHM)DIODESD3110 996510024423 DIODE,CHIP1SS355TD3325 996510024213 DIODE,ZENER7.5VD3326 996510024213 DIODE,ZENER7.5VD3327 996510024193 DIODE,SCHOTTKEYBARRIERHKD3328 996510024193 DIODE,SCHOTTKEYBARRIERHKD3701 996510024423 DIODE,CHIP1SS355TD3702 996510024423 DIODE,CHIP1SS355TD3703 996510024423 DIODE,CHIP1SS355TD3704 996510024423 DIODE,CHIP1SS355TD3705 996510024423 DIODE,CHIP1SS355TD3706 996510024423 DIODE,CHIP1SS355TD3709 996510024423 DIODE,CHIP1SS355TD3710 996510024423 DIODE,CHIP1SS355TD3711 996510024423 DIODE,CHIP1SS355TD3712 996510024423 DIODE,CHIP1SS355TD3713 996510024423 DIODE,CHIP1SS355TD3714 996510024423 DIODE,CHIP1SS355TD3715 996510024423 DIODE,CHIP1SS355TD3716 996510024423 DIODE,CHIP1SS355TD3717 996510024423 DIODE,CHIP1SS355TD3718 996510024423 DIODE,CHIP1SS355TD3719 996510024423 DIODE,CHIP1SS355TD3720 996510024423 DIODE,CHIP1SS355TEN 140 3139 785 34870 10. Exploded View & Spare Parts ListTRANSISTORSQ3095 996510024313 KTC2875B Q3096 996510024313 KTC2875B Q3097 996510024313 KTC2875B Q3098 996510024313 KTC2875B Q3099 996510024313 KTC2875B Q3100 996510024313 KTC2875B Q3101 996510024313 KTC2875B Q3109 996510024313 KTC2875B Q3110 996510024313 KTC2875B Q3219 996510024313 KTC2875B Q3220 996510024313 KTC2875B Q3301 996510024325 T.R,CHIPKRC107SQ3302 996510024325 T.R,CHIPKRC107SQ3303 996510024325 T.R,CHIPKRC107SQ3304 996510024325 T.R,CHIPKRC107SQ3305 996510024325 T.R,CHIPKRC107SQ3306 996510024325 T.R,CHIPKRC107SQ3307 996510024325 T.R,CHIPKRC107SQ3308 996510024325 T.R,CHIPKRC107SQ3309 996510024287 TR,CHIPKRA107SQ3310 996510024287 TR,CHIPKRA107SQ3311 996510024287 TR,CHIPKRA107SQ3312 996510024287 TR,CHIPKRA107SQ3321 996510024334 KTC3203Y Q3322 996510024363 KTA1271Y INTEGRATED CIRCUITSIC301 996510024283 I.C,INPUTWITH8CHVOLUME(100P QFP)IC302 996510024344 I.C,SHIFTREGISTERCD4094BPWRIC303 996500013228 I.C,OPAMPNJM2068MD-TE1IC351 996510024385 I.CTC74HC7007AFEL IC352 996510024356 IC,PLL(RDS)LC72723MIC361 996510024299 REGULATOR(5VOUTPUTLOW DROP)KIA278R05PIIC363 996510024207 I.C,REGULATOR(-5V)KIA7905PIIC364 996510024298 I.C,REGULATOR+9VKIA7809IC365 996510024408 I.C,REGULATOR(3A,TO220IS-4) KIA378R00PIMAIN UNIT - VIDEO PCB ASSEMBLY ELECTRICAL PARTS LIST:MISCELLANEOUSPCB4 996510024307 HTR9900VIDEOPCBASSY (COMPLETE)CN131 996510024401 WAFER,CARDCABLECN132 996510024401 WAFER,CARDCABLEJK131 996510024352 JACK,S-VIDEO+CVBSJK132 996510024352 JACK,S-VIDEO+CVBSJK133 996510024352 JACK,S-VIDEO+CVBSJK134 996510024359 JACK,BOARDJK135 996510024359 JACK,BOARDINTEGRATED CIRCUITSIC131 996510024386 I.C,VIDEOS/WNJW1321FP1IC133 996510024366 I.CNJM2581MTE1 IC134 996510024327 I.C,VIDEOSWITCHNJM2285MTE1EN 141 3139 785 34870 10. Exploded View & Spare Parts ListMAIN UNIT - HDMI PCB ASSEMBLY ELECTRICAL PARTS LIST:MISCELLANEOUSPCB5 996510024308 HTR9900HDMIPCBASSY (COMPLETE)BN141 996510024224 WAFER15P BN142 996510024224 WAFER15P BN143 996510024399 WAFER5P BN146 996510024312 WIREASSY(9PIN,2.5mm,100mm, STRAIGHT,#22)CN144 996510024276 WAFER,FFC17PCN145 996510024276 WAFER,FFC17PJK140 996510024381 JACK,HDMI(JALCO)JK141 996510024381 JACK,HDMI(JALCO)JK142 996510024381 JACK,HDMI(JALCO)JK143 996510024381 JACK,HDMI(JALCO)JK144 996510024381 JACK,HDMI(JALCO)X1401 996500013570 CRYSTAL,CHIP(27MHZ,SMD)X1402 996510024326 X-TAL,CHIP,19.6608MHz(33P)RESISTORSRN140 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN141 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN142 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN143 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN146 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN147 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN148 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN149 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN150 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN151 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN152 996510024212 RES,4ARRAY22X4/2012RN153 996510024212 RES,4ARRAY22X4/2012RN154 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN156 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN157 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN158 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN159 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN160 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN161 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN162 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RESISTORSRN163 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN164 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN166 996510024194 RES,ARRAY,10K(1608)RN167 996510024194 RES,ARRAY,10K(1608)RN168 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN169 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN170 996510024238 RES,CHIPNETWORK(1/16W, 33ohm,1005X2)RN171 996510024238 RES,CHIPNETWORK(1/16W, 33ohm,1005X2)RN172 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN173 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN174 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN175 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN176 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN177 996510024238 RES,CHIPNETWORK(1/16W, 33ohm,1005X2)RN178 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN179 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN180 996510024238 RES,CHIPNETWORK(1/16W, 33ohm,1005X2)RN181 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN182 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN183 996510024238 RES,CHIPNETWORK(1/16W, 33ohm,1005X2)RN184 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN185 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN186 996510024227 RES,CHIPNETWORK(1/16W, 33ohm,1005X4)RN187 996510024191 RES,ARRAY,10R(1608)RN188 996510024191 RES,ARRAY,10R(1608)RN189 996510024191 RES,ARRAY,10R(1608)RN190 996510024191 RES,ARRAY,10R(1608)RN191 996510024191 RES,ARRAY,10R(1608)RN192 996510024191 RES,ARRAY,10R(1608)RN193 996510024191 RES,ARRAY,10R(1608)RN196 996510024212 RES,4ARRAY22X4/2012EN 142 3139 785 34870 10. Exploded View & Spare Parts ListDIODESD1401 996510024328 DIODE,SCHOTTKYBARRIER 1SS378D1402 996510024323 SCHOTTKEYBARRIER1SR159-200D1403 996510024323 SCHOTTKEYBARRIER1SR159-200D1405 996510024323 SCHOTTKEYBARRIER1SR159-200D1406 996510024323 SCHOTTKEYBARRIER1SR159-200D1407 996510024323 SCHOTTKEYBARRIER1SR159-200D1408 996510024323 SCHOTTKEYBARRIER1SR159-200D1409 996510024323 SCHOTTKEYBARRIER1SR159-200D1410 996510024323 SCHOTTKEYBARRIER1SR159-200D1411 996510024323 SCHOTTKEYBARRIER1SR159-200D1412 996510024323 SCHOTTKEYBARRIER1SR159-200TRANSISTORSQ1401 996510024343 KRA102S Q1402 996510024302 T.R,CHIPKRC103SQ1403 996510024286 F.E.TUPA672T Q1404 996510024343 KRA102S Q1405 996510024302 T.R,CHIPKRC103SQ1406 996510024286 F.E.TUPA672T Q1407 996510024343 KRA102S Q1408 996510024302 T.R,CHIPKRC103SQ1409 996510024286 F.E.TUPA672T Q1410 996510024343 KRA102S Q1411 996510024302 T.R,CHIPKRC103SQ1412 996510024286 F.E.TUPA672T Q1413 996510024302 T.R,CHIPKRC103SQ1414 996510024269 TR,CHIPKRC111SQ1415 996510024302 T.R,CHIPKRC103SQ1416 996510024286 F.E.TUPA672T Q1419 996510024305 KRC102S INTEGRATED CIRCUITSIC141 996510024195 I.C,HDMIRXSW(80PINTQFP) SII9185ACTUIC142 996510024425 I.C,4CHMUXTC7MZ4052FKIC143 996510024405 I.C,EEPROM(2K)AT24C02NSU18IC144 996510024336 I.C,HEXSCHMITTINVERTER TC74VHCT14AFTIC145 996510024336 I.C,HEXSCHMITTINVERTER TC74VHCT14AFTIC146 996510024315 IC,HDMIRX(144PIN,TQFP) SII9135CTUIC147 996510024333 I,C,OCTALBUSBUFFER TC74VCX541FTIC148 996510024362 I.C,INPUTANDGATEKIC7SZ08FU- RTKIC149 996510024354 I.C,REGULATOR(SOT-223) KIA1117S50-RTK/PIC150 996510024354 I.C,REGULATOR(SOT-223) KIA1117S50-RTK/PIC152 996510024291 I.C,FLASHROM32Mbit ES29LV320ET70TGIC152* 996510024254 I.C,FLASHROM32MbitIC ES29LV320FT70TGIC153 996510024267 I.C,256MBDDRSDRAM A3S56D40ETPG5INTEGRATED CIRCUITSIC154 996510024267 I.C,256MBDDRSDRAM A3S56D40ETPG5IC155 996510024362 I.C,INPUTANDGATEKIC7SZ08FU- RTKIC156 996510024419 I.C,EEPROM(32Kbit) M24C32WMN6TPIC158 996510024231 I.C,VIDEOENCODERADV7342BSTZIC159 996510024244 I.C,NJM2566AV(TE1)IC160 996510024203 I.C,BUFFERMK23020S-01TIC161 996510024392 I.C,REGULATORKIA1117S/F33IC162 996510024335 I.C,REGULATORKIA1117S/F18IC163 996510024412 I.C,REGULATORKIA1117S25-RTK/PIC164 996510024392 I.C,REGULATORKIA1117S/F33IC165 996510024392 I.C,REGULATOR(SOT-223) KIA1117S/F33IC166 996510024392 I.C,REGULATORKIA1117S/F33IC167 996510024335 I.C,REGULATOR(SOT-223) KIA1117S/F18IC168 996510024335 I.C,REGULATORKIA1117S/F18IC169 996510024335 I.C,REGULATORKIA1117S/F18IC170 996510024392 I.C,REGULATORKIA1117S/F33IC171 996510024335 I.C,REGULATORKIA1117S/F18IC173 996510024421 IC,HDMITX(100PIN,TQFP) SII9134CTUEN 143 3139 785 34870 10. Exploded View & Spare Parts ListMAIN UNIT - AMPLIFIER PCB ASSEMBLY ELECTRICAL PARTS LIST:MISCELLANEOUS PCB6 996510024296 HTR9900AMPPCBASSY (COMPLETE)BN410 996510024406 WIREASSY(2PIN,3.96mm, STRAIGHTLUG,#18)BN411 996510024394 WIREASSY(2PIN,3.96mm, STRAIGHTLUG,#18)BN412 996510024384 WIREASSY(3PIN,3.96mm, STRAIGHTLUG,#18)BN490 996510024374 WIREASSY(SHIELD,5PIN,2mm, 400mm,STRAIGHT,#26)BN492 996510024369 WIREASSY(5PIN,2.5mm,300mm, STRAIGHT,#26)BN494 996510024361 WIREASSY(5PIN,2mm,400mm, STRAIGHT,#26)CN401 996510024252 WAFER,CARDCABLE13PCN466 996510024208 WAFER3P CN490 996510024353 WAFER15P CN491 996510024331 WAFER5P CN496 996510024322 WAFER3P JK484 996510024248 JACK,9PD-SUBFEMALE (RS-232C,SEMCO)JK485 996510024255 JACK,DIN9PJK487 996510024258 JACK,STEREO(2P3.5PIE)JK489 996510024258 JACK,STEREO(2P3.5PIE)JK492 996510024265 TERMINAL,2PSPK(SCREW, WHITE)JK494 996510024229 TERMINAL,4PSPK(SCREW, GR,RD)JK495 996510024236 TERMINAL,8PSPK (SCREW,TAN,BR,GREY,BL)RY491 996510024418 RELAY RY492 996510024418 RELAY RY494 996510024418 RELAY RY495 996510024418 RELAY RY496 996510024418 RELAY SW480 996510024232 TACTSWITCH TH492 996510024411 POSISTOR,ASSYCAPACITORSC4961 996510024243 CAP,METALLIZEDFILM0.1UF250VC4962 996510024243 CAP,METALLIZEDFILM0.1UF250VC4963 996510024243 CAP,METALLIZEDFILM0.1UF250VC4964 996510024243 CAP,METALLIZEDFILM0.1UF250VC4972 996510024316 CAP,ELECT18000UF63VC4973 996510024316 CAP,ELECT18000UF63VRESISTORSR4113 996510024341 RES,METALOXIDEFILM5.6K1WR4114 996510024341 RES,METALOXIDEFILM5.6K1WR4117 996510024306 RES,METALOXIDEFILM10OHM 1WJR4118 996510024398 RES,CEMENT2X0.22OHM5WR4128 996510024306 RES,METALOXIDEFILM10OHM 1WJR4213 996510024341 RES,METALOXIDEFILM5.6K1WRESISTORSR4214 996510024341 RES,METALOXIDEFILM5.6K1WR4217 996510024306 RES,METALOXIDEFILM10OHM 1WJR4218 996510024398 RES,CEMENT2X0.22OHM5WR4228 996510024306 RES,METALOXIDEFILM10OHM 1WJR4313 996510024341 RES,METALOXIDEFILM5.6K1WR4314 996510024341 RES,METALOXIDEFILM5.6K1WR4317 996510024306 RES,METALOXIDEFILM10OHM 1WJR4318 996510024398 RES,CEMENT2X0.22OHM5WR4328 996510024306 RES,METALOXIDEFILM10OHM 1WJR4413 996510024341 RES,METALOXIDEFILM5.6K1WR4414 996510024341 RES,METALOXIDEFILM5.6K1WR4417 996510024306 RES,METALOXIDEFILM10OHM 1WJR4418 996510024398 RES,CEMENT2X0.22OHM5WR4428 996510024306 RES,METALOXIDEFILM10OHM 1WJR4513 996510024341 RES,METALOXIDEFILM5.6K1WR4514 996510024341 RES,METALOXIDEFILM5.6K1WR4517 996510024306 RES,METALOXIDEFILM10OHM 1WJR4518 996510024398 RES,CEMENT2X0.22OHM5WR4528 996510024306 RES,METALOXIDEFILM10OHM 1WJR4613 996510024341 RES,METALOXIDEFILM5.6K1WR4614 996510024341 RES,METALOXIDEFILM5.6K1WR4617 996510024306 RES,METALOXIDEFILM10OHM 1WJR4618 996510024398 RES,CEMENT2X0.22OHM5WR4628 996510024306 RES,METALOXIDEFILM10OHM 1WJR4713 996510024341 RES,METALOXIDEFILM5.6K1WR4714 996510024341 RES,METALOXIDEFILM5.6K1WR4717 996510024306 RES,METALOXIDEFILM10OHM 1WJR4718 996510024398 RES,CEMENT2X0.22OHM5WR4728 996510024306 RES,METALOXIDEFILM10OHM 1WJR4828 996510024206 RES,CEMENT0.1OHM5WR4829 996510024206 RES,CEMENT0.1OHM5WR4934 996510024303 RES,METALOXIDEFILM4.7OHM 1W5%R4936 996510024306 RES,METALOXIDEFILM10OHM 1WJR4938 996510024306 RES,METALOXIDEFILM10OHM 1WJR4946 996510024281 RES,METALOXIDEFILM47OHM 1WVR410 996510024268 RES,SEMIFIXED(220,BCURVE)VR420 996510024268 RES,SEMIFIXED(220,BCURVE)VR430 996510024268 RES,SEMIFIXED(220,BCURVE)VR440 996510024268 RES,SEMIFIXED(220,BCURVE)VR450 996510024268 RES,SEMIFIXED(220,BCURVE)VR460 996510024268 RES,SEMIFIXED(220,BCURVE)VR470 996510024268 RES,SEMIFIXED(220,BCURVE)EN 144 3139 785 34870 10. Exploded View & Spare Parts ListCOILSL4126 996500013513 COIL,SPEAKER0.5UHL4226 996500013513 COIL,SPEAKER0.5UHL4326 996500013513 COIL,SPEAKER0.5UHL4426 996500013513 COIL,SPEAKER0.5UHL4526 996500013513 COIL,SPEAKER0.5UHL4626 996500013513 COIL,SPEAKER0.5UHL4726 996500013513 COIL,SPEAKER0.5UHDIODESD4115 996510024199 DIODE,ZENERZJ3.3B1/2WD4116 996510024199 DIODE,ZENERZJ3.3B1/2WD4117 482213032778 1SS133 D4118 482213032778 1SS133 D4123 482213032778 1SS133 D4215 996510024199 DIODE,ZENERZJ3.3B1/2WD4216 996510024199 DIODE,ZENERZJ3.3B1/2WD4217 482213032778 1SS133 D4218 482213032778 1SS133 D4223 482213032778 1SS133 D4315 996510024199 DIODE,ZENERZJ3.3B1/2WD4316 996510024199 DIODE,ZENERZJ3.3B1/2WD4317 482213032778 1SS133 D4318 482213032778 1SS133 D4323 482213032778 1SS133 D4415 996510024199 DIODE,ZENERZJ3.3B1/2WD4416 996510024199 DIODE,ZENERZJ3.3B1/2WD4417 482213032778 1SS133 D4418 482213032778 1SS133 D4423 482213032778 1SS133 D4515 996510024199 DIODE,ZENERZJ3.3B1/2WD4516 996510024199 DIODE,ZENERZJ3.3B1/2WD4517 482213032778 1SS133 D4518 482213032778 1SS133 D4523 482213032778 1SS133 D4615 996510024199 DIODE,ZENERZJ3.3B1/2WD4616 996510024199 DIODE,ZENERZJ3.3B1/2WD4617 482213032778 1SS133 D4618 482213032778 1SS133 D4623 482213032778 1SS133 D4715 996510024199 DIODE,ZENERZJ3.3B1/2WD4716 996510024199 DIODE,ZENERZJ3.3B1/2WD4717 482213032778 1SS133 D4718 482213032778 1SS133 D4723 482213032778 1SS133 D4770 482213032778 1SS133 D4801 996510024423 DIODE,CHIP1SS355TD4802 996510024423 DIODE,CHIP1SS355TD4803 996510024423 DIODE,CHIP1SS355TD4804 996510024423 DIODE,CHIP1SS355TD4805 996510024423 DIODE,CHIP1SS355TD4806 996510024423 DIODE,CHIP1SS355TD4807 996510024423 DIODE,CHIP1SS355TD4811 996510024423 DIODE,CHIP1SS355TD4812 996510024423 DIODE,CHIP1SS355TD4813 996510024423 DIODE,CHIP1SS355TD4814 996510024423 DIODE,CHIP1SS355TD4815 996510024423 DIODE,CHIP1SS355TD4816 996510024423 DIODE,CHIP1SS355TDIODESD4817 996510024423 DIODE,CHIP1SS355TD4821 482213032778 1SS133 D4861 482213032778 1SS133 D4862 482213032778 1SS133 D4863 996510024219 DIODE,ZENERMTZJ5.1B1/2WD4900 996510024423 DIODE,CHIP1SS355TD4910 996510024423 DIODE,CHIP1SS355TD4922 482213032778 1SS133 D4930 996510024423 DIOD